ig - scw technical data sheet issue 02 june 29th 2020
TRANSCRIPT
IG – SCWSelf – Contained Water Cooled
Full Height Doored Medium Temperature
Multideck
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 02 of 13
CA
BIN
ET
TEC
HN
ICA
L D
ATA
Multi Deck Full Height Medium Temperature
Cabinet Type:
Model Designation:
Document Issue:
Self – Contained Water
IG - SCW
(01) 31st January 2020
Contents:
Section 01. Cabinet Technical Data – pages 3&4
Section 02. Cabinet Side View - page 5
Section 03. Cabinet Plan View - Drain & Foot Locations – page 6
Section 04. Cabinet Plan View - Condensing Unit s & Electrical Control Panel Location – page 7
Section 05. Cabinet Side View Back To Back Island – page 8
Section 06. Control Panel - Electrical Schematic – page 9
Section 07. Electrical Wiring Cabinet Loom – page 10
Section 08. Kick Plate Assembly Connections To Electrical Control Panel – page 11
Section 09. Condensate Pump Alarm Cable Connections To Electrical Control Panel - page 12
Section 10. Temperature Air ‘Return’ & ‘Discharge’ Probe Locations – page 13
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June2020
Product Type Meat /Dairy
Maximum Design Ambient 75°F @ 55% RH
Case Length 12’(6 door)
8’(4 door)
6’(3 door)
4’(2 door)
Refrigeration Data – Water Cooled Charge Amounts
Refrigerant Charge per Cabinet (R449A)
1390 grms49 oz
3.06 lb3 lb 1 oz
1190 grms42 oz
2.63 lb2 lb 10 oz
1500 grms53 oz
3.31 lb3 lb 5 oz
1190 grms42 oz
2.63 lb2 lb 10 oz
TXV Orifice size 01 00 00 00
Electrical Data (115v 60 Hz) (Hot , Neutral & Ground) Amps Amps Amps Amps
Fan Motors (EC) 0.42 0.28 0.21 0.14
Compressor Cooling Fan Motors (EC) 0.18 0.18 0.18 0.1.8
Lights (LED) : Doors only 0.97 0.7 0.55 0.41
Controller 0.08 0.08 0.08 0.08
Kick Plate Fans 0.52 0.32 0.37 0.16
Trim Heaters N/A N/A N/A N/A
Condensate Pump (where fitted) 0.08 0.08 0.08 0.08
Electrical Data (208v 60 Hz) ( 2 Hots & Ground) Amps Amps Amps Amps
Condensing Unit 8.8 6.5 6.5 5.6
Defrost Heaters N/A N/A N/A N/A
Combined Single Point Load (MCA – Ref) 12.5 9.01 9.01 7.59
MOPD 15 15 15 15
Miscellaneous Data
Total Heat Rejection (THR) (BTU/hr) 13989 10407 10407 8352
Total Heat Rejection (THR) To Air (BTU/hr) 1024 1024 1024 1024
Total Heat Rejection (THR) To Water (BTU/hr) 12966 9383 9383 7329
Evaporator Case Load THR (BTU/hr) (10°F) 6448 4299 3207 2149
Pressure Drop (psi) 1.27 1.27 1.27 1.27
Total Internal Volume Cu.ft 110 73 55 37
Water INLET Temperature (°F)Optimum Range 65 to 105 - Max Limit 105
Water OUTLET Temperature (°F) Optimum Range 75 to 115 - Max Limit 115
Electrical Connection Top left hand side of case – see plan drawing page 7 for location
Drainage Connection 40mm (1 9/16”) Outlet reducing to 25mm (1”) – see plan drawing page 6 for quantity and location
Note: Specific Heat of Glycol @ 105 °F KJ/Kg – K 4.0425
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 03 of 13Section 01. Cabinet Technical Data Sheet: IG - SCW - TXV
Set – Up Data Meat Dairy
Set Point Temperature (cut in) (F°) 34 36
Differential (below) (F°) 6 4
Evaporating Temperature - Calculated (F°) 23 25
Cabinet Temperature Ratio (air on %) 100 100
Anti – cycle Time (seconds) 180 180
No. Defrosts (per 24hrs) 6 6
Maximum Defrost Time (minutes) 45 45
Defrost Termination Temperature (air off) (F°) 47 47
Drain Down Time (mins) 1 1
Fans in Defrost ON ON
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29-June 2020
Page 04 of 13Section 01. Cabinet Technical Data Sheet: ID – SCW - TXV
Case Length 12’ (6 door) 8’ (4 door) 6’ (3 door) 4’ (2door)
Fan Speed
