major alterations - aso · 2020. 4. 9. · 1111 ·abov e work was performed in accordanc with...

MAJOR ALTERATIONS DESCRIPTION OF ALTERATION

Tl ! [ FOLLOW ING SUPPLEl'vlLNT,\L TYPE CFRTll ' lCA ITS IIAVL:: 13EEN INSTALLED ON T l !I S .\lRCRi \l'T SA I 0588SC SE I 0589SC SAO I 70XSF:/

CDC Cirrus Design Corporation Duluth. f\l N US. \ PC# 338CE

J'I w FOLLOW I NCJ SLJPPLl :Ml :NTAL TYPI ~ c 1m.TIFICATI ~

NUML3L R I !AS m :1:N INSTALL!]) ON Tl ll S AIRCRAFT

SJ\0'.20 I 3C J I

CDC on .5 _LI_,! 1#{ Cirrus Desi gn Corporation Duluth , MN USA PC# 338CE

ul'\1r:..1nuun.;, f\I IN.:llf\LL Uf'i l .D.U.

--- '- PART NA i\ I E

C.ll'S Rocket \lotor

--_,__

_,__

_...._

_...._

_,__

--

--

CAPS Parachute

CAPS Reding Linc Cutt ers

EL T Battc1y Pack

EMA Controller, AAIR

Oxygen Bottle Assembly

CO Detector

Pi lot Seat lnflator Assembly Co-Pilot Seat lnflator Assembly

Life Limited Parts SR22

Plln \l \IB ER

2 18 1-1-00 1

20331-00 1

52 12

-152 -(1-l'Jl)

20'!02 -001

IOON0020--I

2-16(,()-002

20'!02-002

20'102-002

/C LOT ........,__... Date l11'talkd

Ql - 7-01

lvlFG I Da tc 0:A/t!1"'

·- "p!IJJ..V SN JDJ.i .1

A /t,5; i,H I/ SN f i).).. l:ll

UAlt./ HUUH!>

E\PIRES

16/ iJ.01S ,..., I . , ,_ U 7 7 / 1 J

8 /JL1 ~ TY / f ,

LtKI. NU.

AIRWORTHINESS DIRECTIVE/FACTORY BULLETIN COMPLIANCE RECORD lllM DATE & HRS. METHOD OF I TYPE OF A.O. I NEXT COMP. AUTHORIZED SIGNATURE

1111 ECTED AT COMP. COMPLIANCE I TIME/ RECUR. DATE/ HRS./CYCLE CERTIFICATE NO.

I I

A -5/t-'IO<t Searched J\ D's th ro uoh bi - \.vcd lv _/,£,/1K, ?);ft!._ JJ~

~-Z. b -

issue za:>9- l o All J\ D's arc in t/ {/ tW;. compli ance at thi s time.

\5t17

I I

I HEREBY VERIFY T l IAT SERVICE BULLETI N S8-2X-'.28-08 R I 11 /\S 13 EEN COM PL! ED WIT! I.

CDC 0 11~~%P! Cirrus Des ign Corpora tion Duluth , MN US/\

PC# 338CE

I I I I

AIRWORTHINESS DIRECTIVE/FACTORY BULLETIN COMPLIANCE RECORD DATE & HRS.

AT COMP.

1f\kt\.ir

RDU004608 9-10-08

METHOD OF COMPLIANCE

TYPE OF A.O. 1 TIME/ RECUR.

NEXT COMP. DATE/ HRS./CYCLE

TAC Air Aircraft Maintenance 1725 E. International Drive, Raleigh NC 27623

Raleigh Durham Internationa l Airport Phone: 919) 840-4440 Fax: 919) 840-4441

N69YY Cirrus SR22 3370

AUTHORIZED SIGNATURE CERTIFICATE NO.

~ ~ CIR Fl U S

131 .0

Complied with Cirrus SB2X-32-19R1 NG Inspection by visual inspection with no defects noted. SB next due FH206.3.

1!11 I

I certi fy the entry identified above was repaired and inspected in accordance with current FAA Regulations and for the wor ~ performed onl and was found airworth and is a roved for return to service. Pertinent detai ls of this re air are on file at this f.11 1111

Authorized Signature: Otis D. Hudson, Jr. A&P2468264:,; ·

FACTURER

ALTIMETER & STATIC SYSTEM CHECKS F.A.R. 91 .411

MODEL SERIAL NO. LOCATION MAX.ALT. RECHECK

REQUIRED

I certify that the altimeter, stati c system, transponder, and altitude reporter test required by FAR 's 91.4 11 , 9 1.4 13, & 91 . ~ 17 have been performed and found with in the I im its of FAR 43 appendices E & F and AC 43-68.

FEET ON o'i_fQBLog TESTED TO 25 000 . Transponder: Mfg Garmin P/N 24653

Model: GTX-33 S/N 8q1os'"/9o

Air Data Computer: Model GDC74A P/N 24651 S/N 20fJ0{;,'-/33

Altimeter: Mfg Uni ted P/N 1273 1-003 S/N L/T-t.Z.~

CDC Quality Assu rance on o1!08!<8 Cirrus Design Corporation Duluth , MN USA PC# 338CE

APPROVED BY: AGENCY CERT.

DATE

--

--

----

--

--

--

ALTIMETER & STATIC SYSTEM CHECKS F.A.R. 91 .411

MANUFACTURER MODEL SERIAL NO. LOCATION MAX. ALT. RECHECK REQUIRED

I .og Hook I entry Nl71(! I lobbsrrach f OJ. l S!N,3570,

I certify that the stati c, a ltimeter. ar d < titudc re porting system test required by FAR 9 1.4 11 Were performed thi s dat '?.1 )l/l and found to T]leet the requ irement of

FAR~ rx JC~. WO# 6)-- (? 7/f Signatu re /:-,,. ~~ fo r RA~Ai r Freight C RS FF KR873 D

/

Altimeter # I MakcGft,.,_-,._., Model {zfift 7f S/ N )l'(Cl.>7._ 3 3 SIN r1izo~, Altimeter #2 Make j:. Model ._:, ''f

I I

Log !3ook Entry Ntrrr I lobbs/Tach Yt'7

APPROVED BY: AGENCY CERT. NO

z S/N 3376

I ce rt ify that the ATC transponder test and ins pect ions req ui red hy FAR 9 1.4 13 \.\crL· Perlormcd this date /,/}-//).;;.., / and fo und to meet the requiremen t of

FA l~·- /,Cj/'-j Signature 7 lor Ram Ai r Fre ight t ·Rs FFKR873D _,

Transponder ff I Makef/(/Z,'1.,fl/ Mode l lrTlJ ::2 S/N !:>71u (~rrl Transponder #2 Make JV~ Model --- S/N .......

.,....... - -

IHl l\ I

11 1\ U

RADIO & ELECTRONIC CHECKS -----.--~~;;;~~~;==-=-~ER~Ri.OR~O;;R-=---=-,-NNOEX:i"T cCiiHiECEci"K_T ___ ----oiirn1 (Kl Ill 1 l)llll'MI Nl TCYHPEECOKF RESULTS DUE SIGNAllJHI - (I ( 111 < KLD

J AVIONICS "UAe'-..,r FAA CRS #UYNR952Y UNIVERSITY AIR CENTER

University Air Center 4701 NE 40TH TERRACE • GA1Hesv1LLE, FL 32sos Pt!ONE (352) 373-2426 I 373..0740 I FAX (352) 338-0593

Date: Nov 21 . 2013 Tach: 755.5 Hobbs: 908.9 TT: 755.5

I 1 1 111 l ~ 1 lw t the altimeter, static system, transponder and altitude reporter tests required I 11 I 1\ R · s 91.411 & 91.413 have been performed and found within the limits of FAR 43 q1prndiccs E & F.

I n kd to 20,000 Feet on November 21, 2013 . I 1 unsponder:

I f~ : Garmin Model: GTX-33 SIN: 89108490 \ I)(' :

If~: Garmin Model: GDC-74A SIN: 20606433. \llimeter #2:

M fg: United PIN: 5934D-3 S/N:472209.

··/:,..---~igned : ________ __ ~------~

William J. Pritchett - Repairman #3336440

MAINTENANCE RECORD F.A.R. 43.9

AGENCY & CERTIFICATE NO. Alllllll\11 llMI Ill ', I llVIC I

DESCRIPTION OF WORK PERFORMED OR APPROVED DATA USED WORK PERFORMED/RETURNED TO SERVICE

TAC Air Aircraft Maintenance ~ 1725 E. International Drive, Raleigh NC 27623 '!11/Z J

Raleigh Durham International Airport ~ Phone: 919 840-4440 Fax: 919 840-4441 c" • vs

Authoriied Cirrus Service

Center

111 Ii 1 I Ii 1 I Dale "N" Number Aircraft Make Model Serial No. Hobbs Tim

111111 I "' // 1!,/2009 N69YY Cirrus SR22 3370 69.7 56.7

I• II d 1111 1 11 •11111 v<'d nose wheal, inspected wheel halves, cleaned, inspected wheel bearings, repacked and re-installed bearings , 1 1111 , I 11 1 • , I 1111111 Special II 5.00-5 (6 Ply) and 500-5 TR 67 Tube per AMM32-41, serviced tire, balanced wheel , re-installed wheel ,

111 JI I 111111q I 1111 .... ........ ..

I ' • 1111 y 1111 · 1•111ry identified above was repaired and inspected in accordance with current FAA Regulations and for the work I" 111 ·1111• " I 11111 .111li was found airwort for return to service. Pertinent details of this re air are on file at this facilit

li1111t .. 11 . •·ti :; i<Jna ture: Warren Bourne A & P 3236539

TAC Air Aircraft Main tenance 1725 E. International Drive, Raleigh NC 27623

Raleigh Durham International Ai/port Phone: 919 840-4440 Fax: 919 840-4441

11 1 '" '"' rJ •> Dale "N" ~' b .um er Aircraft Make Model Serial No. H 111111 I . t' ' 22 JUL 2009 N69YY Cirrus SR22 3370 obbs

'

l111·l1«l 11ql11 w111g. Replaced defective RH wing fuel tank drain valve ( /n 14354 00 ) . . 74.9 • 1 .. I""''" .111 ft oms stem. P - 1 · Fueled nght wing and performed extended ground

'1111; Iii.II lltt• work described above was performed satisfactoril y and in accordan · . 'I"/'''" •" I 1111 1 <·I urn to serv ice with re ard to work performed. ce with approved/acceptable data and that t111s article is

~~ Jon A. Delamarter, A&P 3035359

DATE OF COMPLETION

AIRCRAFT TIME IN SERVICE


DESCRIPTION OF WORK PERFORMED OR APPROVED DATA USED

LEADINfi EDliE ~ )!;~ Ji VIA TION SERVICES .. INC. ~

CIRRUS

AGENCY & CERTIFICATE NO. WORK PERFORMED/RETURNED TO SERVICI

Tam pa, FL Aurnomzm smv1cE cENrm Date: 12111 12009; Aircraft N69YY ; Type: CIRRUS; SIN: 3370; I lebes : 62 .6; TseR 12.4, Totel Ti FR~ II s : /'( '- · t> FH

E .... +e..--eJ.. :... e......, r -Removed damaged propeller & replaced propeller with serviceable unit of the same model. Model : PHC-J3YF-1 N SIN: FP7243B

-Removed engine TCM 10-550-N SIN: 692206 and reinstzlled same SIN on this airframe after inspe:;,' '.)11 by Western Skyway's, Inc. W/( 111

0025434.

·-Propeller governor removed & replaced with same SIN unit after outside overl1aul. Pl f'J: C2~· ·;~;:., · .. . _.;, :::::.-:: (;8070:) i'\epaireci t3y: Ou.tid y Aircraft Accessories Inc. WI0#92701

-Inspected landing gear, firewall , and forward fuselage structure . No damage noted at this time.

-Refinished left MLG fairing , and nose fairing . Base coat I clear coat. Repair P·~rformed Ry: Geory•, Aian Shaw

-Installed new placards and Aero-Teet on left MLG fairing and nose wheel fairing after repair.

-Removed & replaced engine mount with new. PIN:16546-001 SIN: 3169

-Removed & replaced nose landing gear assembly with new assembly, new hcirdware installed . ;":,'; :Hi100-40·:.

