Death or serious injury may occur when inletis supplied by a pressurized source and valveis closed.
Risque de blessures serieuses ou de mortquand l'entree est ailmentee par une sourcedynamique et quand la valve est fermee.
BLEEDER
2 1/2" INLET
BUR
AIR OUT
BLK
1
RED
1 1/2" SPEEDLAY
2
ORG
1 1/2" SPEEDLAY
7
BRN
2 1/2" RIGHT
5
YLW
2 1/2" REAR
6
GRN
2 1/2" LEFT
8
BLU
2 1/2" LEFT
3
SLV
3" MONITOR
9
GLD
4" RIGHT
4
WHT
2 1/2" REAR
F
OA
M
RE
D
F
OA
M
RE
D
F
OA
M
RE
D
F
OA
M
RE
D
FOAM
RED
FOAM
RED
RED
1
ORG
2
BLEEDER
1
RED
BLEEDER
2
ORG
SLVR
3
3
SL
V
BLEED / DRAIN
IDLE
PRESET
INC
DEC
MODE
MENU/
SILENCE
RPMPSI
PUMP ENGAGED OK TO PUMP THROTTLE READY
PUMP INTAKE PUMP DISCHARGE
INFO CENTER
RPM
CHECKENGINE
STOPENGINE
GRN
6
BLU
8
6
GR
N
BLEEDER
8
BL
U
BLEEDER
SUCTION SIDE RELIEF VALVE
DO NOT CAP
SUCTION SIDE RELIEF VALVE
DO NOT CAP
TO COMPLETELY DRAIN
PUMP AND PLUMBING
- REMOVE ALL DISCHARGE AND
SUCTION CAPS AND PLUGS
- OPEN MASTER DRAIN VALVE
- OPEN ALL BLEEDER VALVES
- OPEN ALL DISCHARGE AND
SUCTION VALVES HALF WAY
- OPERATE PRIMER FOR 5 SECONDS
AFTER PLUMBING IS DRAINED
MASTER
DRAIN
O
P E
N
C
L O SE
FOAM HEADER DRAIN
RED
No load governed speed
TPM sans charge
RPM
RPM
RPM
RPM
250 psi
200 psi
150 psi
IGPM
IGPM
IGPM
Date:I GAL
Water Tank Capacity
Capacite du reservoir d'eau
Vehicle Identefication number
Numero d'identification du vehicule
No.Standard: CAN\ULC-S515-04HOMOLOGUE
LISTED
APPAREIL DE LUTTE CONTRE L'INCENDIE
AUTOMOBILE FIRE FIGHTING APPARATUS
C
L
U
WARNING
!
Death or Serious injury might
occur if proper operating
procedures are not followed
The pump operator, as well as
individuals connecting supply or
discharge hoses to the apparatus,
must be familiar with water
hydraulics hazzards and
componant limitations
WATER LEVEL
CLASS 1
ENGINE COOLER
BLK
RESET
SELECT
FOAM
....
F OAMP RO
HYPROROPOAMF
1. Push red button to turn
system
ON/OFF. Light below switch
will indicate
unit is operating and flash
when foam
is being injected.
2. change foam percentage using keys.
3. Gray button will display
water flow,
total water flowed, foam
concentration,
and total foam flowed. Push
keys
together to reset total
values.
FoamPro 2001 Foam System
Maximun operating pressure
3000 psi
1300 GPM @ 0.2%
520 GPM @0.5%
260 GPM @1.0%
85 GPM @3.0%
Maximum water flows
Maximum foam viscosity
2000 cps
Maximun foam concentration
10%
Class A and B foam SystemCAUTION / ATTENTION
Avoid equipmentdamage.Water tank fillprocedure:1. Fill at 100 PSImaximum on all tanks.2. Fill rate in GPM =Tank size capacity.3. Tanks over 1000 Gallons, maximum fill rate = 1000 GPM
4. Gate back fill when water reaches top of tank.
Failure to follow these procedurescould result in overpressurization,premature tank failure, and possiblyvoid your warranty.
Prevention des dommagesa l'equipment. Procedurede remplissage dureservoir:1.Remplir le reservoir a 100 PSI MAXIMUM.
2. Debit de remplissage en GPM=Capacite du reservoir.3. Reservoir de 1000 gallons et plus - Debit de remplissage = 1000 GPM.4. Reduire la valve de remplissage quand l'eau arrive a son niveau maximum.
NE PAS suivre ces procedure pourraitoccasionner une supression, un eclatementdu reservoir et possiblement l'annulationde la garantie.
