pet-320

DVD Portable Player PET320/00/05/37

3141 785 30840

Version 1.0

TABLE OF CONTENTS Chapter Technical Specification……………………………………….. 1 Safety Instructions…………………………………………….. 2 Instruction for Use……………………………………………… 3 Mechanical Instructions………………………………………. 4 Troubleshooting & Service Tips………………………………5 Overall Block Diagram…………………………………………. 6 Electrical Diagram……………………………………………… 7 Component Layout…………………………………………….. 8 Exploded View Diagram & Service Part List………………. 9 Revision List……………………………………………………. 10

©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips

Service Manual

1. TECHNICAL SPECIFICATION

General Dimensions (WxLxH) : 154.5mm*164.48mm*27.61mm

(+- 0.3mm) Weight : 546.6g +- 10g Power supply : +5V / 2A Power consumption : Play back :4W Operating temp. range : 0 – 50 Degree Laser wavelength: DVD 655nm, CD 790nm Video system : NTSC/PAL/AUTO. Frequency response : Audio +1dB / -0.5dB Signal/noise ratio Audio > 80 dB Audio distortion + noise Audio < 0.6 % Channel separation: Audio > 85 dB Dynamic range

Audio > 80 dB

Output Audio out (analog audio)

1.2 V +/- 0.1V rms

Load impedance:

47K ohm

Video out Output level:

1 V p-p

Load impedance:

75 ohm

Current consumption

DC-IN SUPPLY (5.0V) Battery Charging Current Stand by : 1.7 Amp

Operating : 0.85 Amp BATT. SUPPLY (3.6V)

Power Off 3.4V Playback with TFT on 1.45A ( Normal volume) Playback without TFT on 0.9A ( Normal volume) Battery playtime 2.5Hours Headphone out (headphone output load 2x16 ohm) Maximum output power : 2.3mW Frequency response : +/- 3dB SNR (A-wght) : 80 dB THD (1kHz) : 1 % Left-Right Channel Separation :

55 dB

Left-Right Channel Balance :

2 dB

Supported disc type DVD video discs:

Video CD:

Audio CD :

Applicable DVD Formats DVD-Video on DVD-

ROM (DVD-5, DVD-9, DVD-10, DVD-18), DVD-R, DVD-RW, DVD+R and DVD+RW

Applicable CD Formats (Read) CD-DA, Video CD (MPEG-1), MP3/WMA/JPEG CD on CD-ROM, CD-R, and CD-RW

Disc Diameter 8cm/12cm Software upgrades For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. To check the software version of your DVD Portable. 1. Press the II key to power on the player 2. Insert a DVD disc into the player 3. Press SETUP key to enter the set up menu 4. Press MENU + MENU + OSD key within 1

sec 5. The display will show the software version on

the screen as below:

Procedure on how to upgrade the software of the DVD Portable 1. Download the latest software from the Philips

support site 2. Unzipped the files and then burn it onto a CD

ROM then playback the CD ROM on the DVD Portable

3. Press the OK key to upgrade the software

Pixel specification <= 4 (max. 1 bright dots and 3 dark dots)

SET :

VER :

MODEL :

SETUP MENU

2. SAFTETY INSTRUCTIONS

GB WARNING

All ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.

F ATTENTION

Tous les IC et beaucoup d’autressemi-conducteurs sont sensibles auxdécharges statiques (ESD).Leur longévité pourrait être considérablementécourtée par le fait qu’aucune précaution n’estprise à leur manipulation.Lors de réparations, s’assurer de bien être reliéau même potentiel que la masse de l’appareil etenfiler le bracelet serti d’une résistance desécurité.Veiller à ce que les composants ainsi que lesoutils que l’on utilise soient également à cepotentiel.

ESD

D WARNUNG

Alle ICs und viele andere Halbleiter sindempfindlich gegenüber elektrostatischenEntladungen (ESD).Unsorgfältige Behandlung im Reparaturfall kandie Lebensdauer drastisch reduzieren.Veranlassen Sie, dass Sie im Reparaturfall überein Pulsarmband mit Widerstand verbundensind mit dem gleichen Potential wie die Massedes Gerätes.Bauteile und Hilfsmittel auch auf dieses gleichePotential halten.

NL WAARSCHUWING

Alle IC’s en vele andere halfgeleiders zijngevoelig voor electrostatische ontladingen(ESD).Onzorgvuldig behandelen tijdens reparatie kande levensduur drastisch doen verminderen.Zorg ervoor dat u tijdens reparatie via eenpolsband met weerstand verbonden bent methetzelfde potentiaal als de massa van hetapparaat.Houd componenten en hulpmiddelen ook opditzelfde potentiaal.

I AVVERTIMENTO

Tutti IC e parecchi semi-conduttori sonosensibili alle scariche statiche (ESD).La loro longevità potrebbe essere fortementeridatta in caso di non osservazione della piùgrande cauzione alla loro manipolazione.Durante le riparazioni occorre quindi esserecollegato allo stesso potenziale che quello dellamassa dell’apparecchio tramite un braccialettoa resistenza.Assicurarsi che i componenti e anche gli utensilicon quali si lavora siano anche a questopotenziale.

“Pour votre sécurité, ces documentsdoivent être utilisés par des spécia-listes agréés, seuls habilités à réparervotre appareil en panne”.

GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be used.

NL

Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie inzijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,identiek aan de gespecificeerde, worden toegepast.