-Removed & replaced left main brake caliper and rotor with new. Cleaned and repacked wheel be ~,r; ngs . Bled both brake systems "' • ~1· I tires with air. Rotor PIN:164-02504

-Replaced LH exhaust manifold with new part. P/N:ETl-SR22-103-3-E SIN:3370

-Removed & replaced NACA duct sleeve with new. PIN:18892-002


AGENCY & CERTIFICATE NO. 1\1114111\ll llMI It< '•I llVI< I

DESCRIPTION OF WORK PERFORMED OR APPROVED DATA USED WORK PERFORMED/ RETURNED TO SERVICE

""1" 1d 11 •·d .111 . 111 rrncros~itch with new. PIN:311SX5-T

I .... 1" l'Ltt 1•cl I KS dral with new. PIN: 17382-511

'"""" o1w1J l11dl' rence to Cirrus SR-22 AMM.

I • • •" I w. '" per formed in accordance with current regulations of the Federal Aviation Ad1T i,·· ; traton and is approved for return to

Jlt l•

I" 11 "'""'I lo work performed .

t: <-'11 A&P 267433553 . Tampa, Fl 33610

Ort (KTPX) 813 626 1515

tEADINli EDliE '->- ~ fiVIATIONSERVICES, INC. ~

CIRRUS

Tampa, FL AurnomzmsERv1cEcENrm I )13012009; Aircraft: N69YY; Type : CIRRUS ; SIN: 3370; Holl13s: 141 .6, Tach . 141 .6; Total Tiffie : 141 .6

J3,./11rd /A i!!r/"cr 1 olp1 ·.ted prop governor as required with reference to Cirrus AMM.

111 11 .. 111oved and replaced Aerotect on NLG fairing , strut, and LMLG strut.

Tl5: 174( 6 PH

1111 ·above work was performed in accordance with current regu lations of the Federal Aviation Admin istration and is approved for return to 1•1vrce pertaining to work performed. . 1 <'

Brian Bills ' ~ ,,---, ~ A&P 3197850 6582 Eureka Springs RCflTampa, F'r3"3m 0 Tampa Executive Airport (KTPX) 813 626 1515

-/. MAINTENANCE RECORD

F.A.R. 43.9 AIRCRAFT TIME DESCRIPTION OF WORK PERFORMED AGENCY & CERTIFICATE NO.

IN SERVICE OR APPROVFO DATA U<;FO WODll PC"QCnl:U. Acn 111CTllOtr..1cn T l'\ cc-ornr•

....;;..-..!...~~~::..::.:::;.r-~~~~~~~~TA-;7.C~A~ir~A~1:rc:r~a~f7t~M~a~in:t~e:n~a:n:c:e:--~~~__:~~-r..;;;,;,~~~~~ •. ~. ~1_ ~- ~~ Authorized , ,

1725 E International Drive, Raleigh NC 27623 Raleigh Durham International Airpoit

Clrru.$ servlci - C!nte.~~

Work Order No.

RDU 7573

Date

12-2-10

Phone: 919 840-4440 Fax: 919 840-4441 c•••u• "N" Number

69YY

Aircraft Make

CIRRUS

Model

SR22T

Serial No.

3370

Hobbs Time

418.9

Fl1 ht Ho

356 {,

rerformed servicing of TKS system, and oxygen system. Serviced tire pressures and lubricated doors. Relamped right nav lamp P/N

7512-24. O s checks ok. I certify the entry identified above was repaired and inspected in accordance with current FAA Regulations and f_or the work

erformed onl and was found airworth and is a roved for return to service. Pertinent details of this re air are on file at this fac1llly

Authorized Signature:

TAC Air Aircraft Maintenance 1725 E International Drive, Raleigh NC 27623

Raleigh Durham International Airport Phone: 919 840-4440 Fax: 919 840-4441

J . Shawn Crean A&P 3230521

.. ,~ .. ~ .. -~ \ · Author1,1d Cirrui Servlot

'. : ' ; 9~ntp( · , Date "N" Number Aircraft Make Model Serial No. Hobbs Fii Ii

13 June 2011 N69YY Cirrus SR22 3370 458.8 ·1•111 •, • Removed #1 GIA63W (p/n 011 -01105·01 , sin 15W008611) due to inoperative COM. Installed newly overhauled #1 GIA63W (1 • 11

011-01105-01, sin 15W008231); unit overhauled by GARMIN (CRS# G6XR582Y) under SO# 1519872 dated June 01 2011 . l '1·il• "'"' installation IAW GARMIN Perspective Line Maintenance Manual (p/n 190-00920-00, Rev. E, Sep 2009) chap. 6.4 .

• Updated Perspective Integrated Avion ics System software to v0764.09 JAW SB 2X-42-06 R2; inserted POH supplemenl (11111 13772-135R3).

I certify that the work described above was performed satisfactorily and in accordance with approved/acceptable data and that ti ll' . .1111o 11 ap roved for return to service with re ard to work performed.

Authorized Signature: Jon A. Delamarter, A&P 303535'1

l1111l111 •1dl l1t 1dl\\ 111 1 111111 \111 l11dl1 J1 l11111 q• l11ll1t . q11111•111 1.1l1 d\HHlll 11111 lllllllllll , lllll"lllJ:lUi.11.

1111

11

I 11ld1t

1111111 d

I I'' 'I ll

111111110 I\' HI 1111d11d111ld111l l'l \t\11 11111d1111l1111111111d111t1 \\1111 I \ \/\ l 'a1f 1-15 and in respect to that work the corn

tlo111« t•l rnrt the requirements of the maintenance 1 \ I I

I 111•

11 • 111111 11,, 111111 1d1 tlldt1 d du \1 I• II 1111111111111 1! Ill• 11td1111111I\ 1 .. 19. 14 ('FR 43.9 Return to Service

I I 1.1 I 1111110 1111 tlo •1111111 111 I

11 I Ill II Ill Certifies that unless otherwise spccili

ti I 11 11 I I and described in Block 13 \Vas acco1

ITdcral Regulations, pan 43 and inn

rL·turn l\) :-.en ice.

A If 11 1 " 111111·11 1111111 " I ~(I Aut hu11/L'd '; 1 g. 11<1tur~

I llol 111! d '22 '\,111w( l \p1·d111 l'11n1c·d)

Paige E. Bart

~ I I I 11'l11 lkr RC"~pomil>ilitil'~

I ti II 11111 , , .i, I" 11111 11111 11111•1111111 ilh < 1111stit u1c· .1u1l111111\ 11> 111't.ill t lic· p:1 rt ClllllPPllCll

•Iii 11 II !lit II d 11 1ol 111 " ool Ill 11111 .. 11l11nc>' au1liu1111 dilk1L'lll l l1.1n Ilic ain\llrthinc

I "' l 1tl1111 111tl11111I II I' pl. p11rts'1.lllllj)Plll'llh .l ........ l'lllhl1L· .... 110111 the J\in\llrl

t 1111111 Ii ,, , 11 II I I I "' I Ill I 11 itl I II Ill I Ii ill 1111 1 ilt 111.11ntc; ~111cl· 1n 111d , 11111 .... 1 lu111.1111 .in 111,1all;111n1

ll.11111111 I• ,,1 I' lo tl1 I " '1, 11 I I 111 "' I i!l 1111 1 .. 11 ..

\ \ I """ \I '11 ; t t• 11 t I II I Ill I 11 tllHlll/ Ill' i{c·, II l 11.1.1ik1 11111 I 1 111 , 1

.\

AIHC lll\11 llMI

IN ·. t ltV I< I

I/ '/\tr





AGENCY & CERTIFICA1 L.

WORK PERFORMED/ RETURNED TO SEli. ·~ -

CIRRUS .. 1 11 ~ II ... f I

1 htt I I•• I IJ01tc "N" Number Aircraft Make Model Serial No. Hobbs 11! 111 1 :• / ~)I P 2011 N69YY Cirrus SR22 3370 499.6

ii lo 1." 11 v .. 11: 1 /\I IRS unit (Garmin GRS77, p/n 011 -00868-10, s/n 42011670). Installed newly overhauled #2 AHAS (Garmin I "1 111 tlllll(iU 10. sin 42001463); unit was overhauled by Garmin (FAA CRS# G6XR582Y) under SO# 1593928 on Sep 09 2011 .

'"" o1 ' l "' ' ·ilu11 1.il cl1eck und test fli ht. Ill II• .i 11, .. W• " k cluscribed above was performed satisfactori ly and in accordance with approved/acceptable data and that this article is

ard to work performed.

Jon A. Delamarter, A&P 3035359

Aircraft Logbook Entry 'J.Q,bs ~~(. .Z,

Date 1 ~ ~ \ 1, Reg . ' 1./\ 1 ~ \ Aircraft Typ C. t 0~ Services Render e ~ _:___:_~~1'<;.~r(":........:.')__:,.:~_.:___.:. _ __.!.r_'.-.:"-'A::!":___.i,.~-r7-.;.__"~--r-

- --+- - ~ ./'.Jo'"-" /\- ) o~ ' 'i. (! 4:')" ' /r

Mechanic Signatdre~(~~+-J-.,.....,.-;-:---::-:---;--:-:-------- ..._ ____ _ - -+--- Certificate # ____ -r---=¥--~t=--~_!f_· _'.:...Z.!...r...L~_t;__Jr,L.;;=--1---;;:==::::;---- ______ _

National Jets, Inc., Ft. Laud

-:E_EOF COJ.;rPLETION

_ , AIRCRAFT TIME

IN SERVICE

U\ . .JG-i\ir



AGENCY & CERTIFICATE NO. WORK PERFORMED/RETURNED TO SERVICI

TAC Air Aircraft Maintenance ~

1725 E. International Drive, Raleigh NC 27623 J/Jf,! / Raleigh Durham International Airport ~

Phone. (919) 840-4440 Fax: 91 !!J.!!..4_0_-_44_4_1~----'--~c-'_'"_"_' __

... • I .. '

Authorized Cirrus Service

• Center

1t-W_o_rk_O_ rd_e_r_N_o_. -+-_D_a_t_e_C_o_m~l_e_te_d---1_"_N_" _N_u_m_b_e_r---1_ A_ir_c_ra_ft_M_a_k:..::e--1---'-M-'-o:....:d::..:e-'-l --1----=S-=e-'-ri=a.:...I :....:N-=o.:.... -+----'H'-'o=-b=.:b=.:s=---:.T.::.im:..:e=----.!..--'-F-"li.il'...'.:ht HC1l 1l 11

RDU-11553 5APR2012 N69YY Cirrus SR22 3370 592.4 50.' ·I

Both grab handles corroded. Replaced both grab handles, PN 1 690-003. IAW SR22 AMM 53-20.

eturn to service. Ecertify that the work described above w rily and in accordance with approved/acceptable data and is approv•" I i."

-"-'--

Authorized Signature:



Gregory P. Ziegler A&P 345231'.1

Work Order No. ·+--=D-=a....:te::_....:C-'o-'-m'-'Jp"'l-=e.:..:te:...d:--1-"-'-N_" _N-'-u-'-m-'-b:....:e:..:.r--1_A_ir::..:c_ra-'-ftcc.:...M....:a_k....:e--1 ___ M_o-'d-'-e_l __ 1-·-'-S_e_ri-'-a_I _N_o_. --+--Hobbs I 111 io •

RDU-12275 11 JUL 2012 N69YY Cirrus SR22 RDU-11845

G:S/ II 3370

PFD bottom half of display bounces up and down. Replaced PFD GDU1240A with unit overhauled by Garmin u11d"' Wr 111 011-01440-30, SN 14Y005744 IAW SR22 AMM 31-60. Functional and ops checks good ..... Replaced sonic hcill<'1 1111 " ' r

ETl-G3-403-1 IAW TAT ICA 22-646006. Leak checks ood. ctorily and in accordance with approvedi<icccpt. il >I• · d . 11 • ""I I •1

return to service .

/\ 11tl1or i/ed Signature: C rr ·qrny I ' /ll'qh·1 /\.~I' 11

.- .

