six monthly compliance report · cfbc boiler is sold to local cement plant/brick manufacturers....

Six Monthly Compliance Report JAI BALAJI INDUSTRIES LIMITED- UNIT IV

(APRIL’19-SEPTEMBER’19)

1

INTRODUCTION

Jai Balaji Industries Limited has established an expansion of Steel Plant (Unit-IV) by

installation of Coke Oven Plant (Non recovery type, 1,65,000 TPA) along with Producer

Gas Plant (9,000 Nm3/hr) and Captive Power Plant (WHRB 9 MW & CFBC 36 MW) at

Village – Banskopa, P.O. – Rajbandh, Dist. – Burdwan, West Bengal. It has started its

commercial production as per Consent Letter No. Co110222, dtd. 09.10.2018.

Jai Balaji Industries Limited was granted Environmental Clearances from Ministry of

Environment & Forest (MoEF), Consent to Establish as well as Consent to operate (CTO)

from West Bengal Pollution Control Board respectively. As part of the compliance of

statutory requirement environmental quality monitoring is being done.

Stack Gas monitoring, Ambient Air Quality Monitoring, Work Zone monitoring, Drinking

water and Noise level monitoring has been conducted for the period of April 19 to

September 2019. Presently environmental quality monitoring & analysis is being carried

out by M/s. Envirocheck, accredited by NABL, MoEF&CC, recognition by WBPCB.

As per the conditions of MoEF the unit is complying all the conditions. The detail regarding

compliance is given herewith in the following pages for the half yearly period of April 2019

to September, 2019.



2

COMPLIANCE STATUS ON ENVIRONMENTAL CLEARANCE

Name of the Project : Integrated Steel Plant

Address : Village – Banskopa, P.O. – Rajbandh,

dist. – Burdwan, West Bengal

Clearance Letter No. : F-No. J-11011/496/2009-IA-II (I), dated 29th November 2010

Period of Compliance Report : APRIL 2019 TO SEPTEMBER, 2019.

A. SPECIFIC CONDITIONS:

Sl. COMPLIANCE CONDITIONS : COMPLIANCE STATUS

i. Effort shall be made to reduce RSPM

levels in the ambient air and a time bound

action plan shall be submitted. On-line

ambient air quality monitoring and

continuous stack monitoring facilities for

all the stacks shall be provided.

Appropriate effort is made to reduce

RSPM levels in the ambient air and

regular monitoring is undertaken at

different ambient locations. The test

reports are enclosed in the

Annexure 1.

ii. The National Ambient Air Quality

Standards issued by the Ministry vide

G.S.R. No. 826(E) dated 16th

November,2009 should be followed.

: Is being followed.

iii. Stack monitoring facilities for the entire

major stacks and adequate air pollution

control systems viz. dust catchers, bag

filters etc. to control particulate emission

within the prescribed limits from coke oven

shall be provided. Electrostatic

: There is provision for Stack

monitoring facilities for all the major

stack and adequate air pollution

control systems to control

particulate emission within the

prescribed limits. Electrostatic



3


Precipitators shall be installed to control

particulate emissions from the captive

power plant. Carbon mono-oxide (CO)

shall also be monitored along with other

parameters and standards notified under

Environment (Protection)Act shall be

followed. The reports shall be submitted to

the Ministry’s Regional Office at the

Bhubaneswar, Central Pollution Control

Board (CPCB) and West Bengal Pollution

Control Borad (WBPCB).

Precipitators is installed to control

particulate emissions from the

captive power plant. Carbon mono-

oxide (CO) is being monitored

along with other parameters and

standards notified under

Environment (Protection) Act are

followed. The reports are being

given herewith in Annexure – 1.

iv. Multi stage scrubber shall be installed to

control gaseous and dust emission from

the coke oven stack. Measures shall be

taken to prevent leakages from the coke

oven plant.

: There is provision for Multi stage

scrubber to control gaseous and

dust emission from the coke oven

stack. Necessary measures are

taken to prevent leakages from the

coke oven plant.

v. The prescribed emission standards for

coke oven plants, as notified vide

notification no. GSR 46 (E) dated 3rd

February,2006 and subsequently

amended shall be complied with.

: Is being complied with.

vi. In-plant control measures like bag filters,

de-dusting and dust suppression system

shall be provided to control fugitive

emissions from all the vulnerable sources.

Dust extraction and suppression system

shall be provided at all the transfer points,

coal handling plant and coke sorting plant

of coke oven plant. Bag filters shall be

: Air pollution control measures and

devices like bag filters, de-dusting

and dust suppression system is

provided to control fugitive

emissions from all the vulnerable

sources. Dust extraction and

suppression system is provided at

all the transfer points, coal handling



4


provided to hoods and dust collectors to

coal and coke handling to control dust

emissions. Water sprinkling system shall

be provided to control secondary fugitive

dust emissions generated during

screening loading, unloading, handling

and storage of raw materials etc.

plant and coke sorting plant of coke

oven plant. Bag filters is provided to

hoods and dust collectors to coal

and coke handling to control dust

emissions. Water sprinkling system

is provided to control secondary

fugitive dust emissions generated

during screening loading,

unloading, handling and storage of

raw materials etc.

vii. Secondary fugitive emissions shall be

controlled within the prescribed limits,

regularly monitored and records

maintained. Guidelines/Code of Practice

issued by the CPCB in this regard shall be

followed.

: Appropriate measures to control

Secondary fugitive emissions have

been undertaken to keep it within

the prescribed limits. The latest

Work Zone Air Monitoring reports

are given in Annexure 3.

viii. Vehicular pollution due to transportation of

raw material and finished product shall be

controlled. Proper arrangements shall also

be made to control dust emission during

loading and unloading of the raw material

and finished product. Efforts shall also be

made to reduce impact of the transport of

the raw materials and end products on the

surrounding environment including

agricultural land. All the raw materials

including fly ash shall be transported in

the closed containers only and shall not

be overloaded vehicular emissions shall

be regularly monitored and records kept.

: The proponent has undertaken

suitable measures to control

vehicular pollution due to

transportation of raw material and

finished product is kept under

control. All the raw materials

including fly ash is being

transported in the closed containers

only. The Project Proponent takes

necessary arrangement to reduce

impact of the transport of the raw

materials and end products on the

surrounding environment including

agricultural land.



5


ix. The company shall explore possibility of

use of bottom ash for brick manufacturing.

: All the fly ash generated during the

process is distributed to M/s Ultra

Tech Cement located near to the

project site. Similarly, now, 100%

bottom ash is being used to fill the

low lying area of the project site.

x. The makeup requirement of the water

shall not exceed 30 m3/hr. All the treated

wastewater shall be recycled for dust

suppression and green belt development.

Domestic wastewater shall be treated in

septic tank followed by soak pit and used

for green belt development. Zero effluent

discharge shall be strictly followed and no

wastewater shall be discharged outside

the premises. Regular monitoring of Trace

elements including Arsenic in the Ground

Water has to be done.

: The utmost care is taken to

maintain the makeup requirement

of the water within 30m3/hr. All the

treated wastewater is being

recycled for dust suppression and

green belt development. Zero

effluent discharge is being strictly

followed and no wastewater is

being discharged outside the

premises.

xi. Efforts shall be made to make use of rain

water harvested. If needed capacity of the

reservoir shall be enhanced to meet the

maximum water requirement. Only

balance water requirement shall be met

from other sources.

There is already provision for rain

water harvesting pond within the

factory premises. The harvested

water is used in various units to

reduce raw water consumption per

ton of finished product. The

harvested water is also used for

sprinkling on the road and in the

green belt development.

xii. The company shall obtain a certificate

from the supplier of coking coal that it

does not contain any toxic or trace

: The quality of coal is as per Indian

coal.



6


metals. A copy of certificate shall be

submitted to the Ministry of Environment

and Forests.

xiii. Coke breeze shall be used as fuel in the

existing ferro alloy plant. Coal fines shall

be recycled and reused in the process.

Fly ash generated from CFBC boiler

shall be sold to local cement plant/brick

manufacturers. Tar generated from

Producer Gas plant shall be sold to

authorized recyclers. The bag filter dust

shall be used for landfilling. The waste oil

shall be property disposed off as per the

Hazardous Waste (Management

Handling, Handling and Transboundry

Movement) Rules, 2008.

: Coke breeze is used as fuel in the

existing ferroalloy plant. Coal fines

is recycled and reused in the

process. Fly ash generated from

CFBC boiler is sold to local

cement plant/brick manufacturers.

xiv. Risk and Disaster Management Plant

along with the mitigation measures shall

be prepared and a copy submitted to the

Ministry’s Regional Office at

Bhubaneswar SPCB and CPCB within 3

months of issue of environment

clearance letter.

: A plan on Risk & Disaster

Management Plant has already

been drafted along with the

mitigation measures.

xv. The recommendations made in the

Charter on Corporate Responsibility for

Environment Protection (CREP) for the

Coke Oven Plants shall be implemented.

: Is being implemented.

xvi. As proposed green belt should be

developed in at least 33% of the project

area with a revised green belt plan so as

: Is being complied with.



7


to have a minimum width of 15 to 20 m.

Selection of plant species shall be as per

the CPCB guidelines in consultation with

the DFO.

xvii. All the commitments made to the public

during the Public Hearing/Public

Consultation meeting held on 15th

july,2010 shall be satisfactorily

implemented and a separate budget for

implementing the same shall be

allocated and information submitted to

the Ministry’s Regional Office at

Bhubaneswar.

: This condition is complied with.

xviii. At least 5% of the total cost of the project

shall be earmarked towards the

corporate social responsibility and item-

wise details along with time bound action

plan should be prepared and submitted

to the Ministry’s Regional Office at

Bhubaneswar Implementation of such

program shall be ensured accordingly in

a time bound manner.

: It is already implemented. Some

photographs on event of corporate

social responsibilities are attached

with the compliance report.

xix. The company shall provide housing for

construction labour within the site with all

necessary infrastructure and facilities

such as fuel for cooking, mobile toilets,

mobile STP, safe drinking water medical

health care, crèche etc. The housing

may be in the form of temporary

structures to be removed after the

: The project is now in operation

phase so it is not applicable now.



8


completion of the project.

B. GENERAL CONDITIONS


i. The Project Authorities must strictly

adhere to the stipulations made by West

Bengal Pollution Control Board (WBPCB)

and State Government.

: Is complied with.

ii. No further expansion or modification of

the plant shall be carried out without prior

approval of this Ministry of Environment

and Forest.

