esquemas 966 h

RENR6332-02March 2008

966H and 972H

Electrical SystemWheel Loader

972H:A7D1-UPA7G1-UPA7J1-UP


Volume 1 of 2 : Chassis

© 2008 Caterpillar, All Rights Reserved Printed in U.S.A.

1

2 200-L32 BK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795

9X-1123ComponentPart Number

Single WireConnector

SocketPin

AG-C3130-6795

Pin or Socket Number

Wire, Cable, or Harness Assembly Identification:Includes Harness Identification Letters and Harness

Connector Serialization Codes Harness Connector Serialization Code: The "C" standsfor "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)Part Number For Connector Recepticle

Part Number forConnector Plug

Harness Identification Letter(s):(A, B, C, ..., AA, AB, AC, ...)

Plug

GroundConnection

325-AG135 PK-14

Circuit IdentificationNumber Wire Color Wire Gauge

Harness identification code: This example indicates wire 135 in harness "AG".

Receptacle

PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit BreakerSymbol

Harness and Wire Symbols

1 12 2

Sure-Seal connector: Typical representationof a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

Deutsch connector: Typical representationof a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

Symbols

Symbols and Definitions

Harness And Wire Electrical Schematic Symbols

Fuse(5 Amps)

5A

Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. Thegrounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.T

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

RE

NR

6332-0

2 V

OL

1 o

f 2

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

3

45

68

9

10

11

12

14 15

13

16

1

2

17

18

19

20

21

22

23

24

2526

27

28

29

30

31

32

37

35

33

34

36

38

7

39

40

41

42

43

44 45

46

47

48

49

50

3

4

5

6

8

9

10

1

2

7

21

22

23

24

25

26

27

28

29

30

31

32

37

35

33

34

36

38 39

40

4142

43

44

45

46

47

48

49

50

11

12

14 1513

16

17

18

19

20

Component Identifiers (CID¹)Module Identifier (MID²)Engine Control System

(MID No. 036)CID Component0001 Fuel Injector Solenoid #10002 Fuel Injector Solenoid #20003 Fuel Injector Solenoid #30004 Fuel Injector Solenoid #40005 Fuel Injector Solenoid #50006 Fuel Injector Solenoid #60041 ECM 8V DC Supply0091 Throttle Sensor0094 Fuel Pressure Sensor0100 Oil Pressure Sensor0110 Engine Coolant Temperature Sensor0168 Electrical Power Supply0172 Intake Manifold Air Temperature Sensor0174 Fuel Temperature Sensor0190 Engine Speed Sensor0253 Personality Module0261 Engine Speed Sensor0262 5 Volt Sensor Supply0267 Engine Shutdown Switch0268 Check Programmable Parameters0274 Atmospheric Pressure Sensor0275 Right Turbo Inlet Pressure Sensor0283 Filter Restrict Lamp0291 Engine Cooling Fan Solenoid0296 Transmission ECM0342 Camshaft Position Sensor0596 Implement Control1639 Machine Security System1785 Intake Manifold Pressure Sensor2417 Start Aid Solenoid

¹ The CID is a diagnostic code that indicates which circuit is faulty.² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.

Component Location Volume 1Component Schematic

LocationMachineLocation Component Schematic

LocationMachineLocation

Alarm - Backup D-14 1Alternator B-12 2Arc Suppressor - A/C B-10 3

Sensor - Lift Position G-2 8

Arc Suppressor - Quick Coupler J-2 4

Sensor - Oil Pressure C-12 24

Arc Suppressor - Secondary Steering I-7 5

Sensor - Rear Axle Oil Temp. B-7&8 21

Arc Suppressor - Start Relay H-11 6

Sensor - Tilt Position G-1 25

Batteries J-10 7

Sensor - Transmission Oil Temperature H-7 26

Block Asm. J-10 7

Sensor - Transmission Input Speed H-7 27

Breaker - Alternator G-12 6

Sensor - Trans. Output Speed (Leading) G-7 28

Breaker - Belly Guard Actuator I-12 6

Sensor - Trans. Output Speed (Trailing) G-7 28

Breaker - Hood Actuator I-12 6

Sensor - Turbo Inlet Pressure F-10 29

Breaker - Main H-12 6

Solenoid - A/C Clutch B-11 3

Breaker - Running Lamp I-12 6

Solenoid - Aux Lift Prop G-2 22

Breaker - Start H-12 6

Solenoid - Aux Lower Prop H-2 22

Breaker - Unswitched Bus (Cab) I-12 6

Solenoid - Dump Prop H-3 22

Control - Engine C-F/11-12 8

Solenoid - Lift Anti-Drift G-3 22

Control - Hood Raise/Lower I-10 6

Solenoid - Lift Prop G-3 22

Motor - Autolube Pump B-5 9

Solenoid - Lower Prop H-3 22

Motor - Belly Guard J-12 10

Solenoid - On / Off Pilot G-2 22

Motor - Front Washer C-4&5 11

Solenoid - Quick Coupler J-2 4

Motor - Fuel Priming Pump B-10 12

Solenoid - Rack Back Prop H-3 22

Motor - Hood Actuator F-12 13

Solenoid - Reversing Fan C-10 30

Motor - Rear Washer C-4&5 11

Solenoid - Start Aid I-6 31

Motor - Secondary Steering H-8 5

Solenoid - Tilt Anti-Drift H-3 22

Motor - Starter I-9 14

Solenoid - Variable Speed Fan C-10 30

Relay - Main H-12 6

Solenoids - Cylinder Head ( 1 & 2) F-14 21

Relay - Secondary Steering I-8 5Solenoids - Ride Control (1& 2) G-2 22

Relay - Secondary Steering Intermediate I-8 15 Solenoids - Trans. Clutch (1 - 3) H-8 32Relay - Start H-12 6

Switch - A/C Refrigerant B-11 3Resistor - CAN E-8 8

Switch - Belly Guard Actuator 1,2 J-11 33Sender - Fuel Level G-13 8

Switch - Brake Oil Pressure C-11 30Sender - T/C Temperature E-7&8 3

Switch - Differential Pressure C-13 12Sensor - Atmospheric Pressure E-12 16

Switch - Disconnect J-10 33Sensor - Boost Pressure D-13 17

Switch - Fuel Priming Pump B-10 12Sensor - Cam Shaft Speed Timing D-12 18

Switch - Ground Level Shutdown G-11 6Sensor - Coolant Temperature E-12 12

Switch - Hood Actuator G-11 6Sensor - Crank Shaft Speed Timing D-13 12

Switch - Hydraulic Filter Bypass Pressure D-5 34Sensor - Front Axle Oil Temperature J-2 19

Switch - Park Brake Pressure D-5 35Sensor - Fuel Pressure C-13 20

Switch - Primary Steering Pressure I-6 36Sensor - Fuel Temperature B-13 21

Switch - Secondary Steering Pressure I-6 36Sensor - Hydraulic Oil Temperature H-4 3

Switch - Trans Filter Bypass D-5 37

Connector Location Volume 1Connector Number Schematic


CONN 1 C-14 38CONN 2 C-14 38CONN 3 I-13 39CONN 4 H-13 39CONN 5 C-12 8CONN 6 Timing/Cal Probe D-12 8CONN 7 E-13 21CONN 8 Jump Start Recptacle J-10 40CONN 9 B-8 41CONN 10 F-8 14CONN 11 I-7 15CONN 12 C-6 34CONN 13 D-6 34CONN 14 G-5,H-5 42CONN 15 G-5 43CONN 16 F-5.G-5 43CONN 17 E-5 43CONN 18 H,I-4 44CONN 19 J-3 45CONN 20 J-3 46CONN 21 I-2,3 47CONN 22 H-2,3 48CONN 23 G-3 49CONN 44 B-5 50CONN 45 C-6 9

Failure Mode Identifiers (FMI)¹FMI No. Failure Description

0 Data valid but above normal operational range.1 Data valid but below normal operational range.2 Data erratic, intermittent, or incorrect.3 Voltage above normal or shorted high.4 Voltage below normal or shorted low.5 Current below normal or open circuit.6 Current above normal or grounded circuit.7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.9 Abnormal update.10 Abnormal rate of change.11 Failure mode not identifiable.12 Bad device or component.13 Out of calibration.14 Parameter failures.15 Parameter failures.16 Parameter not available.17 Module not responding.18 Sensor supply fault.19 Condition not met.20 Parameter failures.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

Event CodesEngine Control

Event Code Condition

E096 High Fuel Pressure

E172 High Air Filter Restriction

E194 High Exhaust Temperature

E265 User Defined Shutdown

E360 Low Engine Oil Pressure

E362 Engine Overspeed

E363 High Fuel Temperature

E390 Fuel Filter Restriction

E441 Idle Elevated to Increase Battery Voltage

E539 High Intake Manifold Air Temperature

Off Machine Switch SpecificationPart No. Function Actuate Deactuate Contact Position114-5333 A/C (High / Low) Pressure 275 to 1750 kPa¹

(39.9 to 253.8 psi)--

Normally Open²

117-7773 Hydraulic Filter Bypass Pressure 138 ± 28 kPa(20 ± 4 psi)

89 ± 20 kPa(12.9 ± 2.9 psi)

Normally Closed

174-4312 Park Brake Pressure 8270 kPa MAX(1200 psi MAX)

6890 ± 345 kPa(1000 ± 50 psi)

A-B, Normally OpenA-C, Normally Closed

175-3244 Brake Oil Pressure 10700 kPa MAX(1550 psi MAX)

8960 ± 537 kPa(1300 ± 79 psi)

A-B, Normally OpenA-C, Normally Closed

230-5771 Secondary Steering Pressure 1200 kPa MAX(174.0 psi MAX)

700 ± 100 kPa(102 ± 14.5 psi)

A-B Normally OpenA-C Normally Closed

258-0883 Fuel Differential Pressure 110.3 ± 13.8 kPa(16 ± 2 psi)

69 kPa MIN(10 psi MIN)

Normally Closed

3E-6450 Primary Steering Pressure 1200 kPa MAX(174.0 psi MAX)

700 ± 100 kPa(102 ± 14.5 psi)

A-B Normally OpenA-C Normally Closed

¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained down to 170 kpa (25psi).

² Contact postion at the contacts of the harness connector.

Related Electrical Service ManualsTitle Form Number

Alternator: 177-9953 (Denso HDB 80A)SENR4130

197-8820 (Denso HDB 95A)

Electric Starting Motor: 165-4619 (Delco 42MT) SENR3581

Engine Control: RENR9318

Resistor, Sender and Solenoid SpecificationsPart No. Component Description Resistance (Ohms)¹128-7991 Solenoids: Fuel Injection 1.06 ± 0.05134-2540 Resistor: CAN Data Link 108 - 132

138-2924 Solenoids:

Aux Lift Raise Prop

7.75 ± 1.0

Aux Lower PropDump PropLift PropLower PropRackback Prop

145-7028 Sender: T/C Temperature 1000148-2350 Solenoid: Variable Speed Fan 5.0 ± 0.3152-6761 Solenoid: On/Off Pilot 32.6 ± 1.6152-8340 Solenoid: Auto Reversing Fan 32.6 ± 1.6163-0872 Solenoid: A/C Compressor Clutch 17.6±0.6168-6452 Solenoid: Axle Oil Cooler Clutch 9.4 ± 5.0216-5338 Solenoids: Transmission Clutch 8.7 ± 0.4

220-8214 Sender: Fuel Level Empty: 240 - 250Full: 28 - 33

237-2234 SolenoidLeft Anti-DriftRide Control (3)Tilt Anti-Drift

33.8

239-1134 Solenoid: Start Aid 20.0¹ At room temperature unless otherwise noted.

Wire DescriptionWire

Number Description WireNumber Description

Power Circuits Control Circuits101 RD Bat (+) G790 PK Not Used102 RD Hd Lmp G791 BR Not Used103 YL Auto Lube Pump to Auto Lube Pressure Sw. H702 PU Implement Control Reversing Fan Sw (N.O.)106 WH Tilt/Lift Position Sensors H703 YL Implement Control Reversing Fan Sw (N.C.)110 RD Engine ECM H704 PK Auto Reverseing Fan Solenoid112 PU Main Power Rly Output H713 PK Implement Control Lift Proportional Sol114 RD Warning Horn (forward) H714 OR Implement Control Lower Proportional Sol124 GN Auto Lube Pump to Auto Lube Pressure Sw. H717 BR Implement Control Pilot Press Sol 129 RD Fuel Priming Pump to Machine Interface H718 GY Implement Control Tilt Cyl Position136 GN Supplemental Steering H746 YL Variable Speed Fan Solenoid138 GN Auto Lube Pump To PCS H747 BR Variable Speed Fan Solenoid141 RD Beacon / Heated Mirrors H795 PK Engine Digital Sensor (Return)147 RD ECAP / Center Dash Indicator Panel J764 BR Transmission Switch/Sensor Return #1150 OR Implement/Transmission/Engine ECM K737 BR Not Used174 RD Unswitched Bus Power K738 GN Not Used175 RD Hood Actuator K739 BU Not Used199 RD Hood Actuator N707 PU Fuel Differential Pressure (Return)

Ground Circuits R746 PK Atmosphereic Pressure Sensor (Ground)200 BK Main Chassis R747 GY Boost Pressure Sensor Signal201 BK Operator Monitor Return T725 WH Fuel Differential Pressure Signal202 BK Xmsn Ctrl Y794 OR Expanded Can Data Link +229 BK Engine ECM Y795 GN Expanded Can Data Link -261 BK Brake Oil Pressure Sw. 838 YL Belly Guard Actuator

C216 BK Implement Return 839 BU Belly Guard ActuatorBasic Machine Circuits A893 OR Fuel Priming Sw.

304 WH Starter Relay to Starter Motor G828 WH Engine +5V Sensor Supply306 GN Starter Relay Coil to Transmission Control G829 GN Engine Sensor Ground308 YL Main Power Relay Coil G833 PK Fuel Temperature Sensor (Ground)321 BR Backup Alarm Lamp Travel Alarm G850 BU Inlet Air Heater322 GY Warning Horn (Forward) G856 WH Timing/Cal. Probe (+)326 PU Key Sw 'C' Term. G857 YL Timing/Cal. Probe (-)397 OR Hood Actuator Motor (Lower) J807 BK Proportional Return (1-3)398 BU Hood Actuator Motor (Raise) J808 BK Proportional Return (4/Rev)

A300 GN Lower Hood J809 BK Proportional Return (Forward)A301 WH Raise Hood J813 BK Implement Proportional ReturnA307 GY Throttle Position J814 BK Implement Proportional ReturnX337 WH Not Used J815 BK Ride Control Solenoids Proportional Return

Monitoring Circuits J843 BK Turbo Inlet Pressure Sensor (Ground)403 GN Alternator (R) Term. J844 GY Turbo Inlet Pressure Sensor (+ Battery)416 OR Supplemental Steering Sw T858 GY Fuel Injector Solenoid #1/2 Common417 GY Primary Steering Sw T859 WH Fuel Injector Solenoid #3/4 Common419 YL Opr Mon Parking Brake T860 OR Fuel Injector Solenoid #5/6 Common426 BR Opr Mon Power Train Oil Filter 900 PU Xmsn Shift Sol No. 5 Or 4430 BU Opr Mon Air Filter 901 WH Xmsn Shift Sol No. 6432 PK Opr Mon Brake Press. (oil) 944 OR Cat Data Link +439 YL Lamp Indicator 945 BR Cat Data Link -442 GY Hyd System Temp Gage 976 OR Ride Cont Solenoid 1443 YL Power Train Temp Gage 987 WH Third Function Diverter Sol447 PK Fuel Level Gage 994 GY Oil Pressure Sensor (Signal)450 YL Tach Sender (+) 995 BU Coolant Temperature Sensor (Signal)453 PK Supplemental Steering Fault Lamp A958 WH Park Brake Sol484 YL Primary Steering Lamp A982 BR Engine Throttle Cont

E455 BR Hydraulic Oil Filter C967 BU Intake Manifold Air Temperature Sensor (Signal)F421 YL Fuel Temperature Sensor (Signal) C991 PK Fuel Pressure Sensor (Signal)G479 WH Prelube Indicator E900 WH Trans Output Spd +G485 BU Opr Mon Front Brake Temperature E901 GN Trans Output Spd -G486 GN Opr Mon Rear Brake Temperature E906 OR Trans Output Spd Q+

Accessory Circuits E907 GY Trans Output Spd Q-506 PU Washer - Front E908 BR Trans Input Spd +507 WH Washer - Rear E909 WH Trans Input Spd -513 OR A/C Pressure Sw. to A/C Clutch Solenoid E919 YL Aux Lower Proportional Sol521 YL A/C Sw To Refrigerant Sw E920 BR Aux Lift Proportional Sol522 WH A/C Clutch To Thermostat Sw E921 PK Rackback Proportional Sol

C529 GY Lift Press Sensor E922 GN Dump Proportional SolenoidC530 BU Lift Position Sensor E963 BK Crank Speed/Timing (-)

Lighting Circuits E964 WH Crank Speed/Timing (+)604 OR Stop Lamp E965 BU Cam Speed/Timing (-)605 YL Turn Lamp - Left E966 YL Cam Speed/Timing (+)606 GY Turn Lamp - Right K927 BU On/Off Pilot Solenoid (Return)611 PU Head Lamp Hi K977 PK Trans Oil Temp Sensor614 PU Park/Tail/Dash/Lamp N939 GN Ride Control Solenoid 2617 BR Tail/position Lamp - Left (Road Pkg)/Width P945 OR Anti Drift Sol- Stick619 GN Head Lamp Low P946 BR Anti Drift Sol- Boom

Control Circuits P976 BR Quick Coupler Sw To Low Pressure Sol727 GN Supplemental Steering Motor Relay P990 BR Start Relay Ctrl (Return)728 BU Supplemental Steering Cont Sw T957 PU Fuel Injector Solenoid #1751 GN Xmsn Shift Sol No. 1 Or 3 T958 YL Fuel Injector Solenoid #2752 YL Xmsn Shift Sol No. 2 T959 BR Fuel Injector Solenoid #3754 BU Xmsn Shift Sol No. 3 Or 1 T960 BU Fuel Injector Solenoid #4755 OR Xmsn Shift Sol No. 4 Or 5 T961 GN Fuel Injector Solenoid #5

E748 BK Auto Reverse Fan/Start Aid Solenoid Return T962 WH Fuel Injector Solenoid #6F713 OR Turbo Inlet Pressure Sensor (Signal) X918 PU Ground Level Shut Down (N.O.)F762 GY Start Aid Solenoid X919 WH Ground Level Shut Down (N.C.)G764 PK Xmsn Cont Park Brake Lever Sw To Gnd

WireColor

WireColor

Solenoids - Cylinder Head ( 3 - 6) E-14 21

Solenoids - Ride Control (3) F-2 22

Solenoids - Trans. Clutch (4 - 6) G-8 32Switch - Autolube Pressure B-5 9

Sensor - Intake Manifold Air Temp E-12 22Sensor - Lift Cylinder Head End Pressure I-2 23

SYMBOL DESCRIPTION

BLADE, SPADE, RING OR SCREWTERMINAL

CIRCUIT CONNECTED

CIRCUIT NOT CONNECTED

ELECTRICAL CONNECTION TOMACHINE STRUCTURE

INTERNAL ELECTRICAL CONNECTIONTO SURFACE OF COMPONENT

CONNECTOR

ATCH WIRE, CABLE, COMPONENT

CIRCUIT CONNECTED

SPLICE

CIRCUIT GROUPING DESIGNATIONH#

ABBREVRDWHORYLPKBKGYPUBRGNBU

COLORRED

WHITEORANGEYELLOW

PINKBLACKGRAY

PURPLEBROWNGREENBLUE

COLOR ABBREVIATIONS

OTHER COLOR DESCRIPTIONSHIGHWAYS

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.

STARTING CIRCUIT.GROUND CIRCUIT.STARTING AID CIRCUIT.

MONITOR CIRCUIT.ENGINE CONTROL CIRCUIT.

PAYLOAD CONTROL CIRCUIT.TRANSMISSION CONTROL CIRCUIT.IMPLEMENT CONTROL CIRCUIT.

HEATER AND AIR CONDITIONER CIRCUIT.TURN SIGNAL/WIPER/WASHER CIRCUIT.

WIRE GROUP COLOR DESCRIPTIONS

CAT DATA LINK.CAN DATA LINK.

RE

NR

6332-0

2 V

OL

1 o

f 2

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

A

B

C

D

E

F

1234567891011121314

G

H

I

J

1234567891011121314

A

B

C

D

E

F

G

H

I

J

THIS SCHEMATIC IS FOR THE THE 966H / 972H WHEEL LOADER CHASSIS WITH ELECTRO-HYDRAULIC AND PILOT IMPLEMENT CONTROL. CCS AND HMU STEERING AND ELECTRONIC ENGINE CONT.VOLUME 1 of 2: PART NUMBER: 237-5751, CHANGE: 02, VERSION: -,V,XComponents are shown installed on a fully operable machine.

Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

12GROUND

SIGNAL

FUEL TEMP SENSOR130-9811

OR-18YL-18GROUND

+5V

SIGNAL GN-18

FUEL PRESSURE SENSOR239-2396

DIFF PRESS SW258-0883

BK-18BK-18

12345678

2

1234

AW-C23E3376

12

AW-C1155-2264

345678

12

AW-C3155-2269

GROENEVELD AUTOLUBE

136-AW5 GN-18136-AW5 GN-18

136-AW6 GN-18

136-AW6 GN-18136-AW7 GN-18

136-AW7 GN-18

200-AW1 BK-18200-AW1 BK-18

200-AW1 BK-18

124-AW3 GN-16

124-AW3 GN-16

124-AW3 GN-16103-AW2 YL-16

103-AW2 YL-16

103-AW2 YL-16

439-AW4 YL-18

439-AW4 YL-18439-AW4 YL-18

PUMP

AUTOLUBE GROENEVELD PUMP184-0704

GN

GNBK

YL

GNYL

AY-C23E3388

136-AY6 GN-18

136-AY7 GN-18200-AY1 BK-18

124-AY3 GN-16103-AY2 YL-16

439-AY4 YL-18

AY-C1146-4055

124-AX1 GN-16103-AX2 YL-16

AX-C23E3364

1

AX-C1146-4073

PRESSURE SW.177-3519

CONN 44

CONN 45

12

M-C13E3388

345678

M-C61552269

M-C71552267

A

CB

M-C52304011

12

M-C42304012

M-C23E3370

ABC

12

M-C31552269

12

FR-C21552269

12

FR-C31552269

12

FR-C11552252

3456789101112

12

FL-C21552269

12

FL-C31552269

12

FL-C11552252

3456789101112

12

FC-C11552252

3456789101112

12

FC-C21552269

12

FA-C11552252

3456789101112

12

FA-C21552269

EU-C11552267

ABC

12

EU-C21552269

12

EU-C51552269

EA-C21552267

ABC

12

EA-C57T5957

12

EA-C67T5957

12

EA-C41552269

12

EA-C31552269

12

EA-C11552252

3456789101112

12

CY-C13E3364

12

CY-C21552269

12

J-C13E7990

3456789101112

12

J-C27E6513

12

J-C37E6513

12

J-C47E6513

12

J-C57E6513

12

J-C67E6513

12

J-C77E6513

12

CV-C11552269

1524

CV-C39X1054

12

CV-C23E3382

3456

12

CP-C21552269

12

CP-C11552269

12

CJ-C21552269

12

CJ-C33E3364

12

CJ-C161552273

3456

CJ-C331552267

A

CB

12

CJ-C321552269

12

CJ-C313E3364

CJ-C81552267

A

CB

12

CJ-C261552269

12

CJ-C273E3364

1234567

CJ-C118N1533

1

CJ-C201297163

1

CJ-C171297164

12

CJ-C401552269

12

CJ-C151552269

12

CJ-C301552269

CJ-C181552267

ABC

CJ-C191552267

ABC

12

CJ-C141552269

12

CJ-C121552273

3456

12

CJ-C133E3382

3456

12

CJ-C223E3364

CJ-C233E3370

ABC

CJ-C243E3370

ABC

123456789101112131415161718192021222324

CJ-C41607689

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12

CJ-C61552269

123456789101112131415161718192021222324

CJ-C211835784

25262728293031323334353637383940

123456789101112131415161718192021222324

CJ-C101130580

25262728293031323334353637383940

CJ-C251552267

ABC

12

CJ-C361552272

34

12

CJ-C411552269

123456789101112131415161718192021222324

CJ-C13E6286

25262728293031323334353637383940

12

CJ-C383E3364

12

CJ-C93E5179

3456789101112

12

CJ-C341552272

34

1234

CJ-C353E3376

12

CJ-C281552269

12

CJ-C293E3364

21

CH-C31552269

12

CH-C141552269

12

CH-C51552269

CH-C153E3370

ABC

CH-C161552267

A

BC

123456789101112131415161718192021222324

CH-C13E6286

25262728293031323334353637383940

CH-C91552267

ABC

123456789101112131415161718192021222324

CH-C21607689

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12

CH-C71552269

12

CH-C83E3364

12

CH-C101552269

12

CH-C113E3364

12

CH-C121552269

CH-C61552267

ABC

12

CH-C41552269

CF-C21552267

ABC

12

CF-C41552269

CF-C13E3370

ABC

12

CF-C33E3364

CE-C21552267

ABC

CE-C13E3370

ABC

12

CE-C41552269

12

CE-C33E3364

12

A-C121552269

12

A-C71552269

12

A-C111552269

12

A-C81552269

12

A-C91552269

A-C53E3370

ABC

A-C133E3364

A-C43E3370

ABC

A-C61552267

ABC

123456789101112131415161718192021222324

A-C12274002

252627282930313233343536373839404142434445464748495051525354555657585960616263646566676869707172737475767778798081828384858687888990919293949596979899100101102103104105106107108109110111112113114115116117118119120

