saline ground water resource development in nm - bt eds - temp/saline ground water... · •current...
TRANSCRIPT
Saline Ground Water Resource Development in NM: Issues & Challenges Bruce Thomson
Civil Engineering Water Resources Program
UNM ([email protected])
November 21, 2008 Introduction
•Demand for water by municipalities & industry leads to increased willingness to pay for water
•Improvements in treatment technologies, including desalination, lead to reduced costs
•NM water laws that may not cover saline water sources
•Convergence of these 3 factors lead utilities to consider low quality water as potential source:
•Wastewater for reuse
•Brackish & saline water Concern
• Many developments have little consideration of sustainability
• Typical projects propose extraction of small fraction of the total resource - yet aggregate of multiple projects can be large fraction
• Short planning horizon - NM Subdivision Act gives Counties authority to establish water supply reqts. Range is 40-100 yrs.
• Five large brackish/saline water development projects under consideration at present (Tularosa Basin, Salt Basin, Bernalillo Co., Sandoval Co., Gallup). Objectives of Presentation
• Saline water considerations - case study:
•Size of the resource
•Amount that can be recovered
•Potential impact on future generations
• Consider desalination issues
•Recovery
•Fouling
•Brine disposal
•Energy
•Consider policy issues Saline Water Resources Case Study: Estancia Basin Brackish/Saline Water Sources in NM
Time
Unit
Co
st
Willingness to Pay
Treatment Cost
2
•~75% of ground water in NM is brackish/saline (Reynolds, 1962) Location Map
NM Population Projections (BBER, 2007)
•Steady growth
•Basin pop is small relative to ABQ & SAF
Cost of Water in Central NM
•Pre-1907 rights sell for >$30K/AF
•If consumptive use = 100 gpcd = 0.112 AF/yr-person
•$3,300/person to purchase rights for new development
•Total cost of rights for new residents in Central NM ~ $1.5B by 2035 Uncertain Status of Brackish/Saline Water Rights
•State Engineer doesn’t have authority over water that is:
•Depth > 2,500 ft
•TDS > 1,000 mg/L
0.0E+00
5.0E+05
1.0E+06
1.5E+06
2.0E+06
2.5E+06
3.0E+06
3.5E+06
2000 2010 2020 2030 2040
Year
Po
pu
lati
on
New Mexico
Mid Rio Grande
Estancia Basin
3
•State Engineer does have jurisdiction if development of deep or saline water will impact fresh water resources
•Lots of work for hydrogeologists!
Case Study Estancia Basin (Estancia Basin Water Plan Update, 2008) •2260 mi2
•~40 miles east of Albuquerque
•Topographically closed basin
•Ground water flow to SE
•Elev. 6,000 - >10,000 ft
•~38,000 residents
•97% of water used for ag
•Playa lakes
•Brackish water east of HW 41 (Shear zone) Principal Water Bearing Formations
Water Bearing Unit Saturated Thickness (ft) Specific Yield Avg. Saturated Thickness (ft)
Valley Fill 50 to 325 0.125 131.6
San Andres Limestone 50 to 150 0.01 117.9
Glorieta Sandstone 50 to 215 0.15 125.5
Yeso Formation 35 to 800 0.1 363.3
Abo Formation 100 to 800 0.1 60.9
Madera Group 100 to 1,165 0.01 903.8
Mildly brackish 1,000 - 5,000 mg/l
Moderately brackish 5,000 - 15,000 mg/l
Heavily brackish 15,000 - 35,000 mg/l
Seawater and Brine > 35,000 mg/l
4
Stratigraphy
Annual Depletion
•Current GW depletion ~110 KAF/yr
•Basin plan calls for reduction to 20 KAF/yr by 2040 in valley fill
•Model predicts > 60 ft drawdown in pumping centers
Summary of Brackish Water Export Proposal
•Construct wells in eastern side of basin
•Extract 7200 AF/yr
•Construct desalination plant & pipeline to Santa Fe (~75 miles)
•Estimated project cost = $100 M ($14/KAF)
•$120 M profit at $30/KAF for water
Water Bearing Unit Ground Water in
Storage (MAF)
Depletion Rate
(KAF/yr)
Avg. Saturated
Thickness (ft)
Valley Fill 6.58 52.1 131.6
San Andres Limestone 0.067 N/A 117.9
Glorieta Sandstone 5.85 N/A 125.5
Yeso Formation 23.8 N/A 363.3
Abo Formation 44.9 N/A 60.9
Madera Group 11.1 61.2 903.8
5
Limited Water Quality Information (Hawley, from Smith)
WELLS IN RANGE 8 E ELECT. COND. WELLS IN RANGE 10 E ELECT. COND.
