proton cataloguerustrade.org.uk/eng/wp-content/uploads/led-traffic-lights.pdf ·...

JSC PROTON

PROTON

Orel www.proton-orel.ru

LED traffic

management products

Catalogue

2013

http://www.proton-orel.ru/

PROTON

JSC “PROTON”

302040,Russia,Orel,Leskova 19 str.

Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03

E-mail: [email protected], www.proton-orel.ru

LED TRAFFIC LIGHTS ADVANTAGES

Variable fastening

horizontal

vertical

Light module

The most bright LEDs don`t

require operation expenses

Vandal resistant

Polycarbonate package

Concave lenses Special design provides high luminous flux distribution uniformity on the whole emitting surface

Uncoloured lens excludes

the possibility of false signal Wide temperature range from -60 to 60 ̊C

Package material

High impact polycarbonate

Block design enables to build traffic light construction desired (with or without additional unit)


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED TRAFFIC LIGHT type Т.1.2-CP

Description LED traffic light of Т.1.2-CP type is the cross breed, that combined street-traffic control light of Т.1.2 type

( diameter of signal exit aperture 300 mm) with countdown panel (CP).

LED traffic light consists of three modules of green, red and yellow light. Yellow module combined with

countdown panel. Countdown panel displays time left to red or green lighting. The time of green signal

displayed by green figures lighting, the time of red signal displayed by red figures lighting

.

Combined application of traffic light and countdown panel enables to decrease the amount of road accidents.

Traffic light board supplied with Smart Mode, automatically fit into time modes of traffic light controller, works

with any type of controller.

Switch-in accomplishment is according to marking on connector block inside the package of traffic light.

Basic characteristics

Supply voltage: ~220 V from traffic controller signals

Working temperature range: from - 60ºС to + 60ºС

Amount of countdown panel regimes : 2

Axial lighting force of one red-signal or green-signal bit , not less: 300 cd

Axial lighting force of one yellow-signal bit, not less: 400 cd

Power consumption, not more: 35 W

Maximum counting time of countdown panel: 99 sec

Durability, not less: 12 years

Warranty: 5 years

Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED Traffic Lights

«CP-200G», «CP-200G-24», «CP-300G»,

«CP-200R,G», «CP-200R,G-24», «CP-300R,G»

Description LED traffic light is two-digit countdown panel of green and red lighting or green lighting in the package (pic 1).

One-colour digital panel (CP-200/300G) of green lighting can be installed to traffic light as additional informational

element and displays the time left to green lighting (pic 2).

Two-colour digital panel (CP-200/300RG) of red or green lighting installs to pedestrian traffic light as additional informational element and displays the time left to red or green lighting (pic 3).

Panel CP-200G, CP-300G, CP-200R,G, CP-300R,G designed to function with supply voltage 220 V 10% of alternate current 50 Hz. Panel CP-200G-24, CP-200R,G-24 designed to function with supply voltage 24 V 10% of direct current. Traffic light board supplied with Smart Mode, automatically fit into time modes of traffic light controller, works with any type of controller in parallel connection to traffic light section.



Working temperature range from - 60оC to +60оC Axial lighting force of one signal bit not less 50 cd Power consumption not more 24 Wt Maximum counting time 99 sec Lens diameter 200 or 310 mm Warranty 5 years Durability not less 12 years

pic 2 pic 3

pic 1


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED PEDESTRIAN TRAFFIC LIGHT type P.1.1-CP

Description LED pedestrian traffic light of P.1.1-CP type is the cross breed, that combined pedestrian traffic light of P.1.1

type and countdown panel CP.

Traffic light consists of two modules - green (walking man image) and red (standing man image).

Standing man image of red lighting combined with countdown panel, that displays time left to green lighting.

Combined application of traffic light and countdown panel enables to decrease the amount of road accidents

and especially accidents with pedestrians.