12

A-C21552252

3456789101112

12345678

A-C101552264

12

AY-C21552273

3

45

6

12

AY-C11552252

3456789101112

12

AT-C11552269

12

AT-C91552269

12

AT-C131552269

123456789101112131415161718192021222324

AT-C107X6222

12

AT-C141552269

1 2

AT-C51552269

1 2

AT-C41552269

1 2

AT-C21552269

1 2

AT-C61552269

1 2

AT-C71552269

1 2

AT-C81552269

AM-C13E3370

ABC

AM-C21552267

ABC

12

AL-C21552273

3

45

6

12

AL-C11552252

3456789101112

12

AH-C11552273

3456

12

AH-C21552269

12

AG-C31552269

12

AG-C171552269

AG-C121552267

ABC

AG-C81552267

ABC

12

AG-C133E3364

AG-C193E3370

ABC

AG-C211552267

ABC

12

AG-C331552269

12

AG-C341552269

12

AG-C181552269

12

AG-C201552269

12

AG-C261552269

12

AG-C271552269

12

AG-C111552269

12

AG-C321552269

12

AG-C311552269

12

AG-C291552269

12

AG-C71552269

12

AG-C363E3364

12

AG-C283E3364

12

AG-C303E3364

12

AG-C353E3364

12345678910111213141516171819202122232425262728293031323334353637383940

AG-C11130580

12

AG-C371552269

12

AG-C383E3364

12

AG-C43E5179

3456789101112

12

AG-C53E5179

3456789101112

AG-C23E3370

ABC

AG-C91552267

ABC

12

AG-C241552269

12

AG-C253E3364

WH-18BR-18GN-18 +24V

GROUNDSIGNAL

LIFT CYL HEAD END PRESS SNSR221-3416

WH-18BK-18OR-18 +24V

GROUNDSIGNAL

LIFT POS SENSOR169-0417

WH-18RD-14BU-14BK-14GN-18OR-14 MOTOR LOWER

LOWER HOODGROUNDMOTOR RAISE+28VRAISE HOOD

HOOD RAISE/LOWER MOTOR CONTROL1492612

20A

HOOD ACTUATOR BREAKER6T-3644

15A

RUNNING LAMP BREAKER3T-2662

80A

MAIN BREAKER1712210

105A

ALTERNATOR BREAKER1712212

BK-18BK-18

MAIN RELAY2418368

BK-18BK-18

START RELAY3E0075

CLUTCH 1 REV216-5338

CLUTCH 2 FWD216-5338

CLUTCH 3 4TH216-5338

CLUTCH 4 3RD216-5338

CLUTCH 5 2ND216-5338

CLUTCH 6 1ST216-5338

OUTPUT SPEED SNSR (LEADING)193-2550

BK-18WH-18

BU-16RD-16BK-16

PARK BRAKE PRESS SW174-4312

BU-16RD-16BK-16

BRAKE OIL PRESS SW175-3244

ALT

+ R

ALTERNATOR177-9953 80A(197-8820 95A ATCH)

G S

MTR BAT

MOTOR STARTER165-4619

DISCONNECT SW7N0718

BK-18BK-18

START AID SOL2391134

MOTOR

HOOD ACTUATOR MOTOR1614002

BK

RD

BU-16RD-16BK-16

PRIMARY STEERING PRESS SW3E-6450

BLOCK AS8C6358

NEGPOS

12V BATTERY 11152422

NEGPOS

12V BATTERY 21152422

KK-C12466196

12

VARIABLE SPEED FAN SOL148-2350

SIGNALGROUND

INTAKE MAN AIR TEMP SNSR1978391

OR-18YL-18GROUND

+5V

SIGNAL GN-18

BOOST PRESSURE210-1747

SIGNALGROUND

COOLANT TEMP SENSOR1978392

MOTOR

FUEL PRIMING PUMP162-2211

FUEL PRIMING PUMP SW165-5970

RD-18BK-18WH-18

MOM

30A

UNSWITCHED BUSS BREAKER (CAB)6N-9349

BACKUP ALARM1236449

BK-18BK-18

LH FORWARD HORNXXX-XXXX

RH FORWARD HORN163-1201

BU-18BK-18OR-18 +V

SIGNALGROUND

TILT POSITION SENSOR169-0417

MOTOR

FRONT WASHER PUMP7T-8890

MOTOR

REAR WASHER PUMP7T-8890

OUTPUT SPEED SENSOR (TRAILING)193-2550

BK-18WH-18

INPUT SPEED SENSOR193-2550

BK-18WH-18

GROUNDSIGNAL

XSMN OIL TEMP SENSOR145-7028

BU-16RD-16BK-16

SECONDARY STEERING PRESS SW230-5771

MOTORSECONDARY STEERING MOTOR183-6967

SECONDARY STEERING RELAY183-6970

FUEL LEVEL SENDER2208214

PK-18BK-18

87a87

85

8630

SEC STEER INTERMEDIATE RELAY3E-5239

BK-18BK-18

XMSN FILTER BYPASS SWITCH164-7577

LH GROUND

ENGINE GROUND

SECONDARY STEERING GROUND

CRANKSHAFT SPD TIMING2366221

BK-18BK-18

RH GROUND

GROUNDSIGNAL

TORQ CONV TEMP SENDER145-7028

+V

SIGNALGROUND

OIL PRESSURE SENSOR1611705

+V

SIGNALGROUND

ATM PRES1978393

OR-18BK-18GROUND

+BATTERY

SIGNAL YL-18

TURBO INLET PRESSURE SENSOR194-6722

GN-14GN-14

QUICK COUPLER SOLENOID180-8585

QUICK COUPLER ARC SUPPRESSOR218-4935

50A

START BREAKER1712206

ALT GROUND

312

HOOD ACTUATOR SW1460240

RD-18

BK-18WH-18

GROUND LVL SHUTDOWN SW1586634

RD-18BK-18WH-18

LIFT ANTIDRIFT SOL237-2234

TILT ANTIDRIFT SOL237-2234

LIFT PROP SOL138-2924

RACKBACK PROP SOL138-2924

DUMP PROP SOL138-2924

LOWER PROP SOL138-2924

RIDE CONTROL SOL 1252-0737

AUX LOWER PROP SOL138-2924


AUX LIFT PROP SOL138-2924

GN-14GN-14

ON OFF PILOT SOL152-6761

GROUNDSIGNAL

REAR AXLE OIL TEMP SENSOR130-9811

GROUNDSIGNAL

HYD OIL TEMP SENSOR130-9811

GROUNDSIGNAL

FRONT AXLE OIL TEMP SENSOR130-9811

ANALOG SENSOR POWERANALOG SENSOR RETURN

THROTTLE SENSOR POWERDIGITAL SENSOR/SWITCH RETURN

CAT DATA LINK +CAT DATA LINK -

TURBO INLET PRESSURE SENSOR SIG

GROUND LEVEL SHUTDOWN(N/C)

ENG SPEED SIGNAL TO XMSN CONTROL

GROUND LEVEL SHUTDOWN(N/O)

DEMAND FAN SOL +

+ BATTERY

DEMAND FAN SOL -+ BATTERY+ BATTERY

- BATTERY

- BATTERY

THROTTLE PEDAL POSITION

KEY SWITCH ON (B+)

TRANSMISSION LUBE OIL SENSOR

AIR FILTER RESTRICTED INDICATORSTART AID INDICATOR

PRELUBE INDICATOR

- BATTERY

JAKE/CAT BRAKE SOLENOID L/H

INJECTOR 2 RETURN

A4 E4 V2 2267467

J1J2

JAKE/CAT BRAKE SOLENOID M/H

COOLANT TEMPJAKE/CAT BRAKE RETURN

INTAKE MANIFOLD AIR PRESSURE

PRESSURE SENSOR RETURN

CRANK S/T-TDC SERVICE PROBE+

LUBE OIL PRESSURE

TEMP SENSOR RETURN

CRANK S/T+

FUEL PRESSURE

USED ON J1

TDC SERVICE PROBE -

CAM S/T +CAM S/T -

UNDERCOVER SENSOR RETURN

INTAKE MANIFOLD AIR TEMP

FUEL TEMP

DIFFERENTIAL FUEL PRESSURE

PRESSURE SENSOR +5V

INPUT SWITCH RETURN

BOOST PRESSURE

INJECTOR 5+6 HIGH SIDE

INJECTOR 1+2 HIGH SIDEINJECTOR 6 RETURN

INJECTOR 3+4 HIGH SIDEINJECTOR 1 RETURN

EVAC ON

EVAC ENABLED

PRELUBE/EVAC RELAY

DRIVER RTN

ETHER ON SOL

USED ON J1

UNDERCOVER SENSOR +5V

INJECTOR 3 RETURNINJECTOR 5 RETURNINJECTOR 4 RETURN

AUTO REV FAN SOL

AUTO REV FAN (NC)AUTO REV FAN (NO)

CYL HEAD 11287991

CYL HEAD 21287991

CYL HEAD 31287991

CYL HEAD 41287991

CYL HEAD 51287991

CYL HEAD 61287991

12 3

BK-18BK-18

AC PRESS SW114-5333

GN-18GN-18

AC CLUTCH SOL163-0872

LH STOP TAIL TURN LAMP1456929

RD-18WH-18BK-18

ST

RD-18BK-18

STOP/TAIL

TURN

RH STOP TAIL TURN LAMP1456929

RD-18WH-18BK-18

ST

RD-18BK-18

STOP/TAIL

TURN

CAMSHAFT SPD TIMING SNR2366221

BK-18BK-18

15A

BELLY GUARD BREAKER3T-2662

ACTUATOR SW157-13644

1

5

23

6MOTOR

BELLY GUARD ACTUATOR196-7329

ABC

DC CAN RESISTOR 11342540

AUTO REV FAN SOL1152-8340

ARC SUPPRESSOR2184935

ARC SUPPRESSOR 12184935

ARC SUPPRESSOR START RLY2184935

BK-18BK-18

HYD FILT BYPASS117-7773


LH FRONT FLOODXXX-XXXX

RH FRONT FLOODXXX-XXXX

LEFT FRONT FLOOD176-0780

RIGHT FRONT FLOOD176-0780

LH TURN SIGNAL3E-6466

RD-18BK-18

RH TURN SIGNAL3E-6466

RD-18BK-18

BU-18RD-18WH-18YL-18BK-18

LH HI LO POS TURN LAMP105-4849

BU-18RD-18WH-18YL-18BK-18

RH HI LO POS TURN LAMP105-4850

RH HOOD STOP TAIL TURN LAMP1456929

RD-18WH-18BK-18

ST

RD-18BK-18

STOP/TAIL

TURN

LH HOOD STOP TAIL TURN LAMP1456929

RD-18WH-18BK-18

ST

RD-18BK-18

STOP/TAIL

TURN

J814-AG36BK-18

J813-AG25BK-18

J813-AG41BK-18

J814-AG49BK-18

J813-AG51BK-18

J813-AG42BK-18

K927-AG57BU-18

FRONT FRAME

J815-AG63BK-18

J815-AG60BK-18

114-AG1RD-18

114-AG1RD-18114-AG33RD-18

114-AG33RD-18

114-AG32RD-18

114-AG32RD-18

106-AG3WH-18

106-AG3WH-18106-AG35WH-18

106-AG35WH-18

106-AG34WH-18

106-AG34WH-18

200-AG7BK-14

200-AG7BK-14

200-AG37BK-16

200-AG37BK-16

200-AG8BK-14

200-AG8BK-14

200-AG40BK-14

200-AG40BK-14

200-AG38BK-14

200-AG38BK-14

C216-AG10BK-18

322-AG11GY-18

322-AG11GY-18322-AG44GY-18

322-AG44GY-18

322-AG43GY-18

322-AG43GY-18

619-AG17GN-14 619-AG17GN-14619-AG46GN-14

619-AG46GN-14

619-AG45GN-14

619-AG45GN-14

138-AG2GN-18138-AG2GN-18

C529-AG12GY-18

C529-AG12GY-18

C530-AG14BU-18

C530-AG14BU-18

C530-AG14BU-18

605-AG15YL-16

605-AG15YL-16

605-AG15YL-16 606-AG16GY-16606-AG16GY-16

H713-AG18PK-18

H713-AG18PK-18

H714-AG19OR-18

H714-AG19OR-18

J815-AG20BK-14

J815-AG20BK-14

H717-AG21BR-18

H717-AG21BR-18

E919-AG23YL-18

E919-AG23YL-18

E920-AG24BR-18

E920-AG24BR-18

E921-AG26PK-18

E921-AG26PK-18

E922-AG27GN-18

E922-AG27GN-18

N939-AG4GN-18

N939-AG4GN-18

976-AG29OR-18

976-AG29OR-18

FRONT FRAME

175-CJ95RD-14

175-CJ95RD-14

175-CJ95RD-14

RELAY PANEL

RELAY PANEL

J808-AT24BK-18J808-AT24BK-18

J807-AT23BK-18

J807-AT23BK-18J807-AT26BK-18

J807-AT26BK-18

TRANSMISSION

SHOWN WITH BRAKE ON

SHOWN WITHBRAKE OFF

605-CJ57YL-16

605-CJ57YL-16

605-CJ66YL-16

605-CJ66YL-16

605-CJ66YL-16

606-CJ58GY-16

606-CJ58GY-16606-CJ69GY-16

606-CJ69GY-16

614-CJ60PU-16

614-CJ60PU-16

614-CJ70PU-16

614-CJ70PU-16

614-CJ70PU-16

617-CJ61BR-16

617-CJ61BR-16

617-CJ72BR-16

617-CJ72BR-16

617-CJ72BR-16

606-CJ69GY-16

138-CJ22GN-18

138-CJ22GN-18

138-CJ22GN-18

138-CJ22GN-18

106-CJ20WH-18

106-CJ20WH-18

106-CJ20WH-18

106-CJ20WH-18

N939-CJ47GN-18

N939-CJ47GN-18

N939-CJ47GN-18

322-CJ25GY-18

322-CJ25GY-18

322-CJ25GY-18

322-CJ25GY-18

C529-CJ28GY-18

C529-CJ28GY-18

C529-CJ28GY-18

C529-CJ28GY-18

C530-CJ29BU-18

C530-CJ29BU-18

C530-CJ29BU-18

C530-CJ29BU-18

619-CJ3GN-14

619-CJ3GN-14

619-CJ3GN-14

619-CJ3GN-14

H713-CJ37PK-18

H713-CJ37PK-18

H713-CJ37PK-18

H713-CJ37PK-18

H714-CJ38OR-18

H714-CJ38OR-18

H714-CJ38OR-18

H714-CJ38OR-18

H717-CJ46BR-18

H717-CJ46BR-18

H717-CJ46BR-18

H717-CJ46BR-18

E919-CJ31YL-18

E919-CJ31YL-18

E919-CJ31YL-18

E919-CJ31YL-18

E920-CJ32BR-18

E920-CJ32BR-18

E920-CJ32BR-18

E920-CJ32BR-18

E921-CJ33PK-18

E921-CJ33PK-18

E921-CJ33PK-18

E921-CJ33PK-18

E922-CJ34GN-18

E922-CJ34GN-18

E922-CJ34GN-18

E922-CJ34GN-18

976-CJ27OR-18

976-CJ27OR-18

976-CJ27OR-18

611-CJ2PU-14

611-CJ2PU-14

611-CJ2PU-14

611-CJ2PU-14

CBL-EERD-00 CBL-GGBK-00 CBL-HHBK-00

CBL-KK2BK-00CBL-KK1RD-00

DASHED FONT INDICATES AN ATTACHMENT COMPONENTOR HARNESS

TIMING CALPROBE

A982-CH10BR-18

A982-CH10BR-18

A982-CH10BR-18

944-CH7OR-18

944-CH7OR-18

944-CH7OR-18

945-CH8BR-18

945-CH8BR-18

945-CH8BR-18

150-CH6OR-18

150-CH6OR-18

150-CH6OR-18

A307-CH9GY-18

A307-CH9GY-18

A307-CH9GY-18

H795-CH49PK-18

110-CH36RD-14

110-CH36RD-14

110-CH34RD-14

110-CH34RD-14

110-CH33RD-14

110-CH33RD-14

229-CH32BK-14

229-CH31BK-14

229-CH30BK-14

G828-A1WH-18

G829-A2GN-18

R746-A20PK-18

R746-A20PK-18G829-A41GN-18

G828-A35WH-18

G828-A35WH-18

G828-A39WH-18

G833-A45PK-18

G833-A45PK-18

G833-A44PK-18

G833-A44PK-18

G856-A22WH-18

G856-A22WH-18

E964-A26WH-18

E964-A26WH-18

994-A10GY-18

994-A10GY-18

995-A12BU-18

995-A12BU-18

C967-A15BU-18

C967-A15BU-18

G857-A30YL-18

G857-A30YL-18

E963-A27BK-18

E963-A27BK-18

R747-A6GY-18

R747-A6GY-18

E966-A49YL-18

E966-A49YL-18

E965-A48BU-18

E965-A48BU-18

T961-A28GN-18-XLPE

T961-A28GN-18-XLPE

T962-A29WH-18-XLPE

T962-A29WH-18-XLPE

T957-A16PU-18-XLPE

T958-A17YL-18-XLPE

T958-A17YL-18-XLPE

T959-A18BR-18-XLPE

T959-A18BR-18-XLPE

T960-A19BU-18-XLPE

T960-A19BU-18-XLPE

T860-A34OR-18-XLPE

T860-A34OR-18-XLPE

G485-AG6BU-18

G485-AG6BU-18G485-CJ35BU-18

G485-CJ35BU-18

G485-CJ35BU-18

G485-CJ35BU-18

426-CJ63BR-18

426-CJ63BR-18

426-CJ63BR-18

114-CJ21RD-18

114-CJ21RD-18114-CJ21RD-18

114-CJ21RD-18

J815-CJ45BK-14

J815-CJ45BK-14

J815-CJ45BK-14

J815-CJ45BK-14

CBL-WW

RD-00

CBL-CC

RD-00

CBL-JJ

BK-00

304-CJ96WH-8

102-CJ48RD-14

102-CJ48RD-14

102-CJ48RD-14

102-CJ48RD-14

102-CJ48RD-14

174-CJ4RD-10

174-CJ4RD-10

174-CJ4RD-10

174-CJ4RD-10

174-CJ4RD-10

308-CJ52YL-18308-CJ52YL-18

308-CJ52YL-18

308-CJ52YL-18

200-CJ88BK-18

200-CJ88BK-18

200-CJ88BK-18

306-CJ51GN-18

306-CJ51GN-18

306-CJ51GN-18

306-CJ51GN-18

P990-CJ75BR-18

P990-CJ75BR-18

112-CJ1PU-4

112-CJ1PU-4

112-CJ1PU-4

112-CJ1PU-4

112-CJ1PU-4

200-CJ89BK-14

200-CJ89BK-14

200-EA13BK-18200-EA14BK-18

H718-AG13GY-18

H718-AG13GY-18

H718-AG13GY-18

200-CJ92BK-14

200-CJ92BK-14

200-CJ91BK-14

H718-CJ19GY-18

H718-CJ19GY-18

H718-CJ19GY-18

H718-CJ19GY-18

202-CJ64BK-18

202-CJ64BK-18

202-CJ6BK-18

202-CJ6BK-18

419-CJ7YL-18

419-CJ7YL-18

419-CJ7YL-18

432-CJ8PK-18

432-CJ8PK-18

432-CJ8PK-18442-CJ9GY-18

442-CJ9GY-18

442-CJ9GY-18

442-CJ9GY-18

442-CJ9GY-18

E455-CJ14BR-18

E455-CJ14BR-18

E455-CJ14BR-18

E455-CJ14BR-18G764-CJ15PK-18

G764-CJ15PK-18

G764-CJ15PK-18

398-CJ103BU-14

398-CJ103BU-14

397-CJ104OR-14

397-CJ104OR-14

110-CH26RD-14

521-CH4YL-14

521-CH4YL-14

521-CH4YL-14

521-CH4YL-14

522-CH5WH-14

522-CH5WH-14

522-CH5WH-14

522-CH5WH-14

326-CH1PU-16

326-CH1PU-16

326-CH1PU-16

326-CH1PU-16

T860-J8OR-16-NW

T860-J8OR-16-NW

T962-J16WH-16-NW

T962-J16WH-16-NW

T859-J9WH-16-NW

T859-J9WH-16-NW

T860-J5OR-16-NW

T960-J17BU-16-NW

T960-J17BU-16-NW

T958-J14YL-16-NW

T958-J14YL-16-NW

T859-J3WH-16-NW

T859-J4WH-16-NW

T858-J1GY-16-NWT957-J13PU-16-NW

T957-J13PU-16-NW

T961-J15GN-16-NW

T961-J15GN-16-NW

T959-J18BR-16-NW

T959-J18BR-16-NW

T858-J7GY-16-NW

T858-J7GY-16-NW

ENGINE INJECTOR HARNESS

H746-CH37YL-18

H746-CH37YL-18

H747-CH35BR-18

H747-CH35BR-18

H747-CH35BR-18H746-CH37YL-18

J808-AT25BK-18

J808-AT25BK-18

J809-AT21BK-18

J809-AT21BK-18

J807-AT22BK-18

J807-AT22BK-18

202-CJ64BK-18202-CJ65BK-18

202-CJ65BK-18

202-CJ65BK-18

202-CJ30BK-18

202-CJ30BK-18202-CJ30BK-18

417-CJ43GY-18

417-CJ43GY-18

417-CJ43GY-18

484-CJ16YL-18

484-CJ16YL-18

484-CJ16YL-18

416-CJ17OR-18

416-CJ17OR-18

416-CJ17OR-18453-CJ18PK-18

453-CJ18PK-18

453-CJ18PK-18

200-AG39BK-16

200-AG39BK-16

G485-CP1BU-18201-CP2BK-18

TWISTED WIRES

F762-CH20GY-18

F762-CH20GY-18

605-CJ67YL-16

605-CJ67YL-16

200-CJ112BK-16

200-CJ113BK-16

606-CJ68GY-16

606-CJ68GY-16

200-CJ112BK-16

200-CJ109BK-16

200-CJ109BK-16

200-CJ54BK-16

321-CJ55BR-18

P990-CJ74BR-18

605-CJ67YL-16606-CJ68GY-16

P990-CJ74BR-18

200-CJ113BK-16

200-CJ54BK-16

321-CJ55BR-18

604-CJ56OR-16

604-CJ56OR-16

604-CJ56OR-16

617-CJ73BR-16

617-CJ73BR-16

604-CJ115OR-16

604-CJ115OR-16

604-CJ115OR-16

604-CJ114OR-16

604-CJ114OR-16

604-CJ114OR-16

200-CJ110BK-16

200-CJ110BK-16

X919-CH19WH-18

X919-CH19WH-18

X918-CH18PU-18

X918-CH18PU-18

136-CV12GN-18

200-CV7BK-18

200-CV7BK-18

727-CV1G

N-18

727-CV10GN-18

727-CV9GN-18

727-CV10GN-18

200-CV6BK-18

728-CV5BU-18

728-CV5BU-18

CBL-NN1RD-00

CBL-NN1RD-00

CBL-PP1BK-00

CBL-CCRD-00

136-CJ53GN-18

136-CJ53GN-18

136-CJ53GN-18

202-CJ76BK-18

202-CJ76BK-18

202-CJ76BK-18728-CJ39BU-18

728-CJ39BU-18

728-CJ39BU-18

SECONDARY STEERING ATTACHMENT

CBL-RR

BK-00

FUEL PRIMING SYSTEM

175-CJ95RD-14

T858-J2GY-16-NW

727-CV2GN-18

727-CV2GN-18

727-CJ40GN-18

727-CJ40GN-18

727-CJ40GN-18

727-CJ40GN-18

430-CH13BU-18

430-CH13BU-18

430-CH13BU-18

G850-CH14BU-18

G850-CH14BU-18

G850-CH14BU-18

C216-AG30BK-18

C216-AG30BK-18

J844-CH39GY-18

J844-CH39GY-18

F713-CH43OR-18

F713-CH43OR-18

F713-CH43OR-18

J844-CH39GY-18

A893-CH14OR-16

A893-CH14OR-16

CONNECTS TO C-C2ON THE CAB SCHEMATIC

CONNECTS TO C-C1 ON THE CAB SCHEMATIC


617-CJ73BR-16

605-CJ67YL-16

605-CJ67YL-16

617-CJ73BR-16

606-CJ68GY-16

606-CJ68GY-16

PUMP GP (177-2921)

