refrigeration heat exchangers• lower system costs — better heat transfer coefficient (htc) gives...

871

REFRIGERATION HEAT EXCHANGERS

SWEP COMPACT BRAZED HEAT EXCHANGERS (CBE’s)• Maximum Material Efficiency — No “dead zone” outside gaskets because

there is no need for gaskets. Up to 25% more capacity utilization than PHEs (gasketed, plate-and-frame heat exchangers), and up to ten times more than shell-and-tubes!

• Small Hold-up Volumes — The compact system uses only a fraction of the heat transfer medium, e.g. refrigerant. Less volume costs less and is posi-tive for the environment.

• Lower System Costs — Better heat transfer coefficient (HTC) gives better ∆T (temperature difference), which in turn means a lower mass flow of media, resulting in smaller, less expensive pumps, etc. and lower energy consumption.

• Small Temperature Difference — Operates efficiently even at temperature differences as low as 1k.

• High Working Pressure — No problem even if you have high pressure. Our CBEs are tested at 1.5 times the maximum operating pressure rating.

• Low Pressure Drop — In most cases lower than any other system. Allows smaller pumps and lower operating costs.

• True Counter-Current Flow — Allows close temperature approach.

• Self-Cleaning — Thanks to high turbulence throughout the exchanger. Boosts up time and cuts costs.

• Uniform High Quality — Plates are pressed in the same tool, brazed in the same automated procedure with rigorous standards of quality control. Per-formance is known and consistent. Maintenance and repair minimized.

• Overall Economy — High-volume, automated production, easy assembly, low operating costs and excellent heat transfer. The bottom line: outstand-ing performance and a short payback time.

P4157

872


SWEP COMPACT BRAZED HEAT EXCHANGERSApplication: EVAPORATORS

NOTES:Nominal Tons 12,000 Btu.Conditions — 54 F EWT, 44 HF LWT, 35 F Evaporating Temp, 9 F Superheat, 2.4 Gpm per ton, R-22.For other conditions call the Totaline Commercial Refrigeration Hotline.Various connection executions are possible, please get in touch with RCD Commercial Refrigeration.

*These units have a 22 psi pressure drop across the evaporating refrigerant side, can be reduced, consult RCD.**These have a 15 psi pressure drop, as above.

PARTNUMBER

MODEL TONSWIDTH

(in.)LENGTH

(in.)DEPTH

(in.)

REFRIGERANT WATER-NPT(F2 & F4)I.D. (in.)

NETWEIGHTIn (F3)

I.D. (in.)Out (F1)I.D. (in.)

SW10650-016 B8 E 1/2 1/2 2.8 12.2 1.6 5/8 7/8 3/4 4.5SW10650-020 B8 E 3/4 3/4 2.8 12.2 1.9 5/8 7/8 3/4 5.1SW10650-024 B8 E 1/2 1 2.8 12.2 2.3 5/8 7/8 3/4 5.7SW10651-016 B15 E 1-1/2 1-1/2 2.8 18.3 1.6 5/8 7/8 3/4 6.6SW10651-020 B15 E 2 2 2.8 18.3 1.9 5/8 7/8 3/4 7.5SW10651-024 B15 E 2-1/2 2-1/2 2.8 18.3 2.3 5/8 7/8 3/4 8.5SW11510-020 B25 E 3 3 4.6 20.6 2.0 7/8 7/8 1 15.8SW11510-020 B25 E 3-1/2 3-1/2 4.6 20.6 2.0 7/8 7/8 1 15.8SW11510-024 B25 E 4 4 4.6 20.6 2.4 7/8 7/8 1 17.9SW10152-030 B25 E 5 5 4.6 20.6 2.9 1-1/8 1-1/8 1 21.0SW10152-044 B25 E 7-1/2 7-1/2 4.6 20.6 4.2 1-1/8 1-1/8 1 28.2SW10308-026 B45 E 10 10 9.5 20.6 2.8 1-3/8 1-3/8 1-1/2 36.6SW10308-032 B45 E 12-1/2 12-1/2 9.5 20.6 3.4 1-3/8 1-3/8 1-1/2 42.3SW10308-040 B45 E 15 15 9.5 20.6 4.1 1-3/8 1-3/8 1-1/2 49.8SW11057-054 V45 E 20* 20 9.5 20.6 5.5 1-1/8 1-5/8 2 65.4SW11057-070 V45 E 25* 25 9.5 20.6 7.0 1-1/8 1-5/8 2 81.1SW11057-080 V45 E 30* 30 9.5 20.6 7.9 1-1/8 1-5/8 2 91.0SW11727-090 V57E 40 40 9.6 27.3 9.2 1-3/8 2-5/8 2-1/2 164.3SW11727-110 V57E 50 50 9.6 27.3 11.2 1-3/8 2-5/8 2-1/2 192.9SW11727-140 V57E 60 60 9.6 27.3 14.0 1-3/8 2-5/8 2-1/2 235.9SW11727-160 V57E 70 70 9.6 27.3 16.0 1-3/8 2-5/8 2-1/2 264.6SW11727-200 V57E 80 80 9.6 27.3 19.8 1-3/8 2-5/8 2-1/2 321.9SW11727-220 V57E 90 90 9.6 27.3 21.7 1-3/8 2-5/8 2-1/2 350.6SW10676-150 V65E 100** 100 14.3 34.0 14.4 3 4-1/2 4-1/2 490.6SW10676-180 V65E 110** 110 14.3 34.0 17.1 3 4-1/2 4-1/2 563.4SW10676-180 V65E 120** 120 14.3 34.0 17.1 3 4-1/2 4-1/2 563.4

873


SWEP COMPACT BRAZED HEAT EXCHANGERSApplication: CONDENSERS

NOTES:Nominal Tons 15,000 Btu/h.Conditions — 85 F EWT, 105 F Condensing Temp, 3.5 F Sub-Cooling, 3 Gpm per ton, R-22.For other conditions call the Totaline Commercial Refrigeration Hotline.Various connection executions are possible, please get in touch with RCD Commercial Refrigeration.

PARTNUMBER

MODEL TONSWIDTH

(in.)LENGTH

(in.)DEPTH

(in.)


NETWEIGHTIn (F1)


SW10010-010 B8 CD 1/2 1/2 2.8 12.2 1.1 7/8 7/8 3/4 3.5SW10010-016 B8 CD 3/4 3/4 2.8 12.2 1.6 7/8 7/8 3/4 4.5SW10010-016 B8 CD 1 1 2.8 12.2 1.6 7/8 7/8 3/4 4.5SW10010-020 B8 CD 1-1/2 1-1/2 2.8 12.2 1.9 7/8 7/8 3/4 5.1SW10010-024 B8 CD 2 2 2.8 12.2 2.3 7/8 7/8 3/4 8.5SW10010-030 B8 CD 2-1/2 2-1/2 2.8 12.2 2.8 7/8 7/8 3/4 9.9SW10039-020 B15 CD 3/4 3 2.8 18.3 1.9 7/8 7/8 3/4 7.5SW10039-026 B25 E 3-1/2 3/12 2.8 18.3 2.5 7/8 7/8 3/4 8.9SW10039-026 B15 CD 4 4 2.8 18.3 2.5 7/8 7/8 3/4 8.9SW10039-040 B15 CD 5 5 2.8 18.3 3.7 7/8 7/8 3/4 12.2SW10961-030 B27 CD 7-1/2 7-1/2 4.7 20.7 2.9 1-3/8 1-3/8 1-1/4 19.4SW10961-040 B27 CD 10 10 4.7 20.7 3.9 1-3/8 1-3/8 1-1/4 24.3SW10961-050 B27 CD 12-1/2 12-1/2 4.7 20.7 4.8 1-3/8 1-3/8 1-1/4 29.3SW10961-060 B27 CD 15 15 4.7 20.7 5.7 1-3/8 1-3/8 1-1/4 34.3SW10175-040 B45 CD 20 20 9.5 20.6 4.1 1-5/8 1-5/8 1-1/2 49.8SW11751-050 B57 CD 30 30 12.0 27.3 5.2 2-5/8 2-5/8 2-1/2 77.6SW11751-070 B57 CD 40 40 12.0 27.3 7.1 2-5/8 2-5/8 2-1/2 96.3SW11751-080 B57 CD 50 50 12.0 27.3 8.0 2-5/8 2-5/8 2-1/2 105.7SW11751-100 B57 CD 60 60 12.0 27.3 7.1 2-5/8 2-5/8 2-1/2 124.4SW11751-120 B57 CD 70 70 12.0 27.3 11.6 2-5/8 2-5/8 2-1/2 143.1SW11751-140 B57 CD 80 80 12.0 27.3 13.5 2-5/8 2-5/8 2-1/2 161.8SW11751-160 B57 CD 90 90 12.0 27.3 15.3 2-5/8 2-5/8 2-1/2 180.5SW11751-180 B57 CD 100 100 12.0 27.3 17.1 2-5/8 2-5/8 2-1/2 199.2SW11751-200 B57 CD 110 110 12.0 27.3 18.9 2-5/8 2-5/8 2-1/2 217.9SW11751-220 B57 CD 120 120 12.0 27.3 20.8 2-5/8 2-5/8 2-1/2 236.6

874


SWEP COMPACT BRAZED HEAT EXCHANGERSApplication: SUBCOOLERS ECONOMIZERS

NOTES:Nominal Tons 12,000 Btu/h.Liquid refrigerant subcooled from 110 F to 50 F, Evaporating Temp 35 F, Superheat 9 F, per Ton.For other conditions run unit performance calculation on SSP.Pressure drop across the liquid side of the subcoolers is less than 3.75 psi for all selections.

PARTNUMBER

MODEL TONSWIDTH

(in.)LENGTH

(in.)DEPTH

(in.)


NETWEIGHTIn (F3)


SW10014-016 B8 SE 2 2 2.80 12.20 1.60 7/8 7/8 7/8 4.50SW10015-016 B10 SE 3 3 4.6 11.3 1.7 7/8 7/8 7/8 7.8SW10015-026 B10 SE 5 5 4.6 11.3 2.6 7/8 1-1/8 1-1/8 10.5SW11142-020 B27 SE 7 7 4.6 20.7 2.0 7/8 1-1/8 1-1/8 12.4SW10863-026 B27 SE 10 10 4.6 20.7 2.6 7/8 1-3/8 1-3/8 17.4SW10863-030 B27 SE 12 12 4.6 20.7 2.9 7/8 1-3/8 1-3/8 19.4SW11730-036 B27 SE 14 14 4.6 20.7 3.5 7/8 1-5/8 1-5/8 22.3SW11731-040 B27 SE 16 16 4.6 20.7 3.9 1-3/8 1-5/8 1-5/8 24.3SW11733-026 B45 SE 18 18 9.5 20.7 2.8 1-3/8 1-5/8 2-1/8 36.6SW11733-030 B48 SE 20 20 9.5 20.7 3.2 1-3/8 1-5/8 2-1/8 40.4SW11733-034 B48 SE 22 22 9.5 20.7 3.6 1-3/8 1-5/8 2-1/8 44.1SW11732-040 B48 SE 28 28 9.5 20.7 4.1 1-3/8 2-1/8 2-1/8 49.8

875

REFRIGERANT HEAT EXCHANGERS

REFRIGERANT HEAT EXCHANGERSFOR USE WITH TOTALINE UNIT COOLER MODELS

HEAT EXCHANGER CAPACITY GUIDE

CAPACITY RATINGS (BTUH) HEAT EXCHANGERFREEZER COOLER MFG. P/N P/N

5,500 8,500 HXR-50 83540187,500 15,000 HXR-75 8354019

10,000 17,500 HXR-100 835402015,000 25,000 HXR-150 835402125,000 43,000 HXR-250 835402232,500 65,000 HXR-350 835402361,200 85,000 HXR-500 835402473,000 120,000 LHXR-15 835403093,000 164,400 LHXR-20 8354031

118,000 208,800 LHXR-25 8354032141,000 246,000 LHXR-30 8354033166,000 288,000 LHXR-35 8354034

• COAXIAL DESIGN FOR OPTIMUM HEAT TRANSFER.

• FOR FREEZER CAPACITY: 5500 TO 166,000 BTUs.

• FOR COOLER CAPACITY: 8500 TO 288,000 BTUs.

• U.L. RECOGNIZED.

• COPPER REFRIGERANT CONNECTION.

• MODELS: 8354018 THRU 8354024 HAVE A COPPER SHELL AND RED BRASS INNER TUBE.

• MODELS: 8354030 THRU 8354034 HAVE A STEEL SHELL AND A STAINLESS STEEL INNER TUBE.

876


REFRIGERANT HEAT EXCHANGERS“HXR & LHXR” SERIES DIMENSIONAL DATA

DIAGRAM #1: “HXR” SERIES HEAT EXCHANGERS

DIAGRAM #2: “LHXR” SERIES HEAT EXCHANGERS

SEEDIA. #

DIMENSIONS (IN INCHES) HEAT EXCHANGERA B C D E F G H J K L MFG. P/N P/N

1

3/8 5/8 12-3/4 11 13 1-5/8 7/8 2-5/16 7/8 - - HXR-50 83540183/8 7/8 13-5/8 11 13 1-3/4 1-1/8 2-9/16 1-5/16 - - HXR-75 83540193/8 1-1/8 14-1/8 11 12-3/4 1-7/8 1-3/8 2-13/16 1-9/16 - - HXR-100 83540201/2 1-1/8 14-1/8 11 13-3/4 2 1-3/8 3 1-9/16 - - HXR-150 83540215/8 1-3/8 14-1/4 11 14-1/4 2-3/8 1-5/8 3-9/16 1-5/8 - - HXR-250 83540225/8 1-5/8 16-1/4 12 15-1/4 2-3/8 1-5/8 3-9/16 2-1/8 - - HXR-350 83540237/8 2-1/8 17-1/4 12 13 2-15/16 2-5/8 4-5/8 2-5/8 - - HXR-500 8354024

2

7/8 2-1/8 29-1/2 24 21-3/8 3-7/16 2-7/8 6-7/8 2-3/4 1-5/16 2 LHXR-15 83540301-1/8 2-1/8 29-1/2 24 21-3/8 3-7/16 2-7/8 6-7/8 2-3/4 1-5/16 2 LHXR-20 83540311-1/8 2-5/8 38 32-1/2 29-3/4 3-3/4 3-1/2 7-1/2 2-3/4 1-3/8 2 LHXR-25 83540321-3/8 2-5/8 38 32-1/2 29-3/4 4 3-1/2 8 2-3/4 1-3/8 2-1/4 LHXR-30 83540331-3/8 2-5/8 40-1/8 34-5/8 31-7/8 4 3-1/2 8 2-3/4 1-3/8 2-1/4 LHXR-35 8354034

A

I.D.B

C

D

E

F

G

J

I.D.

J

H

CE

D

G

J

H

A I.D.

L

A I.D.

BI.D.

F

K

877


REZNOR HEAT EXCHANGERS

Type AL, 409 S.S., & 321 S.S. differ only by material composition.

Catalogs & Price Pages available upon request.

Entire line of Reznor parts available under P/N’s REZ-nnn.

MODEL NUMBERTYPE AL

P/NTYPE 409 S.S.

P/NTYPE 321 S.S.

P/N(H,C)X 50 REZ-9962 REZ-19427 N/A

(H,C)X 75 & 100 REZ-9895 REZ-19429 REZ-19438(H,C)X 125 REZ-9855 REZ-19430 REZ-19439

(H,C)X 150 & 175 REZ-9817 REZ-19431 REZ-19440(H,C)X 200 & 225 REZ-9779 REZ-19432 REZ-19441(H,C)X 250 & 300 REZ-9743 REZ-19433 REZ-19442

(H,C)X 350 REZ-9707 REZ-19434 REZ-19443(H,C)X 400 REZ-9514 REZ-19435 REZ-19444

F,B,FE & BE25 REZ-102282 REZ-102311 N/AF,B,FE & BE50 REZ-102283 REZ-102312 N/AF,B,FE & BE75 REZ-102284 REZ-102313 N/A

F,B,FE & BE100 REZ-102285 REZ-102314 N/AF,B,FE & BE130 REZ-102286 REZ-102315 N/AF,B,FE & BE165 REZ-102287 REZ-102316 N/AF,B,FE & BE200 REZ-102288 REZ-102317 N/AF,B,FE & BE250 REZ-102289 REZ-102318 N/AF,B,FE & BE300 REZ-102290 REZ-102319 N/AF,B,FE & BE400 REZ-102291 REZ-102320 N/A

(H,C)R,SC(G,P,X) 75 & 100 REZ-44301 REZ-44302 REZ-44303(H,C)R,SC(G,P,X) 125 REZ-44304 REZ-44305 REZ-44306

(H,C)R,SC(G,P,X) 150 &175 REZ-44307 REZ-44308 REZ-44309(H,C)R,SC(G,P,X) 200 & 225 REZ-44310 REZ-44311 REZ-44312(H,C)R,SC(G,P,X) 250 & 300 REZ-44313 REZ-44314 REZ-44315

(H,C)R,SC(G,P,X) 350 REZ-44316 REZ-44317 REZ-44318(H,C)R,SC(G,P,X) 400 REZ-44319 REZ-44320 REZ-44321

878

REFRIGERATION MOTORS

UNIT BEARING MOTORS

P162

CAST IRON, SHADED POLE

ALUMINUM, SHADED POLE

DIMENSIONS (in.)

WATTS VOLTS AMPS RPM ROT B C P/N

2.5W 115 0.3 1000 CW 2.8 3.3 GE-51114W 115 0.3 1550 CW 2.8 3.3 GE-52114W 115 0.3 1550 CCW 2.8 3.3 GE-52124W 230 0.2 1550 CW 2.8 3.3 GE-52214W 230 0.2 1550 CCW 2.8 3.3 GE-52226W 115 0.4 1550 CW 3.3 3.8 GE-53116W 115 0.4 1550 CCW 3.3 3.8 GE-53129W 115 0.6 1550 CW 3.3 3.8 GE-54119W 115 0.6 1550 CCW 3.3 3.8 GE-54129W 230 0.3 1550 CW 3.3 3.8 GE-54219W 230 0.3 1550 CCW 3.3 3.8 GE-542216W 115 1 1550 CW 3.5 4 GE-581116W 115 1 1550 CCW 3.5 4 GE-581216W 230 0.5 1550 CW 3.5 4 GE-582116W 230 0.5 1550 CCW 3.5 4 GE-5822

DIMENSIONS (in.)

WATTS VOLTS AMPS RPM ROT B C P/N

2W 115 0.1 1550 CW 2.8 3.3 GE-51082W 115 0.3 1550 CW 2.8 3.3 GE-5109

2.5W 115 0.3 1000 CW 2.8 3.3 GE-51134W 115 0.3 1550 CW 2.8 3.3 GE-52134W 115 0.3 1550 CCW 2.8 3.3 GE-52144W 230 0.2 1550 CW 2.8 3.3 GE-52234W 230 0.2 1550 CCW 2.8 3.3 GE-52246W 115 0.4 1550 CW 3.3 3.8 GE-53136W 115 0.4 1550 CCW 3.3 3.8 GE-53149W 115 0.6 1550 CW 3.3 3.8 GE-54139W 115 0.6 1550 CCW 3.3 3.8 GE-54149W 230 0.3 1550 CW 3.3 3.8 GE-54239W 230 0.3 1550 CCW 3.3 3.8 GE-542416W 115 1 1550 CW 3.5 4 GE-581316W 115 1 1550 CCW 3.5 4 GE-581416W 230 0.5 1550 CW 3.5 4 GE-582316W 230 0.5 1550 CCW 3.5 4 GE-5824

FEATURES:

• PERMANENTLY LUBRICATED TO RUN FOR YEARS

• VERY QUIET OPERATION

• 24″ CORD WITH MOLDED STRAIN RELIEF

• TOTALLY ENCLOSED

• SUITABLE FOR ALL ANGLE OPERATION

• THREADED SHAFT 1/4-20, .51/.41 INCHES LONG

• SHADED POLE OR PERMANENT SPLIT CAPACITOR (PSC)

• EASY INSTALLATION:

— ALL MOTORS HAVE STANDARD 3 TAPPED END MOUNTING BOSSES.

— ALL MOTORS HAVE SINGLE SIDE PAD MOUNTING WITH 4 TAPPED HOLES, EXCEPT THE 2 WATT ALUMINUM.

TYPICAL APPLICATIONS:

• REFRIGERATION CONDENSING UNITS

• UNIT HEATERS

• WALK-IN COOLERS

• DEHUMIDIFIERS

• WATER COOLERS

• REFRIGERATORS

• VENDING MACHINES

CAST IRON, PSC - DUAL ROTATION

DIMENSIONS (in.)

WATTS VOLTS AMPS RPM B C P/N

4W 115 0.2 1550 3.5 4 GE-5114

6W 115 0.2 1550 3.5 4 GE-5116

9W 115 0.3 1550 3.5 4 GE-5117

16W 115 0.6 1550 3.5 4 GE-5118

879

ACCESS FITTINGS

A-1 ACCESS FITTINGSAccess Fittings provide a servicing aperture to facilitate recovery or recharge of refrigerants. All our Access Fittings come standard with 1/4″″″″ SAE male flare connections, built-in valve cores & brass caps. For availability of larger bulk pack quantities, please contact the factory.

Features:• AV Series have a permanent access ports & have 1/4″ SAE male

flare connections.

• AVX Series have a unique design, tube stops located on the tube to control insertion depth (thus preventing restriction of flow).

P4227

880

ACCESS FITTINGS

A-1 ACCESS FITTINGS

“R” suffix identifies parts with core remover cap.*Identifies parts without core depressor.

PRODUCT NO. MODEL SIZE WEIGHTPACKAGE

QTY.ORDER

NO.100

PACKAV2-456 Step down Solder 1/8″ I.D. hole, 3/16″, 1/4″, 5/16″ steps 0.045 5 6169 6294

AV2-456R Step down Solder 1/8″ I.D. hole, 3/16″, 1/4″, 5/16″ steps 0.043 5 6168AV3-346 Step down Solder 3/16″ O.D. tube or 1/4″ and 3/8″ solder 0.045 5 6141 6290

AV3-346R Step down Solder 3/16″ O.D. tube or 1/4″ and 3/8″ solder 0.042 5 6230AV-34 Straight Solder 3/16″ O.D. tube or 1/4″ solder 0.040 5 6142 6296

AV-34R Straight Solder 3/16″ O.D. tube or 1/4″ solder w/core remover 0.039 5 6232AV-46R Straight Solder 1/4″ O.D. tube or 3/8″ solder w/core remover 0.043 5 6234

AVU-24R Half Union 1/8″ M.P.T. or 1/4″ O.D. solder 0.044 5 6236AVU-45 Half Union 1/4″ M.P.T. or 5/16″ O.D. solder 0.072 5 6145 6287

AVU-45R Half Union 1/4″ M.P.T. or 5/16″ O.D. solder 0.070 5 6238AVU-4 Union w/Flare Nut 1/4″ male flare x 1/4″ access 0.089 4 6214 6286

AVU-4R Union w/Flare Nut 1/4″ male flare x 1/4″ access w/core remover 0.089 4 6240AVU-44 Union 1/4″ male flare x 1/4″ female flare 0.084 4 6215 6295

AVU-44R Union 1/4″ male flare x 1/4″ female flare w/core remover 0.089 4 6240AVX-2R 1/8″ O.D. x 2″ copper tube extension 0.045 5 6248 6302AVX-3R

Straight Solderwith 2″ extended

end tube andstops

3/16″ O.D. x 2″ copper tube extension 0.048 5 6250 6303AVX-5 5/16″ O.D. x 2″ copper tube extension 0.069 5 6178 6293

AVX-5R 5/16″ O.D. x 2″ copper tube extension 0.069 5 6254AVX-6 3/8″ O.D. x 2″ copper tube extension 0.080 5 6216 6299

AVX-6R 3/8″ O.D. x 2″ copper tube extension 0.080 5 6256AVT-4 Copper Solder Tee 1/4″ O.D. x tube x 1/4″ male flare 0.065 3 6222 6283

AVT-4R access on branch 0.065 3 6546AVT-5 Copper Solder Tee 5/16″ O.D. x tube x 1/4″ male flare 0.065 3 6223

AVT-5R access on branch 0.065 3 6547AVT-6 Copper Solder Tee 3/8″ O.D. x tube x 1/4″ male flare 0.073 3 6224 6191

AVT-6R access on branch 0.073 3 6548AVW-8 Copper Solder Tee 1/2″ O.D. x tube x 1/4″ male flare 0.088 2 6241

AVW-8R access on branch 0.088 1 6551AVW-10 Copper Solder Tee 5/8″ O.D. x tube x 1/4″ male flare 0.094 2 6244



AVW-14R access on branch 0.131 1 6554AVT-34 Brass Union Tee 1/8″ M.P.T. x 1/4″ male flare on run 0.098 3 6225

x 1/4″ male flare access on branchAVT-44 Brass Union Tee 3-1/4″ SAE Flare “T” Valve with 2 valve cores 0.098 3 6227AVS-4 Union w/Swivel Nut 1/4″ male flare access x swivel nut 0.088 3 6247

Core Depressor on runAVS-44N* Swivel Nut and male flare access on branch 6195

AVS-64 Core Depressor 1/4″ male flare x 1/4″ access on run 0.138 3 6219 6272AVS-64N* x swivel nut on branch 6196AVB-46 Brass Straight 1/4″ Lg. male flare x 1/4″ solder

Solder head body w/cap, core and nut 0.062 3 6124

881

ACCESS FITTINGS

A-1 ACCESS FITTINGSAVUX Series

Our new AVUX Series access fittings provide copper tubing with 1/8″ pipe thread below the hex. Other various tube sizes are available to provide proper fitting. A core remover cap is included in the AVUX series.

PRODUCT NO. SIZEPACKAGE

QTY.

AVB-461/4″ long male flare x c solder bulk head

body w/cap & cap retainer3

AVU-345R1/8″ MPT — 3/16″, 1/4″ 5/16″ steps —

1/8″ hole core tool5

AVUX-234R1/8″ MPT — 1/4″ x 2″ copper tube

w/3/16 x 1/8″ bushings5

AVUX-2R1/8″ MPT — 3/16″, 1/4″ 5/16″ steps —

1/8″ x 2″ cooper ext.5

AVUX-3R1/8″ MPT — 3/16″, 1/4″ 5/16″ steps —

3/16″ x 2″ cooper ext.5

AVUX-4R1/8″ MPT — 5/16″ steps — 1/4″ x 2″

cooper ext. — core tools5

P4228

P4229

A-1 VCT-1 VALVE CORE TOOL (Not Shown)

Features a hollow handle for the storage of replacement valve cores. The brass body is knurled for easier grip. Supplied with a plated steel core remover cap for additional strength.

VCRT VALVE CORE REMOVER TOOL

Permits easy installation of new core in access fitting without loss of gas or charge. Replaces C/D 3910, Robinair #14650.

VALVE CORES AND BRASS CAPS

Replacement valve cores available 6 in a tube. Included in the container is the QC-4R core remover cap. Standard QC-4R caps sold separately.

VALVE CORES — TOOLS — BRASS CAPS

PRODUCT NO. DESCRIPTION WEIGHTQC-4R Cap w/core remover for 1/4″ male flare 0.013VCT-1 Valve Core Tool

P4230

882

TOTALINE® REFRIGERATION CONDENSERS

P703 AIR-COOLED CONDENSERS AND DRY COOLERSTotaline’s refrigeration condensers are used for refrigerationsystems.

These condensers are designed for large coolers or freezers. The Totaline fluid cooler is suitable as a secondary heat exchanger.

Condensers are available in capacities from 41,000 BTUH to over 3 million BTUH.

Dry type fluid coolers from 5 GPM to over 400 GPM.

Condenser FeaturesAll Totaline refrigeration condensers provide the design flexibility required in replacement, renovation, and new construction. All refrigeration unit condensers feature the following benefits:

• Fan motors feature permanently lubricated, sealed ball bear-ings and inherent thermal protection for long life and depend-able service

• Fan guards and motor mounts are welded wire construction for full protection from moving parts. Baked on powder epoxy coat-ing protects from corrosion

• Aluminum fan blades are statically and dynamically balanced for smooth, vibration-free operation

• PVC coated wire fan guards with aluminum fans • Labeled terminal block for field wiring• Modular design allows minimal part inventory and replacement• Plated hardware for light weight and corrosion-free assembly• Weather resistant control box protects motor wiring• Smooth tubes simplify change from CFC and HCFC to HFC

refrigerant• Exclusive non-metallic supports for friction free coil assembly• Dry fluid coolers FXBs• Available in single or multi circuits• All units are ETL and CSA approved

P4377

Dry Fluid Cooler & Heat Reclaim Unit Features• Designed with features identical to our air-cooled condensers

Options• Copper to be copper fin coils available option• Various fins spacing 6, 8, 10, 12 fins per inch• Wide range of head pressure control from fan cycling methods as well as various

flooding control methods to meet your application needs• Wide range of control box options

Available Types of Protective Coatings• Pre-coated epoxy aluminum (Gold color)• Blygold (PoluAl) (Aluminum color)• Heresite (Baked Phenolic) (Brown Color)

General NotesPacking

• Standard domestic packaging which provides coil protection• Optional, full crate

Ordering InformationNOTE: You must order a control box and condenser/fluid cooler using two separate P/Ns.The two P/Ns must be submitted together as one order.

®

883


P703 AIR-COOLED CONDENSERS AND DRY COOLERS

Nominal Condenser THR (Tons)@ 25 °F TD (R-22)

P703 – C L D 180 H – 9

Totaline Condenser

C – CondenserH – Heat ReclaimF – Dry Type Fluid Cooler

Unit Voltage (V/Ph/Hz)2 – 240/1/605 – 208-240/3/608 – 600/3/609 – 480/3/60

Horsepower (RPM)C – 1/4 (825)M – 1/2 (1140)L – 1 (825)I – 1-1/2 (1140)H – 1-1/2 (850)Q – 1/2 (560)

AirflowH – Horizontal Airflow

D – Direct Drive8 – 8 Fins Per Inch (FPI)

AIR-COOLED CONDENSER, HEAT RECLAIM & DRY-TYPE FLUID COOLER NOMENCLATURE

LEGEND

TD — Temperature Difference

884


P703 AIR-COOLED CONDENSERS AND DRY COOLERSAIR-COOLED CONDENSER & FLUID COOLER CONTROL PANEL NOMENCLATURE

TOTALINEPANEL

TYPE OFPANEL

FANARRANGEMENT

UNITVOLTAGE

CONTROLVOLTAGE OPTIONS

P 04 24 8 1 ACE

11 = 1 x 1 2 240/1/60 1 120/1/6012 = 1 x 2 5 208-240/3/60 2 240/1/6013 = 1 x 3 8 600/3/60 X 24/1/6014 = 1 x 4 9 480/3/60 N NONE15 = 1 x 522 = 2 x 223 = 2 x 3 N NONE24 = 2 x 4 A MOTOR FUSING (IN PAIR FOR TWO FAN WIDE UNIT)25 = 2 x 5 B INDIVIDUAL MOTOR FUSING (FOR TWO FAN WIDE UNIT ONLY)26 = 2 x 6 C SPEED MOTOR CONTROLLER (PRESSURE SENSING)

D SPEED MOTOR CONTROLLER (TEMPERATURE SENSING)E NON-FUSED DISCONNECTF FUSED DISCONNECT

STANDARD PANELS01 CONTROL BOX, TERMINAL BLOCK, NO CONTROLS, NO CONTACTORS02 CONTACTOR(S) WITHOUT CONTROLS03 CONTACTOR(S), AMBIENT FAN CYCLING04 CONTACTOR(S), PRESSURE FAN CYCLING (2)05 CONTACTOR(S), PRESSURE FAN CYCLING, DUAL CIRCUITS (3)06 CONTACTOR(S), ELECTRONIC AQUASTAT™ THERMOSTAT CONTROL (1, 2)07 CONTACTOR(S), ELECTRONIC AQUASTAT THERMOSTAT CONTROL, FIRST STAGE CYCLING (1, 2)10 CONTACTOR(S), MECHANICAL AQUASTAT THERMOSTAT CONTROL (1, 2)11 CONTACTOR(S), MECHANICAL AQUASTAT THERMOSTAT CONTROL, FIRST STAGE CYCLING (1, 2)12 CONTACTOR(S), MOTORS INDIVIDUALLY WIRED, NO CONTROLS (4, 5)13 SPLIT ELECTRICAL, CONTACTOR(S), ELECTRONIC AQUASTAT THERMOSTAT CONTROL (1, 4, 5, 6)14 SPLIT ELECTRICAL, CONTACTOR(S), ELECTRONIC AQUASTAT THERMOSTAT CONTROL, FIRST STAGE CYCLING (1, 4, 5, 6)16 SPLIT ELECTRICAL, CONTACTOR(S), MECHANICAL AQUASTAT THERMOSTAT CONTROL (1, 4, 5, 6)17 SPLIT ELECTRICAL, CONTACTOR(S), MECHANICAL AQUASTAT THERMOSTAT CONTROL, FIRST STAGE CYCLING (1, 4, 5, 6)18 SPLIT ELECTRICAL, CONTACTOR(S), AMBIENT FAN CYCLING (4, 5, 6)19 SPLIT ELECTRICAL, CONTACTOR(S), PRESSURE FAN CYCLING (3, 4, 5, 6)20 CONTACTOR(S), AMBIENT FAN CYCLING WITH PRESSURE OVERRIDE (2)55 SPECIAL CONTROL PANEL

SPECIFICATIONS:1 AVAILABLE ONLY ON FLUID COOLED UNITS2 AVAILABLE ONLY ON SINGLE CIRCUIT OR TWO CIRCUITS FOR SINGLE CIRCUIT APPLICATION3 AVAILABLE ONLY ON TWO REFRIGERANT CIRCUITS UNITS4 AVAILABLE ONLY ON TWO FANS WIDE UNITS5 FAN MOTORS ARE INDIVIDUALLY WIRED, NOT IN PAIR (OPTION “A” NOT AVAILABLE)6 DUAL POWER SUPPLY FOR TWO FANS WIDE UNITS (SUPPLIED WITH TWO ELECTRICAL BOXES)

NOTES:1 FIRST STAGE IS NOT CYCLED, UNLESS OTHERWISE NOTED2 ON TWO FAN WIDE UNITS, FAN MOTORS ARE WIRED IN PAIRS, UNLESS OTHERWISE NOTED

885


P703 AIR-COOLED CONDENSERS AND DRY COOLERSLOW CFM AIR-COOLED CONDENSERS (Standard Fin Spacing)

LEGENDTD — Temperature DifferenceNOTES:1. Multiply capacity by 0.98 for R-404A and R-507.2. Multiply capacity by 0.92 for 50 Hz units.3. Connections are based on 30° F TD, 40° F suction and R-22.4. Refrigerant summer charge is based on 100° F liquid, 30% liquid and 70% vapor.5. Refrigerant winter charge is based on –20° F liquid, 90% liquid and 10% vapor.

PARTNUMBER

TOTAL HEAT REJECTION MBTUH(R-22, R-134a)

TEMPERATURE DIFFERENCE (TD)

NUMBERCIRCUITS

(CKT)

CAP./CKTBtuh/F TD

FANARRANGEMENT

CONNECTION SIZES(in.)

REFRIGERANTCHARGE

(lbs)

SHIPPINGWEIGHT

(lbs)1° ° ° ° F 15° ° ° ° F 20° ° ° ° F 25° ° ° ° F 30° ° ° ° F Discharge Liquid Summer Winter

P703-CCD02 1.38 20.64 27.52 34.40 41.28 4 344 1 X 1 7/8 5/8 1.8 5.8 190P703-CCD03 1.69 25.39 33.86 42.32 50.79 5 339 1 X 1 7/8 5/8 2.7 8.7 201P703-CCD04 1.89 28.36 37.82 47.27 56.73 4 473 1 X 1 7/8 7/8 3.5 12 210P703-CMD05 2.63 39.50 52.67 65.84 79.00 7 376 1 X 1 7/8 7/8 3.3 11 308P703-CMD07 3.33 49.90 66.53 83.16 99.79 7 475 1 X 1 7/8 7/8 4.9 16 335P703-CMD08 3.73 55.98 74.65 93.31 111.97 7 533 1 X 1 1-1/8 7/8 6.5 22 350P703-CMD09 5.27 79.00 105.34 131.67 158.00 13 405 1 X 2 1-1/8 7/8 6.3 21 489P703-CMD11 5.99 89.84 119.79 149.74 179.69 14 428 1 X 2 1-1/8 1-1/8 9.5 31 518P703-CMD12 6.65 99.79 133.06 166.32 199.58 14 475 1 X 2 1-1/8 1-1/8 9.5 31 532P703-CMD13 6.87 103.06 137.41 171.77 206.12 14 491 1 X 2 1-1/8 1-1/8 13 42 544P703-CMD14 7.46 111.97 149.29 186.62 223.94 14 533 1 X 2 1-3/8 1-1/8 13 42 566P703-CMD18 8.98 134.69 179.59 224.48 269.38 20 449 1 X 3 1-3/8 1-1/8 14 47 727P703-CMD20 9.98 149.69 199.58 249.48 299.38 20 499 1 X 3 1-3/8 1-1/8 14 47 741P703-CMD21 10.31 154.59 206.12 257.65 309.18 27 382 1 X 3 1-3/8 1-1/8 19 62 767P703-CMD23 11.20 167.95 223.94 279.92 335.91 27 415 1 X 3 1-3/8 1-1/8 19 62 789P703-CLD009 4.40 65.93 87.91 109.89 131.87 11 400 1 X 1 1-1/8 1-1/8 5.8 19 515P703-CLD010 5.17 77.52 103.36 129.20 155.03 11 470 1 X 1 1-1/8 1-1/8 5.8 19 525P703-CLD012 5.77 86.58 115.43 144.29 173.15 17 340 1 X 1 1-1/8 1-1/8 8.8 29 592P703-CLD013 6.56 98.46 131.27 164.09 196.91 17 386 1 X 1 1-1/8 1-1/8 8.8 29 602P703-CLD014 6.87 103.06 137.41 171.77 206.12 17 404 1 X 1 1-3/8 1-1/8 12 38 641P703-CLD015 7.39 110.78 147.71 184.64 221.56 17 434 1 X 1 1-3/8 1-1/8 12 38 654P703-CLD018 8.78 131.72 175.63 219.53 263.44 17 517 1 X 2 1-3/8 1-1/8 12 38 985P703-CLD021 10.34 155.03 206.71 258.39 310.07 17 608 1 X 2 1-3/8 1-3/8 12 38 1005P703-CLD023 11.55 173.30 231.07 288.83 346.60 26 444 1 X 2 1-5/8 1-3/8 17 57 1063P703-CLD026 13.13 196.91 262.55 328.19 393.82 26 505 1 X 2 1-5/8 1-3/8 17 57 1091P703-CLD028 13.73 205.97 274.63 343.28 411.94 35 392 1 X 2 1-5/8 1-3/8 23 76 1117P703-CLD030 14.76 221.41 295.22 369.02 442.83 35 422 1 X 2 1-5/8 1-3/8 23 76 1159P703-CLD035 17.33 259.88 346.50 433.13 519.75 52 333 1 X 3 1-5/8 1-5/8 26 85 1460P703-CLD040 19.69 295.37 393.82 492.28 590.73 52 379 1 X 3 2-1/8 1-5/8 26 85 1490P703-CLD042 20.68 310.22 413.62 517.03 620.43 34 608 2 X 2 (2) 1-3/8 (2) 1-3/8 23 75 1625P703-CLD043 21.02 315.27 420.35 525.44 630.53 70 300 1 X 3 2-1/8 1-5/8 34 112 1570P703-CLD045 22.13 331.90 442.53 553.16 663.80 70 316 1 X 3 2-1/8 1-5/8 34 112 1609P703-CLD049 24.41 366.20 488.27 610.34 732.40 52 469 2 X 2 (2) 1-5/8 (2) 1-3/8 35 115 1792P703-CLD050 24.41 366.20 488.27 610.34 732.40 52 469 1 X 4 2-1/8 1-5/8 34 112 1875P703-CLD053 26.25 393.82 525.10 656.37 787.64 52 505 2 X 2 (2) 1-5/8 (2) 1-3/8 35 115 1781P703-CLD054 26.25 393.82 525.10 656.37 787.64 52 505 1 X 4 2-1/8 1-5/8 34 112 1915P703-CLD056 28.04 420.55 560.74 700.92 841.10 70 401 2 X 2 (2) 1-5/8 (2) 1-3/8 47 153 1882P703-CLD057 28.04 420.55 560.74 700.92 841.10 70 401 1 X 4 2-1/8 1-5/8 46 150 2019P703-CLD060 29.51 442.68 590.24 737.80 885.36 70 422 2 X 2 (2) 1-5/8 (2) 1-3/8 47 153 1934P703-CLD061 29.51 442.68 590.24 737.80 885.36 70 422 1 X 4 2-1/8 1-5/8 46 150 2071P703-CLD063 30.67 460.05 613.40 766.76 920.11 70 438 2 X 3 (2) 1-5/8 (2) 1-3/8 34 112 2323P703-CLD066 32.82 492.28 656.37 820.46 984.56 52 631 1 X 5 2-1/8 2-1/8 43 140 2403P703-CLD070 35.04 525.54 700.72 875.90 1051.08 70 501 1 X 5 2-1/8 2-1/8 57 187 2475P703-CLD075 36.88 553.16 737.55 921.94 1106.33 70 527 1 X 5 2-1/8 2-1/8 57 187 2540P703-CLD080 39.38 590.73 787.64 984.56 1181.47 104 379 2 X 3 (2) 2-1/8 (2) 1-5/8 52 169 2508P703-CLD085 42.06 630.83 841.10 1051.38 1261.66 140 300 2 X 3 (2) 2-1/8 (2) 1-5/8 69 225 2664P703-CLD090 44.26 663.94 885.26 1106.57 1327.89 140 316 2 X 3 (2) 2-1/8 (2) 1-5/8 69 225 2742P703-CLD099 48.84 732.55 976.73 1220.92 1465.10 104 470 2 X 4 (2) 2-1/8 (2) 1-5/8 68 224 3029P703-CLD106 52.51 787.64 1050.19 1312.74 1575.29 104 505 2 X 4 (2) 2-1/8 (2) 1-5/8 68 224 3129P703-CLD113 56.06 840.96 1121.27 1401.59 1681.91 140 400 2 X 4 (2) 2-1/8 (2) 1-5/8 91 299 3338P703-CLD120 59.01 885.21 1180.28 1475.35 1770.42 140 422 2 X 4 (2) 2-1/8 (2) 1-5/8 91 229 3442P703-CLD124 61.16 917.43 1223.24 1529.06 1834.87 104 588 2 X 5 (2) 2-1/8 (2) 2-1/8 85 280 4198P703-CLD132 65.65 984.70 1312.94 1641.17 1969.41 104 631 2 X 5 (2) 2-1/8 (2) 2-1/8 85 280 4298P703-CLD142 70.08 1051.23 1401.64 1752.05 2102.46 140 501 2 X 5 (2) 2-1/8 (2) 2-1/8 114 373 4560P703-CLD150 73.77 1106.62 1475.50 1844.37 2213.24 140 527 2 X 5 (2) 2-1/8 (2) 2-1/8 114 373 4690P703-CLD159 78.76 1181.47 1575.29 1969.11 2362.93 86 916 2 X 6 (2) 2-5/8 (2) 2-1/8 164 553 5292P703-CLD170 84.00 1260.02 1680.03 2100.04 2520.05 116 724 2 X 6 (2) 2-5/8 (2) 2-1/8 218 717 5642P703-CLD180 88.54 1328.04 1770.71 2213.39 2656.07 116 763 2 X 6 (2) 2-5/8 (2) 2-1/8 218 717 5798

886


P703 AIR-COOLED CONDENSERS AND DRY COOLERSLOW CFM AIR-COOLED CONDENSERS (8 FPI)

LEGENDFPI — Fins per inch

NOTES:1. Multiply capacity of 0.98 for R-404A and R-507.2. Multiply capacity by 0.92 for 50 Hz units.3. Connections are based on 30° F TD, 40° F suction and R-22.4. Refrigerant summer charge is based on 100° F liquid, 30% liquid and 70% vapor.5. Refrigerant winter charge is based on –20° F liquid, 90% liquid and 10% vapor.

