interactive schematic - justanswer · click here to view the schematic symbols and definitions page...
TRANSCRIPT
Click here to view the Schematic Symbols and Definitions page
INTERACTIVE SCHEMATIC
The Bookmarks panel will allow you to quickly navigate to points of interest.
Click on any text that is BLUE and underlined. These are hyperlinks that can be used to navigate the schematic and machine views.
When only one callout is showing on a machine view, clicking on this button will make all of the callouts visible. This button is located in the top right corner of every machine view page.
VIEW ALL CALLOUTS
Cover PageTables
SchematicMachine Views
ComponentConnector
Chassis View
Cab View
Engine View
Features
Options
Bookmarks X
EC-C3EC-C2 E-C60
EC-C1
E-C61
To set your screen resolution do the following:RIGHT CLICK on the DESKTOP. Select PROPERTIES. CLICK the SETTINGS TAB. MOVE THE SLIDER under SCREEN RESOLUTION until it shows 1024 X 768. CLICK OK to apply the resolution.
*This document is best viewed at a screen resolution of 1024 X 768.
*Due to different monitor sizes and PDF reader preferencesthere may be some variance in linked schematic locations
FUNCTION Zoom In
HOTKEYS (Keyboard Shortcuts)
Zoom OutFit to PageHand Tool
“CTRL” / “+”
KEYS
“CTRL” / “-”“CTRL” / “0” (zero)“SPACEBAR” (hold down)
Find “CTRL” / “F”
PressureSwitch
TemperatureSwitch
LevelSwitch
FlowSwitch Circuit Breaker
T
ELECTRICAL SYMBOLS
Spring(Adjustable)
Variability
FluidConditioner
Pumpor Motor
BASIC HYDRAULICCOMPONENT SYMBOLS
Click here to save a copy of this interactive schematic
to your desktop
SCHEMATIC SYMBOLS AND DEFINITIONS
HYDRAULIC SYMBOLS - ELECTRICAL
Transducer(Fluid)
Transducer(Gas / Air)
G
Generator ElectricalWire
Pressure Switch
MElectricMotor
Pressure Switch (Adjustable)
TemperatureSwitch
PressureSwitch
TemperatureSwitch
LevelSwitch
FlowSwitch Circuit Breaker
T
ELECTRICAL SYMBOLS
Spring
ControlValves
Restriction Line Restriction(Fixed)
2-SectionPump
MAIN AUX.
Spring(Adjustable)
Variability
Line Restriction(Variable)
PressureCompensation
Pump: Variable andPressure Compensated
Hydraulic PneumaticEnergy Triangles
FluidConditioner
Attachment
Pumpor Motor
BASIC HYDRAULICCOMPONENT SYMBOLS
Line RestrictionVariable and Pressure
Compensated
Vented Pressurized Return Above Fluid Level Return Below Fluid Level
FLUID STORAGE RESERVOIRS
Pressure Temperature Flow
MEASUREMENT
Unidirectional Bidirectional
ROTATING SHAFTS
One Position Two Position Three Position
Two-way Three-Way Four-Way
ENVELOPES
PORTS
CONTROL
BasicSymbol
SpringLoaded
Normal Position
A B
P T
A B
P TShifted Position Infinite Position
Shuttle PilotControlled
VALVES
CHECK
Solenoidor Manual
Solenoidand Pilot
Solenoid and Pilot or Manual
Solenoid Servo Thermal Detent
COMBINATION CONTROLS
T
Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicatesthat the component has screw terminals and a wire can be disconnected from it.
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component.
Ground (Wired): This indicates that the component is connected to a grounded wire.The grounded wire is fastened to the machine.
Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts ofa normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender:
A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure.Its resistance changes to give an indication to the gauge of the temperature or pressure.
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.It has a coil that makes an electromagnet when current flows through it.The electromagnet can open or close the switch part of the relay.
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it.The electromagnet can open or close a valve or move a piece of metal that can do work.
Magnetic Latch Solenoid: An electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.
BASIC ELECTRICAL COMPONENT SYMBOLS
Push-pull Lever PedalGeneral Manual Push Button SpringManual Shutoff
MANUAL CONTROL
External Return Internal Return
Simplified CompleteInternal
Supply Pressure
RELEASED PRESSURE
REMOTE SUPPLY PRESSURE
PILOT CONTROL
Spring Loaded Gas Charged
ACCUMULATORS
Crossing Joining
LINES
Double ActingSingle Acting
CYLINDERSUnidirectional
Bidirectional
FIXED DISPLACEMENT
VARIABLE DISPLACEMENTNON- COMPENSATED
PUMPS
Unidirectional
Bidirectional
Unidirectional
Bidirectional
FIXED DISPLACEMENT
VARIABLE DISPLACEMENTNON- COMPENSATED
MOTORS
Unidirectional
Bidirectional
TwoPosition
InfinitePositioning
FLOW IN ONEDIRECTION
FLOW ALLOWED INEITHER DIRECTION
ThreePosition
CROSSFLOW
PARALLELFLOW
INTERNAL PASSAGEWAYS
1
2
AG-C4111-7898
L-C123E-5179
9X-1123 ComponentPart Number
Pin or Socket Number
Part Number: forConnector Plug
Harness Identification Letter(s): (A, B, C, AA, AB, AC, ...)
Plug
325-AG135 PK-14
Wire ColorWire Gauge
Receptacle
1
12
2Sure-Seal connector: Typical representationof a Sure-Seal connector. The plug and receptacle contain both pins and sockets.
Deutsch connector: Typical representationof a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.
Fuse (5 Amps)
5A
Harness identification code:This example indicates wire group 325,
wire 135 in harness "AG".
L-C123E-5179
Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes (see sample).
Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness (C1, C2, C3, ...)
HARNESS AND WIRE SYMBOLS
UENR2648May 2013
C18 SCAC Marine GensetElectrical SystemJHL1-UPDTP1-UP
Printed in U.S.A.© 2013 Caterpillar, All Rights Reserved
Components are shown installed on a fully operable engine with the key and engine off.Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
SCHEMATIC PART NUMBER: 382-9672, CHANGE: 00, VERSION: -
THIS SCHEMATIC IS FOR THE C18 SCAC MARINE GENSET ELECTRICAL SYSTEMMEDIA NUMBER: UENR2648
Note: Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
12345678
A
B
C
D
E
F
12345678
A
B
C
D
E
F
ABBREVRDWHORYLPKBKGYPUBRGNBU
COLORRED
WHITEORANGEYELLOW
PINKBLACKGRAY
PURPLEBROWNGREENBLUE
SYMBOL DESCRIPTION
BLADE, SPADE, RING OR SCREWTERMINAL
CIRCUIT CONNECTED
CIRCUIT NOT CONNECTED
ELECTRICAL CONNECTION TOMACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTIONTO SURFACE OF COMPONENT
CONNECTOR
ATCH WIRE, CABLE, COMPONENT
SPLICE
CIRCUIT GROUPING DESIGNATIONH#
SENSOR / ACTUATOR SUPPLY
(+) BATTERY SWITCHED
SIGNAL TO ECM
(+) BATTERY
(-) BATTERY / SENSOR RETURN
STARTING CIRCUIT
CAT DATA LINK
CONTROL (POSITIVE) FROM ECMCONTROL (RETURN) FROM ECM
J1939 DATA LINK
HIGHWAYS
PARTS LIST
IDENT PART NO. CHG DESCRIPTION
AJ 424-5193 00 ALM & PROTN EXT HARN- 5m
AJ 424-5196 00 ALM & PROTN EXT HARN- 10m
AL 359-4974 00 AIR START
AP 345-9178 03 ALM & PROTN (LH)
AP 356-4049 03 ALM & PROTN (RH)
CD 338-3387 03 GENERATOR INTERNAL
E 356-3395 00 GENSET J1 INTERFACE (RH)
E 345-9086 00 GENSET J1 INTERFACE (LH)
EJ 424-5192 00 L3 PANEL EXT - 5m
EJ 424-5195 00 L3 PANEL EXT - 10m
EL 359-4970 01 ELECTRIC START
EM 397-2919 00 REMOTE E-STOP (5M)
EM 397-2921 00 REMOTE ESTOP (20M)
ET 397-2935 00 REMOTE E-STOP PANEL
GG NOTE C GENERATOR RTD (SR-4B)
GN 372-5035 00 GENERATOR INTERFACE
JE 363-4033 00 ENG OIL LVL JUMPER- OPT
L 357-4916 00 GENERATOR EXT (RH)
L 348-7097 00 GENERATOR EXT (LH)
LJ 424-5194 00 GENERATOR EXT HARN- 5m
LJ 424-5197 00 GENERATOR EXT HARN- 10m
N 351-1765 02 ALT TO STARTER (NEG)
R 351-1766 02 ALT TO STARTER (POS)
XA 347-1248 01 TRANSFORMER
XB 347-1248 01 TRANSFORMER
WIRES IN THE FOLLOWINGGROUPS SHALL BE TWISTED:ONE TWIST PER 25 MM.
