uk model e modelmonitor.espec.ws/files/xm-sd46x__180.pdf · ver. 1.0 2004. 12 service manual us...

1

Ver. 1.0 2004. 12

SERVICE MANUAL US ModelCanadian Model

AEP ModelUK Model

E Model

XM-SD46X

AUDIO POWER SPECIFICATIONS (US MODEL)POWER OUTPUT AND TOTAL HARMONIC DISTORTION60 watts per channel minimum continuous average power into4 ohms, both channels driven from 20 Hz to 20 kHz with no morethan 0.08% total harmonic distortion per Car Audio Ad HocCommittee standards.

Other SpecificationsCircuit system OTL (output transformerless) circuit

Pulse power supplyInputs RCA pin jacks

High level input connectorOutputs Speaker terminalsSuitable speaker impedance

2 – 8 Ω (stereo)4 – 8 Ω (when used as a bridging amplifier)

Maximum outputs Four speakers:120 W × 4 (at 4 Ω)150 W × 4 (at 2 Ω)Three speakers:120 W × 2 + 300 W × 1 (at 4 Ω)

Rated outputs (supply voltage at 14.4 V)Four speakers:60 W RMS × 4 (20 Hz – 20 kHz,0.08% THD + N, at 4 Ω)75 W RMS × 4 (20 Hz – 20 kHz,0.1% THD + N, at 2 Ω)Three speakers:60 W RMS × 2 + 150 W RMS × 1 (20Hz – 20 kHz, 0.1% THD + N, at 4 Ω)

SN Ratio 97 dBA (Reference 1W into 4 Ω)Frequency response 5 Hz – 50 kHz ( dB)Harmonic distortion 0.005% or less (at 1 kHz)

SPECIFICATIONS

Input level adjustment range0.3 – 6.0 V (RCA pin jacks)1.2 – 12 V (High level input)

High-pass filter 50 – 300 Hz, –12 dB/octLow-pass filter 50 – 300 Hz, –12 dB/octLow boost 0 – 10 dB (40 Hz)Power requirements 12 V DC car battery

(negative ground)Power supply voltage 10.5 – 16 VCurrent drain at rated output: 31 A (4 Ω)

Remote input: 1 mADimensions Approx. 403 × 55 × 277 mm

(w/h/d) (15 7/8 × 2 1/4 × 11 in) notincl. projecting parts and controls

Mass Approx. 4.7 kg (10 lb. 6 oz.) not incl.accessories

Supplied accessories Mounting screws (4)High level input cord (1)Protection cap (1)

Design and specifications are subject to change withoutnotice.

Sony Corporatione Vehicle Company

Published by Sony Engineering Corporation

9-879-366-012004L04-1

© 2004. 12

STEREO POWER AMPLIFIER

+0–3

2

XM-SD46X

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!!

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LESDIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCESSONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCESSONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUELOU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

Notes on Chip Component Replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARK

Unleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40 °C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350 °C.Caution: The printed pattern (copper foil) may peel away if the

heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow) thanordinary solder so use caution not to let solder bridges occursuch as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

TABLE OF CONTENTS

1. GENERALLocation and Function of Controls .......................................... 3Connections ............................................................................. 4

2. DISASSEMBLY2-1. Bottom Plate ........................................................................ 62-2. Main Board Section ............................................................ 72-3. Main Board, Input Level Board .......................................... 72-4. LED Board .......................................................................... 8

3. ELECTRICAL ADJUSTMENT ...................................... 9

4. DIAGRAMS4-1. Block Diagram .................................................................. 114-2. Printed Wiring Board –Main Section– .............................. 124-3. Schematic Diagram –Main Section (1/2)– ........................ 134-4. Schematic Diagram –Main Section (2/2)– ........................ 144-5. Printed Wiring Boards –Input Level, LED Section– ......... 15

5. EXPLODED VIEWS5-1. Heat Sink (Main) Section .................................................. 165-2. Main Board Section .......................................................... 17

6. ELECTRICAL PARTS LIST ........................................ 18

3

XM-SD46XSECTION 1GENERAL This section is extracted

from instruction manual.

4

XM-SD46X

5

XM-SD46X

6

XM-SD46XSECTION 2

DISASSEMBLY

Note : This set can be disassemble according to the following sequence.

Note : Follow the disassembly procedure in the numerical order given.

2-1. BOTTOM PLATE

4 bottom plate

5 insulating sheet

1 two screws (+BTP 3 x 6)



2-1. BOTTOM PLATE()

2-2. MAIN BOARD SECTION (Page 7)

2-4. LED BOARD(Page 8)

SET

2-3. MAIN BOARD,INPUT LEVEL BOARD(Page 7)

7

XM-SD46X

2-3. MAIN BOARD, INPUT LEVEL BOARD

2-2. MAIN BOARD SECTION

heat sink (main)

6 CN850

5 MAIN board section

1 three screws (+P 3 x 8)


3 screw (+P 3 x 8)


7 front panel

5 INPUT LEVEL board

4 CNP101

8 MAIN boardtwo claws

6 bracket (HI LEVEL)

A

A

1 two screws (+P 3 x 8)


3 two screws (+P 3 x 8)

8

XM-SD46X

2-4. LED BOARD

3 LED board

2 bracket (LED)

heat sink (main)


9

XM-SD46X

Bias Adjustment

Note : The Bias adjustment should be performed only if any ofQ109 and Q110 for RV104, Q209 and Q210 for RV204,Q309 and Q310 for RV304, and Q409 and Q410 for RV404are replaced.

Setting :

Procedure:1. Rotate variable resistors RV104 (FRONT L-CH), RV204

(FRONT R-CH), RV304 (REAR L-CH) and RV404 (REARR-CH) full clockwise as seen from the pattern side to minimizethe bias current.

2. The input signal is with no signal.3. Connect the stabilized power supply between B+ and REM

terminals and gradually increase the voltage to 14.4 V whilechecking for any abnormal current.

4. Adjust RV104 (FRONT L-CH), RV204 (FRONT R-CH), RV304(REAR L-CH) and RV404 (REAR R-CH) so that the digitalvoltmeter connected between the respective test points reads6±1 mV.

5. After this adjustment, verify that the current value of thestabilized power supply is 1.4 to 1.8 A.

Adjustment Location :

SECTION 3ELECTRICAL ADJUSTMENT

+_

stabilized power supply

digitalvoltmeterB+, REM terminals

set

GND terminal test points

RV Ref. No. Test points

RV104 TP11 and TP12

RV204 TP21 and TP22

RV304 TP31 and TP32

RV404 TP41 and TP42

TP32

TP22

TP21

TP11

TP12

TP31TP41TP42

RV404BIAS ADJUSTMENT

(REAR R-CH) RV104BIAS ADJUSTMENT

(FRONT L-CH)


(FRONT R-CH)


(REAR L-CH)

– MAIN BOARD (CONDUCTOR SIDE) –

10

XM-SD46X

• IC BLOCK DIAGRAM

IC901 TL594INSR

SECTION 4DIAGRAMS

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printedin each block.)

for schematic diagram:Note:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwisespecified.

• % : indicates tolerance.• 2 : nonflammable resistor.• C : panel designation.

• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Power voltage is dc 14.4V and fed with regulated dc power

supply from +12V and REM terminals.• Voltage and waveform are dc with respect to ground un-

der no-signal condition.• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

F : AUDIO

for printed wiring boards:Note:• X : parts extracted from the component side.• : Pattern from the side which enables seeing.

