philips lc4.1heab

32
Published by WS 0572 Customer Service Printed in the Netherlands Subject to modification EN 3122 785 15790 © Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Colour Television Chassis LC4.1HE AB Supplement to manual LC4.1E AB: 3122 785 15310 E_14520_000.eps 170904 Contents Page 1. Technical Specifications, Connections, and Chassis Overview 2 2. Safety Instructions, Warnings, and Notes 3 3. Directions for Use 3 4. Mechanical Instructions 4 5. Service Modes, Error Codes, and Fault Finding 6 6. Block Diagrams, Test Point Overviews, and Waveforms Wiring Diagram 15” 7 Wiring Diagram 20” & 23” 8 Block Diagram Video 9 Block Diagram Audio & Control 10 Testpoint Overview SSB (Top Side) 11 Testpoint Overview SSB (Bottom Side) 12 I2C Overview 13 Supply Voltage Overview 14 7. Circuit Diagrams and PWB Layouts Diagram PWB Side I/O Panel & LKB 15” (D)15 16 Side I/O & Panel & LKB 20” & 23” (D)17 18 i-Board Panel (HC)19 20 LED and IR Panel (J)21 22 LCD Clock Panel (J)23 8. Alignments 25 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets 28 Abbreviation List 28 IC Data Sheets 28 10. Spare Parts List 29 11. Revision List 32

Upload: repartout

Post on 02-Apr-2015

1.180 views

Category:

Documents


15 download

DESCRIPTION

Service manaul ref 15790, supplément au sm ref 15310

TRANSCRIPT

Page 1: PHILIPS LC4.1HEAB

Published by WS 0572 Customer Service Printed in the Netherlands Subject to modification EN 3122 785 15790

©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.

Colour Television Chassis

LC4.1HEAB

Supplement to manual LC4.1E AB: 3122 785 15310

E_14520_000.eps170904

Contents Page1. Technical Specifications, Connections, and Chassis

Overview 22. Safety Instructions, Warnings, and Notes 33. Directions for Use 34. Mechanical Instructions 45. Service Modes, Error Codes, and Fault Finding 66. Block Diagrams, Test Point Overviews, and

WaveformsWiring Diagram 15” 7Wiring Diagram 20” & 23” 8Block Diagram Video 9Block Diagram Audio & Control 10Testpoint Overview SSB (Top Side) 11Testpoint Overview SSB (Bottom Side) 12I2C Overview 13Supply Voltage Overview 14

7. Circuit Diagrams and PWB Layouts Diagram PWBSide I/O Panel & LKB 15” (D)15 16Side I/O & Panel & LKB 20” & 23” (D)17 18i-Board Panel (HC)19 20LED and IR Panel (J)21 22LCD Clock Panel (J)23

8. Alignments 259. Circuit Descriptions, Abbreviation List, and IC Data

Sheets 28Abbreviation List 28IC Data Sheets 28

10. Spare Parts List 2911. Revision List 32

Page 2: PHILIPS LC4.1HEAB

Technical Specifications, Connections, and Chassis OverviewEN 2 LC4.1HE AB1.

1. Technical Specifications, Connections, and Chassis Overview

Index of this chapter: 1.1 Technical Specifications1.2 Connection Overview1.3 Chassis Overview

Notes: • Only information that is related to the iTV module, is

published in this manual. For the other information, see the relevant chassis manual (order code on front page).

• Some models in this chassis range have a different mechanical construction. The information given here is therefore model specific.

• Figures below can deviate slightly from the actual situation, due to the different set executions.

• Specifications are indicative (subject to change).

1.1 Technical Specifications

1.1.1 Vision

Display type : LCDScreen size : 15” (38 cm), 4:3

: 20” (51 cm), 4:3: 23” (58 cm), 16:9

Resolution (HxV pixels) : 1024x768 (15”): 640x480 (20”): 1366x768 (23”)

Contrast ratio : 500: 1 (15”): 350 : 1 (20”): 450 : 1 (23”)

Light output (cd/m2) : 450 (15” + 20”): 500 (23”)

Response time (ms) : 16 (15” + 23”): 25 (20”)

Viewing angle (HxV degrees) : 130x100 (15”): 176x176 (20”): 140x125 (23”)

Tuning system : PLLTV Colour systems : PAL B/G, D/K, I

: SECAM B/G, D/K, L/L’Video playback : NTSC

: PAL: SECAM

Supported computer formats : 640x480 (all): 720x400 (15”+23”): 640x480 (15” + 23”): 832x624 (15” + 23”): 800x600 (15” + 23”): 1024x768 (15” + 23”): 1280x768 (23”)

Supported video formats : 640x480i-1fH (all): 640x480p-2fH

(15”+23”): 720x576i-1fH (all): 720x576p-1fH (all): 1280x720p-3fH

(15”+23”): 1920x1080i-2fH

(15”+23”)Presets/channels : 125 presetsTuner bands : VHF

: UHF: S-band: Hyper-band: FM-radio

1.1.2 Sound

Sound systems : FM-mono: AM-mono: FM-stereo B/G: NICAM B/G, D/K, I, L: AV Stereo: Virtual Dolby

SurroundMaximum power (WRMS) : 2 x 2 (15”)

: 2 x 5 (20” + 23”)

1.1.3 Miscellaneous

Power supply:- Mains voltage (VAC) : 90 - 240 (15”+ 23”)

: 100 - 250 (20”)

- Mains frequency (Hz) : 50 / 60

Ambient conditions:- Temperature range (°C) : +5 to +40- Maximum humidity : 90% R.H.

Power consumption (values are indicative)- Normal operation (W) : ≈ 42/55/92- Stand-by (W) : < 1/1.5/3

Dimensions (WxHxD cm) : 47.2x30.8x7.65 (15”): 58.3x38.6x8.7 (20”): 71.6x37.5x9.8 (23”)

Weight (kg) : 5 (15”): 8.5 (20”): 8.8 (23”)

1.2 Connection Overview

Note: The following connector colour abbreviations are used (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, and Ye= Yellow.

1.2.1 Side Connections

Figure 1-1 Side I/O: 15” (left side), 20”+23” (right side)

F_15790_002.eps211105

F_15790_003.eps211105

Page 3: PHILIPS LC4.1HEAB

Safety Instructions, Warnings, and Notes EN 3LC4.1HE AB 2.

Mini Jack: Audio Head phone - OutBk - Head phone 32 - 600 ohm / 10 mW

Cinch: Video CVBS - In, Audio - InYe - Video CVBS 1 VPP / 75 ohm

Wh - Audio L 0.5 VRMS / 10 kohm

Rd - Audio R 0.5 VRMS / 10 kohm

Mini Jack: DVI-Audio - In1 - Ground Y Gnd

2 - Ground C Gnd 3 - Video Y 1 VPP / 75 ohm

4 - Video C 0.3 VPP / 75 ohm

S-Video (Hosiden): Video Y/C - In1 - Ground Y Gnd

2 - Ground C Gnd

3 - Video Y 1 VPP / 75 ohm 4 - Video C 0.3 VPP / 75 ohm

12VDC - In (15-inch models)1 - Supply +12 VDC 2 - Ground Gnd

3 - n.c.

Mini Jack: Speaker - Out (20 + 23-inch models)- Loudspeaker 8 ohm

RJ45: DATA2 (Xpress Box- In/Out)1 - +12V +12 V / 1 W

2 - GND Gnd 3 - HSYN Signal

4 - VSYN Signal

5 - TXD232 Signal 6 - RXD232 Signal 7 - SDA3_IR-OUT Signal

8 - DCM-POR Signal 9 - CVBS-terr Signal

10 - GNDA Gnd

RJ12: DATA1 (HM-Link - In/Out)1 - LED_in < 0.3 V, active low

2 - IR_in < 0.3 V, active low

3 - MODE Vcc 4 - TV Power Status 4.5 to 5 V - TV “On”, < 0.3V -

TV “Stdby”, High impedance - TV “Off”

5 - GND Gnd

6 - IR_out Signal

1.2.2 Rear I/O connections

Rear connections are the same as for the LC4.1E.

1.3 Chassis Overview

Figure 1-2 PWB locations (depending on model)

2. Safety Instructions, Warnings, and Notes

See the relevant chassis manual (order code on front page).

3. Directions for Use

See the relevant chassis manual (order code on front page).

F_15790_005.eps061205

B SMALL SIGNALBOARD

POWER SUPPLYPANEL

ETOP CONTOL PANEL

HCi-BOARD

DSIDE I/O PANEL

DiTV SIDE I/OPANEL

iTV LED & IRPANEL J

Page 4: PHILIPS LC4.1HEAB

Mechanical InstructionsEN 4 LC4.1HE AB4.

4. Mechanical Instructions

Index of this chapter:4.1 Service Position4.2 Cable Dressing4.3 Assy/Panel Removal4.4 Set Re-assembly

Notes: • Only information that is related to the iTV module, is

published in this manual. For the other information, see the relevant chassis manual (order code on front page).

• Figures below can deviate slightly from the actual situation, due to the different set executions.

• Follow the disassembling instructions in described order. Note: To diagnose the set with ComPair it is not needed to open the set entirely. To access the ComPair connector, proceed with the following:1. Manually unlock and remove the cover cap.2. Remove the tape shielding that covers the ComPair

connector (1).

Note: Make sure that both the ComPair connector and the UART connector are shielded off with a piece of insulating tape after repair for ESD reasons. Place this tape over the holes in the rear cover of the set.

Figure 4-1 ComPair connector

4.1 Service Position

4.1.1 Foam Bars

Figure 4-2 Foam bars

The foam bars (order code 3122 785 90580) can be used for all types and sizes of Flat TVs. By laying the plasma or LCD TV flat on the (ESD protective) foam bars, a stable situation is created to perform measurements and alignments. By placing a mirror under the TV, you can easily monitor the screen.

4.2 Cable Dressing

Figure 4-3 Cable dressing (15-inch model)

E_14520_034.eps160904

1

E_06532_018.eps170504

F_15790_004.eps051205

Page 5: PHILIPS LC4.1HEAB

Mechanical Instructions EN 5LC4.1HE AB 4.

4.3 Assy/Panel Removal

4.3.1 Rear Cover

Warning: Disconnect the mains power cord before you remove the rear cover. 1. Remove the screws that secure the rear cover.2. Lift the rear cover from the cabinet cautiously. Make sure

that wires and other internal components are not damaged during cover removal.

4.3.2 i-Board Panel

Figure 4-4 i-Board panel

1. Disconnect all cables from the panel.2. Untwist the fixation lip [1] c.c.w. with a pair of pliers.3. Remove the panel.

4.3.3 Side I/O Panel

Figure 4-5 Side I/O panel

1. Disconnect the cable [1] from the panel.2. Release the two fixation clamps [2] and lift the panel out of

the bracket.

4.4 Set Re-assembly

To re-assemble the whole set, execute all processes in reverse order.

Notes:• While re-assembling, make sure that all cables are placed

and connected in their original positions. See Figure "Cable dressing". Also make sure that the anti-static copper foils are not damaged and that they make good electrical contact with the metal frame. Be careful with the fragile LVDS cable.

F_15800_004.eps201205

1

F_15800_005.eps071205

1

2

2

Page 6: PHILIPS LC4.1HEAB

Service Modes, Error Codes, and Fault FindingEN 6 LC4.1HE AB5.

5. Service Modes, Error Codes, and Fault Finding

See the relevant chassis manual (order code on front page).

Personal Notes:

E_06532_012.eps131004

Page 7: PHILIPS LC4.1HEAB

Block Diagrams, Test Point Overviews, and Waveforms 7LC4.1HE AB 6.

6. Block Diagrams, Test Point Overviews, and Waveforms

Wiring Diagram 15”

F_15790_006.eps061205

LEFTSPEAKER

B SSB

POWERSUPPLY

+INVERTER

TUNER

1910

12P

RIGHTSPEAKER

J ITV IRMODULE

i2 ITV SIDEIO FOR C2

5P

1540

1751

5P

1401

4P

1010

10P

1404

20P

LVDS CONNECTORTO DISPLAY

20P

1007

8P

1684

3P

1701

3P

1462

5P

J2

4P

J14P

HC I BOARD

J10

3P

J6

8P

J3

5P

1332

4P

1200

12PCN1

5P

POWER IN1001

2P

1111

4P

1108

10P

1105

4P

1110

3P

D SIDE I/O

1540

5PJ424

P

1001

24P

89108951

8462

8010

8401

8870

8701

8403

8408

8404

8406

8105

8105

1951

5P

1684

3P

E TOP CONTROL

8684

Wiring 15”

1360

2P3

1362

2P3

1365

2P3

1367

2P3

TO D

ISP

LAY

TO D

ISP

LAY

Page 8: PHILIPS LC4.1HEAB

8LC4.1HE AB 6.Block Diagrams, Test Point Overviews, and Waveforms

Wiring Diagram 20” & 23”

F_15790_007.eps061205

LEFTSPEAKER

B SSB

POWERSUPPLY

+INVERTER

TUNER

1910

12P

RIGHTSPEAKER

J ITV IRMODULE

i2 ITV SIDEIO FOR C2

5P1540

1751

5P

1401

4P

1010

10P

1404(1402)

20P(40P)

LVDS CONNECTORTO DISPLAY

20P(40P)

1007

8P16843P

1701

3P

1462

5P

J2

4P

J14P

HC I BOARD

J10

3P

J8

6P

J3

5P

1332

4P

1684

3PE

TOP

CO

NT

RO

L

I AUDIO AMPLIFIER

1704

5P 1703

2P

1706

5P

1200

12P

1260

3P

O CLOCKMODULE

J1

4P

PO

WE

R IN

1001

2P

1111

4P

1108

10P

1105

4P

1107

5P

D SIDE I/O

1540

5P

J424P

1001

24P

8910

8910

8400

8405

8462

8010

8401

8870

8409

8403

8107

8751

8408

8404

(840

2)

8406

8105

8105

THE NUMBERS BETWEEN ( )ARE FOR THE 20” DISPLAYS

WIRING 20” AND 23”

8684

3P 1701

Page 9: PHILIPS LC4.1HEAB

Block Diagrams, Test Point Overviews, and Waveforms 9LC4.1HE AB 6.