Supply voltage ~220 V from traffic controller signals

Amount of countdown panel regimes 2

Lens diameter 200 mm

Axial lighting force of signal bit, not less 50 cd Power consumption, not more 18 Wt Maximum counting time of countdown panel 99 sec

Working temperature range from - 60ºС to + 60ºС

Warranty 5 years

Durability, not less 12 years

Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED pedestrian traffic light type P.1.1-CPA

Description

LED pedestrian traffic light of P.1.1-CPA type is a cross-breed that combined pedestrian traffic light of P.1.1

type (diameter of signal exit aperture 200 mm) with countdown panel and audio signal for blind or partially

sighted people.

LED pedestrian traffic light consists of two modules of green (walking man image) and red (standing man

image) lighting. Standing man image of red lighting combined with countdown panel that displays time left to

green lighting. Traffic light utilizes animation features while green light working (walking man motions imitation).

Green lighting is synchronized with intermitted audible signal. Closer to the end of green lighting animating and

signaling frequency increase.

Combined application of traffic light and countdown panel enables to decrease the amount of road accidents

and especially accidents with pedestrians.



Basic characteristics Supply voltage ~220 V from traffic controller signals


Lens diameter: 200 mm

Axial lighting force of one signal bit, not less 50 cd Power consumption, not more 18 Wt Maximum counting time of countdown panel 99 sec

Audio signal frequency 2300 ±15% Hz Audio level 90 dBA Working temperature range from - 60ºС to + 60ºС

Warranty 5 years


Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED traffic light Т.3.1

Advantages over lamp equivalent

- long exploitation period - 100 000 hours

- lower power consumption (4 Wt per section) – economy up to 80% in comparison to incandescent lamp.


Supply voltage, V 220 V, 50 Hz

Power consumption of each colour , Wt, not more

4

Emitting colour red, yellow, green

Lighting force, Cd, not less 20

Lens diameter, mm 100

Working temperature range, ºС

from – 60 to +60

LED traffic light Т.3.1 (diameter 100 mm)

designed as type 1 traffic lights

transponder in case of observation

difficulty to the driver standing right close

to the stop line.

LED traffic light T.3.1 can be applicated

to manage bicycle traffic in the road

sections crossed by bicycle lane.


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED tramway traffic light Т.5.1

Description

LED traffic light Т.5.1 (tramway traffic light) designed to manage tramway traffic and generally installed at the

low visibility sectors, excessive gradients, at the entrance/exit of tramway depot and before tramway points

and crossing.

The main purpose of the tramway traffic light is signaling tramway drivers of the sector occupancy after the

traffic light. LED traffic light T.5.1 is for the tramway use only.

Tramway traffic light is Т-shaped with four round moon-like white colour signals. Upper signals displays the

directions permission to go (left, forward, right). Lower signal permits motion start.

Advantages over lamp equivalent

- long exploitation period - 100 000 hours

- lower power consumption (4 Wt per section) – economy up to 80% in comparison to incandescent lamp.


Supply voltage, V 220 V, 50 Hz

Power consumption of each colour , Wt, not more 4

Emitting colour moon-like white

Lighting force, Cd, not less 50

Lens diameter, mm 100

Working temperature range, ºС from – 60 to +60


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED TRAFFIC LIGHT type Т.1.2-CP-F

Description LED traffic light consists of three modules of green, red and yellow light. Red and green modules are

combined with two-digit countdown panel in the yellow module of the traffic light displaying time left to green

or red lighting.


with any type of controller

According to customer`s demand the traffic light can be accomplished by additional contour screen.