05N.08E.15.131 380 05N.10E.13.443 4,210
05N.08E.17.323 619 06N.10E.05.300 3,010
05N.08E.24.311 416 07N10E.19.112 6,640
06N.08E.11.420 541 07N.10E.19.411 6,920
06N.08E.09.112 553 07N.10E.30.411 4,820
06N.08E.32.113 465 08N.10E.14.111 3,050
07N.08E.20.342 834 08N.10E.36.241 4,410
08N.08E.10.111 547 09N.10E.18.411 3,450
09N.08E.14.200 997 09N.10E.18.233 3,350
10N.8E.23.144 614 10N.10E.32.333 3,630
Water Chemistry Will Present Desal Challenge
•High hardness
•High SO42-
•Moderate Si
Siavg = 19.4 mg/L Simax = 30.4 mg/L
6
Recharge & Salinity (Shafike & Flannigan, 1999)
•Virtually all recharge is from mountain front on west
•Salinity principally due to concentration by evaporation
•Confirms little recharge from east
•No recharge studies in east Drawdown Is Increasing Salinity of Existing Wells TDS 1948-1966 TDS 1977-2001
Observations from Estancia Valley Proposal
•Very large economic incentives to develop alternative sources - “New Water”
•Estancia Basin case study offers several important observations:
•Largest users are agriculture - 97%
•Ground water resources are currently being depleted
•Good ground water model exists, but little understanding of salinity issues
•Limited administrative authority to curtail ground water use Desalination Issues
Desalination
•Traditional application - Removal of salts from sea water.
•Current interests - Remove all dissolved constituents from source water (including organics)
•Interest in desalination technologies for advanced wastewater treatment for indirect (& possibly direct) potable reuse Seawater vs. Inland Desalination
•Much experience & familiarity with seawater desalination
7
•Limited understanding & appreciation of differences of inland desalination
•Important differences include:
•Feed water recovery objectives
•Water chemistry & fouling
•Brine disposal options Desalination Technologies (NAS, 2007)
•Membrane technologies - RO, EDR
•Phase transfer technologies - Variations of distillation including thermal distillation, multistage flash distillation, multiple effect distillation, vapor compression
•Ion exchange Thermal vs Membrane Desalination (NAS, 2008)
Types of membranes in water treatment
Electrodialysis Reversal (EDR)
•Uses electrical potential as driving force instead of pressure
•Only removes ionic constituents
•Less energy consumption than RO if TDS < 3500 mg/L
Microfiltration
Ultrafiltration
Nanofiltration
Reverse osmosis
Incre
asin
g p
ressure
Decre
asin
g p
ore
siz
e
Mem
bra
ne
filtra
tion
Revers
e
osm
osis
~ 0.1 µm pores
~ 0.01 µm pores
~ 0.001 µm pores
non-porous
Particles Sediment Algae Protozoa Bacteria
Small colloids Viruses
Dissolved organic matter Divalent ions (Ca
2+, Mg
2+)
Ionic Species (Na+, Cl
-)
Water
8
•Not widely used Reverse Osmosis
•Use pressure to force water through semi-permeable membrane - considered diffusion of H2O molecules through membrane, not filtration
•Osmotic pressure - depends on ionic concentration & nature of ions
•π = Pressure (bar)
•i = Conc. of ions (mol/L)
•T = Temperature (K)