WIRE GROUP WIRE NAME
AP TW1 E963-AP11
AP TW1 E964-AP10
E TW1 944-E38
E TW1 945-E5
E TW2 944-E3
E TW2 945-E4
E TW3 944-E39
E TW3 945-E37
SERVICE TOOLCONNECTOR(J60)
CONNECTTO MGCP OREJ-C1
BTRY (-)
UNSWITCHED BTRY (+)
SECONDARY THROTTLE POSITION
CAT DATA LINK (+)UNSWITCHED BATTERY (+)
BTRY (-)
J1939 DATA (+)
UNSWITCHED BTRY (+)
J1939 DATA (-)
CAT DATA LINK (-)
PRIMARY THROTTLE POSITION
REMOTE SHUTDOWN SWENABLE DIGITAL THROTTLEDIGITAL THROTTLE LOWER
J1939 SHIELD
REMOTE STARTKEYSWITCH
BTRY (-)
SMMS RETURN
KEYSWITCHBATTERY (-)J1939 SHIELD (NOTE A)CAT DATA LINK (+) CAT DATA LINK (-) J1939 DATA LINK (-) (NOTE A)J1939 DATA LINK (+) (NOTE A)
159-R1 RD-4
255-N1 BK-4
MONITORING SYSTEMS OVERRIDE
EVENT RESETLOW IDLE SWITCH
RUN / STOP
C214-EL4 BK-18-GXLC214-EL5 BK-18-GXL
T789-EL7 YL-18-GXLT789-EL8 YL-18-GXL
T789-EL6 YL-18-GXL
CRANK OVERRIDE
UNSWITCHED BTRY (+)
BTRY (-)
F701-EL2 BR-18-GXL
C214-EL1 BK-18-GXL
T789-EL3 YL-18-GXL
C214-EL1 BK-18-GXL
T789-EL3 YL-18-GXLF701-EL2 BR-18-GXL
C214-EL4 BK-18-GXLT789-EL7 YL-18-GXL
T789-EL6 YL-18-GXLF701-EL2 BR-18-GXL
C214-EL5 BK-18-GXLT789-EL8 YL-18-GXL
229-AL2 BK-18-GXL
229-AL2 BK-18-GXL
314-AL3 PU-18-GXL
314-AL3 PU-18-GXL
314-AL4 PU-18-GXL314-AL4 PU-18-GXL
314-AL1 PU-18-GXL314-AL1 PU-18-GXL
229-AL5 BK-18-GXL
229-AL5 BK-18-GXL229-AL6 BK-18-GXL
229-AL6 BK-18-GXL
SYNC 2SYNC 1
DIGITAL THROTTLE RAISE
START RELAY 2
140-AP2 BU-18-GXL
M914-AP5 WH-18-GXL
A402-AP4 BU-18-GXL
140-AP3 BU-18-GXL
A402-AP4 BU-18-GXL
M914-AP5 WH-18-GXL
377-0263COOLING WATER
PRESSURE
377-0263START AIR PRESSURE
M998-AP8 OR-18-GXL
N770-AP9 BU-18-GXL
220-AP6 BK-18-GXL366-AP7 PK-18-GXL
E964-AP10 WH-18-CBLE963-AP11 BK-18-CBL
366-AP7 PK-18-GXL
N770-AP9 BU-18-GXLE964-AP10 WH-18-CBLE963-AP11 BK-18-CBL
ALARM & PROTECTION
140-AP2 BU-18-GXL
140-AP3 BU-18-GXL
220-AP6 BK-18-GXL
M998-AP8 OR-18-GXL
A235-AP12 SHLD-18-CBL
A235-AP12 SHLD-18-CBL
CABLE PN127-8770 NOTE B
OPTIONAL
AIR START - OPTION
ELECTRIC START - OPTION
CONNECT TOINT GEN HARNGN-C4
J1939 DATA (+) J1939 DATA (-)J1939 SHIELD
K900-L6 YL-18-CBLK990-L5 GN-18-CBLA234-L4 SHLD-18-CBLK900-L3 YL-18-CBLK990-L2 GN-18-CBLA234-L1 SHLD-18-CBL
F448-L7 PK-18-GXLF449-L8 PU-18-GXLF450-L9 BR-18-GXLF452-L10 YL-18-GXLA376-L11 PU-18-GXLE488-L12 WH-18-GXLN717-L13 PK-18-GXL
200-L15 BK-18-GXLA374-L16 YL-18-GXLA375-L17 GN-18-GXLE486-L18 GY-18-GXLN715-L19 BU-18-GXL
N715-L21 GY-18-GXLN716-L22 WH-18-GXLN719-L23 BR-18-GXLN705-L24 YL-18-GXLN720-L25 GN-18-GXLN752-L26 PK-18-GXL
N706-L27 GY-18-GXLA378-L28 BU-18-GXLN702-L29 PU-18-GXLN704-L30 GN-18-GXLJ904-L31 GY-18-GXLN714-L32 GY-18-GXLJ905-L33 PU-18-GXLN713-L34 YL-18-GXLN718-L35 PU-18-GXL101-L36 RD-18-GXL229-L37 BK-18-GXL
A375-L17 GN-18-GXL
N705-L24 YL-18-GXL
A374-L16 YL-18-GXL
A234-L1 SHLD-18-CBLK990-L2 GN-18-CBL
K900-L3 YL-18-CBL
200-L15 BK-18-GXL
A376-L11 PU-18-GXL
F452-L10 YL-18-GXLF450-L9 BR-18-GXL
F448-L7 PK-18-GXLF449-L8 PU-18-GXL
229-L37 BK-18-GXL
101-L36 RD-18-GXL
E486-L18 GY-18-GXL N715-L19 BU-18-GXLE488-L12 WH-18-GXL
N717-L13 PK-18-GXL
N715-L21 GY-18-GXL
N716-L22 WH-18-GXL
N719-L23 BR-18-GXLN720-L25 GN-18-GXLN752-L26 PK-18-GXL
N718-L35 PU-18-GXL
N713-L34 YL-18-GXL
J905-L33 PU-18-GXL
N714-L32 GY-18-GXL
J904-L31 GY-18-GXL
N704-L30 GN-18-GXLN702-L29 PU-18-GXL
A378-L28 BU-18-GXL
N706-L27 GY-18-GXL
A234-L4 SHLD-18-CBLK990-L5 GN-18-CBL
K900-L6 YL-18-CBL
CT H1 PHASE ACT H2 PHASE COM
CT H1 PHASE BCT H1 PHASE C
SENSING PHASE CVAR/PF ENABLE
PMG PHASE A (CDVR)
EXCITATION DISABLECONTACT SENSE-RAISE
GROUND
EXCITER(-)(CDVR)
BTRY-
SENSING PHASE ASENSING PHASE B
EXCITER (+)CONTACT SENSE-LOWER
ALARM DRIVER
EXCITER (-)PMG PHASE C (CDVR)
PMG PHASE APMG PHASE C
FAULT SHUTDOWN DRIVE SWITCH+/- 10VDC INPUT (A+)
FAULT SHUTDOWN DRIVER SUPPLY+/- 10VDC INPUT (B-)CONTACT SENSE-COMMON
EXTERNAL GEN HARN
UNSWITCHED BTRY (+)
NOTE A: USE RECOMMENDED CABLE OR EQUIVALENT PER SAE J1939 SPECIFICATIONS FOR ALL SAE J1939 CAN DATA LINK CONNECTIONS.NOTE B: SHIELD WIRE REMAINS UNCONNECTED AT THIS LOCATION.
