BOW THRUSTERSBOW THRUSTERSBOW THRUSTERSBOW THRUSTERS

BOW THRUSTERS ARE USUALLY BOW THRUSTERS ARE USUALLY MOUNTED IN A FIXED TUBE INSTALLEDMOUNTED IN A FIXED TUBE INSTALLEDMOUNTED IN A FIXED TUBE INSTALLED MOUNTED IN A FIXED TUBE INSTALLED

ATHWART SHIPS IN THE BOWATHWART SHIPS IN THE BOW

STERN THRUSTERS ARE USUALLY STERN THRUSTERS ARE USUALLY MOUNTED IN A TUBE BOLTED TO THE MOUNTED IN A TUBE BOLTED TO THE OUTSIDE OF THE TRANSOM, BUT MAY OUTSIDE OF THE TRANSOM, BUT MAY ,,

ALSO BE IN A FIXED TUBEALSO BE IN A FIXED TUBE

THRUSTER FUNCTIONDocking in cross winds and cross

t l tcurrents, close quartersManeuvering in marinas, locks, canalsHolding the boat against the dock, lock

wall or another vessel without linesSt ti h ldi i th f Station holding in the open sea for

fishing, diving etcBoat position while fishing Boat position while fishing Emergency steering

THRUSTER MODELS

10 Different Electric Models10 Different Electric Models10 Different Electric Models10 Different Electric Models

2 hp to 21.5 hp Electric2 hp to 21.5 hp Electric

Ignition Protected ModelsIgnition Protected ModelsIgnition Protected ModelsIgnition Protected Models

Stern Thruster Kits For All ModelsStAll Models

THRUSTER INSTALLATION1.1.MARK THE WATER LINEMARK THE WATER LINE2.2.HAUL AND BLOCK THE BOATHAUL AND BLOCK THE BOAT3.3.MARK THE RANGE OF LOCATIONS OF MARK THE RANGE OF LOCATIONS OF

THE BOTTOM OF THE TUNNELTHE BOTTOM OF THE TUNNEL4.4.MARK THE MOSTMARK THE MOST--FORWARD LOCATION AT FORWARD LOCATION AT 4.4.MARK THE MOSTMARK THE MOST FORWARD LOCATION AT FORWARD LOCATION AT

WHICH MINIMUM TUBE LENGTH CAN BE WHICH MINIMUM TUBE LENGTH CAN BE OBTAINEDOBTAINED

55 MARK THE ADJUSTED MOSTMARK THE ADJUSTED MOST FORWARD FORWARD 5.5.MARK THE ADJUSTED MOSTMARK THE ADJUSTED MOST--FORWARD FORWARD LOCATION AT WHICH MINIMUM TUBE LOCATION AT WHICH MINIMUM TUBE LENGTH CAN BE OBTAINEDLENGTH CAN BE OBTAINED

6.6.DRILL THE PILOT HOLESDRILL THE PILOT HOLES7.7.MARK AND CUT OUT THE HOLES FOR MARK AND CUT OUT THE HOLES FOR

THE TUNNELTHE TUNNELTHE TUNNELTHE TUNNEL

THRUSTER INSTALLATION8.8.MARK AND CUT THE TUBEMARK AND CUT THE TUBE9.9. INSTALLINSTALL THE TUBETHE TUBE10.10.INSTALL THE TAILPIECE AND POWERINSTALL THE TAILPIECE AND POWER--

HEADHEAD1111 CONNECT THE POWER HEAD TO ITS CONNECT THE POWER HEAD TO ITS 11.11.CONNECT THE POWER HEAD TO ITS CONNECT THE POWER HEAD TO ITS

POWER SUPPLYPOWER SUPPLY12.12.CONNECT THE CONTROL CABLES AND CONNECT THE CONTROL CABLES AND

CONTROL PANELSCONTROL PANELSCONTROL PANELSCONTROL PANELS13.13.DRY TESTINGDRY TESTING14.14.FAIRING AND PAINTINGFAIRING AND PAINTING15.15.LAUNCHLAUNCH

STERN THRUSTERSTERN THRUSTER TUNNEL SHOWN WITH STERN THRUSTER TUNNEL SHOWN WITH

OPTIONAL THRUST DIVERTERSOPTIONAL THRUST DIVERTERSOPTIONAL THRUST DIVERTERSOPTIONAL THRUST DIVERTERS

STERN TUNNEL BOLTS TO TRANSOMSTERN TUNNEL BOLTS TO TRANSOMDIVERTERS ARE USED FOR OBSTRUCTIONSDIVERTERS ARE USED FOR OBSTRUCTIONS