Note:The components identi-fied by mark 0 or dottedline with mark 0 are criti-cal for safety.Replace only with partnumber specified.

Note:Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepiéce portant le numérospécifié.

16 15 14 13 12 11 10 9

1 2 3 4 5 6 7 8

OSC

REF. REG.

ERROR

ERROR

0.1V

Ref. No. LocationD101 D-10D141 E-12D201 G-10D241 F-12D301 D-10D341 C-10D401 D-8D441 C-9D801 E-8D802 E-8D805 D-8D824 D-8D825 D-8D826 D-8D827 D-8D828 C-7D829 C-7D901 H-2D902 H-2D903 E-6D904 E-6D905 D-6D906 D-6D907 B-2D908 C-2D911 D-6D912 E-6D913 F-8D914 F-8D917 E-6D918 E-5

IC801 H-9IC802 I-10IC806 H-10IC807 H-11IC808 H-8IC809 H-8IC811 G-7IC812 H-7IC813 G-7IC814 H-6IC901 G-1IC902 E-7

Q101 H-10Q102 E-11Q103 E-11Q104 E-11Q107 E-11Q108 E-11Q109 E-12Q110 D-12Q111 E-12

• Semiconductor Location (MAIN SECTION)

Q112 D-10Q201 H-12Q202 G-10Q203 F-11Q204 F-11Q207 F-11Q208 F-11Q209 G-12Q210 G-12Q211 F-12Q212 G-10Q301 G-6Q302 D-10Q303 C-10Q304 C-10Q307 C-10Q308 D-10Q309 B-10Q310 B-11Q311 B-10Q312 D-11Q401 H-6Q402 D-9Q403 C-9Q404 C-9Q407 C-9Q408 C-9Q409 B-8Q410 B-8Q411 B-9Q412 D-8Q801 E-8Q802 E-8Q803 A-5Q804 B-5Q805 A-4Q810 C-7Q812 B-4Q813 A-4Q814 A-3Q850 B-4Q901 H-1Q902 H-2Q903 H-2Q904 F-2Q905 E-2Q906 E-2Q907 D-2Q908 E-2Q909 E-2Q910 F-8Q911 F-8Q912 E-2Q913 E-2

Ref. No. Location

11 11

XM-SD46X

XM-SD46X

4-1. BLOCK DIAGRAM

32

1 32

21

PRE AMPIC801 (1/2) LINE AMP

IC802 (1/2)

56

7

LOW BOOSTIC806 (2/2)

HPFIC806 (1/2)

DIFFERENTIALAMPQ103

POWERAMPQ109

DRIVEAMPQ107

DIFFERENTIALAMPQ104

POWERAMPQ110

DRIVEAMPQ108

BIASQ111

BOOSTGAINQ101

FILTERS801-1

HPF

OFF

B+(+14.2V)

B–(–14.2V)

B+(+14.2V)

B–(–14.2V)

CNJ100-1

CNJ100-2

CNJ802 (1/2) RV801-2FILTER

RV803-1LEVEL

RV801-1FILTER

LINESWITCH

Q102

+12V

GND

10

7 56


IC802 (2/2)

56

7


DIFFERENTIALAMPQ203

POWERAMPQ209

DRIVEAMPQ207

DIFFERENTIALAMPQ204

SWITCHCONTROLQ801,802

POWERAMPQ210

DRIVEAMPQ208

BIASQ211

BOOSTGAINQ201RV802-2

LOWBOOST(40Hz)

RV802-1LOW

BOOST(40Hz)

RV805-1LOW

BOOST(40Hz)

RV805-2LOW

BOOST(40Hz)

-1L

-5L-6R-2R

L

(FRONT)

INPUT

(REAR)

INPUT

R

CN810

L

R

LINESWITCH

Q202

RV204BIAS

RV104BIAS

1516

12

14

12

TEMP.DETTHN801,804-807

REF.REG

CN800F90125A

SWITCHINGDRIVER

Q904,905

SWITCHINGDRIVER

Q906,907

DRIVERQ908,909

BUFFERQ913

BUFFERQ912

11

9

8

3D854

PROTECTORD850-853(POWER)

FRONTSPEAKER

OUT

DC-DCCONVERTER

TRANSFORMERT801

DC-DC CONVERTERIC901

• Signal path : AUDIO

2

3

1

POWERSWITCH

Q901

FILTERS801-2

HPF

OFF

OVER LOADDET

Q112

OVER LOADDET

Q212

CN811

L

(L+R)

R

REARSPEAKER

OUT

65

CNJ100-3

CNJ100-4

CNJ802 (2/2)

L(L+R)

R(L+R)

REM

PL802(PILOT LAMP)

+14.2VREGQ910

–14.2VREGQ911

B+(+23.5V)

B+(+23.5V)

B+(+37V)

B+(+30.5V)

(–30.5V)

(–37V)

(–14.2V)

B –

B –

B –

B+(+14.2V)

PROTECTIONQ812-814

PROTECTDRIVER

Q850

OFFSETDET

Q803-805

POWERON/OFFQ903

DC DETIC902

D903

D906

D905

D904

D917

D912

D911

D918

D905,906RECT

D911,912RECT

D903,904RECT

D917,918RECT

D907,908RECT

D907

D908

(FRONT)

(REAR)

-3L

-4R

-8R

-7L

HIGH LEVELINPUT(REAR)

HIGH LEVELINPUT

(FRONT)

F90225A

13

RV806-1LEVEL

21

HPFIC807 (1/2)

RV801-3FILTER

RV803-2LEVEL

RV801-4FILTER

37

7 56

7 3 1 6 7 6 7


IC809 (1/2)

32

1


HPFIC811 (1/2)

BPFIC811 (2/2)

LPFIC813 (1/2)

DIFFERENTIALAMPQ303

POWERAMPQ309

DRIVEAMPQ307

DIFFERENTIALAMPQ304

POWERAMPQ310

DRIVEAMPQ308

BIASQ311

BOOSTGAINQ301

B+(+14.2V)

B–(–14.2V)

B+(+14.2V)

B–(–14.2V)

RV804-1FILTER

RV804-2FILTER

LINESWITCH

Q302

1 32

1 3 1 6 7 6 7


IC809 (2/2)

32

1


HPFIC812 (1/2)

BPFIC812 (2/2)

LPFIC814 (1/2)

DIFFERENTIALAMPQ403

POWERAMPQ409

DRIVEAMPQ407

DIFFERENTIALAMPQ404

POWERAMPQ410

DRIVEAMPQ408

BIASQ411

BOOSTGAINQ401

RV804-3FILTER

RV804-4FILTER

LINESWITCH

Q402

RV404BIAS

RV304BIASFILTER

S802-1

LPF

OFF

HPF

FILTERS802-2

LPF

OFF

HPF

OVER LOADDET

Q4123

OVER LOADDET

Q31265

2

RV806-2LEVEL

BUFFERQ810

VCC

REF

D829 D828

OVERVOLTAGEDETECT

Q902

1212

XM-SD46X

XM-SD46X

4-2. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 10 for Semiconductor Location. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