CONNECTTO MGCPOR LJ-C2
229-L37 BK-18-GXL101-L36 RD-18-GXLE486-L18 GY-18-GXL
N715-L19 BU-18-GXL
E488-L12 WH-18-GXLN717-L13 PK-18-GXL
N715-L21 GY-18-GXL
N716-L22 WH-18-GXLN719-L23 BR-18-GXLN720-L25 GN-18-GXLN752-L26 PK-18-GXLN718-L35 PU-18-GXLN713-L34 YL-18-GXLJ905-L33 PU-18-GXL
N714-L32 GY-18-GXL
J904-L31 GY-18-GXLN704-L30 GN-18-GXLN702-L29 PU-18-GXLA378-L28 BU-18-GXLN706-L27 GY-18-GXL
A234-L4 SHLD-18-CBL
K990-L5 GN-18-CBL
K900-L6 YL-18-CBL
F449-L8 PU-18-GXLF448-L7 PK-18-GXL
F450-L9 BR-18-GXL
F452-L10 YL-18-GXL
A376-L11 PU-18-GXL
200-L15 BK-18-GXL
K900-L3 YL-18-CBL
K990-L2 GN-18-CBL
A234-L1 SHLD-18-CBL
A374-L16 YL-18-GXLN705-L24 YL-18-GXL
A375-L17 GN-18-GXL
A774-EM4 GN-18-GXL
A774-EM4 GN-18-GXL
A774-EM5 GN-18-GXL
A774-EM5 GN-18-GXL
A774-EM6 GN-18-GXL
A774-EM6 GN-18-GXL
115-EM1 PK-18-GXL
115-EM1 PK-18-GXL
115-EM3 PK-18-GXL
115-EM3 PK-18-GXL
115-EM2 PK-18-GXL115-EM2 PK-18-GXL
115-ET1 PK-18-GXL
A774-ET2 GN-18-GXL
E-STOPREMOTE E-STOP PANEL
115-AP15 PK-18-GXL
115-AP15 PK-18-GXL
A744-AP16 OR-18-GXL
A744-AP16 OR-18-GXL
EXCITER (+) (CDVR)
FAULT RESET
M996-JE1 GY-18-GXL230-JE2 BK-18-GXL
CONNECT TO J1 ENG HARNE-C61
101-EJ1 RD-16-GXL
101-EJ5 RD-16-GXL
101-EJ8 RD-16-GXL
101-EJ50 RD-16-GXL
229-EJ2 BK-16-GXL229-EJ3 BK-16-GXL
229-EJ9 BK-16-GXL
200-EJ26 BK-16-GXL
C214-EJ42 BK-16-GXL
229-EJ52 BK-16-GXL
M972-EJ4 PK-18-GXL
F448-EJ12 PK-18-GXL
N717-EJ21 PK-18-GXL
391-EJ29 PK-18-GXL
N752-EJ48 PK-18-GXL
C968-EJ69 PK-18-GXLN715-EJ68 WH-18-GXL
N716-EJ38 WH-18-GXL
E488-EJ20 WH-18-GXL
945-EJ6 BR-18-GXL
F450-EJ14 BR-18-GXL
J906-EJ30 BR-16-GXL
M973-EJ34 BR-18-GXL
N719-EJ44 BR-18-GXL
L460-EJ67 YL-18-GXL
N713-EJ65 YL-18-GXL
T789-EJ57 YL-18-GXL
N705-EJ45 YL-18-GXL
M974-EJ35 YL-18-GXL
A374-EJ27 YL-18-GXL
F452-EJ15 YL-18-GXL
944-EJ7 OR-18-GXL
M971-EJ10 BR-18-GXL
N917-EJ47 OR-18-GXL
N704-EJ61 GN-18-GXL
N720-EJ46 GN-18-GXL
A375-EJ28 GN-18-GXL
E487-EJ32 BU-18-GXL
N718-EJ66 PU-18-GXL
N702-EJ60 PU-18-GXL
J905-EJ64 PU-18-GXL
314-EJ54 PU-18-GXL
G966-EJ36 PU-18-GXL
F449-EJ13 PU-18-GXL
A376-EJ19 PU-18-GXL
E486-EJ31 GY-18-GXL
N715-EJ37 GY-18-GXL
N706-EJ58 GY-18-GXL
J904-EJ62 GY-18-GXLN714-EJ63 GY-18-GXL
A378-EJ59 BU-18-GXL
K990-EJ18 GN-18-CBL
A234-EJ16 SHLD-18-CBLK900-EJ17 YL-18-CBL
140-EJ23 BU-18-GXL
C436-EJ33 BU-18-GXL
E480-EJ11 PK-18-GXL
E481-EJ22 PU-18-GXL
L923-EJ24 WH-18-GXLL924-EJ25 GN-18-GXL
CONNECT TO MGCP
L3 PANEL EXTENSION
140-AJ1 BU-18-GXL402-AJ2 BU-18-GXL140-AJ3 BU-18-GXL
140-AJ5 BU-18-GXL
140-AJ7 BU-18-GXLN770-AJ8 BU-18-GXL
M914-AJ4 WH-18-GXL
E964-AJ9 WH-18-CBL
366-AJ6 PK-18-GXL
115-AJ23 PK-18-GXL
E963-AJ10 BK-18-CBLA235-AJ11 SHLD-18-CBL
A744-AJ24 GN-18-GXL
E482-AJ13 BR-18-GXLE483-AJ14 GN-18-GXL
L922-AJ20 BU-18-GXLL921-AJ19 YL-18-GXL
ALARM & PROTECTION EXTENSION
CONNECT TOA&P HARN
AP-C1
CONNECT TO MGCP24 PIN A&P CONN
GENERATOR EXTENSION
TO EXTERNAL GEN HARNCONN L-C1
CT H1 PHASE ACT H2 PHASE COM
CT H1 PHASE BCT H1 PHASE C
SENSING PHASE CVAR/PF ENABLE
PMG PHASE A (CDVR)
EXCITATION DISABLECONTACT SENSE-RAISE
GROUND
EXCITER(-)(CDVR)
BTRY (-)
SENSING PHASE ASENSING PHASE B
EXCITER (+)
CONTACT SENSE-LOWERALARM DRIVER
EXCITER (-)PMG PHASE C (CDVR)PMG PHASE APMG PHASE CFAULT SHT DN DRIVER SW+/- 10VDC INPUT (A+)FAULT SHT DN DRIVER SUPPLY+/- 10VDC INPUT (B-)CONTACT SENSE-COMMON
UNSWITCHED BTRY (+)
EXCITER (+) (CDVR)
FAULT RESET
J1939 DATA (+)J1939 DATA (-) J1939 SHIELD
CONNECT TO MGCP24 PIN A&P CONNOR AJ-C1
NOTE C: HARNESS WIRING IS PROVIDED BY THE GENERATOR MANUFACTURER AND IS SHOWN FOR REFERENCE ONLY
F448-LJ1 PK-18-GXL
N752-LJ20 PK-18-GXL
N717-LJ7 PK-18-GXL
F449-LJ2 PU-18-GXL
A376-LJ5 PU-18-GXL
N702-LJ32 PU-18-GXL
J905-LJ36 PU-18-GXL
N718-LJ38 PU-18-GXL
F450-LJ3 BR-18-GXL
N719-LJ17 BR-18-GXL
F452-LJ4 YL-18-GXL
A374-LJ10 YL-18-GXL
N705-LJ18 YL-18-GXL
N713-LJ37 YL-18-GXL
E488-LJ6 WH-18-GXL
N716-LJ14 WH-18-GXL
200-LJ9 BK-18-GXL
229-LJ40 BK-18-GXL
A375-LJ11 GN-18-GXL
N720-LJ19 GN-18-GXL
N704-LJ33 GN-18-GXL
E486-LJ12 GY-18-GXL
N715-LJ15 GY-18-GXL
N706-LJ30 GY-18-GXL
J904-LJ34 GY-18-GXLN714-LJ35 GY-18-GXL
E487-LJ13 BU-18-GXL
A378-LJ31 BU-18-GXL
101-LJ39 RD-18-GXL
CONNECTTO MGCP
DIFF AIR PRESS.