FOAM LEVEL
CLASS 1
HEATER
BLK
Class 1
VACUUM PRESSURE
LS TELELIGHT
BLK
RS TELELIGHT
BLK
SLIDING TRAY SLIDING TRAY
ADJ. SHELF
ADJ. SHELF
ADJ. SHELF
ADJ. SHELF
C4
C2 C5
6" INLET
BLK
AUTO EJECT
KUSSMAUL
AUTO CHARGE
AIR EJECT
L
U
A
M
S
S
UK O
CS
C
I
N
O
RT
C
EL
E
POINT-DE-BUTEFIRE DEPARTMENT
20668-19 0
GENERAL ARRANGEMENT
AutoCAD SHX Text
METALFAB REAR MUDFLAPS
AutoCAD SHX Text
METALFAB REAR MUDFLAPS
AutoCAD SHX Text
EXTENDED EXHAUST
AutoCAD SHX Text
SIDE VIEW CAMERA TYP B/S
AutoCAD SHX Text
LED GROUND/ STEP LIGHTS
AutoCAD SHX Text
500LB LOCK IN-LOCK OUT SLIDING TRAY
AutoCAD SHX Text
ZICO LAS w 1-24' 2-SECTION LADDER, 1-14' ROOF LADDER, 1-10' ATTIC LADDER FLASHING LIGHTS & REFLECTIVE TAPE
AutoCAD SHX Text
CLARE HOSE WRENCHES
AutoCAD SHX Text
FOAM FILL
AutoCAD SHX Text
FEDERAL QL43 LED FLASHERS
AutoCAD SHX Text
REAR VIEW CAMERA
AutoCAD SHX Text
REAR PINTLE HOOK
AutoCAD SHX Text
TAIL LIGHT BOX w PAC STRAPS FOR ABC & CO2 EXTINGUISHER
AutoCAD SHX Text
10" SS NEWTON DUMP w SS 36" TELECHUTE & ELECTRIC ACTUATOR
AutoCAD SHX Text
ELECTRIC DUMP SWITCH
AutoCAD SHX Text
4" DIRECT TANK FILL (FIREMAN'S FRIEND)
AutoCAD SHX Text
LED TUBE GROUND LIGHTS
AutoCAD SHX Text
WHELEN 64 LED TAIL/BRAKE LIGHT MODULE
AutoCAD SHX Text
6" SUCTION HOSE TUBE w DOOR
AutoCAD SHX Text
PIKE POLE TUBE w 10' & 6' POLES & SS DOOR
AutoCAD SHX Text
LAS SWITCH
AutoCAD SHX Text
BAR w BRACKET
AutoCAD SHX Text
PADDED LADDER BOOT
AutoCAD SHX Text
REAR SUCTION
AutoCAD SHX Text
RED/YLW REFLECTIVE NFPA CHEVRON ON REAR OF BODY
AutoCAD SHX Text
LED SIGNAL MASTER WARNING LIGHT SL8
AutoCAD SHX Text
FEDERAL NVG10 REAR BEACON
AutoCAD SHX Text
UNITY REAR LED FLOOD LIGHT
AutoCAD SHX Text
ALUM HOSE BED w LIGHTED COVER, (2) ADJ DIVIDERS, & (ONE) FIXED DIVIDER
AutoCAD SHX Text
LIGHTED FOLDING STEPS
AutoCAD SHX Text
LED MARKER LIGHTS
AutoCAD SHX Text
ALUM HANDRAIL
AutoCAD SHX Text
LED STEP LIGHT
AutoCAD SHX Text
FEDERAL QL43 LED FLASHERS
AutoCAD SHX Text
FLUSH MOUNT ALUM FLIP-UP DOOR
AutoCAD SHX Text
2 1/2" DISCHARGE
AutoCAD SHX Text
OPEN STORAGE w LIGHTING
AutoCAD SHX Text
PUMP ACCESS DOOR
AutoCAD SHX Text
ALUM HANDRAIL
AutoCAD SHX Text
GRIPSTRUT PANEL HOOD STEP w NFPA EDGE DELINIATION
AutoCAD SHX Text
SPEEDLAYS w PULL OUT TRAYS, SS ROLLERS, & END TARPS
AutoCAD SHX Text
6" BARREL STRAINER w MOUNT
AutoCAD SHX Text
TFT 6" LOW LEVEL STRAINER
AutoCAD SHX Text
PICK HEAD AXE & BRACKET TYP (2) PLCS
AutoCAD SHX Text
SCBA CAROUSEL w (4) BRACKETS & STRAPS
AutoCAD SHX Text
