electronics for sanitation and disinfection · pcuv15 254 nm (uvc) (germicide) 540x170x125mm 20w...
TRANSCRIPT
Aparatos ElectrónicosElectronics Devices
ELECTRONICSFOR HYGIENE ANDDISINFECTION
AIR PURIFIERS AND VENTILATION UNITSTO IMPROVE THE AIR QUALITY IN PUBLIC AREAS AND COMMERCIAL ESTABLISHMENTS
HIGH EFFICIENCY SOLUTIONS ABLE TO KILLVIRUSES AND BACTERIA
Tel. 902 88 66 98 · Fax. 902 87 64 87
Tel. (+34) 965 82 00 02 · Fax. (+34) 965 82 04 49
www.pritec.com · [email protected]
FÁBRICA 2 / FACTORY 2
Parque tecnológico, Avda. del Vidrio, 5 (D)
02660 · Caudete
ALBACETE · SPAIN
FÁBRICA 1 / FACTORY 1 Avda. de la Electrónica, s/n
03409 · Canyada de Biar
ALACANT · SPAIN
APARATOS ELECTRÓNICOSELECTRONIC DEVICES
PFUVC
The use of short-wave UV light and specifically the wavelength of 254nm, has been proved as a highly
effective germicidal system for dozens of years.
The wall light from the Pritec FUVC assortment takes air from the top and passes it all along the entire
length of the germicidal tube, eliminating a large number of viruses, bacteria and fungi in suspension. The
equipment fan forces the treated stream air out from the back of the device.
The C-spectrum UV light is not a problem for the user since it remains at all times inside the product and therefore it allows, unlike other systems, to be constantly in operation helping to have an environment free of microorganisms.
-
Model
Power
Tube power
Ventilation method
Envelope
254 nm (UVC) (Germicide)
Brushless fan
230V/50HzOperating voltage
617x127x62mm
Microorganisms, viruses, bacteria...
Size
Effective against:
767x127x62mm
20W
Baked paintedmetal (white)
15W
PFUVC15B PFUVC15IX
20W
15W
Satinstainless steel
Baked paintedmetal (white)
PFUVC20B
25W
20W
PFUVC20IX
25W
20W
Satinstainless steel
90% air disinfection capacity
25,3m /h 25,3m /h 27m /h 27m /h
1
m2 meters calculated witha 2.5m ceiling 90% sterilized
313,2m /h 313,2m /h 315,84m /h 315,84m /h
Fan capacity 3445m /h
Maximum recommended area per unit 50m2 60m250m2 60m2
PFUVC15B
PFUVC15IX
PFUVC20B
PFUVC20IX
2
Air treatment
DISINFECTIONEVOLUTION TIME
Purified air
outlet
Ambient air
input without
purification
PURIFIER ENVIRONMENTAL AIR
SAFE
UV
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
Tube wavelength
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
The PSPVC wall light is specifically designed to be used together with indoor air conditioning units (split),
being placed above the air inlet and thus purifying the air in the room using the air conditioning impulsion
system. A practical and easy-to-install system with a sterilization rate of 99.9% *.
The C-spectrum UV light is not a problem for the user since it remains at all times inside the product and
therefore it allows, unlike other systems, to be constantly in operation helping to have an environment free
of microorganisms.
* The sterilization level depends on the correct dimensioning of the product, as well as the flow rate of the split.
20W
254 nm(UVC) (Germicide)
PSPVC16
15W
Microorganisms, viruses, bacteria...
24W
254 nm(UVC) (Germicide)
PSPVC21
20W
Model
Power
Tube power
Ventilation method
Envelope
Operating voltage
Size
Effective against:
90% air disinfection capacity
m2 meters calculated witha 2.5m ceiling 90% sterilized
Maximum recommended area per unit
313,2m /h 315,84m /h
25,3m /h 27m /h
Internal split fan
50m2 60m2
Baked painted metal (white color)
230V/50Hz
PSPVC
-3 4
DISINFECTIONEVOLUTION TIME
SAFE
UV
PSPVC16PSPVC21
Purified air
outlet
Ambient air
input without
purifying
650x150x60mm
Air treatment
PURIFIER ENVIRONMENTAL AIR
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
Tube wavelength
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
PCUV15
254 nm (UVC) (Germicide)
540x170x125mm
20W
15W
Model
Power
15m /h3
6m /h2
60m2
230V/50Hz
-
The PCUV15 model is designed to be installed quickly and easily in the return of the duct air
conditioning system. Compact, low pressure ducts where other equipment does not fit and exert
excessive opposition to the passage of air.
