winter air crew operations briefing
DESCRIPTION
Winter Air Crew Operations Briefing. Courtesy MN Wing/DO Updated by ND Wing/DO. ND Wing Cold Weather Operations. 60-1 ND Wing Supplement Winter Operations: November 15 Thru April 15 - PowerPoint PPT PresentationTRANSCRIPT
![Page 1: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/1.jpg)
Performing Missions For America
U.S. AIR FORCE A U X I L I A R YU.S. AIR FORCE A U X I L I A R Y
Winter Air Crew
Operations Briefing
Courtesy MN Wing/DOUpdated by ND Wing/DO
![Page 2: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/2.jpg)
D I g I t a l I m a g I n g
ND Wing Cold Weather Operations
60-1 ND Wing Supplement Winter Operations:
November 15 Thru April 15All Wing Pilots operating
aircraft below 0 degrees F. are required to attend an annual cold weather flying course.Safety ProceduresAircraft Operational Requirements in extreme cold weather conditions
![Page 3: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/3.jpg)
D I g I t a l I m a g I n g
Potential Winter Hazards
Aircraft IcingIce build-up at the top of the hangarIce build-up outside the hangar on the hangar ramp Ice on taxi-way or runwaySnow piles obscuring view or contacting wing tipFrost bite pre-flighting or re-fuelingFlooding engineEngine fireSlipping and falling
![Page 4: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/4.jpg)
D I g I t a l I m a g I n g
Aircraft Temperatures & Wind-Chill Limitations
• Temperature: Wind-Chill: Limitation:
• Above 0°F. Above -30°F. None• 0°F. to-20°F. -30°F. to -50°F. 2 Occupant minimum• NO TRAINING,
NO T&G• Actual Missions
ONLY • Below -20° F.Below -50° F. DO Approval ONLY
![Page 5: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/5.jpg)
D I g I t a l I m a g I n g
Aircraft Temperatures & Wind-Chill Limitations
• Temperature: Requirement:
• Below 0° F. Flight Release Officer has to be a pilot
• Below 0° F. Pilot attended annual cold weather flying course
• Below 0° F. Incident Commanders discretion if air support
is required
![Page 6: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/6.jpg)
D I g I t a l I m a g I n g
Winter Kit ( Bug Eyes)
Located in the rear baggage shelf area
Reduces the opening of the cowling and the amount of airflow over the engine
![Page 7: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/7.jpg)
D I g I t a l I m a g I n g
Winter kit ( Bug Eyes)
Pilot is responsible to install the winter kit to the cowling prior to flight when O.A.T is below 20 degrees F. or removal if the temperature is above 20 degrees F.
![Page 8: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/8.jpg)
D I g I t a l I m a g I n g
Engine oil cooler
Located under the engine cover and is visible thru the oil fill access cover
![Page 9: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/9.jpg)
D I g I t a l I m a g I n g
Engine oil cooler restrictor plate
C-172 OnlyOrange colorReduces air flow thru coolerInstalled and removed by MaintenanceN/A 182-T
![Page 10: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/10.jpg)
D I g I t a l I m a g I n g
Engine Heater & Blanket
Aircraft are RequiredTo have the following 24/7 when
not in use:Tannis heater plugged inInstall engine blanket
This is required regardless of the date, any time the forecast ambient temperature is to be less than 30 degrees F. for more than a 24 hr. period
If plug-in is not available, engine MUST be preheated either by Tannis heater or an external heater before attempting a start.
![Page 11: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/11.jpg)
D I g I t a l I m a g I n g
Pre-Flight
Following snow conditions, be extra careful on pre-flight to check:Inside pitot tubeStatic openingFuel ventsHeater intakeCarburetor air intakeTrim tabs and controlsTires & BrakesEngine oil Level
![Page 12: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/12.jpg)
D I g I t a l I m a g I n g
Engine Oil Level
C-172 6 Quarts
C-182 8 Quarts
Overfilling just blows out
![Page 13: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/13.jpg)
D I g I t a l I m a g I n g
Engine Crankcase Breather Tube
Located under the belly at the rear by firewallCheck for any Ice or other blockage
![Page 14: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/14.jpg)
D I g I t a l I m a g I n g
Pitot Tube
Check for any restriction Check Pitot Heat
![Page 15: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/15.jpg)
D I g I t a l I m a g I n g
Tire Inflation
Use a Tire Gauge to Check Prior to Each FlightPressure listed on gear strut and cover of Aircraft Information File
![Page 16: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/16.jpg)
D I g I t a l I m a g I n g
Nose Strut
Check Clearance 3 fingersCheck for cracksCheck linkage
![Page 17: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/17.jpg)
D I g I t a l I m a g I n g
Stall Horn
Check OperationSuction OperatedCheck for Restriction
![Page 18: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/18.jpg)
D I g I t a l I m a g I n g
Brakes
Check padsCheck fluid leaksRotor thicknessCheck for IceKeep out of slush
![Page 19: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/19.jpg)
D I g I t a l I m a g I n g
Plan for the Unexpected
Survival Kit (kit shown is not our kit)
3 Lbs of additional weight
Supplemental EquipmentCell PhoneGlovesHatBootsJacket
![Page 20: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/20.jpg)
D I g I t a l I m a g I n g
Carbon Monoxide Detector
Carbon Monoxide Detector colorDateCheck exhaust
![Page 21: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/21.jpg)
D I g I t a l I m a g I n g
Power Off Maneuvers
• Temperature: Limitations:
• 0° F. to +10° F. 1500 RPM or 15” of Manifold Pressure
• Avoid Shock Cooling
![Page 22: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/22.jpg)
D I g I t a l I m a g I n g
Cold Weather Engine Starting
General rule for engine starters: after three, 10-second periods of operation, with a
pause between each, a five minute cooling period is requiredFailure to observe this can lead to starter overheating and damage/failureDO NOT Continue cranking until the battery is dead. This can cause a battery to freeze over a short period of time depending on the temperature.
