wheelhorse model 603 service manual
DESCRIPTION
WheelHorse model 603 service manualTRANSCRIPT
.. .. .. II II II .. '" .. .. .. .. '" .. .. II II .. .. II .. .. .. .. II II
I II II II It .. .. .. .. .. .. .. .. .. II .. III .. .. .. .. OIl
U T I ..
I !II .. .. .. .. .. .. .. .. .. ..
THINGS YOU SHOULD KNOW
WARRANTY
and the manufacturer.
CONTACT YOUR LOCAL ENGINE OR BATTERY SERVICE HEADQUARTERS.
NOTE: 90 DIlY Warranty for Commercial Use.
BEFORE YOU START
oil should be all
located at the rear and fill to level of hole
S.A.E. 90 Gear Lube
transmission should be checked after
TIRES
should be bottom to
is a
All clutch tractor.
1.
STARTING ENGINE
CLUTCHING
PARKING BRAKE
desirable have to
as far forward.
clutch-brake back.
ATTACHING TOOLS
CARE OF TRACTOR and oiled
the location transmission and
attachment side of the
air cleaner clean. This will add
3. Keep tires properly inflated. See previous instructions.
4. Keep tractor covered and in a dry place when not in use.
S. Keep grass and dirt out of engine cowling as these will stop the flow of air and decrease engine life.
6. BRAKE ADJUSTMENT. The brake band, located on the left side of the transmission, brakes the transmission and in turn stops the wheels.
To adjust first set the parking brake then adjust the nut on the brake rod until it locks the rear wheels. Disengage pprking brake, remove cotter pin from clutch rod at clutch brake pedal and by turning in or. out adjust clutch brake pedal to operators desired position.
7. When replacing belts or mounting drive implements make sure all pulleys are in line.
S. Your tractor is only as good as the service you give it. See your Wheel Horse Dealer for a through check-up after each season of use.
9. When replacing belts be sure to purchase them from your Wheel Horse Dealer, as these belts are specifically designed for each application.
(NOTE: Make sure all pulleys are in line.)
FOR YOUR SAFETY
A. Keep all guards on at all times. B. Never abuse your tractor by improper handling. C. Keep hands and feet from moving parts. D. Remove key when not in use. E. Be careful on high uneven ground.
WHEEL HORSE MODEL 603 TRACTOR SPECIFICATIONS
(Specifications subject to change without notice.)
Length overall .. , . . .. .. .. . . .. . .. .. .... 61 inches Wheelbase . .. . ...... , ..... 41 % inches Width overall .... . 30 inches Width at front wheels . .. .. . .... , ....... 28};2 inches Height .. .. ... .... . . .. . . ... . . ... . .... ...... 36};2 inches Height to top of hood . ....... ................ 32 inches Net weight . ... . .. .. .. ............. . ....... 349 Ibs. Crop clearance ..... .. ... .. . ... .. . ......... ..... .. 7% inches Frame clearance , .. .. . ..... . .. ........... 13};2 inches Engine (4-cycle, single cylinder, air cooled) ... . . 6 hp. Fuel capacity .. . . . . .. .. .. . . . . . .... , . , ... 4 quarts Tires (front) "" 4:00 x 8" pneumatic (16" wheel dia.) Tires (rear) Cleat-type or All Purpose tread
6:00 x 12" pneumatic (22" wheel dia.)
Figure 1
Frame
Transmission - see last page for Transmission break down and P"rts
Rllq'd.
Soc. 1
10 27 4413
28 933217
2
2 30 4412
908035·4
9
33 3917
34 933215
2
37
4447
40 4408
3949
6 3940 • Drog
Axle
47 4
48
49
50 1621
x 2
52 97 909484
53 98 1576
99 1786
55 100 1192
56 101 1217
57 102 2734 Throllie 8. Choke
58 1363 103 3328 1
59 104 2
60 2593 105 2
106 3329
62 107 4
63 3:9>!liI 108 2
64 109
65 306.2i
66 4222 III 1385 2
67 Manual
68 4438 2
4~39 3
116
72 17 1667 2
2
119 1662 2
120 1654 2
3 121 6
5 1709 2
1712 2
2
Tube 2
2
Wheel - Steering
Pin· x 1% - Choke & Throlile
Decal Wheel Horse Emblem
EI.
2
No.
1 2 2 2 2
2
form No 127