: No further expansion or

modification of the plant will be

carried out without prior approval of

this Ministry of Environment and

Forest.

iii. The gaseous emission from various

process units shall conform to the

load/mass based standards notified by

the Ministry on 19th May, 1993 and

standards prescribed from time to time.

The State Board may specify more

stringent standards for the relevant

parameters keeping in view the nature of

the industry and its size and location.

: The gaseous emission from various

process units is analyzed and the

latest test reports are attached as

per Annexure – 1 to 3.

iv. At least four ambient air quality

monitoring stations should be established

in the downward direction as well as

where maximum ground level

concentration of PM10, SO2 and NOx are

anticipated in consultation with the SPCB.

Data on ambient air quality and stack

emission shall be regularly submitted to

: Regular monitoring of Stack Gas,

Ambient Air Quality are conducted

by accredited Laboratory. The latest

test results are attached herewith

as Annexure- 1 to 3.



9


this Ministry including its Regional Office

at Bhubaneswar and the SPCB/CPCB

once in six months.

v. Industrial wastewater shall be properly

collected treated so as to conform to the

standards prescribed under GSR 422 (E)

dated 19th May, 1993 and 31st

December,1993 or as amended from time

to time. The treated wastewater shall be

utilized for plantation purpose.

: Industrial wastewater is being

collected, treated and reused for

plantation purpose and other uses.

vi. The overall noise levels in and around

the plant area shall be kept well

within the standards 85 dBA by

providing noise control measures

including acoustic hoods, silencers,

enclosures, etc. on all sources of

noise generation. The ambient noise

levels shall conform to the standards

prescribed under Environmental

Protection Act, 1989 Rules viz. 75

dBA (day time) and 70 dBA (night time).

: The overall noise levels in and

around the plant area is kept well

within the standards. The latest test

reports are attached as per

Annexure – 6.

vii. Occupational health surveillance of the

workers shall be done on a regular

basis and records maintained as per the

Factory Act.

: This condition is being complied

with.

viii. The company shall develop rain water

harvesting structures to harvest the rain

water for utilization in the lean season

besides recharging the ground water

table.

: Complied with.



10


ix. The project proponent shall also comply

with all the environmental protection

measures and safeguards recommended

in the EIA/EMP report. Further the

company must undertake socio-

economic development activities in the

surrounding villages like community

development programmes, educational

programmes, drinking water supply and

health care etc.

: Appropriate efforts are already

being taken to comply with all the

environmental protection

measures and safeguards

recommended in the EIA/EMP

report. Besides, socio-economic

development activities are

undertaken in the neighbouring

villages.

x. Requisite amount shall be earmarked

towards capital cost and recurring

cost/annum for environment pollution

control measures to implement the

conditions stipulated by the Ministry of

Environment and Forests as well as the

State Government. An implementation

schedule for implementing all the

conditions stipulated herein shall be

submitted to the Regional Office of the

Ministry of Bhubaneswar. The funds so

provided shall not be diverted for any other

purpose.

: The fund earmarked towards the

capital cost and recurring cost

/ annum for environmental pollution

control measures is utilized to

implement the conditions stipulated

by the Ministry of Environment and

Forests as well as the State

Government.

xi. A copy of clearance letter shall be sent by

the proponent to concerned Panchayat,

Zila Parishad/Municipal Corporation.

Urban Local Body and the local NGO, if

any from whom

suggestions/representations, if any were

received while processing the proposal.

: The clearance letter has been put

on display in the web site of the

company.



11


The clearance letter shall also be put on

the web site of the company by the

proponent.

xii. The project proponent shall upload the

status of compliance of the stipulated

environment clearance conditions,

including results of monitored data on their

website and shall update the same

periodically. It shall simultaneously be sent

to the Regional Office of the MoEF at

Bhubaneswar, the respective Zonal Office

of CPCB and the CECB. The criteria

pollutant levels namely. PM10, SO2, NOx

(ambient levels as well as stack

emissions) or critical sectoral parameters,

indicated for the projects shall be

monitored and displayed at a convenient

location near the main gate of the

company in the public domain.

: This condition is being complied.

The analysis of PM10, SO2, NOx are

being conducted by the NABL

accredited laboratory, M/s.

ENVIROCHECK. The test results

are being displayed at the main

gate of the company.

xiii. The project proponent shall also submit six

monthly reports on the status of the

compliance of the stipulated environmental

conditions including results of mentioned

data (both in hard copies as well as by e-

mail) to the Regional Office of MoEF the

respective Zonal Office of CPCB and the

SPCB. The Regional Office of this Ministry

At Bhubaneswar/CPCB/SPCB/ shall

monitor the stipulated conditions.

: This condition is complied with.



12


xiv. The environmental statement for each

financial year ending 31st March in Form-

V as is mandated to be submitted by the

project proponent to the concerned State

Pollution Control Board as prescribed

under the Environment (Protection)

Rules,1986, as amended subsequently

shall also be put on the website of the

company along with the status of

compliance of environmental conditions

and shall also be sent to the respective

Regional Office of the MoEF at

Bhubaneswar by e-mail.

: Will be complied with.

xv. The Project Proponent shall inform the

public that the project has been accorded

environmental clearance by the Ministry

and copies of the clearance letter are

available with the W. B. Pollution Control

Board / Committee and may also be seen

at Website of the Ministry of Environment

and Forests at http:/envfor.nic.in. This

should be advertised within seven days

from the date of issue of the clearance

letter at least in two local newspapers

that are widely circulated in the region of

which one shall be in the vernacular

language of the locality concerned and a

copy of the same shall be forwarded to

the Regional office at Bhubaneswar.

: Complied with.



13


xvi. Project Authorities shall inform the

Regional Office as well as the Ministry,

the date of financial closure and final

approval of the project by the

concerned authorities and the date of

commencing the land development

work.

: The project was approved in

February, 2007 by the Board of

Directors and the land

development work started in

September, 2007.The Consent to

operate is attached as Annexure

7.

ANNEXURE 1

TEST REPORT FORMAT NO : ENV/FM/38

Name of the

Industry

: Jai Balaji Industries Ltd. (Unit # IV) Type of Industry : Steel Plant

Address : Banskopa, Rajbandh, Durgapur, Paschim Burdwan, Pin

- 713212

Sampling Date : 08.07.2019

Period of analysis : 09.07.2019 – 09.07.2019

Date of Issue : 13.07.2019

Sampling Plan & Procedure : ENV/SOP/01 Deviation from the Sampling Method and Plan : No Type of

Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/I Report No. : 432/EC/M/TR(A)/I/19-20

A. GENERAL INFORMATION ABOUT STACK PROVIDED BY THE INDUSTRY

Stack Attached to : Rotary Kiln (No.1 & 2) attached (DRI)

Shape of Stack : Circular Height of Stack (mtr.) (from

G. L.)

: 30.0

Materials of

Construction

: M.S. Stack I.D. at sampling point

(mtr.)

: 1.2

Capacity : 100 TPD/Kiln Height of sampling port

(mtr.) (from G.L.)

: 25.0

Emission Due to : Combustion of Coal & Reduction of Fe-Ore

Fuel Used : Coal Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: 5.5 MT/hr./Kiln

Pollution Control Device : E.S.P

B. RESULTS

SL.

NO.

PARAMETERS UNIT METHOD NO. RESULTS

1. Flue Gas Temperature OC IS : 11255 (Part 1) : 154.0

2. Barometric Pressure mm of Hg. -- : 755.0

3. Velocity of Gas flow m/s IS : 11255 (Part 3) : 10.71

4. Quantity of Gas flow Nm3/hr. IS : 11255 (Part III) : 28797.43

5. Concentration of SO2 mg/Nm3 IS 11255 (Part 2) 1985 RA 2003 : 891.42

6. Concentration of CO2 % (v/v) IS 13270 1992 RA 2003 : 11.0

7. Concentration of CO %(v/v) IS 13270 1992 RA 2003 : <1.0

8. a) Concentration of Particulate

Matter (at 11% CO2)

b) Concentration of Particulate

Matter (at 12% CO2)

mg/Nm3

IS 11255 (Part – 1) 1985 RA 2003 & ASTM D

3685/D 3685M-98 (reapproved 2005) : Sec

11(Vol. 3 11.07) : 2011

:

:

42.22

46.05

Remarks :

Reviewed By : Approved By :

(Durbadal Chakraborty) (Dr. Ajoy Paul)

(Dy. Quality Manager) (Quality Manger)


Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/II Report No. : 432/EC/M/TR(A)/II/19-20


Stack Attached to : Rotary Kiln (No.3 & 4) attached (DRI)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 1.2

Capacity : 100 TPD/Kiln Height of sampling port

(mtr.) (from G.L.)

: 25.0

Emission Due to : Combustion of Coal & Reduction of Fe-Ore


Working Fuel

Consumption

: 5.5 MT/hr./Kiln


B. RESULTS

SL.

NO.










Matter (at 11.2% CO2)


Matter (at 12% CO2)

mg/Nm3

IS 11255 (Part – 1) 1985 RA 2003 & ASTM D


11(Vol. 3 11.07) : 2011

:

:

39.03

41.81

Remarks :





Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/III Report No. : 432/EC/M/TR(A)/III/19-20


Stack Attached to : Cooler Discharge


G. L.)

: 15.24

Materials of

Construction


(mtr.)

: 0.45

Capacity : -- Height of sampling port

(mtr.) (from G.L.)

: 10.6

Emission Due to : During Processing

Fuel Used : N.A. Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: Nil

Pollution Control Device : Bag Filter

B. RESULTS

SL.

NO.






5. Concentration of Particulate

Matter

mg/Nm3 IS 11255 (Part – 1) 1985 RA 2003 & ASTM D


11(Vol. 3 11.07) : 2011

: 36.48

Remarks :





Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/IV Report No. : 432/EC/M/TR(A)/IV/19-20


Stack Attached to : Product House


G. L.)

: 15.24

Materials of

Construction


(mtr.)

: 0.45


(mtr.) (from G.L.)

: 10.6



Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.







Matter



11(Vol. 3 11.07) : 2011

: 28.20

Remarks :





Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/V Report No. : 432/EC/M/TR(A)/V/19-20


Stack Attached to : Coal Crusher


G. L.)

: 15.24

Materials of

Construction


(mtr.)

: 0.45


(mtr.) (from G.L.)

: 10.6



Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.







Matter



11(Vol. 3 11.07) : 2011

: 32.83

Remarks :





Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/VI Report No. : 432/EC/M/TR(A)/VI/19-20


Stack Attached to : Coke Oven Battery trough WHRB – 1 (2 nos.) (42 TPH)


G. L.)

: 70.0

Materials of

Construction


(mtr.)