HEAT RECLAIM UNITS

NOTES:1. Multiply capacity of 0.98 for R-404A and R-507.2. Multiply capacity by 0.92 for 50 Hz units.3. Connections sizes are based on 40° F TD at 50% recovery.4. Refrigerant charge is based on 10% liquid and 90% vapor.

PARTNUMBER



NUMBERCIRCUITS

(CKT)

CAP./CKTBtuh/F TD

FANARRANGEMENT


REFRIGERANTCHARGE

(lbs)

SHIPPINGWEIGHT


P703-CL8009 4.49 67.42 89.89 112.37 134.84 11 409 1 X 1 1-1/8 1-1/8 5.8 19 515

P703-CL8012 5.83 87.47 116.62 145.78 174.93 17 343 1 X 1 1-1/8 1-1/8 8.8 29 592P703-CL8014 6.70 100.53 134.05 167.56 201.07 17 394 1 X 1 1-3/8 1-1/8 12 38 641P703-CL8018 8.99 134.84 179.78 224.73 269.68 17 529 1 X 2 1-3/8 1-1/8 12 38 985P703-CL8024 11.66 174.93 233.24 291.56 349.87 26 449 1 X 2 1-5/8 1-3/8 17 57 1063P703-CL8027 13.40 201.07 268.09 335.12 402.14 35 383 1 X 2 1-5/8 1-3/8 23 76 1117P703-CL8035 17.49 262.40 349.87 437.33 524.80 52 336 1 X 3 1-5/8 1-5/8 26 85 1460

P703-CL8036 17.98 269.68 359.57 449.46 539.35 34 529 2 X 2 (2) 1-3/8 (2) 1-3/8 23 75 1625P703-CL8041 20.11 301.60 402.14 502.67 603.21 70 287 1 X 3 2-1/8 1-5/8 34 112 1570P703-CL8047 23.32 349.87 466.49 583.11 699.73 52 449 2 X 2 (2) 1-5/8 (2) 1-3/8 35 115 1792P703-CL8048 23.32 349.87 466.49 583.11 699.73 52 449 1 X 4 2-1/8 1-5/8 34 112 1875P703-CL8053 26.81 402.14 536.18 670.23 804.28 70 383 2 X 2 (2) 1-5/8 (2) 1-3/8 47 153 1882P703-CL8054 26.81 402.14 536.18 670.23 804.28 70 383 1 X 4 2-1/8 1-5/8 46 150 2019

P703-CL8055 26.97 404.51 539.35 674.19 809.03 70 385 2 X 3 (2) 1-5/8 (2) 1-3/8 34 112 2323P703-CL8059 29.55 443.27 591.03 738.79 886.55 52 568 1 X 5 2-1/8 2-1/8 43 140 2403P703-CL8068 33.51 502.67 670.23 837.79 1005.35 70 479 1 X 5 2-1/8 2-1/8 57 187 2475P703-CL8071 34.99 524.80 699.73 874.67 1049.60 104 336 2 X 3 (2) 2-1/8 (2) 1-5/8 52 169 2508P703-CL8081 40.21 603.21 804.28 1005.35 1206.41 140 287 2 X 3 (2) 2-1/8 (2) 1-5/8 69 225 2664P703-CL8094 46.65 699.73 932.98 1166.22 1399.46 104 449 2 X 4 (2) 2-1/8 (2) 1-5/8 68 224 3029

P703-CL8108 53.62 804.28 1072.37 1340.46 1608.55 140 383 2 X 4 (2) 2-1/8 (2) 1-5/8 91 299 3338P703-CL8118 58.37 875.56 1167.41 1459.26 1751.11 104 561 2 X 5 (2) 2-1/8 (2) 2-1/8 85 280 4198P703-CL8135 67.04 1005.64 1340.86 1676.07 2011.28 140 479 2 X 5 (2) 2-1/8 (2) 2-1/8 114 373 4560P703-CL8141 69.97 1049.60 1399.46 1749.33 2099.20 86 814 2 X 6 (2) 2-5/8 (2) 2-1/8 164 553 5292P703-CL8162 80.43 1206.41 1608.55 2010.69 2412.83 116 693 2 X 6 (2) 2-5/8 (2) 2-1/8 218 717 5642

PARTNUMBER



NUMBERCIRCUITS

(CKT)

CAP./CKTBtuh/F TD

FANARRANGEMENT


REFRIGERANTCHARGE

(lbs)

SHIPPINGWEIGHT

(lbs)1° ° ° ° F 30° ° ° ° F 35° ° ° ° F 40° ° ° ° F 45° ° ° ° F Discharge Liquid

P703-HCD02 1.38 41.28 48.16 55.04 61.92 19 72 1 X 1 1-1/8 1-1/8 0.6 190P703-HCD03 1.69 50.79 59.25 67.72 76.18 14 121 1 X 1 1-1/8 1-1/8 0.9 201P703-HCD04 1.89 56.73 66.18 75.64 85.09 19 100 1 X 1 1-1/8 1-1/8 1.2 210P703-HMD05 2.63 79.00 92.17 105.34 118.50 27 98 1 X 1 1-3/8 1-3/8 1.1 308P703-HMD07 3.33 99.79 116.42 133.06 149.69 20 166 1 X 1 1-3/8 1-3/8 1.6 335

P703-HMD08 3.73 111.97 130.63 149.29 167.95 27 138 1 X 1 1-3/8 1-3/8 2.1 350P703-HMD09 5.27 158.00 184.34 210.67 237.01 27 195 1 X 2 1-5/8 1-5/8 2.1 489P703-HMD11 5.99 179.69 209.63 239.58 269.53 40 150 1 X 2 1-5/8 1-5/8 3.1 518P703-HMD12 6.65 199.58 232.85 266.11 299.38 40 166 1 X 2 2-1/8 2-1/8 3.1 532P703-HMD13 6.87 206.12 240.47 274.82 309.18 27 254 1 X 2 2-1/8 2-1/8 4.3 544P703-HMD14 7.46 223.94 261.26 298.58 335.91 27 276 1 X 2 2-1/8 2-1/8 4.3 566

P703-HMD18 8.98 269.38 314.28 359.17 404.07 40 224 1 X 3 2-1/8 2-1/8 4.6 727P703-HMD20 9.98 299.38 349.27 399.17 449.06 40 249 1 X 3 2-1/8 2-1/8 4.6 741P703-HMD21 10.31 309.18 360.71 412.24 463.77 54 191 1 X 3 2-1/8 2-1/8 6.3 767P703-HMD23 11.20 335.91 391.89 447.88 503.86 54 207 1 X 3 2-1/8 2-1/8 6.3 789

887


P703 AIR-COOLED CONDENSERS AND DRY COOLERSHIGH CFM AIR-COOLED CONDENSERS (Standard Fins)

NOTES:1. Multiply capacity of 0.98 for R-404A and R-507.2. Multiply capacity by 0.92 for 50 Hz units.3. Connections sizes are based on 30° F TD, 40° F suction and R-22.4. Refrigerant summer charge is based on 100° F liquid, 30% liquid and 70% vapor.5. Refrigerant winter charge is based on –20° F liquid, 90% liquid and 10% vapor.

PARTNUMBER



NUMBERCIRCUITS

(CKT)

CAP./CKTBtuh/F TD

FANARRANGEMENT


REFRIGERANTCHARGE

(lbs)

SHIPPINGWEIGHT


P703-CID010 5.08 76.18 101.57 126.97 152.36 11 462 1 X 1 1-1/8 1-1/8 5.8 19 515

P703-CID011 5.88 88.21 117.61 147.02 176.42 11 535 1 X 1 1-1/8 1-1/8 5.8 19 525P703-CID013 6.59 98.90 131.87 164.84 197.80 17 388 1 X 1 1-1/8 1-1/8 8.8 29 592P703-CID014 7.39 110.78 147.71 184.64 221.56 17 434 1 X 1 1-1/8 1-1/8 8.8 29 602P703-CID016 7.76 116.42 155.23 194.04 232.85 17 457 1 X 1 1-3/8 1-1/8 12 38 641P703-CID017 8.27 124.00 165.33 206.66 248.00 17 486 1 X 1 1-3/8 1-1/8 12 38 654P703-CID020 10.17 152.51 203.35 254.18 305.02 17 598 1 x 2 1-3/8 1-1/8 12 38 985

P703-CID023 11.76 176.42 235.22 294.03 352.84 17 692 1 X 2 1-3/8 1-3/8 12 38 1005P703-CID025 13.20 197.95 263.93 329.92 395.90 26 508 1 X 2 1-5/8 1-3/8 17 57 1063P703-CID029 14.78 221.71 295.61 369.52 443.42 26 568 1 X 2 1-5/8 1-3/8 17 57 1091P703-CID031 15.52 232.85 310.46 388.08 465.70 35 444 1 X 2 1-5/8 1-3/8 23 76 1117P703-CID034 16.54 248.14 330.86 413.57 496.29 35 473 1 X 2 1-5/8 1-3/8 23 76 1159P703-CID039 19.79 296.85 395.80 494.75 593.70 52 381 1 X 3 1-5/8 1-5/8 26 85 1460

P703-CID044 22.17 332.49 443.32 554.15 664.98 52 426 1 X 3 2-1/8 1-5/8 26 85 1490P703-CID046 22.98 344.67 459.56 574.45 689.34 34 676 2 X 2 (2) 1-3/8 (2) 1-3/8 23 75 1625P703-CID049 23.29 349.42 465.89 582.37 698.84 70 333 1 X 3 2-1/8 1-5/8 34 112 1570P703-CID051 24.80 371.99 495.99 619.99 743.99 70 354 1 X 3 2-1/8 1-5/8 34 112 1609P703-CID054 27.48 412.24 549.65 687.06 824.47 52 529 2 X 2 (2) 1-5/8 (2) 1-3/8 35 115 1792P703-CID055 27.48 412.24 549.65 687.06 824.47 52 529 1 X 4 2-1/8 1-5/8 34 112 1875

P703-CID058 29.54 443.12 590.83 738.54 886.25 52 568 2 X 2 (2) 1-5/8 (2) 1-3/8 35 115 1781P703-CID059 29.54 443.12 590.83 738.54 886.25 52 568 1 X 4 2-1/8 1-5/8 34 112 1915P703-CID064 31.06 465.84 621.13 776.41 931.69 70 444 2 X 2 (2) 1-5/8 (2) 1-3/8 47 153 1882P703-CID065 31.06 465.84 621.13 776.41 931.69 70 444 1 X 4 2-1/8 1-5/8 46 150 2019P703-CID068 33.08 496.14 661.52 826.90 992.28 70 473 2 X 2 (2) 1-5/8 (2) 1-3/8 47 153 1934

P703-CID069 33.08 496.14 661.52 826.90 992.28 70 473 1 X 4 2-1/8 1-5/8 46 150 2071P703-CID070 35.28 529.25 705.67 882.09 1058.51 70 504 2 X 3 (2) 1-5/8 (2) 1-3/8 34 112 2323P703-CID073 36.95 554.20 738.94 923.67 1108.40 52 711 1 X 5 2-1/8 2-1/8 43 140 2403P703-CID079 38.82 582.27 776.36 970.45 1164.54 70 555 1 X 5 2-1/8 2-1/8 57 187 2475P703-CID085 41.33 619.99 826.65 1033.31 1239.98 70 590 1 X 5 2-1/8 2-1/8 57 187 2540P703-CID088 44.31 664.69 886.25 1107.81 1329.37 104 426 2 X 3 (2) 2-1/8 (2) 1-5/8 52 169 2508

P703-CID095 46.57 698.54 931.39 1164.24 1397.09 140 333 2 X 3 (2) 2-1/8 (2) 1-5/8 69 225 2664P703-CID101 49.62 744.28 992.38 1240.47 1488.56 140 354 2 X 3 (2) 2-1/8 (2) 1-5/8 69 225 2742P703-CID112 54.96 824.47 1099.30 1374.12 1648.94 104 529 2 X 4 (2) 2-1/8 (2) 1-5/8 68 224 3029P703-CID119 59.08 886.25 1181.66 1477.08 1772.50 104 568 2 X 4 (2) 2-1/8 (2) 1-5/8 68 224 3129P703-CID129 62.09 931.39 1241.86 1552.32 1862.78 140 444 2 X 4 (2) 2-1/8 (2) 1-5/8 91 299 3338P703-CID137 66.14 992.13 1322.84 1653.55 1984.26 140 472 2 X 4 (2) 2-1/8 (2) 1-5/8 91 229 3442

P703-CID141 68.72 1030.74 1374.32 1717.90 2061.48 104 661 2 X 5 (2) 2-1/8 (2) 2-1/8 85 280 4198P703-CID149 73.87 1108.11 1477.48 1846.85 2216.21 104 710 2 X 5 (2) 2-1/8 (2) 2-1/8 85 280 4298P703-CID162 77.64 1164.54 1552.72 1940.90 2329.07 140 555 2 X 5 (2) 2-1/8 (2) 2-1/8 114 373 4560P703-CID171 82.68 1240.27 1653.70 2067.12 2480.54 140 591 2 X 5 (2) 2-1/8 (2) 2-1/8 114 373 4690P703-CID178 88.64 1329.67 1772.89 2216.12 2659.34 86 1031 2 X 6 (2) 2-5/8 (2) 2-1/8 164 553 5292P703-CID194 93.14 1397.09 1862.78 2328.48 2794.18 116 803 2 X 6 (2) 2-5/8 (2) 2-1/8 218 717 5642

P703-CID205 99.89 1498.37 1997.82 2497.28 2996.73 116 861 2 X 6 (2) 2-5/8 (2) 2-1/8 218 717 5798

888

TOTALINE® REFRIGERATION UNIT COOLERS

P704 REFRIGERATION UNIT COOLERSThirteen different models of unit coolers featuring many capacities and types allow flexibility to meet most applications.

Standard Features:All Totaline refrigeration coolers provide the design flexibility required in replacement, renovation, and new construction. Unit coolers are available in many models to suit most needs.

• Low sound levels• Heavy duty construction• Wide selection of fin spacing available• Corrosion resistant fan guards (silver color)• Easy access to refrigerant and electrical connections• Warranty against material and labor defects• UL listed• NSF approved

Options:• Custom coil manufacturing —

i.e., gravity coils, copper tube/copper fin• Custom fin spacing —

i.e., 3 Fin Per Inch• TX valves and solenoid valves• Option coil coating available for

adverse environments

Available Types of Protective Coating:• Pre-coated epoxy aluminum (Gold color)• Blygold (Polu Al) (Aluminum color)• Heresite (Baked Pheonolic) (Brown color)

General Note:240 volt unit can be used for 200-220/1/50.

Unit Capacity@ 10 °F TD22,400 Btuh

Totaline Unit Cooler

E – Evaporator

Unit Voltage (V/Ph/Hz)1 – 120/1/602 – 240/1/605 – 208-240/3/608 – 600/3/609 – 480/3/60

B – Blast FreezerC – Compact Reach-InD – Dual Flow Reach-InF – Free Standing Blast FreezerH – High Profile Unit CoolerI – Industrial Unit CoolerK – Compact Unit CoolerL – Low Height Unit CoolerM – Medium Profile Unit CoolerP – Medium Velocity Unit CoolerS – Single Flow Unit CoolerV – Low Velocity Unit CoolerW – Wall Mount Reach-In

Product Generation

A – Air DefrostE – Electric DefrostG – Reverse Cycle Defrost With

Electric Heated Drain PanH – Three Pipe Defrost With

Electric Heated Drain PanR – Reverse Cycle Hot Gas DefrostT – Three Pipe Hot Gas Defrost

P704 – E L A 224 1 – 1

P704 NOMENCLATURE

P4378B

LEGEND

TD — Temperature Difference

P4378D

P4378A

889


P704 REFRIGERATION UNIT COOLERSP704-ECA SPACE SAVER REACH-IN-UNIT COOLERS (Air Defrost) FOR COOLERS ABOVE +34 F

• Single coil construction.• Heavy gauge textured aluminum casings with polycarbonate fan guards,

polypropylene fans and stainless steel or plated hardware for a light weight and corrosion free assembly.

• Life lubricated, thermal protected, heavy duty fan motors are provided for long life and dependable service.

• Air is discharged through the back of the unit.• Ceiling or back wall mounting.

Air Defrost

MODELNUMBER

CAPACITY (BTU/H) UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)10° F TD 15° F TD Depth Height Width

P704-ECA100-(1) 1000 1500 10-1/4 7-3/4 16-5/8 10.5P704-ECA130-(1) 1300 1950 10-1/4 7-3/4 16-5/8 11.5P704-ECA150-(1) 1500 2250 10-1/4 7-3/4 16-5/8 12.5

P4379

P704-EWA MULLION REACH-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F

• Single coil construction.• Heavy gauge textured aluminum casings with polycarbonate fan guards,



• Up or down airflow.• Wall or mullion mounted.• Upflow standard configuration can be modified to downflow.

Air Defrost

Models ECA and EWA are available in:1 = 120/1/602 = 240/1/60

NOTE: Standard voltage for ECA and EWA is 120/1/60, optional voltage is 240/1/60.

MODELNUMBER


P704-EWA130-(1) 1300 1950 5-3/4 18-1/4 15-3/4 13P704-EWA180-(1) 1800 2700 5-3/4 18-1/4 15-3/4 14P704-EWA230-(1) 2300 3450 5-3/4 18-1/4 21-3/4 17

P4380

P704-EDA DUAL FLOW REACH-IN-UNIT COOLERS (Air Defrost)FOR COOLERS ABOVE +34 F

• Dual coil construction for equal air distribution on both sides of the cooler.• Heavy gauge textured aluminum casings with polycarbonate fan guards,


• Life lubricated, impedance protected, heavy duty fan motors are provided for long life and dependable service.

Air Defrost

MODELNUMBER


P704-EDA102-(1) 1000 1500 14-1/8 3-1/2 18-1/8 11.5P704-EDA132-(1) 1300 1950 14-1/8 3-1/2 18-1/8 12.5P704-EDA152-(1) 1500 2250 14-1/8 4-1/2 18-1/8 13P704-EDA182-(1) 1800 2700 14-1/8 4-1/2 18-1/8 14P704-EDA232-(1) 2300 3450 17-1/8 5-1/2 20-1/8 17P704-EDA282-(1) 2800 4200 17-1/8 5-1/2 20-1/8 18.5P704-EDA332-(1) 3300 4950 17-1/8 5-1/2 20-1/8 20

P4381

890


P704 REFRIGERATION UNIT COOLERSP704-ESA SINGLE FLOW REACH-IN-UNIT COOLERS (Air Defrost) FOR COOLERS ABOVE +34 F

• Single coil construction for air distribution on the back of cooler.• Heavy gauge textured aluminum casings with polycarbonate fan guards,



Air Defrost

Models EDA and ESA are available in:1 = 120/1/602 = 240/1/60

NOTE: Standard voltage for EDA and ESA is 120/1/60, optional is 240/1/60.

MODELNUMBER


P704-ESA102-(1) 1000 1500 15 4-1/2 17-1/4 9.0P704-ESA132-(1) 1300 1950 15 4-1/2 17-1/4 10.0P704-ESA152-(1) 1500 2250 15 4-1/2 21-3/4 11.5P704-ESA182-(1) 1800 2700 15 4-1/2 25-3/4 13.0P704-ESA232-(1) 2300 3450 15 4-1/2 33-3/4 17.0P704-ESA282-(1) 2800 4200 15 4-1/2 33-3/4 18.5P704-ESA332-(1) 3300 4900 15 5-1/2 33-3/4 20.0P704-ESA452-(1) 4500 6750 17 5-1/2 43-3/4 27.0P704-ESE552-(1) 5500 8250 17 5-1/2 43-3/4 32.5

P4382

P704-ESE SINGLE FLOW REACH-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS AND FREEZERS FROM –20 TO +34 F

• Single coil construction for air distribution to back of cooler or freezer.• These units are provided with stainless steel low watt density tubular

heaters, defrost termination and fan delay thermostat for positive defrost and high efficiency.

• Heavy gauge textured aluminum casings with polycarbonate fan guards, polypropylene fans and stainless steel or plated hardware for a light weight and corrosion free assembly.


Electric Defrost

Model ESE is available in:1 = 120/1/602 = 240/1/60

NOTE: Standard voltage for ESE is 240/1/60, optional voltage is 120/1/60.

MODELNUMBER

CAPACITY (BTU/H) UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)–20° F +20° F Depth Height Width

P704-ESE102-(1) 850 1000 15 4-1/2 17-1/4 11.0P704-ESE132-(1) 1105 1300 15 4-1/2 17-1/4 11.5P704-ESE152-(1) 1275 1500 15 4-1/2 21-3/4 13.5

P704-ESE182-(1) (2) 1530 1800 15 4-1/2 25-3/4 15.5P704-ESE232-(1) (2) 1955 2300 15 4-1/2 33-3/4 19.5P704-ESE282-(1) (2) 2380 2800 15 4-1/2 33-3/4 21.0P704-ESE332-(1) (2) 2805 3300 15 5-1/2 33-3/4 23.0P704-ESE452-(1) (2) 3825 4500 17 5-1/2 43-3/4 30.5P704-ESE552-(1) (2) 4675 5500 17 5-1/2 43-3/4 35.5

P4382

891


P704 REFRIGERATION UNIT COOLERSP704-ELA HIGH VELOCITY WALK-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F

• High velocity/single coil construction for air distribution toward the center of the cooler.

• The fans draw air from the evaporator coil and discharge it through the fan guards on the front of the unit. Air throw is 20 to 30 ft.


• Heavy gauge textured aluminum casings with polycarbonate fan guards, aluminum fans and stainless steel or plated hardware for a light weight and corrosion free assembly.

Air Defrost

Model ELA is available in: 1 = 120/1/602 = 240/1/605 = 208-240/3/60

NOTE: Standard voltage for ELA is 120/1/60, optional voltage is 240/1/60.

MODELNUMBER


P704-ELA0381-(1) 3,800 5,700 11-1/2 13-1/4 31-1/8 35P704-ELA0491-(1) 4,900 7,350 11-1/2 13-1/4 31-1/8 39P704-ELA0561-(1) 5,600 8,400 11-1/2 13-1/4 31-1/8 42P704-ELA0661-(1) 6,600 9,900 11-1/2 13-1/4 43-1/8 52P704-ELA0831-(1) 8,300 12,450 11-1/2 13-1/4 43-1/8 57P704-ELA0961-(1) 9,600 14,400 11-1/2 13-1/4 43-1/8 63P704-ELA1121-(1) 11,200 16,800 11-1/2 13-1/4 51-1/8 96P704-ELA1471-(1) 14,700 22,050 11-1/2 13-1/4 71-1/8 107P704-ELA1681-(1) 16,800 25,200 11-1/2 13-1/4 71-1/8 123P704-ELA1851-(1) 18,500 27,750 11-1/2 13-1/4 71-1/8 138P704-ELA2241-(1) 22,400 33,600 11-1/2 13-1/4 91-1/8 152P704-ELA2801-(1) 28,000 42,000 11-1/2 13-1/4 111-1/8 180P704-ELA3361-(1) 33,600 50,400 11-1/2 13-1/4 131-1/8 207P704-ELA3701-(1) 37,000 55,500 11-1/2 13-1/4 131-1/8 220

P4384

P704-ELE HIGH VELOCITY WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS AND FREEZERS FROM –20 TO +34 F


• The fans draw air from the evaporator coil and discharge it through the fan guards on the front of the unit.Air throw is 20 to 30 ft.


• Heavy gauge textured aluminum casings with polycarbonate fan guards, aluminum fans and stainless steel or plated hard-ware for a light weight and corrosion free assembly.

• Series ELE units are provided with stainless steel, flexible low watt density tubular heaters inserted within the evaporator, ter-minal block, defrost termination and fan delay thermostat for positive defrost and high efficiency.

Electric Defrost

Model ELE is available in: NOTE: Standard voltage for ELE is 240/1/60, optional voltage is 120/1/60.1 = 120/1/602 = 240/1/605 = 208-240/3/60

MODELNUMBER

CAPACITY (BTU/H) @ 10° F TD UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)–20° F +20° F Depth Height Width

P704-ELE0441-(2) 3,740 4,400 11-1/2 13-1/4 31-1/4 45P704-ELE0521-(2) 4,420 5,200 11-1/2 13-1/4 31-1/4 47P704-ELE0781-(2) 6,630 7,800 11-1/2 13-1/4 43-1/4 64P704-ELE0901-(2) 7,650 9,000 11-1/2 13-1/4 43-1/4 70P704-ELE1041-(2) 8,840 10,400 11-1/2 13-1/4 51-1/4 105P704-ELE1321-(2) 11,220 13,200 11-1/2 13-1/4 71-1/4 120P704-ELE1561-(2) 13,260 15,600 11-1/2 13-1/4 71-1/4 135P704-ELE1751-(2) 14,875 17,500 11-1/2 13-1/4 71-1/4 146P704-ELE2081-(2) 17,680 20,800 11-1/2 13-1/4 91-1/4 168P704-ELE2601-(2) 22,100 26,000 11-1/2 13-1/4 111-1/4 199P704-ELE3121-(2) 26,520 31,200 11-1/2 13-1/4 131-1/4 230P704-ELE3501-(2) 29,750 35,000 11-1/2 13-1/4 131-1/4 243

ELA/ELE

892


P704 REFRIGERATION UNIT COOLERSP704-ELR/ELT HIGH VELOCITY WALK-IN-UNIT COOLERS(Gas Defrost) FOR COOLERS AND FREEZERS FROM –30 F TO +34 F


• The fans draw air from the evaporator coil and discharge it through the fan guards on the front of the unit. Air throw is 20 to 30 ft.


• Heavy gauge textured aluminum casings with polycarbonate fan guards, aluminum fans and stainless steel or plated hardware for a light weight and corrosion free assembly.

• ELR and ELT series are provided with hot gas drain pan grid, adjustable fan delay thermostat and defrost termination thermostat.

Gas Defrost

Models ELR and ELT are available in:1 = 120/1/602 = 240/1/605 = 208-240/3/60

NOTES:1. Standard voltage for ELR and ELT is 120/1/60, optional voltage is 240/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

ELR — Reverse style hot gas defrostELT — Three pipe hot gas defrost with gas drain pan

MODELNUMBER

CAPACITY (BTU/H)@ 10° F TD

UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)

–20° F +20° F Depth Height WidthP704-EL( )0441-(1) 3,740 4,400 11-1/2 13-1/4 31-1/4 42P704-EL( )0521-(1) 4,420 5,200 11-1/2 13-1/4 31-1/4 45P704-EL( )0781-(1) 6,630 7,800 11-1/2 13-1/4 43-1/4 60P704-EL( )0901-(1) 7,650 9,000 11-1/2 13-1/4 43-1/4 66P704-EL( )1041-(1) 8,840 10,400 11-1/2 13-1/4 51-1/4 99P704-EL( )1321-(1) 11,220 13,200 11-1/2 13-1/4 71-1/4 113P704-EL( )1561-(1) 13,260 15,600 11-1/2 13-1/4 71-1/4 128P704-EL( )1751-(1) 14,875 17,500 11-1/2 13-1/4 71-1/4 148P704-EL( )2081-(1) 17,680 20,800 11-1/2 13-1/4 91-1/4 159P704-EL( )2601-(1) 22,100 26,000 11-1/2 13-1/4 111-1/4 187P704-EL( )3121-(1) 26,520 31,200 11-1/2 13-1/4 131-1/4 215P704-EL( )3501-(1) 29,750 35,000 11-1/2 13-1/4 131-1/4 238

P4384

893


P704 REFRIGERATION UNIT COOLERSP704-EPA MEDIUM VELOCITY WALK-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F

• Medium velocity/dual coil construction.• Air distribution on either side of the cooler. Air throw is 8 to 15 ft each side.• Heavy gauge textured aluminum casings with polycarbonate fan guards,

ALUMINUM fans and stainless steel or plated hardware for a light weight and corrosion free assembly.


Air Defrost

Model EPA is available in:1 = 120/1/602 = 240/1/60

NOTES:1. Standard voltage for EPA is 120/1/60, optional voltage is 240/1/60.2. Standard units are 8 FPI, for 4 FPI multiply capacity by 0.75.

MODELNUMBER


P704-EPA0561-(1) 5,600 8,400 24 9-1/2 31-3/8 51P704-EPA0831-(1) 8,300 12,450 24 9-1/2 43-3/8 69P704-EPA0961-(1) 9,600 14,400 24 9-1/2 43-3/8 75P704-EPA1121-(1) 11,200 16,800 24 9-1/2 51-3/8 98P704-EPA1471-(1) 14,700 22,050 24 9-3/4 71-3/8 110P704-EPA1681-(1) 16,800 25,200 24 9-3/4 71-3/8 121P704-EPA1851-(1) 18,500 27,750 24 9-3/4 71-3/8 143P704-EPA2241-(1) 22,400 33,600 24 9-3/4 91-3/8 156P704-EPA2801-(1) 28,000 42,000 24 10 111-3/8 193P704-EPA3361-(1) 33,600 50,400 24 10 131-3/8 227P704-EPA3701-(1) 37,000 55,500 24 10 131-3/8 248

P4386

P704-EPE MEDIUM VELOCITY WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS FROM +26 F TO +34 F

• Medium velocity/dual coil construction.• Air distribution on either side of the cooler. Air throw is 8 to 15 ft each side.• Heavy gauge textured aluminum casings with polycarbonate fan guards, ALUMINUM fans and

stainless steel or plated hardware for a light weight and corrosion free assembly.• Series EPE units are provided with stainless steel, flexible low watt density tubular heaters inserted within

the evaporator, terminal block, defrost termination and fan delay thermostat for positive defrost and high efficiency.

Electric Defrost

Model EPE is available in:1 = 120/1/602 = 240/1/60

NOTES:1. Standard voltage for EPE is 240/1/60, optional voltage is 120/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

MODELNUMBER


P704-EPE0521-(2) 5,200 7,800 24 9-1/2 31-3/8 56P704-EPE0781-(2) 7,800 11,700 24 9-1/2 43-3/8 77P704-EPE0901-(2) 9,000 13,500 24 9-1/2 43-3/8 83P704-EPE1041-(2) 10,400 15,600 24 9-1/2 51-3/8 108P704-EPE1321-(2) 13,200 19,800 24 9-3/4 71-3/8 124P704-EPE1561-(2) 15,600 23,400 24 9-3/4 71-3/8 135P704-EPE1751-(2) 17,500 26,250 24 9-3/4 71-3/8 160P704-EPE2081-(2) 20,800 31,200 24 9-3/4 91-3/8 176P704-EPE2601-(2) 26,000 39,000 24 10 111-3/8 216P704-EPE3121-(2) 31,200 46,800 24 10 131-3/8 256P704-EPE3501-(2) 35,000 52,500 24 10 131-3/8 267

EPA/EPE

894


P704 REFRIGERATION UNIT COOLERSP704-EPG/EPH MEDIUM VELOCITY WALK-IN-UNIT COOLERS(Gas Defrost)

• Medium velocity/dual coil construction.• Air distribution on either side of the cooler. Air throw is 8 to 15 ft each side.• Heavy gauge textured aluminum casings with polycarbonate fan guards,

aluminum fans and stainless steel or plated hardware for a light weight and corrosion free assembly.

• Series EPG and EPH units are provided with stainless steel low watt den-sity drain pan heaters, terminal block, fan and drain pan controls for posi-tive defrost and high efficiency.

Gas Defrost

Models EPG and EPH are available in:1 = 120/1/602 = 240/1/60

NOTES:1. Standard voltage for EPG and EPH is 120/1/60, optional voltage is 240/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EPG — Reverse cycle hot gas defrost with electric drain pan heater.EPH — Three pipe hot gas defrost with electric drain pan heater.

MODELNUMBER


P704-EP( )0521-(1) 5,200 7,800 24 9-1/2 31-3/8 54P704-EP( )0781-(1) 7,800 11,700 24 9-1/2 43-3/8 72P704-EP( )0901-(1) 9,000 13,500 24 9-1/2 43-3/8 78P704-EP( )1041-(1) 10,400 15,600 24 9-1/2 51-3/8 104P704-EP( )1321-(1) 13,200 17,800 24 9-3/4 71-3/8 118P704-EP( )1561-(1) 15,600 23,400 24 9-3/4 71-3/8 128P704-EP( )1751-(1) 17,500 26,250 24 9-3/4 71-3/8 154P704-EP( )2081-(1) 20,800 31,200 24 9-3/4 91-3/8 162P704-EP( )2601-(1) 26,000 39,000 24 10 111-3/8 211P704-EP( )3121-(1) 31,200 46,800 24 10 131-3/8 236P704-EP( )3501-(1) 35,000 52,500 24 10 131-3/8 251

EPG/EPH P4386

895


P704 REFRIGERATION UNIT COOLERSP704-EVA LOW VELOCITY WALK-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F

• Low velocity/dual coil construction.• The fans draw air from the fan guards and discharge it on two

evaporator coils, on each side of the unit. Air throw is 8 to 12 ft each side.

• Heavy gauge white-painted aluminum casings with polycar-bonate fan guards, aluminum fans and stainless steel or

plated hardware for a light weight and corrosion freeassembly.


Air Defrost

Model EVA is available in:1 = 120/1/602 = 240/1/60

NOTES:1. Standard voltage for EVA is 120/1/60, optional voltage is 240/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

MODELNUMBER


P704-EVA0601-(1) 6,000 9,000 24 9-1/2 51-3/8 74P704-EVA0801-(1) 8,000 12,000 24 9-3/4 71-3/8 98P704-EVA1001-(1) 10,000 15,000 24 9-3/4 71-3/8 112P704-EVA1201-(1) 12,000 18,000 24 12-1/4 71-3/8 130P704-EVA1501-(1) 15,000 22,500 24 12-1/4 91-3/8 179P704-EVA1801-(1) 18,000 27,000 24 12-1/4 91-3/8 205P704-EVA2401-(1) 24,000 36,000 24 14-3/4 91-3/8 260P704-EVA3001-(1) 30,000 45,000 24 15 111-3/8 316P704-EVA3601-(1) 36,000 54,000 24 15 131-3/8 371

P704-EVE LOW VELOCITY WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS FROM +26 F TO +34 F

• Low velocity/dual coil construction.• The fans draw air from the fan guards and discharge it on two

evaporator coils, on each side of the unit. Air throw is 8 to 12 ft each side.

• Heavy gauge white-painted aluminum casings with polycar-bonate fan guards, aluminum fans and stainless steel or plated hardware for a light weight and corrosion freeassembly.


• Series EVE units are provided with stainless steel flexible low watt density tubular heaters inserted within the evaporator, ter-minal block, defrost termination and fan delay thermostat for positive defrost and high efficiency.

Electric Defrost

Model EVE is available in:1 = 120/1/602 = 240/1/60

NOTES:1. Standard voltage for EVE is 240/1/60, optional voltage is 120/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

MODELNUMBER


P704-EVE0601-(2) 6,000 9,000 24 9-1/2 51-3/8 80P704-EVE0801-(2) 8,000 12,000 24 9-3/4 71-3/8 107P704-EVE1001-(2) 10,000 15,000 24 9-3/4 71-3/8 121P704-EVE1201-(2) 12,000 18,000 24 12-1/4 71-3/8 141P704-EVE1501-(2) 15,000 22,500 24 12-1/4 91-3/8 194P704-EVE1801-(2) 18,000 27,000 24 12-1/4 91-3/8 220P704-EVE2401-(2) 24,000 36,000 24 14-3/4 91-3/8 280P704-EVE3001-(2) 30,000 45,000 24 15 111-3/8 340P704-EVE3601-(2) 36,000 54,000 24 15 131-3/8 400

P4387BEVA/EVE

896


P704 REFRIGERATION UNIT COOLERSP704-EVG/EVH LOW VELOCITY WALK-IN-UNIT COOLERS(Gas Defrost) FOR COOLERS FROM +26 F to +34 F

• Low velocity/dual coil construction.• The fans draw air from the fan guards and discharge it on two evaporator coils,

on each side of the unit. Air throw is 8 to 12 ft each side.• Heavy gauge white-painted aluminum casings with polycarbonate fan guards,

aluminum fans and stainless steel or plated hardware for a light weight and corrosionfree assembly.

• Life lubricated, thermal protected, heavy duty fan motors are provided forlong life and dependable service.

Gas Defrost

Models EVG and EVH are available in:1 = 120/1/602 = 240/1/605 = 208-240/3/60

NOTES:1. Standard voltage for EVG and EVH is 120/1/60, optional voltage is 240/1/60.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EVG — Reverse cycle defrost with electric drain pan heaters.EVH — Three pipe defrost pan heaters with electric drain pan heaters.

MODELNUMBER


P704-EV( )0601-(1) 6,000 9,000 24 9-1/2 51-3/8 77P704-EV( )0801-(1) 8,000 12,000 24 9-3/4 71-3/8 102P704-EV( )1001-(1) 10,000 15,000 24 9-3/4 71-3/8 115P704-EV( )1201-(1) 12,000 18,000 24 12-1/4 71-3/8 134P704-EV( )1501-(1) 15,000 22,500 24 12-1/4 91-3/8 184P704-EV( )1801-(1) 18,000 27,000 24 12-1/4 91-3/8 210P704-EV( )2401-(1) 24,000 36,000 24 14-3/4 91-3/8 266P704-EV( )3001-(1) 30,000 45,000 24 15 111-3/8 324P704-EV( )3601-(1) 36,000 54,000 24 15 131-3/8 380

P4387BEVG/EVH

897


P704 REFRIGERATION UNIT COOLERSP704-EKA/EKE COMPACT WALK-IN-UNIT COOLERS (Air Defrost) FOR COOLERS ABOVE +34 F;(Electric Defrost) FOR COOLERS AND FREEZERS FROM –20 F TO +34 F

• Compact, high velocity/single coil construction.• Air distribution toward the center of the cooler or freezer. Air

throw is 40 to 50 ft.• Heavy gauge, textured aluminum casings, polycarbonate fan

guards and aluminum fans, pleated hardware for a light weight and corrosion free assembly.

• Life lubricated, thermally protected, heavy duty fan motors are provided for long life and dependable service.

• EKE models are provided with a non-adjustable defrost termi-nation and fan delay thermostat. All units feature low wattdensity tubular heaters. They are imbedded within the coil for positive defrost and high energy efficiency. This allows to reduce heat gain in coolers and freezers. They are available for 208-240/1/60, 208-240/3/60, 480/3/60 and 600/3/60. All units use proper quantity of heaters for even-phase loading.

Air Defrost

Model EKA is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTE: For EKA, standard units are 8 FPI, for 4 FPI multiply capacity by 0.75.

