diesel generator set - advanced diesel … item 50 hz 60 hz motor starting capability* kva...
TRANSCRIPT
Engine Make & Model:
Circuit Breaker Type:
Fuel Tank Capacity: litres (US gal)
Frequency: 50 Hz 60 Hz
Fuel Consumption, Prime: l/hr (US gal/hr)
Engine Speed: RPM
Base Frame Type:
Fuel Consumption, Standby : l/hr (US gal/hr)
Heavy Duty Fabricated Steel
Generator Model:
Control Panel: EMCP 4.1
Output Ratings
Generator Set Model - 3 Phase Standby*Prime*
* Refer to ratings definitions on page 4.Ratings at power factor.
Technical Data
EU stage II emissions compliant.
Image shown may not reflect actual package
250 (66.0)
)8.6(7.52)7.5(7.12
00810051
)5.7(5.82)3.6(8.32
LC3114F
110.0 kVA
88.0 kW
100.0 kW
125.0 kVA
100.0 kVA
80.0 kW
90.4 kW
113.0 kVA480/277 V, 60 Hz
400/230 V, 50 Hz
0.8
DE110E2
DIESEL GENERATOR SETCaterpillar Diesel Generator Range
Air Filter Type:
Combustion Air Flow:
m³/min (cfm) -Standby:
-Prime:
Max. Combustion Air Intake
Restriction: kPa (in H2O)
Radiator Cooling Air Flow:
m³/min (cfm)
External Restriction to
Cooling Air Flow: Pa (in H2O)
Air System 60 Hz50 Hz
Moment of Inertia: kg m² (lb. in²)
Governing Type:
Governing Class:
Compression Ratio:
Displacement: l (cu.in)
Engine Electrical System:
-Voltage/Ground:
-Battery Charger Amps:
Weight: kg (lb) - Dry:
- Wet:
Cooling Method:
Bore/Stroke: mm (in)
Induction:
Manufacturer:
Model:
No. of Cylinders/Alignment:
Cycle:
Regenerative Power: kW-Prime:
-Standby:
BMEP: kPa (psi)
-Prime:
-Standby:
Gross Engine Power: kW (hp)Engine Speed: RPM
Oil Pan l (US gal):
Total Oil Capacity l (US gal):
Oil Filter Type:
Oil Type:
Cooling Method:
Prime
50 Hz
60 Hz
(based on diesel fuel with a speci�c gravity of 0.85 and conforming to BS2869, Class A2)
Recommended Fuel:
Fuel Consumption: l/hr (US gal/hr)
110%Load
75%Load
50%Load
100%Load
Fuel Filter Type:
Standby
50 Hz
60 Hz
Level: dB
Silencer System: kPa (in Hg)
Pressure Drop Across
Silencer Noise Reduction
Silencer Type:
Pressure: kPa (in. Hg)
Max. Allowable Back
-Prime:
m³/min (cfm) -Standby:
Exhaust Gas Flow:
-Prime:
-Standby:
Exhaust Gas Temperature: °C (°F)
Silencer Model & Quantity:Cooling System Capacity:
l (US gal)
Water Pump Type:
Heat Rejected to Water &
Lube Oil: kW (Btu/min)
-Standby:
-Prime:
-Prime:
kW (Btu/min) -Standby:
Heat Radiation to Room: Heat radiated from engine and alternator
Radiator Fan Load: kW (hp)
Cooling System 60 Hz50 Hz
Performance 60 Hz50 Hz
Fuel System
Exhaust System
Lubrication SystemPhysical Data
Engine Technical Data
60 Hz50 Hz
Class A2 Diesel or BSEN590
Cooling system designed to operate in ambient conditions up to 50°C(122 °F). Contact ADVANCED for power ratings at specific siteconditions
DIESEL GENERATOR SETCaterpillar Diesel Generator Range
8.0 (32.1)
187.8 (6632)
Replaceable Element
7.8 (275)6.3 (221)
7.8 (274)6.0 (212)
8.0 (32.1)
125 (0.5)125 (0.5)
244.2 (8624)
1.51 (5160)
Water
Electronic�
ISO�8528�G2
18.3:1
4.4 (268.5)
105.0 (4.1)/127.0 (5.0)
12/Negative
65500 (1102)
520 (1146)
Caterpillar
C4.44 / In Line
4 Stroke
Turbocharged Air To AirCharge Cooled
13.88.21702.0 (246.9) 1619.0 (234.8)
1781.0 (258.3)1873.0 (271.7)
106.8 (143.0)93.6 (126.0)103.0 (138.0) 117.5 (158.0)
18001500
Spin-On, Full Flow
8.0 (2.1)7.0 (1.8)
API CC/SE
Water
11.7 (3.1)14.1 (3.7)19.6 (5.2)25.7 (6.8)28.5 (7.5)
16.5 (4.4)21.7 (5.7)23.8 (6.3)
Replaceable Element
12.6 (3.3)18.0 (4.8)23.8 (6.3)15.2 (4.0)21.5 (5.7)28.5 (7.5)
EXSY1 (1)
3.56 (1.051)2.10 (0.620)
1722
15.0 (4.4)18.0 (5.3)
20.4 (720)16.3 (576)
18.4 (650)15.2 (537)
574 (1065)543 (1009)
517 (963)514 (957)
Industrial
50.7 (2883)
4.8 (6.4)
17.5 (4.6)17.5 (4.6)Centrifugal
64.0 (3640)
57.7 (3281)46.1 (2622)
17.7 (1007)15.3 (870)
15.7 (893)13.7 (779)
2.8 (3.8)
�
Data Item
50 Hz 60 Hz
Motor Starting Capability* kVA
Reactances: Per Unit
Xd
X'd
X''d
Reactances shown are applicable to prime ratings. *Based on 30% voltage dip at 0.6 power factor and SHUNT excitation system.