Block Diagram Video

1302UR1316S

TV IN

TUNER

232111

1328 VIF2

VIF18

7

2

4 5 1 3311 RF_AGC

SC

L

SD

A

DC

AC AGCDetect

1101

20

7

16

15

11

CVBS_SC1_AV1_IN

21

1

SCART 1

104

105

95

71

70

74

19 SC1_CVBS_RF_OUTEF7101

52 51 50 49

EF7014

R_SDTV

EF7013

G_SDTV

EF7012

B_SDTV

44

43

42

55 54 53 59 58 56

107

62

7461

27

3

7

25

1

5

R_MUX

R_MUX

R_MUX

17

14

11

VS_PC 2

HS_PC 12

74631

13

V_SDTV

H_CS_SDTV CS_HSYNC

VSYNC

14

15

7510

1

5

4

8 182

181

1485

15

18

23

24

17

+5VSWI14

9

10

11

2

1

ANALOGINPUTPORT

DVI/HDMIINPUTPORT

7403 MX29LV040QC

SDRAM1Mx32x4

RMDATA

RMADDR

7401GM5221H

GRAPHICZOOM

DISPLAYTIMINGGEN.

VIDEOZOOM

OS

D C

ON

TR

OLL

ER

OU

T B

LEN

DE

R

BR

IGH

TN

ES

S/C

ON

TR

AS

T/H

UE

/SAT

SYSTEM

7402M24C32

EEPROM(NVM)4Kx8

1404

2

5

3

4

76

8

9

10

12

15

18

20

19

14

16

PAN_VCC

RGB/Pr Pb InsertYUV Interface

RGB MatrixBlue & Black

StrechGamma Corr.

PAL/NTSC/SECAM

Decoder &Baseband

Delay

Sync SepH-OSCH-ShiftH-Drive

Vertical &East-WestGeometry

CV

BS

/Y

VDRB

H/V HOUT

RO

GO

BO

INS

SW

3

Chroma

Yint

R/P

r-3

G/Y

3

B/P

b-3

YO

UT

VO

UT

UO

UT

VIN

UIN

YS

YN

C

B_O

SD

G_O

SD

R_O

SD

Fast

Bla

nkin

g

PeakingSCAVEMU/V Delay

Skin ToneU/V Tint

Saturation

YUV

YUV in/out

SAT

SCAVEMon text

Dig. 2H/4HCombfilter

Y Delay Adj.

c

cvbs/y

SoundTraps

VideoSwitch

+Control

Uint

Vint

CVBS1

HS_PC

VS_PC

B_Pb_PC

G_Y_PC

R_Pr_PC

RX0n

RX0p

RXCp

RXCn

RX1n

RX1p

RX2p

RX2n

ROMINTERFACE

QSS MixerAM Demod. AM

QSS/FM1330 7

8

2 SIF2

SIF1

99

100

I044

I041

I039

IF-TER 22

13

21

14

20

19

15

16

18

17

119

118

124123

129

128

132

133

151

147

142

7011TDA15021H1

V_SDTV

H_CS_SDTV

DVI-ICONNECTOR

8 STATUS_1

6 7

+5SW_a+VTUN

18

916

1724

C5

C1C2

C3C4 28

8

27

26

25

F_15790_008.eps061205

SD_PCHD_SEL10,11

2

1108 1010

2

4 4

1

5

SVHS

24

3

1101

1102

AV3_C_IN

AV3_CVBS_Y_IN

86

SC1_FBL_IN

SC1_R_V_IN

SC1_G_Y_IN

SC1_B_U_IN

B2

AV3_CVBS_Y_IN

AV3_C_IN

LV_E0_TX0-

LV_E9_TX3+

LV_E1_TX0+

LV_E2_TX1-

LV_E3_TX1+

LV_E7_TXC+LV_E6_TXC-

LV_E4_TX2-

LV_E5_TX2+

LV_E8_TX3-

14021

31

33

35

37

39

42

TO D

ISP

LAY

(20

”)TO

DIS

PLA

Y (

15” ,

23”

)

23

SCALER

B7

PC_HD_SEL

EXT 1

VIDEOIN

S-VHS

FM IN

7316

SSIFB2

SEL_IFB2

7320363

23

AV3_CVBS_Y_IN

AV3_C_IN

B_Pb_PC

G_Y_PC

R_Pr_PC

SD_PCHD_SEL

22

B7

1

38

31

37

32

36

35

29

30

34

33

LV_O0

LV_O7

LV_O1

LV_O2

LV_O3

LV_O9LV_O8

LV_O4

LV_O5

LV_O6

SDA_IO

SCL_IO

WC

93

92

84

7

6

5

48

47

43

44

55

49

45

46

FHSYNC

PD20

PD21

HSHCLKFVSYNC

PD22

PD23

FED

PAN_VCC

EG1

ER0

EG0

ER1

ER7

ER6

ER2

ER3

ER5

ER4

EB3

EG4

EB2

EG5

EB1

EB0

EG2

EG3

EG7

EG6

EB5

EB4

EB7

EB6

ER(0-8)

EG(0-8)

EB(0-8)

LV_E0_TX0-

LV_E9_TX3+

LV_E1_TX0+

LV_E2_TX1-

LV_E3_TX1+

LV_E7_TXC+LV_E6_TXC-

LV_E4_TX2-

LV_E5_TX2+

LV_E8_TX3-

2057

2056

2027

SC1_CVBS_RF_OUT

H_CS_SDTV

V_SDTV

1462 J3

4 4

3 3

1 1

2 2

B2

B2

Q2

CVBSTERR

+5VA

Q11

+5VA

Q10

HSYNC

Q9

+5VA

Q8

VSYNC

J4 1001

9 9

13 13

8 8

10039

3

4

HSYN

VSYN

CVBSterrB2

B8

B8

B8

For ITVonly

TO SMART CARDEXPRESS BOX

F306

F313

F315

F312

F314

F499

F503

F534

HD_FILTER

21

B1 TUNER + VIF

B10 REAR IO SCART

B2 HERCULES B8 SCALER I/O B6 SCALER

VIDEO

D SIDE AV

HERCULES

B8 SYNC INTERFACE HC I-BOARD I2 MODULE SIDE I/OONLY FOR ITV SETS

B7 SCALER

Page 10: PHILIPS LC4.1HEAB

10LC4.1HE AB 6.Block Diagrams, Test Point Overviews, and Waveforms

Block Diagram Audio & Control

B4 AUDIO AMPLIFIER I AUDIO AMPLIFIER (20”, 23”)B2 HERCULESB1 TUNER + IF

AUDIO

B10 REAR IO SCART

B10 REAR IO SCART

D SIDE AV

D SIDE AV

CONTROLi2 MODULE SIDE I/OJ IR LED PANEL B3 HERCULESHC I-BOARD B2 HERCULES

E KEYBOARD CONTROL

i2 SIDE AV (20”, 23”)

1001

4

3

LEFTSPEAKER

RIGHTSPEAKER

60

61 AUDOUTLSR

AUDOUTLSL

17013 3

1110

1 1

7217TDA15021H

1302UR1316S

TV IN

FM IN

TUNER

232111

4 5

SC

L

SD

A

QSS MixerAM Demod.

AM1330 7

8

2 SIF2

SIF1

AD Conv.Std StereoDecoder

21

11101

21

1

SC1_L_RF_OUT

SC1_R_RF_OUT

SCART 1

PCAUDIO

IN

PC_AUDIO_L

PC_AUDIO_R

53

54

L_SC1_AV1_IN

R_SC1_AV1_IN

L_SC1_AV1_IN

R_SC1_AV1_IN

34

35

56

57SCART 1

62

63

36

37

99

100

33

IF-TERIFOUT

F306

AUDIOSELECT

ADC/DAC

AUDIOCONTROLVol/Treb/

BassFeatures

DACs

I2SProcessor

QSS/FM

MUTE

POWER_DOWN

SOUND_ENABLE

F_15790_009.eps061205

6323

7320

3

SEL_IF_SDMB2

OUT_MUTEMUTE

1751

4 4

1706

2 2

5 5MUTE

7370

11016

2

1102

6 6

7 7

AV3_L_IN

AV3_R_IN

AV3_L_IN

AV3_R_IN

49

50

1108 1010

7712TDA1517ATW

12,13

8,9

18

3

SC1_L

SC1_R

11044

3

EXT_MUTE

1

12

13

760274HC08PW

B2

3

11

MUTE

&

&2

EXT 1

AUDIOL/R IN

EXT 1

3

1

10

SIFF

7316

PC_AUDIO_L

PC_AUDIO_R

9 9

10 10

STANDBYB2

11

7752

77027703

1 1STANDBYB2

7712TDA1517ATW

2

5

14

7

AUDOUTLSR

AUDOUTLSL

9

8

7703-2

7703-1

19

16

2

1

R+

R-

L+

L-

1704

4 4

1107

5 5

1 1

2 2

1106

1 1

2 2

1001 J41002

1

2

3

4

5

6

4 4

2 2

1540 1540

6540B

6540A

75407542

7541

3544

6541

GND

+5VA

VS

OUT

5 5

3 3

1 1PC-TV-LED

LED-SEL

IR

3540 +5VARed

Green

LED_CTRL

RD_GR_LED

RC_IR

+5V

LEDIN_CLK

IRIN_DATA-IN

MODESTATUS_DATA-OUTGND

IR_OUT

LEDIN_CLK

IRIN_DATA-IN

MODESTATUS_DATA-OUTGND

IR_OUT

LED_CTRL

+5V

RD_GR_LED

RC_IR

3 3

4 4

5 5

6 6

17 17

20 20

21 21

22 22

23 23

7 1

6 6

J6 1007

5 5

2 2PC_TV_LED_OUT

97

7011TDA15021H1

115

107

120

7060+3V3STBY

+5VSW

3063

6060

3 3

LED_SEL_OUT

RC_IR

+5V

PC-TV-LED

LED-SEL

LIGHT-SENSOR

IR

To Smart CardExpress Box

LEDIN_CLK_TXD_SCL1

IR_IN_DATA-IN_RXD_SDA1

MODE

STATUS_DATA_OUT

U5P89C664

40

PC_TV_LED

13

10

11

114 SEL_IF

4015

SERVICESDM

116 STATUS_1 B3

102 EXT_MUTE B3

111 SOUND-ENABLE

122 STANDBY B3

B1

MICROCONTR.

HERCULES

See BlockdiagramI²C

U3HEF4053BT

4

9

18

4 4+3V3STBY+3V3STBY

LED-SEL

U4HEF4053BT

15

IR_IN_TV

1

LIGHT-SENSOR

1309

1310

1311

1312

1314

Channel+Channel-

Volume+

Volume-

Menu

KB

16842 2

1684KEYBOARD

IR_OUTCONTR.

4MULTIPLEX

MULTIPLEX

100111

10

98 TV_IRQB5

B4

99 TV_SC_COMB5

6073126

1286076

POWER_DOWNB4 B5

B3

B3

FOR 20”, 23”DISPLAY

FOR 15”DISPLAY

31701

1BATHROOMSPEAKER

1005

FOR 20”, 23”DISPLAY

HEADPHONE

1313Power

Page 11: PHILIPS LC4.1HEAB

Block Diagrams, Test Point Overviews, and Waveforms 11LC4.1HE AB 6.