Electric Defrost

Model EKE is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTE: For EKE, standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

MODELNUMBER

CAPACITY (MBH) UNIT SIZE (in.) SHIPPINGWEIGHT

(Lbs)10° F TD 15° F TD Depth Height Width

P704-EKA1400-( ) 14 21 21-1/2 21-1/8 43 100P704-EKA1600-( ) 16 24 21-1/2 21-1/8 43 110P704-EKA1800-( ) 18 27 21-1/2 21-1/8 51 153P704-EKA2100-( ) 21 31.5 21-1/2 21-1/8 51 167P704-EKA2400-( ) 24 36 21-1/2 21-1/8 71 196P704-EKA3000-( ) 30 45 21-1/2 21-1/8 71 214P704-EKA3600-( ) 36 54 21-1/2 21-1/8 91 243P704-EKA4200-( ) 42 63 21-1/2 21-1/8 91 264P704-EKA5400-( ) 54 81 21-1/2 21-1/8 111 313P704-EKA6300-( ) 63 94.5 21-1/2 21-1/8 131 361

MODELNUMBER

CAPACITY (MBH)@ 10° F TD

UNIT SIZE (in.) SHIPPINGWEIGHT

(Lbs)–20° F +20° F Depth Height WidthP704-EKE1300-( ) 11.1 13 21-1/2 21-1/8 43 110P704-EKE1500-( ) 12.8 15 21-1/2 21-1/8 43 121P704-EKE1700-( ) 14.5 17 21-1/2 21-1/8 51 168P704-EKE2000-( ) 17 20 21-1/2 21-1/8 51 184P704-EKE2200-( ) 18.7 22 21-1/2 21-1/8 71 216P704-EKE2900-( ) 24.7 29 21-1/2 21-1/8 71 235P704-EKE3400-( ) 28.9 34 21-1/2 21-1/8 91 267P704-EKE4000-( ) 34 40 21-1/2 21-1/8 91 290P704-EKE5000-( ) 42.5 50 21-1/2 21-1/8 111 344P704-EKE6000-( ) 51 60 21-1/2 21-1/8 131 397

P4385

898


P704 REFRIGERATION UNIT COOLERSP704-EKR/EKT COMPACT WALK-IN-UNIT COOLERS(Gas Defrost) FOR COOLERS AND FREEZERS FROM –20 F TO +34 F

• Compact, high velocity/single coil construction.• Air distribution toward the center of the cooler or freezer. Air

throw is 40 to 50 ft.• Heavy gauge textured aluminum casings, polypropylene fan

guards and aluminum fans, plated hardware for a light weight and corrosion free assembly.


• EKR and EKT models are provided with a sealed nonadjust-able fan delay thermostat, defrost termination thermostat and a hot gas defrost drain pan grid. Use EKR model for reverse cycle defrost or EKT model for three pipe defrost.

• All models are provided with terminal block(s) for easier field wiring. Terminals are clearly identified to match wiring diagram which is supplied with the unit.

Hot Gas Defrost

Models EKR and EKT are available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTE: Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EKR — Reverse cycle hot gas defrost with hot gas drain pan grid.EKT — Three pipe hot gas defrost with hot gas drain pan grid.

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EK( )1300-( ) 11.1 13 21-1/2 21-1/8 43 108P704-EK( )1500-( ) 12.8 15 21-1/2 21-1/8 43 118P704-EK( )1700-( ) 14.5 17 21-1/2 21-1/8 51 165P704-EK( )2000-( ) 17 20 21-1/2 21-1/8 51 180P704-EK( )2200-( ) 18.7 22 21-1/2 21-1/8 71 211P704-EK( )2900-( ) 24.7 29 21-1/2 21-1/8 71 230P704-EK( )3400-( ) 28.9 34 21-1/2 21-1/8 91 261P704-EK( )4000-( ) 34 40 21-1/2 21-1/8 91 284P704-EK( )5000-( ) 42.5 50 21-1/2 21-1/8 111 337P704-EK( )6000-( ) 51 60 21-1/2 21-1/8 131 388

P4385

899


P704 REFRIGERATION UNIT COOLERSP704-EMA MEDIUM PROFILE WALK-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F

• High velocity/single coil construction.• Air distribution toward the center of the cooler or freezer. Air

throw is 40 to 50 ft.• Heavy gauge textured aluminum casings with PVC coated wire

fan guards and aluminum fans and plated hardware for a light weight and corrosion free assembly.


Air Defrost

Model EMA is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60


MODELNUMBER

CAPACITY (MBH) UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)10° F TD 15° F TD Depth Height Width

P704-EMA02150-( ) 21.5 32.3 29 28 54-1/4 210P704-EMA02550-( ) 25.5 38.3 29 28 54-1/4 225P704-EMA03000-( ) 30.0 45.0 29 28 54-1/4 245P704-EMA04300-( ) 43.0 64.5 29 28 94-1/4 375P704-EMA05100-( ) 51.0 76.5 29 28 94-1/4 400P704-EMA06000-( ) 60.0 90.0 29 28 94-1/4 440P704-EMA07650-( ) 76.5 114.8 29 28 134-1/4 595P704-EMA09000-( ) 90.0 135.0 29 28 134-1/4 640P704-EMA10200-( ) 102 153 29 38 134-1/4 785P704-EMA12000-( ) 120 180 29 38 134-1/4 830

P704-EME MEDIUM PROFILE WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS AND FREEZERS FROM –40 F TO +34 F





• Series EME units are provided with stainless steel, flexible low watt density tubular heaters inserted within the evaporator, an adjustable defrost termination and fan delay thermostat for pos-itive defrost and high efficiency.

Electric Defrost

Model EME is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60


MODELNUMBER



–20° F +20° F Depth Height WidthP704-EME02000-( ) 17.0 20.0 29 28 54-1/4 255P704-EME02400-( ) 20.4 24.0 29 28 54-1/4 265P704-EME02900-( ) 24.7 29.0 29 28 54-1/4 295P704-EME04000-( ) 34.0 40.0 29 28 94-1/4 455P704-EME04800-( ) 40.8 48.0 29 28 94-1/4 480P704-EME05800-( ) 49.3 58.0 29 28 94-1/4 540P704-EME07200-( ) 61.2 72.0 29 28 134-1/4 720P704-EME08700-( ) 74 87.0 29 28 134-1/4 772P704-EME09600-( ) 81.6 96 29 38 134-1/4 930P704-EME1600-( ) 98.6 116 29 38 134-1/4 989

P4378CEMA/EME

900


P704 REFRIGERATION UNIT COOLERSP704-EMG/EMH/EMR/EMT MEDIUM PROFILE WALK-IN-UNIT COOLERS(Gas Defrost) FOR COOLERS AND FREEZERS FROM –40 F TO +34 F





• Series EMG and EMH are provided with stainless steel low watt density drain pan heaters, terminal block, fan motor, heater contractors, fan and drain pan controls for positive defrost and high efficiency.

Gas Defrost

Models EMG, EMH, EMR and EMT are available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTES:1. For EMT and EMR height add 5/8 inch.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EMG — Reverse cycle hot gas defrost with electric drain pan heater.EMH — Three pipe hot gas defrost with electric drain pan heater.EMR — Reverse cycle hot gas defrost with hot gas drain pan grid.EMT — Three pipe hot gas defrost with hot gas drain pan grid.

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EM( )02000-( ) 17.0 20.0 29 28 54-1/4 230P704-EM( )02400-( ) 20.4 24.0 29 28 54-1/4 245P704-EM( )02900-( ) 24.7 29.0 29 28 54-1/4 265P704-EM( )04000-( ) 34.0 40.0 29 28 94-1/4 405P704-EM( )04800-( ) 40.8 48.0 29 28 94-1/4 430P704-EM( )05800-( ) 49.3 58.0 29 28 94-1/4 470P704-EM( )07200-( ) 61.2 72.0 29 28 134-1/4 630P704-EM( )08700-( ) 74 87.0 29 28 134-1/4 680P704-EM( )09600-( ) 81.6 96 29 38 134-1/4 835P704-EM( )11600-( ) 98.6 116 29 38 134-1/4 900

P4378CEMG/EMH/EMR/EMT

901


P704 REFRIGERATION UNIT COOLERSP704-EHA HIGH PROFILE WALK-IN-UNIT COOLERS(Air Defrost) FOR COOLERS ABOVE +34 F


throw is 50 to 60 ft.• Heavy gauge, galvanized steel casings with PVC coated wire



Air Defrost

Model EHA is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTE: For EHA, standard units are 8 FPI, for 4 FPI multiply capacity by 0.75.

MODELNUMBER

CAPACITY (MBH) UNIT SIZE (in.) SHIPPINGWEIGHT (Lbs)10° F TD 15° F TD Depth Height Width

P704-EHA04500-( ) 45.0 67.5 29-1/2 53 54-1/4 480P704-EHA05400-( ) 54.0 81.0 29-1/2 53 54-1/4 500P704-EHA06200-( ) 62.0 93.0 29-1/2 53 54-1/4 545P704-EHA09000-( ) 90.0 135.0 29-1/2 53 94-1/4 805P704-EHA10800-( ) 108.0 162.0 29-1/2 53 94-1/4 850P704-EHA12400-( ) 124.0 186.0 29-1/2 53 94-1/4 940P704-EHA16200-( ) 162.0 243.0 29-1/2 53 134-1/4 1240P704-EHA18600-( ) 186.0 279.0 29-1/2 53 134-1/4 1335P704-EHA24800-( ) 248 372 29-1/2 53 174-1/4 1880

P704-EHE HIGH PROFILE WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS AND FREEZERS FROM –40 F TO +34 F


throw is 60 to 70 ft.• Heavy gauge, galvanized steel casings with PVC coated wire



• Series EHE units are provided with stainless steel, flexible low watt density tubular heaters inserted within the evaporator, an adjustable defrost termination and fan delay thermostat for pos-itive defrost and high efficiency.

Electric Defrost

Model EHE is available in:2 = 240/1/605 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTE: For EHE, standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EHE04000-( ) 34.0 40.0 29-1/2 53 54-1/4 560P704-EHE04800-( ) 40.8 48.0 29-1/2 53 54-1/4 590P704-EHE06000-( ) 51.0 60.0 29-1/2 53 54-1/4 640P704-EHE08000-( ) 68.0 80.0 29-1/2 53 94-1/4 960P704-EHE09600-( ) 81.6 96.0 29-1/2 53 94-1/4 1018P704-EHE12000-( ) 102.0 120.0 29-1/2 53 94-1/4 1125P704-EHE14000-( ) 122.4 144.0 29-1/2 53 134-1/4 1495P704-EHE18000-( ) 153.0 180.0 29-1/2 53 134-1/4 1610P704-EHE24000-( ) 204 240 29-1/2 53 174-1/4 2036

P4378DEHA/EHE

902


P704 REFRIGERATION UNIT COOLERSP704-EHG/EHH/EHR/EHT HIGH PROFILE WALK-IN-UNIT COOLERS (Gas Defrost)


throw is 50 to 60 ft.• Life lubricated, thermally protected, heavy duty fan motors are

provided for long life and dependable service.

• Series EHG and EHH are provided with stainless steel low watt density drain pan heaters, terminal block, fan motor, heater contractors, fan and drain pan controls for positive defrost and high efficiency.

Gas Defrost

Models EHG, EHH, EHR and EHT are available in:5 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTES:1. For EHR and EHT height add 5/8 inch.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EHG — Reverse cycle hot gas defrost with electric drain pan heater.EHH — Three pipe hot gas defrost with electric drain pan heater.EHR — Reverse cycle hot gas defrost with hot gas drain pan grid.EHT — Three pipe hot gas defrost with hot gas drain pan grid.

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EH( )04000-( ) 34.0 40.0 29-1/2 53 54-1/4 500P704-EH( )04800-( ) 40.8 48.0 29-1/2 53 54-1/4 520P704-EH( )06000-( ) 51.0 60.0 29-1/2 53 54-1/4 565P704-EH( )08000-( ) 68.0 80.0 29-1/2 53 94-1/4 835P704-EH( )09600-( ) 81.6 96.0 29-1/2 53 94-1/4 880P704-EH( )12000-( ) 102.0 120.0 29-1/2 53 94-1/4 970P704-EH( )14000-( ) 122.4 144.0 29-1/2 53 134-1/4 1280P704-EH( )18000-( ) 153.0 180.0 29-1/2 53 134-1/4 1375P704-EH( )24000-( ) 204 240 29-1/2 53 174-1/4 1940

P4378DEHG/EHH/EHR/EHT

903


P704 REFRIGERATION UNIT COOLERSP704-EIE/EIG/EIH/EIR/EIT INDUSTRIAL WALK-IN-UNIT COOLERS(Electric Defrost) FOR COOLERS AND FREEZERS FROM –40 F TO +0° F;(Hot Gas Defrost) FOR COOLERS AND FREEZERS FROM –40 F TO +0° F

• Extra-high velocity/single coil construction.• Air distribution toward the center of the cooler or freezer. Air

throw is 60 to 70 ft.• Heavy gauge, galvanized steel with PVC coated wire fan

guards and aluminum fans and plated hardware for a heavy duty and corrosion free assembly.


• Series EIE units are provided with stainless steel, flexible low watt density tubular heaters inserted within the evaporator, an adjustable defrost termination and fan delay thermostat for positive defrost and high efficiency.

• Series EIG and EIH are provided with stainless steel low watt density drain pan heaters, terminal block, fan motor, heater contactors, fan and drain pan controls for positive defrost and high efficiency.

Electric Defrost

Hot Gas Defrost

Models EIE, EIG, EIH, EIR and EIT are available in:5 = 208-240/3/608 = 600/3/609 = 480/3/60

NOTES:1. For EIT and EIR height add 5/8 inch.2. Standard units are 6 FPI, for 4 FPI multiply capacity by 0.85.

EIE — Electric DefrostEIG — Reverse cycle hot gas defrost with electronic drain pan.EIH — Three pipe hot gas defrost with electronic drain pan.EIR — Reverse cycle hot gas defrost with hot gas drain pan.EIT — Three pipe defrost with hot gas drain pan.

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EIE04400-( ) 37.4 44 29-1/2 53 54-1/4 560P704-EIE05400-( ) 45.9 54 29-1/2 53 54-1/4 590P704-EIE06800-( ) 57.8 68 29-1/2 53 54-1/4 640P704-EIE08800-( ) 74.8 88 29-1/2 53 94-1/4 960P704-EIE10800-( ) 91.8 108 29-1/2 53 94-1/4 1018P704-EIE13600-( ) 115.6 136 29-1/2 53 94-1/4 1125P704-EIE16200-( ) 137.7 162 29-1/2 53 134-1/4 1495P704-EIE20400-( ) 173.4 204 29-1/2 53 134-1/4 1610P704-EIE27200-( ) 231.2 272 29-1/2 53 174-1/4 2250

MODELNUMBER



–20° F +20° F Depth Height WidthP704-EI( )04400-( ) 37.4 44 29-1/2 53 54-1/4 500P704-EI( )05400-( ) 45.9 54 29-1/2 53 54-1/4 520P704-EI( )06800-( ) 57.8 68 29-1/2 53 54-1/4 565P704-EI( )08800-( ) 75.2 88 29-1/2 53 94-1/4 835P704-EI( )10800-( ) 91.8 108 29-1/2 53 94-1/4 880P704-EI( )13600-( ) 115.8 136 29-1/2 53 94-1/4 970P704-EI( )16200-( ) 137.7 162 29-1/2 53 134-1/4 1280P704-EI( )20400-( ) 173.4 204 29-1/2 53 134-1/4 1375P704-EI( )27200-( ) 231 272 29-1/2 53 174-1/4 1940

P4378DEIE/EIG/EIH/EIR/EIT

904


P704 REFRIGERATION UNIT COOLERSP704-EBE BLAST FREEZER UNIT COOLERS(Electric Defrost) FOR FREEZERS FROM –40 F TO +0° F

• Extra-high velocity/floor mounted units.• Designed for fast freezing in tunnel.• The fans draw air from the evaporator coil and discharge it through the fan

guards on the front of the unit.• The blast freezer series EB casings are heavy gauge, galvanized steel with

PVC coated wire fan guards, aluminum fans and plated hardware for a heavy duty and corrosion free assembly.


• Series EBE units are provided with stainless steel, flexible low watt density tubular heaters inserted within the evaporator, an adjustable defrost termina-tion and fan delay thermostat for positive defrost and high efficiency.

Electric Defrost

Model EBE is available in:5 = 208-240/3/608 = 600/3/609 = 480/3/60

MODELNUMBER

CAPACITY (MBH) @ 10° F TD–40° F SST AIR STATIC


0″″″″ 0.1″″″″ 0.2″″″″ Depth Height WidthP704-EBE03420-( ) 32 32 31 37 56 54 750P704-EBE04530-( ) 43 42 41 37 56 54 830P704-EBE05460-( ) 52 51 49 37 56 54 880P704-EBE06840-( ) 67 65 63 37 56 94 1190P704-EBE09060-( ) 88 86 84 37 56 94 1320P704-EBE10910-( ) 107 104 99 37 56 94 1430P704-EBE13600-( ) 132 126 121 37 56 134 1800P704-EBE16370-( ) 158 156 150 37 56 134 1900P704-EBE18610-( ) 177 173 170 37 56 174 2180P704-EBE22210-( ) 211 208 201 37 56 174 2370P704-EBE17160-( ) 163 159 154 37 96 94 2100P704-EBE20980-( ) 199 195 190 37 96 94 2205P704-EBE25730-( ) 245 241 237 37 96 134 2700P704-EBE31460-( ) 299 286 279 37 96 134 3060P704-EBE35400-( ) 336 328 316 37 96 174 3960P704-EBE42720-( ) 406 388 378 37 96 174 4410

P4387

905


P704 REFRIGERATION UNIT COOLERSP704-EBR/EBT BLAST FREEZER UNIT COOLERS(Gas Defrost) FOR FREEZERS FROM –40 F TO +0° F

• Extra-high velocity/floor mounted units.• Designed for fast freezing in tunnel.• The fans draw air from the evaporator coil and discharge it through the fan

guards on the front of the unit.• The blast freezer series EB casings are heavy gauge, galvanized steel with

PVC coated wire fan guards, aluminum fans and plated hardware for a heavy duty and corrosion free assembly.


• Series EBR and EBT are provided with hot gas drain pan grid, adjustable fan delay thermostat and defrost termination thermostat.

Gas Defrost

Models EBR and EBT are available in:5 = 208-240/3/608 = 600/3/609 = 480/3/60

EBR — Reverse cycle hot gas defrost with hot gas drain pan.EBT — Three pipe hot gas defrost with hot gas drain pan.

MODELNUMBER

CAPACITY (MBH) @ 10° F TD–40° F SST AIR STATIC


0″″″″ 0.1″″″″ 0.2″″″″ Depth Height WidthP704-EB( )03420-( ) 34 33 32 37 56 54 750P704-EB( )04530-( ) 46 44 43 37 56 54 830P704-EB( )05460-( ) 55 54 52 37 56 54 880P704-EB( )06840-( ) 71 69 67 37 56 94 1190P704-EB( )09060-( ) 93 91 88 37 56 94 1320P704-EB( )10910-( ) 113 109 104 37 56 94 1430P704-EB( )13600-( ) 139 137 136 37 56 134 1800P704-EB( )16370-( ) 166 164 157 37 56 134 1900P704-EB( )18610-( ) 186 182 179 37 56 174 2180P704-EB( )22210-( ) 222 219 211 37 56 174 2370P704-EB( )17160-( ) 172 167 163 37 96 94 2100P704-EB( )20980-( ) 210 205 200 37 96 94 2205P704-EB( )25730-( ) 257 254 250 37 96 134 2700P704-EB( )31460-( ) 315 301 293 37 96 134 3060P704-EB( )35400-( ) 354 345 333 37 96 174 3960P704-EB( )42720-( ) 427 408 398 37 96 174 4410

P4387

906


P704 REFRIGERATION UNIT COOLERSP704-EFE/EFR/EFT FREE-STANDING BLAST FREEZER(Electric Defrost) AND (Gas Defrost)

• Extra-high velocity/floor mounted units.• Designed for fast freezing in tunnel. The field supplied fans can be mounted

for air draw or blow through installation.• The blast freezer series EF casings are heavy gauge, galvanized steel for a

heavy duty and corrosion free assembly.• Series EFE units are provided with stainless steel, flexible low watt density

tubular heaters inserted within the evaporator, an adjustable defrost termina-tion and fan delay thermostat for positive defrost and high efficiency.

• EFR/EFT series are provided with a hot gas drain pan, adjustable fan.

Electric Defrost

Gas Defrost

*(R) or (T).

Models EFE, EFR AND EFT are available in:5 = 208-240/3/60

EFR — Reverse cycle hot gas defrost with hot gas drain pan.EFT — Three pipe hot gas defrost with hot gas drain pan.

MODELNUMBER

CAPACITY (MBH) @ 10° F TD –40° F SSTUNIT SIZE (in.) SHIPPING

WEIGHT (Lbs)FPM

600 700 800 Depth Height WidthP704-EFE03420-( ) 29.4 30.9 33.3 27 56 54 580P704-EFE04530-( ) 40.1 42.5 46.2 27 56 54 650P704-EFE05460-( ) 49.1 52.4 55.5 27 56 54 710P704-EFE06840-( ) 60.7 63.8 66.7 27 56 94 880P704-EFE09060-( ) 81.2 86.8 91.4 27 56 94 1000P704-EFE10910-( ) 98.2 108.2 114.6 27 56 94 1140P704-EFE13600-( ) 122 133.9 140.6 27 56 134 1380P704-EFE16370-( ) 148.7 158.8 173.7 27 56 134 1570P704-EFE18610-( ) 163.7 173.6 188.6 27 56 174 1730P704-EFE22210-( ) 199.2 212.8 225.3 27 56 174 2020P704-EFE17160-( ) 145.2 158.7 167.1 27 96 94 1657P704-EFE20980-( ) 181.6 194.1 205.6 27 96 94 1810P704-EFE25730-( ) 209.6 238.1 250.7 27 96 134 1953P704-EFE31460-( ) 274.5 293.5 308.4 27 96 134 2322P704-EFE35400-( ) 299.3 317.5 334.3 27 96 174 3114P704-EFE42720-( ) 358.9 398.5 419 27 96 174 3620

MODELNUMBER

CAPACITY (MBH) @ 10° F TD –40° F SSTUNIT SIZE (in.) SHIPPING

WEIGHT (Lbs)FPM

600 700 800 Depth Height WidthP704-EF(*)03420-( ) 31 32.5 35.1 27 56 54 580P704-EF(*)04530-( ) 42.3 44.8 48.6 27 56 54 650P704-EF(*)05460-( ) 51.7 55.2 58.4 27 56 54 710P704-EF(*)06840-( ) 63.9 67.1 70.2 27 56 94 880P704-EF(*)09060-( ) 85.5 91.4 96.2 27 56 94 1000P704-EF(*)10910-( ) 103.3 113.9 120.6 27 56 94 1140P704-EF(*)13600-( ) 128.5 140.5 148 27 56 134 1380P704-EF(*)16370-( ) 156.5 167.2 182.8 27 56 134 1570P704-EF(*)18610-( ) 172.4 182.8 198.8 27 56 174 1730P704-EF(*)22210-( ) 209.6 224.1 237.2 27 56 174 2020P704-EF(*)17160-( ) 152.8 167.1 175.9 27 96 94 1657P704-EF(*)20980-( ) 191.2 204.3 216.4 27 96 94 1810P704-EF(*)25730-( ) 220.7 250.6 263.9 27 96 134 1953P704-EF(*)31460-( ) 288.9 309 324.6 27 96 134 2322P704-EF(*)35400-( ) 315 334.2 351.9 27 96 174 3114P704-EF(*)42720-( ) 377.8 419.5 441 27 96 174 3620

P4388

907

TOTALINE® REFRIGERATION CONDENSING UNITS

P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITS

P4389A

Totaline’s outdoor and indoor refrigeration condensing units are available in several models and sizes for various applications.

Condensing units are air cooled or water cooled and are available with semi-hermetic, hermetic, or scroll compres-sors. A remote condenser unit is also available. Sizes are available from 3/4 HP up to 80 HP.

STANDARD FEATURES:• Painted outdoor galvanized protective cabinet (outdoor

units up to 22 HP).• Outdoor galvanized protective cabinet (outdoor units

above 25 HP).• Aluminum fin and copper tube condenser.• True subcooling circuit integrated in the condenser coil.• Fixed head pressure control flooding valve (outdoor

units up to 22 HP).• Adjustable head pressure control flooding valves (out-

door units above 25 HP).• Crankcase heater (outdoor units).• Rigid mounted hermetic and scroll compressors.• Spring mounted semi-hermetic compressor with

vibrasorbers.• Tamper-proof adjustable high pressure switch.• Tamper-proof adjustable low pressure switch (hermetic

and scroll).• Units available for R-22, R-404A, R-507 and -134a.

FACTORY-INSTALLED OPTIONS:

• Low ambient kit includes: heated and insulated receiver.• Liquid line kit: liquid drier (standard or replaceable), sight

glass/moisture indicator, liquid line solenoid valve (shipped loose).

• Suction filter (standard or replaceable).• Adjustable high and low pressure switch with flexible hoses.• Suction accumulator.• Oil separator (ICH units).• Oil separator including check valve, insulation and heater

(OCH units).

• Non-fused disconnect switch.• Fused disconnect switch.• Hot gas defrost kit.• Electric defrost timer (single phase).• Electric defrost kit includes timer, heater, fan contactors and

lockout relay (3 phase).• Air defrost timer.• Fan speed control kit (dual fan condensing units only).

P4389B

908


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITS

P705 – O C S – 100 – 1 H 2 – 9 – A* – E* – H* – J*

– – No Option J – 62A – Electric Defrost Kit – StdA – Air Defrost Timer Only K – 62A – Electric Defrost Kit – FusedB – 25A – Electric Defrost Kit – Std L – 75A – Electric Defrost Kit – StdC – 25A – Electric Defrost Kit – Fused M – 75A – Electric Defrost Kit – FusedD – 35A – Electric Defrost Kit – Std N – 90A – Electric Defrost Kit – StdE – 35A – Electric Defrost Kit – Fused O – 90A – Electric Defrost Kit – FusedF – 40A – Electric Defrost Kit – Std P – 125A – Electric Defrost Kit – StdG – 40A – Electric Defrost Kit – Fused Q – 125A – Electric Defrost Kit – FusedH – 50A – Electric Defrost Kit – Std R – Electric Defrost Timer OnlyI – 50A – Electric Defrost Kit – Fused

NOTE: This option is only needed when unit cooler is matched with the condensingunit. Please refer to unit cooler product data & select correct ampacity for defrost unit.

– – No Option M – A+C+DA – Low Ambient Kit N – B+C+DB – Suction Accumulator O – A+B+C+DC – Oil Separator P – Fused DisconnectD – Non-Fused Disconnect Q – A+PE – A+B R – B+PF – A+C S – C+PG – A+D T – A+B+PH – B+C U – A+C+PI – B+D V – B+C+PJ – C+D W – A+B+C+PK – A+B+CL – A+B+D

– – No Option G – B+CA – Liquid Line Kit with H – B+D

Standard Filter Drier I – Flooding Valve KitB – Liquid Line Kit with J – A+I

Replaceable Filter Drier K – A+C+IC – Suction Filter – Standard Filter L – A+D+ID – Suction Filter – Replaceable Filter M – B+IE – A+C N – B+C+IF – A+D O – B+D+I

Application Temperature RangeH – High Suction Temp./Medium

(0° to 45° Suction Temp.)M – Medium Suction Temp.

(0° to 30° Suction Temp.)L – Low Suction Temp.

(–40° to 0° Suction Temp.)T – Two Stage Suction Temp.

(–50° to 0° Suction Temp.)

Condensing Unit TypeO – Outdoor Air CooledI – Indoor Air CooledW – Water CooledM – Sea Water CooledS – Remote Compressor Unit

NOTE: For sea water applications,use M designation in place of W(water-cooled) or S (Remote)

Totaline Condensing Units

S – Semi-HermeticH – HermeticZ – Scroll

C – Condensing Unit

Nominal Compressor HP – 10

Compressor1 – Copeland2 – Carlyle

– – No Option I – Copeland Unloading – 33%A – Fan Speed Control J – Copeland Unloading – 33% & 66%B – Adjustable High & Low Pressure K – Copeland Unloading – 50%

Switch with Flexible Hoses Only L – 3 TR, R22 – Hot Gas BypassFor Hermetic Condensing Units) M – 6 TR, R22 – Hot Gas Bypass

C – A + B N – 9 TR, R22 – Hot Gas BypassD – Carlyle Unloading – 33% O – 15 TR, R22 – Hot Gas BypassE – Carlyle Unloading – 66% P – 25 TR, R22 – Hot Gas BypassF – Carlyle Unloading – 33% & 65% Q – 35 TR, R22 – Hot Gas BypassG – Carlyle Unloading – 50% R – TCB Sporlan – Hot Gas BypassH – Copeland Unloading – Moduload

Refrigerant2 – R-224 – R-404A & R-507

Unit Voltage (V/Ph/Hz)2 – 240/1/605 – 208-240/3/608 – 600/3/50

P705 CONDENSING UNIT NOMENCLATURE

*Indicates factory-installed option(s).

909


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSHERMETIC CONDENSING UNITS — COPELAND COMPRESSORS

P705-OCH Outdoor Air-Cooled Condensing Unit (Sizes 008 to 050) R-22P705-ICH Indoor Air-Cooled Condensing Unit (Sizes 008 to 050) High Temperature

LEGEND

MBTUH — Btuh in thousands*Use I for indoor units and O for outdoor units.

PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)

SATURATED SUCTION TEMP (°F) (CAPACITY MBTUH) LINE SIZESOD (in,) RECEIVER

(lbs)

REFRGERANTCHARGE (lbs)

15 20 25 30 35 40 45 Suction Liquid Summer Winter

P705-(*)CH-008-1H2 RSE-0075

90 5.4 6.1 7.0 7.8 8.7 9.7 10.8

1/2 3/8 17 1.9 2.995 5.1 5.9 6.6 7.4 8.3 9.3 10.3

100 4.8 5.6 6.3 7.1 8.0 8.9 9.9105 4.6 5.3 6.0 6.8 7.6 8.5 9.4

P705-(*)CH-010-1H2 RRG-0100

90 6.5 7.4 8.4 9.5 10.6 11.9 13.2

1/2 3/8 17 1.9 2.995 6.1 7.0 8.0 9.0 10.1 11.3 12.6

100 5.8 6.6 7.6 8.6 9.6 10.8 12.0105 5.5 6.3 7.2 8.1 9.1 10.2 11.4

P705-(*)CH-012-1H2 REK-0125

90 7.9 9.1 10.3 11.6 13.0 14.5 16.0

1/2 3/8 17 2.6 4.695 7.4 8.5 9.7 11.0 12.3 13.8 15.3

100 7.0 8.0 9.2 10.4 11.7 13.1 14.6105 6.5 7.5 8.7 9.9 11.1 12.5 13.9

P705-(*)CH-015-1H2 REY-0175

90 10.0 11.5 13.0 14.7 16.6 18.5 20.5

5/8 3/8 17 2.6 4.695 9.7 11.0 12.6 14.2 16.0 17.8 19.8

100 9.4 10.6 12.1 13.6 15.4 17.1 19.0105 9.0 10.2 11.6 13.1 14.7 16.4 18.2

P705-(*)CH-020-1H2 CRD1-0200

90 13.0 15.0 17.2 19.4 22.0 24.6 27.4

5/8 3/8 17 3.9 6.895 12.4 14.3 16.4 18.6 21.1 23.6 26.3

100 11.8 13.7 15.7 17.8 20.2 22.7 25.2105 11.3 13.1 15.0 17.1 19.4 21.7 24.2

P705-(*)CH-025-1H2 CRF4-0250

90 16.2 19.4 21.3 24.1 27.1 30.3 33.7

7/8 3/8 17 3.9 6.895 15.4 18.6 20.3 23.0 25.9 28.9 32.2

100 14.7 17.8 19.3 21.9 24.7 27.6 30.7105 13.9 16.1 18.4 20.9 23.5 26.3 29.4

P705-(*)CH-030-1H2 CRJ3-0300

90 19.5 22.6 26.0 29.8 33.9 38.4 43.3

7/8 1/2 17 4.8 9.195 18.3 21.3 24.6 28.3 32.2 36.6 41.2

100 17.3 20.1 23.3 26.8 30.6 34.7 39.2105 16.2 18.9 21.9 25.3 28.9 32.9 37.2

P705-(*)CH-035-1H2 CRL3-0350

90 24.0 28.1 32.7 37.6 42.8 48.3 54.1

7/8 1/2 29 7.4 1495 22.6 26.6 30.9 35.7 40.7 46.1 51.6

100 21.2 25.0 29.2 33.8 38.6 43.8 49.1105 19.8 23.4 27.4 31.8 36.5 41.4 46.6

P705-(*)CH-040-1H2 CRM3-0400

90 28.1 32.6 37.4 42.3 47.4 52.8 58.5

7/8 1/2 29 7.4 1495 26.5 30.9 35.6 40.4 45.4 50.6 56.1

100 24.8 29.2 33.7 38.5 43.3 48.4 53.7105 23.1 27.4 31.9 36.5 41.3 46.2 51.3

P705-(*)CH-050-1H2 CRN5-0500

90 34.7 39.6 44.8 50.0 56.0 62.1 68.7

7/8 1/2 29 8.7 1795 33.1 37.8 42.9 48.0 53.8 59.7 66.0

100 31.4 36.1 41.0 46.0 51.6 57.3 63.4105 29.7 34.3 39.1 44.1 49.4 54.9 60.8

910


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSHERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)

P705-OCH Outdoor Air-Cooled Condensing Unit (Sizes 007 to 050) R-404A & R-507P705-ICH Indoor Air-Cooled Condensing Unit (Sizes 007 to 050) Medium Temperature

R-404A & R-507Low Temperature

LEGENDMBTUH — Btuh in thousands*Use I for indoor units and O for outdoor units.†Based on 95° F ambient temperature.NOTES:1. For 90° F ambient multiply capacity by 1.05.2. For 100° F ambient multiply capacity by 0.96.

PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)

SATURATED SUCTION TEMP (°F) (CAPACITY MBTUH) LINE SIZESOD (in.) RECEIVER

(lbs)

REFRIGERANTCHARGE (lbs)

–10 –5 0 5 10 15 20 25 30 Suction Liquid Summer Winter

P705-(*)CH-007-1M4 RS43C1E

90 2.4 2.9 3.3 3.8 4.4 5.0 5.7 6.5 7.3

1/2 3/8 15 1.7 2.695 2.2 2.6 3.0 3.5 4.0 4.6 5.2 6.0 6.8

100 2.0 2.4 2.7 3.2 3.6 4.2 4.8 5.4 6.2105 1.9 2.2 2.5 2.8 3.3 3.7 4.3 4.9 5.6

P705-(*)CH-008-1M4 RS55C1E

90 3.1 3.6 4.1 4.7 5.3 5.9 6.7 7.4 8.3

1/2 3/8 15 1.7 2.695 2.8 3.2 3.8 4.3 4.9 5.5 6.1 6.9 7.7

100 2.4 2.9 3.4 3.9 4.4 5.0 5.6 6.4 7.2105 2.1 2.5 3.0 3.5 4.0 4.5 5.1 5.8 6.6

P705-(*)CH-010-1M4 RS70C1E

90 4.1 4.7 5.4 6.1 6.8 7.6 8.4 9.3 10.3

1/2 3/8 15 2.3 4.195 3.8 4.4 5.0 5.7 6.4 7.1 v7.8 8.6 9.5

100 3.4 4.0 4.6 5.2 5.9 6.5 7.2 8.0 8.8105 3.1 3.6 4.2 4.8 5.4 6.0 6.6 7.3 8.1

P705-(*)CH-015-1M4 RS97C1E

90 5.5 6.4 7.4 8.4 9.5 10.6 11.8 13.0 14.3

5/8 3/8 15 2.3 4.195 5.1 5.9 6.9 7.8 8.8 9.9 10.9 12.1 13.3

100 4.6 5.5 6.3 7.2 8.2 9.1 10.1 11.2 12.3105 4.2 5.0 5.8 6.7 7.5 8.4 9.3 10.3 11.3

P705-(*)CH-020-1M4 CS12K6E

90 6.7 8.0 9.3 10.8 12.4 14.0 15.8 17.8 19.8

5/8 3/8 15 3.5 6.195 6.0 7.2 8.5 9.9 11.4 13.0 14.7 16.5 18.4

100 5.4 6.5 7.7 9.0 10.4 11.9 13.5 15.2 17.0105 4.8 5.8 7.0 8.2 9.5 10.8 12.3 14.0 15.7

P705-(*)CH-025-1M4 CS14K6E

90 8.2 9.6 11.1 12.7 14.4 16.2 18.0 19.8 21.6

7/8 3/8 15 3.5 6.195 7.5 8.9 10.3 11.8 13.4 15.0 16.7 18.4 20.1

100 6.9 8.1 9.4 10.8 12.3 13.8 15.4 16.9 18.5105 6.2 7.4 8.6 9.9 11.3 12.7 14.1 15.6 17.0

P705-(*)CH-030-1M4 CS18K6E

90 10.1 12.0 14.1 16.3 18.6 20.9 23.3 25.7 28.1

7/8 1/2 15 4.3 8.195 9.2 10.9 12.9 14.9 17.1 19.3 21.5 23.8 26.0

100 8.2 9.9 11.7 13.6 15.6 17.7 19.8 21.9 24.0105 7.4 8.9 10.5 12.3 14.2 16.1 18.1 20.0 22.0

P705-(*)CH-035-1M4 CS20K6E

90 11.8 13.7 15.8 18.1 20.6 23.3 26.3 29.6 33.2

7/8 1/2 25 6.6 1295 10.7 12.5 14.4 16.5 18.9 21.4 24.2 27.3 30.7

100 9.6 11.3 13.1 15.0 17.2 19.5 22.1 25.1 28.3105 8.4 10.0 11.7 13.5 15.5 17.7 20.2 22.9 26.0

P705-(*)CH-040-1M4 CS27K3E

90 14.2 16.7 19.5 22.6 26.1 29.6 33.4 37.3 41.4

7/8 1/2 25 6.6 1295 13.0 15.3 17.8 20.7 24.0 27.3 30.9 34.7 38.6

100 11.9 13.9 16.2 18.9 22.0 25.0 28.5 32.1 35.9105 10.8 12.5 14.6 17.1 19.8 22.9 26.1 29.6 33.2

P705-(*)CH-050-1M4 CS33K3E

90 18.2 21.2 24.3 27.6 31.3 35.1 39.2 43.8 48.7

7/8 1/2 25 7.7 1595 16.6 19.3 22.2 25.3 28.9 32.4 36.4 40.8 45.5

100 14.9 17.4 20.1 23.1 26.4 29.8 33.6 37.8 42.5105 13.3 15.6 18.1 20.9 23.9 27.2 30.9 35.0 39.6

PARTNUMBER*

SATURATED SUCTION TEMPERATURE (°°°°F)(CAPACITY MBUTH)†

LINE SIZEOD (in.) RECEIVER

(lbs)


–30 –25 –20 –15 –10 –5 0 Suction Liquid Summer WinterP705-(*)CH-010-1L4 2.3 2.9 3.6 4.3 5.0 5.9 6.8 1/2 3/8 15 2.3 4.1P705-(*)CH-015-1L4 4.0 4.9 6.0 7.2 8.4 9.6 10.9 5/8 3/8 15 2.3 4.1P705-(*)CH-020-1L4 5.9 7.3 8.9 10.5 12.3 14.2 16.2 5/8 3/8 15 3.5 6.1P705-(*)CH-025-1L4 8.0 9.7 11.4 13.1 15.0 17.0 19.2 7/8 3/8 15 3.5 6.1

911


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — CARLYLE COMPRESSORS

P705-OCS Outdoor Air-Cooled (Sizes 030 to 802) R-22P705-ICS Indoor Air-Cooled (Sizes 030 to 200) Medium Temperature

LEGEND

MBTUH — Btuh in thousands

*Use I for indoor units and O for outdoor units.

NOTE: Units 502 through 802 have dual compressors.

PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)


(lbs)


0 5 10 15 20 25 30 35 40 Suction Liquid Summer Winter

P705-(*)CS-030-2M2 06DM-808

90 15.2 17.5 20.0 22.7 25.5 28.7 32.0 35.6 39.4

7/8 1/2 17 4.8 9.195 14.3 16.5 18.9 21.5 24.3 27.3 30.6 34.0 37.8

100 13.4 15.6 17.9 20.4 23.1 26.0 29.2 32.5 36.2105 12.6 14.6 16.9 19.3 21.9 24.8 27.8 31.1 34.7

P705-(*)CS-050-2M2 06DM-313

90 22.9 26.4 30.3 34.6 39.1 44.0 49.3 55.0 61.1

1-1/8 1/2 29 8.7 1795 21.4 24.8 28.6 32.7 37.1 41.8 46.9 52.4 58.3

100 19.9 23.2 26.9 30.8 35.0 39.6 44.6 50.0 55.7105 18.5 21.7 25.2 29.0 33.1 37.6 42.4 47.7 53.3

P705-(*)CS-060-2M2 06DM-316

90 29.0 33.2 37.7 42.6 47.9 53.6 59.7 66.2 73.3

1-1/8 1/2 29 8.7 1795 27.4 31.4 35.7 40.4 45.5 51.0 57.0 63.4 70.2

100 25.7 29.6 33.8 38.3 43.3 48.6 54.4 60.7 67.5105 24.2 27.9 31.9 36.4 41.4 46.4 52.1 58.3 65.1

P705-(*)CS-070-2M2 06DA-818

90 33.5 38.5 43.9 49.7 56.0 62.7 69.9 77.6 85.8

1-1/8 5/8 29 11 2195 31.4 36.3 41.5 47.1 53.2 59.7 66.7 74.2 82.3

100 29.4 34.1 39.1 44.6 50.5 56.8 63.7 71.1 79.0105 27.4 31.9 36.8 42.2 47.9 54.1 60.9 68.2 76.1

P705-(*)CS-080-2M2 06DR-820

90 43.1 48.5 54.5 60.9 67.6 75.4 83.5 92.2 101.6

1-3/8 5/8 62 13 2695 41.4 46.6 52.3 58.5 65.0 72.5 80.4 88.8 97.9

100 39.7 44.7 50.2 56.2 62.5 69.7 77.3 85.5 94.4105 38.0 42.9 48.2 54.0 60.4 67.1 74.5 82.5 91.6

P705-(*)CS-090-2M2 06DR-724

90 47.6 54.2 61.4 69.1 77.5 86.7 96.4 106.9 118.2

1-3/8 5/8 62 13 2695 45.2 51.5 58.4 65.9 73.9 82.8 92.3 102.5 113.4

100 42.7 48.8 55.5 62.7 70.5 79.1 88.3 98.3 109.0105 40.4 46.3 52.7 59.7 67.7 75.7 84.7 94.5 105.1

P705-(*)CS-090-2M2 06DR-724

90 56.9 64.4 72.6 81.5 91.0 101.5 112.7 124.7 137.6

1-5/8 7/8 62 16 3295 54.3 61.5 69.4 77.9 87.1 97.2 108.0 119.7 132.2

100 51.7 58.6 66.2 74.4 83.3 93.1 103.6 115.0 128.0105 49.2 55.9 63.2 71.2 80.1 89.8 100.1 111.3 123.5

P705-(*)CS-150-2M2 06DM-337

90 74.2 84.1 94.8 106.4 118.9 132.7 147.4 163.2 180.2

1-5/8 7/8 81 18 3695 70.8 80.2 90.5 101.8 113.7 127.1 141.3 156.6 173.1

100 67.4 76.5 86.4 97.2 108.7 121.7 135.5 150.4 166.6105 64.1 72.9 82.4 92.9 104.7 116.7 130.2 144.8 178.9

P705-(*)CS-200-2M2 06EM-150

90 89.2 103.1 117.9 133.8 151.2 169.0 188.4 209.1 231.1

2-1/8 7/8 81 22 4795 83.1 96.6 111.1 126.6 143.5 160.9 179.8 200.1 221.9

100 77.1 90.2 104.3 119.4 135.9 153.1 171.7 191.8 213.4105 71.1 83.9 97.7 112.6 128.6 145.8 164.3 184.3 206.0

P705-OCS-250-2M2 06EA-265

90 123.5 140.9 160.1 180.9 203.6 227.8 254.1 282.3 312.7

2-1/8 1-1/8 106 27 5695 116.8 133.5 151.9 171.8 193.7 217.0 242.4 269.8 299.5

100 110.3 126.3 143.9 163.1 184.1 206.8 231.5 258.3 287.5105 104.0 119.5 136.5 155.0 175.4 197.5 221.7 248.1 277.0

P705-OCS-300-2M2 06EM-175

90 134.9 154.8 176.3 199.5 224.8 251.2 279.9 310.6 342.0

2-1/8 1-1/8 144 37 7595 126.8 146.0 166.7 189.1 213.6 239.2 267.1 297.1 329.3

100 118.8 137.3 157.3 179.0 202.8 227.8 255.1 284.6 316.5105 110.9 128.9 148.3 169.5 192.4 217.3 244.2 273.4 305.2

P705-OCS-400-2M2 06EM-199

90 186.8 212.4 240.1 270.0 301.9 336.7 373.7 413.3 455.7

2-1/8 1-1/8 182 54 11095 177.3 202.0 228.8 257.7 288.6 322.3 358.2 396.8 440.7

100 167.7 191.6 217.5 245.5 275.5 308.3 343.4 383.4 424.0105 158.4 181.6 206.7 233.9 264.6 297.1 331.6 368.9 409.2

P705-OCS-502-2M2 06EA-265

90 247.0 281.8 320.2 361.8 407.2 455.6 508.2 564.6 625.4

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 233.6 267.0 303.8 343.6 387.4 434.0 484.8 539.6 599.0

100 220.6 252.6 287.8 326.2 368.2 413.6 463.0 516.6 575.0105 208.0 239.0 273.0 310.0 350.8 395.0 443.4 496.2 554.0

P705-OCS-602-2M2 06EM-175

90 269.8 309.6 352.6 399.0 449.6 502.4 559.8 621.2 684.0

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 37 (2) 7595 253.6 292.0 333.4 378.2 427.2 478.4 534.2 594.2 658.6

100 237.6 274.6 314.6 358.0 405.6 455.6 510.2 569.2 633.0105 221.8 257.8 296.6 339.0 384.8 434.6 488.4 546.8 610.4

P705-OCS-802-2M2 06EM-199

90 373.6 424.8 480.2 540.0 603.8 673.4 747.4 826.6 911.4

(2) 2-1/8 (2) 1-1/8 (2) 182 (2) 54 (2)11095 354.6 404.0 457.6 515.4 577.2 644.6 716.4 793.6 881.4

100 335.4 383.2 435.0 491.0 551.0 616.6 686.8 766.8 848.0105 316.8 363.2 413.4 467.8 529.2 594.2 663.2 737.8 818.4

912


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — CARLYLE COMPRESSORS (cont)

P705-OCS Outdoor Air-Cooled (Sizes 030 to 802) R-404A & R-507P705-ICS Indoor Air-Cooled (Sizes 030 to 200) Medium Temperature

LEGENDMBTUH — Btuh in thousands*Use I for indoor units and O for outdoor units.NOTE: Units 502 through 802 have dual compressors.

PARTNUMBER*

CARLYLENUMBER

AMBIENTTEMP (°F)

SATURATED SUCTION TEMP (° F) (CAPACITY MBTUH) LINE SIZESOD (in.) RECEIVER

(lbs)



P705-(*)CS-030-2M4 06DM-808

90 16.8 19.2 21.8 24.5 27.6 30.6 34.0

7/8 1/2 15 4.3 8.195 15.7 18.0 20.4 23.0 25.9 28.8 31.9

100 14.6 16.8 19.1 21.5 24.2 27.0 30.0105 13.6 15.6 17.8 20.1 22.5 25.2 28.1

P705-(*)CS-050-2M4 06DM-313

90 25.1 29.1 33.3 37.8 42.7 47.5 52.8

1-1/8 1/2 25 7.7 1595 23.2 26.9 30.9 35.2 39.8 44.4 49.4

100 21.2 24.8 28.6 32.6 37.0 41.4 46.1105 19.3 22.7 26.3 30.1 34.1 38.4 43.0

P705-(*)CS-060-2M4 06DM-316

90 31.7 36.3 41.2 46.4 52.2 57.8 63.9

1-1/8 1/2 25 7.7 1595 29.5 33.8 38.4 43.3 48.8 54.0 59.9

100 27.3 31.3 35.7 40.3 45.2 50.5 56.1105 25.1 29.0 33.1 37.5 42.1 47.2 52.6

P705-(*)CS-080-2M4 06DR-820

90 50.3 56.4 62.9 69.8 77.1 84.8 93.0

1-3/8 5/8 55 12 2395 47.8 53.6 59.7 66.3 73.2 80.5 88.3

100 45.2 50.7 56.5 62.7 69.3 76.2 83.6105 42.5 47.8 53.3 59.2 65.5 72.1 79.2

P705-(*)CS-090-2M4 06DR-724

90 55.0 62.0 69.4 77.3 85.9 94.6 104.0

1-3/8 5/8 55 12 2395 51.9 58.5 65.5 73.0 81.1 89.3 98.2

100 48.7 55.0 61.6 68.7 76.4 84.2 92.7105 45.6 51.6 57.9 64.6 71.7 79.3 87.5

P705-(*)CS-100-2M4 06DR-228

90 67.8 75.9 84.5 93.6 103.4 113.3 123.9

1-5/8 7/8 55 14 2895 64.2 71.9 80.0 88.6 97.9 107.3 117.4

100 60.5 67.8 75.5 83.7 92.5 101.4 111.1105 57.0 63.9 71.2 79.0 87.2 95.9 105.3

P705-(*)CS-150-2M4 06DM-337

90 84.4 94.9 106.2 118.3 130.8 144.9 159.4

1-5/8 7/8 72 16 3295 79.6 89.6 100.3 111.7 123.5 136.8 150.6

100 74.8 84.3 94.3 105.1 116.5 129.0 142.2105 70.1 79.1 88.6 98.9 109.8 121.6 134.3

P705-(*)CS-200-2M4 06EM-150

90 98.4 111.9 126.2 141.4 157.8 174.1 191.7

2-1/8 7/8 72 20 4295 91.7 104.5 118.1 132.4 148.0 163.5 180.3

100 85.1 97.3 110.2 123.7 138.5 153.3 169.4105 78.7 90.3 102.5 115.5 129.0 143.8 159.4

P705-OCS-250-2M4 06EA-265

90 130.3 149.5 169.8 191.2 213.9 237.2 261.9

2-1/8 1-1/8 94 25 5095 120.5 138.9 158.3 178.6 200.2 222.4 246.0

100 110.8 128.3 146.8 166.2 186.9 208.1 230.8105 101.2 118.0 135.6 154.2 173.7 194.6 216.6

P705-OCS-300-2M4 06EM-175

90 155.9 176.5 198.4 221.5 246.2 271.8 292.7

2-1/8 1-1/8 162 48 9895 146.1 165.6 186.3 208.1 231.5 255.7 275.8

100 136.4 154.9 174.4 195.1 217.3 240.3 259.8105 126.9 144.5 163.1 182.8 203.6 226.0 245.2

P705-OCS-400-2M4 06EM-199

90 254.3 274.7 296.5 319.6 345.3 370.0 397.4

2-1/8 1-1/8 162 48 9895 236.5 255.9 276.4 298.1 322.7 345.5 371.3

100 218.0 236.3 255.6 276.1 299.6 321.0 345.3105 199.1 216.4 234.7 254.2 274.9 296.8 320.2

P705-OCS-502-2M4 06EA-265

90 260.6 299.0 339.6 382.4 427.8 474.4 523.8

(2) 2-1/8 (2) 1-1/8 (2) 94 (2) 25 (2) 5095 241.0 277.8 316.6 357.2 400.4 444.8 492.0

100 221.6 256.6 293.6 332.4 373.8 416.2 461.6105 202.4 236.0 271.2 308.4 347.4 389.2 433.2

P705-OCS-602-2M4 06EM-175

90 311.8 353.0 396.8 443.0 492.4 543.6 585.4

(2) 2-1/8 (2) 1-1/8 (2) 128 (2) 33 (2) 6795 292.2 331.2 372.6 416.2 463.0 511.4 551.6

100 272.8 309.8 348.8 390.2 434.6 480.6 519.6105 253.8 289.0 326.2 365.6 407.2 452.0 490.4

P705-OCS-802-2M4 06EM-199

90 508.6 549.4 593.0 639.2 690.6 740.0 794.8

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 48 (2) 9895 473.0 511.8 552.8 596.2 645.4 691.0 742.6

100 436.0 472.6 511.2 552.2 599.2 642.0 690.6105 398.2 432.8 469.4 508.4 549.8 593.6 640.4

913


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — CARLYLE COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 020 to 602) R-22P705-ICS Indoor Air-Cooled (Sizes 020 to 200) Low Temperature


PARTNUMBER*

CARLYLENUMBER

AMBIENTTEMP (°F)


(lbs)

REFRIGERATIONCHARGE (lbs)

–30 –25 –20 –15 –10 –5 0 Suction Liquid Summer Winter

P705-(*)CS-020-2L2 06DR-109

90 7.0 8.5 10.1 11.8 13.6 15.5 17.6

7/8 3/8 17 3.9 6.895 6.4 7.9 9.5 11.1 12.9 14.8 16.8

100 5.8 7.3 8.8 10.5 12.2 14.0 16.0105 5.2 6.7 8.2 9.8 11.5 13.3 15.3

P705-(*)CS-030-2L2 06DR-013

90 10.8 13.1 15.4 17.8 20.3 23.1 26.0

1-1/8 1/2 17 4.8 9.195 10.1 12.3 14.6 16.9 19.4 22.1 25.0

100 9.4 11.6 13.7 16.1 18.5 21.2 24.0105 8.7 10.7 12.9 15.2 17.6 20.2 23.2

P705-(*)CS-040-2L2 06DR-316

90 13.7 16.3 19.0 21.9 24.9 28.2 31.7

1-1/8 1/2 29 7.4 1495 12.8 15.5 18.1 20.9 23.9 27.1 30.5

100 12.0 14.6 17.2 19.9 22.8 26.0 29.3105 11.3 13.7 16.3 18.9 21.8 24.9 28.3

P705-(*)CS-050-2L2 06DR-718

90 16.3 19.3 22.3 25.6 29.1 32.8 36.5

1-1/8 1/2 29 8.7 1795 15.5 18.4 21.4 24.5 28.0 31.6 35.2

100 14.6 17.5 20.4 23.4 26.7 30.4 33.9105 13.8 16.6 19.4 22.4 25.6 29.2 32.9

P705-(*)CS-060-2L2 06DR-820

90 19.2 22.6 26.0 29.7 33.6 37.9 42.6

1-3/8 1/2 29 8.7 1795 18.2 21.5 24.8 28.3 32.1 36.2 40.7

100 17.2 20.4 23.5 26.9 30.6 34.6 38.9105 16.2 19.3 22.4 25.6 29.1 33.3 37.3

P705-(*)CS-070-2L2 06DR-724

90 20.3 24.2 28.2 32.5 37.1 42.2 47.8

1-3/8 5/8 29 11 2195 19.1 22.8 26.7 30.8 35.2 40.1 45.4

100 17.9 21.5 25.1 29.0 33.3 38.0 43.2105 16.7 20.1 23.7 27.4 31.5 36.0 41.3

P705-(*)CS-080-2L2 06DR-228

90 24.9 29.5 34.4 39.6 45.3 51.6 58.4

1-5/8 5/8 62 13 2695 23.4 27.8 32.5 37.5 43.0 49.1 55.6

100 21.8 26.1 30.6 35.4 40.7 46.6 52.9105 20.2 24.3 28.6 33.3 38.5 44.2 50.8

P705-(*)CS-100-2L2 06DR-337

90 32.6 39.5 46.6 53.9 61.8 70.7 79.2

1-5/8 7/8 62 16 3195 30.4 37.1 44.0 51.3 59.0 67.2 76.0

100 27.9 34.6 41.4 48.5 56.1 64.2 72.8105 25.5 31.9 38.6 45.7 53.2 61.2 70.2

P705-(*)CS-150-2L2 06ER-150

90 39.8 49.2 58.8 69.0 79.9 91.5 104.0

2-1/8 7/8 81 18 3695 36.4 45.5 55.0 65.0 75.6 87.1 99.3

100 32.8 41.7 51.1 60.9 71.3 82.5 94.5105 29.0 37.8 47.0 56.7 66.9 78.0 90.6

P705-(*)CS-200-2L2 06ER-165

90 49.5 61.1 73.0 85.6 99.1 113.7 129.5

2-1/8 7/8 81 22 4795 45.3 56.5 68.2 80.4 93.6 107.8 123.2

100 41.0 51.9 63.2 75.2 88.0 101.9 117.1105 36.5 47.2 58.3 70.0 82.6 96.3 111.9

P705-OCS-250-2L2 06ER-175

90 62.4 75.3 88.1 101.7 116.3 132.0 148.5

2-1/8 1-1/8 106 27 5695 58.4 71.0 83.6 96.9 111.2 126.5 142.7

100 54.2 66.6 78.9 92.0 105.9 121.0 136.8105 50.2 62.0 74.2 87.0 100.7 115.5 132.1

P705-OCS-300-2L2 06ER-099

90 77.0 93.1 109.4 126.8 146.4 166.7 187.6

2-1/8 1-1/8 144 37 7595 72.0 87.6 103.5 120.3 138.4 159.2 179.4

100 66.8 82.0 97.4 113.8 131.4 150.6 171.4105 61.7 76.4 91.5 107.4 124.6 143.4 164.6

P705-OCS-402-2L2 06ER-165

90 99.0 122.2 146.0 171.2 198.2 227.4 259.0

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 21 (2) 4095 90.6 113.0 136.4 160.8 187.2 215.6 246.4

100 82.0 103.8 126.4 150.4 176.0 203.8 234.2105 73.0 94.4 116.6 140.0 165.2 192.6 223.8

P705-OCS-502-2L2 06ER-175

90 124.8 150.6 176.2 203.4 232.6 264.0 297.0

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 116.8 142.0 167.2 193.8 222.4 253.0 285.4

100 108.4 133.2 157.8 184.0 211.8 242.0 273.6105 100.4 124.0 148.4 174.0 201.4 231.0 264.2

P705-OCS-602-2L2 06ER-099

90 154.0 186.2 218.8 253.6 292.8 333.4 375.2

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 37 (2) 7595 144.0 175.2 207.0 240.6 276.8 318.4 358.8

100 133.6 164.0 194.8 227.6 262.8 301.2 342.8105 123.4 152.8 183.0 214.8 249.2 286.8 329.2

914


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — CARLYLE 2-STAGE COMPRESSORSP705-OCS Outdoor Air-Cooled (Sizes 040 to 602) R-22P705-ICS Indoor Air-Cooled (Sizes 040 to 200) Low Temperature


PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)


(lbs)


–40 –35 –30 –25 –20 Suction Liquid Summer Winter

P705-(*)CS-040-2T2 06CC-016

90 11.1 13.5 16.1 19.0 22.2

1-1/8 1/2 29 7.4 1495 10.6 13.0 15.6 18.5 21.6

100 10.0 12.4 15.0 17.9 21.0105 9.4 11.8 14.4 17.3 20.4

P705-(*)CS-050-2T2 06CC-018

90 15.9 18.2 21.0 23.9 27.2

1-3/8 1/2 29 8.7 1795 15.6 17.9 20.6 23.5 26.8

100 15.1 17.4 20.1 23.1 26.3105 14.8 16.9 19.7 22.6 25.8

P705-(*)CS-070-2T2 06CC-124

90 17.0 19.5 22.5 25.7 29.2

1-3/8 5/8 29 11 2195 16.9 19.4 22.4 25.6 29.1

100 16.8 19.3 22.2 25.4 28.9105 16.7 19.2 22.1 25.3 28.7

P705-(*)CS-080-2T2 06CC-228

90 20.3 23.4 26.9 30.8 34.9

1-3/8 5/8 29 11 2195 20.2 23.3 26.8 30.5 34.8

100 20.1 23.2 26.7 30.3 34.6105 20.0 22.9 26.5 30.1 34.4

P705-(*)CS-100-2T2 06CC-337

90 27.3 31.9 36.5 41.7 47.4

1-5/8 7/8 62 13 2695 27.2 31.4 36.3 41.4 47.1

100 27.0 31.3 36.1 41.2 46.9105 26.9 31.2 35.9 41.0 46.6

P705-(*)CS-150-2T2 06CC-550

90 36.6 43.6 51.5 60.4 70.4

1-5/8 7/8 81 18 3695 35.5 42.4 50.1 58.8 68.7

100 34.3 41.1 48.7 57.3 67.0105 33.1 39.9 47.3 55.8 65.3

P705-(*)CS-200-2T2 06CC-665

90 49.6 56.8 65.2 74.2 84.2

1-5/8 7/8 81 22 4795 49.3 56.5 65.0 74.0 83.9

100 49.1 56.3 64.7 73.7 83.7105 48.5 56.2 64.4 73.4 83.4

P705-(*)CS-250-2T2 06CC-675

90 55.5 64.4 73.8 84.3 95.9

1-5/8 1-1/8 106 27 5695 55.2 63.9 73.4 83.7 95.3

100 54.8 63.5 72.9 83.2 94.7105 54.3 63.1 72.4 82.7 94.1

P705-OCS-300-2T2 06CC-899

90 71.3 81.5 94.0 107.4 122.3

1-5/8 1-1/8 106 37 7595 70.9 81.0 93.4 106.8 121.6

100 70.5 80.4 92.8 106.1 120.8105 69.2 80.3 92.3 105.5 120.2

P705-OCS-402-2T2 06CC-665

90 99.2 113.6 130.4 148.4 168.4

(2) 1-5/8 (2) 1-1/8 (2) 106 (2) 21 (2) 4095 98.6 113.0 130.0 148.0 167.8

100 98.2 112.6 129.4 147.4 167.4105 97.0 112.4 128.8 146.8 166.8

P705-OCS-502-2T2 06CC-675

90 111.0 128.8 147.6 168.6 191.8

(2) 1-5/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 110.4 127.8 146.8 167.4 190.6

100 109.6 127.0 145.8 166.4 189.4105 108.6 126.2 144.8 165.4 188.2

P705-OCS-602-2T2 06CC-899

90 142.6 163.0 188.0 214.8 244.6

(2) 1-5/8 (2) 1-1/8 (2) 106 (2) 37 (2) 7595 141.8 162.0 186.8 213.6 243.2

100 141.0 160.8 185.6 212.2 241.6105 138.4 160.6 184.6 211.0 240.4

915


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — CARLYLE COMPRESSORSP705-OCS Outdoor Air-Cooled (Sizes 020 to 602) R-404A & R-507P705-ICS Indoor Air-Cooled (Sizes 020 to 200) Low Temperature

LEGEND




PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)


(lbs)


–40 –35 –30 –25 –20 –15 –10 –5 0 Suction Liquid Summer Winter

P705-(*)CS-020-2L4 06DR-109

90 6.4 7.6 8.8 10.3 11.8 13.5 15.4 17.4 19.6

7/8 3/8 15 4.3 8.195 6.0 7.1 8.3 9.7 11.2 12.8 14.5 16.5 18.6

100 5.6 6.7 7.9 9.1 10.5 12.1 13.7 15.6 17.5105 5.3 6.3 7.4 8.6 9.9 11.3 12.9 14.6 16.5

P705-(*)CS-030-2L4 06DR-013

90 7.1 8.7 10.6 12.7 15.0 17.5 20.3 23.3 26.5

1-1/8 1/2 15 4.3 8.195 6.5 8.0 9.8 11.7 13.9 16.3 18.9 21.7 24.8

100 5.9 7.3 9.0 10.8 12.8 15.1 17.6 20.2 23.1105 5.3 6.6 8.2 9.9 11.8 13.9 16.2 18.7 21.5

P705-(*)CS-040-2L4 06DR-316

90 11.0 13.3 15.8 18.5 21.5 24.7 28.1 31.8 35.7

1-1/8 1/2 25 6.6 1295 10.2 12.4 14.7 17.3 20.1 23.2 26.5 30.0 33.7

100 9.4 11.4 13.7 16.1 18.8 21.7 24.8 28.2 31.8105 8.5 10.5 12.6 15.0 17.5 20.3 23.2 26.4 29.9

P705-(*)CS-050-2L4 06DR-718

90 14.2 16.9 19.8 23.0 26.3 29.9 33.8 37.9 42.4

1-3/8 1/2 25 7.7 1595 13.3 15.9 18.7 21.7 24.9 28.3 32.0 36.0 40.2

100 12.3 14.9 17.5 20.4 23.4 26.7 30.2 34.0 38.1105 11.5 13.8 16.3 19.0 22.0 25.1 28.5 32.1 36.0

P705-(*)CS-060-2L4 06DR-820

90 15.1 18.2 21.4 25.0 28.8 32.9 37.3 42.0 47.0

1-3/8 1/2 25 7.7 1595 14.1 17.0 20.1 23.5 27.1 31.0 35.2 39.6 44.4

100 13.0 15.8 18.7 21.9 25.4 29.1 33.1 37.3 41.9105 11.9 14.6 17.4 20.4 23.7 27.2 31.0 35.1 39.5

P705-(*)CS-070-2L4 06DR-724

90 15.7 19.2 22.9 26.9 31.3 36.0 41.0 46.3 52.0

1-3/8 5/8 25 9.3 1995 14.4 17.8 21.3 25.1 29.3 33.8 38.6 43.6 49.1

100 13.2 16.3 19.7 23.3 27.3 31.5 36.1 41.0 46.1105 11.9 14.9 18.1 21.6 25.3 29.4 33.7 38.4 43.4

P705-(*)CS-080-2L4 06DR-228

90 21.4 25.8 30.5 35.6 41.0 46.8 52.8 59.5 66.5

1-5/8 5/8 55 12 2395 19.9 24.1 28.6 33.5 38.7 44.2 50.1 56.5 63.2

100 18.2 22.3 26.7 31.3 36.3 41.7 47.3 53.4 59.8105 16.4 20.4 24.7 29.2 34.0 39.1 44.5 50.3 56.5

P705-(*)CS-100-2L4 06DR-337

90 31.2 36.2 41.5 47.3 53.6 60.5 67.9 76.0 84.6

1-5/8 7/8 55 14 2895 29.3 34.1 39.1 44.5 50.5 57.0 64.0 71.6 79.7

100 27.5 32.0 36.7 41.8 47.4 53.5 60.1 67.2 74.9105 25.8 29.9 34.3 39.2 44.4 50.1 56.3 63.1 70.5

P705-(*)CS-150-2L4 06ER-150

90 36.5 44.8 53.6 63.0 73.0 83.7 95.0 106.9 119.6

2-1/8 7/8 72 16 3295 33.3 41.3 49.8 58.9 68.5 78.8 89.6 101.1 113.2

100 30.0 37.7 45.9 54.7 63.9 73.8 84.2 95.2 106.9105 26.6 34.0 42.0 50.4 59.3 68.8 78.8 89.5 100.8

P705-(*)CS-200-2L4 06ER-165

90 46.5 55.6 65.5 76.2 87.9 100.4 114.5 128.1 143.3

2-1/8 7/8 72 20 4295 42.6 51.2 60.6 70.7 81.7 93.5 106.8 119.8 134.2

100 38.7 46.9 55.7 65.3 75.7 86.8 99.4 111.7 125.5105 35.0 42.6 51.0 60.1 69.9 80.5 91.9 104.2 117.5

P705-OCS-250-2L4 06ER-175

90 52.1 64.0 76.6 90.2 104.8 120.5 137.6 155.3 174.4

2-1/8 1-1/8 94 25 5095 47.8 59.3 71.3 84.3 98.3 113.3 129.6 146.5 164.7

100 43.4 54.3 65.9 78.3 91.7 106.0 121.6 137.7 155.2105 39.1 49.4 60.4 72.3 85.1 98.8 113.4 129.1 145.9

P705-OCS-300-2L4 06ER-099

90 72.3 85.6 99.6 114.7 130.9 148.2 166.5 186.2 207.0

2 1/8 1 1/8 94 33 6795 66.8 79.5 92.9 107.2 122.6 139.1 156.6 175.2 194.9

100 61.2 73.3 86.1 99.8 114.4 130.0 146.9 164.4 183.3105 55.7 67.2 79.4 92.4 106.4 121.3 137.2 154.2 172.4

P705-OCS-402-2L4 06ER-165

90 93.0 111.2 131.0 152.4 175.8 200.8 229.0 256.2 286.6

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 19 (2) 3695 85.2 102.4 121.2 141.4 163.4 187.0 213.6 239.6 268.4

100 77.4 93.8 111.4 130.6 151.4 173.6 198.8 223.4 251.0105 70.0 85.2 102.0 120.2 139.8 161.0 183.8 208.4 235.0

P705-OCS-502-2L4 06ER-175

90 104.2 128.0 153.2 180.4 209.6 241.0 275.2 310.6 348.8

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 25 (2) 5095 95.6 118.6 142.6 168.6 196.6 226.6 259.2 293.0 329.4

100 86.8 108.6 131.8 156.6 183.4 212.0 243.2 275.4 310.4105 78.2 98.8 120.8 144.6 170.2 197.6 226.8 258.2 291.8

P705-OCS-602-2L4 06ER-099

90 144.6 171.2 199.2 229.4 261.8 296.4 333.0 372.4 414.0

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 33 (2) 6795 133.6 159.0 185.8 214.4 245.2 278.2 313.2 350.4 389.8

100 122.4 146.6 172.2 199.6 228.8 260.0 293.8 328.8 366.6105 111.4 134.4 158.8 184.8 212.8 242.6 274.4 308.4 344.8

916


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORSP705-OCS Outdoor Air-Cooled (Sizes 008 to 802) R-22P705-ICS Indoor Air-Cooled (Sizes 008 to 200) High Temperature

LEGENDMBTUH — Btuh in thousands*Use I for indoor units and O for outdoor units.

PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)


(lbs)


0 5 10 15 20 25 30 35 40 45 Suction Liquid Summer Winter

P705-(*)CS-008-1H2 KAN2-0075

90 3.7 4.2 4.8 5.4 6.1 6.9 7.7 8.6 9.5 10.5

5/8 3/8 17 1.9 2.695 3.5 4.0 4.6 5.2 5.9 6.6 7.4 8.2 9.1 10.1

100 3.3 3.8 4.3 4.9 5.6 6.2 7.0 7.8 8.7 9.6105 3.1 3.6 4.1 4.7 5.3 6.0 6.7 7.5 8.3 9.2

P705-(*)CS-010-1H2 KAR2-0100

90 5.2 5.9 6.7 7.6 8.5 9.5 10.6 11.8 13.0 14.2

5/8 3/8 17 1.9 2.695 5.0 5.6 6.4 7.2 8.1 9.1 10.1 11.2 12.4 13.6

100 4.7 v5.3 6.1 6.9 7.8 8.7 9.7 10.7 11.8 13.0105 4.4 5.0 5.8 6.5 7.4 v8.3 9.2 10.3 11.4 12.5

P705-(*)CS-015-1H2 KAGB-0150

90 6.5 7.4 8.4 9.5 10.7 12.0 13.5 15.1 16.8 18.5

7/8 3/8 17 2.6 4.695 6.2 7.0 7.9 9.0 10.2 11.5 12.9 14.4 16.1 17.8

100 5.9 6.6 7.5 8.5 9.7 10.9 12.3 13.8 15.4 17.0105 5.6 6.3 7.1 8.1 9.2 10.4 11.8 13.2 14.8 16.4

P705-(*)CS-020-1H2 KAKB-0200

90 9.2 10.7 12.2 13.8 15.5 17.3 19.3 21.4 23.7 26.1

7/8 3/8 17 3.9 6.895 8.8 10.2 11.7 13.3 14.9 16.6 18.6 20.6 22.8 25.1

100 8.3 9.7 11.2 12.7 14.3 15.9 17.8 19.8 21.9 24.1105 7.9 9.3 10.7 12.1 13.7 15.3 17.1 19.0 21.0 23.2

P705-(*)CS-030-1H2 ERF1-0311

90 15.7 17.8 20.1 22.6 25.3 28.0 31.2 34.4 37.9 41.7

1-1/8 1/2 17 4.8 9.195 14.9 17.0 19.2 21.6 24.2 26.9 29.9 33.1 36.5 40.1

100 14.1 16.2 18.3 20.6 23.1 25.7 28.7 31.7 35.0 38.5105 13.3 15.3 17.4 19.7 22.1 24.8 27.5 30.5 33.7 37.1

P705-(*)CS-040-1H2 NRB2-0400

90 19.0 22.7 26.5 30.4 34.4 38.5 42.9 47.4 52.2 57.3

1-1/8 1/2 29 7.4 1495 17.9 21.5 25.1 28.9 32.7 36.7 40.9 45.3 50.0 55.0

100 16.7 20.2 23.7 27.4 31.1 35.0 39.1 43.5 48.0 52.9105 15.6 19.0 22.4 26.0 29.7 33.7 37.6 41.9 46.4 51.6

P705-(*)CS-050-1H2 NRA2-0500

90 23.6 27.5 31.6 36.0 40.7 45.7 50.8 56.3 61.9 67.8

1-3/8 1/2 29 8.7 1795 22.4 26.0 30.0 34.2 38.7 43.4 48.4 53.6 59.0 64.7

100 21.0 24.6 28.3 32.4 36.7 41.3 46.1 51.1 56.4 62.0105 19.8 23.1 26.8 30.7 34.9 39.5 44.0 49.3 54.4 59.9

P705-(*)CS-060-1H2 2DD3-0500

90 28.2 32.4 36.8 41.6 46.6 52.0 57.8 63.9 70.4 77.3

1-3/8 1/2 29 8.7 1795 26.6 30.7 35.0 39.6 44.5 49.8 55.3 61.3 67.6 74.3

100 25.1 29.1 33.3 37.7 42.5 47.6 53.0 58.8 65.0 71.6105 23.6 27.5 31.6 35.9 40.6 45.7 50.9 56.6 63.0 69.6

P705-(*)CS-070-1H2 2DL3-0750

90 35.9 41.2 46.7 52.5 58.7 65.2 72.2 79.6 87.5 95.8

1-3/8 5/8 29 11 2195 34.2 39.3 44.6 50.3 56.2 62.6 69.3 76.5 84.1 92.4

100 32.5 37.4 42.6 48.1 53.8 60.0 66.5 74.0 81.5 89.6105 30.8 35.6 40.7 46.0 51.6 52.3 64.2 71.3 78.8 86.9

P705-(*)CS-080-1H2 2DA3-0750

90 41.5 47.8 54.4 61.4 68.8 76.5 84.8 93.6 102.8 112.6

1-3/8 5/8 62 13 2695 39.3 45.5 52.0 58.8 66.0 73.4 81.5 89.9 98.9 108.3

100 36.9 43.1 49.5 56.1 63.1 70.3 78.2 86.4 95.0 104.7105 34.5 40.6 46.9 53.5 60.3 67.8 75.1 83.0 91.9 100.9

P705-(*)CS-090-1H2 3DA3-0750

90 52.1 58.7 65.9 73.5 81.7 90.4 99.8 109.8 120.4 131.7

1-3/8 5/8 62 13 2695 49.9 56.3 63.2 70.6 78.5 86.9 96.1 105.8 116.1 127.1

100 47.7 53.9 60.6 67.7 75.5 83.6 92.5 102.0 112.1 122.9105 45.5 51.6 58.1 65.1 72.6 81.0 89.4 98.7 109.3 120.0

917


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 802) R-22P705-ICS Indoor Air-Cooled (Sizes 008 to 200) High Temperature

LEGEND




PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°F)


(lbs)


0 5 10 15 20 25 30 35 40 45 Suction Liquid Summer Winter

P705-(*)CS-100-1H2 3DB3-1000

90 63.0 71.0 79.3 88.1 97.5 107.0 118.5 129.9 142.2 155.2

1-3/8 7/8 62 16 3295 60.5 67.8 76.2 84.7 93.8 103.0 114.1 125.3 137.2 150.0

100 57.9 65.0 73.2 81.4 90.3 99.1 110.0 120.9 132.6 145.1105 55.4 62.3 70.2 78.2 86.9 95.9 106.1 116.9 128.5 140.9

P705-(*)CS-150-1H2 3DS3-1500

90 83.3 93.7 105.4 117.3 130.0 142.6 157.2 172.4 188.7 206.0

1-5/8 7/8 81 18 3695 80.4 91.0 101.7 113.2 125.4 137.4 152.3 167.1 182.9 199.8

100 78.1 87.9 98.2 109.2 121.0 132.6 147.0 161.4 176.8 193.2105 74.8 85.0 95.0 105.7 117.0 128.8 142.3 156.3 171.3 187.5

P705-(*)CS-200-1H2 4DA3-2000

90 86.9 98.7 111.2 124.6 139.2 154.1 171.8 189.8 205.4 225.3

1-5/8 7/8 81 22 4795 84.2 95.5 107.4 120.3 134.2 148.4 165.2 182.5 197.4 216.7

100 81.5 92.2 103.6 115.8 129.0 142.5 158.6 175.1 189.7 208.4105 78.7 88.7 99.4 111.1 123.6 137.1 152.0 167.9 183.5 200.6

P705-OCS-250-1H2 4DH3-2500

90 111.9 126.7 143.4 161.6 181.4 202.2 224.2 246.9 266.8 290.0

2-1/8 1-1/8 106 27 5695 107.0 121.1 137.1 154.7 173.7 193.7 215.1 237.1 258.8 279.4

100 102.0 115.5 130.8 147.7 166.0 185.5 206.2 227.7 251.2 269.8105 97.0 109.9 124.6 140.9 158.7 178.3 199.1 220.2 242.1 261.1

P705-OCS-300-1H2 4DJ3-3000

90 132.4 150.5 169.6 190.2 212.3 234.6 260.6 286.6 314.0 342.7

2-1/8 1-1/8 106 37 7595 127.5 144.7 162.9 182.7 203.9 225.3 250.5 275.7 302.3 330.2

100 122.5 138.8 156.2 175.2 195.5 216.1 240.5 265.0 291.0 318.4105 117.9 133.0 149.6 167.7 187.3 208.0 231.0 255.0 280.6 307.7

P705-OCS-350-1H2 6DH3-3500

90 170.7 191.8 214.1 238.2 264.1 289.8 321.8 354.4 388.8 425.5

2-1/8 1-1/8 144 54 11095 164.5 184.8 206.1 229.2 254.0 278.7 309.3 340.5 373.6 408.9

100 158.1 177.6 198.1 220.2 244.1 267.9 297.1 327.2 359.1 393.4105 151.1 170.6 190.3 211.6 234.5 258.9 286.1 314.9 346.0 379.4

P705-OCS-400-1H2 6DJ3-4000

90 204.0 230.1 257.2 286.3 317.2 347.6 384.3 421.0 459.4 499.6

2-1/8 1-1/8 144 54 11095 196.9 221.9 247.9 275.8 305.4 334.5 369.8 405.2 442.2 481.2

100 189.9 213.8 238.8 265.5 293.9 322.1 355.9 390.2 426.1 464.0105 183.6 205.9 229.9 255.6 283.0 311.7 343.3 376.3 411.4 448.7

P705-OCS-502-1H2 4DH3-2500

90 223.8 253.4 286.8 323.2 362.8 404.4 448.4 493.8 533.6 580.0

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 214.0 242.2 274.2 309.4 347.4 387.4 430.2 474.2 517.6 558.8

100 204.0 231.0 261.6 295.4 332.0 371.0 412.4 455.4 502.4 539.6105 194.0 219.8 249.2 281.8 317.4 356.6 398.2 440.4 484.2 522.2

P705-OCS-602-1H2 4DJ3-3000

90 264.8 301.0 339.2 380.4 424.6 469.2 521.2 573.2 628.0 685.4

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 37 (2) 7595 255.0 289.4 325.8 365.4 407.8 450.6 501.0 551.4 604.6 660.4

100 245.0 277.6 312.4 350.4 391.0 432.2 481.0 530.0 582.0 636.8105 235.8 266.0 299.2 335.4 374.6 416.0 462.0 510.0 561.2 615.4

P705-OCS-702-1H2 6DH3-3500

90 341.4 383.6 428.2 476.4 528.2 579.6 643.6 708.8 777.6 851.0

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 54 (2) 11095 329.0 369.6 412.2 458.4 508.0 557.4 618.6 681.0 747.2 817.8

100 316.2 355.2 396.2 440.4 488.2 535.8 594.2 654.4 718.2 786.8105 302.2 341.2 380.6 423.2 469.0 517.8 572.2 629.8 692.0 758.8

P705-OCS-802-1H2 6DJ3-4000

90 408.0 460.2 514.4 572.6 634.4 695.2 768.6 842.0 918.8 999.2

(2) 2-1/8 (2) 1-1/8 (2) 182 (2) 54 (2) 11095 393.8 443.8 495.8 551.6 610.8 669.0 739.6 810.4 884.4 962.4

100 379.8 427.6 477.6 531.0 587.8 644.2 711.8 780.4 852.2 928.0105 367.2 411.8 459.8 511.2 566.0 623.4 686.6 752.6 822.8 897.4

918


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 802) R-404A & R-507P705-ICS Indoor Air-Cooled (Sizes 008 to 200) Medium Temperature

LEGENDMBTUH — Btuh in thousands*Use I for indoor units and O for outdoor units.

PARTNUMBER*

COPELANDNUMBER

AMBIENTTEMP (°°°°F)

SATURATED SUCTION TEMP (°°°°F) (CAPACITY MBTUH) LINE SIZESOD (in.) RECEIVER

(lbs)



P705-(*)CS-010-1M4 KARB-010E

90 5.8 6.5 7.3 8.1 8.9 9.7 10.5

5/8 3/8 15 1.7 2.695 5.4 6.1 6.9 7.6 8.4 9.2 9.9

100 5.1 5.7 6.4 7.1 7.9 8.6 9.3105 4.7 5.3 6.0 6.7 7.4 8.0 8.7

P705-(*)CS-015-1M4 KAKB-021E

90 9.5 10.6 11.8 13.0 14.4 16.0 17.8

7/8 3/8 15 2.3 4.195 9.0 10.0 11.1 12.2 13.6 15.0 16.8

100 8.4 9.4 10.4 11.5 12.8 14.1 15.8105 7.9 8.8 9.7 10.7 11.9 13.2 14.8

P705-(*)CS-020-1M4 ERCA-021E

90 12.1 13.6 15.3 17.0 19.0 21.0 23.3

7/8 3/8 15 4.3 6.295 11.3 12.7 14.3 15.9 17.8 19.7 21.8

100 10.4 11.8 13.3 14.8 16.5 18.4 20.4105 9.6 11.0 12.3 13.8 15.3 17.1 19.1

P705-(*)CS-030-1M4 ERFA-031E

90 17.3 19.5 21.8 24.2 27.1 29.7 32.8

1-1/8 1/2 15 3.5 8.195 16.2 18.3 20.5 22.8 25.2 27.9 30.8

100 15.1 17.1 19.1 21.3 23.6 26.2 28.9105 14.0 15.9 17.8 19.9 22.1 24.5 27.1

P705-(*)CS-040-1M4 NRB2-040E

90 22.5 25.6 28.9 32.3 36.3 40.0 44.2

1-1/8 1/2 29 7.4 1495 20.9 23.8 26.9 30.2 33.6 37.4 41.3

100 19.3 22.1 25.0 28.1 31.3 34.8 38.6105 17.8 20.4 23.2 26.1 29.1 32.5 36.0

P705-(*)CS-050-1M4 2DC3-050E

90 26.3 29.7 33.4 37.3 41.5 45.9 50.5

1-3/8 1/2 25 7.7 1595 24.8 27.9 31.4 35.1 39.0 43.1 47.5

100 23.2 26.2 29.4 32.9 36.5 40.4 44.6105 21.7 24.5 27.6 30.8 34.3 38.1 42.0

P705-(*)CS-060-1M4 2DD3-050E

90 31.3 35.2 39.3 43.8 48.6 53.6 58.8

1-3/8 1/2 25 7.7 1595 29.5 33.1 37.1 41.3 45.7 50.5 55.4

100 27.8 31.2 34.8 38.8 43.0 47.5 52.1105 26.1 29.2 32.7 36.4 40.4 44.6 49.1

P705-(*)CS-070-1M4 2DL3-075E

90 38.8 43.4 48.4 53.6 59.2 65.1 71.3

1-3/8 5/8 25 9.3 1995 36.7 41.0 45.7 50.6 55.9 61.5 67.3

100 34.6 38.7 43.1 47.8 52.7 58.0 63.5105 32.6 36.4 40.6 45.0 49.7 54.7 60.1

P705-(*)CS-080-1M4 2DA3-075E

90 47.5 53.0 58.9 65.2 71.8 79.1 86.8

1-3/8 5/8 55 12 2395 45.0 50.2 55.7 61.7 67.9 74.8 82.0

100 42.4 47.4 52.6 58.2 64.1 70.5 77.3105 39.9 44.6 49.5 54.8 60.4 66.5 72.9

P705-(*)CS-090-1M4 3DA3-075E

90 54.0 60.3 67.0 74.2 82.2 89.9 98.2

1-3/8 5/8 55 12 2395 51.5 57.4 63.7 70.5 78.1 85.1 93.0

100 49.1 54.6 60.6 66.9 73.5 80.7 88.1105 46.6 51.9 57.5 63.5 69.8 76.5 83.6

P705-(*)CS-100-1M4 3DB3-100E

90 65.0 72.3 80.0 88.1 96.7 105.9 115.4

1-3/8 7/8 55 14 2895 61.8 68.6 75.9 83.6 91.6 100.2 109.3

100 58.5 65.0 71.9 79.1 86.7 94.8 103.4105 55.3 61.5 68.0 74.9 82.1 89.8 98.0

919


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 802) R-404A & R-507P705-ICS Indoor Air-Cooled (Sizes 008 to 200) Medium Temperature

LEGENDMBTUH — Btuh in thousands

*Use I for indoor units and O for outdoor units.NOTE: Units 502 through 802 have dual compressors.

PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-150-1M4 3DS3-150E

90 89.2 99.1 109.7 120.9 133.7 145.5 158.8

1-5/8 7/8 72 16 3295 84.7 94.0 104.0 114.6 125.7 137.7 150.2

100 80.2 89.1 98.4 108.4 118.8 130.1 142.0105 75.9 84.3 93.2 102.6 112.6 123.2 134.4

P705-(*)CS-200-1M4 4DA3-200E

90 92.1 103.0 114.8 127.3 140.8 154.2 168.4

1-5/8 7/8 72 20 4295 86.1 96.4 107.5 119.2 131.9 144.6 158.0

100 80.2 89.9 100.3 111.4 123.3 135.4 148.2105 74.6 83.7 93.5 104.0 115.1 126.8 139.0

P705-OCS-250-1M4 4DH3-250E

90 120.1 134.2 149.5 165.8 182.9 201.0 219.3

2-1/8 1-1/8 94 25 5095 113.7 126.8 141.2 156.7 172.7 189.9 207.4

100 107.2 119.6 133.1 147.8 163.0 179.4 196.0105 100.9 112.5 125.4 139.3 154.0 169.5 185.5

P705-OCS-300-1M4 4DJ3-300E

90 143.2 160.1 178.1 197.2 217.1 238.4 260.4

2-1/8 1-1/8 128 33 6795 135.5 151.3 168.2 186.1 204.8 224.9 245.7

100 127.9 142.7 158.5 175.3 192.9 211.9 231.6105 120.5 134.3 149.1 165.0 181.7 199.6 218.4

P705-OCS-350-1M4 6DH3-350E

90 185.1 206.4 229.2 253.8 279.6 307.9 337.5

2-1/8 1-1/8 128 48 9895 175.0 195.2 216.8 240.0 264.3 290.9 318.8

100 164.9 184.0 204.4 226.2 249.1 274.2 300.5105 154.9 173.0 192.2 212.8 234.9 258.1 283.0

P705-OCS-400-1M4 6DJ3-400E

90 216.4 240.5 266.3 293.6 322.2 352.8 384.4

2-1/8 1-1/8 162 48 9895 204.9 227.7 252.1 277.9 304.9 333.8 363.7

100 193.6 215.1 238.0 262.4 287.9 315.3 343.6105 182.4 202.7 224.4 247.4 271.8 297.6 324.6

P705-OCS-502-1M4 4DH3-250E

90 240.2 268.4 299.0 331.6 365.8 402.0 438.6

(2) 2-1/8 (2) 1-1/8 (2) 94 2 (25) 2 (50)95 227.4 253.6 282.4 313.4 345.4 379.8 414.8

100 214.4 239.2 266.2 295.6 326.0 358.8 392.0105 201.8 225.0 250.8 278.6 308.0 339.0 371.0

P705-OCS-602-1M4 4DJ3-300E

90 286.4 320.2 356.2 394.4 434.2 476.8 520.8

(2) 2-1/8 (2) 1-1/8 (2) 128 2 (33) 2 (67)95 271.0 302.6 336.4 372.2 409.6 449.8 491.4

100 255.8 285.4 317.0 350.6 385.8 423.8 463.2105 241.0 268.6 298.2 330.0 363.4 399.2 436.8

P705-OCS-702-1M4 6DH3-350E

90 370.2 412.8 458.4 507.6 559.2 615.8 675.0

(2) 2-1/8 (2) 1-1/8 (2) 128 2 (48) 2 (98)95 350.0 390.4 433.6 480.0 528.6 581.8 637.6

100 329.8 368.0 408.8 452.4 498.2 548.4 601.0105 309.8 346.0 384.4 425.6 469.8 516.2 566.0

P705-OCS-802-1M4 6DJ3-400E

90 432.8 481.0 532.6 587.2 644.4 705.6 768.8

(2) 2-1/8 (2) 1-1/8 (2) 162 2 (48) 2 (98)95 409.8 455.4 504.2 555.8 609.8 667.6 727.4

100 387.2 430.2 476.0 524.8 575.8 630.6 687.2105 364.8 405.4 448.8 494.8 543.6 595.2 649.2

920


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 602) R-22P705-ICS Indoor-Air-Cooled (Sizes 008 to 220) Low Temperature

LEGEND



PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-008-1L2 KAMB-0075

90 1.7 2.1 2.5 3.0 3.5 4.0 4.7 5.3 6.0

5/8 3/8 17 1.9 2.995 1.6 2.0 2.4 2.8 3.3 3.9 4.5 5.1 5.8

100 1.5 1.9 2.2 2.7 3.2 3.7 4.2 4.8 5.5105 1.4 1.7 2.1 2.5 3.0 3.5 4.0 4.6 5.2

P705-(*)CS-010-1L2 KAJB-0100

90 2.2 2.7 3.2 3.7 4.3 5.0 5.7 6.6 7.5

5/8 3/8 17 1.9 2.995 2.1 2.5 3.0 3.5 4.1 4.8 5.5 6.3 7.1

100 1.9 2.4 2.8 3.4 3.9 4.5 5.2 6.0 6.8105 1.8 2.2 2.7 3.2 3.7 4.3 5.0 5.7 6.5

P705-(*)CS-015-1L2 KAKB-0200

90 2.7 3.2 3.8 4.4 5.1 5.9 6.8 7.8 8.9

7/8 3/8 17 2.6 4.695 2.5 3.0 3.6 4.2 4.9 5.6 6.5 7.4 8.5

100 2.3 2.8 3.4 3.9 4.6 5.3 6.1 7.0 8.1105 2.1 2.6 3.1 3.7 4.3 5.0 5.8 6.7 7.7

P705-(*)CS-020-1L2 EADA-0200

90 3.6 4.4 5.4 6.4 7.5 8.8 10.1 11.6 13.2

7/8 3/8 17 3.9 6.895 3.3 4.2 5.0 6.0 7.1 8.3 9.5 11.0 12.5

100 3.1 3.9 4.7 5.6 6.7 7.8 9.0 10.4 11.9105 2.8 3.6 4.4 5.2 6.2 7.3 8.5 9.8 11.2

P705-(*)CS-025-1L2 EAVB-0210

90 4.4 5.3 6.3 7.4 8.8 10.3 11.9 13.9 15.9

7/8 3/8 17 3.9 6.895 4.2 5.0 5.9 7.1 8.4 9.8 11.4 13.2 15.2

100 3.9 4.7 5.6 6.7 7.9 9.3 10.8 12.6 14.4105 3.7 4.4 5.2 6.3 7.4 8.8 10.2 11.8 13.6

P705-(*)CS-030-1L2 LAHA-0310

90 6.0 7.2 8.8 10.7 12.9 15.4 17.9 20.8 23.6

1-1/8 1/2 17 4.8 9.195 5.6 6.8 8.3 10.2 12.3 14.6 17.1 19.8 22.5

100 5.3 6.4 7.9 9.6 11.6 13.9 16.2 18.8 21.4105 4.8 5.9 7.3 9.0 10.9 13.0 15.3 17.7 20.2

P705-(*)CS-040-1L2 2DF3-0300

90 8.5 10.4 12.5 14.7 17.2 20.0 23.2 26.8 30.8

1-3/8 1/2 29 7.4 1495 7.8 9.7 11.6 13.8 16.2 18.9 21.9 25.3 29.2

100 7.1 8.9 10.8 12.9 15.2 17.7 20.6 23.9 27.6105 6.2 8.0 9.9 11.9 14.1 16.6 19.4 22.6 26.1

P705-(*)CS-050-1L2 2DL3-0400

90 10.1 12.3 14.8 17.6 20.8 24.2 28.1 32.1 36.2

1-3/8 1/2 29 8.7 1795 9.4 11.4 13.9 16.6 19.6 22.9 26.7 30.5 34.4

100 8.6 10.6 12.9 15.5 18.4 21.6 25.2 28.7 32.7105 7.8 9.7 11.9 14.4 17.2 20.2 23.6 27.2 31.0

P705-(*)CS-060-1L2 2DA3-0600

90 11.6 14.2 17.1 20.3 23.9 27.7 32.1 36.5 41.4

1-3/8 1/2 29 8.7 1795 10.8 13.2 16.0 19.1 22.5 26.2 30.4 34.6 39.3

100 10.0 12.3 14.8 17.8 21.0 24.6 28.6 32.7 37.3105 9.1 11.2 13.7 16.4 19.5 22.9 26.7 30.8 35.3

P705-(*)CS-070-1L2 3DA3-0600

90 14.7 17.8 21.1 24.8 28.8 33.3 38.4 43.9 49.6

1-3/8 5/8 29 11 2195 13.7 16.7 19.9 23.4 27.3 31.7 36.6 41.8 47.3

100 12.5 15.4 18.6 22.0 25.8 30.0 34.8 39.8 45.1105 11.3 14.1 17.2 20.5 24.2 28.3 32.9 37.6 42.9

921



LEGEND



NOTE: Units 442, 542 and 602 have dual compressors.

PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-080-1L2 3DB3-0750

90 19.5 23.2 27.3 31.7 36.5 41.7 47.7 54.2 61.0

1-3/8 5/8 62 13 2695 18.1 21.7 25.6 29.9 34.5 39.6 45.4 51.8 58.4

100 16.5 20.1 23.9 28.0 32.6 37.5 43.2 49.3 55.8105 15.0 18.5 22.2 26.2 30.6 35.5 41.0 46.8 53.3

P705-(*)CS-090-1L2 3DF3-0900

90 21.9 26.4 31.4 37.0 43.1 49.7 57.0 64.9 72.9

1-3/8 5/8 62 13 2695 20.6 24.8 29.6 34.9 40.8 47.2 54.4 62.1 69.9

100 19.1 23.1 27.6 32.8 38.4 44.7 51.7 59.3 66.9105 17.6 21.4 25.7 30.6 36.1 42.2 49.2 56.2 64.1

P705-(*)CS-100-1L2 3DS3-1000

90 23.7 28.7 34.1 40.1 46.5 53.6 61.4 70.0 78.7

1-3/8 7/8 62 16 3295 22.2 27.1 32.3 38.0 44.2 51.0 58.6 66.9 75.4

100 20.8 25.4 30.4 35.8 41.8 48.4 55.8 63.8 72.0105 19.4 23.7 28.4 33.6 39.4 45.7 53.0 60.3 68.7

P705-(*)CS-150-1L2 4DL3-1500

90 33.2 40.3 47.9 56.0 64.9 74.5 85.1 96.9 108.8

1-5/8 7/8 81 18 3695 30.7 37.6 44.9 52.9 61.5 70.8 81.1 92.6 104.1

100 28.2 34.8 41.9 49.6 57.9 66.9 77.0 88.2 99.4105 25.5 31.9 38.8 46.2 54.2 63.0 72.7 83.2 94.7

P705-(*)CS-220-1L2 4DT3-2200

90 39.5 48.4 57.1 66.5 76.3 86.9 98.6 112.3 127.9

2-1/8 1-1/8 81 22 4895 37.1 45.9 54.4 63.6 73.0 83.4 94.7 107.8 123.0

100 34.8 43.4 51.6 60.1 69.6 79.6 90.5 103.3 117.1105 32.5 40.6 48.6 56.8 65.5 75.1 86.3 98.0 111.9

P705-OCS-270-1L2 6DL3-2700

90 49.4 60.5 71.9 83.9 97.4 111.4 126.1 142.9 161.6

2-1/8 1-1/8 106 27 5695 46.1 57.0 68.2 79.9 92.4 106.6 120.9 137.3 155.4

100 42.6 53.2 64.1 75.6 87.7 100.9 115.6 131.3 148.9105 38.7 49.1 59.8 70.9 82.7 95.5 110.0 124.6 141.4

P705-OCS-300-1L2 6DT3-3000

90 59.2 72.3 85.3 99.6 114.5 130.7 148.7 168.7 191.7

2-1/8 1-1/8 144 37 7595 56.2 69.0 81.5 95.3 109.6 125.2 142.5 161.6 183.7

100 53.0 65.5 77.5 90.8 104.5 119.4 136.0 154.3 175.5105 49.6 61.2 72.9 85.1 98.1 113.1 128.8 146.8 167.0

P705-OCS-442-1L2 4DT3-2200

90 79.0 96.8 114.2 133.0 152.6 173.8 197.2 224.6 255.8

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 21 (2) 4195 74.2 91.8 108.8 127.2 146.0 166.8 189.4 215.6 246.0

100 69.6 86.8 103.2 120.2 139.2 159.2 181.0 206.6 234.2105 65.0 81.2 97.2 113.6 131.0 150.2 172.6 196.0 223.8

P705-OCS-542-1L2 6DL3-2700

90 98.8 121.0 143.8 167.8 194.8 222.8 252.2 285.8 323.2

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 92.2 114.0 136.4 159.8 184.8 213.2 241.8 274.6 310.8

100 85.2 106.4 128.2 151.2 175.4 201.8 231.2 262.6 297.8105 77.4 98.2 119.6 141.8 165.4 191.0 220.0 249.2 282.8

P705-OCS-602-1L2 6DT3-3000

90 118.4 144.6 170.6 199.2 229.0 261.4 297.4 337.4 383.4

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 37 (2) 7595 112.4 138.0 163.0 190.6 219.2 250.4 285.0 323.2 367.4

100 106.0 131.0 155.0 181.6 209.0 238.8 272.0 308.6 351.0105 99.2 122.4 145.8 170.2 196.2 226.2 257.6 293.6 334.0

922



LEGEND




PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-080-1L2 3DB3-0750

90 19.5 23.2 27.3 31.7 36.5 41.7 47.7 54.2 61.0

1-3/8 5/8 62 13 2695 18.1 21.7 25.6 29.9 34.5 39.6 45.4 51.8 58.4

100 16.5 20.1 23.9 28.0 32.6 37.5 43.2 49.3 55.8105 15.0 18.5 22.2 26.2 30.6 35.5 41.0 46.8 53.3

P705-(*)CS-090-1L2 3DF3-0900

90 21.9 26.4 31.4 37.0 43.1 49.7 57.0 64.9 72.9

1-3/8 5/8 62 13 2695 20.6 24.8 29.6 34.9 40.8 47.2 54.4 62.1 69.9

100 19.1 23.1 27.6 32.8 38.4 44.7 51.7 59.3 66.9105 17.6 21.4 25.7 30.6 36.1 42.2 49.2 56.2 64.1

P705-(*)CS-100-1L2 3DS3-1000

90 23.7 28.7 34.1 40.1 46.5 53.6 61.4 70.0 78.7

1-3/8 7/8 62 16 3295 22.2 27.1 32.3 38.0 44.2 51.0 58.6 66.9 75.4

100 20.8 25.4 30.4 35.8 41.8 48.4 55.8 63.8 72.0105 19.4 23.7 28.4 33.6 39.4 45.7 53.0 60.3 68.7

P705-(*)CS-150-1L2 4DL3-1500

90 33.2 40.3 47.9 56.0 64.9 74.5 85.1 96.9 108.8

1-5/8 7/8 81 18 3695 30.7 37.6 44.9 52.9 61.5 70.8 81.1 92.6 104.1

100 28.2 34.8 41.9 49.6 57.9 66.9 77.0 88.2 99.4105 25.5 31.9 38.8 46.2 54.2 63.0 72.7 83.2 94.7

P705-(*)CS-220-1L2 4DT3-2200

90 39.5 48.4 57.1 66.5 76.3 86.9 98.6 112.3 127.9

2-1/8 1-1/8 81 22 4895 37.1 45.9 54.4 63.6 73.0 83.4 94.7 107.8 123.0

100 34.8 43.4 51.6 60.1 69.6 79.6 90.5 103.3 117.1105 32.5 40.6 48.6 56.8 65.5 75.1 86.3 98.0 111.9

P705-OCS-270-1L2 6DL3-2700

90 49.4 60.5 71.9 83.9 97.4 111.4 126.1 142.9 161.6

2-1/8 1-1/8 106 27 5695 46.1 57.0 68.2 79.9 92.4 106.6 120.9 137.3 155.4

100 42.6 53.2 64.1 75.6 87.7 100.9 115.6 131.3 148.9105 38.7 49.1 59.8 70.9 82.7 95.5 110.0 124.6 141.4

P705-OCS-300-1L2 6DT3-3000

90 59.2 72.3 85.3 99.6 114.5 130.7 148.7 168.7 191.7

2-1/8 1-1/8 144 37 7595 56.2 69.0 81.5 95.3 109.6 125.2 142.5 161.6 183.7

100 53.0 65.5 77.5 90.8 104.5 119.4 136.0 154.3 175.5105 49.6 61.2 72.9 85.1 98.1 113.1 128.8 146.8 167.0

P705-OCS-442-1L2 4DT3-2200

90 79.0 96.8 114.2 133.0 152.6 173.8 197.2 224.6 255.8

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 21 (2) 4195 74.2 91.8 108.8 127.2 146.0 166.8 189.4 215.6 246.0

100 69.6 86.8 103.2 120.2 139.2 159.2 181.0 206.6 234.2105 65.0 81.2 97.2 113.6 131.0 150.2 172.6 196.0 223.8

P705-OCS-542-1L2 6DL3-2700

90 98.8 121.0 143.8 167.8 194.8 222.8 252.2 285.8 323.2

(2) 2-1/8 (2) 1-1/8 (2) 106 (2) 27 (2) 5695 92.2 114.0 136.4 159.8 184.8 213.2 241.8 274.6 310.8

100 85.2 106.4 128.2 151.2 175.4 201.8 231.2 262.6 297.8105 77.4 98.2 119.6 141.8 165.4 191.0 220.0 249.2 282.8

P705-OCS-602-1L2 6DT3-3000

90 118.4 144.6 170.6 199.2 229.0 261.4 297.4 337.4 383.4

(2) 2-1/8 (2) 1-1/8 (2) 144 (2) 37 (2) 7595 112.4 138.0 163.0 190.6 219.2 250.4 285.0 323.2 367.4

100 106.0 131.0 155.0 181.6 209.0 238.8 272.0 308.6 351.0105 99.2 122.4 145.8 170.2 196.2 226.2 257.6 293.6 334.0

923


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 602) R-404A & R-507P705-ICS Indoor-Air-Cooled (Sizes 008 to 220) Low Temperature

LEGEND



PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-008-1L4 KAMB-007E

90 2.0 2.3 2.7 3.1 3.6 4.2 4.9 5.5 6.2

5/8 3/8 15 1.7 2.695 1.9 2.1 2.5 2.9 3.4 4.0 4.6 5.2 5.8

100 1.7 2.0 2.3 2.7 3.2 3.7 4.3 4.9 5.5105 1.5 1.7 2.1 2.5 2.9 3.4 4.0 4.5 5.1

P705-(*)CS-010-1L4 KAJB-010E

90 2.5 3.0 3.6 4.2 4.8 5.5 6.2 7.0 7.9

5/8 3/8 15 1.7 2.695 2.3 2.8 3.3 3.8 4.4 5.1 5.8 6.6 7.4

100 2.1 2.5 3.0 3.5 4.1 4.7 5.4 6.1 6.8105 1.9 2.3 2.7 3.2 3.7 4.3 4.9 5.6 6.3

P705-(*)CS-015-1L4 KAKB-011E

90 2.9 3.6 4.3 4.9 5.6 6.3 7.2 8.1 9.2

5/8 3/8 15 2.3 4.195 2.6 3.3 4.0 4.6 5.2 5.9 6.6 7.5 8.6

100 2.4 3.0 3.6 4.2 4.8 5.4 6.1 7.0 8.0105 2.1 2.8 3.3 3.8 4.4 5.0 5.6 6.5 7.5

P705-(*)CS-017-1L4 KALB-015E

90 3.8 4.5 5.3 6.2 7.1 8.1 9.2 10.3 11.5

7/8 3/8 15 2.3 4.195 3.5 4.2 5.0 5.8 6.7 7.6 8.7 9.7 10.9

100 3.2 3.9 4.6 5.4 6.2 7.1 8.0 9.1 10.2105 2.9 3.5 4.2 4.9 5.7 6.6 7.5 8.5 9.5

P705-(*)CS-020-1L4 EADB-021E

90 4.4 5.2 6.1 7.2 8.4 9.8 11.3 12.8 14.5

7/8 3/8 15 3.5 6.195 3.9 4.7 5.6 6.6 7.8 9.0 10.5 11.9 13.5

100 3.6 4.3 5.1 6.0 7.1 8.3 9.5 11.0 12.5105 3.2 3.9 4.6 5.5 6.4 7.5 8.7 10.1 11.6

P705-(*)CS-025-1L4 EAVB-021E

90 5.2 6.1 7.1 8.3 9.6 11.0 12.6 14.2 16.0

7/8 3/8 15 3.5 6.195 4.7 5.6 6.6 7.7 9.0 10.3 11.8 13.3 15.0

100 4.1 5.0 6.0 7.2 8.3 9.6 11.1 12.4 14.0105 3.5 4.4 5.5 6.5 7.7 8.9 10.2 11.6 13.0

P705-(*)CS-030-1L4 LAHB-032E

90 6.7 8.4 10.2 12.3 14.5 16.8 19.4 22.0 24.8

1-1/8 1/2 15 4.3 8.195 6.0 7.6 9.4 11.3 13.4 15.6 18.1 20.5 23.1

100 5.2 6.7 8.5 10.3 12.3 14.4 16.7 19.0 21.5105 4.4 5.9 7.5 9.3 11.2 13.3 15.4 17.6 19.9

P705-(*)CS-040-1L4 2DF3-030E

90 11.0 13.0 15.2 17.6 20.2 23.0 26.2 29.4 32.9

1-3/8 1/2 25 6.6 1295 10.1 12.1 14.2 16.5 19.0 21.7 24.7 27.7 30.9

100 9.2 11.1 13.2 15.4 17.8 20.3 23.0 26.0 29.0105 8.2 10.1 12.1 14.3 16.6 19.0 21.6 24.3 27.2

P705-(*)CS-050-1L4 2DL3-040E

90 13.4 15.9 18.6 21.4 24.5 27.9 31.4 35.3 39.4

1-3/8 1/2 25 7.7 1595 12.5 14.9 17.4 20.1 23.1 26.2 29.6 33.3 37.1

100 11.5 13.8 16.2 18.8 21.6 24.6 27.8 31.3 34.9105 10.6 12.8 15.1 17.5 20.2 23.0 26.1 29.3 32.8

P705-(*)CS-060-1L4 2DA3-060E

90 15.6 18.4 21.3 24.4 27.7 31.3 35.1 39.2 43.5

1-3/8 1/2 25 7.7 1595 14.5 17.2 20.0 23.0 26.1 29.5 33.1 37.0 41.1

100 13.4 16.0 18.7 21.5 24.5 27.7 31.1 34.8 38.7105 12.3 14.8 17.4 20.1 23.0 26.0 29.3 32.7 36.5

P705-(*)CS-070-1L4 3DA3-060E

90 19.0 22.2 25.5 29.2 33.2 37.6 42.1 47.1 52.2

1-3/8 5/8 25 9.3 1995 17.9 20.9 24.2 27.7 31.5 35.6 39.9 44.6 49.5

100 16.6 19.5 22.7 26.1 29.7 33.6 37.7 42.2 46.8105 15.2 18.1 21.1 24.4 27.9 31.7 35.6 39.8 44.3

924


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSEMI-HERMETIC CONDENSING UNITS — COPELAND COMPRESSORS (cont)P705-OCS Outdoor Air-Cooled (Sizes 008 to 602) R-404A & R-507P705-ICS Indoor-Air-Cooled (Sizes 008 to 220) Low Temperature

LEGEND




PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CS-080-1L4 3DB3-075E

90 23.1 26.9 31.0 35.5 40.3 45.6 51.6 57.8 64.1

1-3/8 5/8 55 12 2395 21.6 25.5 29.5 33.8 38.4 43.4 49.1 54.9 60.8

100 20.3 24.0 27.8 32.0 36.4 41.2 46.1 51.7 57.6105 18.8 22.4 26.2 30.2 34.4 39.0 44.1 49.0 54.5

P705-(*)CS-090-1L4 3DF3-090E

90 27.2 31.9 36.8 42.2 48.0 54.2 61.1 68.1 75.7

1-3/8 5/8 55 12 2395 25.7 30.2 34.9 40.0 45.6 51.5 58.1 64.7 71.9

100 24.1 28.4 33.0 37.9 43.2 48.8 55.2 61.3 68.2105 22.5 26.7 31.0 35.8 40.8 46.2 52.0 58.2 64.7

P705-(*)CS-100-1L4 3DS3-100E

90 31.4 36.7 42.2 48.2 54.7 61.6 69.3 77.1 84.8

1-3/8 7/8 55 14 2895 29.5 34.6 39.9 45.7 51.8 58.4 65.2 72.7 80.4

100 27.5 32.5 37.6 43.1 49.0 55.2 61.7 68.8 76.1105 25.5 30.3 35.2 0.5 46.2 52.1 58.5 65.1 72.1

P705-(*)CS-150-1L4 4DL3-150E

90 43.0 50.9 58.6 66.6 74.9 83.7 93.6 104.1 114.8

1-5/8 7/8 72 16 3295 40.7 48.4 55.8 63.3 71.2 79.6 89.2 99.1 109.2

100 38.3 45.7 52.8 60.0 67.5 75.5 84.7 94.0 103.7105 35.7 42.8 49.6 56.5 63.7 71.3 79.5 88.5 98.3

P705-(*)CS-220-1L4 4DT3-220E

90 51.2 60.4 69.8 79.5 89.6 100.1 111.1 122.9 135.2

2-1/8 1-1/8 72 20 4295 47.7 56.6 65.6 74.8 84.5 94.5 104.9 116.2 127.8

100 43.9 52.5 61.2 70.2 79.5 89.1 99.1 109.8 121.0105 40.0 48.3 56.9 65.6 74.6 84.0 94.4 104.7 115.6

P705-OCS-270-1L4 6DL3-270E

90 63.3 74.3 86.1 99.0 112.8 127.6 144.1 160.2 176.1

2-1/8 1-1/8 94 25 5095 59.3 70.0 81.4 93.7 107.0 121.1 135.6 151.2 167.1

100 55.1 65.4 76.4 88.3 101.0 114.5 128.3 143.2 158.3105 50.6 60.6 71.2 82.7 95.0 107.9 121.4 135.4 149.8

P705-OCS-300-1L4 6DT3-300E

90 71.8 84.6 97.0 110.8 125.8 141.7 158.4 176.6 195.5

2-1/8 1-1/8 128 33 6795 67.1 78.9 91.3 104.6 118.7 133.8 149.6 166.7 184.5

100 62.1 73.6 85.5 98.2 111.7 126.0 140.9 157.1 173.9105 56.9 68.1 79.7 91.9 104.9 118.5 133.9 148.1 164.0

P705-OCS-442-1L4 4DT3-220E

90 102.4 120.8 139.6 159.0 179.2 200.2 222.2 245.8 270.4

(2) 2-1/8 (2) 1-1/8 (2) 94 (2) 19 (2) 3695 95.4 113.2 131.2 149.6 169.0 189.0 209.8 232.4 255.6

100 87.8 105.0 122.4 140.4 159.0 178.2 198.2 219.6 242.0105 80.0 96.6 113.8 131.2 149.2 168.0 188.8 209.4 231.2

P705-OCS-542-1L4 6DL3-270E

90 126.6 148.6 172.2 198.0 225.6 255.2 288.2 320.4 352.2

(2) 2-1/8 (2) 1-1/8 (2) 94 (2) 25 (2) 5095 118.6 140.0 162.8 187.4 214.0 242.2 271.2 302.4 334.2

100 110.2 130.8 152.8 176.6 202.0 229.0 256.6 286.4 316.6105 101.2 121.2 142.4 165.4 190.0 215.8 242.8 270.8 299.6

P705-OCS-602-1L4 6DT3-300E

90 143.6 169.2 194.0 221.6 251.6 283.4 316.8 353.2 391.0

(2) 2-1/8 (2) 1-1/8 (2) 128 (2) 33 (2) 6795 134.2 157.8 182.6 209.2 237.4 267.6 299.2 333.4 369.0

100 124.2 147.2 171.0 196.4 223.4 252.0 281.8 314.2 347.8105 113.8 136.2 159.4 183.8 209.8 237.0 267.8 296.2 328.0

925


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSCROLL COMPRESSOR CONDENSING UNITS — COPELAND SCROLL COMPRESSORSP705-OCZ Outdoor Air-Cooled Condensing Units (Sizes 015 to 100) R-22P705-ICZ Indoor-Air-Cooled Condensing Units (Sizes 015 to 100) High Temperature

LEGEND



PARTNUMBER*

COPELANDNUMBER



(lbs)



P705-(*)CZ-015-1H2 ZR18K3

90 11.0 12.3 13.7 15.0 16.7 18.4 20.2

5/8 3/8 17 2.6 4.695 10.7 12.0 13.4 14.6 16.2 17.9 19.7

100 10.4 11.6 13.0 14.1 15.8 17.4 19.1105 10.0 11.2 12.5 13.7 15.3 16.8 18.5

P705-(*)CZ-020-1H2 ZR24K3

90 15.1 17.0 18.9 20.7 23.0 25.3 27.8

5/8 3/8 17 3.9 6.895 14.6 16.4 18.3 20.0 22.2 24.5 26.9

100 14.1 15.8 17.6 19.3 21.5 23.7 26.1105 13.5 15.2 17.1 18.7 20.8 23.1 25.3

P705-(*)CZ-025-1H2 ZR30K3

90 18.7 20.8 23.2 25.7 28.1 31.0 34.1

7/8 3/8 17 3.9 6.895 18.0 20.1 22.4 24.9 27.2 30.1 33.1

100 17.3 19.4 21.6 24.0 26.4 29.1 32.1105 16.7 18.7 20.9 23.2 25.5 28.2 31.1

P705-(*)CZ-030-1H2 ZR36K3

90 22.4 25.1 27.9 30.4 33.9 37.3 40.9

7/8 1/2 17 4.8 9.195 21.5 24.1 26.9 29.4 32.8 36.1 39.6

100 20.6 23.2 25.9 28.3 31.6 34.9 38.4105 19.8 22.3 25.0 27.4 30.6 33.8 37.3

P705-(*)CZ-035-1H2 ZR42K3

90 25.9 28.9 32.3 35.2 39.2 43.2 47.5

7/8 1/2 29 7.4 1495 24.9 27.9 31.1 33.9 37.9 41.9 46.0

100 23.8 26.8 30.0 32.7 36.6 40.5 44.6105 22.8 25.7 28.8 31.7 35.4 39.2 43.2

P705-(*)CZ-040-1H2 ZR49K3

90 30.2 33.8 37.7 41.1 45.6 50.2 55.1

7/8 1/2 29 7.4 1495 28.8 32.4 36.2 39.4 43.9 48.5 53.3

100 27.3 30.9 34.7 37.9 42.3 46.9 51.6105 25.8 29.4 33.1 36.5 40.8 45.3 50.0

P705-(*)CZ-050-1H2 ZR61K3

90 37.6 42.0 46.6 50.9 56.2 61.8 67.7

7/8 1/2 29 8.7 1795 36.0 40.3 44.9 49.1 54.3 59.8 65.6

100 34.3 38.6 43.1 47.3 52.4 57.8 63.5105 32.6 36.8 41.3 45.5 50.6 55.9 61.5

P705-(*)CZ-060-1H2 ZR72KC

90 44.3 49.3 54.5 59.4 65.4 71.8 78.5

7/8 1/2 29 8.7 1795 42.7 47.5 52.6 57.4 63.3 69.6 76.2

100 41.0 45.7 50.8 55.5 61.3 67.5 74.1105 39.3 43.9 49.0 53.7 59.5 65.7 72.3

P705-(*)CZ-070-1H2 ZR84KC

90 50.0 55.9 62.3 68.2 75.5 83.2 91.3

1-1/8 5/8 29 11 2195 47.7 53.6 59.9 65.7 72.9 80.5 88.6

100 45.4 51.2 57.4 63.3 70.3 77.9 85.9105 43.0 48.8 55.0 60.9 68.0 75.5 83.6

P705-(*)CZ-080-1H2 ZR94KC

90 58.1 64.9 72.2 78.7 87.5 96.3 105.7

1-1/8 5/8 62 13 2695 55.9 62.6 69.7 76.1 84.6 93.2 102.5

100 53.6 60.1 67.1 73.2 81.5 90.2 99.2105 51.2 57.6 64.5 70.9 78.9 87.2 96.2

P705-(*)CZ-090-1H2 ZR108KC

90 67.5 75.0 83.2 90.6 99.9 109.7 120.0

1-3/8 5/8 62 13 2695 65.2 72.6 80.5 87.9 96.8 106.4 116.4

100 62.9 70.1 77.9 85.1 93.8 103.2 113.0105 60.5 67.6 75.2 82.3 91.0 100.1 109.8

P705-(*)CZ-100-1H2 ZR125KC

90 78.9 87.7 97.1 105.6 116.5 127.8 139.5

1-3/8 7/8 62 16 3295 76.1 84.8 93.9 102.2 112.8 123.9 135.4

100 73.3 81.7 90.7 98.9 109.2 120.1 131.4105 70.5 78.8 87.6 95.9 106.1 116.7 127.9

926


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSCROLL COMPRESSOR CONDENSING UNITS — COPELAND SCROLL COMPRESSORS (cont)P705-OCZ Outdoor Air-Cooled Condensing Units (Sizes 025 to 150) R-22P705-ICZ Indoor-Air-Cooled Condensing Units (Sizes 025 to 150) Medium Temperature

LEGEND



PARTNUMBER*

COPELANDNUMBER



(lbs)

REFRIGERANTCHARGE lbs)


P705-(*)CZ-025-1M2 ZB21KA

90 20.2 22.6 25.0 27.5 30.4 33.4 36.5

5/8 3/8 17 3.9 6.895 19.5 21.9 24.1 26.6 29.4 32.3 35.3

100 18.9 21.1 23.4 25.7 28.5 31.3 34.3105 18.3 20.4 22.6 24.9 27.6 30.3 33.3

P705-(*)CZ-030-1M2 ZB26KA

90 24.7 27.6 30.8 33.9 37.7 41.4 45.3

5/8 1/2 17 4.8 9.195 23.7 26.6 29.7 32.7 36.4 40.0 43.8

100 22.7 25.5 28.5 31.4 35.0 38.6 42.4105 21.7 24.4 27.4 30.4 33.8 37.3 41.0

P705-(*)CZ-035-1M2 ZB30KA

90 29.3 32.8 36.5 40.1 44.5 49.0 53.7

7/8 1/2 29 7.4 1495 28.0 31.5 35.1 38.6 42.9 47.3 51.8

100 26.7 30.1 33.6 37.1 41.3 45.6 50.0105 25.2 28.6 32.2 35.8 39.8 44.0 48.3

P705-(*)CZ-040-1M2 ZB38KA

90 35.9 40.1 44.6 48.9 54.3 59.6 65.1

7/8 1/2 29 7.4 1495 34.5 38.6 43.0 47.2 52.4 57.6 62.9

100 32.9 37.0 41.2 45.4 50.5 55.5 60.8105 31.2 35.3 39.5 43.8 48.7 53.6 58.8

P705-(*)CZ-050-1M2 ZB45KA

90 42.9 47.6 52.6 57.7 63.4 69.4 75.5

7/8 1/2 29 8.7 1795 41.3 45.9 50.8 55.9 61.3 67.1 73.1

100 39.7 44.2 49.0 53.9 59.3 65.0 71.0105 38.0 42.5 47.2 52.1 57.5 63.1 69.1

P705-(*)CZ-070-1M2 ZB56KA

90 53.2 59.4 65.9 72.2 79.3 87.3 95.8

1-3/8 5/8 29 11 2195 51.6 57.6 63.9 70.1 77.0 84.8 93.1

100 50.0 55.8 62.0 68.0 74.8 82.4 90.6105 48.4 54.1 60.1 65.8 72.8 80.2 88.4

P705-(*)CZ-090-1M2 ZB75KA

90 76.3 85.1 94.5 102.5 113.7 125.1 136.9

1-3/8 5/8 62 13 2695 73.6 82.2 91.3 99.1 110.1 121.2 132.8

100 70.9 79.3 88.2 96.0 106.6 117.5 129.0105 68.2 76.5 85.3 93.4 103.6 114.3 125.6

P705-(*)CZ-120-1M2 ZB92KA

90 97.7 107.8 118.9 128.9 142.3 156.7 171.8

1-5/8 7/8 79 21 4595 95.8 105.4 115.9 125.5 138.3 152.1 166.8

100 93.9 103.0 112.9 122.2 134.4 147.7 161.8105 92.3 100.7 110.1 119.2 130.9 143.4 157.2

P705-(*)CZ-150-1M2 ZB11MA

90 113.6 126.5 140.3 152.4 168.7 185.5 203.1

2-1/8 7/8 81 22 4795 109.5 122.1 135.5 147.3 163.2 179.6 196.9

100 105.2 117.5 130.7 142.4 157.9 174.0 191.1105 101.0 113.1 126.1 138.1 153.2 169.0 185.9

927


P705 INDOOR & OUTDOOR REFRIGERATION CONDENSING UNITSSCROLL COMPRESSOR CONDENSING UNITS — COPELAND SCROLL COMPRESSORS (cont)P705-OCZ Outdoor Air-Cooled Condensing Units (Sizes 025 to 090) R-404A & R-507P705-ICZ Indoor-Air-Cooled Condensing Units (Sizes 025 to 090) Medium Temperature

R-404A & R-507Low Temperature

LEGEND



PARTNUMBER*

COPELANDNUMBER



(lbs)


–10 –5 0 5 10 15 20 25 30 35 Suction Liquid Summer Winter

P705-(*)CZ-025-1M4 ZS21K4E

90 13.4 15.0 16.6 18.4 20.2 22.2 24.2 26.4 28.8 31.2

7/8 3/8 15 3.9 6.895 12.8 14.3 15.9 17.5 19.2 21.1 23.0 25.1 27.3 29.6

100 12.2 13.6 15.1 16.6 18.2 20.0 21.8 23.8 25.9 28.1105 11.6 12.9 14.3 15.7 17.3 18.9 20.7 22.6 24.6 26.7

P705-(*)CZ-030-1M4 ZS26K4E

90 16.7 18.7 20.7 22.8 25.1 27.6 30.1 32.9 35.8 38.8

7/8 1/2 15 4.3 8.195 16.0 17.8 19.7 21.8 23.9 26.2 28.7 31.3 34.0 36.9

100 15.2 17.1 18.7 20.6 22.7 24.9 27.1 29.7 32.3 35.0105 14.5 16.2 17.9 19.7 21.6 23.5 25.7 28.1 30.6 33.2

P705-(*)CZ-035-1M4 ZS30K4E

90 19.0 21.4 24.0 26.6 29.5 32.5 35.6 38.9 42.3 45.9

7/8 1/2 29 7.4 14.095 18.1 20.4 22.7 25.2 27.9 30.7 33.6 36.9 40.2 43.6

100 17.3 19.4 21.4 23.8 26.3 28.9 31.7 34.8 38.0 41.3105 16.7 18.3 20.4 22.5 24.7 27.1 29.8 32.7 35.8 39.0

P705-(*)CZ-040-1M4 ZS38K4E

90 23.5 26.3 29.1 32.1 35.2 38.6 42.1 45.9 49.8 53.9

7/8 1/2 29 7.4 1495 22.4 25.1 27.6 30.4 33.4 36.6 39.9 43.5 47.2 51.1

100 21.2 23.8 26.3 28.9 31.6 34.6 37.7 41.1 44.6 48.4105 20.1 22.4 24.8 27.3 30.0 32.8 35.9 38.9 42.3 45.9

P705-(*)CZ-050-1M4 ZS45K4E

90 28.4 31.6 35.0 38.6 42.3 46.3 50.1 54.9 59.1 63.9

7/8 1/2 25 7.7 1595 27.2 30.2 33.4 36.8 40.3 44.0 47.6 52.1 56.5 60.7

100 25.9 28.7 31.8 34.9 38.3 41.8 45.2 49.4 53.6 58.0105 24.4 27.3 30.1 33.1 36.3 39.6 43.1 46.9 50.9 55.1

P705-(*)CZ-070-1M4 ZS56K4E

90 33.7 37.5 41.6 45.8 50.3 55.0 59.6 64.9 70.4 76.1

1-3/8 5/8 25 9.3 1995 32.2 35.8 39.7 43.6 47.8 52.3 56.6 61.9 67.1 72.2

100 30.7 34.1 37.7 41.4 45.4 49.5 53.7 58.6 63.6 68.8105 29.0 32.3 35.7 39.2 43.0 46.9 51.1 55.6 60.3 65.4

P705-(*)CZ-090-1M4 ZS75K4E

90 47.0 52.8 58.9 65.5 72.3 79.4 86.7 94.1 101.5 109.0

1-3/8 5/8 55 12 2395 44.6 50.0 55.7 61.8 68.3 75.1 82.1 89.3 96.5 103.8

100 42.5 47.3 52.5 58.2 64.4 70.8 77.6 84.5 91.6 98.7105 40.8 44.8 49.7 54.9 60.7 66.8 73.3 80.0 86.9 93.9

PARTNUMBER

COPELANDNUMBER



(lbs)



P705-(*)CZ-025-1L4 ZF09K4E

90 6.6 7.5 8.5 9.6 10.8 12.0 13.3 14.9 16.4

7/8 3/8 15 3.5 6.195 6.2 7.1 8.1 9.1 10.3 11.5 12.7 14.2 15.6

100 5.9 6.8 7.7 8.7 9.7 10.9 12.0 13.4 14.8105 5.5 6.3 7.2 8.2 9.2 10.3 11.4 12.7 14.0

P705-(*)CZ-030-1L4 ZF11K4E

90 8.1 9.4 10.6 12.0 13.4 15.0 16.6 18.6 20.5

7/8 1/2 15 4.3 8.195 7.8 9.0 10.2 11.4 12.8 14.3 15.8 17.7 19.6

100 7.4 8.5 9.7 10.9 12.2 13.6 15.0 16.8 18.6105 7.0 8.1 9.1 10.3 11.5 12.9 14.2 15.9 17.5

P705-(*)CZ-035-1L4 ZF13K4E

90 9.4 10.8 12.2 13.8 15.5 17.4 19.2 21.6 24.0

7/8 1/2 25 6.6 12.095 9.0 10.3 11.7 13.2 14.8 16.6 18.3 20.6 22.8

100 8.6 9.8 11.1 12.5 14.0 15.7 17.3 19.4 21.5105 8.2 9.3 10.5 11.8 13.2 14.8 16.4 18.3 20.3

P705-(*)CZ-040-1L4 ZF15K4E

90 11.3 13.0 14.8 16.7 18.7 20.9 23.1 25.8 28.6

7/8 1/2 25 6.6 12.095 10.8 12.5 14.1 15.9 17.8 19.9 21.9 24.5 27.0

100 10.3 11.9 13.4 15.1 16.8 18.8 20.7 23.1 25.5105 9.8 11.1 12.7 14.2 15.9 17.7 19.6 21.7 24.0

P705-(*)CZ-050-1L4 ZF18K4E

90 14.0 15.9 18.1 20.3 22.8 25.5 28.2 31.5 34.9

7/8 1/2 25 7.7 15.095 13.2 15.1 17.2 19.3 21.7 24.3 26.8 29.9 33.2

100 12.5 14.3 16.2 18.3 20.6 23.0 25.4 28.3 31.4105 11.8 13.3 15.3 17.2 19.4 21.7 24.0 26.8 29.6

P705-(*)CZ-070-1L4 ZF24K4E

90 16.3 18.6 21.2 24.0 26.9 30.1 33.4 37.1 41.1

1-3/8 5/8 25 9.3 19.095 15.5 17.8 20.3 22.9 25.7 28.7 31.9 35.3 39.1

100 14.7 16.9 19.3 21.8 24.4 27.2 30.2 33.4 37.0105 13.7 16.0 18.2 20.6 23.1 25.8 28.5 31.7 34.9

P705-(*)CZ-090-1-L4 ZF33K4E

90 23.8 27.3 30.6 34.6 38.6 43.4 47.8 53.2 58.8

1-3/8 5/8 55 12.0 23.095 22.7 26.0 29.3 33.0 36.9 41.2 45.4 50.9 55.8

100 21.6 24.7 27.8 31.3 35.0 39.0 43.0 48.1 53.1105 20.6 23.4 26.4 29.6 33.1 36.9 40.8 45.4 50.1

928


COPELAND AB SERIES HERMETIC AIR-COOLED CONDENSING UNITS —LIGHT COMMERCIAL HERMETIC UNITSAB INDOOR AIR-COOLED HERMETIC CONDENSING UNIT FEATURES

• Ideal for display cases, reach-in coolers, and freezer applications.• Compact coil.• Efficient operation.• Compact design.• Wide selection of units with CFC and HFC refrigerants.• Affordable.• Quiet operation.• Replacement for Tecumseh air-cooled condensing unit models from 1/8 hp

to 1 hp.