: 4.624

Capacity : 42 TPH Height of sampling port

(mtr.) (from G.L.)

: 36.0

Emission Due to : Combustion of Coal (1.4% Ratio Coal)


Working Fuel

Consumption

: --

Pollution Control Device : Nil

B. RESULTS

SL.

NO.










Matter



11(Vol. 3 11.07) : 2011

: 41.52

Remarks :





Name of the

Industry



- 713212





Sample

: Source

Emission

Sample ID No. : 432/EC/M/A/VII Report No. : 432/EC/M/TR(A)/VII/19-20


Stack Attached to : Coke Oven Battery trough WHRB – 2 (2 nos.) (42 TPH)


G. L.)

: 70.0

Materials of

Construction


(mtr.)

: 4.624


(mtr.) (from G.L.)

: 36.0

Emission Due to : Combustion of Coal (1.4% Ratio Coal)


Working Fuel

Consumption

: --


B. RESULTS

SL.

NO.










Matter



11(Vol. 3 11.07) : 2011

: 38.56

Remarks :





Name of the

Industry

: Jai Balaji Industries Ltd. (Unit – IV) Type of Industry : Steel Plant

Address : Banskopa, Rajbandh, Durgapur, Paschim Burdwan, Pin -

713212


Period of Analysis : 26.09.2019 – 26.09.2019



Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/I Report No. : 433/EC/M/TR(A)/I/19-20


Stack Attached to : Induction Furnace (No. 1 & 2) (SMS) attached


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 1.0

Capacity : 15 MT/Heat/Furnace Height of sampling port

(mtr.) (from G.L.)

: 17.0

Emission Due to : Melting of Scraps, Sponge Iron, Pig Iron etc.

Fuel Used : N.A. (Electrically Operated) Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: Nil

Pollution Control Device : Spark arrester & Bag Filter

B. RESULTS

SL.

NO.






5. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 15.80

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/II Report No. : 433/EC/M/TR(A)/II/19-20


Stack Attached to : Induction Furnace (No. 3)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 1.0


(mtr.) (from G.L.)

: 17.0



Working Fuel

Consumption

: Nil

Pollution Control Device : Spark arrester & Bag Filter

B. RESULTS

SL.

NO.






5. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 18.21

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/III Report No. : 433/EC/M/TR(A)/III/19-20


Stack Attached to : Induction Furnace (No. 4 & 5) (attached)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 0.762


(mtr.) (from G.L.)

: 25.16



Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.






5. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 21.90

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/IV Report No. : 433/EC/M/TR(A)/IV/19-20


Stack Attached to : Reheating Furnace (No. 2)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 0.9


(mtr.) (from G.L.)

: 10.6

Emission Due to : Combustion of Producer Gas

Fuel Used : Producer Gas Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: 105 Nm3/Ton of production


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 21.86

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/V Report No. : 433/EC/M/TR(A)/V/19-20


Stack Attached to : Blast Furnace (No. 1) (M.B.F)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 1.2

Capacity : 5 MT/hr. Height of sampling port

(mtr.) (from G.L.)

: 20.0

Emission Due to : Combustion of B. F. Gas

Fuel Used : B. F. Gas Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: 35000 m3/hr.


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 18.63

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/VI Report No. : 433/EC/M/TR(A)/VI/19-20


Stack Attached to : Blast Furnace (No. 2) (M.B.F)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 1.2

Capacity : 5 MT/hr. Height of sampling port

(mtr.) (from G.L.)

: 20.0

Emission Due to : Combustion of B. F. Gas

Fuel Used : B. F. Gas Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: 35000 m3/hr.


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 26.69

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/VII Report No. : 433/EC/M/TR(A)/VII/19-20


Stack Attached to : Tape Hole Emission (No.1)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 0.90


(mtr.) (from G.L.)

: 22.86



Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.






5. Concentration of SO2 mg/Nm3 IS 11255 (Part 2) 1985 RA 2003 :

6. Concentration of CO2 % (v/v) IS 13270 1992 RA 2003 :

7. Concentration of CO %(v/v) IS 13270 1992 RA 2003 :

8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 24.87

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/VIII Report No. : 433/EC/M/TR(A)/VIII/19-20


Stack Attached to : Tape Hole Emission (No.2)


G. L.)

: 30.0

Materials of

Construction


(mtr.)

: 0.90


(mtr.) (from G.L.)

: 22.86



Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 32.53

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/IX Report No. : 433/EC/M/TR(A)/IX/19-20


Stack Attached to : SEAF (No.1 & 2) attached


G. L.)

: 40.0

Materials of

Construction


(mtr.)

: 2.6

Capacity : 9 MVA x 2 (Running - 4.65 MVA x 2) Height of sampling port

(mtr.) (from G.L.)

: 21.5

Emission Due to : Melting of Mn-Ore, Dolomite, Lime Stone

Fuel Used : N.A. (Electricity Operated) Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 28.66

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/X Report No. : 433/EC/M/TR(A)/X/19-20


Stack Attached to : SEAF (No.3)


G. L.)

: 40.0

Materials of

Construction


(mtr.)

: 2.6

Capacity : 16.5 MVA (Running - 9.0 MVA) Height of sampling port

(mtr.) (from G.L.)

: 21.5

Emission Due to : Melting of Mn-Ore, Dolomite, Lime Stone

Fuel Used : N.A. (Electricity Operated) Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 23.52

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/XI Report No. : 433/EC/M/TR(A)/XI/19-20


Stack Attached to : Briquetting Plant


G. L.)

: 21.0

Materials of

Construction


(mtr.)

: 0.8


(mtr.) (from G.L.)

: 9.0

Emission Due to : Combustion of Furnace Oil

Fuel Used : Furnace Oil Permanent Platform & Ladder : Yes

Working Fuel

Consumption

: Nil


B. RESULTS

SL.

NO.









8. Concentration of

Particulate Matter



11(Vol. 3 11.07) : 2011

: 42.23

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/XII Report No. : 433/EC/M/TR(A)/XII/19-20


Stack Attached to : C.F.B.C Boiler (No.1 & 2) (CPP) (attached)

Shape of Stack : Concrete (sampling done from Rectangular

Duct)

Height of Stack (mtr.) (from

G. L.)

: 96.0

Materials of

Construction


(mtr.)

: 1.2 x 2.5


(mtr.) (from G.L.)

: 9.0

Emission Due to : Combustion of Coal


Working Fuel

Consumption

: 90 MT/hr.


B. RESULTS

SL.

NO.










Matter (at 11.6% CO2)


Matter (at 12% CO2)

mg/Nm3

IS 11255 (Part – 1) 1985 RA 2003 & ASTM D


11(Vol. 3 11.07) : 2011

:

:

31.82

32.91

Remarks :





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/XIII Report No. : 433/EC/M/TR(A)/XIII/19-20


Stack Attached to : D. G. – 1000 KVA (No.1)


G. L.)

: 8.53

Materials of

Construction


(mtr.)

: 0.20

Capacity : 1000 KVA Height of sampling port

(mtr.) (from G.L.)

: Final Exhaust

Emission Due to : Combustion of H.S.D

Fuel Used : H.S.D Permanent Platform & Ladder : No

Working Fuel

Consumption

: 130 – 140 litr./hr.


B. RESULTS

SL.

NO.










Matter



11(Vol. 3 11.07) : 2011

: 71.01

Remarks : During monitoring temporary ladder and platform were provided.





Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/XIV Report No. : 433/EC/M/TR(A)/XIV/19-20


Stack Attached to : D. G. – 500 KVA


G. L.)

: 7.0

Materials of

Construction


(mtr.)

: 0.20


(mtr.) (from G.L.)

: Final Exhaust



Working Fuel

Consumption

: 20 litr./hr.


B. RESULTS

SL.

NO.










Matter



11(Vol. 3 11.07) : 2011

: 31.87






Name of the

Industry



713212





Sample

: Source

Emission

Sample ID No. : 433/EC/M/A/XV Report No. : 433/EC/M/TR(A)/XV/19-20


Stack Attached to : D. G. – 380 KVA (No.6)


G. L.)

: 6.0

Materials of

Construction


(mtr.)

: 0.10


(mtr.) (from G.L.)

: Final Exhaust



Working Fuel

Consumption

: 50 - 55 litr./hr.


B. RESULTS

SL.

NO.










Matter



11(Vol. 3 11.07) : 2011

: 61.72





ANNEXURE 2


Name of the

Industry


Address : Banskopa, Rajbandh, Durgapur, Paschim

Burdwan, Pin - 713212

Sampling Date : 23.09.2019 – 24.09.2019



Sampling Plan &

Procedure

: ENV/SOP/01 Deviation from the Sampling Method and

Plan

: No Type of

Sample

: Ambient

Air

Sample ID No. : 433/EC/M/A/XVI Report No. : 433/EC/M/TR(A)/XVI/19-20

A] GENERAL INFORMATION

1. Location of Sampling : Near Main Gate (Western Side)

2. Duration of Sampling : 24 hrs. (09:00 a.m. – 09:00 a.m.)

B] METEOROLOGICAL INFORMATION

1. Average Temperature (0C) : 29.5

2. Average Relative Humidity (%) : 67.0

3. Barometric Pressure (mm of Hg) : 756.0

4. Smell or Odour : No Remarkable Smell

5. Weather Condition : Clear sky

C] RESULTS

SL.

NO.