SENSOR POWER 140-L14 BU-18-GXL
140-L14 BU-18-GXL
140-L14 BU-18-GXL
C436-L20 BU-18-GXL
C436-L20 BU-18-GXL
C436-L20 BU-18-GXL DIFF AIR PRESS.SENSOR POWER
945-E5 BR-18-GXL
944-E3 OR-18-GXL
229-E27 BK-16-GXL
G966-E9 PU-18-GXL
944-E39 OR-18-GXL
944-E38 OR-18-GXL
944-E38 OR-18-GXL
945-E4 BR-18-GXL
J906-E51 BR-16-GXL
A234-E43 SHLD-18-CBL
A234-E41 SHLD-18-CBL
A234-E41 SHLD-18-CBL
K990-E47 GN-18-CBL
K990-E47 GN-18-CBLK900-E44 YL-18-CBL
M971-E30 BR-18-GXL
M971-E30 BR-18-GXL
M972-E32 PK-18-GXL
M972-E32 PK-18-GXL
229-E29 BK-16-GXL
945-E37 BR-18-GXL
A234-E42 SHLD-18-CBL
K900-E46 YL-18-CBL
K990-E49 GN-18-CBL
K990-E49 GN-18-CBL
101-E21 RD-16-GXL
J906-E50 BR-16-GXL
101-E24 RD-16-GXL
J906-E51 BR-16-GXL
K990-E48 GN-18-CBL
J906-E50 BR-16-GXL
J906-E34 BR-16-GXL
K900-E45 YL-18-CBL
K900-E46 YL-18-CBL
A234-E42 SHLD-18-CBL
944-E39 OR-18-GXL
945-E37 BR-18-GXL945-E5 BR-18-GXL
945-E4 BR-18-GXL944-E3 OR-18-GXL
A234-E20 SHLD-18-CBL
K900-E23 YL-18-CBL
K990-E14 GN-18-CBL
J906-E34 BR-16-GXL
101-E24 RD-16-GXL
229-E29 BK-16-GXL
M972-E32 PK-18-GXL
M971-E30 BR-18-GXL
G966-E9 PU-18-GXL
229-E27 BK-16-GXL
101-E21 RD-16-GXL
101-E40 RD-16-GXL
229-E1 BK-16-GXL
229-E1 BK-16-GXL
229-E31 BK-16-GXL
229-E31 BK-16-GXL
F701-E93 BR-18-GXL
N917-E280 OR-18-GXL
N917-E280 OR-18-GXL
N917-E280 OR-18-GXL
L460-E281 YL-18-GXL
L460-E281 YL-18-GXL
L460-E281 YL-18-GXL
N715-E7 WH-18-GXL
N715-E7 WH-18-GXL
N715-E7 WH-18-GXL
C968-E283 PK-18-GXL
C968-E283 PK-18-GXL
C968-E283 PK-18-GXL
391-E57 PK-18-GXL
391-E57 PK-18-GXL
G966-E9 PU-18-GXL
391-E57 PK-18-GXL
C214-E62 BK-18-GXL
C214-E62 BK-18-GXL
T789-E67 YL-18-GXL
229-E26 BK-16-GXL229-E71 BK-16-GXL
229-E71 BK-16-GXL
229-E26 BK-16-GXL
K900-E45 YL-18-CBLK900-E73 YL-18-CBL
K990-E48 GN-18-CBL
A234-E43 SHLD-18-CBL
A234-E72 SHLD-18-CBL
101-E40 RD-16-GXL
C214-E62 BK-18-GXL
T789-E67 YL-18-GXL
T789-E67 YL-18-GXL
229-E11 BK-18-GXL
229-E11 BK-18-GXL
314-E6 PU-18-GXL
314-E6 PU-18-GXL
314-E6 PU-18-GXL
F701-E93 BR-18-GXL
229-E94 BK-16-GXL
229-E94 BK-16-GXL
A234-E20 SHLD-18-CBL
K990-E14 GN-18-CBLK900-E23 YL-18-CBL
A234-E72 SHLD-18-CBL
K990-E75 GN-18-CBL
K990-E75 GN-18-CBL
K900-E73 YL-18-CBL
K900-E63 YL-18-CBL
K990-E64 GN-18-CBL
K990-E64 GN-18-CBL
A234-E65 SHLD-18-CBL
F701-E93 BR-18-GXL
101-E21 RD-16-GXL
101-E24 RD-16-GXL
101-E10 RD-16-GXL
101-E10 RD-16-GXL
229-E19 BK-18-GXL
229-E19 BK-18-GXL
229-E31 BK-16-GXL
M995-E28 GY-18-GXL
M995-E28 GY-18-GXL
M995-E28 GY-18-GXL
M973-E52 BR-18-GXL
M973-E52 BR-18-GXL
M973-E52 BR-18-GXL
M974-E53 YL-18-GXL
M974-E53 YL-18-GXL
M974-E53 YL-18-GXL
101-E54 RD-16-GXL101-E55 RD-16-GXL
101-E55 RD-16-GXL
101-E54 RD-16-GXL
A744-E56 GN-18-GXL
A744-E56 GN-18-GXL
A744-E56 GN-18-GXL
K900-E63 YL-18-CBL
A234-E65 SHLD-18-CBL
229-E29 BK-16-GXL
101-E40 RD-16-GXL
K900-E44 YL-18-CBL
K900-E63 YL-18-CBL
K990-E64 GN-18-CBLA234-E65 SHLD-18-CBL
CONNECT TOE-STOP HARNEM-C1LOC. A-4
ENGINE CONTROL MODULE372-2900
COOLANT TEMPERATURE SENSORSENSOR RETURN
INTAKE MANIFOLD AIR PRESSURE SENSORTRANSMISSION OIL PRESSURE SENSOR
ANALOG RETURN (BOOST)
SHUTDOWN NOTIFY
CRANK SENSOR(-)TDC SERVICE PROBE (+)
TRANSMISSION OIL TEMPERATURE SENSORENGINE OIL PRESSURE SENSOR
SENSOR POWER (COOLANT LEVEL) +8VTEMPERATURE SENSOR (-)
CRANK SENSOR (+)TDC SERVICE PROBE(-)
FUEL LEVEL SENSOREXHAUST TEMPERATURE SENSOR
FUEL PRESSURE SENSOR
CAM SENSOR (+)CAM SENSOR (-)
COOLANT LEVEL SENSOR
PRESSURE SENSOR COMMON (FUEL, LUBE OIL)
INTAKE MANIFOLD AIR TEMPERATURE SENSOROIL PRESSURE-PRE FILTER
FUEL TEMPERATURE SENSOR
PRESSURE SENSOR +5V (BOOST)AFTERCOOLER COOLANT LEVEL SENSOR
PRESSURE SENSOR +5V (FUEL,LUBE)+5V ANALOG POWER (TRANS TEMP, TRANS PRESS.)