Alllill 1111"-11 Ill I llVll I



AGENCY & CERTIFICATE NO. WORK PERFORMED/RETURNED TO SERVICE

--·---·---"-~~~~-~--==--~·=· ====r=:::::;::;:== TAC Air Aircraft Maintenance ~;~. ·

~

I \II 1725 E. International Drive, Raleigh NC 27623 '!/1; ! J

Raleigh Durham International Airport ~ Plw ne: 919 840-4440 Fax: 919 840-4441 °""";

I 111"1 1111111l" lud "N" Number Aircraft Make Model Serial No. ----r-_..:..:...:=.:...:.:..:.::==.-+--.....:.:..:.:::.:::::::..___-1--~~~~

'II /\ l JC, :• () 12

II t d ',11 /lldllllt: .

1/\C/\ir

Date Com leted

10/10/2012


~regory P. Ziegler A.&P 3452313--

-_ __ ·:.::.._ . .:..-=c: ___ - - ·------------JI TAC Air Aircraft Maintenance

1725 E. International Drive, Raleigh NC 27623 Raleigh Durham International Airport

Phone: 919 840-4440 Fax: 919 840-4441 "N" Number

N69YY

Aircraft Make

Cirrus

Model

SR22 G3

Serial No.

3370

Hobbs Tim

716.2

Authorized Cirrus Service

Center

602.9

'" I 111ol 11 •placed #1 battery in accordance with CMM 24-30-71 . P/N installed RG24-11 M. S/N installed 40523784.

1111 111111 11 11, work described above was performed satisfactorily and in accordance with approved/acceptable data and is approved for

11 11 111)1/od Signature: James Hayes A&P 3345460

-

DATE OF

- --- -- - ---- ---- -


COMPLETIO September 29, 2014 N69YY

.,.

\(Vector/\11 Cirrus SR22 S/N 3370 Flight time . 802 9

" ...,. \

Installed Aerospace Logic FL202G, S/N ASL006790 digital fuel quantity display and CIE$'f~~v,rl 'efisors in accordance w11t1

STC SA02825NY See FAA form 337 dated September 29, 2014. ------END----- ( ~ £ ~- · /I --

April 7, 2015 N69YY Cirrus SR22 S/N 3370 Flt meter: 806.2 ACTT: 806 2

Removed and replaced CAPS Reefing line cutters New expirat ion date Ju ly 2021 . -------END------

Joe1 Burkholder V IA3277608

Installed line cutter kit PIN 25347-002, S/~s~ .04 , 7805, Mfr </• ·d I • I• ·111

~ ---7P"l ~yf Jonathan 'c1rlisle AP30639261A

lt ll 11 11 IH\11

tit 111 \; lll

I : I .. \

-

-

-

; -I 1 - .... -· .. J •

-

INSPECTION RECORD F.A.R. 43.11 -91 .409

KIND OF INSPECTION-STATUS & DISCREPANCY LIST SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

Production Flight Test accomplished in accordance with CHTus Procedure #90502.

Name: Brian J. Olson Date .5 ~dy' 0 CJ

s ;gna1W1t~z ?1~ Title. Pro::n ~ ~ilol

I l\ 11d 1\i;ll th e ;i ircr;1i"t meets the requirement s lor the l· ~· ri i lil·; ll io11 1n1ues ted ;rn d h;1\ L' iss ued a11 U .S. Sl;111dard

.\ i1\\mtl1i11ess (\:1l i liL· ;1\c tLtt et ) ·-i / i~~cc:/\ . T l1l· 11e\t in spec tio11 is dul' ,'1)~1 I .& i:d!:tlD·

'

I~·~ ~"'\~ ~~

Trnv J. f'v1cDon<ild .;

0 I ).1\ I\ F--+05 22X-C I·:

I I

I


Date

9-10-09

INSPECTION RECORD F.A.R. 43.11-91.409

KIND OF INSPECTION-STATUS & DISCREPANCY UST SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE


Raleigh Durham International Airport Phone: 919 840-4440 Fax: 919 840-444 1

"N" Number Aircraft Make Model

N69YY Cirrus SR22

Serial No.

3370

~ ~ C IRR US

131.0 1 06. ~l

C/W Cirrus 50Hr. inspection checklist. Cleaned/resealed gascolator, inspected the following items - spark plug leads, engine compart11 11 ·11 1

for leaks/eel. , oil lines & fittings, air intake ducts, breather tube, alternate air door, exhaust system, and brake linings. Replenished brak(• reservoir and checked tire pressure. Removed, cleaned and re-oiled induction air filter per K&N service instructions. Serviced oxygen system. Secured lower sections of wingroot fairings. Complied with Cirrus SB2X-32-19R1 NG Inspection by visual inspection with no defects noted. SB next due FH206.3.

•J

/

I I

I

!>11111

1, I I ()

INSPECTION RECORD F.A.R. 43.11-91 .409

KIND OF INSPECTION- STATUS & DISCREPANCY LIST SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

TAC Air Aircraft Maintenance I 725 E. International Drive, Raleigh NC 27623

Raleigh Durham International Airport P/10ne: 919) 840-4440 Fax: 919 840-4441

"N" Number Aircraft Make Model Serial No.


~ C IRRUS

271 .9

1 , 111 1 11 1111 ·ti ;i11d 1cpacked all wheel bearings. Replaced both main tires with new Goodyear 15X600X6 6ply FC , "ii .1," I w1ll 1 11 uw GY 15X600X6 tubes, torqued wheel halves, serviced tires to specs. Repaired NW fairing and

I It 1 ii 11 , " I 111JI11 side brake linings . Checked nose fork spindle tension, within limits. Complied with Optional Cirrus 111 111 11 11• 1H 1nv replacement/ temp sticker kit p/n 70227-002, with temp . POH revisions. Next brake oring

111 t1111 G/2015 or on condition. Also inserted POH Rev.1 dated 8/26/09 into manual. Bled system as required. 11 111. JI i1 , , 1111iols, hinges and pulleys, checked control cable tensions. Cleaned and replaced seals in fuel strainer,

I \JI"" 1 < ;11ucked battery condition. Checked all lights. Complied with FAR 91.207{d) EL T unit inspection with no 1 111t11"1 I 1.i ll ery due date 3/15, remote bat due 2015, ops check. Performed inspection on Precise Flight Oxygen 111 1,,, 11 f\ 11 102NMAN0003 dated 3/21/08, pages 23-26. Complied with Cirrus SB 2X-32-19 R2 NG inspection and , "' 111 111 I 1y inspection per bulletin with no defects noted . Installed kit# 70238-001 . Gusset plate inspection due every

11 1 l1 K 1 clue FH 324.8. Replaced skeet ducting from r/h innercooler to exhaust, p/n 04-6400001-5-7 4-4. Repaired 1 , I 11,. 11ii1d side where skeet ducting chaffed hole thru, (CAS-08658). Replaced both grab handles p/n 10690-002,

11111, I I) llcplaced LL lens, p/n 17298-001 . Prepared AD and SB listing per FAR91.417(A)(2)(V) , placed with records. 111lv 1111 . .i11craft has been inspected IAW an Annual inspection using Cirrus SR22 MM, Chapter 5-20 as revised and was

1 11111111 •1 I lo IJe in airworth condition and a roved for return to service. Ref. WO# RDU006074 for further details 1 , 1 ·1 lily the entry identified above was repaired and inspected in accordance with current FAA Regulations and for the work

I'' , ,, "1111 •1 I onl and was found airworth and is a roved for return to service. Pertinent details of this re air are on file at this facilit .

' 11111• 1111ed Signature : c:Uixj Jfr'~~ / Otis D. Hudson, Jr. A&P3490004 IA

I L_

~-t~~~~~~-t-~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~-/

I



KIND OF INSPECTION-STATUS & DISCREPANCY LIST DATE SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

TAC Air Aircraft Maintenance 1)\£/\it 1725 E. International Drive, Raleigh NC 27623


Work Order No. Date "N" Number Aircraft Make Model RDU-8315 28 APR 20 11 N69YY Cirrus SR22

• Performed 50 Hr Inspection in accordance with AMM 5-20. • Replenished brake fluid reservoir with Mil-H-5606 hydraulic fluid. • Performed all 100 Hr Lubrication items in accordance with AMM 12-20.

Serial No. 3370

CIRRUS

Hobbs 438.1

• Performed 100 Hr Schedu led Maintenance Checks in accordance with Tornado Alley ICA 22-6460004, Rev. A. • Cleaned and re-oiled induction air filler in accordance with TATI Air Filter Cleaning Instruction No. TAT-S108-05. • Cleaned oil coking residue from LH tailpipe crankcase vent dump {breather port) . • In compliance with Overhaul & Replacement Schedule of Tornado Alley ICA 22-6460004, Rev. A, installed new v-band clamps (p/rr 11

11 00023) and new magneto pressurization filter (p/n 653386). Clamp replacement is due every 450 hrs or after 350 hrs if cla11111 I removed or first annual after 350 hrs, whichever comes first. Magneto pressurization filter replacement is due every 3 y1 s '11 300hrs.

• Com plied with SB 2X-32-19R2, Par. D (upper gusset plate recurring inspection) by inspection in accordance with Par. D. No c r;11 I· detected. Next inspection due @473.8 hrs TIS.

I certify lhal the work described above was performed satisfactorily and in accordance with approved/acceptable data and lhal 1111 · •• 1111• lo 1 approved for return to service with regard tq work performed.

Authorized Signature: Jon A. Delamarter, A&P 3035J!,'I

11111 II Ill II

Ill Ill ltl

II

11.t111

I 1111 '11 11


KIND OF INSPECTION-STATUS & DISCREPANCY LIST SIGNATURE - CERT. NO. OF PERSON APPROVI NG OR DISAPPROVING AIRCRAFT FOR SERVICE


Ra leigh Durham International Airport Phone: 9 19 840-4440 Fax: 91 9 840-4441

"N" Number

N69YY

Aircraft Make

Cirrus

Model

SR22

Serial No.

3370

~ ~ CI A A US

478.7 407.2

'11 111•' tl .i1H I 1cpacked all wheel bearings. Checked nose fork spindle tension , within limits. Lubed all flight 11111 1• 1111 I I'' ili! 'ys, checked control cable tensions. Cleaned and replaced seals in fuel strainer, leak check good .

11 111• ' • ''' '' li l1or 1. Checked all lights. Complied with FAR 91.207(d) EL T unit inspection with no defects noted; ti 111 1 I'•. 1c 11 1ote bat due 2015, ops check good . Performed inspection on Precise Flight Oxygen System per

I It I 11111111 I 1 l;1ted 3/10/2010, pages 22-26. Cirrus SB 2X-32-19 R2 NG Gusset Plate inspection due every 1 t t11 11• I 11 473.8. Performed Adjustment/Test - GMU44 Magnetometer Calibration JAW AMM 34-20; next

11 11 tl11• 1111 :'013. Installed new #2 batteries (p/n 21063-001 ); next battery change due JUL 2013. Installed new 11 Ii" 11•11 I AK-009-G3/TB) on pilot s ide of NW pant. Installed new wellnut (p/n 50763-001) in baggage door sill.

1 ii 1 " 1 •il1 o1 cl11 11kholder using new (p/n 51179-00 1 ). Secured loose nuts on both aft pax Bose headset jacks. Installed 1 11 111 •11 • ... or drive damping bushings (p/n 1133089- 1) using new bolts , washers , and spacers .

11 1111 1111 1. ilt l1as been inspected IAW an Annual inspection using Cirrus SR22 MM, Chapter 5-20 and using Tornado 11111"' 1111 ICA # 22-6460004, Rev. A dated 10 APR 2009 as revised and was determined to be in airworthy condition

'I 'I"" ' ti lrn return to service.(Ref. WO# RDU009227 for further details) I , ildy ll1r1 entry identified above was repaired and inspected in accordance with current FAA Regulations and for the work

11 , , , " I' 1111 and was found airworthy and is a proved for return to service. Pertinent details of this repair are on file at this facil it .

1111.,,,,.,., , Signature: &1~~~ Otis D. Hudson, Jr. A&P3490004 IA

DATE


AIRCRAFT TIM E IN SERVICE



Raleigh Durham International Airport ---~----L---~-Phone: 919 840-4440 Fax: 919 840-4441

"N" Number Aircraft Make

~ C I A AU S

RDU11831

Date

5-21-1 2 N69YY Cirrus

Model

SR22

Serial No.