C907

R203

C115

C104

R20

6

C103

C203

C204

R205

R10

6 R201

R12

2

R102

R202

R10

5

R120

Q201

R10

1

R224

R22

1

C213

R22

0

R117

C113

R218

R21

7

C902

Q101

R124

R118

R121

R222

R204

C215

C111

R213

R11

1

R211

R113

R21

5

R21

4

C901

R119R219

R11

4

R11

5

C211

R12

6R

326

R426

C421

C303

C304

C305

C311

C313

C315

C403

C404

C405

C415

C411

C413

R30

1

R30

2

R30

3

R30

4 R30

5

R30

6

R30

7

R30

8R

309

R31

0

R311

R31

2

R31

3

R31

4

R31

5 R31

6

R317 R31

8R319R320R

321 R322

R324

R401

R403

R405

R40

6

R40

7

R408

R40

9

R410

R411

R41

2

R41

3

R41

4

R41

5

R41

6

R417

R41

8

R419

R42

0

R421

R42

2

R42

4Q301

Q401

C221

R226

R402R404

C908

R10

3

R104

C122

C222

C322

C422

C808

C233

THN

801

C937

C818

C225

C802

C817

C133

C125

C126

C434

C325

C326

C425

THN807

THN806

C426

C226

C334

C433

C333

C134

C913

C234

C914

THN804

C806

C807

C975

C976

THN805Q102

Q207

Q908

Q909

Q902

Q903

Q804

Q803

Q805

Q108

Q107

Q104

Q802

Q801

Q208

Q813

Q812

Q203

Q814

Q103

Q304

Q303

Q204

Q307

Q308

Q404

Q403Q407

Q408

Q302

Q202

Q402

Q112

Q312Q412

Q212

Q850

Q912

Q913

D80

5

D90

2D901

D80

2D

801

D90

6

D91

1

D914 D913

D829

D34

1

D82

8

D90

5

D82

4

D14

1

D82

5

D82

7

D826

D91

2

D10

1

D20

1

D301D40

1

D24

1

D441

IC901

R22

7

R80

3

R24

2

R244

R84

3

R231

R444

R921

R92

0

R80

4

R45

0

R918 R800

R85

0R

902

R90

3R

905

R841

R431

R91

0

R90

6

R915

R13

1

R829

R130

R228

R129

R229

R90

9

R83

0

R82

7

R81

0

R80

8

R806R807

R33

7

R150

R813

R854

R82

5

R82

6

R82

4

R901

R128

R328

R80

2

R33

1R

330

R329

R43

0

R429

R432

R911

R809

R438

R85

5

R805

R856

R23

0

R23

2

R13

2

R90

4 R235

R14

5

R236

R237

R442R335

R931

R801

R42

7

R934

R82

8

R437

R338

R345

R24

5

R136

R238

R138

R14

2

R342

R350

R435

R44

5

R336

R144

R436

R923

R91

6

R33

2

R327

R127

R428

R924

R914

R917R929

R913

R922

R930

R839

R93

3

R135

R83

8

R137

R250

R34

4

R84

5

R84

7

R927

R925

R87

0

R932

JR1

JR2

JR3

JR4

JR5

JR6

JR7

JR8

JR9

JR10

JR11

JR12

JR13

JR14JR

15

JR16

Q810

IC807

IC802

IC806

IC801

IC808

IC809

IC812

IC811

IC814

IC813

RV802RV803

CNP101

RV801

CNJ100

(L+R)

RV806RV804

S802

RV805

S801

C919

RV304

RV104

RV204

RV404

C959

C918

C920

C958

C921

L901

C917

C916

C930C931

C950C951

C952

C953

PL802

CN850

CN810CN811

CN800

L904

Q20

9Q

210

Q11

0

Q409

Q410 Q310Q309

Q21

1Q

111

Q10

9

Q90

1

Q911

Q90

5Q

907

Q90

4Q

906

Q910

Q311

Q411

D90

8

D917

D918

D90

7

D904

D903

IC902

R25

8

R458

R15

8

R358

JW14

JW15

JW16

JW19

JW20

JW23

JW24

JW25

JW26

JW27

JW28

JW29

JW30

JW31

JW32

JW33

JW34

JW35

JW36

JW37

JW38

JW39

JW40

JW41

JW42

JW43

JW44

JW46

JW47

JW48

JW49JW50

JW58

JW59

JW61

JW62

JW63

JW64

JW65

JW67

JW68

JW69JW70

JW73

JW74

JW76

JW77

JW78

JW79

JW80

JW81

JW82

JW83

JW84

JW85

JW86

JW87

JW88

JW92

JW93

JW94

JW97

JW10

7

JW114

JW115

JW11

6

JW11

8

JW11

9

JW135

JW137

JW14

3

JW144

JW145

T801

F902 F901

JW147

JW148JW149

JW150JW151

JW152JW153

JW15

4JW

155

JW15

6

JW157JW158

JW159

JW16

0

JW16

1

JW16

2

JW16

3JW165JW166

JW167JW168

JW169

JW171

JW172

JW173JW174

JW17

9JW

180

JW181

JW182

JW183

JW184

JW18

5

JW18

6

JW18

7

JW188JW189

JW190

JW191

JW192

JW193

JW194JW195

JW196

JW197

JW198

JW199JW200

JW201

JW202

JW203

JW20

4JW

205

JW20

6

JW20

7

JW20

8JW

209

JW21

0

JW21

1

JW21

2

JW21

3

JW21

4

JW21

5

JW216

JW217

JW218

JW219

JW220

JW221JW222

JW223

JW22

4

JW22

5

JW22

6JW

227

JW22

8

JW229

JW230

JW231JW232

JW233JW234

JW236JW237 JW238

JW239

JW240

JW241

JW242

JW243JW244

JW245

JW246

JW247

JW248

JW24

9JW250JW251

JW252

JW25

3

JW25

4JW

255

JW256

JW257

JW267

JW268

JW26

9JW27

0

JW27

9

JW28

0JW

281

JW28

2

JW28

3

JW28

4JW

285

JW28

6

JW287

JW28

8

JW289

JW29

0

JW29

1

JW29

2

JW293

JW294

JW295

JW296

JW297

JW298

JW299

JW30

0

JW30

1

JW30

2JW

303

JW30

4JW30

5

JW30

6JW

307

JW308

JW30

9

JW110

L903

L906

L905

JW12

0

JW12

1JW142

JW141

JW7

JW8

JW310

JW311

L902JW

312

JW10

8

JW75

C924

C925

R15

1

R25

1

R35

1

R45

1

R440 R340

R14

0

R240

L911

L912

C212

C208

C209

C108

C109

C112

C202C102C101

C301

C402

C401

C302 C201

C308

C310

C309

C408

C410C409

C412

C312

C911C910

C912

C223

C123

C801

C323C423

C830

C803

C809

C821

C922

C923

C909

C915

C428

C328

C933

C407

C307

C406

C306

C227

C127

C327

C427

C128C228

C207

C206

C106

C107

C121

C929C928

C971

C980

C981

C972

C983

C982

R13

9

R239

R33

9

R43

9

R811

R82

1

R90

7

R91

2

R233

R23

4

R433

R43

4

R333

R334

R133

R134

JW52

JW26

2

JW51

JW53

JW55

JW56JW57

JW54

JW66

JW23

5

JW315

JW139JW138

JW26

3

JW170

JW13

6

JW14

0

JW146

C804

JW16

4

1-865-444-

INPUT LEVEL

(Page 15)

(Page 15)

13 13

XM-SD46X

XM-SD46X

(Page 14)