As simple as making a 70x45mm hole and inserting the lamp. The equipment box has 4 holes to fix
it to the duct or it can be glued to the duct with mounting adhesive since the weight is balanced and
it exerts very little force on the duct wall.
PCUV15
PURIFIER ENVIRONMENTALAIR FOR DUCT
5 6
Air treatment
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN
Tube wavelength
Tube power
90% air disinfection capacity
m2 meters calculated witha 2.5m ceiling 90% sterilized
Fan capacity
Ventilation method
Maximum recommended area per unit
Envelope
Operating voltage
Size
Effective against:
PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
DISINFECTIONEVOLUTION TIME
Depending on the duct
Air conditioning ducts
Baked paintedmetal
Microorganisms, viruses, bacteria...
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
SAFE
UV
SAFE
UV
PCUV
PURIFIER ENVIRONMENTALAIR FOR DUCT
PCUV30
The purifying modules are specially designed to be installed inside the air conditioning equipment. A
practical and easy-to-install system with a sterilization rate of 99.9% *
The C-spectrum UV light is not a problem for the user since it remains at all times inside the air duct and
therefore it allows, unlike other systems, to be constantly in operation helping to have an environment free
of microorganisms.
Further details about the installation can be found on the next page.
If the installation in the above referred position is not possible, the equipment can be installed in the air duct
itself.
*The level of sterilization depends
on the correct dimensioning of the
product, as well as the flow of the duct.PCUV30
The front flaps create air
turbulence around the tube to
create the germicidal effect.
254 nm (UVC) (Germicide)
255x125x480mm
Microorganisms, viruses, bacteria...
38W
2x15W
Baked paintedmetal
Model
Power
Tube power
Ventilation method
Envelope
Operating voltage
Size
Effective against:
90% air disinfection capacity
m2 meters calculated witha 2.5m ceiling 90% sterilized
Fan capacity
Maximum recommended area per unit
29m /h3
10,8m /h2
Air conditioning ducts
100m2
230V/50Hz
8-7
DISINFECTIONEVOLUTION TIME
PCUV60
PCUV60
70W
255x250x480mm
4x15W
54m /h3
21,6m /h2
254 nm (UVC) (Germicide)
200m2
Depending on the duct
Air treatment
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
Tube wavelength
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
PCUV80
EXAMPLE OF ROUNDDUCT INSTALLATION.
EXAMPLE OF SQUAREDUCT INSTALLATION
PCUV80
The front flaps create air
turbulence around the tube to
create the germicidal effect.
254 nm (UVC) (Germicide)
255x250x630mm
Microorganisms, viruses, bacteria...
80W
4x20W
Baked paintedmetal
Model
Power
Tube power
Ventilation method
Envelope
Operating voltage
Size
Effective against:
90% air disinfection capacity
m2 meters calculated witha 2.5m ceiling 90% sterilized
Fan capacity
Maximum recommended area per unit
72m /h3
28,8m /h2
270m2
230V/50Hz
SAFE
UV
10-9
DISINFECTIONEVOLUTION TIME
The ideal place for the installation of the equipment is the space between the
exchanger / condenser and the propulsion turbine with the pipes transverse
to the air passage. This installation site brings great advantages.
1. All the air supplied to the room is treated by UVC tubes every time it
recirculates. This way it quickly achieves a very high level of sterilization in a
short time.
2. The light projected directly onto the evaporator keeps it free of
microorganisms which, due to humidity, proliferate easily if a containment
system is not installed. The microorganisms' elimination confers 2 great
advantages;
A- It keeps the evaporator efficiency since the biological microfilm in case of
not using the UVC, produces a barrier that reduces the air flow and, therefore,
the system efficiency.
B- The pathogen colonies formed in the condenser and the drip tray, if not
destroyed, are driven into the pipes and later into the rooms. If this air is not
treated, it may become the cause of possible infections or diseases.
3. Coordination with the start-up system is simple as it can be related to the operation of the motor. If the drive motor is running,
the UVC system is running; if the motor stops, the UVC system shuts down. For inverter machines where the motor signal
cannot be used directly, it is possible to detect the operation from another point of the installation.
PCUV
Air treatment
PURIFIER ENVIRONMENTALAIR FOR DUCT
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
Tube wavelength
Air conditioning ducts
Depending on the duct
outdoor air regulation damper
return air
evaporator
drive fan
drive air
The Pritec VC assortment wall light is intended to be installed inside cabinets, drawers or closed receptacles
in order to carry out a deep disinfection of the objects surface inside in a couple of minutes.