Testpoint Overview SSB (Top Side)

3139 123 6019.1F_15310_025.eps

270605

X1

X1 SERVICE TESTPOINT

500mV / div DC5ms / div

X1

F528 B6F529 B6F530 B5F531 B5F532 B5F535 B6F536 B5F537 B6F538 B6F539 B6I414 B5I416 B5I418 B5I420 B5I422 B5

Page 12: PHILIPS LC4.1HEAB

12LC4.1HE AB 6.Block Diagrams, Test Point Overviews, and Waveforms

Testpoint Overview SSB (Bottom Side)

3139 123 6019.1F_15310_026.eps

270605

F002 C4F003 B2F004 A3F005 D4F006 D3F007 E2F009 A3F013 B3F014 B5F015 B4F017 A2F018 A3F020 B3F021 B3F022 B4F023 C2F026 C3F029 D3F034 D3F040 D4F041 D4F042 D3F043 D3F044 D3F045 D3F050 A3F051 A3F099 B2F101 E4F102 E4F103 E4F104 E3F105 E3F106 E3F107 E3F108 E3F109 E3F110 E2F111 E2F112 E2F113 E2F114 E3F115 E3F116 E3F301 E5F302 E4F303 D4F305 D5F306 D5F307 D5F308 E4F309 D4F310 B3F311 D5F312 C5F313 C5F314 C5F315 C5F401 D1F402 D1F403 C1F404 C2F405 C2F406 C2F407 C2F408 D1F409 C1F410 C1F411 C1F412 C1F413 C1F414 B1F415 B1F416 C1F417 C2F455 C2F456 C2F457 C2F471 E1F472 D1F473 D2F474 E1F475 E1F476 E1F477 D1

F478 E1F479 E1F480 E1F481 E1F484 E1F485 E1F487 E2F489 D1F497 D2F498 E2F499 C1F501 D1F502 D3F503 C1F504 D1F505 D1F506 E2F507 E2F533 B1F534 B2F707 B4F708 A4F710 A5F751 D6F752 D6F753 C6F903 A5F904 A6F905 A6F906 A6F907 A6F908 A6F909 A6F910 A6F911 B5F912 C5F913 B5F914 A6F951 A1F952 A1F954 B3I005 B5I008 D3I009 B4I011 D4I015 B3I016 D4I017 B4I018 B4I019 B4I020 B4I022 C5I034 D3I035 D3I036 D3I039 D1I040 C3I041 D2I043 D3I044 D2I046 D3I047 D3I048 D3I049 D3I051 D3I052 D3I053 D3I055 C3I056 B3I057 D2I058 C2I059 C3I060 C2I061 C2I062 C3I063 B3I064 B3I067 C3I068 B3I069 D3I070 C3I071 B3I082 D5I091 C2I093 B3

I094 B4I096 B4I098 A3I101 E4I102 E4I103 E4I104 E3I105 E3I106 E3I107 E3I108 E3I109 E3I110 E2I111 E2I112 E4I113 D4I114 E4I115 D3I116 E3I301 D5I302 D5I303 D5I304 D5I306 D5I307 D5I308 D5I310 D5I401 D2I402 D2I403 C1I404 C1I405 D2I406 D2I407 D2I408 D2I410 C2I411 C2I412 C2I413 A2I419 A1I438 B1I451 B2I462 D1I463 D1I464 D1I483 E1I484 E2I485 E1I486 E1I487 E1I488 E1I492 C1I493 C1I494 C1I496 C1I512 D1I513 D1I514 D1I516 D2I517 E2I518 D3I701 A4I705 A5I706 B4I707 A4I708 A5I709 B4I710 B4I711 A4I714 A5I715 B5I719 B5I720 A5I721 B3I722 A3I751 C6I752 D6I753 D6I901 B6I902 C6I904 B6I905 A6I906 B6I907 B6I908 C6

I909 A6I910 B6I911 B6I912 B6I951 B1I952 A1I953 A1I954 A1I955 A1I956 B2I957 A2

Page 13: PHILIPS LC4.1HEAB

Block Diagrams, Test Point Overviews, and Waveforms 13LC4.1HE AB 6.

I2C Overview

HERCULES TUNER + IFB1I²CB2

SCALER IO (OPTIONAL)B8

SCALERB6

I-BOARDHC SIDE I/Oi2B7 SCALER

SIDE I/OD

SDA

SCL

20

HERCULESSET

PROCESSOR

21

5 4

1302UR1316S

TUNER

ERR10

78 77

7401GM5221

SCALER

ERR4

ERR6

F_15790_011.eps061205

+3V3STBY

3356

3353

5 6

7099M24C16

EEPROMNVM

ERR9

NVM_WP

+3V3STBY

3097

251331

1

2

3

SERVICECONNECTOR

COMPAIR

18

916

1724

C5

C1C2

C3C4

1485

7

6

5 6

7490M24C02

EEPROM256x8

DCC_DVI_5V

3514

3495

SDA_DVI

SCL_DVI

DVI-DCONNECTOR

SDA_IO

SCL_IO

5 6

7402M24C32

EEPROM

93

92

+3V3_DVDD

3443

3414

ERR8

NVM_WPP

7403MX29LV040

FLASHROM

ERR4

ADDRESS

DATA

8480

79

SDA

SCL

7

JTAG_SDA_UART_TX

JTAG_SCL_UART_RX

72

71

+3V3_DVDD

3401

3402

RMDATA

RMADDR

7

7011TDA15021H1

3 2

U5P89C664

8 bit MICRO

CONTROLLER

R26

R25

+5VD

R24

R23

SDA2

SCL2

22

21

2

3

J1

+5VD

R39

R40

U3HEF4053BT

MULTIPLEXER

SDA323 13

+5VD

R69

14

U7ST202ECD

RS232TRANCIEVER 13

14

U2HEF4053BT

MULTIPLEX.

2

12

12

11

TXD

RXD

14

15IR-IN_DATA-IN_

RXD_SDA1

LEDIN_CLK_TXD_SCL1CLK_LED-IN_SCL1

DATA-IN_SDA1

3

13

44

43

TO CLOCK MODULE

(Optional)

5

7

13323 3

J2

2 2

TXD232

RXD232

TXD

RXD

+5VD

RP

1

RP

1

Q12

R67

R68

24 241001

11 11

J4

10 10

7

6

1003

5TXD232

RXD232

SDA3_IR-OUT

TO S

MA

RT

CA

RD

EX

PR

ES

S B

OX

2 2

1 1

2

1002

1

IRIN_DATA-IN

LEDIN_SCL1

TO S

MA

RT

CA

RD

EX

PR

ES

S B

OX

3430

3431

3442

3441

1111

2 2

1401

3 3

1 1

4 4

+3V3_DVDD+3V3STBY

3

1112

2

1 3123

3124

UART DORSERVICE

SDA1

SCL1

5 6

U8MC24C16

R35

R34

24

25

+5VD

RP

5

RP

5

3303

3302

ITVINTERFACE

+3V3_DVDD

3444

3497

3496

SDA

SCL

3353

3354

Page 14: PHILIPS LC4.1HEAB

14LC4.1HE AB 6.Block Diagrams, Test Point Overviews, and Waveforms

Supply Voltage Overview

B5 TV SUPPLY B1 TUNER + IF

B2 HERCULES

B3 HERCULES

B4 AUDIO AMPLIFIER +PROCESSING

B6 SCALER

B7 SCALER

B8 SCALER IO

B9 SUPPLY

B10 REAR IO SCART

I AUDIO AMPLIFIER

J ITV IR MODULE

HC I-BOARD

O CLOCK BOARD (OPTIONAL)

i2 MODULE SIDE I/O

SUPPLYPANEL(PSU)

+INVERTER

SUPPLY LINE OVERVIEW

1

1910

2

3

4

5

6

7

8

9

10

11

12 LAMP_ON_OFF

BACK_LIGHT_ADJ1

STANDBY

POWER_DOWN

1200

HCTO J10

I BOARD(20”, 23”)

1260

1001

AUD_SUP

+3V3STBY

+12VSW

7920

IN OUTCOM

+12VSW +8VSW_TV

7930MC34063AD

SUPPLYIC

5930+12VSW

7936

3935 3937

1

6

5931 5932 +5VSW

+VTUN5932

6910

B2B2

B7B7

+3V3STBY+3V3STBY

+5VSW+5VSW

+VTUN+VTUN

B5

B5

B5

+8VSW_TV+8VSW_TV

+3V3STBY+3V3STBY

+5VSW+5VSW

B5

B5

B5

+1V8_B+1V8_B

+1V8_A+1V8_AB3

B3

+5VSW+5VSW

+3V3STBY+3V3STBY

B5

B5

7004

+1V8_A7001

7003

7002

DECDIG

+1V8_B

B2

3003

3004

3002

3001

10075

+3V3STBY+3V3STBY

AUDIO_SUPAUD_SUP

+5VSW+5VSW

B5

B5

B5

+3V3STBY+3V3STBY

+3V3_DVDD

+3V3_AVDD5401

5404

B5

+1V8+1V8

+1V8_DVDD

+1V8_AVDD5402

5403

B9

+5VSW+5VSW

PAN_VCCPAN_VCC

B5

B9

+3V3STBY+3V3STBY

+5VSW+5VSW

VDD

B5

B5

5520

14855 DCC_DVI_5V54856486

6485

+3V3STBY+3V3STBY

PAN_VCC

B5

5955 7954

7953*

IN OUTCOM

5959

*

5957* 5961

7952PANEL_POWER_CTL

*SEE DIVERSITY LIST

+1V87955

IN OUTCOM

+5VSW+5VSW

+3V3_AVDD+3V3_AVDDB6

+3V3_DVDD+3V3_DVDDB6

AUD_SUP11703

+5VA11540

+3V3STBYJ2

1 +3V3STBY

+3V3L1

+5VU1

SMPS

CONTR

L4D2

+5VA

+5VD

L5

L6J4

21

7

+5VJ10

1 +12V** +12V**

J1

1

B31007

O1442

i21001

PSU1260

(20”,23”)

14421 VDDVDD

HCJ1 L1

12V**71001

11004

+5V21

1540

1J

1540

i21540

HCJ4

12VDCIN

(15”)

F_15790_010.eps061205

B2

B2

HCJ2

B7

B7

PSU1200

12V*

12V*

B1,B2,B3,B4,B6,B8,B9

B4

B9

B1,B2,B3,B4,B7,B8,B10

B1

B2

B55956*+12VSW

B9

B5

5958*

B7

B6

1540

1

PSUCN1

(15”)

PAN_VCC_IN

4,5

B9TO 1951

SSB(15”)

CN

1

F903

F905

F906

F913

F912

15”

1003

112V

*For 15” 12V Supply for I-Board is comming from external supply Module Side I/O (1004)

+12V*

+12V

**For 20”, 23” 12V Supply for I-Board is comming from PSU (1260)

15”

15”

Page 15: PHILIPS LC4.1HEAB

Circuit Diagrams and PWB Layouts 15LC4.1HE AB 7.

7. Circuit Diagrams and PWB Layouts

Side I/O Panel & LKB 15”

1 2 3 4 5 6

A

B

C

D

654321

D

C

B

A

302641.7R

30202K2

302541.7R

3023560R

3019

1K

30221K5

3021 1K-NL

3027

0R

+

20032.2uF, 25V-NL

1

2

3

4

10064B-PH-K-S

1

2

3

4

1007 4B-PH-K-S

1

2

3

4

5

6

7

8

9

10

100310PIN-CONN

123456789

101112131415161718192021222324

1001B24B-PHDSS-B

2

3

11004

TC18-041-03

12 34

1005LGT1509-0200

1

2

3

45001

PH 3112 338 3088

12

34

5000LITAI 320417-3

123

4

7000TCET110-3G

123

456

1733SPPH4

AK 6005BZX384-C10

A K6004

BZX384-C5V1-NL

1

23

7006BC857BW-NL

1

23

7008BC857BW-1

1

23

7007BC857BW-1

13

2

7001BC847BW-1

+

2004

1000uF,16V+2002

100U,50V

2006100nF

2005 4n7F

AK

6007

6V5

C-483X

ZB

AK

6008

6V5

C-483X

ZB

3029220R

300710R, 0805

30165K6 3018

1K8

30175K6

3028

2.2K

30241K-NL

5002

10uH

5003

6.8uH

5004

6.8uH

2008

2n2

6002

BAS3166001BAS316

1

3

2

4

5

66009

BZA408B

1

3

2

4

5

6

6010BZA408B

20072U2

30301K

TO TV Board

TO LoudSPK

303110K

303210K

1

32

7009BC847BW-1

LEDIN_SCL1IRIN_DATA-INMODE_12VSTATUS_DATA-OUTDGNDIR OUT

12V HSYNVSYNTXD232RXD232DCM-PORCVBSterr

GNDA HP-ROUT

HP-LOUT

TO i-BOARD

PEND IR

R+

R+

R-

R-

L+

L-

L-

L+

30330R

30340R

1

2

3

4

5

6

1002

6PIN-CONN

AK

6006

BZX384-C5V1-NL

2009

LN-Fu2.2

LED_CTRL

+5V

RD_GR_LEDRC_IR

1

2

31701

3B-PH-K-S

12345

15405B-PH-K-S

TV_12VHSYNVSYNTXD232RXD232DCM-PORCVBSterrGNDA

300810R, 0805

5006 6.8uH

30351K

2010100pF

5005 6.8uH

6011

PRLL4001

6012

PRLL4001

RJ45

RJ12

1

2

3 4

5

6

9

MH1MOUNTING_HOLE

1

2

3 4

5

6

9

MH2MOUNTING_HOLE

1

10081_PIN_CONN

TV_12V

1

10091_PIN_CONN

SDA1

3036Res, 0603

MODE_12V HC

TO IR MODULE

J

TO SSB

B

i2 SIDE I/O 15”

F_15790_012.eps0712053139 123 5986.2

Page 16: PHILIPS LC4.1HEAB

16LC4.1HE AB 7.Circuit Diagrams and PWB Layouts

Layout Side I/O Panel 15” (Top Side)

Layout Side I/O Panel 15” (Bottom Side)

F_15790_013.eps0612053139 123 5986.2

F_15790_014.eps0612053139 123 5986.2

Personal Notes:

E_06532_012.eps131004

Page 17: PHILIPS LC4.1HEAB

Circuit Diagrams and PWB Layouts 17LC4.1HE AB 7.