Short Circuit Capacity** %
Generator Performance Data
��������
Model:
No. of Bearings:
Insulation Class:
Winding Pitch - Code:
Wires:
Ingress Protection Rating:
Excitation System:
AVR Model:
Overspeed: RPM
Voltage Regulation: (steady state)
Wave Form NEMA = TIF:
Wave Form IEC = THF:
Total Harmonic Content LL/LN:
Radio Interference:
Radiant Heat: kW (Btu/min)
-50 Hz:
-60 Hz:
Suppression is in line with European Standard EN61000-6
Physical Data Operating Data
** With optional Permanent Magnet generator.�
Generator Technical Data
DIESEL GENERATOR SETCaterpillar Diesel Generator Range
�����������
256 240 220 282 280 187 219 205 242
2.666 2.870 3.180 2.372 2.702 4.312 3.598 3.891 3.216
0.120 0.129 0.143 0.107 0.121 0.194 0.162 0.175 0.145
0.072 0.077 0.086 0.064 0.073 0.116 0.097 0.105 0.087
415/240V 400/230V230/115V200/115V
380/220V220/110V
220/127V 480/277V240/139V
380/220V220/110V
240/120V208/120V
230/115V 440/254V220/127V
300 300 300 300 300 300 300 300 300
LC3114F
1
H
2/3 - 6
12
IP23
SHUNT
R250 8.3 (472)
7.8 (444)
2.0%
2.0%
50
+/- 0.5%
2250
��
kWkVAkWkVA
Technical Data
Voltage50 Hz
Prime Standby
Standby Rating
������� ������� ����� ������� ���� ���� ���� �������� ��� �������������������� �������!�� "���#�������$�&������������������� �"���'���� ���� "������ ������ �����$� +���#�� ��������� �"� ��� ����"��������;������!<�!�!��<��#�����"������=�������"��������$
Prime Rating
Output available with varying load for an unlimited time. Average power output is 70% of the prime power rating. Typical peak demand is 100% of prime rated ekW with 10% overload capability for emergency use for a maximum of 1 hour in 12. Overload opeation cannot exceed 25 hours per year.
.Standard Reference Conditions
Note: Standard reference conditions 25°C (77°F) air inlet temp,100m (328ft) A.S.L. 30% relative humidity. Fuel consumption dataat full load with diesel fuel with specific gravity of 0.85 andconforming to BS2869: 1998, Class A2.
Definitions
kWkVAkWkVA
Voltage60 Hz
Prime Standby
Weights & Dimensions
Weights: kg (lb)
Net (+ lube oil)
Wet (+ lube oil & coolant)
Fuel, lube oil & coolant
Dimensions: mm (in)
Height
Width
Length
Documents
A full set of operation and maintenance manuals and circuit wiring diagrams.
Quality Standards
The equipment meets the following standards: IEC60034-1,IEC60034-22, ISO3046, ISO8528, NEMA MG 1-32, NEMA MG 1-33, 2004/108/EC, 2006/42/EC, 2006/95/EC.
General Data
Note: General con�guration not to be usedfor installation. See general dimensiondrawings for detail.
© 2015 ADVANCEDAll rights reserved.
14 Langthwaite Business Park, South Kirkby, Pontefract, West Yorkshire WF9 3AP, UK
www.adeltd.com
DIESEL GENERATOR SET
88.0110.0
88.0110.0
88.0110.0
88.0110.0
88.0110.0
88.0110.0
88.0110.0
80.0
80.0
80.0
80.0100.0
100.0
100.0
100.0
80.0100.0
100.0 80.0
200/115V
220/110V
220/127V
230/115V
380/220V
415/240V
400/230V
80.0100.0
100.0
100.0125.090.4113.0208/120V
100.0125.090.4113.0220/110V
100.0
100.0
100.0
100.0125.090.4113.0380/220V
100.0
100.0125.090.4113.0480/277V
125.0
125.0
125.0
125.0
125.090.4
90.4
90.4
90.4
90.4113.0
113.0
113.0
113.0
240/139V
440/254V
230/115V
240/120V
220/127V
113.0
1358 (2994)
1147 (2529)
1129 (2490)
1375 (54.1)
1120 (44.1)
2089 (82.2)
Caterpillar Diesel Generator Range