1. Concentration of PM2.5 µg/m3 USEPA 1997a, 40 CFR Part 50, Appendix L 93.52

2. Concentration of PM10 µg/m3 IS 5182 (PART 23) : 2006 52.89

3. Concentration of SO2 µg/m3 IS 5182 (Part 2) 2001 & ASTM D 2914-01 reapproved 2007:

Sec. 11 (Vol. 11.07) : 2011

12.50

4. Concentration of NOx µg/m3 IS 5182 (Part 6) 2006 & ASTM D 1607-91 reapproved 2005 : Sec

11 (Vol. 11.07) : 2011

41.82

Remarks :





Name of the

Industry




Sampling Date : 23.09.2019 – 24.09.2019



Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Ambient

Air

Sample ID No. : 433/EC/M/A/XVII Report No. : 433/EC/M/TR(A)/XVII/19-20


1. Location of Sampling : Near Raw Materials Yard (Southern Side)








C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

8.96


11 (Vol. 11.07) : 2011

35.02

Remarks :





Name of the

Industry




Sampling Date : 23.09.2019 – 24.09.2019



Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Ambient

Air

Sample ID No. : 433/EC/M/A/XVIII Report No. : 433/EC/M/TR(A)/XVIII/19-20


1. Location of Sampling : Near Administrative Building (Ferro Div.) (Eastern Side)








C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

8.50


11 (Vol. 11.07) : 2011

32.50

Remarks :





Name of the

Industry




Sampling Date : 23.09.2019 – 24.09.2019



Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Ambient

Air

Sample ID No. : 433/EC/M/A/XIX Report No. : 433/EC/M/TR(A)/XIX/19-20


1. Location of Sampling : Power Plant Control Room (Northern Side)








C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

7.20


11 (Vol. 11.07) : 2011

32.50

Remarks :





Name of the

Industry




Sampling Date : 23.09.2019 – 24.09.2019



Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Ambient

Air

Sample ID No. : 433/EC/M/A/XX Report No. : 433/EC/M/TR(A)/XX/19-20


1. Location of Sampling : Main Administrative Building








C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

7.50


11 (Vol. 11.07) : 2011

28.05

Remarks :




ANNEXURE 3


Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXI Report No. : 433/EC/M/TR(A)/XXI/19-20


1. Location of Sampling : Near Furnace Area (Distance 20 mtr.) (Ferro Div.)

2. Duration of Sampling : 08 hrs. (10:20 a.m. – 06:20 p.m.)






C] RESULTS

SL.

NO.


1. Concentration of SPM µg/m3 NIOSH 0500 : 1994 380.52

2. Concentration of *RPM µg/m3 IS 5182 (PART 23) : 2006 192.80

3. Concentration of *SO2 µg/m3 IS 5182 (Part 2) 2001 & ASTM D 2914-01 reapproved 2007:

Sec. 11 (Vol. 11.07) : 2011

8.50

4. Concentration of *NOx µg/m3 IS 5182 (Part 6) 2006 & ASTM D 1607-91 reapproved 2005 :

Sec 11 (Vol. 11.07) : 2011

30.02

Remarks : The parameters marked with an ( * ) are not Accredited by NABL.





Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXII Report No. : 433/EC/M/TR(A)/XXII/19-20


1. Location of Sampling : Near WHRB (Distance 15 mtr.) & E.S.P







C] RESULTS

SL.

NO.



2. Concentration of RPM µg/m3 IS 5182 (PART 23) : 2006 168.56


Sec. 11 (Vol. 11.07) : 2011

8.20

4. Concentration of NOx µg/m3 IS 5182 (Part 6) 2006 & ASTM D 1607-91 reapproved 2005 :

Sec 11 (Vol. 11.07) : 2011

28.56






Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXIII Report No. : 433/EC/M/TR(A)/XXIII/19-20


1. Location of Sampling : Coke Oven Division (Distance 5 mtr.) (Near Control Room)







C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

7.28


Sec 11 (Vol. 11.07) : 2011

26.50






Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXIV Report No. : 433/EC/M/TR(A)/XXIV/19-20


1. Location of Sampling : Near Furnace Area (SMS)







C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

10.0


Sec 11 (Vol. 11.07) : 2011

38.50






Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXV Report No. : 433/EC/M/TR(A)/XXV/19-20


1. Location of Sampling : Near Finished Goods Stock Yard (Rolling Mill)







C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

7.80


Sec 11 (Vol. 11.07) : 2011

32.52






Name of the

Industry







Sampling Plan &

Procedure


Plan

: No Type of

Sample

: Work Zone

Sample ID No. : 433/EC/M/A/XXVI Report No. : 433/EC/M/TR(A)/XXVI/19-20


1. Location of Sampling : Near Product House (Distance 15 mtr.) (Sponge Iron Unit)







C] RESULTS

SL.

NO.





Sec. 11 (Vol. 11.07) : 2011

7.50


Sec 11 (Vol. 11.07) : 2011

25.20





ANNEXURE 4

FORMAT NO. ENV/FM/55

TEST REPORT

Name of the

Industry


Address : Banskopa, Rajbandh, Durgapur, Paschim Burdwan,

Pin - 713212




Sampling Plan &

Procedure

: ENV/SOP/01 Deviation from the Sampling

Method and Plan

: No Type of Sample : Drinking Water

Location : Ferro Division Tap Sample ID No. : ENV/786A/W/I Report No. : ENV/786A/W/M/I/19-20

SL. NO. PARAMETERS TEST METHOD UNIT RESULTS LIMIT* (IS 10500 :2012)

Acceptable Permissible

1. Conductivity APHA 23rd Ed., 2510-B : 2017 µs/cm 188.0 -- --

2. pH IS 3025 (Part 11): 1984, RA 2012 /

APHA 23rd Ed., 4500-H+B : 2017

mg/l 7.20 6.5-8.5 No

Relaxation

3. Total Hardness APHA 23rd Ed., 2340 C : 2017 / IS 3025

(Part 21): 2009, RA 2014

mg/l 30.0 200.0 600.0

4. Calcium IS 3025 (Part 40): 1991, RA 2014 ;

APHA 23rd Ed., 3500 Ca-B : 2017

mg/l 8.02 75.0 200.0

5. Magnesium IS 3025 (Part 46): 1994, RA 2014/

APHA 23rd Ed., 3500 Mg B : 2017

mg/l 2.4 30.0 100.0

6. Chloride IS 3025 (Part 32): 1988, RA 2014 ;

APHA 23rd Ed.,4500 Cl –B/D : 2017

mg/l 9.98 250.0 1000.0

7. Iron IS 3025(Part 53): 2003, RA 2014 /

APHA 23rd Ed., 3111B : 2017

mg/l 0.08 0.3 No

Relaxation

8 Boron IS 13428: 2005, RA 2014, Annex H /

APHA 23rd Ed., 4500 –B-C : 2017

mg/l <0.1 0.5 1.0

9. Sulphate IS 3025 (Part 24): 1986, RA 2014 /

APHA 23rd Ed., 4500- SO4 2- E: 2017

mg/l 8.50 200.0 400.0

10. Total Dissolved Solids IS 3025(Part 16): 1984, RA 2014 mg/l 120.0 500.0 2000.0

11. Turbidity IS 3025 (Part 10): 1984, RA 2012 /

APHA 23rd Ed., 2130 B : 2017

mg/l <1.0 1.0 5.0

12. Total Alkalinity IS 3025 (Part 23): 1986, RA 2014 /

APHA 23rd Ed., 2320 B: 2017

mg/l 40.0 200.0 600.0

13. Nitrate IS 3025 (Part 34): 1988, RA 2014 /

APHA 23rd Ed., 4500 NO3 – E : 2017

mg/l 2.50 45.0 No

Relaxation

14. Fluoride IS 3025 (Part 60): 2008, RA 2013 /

APHA 23rd Ed., 4500 F –D : 2017

mg/l <0.1 1.0 1.5

15. Total Chromium IS 3025 (Part 52): 2003, RA 2014 /

APHA 23rd Ed., 3111- Cr- B : 2017

mg/l <0.02 0.05 No

Relaxation

16. Zinc IS 3025 (Part 49): 1994, RA 2014 /

APHA 23rd Ed., 3111B : 2017

mg/l 0.65 5.0 15.0





TEST REPORT

Name of the

Industry



Pin - 713212




Sampling Plan &

Procedure


Method and Plan


Location : Ferro Division Tap Sample ID No. : ENV/786A/W/I Report No. : ENV/786A/W/M/I/19-20

SL.

NO.

PARAMETERS TEST METHOD UNIT RESULTS LIMIT* (IS 10500 :2012)

1. Total Coliform 9222B, APHA 23rd Ed., 2017 CFU/100ml. Absent Shall not be detectable in

any 100 ml. sample

2. Fecal Coliform 9222D, APHA 23rd Ed., 2017 CFU/100ml. Absent Shall not be detectable in

any 100 ml. sample

Remarks : CFU indicates Colony Forming Unit.


(Durbadal Chakraborty) (Priyanka Mukherjee)

(Dy. Quality Manager) (Technical Manger, Microbiology)


TEST REPORT

Name of the

Industry



Pin - 713212




Sampling Plan &

Procedure


Method and Plan


Location : SMS Division Tap Sample ID No. : ENV/786A/W/II Report No. : ENV/786A/W/M/II/19-20

SL. NO. PARAMETERS TEST METHOD UNIT RESULTS LIMIT* (IS 10500 :2012)

Acceptable Permissible

1. Conductivity APHA 23rd Ed., 2510-B : 2017 µs/cm 195.0 -- --

2. pH IS 3025 (Part 11): 1984, RA 2012 /

APHA 23rd Ed., 4500-H+B : 2017

mg/l 7.26 6.5-8.5 No

Relaxation

3. Total Hardness APHA 23rd Ed., 2340 C : 2017 / IS 3025

(Part 21): 2009, RA 2014

mg/l 36.0 200.0 600.0

4. Calcium IS 3025 (Part 40): 1991, RA 2014 ;

APHA 23rd Ed., 3500 Ca-B : 2017

mg/l 9.62 75.0 200.0

5. Magnesium IS 3025 (Part 46): 1994, RA 2014/

APHA 23rd Ed., 3500 Mg B : 2017

mg/l 2.88 30.0 100.0

6. Chloride IS 3025 (Part 32): 1988, RA 2014 ;

APHA 23rd Ed.,4500 Cl –B/D : 2017

mg/l 12.70 250.0 1000.0

7. Iron IS 3025(Part 53): 2003, RA 2014 /

APHA 23rd Ed., 3111B : 2017

mg/l 0.10 0.3 No

Relaxation

8 Boron IS 13428: 2005, RA 2014, Annex H /

APHA 23rd Ed., 4500 –B-C : 2017

mg/l <0.1 0.5 1.0

9. Sulphate IS 3025 (Part 24): 1986, RA 2014 /

APHA 23rd Ed., 4500- SO4 2- E: 2017

mg/l 10.0 200.0 400.0

10. Total Dissolved Solids IS 3025(Part 16): 1984, RA 2014 mg/l 125.0 500.0 2000.0

11. Turbidity IS 3025 (Part 10): 1984, RA 2012 /

APHA 23rd Ed., 2130 B : 2017

mg/l <1.0 1.0 5.0

12. Total Alkalinity IS 3025 (Part 23): 1986, RA 2014 /

APHA 23rd Ed., 2320 B: 2017

mg/l 46.0 200.0 600.0

13. Nitrate IS 3025 (Part 34): 1988, RA 2014 /

APHA 23rd Ed., 4500 NO3 – E : 2017

mg/l 3.20 45.0 No

Relaxation

14. Fluoride IS 3025 (Part 60): 2008, RA 2013 /

APHA 23rd Ed., 4500 F –D : 2017

mg/l <0.1 1.0 1.5

15. Total Chromium IS 3025 (Part 52): 2003, RA 2014 /

APHA 23rd Ed., 3111- Cr- B : 2017

mg/l <0.02 0.05 No

Relaxation

16. Zinc IS 3025 (Part 49): 1994, RA 2014 /

APHA 23rd Ed., 3111B : 2017

mg/l 0.72 5.0 15.0





TEST REPORT

Name of the

Industry



Pin - 713212




Sampling Plan &

Procedure


Method and Plan


Location : SMS Division Tap Sample ID No. : ENV/786A/W/II Report No. : ENV/786A/W/M/II/19-20

SL.