Side I/O & Panel & LKB 20” & 23”

1 2 3 4 5 6

A

B

C

D

654321

D

C

B

A

302641.7R

30202K2

302541.7R

3023560R

3019

1K

30221K5

3021 1K-NL

3027

0R

+

20032.2uF, 25V-NL

1

2

3

4

10064B-PH-K-S

1

2

3

4

1007 4B-PH-K-S

1

2

3

4

5

6

7

8

9

10

100310PIN-CONN

123456789

101112131415161718192021222324

1001B24B-PHDSS-B2

3

11004

TC18-041-03

12 34

1005LGT1509-0200

1

2

3

45001

PH 3112 338 3088

12

34

5000LITAI 320417-3

123

4

7000TCET110-3G

123

456

1733SPPH4

AK6005BZX384-C10

A K6004

BZX384-C5V1-NL

1

23

7006BC857BW-NL

1

23

7008BC857BW-1

1

23

7007BC857BW-1

1

32

7001BC847BW-1

+

2004

1000uF,16V

+2002100U,50V

2006100nF

2005 4n7F

AK

6007

BZ

X38

4-C

5V6

AK

6008

BZ

X38

4-C

5V6

3029220R

300710R, 0805

30165K6 3018

1K8

30175K6

3028

2.2K

30241K-NL

5002

10uH

5003

6.8uH

5004

6.8uH

2008

2n2

6002

BAS3166001BAS316

1

3

2

4

5

66009

BZA408B

1

3

2

4

5

6

6010BZA408B

20072U2

30301K

TO TV Board

TO LoudSPK

303110K

303210K

1

32

7009BC847BW-1

LEDIN_SCL1IRIN_DA TA-INMODE_12VSTATUS_DA TA-OUTDGNDIR OUT

12V HSYNVSYNTXD 232

DCM-PORCVBSterr

GNDA HP-ROUT

HP-LOUT

T rd

PEND IR

R+

R+

R-

R-

L+

L-

L-

L+

30330R

30340R

1

2

3

4

5

6

1002

6PIN-CONN

AK

6006

BZX384-C5V1-NL

2009

2.2u

F-N

L

LED_CTRL

+5V

RD_GR_LEDRC_IR

1

2

31701

3B-PH-K-S

12345

15405B-PH-K-S

TV_12VHSYNVSYNTXD 232RXD 232DCM-PORCVBSterrGNDA

300810R, 0805

5006 6.8uH

30351K

2010100pF

5005 6.8uH

6011

PRLL 4001

6012

PRLL 4001

1

2

3 4

5

6

9

MH1MOUNTING_HOLE

1

2

3 4

5

6

9

MH2MOUNTING_HOLE

1

10081_PIN_CONN

TV_12V

1

10091_PIN_CONN

SDA1

3036Res, 0603

MODE_12V

124011

JUMPER

303710K

+5V

4007 0R

RXD 232

12

9002

JUMPER

1 29003

JUMPER

SDA1

12V

1 24001

JUMPER1 2

4002

JUMPER

1 24003

JUMPER

1 24004

JUMPER

1 24005

JUMPER

1 24006

JUMPER

1 24008

JUMPER

1 24009

JUMPER

1 24010

JUMPER

1 29001

JUMPER

TO i-BOARD

RJ45

RJ12

HC

TO IR MODULE

J

TO SSB

B

i2 SIDE I/O 20” & 23”

F_15790_015.eps0712053139 123 6159.1

Page 18: PHILIPS LC4.1HEAB

18LC4.1HE AB 7.Circuit Diagrams and PWB Layouts

Layout Side I/O Panel 20” & 23” (Top Side)

Layout Side I/O Panel 20” & 23” (Bottom Side)

F_15790_016.eps0612053139 123 6159.1

F_15790_017.eps0612053139 123 6159.1

Page 19: PHILIPS LC4.1HEAB

Circuit Diagrams and PWB Layouts 19LC4.1HE AB 7.

i-Board Panel

i-BOARDHC

F_15800_006.eps2405053139 123 6133.3

1 2 3 4 5 6

A

B

C

D

654321

D

C

B

A

L16u8

+3V3STBY+12V +3V3

R50

1R5

X116MHz

8

7

6

5

1

2

3

4

Drive

Ipk Sense

Vcc

ComparatorInv. I/p

SwitchCollector

SwitchEmitter

TimingCapacitor

Ground

Collector

U1MC34063AD

R2

220R

R49 1R5

R5

2K7

R6 470RR4

1K0

C2

100pF

A K

D2SS24

L368uH

+ C1

220uF, 16V

+ C3220uF, 16V

L4

6.8uH

+ C4

220uF, 16V

+5V

L5

6.8uH - 1008+

C5100uF, 16V

+ C6100uF, 16V

L6

6.8uH - 1008

+5VD

+5VA

1234

J1

4P-CONN-TYCO

LCD ClockSDA2SCL2

L7 Ferrite bead

+5V

C7 100nF

To TVBD

SDASCL

SR+3V3STBY

12345

J3

5P-CONN-SR-V

To TVBD

SR

To SideI/O

R7100R 1

32Q2

BC847BW

R8

68R

R9220R

+5VA

C8100nF

HSYNVSYN

LEDIN_CLK_TXD_SCL1IR-IN_DATA-IN_RXD_SDA1MODESTATUS_DATA_OUT

IR_OUTGND

+12VHSYNCVSYNCTXD232RXD232DCM_POR

GNDAHP_ROUT_RC-PULLUPHP_LOUT

PEND_IR

+12V

Za14

Zb15

Zc4

Sa11

Sb10

Sc9

Vdd

16

Y1a13

Y0a12

Y1b1

Y0b2

Y1c 3

Y0c 5

Vss8

Vee7

E6

U2

HEF4053BT

R10 100RR11 100R

+5VAC9

100nF

IRIN_DATA-IN

DATA-IN_SDA1

Za14

Zb15

Zc4

Sa11

Sb10

Sc9

Vdd

16

Y1a13

Y0a12

Y1b 1

Y0b 2

Y1c 3

Y0c 5

Vss8

Vee7

E6

U3

HEF4053BT

R13 100R

C11 100nF

+5VA

TristateSTATUS_DATA_OUT1

R15

10K

R16 100R

1

23

Q3BC857BW

R17

150R

+5VA

1

32

Q4

BC847BW

R18

1K0

R19

10K+5VA

1

32

Q5BC847BW

R20

10K

Za14

Zb15

Zc4

Sa11

Sb10

Sc9

Vdd

16

Y1a13

Y0a12

Y1b1

Y0b2

Y1c 3

Y0c 5

Vss8

Vee7

E6

U4

HEF4053BT

C12 100nF

+5VA

IB_IROUT

IR_IN TV

12345678910

J5

10P-CONN-SR-V

SR

SR

LC04V

LC04C

HP_ROUT_RC-PULLUPHP_LOUTPC_TV_LEDLED_SELGND

LIGHT SENSORIR_IN TVKEYBOARD_TVINTP

P50_ITV

PC_TV_LED

LED_SEL

LIGHT SENSOR

+3V3S

+3V3S

P1.5

/CE

X2

1

P1.6

/SC

L2

P1. 7

/SD

A3

RS T

4

P3. 0

/Rx D

5

NIC

*6

P3. 1

/TxD

7

P3.2

/IN

T0

8

P3.3

/IN

T1

9

P3.4

/ CE

X3/

T0

10

P3. 5

/CE

X4/

T1

11

P3.6/WR12P3.7/RD 13XTAL2 14XTAL1 15VSS16NIC* 17P2.0/A8 18P2.1/A9 19P2.2/A1020P2.3/A1121P2.4/A1222

P2.5

/A13

23P2

.6/ A

1424

P2. 7

/A15

25PS

EN

26A

LE

27N

IC*

28E

A/V

pp29

P0.7

/AD

730

P 0.6

/AD

631

P0.5

/AD

532

P0.4

/AD

433

P0.3/AD334

P0.2/AD235

P0.1/AD136

P0.0/AD037

VCC38

NIC*39

P1.0/T240

P1.1/T2EX41

P1.2/ECI42

P1.3/CEX043

P1.4/CEX144

U5P89C664HBBD

18

27

36

45

RP210K-RP

18

27

36

45

RP310K-RP

+5VD +5VD

IR_IN TV

RJIR_IN

PC_TV_LED_OUTR21

100R

LED_SEL_OUT

R22 1K

LIGHT SENSOR

R244K7

R234K7

R25 100RR26 100R

+5VD

SCL

SDA

C13 27pF

C14 27pF

RX

D

TX

D

R2810K

R27

10K

+5VD

R292K2

+5VD

1

32

Q6BC847BW

R3122K

R3222K

L116.8uH - 1008

C251uF

+5VD

RST1 VCC2

GN

D3

U6DS1813

R305K6

1 2SW1

Tact Switch, SKQNABD010

DC

M_P

OR

CLK_LED-IN_SCL1

C16 27pF

C17 27pF

1 82 73 64 5RP4

10K-RP

RX

DT

XD

TX

DR

XD

+5VD

STATUS_DATA_OUT1

R33 100R

1 2J8

2P-Shrouded-HDR

1 2 3

J93P-CONN-SR-V

SPARE IO

SR

R34 100RR35 100R

SCL1SDA1

C1+ 1V+2

C1- 3

C2+ 4

C2- 5

V-6

T2_OUT7

R2_IN8 R2_OUT 9

T2_IN 10T1_IN 11

R1_OUT 12R1_IN13

T1_OUT14

GN

D15

VC

C16 U7

ST202ECD

TXD232

RXD232

C18

100nF

C19 100nF

C20 100nF

C21100nF

+C22

100uF, 16V

L12

6u8- 1008+5V

C24 100nF

C23 100nF

R36 100R

R37 100R

TXD

RXD

GNDA

PEND_IR

FromTV

RC

_IR

PC_T

V_ L

ED

R38

220R

12345678

J6

8P-CONN-PH-V

P50_ITV

KEYBOARD_TV INTP

IB_IROUT

L86.8uH - 1008

+5V

+C26100uF, 16V C27

100nF

123

J10

3P-CONN-PH-BC28

10uF

+5VD

IR_P

UL

LU

P_SW

123456789101112131415161718192021222324

J4

24P-CONN-PHDSS-B

PC_TV_LED_OUT

+5VL10 6u8- 1008LED_SEL_OUTRC_IR

GNDA

RC_IR

R404K7

R394K7

R44

10K+5VD

C35 10nF

C31

10nF

C30

10nF

C32 10nF

C33

10nFC34

10nF

C361uF

C2910uF

D3

BZ

X38

4-C

5V6

R4822K

1

32

Q7

BC847BW

C3710nF

1

23

Q8BC857BW

R5110K

R5247K

1

32

Q9BC847BW

R554K7

R5410K

R5347K

+5VA

VSYN

VSY

NC

1

23

Q10BC857BW

R5610K

R5747K

1

32

Q11BC847BW

R604K7

R5910K

R5847K

+5VA

HSY

N

HSYNC

R62 100R

R61 100R

1 82 73 64 5

RP5

10K-RP

C38

27pF

C39

27pF

E0 1E1 2E2 3VSS4SDA5

SCL6

WC7

VCC8

U8

MC24C16

SCL1SDA1

C40 1nF

18

27

36

45

RP110K-RP

1

32

Q12

BC847BW

1

32

Q13BC847BWR63

47K

R6410K

R67

100RR68

100R

C42100nF

C41Reserve

SDA

3

TV_POR

+5VD

+5VD

SDA2

SCL2

+5VDR69 10K

SDA3

R70 100R

R72

1K

LCM_POW

LCM_POW

R710R

R73

4K7

C15

1uF

12345

J7

5P-CONN-TYCO

LCM_POW

SDA2SCL2 1

23

Q14PBSS5140U

R75 0R

R74 100R

L13

BLM21P221SN1D

L14

BLM21P221SN1D

R7610K

+5VA

C43

1uF

R79 10K

R8010K

R78

0R

R77 10K

C44 100nF

C4510nF

1

32

Q15BC847BW

R8210K

R831K

+5VA

R81 0R

R840R

HP_ROUT_RC-PULLUP

VSYNC

R8510K

R8610K

R1100R

LED_SEL

R3

100R

1

32

Q1BC847BW

R1210K

LE

D_S

EL

_OU

T

R14

2K2

R474K7

R46 4K7

+C46100uF, 16V

R41

0R

D1

BZX384-C2V7

CVBSTERR

CVBSTERR

IN3

GN

D2

OUT 1

U9 LED50CZ

R87NFR254R7

M2

R42

0R

R430R

1234

J2

4P-CONN-SR-V

DGND

CVBSTERR

Page 20: PHILIPS LC4.1HEAB

20LC4.1HE AB 7.Circuit Diagrams and PWB Layouts

Layout i-Board Panel (Top Side)

Layout i-Board Panel (Bottom Side)

F_15800_007.eps240505

3139 123 6133.3

F_15800_008.eps2405053139 123 6133.3

Page 21: PHILIPS LC4.1HEAB

Circuit Diagrams and PWB Layouts 21LC4.1HE AB 7.

LED and IR Panel

LED & IRJ J

3139 123 6097.1F_15800_012.eps

280505

1 2 3 4 5 6

A

B

C

D

654321

D

C

B

A

3542220R

+5VA

+5VA

PC-TV-LED

IR

LED-SEL+2540

100uF, 16V

+5VA

Green Red

OUT1

GND2

VS3

6541

TSOP34136

1

23

7540

BC857BW-1

1

32

7542BC847BW-1

1

32

7541

BC847BW-1

3540470R

35444K7

3545220R

3546220R

12

6543TSML-1020

12

6542TSML-1020

35474K7

12

6540A

SPR-325MVW

32

6540B

SPR-325MVW

12

6544

SIR-341ST3F

1

2

3

4

51540

S5B-PHK

35484K7

1

32

7543Res3549

Res

254110uF

Page 22: PHILIPS LC4.1HEAB

22LC4.1HE AB 7.Circuit Diagrams and PWB Layouts

Layout LED and IR Panel (Top Side)

Layout LED and IR Panel (Bottom Side)

3139 123 6097.2F_15800_013.eps

281105

3139 123 6097.2F_15800_014.eps

281105

Personal Notes:

E_06532_012.eps131004

Page 23: PHILIPS LC4.1HEAB

Circuit Diagrams and PWB Layouts 23LC4.1HE AB 7.