UNIT OPTIONS

LIQUID CONNECTIONSBill of

MaterialSuctionValve

BaseValve

Receiverwith Valve

PowerCord

BXConduit

FanGuard

911 X X X912 X X913 X X X914 X X X X915 X X X X

Contact your local Totaline Authorized Refrigeration Wholesalerfor competitive products.

AB SERIES AIR-COOLED CONDENSING UNITS NOMENCLATURE

AB Line Nominal HP0013 1/80017 1/6

0020-0023 1/50024-0027 1/40032-0037 1/30049-0051 1/20065-0075 3/4

0100 1

AB C N 0036 – IAA – 915

Series of Air-CooledCondensing Units

Operating RangeC – Commercial Temp.

(Medium – High)L – Low Temp.

Unit Voltage (V/Ph/Hz)IAA – 115/1/60CAA – 115/1/60SAA – 115/1/60

(low torque start)CAV – 208-230/1/60IAV – 208-230/1/60

RefrigerantF – R-12/MP39X – R-22N – R-134AS – R-404A

Bill of Material(BOM)

P4376

929


COPELAND AB SERIES HERMETIC AIR-COOLED CONDENSING UNITS —LIGHT COMMERCIAL HERMETIC UNITSCAPACITY RATINGS — BTUH at 90° F AMBIENT

R-12/MP39 Medium/High Temperature

R-22 Medium/High Temperature

R-134a Medium/High Temperature

R-404A Medium/High Temperature

CONDENSING UNITS VOLT HPEVAPORATOR TEMPERATURE (°°°°F)

0 +10 +15 +20 +25 +30 +35 +40 +45 +50ABCF0017-SAA-912 115 1/6 — 770 870 980 1090 1200 1320 1,450 1,580 1710ABCF0020-SAA-912 115 1/5 — 930 1030 1140 1260 1390 1520 1,650 1,800 1950ABCF0024-SAA-912 115 1/4 — 1270 1420 1570 1730 1890 2070 2,250 2,440 2640ABCF0026-IAA-911 115 1/4 — 1480 1640 1810 1980 2160 2350 2,550 2,760 2980ABCF0026-IAA-913 115 1/4 — 1480 1640 1810 1980 2160 2350 2,550 2,760 2980ABCF0026-IAA-914 115 1/4 — 1480 1640 1810 1980 2160 2350 2,550 2,760 2980ABCF0033-IAA-911 115 1/3 — 1820 2040 2270 2510 2770 3030 3,310 3,600 3910ABCF0033-IAA-913 115 1/3 — 1820 2040 2270 2510 2770 3030 3,310 3,600 3910ABCF0033-IAA-915 115 1/3 — 1820 2040 2270 2510 2770 3030 3,310 3,600 3910ABCF0049-IAA-911 115 1/2 — 2560 2850 3150 3460 3790 4140 4,500 4,870 5260ABCF0049-IAA-913 115 1/2 — 2560 2850 3150 3460 3790 4140 4,500 4,870 5260ABCF0049-IAA-915 115 1/2 — 2560 2850 3150 3460 3790 4140 4,500 4,870 5260ABCF0075-IAA-913 115 3/4 — 4500 5000 5500 6000 6500 7300 8,200 9,100 —ABCF0075-IAA-915 115 3/4 — 4500 5000 5500 6000 6500 7300 8,200 9,100 —ABCF0075-IAV-913 208-230 3/4 — 4500 5000 5500 6000 6500 7300 8,200 9,100 —ABCF0075-IAV-915 208-230 3/4 — 4500 5000 5500 6000 6500 7300 8,200 9,100 —ABCF0100-CAV-913 208-230 1 — 5360 5800 6500 7200 8100 9000 10,000 11,200 —ABCF0100-CAV-915 208-230 1 — 5360 5800 6500 7200 8100 9000 10,000 11,200 —


0 +10 +15 +20 +25 +30 +35 +40 +45 +50ABCX0022-IAA-912 115 1/5 — 1250 1380 1530 1680 1840 2010 2180 2360 2500ABCX0027-IAA-911 115 1/4 — 1910 2130 2360 2600 2850 3110 3380 3660 3960ABCX0027-IAA-913 115 1/4 — 1910 2130 2360 2600 2850 3110 3380 3660 3960ABCX0027-IAA-915 115 1/4 — 1910 2130 2360 2600 2850 3110 3380 3660 3960ABCX0036-IAA-911 115 1/3 — 2270 2550 2830 3140 3460 3790 4140 4500 4880ABCX0036-IAA-913 115 1/3 — 2270 2550 2830 3140 3460 3790 4140 4500 4880ABCX0036-IAA-915 115 1/3 — 2270 2550 2830 3140 3460 3790 4140 4500 4880ABCX0049-CAA-911 115 1/2 — 3090 3460 3840 4250 4680 5130 5600 6090 6600ABCX0049-CAA-913 115 1/2 — 3090 3460 3840 4250 4680 5130 5600 6090 6600ABCX0049-CAA-915 115 1/2 — 3090 3460 3840 4250 4680 5130 5600 6090 6600ABCX0049-CAV-915 208-230 1/2 — 3090 3460 3840 4250 4680 5130 5600 6090 6600


0 +10 +15 +20 +25 +30 +35 +40 +45 +50ABCN0017-SAA-912 115 1/6 — 800 910 1030 1150 1280 1410 1,560 1,710 1860ABCN0020-SAA-912 115 1/5 — 950 1070 1200 1330 1470 1620 1,770 1,930 2100ABCN0024-SAA-912 115 1/5 — 1310 1470 1640 1810 2000 2190 2,390 2,600 2820ABCN0026-IAA-911 115 1/4 — 1530 1700 1890 2080 2280 2490 2,710 ,2940 3180ABCN0026-IAA-913 115 1/4 — 1530 1700 1890 2080 2280 2490 2,710 2,940 3180ABCN0026-IAA-914 115 1/4 — 1530 1700 1890 2080 2280 2490 2,710 2,940 3180ABCN0033-IAA-911 115 1/3 — 1870 2110 2360 2600 2850 3110 3,380 3,660 3960ABCN0033-IAA-913 115 1/3 — 1870 2110 2360 2600 2850 3110 3,380 ,3660 3960ABCN0033-IAA-915 115 1/3 — 1870 2110 2360 2600 2850 3110 3,380 3,660 3960ABCN0049-IAA-911 115 1/2 — 2610 2920 3250 3600 3960 4340 4,740 5,150 5590ABCN0049-IAA-913 115 1/2 — 2610 2920 3250 3600 3960 4340 4,740 5,150 5590ABCN0049-IAA-915 115 1/2 — 2610 2920 3250 3600 3960 4340 4,740 5,150 5590ABCN0075-IAV-913 208-230 3/4 — 4700 5500 6300 7200 8100 — — — —ABCN0075-IAV-915 208-230 3/4 — 4700 5500 6300 7200 8100 — — — —ABCN0100-CAV-913 208-230 1 — — 5900 6800 7800 8800 9800 10,800 11,200 —ABCN0100-CAV-915 208-230 1 — — 5900 6800 7800 8800 9800 10,800 11,200 —


0 +10 +15 +20 +25 +30 +35 +40 +45 +50ABCS0022-IAA-912 115 1/5 — 1340 1460 1590 1720 1860 2010 2180 2360 2550ABCS0025-IAA-911 115 1/4 — — — — — — — — — —ABCS0025-IAA-913 115 1/4 1570 1890 2060 2240 2430 2620 2820 3030 3240 3460ABCS0025-IAA-915 115 1/4 1570 1890 2060 2240 2430 2620 2820 3030 3240 3460ABCS0036-IAA-911 115 1/3 — 2550 2815 3040 3370 3670 3990 4310 4650 5000ABCS0036-IAA-913 115 1/3 — 2550 2815 3040 3370 3670 3990 4310 4650 5000ABCS0036-IAA-915 115 1/3 — 2550 2815 3040 3370 3670 3990 4310 4650 5000ABCS0036-IAV-915 208-230 1/3 — 2550 2815 3040 3370 3670 3990 4310 4650 5000

930


COPELAND AB SERIES HERMETIC AIR-COOLED CONDENSING UNITSLIGHT COMMERCIAL HERMETIC UNITSCAPACITY RATINGS — BTUH at 90° F AMBIENT (cont)

R-404A Low Temperature

R-12/MP39 Low Temperature

R-12/MP39 Medium/High Temperature, Physical Data

R-22 Medium/High Temperature, Physical Data


–25 –20 –15 –10 0 +10 +15 +20 +25 +30ABLS0033-IAA-914 115 1/3 910 1080 1260 1440 1830 2250 — — — —ABLS0040-IAA-915 115 1/2 1430 1650 1880 2120 2640 3200 3490 — — —ABLS0065-IAA-913 115 3/4 1980 2440 2900 3360 4310 5260 5710 6200 — —


–25 –20 –15 –10 0 +10 +15 +20 +25 +30ABCF0017-SAA-912 115 1/6 380 450 510 580 720 — — — — —ABCF0020-SAA-912 115 1/5 470 540 620 700 870 — — — — —ABCF0024-SAA-912 115 1/4 640 750 850 960 1180 — — — — —ABCF0033-IAA-911 115 1/3 860 990 1130 1270 1515 — — — — —ABCF0033-IAA-913 115 1/3 860 990 1130 1270 1515 — — — — —ABLF0034-IAA-911 115 1/3 1160 1330 1510 1700 2080 2500 — — — —ABLF0034-IAA-913 115 1/3 1160 1330 1510 1700 2080 2500 — — — —ABLF0034-IAA-914 115 1/3 1160 1330 1510 1700 2080 2500 — — — —ABLF0050-IAA-913 115 1/2 1620 1880 2140 2440 2980 3520 — — — —ABLF0050-IAA-915 115 1/2 1620 1880 2140 2440 2980 3520 — — — —

CONDENSING UNITSOVERALL DIMENSIONS (in.) MIN CIRCUIT (CKT)

115-1AMPACITY (amp)

230-1SHIPPING WEIGHT

(lbs)Length Width HeightABCF0017-SAA-912 13.8 11.8 9.7 4.2 — 33ABCF0020-SAA-912 13.8 11.8 9.7 5.0 — 35ABCF0024-SAA-912 13.8 11.8 9.7 6.2 — 36ABCF0026-IAA-911 13.8 11.8 9.7 6.9 — 41ABCF0026-IAA-913 13.8 11.8 9.7 6.9 — 41ABCF0026-IAA-914 13.8 11.8 9.7 6.9 — 41ABCF0033-IAA-911 13.8 11.8 9.7 9.9 — 46ABCF0033-IAA-913 13.8 11.8 9.7 9.9 — 46ABCF0033-IAA-915 13.8 11.8 9.7 9.9 — 46ABCF0049-IAA-911 16.2 13.1 11.8 12.2 — 54ABCF0049-IAA-913 16.2 13.1 11.8 12.2 — 54ABCF0049-IAA-915 16.2 13.1 11.8 12.2 — 54ABCF0075-IAA-913 24.0 16.9 12.9 18.6 — 106ABCF0075-IAA-915 24.0 16.9 12.9 18.6 — 106ABCF0075-IAV-913 24.0 16.9 12.9 — 10.0 106ABCF0075-IAA-915 24.0 16.9 12.9 18.7 — 106ABCF0100-CAV-913 24.0 16.9 12.9 — 10.1 112ABCF0100-CAV-915 24.0 16.9 12.9 — 10.1 112


115-1AMPACITY (amp)


(lbs)Length Width HeightABCX0022-IAA-912 13.8 11.8 9.7 6.2 — 36ABCX0027-IAA-911 13.8 11.8 9.7 9.0 — 42ABCX0027-IAA-913 13.8 11.8 9.7 9.0 — 42ABCX0027-IAA-915 13.8 11.8 9.7 9.0 — 42ABCX0036-IAA-911 16.2 13.1 11.8 9.8 — 47ABCX0036-IAA-913 16.2 13.1 11.8 9.8 — 47ABCX0036-IAA-915 16.2 13.1 11.8 9.8 — 47ABCX0049-CAA-911 16.2 13.1 11.8 — 5.6 54ABCX0049-CAA-913 16.2 13.1 11.8 — 5.6 54ABCX0049-CAA-915 16.2 13.1 11.8 — 5.6 54ABCX0049-CAV-915 16.2 13.1 11.8 — 5.6 54

931


COPELAND AB SERIES HERMETIC AIR-COOLED CONDENSING UNITSLIGHT COMMERCIAL HERMETIC UNITSPHYSICAL DATA (cont)

R-134a Medium/High Temperature

R-404A Medium/High Temperature

R-404A Low Temperature

R-12/MP39 Low Temperature


115-1AMPACITY (amp)


(lbs)Length Width HeightABCN0017-SAA-912 13.8 11.8 9.7 4.2 — 33ABCN0020-SAA-912 13.8 11.8 9.7 5.0 — 35ABCN0024-SAA-912 13.8 11.8 9.7 6.2 — 36ABCN0026-IAA-911 13.8 11.8 9.7 6.9 — 36ABCN0026-IAA-913 13.8 11.8 9.7 6.9 — 36ABCN0026-IAA-914 13.8 11.8 9.7 6.9 — 36ABCN0033-IAA-911 13.8 11.8 9.7 6.9 — 46ABCN0033-IAA-913 13.8 11.8 9.7 6.9 — 46ABCN0026-IAA-915 13.8 11.8 9.7 6.9 — 46ABCN0049-IAA-911 16.2 13.1 11.8 12.2 — 50ABCN0049-IAA-913 16.2 13.1 11.8 12.2 — 50ABCN0049-IAA-915 16.2 13.1 11.8 12.2 — 50ABCN0075-IAV-913 24.0 16.9 12.9 — 7.4 106ABCN0075-IAV-915 24.0 16.9 12.9 — 7.4 106ABCN0100-CAV-913 24.0 16.9 16.2 — 7.3 112ABCN0100-CAV-915 24.0 16.9 16.2 — 7.3 112


115-1AMPACITY (amp)


(lbs)Length Width HeightABCS0022-IAA-912 13.8 11.8 9.7 6.2 — 36ABCS0025-IAA-911 13.8 11.8 9.7 9.9 — 36ABCS0025-IAA-913 13.8 11.8 9.7 9.9 — 36ABCS0025-IAA-915 13.8 11.8 9.7 9.9 — 36ABCS0036-IAA-911 13.8 11.8 9.7 10.6 — 45ABCS0036-IAA-913 13.8 11.8 9.7 10.6 — 45ABCS0036-IAA-915 13.8 11.8 9.7 10.6 — 45ABCS0036-IAV-915 13.8 11.8 9.7 10.6 — 45


115-1AMPACITY (amp)


(lbs)Length Width HeightABLS0033-IAA-914 13.8 11.8 9.7 7.7 — 41ABLS0040-IAA-915 13.8 11.8 9.7 8.9 — 47ABLS0065-IAA-913 13.8 11.8 9.7 9.2 — 100

CONDENSING UNITSOVERALL DIMENSIONS (in.) MIN CIRCUIT (CKT.)

115-1AMPACITY (amp)


(lbs)Length Width HeightABCF0017-SAA-912 13.8 11.8 9.7 4.2 — 33ABCF0020-SAA-912 13.8 11.8 9.7 5.0 — 35ABCF0024-SAA-912 13.8 11.8 9.7 6.2 — 36ABCF0033-IAA-911 13.8 11.8 9.7 9.9 — 46ABCF0033-IAA-913 13.8 11.8 9.7 9.9 — 46ABLF0034-IAA-911 13.8 11.8 9.7 6.9 — 47ABLF0034-IAA-913 13.8 11.8 9.7 6.9 — 47ABLF0034-IAA-914 13.8 11.8 9.7 6.9 — 47ABLF0050-IAA-913 13.8 11.8 9.7 10.3 — 73ABLF0050-IAA-915 13.8 11.8 9.7 10.3 — 73

932

REFRIGERATION HERMETIC CONDENSING UNITS

MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITS

P4129

Condensing Unit Nomenclature

CMT E W - 50 - 3 F1 - XXX

Model SeriesCMT = Condensing Unit with MT Compressor

Type of OilE = P.O.E. oil (polyolester oil)Space left blank = Mineral Oil

Condenser TypeSpace left blank = Air CooledW = Water Cooled

B/M

Condenser Code(Air Cooled Units Only)

Unit Power Supply1 = (208-230/1/60)3 = (208-230/3/60)4 = (460/3/60)7 = (575/3/60)

(contact application dept.)

Compressor Size

How to Order:

To order a condensing unit, the following is required:

1. Model series2. Type of oil3. Condenser type4. Compressor size5. Unit power supply

Example:

To order a 460/3/60 water cooled condensing unit with POE oil and a MT 50 compressor, the model number is:

CMT E W - 50 - 4

1 2 3 4 5

SPECIAL BULLETINS

It is impossible to list complete details for all lines, but we will gladly furnishspecial catalogs and bulletins upon request.

933


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSPerformance Data — CMT High-to-Medium Temperature — R-22

Low Profile Units

Standard Units

NOTES:1. Btu/h = Capacity.2. kW = Total Input Power including fans.3. Rated Conditions: 65° F/*40° F Return Gas, 5° F Subcooling, 60 Hz operation.

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)40 30 25 20 10 0 -10*

Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW

CMT1890 15,060 1.70 12,280 1.56 11,000 1.47 9,730 1.39 7,350 1.22 5,340 1.05 3300 0.8695 14,350 1.74 11,770 1.59 10,540 1.50 9,320 1.44 7,020 1.23 5,120 1.06 3150 0.89

100 13,650 1.78 11,260 1.62 10,080 1.53 8,910 1.46 6,710 1.25 4,890 1.07

CMT2290 20,740 2.23 16,760 2.02 14,910 1.91 13,160 1.80 9,960 1.58 7,210 1.35 4900 1.0795 19,840 2.28 16,120 2.06 14,220 1.95 12,520 1.83 9,420 1.60 6,740 1.36 4500 1.08

100 18,940 2.33 15,440 2.10 13,530 1.98 11,890 1.86 8,900 1.62 6,280 1.38

CMT2890 26,230 3.12 21,440 2.75 19,100 2.57 16,890 2.40 12,840 2.06 9,260 1.73 8200 1.6395 25,220 3.20 20,700 2.83 18,470 2.64 16,340 2.46 12,430 2.10 8,960 1.75 7750 1.64

100 24,260 3.28 20,000 2.89 17,850 2.70 15,780 2.52 12,000 2.14 8,660 1.78

CMT3290 23,120 3.25 20,670 3.04 18,350 2.84 14,010 2.44 10,160 2.05 8760 1.8995 22,360 3.32 19,980 3.10 17,730 2.89 13,540 2.48 9,820 2.07 8200 1.91

100 21,590 3.38 19,290 3.16 17,120 2.95 13,070 2.52 9,490 2.10

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)40 30 25 20 10 0 -10*


CMT36

90 36,060 3.96 29,900 3.61 27,010 3.44 24,250 3.27 19,170 2.95 14,670 2.63 11,100 1.8795 34,740 4.07 28,780 3.70 25,970 3.52 23,290 3.34 18,330 3.00 13,920 2.67 10,450 1.91

100 33,420 4.18 27,650 3.79 24,920 3.60 22,320 3.41 17,490 3.05 13,160 2.71110 30,720 4.41 25,340 3.97 22,790 3.76 20,340 3.55 15,790 3.16

CMT50

90 47,090 5.45 37,890 4.96 33,760 4.72 29,950 4.48 23,260 4.00 17,780 3.54 13,020 2.6795 45,290 5.58 36,400 5.07 32,400 4.82 28,700 4.57 22,220 4.08 16,880 3.61 12,280 2.73

100 43,480 5.70 34,900 5.17 31,040 4.91 27,460 4.66 21,180 4.16 15,980 3.68110 39,810 5.93 31,870 5.37 28,280 5.09 24,940 4.83 19,100 4.30

CMT64

90 60,450 6.92 49,150 6.30 43,960 5.99 39,070 5.68 30,270 5.05 22,740 4.43 15,910 2.9395 58,240 7.11 47,340 6.46 42,310 6.13 37,570 5.81 29,020 5.16 21,660 4.52 15,090 2.97

100 56,050 7.29 45,560 6.61 40,700 6.27 36,110 5.93 27,820 5.26 20,640 4.60110 51,750 7.64 42,070 6.88 37,570 6.52 33,300 6.15 25,550 5.43

CMT72

90 65,530 7.58 53,770 6.86 48,300 6.52 43,100 6.18 33,580 5.53 25,280 4.90 18,460 3.8695 63,180 7.81 51,840 7.06 46,540 6.69 41,510 6.34 32,270 5.66 24,150 5.02 17,570 3.96

100 60,820 8.04 49,940 7.26 44,840 6.88 39,980 6.51 31,020 5.81 23,100 5.14110 56,230 8.55 46,300 7.68 41,580 7.28 37,070 6.88 28,720 6.12

CMT100

90 89,900 10.41 72,970 9.69 65,250 9.33 58,030 8.96 45,110 8.21 34,190 7.45 24,450 5.8095 86,270 10.68 69,900 9.89 62,420 9.60 55,410 9.11 42,850 8.31 32,180 7.51 22,710 5.84

100 82,720 10.95 66,910 10.10 69,680 9.67 52,880 9.25 40,690 8.41 30,280 7.57110 75,800 11.51 61,190 10.51 54,460 10.03 48,110 9.55 36,700 8.61 26,840 7.69

CMT125

90 118,300 13.25 96,840 12.18 86,980 11.66 77,750 11.14 60,980 10.13 46,660 9.14 33,670 7.2095 113,540 13.60 92,930 12.47 83,500 11.92 74,530 11.38 58,330 10.32 44,420 9.30 31,880 7.33

100 108,800 13.95 89,130 12.75 79,990 12.17 71,350 11.61 55,740 10.51 42,260 9.45110 99,410 14.61 81,410 13.29 73,040 12.65 65,130 12.03 50,730 10.84 38,150 9.71

CMT144

90 133,330 14.69 109,390 13.47 98,360 12.88 88,060 12.29 69,350 11.15 53,330 10.06 39,060 8.0695 127,780 15.08 104,950 13.78 94,320 13.16 84,300 12.56 66,250 11.37 50,760 10.23 36,910 8.19

100 122,420 15.45 100,410 14.09 90,310 13.44 80,670 12.80 63,270 11.57 48,230 10.40110 111,520 16.18 91,510 14.68 82,300 13.96 73,460 13.27 57,470 11.94 43,460 10.68

CMT160

90 144,830 16.50 118,940 15.08 107,040 14.39 95,830 13,72 75,570 12.43 58,180 11.18 42,440 9.0395 138,960 16.93 114,070 15.43 102,610 14.71 91,800 14.01 72,230 12.66 55,400 11.37 40,250 9.16

100 133,130 17.35 109,240 15.77 98,220 15.01 87,710 14.28 68,960 12.88 52,720 11.54110 121,410 18.17 99,620 16.42 89,510 15.59 79,960 14.79 62,600 13.27 47,590 11.84

934


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSPerformance Data — CMT High-to-Medium Temperature — R-134a

Low Profile Units

Standard Units

NOTES:1. Btu/h = Capacity.2. kW = Total Input Power including fans.3. Rated Conditions: 20° F Superheat, 5° F Subcooling, 60 Hz operation.

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)50 40 30 25 20 10 0


CMTE1890 13,800 1.63 11,200 1.52 8,900 1.40 7,850 1.35 6,800 1.29 5000 1.18 3600 1.0895 13,300 1.67 10,700 1.55 8,500 1.42 7,450 1.37 6,400 1.31 4800 1.20 3300 1.09

100 12,800 1.69 10,300 1.57 8,100 1.44 7,100 1.38 6,100 1.32 4500 1.21 3000 1.10

CMTE2290 18,000 1.92 14,400 1.78 11,800 1.64 10,200 1.57 8,600 1.50 6400 1.37 4800 1.2495 17,200 1.96 13,900 1.81 11,200 1.66 9,850 1.59 8,300 1.52 6100 1.38 4400 1.25

100 16,600 1.99 13,300 1.84 10,500 1.69 9,300 1.61 7,900 1.54 5700 1.40 4000 1.26

CMTE2890 21,400 2.38 18,000 2.17 13,600 1.98 12,100 1.89 10,600 1.79 9900 1.62 5700 1.4595 20,500 2.41 17,400 2.21 13,000 2.01 11,500 1.91 10,000 1.82 7400 1.64 5200 1.47

100 19,900 2.46 16,700 2.24 12,400 2.04 11,000 1.94 9,600 1.84 6900 1.66 4800 1.48

CMTE3290 23,200 2.64 18,900 2.41 15,000 2.18 13,300 2.08 11,600 1.97 8500 1.76 6200 1.5795 22,200 2.69 18,000 2.44 14,300 2.25 12,650 2.11 11,000 2.00 8100 1.78 5700 1.59

100 21,300 2.73 17,300 2.47 13,400 2.24 11,900 2.13 10,400 2.02 7600 1.81 5200 1.60

MODELSAMBIENT

TEMP(°F)



CMTE36

90 27,500 3.18 22,400 2.95 17,600 2.72 15,600 2.24 13,600 2.50 10,100 2.28 7,200 2.0795 26,500 3.25 21,500 2.99 16,800 2.76 14,850 2.27 12,900 2.53 9,600 2.30 6,700 2.09

100 25,400 3.30 22,400 3.04 16,000 2.81 14,050 2.32 12,100 2.56 8,700 2.33 6,000 2.11110 23,600 3.40 18,800 3.12 14,500 2.86 12,650 2.36 10,800 2.61 7,800 2.37 5,000 2.14

CMTE50

90 44,000 4.43 33,400 4.10 26,000 3.77 23,000 3.23 20,000 3.44 15,000 3.11 11,000 2.7995 40,000 4.53 32,000 4.18 24,800 3.84 21,900 3.29 19,000 3.48 14,000 3.15 10,200 2.82

100 38,200 4.63 30,800 4.27 23,600 3.90 20,800 3.35 18,000 3.54 13,000 3.19 9,400 2.85110 35,200 4.80 28,200 4.45 21,200 4.01 18,600 3.46 16,000 3.64 11,200 3.27 7,500 2.91

CMET64

90 51,000 4.95 41,000 4.54 32,000 4.15 28,300 3.60 24,600 3.78 18,000 3.40 13,000 3.0495 49,000 5.05 39,000 4.63 31,000 4.22 27,150 3.66 23,300 3.83 17,000 3.44 12,000 3.06

100 47,500 5.25 37,500 4.73 29,500 4.30 25,850 3.73 22,200 3.88 16,000 3.49 11,000 3.10110 43,200 5.34 34,500 4.88 26,900 4.42 23,450 3.84 20,000 4.00 14,000 3.58 9,200 3.16

CMTE72

90 56,400 5.48 45,400 5.02 35,700 4.58 31,850 3.99 28,000 4.14 20,500 3.72 15,000 3.3195 54,800 5.59 43,800 5.12 34,000 4.66 30,100 4.07 26,200 4.21 19,200 3.76 13,900 3.35

100 52,500 5.69 42,000 5.22 32,200 4.75 28,600 4.14 25,000 4.27 18,000 3.81 12,500 3.38110 8,000 5.93 38,000 5.39 29,200 4.88 25,600 4.26 22,000 4.38 15,800 3.92 10,000 3.46

CMTE100

90 78,500 8.33 64,000 7.67 52,000 7.04 45,500 5.49 39,000 6.41 28,500 5.80 21,500 5.2395 74,000 8.70 61,500 7.81 49,000 7.15 43,000 5.58 37,000 6.50 27,000 5.88 20,000 5.27

100 73,000 8.85 58,800 7.95 47,000 7.28 41,000 5.70 35,000 6.60 25,500 5.95 19,000 5.33110 54,000 8.16 42,000 7.45 36,500 5.86 31,000 6.74 22,000 6.08 15,000 5.43

CMTE125

90 102,000 8.41 82,000 7.90 65,000 7.42 57,500 5.83 50,000 6.73 36,000 6.08 26,000 5.5595 98,000 8.51 79,000 8.03 62,000 7.43 54,500 5.96 47,000 6.97 34,000 6.45 24,000 5.86

100 95,000 8.56 75,500 8.14 59,000 7.62 51,500 6.14 44,000 7.13 32,000 6.59 22,000 6.00110 87,000 8.88 69,000 8.18 53,000 7.78 46,500 6.31 40,000 7.32 28,000 6.78 18,000 6.17

CMTE144

90 115,000 10.84 92,000 10.00 72,000 9.14 64,000 7.48 56,000 8.30 42,000 7.47 30,000 6.6795 111,000 11.13 89,000 10.23 69,000 9.32 61,250 7.63 53,500 8.42 39,000 7.58 28.000 6.73

100 106,000 11.33 85,000 10.42 66,000 9.47 58,000 7.78 50,000 8.56 37,000 7.66 25,000 6.81110 98,000 11.80 78,000 10.76 60,000 9.75 52,250 8.03 44,500 8.80 32,000 7.86 21,000 6.95

CMTE160

90 126,000 12.16 102,000 11.12 80,000 10.13 71,000 8.40 62,000 9.15 46,000 8.20 33,000 7.2795 121,500 12.40 97,000 11.39 76,000 10.34 67,500 8.59 59,000 9.31 43,000 8.32 30,500 7.36

100 118,000 12.63 94,000 11.58 73,000 10.51 64,500 8.73 56,000 9.44 40,000 8.42 28,000 7.44110 108,000 13.15 88,000 11.95 65,500 10.79 57,750 9.00 50,000 9.68 35,000 8.64 23,200 7.61

935


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSPerformance Data — CMTE Medium-to-Low Temperature — R-502

Low Profile Units

Standard Units


MODELSAMBIENT

TEMP(°F)



CMTE1890 13,800 1.63 11,200 1.52 8,900 1.40 7,850 1.35 6,800 1.29 5000 1.18 3600 1.0895 13,300 1.67 10,700 1.55 8,500 1.42 7,450 1.37 6,400 1.31 4800 1.20 3300 1.09

100 12,800 1.69 10,300 1.57 8,100 1.44 7,100 1.38 6,100 1.32 4500 1.21 3000 1.10

CMTE2290 18,000 1.92 14,400 1.78 11,800 1.64 10,200 1.57 8,600 1.50 6400 1.37 4800 1.2495 17,200 1.96 13,900 1.81 11,200 1.66 9,850 1.59 8,300 1.52 6100 1.38 4400 1.25

100 16,600 1.99 13,300 1.84 10,500 1.69 9,300 1.61 7,900 1.54 5700 1.40 4000 1.26

CMTE2890 21,400 2.38 18,000 2.17 13,600 1.98 12,100 1.89 10,600 1.79 9900 1.62 5700 1.4595 20,500 2.41 17,400 2.21 13,000 2.01 11,500 1.91 10,000 1.82 7400 1.64 5200 1.47

100 19,900 2.46 16,700 2.24 12,400 2.04 11,000 1.94 9,600 1.84 6900 1.66 4800 1.48

CMTE3290 23,200 2.64 18,900 2.41 15,000 2.18 13,300 2.08 11,600 1.97 8500 1.76 6200 1.5795 22,200 2.69 18,000 2.44 14,300 2.25 12,650 2.11 11,000 2.00 8100 1.78 5700 1.59

100 21,300 2.73 17,300 2.47 13,400 2.24 11,900 2.13 10,400 2.02 7600 1.81 5200 1.60

MODELSAMBIENT

TEMP(°F)



CMTE36

90 27,500 3.18 22,400 2.95 17,600 2.72 15,600 2.24 13,600 2.50 10,100 2.28 7,200 2.0795 26,500 3.25 21,500 2.99 16,800 2.76 14,850 2.27 12,900 2.53 9,600 2.30 6,700 2.09

100 25,400 3.30 22,400 3.04 16,000 2.81 14,050 2.32 12,100 2.56 8,700 2.33 6,000 2.11110 23,600 3.40 18,800 3.12 14,500 2.86 12,650 2.36 10,800 2.61 7,800 2.37 5,000 2.14

CMTE50

90 44,000 4.43 33,400 4.10 26,000 3.77 23,000 3.23 20,000 3.44 15,000 3.11 11,000 2.7995 40,000 4.53 32,000 4.18 24,800 3.84 21,900 3.29 19,000 3.48 14,000 3.15 10,200 2.82

100 38,200 4.63 30,800 4.27 23,600 3.90 20,800 3.35 18,000 3.54 13,000 3.19 9,400 2.85110 35,200 4.80 28,200 4.45 21,200 4.01 18,600 3.46 16,000 3.64 11,200 3.27 7,500 2.91

CMET64

90 51,000 4.95 41,000 4.54 32,000 4.15 28,300 3.60 24,600 3.78 18,000 3.40 13,000 3.0495 49,000 5.05 39,000 4.63 31,000 4.22 27,150 3.66 23,300 3.83 17,000 3.44 12,000 3.06

100 47,500 5.25 37,500 4.73 29,500 4.30 25,850 3.73 22,200 3.88 16,000 3.49 11,000 3.10110 43,200 5.34 34,500 4.88 26,900 4.42 23,450 3.84 20,000 4.00 14,000 3.58 9,200 3.16

CMTE72

90 56,400 5.48 45,400 5.02 35,700 4.58 31,850 3.99 28,000 4.14 20,500 3.72 15,000 3.3195 54,800 5.59 43,800 5.12 34,000 4.66 30,100 4.07 26,200 4.21 19,200 3.76 13,900 3.35

100 52,500 5.69 42,000 5.22 32,200 4.75 28,600 4.14 25,000 4.27 18,000 3.81 12,500 3.38110 8,000 5.93 38,000 5.39 29,200 4.88 25,600 4.26 22,000 4.38 15,800 3.92 10,000 3.46

CMTE100

90 78,500 8.33 64,000 7.67 52,000 7.04 45,500 5.49 39,000 6.41 28,500 5.80 21,500 5.2395 74,000 8.70 61,500 7.81 49,000 7.15 43,000 5.58 37,000 6.50 27,000 5.88 20,000 5.27

100 73,000 8.85 58,800 7.95 47,000 7.28 41,000 5.70 35,000 6.60 25,500 5.95 19,000 5.33110 54,000 8.16 42,000 7.45 36,500 5.86 31,000 6.74 22,000 6.08 15,000 5.43

CMTE125

90 102,000 8.41 82,000 7.90 65,000 7.42 57,500 5.83 50,000 6.73 36,000 6.08 26,000 5.5595 98,000 8.51 79,000 8.03 62,000 7.43 54,500 5.96 47,000 6.97 34,000 6.45 24,000 5.86

100 95,000 8.56 75,500 8.14 59,000 7.62 51,500 6.14 44,000 7.13 32,000 6.59 22,000 6.00110 87,000 8.88 69,000 8.18 53,000 7.78 46,500 6.31 40,000 7.32 28,000 6.78 18,000 6.17

CMTE144

90 115,000 10.84 92,000 10.00 72,000 9.14 64,000 7.48 56,000 8.30 42,000 7.47 30,000 6.6795 111,000 11.13 89,000 10.23 69,000 9.32 61,250 7.63 53,500 8.42 39,000 7.58 28.000 6.73

100 106,000 11.33 85,000 10.42 66,000 9.47 58,000 7.78 50,000 8.56 37,000 7.66 25,000 6.81110 98,000 11.80 78,000 10.76 60,000 9.75 52,250 8.03 44,500 8.80 32,000 7.86 21,000 6.95

CMTE160

90 126,000 12.16 102,000 11.12 80,000 10.13 71,000 8.40 62,000 9.15 46,000 8.20 33,000 7.2795 121,500 12.40 97,000 11.39 76,000 10.34 67,500 8.59 59,000 9.31 43,000 8.32 30,500 7.36

100 118,000 12.63 94,000 11.58 73,000 10.51 64,500 8.73 56,000 9.44 40,000 8.42 28,000 7.44110 108,000 13.15 88,000 11.95 65,500 10.79 57,750 9.00 50,000 9.68 35,000 8.64 23,200 7.61

936


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSPerformance Data — CMTE Medium-to-Low Temperature — R-404A, R-507

Low Profile Units

Standard Units


MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)30 25 20 10 0 -10 -20 -25

Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW Btu/h kW

CMTE1890 13,000 1.98 11,115 1.94 9,880 1.87 7,695 1.71 5,795 1.56 4085 1.39 2660 1.25 1995 1.1395 12,200 2.00 10,403 1.96 9,215 1.88 7,220 1.72 5,320 1.57 3800 1.40 2470 1.26 1710 1.14

