tech news no. 70 – nov ‘03
TRANSCRIPT
Page 28 of 47
Recent ‘Technical News’ Reprints – Daytona 955i & Speed Triple
Tech News No. 70 – Nov ‘03
Page 45 of 47
Fault Finding
Symptom Possible Cause(s)
Poor starting Check Crank Pick-up sensor resistance and air gap
Running on one cylinder Check appropriate ignition coil
Poor running Check valve timing correct
Bike will start but not rev / fuel starvation
Ensure fuel tank breather hose not kinked, particularly if tank has been removed
Poor running / cutting out
Ensure Airbox inlet rubbers correctly fitted and not kinked or tucked
Rev Limiter appears to be cutting in at too low revs
Check crankshaft sensor air gap not too wide
Intermittent cutting out, glowing MIL, poor running. ossible blown fuses. P
Water ingress into main harness connector plug causing oxidisation. Clean connections if possible. If oo far gone, replace harness t
Abnormally high fuel pressure Check Fuel pressure regulator operating correctly
M IL Flickering - no DTC L oose battery (power) connection
P0462 Fault code appearing for fuel sender
This is due to the configuration of the earth wires in the harness, and the volt drops induced by the current flowing in these wires, causing the ECU to read an input voltage outside of the valid range for the fuel level sender.
To overcome this, the fuel level sender earth needs to be removed from its current location and tied directly in to the ECU ground. A solution has been tested to good effect. Please contact Triumph’s Technical team for further assistance
Oil dripping from air-box breather hose / Centrifugal breather disc leaking
Check breather disc is mounted squarely to crank Ensure run out does not exceed 0.2mm Ensure seal fitted correctly
Poor front brake performance Ensure air has not been induced during shipping – bleed & test
Page 46 of 47
Triumph Daytona 955i Accessories Available:
- Aftermarket Silencer – Carbon High Level * (A9608047) - Aftermarket Silencer – Carbon Std Level * (A9608049) - Aftermarket Silencer – Stainless Std Level * (A9608033) - Alarm / Immobiliser (A9808059) - Sports Tank Bag (A9510023) - Sports Throwover Panniers (A9518026) - Union Flag Cockpit – Yellow (A2304806-ZFAA) - Union Flag Cockpit – Red (A2304806-ZCMA) - Union Flag Cockpit – Black (A2304806-ZPGA) - Rear Hugger (A9748002) - Aero Screen (upto ’04) (A9708050) - Aero Screen (’04 on) (A9708067) - Carbon Tank Pad (A9720009) - Gel Front Seat (A9701157) - Gel Rear Seat (A9701158) - Luggage Rack (A9758035) - Grab Rail (inc OE Rear Seat) (A9758034) - Grab Rail (inc Gel Rear Seat) (A9758050) - Frame Protectors (A9728001) - Axle Nut Cover (A9648000) - Paddock Stand (A9750037) - Front Mudguard Extension (A9708051) - Chain & Sprocket Kit (A9618003) - Service Manual (T3850595) - Dust Cover (A9930060)
* Note this product does not conform to EPA noise standards. Use on motorcycles subject to EPA regulation constitutes
tampering and is a violation of federal law. This product is designed for close circuit competition use only
Page 47 of 47
Triumph Speed Triple Accessories Available:
- Aftermarket Silencer – Carbon High Level * (A9600109) - Aftermarket Silencer – Carbon Std Level * (A9608042) - Aftermarket Silencer – Stainless Std Level * (A9608032) - Alarm / Immobiliser (A9808050) - Sports Tank Bag (A9510023) - Sports Throwover Panniers (A9518026) - Custom Paint Kit – Tornado Red (A9708125-ZCMAA) - Custom Paint Kit – Roulette Green (A9708125-ZHGAA) - Custom Paint Kit – Jet Black (A9708125-ZPGAA) - For individual Custom Painted parts see Accessories Catalogue - Rear Hugger (A9748002) - Fly Screen (A9748008-##) - Seat Cowl (A9708040-##) - Radiator Cowls (A9748018-##) - Belly Pan (A9708052-##) - Carbon Tank Pad (A9720009) - Gel Front Seat (A9701157) - Gel Rear Seat (A9701158) - Luggage Rack (A9758035) - Grab Rail (inc OE Rear Seat) (A9758034) - Grab Rail (inc Gel Rear Seat) (A9758050) - Frame Protectors (A9728001) - Axle Nut Cover (A9648000) - Paddock Stand (A9750037) - Front Mudguard Extension (A9708051) - Chain & Sprocket Kit (A9618003) - Service Manual (T3850595) - Dust Cover (A9930060)
## Add paint code – Tornado Red (CM), Jet Black (PG), Roulette Green (HG)
* Note this product does not conform to EPA noise standards. Use on motorcycles subject to EPA regulation constitutes
tampering and is a violation of federal law. This product is designed for close circuit competition use only