3370

Hobbs Tim

611.4 516 ,,

Jacked aircraft, cleaned and repacked all wheel bearings. Checked nose fork spindle tension, within limits. Set tension 1l11

MLG , AMM 32-10, .008 inch . Lubed all flight controls, hinges and pu lleys, checked control cab le tensions. Cleaned ancl replaced seals in fuel strainer, leak check good . Checked battery condition . Checked al l lights. Complied with FAR 91.207(d) EL T unit inspection with no defects noted; battery due date 3/15, remote bat due 2015, ops check good . Performed inspection on Precise Flight Oxygen System per ICA # 102NMAN0003 dated 3/10/2010, pages 22-26. C 11 111 ·. '. II 2X-32-19 R2 NG Gusset Plate inspection due every 1 OOhrs; next due FH 616.6. Replaced TKS dial , p/n 17382-60 1 Replaced TKS filter element, p/n 26115-101 , 2yr time life item. I certify this ai rcraft has been inspected IAW an Anr 111. ii inspection using Cirrus SR22 MM, Chapter 5-20 and using Tornado Alley Turbo, Inc. ICA # 22-6460004, Rev. A cl;il1 ·1 I 111

APR 2009 as revised and was determined to be in airworthy condition and approved for return to service.(Ref. WO/i RDU 11845 for further details)

I certify the entry idenlified above was repaired and inspected in accordance with current FAA Regulations and for lilo w111I· performed onl and was found airworth and is a roved for return to service. Pertinent details of this re air are on file a l 1111' . l.1 1 1111 1

Authorized Signature: ,__cPJt-. ~ Otis D. Hudson, Jr. A&P349000·I Ill

..,,,,., 11 l /.' 012 1701 NI ·. 4011 TERRACE <11\INISVILLE. FL 32609

N: 69YY MAKE: CIRRUS MODEL: SR22 SIN : 3370 ACTT 606.1 W/0#:

1 11111 pl1o ii '"'I' I ,\R ')l-207(d) by inspection and test of the ELT no defects were found with the

111111 11i. lt.ilh 11 1l'placcment date is march 2015 111 1 i11, .1 111" 11 r h1 brake linings and bleed both brakes

, , "" d 11111•1' kid. panels and Am safe harness t 1 111 1 111• d ""'' insulated cabin air inlet hose under cowling

111 1.tlln l 11n~ right main tire Goodyear FCI I I repacked whet:! bearings ,, 1 11111pl1<'<l 111th SB2X-42-08Rl Garmin software update '1 1 11111pl1<'ll 1~ ith Cirrus SB2X-30-07R3 porous panel vent inspection I 1 1 11111110l1nl with Cirrus SB2X-27-16R I asymmetrical tlap by installation of kit 70255-002

111 t 11111pilnl with Cirrus SB2X-21-05 cabin air coupler rigging 1111 111 .,1.dk:d tape vertical stabilizer end rib hole 111 lw.lalli.:d nylon washer under stainless steel to aluminum screws I • 1 cak:d both GPS antennas I I 1 \llachcd left lower wing to fuselage fillet fairing I I 1 '>ccurc<l lefi aileron bell crank attach hardware I \ 1 Installed new left and right main gear attach grommets 11>1 Adjusted nose gear spindle tension I / ) i{cmoved and hydrostatic tested oxygen bottle due again 10/2017 IX) ( 'omplied with Cirrus SB2X-57-13R2 lower main gear attachment torque

I n: rtil) this aircraft has been inspected in accordance with an annual inspection using the manufacturer's check list and F/\R Part 43 appendix D. This aircraft was found to be in an airworthy

" "'dilioo '"' ,, appm"d rm'""'" to""(:--~

I{ '>cott Lambert AP 3300566 IA ~- -

j _J

- 1

INSPECTION RECORD F .A.R. 43.11 -91 .409

KIND DF INSPECTION STATUS & DISCREPANCY LIST DATE

AIRCRAFT TIME IN SERVICE SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

Texarkana Aircraft Maintenance LLC 48 Globe Ave ., Texarkana , AR 71854

26-November-2012 A/C TT 625.6 (Engine Hobbs) N69YY, Cirrus SR22, S/N 3370 Page 1of1

1. Removed and replaced the nose tire with new tire (Goodyear Flight Custom 111 , 6 ply, 5.00-5 , PIN 505C66-5, S/N 72670108), and n"w Michelin Airstop Tube (P/N 092-308-0). The tire was replaced IAW the Cirrus MM and the Cleveland Wheels and Brakes Techs Servu n

G u id e . ---------------------------------------------------------------------------------E N 0---------------------------------------------------------------------------·

Jerry M/Garr~tt' ,,, A&P 2688220 / ( Date11-26-2012

INSPECTION RECORD F.A.R. 43.11 - 91 .409

KIND OF INSPECTION STATUS & DISCREPANCY LIST lllt 11 11 IHdl

!ti 111\111 SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

ARAPAHOE AERO 1.11 I \ I t 'ONTROL TOWER ROAD ENGLEWOOD, COLORADO 80112 (303) 799-8386 Nt.'1 \ Y Cirrus SR22 S/N: 3370 Airframe Log Entry

I 1111 11111, 20 1_1 Flight Hobbs: 0674.8 Hobbs: 0805.6 c 11 111plt 11·d O 110111· Inspection this date using Cirrus 50 Hour Inspection items and the Precise Flight t 1 • 11 ·,, .. 1,· 111 l11 s1ructions for Continued Airworthiness as a guide. Checked flight controls and fairings . 111 I"• 11· tl ' k:i111:d, resealed , and leak checked fuel strainer. Serviced brake fluid reservoir. Inspected nose 111.I 111. 1111 l.111di 11 g gear tires and serviced to specified pressures. Inspected brake calipers and linings.

• Ii·• I 1 d 111:ii11 wheel fairing bolt torque. Checked oxygen cylinder service pressure, serviced oxygen as "'' tl1 d I 'IH:ckcd service level ofTKS system reservoirs, and serviced as needed . Post inspection ground 11111 1111 .111d systems operational check good . Cleaned windscreen and cabin windows and vacuumed seats

L. John Wells A&P3221132 w/o 32826

DATE

-

c= --

F " I

--

-

'


KIND OF INSPECTION- STATUS & DISCREPANCY LIST AIRCRAFT TIME IN SERVICE SI GNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

ARAPAHOE AERO 12760 EAST CONTROL TOWER ROAD ENGLEWOOD, COLORADO 80112 (303) 799-8386

N69YY Continental 10-550-N S/N: 692206 Engine Log Entry 7 February 2013 Flight Hobbs: 0674.8 Hobbs Meter: 0805.6 Completed 50 Hour Inspection thi s date using Cirru s 50 Hour Inspection items and the Tornado Alley 50 Hour inspection itt:ms as a guide . Changed eng ine oil using (Phillips X/C 20W50) and filt er. Cut oil filter open and inspected, no ferrous contaminates noted. Oil sample taken and submitted . Inspected magnetos, ignition harness and leads for condition and security. Inspected fu e l injection system for leakage and component condition and security. Inspected eng ine exhaust system. Inspected eng ine case and oil lines for leakage. Inspected induction system and alternate air door for security and operation . Inspected cy linder dra ins and eng ine case breather tube for obstructions. Inspected induction and alternate air system. inspected cylinder drains and eng ine case breather tube for obstructions. Checked lubricati on and operation of throttl e, mixture and propeller controls. Inspected eng ine compartment install ation hardware for security. Inspected and wiped down eng ine cowling. Complied with TAT Sl08-0I (Tailpipe Crankcase Breather Discharge Tube) by c leaning crankcase breather di scharge tube of cokin g deposit s per Service Instruction . Next inspection due at Flight Hobbs: 0724.8 or next oil change. Complied with SB09-0J (Exhaust Manifold Cracks) by inspecting exhaust manifolds for cracks around tu rbocharger mounting flan ges. Next inspection due at Flight Hobbs: 0724.8 or next oil change. Comp lied w ith SB12-02 (Fuel Pump 0-ring Seals) by inspecting the fue l pump mi xture control shaft for fue l leakage p l ·1

Service Bulletin , no de fects noted. Next inspection due at Flight Hobbs: 0724.8 or next oil cha nge. Post inspection eng ine ground run-up, operational and leakage check good . ~~ ,,-..L?/~ _____ L.John Wells A&P3221132 w/o ) 'X '"

1U1 li AI I I lf\11

'" 111 \1 111

INSPECTION RECORD F .A.R. 43.11 -91 .409

KIND OF INSPECTION-STATUS & DISCREPANCY UST SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

ARAPAHOE AERO ,11 I \" 1 1 1 tN 11m1 l'OWER ROAD ENGLEWOOD. COLORADO 80112 (303) 799-8386

N(o'>YY Cirrus SR22 S/N: 3370 1 I 111111 •0 1 1 ll o bbs: 0810.4 Flight Hobbs: 0677.9

11 , ti 11il 11111 •• 111d hack blew controller and wastegate, reassembled as needed . Ground run up check 1 1 1t•1 1.0, 11111\ n l oxygen regulator valve. applied 242 loctite to plunger and reassembled. Serviced

11 111 I 1,. , 1~1 1111 L'll leak te§.t no defects noted . Operational check satisfactory. 1 1 • , r r ( // L. John Wells A&P3221132 w/o 32849

ARAPAHOE AERO I' 1>11 1 /\ST CONTROL TOWER ROAD ENGLEWOOD, COLORADO 80112 (303) 799-8386

Nh'>Y Y Cirrus SR22 SIN: 3370 Airframe Log Entry I 1\1 11 •Ii 20 IJ Flight Hobbs: 0690.6 Hobbs: 0826.2

I • "'"'•ti . 111d replaced low pressure relief valve P/ N:OX-0202027. Installed new tape P/N:50640-045U , 11111 I' I \ 111 lower left wing fairing. Serviced TKS reservoirs and tires as needed. Vacuumed a ircraft and

1 11 1)11 ti -~\ illd9'1VS . _/ "-r? ~ 2..---1 /:.v l___Lt~ ~- Nathaniel Alan Beuthcl A&P 3659835 w/o 32927 > <

DATE AIRCRAFT TIME

IN SERVICE


SIGNATURE KIND OF INSPECTION-STATUS & DISCREPANCY LIST

CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

ARAPAHOE AERO 12760 EAST CONTROL TOWER ROAD ENGLEWOOD, COLO RADO 80112 (303) 799-8386

N69YY Continental 10-550-N SIN: 692206 Engine Log Entry 21 March 2013 Flight Hobbs: 0690.6 Hobbs Meter: 0826.2 Removed left wastegate. Insta lled overhauled exchanged unit P/N:47082-9004, S/N:TI RO I 05P, overhauled by Main Turbo Systems, CRS No. MAMR I 90K, W 10 # 45763, dated 03-13-2013 using new gaskets P/N:652457. Removed controller for bench test. Reinstalled unit P/N:470688-0005, S/N:NEN00056, followi'? repair by Ma in Turbo Systems, CRS No. MAMR I 90K, W/0 # 45764, dated 03-13-2013 . Post mai ten 1c: e)lg· e ~1~_,_.operational , and leak check good.

,. • A" ..J, ~~ Nathaniel Alan Beuthel A&P 3659835 w/o 32927 ._____ ___ ___ ARAPAHOE AERO

12760 EAST CONTROL TOWER ROAD ENGLEWOOD, COLORADO 80112 (303) 799-8386 N69YY Cirrus SR22 S/N: 3370 Airframe Log Entry

1 April 2013 Flight Hobbs: 0694.5 Hobbs: 0834.4 Installed new #2 a lternator fi e ld control module P/N:29434-00 I. Ground run operational check or charging s~tem ~t i sfactory. A<!justed XM Radio presd volume as needed.