100 9,833 1.97 8,645 1.89 6,650 1.73 4,750 1.58 3515 1.41 2185 1.27 1520 1.15

CMTE2290 18,200 2.60 15,580 2.54 13,870 2.43 10,640 2.21 7,980 2.01 5890 1.76 3705 1.54 3040 1.3195 17,300 2.62 14,725 2.56 13,015 2.45 10,070 2.22 7,410 2.02 5320 1.77 3420 1.55 2565 1.32

100 13,918 2.57 12,255 2.47 9,405 2.23 6,840 2.03 5035 1.78 3040 1.56 2185 1.36

CMTE2890 21,200 3.58 18,335 3.41 16,530 3.19 13,585 2.85 10,450 2.54 7600 2.31 5320 2.05 4465 1.8595 15,580 3.21 12,635 2.88 9,595 2.55 7125 2.32 4940 2.06 4180 1.86

100

CMTE3290 20,093 3.79 18,335 3.53 14,915 3.16 11,780 2.76 8645 2.56 6175 2.24 5130 2.0295 13,980 3.18 11,210 2.77 7980 2.57 5700 2.25 4750 2.03

100

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)30 25 20 10 0 -10 -20 -10


CMTE36

90 28,000 4.69 24,320 4.50 22,040 4.24 18,050 3.83 14,060 3.44 10,070 3.17 7,220 2.82 6,080 2.5795 26,400 4.77 22,990 4.55 20,900 4.28 16,910 3.85 13,110 3.45 9,310 3.18 6,650 2.84 5,700 2.58

100 25,000 4.82 21,565 4.58 19,380 4.30 15,770 3.87 11,970 3.46 8,550 3.19 6,080 2.86 5,130 2.59110 17,290 4.37 13,680 3.89 10,070 3.47 7,220 3.20 5,130 2.88 4,370 2.60

CMTE50

90 43,500 6.15 37,858 5.75 34,390 5.49 27,930 4.91 21,850 4.37 16,150 3.87 11,400 3.37 7,600 3.1795 41,000 6.25 35,673 5.88 32,395 5.57 26,315 4.92 20,710 4.38 15,200 3.88 10,925 3.39 7,315 3.18

100 39,000 6.30 34,438 5.95 31.825 5.62 24,700 4.93 19,190 4.39 14,250 3.89 10,165 3.41 6,650 3.19110 34,400 6.40 27,645 6.07 22,610 5.71 21.850 4.95 17,005 4.43 12,350 3.90 8,550 3.42 5,700 3.20

CMET64

90 51,700 7.75 45,553 7.29 41,990 6.88 33,725 5.08 26,790 5.40 19,950 4.72 14,250 4.07 9,690 3.8295 49,000 7.82 43,225 7.39 39,900 6.96 31,825 6.10 25,555 5.42 19,900 4.73 13,300 4.09 9,215 3.83

100 46,200 7.88 40,565 7.45 37,240 7.01 29,640 5.12 23,750 5.42 17,575 4.74 12,350 4.12 8,455 3.85110 41,500 8.00 36,290 7.57 33,155 7.11 26,125 6.16 20,615 5.44 15,200 4.75 10,650 4.14 6,650 3.87

CMTE72

90 57,500 8.73 50,588 8.26 46,550 7.75 37,050 6.83 29,450 6.06 21,850 5.27 16,150 4.57 10,925 4.2795 54,500 8.80 47,975 8.36 44,175 7.88 34,960 6.85 27,550 6.08 20,710 5.28 15,200 4.59 10,260 4.28

100 51,600 8.89 45,410 8.43 41,800 7.92 32,300 6.89 25,650 6.10 19,000 5.29 14,050 4.61 9,500 4.29110 40,375 8.57 36,860 8.02 28,500 6.90 21.850 6.15 16,340 5.30 11,875 4.63 7,600 4.30

CMTE100

90 80,000 11.30 69,825 10.80 63,650 10.28 56,810 9.44 42,275 8.64 32,300 7.80 24,510 6.80 20,900 6.5095 75,500 11.40 65,883 10.96 50,040 10.40 48,640 9.54 39,900 8.65 30,400 7.81 22,800 6.86 19,950 6.56

100 71,000 11.50 61,988 11.08 56,525 10.52 45,600 9.61 37,050 8.69 28,025 7.82 21,375 6.87 18,715 6.57110 54,625 11.35 49,400 10.79 39,900 9.69 32,300 8.70 24,225 7.83 18,050 6.89 16,150 6.58

CMTE125

90 107,000 13.70 92,625 13.11 83,600 12.57 72,200 11.52 56,050 10.58 41,800 9.55 31,350 8.25 27,550 7.8595 101,500 13.92 87,638 13.45 78,850 12.74 66,500 11.57 53,200 10.50 39,900 9.56 28,595 8.26 25,650 7.86

100 96,000 14.15 82,650 13.61 74,100 12.89 62,700 11.79 49,400 10.61 36,575 9.57 27,550 8.27 24,700 7.87110 84,000 14.55 73,150 13.91 66,500 13.21 53,200 11.93 42,750 10.62 31,350 9.58 23,750 8.28 20,900 2.78

CMTE144

90 120,000 15.28 104,500 14.58 95,000 13.98 76.950 12.82 62,700 11.76 47,500 10.55 36,100 9.10 30,400 8.6595 114,000 15.50 98,800 14.86 89,300 14.14 73,150 12.96 58,900 11.80 45,600 10.56 34,200 9.12 28,500 8.67

100 107,000 15.72 92,625 15.14 83,600 14.34 68,400 13.09 55,100 11.85 41,800 10.57 31,350 9.14 28,600 8.68110 95,000 16.16 82,175 15.50 74,100 14.70 59,850 13.28 47,500 11.89 36,100 10.58 26,600 9.16 22,800 8.69

CMTE160

90 130,000 16.90 113,050 16.76 102,600 15.95 84,550 14.54 68,400 13.28 52,250 11.90 39,900 10.20 33,250 9.7095 122,000 17.20 106,400 17.00 96,900 16.15 79,800 14.70 64,600 13.30 48,450 11.91 37,050 10.21 31,350 9.75

100 115,000 17.60 100,225 17.00 91,200 16.35 74,100 14.86 59,860 13.32 45,600 11.92 35,150 10.22 29,450 9.77110 102,000 18.40 88,825 17.00 80,750 16.75 64,600 15.02 51,300 13.33 38,950 11.93 30,400 10.23 26,600 9.79

937


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSPerformance Data — CLTE Extra Low Temperature — R-404A, R-507


Performance Data — CLT Extra Low Temperature — R-502

NOTES:1. Btu/h = Capacity.2. kW = Total Input Power including fans.3. Rated Conditions: 40° F/*20° F Return Gas, 5° F Subcooling, 60 Hz operation.

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)-5 -10 -15 -20 -25 -30 -35 -40


CLTE22

90 8,000 2.47 7,200 2.19 6,400 2.05 5,700 1.93 4,850 1.81 4,100 1.69 3,400 1.58 2,850 1.4895 7,800 2.50 6,800 2.20 6,000 2.05 5,200 1.92 4,600 1.79 3,900 1.67 3,200 1.55 2,600 1.44

100 7,100 2.53 6,300 2.21 5,600 2.06 4,750 1.91 4,300 1.78 3,500 1.64 2,900 1.52110 6,100 2.59 5,400 2.21 4,750 2.04 4,100 1.88 3,600 1.73 2,900 1.59

CLTE28

90 11,600 3.24 10,400 3.03 9,300 2.83 8,100 2.64 7,000 2.45 6,000 2.29 5,000 2.13 4,000 1.9795 11,000 3.27 9,700 3.05 8,700 2.83 7,600 2.62 6,400 2.42 5,800 2.25 4,600 2.08 3,600 1.96

100 10,300 3.29 9,000 3.06 8,000 2.83 7,000 2.61 6,000 2.40 5,000 2.22 4,100 2.02110 8,600 3.35 8,200 3.07 6,900 2.81 6,000 2.57 5,000 2.28 4,100 2.12

CLTE44

90 19,500 5.43 17,400 5.12 15,200 4.80 13,400 4.49 11,300 4.18 9,600 3.87 8,400 3.57 7,000 3.2595 18,000 5.45 16,000 5.13 14,000 4.81 12,200 4.49 10,400 5.16 9,000 3.85 7,700 3.53 8,300 3.22

100 17,000 5.45 14,700 5.13 13,000 4.81 11,400 4.48 9,600 4.15 8,400 3.82 7,000 3.50 5,800 3.18110 14,400 5.47 12,800 5.12 11,100 4.77 9,600 4.43 8,200 4.09 6,900 3.76 5,900 3.44 4,800 3.11

CLTE50

90 22,600 6.88 20,000 6.47 18,200 6.05 16,000 5.65 14,400 5.27 12,000 4.90 10,400 4.54 8,400 4.2095 21,000 6.93 19,200 6.49 16,800 6.07 15,000 5.67 13,200 5.27 11,400 4.89 9,700 4.52 8,000 4.17

100 19,600 6.97 17,800 6.51 15,800 6.07 14,000 5.66 12,100 5.27 10,400 4.87 8,900 4.49 7,800 4.13110 16,800 7.05 15,300 6.55 13,500 6.08 12,000 5.62 10,300 4.76 8,600 4.78 7,300 4.38

CLTE88

90 37,000 9.68 33,400 9.13 29,000 8.56 25,200 7.99 21,900 7.42 18,400 6.85 15,800 6.28 12,900 5.7095 35,100 9.81 31,200 9.19 27,200 8.59 23,900 7.99 20,300 7.39 17,300 6.78 14,400 6.20 11,800 5.60

100 32,800 9.89 29,000 9.26 25,200 8.63 21,900 7.99 18,600 7.36 15,800 6.72 13,000 6.10 10,400 5.47110 28,300 10.06 24,400 9.33 21,600 8.62 18,400 7.91 16,000 7.23 12,800 6.55 10,200 5.91 8,300 5.26

CLTE100

90 48,000 12.02 42,500 11.22 38,000 10.45 33,000 9.72 28,500 8.99 24,000 8.28 20,500 7.59 16,500 6.9095 45,200 12.14 40,000 11.33 35,300 10.52 30,500 9.75 27,000 8.99 22,500 8.24 19,000 7.53 15,000 6.81

100 42,500 12.26 38,000 11.39 33,000 10.58 29,000 9.78 24,800 8.99 21,000 8.21 17,500 7.47 13,500 6.73110 36,500 12.49 32,500 11.54 28,500 10.61 24,500 9.74 21,000 8.89 17,500 8.07 14,000 7.28 10,000 6.54

MODELSAMBIENT

TEMP(°F)

EVAPORATING TEMPERATURE (°F)-5 -10 -15 -20 -25 -30 -35 -40


CLT22

90 8,835 2.22 7,820 1.97 6,880 1.75 5,940 1.53 5,080 1.50 4,220 1.46 3,435 1.32 2,650 1.1895 8,335 2.26 7,350 2.01 6,435 1.78 5,520 1.54 4,685 1.50 3,850 1.46 3,325 1.33 2,800 1.19

100 7,845 2.30 6,890 2.04 6,000 1.80 5,110 1.55 4,290 1.51 3,470 1.47110 6,885 2.39 5,990 2.11 5,150 1.84 4,310 1.57 3,530 1.52 2,750 1.47

CLT28

90 12,715 2.96 11,260 2.76 10,000 2.57 8,740 2.37 7,685 2.18 6,630 1.98 5.715 1.79 4,800 1.6095 12,105 2.99 10,700 2.78 9,475 2.58 8,250 2.38 7,225 2.18 6,200 1.98 5,305 1.79 4,410 1.60

100 11,485 3.02 10,130 2.81 8,940 2.60 7,750 2.39 6,755 2.19 5,760 1.98 4,890 1.79 4,020 1.59110 10,190 3.08 8,930 2.85 7,820 2.63 6,710 2.41 5,780 2.20 4,850 1.98

CLT44

90 20,035 4.38 17,860 4.15 15,865 3.90 13,870 3.65 12,075 3.39 10,280 3.12 8,635 2.85 6,990 2.5895 18,920 4.40 16,830 4.16 14,905 3.90 12,980 3.64 11,250 3.37 9,520 3.10 7,920 2.83 6,320 2.55

100 17,830 4.42 15,820 4.17 13,975 3.91 12,130 3.64 10,455 3.36 8,780 3.08 7,225 2.80 5,670 2.52110 15,675 4.49 13,860 4.22 12,170 3.93 10,480 3.64 8,925 3.35 7,370 3.05

CLT50

90 24,900 5.77 22,270 5.43 19,880 5.07 17,490 4.70 15,370 4.33 13,250 3.96 11,300 3.58 9,350 3.2095 23,590 5.85 21,050 5.49 18,730 5.12 16,410 4.74 14,345 4.36 12,280 3.97 10,365 3.58 8,450 3.19

100 22,320 5.94 19,870 5.56 17,620 5.17 15,370 4.77 13,355 4.37 11,340 3.97 9,470 3.58 7,600 3.18110 19,850 6.10 17,590 5.67 15,485 5.24 13,380 4.81 11,475 4.39 9,570 3.96 7,785 3.55 6,000 3.13

CLT88

90 40,010 8.74 35,360 8.15 31,245 7.62 27,130 7.08 23,585 6.59 20,040 6.09 16,930 5.64 13,820 5.1995 37,800 8.78 33,370 8.12 29,435 7.60 25,500 7.08 22,100 6.57 18,700 6.06 15,700 5.59 12,700 5.12

100 35,620 8.90 31,420 8.22 27,670 7.67 23,920 7.11 20,665 6.58 17,410 6.04 14,520 5.55 11,630 5.06110 31,325 9.21 27,590 8.50 24,225 7.86 20,860 7.21 17,910 6.63 14,960 6.05

CLT100

90 49,320 11.64 44,040 10.76 39,325 10.01 34,610 9.25 30,500 8.60 26,390 7.94 22,745 7.38 19,100 6.8195 46,620 11.75 41,660 10.85 37,155 10.08 32,650 9.30 27,235 8.63 21,820 7.96 19,820 7.39 17,820 6.81

100 43,940 11.86 39,280 10.15 35,020 10.15 30,760 9.36 27,040 8.68 23,320 7.99 19,970 7.40 16,620 6.81110 38,665 12.11 34,610 10.31 30,865 10.31 27,120 9.48 23,825 8.77 20,530 8.05 17,505 7.43 14,480 6.81

938


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSTechnical ‘Specifications — Air Cooled Units

*Voltage Code.

MCA = Minimum Circuit AmpacityMFS = Maximum Fuse Size

FLA = Full Load Amperage

NOTE: Units with voltage code 1 or 3 have 208-230/1/60 fan motors. Units with voltage code 4 have 460/1/60 fan motors.

*Voltage Code.

NOTE: CMT(E) indicates CMT or CMTE. CLT(E) indicates CLT or CLTE.

ELECTRICAL

CONDENSINGUNIT MODEL

COMPRESSORMODEL

VOLTAGE CODE FAN MOTOR (each)1

208-230/1/603

208-230/3/604

460/3/60 Hp RpmVoltage Code

1 & 3 4MCA MFS MCA MFS MCA MFS FLA FLA

CMT(E)18*A3 MT(Z)18JA 13.6 20 10.0 15 4.1 15

1/15 1550 1.0 0.5CMT(E)22*B3 MT(Z)22JC 17.1 25 11.9 20 5.0 15CMT(E)28*B3 MT(Z)28JE 24.4 40 17.1 25 7.3 15CMT(E)32*B3 MT(Z)32JF 25.3 40 19.9 30 8.1 15CMT(E)36*E1 MT(Z)36JG 30.6 50 23.4 35 9.0 15 1/4 1075 1.8 0.5CMT(E)50*F1 MT(Z)50HK 36.6 60 24.1 40 12.8 20

1/3 1075 1.8 1.0CMT(E)64*G1 MT(Z)64HM 51.0 80 31.2 50 15.4 25CMT(E)72*H1 MT(Z)72HN 30.4 50 15.4 25CMT(E)100*K1 MT(Z)100HS 48.6 75 23.4 35

1/2 1075 3.7 1.9CMT(E)125*L1 MT(Z)125HU 58.5 90 27.9 45CMT(E)144*M1 MT(Z)144HV 67.3 100 30.6 50CMT(E)160*M1 MT(Z)160HW 72.7 110 35.9 60

CLT(E)22*A3 LT(Z)22JE 17.2 25 11.8 20 5.0 151/15 1550 1.0 0.5

CLT(E)28*B3 LT(Z)28JH 24.3 40 17.2 25 5.7 15CLT(E)44*D1 LT(Z)44HM 34.0 50 23.2 35 9.9 15

1/4 1075 1.8 0.5CLT(E)50*E1 LT(Z)50HP 36.6 60 24.1 40 11.7 20CLT(E)88*G1 LT(Z)88HU 34.9 60 17.2 25

1/3 1075 1.8 1.0CLT(E)100*J1 LT(Z)100HW 42.0 70 21.6 35

MECHANICAL


COMPRESSORMODEL

DIMENSIONS (in.) CONNECTIONS (in.)RECEIVERCAPACITY(lb @ 90%)

CONDENSERAIRFLOW

APPROX.SHIPPING

WT (lb)L W HMountingCenters Liquid

(Flare)Suction(ODS)

ML MW CFM Fan (in.)CMT(E)18*A3 MT(Z)18JA

28-3/8 25 14-1/2 27-3/8 15-5/16 3/8 5/8 10.0 1300 11

160CMT(E)22*B3 MT(Z)22JC 165CMT(E)28*B3 MT(Z)28JE 170CMT(E)32*B3 MT(Z)32JF 170CMT(E)36*E1 MT(Z)36JG 39-3/8 31-1/2 22-1/2 37-3/8 19-1/2 1/2 5/8 17.5 2050 14 265CMT(E)50*F1 MT(Z)50HK

47-5/8 35-1/2 24-1/2 45-5/8 21-5/8 1/2 7/8 19.5 4400 18 355CMT(E)64*G1 MT(Z)64HMCMT(E)72*H1 MT(Z)72HN 47-5/8 35-1/2 24-1/2 45-5/8 21-5/8 1/2 1-1/8 26.0 4400 18 360CMT(E)100*K1 MT(Z)100HS 59-1/2 35-1/2 26-1/2 57-1/2 21-5/8 1/2 1-1/8 36.0 7800 22 465CMT(E)125*L1 MT(Z)125HU 59-1/2 35-1/2 30-1/2 57-1/2 21-5/8 1/2 1-1/8 36.0 7800 22 510CMT(E)144*M1 MT(Z)144HV

59-1/2 35-1/2 34-1/2 57-1/2 21-5/8 1/2 1-3/8 43.0 7800 22545

CMT(E)160*M1 MT(Z)160HW 555CLT(E)22*A3 LT(Z)22JE

28-3/8 31-1/2 14-1/2 27-3/8 19-1/2 3/8 5/8 10.0 1300 11165

CLT(E)28*B3 LT(Z)28JH 170CLT(E)44*D1 LT(Z)44HM 39-3/8 31-1/2 22-1/2 37-3/8 19-1/2 1/2 7/8 17.5 2050 14 290CLT(E)50*E1 LT(Z)50HP 39-3/8 31-1/2 22-1/2 37-3/8 19-1/2 1/2 7/8 26.0 2050 14 355CLT(E)88*G1 LT(Z)88HU 47-5/8 35-1/2 24-1/2 45-5/8 21-5/8 1/2 1-1/8 26.0 4400 18 400CLT(E)100*J1 LT(Z)100HW 47-5/8 35-1/2 26-1/2 45-5/8 21-5/8 1/2 1-1/8 36.0 4400 18 410

P4127

*Hole patterns: 4 holes 5/16-in. bolt, 0.354 in. diameter of hole.

939


MANEUROP CMT/CMTE/CLT/CLTE AIR COOLED CONDENSING UNITSOutdoor Enclosures (Air cooled units only, shipped unassembled)

ENCLOSURE KIT MODELS1-A3B3 2-DE 3-FGH 4J 5K 6L 7-M

CMT(E)18 CMT(E)36 CMT(E)50 CLT(E)100 CMT(E)100 CMT(E)125 CMT(E)160CMT(E)22 CLT(E)44 CMT(E)64 CMT(E)144CMT(E)28 CLT(E)50 CMT(E)72CMT(E)32 CLT(E)88CLT(E)22CLT(E)28

P4128

HOUSINGMODEL

DIMENSIONS (in.) APPROX. SHIPPINGWEIGHT (lb)Length Width Height

1-A3B3 28-3/8 25 15-1/2 272-DE 40-9/16 31-5/8 23-1/2 50

3-FGH 48-13/16 35-11/16 25-1/2 654-J 48-13/16 35-5/8 27-1/2 675-K 60-5/8 35-5/8 28-5/8 796-L 60-5/8 35-5/8 32-5/8 837-M 60-5/8 35-5/8 35-1/2 90

940


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSPerformance Data — CMTW High-to-Medium Temperature — R-22

Btu/h = Capacity.kW = Input Power.GPM = Water Flow in gpm.PSI = Water Pressure Drop through condenser in psi.

Rated Conditions: 65° F/*40° F Return Gas, 5° F Subcooling, 60 Hz operation, 105° F Condensing, 75° F Entering Water (30° ITD).For 20° ITD (ITD = condensing temperature - entering water temperature) allow 3 gpm/ton water flow.

MODELEVAPORATING TEMPERATURE (°F)

40 30 25 20 10 0 -10*

CMTW18

Btu/h 17,000 12,800 11,000 9400 6700 4550 2940kW 1.43 1.34 1.29 1.23 1.10 0.96 0.80

GPM 1.9 1.3 1.1 0.9 0.6 0.4 0.3PSI 2.2 1.3 1.0 0.7 0.4 0.3 0.1

CMTW22

Btu/h 23,350 18,150 15,850 13,700 10,000 6850 4230kW 1.88 1.77 1.69 1.61 1.42 1.21 0.98

GPM 3.1 2.2 1.8 1.5 1.0 0.7 0.4PSI 4.8 2.8 2.1 1.6 0.9 0.5 0.2

CMTW28

Btu/h 31,250 25,050 22,250 19,600 15,000 10,900 7450kW 2.48 2.38 2.31 2.23 2.03 1.79 1.54

GPM 3.3 2.5 2.2 1.9 1.5 1.2 0.9PSI 1.8 1.2 0.9 0.8 0.6 0.4 0.3

CMTW36

Btu/h 39,350 31,800 28,350 25,100 19,400 14,300 9940kW 3.30 3.11 2.99 2.87 2.61 2.33 2.05

GPM 5.2 3.7 3.2 2.7 2.0 1.5 1.1PSI 3.7 2.1 1.7 1.3 0.8 0.6 0.4

CMTW50

Btu/h 51,950 40,400 35,450 31,000 23,400 17,250 12,450kW 4.28 3.97 3.80 3.62 3.23 2.82 2.41

GPM 5.2 3.5 2.9 2.4 1.8 1.4 1.1PSI 2.4 1.3 1.0 0.8 0.6 0.4 0.3

CMTW64

Btu/h 66,750 52,450 46,200 40,400 30,500 22,100 15,200kW 5.50 5.17 4.97 4.75 4.26 3.72 3.15

GPM 8.1 5.3 4.3 3.6 2.5 1.8 1.3PSI 3.4 1.8 1.4 1.1 0.8 0.6 0.5

CMTW72

Btu/h 72,600 57,590 50,920 44,740 33,850 24,620 16,900kW 6.14 5.70 5.46 5.22 4.71 4.19 3.66

GPM 7.9 5.9 5.1 4.5 3.5 2.7 1.9PSI 2.4 1.4 1.2 0.9 0.6 0.4 0.2

CMTW80

Btu/h 82,750 65,660 58,060 51,030 38,620 28,090 19,280kW 6.94 6.43 6.16 5.80 5.30 4.71 4.12

GPM 9.9 7.1 6.1 5.2 4.0 3.1 2.2PSI 3.5 2.0 1.5 1.2 0.7 0.5 0.3

CMTW100

Btu/h 101,240 79,340 69,760 61,000 45,830 33,320 23,200kW 7.85 7.56 7.34 7.09 6.49 5.80 5.05

GPM 13.4 8.4 6.8 5.5 3.7 2.6 1.9PSI 4.2 1.8 1.2 0.9 0.5 0.3 0.3

CMTW125

Btu/h 131,510 103,820 91,680 80,550 61,250 45,270 32,270kW 10.39 9.84 9.51 9.15 8.37 7.52 6.64

GPM 17.8 12.2 10.2 8.6 6.4 5.0 4.1PSI 4.6 2.4 1.8 1.4 1.0 0.7 0.6

CMTW144

Btu/h 149,580 117,910 104,070 91,420 69,560 51,560 37,030kW 11.65 11.03 10.66 10.26 9.39 9.45 7.47

GPM 15.7 11.2 9.6 8.3 6.4 5.3 4.0PSI 3.1 1.7 1.3 1.0 0.6 0.5 0.4

CMTW160

Btu/h 165,160 130,280 115,050 101,140 77,100 57,330 41,400kW 13.06 12.37 11.96 11.51 10.54 9.49 8.41

GPM 19.1 13.2 11.2 9.6 7.2 5.6 4.5PSI 4.4 2.3 1.7 1.3 0.8 0.5 0.4

941


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSPerformance Data — CMTEW High-to-Medium Temperature — R-134a


Rated Conditions: 20° F superheat, 5° F Subcooling, 60 Hz operation, 105° F Condensing, 75° F Entering Water (30° ITD).For 20° ITD (ITD = condensing temperature - entering water temperature) allow 3 gpm/ton water flow.


50 40 30 25 20 10 0

CMTEW18

Btu/h 15,561 12,146 9272 8075 6878 4905 3297kW 1.07 1.00 0.92 0.87 09.82 0.73 0.63

GPM 1.5 1.1 0.8 0.7 0.6 0.4 0.3PSI 1.6 1.0 0.6 0.5 0.4 0.2 0.1

CMTEW22

Btu/h 19,618 15,312 11,690 10,181 8672 6184 4156kW 1.35 1.26 1.16 1.11 1.05 0.92 0.80

GPM 2.2 1.6 1.1 0.9 0.8 0.6 0.5PSI 2.8 1.7 1.0 0.8 0.6 0.4 0.2

CMTEW28

Btu/h 24,738 19,308 14,740 12,838 10.935 7798 5240kW 1.70 1.59 1.46 1.39 1.31 1.16 1.00

GPM 2.3 1.7 1.4 1.2 1.1 0.8 0.6PSI 1.0 0.7 0.5 0.4 0.4 0.3 0.2

CMTEW36

Btu/h 31,123 24,291 18,544 16,151 13,757 9810 6593kW 2.13 2.00 1.84 1.75 1.65 1.46 1.26

GPM 3.2 2.3 1.7 1.5 1.3 0.9 0.7PSI 1.6 1.0 0.7 0.67 0.5 0.3 0.3

CMTEW50

Btu/h 44,079 34,403 26,264 22,874 19,484 13,894 9337kW 3.03 2.84 2.60 2.47 2.34 2.07 1.79

GPM 3.5 2.5 1.9 1.6 1.4 1.1 0.8PSI 1.3 0.8 0.6 0.4 0.4 0.3 0.3

CMTEW64

Btu/h 55,440 43,270 33,034 28,770 24,506 17,475 11,744kW 3.81 3.57 3.28 3.11 2.95 2.61 2.25

GPM 5.1 3.5 2.5 2.1 1.8 1.3 1.0PSI 1.7 1.1 0.8 0.7 0.6 0.5 0.44

CMTEW72

Btu/h 62,247 48,583 37,090 32,303 27,515 19,620 13,186kW 4.27 4.01 3.68 3.50 3.31 2.93 2.53

GPM 5.9 4.5 3.5 3.1 2.7 2.0 1.3PSI 1.4 0.9 0.6 0.5 0.4 0.4 0.1

CMTEW80

Btu/h 69,889 54,547 41,643 36,268 30,892 22,029 14,805kW 4.80 4.50 4.14 3.94 3.73 3.29 2.84

GPM 10.4 8.2 6.3 5.5 4.7 3.3 2.1PSI 3.9 2.5 1.6 1.3 1.0 0.6 0.3

CMTEW100

Btu/h 88,149 68,799 52,524 45,744 38,964 27,785 18,672kW 6.05 5.67 5.21 4.95 4.69 4.14 3.58

GPM 9.1 5.9 3.9 3.3 2.8 2.0 1.4PSI 2.1 1.0 0.5 0.4 0.4 0.3 0.2

CMTEW125

Btu/h 110,888 86,547 66,073 57,544 49,015 34,952 23,489kW 7.62 7.14 6.56 6.23 5.91 5.21 4.51

GPM 12.2 8.6 6.3 5.5 4.9 4.1 3.6PSI 2.4 1.4 0.9 0.8 0.7 0.5 0.5

CMTEW144

Btu/h 124,493 97,166 74,179 64,604 55,029 39,240 26,371kW 8.55 8.02 7.36 7.00 6.63 5.85 5.06

GPM 11.0 8.2 6.3 5.6 4.9 3.9 3.1PSI 1.6 1.0 0.6 0.5 0.5 0.3 0.3

CMTEW160

Btu/h 139,768 109,088 83,280 72,530 61,780 44,055 29,607kW 9.60 9.00 8.48 7.96 7.45 6.57 5.68

GPM 13.3 9.6 7.2 6.3 5.5 4.3 3.3PSI 2.2 1.3 0.8 0.6 0.5 0.4 0.3

942


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSPerformance Data — CMTW Medium-to-Low Temperature — R-502




25 20 10 0 -10 -20*

CMTW18

Btu/h 11,900 10,300 7500 5200 3400 1950kW 1.31 1.25 1.12 0.98 0.83 0.68

GPM 1.2 1.0 0.7 0.5 0.3 0.2PSI 1.1 0.9 0.5 0.3 0.2 0.1

CMTW22

Btu/h 16,650 14,650 11,000 7800 4950 2450kW 1.73 1.65 1.44 1.22 0.98 0.74

GPM 2.0 1.7 1.1 0.8 0.5 0.2PSI 2.3 1.8 1.0 0.6 0.3 0.1

CMTW28

Btu/h 23,300 20,900 16,450 12,300 8500 5050kW 2.37 2.28 2.08 1.84 1.59 1.32

GPM 2.3 2.1 1.6 1.3 0.9 0.7PSI 1.0 0.9 0.6 0.4 0.3 0.2

CMTW36

Btu/h 29,750 26,750 21,200 16,150 11,550 7400kW 3.09 2.98 2.70 2.39 2.04 1.68

GPM 3.4 3.0 2.2 1.7 1.3 0.9PSI 1.8 1.5 1.0 0.6 0.4 0.3

CMTW50

Btu/h 40,200 35,800 27,900 21,000 15,000 9850kW 4.23 4.10 3.75 3.35 2.89 2.41

GPM 3.5 3.0 2.2 1.7 1.3 0.9PSI 1.3 1.1 0.7 0.5 0.4 0.3

CMTW64

Btu/h 50,500 45,050 35,150 26,500 18,950 12,450kW 55.55 5.31 4.78 4.20 3.59 2.96

GPM 5.2 4.3 3.1 2.2 1.6 1.1PSI 1.7 1.4 0.9 0.7 0.5 0.4

CMTW72

Btu/h 55,990 50,050 39,250 29,800 21,550 14,400kW 6.19 5.93 5.36 4.70 4.10 3.48

GPM 5.8 5.1 4.1 3.3 2.4 1.7PSI 1.4 1.2 0.8 0.6 0.3 0.2

CMTW80

Btu/h 63,240 56,520 44,310 33,670 24,440 16,480kW 7.02 6.72 6.04 5.32 4.57 3.62

GPM 7.0 6.1 4.7 3.7 2.8 1.9PSI 2.0 1.6 1.0 0.7 0.4 0.2

CMTW100

Btu/h 74,950 55,800 52,020 39,170 28,040 18,480kW 8.04 7.75 7.12 6.45 5.75 5.04

GPM 7.9 6.5 4.5 3.2 2.3 1.7PSI 1.6 1.2 0.6 0.4 0.3 0.2

CMTW125

Btu/h 97,290 86,410 67,290 51,390 38,320 27,740kW 10.01 9.63 8.85 8.07 7.29 6.54

GPM 13.0 9.6 7.1 5.5 4.5 3.9PSI 2.7 1.7 1.1 0.8 0.6 0.6

CMTW144

Btu/h 103,050 91,360 72,740 59,810 44,280 30,570kW 11.56 11.10 10.15 9.21 8.29 7.40

GPM 9.8 8.5 6.8 5.7 4.6 3.7PSI 1.3 1.0 0.7 0.6 0.4 0.3

CMTW160

Btu/h 122,630 109,440 85,703 65,720 49,050 35,310kW 13.30 12.74 11.61 10.50 9.41 8.36

GPM 12.6 10.8 8.2 6.4 5.1 4.1PSI 2.1 1.6 1.0 0.7 0.5 0.4

943


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSPerformance Data — CMTEW High-to-Low Temperature — R-404A, R-507


Rated Conditions: 20° F Superheat, 5° F Subcooling, 60 Hz operation, 105° F Condensing, 75° F Entering Water (30° ITD).For 20° ITD (ITD = condensing temperature - entering water temperature) allow 3 gpm/ton water flow.


40 30 25 20 10 0 -10 -20 -25

CMTEW18

Btu/h 18,402 14,590 12,647 11,023 8026 5674 3810 2351 1672kW 1.51 1.48 1.44 1.38 1.25 1.10 0.93 0.79 0.67

GPM 2.1 1.6 1.3 1.1 0.8 0.5 0.4 0.3 0.2PSI 2.6 1.7 1.3 1.0 0.6 0.4 0.2 0.1 0.1

CMTEW22

Btu/h 25.859 20,509 17,834 15,564 11,348 8026 5432 3323 2351kW 2.12 2.07 2.02 1.92 1.75 1.55 1.30 1.07 0.88

GPM 3.7 2.7 2.3 1.9 1.3 0.9 0.6 0.4 0.3PSI 6.5 3.8 2.9 2.2 1.2 0.7 0.4 0.2 0.1

CMTEW28

Btu/h 32,504 25,940 23,185 20,266 15,238 11,348 7622 5268 4297kW 3.04 2.84 2.72 2.62 2.36 2.08 1.85 1.59 1.39

GPM 3.8 2.8 2.4 2.1 1.6 1.3 0.9 0.7 0.6PSI 2.2 1.4 1.1 0.9 0.6 0.4 0.3 0.3 0.2

CMTEW36

Btu/h 41,016 32,749 29,182 25,534 19,293 14,348 9726 6810 5513kW 3.82 3.57 3.42 3.30 2.97 2.62 2.35 2.00 1.75

GPM 5.9 4.1 3.5 2.9 2.1 1.6 1.2 0.9 0.8PSI 4.5 2.5 1.9 1.5 0.9 0.5 0.4 0.3 0.3

CMTEW50

Btu/h 57,228 46,610 41,746 37.694 29,021 21,803 15,483 10,700 6971kW 5.50 5.10 4.77 4.57 4.07 3.55 3.05 2.55 2.33

GPM 7.1 4.7 4.0 3.4 2.4 1.6 1.3 1.0 0.8PSI 3.9 2.0 1.6 1.3 0.8 0.5 0.4 0.3 0.3

CMTEW64

Btu/h 71,982 57,656 52,606 47,339 36,559 27,398 19,454 13,376 8754kW 7.06 6.55 6.12 5.87 5.22 4.57 3.90 3.25 2.98

GPM 10.6 6.9 5.8 4.9 3.3 2.4 1.7 1.2 1.0PSI 5.3 2.6 2.0 1.6 1.0 0.7 0.6 0.4 0.4

CMTEW72

Btu/h 80,815 65,821 59,090 53,174 41,016 30,721 21,722 15,077 9809kW 8.07 7.47 7.00 6.70 5.97 5.22 4.45 3.75 3.43

GPM 10.3 7.5 6.5 5.7 4.4 3.3 2.5 1.8 1.2PSI 3.9 2.2 1.7 1.4 0.9 0.6 0.4 0.2 0.1

CMTEW80

Btu/h 90,787 73,927 66,305 59,658 46,040 34,531 24,477 16,858 11,025kW 9.18 8.50 7.95 7.63 6.78 5.93 5.05 4.25 3.88

GPM 13.2 9.3 7.8 6.8 5.1 3.9 2.9 2.1 1.5PSI 6.2 3.3 2.4 1.9 1.1 0.7 0.5 0.3 0.2

CMTEW100

Btu/h 114,131 91,597 81,304 72,062 56,577 43,933 32,181 24,073 19,941kW 9.15 9.37 8.55 8.25 7.60 6.92 6.10 5.10 4.80

GPM 18.3 12.2 9.3 7.6 5.2 3.7 2.6 1.9 1.7PSI 7.2 3.5 2.2 1.5 0.8 0.5 0.3 0.3 0.2

CMTEW125

Btu/h 139,870 113,805 102,213 90,704 71,089 55,283 40,530 30,237 25,128kW 12.27 11.42 10.97 10.60 9.72 8.87 7.85 6.55 6.15

GPM 21.2 14.9 12.6 10.6 7.8 6.0 4.8 4.0 3.8PSI 6.4 3.4 2.5 1.9 1.2 0.9 0.7 0.6 0.5

CMTEW144

Btu/h 157,982 127,830 114,779 102,830 79,924 62,090 45,475 35,000 28,128kW 13.87 12.91 12.40 11.97 11.02 10.05 8.85 7.40 6.95

GPM 18.2 13.1 11.3 9.8 7.6 6.0 4.8 4.0 3.5PSI 4.0 2.2 1.7 1.3 0.9 0.6 0.4 0.4 0.3

CMTEW160

Btu/h 176,385 143,477 128,889 114,299 89,652 69,711 51,067 38,098 31,614kW 15.95 14.85 14.25 13.75 12.65 11.55 10.20 8.50 8.00

GPM 23.4 16.4 13.9 11.8 8.8 6.9 5.4 4.3 3.9PSI 6.3 3.3 2.5 1.8 1.1 0.7 0.5 0.4 0.3

944


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSPerformance Data — CLTEW — Extra Low Temperature — R-404A, R-507


Rated Conditions: 20° F Superheat, 5° F Subcooling, 60 Hz operation, 105° F Condensing, 75° F Entering Water (30° ITD).For 20° ITD (ITD = condensing temperature - entering water temperature) allow 3 gpm/ton water flow.

Performance Data — CLTW Extra Low Temperature — R-502



MODELSEVAPORATING TEMPERATURE (°F)

-5 -10 -15 -20 -25 -30 -35 -40Btu/h kW Btu/h kW Btu/h kW Btu/h kW

CLTEW22

Btu/h 8997 7833 6755 5757 4831 3979 3199 2370kW 1.83 1.71 1.59 1.47 1.35 1.22 1.10 0.97

GPM 1.1 0.9 0.8 0.6 0.5 0.4 0.4 0.3PSI 0.9 0.7 0.6 0.5 0.4 0.3 0.2 0.1

CLTEW28

Btu/h 13,331 11,619 10,020 8550 7177 5907 4733 3495kW 2.71 2.54 2.37 2.19 2.00 1.82 1.63 1.45

GPM 2.0 1.6 1.4 1.1 0.9 0.8 0.6 0.5PSI 2.3 1.8 1.3 1.0 0.8 0.5 0.4 0.3

CLTEW44

Btu/h 23,349 19,872 16,808 14,119 11,778 9747 8009 6076kW 4.61 4.34 4.05 3.75 3.44 3.12 2.81 2.48

GPM 2.1 1.8 1.6 1.4 1.2 1.0 0.9 0.8PSI 0.7 0.6 0.5 0.4 0.5 0.3 0.3 0.3

CLTEW50

Btu/h 29,158 25,301 21,810 18,658 15,808 13,250 10,958 8489kW 5.83 5.52 5.20 4.86 4.51 4.17 3.81 3.46

GPM 2.9 2.5 2.1 1.8 1.6 1.4 1.2 1.0PSI 1.0 0.8 0.7 0.6 0.5 0.4 0.4 0.3

CLTEW88

Btu/h 43,900 37,706 32,120 27,120 22,639 18,641 15,103 11,258kW 8.46 8.05 7.57 7.06 6.51 5.92 5.31 4.69

GPM 5.6 4.5 3.7 3.0 2.5 2.0 1.7 1.4PSI 1.9 1.5 1.1 0.9 0.8 0.6 0.6 0.5

CLTEW100

Btu/h 57,245 49,353 42,197 35,734 29,904 24,653 19,957 14,.891kW 10.58 10.01 9.39 8.75 8.07 7.36 6.65 5.93

GPM 7.7 6.5 5.5 4.7 4.1 3.5 2.9 2.4PSI 2.3 1.7 1.3 1.0 0.8 0.6 0.5 0.3

MODELSEVAPORATING TEMPERATURE (°F)

-5 -10 -15 -20 -25 -30 -35 -40Btu/h kW Btu/h kW Btu/h kW Btu/h kW

CLTW22

Btu/h 9125 7900 6800 5700 4750 3800 2950 2100kW 1.69 1.63 1.54 1.45 1.34 1.22 1.09 0.96

GPM 1.0 0.9 0.8 0.6 0.5 0.4 0.3 0.3PSI 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1

CLTW28

Btu/h 14,000 12,150 10,625 8100 7850 6600 5550 4500kW 2.71 2.55 2.38 2.20 2.02 1.83 1.64 1.45

GPM 2.0 1.7 1.5 1.2 1.0 0.8 0.6 0.5PSI 2.5 1.9 1.5 1.1 0.9 0.6 0.5 0.4

CLTW44

Btu/h 21.975 19,100 16,650 14,200 12,050 9900 8050 6200kW 4.05 3.84 3.60 3.36 3.09 2.82 2.54 2.25

GPM 1.9 1.7 1.5 1.3 1.2 1.0 0.9 0.7PSI 0.6 0.5 0.4 0.4 0.4 0.3 0.3 0.2

CLTW50

Btu/h 27,650 24,200 21,225 18,250 15,675 13,100 10.825 8550kW 5.23 4.98 4.67 4.36 4.01 3.65 3.28 2.90

GPM 2.6 2.3 2.0 1.7 1.5 1.3 1.1 0.9PSI 0.9 0.7 0.6 0.5 0.5 0.4 0.3 0.3

CLTW88

Btu/h 44,425 38,150 33,000 27,850 23,675 19,500 16,050 12,600kW 7.86 7.36 6.86 6.35 5.86 5.36 4.88 4.40

GPM 5.4 4.3 3.5 2.8 2.4 2.0 1.7 1.4PSI 1.8 1.4 1.1 0.9 0.7 0.6 0.5 0.5

CLTW100

Btu/h 56,995 49,250 42,950 36,640 31,615 26,590 22,655 18,720kW 10.57 9.82 9.14 8.45 7.83 7.20 6.64 6.08

GPM 7.7 6.4 5.5 4.7 4.1 3.6 3.1 2.7PSI 2.3 1.7 1.3 1.0 0.8 0.6 0.5 0.4

945


MANEUROP CMTW/CMTEW/CLTW/CLTEW WATER COOLED CONDENSING UNITSTechnical Specifications — Water Cooled Units

*Voltage Code.MCA = Minimum Circuit AmpacityMFS = Maximum Fuse Size

*Voltage Code.ML = distance between mounting holes on “L” side.MW = distance between mounting holes on “W” side.NOTE: CMT(E)W indicates CMTW or CMTEW. CLT(E) indicates CLTW or CLTEW.