Humans, animals, and plants should avoid exposure to C-spectrum ultraviolet light. In order to minimize the
risk of exposure, two kinds of sensor are offered as an option:
A. A pair of deactivation sensors designed to instantly shutdown the system if the door or drawer, where the
appliance is located, is opened. It consists of two sensors to ensure that accidental ignition does not occur
when one of them is accidentally covered up.
B. A motion sensor that immediately deactivates the system when detecting the presence of people.
Model
Power
Tube power
Envelope
20W
254 nm (UVC) (Germicide)
Baked painted metal (white)
230V/50Hz
PAVC15B
15W
Operating voltage
480x125x60mm
Microorganisms, viruses, bacteria...
Size
Effective against:
PAVC15IX PAVC20B PAVC20IX
20W 25W 25W
15W 20W 20W
Baked paintedmetal (white)
Satinstainless steel
Satinstainless steel
630x125x60mm
Sterilization time90%/25cm (**) 12seg
Sterilization time99%/25cm (**)
12seg 10seg 10seg
75seg 75seg 60seg 60seg
Sterilization time90%/50cm (**) 120seg 120seg 100seg 100seg
12-11
PRECAUCIÓN (RG-3):Radiación perjudicial para la piel y ojos. Nunca se exponga directamente a la radiación del tubo UVC.
CAUTION(RG-3):Harmful radiation for the skin and eyes. Never stand directly to the UVC tube radiation.
PAVC15IX
PAVC20IX
PAVC15B
PAVC20B
PAVC
Surface + air treatment
GERMICIDEAPPLICATION
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
(**) Approximate times and surfaces may vary depending on the environment.
Tube wavelength
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
SAFE
UV
SAFE
UV
The 595UVC + Model combines 4 UVC tubes of 15w (60w) totally in sight to obtain a very high disinfection
capacity.
The short wave ultraviolet (UVC) is a highly effective system to quickly fight viruses, bacteria and algae.
Designed to be used when the room is empty of people, animals or plants.
There is a basic version, a version with motion sensor for automatic disconnection, a version with sensor +
remote control and, finally, the version with sensor and control by app that is able to set up on and off
remotely and timed.
It is a tremendously versatile product as it can be installed recessed, surface or even on a wall or
suspended.
Model
Power
Tube power
Envelope
230V/50HzOperating voltage
Microorganisms, viruses, bacteria...
Size
Effective against:
Sterilization time95%/35cm (**) 15seg
Sterilization time70%/200cm (**)
15seg 15seg 15seg
10min
P595UVC+B P595UVC+S P595UVC+SR P595UVC+SW
75W
254 nm (UVC) (Germicide)
4x15W(60W)
Baked painted metal
595x595x50mm
10min 10min 10min
Sterilization time95%/200cm (**) 120min 120min 120min 120min
Maximum recommended area per unit 15m2 15m2 15m2 15m2
P595UVC+B
P595UVC+S
P595UVC+SR
P595UVC+SW
595UVC+
14-13
Surface + air treatment
PRECAUCIÓN (RG-3):Radiación perjudicial para la piel y ojos. Nunca se exponga directamente a la radiación del tubo UVC.
CAUTION(RG-3):Harmful radiation for the skin and eyes. Never stand directly to the UVC tube radiation.
CLEANING AND DISINFECTIONBY C ULTRAVIOLET
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
(**) Approximate times and surfaces may vary depending on the environment.
Tube wavelength
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
SAFE
UV
The Pritec PTWVC unit is intended to be used in small or medium rooms in order to carry out a deep
disinfection of the objects surface within the room in a short period of time.
During the sterilization process the room must be completely empty of people, animals or plants all the
time since UVC light is harmful to eyes and skin.
255x250x1230mm
PTWVC80 (RC) (RCT)
86W
4x20W(80W)
Model
Power
Tube power
Envelope
230V/50HzOperating voltage
Microorganisms, viruses, bacteria...
Size
Effective against:
Sterilization time90%/25cm (**)
Sterilization time99%/25cm (**)
10seg
60seg
Sterilization time90%/50cm (**) 100seg
254 nm (UVC) (Germicide)
Baked painted metal
PTWVC80
PRECAUCIÓN (RG-3):Radiación perjudicial para la piel y ojos. Nunca se exponga directamente a la radiación del tubo UVC.