200-CV6BK-18

426-CJ63BR-18

200-CJ54BK-16200-CJ109BK-16200-CJ110BK-16

200-CJ113BK-16200-CJ112BK-16

200-CJ112BK-16

200-CJ109BK-16200-CJ110BK-16

397-CJ104OR-14

398-CJ103BU-14200-CJ89BK-14

200-CJ89BK-14397-CJ104OR-14398-CJ103BU-14

304-CJ96WH-8306-CJ51GN-18

102-CJ48RD-14

200-CJ88BK-18174-CJ4RD-10

308-CJ52YL-18

112-CJ1PU-4

P990-CJ75BR-18

P990-CJ75BR-18

200-AG48BK-18

P976-AG47BR-18

P976-AG47BR-18

P976-CJ10BR-18

P976-CJ10BR-18

P976-CJ10BR-18

TWISTED WIRES

728-CJ39BU-18

N939-CJ47GN-18

976-CJ27OR-18

G764-CJ15PK-18

306-CJ51GN-18

484-CJ16YL-18

417-CJ43GY-18416-CJ17OR-18

321-CJ55BR-18 453-CJ18PK-18

J764-AT1BR-18

J764-AT1BR-18

E906-AT6OR-18

E906-AT6OR-18

755-AT12OR-18

751-AT3GN-18

E901-AT9GN-18

E901-AT9GN-18

752-AT4YL-18

E900-AT5WH-18

E900-AT5WH-18

E909-AT11WH-18

E909-AT11WH-18

901-AT14WH-18

901-AT14WH-18

J808-AT15BK-18J808-AT15BK-18

E908-AT7BR-18

E908-AT7BR-18754-AT8BU-18754-AT8BU-18

900-AT13PU-18E907-AT10GY-18

E907-AT10GY-18

K977-AT16PK-18

K977-AT16PK-18

419-CJ7YL-18

101-AF2RD-12101-AF3RD-14

101-AF4RD-14

IDENT PART NUMBER CHG LOC NOTE A 219-7461 01 C-12 ELECTRONIC CONTROL J 230-0960 01 E-13 ENGINE INJECTOR HARNESS M 241-0758 02 C-12 JUMPER HARNESS AG 273-0275 01 H,I-4 FRONT HARNESS AH 248-5519 02 J-11 WASTE AR (POWER ACTUATED BOTTOM GUARD) AL 271-4039 02 H-2 NACD ROADING - RH (ATCH) AM 272-9822 00 G-1 TILT POSITION SENSOR AT 247-4863 01 G,H-5 TRANSMISSION

AY 271-4038 02 J-2 NACD ROADING - LH (ATCH) CE 272-8376 00 H,I-13 SIGNAL ON HOOD - LH (ATCH) CF 272-8377 00 C-14 SIGNAL ON HOOD - RH (ATCH) CH 245-3514 03 C,D-11 ENGINE HARNESS CJ 245-3257 04 C,D-6 CHASSIS HARNESS CP 246-2349 01 J-3 FRONT AXLE TEMP MONITORING CV 258-7107 01 I-7 SECONDARY STEERING CY 246-2348 02 B-8 REAR AXLE TEMP MONITORING EA 247-3773 02 D-6 WASHER PUMP/PARK BRAKE/FILTER BYPASS EU 272-8345 00 J-2 QUICK COUPLER (ATCH FA 271-4017 02 I-3 RH FRONT RUNNING HEADLIGHTS FC 271-4017 02 I-3 LH FRONT RUNNING HEADLIGHTS FL 271-4029 02 I-2 LH FRONT SIGNALS (ATCH) FR 271-4030 02 I-2 RH FRONT SIGNALS (ATCH)

CABLE ASSEMBLIES CC 246-1698 01 I-9,10 JUNCTION BLOCK TO STARTER EE 116-0080 01 J-10 BATTERY+ TO BATTERY- GG 246-1697 01 J-10 BATTERY- TO DISCONNECT SWITCH HH 246-1699 01 J-9 DISCONNECT SWITCH TO FRAME GROUND JJ 246-1715 02 I,J-9 STARTER TO FRAME GROUND KC 246-1774 01 B-12 ALTERNATOR TO ENGINE GROUND KK 280-7314 00 J-10 AUX START (ATTACHMENT) NN 183-6971 00 H-7 SECONDARY STEERING RELAY TO MOTOR (ATCH) PP 198-6755 00 H-8 SECONDARY STEERING TO FRAME GROUND RR 4E-2604 00 I-9 STARTER TO ENGINE GROUND UU 246-1553 01 B-G-12 ALTERNATOR TO ALTERNATOR BREAKER VV 280-7314 00 I-10 JUNCTION BLOCK TO SECONDARY STEERING RELAY WW 246-1696 01 J-10 BATTERY TO JUNCTION BLOCK

WIRE ASSEMBLIES

AF 246-4489 01 I-12 CIRCUIT BREAKERS

FOR CAB SCHEMATIC SEE:ELECTRO-HYDRAULIC IMPLEMENTS/CCS STEERING OR HMU STEERING 237-5752

200-CJ91BK-14

200-CJ92BK-14

321-CJ55BR-18

617-CJ73BR-16

321-CJ55BR-18

605-CJ67YL-16606-CJ68GY-16

P990-CJ74BR-18

604-CJ56OR-16

617-CJ73BR-16

398-CJ103BU-14

397-CJ104OR-14

321-CJ55BR-18

605-CJ67YL-16

606-CJ68GY-16

P990-CJ74BR-18

604-CJ56OR-16

617-CJ73BR-16

200-CJ109BK-16200-CJ110BK-16

200-CJ54BK-16

200-CJ112BK-16200-CJ113BK-16

200-CJ113BK-16

200-CJ109BK-16200-CJ110BK-16

200-CJ54BK-16

200-CJ112BK-16

604-CJ56OR-16

752-AT4YL-18751-AT3GN-18

755-AT12OR-18


751-AT3GN-18

752-AT4YL-18

754-AT8BU-18

755-AT12OR-18

901-AT14WH-18

900-AT13PU-18

900-AT13PU-18

TWISTED WIRES

321-CJ55BR-18

P990-CJ74BR-18

G486-CJ23GN-18

G486-CJ23GN-18

G486-CJ23GN-18

G486-CJ23GN-18

G486-CJ23GN-18

450-CH17YL-18

450-CH17YL-18

450-CH17YL-18

200-CH22BK-16

200-CH22BK-16

200-CH22BK-16

201-AG5BK-18

201-AG5BK-18

201-CJ41BK-18

201-CJ41BK-18

201-CJ26BK-18

201-CJ26BK-18

201-CJ26BK-18201-CJ26BK-18

201-AG5BK-18

201-CJ78BK-18

201-CJ78BK-18

201-CJ78BK-18

E748-CJ81BK-18

E748-CJ81BK-18

201-CJ82BK-18

201-CJ82BK-18

H795-CH49PK-18

201-CJ83BK-18

201-CJ83BK-18

201-CJ83BK-18

201-CJ83BK-18

201-CJ83BK-18

614-CJ86PU-16

614-CJ86PU-16

614-CJ86PU-16

614-CJ86PU-16

614-CJ86PU-16

614-CJ86PU-16

614-CJ86PU-16

403-CH58GN-18

403-CH58GN-18

403-CH58GN-18

G829-A43GN-18G828-A38WH-18

G828-A38WH-18

C216-AG10BK-18

321-CJ55BR-18

P990-CJ74BR-18

CBL-JJBK-00

611-AG50PU-14611-AG50PU-14

611-AG56PU-14

611-AG56PU-14611-AG55PU-14

611-AG55PU-14

614-AG53PU-16

614-AG53PU-16

614-AG53PU-16617-AG54BR-16

617-AG54BR-16

617-AG54BR-16

P976-CJ10BR-18

200-EU1BK-18P976-EU4BR-18

201-CJ120BK-18

201-CJ120BK-18

201-CJ120BK-18

201-CJ120BK-18

200-EU5BK-18

200-EU6BK-18

P976-EU3BR-18

P976-EU2BR-18

138-AG2GN-18200-AG9BK-18C529-AG12GY-18

H717-AG21BR-18

E919-AG23YL-18

E920-AG24BR-18

E921-AG26PK-18

E922-AG27GN-18

N939-AG4GN-18

976-AG29OR-18

306-CJ42GN-18

306-CJ71GN-18

P990-CJ36BR-18P990-CJ36BR-18

P990-CJ36BR-18

P990-CJ36BR-18

X919-CH19WH-18X918-CH18PU-18

F762-CH20GY-18

200-CH22BK-16

110-CH26RD-14

200-CJ87BK-16

CBL-KC1B

K-2

CBL-UURD-2

X919-CJ118WH-18

X919-CJ118WH-18

X919-CJ118WH-18

X919-CJ118WH-18

X919-CJ118WH-18

X918-CJ116PU-18

X918-CJ116PU-18

X918-CJ116PU-18

X918-CJ116PU-18

X918-CJ116PU-18

H795-CJ117PK-18

H795-CJ117PK-18

H795-CJ117PK-18

199-CJ127RD-16 199-CJ127RD-16

199-CJ127RD-16

199-CJ127RD-16

199-CJ127RD-16

199-CJ127RD-16

199-CJ127RD-16

A301-CJ126WH-16

A301-CJ126WH-16

A301-CJ126WH-16

A300-CJ128GN-16

A300-CJ128GN-16

A300-CJ128GN-16

A300-CJ128GN-16

A300-CJ128GN-16

A301-CJ126WH-16

A301-CJ126WH-16

X919-CJ118WH-18X918-CJ116PU-18

H795-CJ117PK-18

200-CJ87BK-16

403-CH58GN-18

304-CJ96WH-8

201-CJ11BK-18

201-CJ11BK-18

201-CJ11BK-18

201-CJ11BK-18

326-CJ44RD-16

326-CJ44RD-16

326-CJ44RD-16

326-CJ44RD-16

403-CJ50GN-18

403-CJ50GN-18

403-CJ50GN-18

403-CJ50GN-18

430-CJ59BU-18

430-CJ59BU-18

430-CJ59BU-18

430-CJ59BU-18

430-CJ59BU-18

443-CJ90YL-18

443-CJ90YL-18

443-CJ90YL-18

443-CJ90YL-18

443-CJ90YL-18

450-CJ93YL-18

450-CJ93YL-18

450-CJ93YL-18

450-CJ93YL-18

450-CJ93YL-18

521-CJ94YL-18

521-CJ94YL-18

521-CJ94YL-18

521-CJ94YL-18

521-CJ94YL-18

522-CJ97WH-18

522-CJ97WH-18

522-CJ97WH-18

522-CJ97WH-18

522-CJ97WH-18

944-CJ98OR-18

944-CJ98OR-18

944-CJ98OR-18

944-CJ98OR-18

945-CJ100BR-18

945-CJ100BR-18

945-CJ100BR-18

945-CJ100BR-18

A307-CJ101GY-18

A307-CJ101GY-18

A307-CJ101GY-18

A307-CJ101GY-18

A307-CJ101GY-18

G479-CJ105WH-18

G479-CJ105WH-18

G479-CJ105WH-18

G479-CJ105WH-18

G479-CJ105WH-18

F762-CJ107GY-18

F762-CJ107GY-18

F762-CJ107GY-18

G850-CJ108BU-18

G850-CJ108BU-18

G850-CJ108BU-18

G850-CJ108BU-18

G850-CJ108BU-18

A982-CJ111BR-18

A982-CJ111BR-18

A982-CJ111BR-18

A982-CJ111BR-18

A982-CJ111BR-18

Y794-CJ129OR-18

Y794-CJ129OR-18

Y794-CJ129OR-18

Y794-CJ129OR-18

Y794-CJ129OR-18Y795-CJ130GN-18

Y795-CJ130GN-18

Y795-CJ130GN-18

Y795-CJ130GN-18

Y795-CJ130GN-18Y795-CH51GN-18

Y795-CH51GN-18

Y794-CH50OR-18

Y794-CH50OR-18

G479-CH3WH-18

G479-CH3WH-18

G479-CH3WH-18

J815-AG60BK-18

J815-AG63BK-18

J814-AG62BK-18

J814-AG61BK-18

P945-AG58OR-18

P945-AG58OR-18

P945-AG58OR-18

P946-AG59BR-18

P946-AG59BR-18

P946-AG59BR-18

Y795-CH29GN-18

Y795-CH29GN-18

Y794-CH28OR-18

Y794-CH28OR-18

Y795-CH53GN-18

Y795-CH53GN-18

Y794-CH52OR-18

Y794-CH52OR-18

201-CH23BK-18443-CH2YL-18

201-CH23BK-18

443-CH2YL-18

443-CH2YL-18

201-CH23BK-18

P945-CJ131OR-18

P945-CJ131OR-18

P945-CJ131OR-18

P945-CJ131OR-18

P946-CJ132BR-18

P946-CJ132BR-18

P946-CJ132BR-18

P946-CJ132BR-18

H795-CJ117PK-18

H795-CJ117PK-18

H795-CJ143PK-18

H795-CJ143PK-18

H795-CJ143PK-18

H795-CJ143PK-18

H795-CJ144PK-18

H795-CJ144PK-18

447-CJ145PK-18

447-CJ145PK-18

447-CJ145PK-18

447-CJ145PK-18

447-CJ145PK-18

447-CJ145PK-18

261-CH11BK-18

261-CH11BK-18

261-CH11BK-18

261-CH11BK-18

432-CH15PK-18

432-CH15PK-18

432-CH15PK-18

432-CH15PK-18

432-CJ8PK-18201-CJ82BK-18

201-CJ82BK-18

432-CJ8PK-18

229-CH32BK-14

229-CH31BK-14229-CH30BK-14

229-CJ155BK-14

229-CJ155BK-14

229-CJ155BK-14

101-CJ106RD-4

229-CH16BK-14

229-CH16BK-14

201-CJ79BK-18

201-CJ79BK-18

H714-AG19OR-18

H713-AG18PK-18

J814-AG61BK-18

G486-CY1GN-18201-CY2BK-18

403-CJ50GN-18

945-CJ100BR-18944-CJ98OR-18

J807-AT17BK-18

J807-AT17BK-18

J809-AT21BK-18

P990-CJ75BR-18

J814-AG28BK-14

C216-AG22BK-18

C216-AG22BK-18

C216-CJ24BK-18

C216-CJ24BK-18

C216-CJ24BK-18

C216-CJ24BK-18

K927-AG57BU-18

K927-AG57BU-18

J814-AG28BK-14J813-AG31BK-14

J813-AG31BK-14

K927-CJ62BU-18

K927-CJ62BU-18

K927-CJ62BU-18

K927-CJ62BU-18

J814-CJ77BK-14

J814-CJ77BK-14

J814-CJ77BK-14

J814-CJ77BK-14

J813-CJ80BK-14

J813-CJ80BK-14

J813-CJ80BK-14

J813-CJ80BK-14

P990-CJ74BR-18

200-AG9BK-18

201-CJ79BK-18

110-CJ99RD-14

110-CJ99RD-14

110-CJ99RD-14

110-CJ99RD-14

110-CJ99RD-14

150-CJ85OR-18

150-CJ85OR-18

150-CJ85OR-18

150-CJ85OR-18

150-CJ85OR-18

F762-CJ107GY-18

F762-CJ107GY-18

E748-CJ81BK-18

E748-CH21BK-18 E748-CJ81BK-18

T961-A28GN-18-XLPE

T957-A16PU-18-XLPE

T958-A17YL-18-XLPE

T959-A18BR-18-XLPET960-A19BU-18-XLPE

T962-A29WH-18-XLPE

T860-A34OR-18-XLPE

P990-CJ102BR-18

P990-CJ102BR-18

202-EA1BK-18419-EA2YL-18G764-EA3PK-18E455-EA4BR-18201-EA5BK-18

426-EA7BR-18 201-EA11BK-18201-EA12BK-18506-EA8PU-18

200-EA9BK-16507-EA10WH-18

506-CJ12PU-18

506-CJ12PU-18

506-CJ12PU-18

506-CJ12PU-18

507-CJ13WH-18

507-CJ13WH-18

507-CJ13WH-18

507-CJ13WH-18

200-CJ5BK-16

200-CJ5BK-16

200-CJ5BK-16

200-CJ54BK-16

200-CJ113BK-16

229-CJ155BK-14

200-CJ87BK-16

995-A12BU-18

T957-A16PU-18-XLPE

T959-A18BR-18-XLPE

R747-A6GY-18

E964-A26WH-18

E963-A27BK-18

T961-A28GN-18-XLPE

E966-A49YL-18

G857-A30YL-18

G856-A22WH-18

R746-A20PK-18

G829-A2GN-18

G828-A1WH-18

994-A10GY-18

C967-A15BU-18

T957-A16PU-18T958-A17YL-18

T960-A19BU-18

T962-A29WH-18

E965-A48BU-18

G829-A43GN-18

G829-A41GN-18

G828-A39WH-18

T860-J6OR-16

TWISTED WIRES

TWISTED WIRES

200-CJ91BK-14

F762-CJ107GY-18

E748-CJ81BK-18

E748-CJ81BK-18

TWISTED WIRES

TWISTED WIRES

443-CH2YL-18

201-CH23BK-18

TWISTED WIRES

TWISTED WIRES

TWISTED WIRES

101-CJ106RD-4101-CJ106RD-4

CBL-VVRD-00

CBL-VVRD-00

H795-CH49PK-18

513-CH44OR-14

513-CH45OR-14

513-CH47OR-14522-CH48WH-14

522-CH46WH-14

A/C PRESSURE SWITCH IS NORMALLY OPENBEFORE REFRIGERANT CHARGE

614-CJ121PU-16

614-CJ121PU-16

614-CJ121PU-16

614-CJ121PU-16

614-CJ121PU-16

614-CJ121PU-16

614-CJ121PU-16

F421-A13YL-18G833-A46PK-18T725-A32WH-18N707-A31PU-18

C991-A33PK-18

T859-A37WH-18-XLPE

T859-A37WH-18-XLPE

T858-A23GY-18-XLPE

T858-A23GY-18-XLPE

N707-A31PU-18

N707-A31PU-18

T725-A32WH-18

T725-A32WH-18

F421-A13YL-18

F421-A13YL-18

C991-A33PK-18

C991-A33PK-18

G833-A47PK-18

G833-A47PK-18

G833-A46PK-18

101-AF1RD-14

838-AH7YL-16839-AH6BU-18

838-AH5YL-16838-AH4YL-16

839-AH3BU-18

839-AH2BU-18141-AH1RD-14

200-AH8BK-16

200-AH8BK-16

141-AH1RD-14

200-AH8BK-16200-AH8BK-16

H703-CJ148YL-18H703-CJ148YL-18

H703-CJ148YL-18

H703-CJ148YL-18

H703-CJ148YL-18

H702-CJ149PU-18

H702-CJ149PU-18

H702-CJ149PU-18

H702-CJ149PU-18

H702-CJ149PU-18

H703-CH54YL-18

H703-CH54YL-18

H703-CH54YL-18

H702-CH55PU-18

H702-CH55PU-18

H702-CH55PU-18

E748-CH21BK-18E748-CH57BK-18

E748-CH57BK-18

H704-CH41PK-18

H704-CH41PK-18

H704-CH41PK-18

E748-CH56BK-18

E748-CH56BK-18

J843-CH38BK-18

J843-CH38BK-18

202-EA1BK-18419-EA2YL-18

G764-EA3PK-18E455-EA4BR-18

201-EA5BK-18

426-EA7BR-18506-EA8PU-18

200-EA9BK-16

507-EA10WH-18

G764-EA3PK-18419-EA2YL-18202-EA1BK-18

E455-EA4BR-18201-EA11BK-18

426-EA7BR-18201-EA12BK-18

506-EA8PU-18200-EA13BK-18

507-EA10WH-18200-EA14BK-18

101-AF2RD-12

101-AF1RD-14

101-AF4RD-14

101-AF3RD-14

101-CJ106RD-4

CBL-UURD-2

261-CH11BK-18

432-CH15PK-18

E748-CH56BK-18

H747-CH35BR-18

H746-CH37YL-18H704-CH41PK-18

201-CH23BK-18

Y794-CH52OR-18

Y795-CH53GN-18

J844-CH39GY-18

F713-CH43OR-18

200-CH22BK-16

326-CH1PU-16

403-CH58GN-18

521-CH4YL-14

522-CH5WH-14

200-CH22BK-16

261-CH11BK-18

326-CH1PU-16403-CH58GN-18432-CH15PK-18

521-CH4YL-14

522-CH5WH-14

443-CH2YL-18

110-CH26RD-14

Y795-CH51GN-18

Y794-CH50OR-18

E748-CH21BK-18

229-CH16BK-14

150-CH6OR-18

430-CH13BU-18

450-CH17YL-18

944-CH7OR-18945-CH8BR-18

A307-CH9GY-18A982-CH10BR-18

F762-CH20GY-18G479-CH3WH-18

G850-CH14BU-18

H795-CH49PK-18

X918-CH18PU-18

X919-CH19WH-18

H703-CH54YL-18H702-CH55PU-18

443-CH2YL-18

201-CH23BK-18

147-CJ125RD-16

147-CJ125RD-16

147-CJ125RD-16

147-CJ125RD-16

136-CJ141GN-16

136-CJ141GN-16136-CJ122GN-16

136-CJ122GN-16

136-CJ122GN-16200-CJ123BK-16

200-CJ123BK-16

439-CJ124YL-18

439-CJ124YL-18

439-CJ124YL-18

439-CJ124YL-18

200-CJ123BK-16

326-CJ44RD-16

308-CJ52YL-18

110-CJ157RD-14110-CJ157RD-14

110-CJ157RD-14

110-CJ157RD-14

110-CJ157RD-14229-CJ156BK-14 229-CJ156BK-14

229-CJ156BK-14

229-CJ156BK-14

A958-CJ158WH-18

A958-CJ158WH-18

A958-CJ158WH-18

A958-CJ158WH-18

J813-AG25BK-18J813-AG41BK-18

J813-AG51BK-18J813-AG42BK-18

J814-AG49BK-18

J814-AG62BK-18

J814-AG36BK-18

P976-AG47BR-18200-AG48BK-18

G485-AG6BU-18

A958-AG66WH-18

A958-AG66WH-18

A958-AG66WH-18J815-AG67BK-18

J815-AG67BK-18

200-FA2BK-14619-FA1GN-14

200-FC2BK-14619-FC1GN-14

606-AG68GY-16606-AG68GY-16

606-AG69GY-16

606-AG69GY-16

200-AG70BK-18

200-AG70BK-18200-CJ159BK-18

200-CJ159BK-18

200-CJ159BK-18

200-AY2BK-14605-AY3YL-16

606-AL3GY-16

619-AY1GN-14

619-AL1GN-14

200-AL2BK-14606-AL3GY-16

200-AL2BK-14

619-AL1GN-14

605-AY3YL-16

619-AY1GN-14

200-AY2BK-14

RH HI/LO POS TURN TOWER

611-AY4PU-14 611-AY4PU-14617-AY5BR-16

617-AY5BR-16

611-AL4PU-14611-AL4PU-14

614-AL5PU-16 614-AL5PU-16

619-FL1GN-14200-FL2BK-14605-FL3YL-16200-FL4BK-16

619-FR1GN-14200-FR2BK-14606-FR3GY-16200-FR4BK-16

RH FLOOD/TURN SIG TOWER

LH HI/LO POS TURN TOWER

LH FLOOD/TURN SIG TOWER

WHEN USED PLUGINTO AG-C4




200-CJ54BK-16

200-CJ109BK-16200-CJ110BK-16200-CJ112BK-16200-CJ113BK-16

200-CJ160BK-14

200-CJ160BK-14

200-CJ160BK-14200-CJ160BK-14200-CJ161BK-14

200-CJ161BK-14

200-CJ161BK-14

200-CJ161BK-14

200-CJ87BK-16

200-CJ88BK-18200-CJ89BK-14

200-CJ162BK-14

200-CJ162BK-14

200-CJ162BK-14

200-CJ162BK-14

200-CJ163BK-14

200-CJ163BK-14

200-CJ163BK-14

200-CJ163BK-14

P990-CJ36BR-18

403-CH58GN-18

521-CH4YL-14

CBL-UURD-2

CBL-VVRD-00

CBL-VVRD-00

304-CJ96WH-8

3RD FUNCTION DIVERTER SOL200-AG52BK-16

200-AG52BK-16

987-AG71WH-16987-AG71WH-16

987-AG71WH-16987-CJ49WH-16

987-CJ49WH-16

987-CJ49WH-16

987-CJ49WH-16

AUXILLARY START RECEPTACLECABLES KK1 AND KK2 ARE NOTSERVICED SEPERATELY

JUMPSTART RECEPTACLE

106-AM1WH-18C216-AM2BK-18H718-AM3GY-18

106-AM1WH-18C216-AM2BK-18H718-AM3GY-18

604-CE1OR-16200-CE2BK-16617-CE3BR-16

200-CE5BK-16605-CE4YL-16

200-CF2BK-16

200-CF5BK-16606-CF4GY-16

604-CF1OR-16

614-CF3PU-16

CONNECT TO CJ-C33

CONNECT TO CJ-C32

CONNECT TO CJ-C8

CONNECT TO CJ-C26

RH ON HOOD LAMP

LH ON HOOD LAMP

J843-CH38BK-18

J843-CH38BK-18

E748-CH59BK-18

E748-CH59BK-18

E748-CH59BK-18

X337-CH24WH-18

X337-CH24WH-18

X337-CH24WH-18

X337-CH24WH-18

G790-CH25PK-18

G790-CH25PK-18

G790-CH25PK-18

G790-CH25PK-18

G791-CH12BR-18

G791-CH12BR-18

G791-CH12BR-18

G791-CH12BR-18G828-M1WH-18

G828-M1WH-18

G829-M2GN-18

G829-M2GN-18

C991-M3PK-18

C991-M3PK-18

T725-M6WH-18

T725-M6WH-18

N707-M7PU-18

N707-M7PU-18

F421-M4YL-18

F421-M4YL-18

G833-M5PK-18

G833-M5PK-18

129-M9RD-18

129-M9RD-18

200-M10BK-18

200-M10BK-18

A893-M11OR-18

K738-A5GN-16-HV

K738-A5GN-16-HV

K738-A5GN-16-HV

K738-A5GN-16-HV

K739-A7BU-16-HV

K739-A7BU-16-HV

K739-A7BU-16-HV

K739-A7BU-16-HV

K737-A4BR-16-HV

K737-A4BR-16-HV

K737-A4BR-16-HV

K737-A4BR-16-HV

G829-A3GN-18

T860-A34OR-18-XLPE

T858-A23GY-18-XLPE

T858-A23GY-18-XLPE

T859-A37WH-18-XLPE

T859-A37WH-18-XLPE

G828-A40WH-18

G828-A40WH-18

G829-A42GN-18

G829-A42GN-18

G829-A36GN-18

G829-A36GN-18

TWISTED WIRES

TWISTED WIRES

136-CV11GN-18

136-CV3GN-18136-CV11GN-18

136-CV12GN-18

CONN 1

CONN 2

CONN 3

CONN 4

CONN 7

CONN 6

CONN 5

CONN 8

CONN 9

CONN 10

CONN 11

CONN 12

CONN 13

CONN 14

CONN 15

CONN 16

CONN 17

CONN 18

CONN 19

CONN 20

CONN 21

CONN 22

CONN 21

CONN 21

CONN 22

CONN 22

CONN 23

AW 281-8742 00 B-5 GROENEVELD AUTOLUBE

277-8271 01 C-5 GROENEVELD AUTOLUBE277-8272 01 B-5 GROENEVELD AUTOLUBEAX

AY

BELLY GUARD

966H and 972H

Electrical SystemWheel Loader



Volume 2 of 2: Cab

© 2008 Caterpillar, All Rights Reserved Printed in U.S.A.