LCD Clock Panel

1 2 3 4

A

B

C

D

4321

D

C

B

A

R610K

R7100KC4

0.1uF

C61uF

VDD

C7

12P

AK-8504-CQ4

Q1

BC857B

R1

2K2

R2

100R

LED

VSSSCLSDA

R4 100R

R3 100R

C310P

C210P

R9

2K2

R8

18R

VDD

4MHz

C8

12P

BAS216VDD

BLM21PG221SN1DL1

VDD 1

SDA 2

SCL 3

VSS 4

1442I/O

I/O

SEG01

SEG12

SEG23

SEG34

SEG45

SEG56

SEG67

SEG78

SEG89

SEG910

SEG1011

SEG1112

SEG1213

SEG1314

SEG1415

SEG1516

SEG1617

SEG1718

COM119

COM020

LCD

LCD1442

PB5 1PB4 2PA3/PFD 3PA2 4PA1 5PA0 6PB3 7PB2 8PB1 9PB0 10VSS 11PC0 12PC1 13PC2 14PC315

PC416

PD0/PWM017

PD1/PWM118

/RES19

VDD20

OSC121

OSC222

PA7/SCL23

PA6/SDA24

PA525

PA426

PB727

PB628

U1

HT46R23

COM013

COM114

COM215

COM316

SEG0 48

SEG1 47

SEG2 46

SEG3 45

SEG4 44

SEG5 43

SEG6 42

SEG7 41

SEG8 40

SEG9 39

SEG10 38

SEG11 37

SEG12 36

SEG13 35

SEG14 34

SEG15 33

SEG16 32

SEG17 31

SEG18 30

/CS1

/RD2

/WR3

DATA4

VSS5

OSCO6

OSCI7

VLCD8

VDD9

/IRQ10

BZ11

/BZ12

U2

HT1621

COM1COM0

COM1COM0

R5

10K

VDD

VDD

C5

1uF

VDD

R102K2

R1147R

Q2BC857B

Q3BC857B

C1

100uF

VDD 1

SDA 2

SCL 3

VSS 4

RES 5

I/O

1443I/O

R12

R13

Q4

J11uF

F_15140_007.eps281105

O OLCD CLOCK PANEL

3139 188 6736.1

Page 24: PHILIPS LC4.1HEAB

24LC4.1HE AB 7.Circuit Diagrams and PWB Layouts

Personal Notes:

E_06532_013.eps131004

Page 25: PHILIPS LC4.1HEAB

Alignments EN 25LC4.1HE AB 8.

8. Alignments

Index of this chapter:8.1 General Alignment Conditions8.2 Hardware Alignments8.3 Software Alignments

Notes: • Only information that is related to the iTV module, is

published in this manual. For the other information, see the relevant chassis manual (order code on front page).

• Figures below can deviate slightly from the actual situation, due to the different set executions.

• The Service Default Mode (SDM) and Service Alignment Mode (SAM) are described in chapter 5. Menu navigation is done with the Cursor Up, Down, Left or Right keys of the remote control transmitter.

8.1 General Alignment Conditions

Perform all electrical adjustments under the following conditions:Mains voltage and frequency: 100-240 V / 50/60 Hz.Allow the set to warm up for approximately 10 minutes.Test probe: Ri > 10 MΩ; Ci < 2.5 pF.

8.2 Hardware Alignments

There are no hardware alignments foreseen for the LCD-TV.

8.3 Software Alignments

With the software alignments of the Service Alignment Mode (SAM) the geometry, white tone and tuner (IF) can be aligned.To store the data: Use the RC button Menu to switch to the main menu and next, switch to ‘Stand-by’ mode.

8.3.1 Options

Options OP1...OP7 in the SAM menu can be used for quickly restoring features or settings of the Hercules part of the TV set to their original default factory values (8 groups of 8 features/settings each). When the decimal value of one option byte OP1...OP7 is changed (see the first table below) then a group of 8 bits, representing 8 Hercules options or features, is changed as well (see the second table below for a detailed description of the features or settings that are changed).The second table shows which option byte (OP1...OP7) represents which group of 8 option bits. Each bit (0...7) switches a particular Hercules feature or setting ON or OFF, depending on its value (1 or 0).It is also possible to change the features or settings mentioned in the second table directly at bit level, by means of the NVM Editor in the SAM menu. In the NVM Editor, first the correct NVM address (ADR) has to be entered, then the correct value (VAL, 1 or 0) for each bit (see second table), and finally the settings have to be stored (STORE). For quickly restoring the Hercules part of the TV set to its original factory settings, however, it is more convenient to simply enter the default factory settings OP1...OP7 that are given in the first table below. How to do this, is described in the next paragraph.

How to Change Options at Bit LevelIf you wish to know which features or settings of the Hercules are changed via OP1...OP7, or if you want to change each option or feature bit by bit, use the more detailed table below.

Table 8-1 Option Bytes (OP1 .. 7) overview

OP Bit Feature / Mode

15H

F54

43/1

0

20H

F54

73/1

0

23H

F54

73/1

0

1 7 OP_PHILIPS_TUNER 1 1 16 OP_FM_RADIO 1 1 15 OP_LNA 0 0 04 OP_ATS 1 1 13 OP_ACI 1 1 12 OP_UK_PNP 0 0 01 OP_VIRGIN_MODE 0 0 00 OP_CHINA 0 0 0

Total DEC Value 216 216 2162 7 OP_SC 0 0 0

6 OP_UI_GREEN 0 0 05 OP_CHANNEL_NAMING 0 0 04 OP_LTI (Lum Transient Improvmt) 0 0 03 OP_TILT 0 0 02 OP_FINE_TUNING 1 1 11 OP_PIP_PHILIPS_TUNER 0 0 00 OP_HUE 0 0 0

Total DEC Value 4 4 43 7 OP_EW_FUNCTION 1 1 1

6 OP_2TUNER_PIP 0 0 05 OP_PIP_SPLITTER 0 0 04 OP_SPLITTER 0 0 03 OP_VIRTUAL_DOLBY 1 1 12 OP_WIDE_SCREEN 0 0 11 OP_WSSB 0 0 10 OP_ECO_SUBWOOFER 0 0 0

Total DEC Value 136 136 1424 7 OP_PC_MODE 1 1 1

6 OP_HD 1 1 15 OP_ULTRA_BASS 0 0 04 OP_DELTA_VOLUME 1 1 13 OP_TAIWAN_KOREA 0 0 02 OP_VOLUME_LIMITER 0 0 01 OP_STEREO_DBX 0 0 00 OP_STEREO_NICAM_2CS 1 1 1

Total DEC Value 209 209 2095 7 OP_AV1 1 1 1

6 OP_AV2 0 0 05 OP_AV3 1 1 14 OP_CVI 0 0 03 OP_SVHS2 0 0 02 OP_SVHS3 1 1 11 OP_HOTEL_MODE 0 0 00 OP_SIMPLY_FACTORY 0 0 0

Total DEC Value 164 164 1646 7 OP_PERSONAL_ZAPPING 0 0 0

6 OP_SMART_SURF 0 0 05 OP_FMTRAP 0 0 04 OP_COMBFILTER 1 1 13 OP_ACTIVE_CONTROL 1 1 12 OP_VIDEO_TEXT 0 0 01 OP_LIGHT_SENSOR 0 0 00 OP_TWIN_TEXT 0 0 0

Total DEC Value 24 24 247 7 OP_TIME_WIN1 0 0 0

6 OP_16:9_set 0 0 15 OP_THAI 0 0 04 OP_3D_COMBFILTER 0 0 03 OP_DUMMY6 0 0 02 OP_DUMMY7 0 0 01 OP_WEST_EU 1 1 10 OP_MULTI_STANDARD_EUR 1 1 1

Total DEC Value 3 3 67

Page 26: PHILIPS LC4.1HEAB

AlignmentsEN 26 LC4.1HE AB8.

8.3.2 ADC Gain and Grey Scale Alignment

The table below shows a number of important NVM settings (in decimal values) used for each TV model. Be sure to use the correct editor in the SAM menu (NVM Editor), because this one is used for the Hercules NVM, and the SC NVM Editor for the SCALER (SC) part of the TV set.

Caution: • Do not change the NVM settings without

understanding the function of each setting, because incorrect NVM settings may seriously hamper the correct functioning of the TV set!

• Do not change the Scaler NVM settings below address 320 (dec), as this will hamper the DVI functionality of the TV set!

• Always write down the existing NVM settings, before changing the settings. This will enable you to return to the original settings, if the new settings turn out to be incorrect.

Table 8-2 Hercules default NVM settings (editable via “NVM Editor” in SAM mode)

Byte/Addr. Bit Feature/Mode Description 15HF5443/10 20HF5473/10 23HF5473/10Byte 0/174(dec)

0 QSS (LSB) Mode of quasi split sound amplifier 1 1 11 FMI Connection of output of QSS amplifier 1 1 12 HCO EHT tracking mode 0 0 03 HP2 Synchronization of OSD/Text display 1 1 14 FSL Forced slicing level for vertical sync 1 1 15 TFR DC transfer ratio of luminance signal 1 1 16 OSVE Black current measuring in overscan 0 0 07 MVK (MSB) (For Future Usage, as defined by software) 0 0 0

Total Dec Values 59 59 59Byte 1/175(dec)

0 PSE 0 0 01 OPC 0 0 02 PRIS 0 0 03 CONTINUOUS FACTORY Continuous factory mode 1 1 14 WHITE PATTERN ON Last color pattern status in factory mode 0 0 05 SDM MODE Service default mode on/off 0 0 06 SAM MODE Service Align mode on/off 0 0 07 SVMA Scavm On / Off 0 0 0

Total Dec Values 8 8 8Byte 2/176(dec)

0 MUTE STATUS Mute status 0 0 01 TUNER AUTO MODE Auto mode 1 1 12 CABLE MODE Cable/Antenna mode 0 0 03 LAST POWER MODE Last power status of the set 1 1 14 CHILD LOCK MODE Child lock enabled 0 0 05 SURF MODE Surf mode on/off 0 0 06 FACTORY MODE Factory mode on 1 1 17 PSNS For PAL color enhancement in ES4 1 1 1

Total Dec Values 202 202 202Byte 3/177(dec)

0 RADIO/TV MODE Radio mode or TV mode 0 0 01 WAKE-UP MODE 0 0 02 HOTEL MODE TV in Hotel mode 0 0 03 HOTEL KBD LOCK Keyboard locked 0 0 04 HBL 0 0 05 BLS Blue stretch mode 1 1 16 SL 0 0 07 CFA0 Comb filter On/Off 0 0 0

Total Dec Values 32 32 32Byte 4/178(dec)

0 Signal Strength Signal Strength Switch in MK2 0 0 01 LPG 0 0 02 DVD TRAY LOCK Lock/Unlock DVD tray 0 0 03 SCRSAVER MODE Screen saver mode 1 1 14 BKS Black Stretch Mode 1 1 15 BSD Black Stretch Depth 1 1 16 CRA0 Coring on SVM 0 0 07 PIP QSS PIP QSS 0 0 0

Total Dec Values 56 56 56Byte 5/179(dec)

0 FFI Fast Filter 0 0 01 NNR No red reduction during blue stretch 1 1 12 MUS NTSC matrix 0 0 03 GAM Gamma control 1 1 14 CBS Control sequence of beam current limiting 0 0 05 LLB Low level of beam current limiter 0 0 06 DSA Dynamic skin tone angle 1 1 17 DSK 0 0 0

Total Dec Values 74 74 74

Page 27: PHILIPS LC4.1HEAB

Alignments EN 27LC4.1HE AB 8.

8.4 Setting the Correct iTV Model

If the i-Board is directly replaced by a new off-shelf module (already programmed with platform software), the correct iTV model still must be programmed via below sequences to get to the correct model type with its I/O configurations.

1. Put the iTV remote control (e.g. RC2573) in setup mode.2. Push a number on the remote control to switch “on” the TV.3. Push the RECALL button.4. Check the model number, listed in line 05.

If it is correct, the setting is done.If the number is incorrect, continue with the next point.

5. Key in “042420”, immediately followed by “M”.You now enter SDM.

6. Select and activate NVM EDIT mode.7. Key in address “0022” (hex).8. Push ARROW DOWN to activate the “Value” line.9. From the Diversity table read the diversity code that

belongs to the type of TV set you are adjusting. Enter that number in the “Value” line.

10. Select STORE to put the new value in the NVM.11. Push the POWER button to switch “off” the TV set.12. Pull the mains plug.13. Reconnect the mains plug after a few seconds.14. The new setting is now active.

Table 8-3 Diversity table

Byte 6/180(dec)

0 LTI status LTI last status 0 0 01 INC_LIFE_TIME 0 0 02 PC_MODE 0 0 03 HD_MODE 0 0 04 TACT_SWITCH 0 0 05 SET_IN_SPECIAL_STBY 0 0 06 HOTEL_OSDDISPLAY 0 0 07 HOTEL_MONITOROUT 0 0 0

Total Dec Values 0 0 0Byte 7/181(dec)

0 HOTEL_ICONNMODE 0 0 01 DBE Dynamic Bass Enhancement Status 1 1 12 SET_IN_PC_SLEEP_MODE 0 0 03 Reserved Reserved 0 0 04 Reserved Reserved 0 0 05 Reserved Reserved 0 0 06 Reserved Reserved 0 0 07 Reserved Reserved 0 0 0

Total Dec Values 2 2 2

Byte/Addr. Bit Feature/Mode Description 15HF5443/10 20HF5473/10 23HF5473/10

Diversity Storage Byte

Model Address (hex) Diversity code (hex)

15HF5443/100022

09

20HF5473/1016 10

23HF5473/1017 11

Page 28: PHILIPS LC4.1HEAB

Circuit Descriptions, Abbreviation List, and IC Data SheetsEN 28 LC4.1HE AB9.

