ftl 10 fuel injection system operation service

CBCAUTO

FUEL INJECTION FUEL INJECTION SYSTEM OPERATIONSYSTEM OPERATION

CBCAUTO

FUEL INJECTION TYPES FUEL INJECTION TYPES THROTTLE BODY INJECTION (TBI)

– INJECTED ABOVE THROTTLE PLATES– SINGLE INJECTOR

CENTRAL PORT INJECTION (CFI)– INJECTED ABOVE THROTTLE PLATES– USUALLY MORE THAN ONE INJECTOR

PORT FUEL INJECTION (PFI)– INJECTORS IN INTAKE RUNNERS

CBCAUTO

TBI UNITTBI UNIT(SOMETIMES CALLED CFI)(SOMETIMES CALLED CFI)

FIRST STEP FROM CARBURETORS

SOME CARB CHARACTERISTICS

LOW PRESSURE MOVEABLE PINTLE PRESSURE IS

REGULATED SERVICEABLE

FIG 6-40 CLASS

CBCAUTO

LOW PRESSURE LOW PRESSURE SYSTEMSYSTEM

CBCAUTO

FUEL INLET AND FUEL INLET AND OUTLETOUTLET

CBCAUTO

LOW PRESSURE FUEL LOW PRESSURE FUEL INJECTORINJECTOR

13-16 PSI TWO O-RINGS BALL PINTLE USED ON TBI

AND CFI SYSTEMS

MESH SCREEN EASY TO

REPLACE

CBCAUTO

TWO INJECTOR SYSTEMTWO INJECTOR SYSTEM

CBCAUTO

PORT FUELPORT FUEL INJECTION INJECTION

INJECTS AT EACH CYLINDER

HIGHER PRESSURE

FED OFF OF FUEL RAIL

MORE EFFICIENT OPERATION

MODES– MULTI-PORT– SEQUENTIAL

CBCAUTO

PORT FUEL INJECTIONPORT FUEL INJECTION

CBCAUTO

CENTRAL POINT CENTRAL POINT INJECTIONINJECTION

GM SYSTEM INJECTOR

LOCATED IN LOWER HALF OF INTAKE MANIFOLD

POPPET VALVES HIGH PRESSURE

60 PSI

CBCAUTO

CONTINUOUSCONTINUOUS INJECTION INJECTION

SPRAYS ALL THE TIME MIXTURE CONTROL UNIT FUEL DISTRIBUTOR CONTROL PRESSURE REGULATOR

CBCAUTO

FUEL PRESSURE FUEL PRESSURE REGULATORREGULATOR

Used on TBI systems

Provides constant fuel supply

Fuel pressure on one side

Fuel pressure opens regulator under a certain pressure.

Spring is calibrated

CBCAUTO

INJECTION SYSTEM INJECTION SYSTEM SERVICESERVICE

CBCAUTO

SYSTEM CHECKSSYSTEM CHECKS ADEQUATE AIR SUPPLY PRESSURIZED FUEL SUPPLY ADEQUATE TRIGGER SIGNAL NO VACUUM LEAKS GOOD IGNITION SYSTEM GOOD ENGINE MECHANICAL GOOD FUEL QUALITY PCM OPERATION

CBCAUTO

FUEL DELIVERYFUEL DELIVERY Fuel Pump

noises Does fuel pump

run at all? Fuel filter

condition? Connections to

fuel pump

CBCAUTO

COMPONENT CHECKSCOMPONENT CHECKS AIR INDUCTION AIR FLOW

SENSORS THROTTLE BODY FUEL SYSTEM

CHECKS FUEL DELIVERY INJECTOR CHECKS INJECTOR

CLEANING

6-61 LAB

CBCAUTO

INERTIA SWITCHINERTIA SWITCH

CBCAUTO

INJECTOR TESTSINJECTOR TESTS ELECTRICAL OPERATION

– VOLTAGE SIGNALS– SCOPE TESTING

MECHANICIAL OPERATION– PINTLE OPERATION– BALANCE TEST– FLOW