•φ = Osmotic coefficient (depends on solute) Osmotic Pressure
•Determined by thermodynamics - not membrane characteristics
RO Process
•Important terms
•Permeate - Water that passes through membrane
•Concentrate (Brine) - Solution containing retained solutes
•Recovery - Fraction of feed water recovered as permeate
•Rejection - Fraction of solutes not passing through membrane
RO Process
Spiral wound membrane cartridges
RTiφ=π
P
FeedWater
Permeate
BrineRecycle
RO Modules
Module 1
Module 2
Module 3
Cartridge Filter
9
3 Major Differences Between Seawater & Inland Desalination
•Feed water recovery
•Membrane fouling
•Brine disposal Feed Water Recovery Feed Water Recovery
•Recovery (r) = Fraction of feed water recovered as permeate
•Concentrates dissolved salts
•If rejection ~100%:
•High recovery = High conc. of solutes in concentrate
•Objective of inland desalination is high recovery
Recovery
•Consequences of high recovery
•High osmotic pressure
•Reduced quality of permeate - leakage through RO membrane proportional to feed water quality
•Concentrations of dissolved salts may exceed solubility limits = fouling due to precipitation
•Sea water:
•Unlimited supply hence recovery is less important. Recovery is determined by equipment limits & process economics, not value of water.
•Solutes are Na+ & Cl- - Low inorganic fouling potential Membrane Fouling
Membrane Fouling
•Fouling = Accumulation of material on membrane that reduces flux through membrane.
•Four types:
•Colloidal fouling
•Inorganic fouling
•Organic fouling
•Biological fouling
•Low quality ground water may contribute to all four.
•Most challenging is often inorganic fouling
−=
r1
1CC fc
0
5
10
15
20
25
0 20 40 60 80 100
Recovery (%)
Cc
on
ce
ntr
ate
/Cfe
ed
10
Inorganic Fouling Minerals
Precipitate log Kso Equil. Cation Conc. (mg/L) Equil. Anion Conc. (mg/L)
CaCO3 -8.48 60 751
CaSO4.2H2O -4.58 205 492
SiO2 -2.71 116 -
CaHPO4 -6.6 20 15.62
1 – Concentration of HCO3- in units of mg CaCO3/L 2 –Other phosphate phases such as apatite (Ca5(PO4)3OH) are several orders of magnitude less soluble than CaHPO4. 3 – Ignoring ionic strength and complexation effects.
Seawater vs. Ground Water
ABQ ground water has silica from < 20 mg/L to > 60 mg/L Inorganic Fouling - UNM Tap Water
Brine Disposal
Concentrate Disposal Options
•Seawater desalination disposal options
•Return to sea
•Inland desalination disposal options (NAS, 2008)
•Discharge to surface water
•Evaporation ponds
•Land application
0.0
0.5
1.0
1.5
2.0
2.5
3.0
0 50 100 150 200 250 300 350 400
Run Time, hr
Sp
ec
ific
Flu
x,
L/m
2-h
-ba
r
Module 1
Module 3
Module 2
Mg2+
9%K
+
4% Na+
10%
SO42-
26%
HCO3-
11%
Cl-
9%
Ca2+
31%
Tularosa Basin, NM
TDS = 2,860 mg/L
K+
0.9%
Na+
41.6%
Mg2+
5.1%
Ca2+
0.0
SO42-
3%
HCO3-
0.2%
Cl-
0.5
Seawater
TDS = 35,400 mg/L
11
•Deep well injection
•Landfill of solid wastes Municipal Concentrate Disposal Practice (Mickley, 2006)
Concentrate Disposal Considerations
•Very high TDS
•Concentrated by 4x at 75% recovery
•High concentrations of toxic constituents present in feed water (As, Se, U, etc.)