TURBO COMPRESSOR INLET AIR TEMPEARTURE
4-20 mA (+) THROTTLE4-20 mA (-) THROTTLE
OIL TEMPERATURE SENSORS/T SHIELD
ANALOG SENSOR RETURNFUEL PRESSURE-PRE FILTER
0-5 V (+) THROTTLEJW PRESSURE
INJECTORS 5&6 HS
INJECTOR 1&2 HSINJECTOR 6 LSINJECTOR 3 LSINJECTOR 5 LSINJECTOR 4 LS
INJECTOR 3&4 HSINJECTOR 1 LS
INJECTOR 2 LS
OIL LEVELCAT DATA LINK (+)CAT DATA LINK (-)
CRANK RELAY / SMMS (+)
REMOTE SHUTDOWN SWITCH
J1939 DATA LINK (-)SYNC 1
J1939 SHIELD
SYNC 2
MONITORING SYSTEMS OVERRIDERUN / STOP
UNSWITCHED BATTERY (+)
J1939 DATA LINK (+)
UNSWITCHED BATTERY (+)UNSWITCHED BATTERY (+)
UNSWITCHED BATTERY (+)EVENT RESET
LOW IDLE SWITCH
BATTERY (-)
BATTERY (-)REMOTE STARTBATTERY (-)
PRIMARY THROTTLE POSITIONBATTERY (-)
SECONDARY THROTTLE POSITION
BATTERY KEYSWITCH (+)
ALTERNATOR
+ R
GND
ARC SUPPRESSOR218-4935
EL-C31552269
12
DIODE189-3158
EL-C41552269
12
G S S+
STARTER (RH)
MOT BTRYG-
327-2771
MOTOR
EL-C13E3370
OHMS
120
TERMINATINGRESISTOR134-2540
AIR STARTER281-8687
BK-18BK-18
SUPPRESSOR-AIR START384-2805
AL-C22767614
12
AL-C32767614
12
AL-C13E3364
12
L-C21607689
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
ENGINE OIL LEVELSWITCH213-0677
BK-16BK-16
AP-C33785571
123
AP-C23785571
123
BK-18BK-18
BK-18BK-18
SPEED SENSOR318-1181
BK-18 (-) 1WH-18 (+) 2
AP-C61552269
12
AP-C17X6222
123456789101112131415161718192021222324
L-C33E3382
123456
L-C19X0141
12345678910111213141516171819202122232425262728293031323334353637383940
COOLANT TEMP SHUTDOWN264-1420
T
OIL PRESS. SHUTDOWN264-1419
AP-C42654029
123 10K
AP-C52654029
123 10K
EM-C31552269
12
EM-C21552267
ABC
E STOP308-9773
CONTACT BLOCK377-0245
2 1
4 3
ET-C11407684
ABC
AP-C71552269
12
EM-C13E3364
12
JE-C13E3364
12
JE-C21552269
12
EJ-C11030213
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
EJ-C29X0347
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
AJ-C27X6222
123456789101112131415161718192021222324
AJ-C19X0146
123456789101112131415161718192021222324
EL-C22975475
12
LJ-C19X0141
12345678910111213141516171819202122232425262728293031323334353637383940
LJ-C29X1343
12345678910111213141516171819202122232425262728293031323334353637383940
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
E-C11607689J1ECM
E-C609W1951
ABCDEFGHJ
E-C41552267
ABC
E-C211740502
ABC
E-C51552269
12
E-C31552269
12
E-C619X0347
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
E-C201552269
12
E-C21552273
123456
CDVR314-7755
PMG PHASE APMG PHASE BPMG PHASE CEXCITER (-)EXCITER (+)CHASSIS GND
PHASE B CURRENT SENSING (1)PHASE B CURRENT SENSING (2)+/- 10 VDC INPUT (A)ALARM OUTPUT DRIVERFAULT SHUTDOWN DRIVER+/- 10 VDC INPUT (B)BATTERY (-)BATTERY (+)DRIVER SUPPLYGEN VOLTAGE SENSING CGEN VOLTAGE SENSING BGEN VOLTAGE SENSING A
CAN1+CAN1-CAN1 SHCONTACT SENSE-LOWERCONTACT SENSE-RAISECONTACT SENSE-COMMONEXCITATION DISABLEFAULT RESETVAR/PF ENABLE
GN-T1X1 GN-T1X2
GN-T2X1 GN-T2X2 CD-T2X1 CD-T2X2
T1 T2
22 24
20
GN-T3X1 GN-T3X2
T3
GEN TERMINALSTRIP
342-5717
F1F2111112131326
28
30VDC-AVDC-BMVC-1MVC-3ALMFSDDS50EDISLWRRSECOM2V/PFFRES112229202224
GND
56
VAC-C LO
VAC-B LO
VAC-A LO
VAC-C HI
VAC-B HI
VAC-A HI
GROUND
3-WAY133-0970
1AFT BRG RTDGG-C2342-0556
2
1
RTD APHASE-A RTD
2
1
RTD BPHASE-B RTD
2
1
RTD CPHASE-C RTD
2
PMG
A B C
1
RTD A2PHASE-A RTD 2
2
1
RTD B2PHASE-B RTD 2
2
1
RTD C2PHASE-C RTD 2
2
EXCITERF1
F2
TRANSFORMER 1347-1248
BLACK
WHITE (1.0)BK/WHT
GREEN (1.5)ORANGE
BROWN (2.0)
RED (2.5)
ORANGE
BK/WHT
ABOVE 240V342-5717
VAC-C LO
VAC-B LO
VAC-A LO
VAC-C HI
VAC-B HI
VAC-A HI
BELOW 240V342-5717
VAC-C LO
VAC-B LO
VAC-A LO
VAC-C HI
VAC-B HI
VAC-A HITRANSFORMER 2347-1248
BLACK
WHITE (1.0)BK/WHT
GREEN (1.5)ORANGE
BROWN (2.0)
RED (2.5)
ORANGE
BK/WHT
RTD TERMINAL STRIP
R1W1C1R2W2C2R3W3C3
R4W4C4R5W5C5R6W6C6
GROUND GENERATOR BARREL
CD-F1132-1170C 2A C
CD-F2132-1170B 2A B
CD-F3132-1170A 2A A
12345678
GN-C221552264
GN-C39X0141
12345678910111213141516171819202122232425262728293031323334353637383940
GN-C42242734
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
RTD MODULE234-1645
A
CHANNEL 1PHASE A C
C2
A
CHANNEL 5PHASE C C
C2
A
CHANNEL 2PHASE A2 C
C2
A
CHANNEL 6PHASE C2 C
C2
A
CHANNEL 3PHASE B C
C2
A
CHANNEL 7 CAFTER BEARING C2
A
CHANNEL 4PHASE B2 C
C2
A
CHANNEL 8/NOT USED/ C
C2
BATTERY+CAN (+ CAN (-)
BATTERY (-)CAN SHIELDRS-232 GNDRS-232 TXDRS-232 RXD
GN-C11552267
ABC
GN-C21552267
ABC
GN-C51552267
ABC
GG-C13E3370
200-CD18 PU-18-XLPEA374-CD1 YL-18-XLPEA375-CD2 GN-18-XLPE
N703-CD30 BR-18-XLPE
N713-CD5 YL-18-XLPE
N714-CD6 GY-18-XLPE
112-CD16 PU-18-XLPE229-CD17 BK-18-XLPE
N752-CD7 PK-18-XLPEJ904-CD8 GY-18-XLPE
J905-CD9 PU-18-XLPE
N716-CD10 WH-18-XLPE
N720-CD11 GN-18-XLPEN719-CD12 BR-18-XLPEN718-CD13 PU-18-XLPE
