planning an operation theatre complex
TRANSCRIPT
Planning an Operation Theatre Complex
Operation theaters
Definition
Specialized facility in hospital where invasive treatment is given under strict aseptic controlled environment by trained personnel
Objectives of planning
• Promote high standards of asepsis
• Ensure safety
• Optimal physical working conditions
• Ensure optimum utilization
• Facilitate coordinated services
• Rigidity and flexibility
Design considerations
• Location• Workflow• Basic work areas and Division of space• Zoning concept• Air filters• Machinery and equipment• Organization• Policies and procedures• problems
Zoning
• Why?
• What is it?
• 3 or 4?
Zoning
• ZONE 1 – PROTECTIVE - reception, waiting,trolley bay, change rooms
• ZONE 2 – CLEAN AREA – preoperative,recovery,plaster room,staff lounges,stores
• ZONE 3 – STERILE AREA – operating room, scrub room, anesthesia room,setup room
• ZONE 4 – DISPOSAL AREA – dirty utility, disposal corridor
Special considerations
• Air – supply, direction of flow, pressure changes in areas,air changes, monitoring of quality
• Temperature and humidity – 21-24 centi, 45-60% humidity
• Lighting – at incision area 50 to 125K lux with intensity cntrl, non-shadow ,blue-white color of daylight, heat cntrl
Planning for an Operation Theatre
• 1. O.T. Needs Specialized Planning.
• 2. Different zones of OT Complex
• 3. Basic Principles of Planning an O.T & Recovery room
• 4. Administrative policies & Work schedules in OT functioning
• 5. Measures to check the infection rate
O.T. Needs Specialized Planning.
YES
O.T. Needs Specialized Planning.
• O.T. Work is complex and concentrated and requires intense coordinated team work within the unit & with other agencies providing them the essential supporting services like– Transport of Men and Machine– Cleaning & Sterilization – Disposal– Record Keeping and Monitoring
O.T. Needs Specialized Planning…
• Special features of O.T. working
- Caters to 50% of the total Healthcare seekers.
- Wide range & level of skilled persons working as team.
- Equipments vary from pin to most sophisticated machines.
O.T. Needs Specialized Planning.
• Both the Team members & health care seekers are at the peak of their sympathetic activity at some or the other time of the operative procedure.
S S Harsoor 18
Comfort•Result can be disastrous
O.T. Needs Specialized Planning.
• These special features regarding the O.T. work makes the place very special &hence needs special structural & functionability planning to render better services safely, comfortably and with economy
Different zones of OT Complex
4 Zones…
Different zones of OT Complex
(1) Protective Zone Includes• Change rooms for all staff with conveniences• Transfer bay for patient, material &
equipments• Rooms for administrative staff• Stores & records• Pre & Post operative rooms• I.C.U., Sterile Stores
Different zones of OT Complex
(2) Clean Zone • Connects protective zone to aseptic zone (O.R.)• Has areas
– Equipment Store room– Maintenance Workshop– Kitchenette (Pantry)– Firefighting device room– Service room for staff– Close circuit TV Control area– Emergency exit
Different zones of OT Complex…
3) Aseptic zone Operation Rooms
(Sterile)
4) Disposal zone- Disposal areas from
each OR & Corridor leading to disposal zone
Basic Principles of Planning an O.T & Recovery room
Basic Principles of Planning an O.T & Recovery room
1. Location: 1st floor & above very near to Surgical wards & SICU
2. Corridors : 3 - 3.5 m width for easy movements of men & machines
3. Zone wise distribution of the area so as to avoid criss cross movements of men & machine
4. Provision for emergency exit ( Many people & Machine)
Basic Principles of Planning an O.T & Recovery room
5. Operation rooms:
– No. & size as per the requirement (50% of the surgical beds)
• Size 20’X20’X10’
• Glass windows one side only
– Sliding door, (2 Flap door,1.5 mts)
Basic Principles of Planning an O.T & Recovery room
6. Ventilation & temperature control– 20-30 air exchanges / Hr
– Up to max 80% recirculation of air
– Ultraclean Laminar airflow (90% removal of particles >0.5)
– Temperature 20-240 C (for Pt needs)
– 0.005 H2O Positive air pressure in OR
– Humidity 50-60%
Basic Principles of Planning an O.T & Recovery room
7. Strong & impermeable flooring with minimum no. of joints