NO.

PARAMETERS TEST METHOD UNIT RESULTS LIMIT* (IS 10500 :2012)

1. Total Coliform 9222B, APHA 23rd Ed., 2017 CFU/100ml. Absent Shall not be detectable in

any 100 ml. sample

2. Fecal Coliform 9222D, APHA 23rd Ed., 2017 CFU/100ml. Absent Shall not be detectable in

any 100 ml. sample

Remarks : CFU indicates Colony Forming Unit.


(Durbadal Chakraborty) (Priyanka Mukherjee)

(Dy. Quality Manager) (Technical Manger, Microbiology)

ANNEXURE 5


TEST REPORT

Name of the

Industry







Sampling Plan &

Procedure

: ENV/SOP/01 Deviation from the

Sampling Method

and Plan

: No Type of Sample : Effluent Water (Grab)

Location : E.T.P Outlet Sample ID No. : ENV/786/W Report

No.

: ENV/786/W/M/19-20

SL. NO. PARAMETERS TEST METHOD UNIT RESULTS

1. pH value 4500 H+B APHA 23rd Edition, 2017 - 7.10

2. Total Suspended solids 2540 D APHA 23rd Edition, 2017 mg/l 25.0

3. Oil & Grease 5520 Oil B/D APHA 23rd Edition, 2017 mg/l <1.0

4. Chemical Oxygen Demand 5200 COD B/C/D APHA 23rd Edition,

2017

mg/l 60.0

5. Biochemical Oxygen

Demand for 3 days at 270C

5210 BOD B APHA 23rd Edition, 2017 mg/l 23.0




ANNEXURE 6

NOISE LEVEL SYUDY (SOURCE)

I. Name of the Industry/Factory/Company : Jai Balaji Industries Ltd. (Unit # IV)

II. Address : Village - Banskopa, P.O - Rajbandh, Durgapur, District –


III. Date of Sampling : 23/09/2019

IV. Reporting Date : 26/09/2019

V. Report No : 431/EC/M/N/I/19-20

VI. Method No : IS: 9989 – 1981

VII. Time of Duration of Noise : 20 Minutes

VIII. Height from Ground Level : 4 feet

IX. Type of Industry : Steel Plant with Captive Power Generation

X. Sample Monitoring by : Mr. Partha Sarathi Nandi

RESULT OF NOISE LEVEL STUDY Time : 6:00 – 6:20 A.M

DAY TIME

1. Location : DM Plant (CPP) Sample Code : (ENV/NOISE/01/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 78.5 81.7 80.10 East Side

02. dB(A) 80.8 84.3 82.50 West Side

03. dB(A) 79.9 85.7 82.38 North Side

04. dB(A) 80.6 86.9 82.65 South Side

Average dB(A) Leq 81.90

Reviewed By: Approved By:

Dy. Quality Manager Quality Manager

>End of Report<







V. Report No : 431/EC/M/N/II/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

2. Location : Boiler – 01 (CPP) Sample Code : (ENV/NOISE/02/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 75.8 80.6 78.23 East Side

02. dB(A) 77.5 82.8 81.20 West Side

03. dB(A) 75.2 85.6 79.32 North Side

04. dB(A) 73.6 78.7 75.18 South Side




>End of Report<







V. Report No : 431/EC/M/N/III/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

3. Location : Boiler – 02 (CPP) Sample Code : (ENV/NOISE/03/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 76.8 80.5 78.20 East Side

02. dB(A) 77.7 84.0 82.35 West Side

03. dB(A) 79.1 85.8 83.21 North Side

04. dB(A) 77.6 86.4 82.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/IV/19-20

VI. Method No : IS: 9989 – 1981




X. Sample Monitoring by : Mr. ParthaSarathi Nandi


4. Location : Pump House (CPP) Sample Code : (ENV/NOISE/04/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 81.2 88.9 82.38 East Side

02. dB(A) 78.5 86.4 83.20 West Side

03. dB(A) 70.8 84.2 78.26 North Side

04. dB(A) 78.5 87.6 83.21 South Side




>End of Report<







V. Report No : 431/EC/M/N/V/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

5. Location : Kiln – 1 (DRI) Sample Code : (ENV/NOISE/05/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 75.8 84.8 82.10 East Side

02. dB(A) 78.0 84.6 81.36 West Side

03. dB(A) 74.7 85.8 78.50 North Side

04. dB(A) 79.6 83.5 81.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/VI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

6. Location : CCM (SMS) Sample Code : (ENV/NOISE/06/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 72.6 79.0 76.38 East Side

02. dB(A) 78.6 80.8 80.06 West Side

03. dB(A) 77.4 81.7 79.36 North Side

04. dB(A) 78.0 83.4 81.50 South Side




>End of Report<







V. Report No : 431/EC/M/N/VII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

7. Location : Dispatch Yard (SMS) Sample Code : (ENV/NOISE/07/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 71.2 77.0 73.68 East Side

02. dB(A) 75.3 78.8 76.50 West Side

03. dB(A) 80.4 85.4 82.48 North Side

04. dB(A) 77.6 84.6 83.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/VIII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

8. Location : Pump House (SMS) Sample Code :(ENV/NOISE/08/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 81.7 86.9 83.26 East Side

02. dB(A) 79.7 89.1 83.21 West Side

03. dB(A) 80.6 84.5 82.68 North Side

04. dB(A) 81.4 87.9 83.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/IX/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

9. Location : MBF – 1 (MBF) Sample Code : (ENV/NOISE/09/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 76.8 80.4 78.32 East Side

02. dB(A) 74.6 84.2 82.50 West Side

03. dB(A) 77.8 81.5 81.10 North Side

04. dB(A) 77.5 80.2 79.36 South Side




>End of Report<







V. Report No : 431/EC/M/N/X/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

10. Location : MBF – 2 (MBF) Sample Code : (ENV/NOISE/10/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 76.5 81.9 78.32 East Side

02. dB(A) 78.4 84.6 81.50 West Side

03. dB(A) 81.2 84.7 83.68 North Side

04. dB(A) 78.9 83.2 81.20 South Side




>End of Report<







V. Report No : 431/EC/M/N/XI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

11. Location :Blower House (MBF) Sample Code : (ENV/NOISE/11/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 74.8 81.9 78.98 East Side

02. dB(A) 80.6 84.6 82.50 West Side

03. dB(A) 81.3 86.2 84.61 North Side

04. dB(A) 77.9 83.5 81.50 South Side




>End of Report<







V. Report No : 431/EC/M/N/XII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

12. Location : Pump House (MBF) Sample Code : (ENV/NOISE/12/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 73.6 80.7 76.50 East Side

02. dB(A) 71.4 84.2 78.21 West Side

03. dB(A) 74.5 79.8 76.50 North Side

04. dB(A) 70.4 75.2 73.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/XIII/19-20

VI. Method No : IS: 9989 – 1981





RESULT OF NOISE LEVEL STUDY Time : 10:30 – 10:50A.M

DAY TIME

13. Location : Turbine – 01 (CPP) Sample Code : (ENV/NOISE/13/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 78.8 85.2 82.36 East Side

02. dB(A) 74.2 81.6 79.65 West Side

03. dB(A) 80.9 83.7 82.50 North Side

04. dB(A) 80.7 84.8 82.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/XIV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 77.6 84.8 82.65 East Side

02. dB(A) 78.7 83.8 81.20 West Side

03. dB(A) 81.2 85.9 83.65 North Side

04. dB(A) 81.6 84.6 82.56 South Side




>End of Report<







V. Report No : 431/EC/M/N/XV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 78.3 83.6 82.50 East Side

02. dB(A) 79.0 84.8 81.68 West Side

03. dB(A) 79.6 87.8 85.78 North Side

04. dB(A) 82.8 88.5 86.20 South Side




>End of Report<







V. Report No : 431/EC/M/N/XVI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

16. Location : Kiln – 03 (DRI) Sample Code : (ENV/NOISE/16/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 74.8 86.2 82.65 East Side

02. dB(A) 75.6 83.1 78.36 West Side

03. dB(A) 74.6 88.7 78.35 North Side

04. dB(A) 71.4 78.9 73.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/XVII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

17. Location : WHRB – 02 (DRI) Sample Code : (ENV/NOISE/17/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 73.8 78.5 76.80 East Side

02. dB(A) 77.6 82.8 79.21 West Side

03. dB(A) 75.7 80.8 78.32 North Side

04. dB(A) 74.7 83.4 78.32 South Side




>End of Report<







V. Report No : 431/EC/M/N/XVIII/19-20

VI. Method No : IS: 9989 – 1981





RESULT OF NOISE LEVEL STUDY Time : 11:40 – 12:00P.M

DAY TIME

18. Location : WHRB – 4 (DRI) Sample Code : (ENV/NOISE/18/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 78.5 83.4 81.20 East Side

02. dB(A) 77.6 84.3 82.68 West Side

03. dB(A) 76.5 84.9 78.50 North Side

04. dB(A) 78.5 81.6 80.16 South Side




>End of Report<

NOISE LEVEL SYUDY (AMBIENT)






V. Report No : 431/EC/M/N/XIX/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

19. Location : Raw Material Yard (Coke Oven) Sample Code : (ENV/NOISE/19/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 68.6 80.3 73.32 East Side

02. dB(A) 66.7 74.5 71.52 West Side

03. dB(A) 64.2 77.8 68.32 North Side

04. dB(A) 66.2 73.9 69.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/XX/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

20. Location : Warf (Coke Oven) Sample Code : (ENV/NOISE/20/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 72.5 77.9 74.38 East Side

02. dB(A) 74.6 80.8 76.80 West Side

03. dB(A) 73.7 78.7 75.10 North Side

04. dB(A) 75.3 76.2 75.89 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

21. Location : Near Battery I (Coke Oven) Sample Code : (ENV/NOISE/21/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 74.2 76.6 75.86 East Side

