Computer Diagnostic Service-Computer scan your engine for fault codes and software version.-Actual engine time recorded-Sensor values checked and recorded for future assistance-ECM/PCM harnesses inspected and lubed with dielectric grease

$85.00*Service will let you know your computer systems is working properly.

**Price does not include reflashing ECM/PCM with latest version of software if needed.

***Recommended yearly

Cooling System Flush-Completely drain coolant-Inspect old coolant and dispose of properly-Fill system with new extended life coolant-Check system for leaks-Purge system and top off coolant level.

4 cyl $175.006 cyl $215.008 cyl $235.00

*Recommended every 3-4 years

Stern Drive Services

ALPHA/BRAVO Maintenance Level 1-Remove stern drive-Check engine alignment-Inspect U-joints-Inspect drive shaft splines-Inspect U-joint bellows-Inspect shift cable end-Inspect shift cable bellow-Inspect exhaust bellows-Inspect water input hose-Inspect grounding cables-Inspect anodes-Inspect trim hoses and rams-Drain gear lube-Pressure test lower unit-Grease U-joints, splines, gimbal bearing, and hinge pins.

-Remove propeller-Inspect prop shaft splines-Check for fishing line-Grease prop shaft-Install lower unit -Fill with gear lube -Grease prop shaft-Install propeller

$265.00*Recommended annually or 100hrs

ALPHA Level 2-All of the services included in level 1-Replace water pump assembly

$342.50 *Recommended every 2 years

$77.50 (discount if performed with winterization)

Bravo and Gas Inboard Water Pumps-Remove sea water pump-Inspect hose and clamps-Rebuild pump with repair kit -Includes housing -Impeller -O-rings-Install rebuilt pump-Run to check for leaks and proper operating temperature.

$325.00*Recommended every two years

**Price may change for non-mercruiser engines.

Outboard Impeller Replacement

90hp and Under-Drop lower unit-Inspect splines-Replace impeller-Inspect water pump housing-Install lower unit-Run and check cooling

$179.00

90hp and Above-Drop lower unit-Inspect splines-Replace impeller-Inspect water pump housing-Install lower unit-Run and check cooling

$205.00 *Please add $50 for OMC products

Diesel Water Pump Service-Remove sea water pump-Inspect hoses and clamps-Replace impeller-Re-install pump-Run to check for leaks and proper operating temperature.

$Call for price *Recommended every two years

**Price may vary depending on engine manufacturer

Inboard Transmission Fluid Change-Pump out old fluid-Replace filter-Refill fluid-Inspect cooler-Inspect lines-Run and check for leaks-Check shift operation

$175.00

Repacking Shaft and Rudder Boxes-Clean out old flax packing-Install new flax packing-Inspect for leaks

$120.00 per box

Generator Service-Remove and clean air intake-Inspect exhaust system-Clean sea strainer-Check coolant and top off if needed-Inspect fuel system-Replace impeller-Change spark plugs-Replace belt-Run and check systems

$325.00*Recommended every 2 years

Air Conditioner Service-Inspect and Clean condensation drains-Clean air filter-Inspect hoses and clamps-Clean sea strainer-Run and inspect operation

$80 per unit*Recommended Annually

Battery Service-Inspect and tighten hold downs-Clean terminals-Tighten battery connections-Top off fluid levels-Load test

$50.00 per battery*Recommended monthly for boats that are plugged in full time.

**Discounts for boats with more than 2 batteries.

Thermostat Replacement-Remove thermostat housing/cover-Clean all surfaces-Install new thermostat w/gasket-Run engine to check temp and inspect for water leaks

Outboards $95 per thermostatGas engines $190.00

*Recommended every 2-3 years

Stern Drive Bellows

-Replace all bellows-Inspect gimbal bearing & U-joints

Alpha Drive $740 per drive

Bravo Drive $810 per drive

Prop ReconditioningDiameter Aluminum SS10” and less $65.00 $160.0010” above $90.00 $195.00

4 Blade Aluminum $125.00

Bravo II Aluminum $185.00 Bravo III Stainless $205.00

Yamaha Saltwater SS $205.00 Volvo Aluminum $115.00

Skeg Reconditioning-Remove lower unit-Prep for skeg repair-Send out for repair-Install lower unit back on-Fill with gear lube if needed-Check shift operation

$395.00

South Portland..........................888-622-4265 Raymond...................................888-548-4043 Holden.......................................888-873-9027Rockport...................................888-650-2857 Kittery.......................................888-714-1241

Maintenance Services to Protect

Your Investment

www.portharbormarine.com

2008