fd110xcu om.p65 1 17/2/06, 12:03 pm...
TRANSCRIPT
LOCATION OF PARTS
q Dimmer switch
w Speedometer
e Front Turn Signal switch
r Horn switch
t Throttle grip
y Ignition switch
u Choke lever
i Starter switch (FD110XCD)
o Front brake fluid inspection window
(FD110XCSMU)
!00 Seat lock
!1 Gearshift lever
!2 Fuel tank
!3 Kick starter lever
!4 Rear brake pedal
!5 Engine Oil
filler cap
!6 Engine Oil
drain plug
!7 Arm, clutch
release (FD110XCSMU)FD110XCSMU
!7
FD110XCU_om.p65 17/2/06, 12:03 PM2
Black
1
http://mototh.com
FD110XCSMU FD110XCU,XCD
FD110XCU_om.p65 17/2/06, 12:04 PM13
Black http://mototh.com
Interval Km 1,000 4,000 8,000
Item Months 1 6 12
Battery I I I
Exhaust pipe bolts T T T
Air cleaner - C C
Valve clearance I I I
Spark plug I I R
Engine oil R R R
Inspect oil level every 500 km, replace every 4,000 km
Engine oil filter R - R
Replace every 8,000 km
Fuel hose I I I
Clutch I I I
Fuel filter I I I
Engine idle rpm I I I
Throttle cable play I I I
Drive chain I I I
Brakes I I I
Tires I I I
Steering I I I
Cylinder head nut T T T
Suspension - - I
Chassis bolts and nuts T T T
FD110XCU_om.p65 17/2/06, 12:04 PM18
Black
5
http://mototh.com
The air cleaner element used in this motorcycle isa paper element type. If the element has becomeclogged with dust, intake resistance will increase witha resultant decrease in power output and an increasein fuel consumption due to the richer mixture. Checkand clean the air cleaner element every 4000 km.According to the following procedure.
WARNING
FD110XCU_om.p65 17/2/06, 12:04 PM20
Black http://mototh.com
FD110XCSMUFD110XCU,XCD
FD110XCU_om.p65 17/2/06, 12:04 PM22
Black
6
http://mototh.com
q Check the brake fluid level in front brake fluidreservoir.If the level in the reservoir is below thelower mark, add DOT4 brake fluid and inspect brakepad worn down grooved limit line q.
q When adjusting the travel of brake pedal/lever, adjustthe free travel to 15-25mm.
w Screwing in or out the front/rear brake adjusting nut q.
FD110XCU,XCD
FD110XCSMU
FD110XCSMU
FD110XCU,XCD
FD110XCU.XCD.XCSMU
FD110XCU_om.p65 17/2/06, 12:04 PM25
Black http://mototh.com
New brake shoe must be changed in pair.
CAUTION
FD110XCU_om.p65 17/2/06, 12:04 PM26
Black
7
http://mototh.com
Solo riding Dual riding
Kg./cm.2 Psi Kg./cm.2 Psi
Front 1.75 25 1.75 25
Rear 2.25 33 2.25 33
ITEM
FD110XCU_om.p65 17/2/06, 12:04 PM27
Black http://mototh.com
SPECIFICATIONS
DIMENSIONS AND DRY MASSOverall length .............................................................................. 1920 mm.Overall width ............................................................................... 656 mm.Overall height .............................................................................. 1066 mm.Seat height .................................................................................. 766 mm.Wheel base ................................................................................. 1223 mm.Ground clearance ....................................................................... 123 mm.Dry mass ..................................................................................... 90 Kg. (FD110XCU)
91 Kg. (FD110XCD)88 Kg. (FD110XCSMU)
ENGINEType ............................................................................................ Four-stroke, air-cooled, SOHCNumber of cylinder ...................................................................... 1Bore ............................................................................................ 53.5 mm.Stroke .......................................................................................... 48.8 mm.Piston Displacement ................................................................... 109.6 cm3
Compression ration ..................................................................... 9.6 : 1Carburetor ................................................................................... MIKUNI VM 17 SHAir cleaner ................................................................................... PaperStarter system ............................................................................. Kick starter (FD110XCU, XCSMU)
Electric starter (FD110XCD)Lubrication system ...................................................................... Wet sump
FD110XCU_om.p65 17/2/06, 12:04 PM28
Black http://mototh.com
TRANSMISSIONClutch .......................................................................................... Wet shoe, automatic, centrifugal type (FD110XCU,XCD)
Wet shoe, manual, multi-plate type (FD110XCSMU)Transmission ............................................................................... 4-speed constant meshGearshift pattern ......................................................................... Rotary (FD110XCU, XCD)
1 Down, 3 up (FD110XCSMU)Primary reduction ratio ................................................................ 3.666 (77/21)Final reduction ratio .................................................................... 2.500 (35/14)Gear ratios,
Low ............................................................................... 3.000 (33/11)2nd ............................................................................... 1.875 (30/16)3rd ................................................................................ 1.368 (26/19)Top ................................................................................ 1.052 (20/19)
Drive chain .................................................................................. RK-M 428M, 98 links
CHASSISFrame .......................................................................................... SSRF (Suzuki Single Rectangular Frame)Front suspension ......................................................................... Telescopic, coil spring, oil dampedRear suspension ......................................................................... Swinging arm, coil spring, oil dampedSteering angle ............................................................................. 45° (right & left)Caster ......................................................................................... 27°Trail ............................................................................................. 65 mm.Turning radius ............................................................................. 1.8 m.Front brake .................................................................................. Drum brake (FD110XCU, XCD)
Disc brake (FD110XCSMU)Rear brake .................................................................................. Drum brakeFront tire size .............................................................................. 70/90-17 NR54,44pRear tire size ............................................................................... 80/90-17 NF43,38p
FD110XCU_om.p65 17/2/06, 12:04 PM29
Black http://mototh.com
ELECTRICAL SYSTEMIgnition system ............................................................................ DC-CDISpark plug ................................................................................... NGK:C6HS, ND:U20FS-UBattery ........................................................................................ 12 V (3Ah) / 10 HR (FD110XCU, XCSMU)
12 V (5Ah) / 10 HR (FD110XCD)Generator .................................................................................... AC GeneratorFuse ............................................................................................ 10AHead light .................................................................................... 12 V 32/32 WTail/brake light ............................................................................. 12 V 5/18 WTurn signal light ........................................................................... 12 V 10 WSpeedometer light ....................................................................... 12 V 3 WNeutral indicator light .................................................................. 12 V 1.7 WTurn signal indicator light ............................................................ 12 V 1.7 WGear position indicator light ........................................................ 12 V 1.7 WHigh beam indicator light ............................................................ 12 V 1.7 W
CAPACITIESFuel tank including reserve ......................................................... 4.5 LEngine oil, without filter change .................................................. 800 ml. (FD110XCU, XCD)
700 ml. (FD110XCSMU)Engine oil, with filter change ....................................................... 900 ml. (FD110XCU, XCD)
800 ml. (FD110XCSMU)Engine overhaul .......................................................................... 1000 ml. (FD110XCU, XCD)
900 ml. (FD110XCSMU)Front fork oil ................................................................................ 70 ml.
FD110XCU_om.p65 17/2/06, 12:04 PM30
Black
8
http://mototh.com