RIDE ON ATVitem number: 048-ATV12

Product Specification

Accumulator: 6V7AH/12V7AHElectric: Drive 6 v 20 wAge: 37-72 monthsMaximun user weight: 66 lbs (30 kg)Dimension: 34.6 “ x 24.3” x 25.4” (880 x 618 x 646 mm)Speed: Low Speed 1.4 mph (2.3 km/h)Speed: High Speed 2.2 mph (3.6 km/h)Use Time: 1-2 hrsCharge Time: 8-12 hrs (18 for first time)Charger: DC 6v 1000 MA / 12 V1000 MA

Safety Instruction

When using electrical product, basic safety precaution should always be followed including the following

Read all Instruction before use• To Protect against electrical shock, do not immerse cord, charger, transformer, battery, or the product in

water or other liquid.• This toy is not intended for children below 3 years of age.• only use charging devices and transformer provided by the manufacturer.• For your children’s safety, the product should be assembled by adult.• Close supervision is neccessary when your children is using this product.• Inspect the product before each use. Do not use if you detect any loose hardware.• Personal protective equipment such as helmet is needed when using this product.• Do not use this product as a traffic tool.• Do not use this product on public road, raceway, by the swimming pool, or at any potential dangerious

places.• Do not use this product on slippery surface.• Maximum user weight for this product is 66 lb / 30 kg.• Do not change, modify or add any electrical wiring on this product.• Avoid using this product in tight environment to prevent damage to the product or injury to the user.• Unlatch the battery if not used for a long time.

Parts and Feature

1. Body

2. Seat

3. Seat Lock

4. Rear Wheel Axle

5. Gear Unit

6. Wheel

7. Wheel Washer

8. Wheel Nut

9. Wheel Cover

10. Electric Stopper

11. Battery Holding Bar

12. Battery

13. Steering Column

14. Steering handle

15. Charger

1

2

3

45

6

7

8

9

10

1112 13

14

15

Assembly Instruction

Front axle assembly

Slide on a washer, wheel, and another washer on the front axle. Secure it using the nut. Then snap the wheel cover on. Repeat the same process on the other side.

Rear axle assembly

Slide on the gear unit, wheel, and a washer on the rear axle. Secure it using the nut. Then snap the wheel cover on. Repeat the same process on the other side.

NOTE: Make sure to install the right gear box on the right side and left gear box on the left.

Front Axle

Rear Axle

Wheel Cover

Wheel Cover

Wheel Nut

Wheel Nut

Washer

Washer

Left Gear Box(w/ Blue + Yellow wire)

Right Gear Box(w/ Red + Green wire)

Assembly Instruction

Steering handle assembly

Remove the bolt and nut from the steering handle. Align and insert the steering handle on the steering col-umn. Secure it by replacing and tightening the bolt and nut on the mount.

Battery connection and seat assembly

Connect the battery unit underneath the driver seat by the connectors with correspond colored wires and secure the seat by tightening the seat lock.

NOTE: Make sure the color of the wires match up when connecting. Failing to do so may result in the vehicle not moving or moving in undesired directions.

Sticker Decoration Application

User Instruction

Before Use

• Make sure the product is fully charged.• Make sure all componants are well assembled.

Power / Gear Selsction

• Turn on the power by pushing down the power switch.• Select Low / High speed by using the speed selection boton.• Use the gear selection button to select forward / neutural /

reverse.• Step on the pedal to move.

Music Horn Control

• Music horn control is located on the steering handle. Push the button to use the music horn.

Padel Switch

Slow-FastSwitch

Power Switch

ForwardStopBack

Music Horn Button

User Instruction

Troubleshooting

Care and Maintenance

• Store the product indoor.• Avoid direct sunlight, rain, water, or snow.• Clean the product termly• Do not wash the product with a hose

Problem Possible reason Solution

Vehicle does not move

Battery is too low Fully charge the battery Fuse protection Replace with a new fuse

Disconnected battery Reconnect the batteryfailed battery/ motor/ electric Contact customer service

Battery does not chargeBattery disconnected Reconnect the battery

Charger not connected to socket Plug in the charger

Battery is warm and make noise when charging Normal Chemical reaction Normal phonomenon

(Battery within 60°C / 140°F)

Short milageBattery is too low Fully charge the battery

battery is old change battery

Slow Speed

Battery is too low Fully charge the battery

overload This product rated max user weight as 35kg / 77lbs

Driving on slope / rough surface Normal

Vehicle shudders / jerks motor problem

Ensure properly connection to the battery / gear box.

Contact customer service if fail to address the problem

Forward and reverse flipped incorrect gear unit installationEnsure the gear units are un-

stalled on the correct side on the rear axle.

Limited Term Warranty (One Year from Date of Purchase)

WARRANTY TERMS ADDITIONAL CONDITIONS

ADDITIONAL CONDITIONS

KIDZONE warrants that its merchandise are free from manufacturing defects (workmanship and/or material) and will either give credit or replace defective parts for a period of up to one (1) year from the date of purchase in accordance with the conditions set forth below. If a manufacturing defect is found, KIDZONE should be notified promptly of the defect and supplied a copy of the invoice and delivery ticket. Inspection by a KIDZONE employee or representative may be necessary to verify that a manufacturing defect exists, or you may be required to submit samples to KIDZONE along with a digital image of the defects. If replacement is required in accordance with this warranty and the defective material or merchandise has been discontinued or unavailable, KIDZONE reserves the right to select and supply similar merchandise or offer full credit for the merchandise; otherwise the same material or merchandise will be supplied for replacement purposes. This warranty is made solely to the retailer and is not transferable under any circumstances. It is the retailer’s responsibility to contact KIDZONE with a claim. We will not handle claims from consumers directly; all requests must go through the retailer who sold the merchandise to the consumer. We advise all retailers to retain invoices for a minimum of one (1) year for warranty purposes. This warranty supersedes and replaces all implied warranties of merchantability and use for particular purpose. No representative, employee, agent or any other person is authorized to assume for KIDZONE any additional liability or responsibility in connection with KIDZONEs merchandise except as described above. Implied warranties or merchantability and fitness of the merchandise are limited to a period of one (1) year from the date of purchase. In no event shall KIDZONE be liable for indirect, consequential or incidental damages of any kind.

THE FOLLOWING EXAMPLES ARE NOT MANUFACTURER’S DEFECTS:• Colors may vary slightly from the photo

because of photography and printing tolerances.

• Sizes stated in U.S. standard measurements may vary slightly due to product are manufactured using the metric system.

• No returns for buyer’s remorse.• No returns - other than stated above will be

accepted.

WARRANT IS VOID FOR ANY OF THE FOLLOWING CONDITIONS:1. Improper maintenance or improper use

resulting in damage.2. Any product modifications by dealer,

consumer, or other parties not authorized by KIDZONE will void this warranty.

3. Floor samples sold or products designated “AS IS” at the time of purchase are not covered by the warranty

4. Warranty does not cover minor variations or differences between floor samples or printed illustrations and your product.

5. Cost of packaging and shipping to and from KIDZONE is not covered by the warranty unless expressly arranged by KIDZONE.

6. This warranty covers only articles of appliances intended for residential use only, does not cover any industrial, commercial, institutional or Rental use.

7. Dissatisfaction due to buyer’s remorse.8. Normal wear and tear.9. Damages incurred during transportation.10. Damages incurred during assembling or

maintenance.11. Damage incurred by accidents or abuse.