<-;;/ ) / /, ~ ( 1, ( (, L. John Wells A&P 3221132 w/o 32977

ARAPAHOE AERO 12760 EcAST CONTROL TOWER ROAD ENGLEWOOD, COLORADO 8011""'_ / (303) 7()<)-8\8(>

N69YY Continental I0-550-N S/N· 692206 E · L E I April 2013 Flight Hobbs : 0694.5 Hobbs Meter:. 0834.4 ,ngme og ntry

Removed #2 a lternator P/N :657 I 99, S/N:K030840. Installed new #2 a lternator S/N :H-M 12 16(11 l\qil.ll

1•11

fie ld wire end lenrnnal and secured as needed. Gro und run operational check of charo in o syslclll . sal1sfaclory. ,,, ,,,

__.:%'/~ ( __.!_ I (,J L. .John Wells A&P 3221132 w/o l_H) I I


110 tt 11 IHdl KIND OF INSPECTION-STATUS & DISCREPANCY LIST Ill 111\ltl SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

~ f o);-;r """' - ~

4/25/2013 4701 NE40'"TERACE GAINESVILLE FL 32609

Jn v rsity Air Center

I) < 'l1:111 gcd oil and filter serviced 8 quarts Phillips X/C ' ) 111 tailed o ld filter element washed down and leak checked engine I l Serv iced air conditioning I I Secured nose axel

N: 69YY MAKE: CIRRUS MODLE: SR22 S/N-AIRCRAFTTT: 715.3 AIRCRAFT TC:

I 1 n ti ly the maintenance and/or alteration described above was accomplished in ·•l nirda nce with the requirements of 14 CFR 43 , and with respect to the work 1K·rformed is airworthy and approved for return to service.

R Scott Lambert AP 3300566

DATE AIRCRAFT TIME

IN SERVICE



ARAPAHOE AERO 12760 EAST CONTROL TOW ER ROAD ENGLEWOOD, CO LORADO 80112 (303) 799-8386

N69YY Cirrus SR22 S/N: 3370 Airframe Log Entry 21October2013 Flight Hobbs: 0746.6 Hobbs Mete1·: 0898.0 Completed 50 Hour Inspection thi s date using Cirrus 50 Hour Inspection items as a guide. Checked flight controls and fairings . Inspected nose and main landing gear tires and serviced to spec ified pressures. Inspected brake ca lipers and linings. Checked main wheel fairing bolt torque. Checked oxygen cylinder servi ce pressure, se rviced oxygen as needed . Checked service level of TKS system reservo irs, and serviced as needed . Post inspection gro und run-up and systems operational check good. C leaned w indscreen and cabin windo~s and vacuumed se31ts and interior.

rr-/(.//_ ,.,. L-L_L_L L. John Wells A&P3221132 w/o 33705 ,_ 7

tfi1 111\I I 11~11

Iii tl1\lll

11 .. ..11 L '- 1 IVI" llL'-VnU

F.A.R. 43.11-91.409 KIND OF INSPECTION-STATUS & DISCREPANCY LIST

SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

ARAPAHOE AERO I loll I 1\ S I CONTROL TOW ER ROAD ENGLEWOOD, COLORADO 8011 2 (3 03) 799-8386

NI•'" Y Continental 10-550-N S/N: 692206 Engine Log Entry I 4 1, 111 !11·1 20 IJ Flight Hobbs: 0746.6 Hobbs Meter: 0898.0

1 0111 pl1 ln l '\O llour Inspection thi s date us ing Cirrus 50 Hour Inspection items and the Tornado Alley 50 11 1111 1 111 .1wL 111rn items as a guide. Changed engine oil using (Phillips X/C 20W50) and filt er. Cut oil filter " I" 11 ""I 11 " pi.:c tcd, no ferrous contaminates noted. Oil sample taken and subm itted. Inspected magnetos, 1 111 11 11 11 l1.11 11css and leads for condition and security. Inspected fu el injection system fo r leakage and • 11 1111 11111 \· 11 1 co11dition and security. Inspected engine exhaust system. Checked lubri cation and operation of 1111 11 111 1 111 l\ lu1-e and propeller contro ls. Inspected engine compartment install ati on hardware fo r security. 111 I '' l ln l ;111d wiped down engine cowling. Tightened pins in connector fo r M/\P sensor at rea r eng ine I• tll ll' ( '0111plied with TAT SI08-0I (Tailpipe Crankcase Breather Discharge Tube) by cleaning , 1 11 1k\ .l';i.: hreather di scharge tube of coking deposits per Service Instruction. Next inspection due at I• ht•ht llobbs: 0724.8 or next oil change. Complied with SB09-0I (Exhaust Manifold Cracks) by 11 1 pL·ding exhaust manifolds for cracks around turbocharger mounting fl anges. Next inspection due at I· hi.:ht llobbs: 0724.8 or next oil change. Complied with SB12-02 (Fuel Pump 0 -ring Seals) by 111 ., pcctin g the fu el pump mixture control shaft for fu el leakage per Servi ce Bulletin , no defects noted. Next 1mpection due at Flight Hobbs: 0724.8 or next oil change. Post inspection eng ine ground run-up, 11 pcrat io9a,I and leakage check good.

1 .W h" r-~ Le L' ( L. John Wells A&P3221132 w/o 33705

DATE AIRCRAFT TIME

IN SERVICE


KIND OF INSPECTION-STATUS & DISCREPANCY LIST SIGNATURE - ~T. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

12/3/2013 4701 N.E. 40h TERRACE GAfNESVILLE. FL 32609

N: 69YY MAKE: CIRRUS MODEL. SR22 SIN: 3370 ACTT HR 755.5 W/O#·

University Air Center

I) Complied with FJ\R 91-207 by the inspection and test of the ELT no discrepancies were found with the unit the battery replacement date us March 2015

2) Secured cowling rubber seal at firewall 3) Installed new aileron gap seals left and right wings cirrus part number 14390-0063 4) Installed new wheel fairing to wheel axle retaining boll right wheel fairing 5) Bonded left wing fillet fairing lower section 6) Cleaned treated and painted small surface corrosion left elevator 7) Complied with Cirrus SB 2X-28-l I R2 fuel line replacement and TKS reservoir tank rework and

reseal as per instruction in service bulletin 8) Installed new left main tire Goodyear I 5X6X6PIY Flight Custom 111 the wheel was inspected for

cracks and wheel bearing were repacked 9) Installed new Tornado Alley tailpipe V Band clamps part number 11-1 I 00023 this is a time control

item I 0) All TAT SBs complied with see engine Jog book 11) Complied with Cirrus SB 2X-32-19R2 nose gear gusset for cracks no cracks noted at this time

12) lnstal led new #2 batteries 21063-00 I

I certify this aircraft has been inspected in accordance with an annual in accordance with FAR Part 43 appendix (d) using the manufacturer's checklist and current Federal Air Regulations as guidelines. I his

aircraft wa~ found to be in an airworthy condition and is approved for return to service.

R Scoll I .ambcrt /\P 3.100566 I/\

Jtj I 110 I I I I lllll>)


"' . 1111111. 1l 111spect1on of aircraft in accordance with FAR 43 appendix D, Cirrus SR22 AMM Chapter 05-20 schedule 11<·0 1,., IOOhour and annual items as a guide, Precise Flight instructions for continued airworthiness 50hr items

11o 1 I· o /\11· v' "11 l111ued a1rworth1ness 501100 hour inspection items as a guide. I ii I I I 111 "< ord;111ce with FAR 91 .207 (a-d) , Replaced battery KIT PIN 452-0012 , KIT SIN 10012021 , battery PIN 452-

1 1 I· 1110 1 y ', N 163913-018, due Sept 2021 . "''"" o1 w1!11 I 1irnado Alley, 5108-05 induction filter cleaning , 5108-04 heat exchanger inspection , 8808-01 breather

, 1," 10 1,11,.. ' leaning, 5808-02 PRV duct inspection, 5809-01 Half stamp exhaust manifold inspection , 5812-02 engine 111 111 1110 I 1111111p inspection, 5111 -01 , inspection of exhaust system slip joints , 5811-04 turbo inlet screen , 5811 ~03 Turbo 111 I"" 1 , , "1 . ll1q11111ent, S810-01 alternate air door hinge inspection .

1 111111.i" I w1 111 Cirrus S.8 2X-32-19R2 Inspection of nose landing gear upper gusset welds II "'"v' ii 11xyqcn cylinder and regulator assembly , PIN 1002NOOOO, SIN HPR10090211509, sent to Precise Flight, Inc for v ' "v' ·1 IL1u l and hydrostatic cert . Ref Precise Flight work order# 89237 and FAA form 8130-3 dated March 20 2015

1 o 1111 .i,..o I w1l h al ternator# 1 500 hour inspection, replaced brushes, PIN ALE1013AS 111 1 o1 11 o ·d lower cowling nose gear strut closeout seal PIN 20665-003. 11, "" ovo ·ii nose gear assembly, replaced rebound bumper PIN 18380-001 , strut pivot bushings, P/N's 13705-003, NAS77-8-11•,11 1111 I NAS77-10-013. Reinstalled nose gear assembly. 110 f'I." '·d left side baffle assembly with new PIN 22-5850005.

1'1 11111vcd left forward baffle assembly, replaced sheared rivets and reinstalled . I·, 111. 1<.ed air conditioning compressor drive assembly grommets and spacers , PIN 's 1133089-4, and 11 33089-2

I 0 I io pl.1ced right wastegate interconnect linkage pin MS20392-2C13. 1 1 I '• ·.t~il led left and right brake calipers, MS28775-222 0 -rings and installed new temp indictors, PIN's 51698-001 and -003

'" 1 viced and bled brakes. 1 1 l i q1laced left elevator outboard hinge pin with new PIN 11621-002 • 1. "'"d and serviced K&N engine air filter. Inspected aircraft exhaust, fuel and oil systems, landing gear, structure, wings , , .. 111101 systems and overall aircraft condition . C/W inspection instructions for continued airworthiness for installed STC's, and 1 • rs A list of AD's may be found in aircraft records. I certify this aircraft has been inspected in accordance with an annual

i "1 .pect1on and determined to be in airworthy conditi~~~----------END-------------- 2 I

/ Terrill Shafer /--.;;7 AP28602791A (__./

I r MAKE C:rrus ~OOEL SR22 Tur1:>o s ~ 3370 REG NO 69YY WORK ORDER 17912

Airframe Entries

r r r r l Kim Davidson Aviation, Inc.

Repair Station No. YYKR676L 2701 Airport Avenue Santa Monica , CA 90405 Phone: (Maint 310-391-8293) (Avionics 310-391-0892)

I r r DATE: 8/16/2015

AJC TSN 850. 1 HOBBS 650.1

Performed 50 hr. servicing of aircraft brakes, battery, lights, tires. Lubricated flight control surfaces and engine controls. Ran up and no leaks found .----Replaced Main battery w/new Concorde Sealed RG24-11M. ----Replaced RH strobe light bulb assy. w/new.----Replaced LH brake pads w/new. Function test checked good.----Replaced RH tailpipe to airframe ground strap w/new.----Adjusted & tightened clamps on LH & RH exhaust heat shield.

Maintenance Release

DA TE 6/16/2015

MAt<E Cirrus MODEL SR22 Turbo S.'N 3370 REG NO 69YY WORK ORDER 17938

Airframe Entries

Kim Davidson Certified Repair Station No. YYKR678L

Kim Davidson Aviation, Inc.

Repair Station No. YYKR678L 2701 Airport Avenue

Work Order. 17912

Printed by EB1s 3 (datcomedia com)

DATE: 91312015 AJC TSN: 879.9

FLIGHTTIME 879.9

Santa Monica, CA 90405 Phone: (Maint 310-391-6293) (Avionics 310-391-0692)

Reattached air ducting for pilot's air vent.----lnstalled seat stop for co-pilot seat.

Maintenance Release

· ·d 'f d b as repaired and inspected in accordance with the The aircraft, airframe, engine , propeller, or appl1anAced 1 ent~ ieto~ ~~~~APPROVED FOR RETURN TO SERVICE current maintenance ru les of the Federal Aviation minis ra' ~------

~ }' WOl1< Order _· 17938 DATE: 9/3/2015 SIGNED ~L__ .'::.'.~::...:'.'.::".:.'.'..~-------=K~im~D=-a=-v-id-s-onL.L..--'--'--L--:/7',_.,.,~--~ Printed by EB is 3 (datcomed1a.com)

Certified Repair Station No. YYKR678L

l> I"\

-0 "" -0 "' "" -0 0 l> <Z -n z -< "' .l> --"' "" -< I"\

"" l> :i

'<

Airframe Entr es

Reinsta lled Engine 10 - :s:-~ s - ;o::::-: = = -~-= · - - -884.9.----Reinstalled Prop Governors":::-:::-;:·=_:- ~ ;:_,, . - ~ Replace prop governor gasket w/new ···-C 'Vv -err a:: : : . :: ·: :=-:- -= =: -- - ~- = - -Assy Field Repair Kit lnstallation----C/W Cleaning & Re-c :' ~:. \ :-; -= = • ·-= - - · -TAT-SI08-05----Replaced high pressure hose w/new for air cone ;,c- cc- :·:oo: · :; :: ::.=-: . : - : ~.' O-rings w/new. Serviced air condition system w/freon ----Replaceo ;: · EGT SE"s:· .-. -E , --- :;:--. -= Altimeter System and Altitude Reporting Equipment has been tested IAW FAR 9" ,, . ·a·:':,-:·:::.:-:· with FAR 43 Append ix 'E' and that the ATC Transponder has been tested IAW FAR 91 413 a•o ':- -: :: comply with FAR 43 Appendix 'F' . Tested to 30K feet. FAR's NExt Due 11 /2017----Removed MCU • ~~ s -00479. Insta lled new MCU 140 sin 3525. Function test checked good .