CAUTION(RG-3):Harmful radiation for the skin and eyes. Never stand directly to the UVC tube radiation.
PTWVC
CLEANING TOWERAND DISINFECTION
16-15 PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN
PTWVC60 (RC) (RCT)
PTWVC60
70W
4x15W(60W)
255x250x1080mm
15seg
100seg
160seg
PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
PTWVC60RC
PTWVC60RCT
PTWVC80RC
PTWVC80RCT
10min
The CR model has a remote control able to operate the system remotely and
minimize the risk of exposure to UVC light.
The CRT model, in addition to the remote control, has a timer with a pre-established
time after which the system will automatically stop once it has elapsed. This will
avoid oversights or unnecessary exposures.
Surface + air treatment
Tube wavelength
PVPR (*):
1 metro90% - 30seg
2 metros90% - 1min
4 metros70% - 2,30min / 90% - 5min
6 metros70% - 4min / 90% - 8min
10 metros70% - 7min / 90% - 15min
(RC) 644,22€546,43€
(RC) (RCT) 675,06€577,27€
(**) Approximate times and surfaces may vary depending on the environment.
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this product
contains 35% titanium dioxide (Ti02)
The Pritec MN model is designed for manual disinfection of surfaces in a practical, simple and fast way.
Facing the need to treat furniture such as sofas, chairs, mattresses, counters, tables or other similar
products, it ensures that both the client who uses or test it both at the beginning and at the end, finds a
completely clean and safe surface. The MN equipment is manually passed over the surface, and this way
eliminates all trace of microorganisms almost instantly.
Model
Power
Tube wavelength
Tube power
Envelope
254 nm (UVC) (Germicide)
230V/50HzOperating voltage
620x100x140mm
Microorganisms, viruses, bacteria...
Size
Effective against:
PMNVC15
20W
15W
Satinstainless steel
Sterilization time90%/5cm (**)
Sterilization time99%/5cm (**)
5seg
20seg
Sterilization time90%/20cm (**) 10seg
18-17
PRECAUCIÓN (RG-3):Radiación perjudicial para la piel y ojos. Nunca se exponga directamente a la radiación del tubo UVC.
CAUTION(RG-3):Harmful radiation for the skin and eyes. Never stand directly to the UVC tube radiation.
PMNVC15
Surface + air treatment
GERMICIDEAPPLICATION
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
(**) Approximate times and surfaces may vary depending on the environment.
PMNVC15
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
The coating used in this
p r o d u c t c o n t a i n s 3 5 %
titanium dioxide (Ti02)
SAFE
UV
PCUV
PURIFICADOR DE AIRE AMBIENTAL PARA CONDUCTO
PVHVC15
-
Tratamiento de aire
The PVHVC15 equipment is specially designed to sterilize vehicles in an extremely quick, easy and safe way.
The ultraviolet C wavelength inactivates possible microorganisms in the treated area in a few seconds and it
is perfect for garages, car rental companies, fleet of taxis ...
Its studied design allows it to be placed on the rails of the headrest of the vast majority of vehicles or
alternatively placed it on the few models without these rails, being compatible in one way or another with all
models.
It is possible to use a single or several elements, one on each seat, all of them interconnected to just need a
power supply.
The master unit has a box that is outside the vehicle to activate and time the system. This way the user is
protected from UVC light at all times and ensures only the time necessary for disinfection, turning off the
equipment automatically after the set time has elapsed.
Model
Power
Tube wavelength
Tube power
Envelope
254 nm (UVC) (Germicide)
Operating voltage
Size
Effective against:
PVHVC15M
20W
Baked painted metal (White)
Sterilization time90%/5cm (**)
Sterilization time99%/5cm (**)
12seg
75seg
Sterilization time90%/20cm (**) 120seg
PVHVC
230V/50Hz
480x125x60mm
Microorganisms, viruses, bacteria
PVHVC15S
15W
Security Master unit with timer Auxiliary Unit
(**) Approximate times and surfaces may vary depending on the environment.
PRODUCTS 100% DESIGNED AND MANUFACTURED IN SPAIN PRITEC RESERVES THE RIGHT TO MODIFY THE CHARACTERISTICS OF THE PRODUCTS IN THIS CATALOG.
Surface + air treatment
GERMICIDEAPPLICATION
19 20
EACH PRODUCT INCLUDES 2 ADHESIVES IN SPANISH AND ENGLISH TO
STICK AND REPORT THAT A C CLASS ULTRAVIOLET DISINFECTION SYSTEM
IS BEING USED
SAFE
UV