Supply voltage 220 V15% from traffic

controller

Power consumption

Red module not more 26 W

Yellow module not more 11 W

Green module not more 20 W

Working temperature range from - 60ºС to +60ºС


Axial lighting force

Red not less 300 cd

Yellow not less 400 cd

Green not less 300 cd

Maximum counting time of countdown panel 99 sec

Dimensions not more 1155х410х110 mm

Warranty 5 years

Durability not less 12 years

Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED PEDESTRIAN TRAFFIC LIGHT type P.2.1-CPА-F

Description LED traffic light consists of two modules displaying walking man image of green lighting and standing man image of

red lighting. Walking and standing man combined with two-digit countdown panel of corresponding lighting colour

and showing the time left to lighting.

LED traffic light is additionally upgraded by audio device for partially sighted pedestrians.

Traffic light board supplied with Smart Mode, automatically fit into time modes of traffic light controller and works with

any type of controller.


Combined application of traffic light and countdown panel enables to decrease the amount of road accidents and

especially accidents with pedestrians.


Supply voltage 220 V15% from traffic

controller

Power consumption Red module not more 12 Wt

Green module not more 10 Wt



Axial lighting force of one signal bit Red not less 50 cd



Audio signal frequency (2300 ±15%) Hz

Audio level not less 90 dBA


Durality not less 12 years

Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED PEDESTRIAN TRAFFIC LIGHT type P.2.1-CPА-F1

Description LED traffic light consists of two modules displaying walking man image of green lighting and standing man image of

red lighting. Walking and standing man combined with two-digit countdown panel of corresponding lighting colour

and showing the time left to lighting.

Traffic light board supplied with Smart Mode, automatically fit into time modes of traffic light controller and works with

any type of controller.





Supply voltage ~220 V15% from traffic

controller

Power consumption Red module not more 12 Wt

Green module not more 10 Wt



Axial lighting force of one signal bit Red not less 50 cd




Warranty 5 years


Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED TRAFFIC LIGHTS

«CP-150R,G-3», «CP-150G-3»

Description LED traffic light «CP-150» is three-digit countdown panel of red/green lighting and green lighting.

Two-colour «CP-150R,G-3» or one-coloured «CP-150G-3» countdown panel can be installed as additional

information element to display time left to red or green signal lighting.

Countdown panel application enables to decrease the amount of road accidents.

Countdown panel supplied with Smart Mode, automatically fit into time modes of traffic light controller, works with any type of controller in parallel connection to traffic light section.

Outward appearance


Supply voltage ~220 V from traffic controller

Working temperature range from -60ºС to +60ºС


Axial lighting force of one signal bit not less 50 cd

Emitting colour red/green or green

Power consumption not more 24 Wt

Maximum counting time 9 min 59 sec

Warranty 5 years



PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED TRAFFIC LIGHTS

CP-160RG-2, CP-160G-2

Description

Countdown panel designed to function simultaneously with traffic light.

Two-colour digit panel (CP-160RG-2) or one-colour digit panel (CP-160G-2) can be installed as additional


Countdown panel operates from traffic controller power signals.

Countdown panel supplied with Smart Mode, automatically fit into time modes of traffic light controller, works with

any type of traffic light or controller.





Working temperature range from -60ºС to +60ºС;




Power consumption not more 20 W

Maximum counting time 99 sec


Warranty 5 years

Outward appearance


PROTON

JSC “PROTON”


Phone/fax: +7(4862) 49-85-34,+7(4862) 41-44-03


LED TRAFFIC LIGHT

CP-160RG-3, CP-160G-3

Description

LED countdown panel designed to function simultaneously with traffic light.

Two-colour digit panel (CP-160RG-3) or one-colour digit panel (CP-160G-3) can be installed as additional


Countdown panel operates from traffic controller power signals.

Countdown panel supplied with Smart Mode, automatically fit into time modes of traffic light controller, works with

any type of traffic light or controller.





Working temperature range from -60ºС to +60ºС;




Power consumption not more 24 W

Maximum counting time 9 min 59 sec

Durability 12 years

Warranty 5 years

Outward appearance


proton cataloguerustrade.org.uk/eng/wp-content/uploads/led-traffic-lights.pdf ·...

Documents