9. Circuit Descriptions, Abbreviation List, and IC Data Sheets

Index of this chapter:9.1 Introduction9.2 Abbreviation List9.3 IC Data Sheets

9.1 Introduction

The LC4.1 LCD iTV is a Hotel TV based on the LC4.1 chassis. For a detailed circuit description, please use that specific manual (order code on front page). The iTV specific board in this chassis (i-Board) is for Service a “black box”, and therefore must be replaced completely when defective (board swap).

9.2 Abbreviation List

480i 480 visible lines, interlaced480p 480 visible lines, progressive scanAV External Audio VideoB/G Monochrome TV system. Sound

carrier distance is 5.5 MHz. B= VHF-band, G= UHF-band

ComPair Computer aided rePair. A tool for diagnosing a TV through a PC controlled interface

CSM Customer Service ModeCVBS Composite Video and Blanking Signal;

A single video signal that contains luminance, colour, and timing information

DFU Directions For Use: Owner's manualDST Dealer Service Tool; Special remote

control designed for dealers to enter e.g. service mode (a DST-emulator is available in ComPair)

EU EuropeH H_sync to the module HD High DefinitionI Monochrome TV system. Sound

carrier distance is 6.0 MHz. VHF- and UHF-band

I2C Integrated IC busIC Integrated CircuitIF Intermediate FrequencyIR Infra RedITV Institutional TVLC04 Philips chassis name for LCD TV 2004

projectLCD Liquid Crystal DisplayLED Light Emitting Diode; A semiconductor

diode that emits light when a current is passed through it

L/L' Monochrome TV system. Sound carrier distance is 6.5 MHz. L' is Band I, L is all bands except for Band I

M/N Monochrome TV system. Sound carrier distance is 4.5 MHz. M= 525 lines @ 60 Hz, N= 625 lines @ 50 Hz

NC Not ConnectedNICAM Near Instantaneously Companded

Audio Multiplexing; This is a digital sound system, mainly used in Europe

NTSC National Television Standard Committee. Colour system used mainly in North America and Japan. Colour carrier NTSC M/N = 3.579545 MHz, NTSC 4.43 = 4.433619 MHz (this is a VCR norm, it is not transmitted off-air)

NVM Non Volatile Memory; IC containing data such as alignment values, preset stations

O/C Open CircuitOSD On Screen DisplayPAL Phase Alternating Line. Colour system

used mainly in Western Europe (colour carrier = 4.433619 MHz) and South America (colour carrier PAL M = 3.575612 MHz and PAL N = 3.582056 MHz)

PCB Printed Circuit Board (or PWB)PLL Phase Locked Loop. Used, for

example, in FST tuning systems. The customer can directly provide the desired frequency

PWB Printed Wiring Board (also called PCB or CBA)

RC Remote Control transmitterRC5 or 6 Remote Control system 5 or 6, the

signal from the remote control receiver RGB Red, Green, and Blue colour space;

The primary colour signals for TV. By mixing levels of R, G, and B, all colours (Y/C) are reproduced

SAM Service Alignment ModeS/C Short CircuitSCL Serial CLock Signal on I2C busSDA Serial DAta Signal on I2C busSECAM SÉquence Couleur Avec Mémoire;

Colour system mainly used in France and East Europe. The chroma is FM modulated and the R-Y and B-Y signals are transmitted line sequentially. Colour carriers= 4.406250 MHz and 4.250000 MHz

SIF Sound Intermediate FrequencyVGA Video Graphics Array; 640x480 (4:3)Y/C Y consists of luminance signal,

blanking level and sync; C consists of chroma (colour) signal

9.3 IC Data Sheets

Use the specific manual (order code on front page).

Page 29: PHILIPS LC4.1HEAB

Spare Parts List EN 29LC4.1HE AB 10.

10. Spare Parts List

Set Level

Various

1099 9322 207 48682 LC150X02-A4 (LGPH)1099 9322 220 99682 LC201V02-A3KB (LGPH)1099 9322 232 69682 QD23HL02-REV01(03)1116 3139 267 14001 Side I/O Assy [D] 20-23”1116 3139 267 14051 Side I/O Assy [D] 15”1123 3139 267 22591 i-Board Assy [HC]1124 3139 267 20161 Side I/O Assy [i2] 15”1124 3139 267 20131 Side I/O Assy [i2] 20”1124 3139 267 24531 Side I/O Assy [i2] 23”1125 3139 267 18131 LED/IR Assy [J]1174 3139 188 64861 Audio Amp. Assy [I]1178 3139 188 67361 LCD Clock Assy [O]1188 3139 128 77301 Power supply 15”1188 3341 101 20041 Power supply 20”1188 3122 137 23071 Power supply 23”8400 3104 157 03961 Cable 3p/180/3p8400 3104 311 10941 Cable 3p/400/3p Wh8402 3139 131 03981 Cable 41p 1508404 3139 131 03991 Cable 20p 1508404 3139 131 06101 Cable 20p/220/30p8405 3139 131 06341 Cable 4p/680/4p8406 3139 131 04401 Cable 24p/280/24P8406 3139 131 04571 Cable 24p/180/24p8870 3104 157 02001 Cable 5p/140/5p Bk8990 3139 131 06203 Cable 14p/140/12p

Small Signal Board [B]

Various

1001 2422 543 01414 Xtal 24.576MHz1007 4822 265 11352 Connector 8p1010 2422 025 18734 Connector 11p m1101 4822 265 10703 Socket scart 21p1302 3139 147 23021 TUNER UR1316S/A I H-31328 2422 549 44372 SAW 38.9MHz K3953L1330 2422 549 44369 SAW 38.9MHz K9656L1331 4822 267 10459 Connector 3p1332 2422 025 17764 Connector 4P M1401 2422 025 09406 Connector 4p m1402 2422 025 18024 Connector 40p m1403 2422 543 01374 Xtal 14.318 Mhz1404 2422 025 18314 Connector 20p m1462 2422 025 17931 Connector 5P m1485 2422 033 00515 Socket DVI-I 29p f1684 2422 025 10768 Connector 3p m1701 4822 267 10918 Connector 3p1751 2422 025 18739 Connector 5p m1910 2422 025 18746 Connector 12p m1951 2422 025 18752 Connector 5p m8010 3139 110 25971 Cwas 10pH/10pH Bk8010 3139 110 28151 Cable 10p/140/10p Bk8401 3139 110 27731 Cable 04p/080/04p8401 3139 131 06171 Cable 04p/220/04p8403 3104 311 09811 Cable 4p/180/4p Wh8408 3104 311 09801 Cable 8p/100/8p Wh8408 3104 311 10971 Cable 8p/140/8p Wh8408 3139 110 28031 Cwas 8pH/8pH Bk8409 3139 131 06391 Cable 3p/280/03p Bk8462 3139 131 04471 Cable 5p/140/5p8462 3139 131 05351 Cable 5p/180/5p8701 3103 308 90612 CWAS 03PH/03PH 220

BK AWG268751 3139 131 06181 Cable 5p/340/5p8910 3139 110 28271 Cable 12P8910 3139 131 06321 Cable 12p/180/12p 560/

2p8951 3104 157 02361 Cable 5p 280

2001 2238 586 59812 100nF 20% 50V 06032004 3198 017 42240 220nF 16V Y5V 06032008 3198 017 44740 470nF 10V 06032009 3198 017 41050 1µF 10V 06032010 5322 126 11582 6.8nF 10% 63V2011 3198 017 42240 220nF 16V Y5V 06032012 4822 124 23002 10µF 16V2013 2238 586 59812 100nF 20% 50V 06032016 2238 586 59812 100nF 20% 50V 06032017 2238 586 59812 100nF 20% 50V 06032018 5322 126 11583 10nF 10% 50V 0603

2023 3198 017 42240 220nF 16V Y5V 06032024 4822 124 12084 1µF 20% 50V2027 2238 586 59812 100nF 20% 50V 06032030 2238 586 59812 100nF 20% 50V 06032031 2238 586 59812 100nF 20% 50V 06032032 2238 586 59812 100nF 20% 50V 06032033 3198 017 42240 220nF 16V Y5V 06032035 2020 021 91729 4.7µF 20% 35V2036 4822 126 11785 47pF 5% 50V 06032037 4822 126 11785 47pF 5% 50V 06032043 2238 586 59812 100nF 20% 50V 06032044 3198 017 42240 220nF 16V Y5V 06032049 4822 124 23002 10µF 16V2051 4822 124 23002 10µF 16V2052 3198 016 31020 1nF 25V 06032053 2238 586 59812 100nF 20% 50V 06032054 2238 586 59812 100nF 20% 50V 06032055 2238 586 59812 100nF 20% 50V 06032056 2238 586 59812 100nF 20% 50V 06032057 2238 586 59812 100nF 20% 50V 06032058 3198 016 31020 1nF 25V 06032060 2238 586 59812 100nF 20% 50V 06032061 4822 124 23002 10µF 16V2063 3198 017 31540 150nF 10V 06032067 3198 016 31020 1nF 25V 06032068 3198 017 42240 220nF 16V Y5V 06032072 3198 017 42240 220nF 16V Y5V 06032073 5322 126 11583 10nF 10% 50V 06032074 3198 017 42240 220nF 16V Y5V 06032076 3198 017 42240 220nF 16V Y5V 06032078 2020 552 94427 100pF 5% 50V2082 2238 586 59812 100nF 20% 50V 06032083 2020 552 96637 10µF 10% 6.3V 08052099 3198 016 31020 1nF 25V 06032101 4822 126 14241 330pF 0603 50V2102 4822 124 23002 10µF 16V2103 4822 126 14241 330pF 0603 50V2104 4822 126 14491 2.2µF 10V 08052105 4822 126 14241 330pF 0603 50V2106 4822 124 23002 10µF 16V2107 4822 126 14241 330pF 0603 50V2108 4822 126 14491 2.2µF 10V 08052307 3198 017 34730 47nF 16V 06032309 2020 012 00029 330µF 6.3V2311 4822 124 23237 22µF 6.3V2313 5322 126 11578 1nF 10% 50V 06032314 2238 586 59812 100nF 20% 50V 06032317 5322 126 11578 1nF 10% 50V 06032318 5322 126 11578 1nF 10% 50V 06032321 5322 126 11583 10nF 10% 50V 06032324 5322 126 11583 10nF 10% 50V 06032357 2238 586 59812 100nF 20% 50V 06032359 5322 126 11583 10nF 10% 50V 06032372 2238 586 59812 100nF 20% 50V 06032374 2238 586 59812 100nF 20% 50V 06032375 4822 124 23002 10µF 16V2376 2238 586 59812 100nF 20% 50V 06032377 2238 586 59812 100nF 20% 50V 06032378 3198 017 42240 220nF 16V Y5V 06032379 3198 017 42240 220nF 16V Y5V 06032380 4822 124 12095 100µF 20% 16V2381 2238 586 59812 100nF 20% 50V 06032382 2020 552 00183 2.2µF 10% 6.3V 06032383 2020 552 00183 2.2µF 10% 6.3V 06032384 2020 552 00183 2.2µF 10% 6.3V 06032385 2020 552 00183 2.2µF 10% 6.3V 06032386 3198 017 42240 220nF 16V Y5V 06032387 2020 012 00029 330µF 6.3V2388 2020 012 00028 470µF 20% 16V2389 4822 126 11785 47pF 5% 50V 06032390 4822 126 11785 47pF 5% 50V 06032394 2238 586 59812 100nF 20% 50V 06032395 2238 586 59812 100nF 20% 50V 06032397 4822 126 14249 560pF 10% 50V 06032398 4822 126 14249 560pF 10% 50V 06032401 4822 124 11131 47µF 6.3V2402 2238 586 59812 100nF 20% 50V 06032403 2238 586 59812 100nF 20% 50V 06032404 2238 586 59812 100nF 20% 50V 06032405 2238 586 59812 100nF 20% 50V 06032406 2238 586 59812 100nF 20% 50V 06032407 2238 586 59812 100nF 20% 50V 06032408 2238 586 59812 100nF 20% 50V 06032409 2238 586 59812 100nF 20% 50V 06032410 2238 586 59812 100nF 20% 50V 06032411 2238 586 59812 100nF 20% 50V 06032412 2238 586 59812 100nF 20% 50V 06032413 2238 586 59812 100nF 20% 50V 06032414 2238 586 59812 100nF 20% 50V 0603