C101

C102

C112

C121

C123

C201

C202

C212

C223

C301

C302

C312

C323

C401

C412

C423

Q11

1Q

211

Q31

1Q

411

RV104

RV204

RV304

RV404

CNP101

R151

R251

R351

R451

R134

R233

R234

R333

R433

R434

R139

R239

R339

R439

R140

R240

R340

R440

R125

R225

R325

R425

C119C117

C118 C120

C219

C220

C218

C217

C319C317

C320C318

C419C418

C417 C420

C122

C221 R226

R126

C222

R326

C322 R426C421

C422

R111

C115

R124

C206R211

C215C207

R213R224

R310

R312

C305

R309

R307

R311 C306

R313

C307

C315

R324 R308

R412R410

C415

R407C405

R409

R411

C406

R413

R424 R408

C407

C106 C107

R117

C111

R119

C113

R118 R120 R121 R122

R217

C211

R219

C213

R218 R220 R221 R222

R317

C311

R319

R318 R320 R321 R322

C313

R417

C411

R419

C413

R418 R420 R421 R422

C908

R445

R444 R450

C427

C434

C426

C425

C433

C907R328

R327C327C326

C325

C333

C902

R227

C234

C226C227

C233

C225R235

R237

R127

C901

C126 C127

C125R135

R137

C128

C975

C976

C228

R245

R150

R244 R250

R345

R344 R350

R335

R337

C428

R427

C134

R129

R131

R229

R231

R232

R230R228

R331

R329

R330

R332

R429

R431

R432

R430

R428

Q103

Q104

Q203

Q204

Q303

Q304

Q403

Q404

R132

R130

R128

R133 C133

R138

R136

Q110

Q109

R238

R236Q210

Q209

R338

R336

R438

R436

R437

R435

Q410

Q409

R334C334

Q310

Q309

R145

R144

R215R214

R114 R115R113

R315R314 R316

R415R414 R416

R102

R101

R103

R104

R305 C303

R301

R302

R303

R304

R205 C203

R201

R202

R203

R204

C103R105

R406

C404R404

R403

R402

R401

C403R405

IC801(1/2)

S801

S801

S802

S802

IC802(1/2)IC806(2/2)

IC801(2/2)

IC802(2/2)

IC807(1/2)

IC807(2/2)

IC811(1/2)

IC811(2/2) IC813(1/2)

IC813(2/2)

C104

R106

C204

R206

C304

R306

CNJ802

CNJ101

CNJ100

IC808(2/2)

IC809(2/2)

IC812(1/2)

IC812(2/2) IC814(1/2)

IC814(2/2)

Q107

Q108

Q207

Q208

Q307

Q308

Q407

Q408

Q302

Q402

Q202

Q102

D14

1

D101

D24

1

D201

D34

1

D301

D44

1

D401

Q312

Q212

Q112

Q412

C328

CN811

CN810

C402

RV803RV801

RV801

IC806(1/2)

C109

C108

RV802

R142

R158 TP11

TP13TP12

TP21

TP22TP23

TP31

TP32TP33

TP41

TP42TP43

RV803

RV801

RV801

C209

C208

RV802

R242

R258

IC808(1/2)

IC809(1/2)

RV806

RV804 RV804

C310

C309

C308

RV805

R342

R358

RV806

RV804 RV804

C408

C409

C410

RV805

R442

R458

Q101

Q201

Q401

Q301

INPUT LEVEL

4-3. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) —

1414

XM-SD46X

XM-SD46X

IC B/D

C803

C916

C917

C918

C919THN

801

THN

804

THN

805

THN

806

THN

807

D906

D911

D912

C931

C930

CN850

C921

C920

D907

D908

Q905

L901

L902

C830

CN800

R912

R907

R911

C915 C913

C914

C807 R826

R825

R824

R915

R910

R90

4

R905

R909

R839C818

R85

0

R90

2

C937

R90

3

C909

R901 R929

R934 R932

R933 R931

R930

C806

R924

R906

R805

R801R802

R856

R806

R854

R855

R810C802

R808

R807

R809

R923

C922

R828

R827 C809 C817

R829

C808 R830R811

R803

R804

C801

R800

D905

D918

D917

D904

D903

C923

C933

Q904

R921

Q907

R920

Q906

R922

R927

R925

R917 R913

R918 R914

R916

C912

C910

F902

F901

Q903

D902

D901

Q802

Q805

Q803

L912

L906

L905

L904

L903

L911

D824

D825

D826

D827

D805

Q908

Q909

D828 D829

D802

D801

IC902

D913

D914

C804

R84

1

R84

3

R84

5

R84

7

R83

8

IC901

C911

PL802

C925

C924

C928

C929

C971

C972

C958 C951 C950

C959 C953 C952

C821

Q814

Q812

Q901

Q810

Q912

Q913

Q910

Q911

T801

C982

C980

C981

C983

R870

Q850

Q804

Q801

Q902

Q813

R821

R813

R861R857

R851

R853

R852

JR800

D853 D852

D851 D850CN852

R860

D854

4-4. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 10 for IC Block Diagram.

• Waveform

(Page 13)

Note:The components identi-fied by mark 0 or dottedline with mark 0 are criti-cal for safety.Replace only with partnumber specified.

Note:Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepiéce portant le numérospécifié.

3.4 Vp-p

15 µsec

1 IC901 5

1 V/DIV, 5 µsec/DIV

15

XM-SD46X

4-5. PRINTED WIRING BOARDS — INPUT LEVEL, LED SECTION — : Uses unleaded solder.

(Page 12)

(Page 12)

1

A

B

C

D

E

F

G

2 3 4 5 6 7

D853

R860 R853

R857

D854PROTECTOR

D850-853(POWER)

D852

R85

1R

852

R861

D850

1-865-446-1-865-488-

JR8003

1CN852

D851

C418

C218

C320

C118

C117

C318

C317

C120

C217

C219

C220

C419

C319

C420

C417

C119

CNJ101

CNJ802

JW3

JW4JW6

JW9

R12

5 R225 R325

R425

JW313

JW314

INPUT LEVELBOARD BOARD

LED

16

XM-SD46XSECTION 5

EXPLODED VIEWS

Ref. No. Part No. Description Remark

5-1. HEAT SINK (MAIN) SECTION

Ref. No. Part No. Description Remark

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

Les composants identifiés par unemarque 0 sont critiques pourla sécurité.Ne les remplacer que par une piéceportant le numéro spécifié.

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color• Accessories are given in the last of this parts list.

R R

1 X-2025-302-1 PLATE ASSY, ORNAMENTAL0F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)0F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)

#1 7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S#2 7-685-546-19 SCREW +BTP 3X8 TYPE2 N-S#3 7-685-649-79 SCREW +BVTP 3X14 TYPE2 N-S

1

#1

#1

#2

#2

#2

#2

#3

#3

#2

F901F902

not supplied

not supplied

not supplied

not suppliednot supplied(LED board)

17

XM-SD46X

5-2. MAIN BOARD SECTION

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

51 3-262-164-01 PANEL (FRONT)52 A-1083-678-A MAIN BOARD, COMPLETE53 3-249-924-01 BRACKET (HIGH LEVEL)54 3-238-413-01 SHEET (TR), INSULATING55 3-225-183-22 SCREW (+PSW.TT.3XL)

56 3-225-183-32 SCREW (+PSW.TT.3XL)

57 3-225-184-12 SCREW (+PS.TT.3XL)58 3-253-537-01 SCREW (M5X11)59 3-912-431-01 SCREW (+-P)60 A-1090-736-A INPUT LEVEL BOARD, COMPLETE#4 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT

51

52

53

57

57

58

59

59

59

57 56

54

60

54

55

55

A

B

A

B

#4

not supplied

not supplied

not supplied

not supplied

not supplied

#4

#4

18

XM-SD46XSECTION 6

ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC..: µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark


Les composants identifiés par unemarque 0 sont critiques pourla sécurité.Ne les remplacer que par une piéceportant le numéro spécifié.

When indicating parts by referencenumber, please include the board.