• Conductive flooring to dissipate static electricity (Min 1 Ohm - Max 10 Ohm
Recommended)
8. Washable Wall-• Laminated Polyester or smooth Paint• Collusion corners to be covered with steel• Colour should allow reflection of light yet
give soothing to eyes
Basic Principles of Planning an O.T & Recovery room
9. Electric points on wall/ Pendants• More than 1.5 m height• Explosion-proof plugs• Multiple outlets from different sources of Power
• Load calculation based on equipments
• Proper capacity Current carrying Power Cords
Basic Principles of Planning an O.T & Recovery room
10. Lighting– Room to Surgery area lighting to be 1:3
ratio– Shadowless light with 25000-125000
Lux of light– 10-12” depth of focus of light will
illuminate both surface & deeper tissues– Minimum 2000 Lux light to asses colour
of patient
Basic Principles of Planning an O.T & Recovery room
10.Lighting …
– Blue-white daylight with spectral energy range of 50000K ( 3500-67000 Kelvin acceptable)
– Not >25000W/Cm2 radiant heat to be produced,
– Halogen lights preferred
– UPS of adequate capacity for OR light, monitors, cautery, Anaesthesia machines
Basic Principles of Planning an O.T & Recovery room
11. Piped Gases
• Automatic/ SemiAutomatic fail safe manifold system
• 2 each Gas & suction outlets (Central supply & Emerg stock) for all Pre-Op holding, OR( One N2O), PACU, Recovery
Basic Principles of Planning an O.T & Recovery room
12. Scrub room– Elbow/ Infrared sensor operated Taps– Non-Slippery flooring essential
13. Good pre operative area with reception.
Separate area for Paediatric patients
Provision for future expansion.
Adequate Illumination.
Basic Principles of Planning an O.T & Recovery room
14. O.R. Panels- recessed into walls- contains X ray view,
temperature, Humidity control, hands free phone, clock, time elapsed indicator, music etc
- Foot operated call light system
Recovery room is an integral part of the OT
Recovery room is an integral part of the OT • Pts retained for observation till
the vitals are stable
• All the protective reflexes return to normal
• Before sending the pts. home in case of day care surgery.
Administrative policies in OT.
Administrative policies in OT.• OT is the place where strict discipline has to
be followed.
• Slightest negligence on part of any level of
person can prove disastrous.
• Delegation of work & decentralization
should be the main aspect of OT.
administration.
Administrative policies in OT..– Good communication at all
levels (in staff, with pt’s, with pts relatives & other units etc.)
– Accountability of every person to his /her superior.
– Complete data keeping regarding every procedure.
Administrative policies in OT..• Necessary SOP( standard operating
practices) is to be prepared for the following
– Acceptance of cases for OT– Basic procedures– For preparing OT schedule– OT personnel– House keeping staff– Clerical staff
Work & time schedules in OT functioning…• Check all machine & electric gadgets
(OR wise by OT technician)
• Starting time of operations & order of operations followed strictly
• After checking the identity of patients site & type of surgery & consent, the pt is taken into respective OT.
Measures to check the infection rate
Measures to check the infection rate• O.T discipline, if followed sincerely &
strictly by all staff directly or indirectly related to OT, can bring down the infection rate to minimum.
• Staff should be educated & trained in O.T.discipline & monitored periodically.
Measures to check the infection rate…
• Good CSSD & TSSU., & maintaining sterility of all items used for surgery.
• Proper & periodic cleaning & disinfection of premises & other things used in O.T.
• Taking care of personal factor by all staff members - Scientifically changing dress, cap mask, shoes, scrubbing & gowning
Measures to check the infection rate…
• Taking due precautions while taking infected case & thereafter.
• Proper time spacing between two surgeries.
• Timely & proper disposal of soiled material.
Number of OTs required for 600 bedded hospital.
• For 600 bedded hospital (300 Surg. Beds)
• Out of Surgical Beds, 50% of Pts are expected to undergo the surgery as such
• For 8 Hrs working for 6 days a week– No of surgeries= Surg Beds*Bed Occupancy*Working
days/Average Length of stay• =300 beds* 60% *250 days/10 days(ALS)
• =4500 surgeries/ year