02. dB(A) 74.8 79.1 76.28 West Side

03. dB(A) 72.7 75.4 73.50 North Side

04. dB(A) 76.4 80.5 79.12 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

22. Location : Secondary Crusher (Coke Oven) Sample Code : (ENV/NOISE/22/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 74.3 79.2 76.80 East Side

02. dB(A) 70.5 78.3 73.12 West Side

03. dB(A) 79.6 82.6 80.10 North Side

04. dB(A) 78.2 81.9 79.36 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXIII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

23. Location : Primary Crusher (Coke Oven) Sample Code : (ENV/NOISE/23/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 76.8 81.6 78.36 East Side

02. dB(A) 72.7 80.5 76.98 West Side

03. dB(A) 76.6 82.2 78.20 North Side

04. dB(A) 73.9 80.8 76.48 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXIV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

24. Location : Near Battery IV (Coke Oven) Sample Code : (ENV/NOISE/24/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 73.8 78.6 75.21 East Side

02. dB(A) 77.9 81.4 79.32 West Side

03. dB(A) 75.5 80.7 78.23 North Side

04. dB(A) 78.2 83.5 80.10 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

25. Location : Raw Material Handling Yard (Ferro) Sample Code : (ENV/NOISE/25/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 70.8 77.6 74.36 East Side

02. dB(A) 74.3 80.5 77.89 West Side

03. dB(A) 78.1 83.2 81.10 North Side

04. dB(A) 75.8 80.9 78.32 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXVI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

26. Location : SEAF – 1 (Ferro) Sample Code : (ENV/NOISE/26/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 78.6 81.8 79.32 East Side

02. dB(A) 80.8 87.4 85.26 West Side

03. dB(A) 79.6 82.7 81.36 North Side

04. dB(A) 77.5 85.4 82.50 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXVII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 75.8 82.4 80.16 East Side

02. dB(A) 80.6 84.3 82.65 West Side

03. dB(A) 79.4 83.3 81.20 North Side

04. dB(A) 79.8 84.5 82.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXVIII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 79.4 83.5 81.20 East Side

02. dB(A) 81.6 85.7 82.68 West Side

03. dB(A) 79.4 84.2 83.67 North Side

04. dB(A) 76.9 80.9 78.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXIX/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

29. Location : Pump House Ferro Sample Code : (ENV/NOISE/29/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 74.9 79.6 76.38 East Side

02. dB(A) 77.7 82.5 80.10 West Side

03. dB(A) 76.4 80.9 79.36 North Side

04. dB(A) 78.4 83.5 81.20 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXX/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

30. Location : Rolling Mill (Rolling Mill) Sample Code : (ENV/NOISE/30/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 75.8 80.7 78.23 East Side

02. dB(A) 78.6 81.6 79.35 West Side

03. dB(A) 73.9 84.6 82.58 North Side

04. dB(A) 76.2 82.4 80.12 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXI/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

31. Location : Dispatch Yard (Rolling Mill) Sample Code : (ENV/NOISE/31/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 73.8 81.6 76.32 East Side

02. dB(A) 77.2 83.4 80.10 West Side

03. dB(A) 78.6 81.9 79.32 North Side

04. dB(A) 78.2 84.4 81.26 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME

32. Location : Induction Furnace – 01 (SMS) Sample Code : (ENV/NOISE/32/19-20)

Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 77.9 82.6 79.32 East Side

02. dB(A) 77.3 83.4 81.20 West Side

03. dB(A) 76.9 80.6 78.36 North Side

04. dB(A) 79.5 84.2 82.50 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXIII/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 72.5 80.4 78.32 East Side

02. dB(A) 77.8 81.3 78.30 West Side

03. dB(A) 79.6 86.4 82.68 North Side

04. dB(A) 77.6 83.7 80.68 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXIV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 76.6 80.4 78.50 East Side

02. dB(A) 78.9 81.6 79.26 West Side

03. dB(A) 77.6 83.7 80.10 North Side

04. dB(A) 79.5 84.5 83.12 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXV/19-20

VI. Method No : IS: 9989 – 1981






DAY TIME


Sl.

No.

Unit Minimum

dB(A)

Maximum

dB(A)

Leq

dB(A)

Remarks

01. dB(A) 75.9 80.6 78.30 East Side

02. dB(A) 78.2 84.1 81.56 West Side

03. dB(A) 80.6 87.5 84.65 North Side

04. dB(A) 79.2 83.2 81.23 South Side




>End of Report<







V. Report No : 431/EC/M/N/XXXVI/19-20

VI. Method No : IS: 9989 – 1981





RESULT OF NOISE LEVEL STUDY Time :7:15 – 7:35 P.M DAY TIME

36. Location : Roof Top of Main Administrative Building (AAQMS) Sample Code : (ENV/NOISE/36/19-20) Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks

01. dB(A) 63.8 67.2 65.98 East Side 02. dB(A) 59.6 64.2 62.35 West Side 03. dB(A) 64.3 70.2 68.90 North Side 04. dB(A) 61.7 66.3 65.20 South Side

Average dB(A) Leq 65.60 Time : 10:00 – 10:20P.M

NIGHT TIME Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks





>End of Report<







V. Report No : 431/EC/M/N/XXXVII/19-20

VI. Method No : IS: 9989 – 1981






37. Location : Near Main Gate (Western Side) (AAQMS) Sample Code : (ENV/NOISE/37/19-20) Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks



NIGHT TIME Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks





>End of Report<







V. Report No : 431/EC/M/N/XXXVIII/19-20

VI. Method No : IS: 9989 – 1981






38. Location : Roof of Admin Building Ferro Division (Eastern Side) (AAQMS) Sample Code : (ENV/NOISE/38/19-20) Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks



NIGHT TIME Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks





>End of Report<







V. Report No : 431/EC/M/N/XXXIX/19-20

VI. Method No : IS: 9989 – 1981






39. Location : Near RM Yard (Southern Side) (AAQMS) Sample Code : (ENV/NOISE/39/19-20) Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks



NIGHT TIME Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks





>End of Report<







V. Report No : 431/EC/M/N/XL/19-20

VI. Method No : IS: 9989 – 1981






40. Location : Roof of Power Plant Control Room (Northern Side) (AAQMS) Sample Code : (ENV/NOISE/40/19-20) Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks


Average dB(A) Leq 59.39 Time : 11:40 – 12:00A.M

NIGHT TIME Sl. No.

Unit Minimum dB(A)

Maximum dB(A)

Leq dB(A)

Remarks





>End of Report<

ANNEXURE 7

ANNEXURE 8

\

lo,

3. Ihe delails ol the existi,rc [nits as ,vall as,,rci€r U-,'1 , nto:F.-: it,.' es U.)C-:lhe piop.sed Ljnllr eId their c;p:rc;ti{jrj

Fe-a

! rat:pr:g*.n , uty*,anie) cfr"vAeryY *8"?A"C.TY I:,: ) 1 ,2r.Ll)Q

: i::lt'; .!

r. b].r. J,110a1t496t200S- tA ti {;}Gcvernmenl of India

M;nisXry af environrnent and F{}re5,rg{1.A. Division}

. paryirvaran ghawan*&* *t:r*plex, L{sdhi &*ad

ba*v,s *elht ^ 11aj *t3Y. -*.t ai I : 1c *.i rj d t slry a7 &l ({r-1L c.i n

7*te/ia.x.: *11 * 2436 3g7Zftatedl' t4{-v*n"rber Z&'t," ZglB

Th€ F;r€caor.Mls Jai &atali ,ndusiries Lisnited5, Sentinck Streeq .l

"1 Floor, Kolkata- f00 001

Ph: 033-??44 gE$E Fex *33-?243 A8Z.e'mail: i t*C)iaiirr,riisr*up.*0nr

$ub: Expa*si*n of $1eei fl;rt {Unit-lvi by itrstallati.n *t e*U.r. Avan pta*1. {t*an,recovery type, 1,6F,000.TpA) arong wiih prodrccr *as *tat* 4o,aw rai,tlil it*Ca,rtive pswe r ptant {WHRB, g_MW & e f BC, 36 ?,AW ar. VifiaEe &anskopa., ?.e"xajb€ndh, $iritr,ct Eiird\,van, west gangai bv t&rs J\tiata)i 1;dn.,ttt*e t-|t.1ib;t-regardirl? Environmenial Cl*aranceSr

Thi: ha,"j reiersnce io v.r.tf lefer no. ril daled 14.rg.2A1r rec,jveC in lhe Minjsily'nJ ,'i" Seplombdr, ?010 aiong *ith n

"opy oi AIFMp

^ii-pirt:u. laaring repod see*,naenvironnrent c'.ar;1nr:e undei ihe pr"r"i"l,* ol il,i ij"iiii*rr""iioii,

2 ' Th" L'inis,' ci Enviroflnent atd i;ille$in has exan,lilri the irppltr:at;on f*i iha aitaveprojeci lt is'ot*c lial frls iaibarari r.ndu:r','; L-rd. hd\,e pr"p*",t rili €xpai.r$ir, ,i iir€)exrsri.rq Sted .;r : r.n l r!, n,., -slllldtrca or .,,...r (Jv:r in,., ,\.- .. . ,_r, rvc . . .i l .TDAraisr'g\ir. D..,.,. c.r Ga;'ri ' ,loo,, r""'-,,1;.; ..;.;".. : .:. 1 A,: . ?i_ r.r\& CFBC.36 MU/) ai Viitage nanskope. ?.A. ?,q|:an'h, niiiricif *r,:ro*, \il..*,t t),rn(,r) t,:,,.

l::f::: f:o-].:r. *,;

fu,.."r...u? in an area oi 29.5 acres w*hin ihe exisling steel plantpremrses and gr{.cr bcrl wirl be deveroped n 33 a/(, erca. r,b ,atian.}r pir*slwrli 'iie

sanctuaryrrese i'vt itrcsls ate loc;ted y,'iihtn 1il krr i?Citi$. 'io*l "r,ri

,i lhe ptapo$ed pii)l|.iis Rs. 25?.5 Crores ii$. i 9.0 {_'rore:, and Rs. 3.r.. r:rares wir; ie e:,t:,.arf,::C lolvar.is lolalcapital cosl and ecu,ifi'tg cosl,,annitm lot eilv jronfienial pr:lir.rlicn conlrll iileasLires

FACfi-f?tFs

DRI Plant

EXISTIi.IGCAFACITY

| *arAcrfv u*ai;{xc0a",isTRUC?'St{e* Obtainsd

Mini,Blasl Furrrace

1 ,78 .7_AA T7r.3 x 15

3,6C,COC TPA

a .2-0,AA() Tl'A4 x JC0 TPD

8C 50C T|JA?-x4bM3

2,97 .Q()A TPA(5xa5TJ3,60.0t)0 iPA

.. linil)

6. Rolling Mill 2,40 000 TPA 1,ii*,*0t TPA

Pewer Plant

4. Coking Coel i2,?t,000 TPA) will b* inpo Bd trsin ,\tsliaija ,.d Scuth Ajiira.Oolochar / c{}al tres ?r'ill ile used in th* CFBC boiler Coai wiij be .cijrced t.orlr captive t*aibiock. tarbrnization ol aoal will be carried eui in coke cven pkiiii io pl'duae t_.ori,r a3hmelallurgica: hard roke. H;gh lemperature flu€ gases prcilure4 duiir'ti] coking wili i:esupplied io WllllU irr generation of $leam to generate poiref. The p*pa$?d 45 MW CrplivePower Plani is pianr*d nat only aonsidering thc 4 l"{W pcvder d*rz,.and al !h* pr{:pc$sderpansitxr. bul aisr: c*nsid*ting the exigthg ptwer short tali. t:),*.s2r,lly. io meei lh*additional pawet 'lenand ri;ts existing rnil$, ihe &){{\rit3fr\:l i., ils}di{j*d or slasonfrsdpower. Ara coolarj *otdsnset wiii be insialled.