N717-CD14 PK-18-XLPEN715-CD15 GY-18-XLPE
K900-CD24 YL-18-CBL
K990-CD25 GN-18-CBLA234-CD26 SHLD-18-CBL
N752-CD7 PK-18-XLPEJ904-CD8 GY-18-XLPE
N714-CD6 GY-18-XLPE
229-CD17 BK-18-XLPE112-CD16 PU-18-XLPE
J905-CD9 PU-18-XLPEN716-CD10 WH-18-XLPEN720-CD11 GN-18-XLPEN719-CD12 BR-18-XLPEN718-CD13 PU-18-XLPEN717-CD14 PK-18-XLPEN715-CD15 GY-18-XLPE
N713-CD5 YL-18-XLPE
E488-CD21 WH-18-XLPE
E487-CD22 BU-18-XLPE
E486-CD23 GY-18-XLPE
E488-CD21 WH-18-XLPEE487-CD22 BU-18-XLPEE486-CD23 GY-18-XLPE
F454-CD19 BU-18-XLPEF455-CD20 WH-18-XLPE
A378-CD4 BU-18-XLPE
N702-GN6 PU-18-GXL
N704-GN7 GN-18-GXL
N714-GN9 GY-18-GXLA374-GN1 YL-18-GXLA375-GN3 GN-18-GXL
N713-GN11 YL-18-GXL
N752-GN13 PK-18-GXLJ904-GN8 GY-18-GXLJ905-GN10 PU-18-GXLN716-GN16 WH-18-GXLN720-GN14 GN-18-GXLN719-GN15 BR-18-GXLN718-GN12 PU-18-GXLN717-GN18 PK-18-GXLN715-GN17 GY-18-GXL112-GN22 PU-18-GXL229-GN23 BK-18-GXL
K900-GN59 YL-18-CBLK990-GN60 GN-18-CBLA234-GN61 SHLD-18-CBL
F448-GN25 PK-18-GXLF450-GN26 BR-18-GXLF452-GN27 YL-18-GXL
F449-GN67 PU-18-GXL
F449-GN68 PU-18-GXL
F449-GN71 PU-18-GXLF449-GN24 PU-18-GXL
200-GN31 BK-18-GXL
F454-CD65 BU-18-XLPE
F455-CD66 WH-18-XLPEF455-CD66 WH-18-XLPE
F454-CD65 BU-18-XLPE
K990-GN45 GN-18-CBL
K900-CD24 YL-18-CBLK990-CD25 GN-18-CBLA234-CD26 SHLD-18-CBL
F449-GN69 PU-18-GXL
K900-GN44 YL-18-CBL
A234-GN46 SHLD-18-CBL
K900-GN59 YL-18-CBLK990-GN60 GN-18-CBLA234-GN61 SHLD-18-CBL
X899-GN32 WH-18-GXL
X899-GN32 WH-18-GXL
Y956-GN34 PU-18-GXL
Y956-GN34 PU-18-GXL
Y799-GN33 BK-18-GXL
Y799-GN33 BK-18-GXL
E488-GN19 WH-18-GXL
E488-GN19 WH-18-GXL
E487-GN20 BU-18-GXL
E487-GN20 BU-18-GXL
E486-GN21 GY-18-GXL
E486-GN21 GY-18-GXL
L849-GG18 PU-18-GXL
M755-GG6 PU-18-GXL
X813-GG16 WH-18-GXL
Y796-GG11 WH-18-GXLX811-GG10 WH-18-GXL
M756-GG5 WH-18-GXLX808-GG4 WH-18-GXL
L850-GG17 WH-18-GXL
Y793-GG12 PU-18-GXL
Y799-GG23 WH-18-GXLX899-GG22 WH-18-GXL
M756-GN36 WH-18-GXLM755-GN37 PU-18-GXL
X811-GN38 WH-18-GXLY957-GN39 WH-18-GXLY793-GN40 PU-18-GXL
X813-GN41 WH-18-GXLL850-GN42 WH-18-GXLL849-GN43 PU-18-GXL
X808-GN35 WH-18-GXL
F436-GG25 BR-18-GXLF434-GG26 PK-18-GXL
F436-GG25 BR-18-GXLF434-GG26 PK-18-GXLF435-GG27 PU-18-GXL
N702-GG1 PU-18-GXLN703-GG2 BR-18-GXL
N704-GG3 GN-18-GXL
200-GN28 BK-18-GXL
M757-GG9 PU-18-GXL
Y792-GG8 WH-18-GXLX810-GG7 WH-18-GXL
L841-GG15 PU-18-GXL
L842-GG14 WH-18-GXLX812-GG13 WH-18-GXL
P923-GG21 PU-18-GXL
X814-GG19 WH-18-GXLP924-GG20 WH-18-GXL
Y956-GG24 PU-18-GXL
N705-GN2 YL-18-GXL
N705-GG29 YL-18-GXL
N706-GN4 GY-18-GXL
N706-GG30 GY-18-GXL
A376-CD3 PU-18-XLPE
F436-CD29 BR-18-XLPE
F435-CD28 PU-18-XLPE
F434-CD27 PK-18-XLPE
F435-GG27 PU-18-GXL
F434-CD27 PK-18-XLPEF435-CD28 PU-18-XLPEF436-CD29 BR-18-XLPE
N703-GN63 BR-18-GXLA376-CD3 PU-18-XLPEA376-GN62 PU-18-GXL
N705-GN2 YL-18-GXL
N706-GN4 GY-18-GXL
A378-GN5 BU-18-GXL
N703-GN63 BR-18-GXL
N704-GG3 GN-18-GXLN703-GG2 BR-18-GXL
N706-GG30 GY-18-GXLN702-GG1 PU-18-GXL
N705-GG29 YL-18-GXL
F416-CD31 BR-18-GXL
F415-CD32 PU-18-GXL
F414-CD33 PK-18-GXL
E487-XA7 BK WH-18
E487-XA7 BK WH-18
E487-XB6 BK WH-18
E487-XB6 BK WH-18
E488-XA5 OR-18-XLPE
E488-XA5 OR-18-XLPE
E486-XB8 OR-18-XLPE
E486-XB8 OR-18-XLPE
F415-XA3 BK-18-XLPE
F415-XA3 BK-18-XLPEF415-XB2 BK-18-XLPE
F415-XB2 BK-18-XLPE
F414-XA1 PK-18-XLPE
F414-XA1 PK-18-XLPE
F416-XB4 RD-18-XLPE
F416-XB4 RD-18-XLPE
VOLTAGE OPTIONS
240V OR BELOW
ABOVE 240V
M757-GN75 PU-18-GXL
X810-GN77 WH-18-GXL
P923-GN81 PU-18-GXL
X814-GN83 WH-18-GXL
Y792-GN76 WH-18-GXL
L841-GN78 PU-18-GXLL842-GN79 WH-18-GXLX812-GN80 WH-18-GXL
P924-GN82 WH-18-GXL
L841-GN78 PU-18-GXL
X812-GN80 WH-18-GXL
X814-GN83 WH-18-GXL
200-GN90 BK-18-GXL
F416-CD31 BR-18-XLPE
F415-CD32 PU-18-XLPE
F414-CD33 PK-18-XLPE
3N-5977 FUSE BLOCK
200-GN99 BK-18-GXL
F449-GN70 PU-18-GXL
F449-GN72 PU-18-GXL
F452-GN27 YL-18-GXL
A376-GN62 PU-18-GXL
F450-GN26 BR-18-GXL
F448-GN25 PK-18-GXL
F449-GN24 PU-18-GXL229-GN29 BK-18-GXL112-GN91 PU-18-GXL
N717-GN18 PK-18-GXLN715-GN17 GY-18-GXLN716-GN16 WH-18-GXLN719-GN15 BR-18-GXLN720-GN14 GN-18-GXLN752-GN13 PK-18-GXLN718-GN12 PU-18-GXLN713-GN11 YL-18-GXLJ905-GN10 PU-18-GXLN714-GN9 GY-18-GXLJ904-GN8 GY-18-GXLN704-GN7 GN-18-GXLN702-GN6 PU-18-GXLA378-GN5 BU-18-GXL
200-GN31 BK-18-GXL
X808-GN35 WH-18-GXLM756-GN36 WH-18-GXL
M755-GN37 PU-18-GXL
X811-GN38 WH-18-GXLY957-GN39 WH-18-GXL
Y793-GN40 PU-18-GXL
X813-GN41 WH-18-GXLL850-GN42 WH-18-GXL
L849-GN43 PU-18-GXL
M757-GN75 PU-18-GXL
Y792-GN76 WH-18-GXLX810-GN77 WH-18-GXL
L842-GN79 WH-18-GXL
P923-GN81 PU-18-GXL
P924-GN82 WH-18-GXL
A374-GN1 YL-18-GXL
A375-GN3 GN-18-GXL
A378-CD4 BU-18-XLPE
A374-CD1 YL-18-XLPEA375-CD2 GN-18-XLPE
200-CD18 PU-18-XLPE
F454-CD19 BU-18-XLPEF455-CD20 WH-18-XLPE
N703-CD30 BR-18-XLPE
N702-GN6 PU-18-GXL
A378-GN5 BU-18-GXLA376-GN62 PU-18-GXL