RENR6332-02March 2008

1

2 200-L32 BK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795

9X-1123ComponentPart Number

Single WireConnector

SocketPin

AG-C3130-6795

Pin or Socket Number

Wire, Cable, or Harness Assembly Identification:Includes Harness Identification Letters and Harness

Connector Serialization Codes Harness Connector Serialization Code: The "C" standsfor "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)Part Number For Connector Recepticle

Part Number forConnector Plug

Harness Identification Letter(s):(A, B, C, ..., AA, AB, AC, ...)

Plug

GroundConnection

325-AG135 PK-14

Circuit IdentificationNumber Wire Color Wire Gauge

Harness identification code: This example indicates wire 135 in harness "AG".

Receptacle

PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit BreakerSymbol

Harness and Wire Symbols

1 12 2

Sure-Seal connector: Typical representationof a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

Deutsch connector: Typical representationof a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

Symbols

Symbols and Definitions

Harness And Wire Electrical Schematic Symbols

Fuse(5 Amps)

5A

Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. Thegrounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.T

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

RE

NR

6332-0

2 V

OL

2 o

f 2

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

V

W

X

Y

Z

AA

BB

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

P

Q

R

S

T

U

V

W

X

Y

Z

AA

BB

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

P

Q

R

S

T

U

31302927 282625242322212019181715 16141311 1210987654321

31302927 282625242322212019181715 16141311 1210987654321

Component Identifiers (CID¹)Module Identifier (MID²)

Caterpillar Monitoring System(MID No. 030)

CID Component0096 Fuel Level Sender0100 Engine Oil Pressure Sensor0110 Engine Coolant Temperature Sensor0177 Torque Converter Oil Temperature Sensor0248 Data Link0263 Sensor Power Supply0271 Action Alarm0324 Action Lamp0600 Hydraulic Oil Temperature Sensor0819 Display Data Link0821 Display Power Supply0826 T/C Oil Temperature Sensor0830 Brake Oil Temperature Sensor

Payload Control System(MID No. 074)

CID Component0248 CAT Data Link0364 Head End Lift Cylinder Pressure Sensor0591 PCS EEPROM0769 Rod End Lift Cylinder Pressure Sensor1964 Lift Position Sensor

Electronic Transmission Control System(MID No. 081)

CID Component0041 8 Volt DC Supply0168 Electrical System Voltage0177 Transmission Oil Temperature Sensor0190 Engine Speed Sensor0262 5 Volt DC Supply0268 Programmed Parameter Fault0367 Ride Control Switch0368 Transmission Auto/Manual Switch0444 Start Relay0562 Electronic Monitoring System0585 Transmission Output Speed Sensor 10590 Engine Control Module0596 Implement Control 0623 Directional Switch0627 Parking Brake Pressure Sw.0672 Transmission Input Speed Sensor0673 Transmission Output Speed Sensor 20702 Lever Switch (Transmission Shifting/Direction)0737 Left Brake Pedal Position Sensor0793 Primary Steering Pressure Switch0794 Secondary Steering Pressure Switch0795 Secondary Steering Relay0967 Machine Application1326 ECM Location Code1400 Rear Axle Oil Cooler Solenoid1401 Reverse Solenoid1402 Forward Solenoid1403 Fourth Speed Clutch1404 Third Speed Clutch1405 Second Speed Clutch1406 First Speed Clutch1521 Part-Throttle Autoshift Selector Switch1960 Ignition Key Reader2129 Ride Control Solenoid (1)2274 Transmission Direction Switch #22347 Ride Control Solenoid (2)2684 Ride Control Solenoid (3)

Electronic Implement Control(MID No. 082)

CID Component0041 8 Volt DC Supply0168 Electrical System Voltage0268 Programmed Parameter Fault0296 Transmission Control0350 Lift Linkage Position Sensor0351 Tilt Linkage Position Sensor0352 Lift Lever Position Sensor0353 Tilt Lever Position Sensor0354 Raise Solenoid0355 Lower Solenoid0356 Dump Solenoid0357 Rackback Solenoid0358 Pilot Pressure Solenoid0364 Lify Cylinder Head End Oil Pressure Sensor0365 Kickout Set Switch0487 3rd Lever Position Sensor0490 Implement Lockout Switch0491 3rd Function Forward Solenoid0492 3rd Function Rearward Solenoid0562 Caterpillar Monitoring System0590 Engine Electronic Control Module0965 Autodig Dig Mode Switch0967 Machine Application1187 Continuous Flow Rocker Switch1324 Autodig Operation Mode Select Switch1325 Autodig Trigger Switch1326 ECM Location Code1592 Autodig Kickout Set Switch1639 Machine Security System ECM1718 Fine Modulation Switch2326 Lower Anti-Drift Solenoid Valve2328 Dump Anti-Drift Solenoid Valve

Product Link Radio(MID No. 122)

CID Component0168 Electrical System Voltage0254 Electronic Control Module0269 Sensor Power Supply1250 Remote Communication Module1251 Alternator "R" Terminal

Machine Security System(MID No. 124)

CID Component0168 Electrical System Voltage0248 Data Link0817 ECM Internal Backup Battery1391 Theft Deterent Output Driver #11392 Theft Deterent Output Driver #2

¹ The CID is a diagnostic code that indicates which circuit is faulty.² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.

Failure Mode Identifiers (FMI)¹FMI No. Failure Description

0 Data valid but above normal operational range.1 Data valid but below normal operational range.2 Data erratic, intermittent, or incorrect.3 Voltage above normal or shorted high.4 Voltage below normal or shorted low.5 Current below normal or open circuit.6 Current above normal or grounded circuit.7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.9 Abnormal update.10 Abnormal rate of change.11 Failure mode not identifiable.12 Bad device or component.13 Out of calibration.14 Parameter failures.15 Parameter failures.16 Parameter not available.17 Module not responding.18 Sensor supply fault.19 Condition not met.20 Parameter failures.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

Component LocationComponent Schematic

LocationMachineLocation Component Schematic


Alarm - Action E-12 H-12 , V-12 Switch - Auto/Manual Gear Select D-3 L-14 , Y-14Alarm - Implement Audible Alert D-12 H-12 , V-12 Switch - Autodig Kickout Set C-1 L-14 , Y-14Alarm - Quick Coupler D-1 L-14 , Y-14 Switch - Autodig Mode D-2 L-14 , Y-14Arc Suppressor - Forward Horn G-6 H-13 , X-13 Switch - Autodig Mode Select C-1 L-14 , Y-14Control - Caterpillar Monitoring System D-5 / E-5 L-15 , Y-15 Switch - Autodig Trigger F-5 H-13 , X-13Control - Dimmer D-12 H-12 , V-12 Switch - Beacon F-3 I-16 , W-16Control - Implement Control System C,D,E-10 H-12 , U-12 Switch - Blower Fan Speed D-5 L-15 , Y-15Control - Payload Control System C,E,-5 K-15 , Y-15 Switch - Bucket/Fork Select D-2 L-14 , Y-14Control - Product Link (Gateway) G,H-8 G-12 , W-12 Switch - Cat Mon Sys Mode Select C-5 L-15 , Y-15Control - Transmission Control System G,H,I-14 H-12 , W-12 Switch - Dimmer G-1 G-16 , X-16Converter - Voltage (10A) F-12,13 H-12 , W-12 Switch - Downshift D-5 H-13 , X-13Diode - Blower Motor I-12 H-12 , W-12 Switch - Fine Modulation E-6 H-13 , X-13Display - Groeneveld Autolube E-5 L-15 , Y-15 Switch - Forward Horn G-2 I-15 , W-15Flasher - 24V D-12 H-12 , V-12 Switch - Forward Horn 2 F-7 H-13 , X-13Fuse - Block B-12 H-12 , V-12 Switch - Front Intermittent Wiper/Washer D-4 L-15 , Y-15Fuse - Thermal Cut Out I-12 H-12 , W-12 Switch - Hazard Lamp F-3 I-16 , W-16Guage - Quad H-1 I-16 , W-16 Switch - Heated Mirror D-2 L-14 , Y-14Indicator - Center Dash I-1 I-16 , W-16 Switch - HID Lamp H-3 I-16 , W-16Indicator - Left Hand Panel I-1 I-16 , W-16 Switch - HVAC Select D-5 L-15 , Y-15Indicator - Right Hand Panel H-1 I-16 , W-16 Switch - HVAC Temperature Select D-4 L-15 , Y-15Joystick - Implement Control G-6 H-13 , X-13 Switch - Implement Lockout F-6 H-13 , X-13Keypad - WLPCS C-5 K-15 , Y-15 Switch - Key Start F-3 I-16 , W-16Motor - Blend Door Actuator I-12 H-12 , W-12 Switch - Lift Tilt Kickout Set E-1 L-14 , Y-14Motor - Blower I-12 H-12 , W-12 Switch - Neutral Override C-2 L-14 , Y-14Motor - Front Wiper G-1 H-17 , W-17 Switch - Quick Coupler D-1 L-14 , Y-14Motor - Rear Wiper H-11 I-12 , V-12 Switch - Rear Wiper/Washer D-3 L-14 , Y-14Radio - Product Link H-8 G-12 , W-12 Switch - Remote FNR F-5 H-13 , X-13Relay - Axle Cooler C-12 H-12 , V-12 Switch - Reversing Fan D-1 L-14 , Y-14Relay - Forward Cab Floodlamp C-12 H-12 , V-12 Switch - Ride Control C-2 L-14 , Y-14Relay - Forward Horn C-12 H-12 , V-12 Switch - Running Lamp I-2 I-16 , W-16Relay - Heated Mirrors Timer D-12 H-12 , V-12 Switch - Secondary Steering Test D-2 L-14 , Y-14Relay - Rear Floodlamp C-12 H-12 , V-12 Switch - Stop Lamp F-1 G-15 , W-15Resistor A/C (1) I-11 H-12 , W-12 Switch - Third Function Control Flow H-3 I-16 , W-16Resistor A/C (2) I-11 H-12 , W-12 Switch - Third Function Diverter F-6 H-13 , X-13Resistor - Blower Motor I-12 H-12 , W-12 Switch - Transmission Gear Selector G-2 I-15 , W-15Resistor - CAN A I-4 I-16 , W-16 Switch - Transmission Shifter Assembly G-2 I-15 , W-15Sensor - 3rd Lever Position D-5 H-13 , X-13 Switch - Turn Signal G-2 I-15 , W-15Sensor - Left Hand Brake Pedal F-1 G-15 , W-15 Switch - Variable Shift Control D-3 L-14 , Y-14Sensor - Lift Lever Position F-5 H-13 , X-13 Tach/Speedometer H-1 I-16 , W-16Sensor - Throttlle Position F-1 G-15 , V-15 Thermostat I-12 H-12 , W-12Sensor - Tilt Lever Position F-5 H-13 , X-13

Connector LocationConnector Number Schematic


CONN 14 D,E-14 D-10 , U-10CONN 15 D-14 I-12 , V-12CONN 16 D-14 I-12 , V-12CONN 17 B-14 I-12 , V-12CONN 24 E-12 H-12 , V-12CONN 25 Service Mode Plug E-12 H-12 , V-12CONN 26 I-11 H-12 , W-12CONN 27 G-10 H-12 , V-12CONN 28 F,G-7 H-13 , X-13CONN 29 F,G-7 H-13 , X-13CONN 30 E-7 H-12 , V-12CONN 31 D-6 L-15 , Y-15CONN 32 I-6 L-11 , Y-11CONN 33 I-5 L-16 , Y-16CONN 34 I-6 L-11 , U-11CONN 35 I-5 L-16 , U-16CONN 36 PCS Customer Data Conn C-6 K-15 , Y-15CONN 37 G-3 I-16 , W-16CONN 38 G-3 I-16 , W-16CONN 39 G-2 I-15 , W-15CONN 40 E-3 I-16 , W-16CONN 41 Service Tool Conn E-2 I-16 , W-16CONN 42 F,G-1 G-16 , X-16CONN 43 F-1 G-15 , W-15

Off Machine Switch SpecificationPart No. Function Actuate Deactuate Contact Position

3E-5464 A/C Thermostat-1.1 ± 0.8°C 2.2 ± 0.8°C(30 ± 1.4°F) (36 ± 1.4°F)

Normally Closed

Related Electrical Service ManualsTitle Form Number

Machine Security System: RENR2462

Product Link Radio: RENR7911

Power Train Control: RENR8846

Implement Control: RENR8858

Caterpillar Monitoring System: SENR1394

Payload Control System: RENR6293

Resistor, Sender and Solenoid SpecificationsPart No. Component Description Resistance (Ohms)¹9G-1950 Resistor: Blower Motor Speed Overall: 2.0 ± 0.1

Tap 1.0 ± .05134-2540 Resistor: CAN 120¹ At room temperature unless otherwise noted.

Wire DescriptionWire

Number Wire Color Description WireNumber Wire Color Description

Power Circuits Lighting Circuits Continued102 RD Hd Lmp 619 GN Head Lamp Low104 YL MSS / Product Link 633 BU Attach Lighting Ckt105 RD Key Sw 646 OR Light Sw To Front Flood Relay106 WH Tilt/Lift Position Sensors 647 GN Light Sw To Rear Flood Relay108 BU Air Seat 651 PK Flood Lamp Rear110 RD Engine ECM 661 GN Tachometer Lamp112 PU Main Power Rly Output 662 YL Speedometer Lamp113 OR Opr Mon Panel Vmis B+ Switched 663 GY Gage Lamps114 RD Warning Horn (forward) 691 GY Warning Lights To Breaker115 PK Voltage Converters / Radio A629 BU Front Rops Hid Flood Attachment118 GY Front/Rear Wiper/Washer Control Circuits120 RD Voltage Converter Memory 720 PU Xmsn Brake Sw121 RD Back Alarm To Lamp 727 GN Supplemental Steering Motor Relay122 RD Dome Lamps 728 BU Supplemental Steering Cont Sw124 GN AC 751 GN Xmsn Shift Sol No. 1 Or 3125 RD Product Link ECM/Radio 752 YL Xmsn Shift Sol No. 2126 PK Xmsn Ctrl 754 BU Xmsn Shift Sol No. 3 Or 1127 OR Front Cab Flood Lamps 755 OR Xmsn Shift Sol No. 4 Or 5130 RD Stop Lamps 762 YL Bucket Positioner Sol Sw131 BR Flasher / Front/Rear Flood Relays E701 PK Auto Ride Control Sw133 RD LH/RH Dash Indicator Panels E707 GN CMS Display +v134 YL Rear Cab Flood Lamps E708 PK CMS Display Clock135 BU Converter 12 Volt Switched Out E735 PU CMS Tack/Serv Mtr/Odometer Select136 GN Supplemental Steering E746 GN Downshift Sw (N.O.)138 GN Auto Lube Pump To PCS G746 WH Xmsn Cont Torque Limit139 RD LH Tail / Clearance Lamps G750 BU Xmsn Cont Fwd Sw To Gnd141 PK Beacon / Heated Mirrors G755 GY Xmsn Cont Rev Sw To Gnd142 BU Converter 12 Volt Switched Out G760 WH Xmsn Cont Speed 2 Sw To Gnd147 RD ECAP / Center Dash Indicator Panel G761 YL Xmsn Cont Speed 3 Sw To Gnd148 RD Voltage Converter Memory G762 BR Xmsn Cont Speed 4 Sw To Gnd150 OR Bat (+) G763 PU Xmsn Cont Neut Sw To Gnd151 GN Axle Oil Cooler Clutch G764 PK Xmsn Cont Park Brake Lever Sw To Gnd164 WH Hydro Ctrl Wtl Powertrain Ctrl G766 GN Impl Cont Sw To Gnd N.O.168 GN Quick Coupler G767 WH Impl Cont Sw To Gnd N.C.170 RD Transmission ECM G768 GN Xmsn Cont Speed 1 Sw To Gnd174 RD Unswitched Bus Power G787 GN Xmsn Cont Remote Fwd Sw To Gnd199 RD Hood Actuator G788 YL Xmsn Cont Remote Rev Sw To Gnd

A105 OR 8 Volt Sensor Supply+ H702 PU Impl Cont Reversing Fan Sw (N.O.)Ground Circuits H703 YL Impl Cont Reversing Fan Sw (N.C.)

200 BK Main Chassis H708 OR Impl Cont Kickout Sw 1201 BK Operator Monitor Return H709 BU Impl Cont Kickout Sw 2202 BK Xmsn Ctrl H710 PK Impl Cont Lift Lever Position210 BK Converter Output (24/12 Volt) H711 GN Impl Cont Tilt Lever Position250 BK Payload Mon - Customer Gnd H713 PK Impl Cont Lift Proportional Sol251 BK Payload Mon - System Gnd H714 OR Impl Cont Lower Proportional Sol290 BK CMS Service H717 BR Impl Cont Pilot Press Sol 291 BK CMS Clear H718 GY Impl Cont Tilt Cyl Position

A272 BK Implement Ctrl B- H722 GN Xmsn Cont L. Brake Pedal Position SensA273 BK Transmission Ctrl B- H728 GN CCS Auto 3C216 BK Implement Return H729 WH CCS Auto 2

Basic Machine Circuits H730 BR CCS Auto 1-4306 GN Starter Relay Coil to Transmission Control H795 PK Throttle Sensor Common307 OR Key Sw to Transmission Control J764 BR Transmission Switch/Sensor Return #1308 YL Main Power Relay Coil P739 BU Axle Cooler Clutch320 OR Horn Relay Coil To Sw Y794 OR Expanded Can Data Link +321 BR Backup Alarm Lamp Travel Alarm Y795 GN Expanded Can Data Link -322 GY Warning Horn (forward) 818 BR Serial Data (transmit)326 PU Key Sw 'C' Term. 819 GY Serial Data (receive)

A307 GY Throttle Position G848 GN Led Driver 2Monitoring Circuits G850 BU Inlet Air Heater

403 GN Alternator (R) Term. J807 BK Proportional Return (1-3)410 WH Opr Mon Action Alarm J808 BK Proportional Return (4/Rev)411 PK Opr Mon Master J809 BK Proportional Return (Forward)413 BR Opr Mon Fuel Press. J813 BK Implement Proportional Return416 OR Supplemental Steering Sw J814 BK Implement Proportional Return417 GY Primary Steering Sw J815 BK Ride Control Solenoids Proportional Return419 YL Opr Mon Parking Brake J887 PU Axle Cooler Relay426 BR Opr Mon Power Train Oil Filter T852 GY Auto Dig Mode Sw. Pos #1430 BU Opr Mon Air Filter T853 OR Auto Dig Mode Sw. Pos #2432 PK Opr Mon Brake Press. (oil) T854 YL Auto Dig Mode Sw. Pos #3436 OR Opr Mon Power Train Oil Filter Jumper T855 BU Auto Dig Mode Sw. Pos #4439 YL Lamp Indicator T856 WH Auto Dig Mode Select Sw. Pos #1442 GY Hyd System Temp Gage T857 GN Auto Dig Mode Select Sw. Pos #2443 YL Power Train Temp Gage T858 GY Auto Dig Kickout Set Sw. (N.O.)447 PK Fuel Level Gage T859 WH Auto Dig Kickout Set Sw. (N.C.)450 YL Tach Sender (+) T860 OR Auto Dig Trigger Sw. (N.O.)453 PK Supplemental Steering Fault Lamp T861 YL Auto Dig Trigger Sw. (N.C.)484 YL Primary Steering Lamp T862 BU Auto Dig Auto Trigger Indicator

C413 YL CMS Display Data T863 PU Auto Dig Record Mode IndicatorC414 BU CMS Display Load T864 BR Auto Dig Operator Trigger IndicatorE416 PU Lift Cyl Press Sensor T866 YL Dump DetentE455 BR Hydraulic Oil Filter T869 WH Fine Modulation Sw 1G479 WH Prelube Indicator T870 BR Fine Modulation Sw 2G480 GN Fuel Level Low Indicator 900 PU Xmsn Shift Sol No. 5 Or 4G485 BU Opr Mon Front Brake Temperature 901 WH Xmsn Shift Sol No. 6G486 GN Opr Mon Rear Brake Temperature 910 YL Xmsn Neutizer Override Indicator

Accessory Circuits 944 OR Cat Data Link +500 BR Wiper - Front (Park) 945 BR Cat Data Link -501 GN Wiper - Front (Low) 961 BR Selector Sw502 OR Wiper - Front (Hi) 964 BU Fork Position Select503 BR Wiper - Rear (Park) 973 BR Autoshift- Auto/Manual Sw 2504 YL Wiper - Rear (Low) 976 OR Ride Cont Solenoid 1505 BU Wiper - Rear (Hi) 977 YL Autoshift- Auto/Manual Sw 1506 PU Washer - Front 987 WH Third Function Diverter Sol507 WH Washer - Rear A958 WH Park Brake Sol508 PU Radio Speaker - Left A982 BR Engine Throttle Cont509 WH Radio Speaker - Left (Commom) E900 WH Trans Output Spd +511 BR Radio Speaker - Right E901 GN Trans Output Spd -512 GN Radio Speaker - Right (Common) E906 OR Trans Output Spd Q+515 GY Blower Motor (Hi) E907 GY Trans Output Spd Q-516 GN Blower Motor (Medium) E908 BR Trans Input Spd +517 BU Blower Motor (Low) E909 WH Trans Input Spd -518 OR Hazard Flasher To Sw E917 WH Implement Lockout Sw To Gnd (N.O.)521 YL A/C Sw To Refrigerant Sw E918 GN Implement Lockout Sw To Gnd (N.C.)522 WH A/C Clutch To Thermostat Sw E919 YL Aux Lower Proportional Sol537 GN Turn Signal Sw To Flasher E920 BR Aux Lift Proportional Sol538 BR Hazard Indicator E921 PK Rackback Proportional Sol539 BU Turn Signal Indicator Basic/Right E922 GN Dump Proportional Solenoid540 WH Turn Signal Indicator Left E955 OR PCS Keypad Data550 GY Aux Hyd Left- Disconnect To Sw K927 BU On/Off Pilot Solenoid Return567 WH A/C Sw Jumper K977 PK Trans Oil Temp Sensor592 BU DC/DC Converter Power Output N939 GN Ride Control Solenoid 2

A513 RD DC/DC Converter Memory Output N957 PK Rxd - Comm #1A523 PU Temp Potentiometer Pos 1 N959 PK Rxd - Comm #3A524 BR Temp Potentiometer Pos 2 N960 OR Txd - Comm #1A525 GN Temp Potentiometer Pos 3 N963 OR Txd - Comm #3A541 PU Flasher To Indicator Lights N970 YL Dtr - Comm #1C529 GY Lift Press Sensor N973 BR Dcd - Comm #1C530 BU Lift Position Sensor N979 GN Signal Gnd - Comm #1C542 GN Heated Mirror Power N981 GN Signal Gnd - Comm #3C543 GY Aux Heater Blower P910 BR Secondary Steering Test Sw InputC583 GN +24v Relay To A/C Control Module P915 PK Xmsn Neutral IndicatorF523 PU Temp Potentiometer Pos 1 P916 OR Xmsn Neutral SwitchF524 BR Temp Potentiometer Pos 2 P945 OR Anti Drift Sol- StickF525 GN Temp Potentiometer Pos 3 P946 BR Anti Drift Sol- Boom

Lighting Circuits P976 BR Quick Coupler Sw To Low Pressure Sol603 PK Rotary Beacon P990 BR Start Relay Ctrl Return604 OR Stop Lamp T901 YL MSS Exciter Coil In605 YL Turn Lamp - Left T902 PK MSS Exciter Coil Out606 GY Turn Lamp - Right T969 YL Third Function Control Flow Switch608 GN Flood Lamp - Rear T970 GY Third Function Control Flow Switch610 OR Head Lamp Basic X972 GN Part Throttle Auto Shift Position 1611 PU Head Lamp Hi X973 BU Part Throttle Auto Shift Position 2614 PU Park/Tail/Dash/Lamp X974 BR Part Throttle Auto Shift Position 3615 YL Cab Flood Lamp/Rops X998 BR Digital Sensor Return617 BR Tail/position Lamp - Left (Road Pkg)/Width

SYMBOL DESCRIPTION

BLADE, SPADE, RING OR SCREWTERMINAL

CIRCUIT CONNECTED

CIRCUIT NOT CONNECTED

ELECTRICAL CONNECTION TOMACHINE STRUCTURE

INTERNAL ELECTRICAL CONNECTIONTO SURFACE OF COMPONENT

CONNECTOR

ATCH WIRE, CABLE, COMPONENT

CIRCUIT CONNECTED

SPLICE

CIRCUIT GROUPING DESIGNATIONH#

ABBREVRDWHORYLPKBKGYPUBRGNBU

COLORRED

WHITEORANGEYELLOW

PINKBLACKGRAY

PURPLEBROWNGREENBLUE

COLOR ABBREVIATIONS

OTHER COLOR DESCRIPTIONSHIGHWAYS

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.VOLTAGE CONVERTER OUTPUT CIRCUIT.STARTING CIRCUIT.GROUND CIRCUIT.