5. Thete wiil be ao *migsi{}rs Jlom produciicn prcress. as nncaiiv* pressure ipchnrlogyis adopted an the pmposed planl. Adeqtate d!si exaractior]/.jusl sLli?preislon syslerrr! wiil beinstalled a{ ail lorations oi du$i gereration. Waler sp.inkling sy$i*ri ';yili i}r ljsed lo r*ntrollugitive emissirsus ri.fing halrdling of coke ard.oal. A beffle pjate dusl cojlerlcr uill beprovided at Coke quenching tower. Dust etara{:!.tot1 $ysten, wlll b* prrvidei al ici(escreening & crushet house and coke slofage brnk3r hotlse. iligh €,iircielrcy i.$l wii; beinslai,ed to coiririrl ll. du$l rn]issions fr*rn CF|SC & Wi"JR borie rs

6" Make p wale r rcquitamenl i$ 30m3lhr, vlhich will be $furceJ irc A$an$ri itrgaouiDevelopnent Authorlty {ApDA), No indusliial etilu€nt will be dis.hai"ga.J as the qiJonrh,;igwater alter $edirnenlalion will be re-circulateC back into ihe sysi*r?t ihe niaj*r pari ofcooling tower blow do!,/n. boiler blntv dGwn and tM plant eflloatli {rolrr in. Cpp wiii ba e*dior coke q|]*nchir]g 3nd'lhe i:alance wili b* rsed fcr dusl $!rpr,i$$irr and qrsstbelldevelcpmenl irside ?he plroi. li ir ai$o proposed i* Cevelop ra,tt watet lat,e$ting slruciirr*.

7. fV ash. gsner€ied in:m CFBC boller ,#ill be sotd io orlYrilr! ,riant I ar.ickn]anutactur13.!. Bailnn] ash wiil ila di$pil$e{l !* aban{jonsC rrir*s lar, ten*fated lioi.lprodrger gas planl rxi'l bf sold tr atlhorized recyc!*rs. Cok* brer;e !'Jili tJr: !$ed *i fuei !nthe exising f*rrc alloy I sinter plant

8. Al? th* Cck* Oven Planis i>2.5fJ.00C TtAj ar* liste(i *t Sl |,]c 4 ij:) uniier Ciitc.lcrv'A' in ihe sched[is if f lA Notlfication. 2006 atlil are apysrais*4 by it4t exper] A;:pri,itial0orfin'ritteo in th* Ministry.

:hc p, J:ilsal !1.1\ L6nstcercfl by :rC ixde l -.or)rd,i.t.,;: r.r..ri..i" 1 r,,,J.,s: I ,

ils 15': r-.reer,nq l'€r'i dL,rinq 21,1\- 27$ Ocbber, 2C1A. ?he Crm,ijilt:e recc,:lll,o ded iheprrpasal for environmonlal c,earanee sijbjeai lo $1ipulatioir li $piic.t,- ,.J.,Jrr,ons dlo,rg iiiihoth€r envirofir*ent:11 cond:t;$s. Public hearing of the projecl wan h*rL. , r,' J ii\ /t ia

10. Basod *ri th* intormatl*n submitled Dy you. p:es€nlatioll made !]y y{rir axrlconsuliani. l',4/e etlvri.rtecb fasl Pvt- Lld.. Kotkata. the Minislry $l frviffnntsnt ani Forestl

II

I

her$bv ac*atds srlvironmantal Nlear*n{:e to the abov* projeci und*f iire pfiivlsions *t IlANotitication dated 14"' Seplember 2006 subiecl tc $trici co'r'roli:rqe ct i!-r* f!)llnllling speciiic

and {ienera, c(}niiili*ns.

$PeelFlf c0t{p,?l*l,i$ :

I -

llffor-ls shall b* mace t0 feduce RSPitl lgvgls in ihe an*r*rli air and e iinle bo|rnc

aclion pian 5h;tlt h,e subfi]itted. On'line an]bienl ak qraliiY xllartlttin$ and corllinriusstack rn{;nilorang laciljliss tor all the statks 3h3ll be pr*vided.

The Natrafl:rl F,mbieni Air Quaiily $ta*dard$ iis €d by llre triifli:riry vide C $ 4. N3

826(t) d*t*.J 1$ii' Noven:ber, 2009 slrollcl b€ lollt"';ed.

slack monitoring iarililies for all lite m*jor stack$ and ei*qtaie a'r oolltilioil co;.:trcl

syslen,s vi: Crsl c:tclrers. bait tillers elc to No iisl rradiciilriE el''li:*iei1$ ''tiihi:'l ll€

pi*scribctJ lilriis ?om coke oven shsll be pfovided i:iecl:"oshl1: f retipl1alcr.i :;hell ;tinsi;r{led io rontr*l pa*ioulatc eilissions lrom the capliv* ?*w{r{ pi?frt" Catbor nrl;-;r-

nxide {CO) tha,l niso be rnoniiored sltng wilh clhst par a}r*let:i and 5!:rrdal'i$noiified under lnv;ronm3nt {Prctsction] Arl shail be iclloltac i-he |eporl$ shall be

s*bmitied 1r the Mini$|ry'$ Regionai O!11.e at the thLlban"swar' Ce'lllai Poiluilcfl

Conlrcl goard {CpCA) a*d West 8enga, f*lluiion Crillrri Bcard iWBPCS}.

Multi riag* rc.ubbB'. shali be instailgd 1{r fcnlroi gaseOts antl .ju3l {rmlssion trom'lll€

cok€ t1,,€r1 stack. Measl:res shall be li:lkefi le plev*nl l*akages ittl]'l llle a3ke nvsn

planl

l-h* pie:crtb*d emission stanilsrijs for .nle over pla,lis as r'*litia<i uidt noliiii:allcnno. i;sa 46 ii:i riaLd 3" !:ellruary. 2tJQ5 a{1d subseq''r*:l1iY zx*et:'lec sl'1''1 be

colnpil{:ii rriilr

in plarl i:on|rri rreasurei like bag fillers. d€-C.jsiilrE ar'4 cr.l slrpt.a$$ior.1 !;y$tjir:shall be prrvidrd io conlrol i gitive elnissrcns lram ail {hs vLti.tzraaie soi.rrcos Dusl

srtraciiofl and s pp.e$sion syste$ *ilall be paovided al ail lhs t:a|l$f*r F-loinis, *oai

handling anl and coke soding plarii ol rok* oven plt{ti. 8.}|} liJters $hall be

provideC lo h.ads '1nd

dusl coll€ctl}r$ tc coai and coke l:andling 10 tonltJl .iusien-.is;icfls Waler sprinkiing syslgm shall ba plolideiJ tc{)crllroi sccondarl' lugi:i|edusi er.r'j,ssicrls gen*nled during scr*e::il3 !oadin!]. irninad;ll!, lal,ijiiilg eril sloragtof rau; rraarrial$ €tc.

Secondary tagiiive emissions shall be cnnlm'led !'riil-rin tha gr::scril:{.d limiis' regulafly

*ronitofsd and rscords maintained. G|ljdeilnas : Cc'e Ql praciicc i$sued by lhsCPCB in thls r*gard shall be follcwed

Vel]ic lair F il iion du* 10 :ran$pot1aiii,.l oi.aw n'iaigii*i arlij liri:;iea plcdutl $laii ilecrntroiiod- Froper arta*semenls shaii al$6 be fiade io contrc1 *usi eryris3icns drli*iJlnadint ard |J*lr,adirg of the raw maisrirl aniJ fantshed pt**':..i i;iirds shall sisc bs

$ade tQ rca!\ce irrp&c. oi the lra'1spoil 3i ifi'3 rcvr n*i/:tiai' ailil i:nd praduct3 cn th*sulror {jing erriroriu*rii includ,ng agir.Llilrrr! la*.i. Ali th* i:ew i:--tl.rials incitding tiyash shali ;r€ irantpo*ed i* the cio$3d i;*tiiainots only a d 3i1rii t:ol be ,'te,lced*(j.Vehicula jr ri$$ion$ $hall be regrlarly l:'icnitoled and rscarjt: r.*iit

The cc*rparl.7 $hall exp,cr* po$sibillty {)1 i-i$a ct bollcn it'"*1lat *t i.:L ffanuiact ri*g

v l.