Maintenance Release

The aircraft , airframe, engine , propeller, or appliance identified above was repaired and inspected in accordance with th6 current maintenance rules of the Federal Aviation Administration and is APPROVED FOR RETURN TO SERVICE

DATE 11/13/2015

MAKE: Ci rrus MODEL. SR22 Turbo SIN 3370 REG NO: 69YY WORK ORDER : 18309

Airframe Entr ies

SIGNED :~~ Work Order: 18091

Kim Davidson Printed by EBis 3 (datcomedia.com) Certified Repair Station No. YYKR678L


Repair Stat ion No YYKR678L 2701 Airport Avenue Santa Monica , CA 90405 Phone: (Main! 310-391-6293) (Avionics 310-:S91-0692)

DATE: 1/29/2016 AiC TSN: ~09 2

F LIG~TTIME: 909.2

Purged LH & RH Wing & Elevator TKS panels TKS w/Oe-ice fluid per Cirrus MM. Even flow across panels. ----Serviced Oxygen Bottle IAW standard maintenance practices.----Replaced ground strap w/new for RH exhaust tail pipe.----Replaced air condition drive/bearing housing & drive shaft w/Serviced Exchange from Cirrus. Function test checked good.----C/W Chadwick Dynamic Prop Balance & Balanced Prop to .05 IPS. ----Cleaning & Re-oil of K&N engine air filter IAW Tornado Alley TAT-SI08-05 Instructions.

Maintenance Release

The aircraft , airframe, engine, propel ler, or appliance identified above was repaired and inspected in accordance with the current maintenance rules of the Federal Aviation Adm1nistr lion and 1s A ROVED FOR RETURN TO SERVICE.

DATE: 1/29/2016 SIGNED: Work Oraer. 18309

Kim Davidson Cert ified Repair Station No YY KR678L

I I I -·:: : --~

Airframe Entries

I I I I I I I I I I I I I t I @

Kim Oav1dso11 Av1c:t1on , Inc

Re pa ir .s•at10'1 No ' YKRG78L 270 1 Airport Ave~ J e

Santa Mor.•':<' CA 904C5 PhMe (Ma1nt 3i0-391 6293} (Avionics 310-391-0692 )

DATE. 216/2016 A/C I SN· 91 ~ .4

fUGH-""." IW.E : 9 11 4

Res acea s!arter relay cantactor wi new inside MCU. Function test checked good ----Repaired/Spl iced new :. ·e & ;erm1nal for Alt #2 Function test checked good .

'h : -·e'"'a,,ce Release

-- e; •c•aft a,r'rame. engine, propeller or appliance 1aentif1ed above was Repaired & Inspected in accordance with the current -,, "'c 0 acce '"'~ s of the Federal Aviation Administration and is AP PROVED FOR RETU ERVICE.

:,:, - E 216!2016

........ ; .. ': 'r:...:~ . \'OC.::;_ sq22 turbo s \, '.! : -;:i ~EG 1-..1 0 69YY WoJRr< CRWER 8480

Airframe Entries

SIGNED·

Kim Davi son Cert ified Repair Station No. YYKR678L

Work Order. 18332

Printed by EB1s 3 (datcomed ia com)

:-,\ - ~. 'r'' 2 '?.·.'. ~ :_ A.JC rs~~ - ;;3 ;:;

FL..1 -31 .. TTIME: 92'3

I certify that this A ircraft has been Inspected in accordance wit11 an ANNUAL Inspection per Cirru s Checklist and has been determined to be in AIRWORTHY CONDITION .----1 certify that th is Propeller has been Inspected in accordance with an 1 OOhr Inspection per Cirrus Checkli st and has been determined to be in AIRWORTHY CONDITION .----C/W Maintenance Checks IAW Tornado Alley Continued Airworth iness 22-6460004 including TATI Service Bu lletins----C/W 100hri 12mo Cleaning & Re-oil of K&N engine air filter 2 IAW Torr.ado Alley TAT-SIOB-05----Performed 12 mo ELT Test & Inspection IAW FAR 91 .207(d). FAR 1 91.207 Next Due 5i2017. ELT Batteries Expire 912021. ----C/W Battery Capacity test per battery iCA. Found '\ to be at 99%----C/W Am-Safe Airbag Restra int Diagnostic Test , checks good at tn is time good . ) ----Researched All AD's through Bi-weekly issue 2016-09----C/W ?yr Inspection of Am-Safe Seat Belt ' Inflatable Restraint System Electronic Module Assembly. Removed EMA sin 05SEP08· 129 and Installed ' Rebuilt EMA Assy sin RA 12MA Y16-2 . EMA Assy Next Due 5i2023.----Replaced EL T Remote Switch Battery wi new. Remote Switch Elattery Expires 3i2024.----C/W SB 2x-28-12R1 Electric Fuel Pump Inspection . Performed Electric Fuel Pump Leak Check per Ci rrus MM & Inserted TPOH Rev15-27 into AFM/POH .----C/W Cirrus SB 2x-42-1 1 Perspective System Software Update to v0764.24. Inserted TPOH Rev 15-21 into AFM/POH.----Rebui lt Co-pilot RH brake master cylinder by Replacing master cyli nder 0-rings & sea ls w/new. Bled Co-pilot brakes & leak test check good .----Reattached RH & LH bottom inboard wing root w/new double sided tape per Cirrus MM.----Reinstalled LH aileron after Cleaning & Torque of aileron actuation bolt per Cirrus MM.----Replaced RH brake pads & RH brake caliper insulator shim w/new Function test checked good .---- lnstalled anti-chafe tape to inboard lead ing edge of RH flap----Replaced LH & RH cab;n entry step non skid tape winew.----Reinstalled pi tch trim motor assy after tight.,n ing & Re-torque of : ·c>- \· or motor mounting bolts to mounting bracket per Cirrus MM----Replaced landing light lens cover

- - - - ;.- - -;. :·::..; ;;.· :· 2:: a ... :e :::e...,: 'ea aoove was Repaired & Inspected 1n accordance wtth tne current

---~',_-:~:-~~~a: sAP~R~~SERVICE ,, , ~~ oeo1~C

, -----.-;. - · ~: :. EB s 3 ldatcorned1a com) --

MAKE. Cirrus MODEL· SR22 Turbo SIN 3370 REG N0: 69YY WORK ORDER 18675

Airfram e Entries

San:a Monica C .:., '? ::.!. ·: Phone i Ma1111 310-39" -~i:~~

Performed 50hr servicing of aircraft brakes, battery, lights. tires Lubricated fl1gct cc-;-: ;, ~ ,, :~: :- : o· ~ -o controls. Ran up and no leaks found .----C/W Tornado Alley Turbo Maintenance checks IA:J -~-a::~ ~ Continued A irworthiness 22-6460004.----Replaced Rrl main tube & ti 1·e wlnew 15x6 00-6 6Ply Goo: 1e: · FClll. Cleaned & Repacked wheel bearings. Installed shim to correct for inboard wear. Re1nstallea RH ~a -wheel.----Removed CO Detector sin 85852. Installed Rebuilt & Calibrated CO Detector sin 85696 Function test checked good.

Maintenance Release

The aircraft, airframe. engine, propeller or appliance identif ied above was Repaired & Inspected in accci"rdance with the current maintenance rules of the Federal Av1at1on Adm1n1strat1on an is APPROV FOR RETURN TO SERVIC~

DATE 9/23/2016

ERR'V

SIGNED

Kim Davidson Cert1f1ed Repair St8t1on No. YYKR678L

I 200CT 2016

N#: N69YY

I I I I I Tach: 992.9

Type: SR22

Printed by EB is 3 (datcomed1a co"' )

~z -n "' VI VI "O AO O rn z" l> = o= .,,o

\CO ~~

S/N: 3370

formed wing strike Inspection ref. Cirrus Maintenance Manual 05-50, Page 1, Para 2 (A). No discrepancies noted. Removed r ~tip and replaced with new, PN: 21910-002-01 Trimmed trailing edge, primed and painted trimmed area -EN[)..-

, Jeffrey Fay 26793151

I II ~ I

:::::

10-55.:J-N !:.:\G l\i:: S/N· 6S2:2CG r'<~G N069YY WORO\ ORO::::<' 18852

Log Entries

f '1 I..·-----·-·. Kim Dav idson Aviation , Inc .

Repair Station No . YYKR678L 2701 Airpor~ Av enue Santa Monica, CA 90405 Phone• (Ma111l 310-391-6293j (Av10111cs 3~ C-391-0692~

DATE: 11122/2016 A.JC "TSN 1002: Ef\IG TT: ~002. t

FLIGHTTlW!:: : 1002 ~

C!'vV Tanis Engine PreHeat Kit lnstal:ation STC# SE03309C!-l lnstai!ed Kit pin fSP6CYL-2927-115 sir. 51052 per Tan is Installation Document No. TNP2927 Rev E. Installed Fiush Mount Plug to LH Engine Baffle per Tanis Instructions Document No. TN02533 Rev B Installed Indicator Light to LH Engine Battie per Tanis Instruction Document No. TN0309. Inserted POH Supplement Document No TPG0001 Rev F. W&B has bee~ ~E'J1sed , See POH for W&B dated 11/2016. See copy of FAA 337 Form by KDA dated 11/2016 for niore 1:i:o on Tanis Installation. Tanis STC pape:work . including ICAW Install Manual & 337 put with log bocks

Ma ir,te'la·-:ce Release

T--:e a1~c·a':. a1rfrar11e, eng.ne, propeller or app!iance 1dent1fted above was Repaired & Inspected 1n accordance w;t'i tne current , ... 2.r~e'"'a ..... ce r:..;~es of the Federal Av 1at1on Adrn1rns!ra::u~ and is APPR.OV - R RETURN TO SERVICE.

CPTE ~ "./2.?/2816 SIGNED Wor'< Order 18852

K.m 8av;dson Pnntec by EB1s 3 (datcomed1a corn) c:c~~,f-~d Reoa•r Station No YYKR678L

~ of 1

EPANCY LIST 'PROVING AIRCRAFT FOR SERVICE

11 I''' HI• _ ....... ~.~

II• II•

11•1 II

INSPECTION RECORD .........

Lone Mountain Aviation, Inc.

Repair Station No. L90R473Y 2830 N. Rancho Dr Suite A Las Vegas, NV 89130 Phone: (702) 309-2200

DATE 1212712016 A/C TSN 1007 8

FUGH IT IMC 1007 8

1111 11111 I 11ln11s

1 1 ",, ,. ,, "1 1" 1111 wu ig inboard TKS panel PIN 18689-002 S/N AST08K029 Installed new TKS Bas1c2 panel PIN 18689 002 SIN AST08K 199 to

I l ! I I It vtlll I ()p'.. c.t1ecked good. IAW Cirrus SR22T MM 30-10. 1 .i """"'"'"!Jill wing outboard TKS panel PIN 18689-006 SIN AST008J821. Installed new TKS Bas1c2 panel PIN 18689-002 SIN CAV116J304 to

" 1 .r 1111 w 11u1 IAW Cirrus SR22T MM 30-10 1 111d '" l 1. 1111lnd lop engine cowling IAW Cirrus SR22 MM 51-20

1 1 1 1. 11 1 11. 11 10 all rKS sealant edges after replacement of TKS panels IAW Cirrus SR22 MM 51-20

1 111d 1t>pl.teed top engine cowl 011 door hinge IAW Cirrus SR22 MM 51-20.