MONITOR CIRCUIT.ENGINE CONTROL CIRCUIT.

PAYLOAD CONTROL CIRCUIT.TRANSMISSION CONTROL CIRCUIT.IMPLEMENT CONTROL CIRCUIT.

HEATER AND AIR CONDITIONER CIRCUIT.TURN SIGNAL/WIPER/WASHER CIRCUIT.

WIRE GROUP COLOR DESCRIPTIONS

PRODUCT LINK RS-232 DATA LINK.

CAT DATA LINK.CAN DATA LINK.

RE

NR

6332-0

2 V

OL

2 o

f 2

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

THIS SCHEMATIC IS FOR THE 950H/962H/966H/972H/IT62H WHEEL LOADER CAB WITH ELECTRO-HYDRAULIC CONTROLLED IMPLEMENTS VOLUME 2 of 2: DESCRIPTIONPART NUMBER: 237-5752, CHANGE: 02, VERSION: -,V,XComponents are shown installed on a fully operable machine.

Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

A

B

C

D

E

F

1234567891011121314

G

H

I

J

1234567891011121314

A

B

C

D

E

F

G

H

I

J

12

Y-C21552269

12

Y-C51552269

12

Y-C11552269

12

Y-C61552269

X-C13E3370

ABC

W-C13E3370

ABC

12

WA-C21552252

3456789101112

123456789101112131415161718192021222324

WA-C31607690

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112

WA-C13E5179

12

T-C11552269

123456789101112

N-C43E5178

201321915161241812593481011226231721714

N-C17X6222

ED

N-C33E5136

ACB

12cN-C5

3T3158

N-C21698669

ABC

12

M-C13E3364

12

M-C21552269

12

M-C31552269

12

L-C13E3364

12

L-C21552269

12

L-C31552269

12

K-C13E3364

12

K-C21552269

12

K-C31552269

12

J-C11552269

12

H-C13E3364

12

H-C21552269

12

H-C31552269

12

G-C11552252

3456789101112

12

G-C21552252

3456789101112

12

G-C61552269

12

G-C41552273

34561

2345678

G-C31552264

G-C51552267

ABC

12345678910

G-C72234778

12

F-C13E5179

3456789101112

12

F-C3

3456

12

F-C41698668

12

E-C21552252

3456789101112 1

2

E-C111552269

E-C131552267

BC

A

12345678910

E-C62234778

12

E-C71552272

34

12

E-C91552272

34

12

E-C101552272

34

1234

E-C53E3376

12345678

E-C31552264

E-C43E3370

BC

A

E-C13E3370

ABC

12

EG-C11552273

3456

12

EG-C23E3376

34

12

EG-C31552272

34

12

EG-C41552272

34

1234

EG-C53E3376

1234

EG-C63E3376

1234

C-C111965330

12

C-C41552272

34

12

C-C211552252

3456789101112

12

C-C451552273

3

4

5

6

1524

C-C59X1054

12

C-C91552269

C-C181552267

A

BC

C-C61552267

A

BC

12

C-C203E5179

3456789101112

12

C-C101552273

3

4

5

6

12

C-C851552252

3456789101112

12

C-C811552264

345678

12345678

C-C823E3388

12

C-C901552272

34

12

C-C231552269

12

C-C281552273

3456

12

C-C831552273

3456

C-C511552267

ABC

12

C-C521552264

345678

12

C-C531552264

345678

12

C-C551552273

3456

12

C-C571552273

3456

1234567

C-C28N1532

1524

C-C139X1054

12

C-C121552269

1524

C-C299X1054

12345678910111213141516171819202122232425262728293031323334353637383940

C-C351835785

12

C-C541552273

3456

12

C-C727T5957

12

C-C173E3382

3456

123456

C-C563E3382

123456

C-C843E3382

C-C741552267

ABC

C-C752304013

123

12

C-C763E3364

C-C771552267

ABC

10A 10A

DOME LAMPS KEY START SW/PRODUCT LINK

10A 10A

VOLTAGE CONVERTOR HORN

15A 15A

STOP LAMPS HOOD ACTUATOR

15A 10A

LH TAIL/CLEARANCE LAMPS ECAP/CENTER DASH IND PNL

10A 10AVOLTAGE CONVERT0RS/24V RADIO PAYLOAD CONTROL SYSTEM

15A 10AFRONT/REAR WIPER/WASH EMS/(QUAD GAUGE/

15A 10AAIR SEAT LEVER SENSORS/

10A 10ATILT/LIFT POSITION SENSORS

FRONT CAB FLOODLAMPS

10A 10A

MSS/PRODUCT LINK

LH/RH DASH INDICATOR PNL

10A 15ABEACON/HEATED MIRRORS

TS FLASHER/FRNT

10A 10AECM SWITCHED PWR SECONDARY STEERING

10A 15ASPARE REAR CAB FLOODLAMPS

C-C301886253

UNSWITCHED BUS

SWITCHED BUS

10A 10A

IMPL ECM

VOL CONV MEM (ATTA)

10A 10A

ENGINE ECM

XMSN ECM

10A 20A

HMU SHIFT HANDLE AXLE OIL COOLER CLUTCH10A 10A

QUICK COUPLER HVAC

2

4

6

8

10

12

14

16

18

20

22

24

26

28

30

32 31

29

27

25

23

21

19

17

15

13

11

9

7

5

3

1

MEMORY (STANDARD)

SPD TACH BACKLIGHTS)

LH BRAKE PEDAL SENSOR

REAR FLOOD RELAYS

(NOT USED ON 980G)

123456789101112131415161718192021222324

C-C269X0145

12

C-C481552273

3456

12

C-C341552272

34

12

C-C583E3376

34

12

C-C863E3364

12

C-C427T5957

12

C-C221552273

3456

12

C-C241552272

34

12

C-C781552264

345678

12345678910

C-C792234778

12345678910

C-C802234778

12345678910

C-C662234778

12345678910

C-C672234778

12345678910

C-C652234778

12345678910

C-C612234778

12345678910

C-C592234778

12345678910

C-C602234778

12345678910

C-C622234778

12345678910

C-C642234778

12345678910

C-C432234778

12345678910

C-C492234778

12345678910

C-C502234778

12345678910

C-C942234778

12345678910

C-C462234778

12345678910

C-C392234778

12345678910

C-C382234778

12

C-C323E3376

34

12

C-C401552252

3456789101112

123456789101112C-C413E5179

123456789101112131415161718192021222324

C-C71471445J1

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112131415161718192021222324

C-C81471446J2

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112131415161718192021222324

C-C311471445

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112131415161718192021222324

C-C331471446

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112131415161718192021222324

C-C12144208

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12

C-C141552273

3456

12

C-C151552273

3456

1 2

C-C683T3158

1 2

C-C693T3158

1 2

C-C713T3158

1 2

C-C703T3158

12

C-C441552252

3456789101112

12

C-C931552273

3456

12

C-C161552273

3456

12

C-C251552264

345678

1524

C-C871195094

12345678

C-C273E3388

12

C-C911552269

12

C-C731552252

3456789101112

123456789101112131415161718192021222324

C-C38T9834

25262728293031323334353637383940

ABC

C-C881552267

12

C-C193E3388

345678

12

C-C363E3364

12345678910

C-C952234778

12

C-C921552269

123456

C-C473E3382

12

C-C893E3364

12

C-C371552252

3456789101112

123456789101112

C-C633E5179

1524

C-C961195094

12345678910

C-C972234778

C-C982469371

C-C992469371

12345678910

C-C1022234778

12

C-C1003E3376

34

12

C-C1011552272

34

C-C1031552267

ABC

C-C1043E3370

ABC

FINE MODULATION SW2364622

FUSE PANEL/ELECTRICAL INSTALLATION

PANEL B

SERVICEMODEPLUG

SERVICETOOL CONNECTOR

CAP PART NUMBER8C-6354

610-W2OR-14619-W3GN-14611-W1PU-14

200-X1BK-14

NOTE: JUMPER 610-OR TO 619-GNON MACHINES NOT EQUIPPED WITHROADING LIGHTS.

GND STRAP8X-5802

CABLE AS. 124-4885 CABLE AS. 124-4883

CABLE AS. 124-4884

202-CR1BK-16

202-CR1BK-16

322-CR2GY-16

G768-CR5GN-16 G768-CR5GN-16G760-CR6WH-16 G760-CR6WH-16G761-CR7YL-16 G761-CR7YL-16

G762-CR8BR-16G762-CR8BR-16

G763-CR9PU-16

G763-CR9PU-16

COMMAND CONTROL STEERING WHEEL

C216-E11BK-18

C216-E11BK-18C216-E15BK-18

C216-E17BK-18C216-E16BK-18

164-E7WH-18

164-E7WH-18164-E19WH-18164-E20WH-18164-E21WH-18

320-E12OR-16

320-E12OR-16

H722-E9GN-18

H722-E9GN-18

H711-E2GN-18

H711-E2GN-18

H710-E1PK-18

H710-E1PK-18

IMPLEMENT POD

200-C334BK-16

200-C334BK-16

200-C416BK-18

200-C416BK-18

200-C416BK-18

537-C56GN-16

102-C248RD-14

DASH

DASH

FUSE PANEL/ELECTRICAL INSTALLATION

537-AY1GN-14

537-AY1GN-14

539-AY2BU-18

539-AY2BU-18

540-AY3WH-18

540-AY3WH-18

605-AY4YL-14 605-AY4YL-14606-AY5GY-14

606-AY5GY-14

A541-AY6PU-18

A541-AY6PU-18

537-C56GN-16

118-C355GY-18

118-C355GY-18

118-C352GY-18

118-C352GY-18

202-C350BK-18

202-C350BK-18

C216-C22BK-16

C216-C22BK-16

308-C87YL-18

308-C87YL-18

308-C87YL-18

138-C20GN-18

138-C20GN-18

C529-C48GY-18

C529-C48GY-18

C529-C59GY-18

C529-C59GY-18

C529-C59GY-18

C529-C59GY-18

C530-C49BU-18

C530-C49BU-18 C530-C61BU-18

C530-C61BU-18

C530-C61BU-18

945-C128BR-18

945-C128BR-18

945-C128BR-18

945-C128BR-18

945-C128BR-18

944-C127OR-18

944-C127OR-18

944-C127OR-18

944-C127OR-18

944-C127OR-18

604-C78OR-16

604-C78OR-16

604-C78OR-16

614-C82PU-16

614-C82PU-16

614-C96PU-18

614-C96PU-18

614-C96PU-18

614-C96PU-18

614-C96PU-18

605-C79YL-16

605-C79YL-16

605-C91YL-16

605-C91YL-16

605-C91YL-16

606-C80GY-16

606-C80GY-16606-C89GY-16

606-C89GY-16

606-C89GY-16

320-C319OR-16

320-C319OR-16

320-C319OR-16

202-C4BK-18

202-C4BK-18

202-C31BK-16

202-C31BK-16

202-C31BK-16

202-C31BK-16

611-C32PU-14

611-C32PU-14

611-C32PU-14

611-C32PU-14

403-C123GN-18

403-C123GN-18

320-C319OR-16

606-C89GY-16605-C91YL-16

509-C340WH-18

508-C302PU-18

508-C302PU-18

508-C302PU-18

508-C302PU-18

508-C302PU-18

691-C326GY-16131-C266BR-16

320-C317OR-16

320-C317OR-16

320-C317OR-16

320-C317OR-16

322-C39GY-16

322-C39GY-16

322-C39GY-16

322-C39GY-16

322-C39GY-16

322-C39GY-16

127-C267OR-14

199-C72RD-16

199-C72RD-16

199-C72RD-16

199-C72RD-16

199-C72RD-16

199-C72RD-16

150-C126OR-16

150-C126OR-16

150-C126OR-16

106-C18WH-18

106-C18WH-18

106-C18WH-18

106-C18WH-18

106-C18WH-18

106-C18WH-18

112-C1PU-4

112-C1PU-4112-C1PU-4

112-C1PU-4

112-C1PU-4

112-C1PU-4

619-C40GN-14619-C40GN-14

619-C40GN-14

619-C40GN-14

A523-C236PU-18

A523-C236PU-18

A523-C236PU-18

A523-C236PU-18

A523-C236PU-18

A524-C237BR-18

A524-C237BR-18

A524-C237BR-18

A524-C237BR-18

A524-C237BR-18

A524-C237BR-18

A524-C237BR-18

A525-C238GN-18

A525-C238GN-18

A525-C238GN-18

A525-C238GN-18

A525-C238GN-18

A525-C238GN-18

A525-C238GN-18

517-C240BU-14

517-C240BU-14

517-C240BU-14

517-C240BU-14

517-C240BU-14

517-C240BU-14

517-C240BU-14

516-C241GN-14

516-C241GN-14

516-C241GN-14

516-C241GN-14

516-C241GN-14

516-C241GN-14

516-C241GN-14

515-C235GY-14

515-C235GY-14

515-C235GY-14

515-C235GY-14

515-C235GY-14

515-C235GY-14

515-C235GY-14

522-C125WH-18

522-C125WH-18

522-C125WH-18

522-C125WH-18

522-C125WH-18

522-C125WH-18

504-C255YL-18

504-C255YL-18

504-C255YL-18

504-C255YL-18

504-C255YL-18

504-C255YL-18

504-C255YL-18

503-C256BR-18

503-C256BR-18

503-C256BR-18

503-C256BR-18

503-C256BR-18

503-C256BR-18

503-C256BR-18

505-C254BU-18

505-C254BU-18

505-C254BU-18

505-C254BU-18

505-C254BU-18

505-C254BU-18

505-C254BU-18

A982-C130BR-18

A982-C130BR-18

A982-C130BR-18

A982-C130BR-18

A307-C129GY-18

A307-C129GY-18

A307-C129GY-18

A307-C129GY-18

521-C124YL-14

521-C124YL-14

521-C124YL-14

521-C124YL-14

102-T2RD-16604-T1OR-16

500-C252BR-18

500-C252BR-18

500-C252BR-18

506-C10PU-18

506-C10PU-18

506-C10PU-18

506-C10PU-18

507-C11WH-18

507-C11WH-18

507-C11WH-18

507-C11WH-18

501-C257GN-18

501-C257GN-18

501-C257GN-18

502-C253OR-18

502-C253OR-18

502-C253OR-18

617-C83BR-16

617-C83BR-16

617-C83BR-16

617-C83BR-16

617-C83BR-16

617-C83BR-16

102-C69RD-14

102-C69RD-14

102-C69RD-14

102-C69RD-14

131-C266BR-16

127-C267OR-14

691-C326GY-16

604-C78OR-16

174-C2RD-10

174-C2RD-10

174-C2RD-10

174-C2RD-10

174-C2RD-10

174-C2RD-10

138-C20GN-18

118-C274GY-18

118-C274GY-18

118-C274GY-18

118-C274GY-18

118-C274GY-18

118-C274GY-18

201-C224BK-18

201-C224BK-18

134-C268YL-14

200-C220BK-18

200-C220BK-18

200-C220BK-18

200-C220BK-18

608-C294GN-14

608-C294GN-14

608-C294GN-14

608-C294GN-14

608-C294GN-14

608-C294GN-14

608-C294GN-14

608-C294GN-14

A272-C233BK-14

114-C41RD-16

114-C41RD-16

114-C41RD-16

114-C41RD-16

114-C41RD-16

114-C41RD-16

114-C42RD-16

201-C224BK-18

200-C213BK-16

200-C213BK-16

200-C213BK-16

200-C213BK-16

200-C212BK-18

200-C212BK-18

200-C212BK-18

200-C212BK-18

200-C211BK-16

200-C211BK-16

200-C211BK-16

200-C211BK-16

200-C210BK-18

200-C210BK-18

200-C210BK-18

200-C210BK-18

200-C210BK-18

200-C210BK-18

200-C209BK-14

200-C209BK-14

200-C209BK-14

200-C209BK-14

200-C209BK-14

200-C209BK-14

134-C268YL-14

114-C42RD-16

136-C75GN-16

136-C75GN-16

136-C75GN-16

136-C75GN-16

136-C75GN-16

164-E20WH-18C216-E16BK-18H722-E9GN-18

164-E19WH-18C216-E15BK-18H711-E2GN-18

164-E21WH-18C216-E17BK-18H710-E1PK-18

320-E12OR-16

G763-CA1 PU 20202-CA2BK-20G750-CA3 BU 20G755-CA4 GY 20G768-CA5GN-20G760-CA6 WH 20G761-CA7 YL 20G762-CA8 BR 18

200-C344BK-18

200-C344BK-18

200-C343BK-18

200-C343BK-18

200-C345BK-18

200-C345BK-18

727-C289GN-16

727-C289GN-16

727-C289GN-16

727-C289GN-16

COMPONENTS ARE SHOWN INSTALLED ON A FULLYOPERABLE MACHINE WITH THE KEY AND ENGINE OFFAND XMSN SHIFTER IN NEUTRAL

DASHED FONT INDICATES AN ATTACHMENT COMPONENTOR HARNESSCOMPONENTS IN THE FOLLOWING SYSTEMSARE NOT OFFERED WITH OROPS CABS:HVAC, RADIO READY, WINDSHIELD WIPER AND WASHER

200-C342BK-18

200-C342BK-18

CONNECTIONS FOR COMMUNICATIONS RADIO

CONNECTS TOCJ-C11 ON THE

CHASSIS ANDENGINE DGM

FOR PART #'SSEE THE

TITLE BLOCK

CONNECTS TOCJ-C4 ON THECHASSIS AND ENGINE DGM

FOR PART #'SSEE THE

TITLE BLOCK

CONNECTS TOCJ-C21 ON THE

CHASSIS ANDENGINE DGM

FOR PART #'SSEE THE

TITLE BLOCK

C216-C314BK-18

C216-C314BK-18

C216-C314BK-18

C216-C314BK-18C216-C24BK-18

C216-C24BK-18

C216-C24BK-18

C216-C24BK-18

C216-C24BK-18

ELECTRICAL STUDS PASSTHROUGH THE CAB ROOFCONNECTING TO TERMINALSON THE CHASSISAND ENGINE DIAGRAMSFOR PART NUMBERS SEE THETITLE BLOCK

200-C334BK-16

200-C341BK-16

A982-C130BR-18A307-C129GY-18

A307-C129GY-18

619-C40GN-14

604-C78OR-16

619-C40GN-14

592-C202BU-16

200-C335BK-16

200-C335BK-16

200-C335BK-16

201-C292BK-18

201-C292BK-18

G746-C13WH-18

G746-C13WH-18

G746-C13WH-18

G746-C13WH-18

G746-C13WH-18

202-C143BK-18

611-C32PU-14

973-C195BR-18

973-C195BR-18

973-C195BR-18

973-C195BR-18

977-C197YL-18

977-C197YL-18

977-C197YL-18

977-C197YL-18

H728-C198GN-18

H728-C198GN-18

H728-C198GN-18

H728-C198GN-18

720-C234PU-18

720-C234PU-18

720-C234PU-18

720-C234PU-18

X973-C192BU-18

X973-C192BU-18

X973-C192BU-18

X973-C192BU-18X974-C200BR-18

X974-C200BR-18

X974-C200BR-18

X974-C200BR-18

H730-C201BR-18

H730-C201BR-18

H730-C201BR-18

H730-C201BR-18

X972-C188GN-18

X972-C188GN-18

X972-C188GN-18

X972-C188GN-18

G767-C190WH-18

G767-C190WH-18

G767-C190WH-18

G767-C190WH-18

P910-C38BR-18

P910-C38BR-18

P910-C38BR-18

P910-C38BR-18

G766-C189GN-18

G766-C189GN-18

G766-C189GN-18

G766-C189GN-18

592-C8BU-16

592-C8BU-16

592-C8BU-16

592-C8BU-16

G755-C186GY-18

G755-C186GY-18

G755-C186GY-18

G755-C186GY-18

G755-C186GY-18G750-C196BU-18

G750-C196BU-18

G750-C196BU-18

G750-C196BU-18

G750-C196BU-18

G763-C185PU-18

G763-C185PU-18

G763-C185PU-18

G763-C185PU-18

G763-C185PU-18G768-C187GN-18

G768-C187GN-18

G768-C187GN-18

G768-C187GN-18

G768-C187GN-18

G760-C191WH-18

G760-C191WH-18

G760-C191WH-18

G760-C191WH-18

G760-C191WH-18

142 BU IS A 12 VOLT CIRCUIT115 PK IS A 24 VOLT CIRCUIT

200-C288BK-18

200-C288BK-18

H729-C63WH-18

H729-C63WH-18

H729-C63WH-18

H729-C63WH-18

P976-C77BR-16

P976-C77BR-16

P976-C77BR-16

P976-C77BR-16

202-C143BK-18

611-C100PU-14

611-C100PU-14

STEERING GROUP

201-C102BK-18

201-C102BK-18

201-C102BK-18

201-C102BK-18

FUSE PART NUMBERS10 AMP (9W-1442)15 AMP (9W-1441)20 AMP (9W-1446)

HARNESS ASSEMBLIESIDENT PART NUMBER CHG LOC NOTE A 260-9602 01 E-2,3 SERVICE TOOL C 273-0274 00 H,I-14 MAIN CAB E 246-0578 03 F-11 IMPLEMENT POD F 192-2823 01 I-11 HVAC G 245-8335 04 G-7 IMPLEMENT POD JOYSTICK (ATTACHMENT) H 280-1436 00 I-5 CAB FLOOD LAMPS (ATTACHMENT) J 236-7775 01 I-9 BEACON (ATTACHMENT) K 280-1436 00 I-5 CAB FLOOD LAMPS (ATTACHMENT) L 280-1437 00 I-6 CAB FLOOD LAMPS (ATTACHMENT) M 280-1437 00 I-6 CAB FLOOD LAMPS (ATTACHMENT) N 188-1421 02 D-6 PAYLOAD CONTROL SYSTEM (ATTACHMENT) T 146-1892 01 F-1 LH PEDAL STOP LAMP SWITCH W 121-8039 01 G-1 DIMMER SWITCH (JAPAN ATTACHMENT) Y 235-5506 03 I-6 CAB FLOOD LAMPS (STANDARD) AT 192-7805 00 F-7 AIR SEAT AY 154-4563 01 G-3 TURN SIGNAL SWITCH (ATTACHMENT) CA 152-6432 06 G-2 COMMAND CONTROL STEERING (ATTACHMENT) CE 236-7773 01 I-8 CAB HID LIGHTING (ATTACHMENT) CF 236-6207 01 I-9 HEATED OUTSIDE MIRRORS (ATTACHMENT) CR 118-2943 04 G-3 HORN SWITCH/COMAND CONTROL STEERING EG 236-7772 01 E-12 10A VOLT CONVERTER (ATTACHMENT) WA 276-0031 01 G-10 GATEWAY PRODUCT LINK (ATTACHMENT))

WIRE ASSEMBLIES X 121-8038 02 G-1 DIMMER SWITCH JUMPER

FOR CHASSIS/ENGINE DIAGRAMS SEE: 237-5751

C216-C148BK-18

C216-C148BK-18

C216-C149BK-18

C216-C149BK-18

121-C133RD-14

121-C150RD-14

121-C170RD-14

T866-C174YL-18

T866-C174YL-18

T866-C174YL-18

T866-C174YL-18

T866-C174YL-18

944-C141OR-18

944-C141OR-18

944-C141OR-18

944-C141OR-18

945-C134BR-18

945-C134BR-18

945-C134BR-18

945-C134BR-18

H709-C158BU-18

H709-C158BU-18

H709-C158BU-18

H709-C158BU-18

H708-C157OR-18

H708-C157OR-18

H708-C157OR-18

H708-C157OR-18

T859-C176WH-18

T859-C176WH-18

T859-C176WH-18

T859-C176WH-18

T858-C175GY-18

T858-C175GY-18

T858-C175GY-18

T858-C175GY-18

T858-C175GY-18

T857-C156GN-18

T857-C156GN-18

T857-C156GN-18

T857-C156GN-18

T856-C155WH-18

T856-C155WH-18

T856-C155WH-18

T856-C155WH-18

T855-C166BU-18

T855-C166BU-18

T855-C166BU-18

T855-C166BU-18

T853-C164OR-18

T853-C164OR-18

T853-C164OR-18

T853-C164OR-18

T852-C163GY-18

T852-C163GY-18

T852-C163GY-18

T852-C163GY-18

T854-C165YL-18

T854-C165YL-18

T854-C165YL-18

T854-C165YL-18

A272-C233BK-14

E920-C52BR-18

E920-C52BR-18

E920-C52BR-18

E920-C52BR-18

E920-C52BR-18

E919-C51YL-18

E919-C51YL-18

E919-C51YL-18

E919-C51YL-18

E919-C51YL-18

E921-C53PK-18

E921-C53PK-18

E921-C53PK-18

E921-C53PK-18

E921-C53PK-18

E922-C54GN-18

E922-C54GN-18

E922-C54GN-18

E922-C54GN-18

E922-C54GN-18

H713-C57PK-18

H713-C57PK-18

H713-C57PK-18

H713-C57PK-18

H713-C57PK-18

H717-C67BR-18

H717-C67BR-18

H717-C67BR-18

H717-C67BR-18

H717-C67BR-18

H714-C58OR-18

H714-C58OR-18

H714-C58OR-18

H714-C58OR-18

H714-C58OR-18

C216-C26BK-16

C216-C26BK-16

C216-C26BK-16

C216-C26BK-16

C529-C60GY-18

C529-C60GY-18

C529-C60GY-18

C529-C60GY-18

C530-C62BU-18

C530-C62BU-18

C530-C62BU-18

C530-C62BU-18

T860-C161OR-18

T860-C161OR-18

T860-C161OR-18

T860-C161OR-18

T861-C162YL-18

T861-C162YL-18

T861-C162YL-18

T861-C162YL-18

T869-C168WH-18T869-C168WH-18

T869-C168WH-18

T869-C168WH-18

T869-C168WH-18

H711-C172GN-18

H711-C172GN-18

H711-C172GN-18

H711-C172GN-18

E917-C152WH-18

E917-C152WH-18

E917-C152WH-18

E917-C152WH-18

E917-C152WH-18

E918-C153GN-18

E918-C153GN-18

E918-C153GN-18

E918-C153GN-18

E918-C153GN-18

T870-C167BR-18

T870-C167BR-18

T870-C167BR-18

T870-C167BR-18

T870-C167BR-18

H710-C171PK-18

H710-C171PK-18

H710-C171PK-18

STRAP AS.

