ps-1250 12 volt 5.0 ah - power-sonic · pdf filemode l ps - 1250 f 12 volt 5.0 amp. hr. wa rn...
TRANSCRIPT
MODE L P S -1250 F 112 Volt 5.0 Amp. Hr.
Warning: R isk of fire, explos ion, or burns .Do not disassemble,heat above 60 C ,or incinerate.
8 61 3 3 4 0 0 1 0 4 0
R echargeable S ealedLead-Acid B atteriesDC power constant voltage chargeC ycle use: 14.4 - 15.0V (20 C )S tandby use: 13.5 - 13.8V (20 C )Initial current: 1.5A MAX
S ealed R echargeableB attery
120050260208
L
HT
W
H
6.35
4.75
3.2F1 F2
0.87.95
6.35
3.4
0.8
Tolerances are +/- 0.04 in. (+/- 1mm) and +/- 0.08 in. (+/- 2mm) for height dimensions. All data subject to change without notice.
Physical Dimensions: in (mm)
Features
• Absorbent Glass Mat (AGM) technology for superior performance
• Valve regulated, spill proof construction allows safe operation in any position
• Power/volume ratio yielding unrivaled energy density
• Rugged impact resistant ABS case and cover (UL94-HB)
• Approved for transport by air. D.O.T., I.A.T.A., F.A.A. and C.A.B. certified
• U.L. recognized under file number MH 20845
Performance Specifications
Nominal Voltage .......................................................12 volts (6 cells)
Nominal Capacity
20-hr. (250mA to 10.50 volts) .......................................... 5.00 AH
10-hr. (450mA to 10.50 volts) .......................................... 4.50 AH
5-hr. (750mA to 10.20 volts) .......................................... 3.75 AH
1-hr. (2.85A to 9.00 volts) ............................................. 2.85 AH
15-min. (9A to 9.00 volts) ....................................................2.25 AH
Approximate Weight ......................................... 3.50 lbs. (1.59 kg)
Energy Density (20-hr. rate) ............... 1.54 W-h/in3 (94.16 W-h/l)
Specific Energy (20-hr. rate) ............ 17.14 W-h/lb (37.79 W-h/kg)
Internal Resistance (approx.) ..................................... 40 milliohms
Max Discharge Current (7 Min.) ............................... 15.0 amperes
Max Short-Duration Discharge Current (10 Sec.) .... 50.0 amperes
Shelf Life (% of nominal capacity at 68°F (20°C)
1 Month ................................................................................. 97%
3 Months ................................................................................ 91%
6 Months ............................................................................... 83%
Operating Temperature Range
Charge ................................................ -4°F (-20°C) to 122°F (50°C)
Discharge ............................................ -40°F (-40°C) to 140°F (60°C)
Case ..................................................................................ABS Plastic
Power-Sonic Chargers ...............................................PSC-12500A-C
PS-1250
www.power-sonic.com To ensure safe and efficient operation always refer to the latest edition of our Technical Manual, as published on our website.All data subject to change without notice.
Terminals: (mm)
• F1 - Quick disconnect tabs, 0.187” x 0.032”- Mate with AMP. INC. FASTON “187” series
• F2 - Quick disconnect tabs, 0.250” x 0.032” - Mate with AMP. INC FASTON “250” series
12 Volt 5.0 AH
L: 3.54 (90) W: 2.76 (70) H: 3.98 (101) HT: 4.21 (107)
OR
ChargingCycle Applications: Limit initial current to 1.2A. Charge until battery voltage (under charge) reaches 14.4 to 14.7 volts at 68°F (20°C). Hold at 14.4 to 14.7 volts until current drops to under 50mA. Battery is fully charged under these conditions, and charger should be disconnected or switched to “float” voltage.
“Float” or “Stand-By” Service: Hold battery across constant voltage source of 13.5 to 13.8 volts continuously. When held at this voltage, the battery will seek its own current level and maintain itself in a fully charged condition.
Note: Due to the self-discharge characteristics of this type of battery, it is imperative that they be charged within 6 months of storage, otherwise permanent loss of capacity might occur as a result of sulfation.
ChargersPower-Sonic offers a wide range of chargers suitable for batteries up to 100AH. Please refer to the Charger Selection Guide in our specification sheets for “C-Series Switch Mode Chargers” and “Transformer Type A and F Series”. Please contact our Technical department for advice if you have difficulty in locating suitable models.
Cap
acity
Ret
entio
n R
atio
(%)
Standing Period (Months)
100
80
60
40
00 2 4 6 8 10 12 14 16 18 20
40oC(104oF)
30oC(86oF)
20oC(68oF)
5oC(41oF)
Charging is not necessary unless 100% of capacity is required.
Charging beforeuse is necessaryto help recoverfull capacity.
Charge may failto restore fullcapacity. Do notlet batteries reachthis state.
100
80
60
40
20
00 1 2 3 4
Ambient Temperature 20˚C (68˚F)
Float Charging Voltage2.25 - 2.30 V/Cell
Ret
entio
n C
apac
ity (%
)
Years
120
100
80
60
40
20
00 200 400 600 800 1000 1200
Number of Cycles
1. Discharge Current 0.2C (Final Voltage 1.7V/Cell)2. Charge Current: 0.1C3. Ambient Temperature: 20oC to 25oC (68oF to 77oF)R
eten
tion
Cap
acity
(%)
DischargeDepth 30%
DischargeDepth 100%
DischargeDepth 50%
Discharge Characteristics
Discharge Time vs. Discharge Current
Shelf Life & Storage
Life Characteristics in Stand-By Use
Life Characteristics in Cyclic Use
PS-1250 12 Volt 5.0 AH®
Further InformationPlease refer to our website www.power-sonic.com for a complete range of useful downloads, such as product catalogs, material safety data sheets (MSDS), ISO certification, etc.
13.0
12.0
11.0
10.0
9.0
8.0
14.0
CORPORATE OFFICE • 7550 Panasonic Way • San Diego, CA 92154 • USA • Tel: +1-619-661-2020 • Fax: +1-619-661-3650
CUSTOMER SERVICETel: +1-619-661-2030 Fax: [email protected]
INTERNATIONAL SALESTel: +1-650-364-5001 Fax: [email protected]
DOMESTIC SALESTel: +1-619-661-2020Fax: [email protected]
TECHNICAL SUPPORTTel: +1-619-661-2020 Fax: [email protected]
Contact Information www.power-sonic.com
0816 1M
© 2016. Power-Sonic Corporation. All rights reserved. All trademarks are the property of their respective owners.
Term
inal
Vol
tage
(V)
Ambient Temperature 20oC (68oF)
1.2 2.4 6 12 24 36 48 1 2 4 6 8 10 20 4 0
Discharge Time
FinalVoltage
min h
0.250.501.0
2.5
5.0
10
0.25 0.50 1.0 2.5 5.0 10Discharge Current (A)
201510
5
2
1
30
10
5
Dis
char
ge T
ime
40oC (104oF)20oC (68oF) 0oC (32oF)
min
h
10.2V
9.6V
9.0V
8.1V
FinalVoltage10.5V