11 .,, r .111 , 111d/or component 1dent1fied above was repaired and inspected in accordance with current regulations of the Federal Av1ation Adm1nistrat1on

11 1 11 •1•111vt '<I for return to service. Pertinent details are n file at this fac1l1ty under the above W .O number.

I I/\ 11 \ ')/27_1_2_0_1 _6 ______ _.c,=..:::::;;;;:;,,.~~:22""1('.,l.~~!S..<!'C..~~~~'..!..JO~~~ ...... '-----W--o_rk_O __ rd_e_:_r_: 9::...4_5_4_-_12::...-_2_:_0_16::... Printed by EBis 3 (datcomedia.com)

I N# 6ci rr ASN 0i- 3 3 za WO# _________ Hobbs J230, 'J, Performed required post maintenance flight test IAW CDC PS

90500~90504 throughout its normal ranges of operation

and found sa tisfactory .

Pilot: Brett Scheide Cirrus Engineering Flight Test Pilct

A --=/ff/~",/' Signature: ~__p-- Date 20 Oec /C

I

=

MAKE: Cirrus MOOEL SR22 Turbo SIN· 3370 REG. NO 69YY WORK ORDER 18935

Airframe Entries


Repair Station No YYKRB78L 2701 Airport Avenue Santa Monica, CA 90405 Phone: (Maint 310-391-6293) (Avionics 310-391-0692)

11~ I DATE 31312017

AIC TSN 1028 2 FLIGHTIIME 1028 2

Performed 50hr servicing of aircraft brakes, battery, lights, tires and lubrication of surface and engine controls. Ran up and no leaks found.·---Tightened induction clamps as needed.

MAKE: Cirrus MODEL: SR22 Turbo SIN 3370 REG. NO 69YY WORK ORDER 19112

Airframe Entries

@ Kim .Davidson Aviation, Inc.

Repair Station No YYKR678L 2701 Airpart Avenue Santa Monica, CA 90405 Phone (Mamt 310-391-6293) (Avionics 310-391-0692)

DATE 512512017 AIC TSN 1058 7

FLIGHTTIME 1058 7

I certify that this Aircraft has been Inspected in accordance with an ANNUAL Inspection per Cirrus Checklist and has been determined to be in AIRWORTHY CONDITION.----1 certify that this Propeller has been Inspected in accordance with an 1 OOHr Inspection/Cirrus Annual Inspection Checklist and has been determined to be in AIRWORTHY CONDITION ----C/W Maintenance Checks IAW Tornado Alley Continued Airworthiness 22-6460004 including TATI Service Bulletins.----C/W 100hr/12mo Cleaning & Re-oil of K&N engine air filter IAW Tornado Alley TAT-SI08-05----Performed 12 mo ELT Test & Inspection IAW FAR 91 207(d). FAR 91 .207 Next Due 5/2018. EL T Batteries Expire 9/2021.----C/W Battery Capacity test Per Gill ICA. Found to be at 108%--C/W Am-Safe Airbag Restraint Diagnostic Test, checks good at this time good. ----Researched All AD's through Bi-weekly issue 2017-10 ----Sealed Traffic, #1 Com, #1 & #2 GPS antennas w/sealant per Cirrus MM.----Re-torqued pilot door attachment hardware & Adjusted pilot door top & bottom strike pins on fuselage.----C/W SB 2x-52-08 R2 Catcher/Diverter & Gas Strut Rod End Replacement on LH & RH Cabin Doors.----Replaced fresh air duct from cowling inlet to air mixing chamber w/new.----Replaced decal for bottom row circuit breaker panel w/new----Removed pilot LH brake master cyl. & co-pilot RH brake master cylinder. Cleaned & tightened hydraulic fittings. Reinstalled pilot LH & copilot RH brake master cyl. Bled brakes. Leak test check good.----Tighten & Torque rudder middle hinge bolt. Replace bearing w/new in bottom hinge bracket mounted to rudder. Replace hardware w/new for bottom rudder hinge bracket.

1of2

'.'a - '. ~-a-ce qe ease -- .:- ~ ·:.-=- :: _.·a-e e-; -.e p~ope•ler or appliance 1d~t 1f1 ed-.a'bove was Repaired & In ec d 1n accordance with the current - : - =- :- :: -- es ::' --= =e:~·a ~.a'. c· Ad~10 s)lation and 1s APPROVED FOR RE N 0 SERVICE

/ ,,,. .,If .7 - · o ~·.=:/ ~_..........~ Y WorkOrder 19112

- • ""' 41":- -~

I c ...

\,'-·.: : -'J:::._ ~=..::.: -_-.,....: s ·, ;;-: REG ~,: :~·" WORK ORDER ~ ;~:-

Airframe Entries

Sa-i A • if.-:• .... .; ril.ii ,,,-

Replaced RH main tire w/new Reinstalled rra - ""*

Maintenance Release -The aircraft. airframe, engine, propeller or appliance 1dent maintenance rules of the Federal Av1at1on Adm1nistra ~arr~;~~;~,:~~::,~,-~~ ~~~ =:.r '"· - -~ -~ DATE 711412017

MAKE Cirrus MODEL SR22 Turbo SIN 3370 REG NO 69YY WORK ORDER. 19355

Airframe Entries

SIGNED

Kim Davidson Cert1f1ed Repair Station No YYKR678L


Repair Station No YYKR678L 2701 Airport Avenue Santa Monica, CA 90405 Phone (Mam! 310-391-6293) (Avionics 310-391-0692)

_,./ _ ... Pnnted by EB s 3 :a:::-~: : :~ -

DATE 9/29/2017 AIC TSN 1091 .2

FLIGHTIIME 1091 .2

Performed 50hr servicing of aircraft brakes, battery, lights, tires and lubrication of surface and engine controls. Ran up and no leaks found.----C/W Tornado Alley Maintenance Checks l/A/W Tornado Alley Continued Airworthiness 22-6460004----Serviced Oxygen Bottle IAW standard maintenance practices. ----Replaced TANIS Heater indicator LED light w/new per T IS instructions. Functi e checked good.

Maintenance Release The aircraft, airframe, engine, propeller or apphanc en ce with the current maintenance rules of the Federal Aviation Adm1 rat1

DATE 912912017 Work Order 19355

Kim Davidson Printed by EB1s 3 (datcomed1a com) Certified Repair Station No. YYKR678L

z .,

MAKE Cirrus MODEL SR22 Turbo SIN 3370 REG NO 69YY WORK ORDER 19207

Kim Davidson Av iation, Inc.

Repair Station No YYKRB78L 2701 Airpor1 Avenue Senta Monica, CA 90405

II

DATE 7/1412017 AJC TSN 1 066 3

FLIGHTIIME 1066 3

Phone• (Maint 310-391-6293) (Aviomcs 310-391-0692)

Airframe Entries Replaced RH main tire w/new.

Maintenance Release. The aircraft, airframe, engine, propeller or appliance 1 nt1fi maintenance rules of the Federal Av1at1on Adm1nis t10

DATE. 711412017

MAKE: Cirrus MODEL SR22 Turbo SIN 3370 REG. NO: 69YY WORK ORDER 19514

SIGNED

Kim Davidson Cert1f1ed Repair Station No. YYKR678L


Repair Station No. YYKR678L 2701 Airport Avenue Santa Monica, CA 90405

Work Order 19207

Printed by EB1s 3 (datcomed1a com)

DATE 12121/2017 AJC TSN 1124 2

FLIGHTIIME.11242

Phone: (Maint 310-391-6293) (Avionics 310-391-0692)

Airframe Entries I certify that the Altimeter System and Altitude Reporting Equipment has been tested JAW FAR 91.411 and found to comply with FAR 43 Appendix 'E' and that the ATC Transponder has been tested IAW FAR 91 413 and found to comply with FAR 43 Appendix 'F'. Tested to 30K feet FAR's Next Due 12/2019.

Maintenance Release The aircraft, airframe, engine, propeller or appliance 1dEll'l!!f1e maintenance rules of the Federal Aviation Adm1nisti:aefon 1s APP RO

DATE 12/21/2017 SIGNED~~~ Kim Davidson Certified Repair Station No YYKR678L

& Inspected in accordance with the current ETURN TO SERVICE

Work Order 19514


: . . r r ,. .. . . ~

...... :

v-::-:.. ~.:

s .... ~,;-:

REG "-IC s;.-,, WORK ORDE~ • *Z:

Airframe Entries

Performed 50hr servicing of aircraft brakes bat:e", :-·; · ·:; _.: - ::.:-=-: • ::- =~ a...: controls . Ran up and no leaks found .----C/W Tornaao-AI e, - _ -::-: '·'-"' -·=-=- _-,, .::-.;-::- !

Continued Airworthiness 22-6460004

Maintenance Release The aircraft, airframe, engine propeller or appliance ident1fl~d ab was Rep~~1 ;;.:..:~':a·:.= • ·· -" -maintenance rules of the Federal Av1at1on Adm1nistrat10 nd PPROVED FOR RETURN TOSERV CE

DATE 1/19/2018 SIGNED ~ --

MAKE· C irrus MOD!::L SR22 Turbo ')1.-l . J37C 1-{EG r..i u 6'lYY WORK URDER: 19625

A irfDme Entries

Kim Davidson Cert1f1ed Repair Station No YYKR678L


kepo1r Sta:1or. No. YVKR678L 270 1 Airi.10'1 Aven·1e Sanlo 'vlon1r-a , Cf.. 9~05 Phnr,e: (W1<11r,1 310-J91 -6293) (AV101"1 1cs 3 10-38 1-0692)

Printed by EB1s 3 (datcorl'ed.a cc-

DATE. 5/11 /2018 NC TSN: 1172.5

FLIGHTTIME 1172.5

CiW CAPS Rocket anr; Paracr.utc Replacement l/A/W CAPS Overhaul Manual. Rerr oved Parachute sin 0J669. Installed Repacked Paracl ,~te ~ In 03324R 1. Parachute Next Due 4/2028. Removed Rocket Motor Assy si n 4587. lr.:;i3 l!ed New Rucke l t.1otor Assy sin 3107. Rncket Motor Next Due 3/29i28.----C/VV SB 2x-9!1-1 f! ct.PS i'?0cket Motor Assy Repbce1 nent per Cirrus Service Bulletin Instructions, CAPS Rocket E:ectric lgnitiu:·, Syst?.m lnstai:ed. Inserted POH revision 1 POl-i 13-08. W&B has been Revised, See POH for W&B dillea 5/2018.----CiW SB 2x-9:i-13 CAPS Strap Inspection and Grommet lnstallaiion----C/VV SB 2x-55-24 R1 CAPS Roc<ei Shelf Ground Wi;e lnsta ll3tion per Cirrus lnstn.1ctian ------. - --- - ---Ma 1ri ten r:tn ~e Release : / The airc1 aft airfrnrr·e engin-$ , propsl!er or appliance irle :i 1ed,above was Repal~ ti & lnspec ··din acco~dance with the current "'a i n t~nance ru les of the Federal Aviation Admin~tibn anc! is APPROVED~- . E ETURN 0 SERViCE.