A-1090-736-A INPUT LEVEL BOARD, COMPLETE****************************

3-249-924-01 BRACKET (HIGH LEVEL)7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT

< CAPACITOR >

C117 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC118 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC119 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC120 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC217 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C218 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC219 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC220 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC317 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC318 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C319 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC320 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC417 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC418 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC419 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16V

C420 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16V

< CONNECTOR >

CNJ101 1-784-916-11 CONNECTOR, BOARD TO BOARD 9PCNJ802 1-580-283-11 PIN, CONNECTOR (PC BOARD) 8P

(HIGH LEVEL INPUT)

< RESISTOR >

R125 1-249-421-11 CARBON 2.2K 5% 1/4WR225 1-249-421-11 CARBON 2.2K 5% 1/4WR325 1-249-421-11 CARBON 2.2K 5% 1/4WR425 1-249-421-11 CARBON 2.2K 5% 1/4W

*************************************************************

LED BOARD**********

< DIODE >

D850 6-501-118-01 LED SEL6E10C-STP5 (POWER)D851 6-501-118-01 LED SEL6E10C-STP5 (POWER)D852 6-501-118-01 LED SEL6E10C-STP5 (POWER)D853 6-501-118-01 LED SEL6E10C-STP5 (POWER)D854 6-501-117-01 LED SEL2110W-TP3 (PROTECTOR)

< JUMPER RESISTOR >

JR800 1-216-296-11 SHORT CHIP 0

< RESISTOR >

R851 1-216-815-11 METAL CHIP 330 5% 1/10WR852 1-216-815-11 METAL CHIP 330 5% 1/10WR853 1-216-815-11 METAL CHIP 330 5% 1/10WR857 1-216-815-11 METAL CHIP 330 5% 1/10WR860 1-216-815-11 METAL CHIP 330 5% 1/10W

R861 1-216-815-11 METAL CHIP 330 5% 1/10W*************************************************************

A-1083-678-A MAIN BOARD, COMPLETE*********************

3-225-183-22 SCREW (+PSW.TT.3XL)3-225-183-32 SCREW (+PSW.TT.3XL)3-225-184-12 SCREW (+PS.TT.3XL)3-238-413-01 SHEET (TR), INSULATING3-253-537-01 SCREW (M5X11)

3-912-431-01 SCREW (+-P)7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT

< CAPACITOR >

C101 1-126-794-11 ELECT 4.7uF 20% 50VC102 1-126-794-11 ELECT 4.7uF 20% 50VC103 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC104 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC106 1-136-167-00 FILM 0.15uF 5% 50V

C107 1-136-167-00 FILM 0.15uF 5% 50VC108 1-126-795-11 ELECT 10uF 20% 50VC109 1-126-795-11 ELECT 10uF 20% 50VC111 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC112 1-126-794-11 ELECT 4.7uF 20% 50V

C113 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

INPUT LEVEL MAINLED

19

XM-SD46X


C115 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC121 1-128-499-11 ELECT 220uF 20% 16VC122 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC123 1-126-786-11 ELECT 47uF 20% 16VC125 1-162-918-11 CERAMIC CHIP 18PF 5% 50V

C126 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC127 1-136-497-81 FILM 0.1uF 5% 50VC128 1-136-161-00 FILM 0.047uF 5% 50VC133 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC134 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C201 1-126-794-11 ELECT 4.7uF 20% 50VC202 1-126-794-11 ELECT 4.7uF 20% 50VC203 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC204 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC206 1-136-167-00 FILM 0.15uF 5% 50V

C207 1-136-167-00 FILM 0.15uF 5% 50VC208 1-126-795-11 ELECT 10uF 20% 50VC209 1-126-795-11 ELECT 10uF 20% 50VC211 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC212 1-126-794-11 ELECT 4.7uF 20% 50V

C213 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC215 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC221 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC222 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC223 1-126-786-11 ELECT 47uF 20% 16V

C225 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC226 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC227 1-136-497-81 FILM 0.1uF 5% 50VC228 1-136-161-00 FILM 0.047uF 5% 50VC233 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C234 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC301 1-126-794-11 ELECT 4.7uF 20% 50VC302 1-126-794-11 ELECT 4.7uF 20% 50VC303 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC304 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C305 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC306 1-136-167-00 FILM 0.15uF 5% 50VC307 1-136-167-00 FILM 0.15uF 5% 50VC308 1-126-795-11 ELECT 10uF 20% 50VC309 1-126-795-11 ELECT 10uF 20% 50V

C310 1-126-795-11 ELECT 10uF 20% 50VC311 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC312 1-126-794-11 ELECT 4.7uF 20% 50VC313 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC315 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C322 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC323 1-126-786-11 ELECT 47uF 20% 16VC325 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC326 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC327 1-136-497-81 FILM 0.1uF 5% 50V

C328 1-136-161-00 FILM 0.047uF 5% 50VC333 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC334 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC401 1-126-794-11 ELECT 4.7uF 20% 50VC402 1-126-794-11 ELECT 4.7uF 20% 50V

C403 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC404 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC405 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C406 1-136-167-00 FILM 0.15uF 5% 50VC407 1-136-167-00 FILM 0.15uF 5% 50VC408 1-126-795-11 ELECT 10uF 20% 50VC409 1-126-795-11 ELECT 10uF 20% 50VC410 1-126-795-11 ELECT 10uF 20% 50V

C411 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC412 1-126-794-11 ELECT 4.7uF 20% 50VC413 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC415 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC421 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16V

C422 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC423 1-126-786-11 ELECT 47uF 20% 16VC425 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC426 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC427 1-136-497-81 FILM 0.1uF 5% 50V

C428 1-136-161-00 FILM 0.047uF 5% 50VC433 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC434 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC801 1-126-796-11 ELECT 22uF 20% 50VC802 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V

C803 1-126-786-11 ELECT 47uF 20% 16VC804 1-136-497-81 FILM 0.1uF 5% 50VC806 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC807 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC808 1-162-962-11 CERAMIC CHIP 470PF 10% 50V

C809 1-126-964-11 ELECT 10uF 20% 50VC817 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC818 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC821 1-136-497-81 FILM 0.1uF 5% 50VC830 1-126-786-11 ELECT 47uF 20% 16V

C901 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC902 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC907 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC908 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC909 1-130-471-00 MYLAR 0.001uF 5% 50V

C910 1-126-786-11 ELECT 47uF 20% 16VC911 1-126-960-11 ELECT 1uF 20% 50VC912 1-104-665-11 ELECT 100uF 20% 25VC913 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC914 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V

C915 1-137-194-81 FILM 0.47uF 5% 50VC916 1-131-731-11 ELECT 2200uF 20% 16VC917 1-131-731-11 ELECT 2200uF 20% 16VC918 1-131-731-11 ELECT 2200uF 20% 16VC919 1-131-731-11 ELECT 2200uF 20% 16V

C920 1-126-968-11 ELECT 100uF 20% 50VC921 1-126-968-11 ELECT 100uF 20% 50VC922 1-136-497-81 FILM 0.1uF 5% 50VC923 1-136-497-81 FILM 0.1uF 5% 50VC924 1-126-968-11 ELECT 100uF 20% 50V

C925 1-126-968-11 ELECT 100uF 20% 50VC928 1-136-497-81 FILM 0.1uF 5% 50VC929 1-136-497-81 FILM 0.1uF 5% 50VC930 1-126-942-61 ELECT 1000uF 20% 25VC931 1-126-942-61 ELECT 1000uF 20% 25V