202-C113BK-16

202-C113BK-16

202-C113BK-16

202-C19BK-18

751-C115GN-18

751-C115GN-18

751-C115GN-18

751-C115GN-18

752-C111YL-18

752-C111YL-18

752-C111YL-18

752-C111YL-18

E900-C207WH-18

E900-C207WH-18

E900-C207WH-18

E900-C207WH-18

E906-C221OR-18

E906-C221OR-18

E906-C221OR-18

E906-C221OR-18

E908-C227BR-18

E908-C227BR-18

E908-C227BR-18

E908-C227BR-18

754-C142BU-18

754-C142BU-18

754-C142BU-18

754-C142BU-18

E901-C203GN-18

E901-C203GN-18

E901-C203GN-18

E901-C203GN-18

E907-C246GY-18

E907-C246GY-18

E907-C246GY-18

E907-C246GY-18

E909-C218WH-18

E909-C218WH-18

E909-C218WH-18

E909-C218WH-18

755-C120OR-18

755-C120OR-18

755-C120OR-18

755-C120OR-18

900-C147PU-18

900-C147PU-18

900-C147PU-18

900-C147PU-18

901-C121WH-18

901-C121WH-18

901-C121WH-18

901-C121WH-18

K977-C205PK-18

K977-C205PK-18

K977-C205PK-18

K977-C205PK-18

944-C110OR-18

944-C110OR-18

944-C110OR-18

944-C110OR-18

944-C110OR-18

945-C105BR-18

945-C105BR-18

945-C105BR-18

945-C105BR-18

945-C105BR-18

G763-C185PU-18

G763-C185PU-18

G755-C186GY-18

G755-C186GY-18

G768-C187GN-18

G768-C187GN-18

X972-C188GN-18

X972-C188GN-18

G766-C189GN-18

G766-C189GN-18

G767-C190WH-18

G767-C190WH-18

G760-C191WH-18

G760-C191WH-18

X973-C192BU-18

X973-C192BU-18

973-C195BR-18

973-C195BR-18

G750-C196BU-18

G750-C196BU-18

977-C197YL-18

977-C197YL-18

H728-C198GN-18

H728-C198GN-18

H729-C63WH-18

H729-C63WH-18

720-C234PU-18

720-C234PU-18

X974-C200BR-18

X974-C200BR-18

P910-C38BR-18

P910-C38BR-18

H730-C201BR-18

H730-C201BR-18

G746-C13WH-18

G746-C13WH-18

728-C106BU-18

728-C106BU-18

728-C106BU-18

728-C106BU-18

306-C109GN-18

306-C109GN-18

306-C109GN-18

306-C109GN-18

N939-C112GN-18

N939-C112GN-18

N939-C112GN-18

N939-C112GN-18

976-C116OR-18

976-C116OR-18

976-C116OR-18

976-C116OR-18

G764-C117PK-18

G764-C117PK-18

G764-C117PK-18

G764-C117PK-18

453-C119PK-18

453-C119PK-18

453-C119PK-18

453-C119PK-18

484-C140YL-18

484-C140YL-18

484-C140YL-18

484-C140YL-18

417-C183GY-18

417-C183GY-18

417-C183GY-18

417-C183GY-18

416-C184OR-18

416-C184OR-18

416-C184OR-18

416-C184OR-18

321-C249BR-18

321-C249BR-18

321-C249BR-18

321-C249BR-18

450-C263YL-18

450-C263YL-18

450-C263YL-18

450-C263YL-18

TWISTEDWIRES

CONNECTS TOAT-C10 ON THECHASSIS ANDENGINE DGM

FOR PART #'SSEE THE

TITLE BLOCK

326-C287PU-18

326-C287PU-18

326-C287PU-18

326-C287PU-18

326-C287PU-18

200-C346BK-18

200-C346BK-18

J1

J2

H795-C222PK-18

516-C241GN-14517-C240BU-14

A525-C238GN-18A524-C237BR-18

515-C235GY-14

521-C124YL-14

A525-C238GN-18A524-C237BR-18

517-C240BU-14

516-C241GN-14

515-C235GY-14

521-C124YL-14

502-C253OR-18

500-C252BR-18506-C10PU-18

501-C257GN-18

T855-C166BU-18

T852-C163GY-18

T854-C165YL-18T853-C164OR-18

H729-C63WH-18

505-C254BU-18

H728-C198GN-18977-C197YL-18973-C195BR-18

504-C255YL-18503-C256BR-18507-C11WH-18

720-C234PU-18

500-C252BR-18

502-C253OR-18506-C10PU-18

501-C257GN-18

503-C256BR-18

977-C197YL-18

507-C11WH-18505-C254BU-18504-C255YL-18

973-C195BR-18

H728-C198GN-18H729-C63WH-18

T855-C166BU-18

T852-C163GY-18

T854-C165YL-18T853-C164OR-18

H795-C222PK-18

720-C234PU-18

C530-C61BU-18C529-C59GY-18

P910-C38BR-18

T857-C156GN-18

G767-C190WH-18

727-C289GN-16

G766-C189GN-18 T856-C155WH-18

C529-C59GY-18C530-C61BU-18

H730-C201BR-18

X973-C192BU-18X972-C188GN-18

X974-C200BR-18

X973-C192BU-18X974-C200BR-18

X972-C188GN-18

P910-C38BR-18

T858-C175GY-18T857-C156GN-18

G767-C190WH-18

H709-C158BU-18

T859-C176WH-18

T856-C155WH-18

G766-C189GN-18

614-C94PU-18

727-C289GN-16

H708-C157OR-18

200-C344BK-18200-C346BK-18

200-C342BK-18

200-C343BK-18

200-C345BK-18

200-C206BK-16

604-C78OR-16

604-C78OR-16

G746-C13WH-18

617-C83BR-16

509-C340WH-18

509-C340WH-18

592-C8BU-16

308-C87YL-18

592-C8BU-16

320-C319OR-16

G750-C196BU-18G755-C186GY-18G768-C187GN-18G760-C191WH-18

G763-C185PU-18

320-C319OR-16

G750-C196BU-18G755-C186GY-18

G763-C185PU-18G768-C187GN-18

G760-C191WH-18

606-C89GY-16605-C91YL-16

326-C287PU-18

606-C89GY-16605-C91YL-16

326-C287PU-18501-C257GN-18

502-C253OR-18500-C252BR-18

502-C253OR-18

500-C252BR-18501-C257GN-18

537-C16GN-16

537-C56GN-16

537-C56GN-16

537-C56GN-16

537-C56GN-16

537-C56GN-16

508-C302PU-18

508-C302PU-18

202-C143BK-18

202-C143BK-18

202-C143BK-18

202-C31BK-16

202-C31BK-16

102-C69RD-14

308-C87YL-18

104-C30YL-16

104-C30YL-16

104-C30YL-16

104-C30YL-16

104-C30YL-16

201-C304BK-16

147-A1RD-18200-A2BK-18

944-A3OR-18945-A4BR-18

201-C292BK-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

307-C3OR-18

LH BRAKE PEDAL (178-3186)

H730-C201BR-18

HVAC UNIT

HVAC UNIT

200-F2BK-18

A523-C236PU-18

A523-C236PU-18

A523-C236PU-18

A523-C236PU-18

592-C392BU-16

592-C392BU-16

592-C392BU-16

592-C392BU-16

592-C392BU-16135-F16BU-18

135-F16BU-18135-A17BU-16

135-F18BU-18

135-F18BU-18

A525-F15GN-18

F525-F15GN-18

A524-F14BR-18

F524-F14BR-18

F524-F14BR-18

517-F10BU-14

517-F10BU-14

A523-F13PU-18

F523-F13PU-18

516-F9GN-14

516-F9GN-14

516-F9GN-14

550-F11GY-14

515-F6GY-14

515-F6GY-14

200-F1BK-14200-F1BK-14522-F12WH-14

522-F12WH-14

522-F12WH-14 200-F4BK-14

200-F4BK-14

135-A17BU-16

200-F5BK-18

200-F5BK-18

200-F3BK-14

200-F3BK-14

515-F7XXGY-14

200-F2BK-18

522-F12WH-14

A982-C130BR-18

619-C40GN-14

611-C100PU-14

202-C143BK-18

G746-C13WH-18

A982-C130BR-18A307-C129GY-18

201-C224BK-18

200-C312BK-16

200-C312BK-16

200-C312BK-16

148-C282RD-16

148-C282RD-16

115-C103PK-16

115-C103PK-16115-C283PK-16

115-C283PK-16200-C219BK-16

200-C219BK-16

200-C219BK-16

200-C219BK-16

120-C281RD-16

120-C281RD-16

120-C281RD-16

120-C281RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

A513-C339RD-16

592-C272BU-16

592-C272BU-16

592-C272BU-16

592-C272BU-16

592-C272BU-16

TO INSURE PROPER GROUNDREMOVE PAINT ANDCORROSION BEFORECONNECTING GROUND STRAP

945-C105BR-18

944-C110OR-18

944-C110OR-18

945-C105BR-18

170-C70RD-14

170-C70RD-14

170-C70RD-14

170-C70RD-14

170-C107RD-14

170-C107RD-14

170-C107RD-14

170-C107RD-14

A272-C35BK-14

A272-C35BK-14

A272-C35BK-14

A272-C35BK-14

A272-C35BK-14

A272-C35BK-14

139-C277RD-16

139-C277RD-16

139-C277RD-16

139-C277RD-16

139-C277RD-16

139-C277RD-16

139-C277RD-16139-C277RD-16

139-C277RD-16

131-C265BR-18

131-C265BR-18

131-C265BR-18131-C265BR-18

131-C265BR-18

131-C265BR-18

131-C265BR-18131-C265BR-18

131-C265BR-18

141-C285PK-16

141-C285PK-16141-C285PK-16

141-C285PK-16

141-C285PK-16

141-C285PK-16141-C285PK-16

105-C259RD-16

105-C259RD-16105-C259RD-16

105-C259RD-16

105-C259RD-16

105-C259RD-16

105-C259RD-16

105-C259RD-16

105-C259RD-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

168-C68GN-16

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

164-C264WH-18

115-C280PK-16

115-C280PK-16115-C280PK-16

115-C280PK-16

115-C280PK-16

115-C280PK-16115-C280PK-16

130-C5RD-16

130-C5RD-16

130-C5RD-16

130-C5RD-16

130-C5RD-16

130-C5RD-16130-C5RD-16

130-C5RD-16

130-C5RD-16

118-C258GY-16

118-C258GY-16

118-C258GY-16

118-C258GY-16

147-C73RD-18

147-C73RD-18147-C73RD-18

147-C73RD-18

147-C73RD-18

147-C73RD-18

147-C73RD-18

147-C73RD-18

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

518-C329OR-16

538-C331BR-16

538-C331BR-16

538-C331BR-16

538-C331BR-16

538-C331BR-16

538-C331BR-16

606-C88GY-16

606-C88GY-16

606-C88GY-16

606-C88GY-16

606-C88GY-16

605-C90YL-16

605-C90YL-16

605-C90YL-16

605-C90YL-16

605-C90YL-16

615-C291YL-14

615-C291YL-14

615-C291YL-14

615-C291YL-14

615-C291YL-14

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

646-C293OR-18

647-C290GN-18

647-C290GN-18

647-C290GN-18

647-C290GN-18

647-C290GN-18

647-C290GN-18

647-C290GN-18

647-C290GN-18647-C290GN-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C144OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

944-C28OR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C136BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

945-C17BR-18

136-C310GN-16

136-C310GN-16

136-C310GN-16

136-C310GN-16

136-C310GN-16

136-C310GN-16136-C310GN-16

136-C310GN-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

A541-C327PU-16

138-C37GN-18

138-C37GN-18

138-C37GN-18

138-C37GN-18

138-C37GN-18138-C43GN-18

138-C43GN-18

138-C43GN-18

138-C43GN-18

138-C43GN-18

200-C311BK-18

200-C311BK-18

200-C311BK-18

200-C311BK-18

200-C311BK-18

200-C204BK-14

200-C204BK-14

200-C204BK-14

200-C204BK-14

200-C309BK-16

200-C309BK-16

200-C309BK-16

200-C309BK-16

122-C279RD-16

122-C279RD-16

122-C279RD-16

122-C279RD-16

122-C279RD-16

122-C279RD-16

122-C279RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

122-C278RD-16

164-C276WH-18

164-C276WH-18

164-C276WH-18

164-C276WH-18

164-C276WH-18

164-C276WH-18

164-C276WH-18108-C271BU-14

108-C271BU-14

108-C271BU-14

108-C271BU-14

108-C271BU-14

108-C271BU-14

108-C271BU-14

TWISTED WIRES

118-C275GY-18

118-C275GY-18

118-C275GY-18

118-C275GY-18

118-C275GY-18

118-C275GY-18

STRAP AS.

ECM MOUNT BOLT

ECM MOUNT BOLT

200-C288BK-18

H709-C158BU-18

H708-C157OR-18

614-C94PU-18

PANEL B

IMPLEMENT POD

102-C248RD-14

614-C330PU-16

614-C330PU-16

H795-C222PK-18

H795-C222PK-18

H795-C222PK-18

509-C340WH-18

509-C340WH-18

509-C340WH-18

509-C340WH-18

515-F7GY-14

515-F7GY-14

515-F8GY-14

515-F8GY-14

H722-C301GN-18

H722-C301GN-18

H722-C301GN-18

H722-C301GN-18

H722-C301GN-18

164-G8WH-18

164-G8WH-18C216-G9BK-18C216-G9BK-18H711-G10GN-18

H711-G10GN-18

H711-G10GN-18

H710-G13PK-18

H710-G13PK-18

H710-G13PK-18 H722-G3GN-18

H722-G3GN-18

H722-G3GN-18

200-G4BK-16

320-G7OR-16

320-G7OR-16

H795-C222PK-18

102-C248RD-14102-C131RD-16

102-C131RD-16

102-C131RD-16

537-C16GN-16

537-C16GN-16537-C305GN-16

537-C305GN-16

537-C305GN-16

124-C23GN-14

124-C23GN-14

124-C23GN-14

124-C23GN-14

124-C23GN-14

124-C23GN-14

124-C23GN-14

124-C23GN-14

C542-C393GN-16

C542-C393GN-16

C542-C393GN-16

C583-C395GN-18

C583-C395GN-18

C583-C395GN-18

141-C397PK-16

141-C397PK-16

202-C396BK-18

202-C396BK-18

T859-C176WH-18

T858-C175GY-18

134-C337YL-14

134-C337YL-14

134-C337YL-14134-C337YL-14

134-C337YL-14

134-C337YL-14

134-C337YL-14134-C337YL-14

134-C337YL-14

127-C336OR-14

127-C336OR-14

127-C336OR-14127-C336OR-14

127-C336OR-14

127-C336OR-14

127-C336OR-14 127-C336OR-14

127-C336OR-14

320-C390OR-16

320-C390OR-16

320-C390OR-16

320-C390OR-16

320-C390OR-16

C216-C365BK-18

C216-C365BK-18

202-C358BK-18

202-C358BK-18

202-C358BK-18

202-C351BK-18

202-C351BK-18

202-C351BK-18

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

A629-C300BU-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

651-C239PK-14

200-G17BK-16

200-G17BK-16

320-G18OR-16

320-G18OR-16

320-G19OR-16

320-G19OR-16

C542-C393GN-16

121-EG1RD-18

121-EG1RD-18

121-EG1RD-18

115-EG2PK-18

115-EG2PK-18

115-EG4PK-18

115-EG4PK-18

200-EG3BK-18

200-EG3BK-18

200-EG5BK-18

200-EG5BK-18

200-EG10BK-18200-EG6BK-18

115-EG9PK-18

115-EG12PK-18

142-EG8BU-18

142-EG8BU-18142-EG11BU-18142-EG7BU-18

200-EG10BK-18142-EG11BU-18115-EG9PK-18

115-EG12PK-18

142-EG7BU-18200-EG6BK-18

IMPLEMENT POD (JOYSTICK)

IMPLEMENT POD (JOYSTICK)