DATE· o/11/2018 SIGNED:/ ~ ./? fe.-- Work Order: 19625 --- ----- - - -Kim Oav1ds::m PrinLP.d by EBi!:> 3 (cJ atr:ori 1eCJia .com) Ce-tieed Repeir Station No. YYKR678L

11~~1

MAKE Cir rus MC ,_ 1tl: SR2Z Tui bo Si f\o . 337J REG. rJO. 68YY 'NORl': ORDl::.R. 19742

Airframe l:"n : ri ~s


P.ep~ir Station No YYKK67SL 2iu ~ Airnort Avenue Santa '"10nica, CA 9U405 Prone: (M;:imt 310-3S1-f.2.4J) (A1 i0'1ics 31 0-391-C69.i)

DATE· 5/ 1412~ 18

AIC TSN: 1172 5 1-=LiGtfn IMC::: : 1172.5

1 certity that thi& Aircraft ha~ been !nsµe~ted in accurdance will 1 an ANNUAL lnsi:iectinn per Cirrus Checklist 31!d hr-sheen ~ettirmine :J tc be in AIR1VO"-THY CONDITION .----1 certify that th;s Prope:ler has been li~~;:iec!ed in acGo;dance with im 1 OOf-i.- Inspection/Cirrus Annu;~I ln~pection Che-:klist and has been determined to be in AIRWORTHY CONDITION.----C/W Maintenance Checks \AW Torn<id<J Aliey Continued P..irworthiness 22-6460004 Including lATI Service Bulletir.s.----C/W 100hr/12mo Cl:.>aning & Re-oil of K&N engi~c Air Filter IAW Tornado Alley TAT-S108-05----Performed 12 mo ELT Test & Inspection IAW FAR 21 .207\d). F/'.R 01.207 Next DuP 512019 . EL T Ea'.'.enes Ex;:iire g/2021.----Cl'v'/ Battery Capacitv test Per Gill \CA. F,1~11d •o be ate 1 %----C/W Am-Safe Airbc\g R:>straint Diagnostic T%t, checks good al this time good ----Researched Ali AD's through Bi-wce~ ly issL1e :;,a ;8-08.----C/W 4SOhr Tirne Cildnge of V-Band Cla'l1ps ~er Torr.aJo Alley Turbo lni:: \CA. '/-Sands Next Due 1522.50 Flight Meter----C/W 2yr/500hr Roplacement of #2 BatteriPs w/new. Next Due 512020 or 1672.5 Flight Meter.----C/W 3yr Reµlacement of Pressuri?ed Mag Filter pe· Tornado All~y Turbo Continued Airworthiness 22 -6460004----Replaced Ai1 Condit;on hose assy w/new, ho:;e un t~e inside cabin from the f;rewal1 fitting to the condenser. Serviceo AC system w/R134 Freon per ;::nv;;o MM. :=unci;nn test checked good .----C/W Tern ado Alley 1 urbo TAT Sl11-03 Replaced LH wa~te,;iate T 0p & Bottr,1.t su;:iport hracket busripg's, su;ipon bolt 0. spring wlnew. C/W alignmP.~t of wasteg<J'.e support :;yshm -· --CIW Tc;rn;;,do Alley Turuo lAT s :11 -03 l~sta:led new anti-~hafe siEeve on RH & LH turbo support roe and Cnec!te<! alignment of turbo support system .----Reµlaced nose wr.eel fa iring RH mou!lting bracket w.'r.ew- ·-lrostalled nev.- tePtn ar.ti-cr.afe tape ~o leadi0g edae of l H fl;io .----Reattilched LH bol101n wing root w/new c!0uble sidea tap:? ~-er Cirr~s MM.---- lnstal!ec naw "No Push" placard to LH El,wator. - ---lnsta l:ed new

"No Puf,h" p:~c.:ir0 to RH [levator lnst'l llea new "CAPS Vv:.i'ning" placards on aircraft fuselage .

______ , ~-+----Maint0nance Release· / } The Bircraft, z,r~rame . eng1r1e. prc,1el!er or applidnce 1tl f1fie~bove was Repatrec! ..,,,~ected in riceonJsnce 'hith the current mamtP.r1ance rutes of the FedE:ral A'lia tion Admirlislf n1('~3 Ar:Jf"O~ED FO I N'T() s4v1ct.

DATE: 5114/2018 SIGNEU: · / ~ / p Work Order 19742 -------------·;;,; ~id•on ---------~L------------------

Cert1fied Rerair Station No. YYKR678L Printed by EBis 3 idatcomedia .con1)

MAKE: Cirrus MOUr::L: SR22 Turbo s1:..i. 3370 REG. NO: b9YY WORK ORDER 19784

Airfrar.ie l::ntries


R3J.ia1 r St.::t11on No. YYKR679L 2701 Airport Av<?.,uc S<:tnta Mof'1ca CA 90405 i:..110M. (iv1a1n1 3 10· 3~1-62S3) (Av1omcs 31 0-391-uoS2)

DATE. 512412018 A.IC TSN : 1181 .3

FLIGHTIIME . 1~ 8 1.3

SM" ~:;a 2.,·42-12 Gnt'Tl1n PerspP.ctiv€ Software Updnte v07f.4 .35 per Cirru s Instructions. Replaced PFD & MFn bottom Garm in SD cards w/new. Function test checked good.

Mointenarice Relea~e ·

Tt-i~ a1rcr2ft. airfr3me, engin!7, propeller or a~pliimce identified above was Repaired & Inspected in ::iccordance with the current ~a1r:era;1cc rcies of 'he rederal Aviation Administration and i> APPROVED FOR ;fURN TU SERVICE.

~:_-_2 5 2~--- 5 '~NED~~~L,~~~===-----~~~~'.::!~84 Shane Wilson Printed lJy EBis 3 (datcomedia .com) :er. fie'1 Re~air Station No YYKR678L

MO!:>C.L si:;,.z .. - - -~.'N 3370 PE:.G f'll0;l1Wl; WORK ORDER 1 ~ 78G

Airframe Entries

- : • :. - - !.

·.:. .> .:. $3r:a •.• Pnof"le (M2 rt;·.-:-~ ·--

,o.;rc,af: Tail# has been C~anged io N21WE. Removed aircraft ta1 = N69Y1 ' · ~- ·.;: ::: : = aircraft ta il# N21WE i~st~lled on fuselage 0faircraft. Replac,ed Aircraft N:: p<acarc or -··=-:· :c-~ ':: , 1g~i'. , ur, switch with N2' W E. C/W c0cifigurafon of lransponder & Traffic, system for ne" :a = •.: · :. :: :-c· Garmin MM function test ~hecked good.

Mamtent:mce Reh~ase : Th8 air..;ra.ft. ai rfra~e:. . engine , propell1::r or applianc.;e i~ertified above was R.ep~ ired or lnspec:ec ;r acco1dance with current m<iin tenJnce rules of the f Pder.JI viation Adrr.ir. ;st1ation a · APPROVED FOR RETUR'J TO SERVICE.

OAT:: : 8/ 11201R SIGNED:

•~im Oavidson C'ertifi~d Repair Station No. YYKR678L

V'l ork Order 19786

Printed by E8is 3 (datcomedia .com)

z~ oz . c O o .,,.,, "O -'" z ,, "' "' "O 0 '" Zn >:::i "O 0 "O z " I OU> < -< -> z -< C'\ C::

o"' ,, Ro cc Vi Vi > ,.., "O ,,

"O '" ,, "O o > <Z - ,.., Z < "' > -- "' "' -~ ~

MAKE Cirrus MODEL SR22 (TN) S/N 3370 REG NO. N21WE WORK ORDER Murneta9496-04-2019

Airframe Entries

·r I

Gryphon Aircraft Services , LLC.

Repair Station No CRS 2SOR2718 37680 Sky Canyon Drive #602 Murneta CA 92563 Phone 951-698·4260

.. II ·1

DATE 711/2019 AIC TSN 1335 3 HOBBS 1335 3

Leak checked NC system found service port valves and High pressure hose from Compressor to firewall leaking Replaced valves and hose with new evacuate system and service system. ops check o k Completed 100 HOUR INSPECTION per Manufacturer's and Gryphon Aircraft Services Inspection forms· Lubricated airframe per MM. Inspect and test EL T per FAR 91 207(d) and found to meet requirements replace battery by 09/21 See AD note update sheet and master list for complete AD note history thru this date and current rev1s1on CIW Tornado Ally ICA22·6460004 CIW Precise flight ICA 102NMAN0003F Replaced LH flap IAW Cirrus AMM section 57 Performed flap operational test IAW section 57 Complied with SB2X-74-02 Ignition Switch Security application of thread locker to 1gnition switch Replaced LH aft nav bulb Replaced LH main tire & tube with new FClll 6 00-6-6ply & AGL tube Replaced RH main tire & tube with new FClll 6 00-6-6ply & AGL tube Replaced main gear grommet IAW Cirrus AMM Replaced Fire Extinguisher Serviced brake fluid with 5606 Replaced nose gear assy bushings bolts and washers IAW Cirrus AMM section 32 Replaced m1ss1ng CAPS cover panel tape per SB2X-95·24R2 Replaced line cutters nylon cord & break thread per Cirrus AMM Inspected RH caliper & replaced brake caliper yellow temp sticker

I Certify that this AIRCRAFT has been inspected IAW <jll,d ANNUAL 1nspect1on and was determined to be 1n AIRWORTHY Cond1t1on . All work performed IAW applicable service fnc Is or other approved documentation Pert inent details of the repair are on file at this repair facility under Work Orde Mur et ~ #2SDR271 B

DATE 7/1/2019 SIGNED Work Order Mumeta9498-04·2019

Glen Kratz Cert1f1ed Repair Station No CRS 2SDR271 B


1of1

:-..Jud ... I: Serial ": Registration: ,\ C Total Hou1-s: t\ C I .andings: APU I lours:

I. I ! I\\ I ll'l Cirrus SR22 33 70 '.'121 \\' E 1359.0 Cnk NA I 1 I!• 11111\l·d ;111d Replaced :; I Batter) Ass). 11ith Ne11 Uatter). (I' N Concord RG2-l- I 5t\ I). (S N -11035270). secured Terminals.

I l11ld d111111 11\ltire Bolts. and Vent rube. Tested nnd rc-sccu1wl coll'ling all 11ork done in accordnnce 11 ith Cirrus SR22 f\l.11111111.111\c' \L111ual ,\ !',\ 2-1--10. Fig.2-1-309. :111d 71-10.

I );1te: 8 2~ 2019

I cert ii) this aircrall has been inspected and 'or repaired per the Cirrus SR22 1\ppn.J1 ed l'\la1ntenance l\lanu:ll in ,1ccordnncc 11 ith 1-1 CTR Part 91.-IOQ(f-).(3 ). I he aircraft 1s apprm·ed for retun~l >crvice 111th n:spect to the 11orl-. p1:rfonned.

'""";,,,, .\Pl s;,,.m..tf-: _"1y~ "".;,;",.;""" ,\&I'.""'""

'\;Jlllc'.

t\l·RO 1 ROl'IL '>. LLC.

· --- --- --- --- ---- -- ---- --------- --- -- --- -- ----- --- -- --- ------- --· ------ -- I 11d-----------------------------------------------------· --------------------

DATE

~---

:I -

:

l

I



KIND OF INSPECTION-STATUS & DISCREPANCY LIST SIGNATURE - CERT. NO. OF PERSON APPROVING OR DISAPPROVING AIRCRAFT FOR SERVICE

MAKE Cirrus Design Corp MODEL: Sr22 S/N 3370 REG. NO N21w" WORK ORDER 1963-09-2019

Airframe Entries

Lone Mountain Aircraft Maintenance 2460 Greentree Road Hangar 12 Lebanon . Ohio 45036 Phone 888-566-3686

DATE. 9/1112019 AIC TSN· 1676 2

TACH: 1372.1

(1) Removed GTX33 and installed GTX33ES IAW Cirrus AMM 34-50 and Cirrus IPC 34-50 Installed P/N 011-00779-30. SIN 89129863 .. (2) Complied with SB2X-42-17 Perspective Software Update v0764.37

DATE: 9/11/2019

ENGINE MODEL ENGINE SIN REG NO N21WE WORK ORDER 0752-02-2020

Engine Entries

Rex Air Maintenance Center 304 Citation Point Naples. Fl 34104 Phone: 239 649 8822

Work Order: 1963-09-2019

Printed by EBis 3 (datcomedia.com)

DATE 2/25/2020 A/C TSN 1379 II ENG TT 137'J 11

TSMOll HOBBS 1681 1

Drained 011, removed and inspected 011 filter - Found no contaminants. Took oil sample Installed new AA48108-2 oil filter and serviced engine 8 quarts Phillips 20W-50 X/C Ran engine for leak check No leaks detected. No defects noted

T echrnc1ans Who Worked On The Items Listed Above· Franklin Alverez, Mike Faulkenbury

Maintenance Release

The aircraft and/or component(s) on N21WE was repaired and inspected 1n accordance with current FARs rules of the Federal Aviation Regulatmn-. 111• t

was found Airworthy for return to service Pertinent details of the repair are on file at this facility under Work Order No 0752-02-2020, Dated 21?51. 'I I. •11

SIGNED /~ - / .c...---- '-----,-z-. DA TE 2/25/2020 Work Order: 075/ o:> -'" ·11

Mike Faulkenbury. A&P 3140481 Printed by EBis 3 (datcomed1.1 • "'"1

major alterations - aso · 2020. 4. 9. · 1111 ·abov e work was performed in accordanc with...

Documents