C933 1-136-161-00 FILM 0.047uF 5% 50VC937 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC950 1-100-199-31 ELECT 2200uF 20% 50V

MAIN

20

XM-SD46X


C951 1-100-199-31 ELECT 2200uF 20% 50VC952 1-100-199-31 ELECT 2200uF 20% 50VC953 1-100-199-31 ELECT 2200uF 20% 50VC958 1-100-199-31 ELECT 2200uF 20% 50VC959 1-100-199-31 ELECT 2200uF 20% 50V

C971 1-136-497-81 FILM 0.1uF 5% 50VC972 1-136-497-81 FILM 0.1uF 5% 50VC975 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC976 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC980 1-125-969-11 CERAMIC 680PF 10% 1KV

C981 1-125-969-11 CERAMIC 680PF 10% 1KVC982 1-125-969-11 CERAMIC 680PF 10% 1KVC983 1-125-969-11 CERAMIC 680PF 10% 1KV

< TERMINAL BOARD >

CN800 1-694-983-11 TERMINAL BOARD (3P+FUSE)(REM,+12V,GND,25A,25A)

CN810 1-694-985-11 TERMINAL BOARD (4P)(SPEAKER OUT (FRONT))

CN811 1-694-985-11 TERMINAL BOARD (4P) (SPEAKER OUT (REAR))

< CONNECTOR >

CN850 1-506-468-11 PIN, CONNECTOR 3PCNP101 1-784-917-11 PIN, CONNECTOR (PWB) 9P

< JACK >

CNJ100 1-779-078-41 JACK, PIN 4P (INPUT)

< DIODE >

D101 8-719-016-74 DIODE 1SS352D141 8-719-017-03 DIODE 02DZ4.7-TPH3D201 8-719-016-74 DIODE 1SS352D241 8-719-017-03 DIODE 02DZ4.7-TPH3D301 8-719-016-74 DIODE 1SS352

D341 8-719-017-03 DIODE 02DZ4.7-TPH3D401 8-719-016-74 DIODE 1SS352D441 8-719-017-03 DIODE 02DZ4.7-TPH3D801 8-719-065-18 DIODE 02DZ6.8-Y(TPH3)D802 8-719-016-74 DIODE 1SS352

D805 8-719-016-74 DIODE 1SS352D824 8-719-016-74 DIODE 1SS352D825 8-719-016-74 DIODE 1SS352D826 8-719-016-74 DIODE 1SS352D827 8-719-016-74 DIODE 1SS352

D828 8-719-016-74 DIODE 1SS352D829 8-719-016-74 DIODE 1SS352D901 8-719-065-18 DIODE 02DZ6.8-Y(TPH3)D902 8-719-065-46 DIODE 02DZ16-Z(TPH3)D903 8-719-987-67 DIODE 11EFS2

D904 8-719-987-67 DIODE 11EFS2D905 8-719-079-92 DIODE 1SR159-200TE25D906 8-719-079-92 DIODE 1SR159-200TE25D907 8-719-079-00 DIODE FCH10A15D908 8-719-079-01 DIODE FRH10A15

D911 8-719-079-92 DIODE 1SR159-200TE25D912 8-719-079-92 DIODE 1SR159-200TE25D913 8-719-065-43 DIODE 02DZ15-Z(TPH3)D914 8-719-065-43 DIODE 02DZ15-Z(TPH3)

D917 8-719-987-67 DIODE 11EFS2D918 8-719-987-67 DIODE 11EFS2

< FUSE >

0F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)0F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)

< IC >

IC801 8-759-385-17 IC NJM4580E(TE2)IC802 8-759-385-17 IC NJM4580E(TE2)IC806 8-759-385-17 IC NJM4580E(TE2)IC807 8-759-385-17 IC NJM4580E(TE2)IC808 8-759-385-17 IC NJM4580E(TE2)

IC809 8-759-385-17 IC NJM4580E(TE2)IC811 8-759-385-17 IC NJM4580E(TE2)IC812 8-759-385-17 IC NJM4580E(TE2)IC813 8-759-385-17 IC NJM4580E(TE2)IC814 8-759-385-17 IC NJM4580E(TE2)

IC901 6-703-643-01 IC TL594INSR

< PHOTO TRANSISTOR >

IC902 8-719-800-42 PHOTO TRANSISTOR TLP521-1-A

< JUMPER RESISTOR >

JR1 1-216-296-11 SHORT CHIP 0JR2 1-216-295-11 SHORT CHIP 0JR3 1-216-296-11 SHORT CHIP 0JR4 1-216-296-11 SHORT CHIP 0JR5 1-216-296-11 SHORT CHIP 0



JR16 1-216-296-11 SHORT CHIP 0

< COIL >

L901 1-419-851-12 INDUCTOR 50uHL902 1-410-396-41 FERRITE 0.45uH

< PILOT LAMP >

PL802 1-517-156-91 LAMP, PILOT (65mA/14V)

< TRANSISTOR >

Q101 8-729-107-45 TRANSISTOR 2SC3624A-L16Q102 8-729-202-38 TRANSISTOR 2SC3326N-AQ103 8-729-014-87 TRANSISTOR 2SC4207-YGRTE85RQ104 8-729-014-85 TRANSISTOR 2SA1618-YGRTE85RQ107 8-729-046-32 TRANSISTOR 2SA1201-Y(TE12L.C)

Q108 8-729-051-72 TRANSISTOR 2SC2881-Y(TE12L.C)Q109 8-729-924-78 FET IRF540


Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepiéce portant le numéro spécifié.

MAIN

21

XM-SD46X


Q110 8-729-053-85 FET IRF9540Q111 8-729-041-66 TRANSISTOR 2SC4015TV2Q112 8-729-200-13 TRANSISTOR 2SC2712-YQ201 8-729-107-45 TRANSISTOR 2SC3624A-L16Q202 8-729-202-38 TRANSISTOR 2SC3326N-A

Q203 8-729-014-87 TRANSISTOR 2SC4207-YGRTE85RQ204 8-729-014-85 TRANSISTOR 2SA1618-YGRTE85RQ207 8-729-046-32 TRANSISTOR 2SA1201-Y(TE12L.C)Q208 8-729-051-72 TRANSISTOR 2SC2881-Y(TE12L.C)Q209 8-729-924-78 FET IRF540





Q410 8-729-053-85 FET IRF9540Q411 8-729-041-66 TRANSISTOR 2SC4015TV2Q412 8-729-200-13 TRANSISTOR 2SC2712-YQ801 8-729-216-22 TRANSISTOR 2SA1162-GQ802 8-729-200-13 TRANSISTOR 2SC2712-Y

Q803 8-729-200-13 TRANSISTOR 2SC2712-YQ804 8-729-216-22 TRANSISTOR 2SA1162-GQ805 8-729-200-13 TRANSISTOR 2SC2712-YQ810 8-729-051-72 TRANSISTOR 2SC2881-Y(TE12L.C)Q812 8-729-200-13 TRANSISTOR 2SC2712-Y

Q813 8-729-216-22 TRANSISTOR 2SA1162-GQ814 8-729-200-13 TRANSISTOR 2SC2712-YQ850 8-729-216-22 TRANSISTOR 2SA1162-GQ901 8-729-052-82 TRANSISTOR KTA1281Y-ATQ902 8-729-216-22 TRANSISTOR 2SA1162-G

Q903 8-729-200-13 TRANSISTOR 2SC2712-YQ904 6-550-341-01 FET FKV550NQ905 6-550-341-01 FET FKV550NQ906 6-550-341-01 FET FKV550NQ907 6-550-341-01 FET FKV550N