CUSTOMERDATA

CONNECTION

200-N4BK-18

200-N4BK-18

251-N6BK-18

251-N6BK-18

138-N11GN-18

138-N11GN-18

138-N5GN-18

138-N5GN-18

C529-N8GY-18

C529-N8GY-18

C530-N9BU-18

C530-N9BU-18

614-N3PU-18

614-N3PU-18

944-N1OR-18

944-N1OR-18

945-N2BR-18

945-N2BR-18

E416-N7PU-18

E416-N7PU-18

818-N12BR-18

250-N14BK-18819-N13GY-18

251-N15BK-18

251-N15BK-18

188-N16WH-18

188-N16WH-18

E955-N10OR-18

E955-N10OR-18

TWISTEDWIRES

118-C352GY-18118-C355GY-18

C530-C61BU-18

A525-C238GN-18A524-C237BR-18

517-C240BU-14

614-C94PU-18

503-C256BR-18504-C255YL-18

515-C235GY-14516-C241GN-14

502-C253OR-18

720-C234PU-18

T857-C156GN-18

G766-C189GN-18

P976-C77BR-16

G767-C190WH-18

H709-C158BU-18

168-C68GN-16

138-C37GN-18138-C43GN-18

124-C23GN-14

C216-C365BK-18

C583-C395GN-18

505-C254BU-18506-C10PU-18

500-C252BR-18

507-C11WH-18

202-C396BK-18

A523-C236PU-18

202-C350BK-18

H708-C157OR-18

727-C289GN-16

T856-C155WH-18

501-C257GN-18

T859-C176WH-18

973-C195BR-18977-C197YL-18

521-C124YL-14

X974-C200BR-18

X972-C188GN-18

H728-C198GN-18H729-C63WH-18

T855-C166BU-18

T852-C163GY-18

H730-C201BR-18

T854-C165YL-18T853-C164OR-18

X973-C192BU-18

P910-C38BR-18

118-C354GY-18

118-C354GY-18

118-C354GY-18118-C353GY-18

118-C353GY-18

118-C353GY-18

200-C384BK-18

200-C384BK-18

200-C384BK-18

H710-C171PK-18

126-C299PK-16

126-C299PK-16126-C299PK-16

126-C299PK-16

126-C299PK-16

126-C299PK-16

126-C299PK-16

126-C299PK-16

126-C299PK-16

614-C7PU-18

614-C7PU-18

614-C7PU-18

G750-CR3BU-16 G750-CR3BU-16G755-CR4GY-16 G755-CR4GY-16

517-F10BU-14

TWISTEDPAIR

603-C297PK-16

603-C297PK-16

603-C297PK-16

603-C297PK-16

603-C297PK-16

603-C297PK-16

603-C297PK-16

603-C297PK-16

419-C118YL-18

419-C118YL-18

419-C118YL-18

419-C118YL-18

200-C415BK-16200-C415BK-16

200-C415BK-16

615-C318YL-18

615-C318YL-18

615-C318YL-18

615-C318YL-18

615-C318YL-18

615-C318YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

910-C15YL-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

436-C47OR-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

G480-C316GN-18

147-C177RD-16

147-C177RD-16

147-C177RD-16

147-C177RD-16

147-C177RD-16

147-C177RD-16

147-C177RD-16

147-C177RD-16

200-C413BK-16

200-C413BK-16

200-C413BK-16

411-C243PK-18

411-C243PK-18

411-C243PK-18

411-C243PK-18

611-C424PU-18

611-C424PU-18

611-C424PU-18

200-C414BK-16

200-C414BK-16

200-C414BK-16

430-C313BU-18

430-C313BU-18

430-C313BU-18

430-C313BU-18

430-C313BU-18

430-C313BU-18

430-C313BU-18

G850-C29BU-18

G850-C29BU-18

G850-C29BU-18

G850-C29BU-18

G850-C29BU-18

G850-C29BU-18

G850-C29BU-18

G479-C315WH-18

G479-C315WH-18

G479-C315WH-18

G479-C315WH-18

G479-C315WH-18

G479-C315WH-18

G479-C315WH-18

T864-C180BR-18

T864-C180BR-18

T864-C180BR-18

T864-C180BR-18

T864-C180BR-18

T864-C180BR-18

T864-C180BR-18

T862-C182BU-18

T862-C182BU-18

T862-C182BU-18

T862-C182BU-18

T862-C182BU-18

T862-C182BU-18

T862-C182BU-18

T863-C179PU-18

T863-C179PU-18

T863-C179PU-18

T863-C179PU-18

T863-C179PU-18

T863-C179PU-18

T863-C179PU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18

633-C328BU-18 633-C328BU-18

E707-C440GN-18E707-C440GN-18

E707-C440GN-18

201-C419BK-18

201-C419BK-18

201-C419BK-18E708-C443PK-18E708-C443PK-18

E708-C443PK-18

C413-C436YL-18

C413-C436YL-18

C413-C436YL-18

C414-C438BU-18

C414-C438BU-18

C414-C438BU-18

663-C433GY-18

663-C433GY-18

663-C433GY-18

200-C411BK-18

200-C411BK-18

200-C411BK-18

200-C406BK-18

200-C406BK-18

200-C406BK-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

661-C296GN-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

662-C295YL-18

200-C412BK-18

200-C412BK-18

200-C412BK-18

E707-C441GN-18

E707-C441GN-18

E707-C441GN-18

201-C420BK-18

201-C420BK-18

201-C420BK-18E708-C442PK-18

E708-C442PK-18

E708-C442PK-18

C413-C437YL-18

C413-C437YL-18

C413-C437YL-18

C414-C439BU-18

C414-C439BU-18

C414-C439BU-18

663-C432GY-18

663-C432GY-18

663-C432GY-18

200-C410BK-18

200-C410BK-18

200-C410BK-18

663-C262GY-18

663-C262GY-18

663-C262GY-18

663-C262GY-18

663-C262GY-18

663-C262GY-18

663-C262GY-18

E708-C247PK-18

E708-C247PK-18

E708-C247PK-18

C413-C251YL-18

C413-C251YL-18

C413-C251YL-18

C414-C244BU-18

C414-C244BU-18

C414-C244BU-18

E707-C250GN-18

E707-C250GN-18

E707-C250GN-18

411-C243PK-18

E708-C247PK-18

C413-C251YL-18C414-C244BU-18E707-C250GN-18

E707-C250GN-18

C413-C251YL-18C414-C244BU-18

411-C243PK-18

E708-C247PK-18

411-C243PK-18

C413-C251YL-18

E708-C247PK-18

C414-C244BU-18

E707-C250GN-18

411-C243PK-18

T901-C487YL-18T902-C488PK-18

614-C76PU-18

614-C76PU-18

614-C76PU-18

614-C92PU-18

614-C92PU-18

614-C92PU-18614-C74PU-18

614-C74PU-18

614-C137PU-16

614-C137PU-16

614-C137PU-16

614-C137PU-16

614-C169PU-18

614-C169PU-18

614-C169PU-18

614-C145PU-16

614-C215PU-18

614-C215PU-18

614-C215PU-18

614-C216PU-18

614-C216PU-18

614-C216PU-18

614-C242PU-18

614-C242PU-18

614-C242PU-18

614-C245PU-18

614-C245PU-18

614-C245PU-18

200-C324BK-18

200-C324BK-18

200-C324BK-18

200-C356BK-18

200-C356BK-18

200-C356BK-18200-C357BK-18

200-C357BK-18

200-C357BK-18

200-C363BK-18

200-C363BK-18

200-C363BK-18

200-C362BK-18

200-C362BK-18

200-C362BK-18

200-C138BK-18

200-C138BK-18

200-C138BK-18

200-C104BK-18

200-C104BK-18

200-C104BK-18

200-C359BK-18

200-C359BK-18

200-C359BK-18

200-C338BK-18

200-C338BK-18

200-C338BK-18

614-C330PU-16

614-C6PU-18

614-C6PU-18

614-C6PU-18

614-C232PU-18

614-C232PU-18

614-C232PU-18

200-C332BK-18

200-C332BK-18

200-C332BK-18

200-C261BK-18

200-C261BK-18

200-C261BK-18

614-C93PU-18

614-C93PU-18

614-C93PU-18

614-C199PU-18

614-C199PU-18

614-C199PU-18

614-C199PU-18

614-C199PU-18

614-C321PU-18

614-C321PU-18

614-C321PU-18

614-C321PU-18

614-C321PU-18

200-C369BK-18

200-C369BK-18

200-C369BK-18

200-C369BK-18

200-C369BK-18

200-C370BK-18

200-C370BK-18

200-C370BK-18

200-C370BK-18

200-C370BK-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

G848-C378GN-18

TWISTED WIRES

TWISTED WIRES

201-C9BK-16

201-C9BK-16

201-C9BK-16

TWISTEDWIRES

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

113-C12OR-16

944-C379OR-18

944-C379OR-18

944-C379OR-18

944-C379OR-18

944-C379OR-18

944-C379OR-18

944-C379OR-18

944-C379OR-18

447-C380PK-18

447-C380PK-18

447-C380PK-18

447-C380PK-18

447-C380PK-18

447-C380PK-18447-C380PK-18

442-C381GY-18

442-C381GY-18

442-C381GY-18

442-C381GY-18

442-C381GY-18

442-C381GY-18

442-C381GY-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

410-C382WH-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

945-C383BR-18

G485-C385BU-18

G485-C385BU-18

G485-C385BU-18

G485-C385BU-18

G485-C385BU-18

G485-C385BU-18

G485-C385BU-18

432-C387PK-18

432-C387PK-18

432-C387PK-18

432-C387PK-18

432-C387PK-18

432-C387PK-18

432-C387PK-18

G486-C388GN-18

G486-C388GN-18

G486-C388GN-18

G486-C388GN-18

G486-C388GN-18

G486-C388GN-18

G486-C388GN-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

290-C391BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

291-C404BK-18

443-C399YL-18

443-C399YL-18

443-C399YL-18

443-C399YL-18

443-C399YL-18

443-C399YL-18

443-C399YL-18

403-C401GN-18

403-C401GN-18

403-C401GN-18

403-C401GN-18

403-C401GN-18

403-C401GN-18

426-C402BR-18

426-C402BR-18

426-C402BR-18

426-C402BR-18

426-C402BR-18

426-C402BR-18

426-C402BR-18

E455-C403BR-18

E455-C403BR-18

E455-C403BR-18

E455-C403BR-18

E455-C403BR-18

E455-C403BR-18

E455-C403BR-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

E701-C405PK-18

C583-C395GN-18

C583-C395GN-18

C583-C395GN-18

C583-C395GN-18

C583-C395GN-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

C543-C407GY-18

202-C284BK-18

202-C284BK-18

202-C284BK-18

PRODUCT LINK ATTACHMENT

110-C66RD-14

110-C66RD-14

110-C66RD-14

110-C66RD-14

110-C66RD-14

110-C66RD-14

322-CR2GY-16

150-C97OR-16

150-C97OR-16

150-C97OR-16

150-C97OR-16

150-C97OR-16

150-C98OR-16

170-C99RD-14

170-C99RD-14

170-C99RD-14

170-C99RD-14

104-C46YL-16

104-C46YL-16

104-C46YL-16

104-C46YL-16104-C46YL-16

104-C46YL-16

164-G8WH-18

A105-G1OR-18

A105-G1OR-18

A105-G1OR-18

X998-G5BR-18

X998-G5BR-18

X998-G5BR-18

X998-C154BR-18

X998-C154BR-18

X998-C154BR-18

X998-C154BR-18

A105-C151OR-18

A105-C151OR-18

A105-C151OR-18

A105-C151OR-18

E746-C44GN-18

E746-C44GN-18

E746-C44GN-18

E746-C44GN-18 202-E3BK-18

202-E3BK-18

E746-E23GN-18

E746-E23GN-18

E746-E23GN-18

G762-C231BR-18

G762-C231BR-18

G762-C231BR-18

G762-C231BR-18

G762-C231BR-18

G762-C231BR-18

G761-C229YL-18

G761-C229YL-18

G761-C229YL-18

G761-C229YL-18

G761-C229YL-18

G761-C229YL-18

H718-C225GY-18

H718-C225GY-18

H718-C225GY-18

H718-C225GY-18

H718-C225GY-18

210-C178BK-14

210-C178BK-14

200-C21BK-18

200-C21BK-18

200-C21BK-18

200-C21BK-18

413-C33BR-18

413-C33BR-18

413-C33BR-18

413-C33BR-18

413-C33BR-18

413-C33BR-18

413-C33BR-18

210-C173BK-14

210-C173BK-14

210-C269BK-14

210-C269BK-14

P945-C270OR-18

P945-C270OR-18

P945-C270OR-18

P945-C270OR-18

P945-C270OR-18

P946-C303BR-18

P946-C303BR-18

P946-C303BR-18

P946-C303BR-18

P946-C303BR-18

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C408BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C409BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

A273-C417BK-14

J764-C273BR-18

J764-C273BR-18

J764-C273BR-18

202-C71BK-18

202-C71BK-18

202-C71BK-18

G787-C418GN-18

G787-C418GN-18

G787-C418GN-18

G787-C418GN-18

G787-C418GN-18

G787-C418GN-18

P916-C421OR-18

P916-C421OR-18

P916-C421OR-18

P916-C421OR-18

P916-C421OR-18

P916-C421OR-18

P915-C422PK-18

P915-C422PK-18

P915-C422PK-18

P915-C422PK-18

P915-C422PK-18

P915-C422PK-18

P915-C422PK-18

G788-C423YL-18

G788-C423YL-18

G788-C423YL-18

G788-C423YL-18

G788-C423YL-18

G788-C423YL-18

G788-C423YL-18

Y794-C425OR-18

Y794-C425OR-18

Y795-C426GN-18

Y795-C426GN-18

Y794-C431OR-18

Y795-C434GN-18

Y794-C374OR-18

Y794-C374OR-18

Y794-C374OR-18

Y794-C374OR-18

Y795-C375GN-18

Y795-C375GN-18

Y795-C375GN-18

Y795-C375GN-18

G787-C418GN-18

202-C71BK-18P916-C421OR-18

Y794-C435OR-18

Y794-C435OR-18

Y794-C435OR-18

Y794-C435OR-18

Y794-C435OR-18

Y795-C444GN-18

Y795-C444GN-18

Y795-C444GN-18

Y795-C444GN-18

Y795-C444GN-18

Y795-C447GN-18Y795-C447GN-18

Y794-C445OR-18

Y795-C448GN-18

Y795-C448GN-18

Y795-C448GN-18

Y794-C449OR-18

Y794-C449OR-18

Y794-C449OR-18

Y794-C450OR-18

Y794-C450OR-18

Y794-C450OR-18

Y794-C450OR-18

Y795-C451GN-18

Y795-C451GN-18

Y795-C451GN-18

Y795-C451GN-18

Y795-C453GN-18

105-C455RD-16

105-C455RD-16

105-C455RD-16

105-C455RD-16

105-C455RD-16

105-C455RD-16

105-C455RD-16

105-C455RD-16

104-C456YL-16

104-C456YL-16

104-C456YL-16

104-C456YL-16

104-C456YL-16

105-C455RD-16

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

944-C458OR-18

945-C459BR-18

945-C459BR-18

945-C459BR-18

945-C459BR-18

945-C459BR-18

945-C459BR-18

945-C459BR-18945-C459BR-18

201-C304BK-16

201-C304BK-16

201-C304BK-16

201-C304BK-16

201-C304BK-16

G787-E5GN-18

G787-E5GN-18

G787-E5GN-18

202-E6BK-18

202-E6BK-18

P916-E10OR-18

P916-E10OR-18

P916-E10OR-18

P915-E13PK-18

P915-E13PK-18

P915-E13PK-18

G788-E14YL-18

G788-E14YL-18

G788-E14YL-18

Y794-C25OR-18

Y794-C25OR-18

Y794-C25OR-18

Y794-C25OR-18

Y795-C114GN-18

Y795-C114GN-18

Y795-C114GN-18

Y795-C114GN-18

TWISTED WIRES

G761-C229YL-18

G761-C229YL-18

G761-C229YL-18

G762-C231BR-18

G762-C231BR-18

G762-C231BR-18

E746-C44GN-18

E746-C44GN-18

E746-C44GN-18

614-E4PU-18

614-E4PU-18

200-G4BK-16

C216-G2BK-18

C216-G2BK-18

200-E18BK-18

200-E18BK-18

200-E22BK-16200-E22BK-16200-E8BK-16

200-E8BK-16

E746-G6GN-18

E746-G6GN-18

E746-G6GN-18

J809-C460BK-18

J809-C460BK-18

J809-C460BK-18

J809-C460BK-18

J808-C194BK-18

J808-C194BK-18

J808-C194BK-18

J808-C194BK-18

J807-C193BK-18

J807-C193BK-18

J807-C193BK-18

J807-C193BK-18

403-C123GN-18

403-C123GN-18

403-C457GN-18

403-C457GN-18

403-C457GN-18

403-C457GN-18

403-C457GN-18

614-C181PU-18

614-C181PU-18

614-C181PU-18

614-C181PU-18

P990-C461BR-18

P990-C461BR-18

P990-C461BR-18

P990-C461BR-18

T861-E24YL-18

T861-E24YL-18

T861-E24YL-18

T860-E25OR-18

T860-E25OR-18

T860-E25OR-18

C216-E26BK-18

C216-E26BK-18

T861-G11YL-18

T861-G11YL-18

T861-G11YL-18T860-G12OR-18 T860-G12OR-18 T860-G12OR-18

C216-G14BK-18

C216-G14BK-18AUTODIG TRIGGER SW

403-C81GN-18

403-C81GN-18

614-C371PU-18

614-C371PU-18

614-C371PU-18

540-C430WH-18

540-C430WH-18

540-C430WH-18

540-C430WH-18

540-C430WH-18

540-C430WH-18

539-C429BU-18

539-C429BU-18

539-C429BU-18

539-C429BU-18

539-C429BU-18

539-C429BU-18

538-C446BR-18

538-C446BR-18

538-C446BR-18

610-C333OR-14

610-C333OR-14

610-C333OR-14

610-C333OR-14

610-C333OR-14

610-C333OR-14

J815-C84BK-14

J815-C84BK-14

J815-C84BK-14

K927-C108BU-18

K927-C108BU-18

K927-C108BU-18

K927-C108BU-18

K927-C108BU-18

201-C135BK-18

201-C135BK-18

201-C135BK-18

J813-C226BK-14

J813-C226BK-14

J813-C226BK-14

J813-C226BK-14

J813-C226BK-14

J814-C286BK-14

J814-C286BK-14

J814-C286BK-14

J814-C286BK-14

J814-C286BK-14

512-C223GN-18

512-C223GN-18

512-C223GN-18

512-C223GN-18

512-C223GN-18

512-C223GN-18

512-C223GN-18

512-C223GN-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

511-C306BR-18

200-C208BK-16

200-C208BK-16

200-C208BK-16

200-C208BK-16

200-C230BK-12

200-C230BK-12

200-C230BK-12

200-C230BK-12200-C230BK-12

200-C260BK-12

200-C260BK-12

200-C260BK-12

200-C260BK-12

200-C260BK-12

200-C260BK-12

512-C223GN-18

200-C230BK-12

C542-C323GN-18

C542-C323GN-18

C542-C323GN-18

C542-C323GN-18

C542-C323GN-18

308-C87YL-18

308-C87YL-18

538-C331BR-16

G787-G15GN-18

202-G16BK-18

P916-G20OR-18P915-G21PK-18G788-G22YL-18

614-G24PU-18

614-G24PU-18

200-G23BK-18

200-G23BK-18

G788-G22YL-18

P915-G21PK-18P916-G20OR-18202-G16BK-18G787-G15GN-18

G788-G22YL-18

P915-G21PK-18P916-G20OR-18

G787-G15GN-18

200-G25BK-16

200-G25BK-16

E735-C86PU-18

E735-C86PU-18

E735-C86PU-18

E735-C86PU-18

E735-C86PU-18

E735-C86PU-18

E735-C86PU-18

E735-C132PU-18

E735-C132PU-18

E735-C132PU-18

E735-C55PU-18

E735-C55PU-18

E735-C55PU-18

200-C45BK-18

200-C45BK-18

200-C45BK-18

614-C64PU-18

614-C64PU-18

614-C64PU-18

201-C347BK-18

201-C347BK-18

201-C347BK-18

201-C347BK-18

201-C347BK-18

201-C347BK-18

201-C348BK-16

201-C348BK-16

201-C348BK-16

201-C348BK-16

201-C348BK-16

201-C348BK-16

567-C360WH-14

567-C360WH-14

567-C360WH-14

567-C360WH-14

567-C360WH-14

567-C360WH-14

567-C473WH-14

567-C473WH-14

567-C473WH-14

567-C473WH-14

567-C473WH-14

567-C473WH-14

567-C364WH-14

567-C364WH-14

567-C364WH-14

567-C364WH-14

567-C364WH-14

567-C364WH-14

567-C372WH-14

567-C372WH-14

567-C372WH-14

567-C372WH-14

567-C372WH-14

567-C372WH-14

C216-C373BK-18

C216-C367BK-18

C216-C367BK-18

C216-C367BK-18

C216-C349BK-18

C216-C349BK-18

C216-C349BK-18

C216-C376BK-18

C216-C376BK-18

C216-C376BK-18

C216-C386BK-18

C216-C386BK-18

C216-C386BK-18

202-E27BK-18

202-E27BK-18

202-E28BK-18

202-E28BK-18

614-E29PU-18

614-E29PU-18

614-E30PU-18

614-E30PU-18

200-E31BK-18

200-E31BK-18

C216-C217BK-18

C216-C217BK-18

C216-C217BK-18

C216-C217BK-18

C216-C217BK-18

200-C320BK-18

200-C320BK-18

200-C320BK-18

200-C320BK-18

200-C320BK-18

614-C322PU-18

614-C322PU-18

614-C322PU-18

614-C322PU-18

614-C322PU-18

614-C325PU-16

614-C325PU-16

614-C325PU-16

614-C325PU-16

202-G26BK-18202-G26BK-18

200-G27BK-18

200-G27BK-18

614-G28PU-18

614-G28PU-18

614-G29PU-18

614-G29PU-18

113-C389OR-16

113-C389OR-16

200-C454BK-16

200-C454BK-16

200-C454BK-16

200-C454BK-16614-C462PU-18

614-C462PU-18

614-C462PU-18

614-C462PU-18

614-C462PU-18

108-AT1BU-14200-AT2BK-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

124-C464GN-14

538-C465BR-16

538-C465BR-16

538-C465BR-16

200-C467BK-18

200-C467BK-18

200-C467BK-18

202-C85BK-18

202-C85BK-18

202-C85BK-18

202-C366BK-18

202-C366BK-18

202-C366BK-18

200-C468BK-18

200-C468BK-18

200-C468BK-18

200-C468BK-18

200-C468BK-18

614-C469PU-18

614-C469PU-18

614-C469PU-18

614-C469PU-18

614-C469PU-18

200-C474BK-18

200-C474BK-18

200-C474BK-18

614-C477PU-18

614-C477PU-18

614-C477PU-18

H703-C478YL-18

H703-C478YL-18

H703-C478YL-18

H703-C478YL-18

H703-C478YL-18

H703-C478YL-18

H703-C478YL-18

H702-C479PU-18

H702-C479PU-18

H702-C479PU-18

H702-C479PU-18

H702-C479PU-18

H702-C479PU-18

H702-C479PU-18

H795-C480PK-18

H795-C480PK-18

H795-C481PK-18

H795-C481PK-18

H795-C481PK-18

H795-C481PK-18

H795-C481PK-18

H795-C481PK-18

614-C482PU-18

614-C482PU-18

614-C482PU-18

200-C483BK-18

200-C483BK-18

200-C483BK-18

P976-C485BR-16

P976-C485BR-16

P976-C486BR-16

P976-C486BR-16

200-C484BK-16

200-C484BK-16

200-C484BK-16

G848-C378GN-18

141-C14PK-18

141-C14PK-18

151-C489GN-16

151-C489GN-16

P739-C493BU-16

P739-C493BU-16

P739-C493BU-16

P739-C493BU-16P739-C493BU-16

P739-C493BU-16

J887-C490PU-18

J887-C490PU-18

J887-C490PU-18

J887-C490PU-18J887-C490PU-18

J887-C490PU-18

J887-C490PU-18

J887-C490PU-18

J815-C492BK-14

J815-C492BK-14

J815-C491BK-18

J815-C491BK-18

J815-C491BK-18 J815-C491BK-18

J815-C491BK-18

J815-C491BK-18

J815-C491BK-18

961-C495BR-18

961-C495BR-18

961-C495BR-18

961-C495BR-18

961-C495BR-18

961-C495BR-18

961-C495BR-18

200-C499BK-18

200-C499BK-18

200-C499BK-18

200-C498BK-18

200-C498BK-18

200-C498BK-18

200-C502BK-18

200-C502BK-18

200-C502BK-18

614-C497PU-18

614-C497PU-18

614-C497PU-18

614-C500PU-18

614-C500PU-18

614-C500PU-18

614-C501PU-18

614-C501PU-18

614-C501PU-18

964-C496BU-18

964-C496BU-18

964-C496BU-18

964-C496BU-18

964-C496BU-18

964-C496BU-18 762-C494YL-18

762-C494YL-18

762-C494YL-18

762-C494YL-18

762-C494YL-18

762-C494YL-18

762-C494YL-18

964-C496BU-18

944-A3OR-18945-A4BR-18

200-A2BK-18147-A1RD-18

J764-C273BR-18

J764-C273BR-18

Y794-C95OR-18

Y795-C139GN-18 Y795-C503GN-18

Y795-C503GN-18

Y795-C503GN-18

Y794-C466OR-18

Y794-C466OR-18

Y794-C466OR-18

Y794-A6OR-18Y794-A6OR-18

Y795-A5GN-18Y795-A5GN-18

200-C341BK-16

200-C341BK-16

592-C202BU-16

592-C202BU-16

592-C202BU-16

592-C202BU-16

592-C202BU-16

AUTOLUBE CONNECTION

987-C160WH-16

987-C160WH-16

987-C160WH-16

987-C160WH-16

987-C160WH-16

987-C160WH-16

151-C159GN-16

151-C159GN-16

151-C159GN-16

151-C159GN-16

151-C159GN-16

151-C159GN-16

151-C159GN-16151-C159GN-16

200-C504BK-18

200-C504BK-18

200-C504BK-18

614-C505PU-18

614-C505PU-18

614-C505PU-18

T969-C307YL-18

T969-C307YL-18

T969-C307YL-18

T969-C307YL-18

T969-C307YL-18

T969-C307YL-18

T969-C307YL-18

T970-C308GY-18

T970-C308GY-18

T970-C308GY-18

T970-C308GY-18

T970-C308GY-18

T970-C308GY-18

T970-C308GY-18

C216-C508BK-18

C216-C508BK-18

C216-C508BK-18

C216-C508BK-18

C216-C508BK-18

C216-C508BK-18

200-C509BK-18

200-C509BK-18

200-C509BK-18

200-C509BK-18

200-C509BK-18

439-C510YL-18

439-C510YL-18 439-C512YL-18

439-C512YL-18

439-C512YL-18

439-C512YL-18

439-C512YL-18

439-C512YL-18

439-C511YL-18

439-C511YL-18

439-C511YL-18

439-C511YL-18

439-C511YL-18

439-C511YL-18

439-C513YL-18

439-C513YL-18

439-C513YL-18

439-C513YL-18

439-C513YL-18

439-C513YL-18

200-C516BK-16

200-C516BK-16

200-C516BK-16

147-C65RD-16

147-C65RD-16

147-C514RD-18

147-C514RD-18

136-C515GN-16

136-C515GN-16

136-C515GN-16

136-C515GN-16

136-C515GN-16

136-C515GN-16

136-C515GN-16

136-C515GN-16

C542-CF1GN-14

C542-CF3GN-14200-CF2BK-14200-CF4BK-14

C542-CF1GN-14

200-CF2BK-14

C542-CF3GN-14

200-CF4BK-14

HEATED OUTSIDE MIRRORS HARNESS (ATTACHMENT)

CAB HID LIGHT HARNESS (ATTACHMENT)

200-CE2BK-14

200-CE8BK-14

200-CE3BK-14

200-CE4BK-14

200-CE3BK-14

200-CE4BK-14

651-CE1YL-14

651-CE7PK-14

A629-CE5BU-14

A629-CE5BU-14

A629-CE6BU-14

A629-CE6BU-14

615-CE9YL-14

615-CE9YL-14

615-CE11YL-14

615-CE11YL-14

608-CE15GN-14

608-CE13GN-14200-CE14BK-14

200-CE12BK-14

200-CE12BK-14

200-CE10BK-14

200-CE10BK-14

200-CE16BK-14

200-Y10BK-14

200-Y7BK-14

651-Y6PK-14

651-Y9PK-14

603-J1PK-14

200-J2BK-14

200-Y10BK-14200-Y7BK-14

651-Y6PK-14651-Y9PK-14

200-Y2BK-14

200-Y4BK-14608-Y3GN-14

608-Y1GN-14BEACON ATTACHMENT HARNESS

CAB LIGHT HARNESS

603-J1PK-14200-J2BK-14

ELECTRICAL STUDS PASSTHROUGH THE CAB ROOFCONNECT TO TERMINALSON THE CAB SCHEMATICPART NUMBERS:PILOT/HMU 186-0696EH/CCS 186-0623

ONE STUD FOR EACH CIRCUIT200,615,608(ATTACH),603(ATTACH)