![Page 23: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/23.jpg)
D I g I t a l I m a g I n g
Engine Priming
PRIMING IS NOT NECESSARY if the A/C is plugged in & or in a heated hangar. Standard Procedure is NO PRIMING on C172!If the A/C has been out on the ramp and has cooled down, A slight amount of priming may be necessary. One pump! No More than Two!However, DO NOT OVERPRIME! This can lead to engine fire! flooding, washing down the cylinders and oil contamination.Throttle position should be slightly closer to idle position, on start-up, because of colder, more dense air
![Page 24: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/24.jpg)
D I g I t a l I m a g I n g
Engine Start up
After start, DO NOT IDLE BELOW 1000 RPM - Cold temperatures increase probability of lead fouling of plugs.SLOWLY INCREASE THROTTLE. Too rapid of a throttle increase will cause the engine to stall in cold weather.Exercise constant speed props to prevent congealing of oil in prop dome
![Page 25: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/25.jpg)
D I g I t a l I m a g I n g
Engine Operation
Allow extra time for oil to warm up after startup. 10-15 minutes at idle (1000 RPM) may be required to bring oil to minimum operating temperature
![Page 26: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/26.jpg)
D I g I t a l I m a g I n g
Engine Operations
Plan descents earlierReduce power graduallyMaintain power throughout descentKeep fuel/air mixture leaned during descentUse Carburetor heat as required
![Page 27: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/27.jpg)
D I g I t a l I m a g I n g
Fuel Considerations
Exercise special caution regarding any possible water contamination of fuel - water can freeze in fuel line; drain tanks and sumpCheck fuel selector valve for freedom of movement; statistics document cases of frozen selectorKeep tanks full (or to the level indicated in the NDWg Supplement to CAPR 60-1) to prevent moisture or frost inside tank
![Page 28: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/28.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
FAR 91.527 Operating in icing conditions.(a) No pilot may takeoff an airplane that has-
(1)Frost, snow, or ice adhering to any propeller, windshield, or power plant installation or to an airspeed, altimeter, rate of climb, or flight attitude instrument system;(3)Any frost adhering to the wings or stabilizer or control surfaces, unless that frost, has been polished to make it smooth.
![Page 29: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/29.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
Assuming that a thin coating of frost or ice is of no consequence, or that snow will blow off during takeoff is asking for trouble!Frost/snow/ice on wing and tail surfaces during takeoff has been a contributing factor in several aircraft accidents.
![Page 30: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/30.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
All frost/snow/ice should be removed before attempting flight
For frost or ice, place aircraft in heated hangar, if possible (be sure water doesn’t run into control surfaces & re-freeze when aircraft is brought outside again)If no hangar is available, face aircraft control surfaces towards the sun to utilize/maximize radiation heating
![Page 31: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/31.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
For snow, brush off (don’t count on snow blowing off during takeoff roll!)Note: Sometimes frost adheres to surfaces below snow coveringAlcohol, glycol or other ice-removal chemicals can be usedExercise extra care when warm aircraft has been pulled from hangar and left out in snow conditions
![Page 32: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/32.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
“Unseen Frost”
Same conditions which cause frost formation on external surfaces can cause internal problemsMoisture in fuel tanks can freeze (good reason for topping tanks after flight) and can cause blockage of fuel flow to engine
![Page 33: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/33.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
Typically, even small buildup of ice can cause 30% reduction in maximum coefficient of lift, decreasing the stall angle-of-attackDrag builds up, and if it exceeds max. thrust (full throttle), leads to descent, whether desired or not!Thrust also lost due to ice accumulation on propeller
![Page 34: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/34.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
First place ice accumulates is small-radius or sharp-edged surfaces (fuel vent, temp. probe, etc)Small leading edge on tail surfaces make them more efficient collectors of ice (almost twice as fast as wing ice accumulation); tail may reach stall angle-of-attack before wing becomes problem
![Page 35: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/35.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
Since horizontal tail produces “down” lift, stall results in tail going up, and aircraft nose pitching downFlap deflection increases downwash on tail, leading to higher (more negative) angle-of-attack, and earlier stall, if tail is iced
![Page 36: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/36.jpg)
D I g I t a l I m a g I n g
Frost-Snow-Ice
Allow extra time for pre-flight planning, aircraft preparation and engine warm-upUnderstand the effects that frost, snow and ice have on an aircraftWhen flying in cold weather, keep in mind the impact that the temperature has on the aircraft and plan maneuvers accordinglyAvoid flight in/through visible moistureFly Safe!!
![Page 37: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/37.jpg)
D I g I t a l I m a g I n g
Check Overhead Hazards
Check for overhead Ice or Snow Build-up prior to opening up
the hangar door
![Page 38: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/38.jpg)
D I g I t a l I m a g I n g
Hangar Access
Remove snow as soon as possible to prevent frozen snow ridges and create a
safety hazard
Aircraft should be able to get in and out of hangar & ready for a
mission
![Page 39: Winter Air Crew Operations Briefing](https://reader036.vdocuments.us/reader036/viewer/2022062409/568148e0550346895db5f9e2/html5/thumbnails/39.jpg)
D I g I t a l I m a g I n g
Cold Weather Operation
Questions?