TUBE MOUNTED 1500 IMP GAL HUSKY PORTABLE TANK w FASTENING SYSTEM
AutoCAD SHX Text
*POLISHED ALUM WHEELS w SS NUT COVERS, HUB CABS, HIGH HATS
AutoCAD SHX Text
*FRONT MUDFLAPS
AutoCAD SHX Text
FEDERAL LPX53DS- NFPA LIGHTBAR
AutoCAD SHX Text
FRC TELESCOPING SPECTRA LED FLOOD w HAZARD SWITCH
AutoCAD SHX Text
FEDERAL SIGNAL WIRELESS VISIBEAM
AutoCAD SHX Text
(2) ANTENNA BASE w CHROME RAINCAP
AutoCAD SHX Text
ALUM HEATPAN
AutoCAD SHX Text
AIR OUTLET
AutoCAD SHX Text
RUBBER MALLET ON PAC TOOLOK 1003 MOUNTING
AutoCAD SHX Text
3" SUMP DRAIN LINKAGE
AutoCAD SHX Text
AMDOR ROLL- UP DOORS
AutoCAD SHX Text
CAPPED MONITOR 3" PIPING
AutoCAD SHX Text
PSTANK WATER LEVEL INDICATOR
AutoCAD SHX Text
SINGLE COLOUR 2303 RED
AutoCAD SHX Text
SCBA CYLINDER STORAGE COMPARTMENT w LOOP & CUSHION
AutoCAD SHX Text
FEDERAL QL43 LED FLASHER
AutoCAD SHX Text
AMDOR PULL STRAPS
AutoCAD SHX Text
(2) HORIZONTAL BRACKETS FOR FOLDING WHEEL CHOCKS
AutoCAD SHX Text
VERTICAL ALUM TREAD FUEL TANK/ STEP TRIM
AutoCAD SHX Text
AIR INLET w AUTO EJECT
AutoCAD SHX Text
120V INLET TO BATT COND w AUTO EJECT & READOUT
AutoCAD SHX Text
*FLASHING LIGHTS
AutoCAD SHX Text
AIR HORNS
AutoCAD SHX Text
FEDERAL QL43 LED FLASHERS
AutoCAD SHX Text
200 WATT SIREN SPEAKER
AutoCAD SHX Text
TANK CERTIFICATION LABEL
AutoCAD SHX Text
CLARE HOSE WRENCHES
AutoCAD SHX Text
TITLE
AutoCAD SHX Text
DRAWING NO.
AutoCAD SHX Text
REV
AutoCAD SHX Text
METALFAB LTD. 847 CENTRAL ST. CENTREVILLE NB. CANADA E7K 2E8
AutoCAD SHX Text
JOB No.
AutoCAD SHX Text
DRAWN BY
AutoCAD SHX Text
DATE
AutoCAD SHX Text
FIRE TRUCKS
AutoCAD SHX Text
* - INCLUDED w CHASSIS
AutoCAD SHX Text
SUCTION:
AutoCAD SHX Text
DISCHARGES:
AutoCAD SHX Text
CHASSIS:
AutoCAD SHX Text
PUMP:
AutoCAD SHX Text
TANK:
AutoCAD SHX Text
FOAM:
AutoCAD SHX Text
HS
AutoCAD SHX Text
09/23/19
AutoCAD SHX Text
20668
AutoCAD SHX Text
HALE QFLO SINGLE STAGE 1050 IGPM
AutoCAD SHX Text
INTERNATIONAL HV607 450 HP 2-DOOR
AutoCAD SHX Text
1 - 6" LEFT (ELEC) 1 - 6" RIGHT (ELEC) 1 - 6" REAR (ELEC GATE 5" PIPE) 1 - 4" TANK TO PUMP (ELEC) 1 - 2 1/2" LEFT 1 - 2 1/2" RIGHT
1 - 4" RIGHT (3" PIPING/VALVE) 1 - 3" MONITOR (CAPPED) 2 - 2 1/2" LEFT 1 - 2 1/2" RIGHT (FOAM) 2 - 2 1/2" REAR (RIGHT SIDE FOAM) 1 - 2 1/2" TANK FILL
AutoCAD SHX Text
2 - 1 1/2" SPEEDLAY (FOAM)
AutoCAD SHX Text
REVISIONS
AutoCAD SHX Text
REV
AutoCAD SHX Text
DESCRIPTION
AutoCAD SHX Text
BY
AutoCAD SHX Text
DATE
AutoCAD SHX Text
0
AutoCAD SHX Text
FIRST ISSUE
AutoCAD SHX Text
----
AutoCAD SHX Text
----