N706-GN4 GY-18-GXLN705-GN2 YL-18-GXL
N704-GN7 GN-18-GXL
N713-GN11 YL-18-GXLN714-GN9 GY-18-GXL
N752-GN13 PK-18-GXL
J904-GN8 GY-18-GXLJ905-GN10 PU-18-GXL
N716-GN16 WH-18-GXL
N720-GN14 GN-18-GXLN719-GN15 BR-18-GXLN718-GN12 PU-18-GXLN717-GN18 PK-18-GXL
N715-GN17 GY-18-GXL
112-GN22 PU-18-GXL
F449-GN71 PU-18-GXL
229-GN23 BK-18-GXL
200-GN99 BK-18-GXL
E488-GN19 WH-18-GXL
E487-GN20 BU-18-GXL
E486-GN21 GY-18-GXL
L849-GN43 PU-18-GXLL850-GN42 WH-18-GXL
X813-GN41 WH-18-GXL
Y793-GN40 PU-18-GXL
Y957-GN39 WH-18-GXL
X811-GN38 WH-18-GXL
M755-GN37 PU-18-GXLM756-GN36 WH-18-GXL
X808-GN35 WH-18-GXL
Y956-GN34 PU-18-GXLY799-GN33 BK-18-GXL
X899-GN32 WH-18-GXL
F452-GN27 YL-18-GXL
F450-GN26 BR-18-GXL
F448-GN25 PK-18-GXL
M757-GN75 PU-18-GXL
Y792-GN76 WH-18-GXL
X810-GN77 WH-18-GXL
L841-GN78 PU-18-GXLL842-GN79 WH-18-GXL
X812-GN80 WH-18-GXL
P923-GN81 PU-18-GXLP924-GN82 WH-18-GXL
X814-GN83 WH-18-GXL
A375-GN3 GN-18-GXLA374-GN1 YL-18-GXL
K900-CD24 YL-18-CBL
K990-CD25 GN-18-CBLA234-CD26 SHLD-18-CBL
F449-GN67 PU-18-GXLF449-GN68 PU-18-GXL
F449-GN69 PU-18-GXL
F454-CD65 BU-18-XLPE
F455-CD66 WH-18-XLPE
F449-GN69 PU-18-GXLF449-GN68 PU-18-GXLF449-GN67 PU-18-GXL
F448-GN25 PK-18-GXL
F450-GN26 BR-18-GXL
F452-GN27 YL-18-GXL
F455-CD66 WH-18-XLPEF454-CD65 BU-18-XLPE
F435-CD28 PU-18-XLPE
F434-CD27 PK-18-XLPE
F436-CD29 BR-18-XLPE
N704-GG3 GN-18-GXLN703-GG2 BR-18-GXL
N705-GG29 YL-18-GXL
F435-GG27 PU-18-GXL
N702-GG1 PU-18-GXL
N706-GG30 GY-18-GXL
F434-GG26 PK-18-GXL
F436-GG25 BR-18-GXL
200-GN90 BK-18-GXL200-GN28 BK-18-GXL
200-GN90 BK-18-GXL
200-GN28 BK-18-GXL
K900-GN84 YL-18-CBLK990-GN85 GN-18-CBLA234-GN86 SHLD-18-CBL
K900-GN88 YL-18-CBL
K900-GN88 YL-18-CBL
K990-GN89 GN-18-CBL
K990-GN89 GN-18-CBL
A234-GN87 SHLD-18-CBL
A234-GN87 SHLD-18-CBL
112-GN91 PU-18-GXL112-GN92 PU-18-GXL
112-GN92 PU-18-GXL
229-GN93 BK-18-GXL
229-GN93 BK-18-GXL
229-GN29 BK-18-GXL
K900-GN44 YL-18-CBLK990-GN45 GN-18-CBLA234-GN46 SHLD-18-CBL
F449-GN71 PU-18-GXL
200-GN30 BK-18-GXL
200-GN30 BK-18-GXL
CABLE153-2707
CONNECT TOEXT GENSET HARN
L-C2
F436-CD29 BR-18-XLPEF435-CD28 PU-18-XLPEF434-CD27 PK-18-XLPE
CD-C12341856
123456
CD-C32341857
123456789
CD-C22341858
123456789101112
CD-C41552267
ABC
INTAKE MAINIFOLD AIR TEMP SENSOR288-3783
SIGNALGROUND
COOLANT TEMP SENSOR288-3783
SIGNALGROUND
COOLANT LEVEL SENSOR JW HEATER204-2518
OR-18 V+ ANALOGYL-18 GROUNDGN-18 SIGNAL
XMSN OIL PRESS SENSOR163-8512
RD-18 ANALOG +5VYL-18 GROUNDGN-18 SIGNAL
XMSN OIL TEMP SENSOR106-0735
OR-18 ANALOG +5VBK-18 GROUNDWH-18 SIGNAL
EXHAUST TEMPERATURE163-7882
OR-18 +8 VOLTSBK-18 GROUNDWH-18 SIGNAL
INJECTOR 11554066
INJECTOR 21554066
INJECTOR 31554066
INJECTOR 41554066
CRANK SPEED TIMING279-9828
BK-18 1WH-18 2
CAM SPEED TIMING279-9829
BK-18 1WH-18 2
INJECTOR 51554066
INJECTOR 61554066
FUEL TEMP SENSOR288-3783
SIGNALGROUND
COOLANT LEVEL SENSOR AFTERCOOLER204-2518
OR-18 V+ ANALOGYL-18 GROUNDGN-18 SIGNAL
OIL TEMPERATURE SENSOR288-3783
SIGNALGROUND
JW PRESS SNSR347-1544
+VGROUNDSIGNAL
OIL PRESS PRE FILTER347-1544
+VGROUNDSIGNAL
FUEL PRESS PRE FILTER347-1544
+VGROUNDSIGNAL
ENGINE OIL PRESS SENSOR347-1544
+VGROUNDSIGNAL
FUEL PRESS POST FILTER347-1544
+VGROUNDSIGNAL
INTAKE MANIFOLD AIR PRESS SENSOR296-5221
+VGROUNDSIGNAL
AIR TEMP SENSOR288-3783
SIGNALGROUND
G826-A46 BR-18-GXL
G826-A46 BR-18-GXL
G827-A43 BU-18-GXL
G827-A43 BU-18-GXL
G428-A5 BU-18-GXL
G428-A5 BU-18-GXL
994-A12 GY-18-GXL
994-A12 GY-18-GXL
A746-A24 PK-18-GXL
A746-A24 PK-18-GXL
A746-A24 PK-18-GXL
994-A12 GY-18-GXL
G428-A5 BU-18-GXL
G826-A47 BR-18-GXL
G826-A47 BR-18-GXL
G827-A41 BU-18-GXL
G827-A41 BU-18-GXL
T957-A37 PU-16
T958-A38 YL-16
T959-A33 BR-16
T960-A35 BU-16
E966-A15 YL-18-GXL
E966-A15 YL-18-GXL
E966-A15 YL-18-GXL
E965-A9 BU-18-GXL
E965-A9 BU-18-GXL
E965-A9 BU-18-GXL
E964-A100 WH-18-CBL
E964-A100 WH-18-CBL
E964-A100 WH-18-CBL
E963-A25 BK-18-CBL
E963-A25 BK-18-CBL
E963-A25 BK-18-CBL
C967-A22 BU-18-GXL
C967-A22 BU-18-GXL
C967-A22 BU-18-GXL
995-A3 BU-18-GXL
995-A3 BU-18-GXL
995-A3 BU-18-GXL
G833-A49 PK-18-GXL
G833-A49 PK-18-GXL
G833-A50 PK-18-GXL
G833-A50 PK-18-GXLG833-A14 PK-18-GXL
G833-A14 PK-18-GXL
N940-A52 BU-18-GXL
N940-A52 BU-18-GXL
N940-A53 BU-18-GXL
N940-A53 BU-18-GXLN940-A26 BU-18-GXL
N940-A26 BU-18-GXL
R818-A11 YL-18-GXL
R818-A11 YL-18-GXL
R818-A11 YL-18-GXL
C991-A18 PK-18-GXL
C991-A18 PK-18-GXL
C991-A18 PK-18-GXL
G833-A51 PK-18-GXL
G833-A51 PK-18-GXL
F421-A23 YL-18-GXL
F421-A23 YL-18-GXLF421-A23 YL-18-GXL
R800-A13 OR-18-GXL
R800-A13 OR-18-GXL
M967-A21 OR-18-GXL
M967-A21 OR-18-GXL
M967-A21 OR-18-GXL
H479-A17 OR-18-GXL
H479-A17 OR-18-GXL
H479-A17 OR-18-GXL
J842-A28 BK-18-GXL
J842-A28 BK-18-GXL
T957-A37 PU-16T958-A38 YL-16T959-A33 BR-16T960-A35 BU-16
T859-A36 WH-16