2415 2238 586 59812 100nF 20% 50V 06032416 2238 586 59812 100nF 20% 50V 06032417 2238 586 59812 100nF 20% 50V 06032418 4822 126 13883 220pF 5% 50V2419 4822 126 13883 220pF 5% 50V2420 4822 124 11131 47µF 6.3V2421 2238 586 59812 100nF 20% 50V 06032422 2238 586 59812 100nF 20% 50V 06032423 2238 586 59812 100nF 20% 50V 06032424 2238 586 59812 100nF 20% 50V 06032425 2238 586 59812 100nF 20% 50V 06032426 4822 126 13883 220pF 5% 50V2427 4822 126 13883 220pF 5% 50V2429 2238 586 59812 100nF 20% 50V 06032430 2238 586 59812 100nF 20% 50V 06032431 2238 586 59812 100nF 20% 50V 06032432 2238 586 59812 100nF 20% 50V 06032433 2238 586 59812 100nF 20% 50V 06032434 2238 586 59812 100nF 20% 50V 06032435 4822 126 13883 220pF 5% 50V2436 4822 126 13883 220pF 5% 50V2438 2238 586 59812 100nF 20% 50V 06032439 2238 586 59812 100nF 20% 50V 06032440 2238 586 59812 100nF 20% 50V 06032441 2238 586 59812 100nF 20% 50V 06032442 2238 586 59812 100nF 20% 50V 06032443 3198 016 35680 5.6pF 0.5pF 50V 06032444 3198 016 35680 5.6pF 0.5pF 50V 06032445 2238 586 59812 100nF 20% 50V 06032448 2238 586 59812 100nF 20% 50V 06032450 4822 126 13883 220pF 5% 50V2451 4822 126 13883 220pF 5% 50V2452 5322 126 11583 10nF 10% 50V 06032463 2238 586 59812 100nF 20% 50V 06032471 4822 124 11131 47µF 6.3V2472 2238 586 59812 100nF 20% 50V 06032473 2238 586 59812 100nF 20% 50V 06032474 2238 586 59812 100nF 20% 50V 06032475 2238 586 59812 100nF 20% 50V 06032476 2020 552 96664 33pF 50V 06032477 3198 017 41050 1µF 10V 06032478 3198 017 41050 1µF 10V 06032479 3198 017 41050 1µF 10V 06032483 2238 586 59812 100nF 20% 50V 06032485 3198 017 41050 1µF 10V 06032486 3198 017 41050 1µF 10V 06032487 3198 017 41050 1µF 10V 06032488 4822 122 33761 22pF 5% 50V2489 4822 122 33761 22pF 5% 50V2490 2238 586 59812 100nF 20% 50V 06032510 2238 586 59812 100nF 20% 50V 06032513 4822 124 23002 10µF 16V2514 3198 016 31590 15pF 10% 50V 06032515 5322 126 11583 10nF 10% 50V 06032516 3198 016 36810 680pF 25V 06032517 5322 126 11583 10nF 10% 50V 06032518 5322 126 11583 10nF 10% 50V 06032519 3198 016 31020 1nF 25V 06032520 2238 586 59812 100nF 20% 50V 06032521 5322 126 11583 10nF 10% 50V 06032522 5322 126 11583 10nF 10% 50V 06032523 5322 126 11583 10nF 10% 50V 06032524 5322 126 11583 10nF 10% 50V 06032525 5322 126 11583 10nF 10% 50V 06032526 5322 126 11583 10nF 10% 50V 06032527 5322 126 11583 10nF 10% 50V 06032703 4822 124 23002 10µF 16V2712 3198 017 41050 1µF 10V 06032714 2020 012 00028 470µF 20% 16V2718 3198 017 41050 1µF 10V 06032719 2238 586 59812 100nF 20% 50V 06032724 4822 124 41584 100µF 20% 10V2736 4822 124 80791 470µF 20% 16V2737 4822 124 80791 470µF 20% 16V2738 3198 016 31020 1nF 25V 06032739 3198 016 31020 1nF 25V 06032741 4822 126 13881 470pF 5% 50V2742 4822 126 13881 470pF 5% 50V2910 4822 126 13881 470pF 5% 50V2911 2022 031 00308 22µF 20% 35V2920 4822 124 80151 47µF 16V2921 4822 124 80151 47µF 16V2930 4822 124 80791 470µF 20% 16V2931 4822 126 13881 470pF 5% 50V2933 4822 124 80791 470µF 20% 16V2934 4822 126 13193 4.7nF 10% 63V2936 5322 126 11578 1nF 10% 50V 06032937 5322 126 11578 1nF 10% 50V 06032938 5322 126 11578 1nF 10% 50V 0603

Page 30: PHILIPS LC4.1HEAB

Spare Parts ListEN 30 LC4.1HE AB10.

2939 5322 126 11578 1nF 10% 50V 06032940 5322 126 11578 1nF 10% 50V 06032941 5322 126 11578 1nF 10% 50V 06032942 5322 126 11578 1nF 10% 50V 06032943 4822 124 80195 470µF 20% 10V2959 2238 586 59812 100nF 20% 50V 06032960 4822 124 80151 47µF 16V2961 5322 126 11583 10nF 10% 50V 06032962 2238 586 59812 100nF 20% 50V 06032963 2238 586 59812 100nF 20% 50V 06032994 4822 124 11131 47µF 6.3V2995 2238 586 59812 100nF 20% 50V 06032996 2238 586 59812 100nF 20% 50V 06032997 4822 124 11131 47µF 6.3V2998 4822 124 40184 1000µF 20% 10V

3001 2322 702 70398 3.9Ω 5% 06033002 4822 051 30223 22kΩ 5% 0.062W3003 2322 702 70398 3.9Ω 5% 06033004 4822 051 30223 22kΩ 5% 0.062W3005 4822 051 30273 27kΩ 5% 0.062W3007 4822 051 30472 4.7Ω 5% 0.062W3008 4822 117 12925 47kΩ 1% 0.063W 06033009 4822 117 13632 100kΩ 1% 0603 0.62W3010 4822 117 12891 220kΩ 1%3011 4822 051 30472 4.7Ω 5% 0.062W3012 4822 051 30101 100Ω 5% 0.062W3013 4822 051 30101 100Ω 5% 0.062W3016 4822 051 30101 100Ω 5% 0.062W3019 4822 051 30101 100Ω 5% 0.062W3020 4822 051 30101 100Ω 5% 0.062W3024 4822 051 30472 4.7Ω 5% 0.062W3052 4822 051 30101 100Ω 5% 0.062W3058 4822 051 30101 100Ω 5% 0.062W3059 4822 051 30102 1kΩ 5% 0.062W3060 4822 051 30393 39kΩ 5% 0.062W3063 4822 051 30222 2.2kΩ 5% 0.062W3064 4822 051 30103 10kΩ 5% 0.062W3066 4822 051 30472 4.7Ω 5% 0.062W3070 4822 051 30101 100Ω 5% 0.062W3075 4822 051 30472 4.7Ω 5% 0.062W3077 4822 051 30472 4.7Ω 5% 0.062W3078 4822 051 30472 4.7Ω 5% 0.062W3079 4822 051 30222 2.2kΩ 5% 0.062W3080 2322 704 61002 1kΩ 1%3081 4822 051 30101 100Ω 5% 0.062W3082 4822 051 30101 100Ω 5% 0.062W3086 4822 051 30222 2.2kΩ 5% 0.062W3087 4822 051 30103 10kΩ 5% 0.062W3091 4822 051 30101 100Ω 5% 0.062W3092 4822 051 30472 4.7Ω 5% 0.062W3093 4822 051 30472 4.7Ω 5% 0.062W3094 4822 051 30109 10Ω 5% 0.062W3097 4822 051 30472 4.7Ω 5% 0.062W3101 4822 051 30151 150Ω 5% 0.062W3102 4822 117 12891 220kΩ 1%3103 4822 051 30103 10kΩ 5% 0.062W3104 4822 051 30153 15kΩ 5% 0.062W3105 4822 051 30151 150Ω 5% 0.062W3106 4822 117 12891 220kΩ 1%3107 4822 051 30103 10kΩ 5% 0.062W3108 4822 051 30153 15kΩ 5% 0.062W3109 4822 051 30759 75Ω 5% 0.062W3110 4822 051 30101 100Ω 5% 0.062W3111 4822 051 30273 27kΩ 5% 0.062W3112 4822 051 30682 6.8Ω 5% 0.062W3113 4822 051 30759 75Ω 5% 0.062W3114 4822 051 30101 100Ω 5% 0.062W3115 4822 051 30759 75Ω 5% 0.062W3116 4822 051 30101 100Ω 5% 0.062W3117 4822 051 30759 75Ω 5% 0.062W3118 4822 051 30101 100Ω 5% 0.062W3119 4822 051 30689 68Ω 5% 0.063W 06033120 4822 051 30102 1kΩ 5% 0.062W3121 4822 051 30759 75Ω 5% 0.062W3122 4822 051 30101 100Ω 5% 0.062W3302 4822 051 30101 100Ω 5% 0.062W3303 4822 051 30101 100Ω 5% 0.062W3309 4822 051 30103 10kΩ 5% 0.062W3311 4822 051 30103 10kΩ 5% 0.062W3314 4822 117 13632 100kΩ 1% 0603 0.62W3315 4822 051 30154 150kΩ 5% 0.062W3316 4822 117 12968 820Ω 5% 0.62W3317 4822 051 30561 560Ω 5% 0.062W3319 4822 051 30273 27kΩ 5% 0.062W3320 4822 051 30183 18kΩ 5% 0.062W3321 4822 051 30222 2.2kΩ 5% 0.062W3322 4822 051 30682 6.8Ω 5% 0.062W3323 4822 051 30222 2.2kΩ 5% 0.062W3327 4822 051 30102 1kΩ 5% 0.062W3350 4822 051 30472 4.7Ω 5% 0.062W

3351 4822 051 30681 680Ω 5% 0.062W3352 4822 051 30681 680Ω 5% 0.062W3353 4822 051 30101 100Ω 5% 0.062W3354 4822 051 30101 100Ω 5% 0.062W3355 4822 051 30332 3.3Ω 5% 0.062W3356 4822 051 30332 3.3Ω 5% 0.062W3359 4822 051 30391 390Ω 5% 0.062W3371 4822 051 30101 100Ω 5% 0.062W3372 4822 051 30101 100Ω 5% 0.062W3374 5322 117 11726 10Ω 5%3375 4822 051 30101 100Ω 5% 0.062W3376 4822 117 13632 100kΩ 1% 0603 0.62W3389 4822 051 30101 100Ω 5% 0.062W3390 4822 051 30101 100Ω 5% 0.062W3391 4822 051 30101 100Ω 5% 0.062W3394 4822 051 30759 75Ω 5% 0.062W3401 4822 051 30103 10kΩ 5% 0.062W3402 4822 051 30103 10kΩ 5% 0.062W3403 2322 704 61501 150Ω 1% 06033404 4822 051 30103 10kΩ 5% 0.062W3405 4822 051 30103 10kΩ 5% 0.062W3406 4822 051 30103 10kΩ 5% 0.062W3407 3198 031 13390 4X 33Ω 5% 12063408 4822 051 30339 33Ω 5% 0.062W3409 4822 051 30339 33Ω 5% 0.062W3410 4822 051 30339 33Ω 5% 0.062W3411 3198 031 13390 4X 33Ω 5% 12063412 3198 031 13390 4X 33Ω 5% 12063413 3198 031 13390 4X 33Ω 5% 12063414 4822 051 30103 10kΩ 5% 0.062W3416 2322 704 61001 100Ω 1% 06033417 4822 051 30103 10kΩ 5% 0.062W3418 4822 051 30103 10kΩ 5% 0.062W3419 4822 051 30103 10kΩ 5% 0.062W3420 4822 051 30103 10kΩ 5% 0.062W3421 4822 051 30103 10kΩ 5% 0.062W3422 4822 051 30103 10kΩ 5% 0.062W3423 4822 051 30103 10kΩ 5% 0.062W3424 3198 031 11030 4 x 10kΩ 5% 12063425 3198 021 31080 1Ω 5% 06033426 3198 021 31080 1Ω 5% 06033427 3198 021 31080 1Ω 5% 06033428 3198 021 31080 1Ω 5% 06033430 4822 051 30101 100Ω 5% 0.062W3431 4822 051 30101 100Ω 5% 0.062W3433 4822 051 30103 10kΩ 5% 0.062W3434 4822 051 30103 10kΩ 5% 0.062W3435 4822 051 30103 10kΩ 5% 0.062W3441 4822 051 30101 100Ω 5% 0.062W3442 4822 051 30101 100Ω 5% 0.062W3443 4822 051 30103 10kΩ 5% 0.062W3444 4822 051 30103 10kΩ 5% 0.062W3445 4822 051 30151 150Ω 5% 0.062W3446 4822 051 30151 150Ω 5% 0.062W3451 4822 051 30339 33Ω 5% 0.062W3452 4822 051 30339 33Ω 5% 0.062W3453 4822 051 30339 33Ω 5% 0.062W3454 4822 051 30339 33Ω 5% 0.062W3455 4822 051 30339 33Ω 5% 0.062W3456 4822 051 30339 33Ω 5% 0.062W3457 4822 051 30339 33Ω 5% 0.062W3458 4822 051 30339 33Ω 5% 0.062W3459 4822 051 30339 33Ω 5% 0.062W3471 4822 117 12968 820Ω 5% 0.62W3478 4822 117 13632 100kΩ 1% 0603 0.62W3481 3198 021 32290 22Ω 5% 06033482 4822 051 30759 75Ω 5% 0.062W3483 3198 021 32290 22Ω 5% 06033484 4822 051 30759 75Ω 5% 0.062W3485 3198 021 32290 22Ω 5% 06033486 4822 051 30759 75Ω 5% 0.062W3487 4822 051 30102 1kΩ 5% 0.062W3488 4822 051 30222 2.2kΩ 5% 0.062W3489 4822 051 30101 100Ω 5% 0.062W3490 4822 051 30103 10kΩ 5% 0.062W3491 4822 051 30102 1kΩ 5% 0.062W3492 4822 051 30102 1kΩ 5% 0.062W3493 4822 051 30102 1kΩ 5% 0.062W3494 4822 051 30222 2.2kΩ 5% 0.062W3495 4822 051 30103 10kΩ 5% 0.062W3496 4822 051 30101 100Ω 5% 0.062W3497 4822 051 30101 100Ω 5% 0.062W3501 4822 051 30103 10kΩ 5% 0.062W3502 4822 051 30221 220Ω 5% 0.062W3503 4822 051 30221 220Ω 5% 0.062W3504 4822 051 30221 220Ω 5% 0.062W3505 4822 051 30221 220Ω 5% 0.062W3506 4822 051 30221 220Ω 5% 0.062W3507 4822 051 30221 220Ω 5% 0.062W3510 4822 051 30221 220Ω 5% 0.062W3511 4822 051 30221 220Ω 5% 0.062W3512 4822 051 30221 220Ω 5% 0.062W3513 4822 051 30221 220Ω 5% 0.062W3514 4822 051 30103 10kΩ 5% 0.062W