AutoCAD SHX Text
NOT SHOWN:
AutoCAD SHX Text
*VEHICLE DATA RECORDER ULC S515-13 & NFPA 1901-2016 COMPLIANCE TIRE PRESSURE INDICATORS - SINGLE AXLE *NON-REMOVEABLE KEY CONSOLE IN CAB w HINGED COVER STORAGE PUMP ENGAGED INDICATOR LIGHT ON SPOT AUTOMATIC TRACTION CHAINS *MASTER BATTERY DISCONNECT *BACK UP ALARM PROTECTION VALVE FOR AIR OP ACCESSORIES DIAMOND LOGIC ELECTRIC SYSTEM MANAGEMENT DIAMOND LOGIC LOW VOLTAGE ALARM IN CAB LED LIGHTING IN ENGINE COMPARTMENT PRO VISION VIDEO SYSTEM MONITOR IN CAB 12 VOLT POWER POINT IN DASH ANODES IN SUCTION & DISCHARGE PIPING OK TO PUMP INDICATOR LIGHT CLASS 1 ENGINE GOVERNOR TPG+ (3) SSRV TRIDENT AIR PRIMER & PRE PRIME *HEAT EXCHANGER FOAM FILL HOSE STORED IN PUMP ACCESS DOOR WHELEN 200 WATT SIREN MODEL 295SLSC1 LED TUBE LIGHTS IN COMPARTMENT DOOR AJAR WARNING LIGHT EQUIPMENT RACK NOT STOWED WARNING LIGHT PROVISIONS FOR (2) CUSTOMER RADIOS TURTLE TILE COMPARTMENT MATTING VERTICAL UNISTRUT TRACKING IN COMPARTMENTS REFLECTIVE STRIPING KROWN RUST PROTECTION UNDERCOATING GRAY ZOLATONE COMPARTMENT INTERIORS HEATER IN PUMPHOUSE MIDSHIP PUMP w AIR SHIFT KUSSMAUL BATTERY CONDITIONER 1200 4" LED STEP LIGHTS FOR BODY STEPS REFLECTIVE STRIPING INSIDE CAB DOORS TO MEET NFPA ADDITIONAL AIR TANK SPEEDLAY TARPS
AutoCAD SHX Text
LABELS:
AutoCAD SHX Text
FLUID CAPACITY PLATE PUMPING TEST PLATE MAXIMUM RIDERS SIGN-2 PERSONS SEAT BELT WARNING LABELS-2 DOOR CHASSIS HELMET WARNING LABEL-DO NOT WEAR HELMET APPARATUS INFORMATION LABEL REAR STEP WARNING LABEL ULTRA LOW SULFUR DIESEL ONLY FOAM CONCENTRATE LABEL DO NOT MOVE APPARATUS WHEN DOOR AJAR LIGHT IS ON
AutoCAD SHX Text
ACCESSORIES
AutoCAD SHX Text
(2) TUBE MOUNTED 6" X 13' SUCTION HOSES 6" BARREL STRAINER BRACKET COMPARTMENT MOUNTED 6" LOW LEVEL STRAINER RUBBER MALLET w PAC TOOLOK 1003 MOUNT COMPARTMENT MOUNTED (3) CLARE HOSE WRENCHES MOUNTED ON R & L SIDE PUMP PANELS & IN REAR COMPARTMENT BAR w BRACKET MOUNTED ON BACK BUMPER 6' PIKE POLE & 10' PIKE POLE TUBE MOUNTED (2) AXES MOUNTED IN REAR COMPARTMENT 24' 2-SECTION EXTENSION LADDER 14' ALUMINUM ROOF LADDER 10' ATTIC LADDER PADDED LADDER BOOT AIR CHUCK w 25' OF 3/8" AIR HOSE 1500 IMP GAL PORTA TANK TUBE STORED AKRON 2581 GATED WYE (LOOSE) 20# DRY CHEMICAL EXTINGUISHER TUBE MOUNT 15# CO2 EXTINGUISHER TUBE MOUNT 2.5 GALLON EXTINGUISHER (LOOSE) (4) SCBA BRACKETS w STRAPS ON ZICO SCBA CAROUSEL (2) LARGE FOLDING WHEEL CHOCK (LOOSE) (2) HORIZONTAL BRACKETS FOR FOLDING WHEEL CHOCKS COMPARTMENT MOUNTED