Q908 8-729-202-38 TRANSISTOR 2SC3326N-AQ909 8-729-202-38 TRANSISTOR 2SC3326N-AQ910 8-729-209-15 TRANSISTOR 2SD2012Q911 8-729-209-60 TRANSISTOR 2SB1375Q912 8-729-051-72 TRANSISTOR 2SC2881-Y(TE12L.C)

Q913 8-729-051-72 TRANSISTOR 2SC2881-Y(TE12L.C)

< RESISTOR >

R101 1-216-837-11 METAL CHIP 22K 5% 1/10WR102 1-216-837-11 METAL CHIP 22K 5% 1/10WR103 1-216-845-11 METAL CHIP 100K 5% 1/10WR104 1-216-845-11 METAL CHIP 100K 5% 1/10WR105 1-216-837-11 METAL CHIP 22K 5% 1/10W

R106 1-216-837-11 METAL CHIP 22K 5% 1/10WR111 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR113 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR114 1-216-845-11 METAL CHIP 100K 5% 1/10WR115 1-216-845-11 METAL CHIP 100K 5% 1/10W

R117 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR118 1-216-833-11 METAL CHIP 10K 5% 1/10WR119 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR120 1-216-819-11 METAL CHIP 680 5% 1/10WR121 1-216-837-11 METAL CHIP 22K 5% 1/10W

R122 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR124 1-216-033-00 RES-CHIP 220 5% 1/10WR126 1-216-214-00 RES-CHIP 4.7K 5% 1/8WR127 1-216-837-11 METAL CHIP 22K 5% 1/10WR128 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R129 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR130 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR131 1-216-837-11 METAL CHIP 22K 5% 1/10WR132 1-216-837-11 METAL CHIP 22K 5% 1/10WR133 1-249-409-11 CARBON 220 5% 1/4W

R134 1-249-409-11 CARBON 220 5% 1/4WR135 1-216-809-11 METAL CHIP 100 5% 1/10WR136 1-216-809-11 METAL CHIP 100 5% 1/10WR137 1-216-845-11 METAL CHIP 100K 5% 1/10WR138 1-216-845-11 METAL CHIP 100K 5% 1/10W

R139 1-249-417-11 CARBON 1K 5% 1/4WR140 1-249-421-11 CARBON 2.2K 5% 1/4WR142 1-216-033-00 RES-CHIP 220 5% 1/10WR144 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR145 1-216-830-11 METAL CHIP 5.6K 5% 1/10W

R150 1-216-853-11 METAL CHIP 470K 5% 1/10WR151 1-215-857-31 METAL OXIDE 10 5% 1W FR158 1-205-991-11 METAL 0.1X2 5WR201 1-216-837-11 METAL CHIP 22K 5% 1/10WR202 1-216-837-11 METAL CHIP 22K 5% 1/10W

R203 1-216-845-11 METAL CHIP 100K 5% 1/10WR204 1-216-845-11 METAL CHIP 100K 5% 1/10WR205 1-216-837-11 METAL CHIP 22K 5% 1/10WR206 1-216-837-11 METAL CHIP 22K 5% 1/10WR211 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R213 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR214 1-216-845-11 METAL CHIP 100K 5% 1/10WR215 1-216-845-11 METAL CHIP 100K 5% 1/10WR217 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR218 1-216-833-11 METAL CHIP 10K 5% 1/10W

R219 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR220 1-216-819-11 METAL CHIP 680 5% 1/10WR221 1-216-837-11 METAL CHIP 22K 5% 1/10WR222 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR224 1-216-033-00 RES-CHIP 220 5% 1/10W

R226 1-216-821-11 METAL CHIP 1K 5% 1/10W

MAIN

22

XM-SD46X


R227 1-216-837-11 METAL CHIP 22K 5% 1/10WR228 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR229 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR230 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR231 1-216-837-11 METAL CHIP 22K 5% 1/10W

R232 1-216-837-11 METAL CHIP 22K 5% 1/10WR233 1-249-409-11 CARBON 220 5% 1/4WR234 1-249-409-11 CARBON 220 5% 1/4WR235 1-216-809-11 METAL CHIP 100 5% 1/10WR236 1-216-809-11 METAL CHIP 100 5% 1/10W

R237 1-216-845-11 METAL CHIP 100K 5% 1/10WR238 1-216-845-11 METAL CHIP 100K 5% 1/10WR239 1-249-417-11 CARBON 1K 5% 1/4WR240 1-249-421-11 CARBON 2.2K 5% 1/4WR242 1-216-033-00 RES-CHIP 220 5% 1/10W

R244 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR245 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR250 1-216-853-11 METAL CHIP 470K 5% 1/10WR251 1-215-857-31 METAL OXIDE 10 5% 1W FR258 1-205-991-11 METAL 0.1X2 5W


R306 1-216-837-11 METAL CHIP 22K 5% 1/10WR307 1-216-833-11 METAL CHIP 10K 5% 1/10WR308 1-216-837-11 METAL CHIP 22K 5% 1/10WR309 1-216-833-11 METAL CHIP 10K 5% 1/10WR310 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W

R311 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR312 1-216-833-11 METAL CHIP 10K 5% 1/10WR313 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR314 1-216-845-11 METAL CHIP 100K 5% 1/10WR315 1-216-845-11 METAL CHIP 100K 5% 1/10W

R316 1-216-845-11 METAL CHIP 100K 5% 1/10WR317 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR318 1-216-833-11 METAL CHIP 10K 5% 1/10WR319 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR320 1-216-819-11 METAL CHIP 680 5% 1/10W

R321 1-216-837-11 METAL CHIP 22K 5% 1/10WR322 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR324 1-216-033-00 RES-CHIP 220 5% 1/10WR326 1-216-821-11 METAL CHIP 1K 5% 1/10WR327 1-216-837-11 METAL CHIP 22K 5% 1/10W

R328 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR329 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR330 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR331 1-216-837-11 METAL CHIP 22K 5% 1/10WR332 1-216-837-11 METAL CHIP 22K 5% 1/10W

R333 1-249-409-11 CARBON 220 5% 1/4WR334 1-249-409-11 CARBON 220 5% 1/4WR335 1-216-809-11 METAL CHIP 100 5% 1/10WR336 1-216-809-11 METAL CHIP 100 5% 1/10WR337 1-216-845-11 METAL CHIP 100K 5% 1/10W

R338 1-216-845-11 METAL CHIP 100K 5% 1/10WR339 1-249-417-11 CARBON 1K 5% 1/4WR340 1-249-421-11 CARBON 2.2K 5% 1/4W

R342 1-216-033-00 RES-CHIP 220 5% 1/10WR344 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR345 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR350 1-216-853-11 METAL CHIP 470K 5% 1/10WR351 1-215-857-31 METAL OXIDE 10 5% 1W F

R358 1-205-991-11 METAL 0.1X2 5WR401 1-216-837-11 METAL CHIP 22K 5% 1/10WR402 1-216-837-11 METAL CHIP 22K 5% 1/10WR403 1-216-845-11 METAL CHIP 100K 5% 1/10WR404 1-216-845-11 METAL CHIP 100K 5% 1/10W


R410 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR411 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR412 1-216-833-11 METAL CHIP 10K 5% 1/10WR413 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR414 1-216-845-11 METAL CHIP 100K 5% 1/10W