3515 4822 051 30103 10kΩ 5% 0.062W3520 4822 051 30333 33kΩ 5% 0.062W3522 3198 021 32290 22Ω 5% 06033523 3198 021 32290 22Ω 5% 06033524 3198 021 32290 22Ω 5% 06033525 3198 021 32290 22Ω 5% 06033526 3198 021 32290 22Ω 5% 06033527 3198 021 32290 22Ω 5% 06033706 4822 051 30103 10kΩ 5% 0.062W3717 4822 051 30103 10kΩ 5% 0.062W3719 4822 051 30103 10kΩ 5% 0.062W3722 3198 021 38220 8.2kΩ 5% 0.062W 06033725 4822 051 30103 10kΩ 5% 0.062W3726 4822 051 30392 3.9Ω 5% 0.063W 06033727 4822 051 30392 3.9Ω 5% 0.063W 06033744 3198 021 38220 8.2kΩ 5% 0.062W 06033745 3198 021 38220 8.2kΩ 5% 0.062W 06033751 4822 051 30101 100Ω 5% 0.062W3752 4822 051 30101 100Ω 5% 0.062W3753 4822 051 30471 47Ω 5% 0.062W3754 4822 051 30102 1kΩ 5% 0.062W3755 4822 051 30471 47Ω 5% 0.062W3910 4822 051 30222 2.2kΩ 5% 0.062W3911 4822 051 30102 1kΩ 5% 0.062W3930 3198 021 31080 1Ω 5% 06033932 2322 704 61002 1kΩ 1%3933 2322 704 63302 3.3kΩ 1% 06033934 3198 021 31080 1Ω 5% 06033935 3198 021 31080 1Ω 5% 06033936 4822 051 30102 1kΩ 5% 0.062W3937 2306 207 03151 150Ω 5% 0.5W3955 4822 051 30103 10kΩ 5% 0.062W3958 4822 051 30102 1kΩ 5% 0.062W

5002 2422 549 44197 Bead 220Ω at 100MHz5003 4822 157 11716 Bead 30Ω at 100MHz5004 4822 157 11716 Bead 30Ω at 100MHz5005 4822 157 11716 Bead 30Ω at 100MHz5006 4822 157 11716 Bead 30Ω at 100MHz5008 2422 549 44197 Bead 220Ω at 100MHz5060 2422 549 44197 Bead 220Ω at 100MHz5070 4822 157 11716 Bead 30Ω at 100MHz5071 2422 549 42896 Bead 120Ω 100MHz5072 2422 549 42896 Bead 120Ω 100MHz5321 3198 018 33970 0.39µH 10% 08055324 4822 157 71334 0.68µH 5% 10085370 4822 157 11716 Bead 30Ω at 100MHz5371 4822 157 11716 Bead 30Ω at 100MHz5372 2422 549 44197 Bead 220Ω at 100MHz5375 2422 536 00667 1000µH 20% 70325376 2422 549 44197 Bead 220Ω at 100MHz5401 4822 157 11717 Bead 50Ω at 100MHz5402 4822 157 11717 Bead 50Ω at 100MHz5403 4822 157 11717 Bead 50Ω at 100MHz5404 4822 157 11717 Bead 50Ω at 100MHz5462 4822 157 11717 Bead 50Ω at 100MHz5485 2422 549 45333 Bead 120Ω at 100MHz5514 2422 549 42896 Bead 120Ω 100MHz5520 4822 157 11716 Bead 30Ω at 100MHz5736 3198 018 72280 2.2µ 8mm5737 3198 018 72280 2.2µ 8mm5751 4822 157 11716 Bead 30Ω at 100MHz5910 2422 536 00667 1000µH 20% 70325930 2422 535 94639 10µH 20%5931 2422 536 00689 220µH 20%5932 2422 535 94639 10µH 20%5956 2422 549 45333 Bead 120Ω at 100MHz5957 2422 549 45333 Bead 120Ω at 100MHz5958 2422 549 45333 Bead 120Ω at 100MHz5959 2422 549 45333 Bead 120Ω at 100MHz5961 4822 157 11717 Bead 50Ω at 100MHz

6005 4822 130 11397 BAS3166060 9322 102 64685 UDZ2.7B6073 4822 130 80622 BAT546076 4822 130 80622 BAT546310 4822 130 11397 BAS3166323 4822 130 11525 1SS3566485 4822 130 11397 BAS3166486 4822 130 11397 BAS3166910 5322 130 34337 BAV996911 9340 548 71115 PDZ33B6930 9322 128 70685 SMSS14

Software

0606 3139 127 05702 SW HERCULES0611 3139 127 05692 SW i-Board

Page 31: PHILIPS LC4.1HEAB

Spare Parts List EN 31LC4.1HE AB 10.

0611 3139 127 05662 SW GENESIS 15”, 23”0611 3139 127 05682 SW GENESIS 20”0626 3139 127 06191 SW DDC DVI 20”0626 3139 127 06181 SW DDC DVI 23”

7001 3198 010 43130 BC807-257002 3198 010 42310 BC847BW7003 3198 010 43130 BC807-257004 3198 010 42310 BC847BW7011 For SW see item 06067012 3198 010 42310 BC847BW7013 3198 010 42310 BC847BW7014 3198 010 42310 BC847BW7060 4822 130 11155 PDTC114ET7099 9322 214 45668 M24C16-WMN6P7101 5322 130 60159 BC846B7316 5322 130 42718 BFS207320 3198 010 42310 BC847BW7370 9340 425 20115 BC847BS7401 9322 219 95671 GM5221H-LF-BC7402 9322 189 01668 AT24C32AN7403 For SW see item 06117461 9322 199 80668 SM5301BS-G7463 9322 164 91668 CD74HC4053M7490 For SW see item 06267510 9322 221 97668 SN74LVC14APW7516 9322 212 97668 MK1575-01G7702 3198 010 42310 BC847BW7703 3198 010 42310 BC847BW7712 9352 683 73118 TDA1517ATW/N17751 9352 500 20118 74LVC08AD7752 3198 010 42310 BC847BW7910 4822 130 42804 BC817-257920 9322 163 24668 L78M08CDT7930 5322 209 90529 MC34063AD7936 4822 130 41087 BC6387952 4822 130 11155 PDTC114ET7953 9322 199 25668 L4940D2T127954 9322 214 00668 SI2301BDS-E37955 9322 189 19668 LD1086D2T18

Side I/O Panel [D]

Various

1101 4822 267 10484 YKF51-53591102 4822 265 10658 Soc 3P1104 2422 026 05513 Soc phone 1p1105 2422 025 09406 Connector 4p m1106 2422 026 05059 Connector Phone1107 4822 267 10637 Connector 5p1108 2422 025 10771 Connector 10p m1110 2422 025 10768 Connector 3p m1111 2422 025 09406 Connector 4p m1112 2422 025 10768 Connector 3p m1112 2422 025 18468 Connector 3p m8107 3139 110 27841 Cable 05p/180/05p

2101 3198 016 31510 150pF 10% 50V 06032101 4822 126 11785 47pF 5% 50V 06032102 3198 016 31510 150pF 10% 50V 06032102 4822 126 11785 47pF 5% 50V 06032103 4822 126 13881 470pF 5% 50V2104 4822 126 13881 470pF 5% 50V2105 2020 552 94427 100pF 5% 50V2106 2020 552 94427 100pF 5% 50V2107 3198 016 31020 1nF 25V 06032108 3198 016 31020 1nF 25V 06032109 3198 016 31020 1nF 25V 06032110 3198 016 31020 1nF 25V 06032111 4822 124 12245 220µF 20% 10V2112 4822 124 12245 220µF 20% 10V2113 4822 126 13881 470pF 5% 50V2114 4822 126 13881 470pF 5% 50V2117 2020 552 96305 4.7µF 20-80% 10V

3101 4822 051 30109 10Ω 5% 0.062W3103 4822 051 30109 10Ω 5% 0.062W3104 4822 051 30759 75Ω 5% 0.062W3105 4822 051 30759 75Ω 5% 0.062W3106 4822 051 30759 75Ω 5% 0.062W3107 4822 051 30223 22kΩ 5% 0.062W3108 4822 117 12925 47kΩ 1% 0.063W 06033109 4822 051 30223 22kΩ 5% 0.062W

3110 4822 117 12925 47kΩ 1% 0.063W 06033111 4822 051 30223 22kΩ 5% 0.062W3112 4822 051 30223 22kΩ 5% 0.062W3113 4822 117 12925 47kΩ 1% 0.063W 06033114 4822 117 12925 47kΩ 1% 0.063W 06033115 4822 051 30121 120Ω 5% 0.062W3116 4822 051 30121 120Ω 5% 0.062W3123 4822 051 30101 100Ω 5% 0.062W3124 4822 051 30101 100Ω 5% 0.062W3125 4822 051 30102 1kΩ 5% 0.062W3126 4822 051 30183 18kΩ 5% 0.062W3127 4822 051 30183 18kΩ 5% 0.062W4102 4822 051 30008 Jumper 06034103 4822 051 30008 Jumper 06034104 4822 051 30008 Jumper 06034105 4822 051 30008 Jumper 06034108 4822 051 30008 Jumper 06034120 4822 051 30008 Jumper 06034121 4822 051 30008 Jumper 06034122 4822 051 30008 Jumper 06034123 4822 051 30008 Jumper 0603

6101 4822 130 11148 UDZ4.7B6102 4822 130 11148 UDZ4.7B6105 4822 130 11148 UDZ4.7B6106 4822 130 11148 UDZ4.7B6109 4822 130 11148 UDZ4.7B6110 4822 130 11148 UDZ4.7B6111 4822 130 11148 UDZ4.7B6112 4822 130 11148 UDZ4.7B

7101 4822 130 60373 BC856B

Keyboard Control Panel [E]

Various

1309 4822 276 13775 Switch 1p 0.1A 12V1310 4822 276 13775 Switch 1p 0.1A 12V1311 4822 276 13775 Switch 1p 0.1A 12V1312 4822 276 13775 Switch 1p 0.1A 12V1313 4822 276 13775 Switch 1p 0.1A 12V1314 4822 276 13775 Switch 1p 0.1A 12V1684 4822 267 10459 Connector 3p8684 3104 157 03961 Cable 3p/180/3p8684 3139 110 27681 Cable 3p/280/03p Bk

3318 4822 051 30151 150Ω 5% 0.062W3319 4822 051 30391 390Ω 5% 0.062W3320 3198 021 31820 1.8kΩ 5% 0.062W 06033321 4822 117 12968 820Ω 5% 0.62W3322 4822 051 30008 Jumper 06033323 4822 051 30008 Jumper 06033324 4822 051 30561 560Ω 5% 0.062W

6306 4822 130 11148 UDZ4.7B

i-Board Panel [HC]

see “Set Level”

Audio Amplifier Panel [I]

Various

1703 2422 025 17117 Connector 2p m1703 2422 025 18737 Connector 2p m1704 2422 025 16966 Connector 5p m SMD1704 2422 025 18739 Connector 5p m1706 2422 025 16702 Connector 5p m h1706 2422 025 18752 Connector 5p m

2703 4822 124 23002 10µF 16V2712 3198 017 41050 1µF 10V 06032713 2238 586 59812 100nF 20% 50V 06032714 2020 012 00003 470µF 16V 20% SMD2715 2020 012 00003 470µF 16V 20% SMD

2718 3198 017 41050 1µF 10V 06032719 2238 586 59812 100nF 20% 50V 06032741 4822 126 13881 470pF 5% 50V2742 4822 126 13881 470pF 5% 50V2746 3198 017 41050 1µF 10V 0603

3701 4822 051 30332 3.3Ω 5% 0.062W3702 4822 051 30332 3.3Ω 5% 0.062W3706 4822 051 30103 10kΩ 5% 0.062W3714 5322 117 13056 8.2kΩ 1% 0.063W 06033715 4822 117 12903 1.8kΩ 1% 0.063W 06033726 5322 117 13056 8.2kΩ 1% 0.063W 06033727 4822 117 12903 1.8kΩ 1% 0.063W 06033744 4822 051 30103 10kΩ 5% 0.062W3746 4822 051 30103 10kΩ 5% 0.062W3747 4822 051 30103 10kΩ 5% 0.062W3748 4822 051 30103 10kΩ 5% 0.062W3749 4822 051 30103 10kΩ 5% 0.062W3750 4822 051 30682 6.8Ω 5% 0.062W3751 4822 051 30682 6.8Ω 5% 0.062W4720 4822 051 30008 Jumper 0603

5709 4822 157 11716 Bead 30Ω at 100MHz5710 4822 157 11716 Bead 30Ω at 100MHz

7703 9340 425 20115 BC847BS7709 9322 206 09668 TDA7297D

Side I/O Panel & LKB [i2]

see “Set Level”

LED/IR Panel [J]

see “Set Level”

LCD Clock Panel [O]

see “Set Level”

Page 32: PHILIPS LC4.1HEAB

Revision ListEN 32 LC4.1HE AB11.

11. Revision ListManual xxxx xxx xxxx.0• First release.