IX,

Coke bresz€ $haii tre tscai as { el in lh3 €xisiing ,ero siioy rl,'i. {lral fines shall iiesold il rccr; iic'rent olant / brick s3nsi3;i;;1" i :-r. g"".r-i-j jir:in Froducer *aspiant -qhalt :re sald i.i authori?ed recycte:s. $- ;;a";;i;;;i1l shall be used tarlanditti*e . T!.:e u/sste oit sl.rat| be properl"y dispo;ert

"*;;;";il :{azer{ious w3*ie{ivarager;i.11 handring, Hanciring and r*luti"ri,i,y'ur*L**,rii-!u,*u. rooo

xv. The ieacmfi€ndaiions maCe in tho Cl.rafter o, Caialr"ui,on ",unt

pioJ*"Joi r in r rr i* *," 1",,$;;"?il;'i;ji i*,::Jiffi ?Jjt

t*xvi' As propr:sed. gre*ft beri shn*'d be deveirred in 3i ic;rsr 33 "/a *i rrle prcieti ar*e v*!.*a. revisec Ar**n beil p,€in so :1s la hava a nlnin.,ur" uri*tlt oi 11ii j ?S n1 $alertjQn rfplanr speri*s sh6r be a$ per the cpca srraeii,,es n ;cisulaaa* wi.h rne nro

-1-

Ths. rnake ,p requiren:enl of th* wrler *hall noi axceed 3A |lftr. /\il lhe l..:rrt!rij:11:".ru" snalt be recycte{r tor. d!.,sr s.:pp.cs;;, ;; ;;.," i,,, ,1*ui, 0,,...uo'nesl.c tlasiewater shall bel,eatectn{aottcldr),(.o ou,ed-rv,.,.rp,,"rn_.,.'." o,green beti devetopmenl Zaro et'u€nl aj*'.Lirg*

'_ir[";. ilr;iri io;tnoooo on,: nowaste'varci qha,l be discna"ged oulsjde lfre prim,ses. n{ tta, irwntt,:rlnp t:t -f rett€Jemetts i rL'Jding Arsc.lrc rrt lJrt GroL : , Lf olr, r ;s l', rr.

-nt ,

Hffons shall be n'lade tr make rrce ol rcii1\uet*, ltairest€d t, .ra,ed*.1,aapacili,,i ihereservoir shall be enhanced to n]get t,rc max;nun: ,"t*,,*o!i*r*:. Cnly ba;at*waier re{iuirernent sha,l be nel iram cft€r srurces

l"he cornpany 6ha,l pr ,ii:i* houring lci,o,irlruclj*n iabaalt,''ilhir llts site !,rilh a;jnec€ssary irizitruc::rre erd tacilitiea ;:;ci.. as iLrsl fa, :ia:iing",lo*ile .toi,*i:. l;:obijc'TP,

saf* dri;klrc !,rat€r. ?;e,ti(:.ai beai*1.,r;. ;;; ;;-;rt )ii.,,.g nrry o* ,. ;,r"{atm al tempa,ar| _qtiurtr.e$ tr be reftov*ij aftsr the lrl',:rpl*lic,t i,i fire pro;ecf,

CTNERAL CS'{DITX}'{S:

'h0 rr*je't aurhoriiies xlu$r striclry ?.r*ers'.., t!re sripur*ii.r'ii rred* by rhe i/!e$lBeflgel tlale po,l iion Cirntrol Boar"C arrrj the $tJi;#;i;r;,,

X.

xii.

xtv

xvl't.

8.

lr.

-i-

l.io tudher expanGion or *.todificatiors jn ih* planl $haji br carfled aul wilhoulprior appfnval of the Minisfry ot Environ:ren1 anrj i:*resls

The 0a€e0',s emissio,,s Imm varrou$ pro?€$$ u'Jir$ shrr c,r]farnl r0 il.]eloadtmses based standards nat'fi*d by iiris w;nlstry olr i lli" t t,ry, 10El anislanderds pre$cribed from time to ti,ne^ Ths Sta{e go:,:rd fiay $r}si;ily nx}rs$iringenl $tandalds for the reievan{ paramaters keeping in .:iew the nalLtre ni ih*induslry irnd its sizs and 'oeation.

il l-,*,t:t: t?,1

"tnlient arr quality monitorlng st:tions sl,rLl,J be csaai:]ti$hed ir traoowrtwarLJ dtrecllon as well as wherc i.taxir*rm gr**r<i 1,]',,i,3i Cl)l]Cetltaritn OfPM10, $O, ard NOx are anticipaleit in cnr:sultai0n .",;jll fh* SpC|]. Drf,

",,'embisnl air qua,|ly and stack efiissicn $hall be reg*:arty sui;ritilir:d to ihis t1in.stryinclldtng tts Regional Oifice at Bhubanes*", ,ni rnJ si,c*iilca onre i, s,r*rilnthg.

l11l:t:1" \,\,,rsiervate: sl-aJr be urcp*r,, r:o,tpcled irea!oq ... :i., io cont3,:n -c ;teslalld\r'rt$ pre9c'ibed Uader GSn 4J-. {[. d;]red ,f. l:ay -.gg, ,no , , .

lJecen"ibor' 1ss3 or as amended fo"{.n r inc to t,,.-,* t t,u t,.-.,Ji i,;asrewater sharibe liliz{:d lor plantatiol] purpose

T're .rvetatt :turse ievelb rr: artd atl]l.. I rnts ,r,;n,

::1 y' *, -,.1 g s! ov o*,0 i'JJ1Ilff '"Jli,jiff i:ff ,-:l l-i'iffi l'l'*ili;r.ooJi s {encers enclnsures etr o,) ali sou,,ces oi n.):se q:t]e.a ol, I neamliieni rcis* ley:lls should conforn.r tc lhe srandards,.rr"r.i,n*a tniiet fpARrles. 19&9 'iiz. 75 dBA {daytirne) end 70 d$,q inigf,tiift;1,

Occrp*ironal healfh sutuaillanca oi'h* r/rorksrg shall b* .loi* *n a regr,ar brslsar,a1 ttltlt*s ftaintatned as pet the Facio!,ies Aci.

tha cai.tlgary $ha,' develop stfiaue ,later ,lL:nesljng 5J. ,:lri.:rj tc lrgt,nosl ihgrain \oel':r fot ulilization jn lhe lean s6;t$on besiajes ,ir*r* i1;r,i irro grcirryl lvalcrlable.

'i'i1e projeei paopon€nl $hafi arso cainply with at fte en,r:ronmentar p;ati.iio,n]oas!.es and saleguarci* recan:nonded in lhe t N?_r,4r, npOit. t li"ttrer. tr.,scAmran\l r]tusl nale{aka socia €lc,:orn c -:c.ell.l:1, - .: jc,tvlttes tI ihesl.r?uuit,ng villages like cornrnuniiy ajevelap.n€ri pr,rgru,r,ini., e,Ju{:aiio:iaiprogra ?nes. drinking waler sl:p ply end reawl ,:ai* F:tc

1X.

ecsvannu*1 6nviii:nntent

Slaie Gove,"nm€ni An

(]lrei prfp{::se_

meaa le$

xr.

x,it.

vil

\he ar,vtttt;t1..*t1lal st;tefienl lot €at a ii1l:tr)ai(,i

xvt

"i:.

the ucjec; ptollonenl s!"tail uplca{ il}e ,tatJ,i,}i c.:,]'r1,,.!itr: i.}i ihe 5i)r).i?ti?.t}c^r''' ... .',lcd.J..it .. .r ljt.clj ,L. .:., L,,-, , . ";

.". .:,,ye ir$ilr .ind shsl' updaie las rslle ,e{i.J.j1.;1y. * st.,at: t,,rrt:t:)rl:i*i.tr;y ac g*|i i.ilr., llrgic r! Athce at lh.- tu1O[F ai thubar' iuer Tr.*,*u1r"..f i.* ;i,i" ;rl ,_" *fC?C* ar* t|',e Cf:.C3. The cite,, .. pr,1.rr.,, , o,-_ ,..i, .,,,, ,lrliA. Sf:r. f.il,i3fitlr;3n1 levels ag v,reil a* gl*c^ $ir.,s;1u,,$r L,, ,_rll;i,:l ,.;\;tot;::.,1 l1aiaft*ie{,,-1i,.1.,1"

tr, ,rr)e Froi,'r1s .\d bt." trnt.,ttavl ana *,r,7.,,aiiii" ;-i a ror1verieni':.){,; ' .. !rr lr1i. rt :rr. .t.r:a c1 :hc : ; .. :.. 1..,. ..:

thaii also tat:a]l ttx tT.)t /.i rril lht siiliir: ?1 lftti

f.Jct f: i'l*t Z*fial Ofiitt .a rl{;* z:,ts:.',te ;Jl:.;.,a. I it<:: i L.:r.al :.:)iltc.tl

i i't l,iat{)., in i:aJii:-ir

- l; :er, r, rl,)3rJ a; lj! . ' ' ', 'c r. ' ,: .. , r-'-:, fl I i*"..

'f otu t iattiii jil.l

{}*^*;*,*,.-*r. ?.L. A}ul{:*i.}

*xi.ri4itt- .r;

?tcied .:r1',\t{itit':3 shaii tfilatrcl th€ Rci_::axal I,iiitce ar; ri,:,::li at, ti}e Mfitsit.:i ir,{:,lat,, ,ia lii",er,aiet c,cstt e t r,d tinal al:?nval t:l |h: r,r+,t.,t:: ,,.t" lhe t:l:,1*, t,t t,erta|:tit,.:r:, ilnii l.ili! dat,a at i,erjnilitat.jt::t {} t-l;e iarlc .:tra,ti:i),i,::,,:| +.|Jr?

11 i'*e L,\itjsi-t / ay rg9*k* cr guspatd ,tlt ,:,:,:r:i eri:; ,t, ia1fi"at,,,.)i..,::_,;),.)t\,_r1 a::.; oi itdLJ!t' C )' :r: ,:,c Jl ..,. jl,L.-',..

12. i|re M:llsti-'y' rfsefr*s lla righl ki s1lpi'liatil ,i.l*iliaflai {:eadl\i:,3a; ja k)un1 t\t.r!),:.atlI ha ilotrtn t irt e hr:) boufitj ffatnei- $lall in1plat|{3:.11 ihsse aa{\)ti.ta},.,.a,

l-3 rhe sbtrf t:]ft'aitcttt s.a'ti ,,t er,!,Jta€jaa ill*I-atia ulti.:t airi r1,r?r::jijr$ t)i rit) v.1i;,..ttpre\Je.ljan & {:rrtttl ti ?)lit.tl;t '.) l'.tl 1€)74. *,t:: ;ry rt}r*,';}rtr^t:t' , a.,,:,.:,.t:,:rt Jl ?oir,1iiet,.) ,\.,1t81, lhe l:.tif ii):*:.:nl i.? {c1".:1i}n} ;ici. t9B6. :1t:z.tr,:at.ts W a,tiJs l,uar,eg<:::eni lirdii',3nd 'i.nnsb'xrriary Mov*r?,,r:]ii l:.{r,-iJ ^r,,-,g -. "_r r'!i r ..o.,u,, ii.rr.rn,.,.,,,.,, ,.iri)tLty A.:i .}ati}1

);ni.: !,,r:i'in , ,...... j::\a -...i-\

:.\": ,.i'," t:,a*\a: .:ii;:i,.ia ,iL

PHOTOGRAPHS

six monthly compliance report · cfbc boiler is sold to local cement plant/brick manufacturers....

Documents