T859-A36 WH-16
T858-A31 GY-16
T858-A31 GY-16
G826-A48 BR-18-GXL
G826-A48 BR-18-GXL
G827-A39 BU-18-GXL
G827-A39 BU-18-GXL
N749-A64 GY-18-GXL
N749-A64 GY-18-GXL
N749-A64 GY-18-GXL
R800-A65 OR-18-GXL
R800-A65 OR-18-GXL
R800-A66 OR-18-GXL
R800-A66 OR-18-GXL
J842-A67 BK-18-GXL
J842-A67 BK-18-GXL
J842-A68 BK-18-GXL
J842-A68 BK-18-GXL
T860-A30 OR-16
T860-A30 OR-16
A725-A34 YL-16
A725-A34 YL-16T962-A32 WH-16
T962-A32 WH-16
T858-J7 GY-16-NW T858-J13 GY-16-NW
T858-J13 GY-16-NW
T858-J14 GY-16-NW
T858-J14 GY-16-NW
T859-J8 WH-16-NW
T859-J8 WH-16-NW T859-J16 WH-16-NW
T859-J16 WH-16-NW
T859-J15 WH-16-NW
T859-J15 WH-16-NW
T860-J9 OR-16-NW
T860-J9 OR-16-NW T860-J17 OR-16-NW
T860-J17 OR-16-NW
T860-J18 OR-16-NW
T860-J18 OR-16-NW
T960-J4 BU-16-NW
T960-J4 BU-16-NW T960-J4 BU-16-NWT959-J3 BR-16-NW
T959-J3 BR-16-NW
T958-J2 YL-16-NW
T958-J2 YL-16-NW
T958-J2 YL-16-NW
T957-J1 PU-16-NW
T957-J1 PU-16-NW
T957-J1 PU-16-NW
T961-J5 GY-16-NW
T961-J5 GY-16-NW
T961-J5 GY-16-NW
T962-J6 WH-16-NW
T962-J6 WH-16-NW
T962-J6 WH-16-NWT959-J3 BR-16-NW
T858-J7 GY-16-NW
OPTIONAL
N941-A20 YL-18-GXL
N941-A20 YL-18-GXL
N941-A54 YL-18-GXL
N941-A55 YL-18-GXL
N941-A56 YL-18-GXL
N941-A54 YL-18-GXLN941-A55 YL-18-GXL
M966-A61 GY-18-GXL
M966-A61 GY-18-GXL
M966-A61 GY-18-GXLJ842-A62 BK-18-GXL
J842-A62 BK-18-GXL
R800-A63 OR-18-GXL
R800-A63 OR-18-GXL
G846-A80 YL-18-GXL
G846-A80 YL-18-GXL
G846-A80 YL-18-GXLG833-A81 PK-18-GXL
G833-A81 PK-18-GXL
A235-A102 SHLD-18-CBL
A235-A102 SHLD-18-CBL
A235-A102 SHLD-18-CBL
CABLE 127-8770NOTE R
H999-A57 BU-18-GXLJ900-A58 WH-18-GXLJ901-A59 OR-16-GXL
H999-A57 BU-18-GXLJ900-A58 WH-18-GXL
J901-A59 OR-16-GXL
N767-A10 PK-18-GXL
N767-A10 PK-18-GXL
N941-A56 YL-18-GXL
993-A71 BR-18-GXL
993-A71 BR-18-GXL
993-A77 BR-18-GXL
993-A77 BR-18-GXLG828-A76 WH-18-GXL
G828-A76 WH-18-GXL
G828-A70 WH-18-GXL
G828-A70 WH-18-GXL
A&P OPTIONAL
T796-A75 GN-18-GXL
T796-A75 GN-18-GXL
T796-A75 GN-18-GXL
P792-A78 BU-18-GXL
P792-A78 BU-18-GXL
P792-A78 BU-18-GXL
N763-A72 PU-18-GXL
N763-A72 PU-18-GXL
N763-A72 PU-18-GXL
993-A6 BR-18-GXL
993-A6 BR-18-GXL993-A8 BR-18-GXL
993-A8 BR-18-GXL
G828-A4 WH-18-GXL
G828-A4 WH-18-GXLG828-A7 WH-18-GXL
G828-A7 WH-18-GXL
C829-A85 GN-18-GXL
C829-A85 GN-18-GXL
C829-A85 GN-18-GXL
G833-A86 PK-18-GXL
G833-A86 PK-18-GXLC829-M1 GN-18-GXLG833-M2 PK-18-GXL
G828-AJ1 WH-18-GXL
G828-AJ1 WH-18-GXLG828-AJ7 WH-18-GXLG828-AJ8 WH-18-GXL
993-AJ2 BR-18-GXL
993-AJ2 BR-18-GXL993-AJ5 BR-18-GXL993-AJ6 BR-18-GXL
N763-AJ3 PU-18-GXL
N763-AJ3 PU-18-GXL
T796-AJ4 GN-18-GXL
T796-AJ4 GN-18-GXL
993-AJ5 BR-18-GXL
993-AJ6 BR-18-GXL
G828-AJ7 WH-18-GXL
G828-AJ8 WH-18-GXL
N763-AJ3 PU-18-GXL
T796-AJ4 GN-18-GXL
AJ-C13438370
1234
AJ-C22975485
123
AJ-C32975485
123
FUEL LEVEL SENSOR240/30 OHMS
BK-18 SIGNALBK-18 GROUND
A-C72975475
12
A-C92975475
12
A-C12645732J2
123456789101112131415161718192021222324252627282930313233343536373839404142434445464748495051525354555657585960616263646566676869707172737475767778798081828384858687888990919293949596979899100101102103104105106107108109110111112113114115116117118119120
A-C112975475
12
A-C183E3364
12
A-C161552267
ABC
A-C101552267
ABC
A-C173E3370
ABC
A-C191552267
ABC
A-C62975475
12
A-C52975475
12
A-C31552252
123456789101112
A-C151552267
ABC
A-C142975475
12
A-C21552273
123456
A-C222975485
123
A-C82975484
123
A-C122975485
123
A-C132975485
123
A-C232975475
1 2
A-C203438366
1234
J-C3702908858
123456789
101112
J-C3013902870
J-C3023902870
J-C3033902870
J-C3043902870
J-C3053902870
J-C3063902870
M-C12975475
1 2
M-C22975479
RIGHT SIDE VIEW
*SOME COMPONENTS REMOVED FOR CLARITY
ALTERNATORSTARTER (RH)L-C1AP-C1E-C61E-C20E STOP
COOLANT LEVELSENSORJW HEATER
COOLANT TEMPSHUTDOWN
DIODE
LEFT SIDE VIEW
VIEW OF AREA “A”(ROTATED FOR CLARITY) *SOME COMPONENTS REMOVED FOR CLARITY
A
TRANSFORMER 2TRANSFORMER 1
GROUND
FUSE BLOCK
GEN TERMINALSTRIP
CDVR
E-C2L-C2
3-WAY
A-C2A-C16A-C17A-C18
ARCSUPPRESSOR
A-C19
A-C23 TO AIR TEMP SENSORECM
CRANK SPEEDTIMING
ENGINE OILLEVEL SWITCH
SUPPRESSORAIR START
AIR STARTER SPEED SENSOR TERMINATINGRESISTOR
SERVICE TOOLCONNECTOR
INTAKE MANIFOLDAIR PRESS SENSOR
COOLANT LEVELSENSORAFTERCOOLER
COOLANT WATERPRESSURE
CONNECTS TOCAM SPEED
TIMING
INTAKEMANIFOLDAIR TEMPSENSOR
TOP VIEW
*SOME COMPONENTS REMOVED FOR CLARITY
B
VIEW OF AREA “B”
R1 W1 C1 R2 W2 C2 R3 W3 C3
R4 W4 C4 R5 W5 C5 R6 W6 C6
RTD TERMINAL STRIP
INJECTOR 6
INJECTOR 5
INJECTOR 4
INJECTOR 3
INJECTOR 2
INJECTOR 1
A-C3
CONNECTS TOFUEL PRESSPRE FILTERGROUND
GENERATORBARRELGN-C5
RTDMODULE
FRONT VIEW
*SOME COMPONENTSREMOVED FOR CLARITY
OIL TEMPERATURESENSOR
FUEL TEMPSENSOR
START AIR PRESSURE
A-C20
FUEL PRESSPOST FILTER
OIL PRESSURESHUTDOWN
COOLANT TEMPSENSOR
ENGINE OILPRESS SENSOR