IGNITION PROTECTED THRUSTER

•• ISO 8846ISO 8846•• 100% WATERTIGHT IP67100% WATERTIGHT IP67•• PETROL / GASOLINE PETROL / GASOLINE •• PETROL / GASOLINE PETROL / GASOLINE

POWERED BOATSPOWERED BOATS•• STERN THRUSTERS STERN THRUSTERS --

WHERE TENDERS JET WHERE TENDERS JET WHERE TENDERS, JET WHERE TENDERS, JET SKIS OR SCOOTERS ARE SKIS OR SCOOTERS ARE GASOLINE POWEREDGASOLINE POWERED

•• IDEAL FOR BOW IN IDEAL FOR BOW IN “WET” CONDITIONS“WET” CONDITIONS

THRUSTER OPTIONS

Simple Single 6 Blade or 7 Simple Single 6 Blade or 7 Blade Prop DesignsBlade Prop Designs

Numerous Control Numerous Control Panel OptionsPanel Options

Several RemoteSeveral RemoteOptionsOptionsOptionsOptions

TunnelsTunnels

THRUSTER CONTROLS

BPJE2BPJE2 ALL CONTROL PANELS OFFER:ALL CONTROL PANELS OFFER:BPJE2BPJE2POWER ON PROTECTIONPOWER ON PROTECTION

DIRECTION CHANGE DELAYDIRECTION CHANGE DELAY

BPSE2BPSE2AUTOMATIC TURN OFF AFTER AUTOMATIC TURN OFF AFTER 30 MINUTES30 MINUTES

2 MINUTE CONTINUOUS RUN 2 MINUTE CONTINUOUS RUN WARNINGWARNING

WARNING LED AND BUZZERWARNING LED AND BUZZER

BPJDE2BPJDE2 WATERTIGHT TO IP66WATERTIGHT TO IP66

EZ DOCK CONTROL

BOW & BOW & STERN STERN THRUSTER THRUSTER THRUSTER THRUSTER CONTROL CONTROL CONTROL CONTROL WITH ONE WITH ONE KNOBKNOBKNOBKNOB

EZ DOCK CONTROL

PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITION

BOAT DIRECTIONBOAT DIRECTION BOAT DIRECTIONBOAT DIRECTION BOAT DIRECTIONBOAT DIRECTION BOAT DIRECTIONBOAT DIRECTION

EZ DOCK CONTROL

PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITIONPANEL POSITIONPANEL POSITIONPANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITION PANEL POSITIONPANEL POSITIONPANEL POSITIONPANEL POSITION

BOAT DIRECTIONBOAT DIRECTION BOAT DIRECTIONBOAT DIRECTION BOAT DIRECTIONBOAT DIRECTIONBOAT DIRECTIONBOAT DIRECTION

CONTROL OPTIONS

WIRELESS REMOTE KITS:WIRELESS REMOTE KITS:WIRELESS REMOTE KITS:WIRELESS REMOTE KITS:REMCO1REMCO1 BOW THRUSTER ONLYBOW THRUSTER ONLYREMCO2REMCO2 BOW & STERN THRUSTERBOW & STERN THRUSTERREMCO2REMCO2 BOW THRUSTER & WINDLASSBOW THRUSTER & WINDLASS

WIRELESS CONTROL PANELWIRELESS CONTROL PANELCONNECTION KITCONNECTION KIT

RCBPRCBP

THRUSTER MAINTENANCEZincs On Every ThrusterZincs On Every ThrusterBOW25 BOW25 BOW95 B hi d PBOW95 B hi d PBOW25 BOW25 –– BOW95 Behind PropBOW95 Behind PropBOW125 BOW125 –– BOW285 Front Of PropBOW285 Front Of Prop

Newer 6 Blade DesignNewer 6 Blade DesignNoise ReductionNoise ReductionR l ll 3 Bl d P E t BOW23R l ll 3 Bl d P E t BOW23Replaces all 3 Blade Props Except BOW23Replaces all 3 Blade Props Except BOW23

New Controls Include ElectronicsNew Controls Include ElectronicsNew Controls Include ElectronicsNew Controls Include ElectronicsReplaces All Older Controls / Adapter AvailableReplaces All Older Controls / Adapter AvailableSame 4 Pin Connection CableSame 4 Pin Connection Cable