R415 1-216-845-11 METAL CHIP 100K 5% 1/10WR416 1-216-845-11 METAL CHIP 100K 5% 1/10WR417 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR418 1-216-833-11 METAL CHIP 10K 5% 1/10WR419 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R420 1-216-819-11 METAL CHIP 680 5% 1/10WR421 1-216-837-11 METAL CHIP 22K 5% 1/10WR422 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR424 1-216-033-00 RES-CHIP 220 5% 1/10WR426 1-216-821-11 METAL CHIP 1K 5% 1/10W

R427 1-216-837-11 METAL CHIP 22K 5% 1/10WR428 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR429 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR430 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR431 1-216-837-11 METAL CHIP 22K 5% 1/10W

R432 1-216-837-11 METAL CHIP 22K 5% 1/10WR433 1-249-409-11 CARBON 220 5% 1/4WR434 1-249-409-11 CARBON 220 5% 1/4WR435 1-216-809-11 METAL CHIP 100 5% 1/10WR436 1-216-809-11 METAL CHIP 100 5% 1/10W

R437 1-216-845-11 METAL CHIP 100K 5% 1/10WR438 1-216-845-11 METAL CHIP 100K 5% 1/10WR439 1-249-417-11 CARBON 1K 5% 1/4WR440 1-249-421-11 CARBON 2.2K 5% 1/4WR442 1-216-033-00 RES-CHIP 220 5% 1/10W

R444 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR445 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR450 1-216-853-11 METAL CHIP 470K 5% 1/10WR451 1-215-857-31 METAL OXIDE 10 5% 1W FR458 1-205-991-11 METAL 0.1X2 5W

R800 1-216-857-11 METAL CHIP 1M 5% 1/10WR801 1-216-821-11 METAL CHIP 1K 5% 1/10WR802 1-216-833-11 METAL CHIP 10K 5% 1/10WR803 1-216-841-11 METAL CHIP 47K 5% 1/10WR804 1-216-841-11 METAL CHIP 47K 5% 1/10W

R805 1-216-839-11 METAL CHIP 33K 5% 1/10WR806 1-216-833-11 METAL CHIP 10K 5% 1/10WR807 1-216-833-11 METAL CHIP 10K 5% 1/10W

MAIN

23

XM-SD46X


R808 1-216-833-11 METAL CHIP 10K 5% 1/10WR809 1-216-833-11 METAL CHIP 10K 5% 1/10WR810 1-216-857-11 METAL CHIP 1M 5% 1/10WR811 1-249-421-11 CARBON 2.2K 5% 1/4WR813 1-216-815-11 METAL CHIP 330 5% 1/10W


R829 1-216-833-11 METAL CHIP 10K 5% 1/10WR830 1-216-833-11 METAL CHIP 10K 5% 1/10WR838 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR839 1-216-857-11 METAL CHIP 1M 5% 1/10WR841 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R843 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR845 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR847 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR850 1-216-833-11 METAL CHIP 10K 5% 1/10WR854 1-216-841-11 METAL CHIP 47K 5% 1/10W

R855 1-216-841-11 METAL CHIP 47K 5% 1/10WR856 1-216-841-11 METAL CHIP 47K 5% 1/10WR870 1-216-295-11 SHORT CHIP 0R901 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR902 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R903 1-216-836-11 METAL CHIP 18K 5% 1/10WR904 1-216-836-11 METAL CHIP 18K 5% 1/10WR905 1-216-849-11 METAL CHIP 220K 5% 1/10WR906 1-216-210-00 RES-CHIP 3.3K 5% 1/8WR907 1-249-417-11 CARBON 1K 5% 1/4W

R909 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR910 1-216-833-11 METAL CHIP 10K 5% 1/10WR911 1-216-833-11 METAL CHIP 10K 5% 1/10WR912 1-249-411-11 CARBON 330 5% 1/4WR913 1-216-819-11 METAL CHIP 680 5% 1/10W

R914 1-216-819-11 METAL CHIP 680 5% 1/10WR915 1-216-833-11 METAL CHIP 10K 5% 1/10WR916 1-216-150-11 RES-CHIP 10 5% 1/8WR917 1-216-819-11 METAL CHIP 680 5% 1/10WR918 1-216-819-11 METAL CHIP 680 5% 1/10W

R920 1-216-150-11 RES-CHIP 10 5% 1/8WR921 1-216-150-11 RES-CHIP 10 5% 1/8WR922 1-216-150-11 RES-CHIP 10 5% 1/8WR923 1-216-065-11 RES-CHIP 4.7K 5% 1/10WR924 1-216-065-11 RES-CHIP 4.7K 5% 1/10W

R925 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR927 1-216-206-00 RES-CHIP 2.2K 5% 1/8WR929 1-216-013-00 RES-CHIP 33 5% 1/10WR930 1-216-013-00 RES-CHIP 33 5% 1/10WR931 1-216-821-11 METAL CHIP 1K 5% 1/10W

R932 1-216-821-11 METAL CHIP 1K 5% 1/10WR933 1-216-821-11 METAL CHIP 1K 5% 1/10WR934 1-216-821-11 METAL CHIP 1K 5% 1/10W

< CERMET RESISTOR >

RV104 1-241-762-11 RES, ADJ, CERMET 2.2KRV204 1-241-762-11 RES, ADJ, CERMET 2.2KRV304 1-241-762-11 RES, ADJ, CERMET 2.2K

RV404 1-241-762-11 RES, ADJ, CERMET 2.2K

< VARIABLE RESISTOR >

RV801 1-225-647-11 RES, VAR, CARBON 20KX4 (FILTER (FRONT))RV802 1-225-648-12 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz)

(FRONT))RV803 1-225-648-12 RES, VAR, CARBON 5KX2 (LEVEL (FRONT))RV804 1-225-647-11 RES, VAR, CARBON 20KX4 (FILTER (REAR))RV805 1-225-648-12 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz)

(REAR))

RV806 1-225-648-12 RES, VAR, CARBON 5KX2 (LEVEL (REAR))

< SWITCH >

S801 1-692-990-21 SWITCH, SLIDE (FILTER (FRONT))S802 1-692-938-11 SWITCH, SLIDE (FILTER (REAR))

< TRANSFORMER >

T801 1-439-636-11 TRANSFORMER, DC-DC CONVERTER

< THERMISTOR (NEGATIVE) >

THN801 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)THN804 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)THN805 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)THN806 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)THN807 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)

*************************************************************

ACCESSORIES************

2-514-766-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)2-514-766-21 MANUAL, INSTRUCTION (GERMAN,ITALIAN)

(AEP,UK,E)2-514-766-31 MANUAL, INSTRUCTION (SPANISH,

TRADITIONAL CHINESE)(AEP,UK,E)

2-514-766-41 MANUAL, INSTRUCTION(DUTCH,PORTUGUESE)

(AEP,UK,E)2-514-766-51 MANUAL, INSTRUCTION (SWEDISH,POLISH)

(AEP,UK,E)

2-514-766-61 MANUAL, INSTRUCTION (GREEK,RUSSIAN)(AEP,UK,E)

*************************************************************

PARTS FOR INSTALLATION AND CONNECTIONS***************************************

101 3-367-410-11 SCREW (DIA. 5X15), TAPPING(MOUNTING SCREW)

102 1-823-952-11 CORD (WITH CONNECTOR) (0.2m)103 3-249-791-01 COVER (POWER)

MAIN

101 102 103

0.2 mφ 5 x 15(x 4)

24

XM-SD46X

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.

Ver. Date Description of Revision1.0 2004. 12 New

uk model e modelmonitor.espec.ws/files/xm-sd46x__180.pdf · ver. 1.0 2004. 12 service manual us...

Documents