200-Y2BK-14

200-Y4BK-14

608-Y1GN-14

608-Y3GN-14

AUOTDIG NOT AVAILABLE ON IT-62

IT-62 ONLY

950/962 ONLY

200-C519BK-14

201-C524BK-16

200-C527BK-18

200-C527BK-18

200-C527BK-18

614-C526PU-18

614-C526PU-18

614-C526PU-18

200-C528BK-14

TWISTED WIRES

TWISTED WIRES

TWISTED WIRES

TWISTEDWIRES

200-C529BK-16

200-C529BK-16

200-C529BK-16

200-C529BK-16

592-C122BU-16

592-C122BU-16

592-C122BU-16

592-C122BU-16

592-C122BU-16

592-C122BU-16

201-C525BK-16

A272-C35BK-14

201-C525BK-16

A273-C476BK-14

A273-C476BK-14

A273-C475BK-14

A273-C475BK-14

210-C533BK-14

210-C533BK-14

210-C532BK-14

210-C532BK-14

202-C27BK-18

202-C27BK-18

202-C27BK-18

202-C27BK-18

202-C19BK-18

202-C19BK-18

202-C19BK-18

200-C519BK-14

200-C312BK-16

200-C528BK-14

200-C521BK-12

200-C521BK-12

200-C520BK-14

200-C520BK-14

200-C208BK-16

200-C206BK-16

200-C206BK-16

200-C206BK-16

200-C534BK-12

200-C534BK-12200-C535BK-12

200-C535BK-12

200-C536BK-16

200-C536BK-16

200-C536BK-16

200-C536BK-16

200-C537BK-18

200-C537BK-18

200-C537BK-18

200-C537BK-18200-C538BK-18

200-C538BK-18

200-C538BK-18

200-C538BK-18

200-C539BK-18

200-C539BK-18

200-C539BK-18

200-C539BK-18200-C540BK-18

200-C540BK-18

200-C540BK-18

200-C540BK-18

614-C541PU-18

614-C541PU-18

614-C541PU-18614-C542PU-16

614-C543PU-16

202-C544BK-18

202-C544BK-18

202-C544BK-18

202-C544BK-18

C216-C545BK-18

C216-C545BK-18

C216-C545BK-18

C216-C545BK-18

P976-C485BR-16P976-C486BR-16

201-C524BK-16

201-C524BK-16

201-C524BK-16

201-C524BK-16

C216-C148BK-18C216-C148BK-18C216-C149BK-18C216-C149BK-18

202-C113BK-16

200-C548BK-16200-C546BK-16

200-C546BK-16

200-C546BK-16

200-C546BK-16

200-C547BK-12

200-C547BK-12

200-C547BK-12

200-C547BK-12

200-C547BK-12

200-C546BK-16

A272-C233BK-14

170-C101RD-14

170-C101RD-14

170-C101RD-14

170-C101RD-14

170-C101RD-14170-C146RD-14

170-C146RD-14

170-C146RD-14

170-C146RD-14

170-C146RD-14

X998-C154BR-18

T870-C167BR-18T869-C168WH-18

T861-C162YL-18T860-C161OR-18

H711-C172GN-18H710-C171PK-18

E918-C153GN-18E917-C152WH-18

A105-C151OR-18

Y795-C114GN-18Y794-C25OR-18

P946-C303BR-18P945-C270OR-18

K927-C108BU-18J814-C286BK-14J813-C226BK-14

H718-C225GY-18

H717-C67BR-18H714-C58OR-18H713-C57PK-18

E922-C54GN-18E921-C53PK-18E920-C52BR-18E919-C51YL-18

C530-C62BU-18C529-C60GY-18

C216-C26BK-16

C216-C148BK-18C216-C149BK-18

T866-C174YL-18

945-C134BR-18944-C141OR-18

150-C98OR-16

121-C150RD-14121-C133RD-14121-C170RD-14

138-C214GN-16

138-C214GN-16

138-C214GN-16

138-C214GN-16

138-C20GN-18

138-C20GN-18

121-C228RD-14 121-C228RD-14

121-C228RD-14

121-C228RD-14

121-C228RD-14121-C361RD-14

121-C361RD-14

121-C361RD-14

121-C361RD-14121-C361RD-14

115-C283PK-16115-C103PK-16

115-C368PK-16

115-C368PK-16

115-C368PK-16

118-C274GY-18

118-C274GY-18118-C463GY-14

118-C463GY-14

118-C463GY-14

118-C463GY-14

141-C397PK-16141-C14PK-18141-C470PK-16

141-C470PK-16

141-C470PK-16

150-C97OR-16

150-C97OR-16

150-C126OR-16

150-C126OR-16150-C471OR-16

150-C471OR-16

150-C471OR-16

150-C471OR-16

150-C471OR-16

200-C209BK-14

200-C209BK-14

200-C210BK-18

200-C210BK-18

A272-C35BK-14

201-C135BK-18

201-C135BK-18

201-C304BK-16

201-C304BK-16110-C472RD-14

110-C472RD-14

110-C472RD-14

110-C472RD-14

110-C472RD-14

110-C472RD-14

C542-C323GN-18C542-C506GN-16

C542-C506GN-16

C542-C506GN-16

C542-C506GN-16

C542-C506GN-16

C542-C506GN-16

202-G30BK-18

202-G30BK-18

608-C294GN-14

A958-C518WH-18

A958-C518WH-18

A958-C518WH-18

A958-C518WH-18

136-C517GN-16

136-C517GN-16

147-C36RD-16

147-C36RD-16

147-C36RD-16

147-C36RD-16

147-C36RD-16

TWISTED WIRES

TWISTEDPAIR

TWISTED WIRES

614-C74PU-18

Y794-C445OR-18

Y794-C452OR-18

Y794-C452OR-18

Y795-C453GN-18

202-G31BK-18

202-G31BK-18

TWISTED WIRES

125-WA18RD-18

125-WA18RD-18

308-WA22YL-18

308-WA22YL-18

200-WA20BK-18

200-WA20BK-18

403-WA24GN-18

403-WA24GN-18

308-WA21YL-18

308-WA21YL-18403-WA23GN-18403-WA23GN-18

200-WA19BK-18

200-WA19BK-18

125-WA17RD-18

125-WA17RD-18403-WA11GN-18

403-WA11GN-18

403-WA11GN-18

200-WA15BK-18

200-WA15BK-18

200-WA15BK-18

200-WA15BK-18

125-WA10RD-18

125-WA10RD-18

125-WA10RD-18

125-WA10RD-18

403-WA11GN-18

944-WA1OR-18

944-WA1OR-18

944-WA1OR-18

945-WA2BR-18

945-WA2BR-18

945-WA2BR-18

Y794-WA9OR-18

Y794-WA9OR-18

Y794-WA9OR-18

Y795-WA8GN-18

Y795-WA8GN-18

Y795-WA8GN-18

308-WA16YL-18

308-WA16YL-18

308-WA16YL-18

308-WA16YL-18

N957-WA3PK-18

N957-WA3PK-18

N957-WA3PK-18

N957-WA3PK-18

N960-WA4OR-18

N960-WA4OR-18

N960-WA4OR-18

N960-WA4OR-18

N979-WA7GN-18

N979-WA7GN-18

N979-WA7GN-18

N979-WA7GN-18

N970-WA5YL-18

N970-WA5YL-18

N970-WA5YL-18

N970-WA5YL-18

N973-WA6BR-18

N973-WA6BR-18

N973-WA6BR-18

N973-WA6BR-18

TWISTED WIRES

TWISTED WIRES

TWISTED WIRES

320-OR

200-WA25BK-16

200-WA25BK-16

200-WA25BK-16

200-WA25BK-16

200-H1BK-14

200-H3BK-14

200-H2BK-14

200-K1BK-14

200-K2BK-14

200-K3BK-14

615-H4YL-14

615-H5YL-14

615-H6YL-14

615-K4YL-14

615-K6YL-14

615-K5YL-14

200-K3BK-14

615-K5YL-14615-K6YL-14

200-K2BK-14

615-K5YL-14

615-K6YL-14

200-K3BK-14

200-K2BK-14

200-H2BK-14

615-H6YL-14615-H5YL-14

200-H3BK-14

200-H2BK-14615-H6YL-14

615-H5YL-14200-H3BK-14

608-Y1GN-14

608-Y3GN-14

200-Y4BK-14200-Y2BK-14

200-L2BK-14

200-L4BK-14

200-L4BK-14

200-L6BK-14200-L6BK-14

200-M2BK-14

200-M4BK-14

200-M6BK-14

608-M1GN-14

608-L1GN-14

608-L3GN-14608-L3GN-14 608-L5GN-14

608-L5GN-14

608-M3GN-14

608-M5GN-14

200-L4BK-14

200-L6BK-14

608-L3GN-14

608-L5GN-14

608-M3GN-14608-M5GN-14

200-M4BK-14200-M6BK-14

608-M3GN-14

608-M5GN-14

200-M6BK-14

200-M4BK-14

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C427RD-18

133-C428OR-16

133-C428OR-16

133-C428OR-16

133-C428OR-16

133-C428OR-16

133-C428OR-16

133-C428OR-16

133-C428OR-16 133-C428OR-16

105-C455RD-16201-C304BK-16

945-C459BR-18

N981-WA14GN-18

N981-WA14GN-18

N981-WA14GN-18

N963-WA12OR-18

N963-WA12OR-18

N963-WA12OR-18

N959-WA13PK-18

N959-WA13PK-18

N959-WA13PK-18 123456789101112

CR-C13E5179

12

CR-C31552264

345678

12

CF-C11552269

12

CF-C21552269 1

2

CE-C11552269

12

CE-C21552269

12

CE-C31552269

12

CE-C41552269

12

CE-C51552269

12

CE-C61552269

12

CE-C71552269

12

CE-C81552269

12345678

CA-C23E3388

12

CA-C11711653

345678

AB

A-C19W1951

CDEFGHJ

123456

A-C23E3382

123456

AY-C13E3381

12

AT-C13E3364

ACTION ALARM3E6328

PK-18BK-18

87a87

85

8630

FORWARD CAB FLOODLAMP RELAY3E5239

RD-14BK-14BR-14

TEMP SELECT POTENT127-4540

RD-16RD-16BK-16WH-16YL-16BU-16BR-16 WASH

PARKLOWHIGHGROUNDWASHER B+WIPER B+

FRONT INTER WIPER WASHER SW110-7886

-+ LH REAR SPEAKER

168-8772

BK-16WH-16RD-16

RH DOME LAMP3E-6389

BK-16WH-16RD-16 LH DOME LAMP

3E-6389

87a87

85

8630

FORWARD HORN RELAY3E5239

GND

B+P

T°

MOTOR

L

H

BR-16GY-16BK-16

OR-16

GN-16

REAR WIPER MOTOR1555789

G750-BU-18

G768-GN-18G760-WH-18G761-YL-18

G755-GY-18

G763-PU-18

UPSHIFT (NO)DOWNSHIFT (NC)

FORWARD SW

UPSHIFT (NC)REVERSE SW

NEUTRAL SW

G762-BR-18

202-BK-18 GROUND

DOWNSHIFT (NO)

XMSN SHIFTER SW AS151-7007

FORWARD HORN SW2T-3360

STOP LAMP SW105-6117

DIMMER SWNOTE:FOR JAPAN ROADING2H-1855

CAB GROUND 2

CAB GROUND 4ENG END FRAME GND

ANTENNA(C.B. RADIO)9U-2332

ANTENNA 1(AM/FM RADIO)9U-2331

KEY SW INPUT

OUT TO DASH BUCKET INDGROUND

HAZ SW INPUTOUT TO CHASSIS LIGHTS

24V FLASHER2178166

OUT TO DASH T/S IND

GND

B+ P

T°

MOTOR

L

H

BR-16GY-16BK-16

OR-16

GN-16

FRONT WIPER MOTOR189-8622

BR-16OR-16PU-16YL-16

STONOFF

BSC

R

KEY START SW110-7887

BR-16BU-16YL-16WH-16

B

WPL

H B

RD-16RD-16

REAR WIPER WASHER SW112-6174

BK-18PK-18BU-18GN-18BR-18 S4

S3S2S1COM

AUTODIG DIG MODE SW106-0107

-+ RH REAR SPEAKER

168-8772

WH-18BK-18OR-18 +V

GROUNDSIGNAL

LH BRAKE PEDAL SENSOR2675222

BK-18BK-18

FORWARD HORN SW 21701821

MOM

56

2

3

1

TURN SIGNAL SW134-9569

4

IMPLEMENT AUDIBLE ALERT1239694

TURN SIGNAL DIODES1729200

TURN SIGNAL DIODE189-3158

CAB GROUND 1

YL-18BK-18RD-18 +V

GROUNDSIGNAL

THROTTLE POSITION SENSOR204-7949

87a87

85

8630

REAR CAB FLOODLAMP RELAY3E5239

BK-16

BK-16BK-16BK-16

432

1

AUTO MANUAL GEAR SELECT CCS SW201-7952

BK-16 5

AUTO 1-4

AUTO 4

AUTO 2

MANUAL

BK-16 6

AUTO 3

BK-18BR-18WH-18 1 2

3 4

AUTODIG TRIGGER SW2658171

MOM

ANTENNA

+ BATTERY (MEM)

LEFT SPKR +GROUND

RIGHT SPKR -GY/BK

BKWHWH/BK

RDYL

GY

LEFT SPKR -

+ BATTERY (12V)

RIGHT SPKR +ATTACHEMENT RADIO173-6530

ECONOMY

BK-16

BK-16BK-16BK-16

432

POWER

MID

1

VARIABLE SHIFT CONTROL SW185-6335

UPPER CAB GROUND

MACHINE SECURITY SYSTEM ANTENNA206-5208

BKBK

MOTOR OPERATOR SEAT HEATER COMPRESSOR2373970OR-16

BK-16

12 VOLT CIGAR LIGHTER 198-6570

HEATER ELEMENT198-6571

12 VOLT ACCESSORY OUTLET117-2311

MOTOR WH/RD-14BK-14

BLOWER MOTOR1741497

RESISTOR9G1950

°T

THERMOSTAT3E5464

+

-

BLEND DOOR ACTUATOR MOTOR1776727

TCFUSE133-9012

RESISTOR 16 2 K

RESISTOR 22 4 K

+24V BATTERY IN+24V SWITCHED IN

GROUND+12V MEMORY OUT

+12V SWITCHED OUTGROUND

10A VOLTAGE CONVERTER2090381

WORK2

WORK1ROADING

PARK

OFF5

4

3

2

1

B3

B2

B1

RUNNING LAMP SW108-3320

OR-14BU-14BR-14YL-14GY-14PK-14GN-14PU-14

BLOWER MOTOR DIODE

HAZARD LAMPS SW236-4616

BEACON SWITCH237-9736

AUTODIG KICKOUT SET SW236-4621

MOM

HVAC BLOWER FAN SPD SW236-4611

LOWMED

HIGH

HVAC SELECT SW236-4610

HEAT

A/C

MODE SELECT SW236-4608

MOM

SECONDARY STEERING TEST SW236-4615

MOM

HEATED MIRROR SW236-4630

MOM

NEUTRALIZER OVERRIDE SW236-4609

MOM

LIFT TILT KICKOUT SET SW236-4619

MOM

MOM

+24V BATTERY IN+24V SWITCHED IN

GROUND+12V MEMORY OUT

+12V SW OUTGROUND

10A VOLTAGE CONVERTER (ATCH)2090381

THUMB ROLLER POWERTHUMB ROLLER GNDTHUMB ROLLER SIGNALCALIBRATEGND FOR SWITCH 1&2SWITCH 1 NOGND FOR TRIGGERSWITCH 2 NOSWITCH 1 AND/OR SWITCH 2 NCTRIGGER NOTRIGGER NC

+24VGNDSIGNAL X-AXIS (TILT)CALIBRATESIGNAL Y-AXIS (LIFT)CALIBRATE

UNUSED

IMPLEMENT JOYSTICK223-6306

FORWARD HORN ARC SUP2184935

DATAGROUND+12 V DISPLAY

WH-18BK-18

PCS KEYPAD149-3253

OR-18

PANEL LAMP 57N-5876

CAT DATA LINK -

LIFT PRESS. SNSR

+24V (IN)ROD END PRESS. SNSR

GROUND

TX OUT

LIFT POS SNSR

PCS ECM165-4077

GROUNDRX IN

CAT DATA LINK +

+ 24V SUPPLYKEYPAD DATA

GROUND

KEYSWITCH ON

CAT DATA LINK +

PILOT SOLENOID(1) BATTERY -

CAT DATA LINK -

(2) BATTERY -

GROUNDIMPL LOCKOUT SW (NO)IMPL LOCKOUT SW (NC)KICKOUT SET SW LIFT

(2) BATTERY +KICKOUT SET SW TILT

FINE MODULATION SW (NO)8V SENSOR PWR8V SENSOR RET

(3) BATTERY +RAISE SOLENOIDLOWER SOLENOID

PROPORTIONAL RETURNRACK SOLENOIDDUMP SOLENOID

SOLENOID RETURNPWM DR RET 11-12PWM DR RET 9-12(5) BATTERY -(3) BATTERY -

THIRD HE SOLENOIDTHIRD RE SOLENOID

PROPORTIONAL RETURNANTI-DRIFT LOWER SOLENOIDANTI-DRIFT DUMP SOLENOIDFINE MODULATION SW (NC)

BAT- (4)

SWB 2

ID CODE 2 (GND)

(1) BATTERY +

PILOT SOLENOID RETURN

AUTODIG OPERATOR TRIG INDAUTODIG AUTO TRIGGER INDAUTODIG RECORD MODE IND

DUMP DETENT

FUEL PRES IND LED

LIFT LEVER POSITION SENSORTILT LEVER POSITION SENSOR

THIRD LEVER POSITION SENSOR

AUTODIG OP MODE SW STEP (S1)AUTODIG OP MODE SW ON (S2)

AUTODIG KICKOUT SET SW (NO)

MACHINE CAN DATALINKMACHINE CAN DATALINK

IMPLEMENT ECM262-1408

AUTODIG KICKOUT SET SW (NC)ROTARY LIFT POSITION SENSOR

AUTODIG MODE SW #1AUTODIG MODE SW #2AUTODIG MODE SW #3AUTODIG MODE SW #4

AUTODIG TRIGGER SW (NO)AUTODIG TRIGGER SW (NC)

LIFT HE PRESSURE SENSOR

ROTARY TILT POSITION SENSOR

KEYSWITCH ONTOS SENSOR (A) +TOS SENSOR (A) -TOS SENSOR (B) +TOS SENSOR (B) -

CAT DATA LINK +

BACKUP ALARMBAT- (1)

CONVERTER OUTPUT SPD SNSR +CONVERTER OUTPUT SPD SNSR -

DIGITAL SENSOR RETURN

CAT DATA LINK -

XSMN OIL TEMP SENSORBAT- (2)

GROUNDHMU 2-4 OR CCS AUTO 4

AUTO/MANUAL SW - MANUALHMU 1-4 OR CCS AUTO 3

PRIMARY STEERING PRES SNSRSECOND STEERING PRES SNSR

BAT+ (4)BAT+ (2)

HMU 1 OR UPSHIFT SW(N/C) HMU 2 OR UPSHIFT SW(N/O)

HMU 3 OR DOWNSHIFT SW(N/C) HMU 4 OR DOWNSHIFT SW(N/O)

8V SENSOR RETBAT+(5)BAT+ (3)

CLUTCH 6 (SPEED1)CLUTCH 4 (SPEED3)

RET FOR SPD CLUTCHES #1-3CLUTCH 5 (SPEED2)

+ BATTERYREAR AXLE OIL TEMP SENDER

RET FOR SPD CLUTCH 4 & REV8V SENSOR RETURN

BAT- (3)

RETURN FOR FORWARD

CLUTCH 2 FORWARDIMPL POD DOWN SHIFT N/O

CLUTCH 3 (SPEED 4)

BAT- (4)

PASSIVE SPD +3PASSIVE SPD -3ALWAYS GROUNDEDID CODE 1(GND)

TORQUE CONVERTER TEMP SNSRFRONT AXLE OIL TEMP SENDER

BAT+ (1)

CLUTCH 1 REVERSEXMSN OIL FILTER BYPASS SW

KEYSWITCH STARTAXLE COOLER SOLENOID

RIDE CNTL SOL ON/OFF #3RIDE CNTL/AXLE COOLER RET

RIDE CTRL SOL ON/OFF #1RIDE CTRL SOL ON/OFF #2

START RELAYSTART RELAY/BACKUP ALM RET

SEC STEER INTMED RELAYHEATED MIRROR RELAY

RIDE CONTROL INDICATOR LEDMSS GREEN LEDMSS RED LED

ALTERNATOR R TERMINAL

LOW FUEL LVL WARN IND LEDXMSN OIL FILTER BYP IND LEDNEUTRALIZER DISABLE IND LED

DO NOT USEDIRECTION SW (NEUTRAL)

ENGINE SPD TACH WIRE (FREQ)PSV ANALOG IN 7

DIRECTION SW (REVERSE)HEATED MIRROR SWITCHXMSN OVERRIDE SWITCH

NEUTRALIZER DISABLE SWITCHVSC #1 (ECONOMY)

VSC #2 (MID)VSC #3 (POWER)

LEFT PEDAL POSITION SENSORSEC STER TEST SWITCH

PRIM STER PRESSURE SW (N/O)PRIM STER PRESSURE SW (N/C)

CCS AUTO 2REMOTE FNR INPUT 1REMOTE FNR INPUT 3REMOTE FNR INPUT 4REMOTE FNR INPUT 6

CCS AUTO 1-4RIDE CONTROL SW (NO)

RIDE CONTROL SW (AUTO)

DIRECTION SW (FORWARD)

PARK BRAKE SW-ENGAGEDPARK BRAKE SW-DISENGAGED

DIFF LOCK SW (N/O)DIFF LOCK SW (N/C)

SEC STEERING PRES SW (N/O)SEC STEERING PRES SW (N/C)CASE DRAIN OIL FILTER SW

CAN A +CAN A -

INJECTOR RETURN 7

PSV/ACT ANALOG IN 8

TRANSMISSION ECM262-1408

+V DISPLAYGROUNDCLOCKDATALOADHARNESS CODE

TACH SPEEDOMETER192-7049

OR-18BK-18GN-18WH-18YL-18BU-18

+V DISPLAYGROUNDCLOCKDATALOADHARNESS CODE

QUAD GAGE166-6928

OR-18BK-18GN-18WH-18YL-18BU-18

AUTODIG AUTO 2AUTODIG AUTO 1DIMMER CONTROLGROUND+24 VOLTSRD-18

BK-18

YL-18

YL-18YL-18

CENTER DASH IND2492775

AUTODIG RECORD

GY-18

XMSN OVERRIDEPARK BRAKE OVERRIDEHAZARDLH TURN SIGNAL

GROUND+24 VOLTS

NEUTRALIZER OVERRIDEFUEL LEVEL LOWAIR FILTER RESTRICTED

FUEL PRESSUREWORK LIGHTS

LH INDICATOR PANEL2492763

RD-18BK-18GY-18YL-18PU-18PU-18YL-18YL-18PU-18PU-18PU-18PU-18

MSS INDRH TURN INDACTION LAMPBUCKET TURN INDICATOR

GROUND+24 VOLTS

RIDE CONTROLSTART AID INDPRELUBE

XMSN FILTER BYPASSHIGH BEAM IND

RH INDICATOR PANEL2492763

PU-18YL-18PU-18PU-18PU-18PU-18PU-18PU-18GY-18BK-18RD-18

YL-18

EMS III ECM154-7443

OPERATOR SW INPUT

XMSN FILTER BYPASS SW

CASE DRAIN OIL FILTER BYP

MODULE CLOCK

CLUSTER +V

CAT DATA LINK +

CAT DATA LINK -

HYD TEMP SENSOR

XMSN TEMP SENSOR}

ACTION ALARM

FUEL LEVEL SENSOR

BRK OIL PRESS

GROUND

ALTERNATOR

+ BATTERY

SERVICE

CLEAR

MODULE LOAD

MODULE DATA

+8V SENSOR SUPPLY

ACTION LAMP

REAR AXLE OIL TEMPHYD FILTER BYPASS SW

FRONT AXLE OIL TEMP

+ BATTERYSPEEDOMETER LAMP

GROUND

TACHOMETER LAMPGAGE LAMP

LIGHTS

DIMMER CONTROL1035526

TIRIS INTERFACE SIGNAL LINE

CAN+

TIRIS GND RETURN

GROUNDKEY SW IN

MSS TRANSPONDER READER MODULE218-0404

CAN-

XMSN GEAR SELECTOR201-0212

BK-18

1234

GROUND

+ BATTERY

FWDREVERSEFIRST GEARSEC GEARTHIRD GEAR

FOURTH GEARNEUTRAL

FWD SW IPREV SW IPNEUT SW IPGND

UNUSED

UNUSED

UNUSED

202-BK

126-PK

G750-BUG755-GYG768-GNG760-WHG761-YL

G762-BRG763-PU

G787-GNG788-YLP916-OR202-BK

BK-18BR-18WH-18 1 2

3 4

DOWN SHIFT SW2631493

MOM

CCS FORWARD HORN SW2T-3360

1-4

BK-16

BK-16BK-16BK-16

432

MANUAL

2-4

1

AUTO MAN GEAR SEL HMU SW185-6335

THIRD FUNC DIV SW256-7822

REMOTE FNR SW2462642

CAN RESIS A1342540

REMOTE FNR SW JY2462642

CALSIGGROUND+24V

3RD LEVER POS SNSR2433166

CALSIGGROUND+24V

TILT LEVER POS SNSR2433166

CALSIGGROUND+24V

LIFT LEVER POS SNSR2433166

MOTOR AIR SEAT COMPRESSOR2373970

IMPLEMENT LOCKOUT SW2511197

RIDE CONTROL SW236-4612

ONOFF

AUTO

AUTODIG MODE SELECT SW236-4620

MOM

HID LAMP SW251-5849

AUTOREV FAN SW236-4623

MOM

MOM

QUICK COUPLER ALARM1321829BK-18BK-18

GATEWAY A4N12399954

CDL +CDL -

RS232 PORT1-TXD

RS232 PORT1-RXDRS232 PORT1-DTR

RS232 PORT1-DCDRS232 PORT1-GND

CAN LOW

CAN SHIELD

CAN HIGH

BATT+

R-TERM

RS232 PORT3-TXDRS232 PORT3-RXDRS232 PORT3-GNDBATT-

KEYSWITCH ON

KEYSWITCH ON

-

BATT +

R-TERMRS-232 TXD

BATT -

RECEIVER2639088

-RS-232 RXDRS-232 GNDRS-232 DTRRS-232 DCD-

ANTENNA

ANTENNA263-8948

QUICK COUPLER SW248-5081

BUCKET FORK SEL SW2364625

87a87

85

8630

HEATED MIRROR RELAY3E5239

87a87

85

8630

AXLE COOLER RLY3E5239

THIRD FUNC CONT FLOWXXXXXXX

LH FRONT CAB FLOOD2196487

LH FWD HID FLOOD2108422

RH FWD HID FLOOD2108422

RH FRONT CAB FLOOD2196487

LH REAR CAB FLOOD2196487

LH REAR HID FLOOD2108423

RH REAR HID FLOOD2108423

RH HEATED MIRROR2001173

BK-18BK-18

LH HEATED MIRROR2001173

BK-18BK-18

RH REAR CAB FLOOD2196487

BEACON1286983

RDBK

YL-18BK-18GN-18

SIGNALGROUND+ BATTERY

GROENEVELD AUTOLUBE DISPLAY221-6803

A

CB

LH RR CAB FLOOD2196487

RH RR CAB FLOOD2196487

LH FR CAB FLOOD2196487

RH FR CAB FLOOD2196487

LH FR CAB FLOOD 22196485

RH FR WORK LAMP 22196485

LH RR CAB FLOOD 22196485

RH RR CAB FLOOD 22196485

CONN 14

CONN 15

CONN 16

CONN 17

CONN 24

CONN 25

CONN 26

CONN 27

CONN 28

CONN 29

CONN 30

CONN 28

CONN 29

CONN 31

CONN 36

CONN 32 CONN 33

CONN 34 CONN 35

CONN 37

CONN 38

CONN 38

CONN 39

CONN 40

CONN 41

CONN 42

CONN 42

CONN 43

esquemas 966 h

Documents