•Reduced evaporation of salt saturated solutions
•High TDS solutions are corrosive
•Impacts on deep well injection
•Corrosion of equipment & well screens
•Precipitation & cementing of subsurface formations Brine Disposal Case Study - Phoenix
•Study of disposal options for 20 Mgd concentrate stream
•Evaporation ponds
•10 square miles in area
•Total capital cost = $410,000,000
•Pipeline to Gulf of California
•184 miles of 30- to 60-inch pipeline, additional distance through existing canal
•Would require approval from Mexico
•Total capital cost = $456,000,000 (includes Tucson)
Energy Considerations
Energy & Environmental Considerations
•A 5 MGD facility treating 2,000 mg/L TDS water to 85% recovery:
•Feed pressure will be about 250 psi.
•Power requirement for the feed pumps (85% eff) will be 12,600 kWh/day.
•Using Albuquerque’s electricity profile, CO2 emissions will be 15,800 lbs CO2/day.
•A 60 MGD facility treating 10,000 TDS water to 75% recovery:
•500 psi; 340,000 kWh/day; 430,000 lbs CO2/day.
Unreported
7%Land
Disposal
2%Evaporation
Ponds
2%
Injection
Wells
17%
Sewers
31%
Surface
Waters
41%
12
Random Points
•Cost - Design study for 5 Mgd system in NM (TDS ~12,000 mg/L)
•Capital cost =$143M
•Total cost of water = $8.50/1,000 gal
•Caution
•Design should be based on water demand (i.e. water delivered to houses) not consumptive use
•Can design for consumptive use if wastewater is recycled back to RO plant for reuse Desalination Conclusions
•Desalination technology offers great potential for water & wastewater treatment.
•3 important differences between seawater & inland desalination:
•Recovery - Inland desalination will only recover 50 - 75% of feed water.
•Fouling - Ground water has higher potential for fouling by Ca and Si minerals than seawater
•May limit recovery
•Adds complexity to O&M
•Brine disposal is challenging for inland systems
•Process is energy intensive Policy Issues
Jurisdiction
•State Engineer doesn’t have authority over deep non-potable water
•Top of formation > 2,500 ft
•TDS > 1,000
•Claimant must prove that these conditions exist.
•Who owns the water?
•Landowner?
•Mineral rights owner?
•First person to drill?
•Atrisco Oil & Gas v. SunCal v. Sandoval County Sustainability
•Term is widely used but has many different definitions
•Brundtland Commission (1987) - “Meets needs of the present without compromising needs of future generations”
•ASCE Committee on Sustainability - “Sustainable water resources systems … contribute to objectives of society now & in the future while maintaining ecological, environmental, & hydrological integrity.”
•My perspective - Future generations will have supply to support quality of life & economy similar to that which exists today Non-renewable Resources
•Extraction of non-renewable resources has been practiced forever:
•Minerals
•Fossil fuels
•However, is water a fundamentally different resource?
• Essential for life, there is no alternative!
13
Conclusions
“New” Water
•“It’s a new source of water.” - Peter Sanchez, ABQ Journal 11/9/8
•“The implications for Sandoval County are huge” - Jack Thomas, ABQ Journal, 11/1/8
•It’s not “new” water. It’s very old water, and probably not renewable. Possible Roles for Saline Water Resources
•Water resource is limited but may be appropriate for drought reserve
•Mineral resources - CaSO4, etc.
•Formation has value:
•Reservoir for aquifer storage & recovery (ASR)
•Waste disposal Saline Water Resources
•Better characterization of saline resources
•Quantity
•Quality
•Recharge
•Hydrology & hydraulics Technology Needs
•Better desalination technology
•Recovery
•Fouling
•Brine disposal
•Energy requirements Jurisdiction & Planning
•State Engineer must be given authority over deep saline water resources
•ABQ Journal candidate profiles in May - 71% supported authority, 18% opposed
•Yet provision repeatedly fails
•Subdivision laws, ordinances and policy need to consider sustainability of water (& possibly other resources)
•If saline supply is used for supply, credible plan must be included to provide sustainable supply Sustainable Future or Delayed Disaster?
14
Acknowledgments
•John Hawley - Hawley Geomatters
•Kerry Howe - UNM
•Nabil Shafik - NM Interstate Stream Commission
•Based largely on presentations at NGWA conference on Nonrenewable Ground Water Resources, Portland, OR, 2008