ELECTRICAL


COMPRESSORMODEL

VOLTAGE CODE1

208-230/1/603

208-230/3/604

460/3/60MCA MFS MCA MFS MCA MFS

CMT(E)W18* MT(Z)18JA 11.6 20 8.0 15 3.1 15CMT(E)W22* MT(Z)22JC 15.1 25 9.9 15 4.0 15CMT(E)W28* MT(Z)28JE 22.4 40 15.1 25 6.3 15CMT(E)W36* MT(Z)36JG 26.8 45 19.6 35 8.0 15CMT(E)W50* MT(Z)50HK 33.0 50 20.5 35 10.8 15CMT(E)W64* MT(Z)64HM 47.4 80 27.6 50 13.4 20CMT(E)W72* MT(Z)72HN 26.8 45 13.4 20CMT(E)W80* MT(Z)80HP 37.5 60 20.5 35CMT(E)W100* MT(Z)100HS 38.4 60 19.6 35CMT(E)W125* MT(Z)125HU 48.3 80 24.1 40CMT(E)W144* MT(Z)144HV 57.1 100 26.8 45CMT(E)W160* MT(Z)160HW 62.5 110 32.1 50CLT(E)W22* LT(Z)22JE 17.0 25 11.0 20 4.5 15CLT(E)W28* LT(Z)28JH 26.0 40 17.0 25 5.3 15CLT(E)W44* LT(Z)44HM 34.0 60 22.0 35 10.0 15CLT(E)W50* LT(Z)50HP 37.0 60 23.0 40 12.0 20CLT(E)W88* LT(Z)88HU 38.0 50 17.0 25CLT(E)W100* LT(Z)100HW 43.0 60 22.0 35

MECHANICAL


COMPRESSORMODEL

DIMENSIONS (in.) CONNECTIONS (in.)RECEIVERCAPACITY(lb @ 90%)

APPROX.SHIPPING

WT (lb)L W HMountingCenters Liquid

(Flare)Suction(ODS)

Water(FPT)

ML MWCMT(E)W18* MT(Z)18JA

24 18 15-3/4 22 16 3/8 5/8 3/8 10.0135

CMT(E)W22* MT(Z)22JC 140CMT(E)W28* MT(Z)28JE 24 18 15-3/4 22 15 3/8 7/8 1/2 10.0 140CMT(E)W36* MT(Z)36JG 25-1/4 21 22 23-1/4 19 1/2 7/8 1/2 10.0 140CMT(E)W50* MT(Z)50HK

25-1/4 21 22 23-1/4 19 1/2 7/8 3/4 16.0 190CMT(E)W64* MT(Z)64HMCMT(E)W72* MT(Z)72HN

25-1/4 21 22 23-1/4 19 1/2 1-1/8 3/4 16.0 195CMT(E)W80* MT(Z)80HPCMT(E)W100* MT(Z)100HS

31-1/2 28-3/8 25 30-1/2 26-3/8 1/2 1-1/8 1 26.0 290CMT(E)W125* MT(Z)125HUCMT(E)W144* MT(Z)144HVCMT(E)W160* MT(Z)160HWCLT(E)W22* LT(Z)22JE 24 18 15-3/4 22 16 3/8 5/8 3/8 10.0 140CLT(E)W28* LT(Z)28JH 24 18 15-3/4 22 16 3/8 7/8 3/8 10.0 140CLT(E)W44* LT(Z)44HM 25-1/4 21 19-1/2 23-1/4 19 1/2 7/8 1/2 16.0 180CLT(E)W50* LT(Z)50HP 25-1/4 21 22 23-1/4 19 1/2 7/8 1/2 16.0 190CLT(E)W88* LT(Z)88HU

3-1/2 28-3/8 25 3-1/2 26-3/8 1/2 1-1/8 3/4 26.0270

CLT(E)W100* LT(Z)100HW 290

P4129

946

REFRIGERATION ENCLOSURES

CONPAK REFRIGERATION ENCLOSURES — PSE Series9 Sizes Accommodate Most Condensing Units 1/2 thru 10 Horsepower Units• Galvanized steel base.

• Galvanized steel cabinet embossed — 20 ga.

• Hinged access for easier servicing.

• Wind safety latch — see insert.

• Shipped knocked down for convenient warehousing.

• Easily assembled in the shop or on the job.

• All necessary fasteners provided.

All Season Weather Protection

• Front louvers are at a 45-degree angle.

• Rain trough under hinge to catch moisture that might seep through hinge.

• Condenser screen protected with a high-temperature baked-on clear lacquer coating.

P4235

P4234

947


CON-PAK REFRIGERATION ENCLOSURES — PSE SeriesDimensions

NOTE: Numbers in parenthesis ( ) indicate interior dimensions in clear.

CON-PAKPSE-

DIMENSIONS (in.)ANCHOR BOLT

HOLD CENTERS (in.) APPROXSHIP. WT (lbs)

HOODPROJECTION

L3L W H L2 W2181D 27 (26) 20 (20) 20 (16) 22-1/2 21-1/4 41 —191D 29-1/2 (28-1/2) 37 (37) 27-1/2 (22-1/2) 29-1/4 33 83 —201D 27 (26) 24-1/2 (24-1/2 22 (18) 22-1/2 25-3/4 49 —231D 35-1/2 (34-1/2) 24 (24) 25 (21) 31 25-1/4 69 —241D 29-1/2 (28-1/2) 37 (37) 27-1/2 (22-1/2) 29-1/4 33 83 —311D 33-1/2 (32-1/2) 48-1/2 (48-1/2) 35-1/2 (30-1/2) 33-1/4 44-1/2 121 15-1/2331D 46-1/2 (45-1/2) 38 (38) 38 (33) 46-1/4 34 141 16-1/2401D 33-1/2 (32-1/2) 48-1/2 (48-1/2) 45 (40) 33-1/4 44-1/2 135 20-1/2411D 42-1/2 (41-1/2) 74 (74) 45-1/2 (40-1/2) 42-1/4 70 270 21-1/2

PSE-181D, PSE-201D, PSE-231D

PSE-191D, PSE-241D

PSE-311D, PSE-331D, PSE-401D, PSE-411D

P4236

P4237

P4238

948


CON-PAK REFRIGERATION ENCLOSURES — PSE SeriesSelections for Copeland Air-Cooled Condensing Units

PSE-181DDBAH-0050 EJAL-A050 F3AM-A078 FJAF-A074 M2FH-0020DBAL-0050 EJAL-A075 F3AM-A101 FJAF-A075 M2FH-0024DBAM-0050 EJAL-A100 F3AM-A102 FJAF-A078 M2FH-0026E3AH-A050 EJAL-A101 F3EH-0035 FJAF-A100 M2FH-0033E3AH-A075 EJCL-A050 F3EH-0050 FJAF-A101 M2FH-0049E3AH-A100 EJCL-A075 F3EH-A049 FJAL-A101 M2FH-0050E3AH-B075 EJCL-A100 F3EH-A304 FJCF-A050 M2FH-0056E3AL-0052 EJWL-0075 F3EM-0051 FJCF-A075 M2FL-0023E3AL-0077 ELAL-A033 F3EM-A049 FJCF-A100 M2FL-0025E3AL-0101 ELAL-A050 F3WM-0078 FJEF-0050 M2FL-0033E3AL-A101 ELAL-A051 F3WM-0101 FJEF-0075 M2YH-0033E3AM-A050 ELAL-A075 FAAH-A033 FTAF-A034 F4FH-0022E3AM-A075 ELAL-A100 FAAH-A050 FTAF-A058 M4FH-0025E3AM-A100 ELCL-A051 FAAL-A034 FTAH-A025 M4FH-0036E3WM-0050 ELCL-A075 FBAH-0050 FTAH-A033 M4FH-0050E3WM-0075 ELCL-A100 FBAH-0051 FTAH-A050 M4FL-0033E7AB-A033 F3AF-0105 FBAH-0075 FTAH-A074 M4FL-0040E7AB-A050 F3AF-A050 FBAH-0100 FTAH-A075 MBFH-0026E7AB-A075 F3AF-A075 FBAH-A025 FTAH-A100 MBFH-0033E7AB-A100 F3AF-A100 FBAH-A033 FTAH-A101 MBFH-0049EBAH-0050 F3AF-0150 FBAH-A050 FTAL-A050 MBFH-0050EBAH-0075 F3AH-0150 FBAH-A075 FTAM-A050 MBFL-0028EBAH-0100 F3AH-0152 FBAH-A100 FTAM-A059 MBFL-0034EBAL-0050 F3AH-A035 FBAH-A101 FTAM-A074 MBFL-0050

EBAL-00975 F3AH-A050 FBAL-0050 FTAM-A075 MCFH-0027EBAL-0100 F3AH-A056 FBAL-A034 FTCL-0050 MCFH-0036EBAL-A033 F3AH-A074 FBAL-A050 FTEF-0034 MCFH-0049EBAL-A050 F3AH-A075 FBAM-0050 FTEF-A032 MCFH-0050EBAL-A075 F3AH-A078 FBAM-0051 FTEH-0025 MGFH-0017EBAL-A100 F3AH-A100 FBAM-0075 FTEH-0033 MGFH-0020EBAM-0050 F3AH-A101 FBAM-0100 FTEH-0050 MGFH-0024EBAM-0075 F3AH-B074 FBAM-A050 FTEH-A024 MGFL-0013EBAM-0100 F3AH-B075 FBAM-A075 FTEH-A032 MGFL-0017EBAM-A050 F3AM-A051 FBAM-A100 FTEH-A049 MGFL-0023EBAM-A07 F3AM-A059 FBAM-A101 FTEL-0050 MMFH-0022

EBAM-A100 F3AM-A074 FJAF-A050 FTEM-0050 MSYH-0025EJAL-A033 F3AM-A077 FJAF-A056 M2FH-0017 MSYH-0033

PSE-331DC3AH-0303 C3DD-0750 C7DB-0750 CDAH-0500 CMDL-0301C3AH-0503 C3DD-0751 CBAH-0503 CJAL-0300 CMDL-0400C3AL-0300 C3DH-0501 CBAL-0303 CJDL-0300 CMDL-0601C3AL-0503 C3DH-0502 CBAM-0303 CJDL-0400 CMDL-0602C3AM-0203 C3DL-0301 CBAM-0503 CJDL-0600 CMDL-0750C3AM-0303 C3DL-0401 CBAM-0753 CJDL-0601 CMDL-0900C3AM-0503 C3DL-0602 CBAU-0503 CJDL-0750 CTDH-0300C3AT-0753 C3DL-0603 CBDH-0500 CJDL-0900 CTDH-0500C3AU-0503 C3DL-0901 CBDL-0501 CLAL-0299 CTDH-0750C3AU-0753 C7AB-0300 CBDL-0751 CLAL-0300

PSE-411DC3AU-1003 C3DL-1500 CJDL-1000 WJWL-0300C3AU-1004 C3DL-1501 CJDL-1500 CBDD-1001C3DD-1001 C7DB-1000 CMDL-1000C3DH-1011 CBAL-1001 CTDH-1000

PSE-231D PSE-201DC3AH-0075 CBAM-0103 D3AH-0075 F3EH-B075C3AH-0100 CBAM-0153 D3AH-0100 F3EM-0077C3AH-0150 CBAM-0203 D3AM-0075 F3EM-0078C3AH-0203 CJAL-0100 D7AB-0075 F3EM-0101C3AL-0153 CJAL-0150 DBAH-0075 F3EM-0102C3AM-0075 CJAL-0151 DBAL-0075 F3WD-0150C3AM-0100 CJAL-0200 DBAM-0075 FJAL-A200C3AM-0200 CLAL-0100 DJAL-0070 FJAL-A250C3AM-0202 CLAL-0150 DLAL-0075 FJAL-A300C3AM-0203 CLAL-0151 EJAE-0175 FJAM-A106C7AB-0075 CLAL-0200 ELAL-A152 FJAM-A125C7AB-0100 CLAL-0299 F3AD-A151 FJAM-A126C7AB-0150 CTAH-0200 F3AF-0150 FJAM-A150C7AB-0200 F3AM-A105 F3AH-0152 FTAH-A150CBAL-0078 W2WH-0150 F3AM-A105 FTEH-0075CBAL-0103 W2WH-0300 F3AM-A175 FTEM-0075CBAL-0153 W7WB-0150 F3AM-A201CBAL-0203 WJWL-0150 F3EH-0101CBAM-0078 CBAH-0078

PSE-241DDLAL-0301 FJAL-A301 V3AH-015H VJAF-025HF3AD-0201 FJAM-A201 V3AH-020H VJAF-030HF3AD-0225 FJAM-A225 V3AH022H VJAL-005SF3AD-0301 FJAM-A300 V3AH-030H VJAL-007SF3AD-0325 FJAM-A325 V3AH-032H VJAL-010SF3AD-A201 FTAH-A200 V3AH-040H VJAL-015SF3AD-A201 FTAH-A201 V3AH-050H W2WH-010F3AD-A225 FTAH-A300 VJAF-012HF3AD-A301 V3AH-010H VJAF-017HF3AD-A325 V3AH-012H VJAF-020H

PSE-311DF3AD-A401 VJAF-025Z VJAL-025Z W7WB-0200F3AD-A501 VJAF-035Z VJAL-035Z CLAL-0300VJAF-035H VJAF-040Z VJAL-040Z FJAM-A400VJAF-040H VJAF-050Z VJAL-050Z FJAM-A500VJAF-022Z VJAL-022Z CLAL-0300

PSE-331DD3AH-0100 D7AB-0150 DBAM-0200 DLAL-0200 VJAF-030HD3AH-0150 D7AB-0200 DJAL-0100 DLAL-0201 VJAL-005SD3AH-0200 DBAH-0150 DJAL-0150 E3AL-0175 VJAL-007SD3AL-0152 DBAL-0100 DJAL-0151 V3AH-010H VJAL-010SD3AL-0201 DBAL-0150 DJAL-0200 V3AH-012H VJAL-015SD3AM-0100 DBAL-0200 DJAL-0300 VJAF-012HD3AM-0200 DBAL-0202 DLAL-0075 VJAF-017HD3AM-0201 DBAM-0100 DLAL-0100 VJAF-020HD7AB-0100 DBAM-0150 DLAL-0150 VJAF-029H

PSE-401DF3AH-0750 F3AH-0900 F3AH-1200F3AH-0751 F3AH-1000

Listed — No. 2L13For all Copeland Condensing Units

949


CON-PAK REFRIGERATION ENCLOSURES — PSE SeriesSelections for Tecumseh Air-Cooled Condensing Units

PSE-181DAE4430AC AEA9415ZXAXC AJ7465YE AK9433EBAE4430YC AEA9417EXAXB AJ9486EC AK9433ECAE4440AB AEA9417EXAXC AJA2422ZXAXB AK9434ACAE4440AC AEA9417EXAXG AJA2422ZXAXC AK9441ACAE4440AL AEA9422ZXAXA AJA2425AXAXB AK9446ECAE4440YB AEA9422ZXAXB AJA2425AXAXC AK9458JCAE4440YC AEA9422AXAXC AJA2425AXDXC AK9461ECAE4440YL AEA9423EXAXA AJA2429AXAXA AK9466JCAE4448AC AEA9423EXAXB AJA2429ZXAXB AK9470ECAE4448YC AEA9423EXAXC AJA4461AXAXB AK9474JC

AEA2410AXAXC AH2435AC AJA4461AXAXC AKA4460YXAXBAE2410AXAXC AH4518AC AJA4461AXDXC AKA4460YXAXC

AEA2413ZXAXC AHA2435AXDXC AJA4492AXAXC AKA4460YXDXCAEA2415AABXC AHA7480AXDXC AJA4492AXDXC AKA4476YXAXCAEA4430AXAXA AHA7480AXFXC AJA4492YXAXC AK4476YXDXCAEA4430AXAXB AJ2422YC AJA4492YXDXC AKA9429ZXAXCAEA4430AXAXC AJ2422YD AJA4512AXDXC AK9433EXAXBAEA4430YXAXA AJ2425AB AJA4512YXDXC AKA9433EXAXCAEA4430YXAXB AJ2425AC AJA7441AXAXC AKA9433EXAXDAEA4430YXAXC AJ4425AC AJA7441AXDXC AKA9433EXDXCAEA4440AXAXB AJ4461AB AJA7465AXAXE AK9446EXAXCAEA4400AXAXC AJ4461AC AJH7465YXAXE AKA9446EXAXDAEA4440AXAXL AJ4492AC AJA7465YXDXE AKA9446EXDXCAEA4440YXAXB AJ4492YC AJA7480ZXDXC AKA9446EXDXDAEA4440YXAXC AJ4512AC AJA9486EXDXC AK9460ZXDXCAEA4440YXAXL AJ4512YC AJA9486EXDXD AKA9461EXDXCAEA4448AXAXC AJ7441AC AJB7465AXDXE AKA9461EXDXDAEA4448YXAXC AJ7465AC AK4460YB AKA9470EXDXCAEA9145ZXAXA AJ7465AE AK4460YC AKA9470EXDXDAEA9415ZXAXB AJ7465BE AK4476YC

PSE-201DAH2445AC AH7480AC AHA2478ZXBXC AHA7514AXDXCAH2466AC AH7511AC AH2478ZXFXC AHB7511AXDXCAH2478JC AH7511BC AHA2410ZXDXC AWE4520EXDXCAH2494JC AH7514AC AHA2410AXFXC AWE4520EXTXC

AH2410 AH7515JC AHA4518AXDXC AWG4520EXDXCAH2411AC AHA2445AXDXC AHA4520EXDXC AWG4520EXNXCAH4518AC AHA2466AXDXC AHA4520EXFXC AWG4520EXTXCAH4520EC AHA2468AXFXC AHA7511AXFXC

PSE-401DAN4590GM AN4612GM SFA4587EXGXC SFA4612EXGXCAN4590HM AN4612HM SFA4587EXTXC SFA4612EXTXC

PSE-311DAG4547AM SC030LMXAAG4553EM SC030XMHAAG4563EM SC050LMXAAG4572EM SC050XMHA

AGA4553EXNXM SFA7533ZXGXCAGA4553EXTXM SFA7533ZXTXC

AGA4563EM SFA7537ZXGXCAGA4563EXNXM SFA7537AXNXCAGA4563EXTXM SFA7537ZXTXC

AGA4572EM SFA7541ZXGXCAGA4572EXNXM SFA7541ZXTXCAGA4572EXTXM

PSE-241DAG4534AM AHA2412ZXDXM AVA4540EXTXM SFA2413ZXNXCAH2480JC AHA2412ZXFXM AWE4524EXDXM SFA2513ZXTXCAH2412KM AHA4524EXDXM AWE4524EXTXM SFA2415ZXGXCAH2413AX AHA4524EXFXM AWG4524EXNXM SFA2514ZXNXCAH4524EM AHA4534EXDXM AWG4524EXTXM SFA2514ZXTXCAH4525AC AHA4534EXFXM AWG4530EXNXN SFA2516ZXGXCAH4534EM AHA4540EXDXM AWG4530EXTXM SFA2516AXTXCAH4540EM AHA4540EXFXM SC020LMXAAH7524JC AVA4540EXNXM SFA2513ZXGXC

Listed — No. 2L13For all Copeland Condensing Units

950


CON-PAK REFRIGERATION ENCLOSURES — PSE SeriesSelections for Coldflow, Frick Blu-Cold, Keeprite, Totaline, and Maneurop

Keeprite Models

Coldflow Models

Totaline Models

Frick Blu-Cold Maneurop

PSE-181D PSE-201D PSE-241D PSE-311DHCUA050H1AAM HCUA075L1ADE HCUA150H2ADF HCUA200H2ADF HCUA350H2ADHCHUA050H1AAN HCUA075M1AAE HCUA150L1ADG HCUA200LSADG HCUA400H2ADHHCUA050H1ADP HCUA075M1ADE HCUA150LSADG HCUA200MADG HCUA500H2ADHHCUA050H1ADN HCUA075MSAAE HCUA150M1ADG HCUA300H2ADF HCUA5002AHHHHCUA050H1AAM HCUA075MSADE HCUA150M5ADG HCUA300M5ADGHCUA050L1AAN HCUA100H2ADDHCUA050L1ADP HCUA100L1ADEHCUA050L1ADN HCUA100LSADEHCUA075H1AAD HCUA100M1ADEHCUA075H1ADD HCUA100MSADEHCUA075L1AAE

PSE-181D PSE-201D PSE-241D PSE-311DCCH-0050AA-H1-B CCH-0100AB-H-1-B CCH-0200BB-M/N-2C CCH-0300BB-H1-CCCH-0050AB-H1-B CCH-0150AB-H1-C CCH-0200BC-M/H2-C CCH-0400BB-M/H2-CCCH-0050AA-L1-B CCH-0150AB-L1-C CCH-0200BB-H1-C CCH-0040BC-M/N2-CCCH-0050AB-L1-B CCH-0150AB-L5-C CCH-0300BB-L5-D CCH-0500BB-M/H2-CCCH-0075AB-H1-B CCH-0150AC-L5-C CCH-0300BC-L5-D CCH-0500BC-M/H2-CCCH-0075AA-L1-B CCH-0150AB-M1-C CCH-0300BB-M5-CCCH-0075AB-L1-B CCH-0150AB-M5-C CCH-0300BBM/H2-CCCH-0075AA-M1-B CCH-0150AB-M/H2-C CCH-0300BC-M/H2-CCCH-0075AB-M1-B CCH-0200AB-H1-CCCH-0100-AB-L1-B CCH-0200AB-L5-CCCH-0100AB-L5-B CCH-0200AC-L5-CCCH-0100AB-M1-B CCH-0200AB-M1-C

CCH-0100AB-M/H2-B CCH-0200AB-M5-CCCH-0100AB-M/H-2B CCH-0200AB-M/H2-C

CCH-0200AC-M/H2-C

PSE-181D PSE-201D PSE-241D PSE-311DCHA-0050-L1A CHA-0100-H1D CHA-0150-H1D CHA-0300-H1DCHA-0050-L1D CHA-0150-L1D CHA-00200-H2D CHA-0400-H2DCHA-0050-M1A CHA-0150-L5D CHA-00200-H2Y CHA-0400-H2YCHA-0050-H1D CHA-0150-M1D CHA-0200-H1D CHA-0500-H2DCHA-0075-L1A CHA-0150-M5D CHA-0300-L5D CHA-0500-H2YCHA-0075-L1D CHA-0150-H2D CHA-0300-M5DCHA-0075-M1A CHA-0200-L5D CHA-0300-H2DCHA-0075-M1D CHA-0200-M1D CHA-0300-H2YCHA-0075-H1D CHA-0200-M5DCHA-0100-L1DCHA-0100-M1DCHA-0100-H2D

PSE-181D PSE-191D PSE-311D PSE-331D11651.2.3 11041,2,33 1151,2,31 17151

11051,2,33 11201,2,31 17201PSE-241D 11301,2,3111071,2,34 17301111101,3,34

171014

PSE-311D PSE-3141DMCLT-22 CMT-36 CMT-50CMT-22 CLT-44 CMT-64CLT-28 CLT-50 CMT-72

CLT-88CLT-100

951

WALK-IN COOLERS

TOTALINE® WALK-IN COOLERSFeatures:

• Standard exterior dimensions are in full foot increments (6′-0″, 7′-0″, 8′-0″, etc., O.D.). Nominal exterior sizing is available.

• Manufactured with built-in Cam-Lock panel fastening system to speed assembly or disassembly process.

• Listed and labeled under NSF Standard #7 of National Sanitation Foundation International.

• Side wall heights are available from 7′-0″ up to 24′-0″ feet in length.

• Standard entry door is 36″ x 78″ with a 7′-0″ side wall and36″ x 84″ with a 8′-0″ side wall.

• Swing Manual Slide, Electric Slide, and Bi-part door are available in a wide variety of widths and heights.

• Available in both “all Urethane Insulation” and in “Wood Framed Insulation” configurations.

• Available finishes: Stucco embossed, galvanized, aluminum, white metal, and stainless steel.

• Meets local building codes.

Contact RCD Commercial Refrigeration for pricing and part numbers.P4362

952

CHANGEOVER MANIFOLD

MUELLER CHANGEOVER MANIFOLDSpecifications

TECHNICAL DATAManifold A-17921 A-17922 B-34550 A-17923 A-17924 B-34559 B-34654

Torque To Seal:Front Seat (ft-lb) 16-18 22-40Back Seat (ft-lb) 16-18 25-45

Pack Gland (ft-lb) 8-12 15-25Seal Cap Finger Tight

Maximum Working Pressure 500 psigBurst Pressure 2500 psig

Working Temperature Range -40/+300° FRefrigerants All Fluorinated Types

P4243

Changeover Manifold

PART NO. INLET OUTLETSA

(In.)B

(in.)C

(in.)D

(in.)E

(in.)F

(in.)A-17921 1/2 NPTFE 1/2 NPTFI 6 1-3/4 1-3/4 1-3/8 2-1/16 3/4A-17922 3/4 NPTFE 3/4 NPTFI 6 1-3/4 1-7/8 1-3/8 2-1/16 3/4A-17923 1 NPTFE 1 NPTFI 8-11/16 2-7/16 2-3/8 1-7/8 3-1/8 1-7/16A-17924 1-1/4 NPTFE 1-1/4 NPTFE 8-7/8 2-7/16 2-7/16 2-1/8 3-1/8 1-7/16B-34550 7/8-14 UNF 2A 7/8-14 UNF 2B 6 1-3/4 1-5/8 1-3/8 2-1/16 3/4B-34559 1-5/16-12 UNF 2A 1-5/16-12 UNF 2B 8-9/16 2-7/16 2-1/8 1-3/4 3-1/8 1-7/16B-34654 1-5/8-12 UNF 2A 1-5/8-12 UNF 2B 8-9/16 2-7/16 2-1/8 1-13/16 3-1/8 1-7/16

953

COMPRESSOR VALVE KITS

MUELLER COMPRESSOR VALVE KITSSpecifications

TECHNICAL DATAKit Number A-17518 A-17519 A-17520 A-17510 A-17511 A-17512 A-17531

Maximum Working Pressure (psig) 500 500 500 500 500 500 500Burst Pressure (psig) 2500 2500 2500 2500 2500 2500 2500

Working Temperature Range (°F) -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300Fluid Compatibility All Fluorinated TypesTorques To SealFront Seat (ft-lb) 14-18 14-18 14-18 14-18 14-18 14-18 14-18Back Seat (ft-lb) 14-18 14-18 14-18 14-18 14-18 14-18 14-18

Pack Gland (ft-lb) 8-12 8-12 8-12 8-12 8-12 8-12 8-12Pipe Plug (ft-lb) 2-3 Threads Exposed

Seal Cap (ft-lb)Plastic NABrass 20-30 20-30 20-30 20-30 20-30 20-30 20-30Steel 3-5 3-5 3-5 3-5 3-5 3-5 3-5

Double Port — 45° Flare Type

P4251 P4252 P4253

Double Port — 45° Flare Type — Forged Brass Body

*Supplied with flare nut and seal bonnet.

KIT NO.FLARE SIZE

AB C D E F

BOLTCENTERS

DIA. BOLTHOLES

PIPE PLUGSIZE

FLANGETHICKNESS

COPELANDNO.

MUELLERVALVE

A-17518 3/8 9/32 1-3/4 4-9/16 5/8 1-1/4 1-5/8 11/32 1/8 7/8 998-0510-15 A-16302*A-17519 1/2 9/32 1-7/8 4-11/16 5/8 1-1/4 1-5/8 11/32 1/8 7/8 998-0510-16 A-16303*A-17520 5/8 9/32 2 4-13/16 5/8 1-1/4 1-5/8 11/32 1/8 7/8 998-0510-17 A-16304*

Double Port

P4254P4255 P4256

Double Port — Solder Type — Forged Brass Body

KIT NO.FLARE SIZE

AB C D E F G

BOLTCENTERS

DIA. BOLTHOLES

PIPE PLUGSIZE

FLANGETHICKNESS

COPELANDNO.

MUELLERVALVE

A-17510 3/8 9/32 1-9/32 4-3/32 5/8 1-1/4 31/32 1-5/8 11/32 1/8 7/8 998-0510-04 A-16307A-17511 1/2 9/32 1-13/32 4-3/32 5/8 1-1/4 1-1/32 1-5/8 11/32 1/8 7/8 998-0510-05 A-16308A-17512 5/8 9/32 1-17/32 4-11/32 5/8 1-1/4 1-1/32 1-5/8 11/32 1/8 7/8 998-0510-06 A-16309

954



TECHNICAL DATAKit Number A-17513 A-17514 A-17521 A-17522 A-17523 A-17524 A-17535 A-17532 A-17555 A-17534

Maximum Working Pressure (psig) 500 500 500 500 500 500 500 500 500 500Burst Pressure (psig) 2500 2500 2500 2500 2500 2500 2500 2500 2500 2500

Working Temperature Range (°F) -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300Fluid Compatibility All Fluorinated TypesTorques To SealFront Seat (ft-lb) 45-65 45-65 45-70 45-70 45-65 45-65 45-65 22-40 22-40 22-40Back Seat (ft-lb) 45-65 45-65 45-65 45-65 45-65 45-65 45-65 25-45 25-45 25-45Pack Gland (ft-lb) 25-35 25-35 55-70 55-70 35-45 35-45 35-45 10-15 10-15 10-15Pipe Plug (ft-lb) 2-3 Threads Exposed

Seal Cap (ft-lb)Plastic Hand Tight

Cast Iron Hand Tight

Flanged Union Style

P4263 P4264

P4265

Flanged Union Style — Solder Type — Cast Iron Valve Body

KIT NO. TUBE SIZEA B C D E F G H J K L M BOLT

CENTERSDIA BOLT

HOLES COPELAND MUELLERVALVE

A-17513 1-5/8 2-1/8 4-17/32 10-1/16 2-1/8 2-3/4 1-13/16 1-17/32 3-3/16 1/4 1/4 2-11/16 2-1/2 17/32 998-0510-07 A-16321A-17514 1-3/8 2-1/8 4-17/32 9-15/16 2-1/8 2-3/4 1-13/16 1-17/32 3-7/16 1/4 1/4 2-11/16 2-1/2 17/32 998-0510-08 A-16320A-17521 3-1/8 3-7/8 6-1/2 14-13/32 3-11/32 4-5/32 2-1/4 2 4-27/32 1/4 1/4 4-21/32 2-5/8 11/16 998-0510-18 A-16365A-17522 2-5/8 3-7/8 6-1/2 15 3-11/32 4-5/32 2-1/4 2 4-3/16 1/4 1/4 4-5/8 3-7/8 11/16 998-0510-19 A-16366A-17523 2-1/8 3-1/16 5-1/16 11-15/16 2-17/32 3-7/32 2-3/8 2-3/16 3-3/4 1/4 1/4 3-7/16 3-1/16 11/16 998-0510-20 A-16324

A-17524 1-5/8 3-1/16 5-1/4 12-1/8 2-17/32 3-7/32 2-3/8 2-3/16 4-5/32 1/4 1/4 3-7/16 3-1/16 11/16 998-0510-21 A-16367

955



TECHNICAL DATAKit Number A-17515 A-17516 A-17517 A-17528 A-17529 A-17530 A-17525 A-17526 A-17527

Maximum Working Pressure (psig) 500 500 500 500 500 500 500 500 500Burst Pressure (psig) 2500 2500 2500 2500 2500 2500 2500 2500 2500

Working Temperature Range (°F) -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300 -40/300Fluid Compatibility All Fluorinated TypesTorques To SealFront Seat (ft-lb) 22-40 22-40 22-40 22-40 22-40 22-40 30-40 30-40 30-40Back Seat (ft-lb) 25-45 25-45 25-45 25-45 25-45 25-45 22-45 22-45 22-45

Pack Gland (ft-lb) 15-25 15-25 15-25 15-25 15-25 15-25 15-25 15-25 15-25Pipe Plug (ft-lb) 2-3 Threads Exposed

Seal Cap (ft-lb)Plastic Hand TightBrass NA NA NA NA 40-50 NA 40-50 40-50 40-50Steel NA

Straight Port

P4257 P4258 P4259

Straight Port — Solder Type — Forged Brass Body

KIT NO. FLARE SIZEA B C D E F G H BOLT

CENTERSDIA. BOLT

HOLESPIPE PLUG

SIZEFLANGE

THICKNESSCOPELAND

NO.MUELLER

VALVEA-17515 7/8 3/4 1-31/32 6-9/16 7/8 1-1/2 1-7/32 1 1-5/8 11/32 1/8 1-21/64 998-0510-12 A-16311A-17516 1-1/8 3/4 2-1/16 6-11/16 7/8 1-1/2 1-5/32 1 1-5/8 11/32 1/8 1-21/64 998-0510-13 A-16312A-17517 3/4 3/4 1-29/32 6-1/2 7/8 1-1/2 1-9/32 1 1-5/8 11/32 1/8 1-21/64 998-0510-14 A-16310

Flanged Union Style

P4260 P4261 P4262

Flanged Union Style — Solder Type — Forged Brass Body

KIT NO. FLARE SIZEA B C D E G H BOLT

CENTERSDIA. BOLT

HOLESPIPE PLUG

SIZEFLANGE

THICKNESSCOPELAND

NO.MUELLER

VALVEA-17525 1-1/8 1 2-15/32 7-1/2 1-1/4 1-9/16 1-1/8 2-3/4 17/32 1/8 1 998-0510-09 A-16315A-17526 1-3/8 1 2-15/32 7-1/2 1-1/4 1-1/2 1-1/8 2-3/4 17/32 1/8 1 998-0510-11 A-16316A-17527 7/8 1 2-5/16 7-11/32 1-1/4 1-9/16 1-1/8 2-3/4 17/32 1/8 1 998-0510-10 A-16314

956

HVAC/R METAL FRAMING, CHANNEL, CLAMPS, SLOTTED ANGLE & FITTINGS

HYDRA-ZORB CUSHION CLAMP ASSEMBLIES

ALL-THREADED RODS

PIPE CLAMPS

CHANNEL NUTS (With Standard Spring)

Use with FS-200 Series Channel

PART NUMBERNOMINAL

COPPER TUBESIZE

COPPER TUBEO.D. SIZE

FS-1400-025 1/8″ 1/4″ O.D.FS-1400-037 1/4″ 3/8″ O.D.FS-1400-050 3/8″ 1/2″ O.D.FS-1400-062 1/2″ 5/8″ O.D.FS-1400-075 5/8″ 3/4″ O.D.FS-1400-087 3/4″ 7/8″ O.D.FS-1400-112 1″ 1-1/8″ O.D.FS-1400-137 1-1/4″ 1-3/8″ O.D.FS-1400-162 1-1/2″ 1-5/8″ O.D.FS-1400-212 2″ 2-1/8″ O.D.FS-1400-262 2-1/2″ 2-5/8″ O.D.FS-1400-312 3″ 3-1/8″ O.D.FS-1400-362 3-1/2″ 3-5/8″ O.D.FS-1400-412 4″ 4-1/8″ O.D.

PART NUMBER DIAMETERSIZE LENGTH THREAD

FS-7125-10 3/8″ 10′ 16FS-7126-10 1/2″ 10′ 13

PART NUMBER O.D.TUBE SIZE GAUGE LOAD

FS-1200-3/8 3/8″ 16 400#FS-1200-1/2 1/2″ 16 400#FS-1200-5/8 5/8″ 16 400#FS-1200-3/4 3/4″ 16 400#FS-1200-7/8 7/8″ 16 400#

FS-1200-1-1/8 1-1/8″ 14 600#FS-1200-1/3/8 1-3/8″ 14 600#FS-1200-1-5/8 1-5/8″ 14 600#FS-1200-2-1/8 2-1/8″ 12 800#FS-1200-2-5/8 2-5/8″ 12 800#

PART NUMBER SIZE THREADFS-3/8RS 3/8″ Spring Nut 16FS-1/2RS 1/2″ Spring Nut 13

P4390

P4391

P4392

P4392

957


SLOTTED CHANNELSlotted metal channel for mounting ductwork, pipe, unit heaters,horizontal furnaces, etc.

Slot 9/16″ wide x 1-1/8″ long

SLOTTED ANGLE

Standard Finish Pre-Galvanized.Each package contains 10 lengths of angle and 75 nuts and bolts.NOTE: Other lengths available on request.

PART NUMBER SIZE GAUGE LENGTHFS-200SSPG10 1-5/8″ x 1-5/8″ 12 10FS-500SSPG10 1-5/8″ x 13/16″ (shallow) 14 10

PART NUMBER SIZE GAUGE LENGTH/UNIT

FA-110PG 1-1/2 x 1-1/2 14 10FA-210PG 2-1/4 x 1-1/2 14 10FA-310PG 3 x 1-1/2 12 10

P4394

P4395

958


KLO-SHURE COUPLINGS*The Klo-Shure insulation coupling reduces the time required to insulate copper tubing used for refrigerant lines, hot and cold water plumbing and chilled water systems. The patented coupling allows sections of the elastomeric insulation to be secured at suspension points.

Selection:The Klo-Shure IDs will correspond to the tubing ODs. Example: The last 3 digits of the Klo-Shure/RCD part number (ex: 703037) will be the same as the copper tubing OD column.

*Klo-Shure Couplings are manufactured by Hydra-Zorb Company.

STRUT MOUNT KLO-SHURE COUPLING: Strut mounted Klo-Shure coupling is supplied with clamp halves, fastener, and locknut. Standard finish for clamp halves is electro-galvanized. Each clamp comes individually packed in a plastic bag. When vertically mounted, channel stop is required at lower end.

CLEVIS KLO-SHURE COUPLING: Klo-Shure couplings are shipped bagged with metal clip. Clevis hangers are not supplied and must be purchased separately.

INSULATION NOMINAL 3/8″″″″ WALL

Part NumberStrut Mount

Part Number Clevis Mount

Copper Tubing Size Klo-ShureInside Diameter

Standard PackNominal Tube Size Outside Diameter

723025 703025 1/8″ 1/4″ 1/4″ 40723037 703037 1/4″ 3/8″ 3/8″ 25723050 703050 3/8″ 1/2″ 1/2″ 20723062 703062 1/2″ 5/8″ 5/8″ 20723075 703075 5/8″ 3/4″ 3/4″ 15723087 703087 3/4″ 7/8″ 7/8″ 15723100 703100 7/8″ 1″ 1″ 20723112 703112 1″ 1-1/8″ 1-1/8″ 12723137 703137 1-1/4″ 1-3/8″ 1-3/8″ 12723162 703162 1-1/2″ 1-5/8″ 1-5/8″ 10723212 703212 2″ 2-1/8″ 2-1/8″ 6


Part Number Strut Mount




724037 704037 1/4″ 3/8″ 3/8″ 25724050 704050 3/8″ 1/2″ 1/2″ 20724062 704062 1/2″ 5/8″ 5/8″ 20724075 704075 5/8″ 3/4″ 3/4″ 15724087 704087 3/4″ 7/8″ 7/8″ 15724100 704100 7/8″ 1″ 1″ 15724112 704112 1″ 1-1/8″ 1-1/8″ 12724137 704137 1-1/4″ 1-3/8″ 1-3/8″ 12724162 704162 1-1/2″ 1-5/8″ 1-5/8″ 10724212 704212 2″ 2-1/8″ 2-1/8″ 6






726025 706025 1/8″ 1/4″ 1/4″ 20726037 706037 1/4″ 3/8″ 3/8″ 20726050 706050 3/8″ 1/2″ 1/2″ 15726062 706062 1/2″ 5/8″ 5/8″ 12726075 706075 5/8″ 3/4″ 3/4″ 12726087 706087 3/4″ 7/8″ 7/8″ 10726112 706112 1″ 1-1/8″ 1-1/8″ 10726137 706137 1-1/4″ 1-3/8″ 1-3/8″ 10726162 706162 1-1/2″ 1-5/8″ 1-5/8″ 6

INSULATION NOMINAL 1″″″″ WALL





728062 708062 1/2″ 5/8″ 5/8″ 10728087 708087 3/4″ 7/8″ 7/8″ 10728112 708112 1″ 1-1/8″ 1-1/8″ 6

P4392

P4400

P4399

refrigeration heat exchangers• lower system costs — better heat transfer coefficient (htc) gives...

Documents