Evaporator: Run State (RPM) 1300 1300 1300 1300
Evaporator: Defrost (RPM) 1300 1300 1300 1300
Compressor Hitachi Hitachi Hitachi Hitachi
Make & modelZS1120X1
(1.5 H.P)1 off
ZS7516X1(1 HP )
1 off
ZS7516X1(1 HP)1 off
ZS6013X1(0.75 HP )
1 off
Start Capacitor Size (per compressor charger box) 60µF / 450V 40µF / 450V 40µF / 450V 40µF / 450V
Run Capacitor Size (per compressor charger box) 45µF / 450V 30µF / 450V 30µF / 450V 30µF / 450V
Pressure Switch High Pressure Low Pressure
Open (PSI) 410 3
Close (PSI) 310 15
Temperature Sensor
Make & Model CPC 10k
Typical Air Flow At Honeycomb
Air Flow (CuFt /min) 1695 1695 1695 1695
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 05 of 13
Section 02. Cabinet Side View Drawing IG - SCW
Drawing Measurements
Inches Metric Millimetres
Side Profile View
Page 06 of 13
Drawing Measurements
Imperial Inches Metric Millimetres
Section 03. Cabinet Plan View Showing Drain & Foot Locations IG - SCW
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Base Plans
Page 07 of 13
Drawing Measurements
Imperial Inches Metric Millimetres
Section 04. Cabinet Plan View Showing Cond. Assy& Electrical Tray Locations IG - SCW
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Top Plans
Page 08 of 13Section 05. Cabinet Side View Showing Cabinet
Back To Back Island IG - SCW
Drawing Measurements
Imperial Inches Metric Millimetres
Back to Back Island Side View
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 09 of 13
*
Ple
ase
note
: Sam
e s
chem
atic
with O
R w
ithout
condensa
te p
um
p
Section 06. Control Panel - Electrical Schematic IG - SCW
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 10 of 13
Fan Baffle Assembly
Condensate Pump Link Cable
LIGHTS
FANS
PUMP PUMP
L1
NE
E2
1
2
WIRING KEY
LIVE L (1)NEUTRAL N (2)EARTH E (GREEN/YELLOW)
Fan lead wiring color :
White (Live), Green (Neutral) Cut back spare wire (Brown)
Section 07. Electrical Wiring Cabinet Loom IG - SCW
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 11 of 13
Section 08. Kick Plate Assembly Connections to Electrical Control Panel IG - SCW
Section plan view: Electrical Control Panel
A
Electrical control panel location
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 12 of 13
Section 09. Condensate Pump Alarm Cable Connections to Electrical Control Panel IG - SCW
Pump CableCabinet Loom ALM0199
Discharge Hose
Elec
tric
al C
on
nec
tio
n: c
on
den
sate
pu
mp
to
ca
bin
et lo
om
Plan View CONDENSATE PUMP
BLACK : Common
YELLOW: Closed during standby or mains
OFF
RED: Closed during alarm condition
Heat shrink
Alarm Extension Cable
Cables connected to alarm extension cable at
Carter Retail Equipment Ltd
BLACK : (No 2) =
RED : Closed during
alarm condition
BLACK : (No 1) =
BLACK : Common
EARTH : =
YELLOW :
Closed during
standby or
mains OFF
Cut back the EARTH & heat shrink cable
BLACK : (No 1) (common)
BLACK : (No 2) (closed
during alarm condition)
BLACK : (No 1) (common)
Alarm Link Cables
Plan View
Inside Electrical
Control Panel
ORANGE : BL10 Plug & Socket
connection to electrical control panel
Return (air on) probe from cabinet
Discharge (air off) probe from cabinet
BLACK : (No 2) (closed
during alarm condition)
Electrical control panel location
Condensate Pump ALARM cable
Contact Telephone: +44 121 250 1111 IG - SCW Technical Data Sheet Issue 02 29th June 2020
Page 13 of 13
Section 10. Temperature Air ‘ON’ & ‘OFF’ Probe Locations IG - SCW
Side View Front View
Air Discharge
Probe 2
Air Return
Probe 1
Air
Dis
ch
arg
e P
rob
e 2
Air
Re
turn
Pro
be 1
Probes Fitted To
LHS of Cabinet