F

Les normes de sécurité exigent que l’appareil soit remis à l’étatd’origine et que soient utiliséés les piéces de rechange identiquesà celles spécifiées.

D

Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zubeachten. Der Original zustand des Geräts darf nicht verändert werden;für Reparaturen sind Original-Ersatzteile zu verwenden.

I

Le norme di sicurezza esigono che l’apparecchio venga rimessonelle condizioni originali e che siano utilizzati i pezzi di ricambioidentici a quelli specificati.

"After servicing and before returning set to customer perform aleakage current measurement test from all exposed metal parts toearth ground to assure no shock hazard exist. The leakage currentmust not exceed 0.5mA."

CLASS 1LASER PRODUCT

3122 110 03420

GB Warning !Invisible laser radiation when open.Avoid direct exposure to beam.

S Varning !

Osynlig laserstrålning när apparaten är öppnad och spärrenär urkopplad. Betrakta ej strålen.

SF Varoitus !

Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiinanäkymättömälle laserisäteilylle. Älä katso säteeseen!

DK Advarse !

Usynlig laserstråling ved åbning når sikkerhedsafbrydere erude af funktion. Undgå udsaettelse for stråling.

When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser

may be received.

2.1 ESD PROTECTION

PREPARATION OF SERVICING

Pickup Head consists of a laser diode that is very susceptible to external static electrocity.

Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement,

its life might be shortened. When replacing, use a conductive mat, soldering iron with ground wire,etc. to

protect the laser diode form damage by static electricity.

And also, the LSI and IC are same as above.

Soldering ironwith ground wireor ceramic type

Ground conductivewrist strap for body.

Conductive matThe ground resistancebetween the ground lineand the ground is less than 10

1M

SAFTY NOTICE

Plug the AC line cord directly into a 120V AC outlet (donot use an isolation transformer for this check). Use anAC voltmeter, having 5000 per volt or more sensitivity.Connect a 1500 10W resistor,paralleled by a 0.15uF150V AC capacitor between a knomn good earth ground(water pipe, conduit, etc.) and all exposed metal parts ofcabinet (antennas, handle bracket, metal cabinetscrewheads, metal overlays, control shafts, etc.).

SAFTY PRECAUTIONS

LEAKAGE CURRENT CHECK

Measure the AC voltage across the 1500 resistor.The test must be conducted with the AC switch on andthen repeated with the AC switch off. The AC voltageindicated by the meter may not exceed 0.3V.A readingexceeding 0.3V indicates that a dangerous potentialexists, the fault must be located and corrected.Repeat the above test with the DVD VIDEO PLAYERpower plug reversed.NEVER RETURN A DVD VIDEO PLAYER TO THECUSTOMER WITHOUT TAKING NECESSARYCORRECTIVE ACTION.

READING SHOULD NOT EXCEED 0.3V

DVD VIDEO PLAYER

AC OUTLET

AC VOLTMETER

Test all exposed metal.Voltmeter Hook-up for Leakage Current Check

0.15uF 150V AC

150010W

(5000 per voltor more sensitivity)

Good earth groundsuch as a water pipe,conduit, etc.

The lightning flash with arrowhead symbol, within anequilateral triangle, is intended to alert the user to thepresence of uninsulated "dangerous voltage" within theproduct's enclosure that may be of sufficient magnitude toconstitute a risk of electric shock to persons.

The exclamation point within an equilateral triangle isintended to alert the user to the presence of importantoperating and maintenance (servicing) instructions in theliterature accompanying the appliance.

3. INSTRUCTION FOR USE

4. MECHANICAL INSTRUCTIONS

Disassembly Procedure on PET320 Screw Philips 12NC 1 Remove the screws on

bottom housing cabinet 994000003857 (7pcs)

2 Use finger or treezer to separate middle cabinet from the bottom cabinet assy

3 Generally open up the bottom cabinet

4 After removal the bottom cabinet, there is the bottom PCBA connected with the bottom cabinet. While another side, there is the driver, LCD and top PCBA connected with the middle and top cabinet.


Disassembly Procedure on PET320 Screw Philips 12NC

5 Remove the screws on bottom PCBA to separate it from the bottom cabinet

994000003858 (5pcs)

6 Lift up the driver generally from the pin area on the middle cabinet

7 Remove the screws on metal plate to separate it from the top cabinet

8 Remove the screws on speaker holder to separate the speaker and top PCBA from the top cabinet

994000003859

994000003861 (4pcs)

994000003863


Disassembly Procedure on PET320 Screw Philips 12NC 9 Remove the screws on

LCD edge to separate it from the top cabinet

994000003862 (4pcs -included in LCD module)

10 The button key could be picked up easily

994000003865

994000003864

994000003866

5. TROUBLESHOOTING & SERVICE TIPS

5.1 Procedure to change region code

1. Open DVD Door 2. Press and hold the OSD key together with the POWER ON ( II) key for about 4sec

to enter CONFINGURATION SETUP menu 3. Press the UP and DOWN ( ▼) key to enter REGION on menu

4. Press the NEXT ( |) key to select REGION NO. 5. Press the UP and DOWN ( ▼) key to select number of 1 to 6 6. Press the OK key to save the selection.

Note : Once press OK, data with new REGION NO. will be stored into EEPROM and replace the old one.

7. Switch off and re-switch on the product 8. Verify Region code change done

Region Code Region 1 USA 2 EUROPE 3 ASIA PACIFIC 4 AUSTRALIA, NEW ZEALAND, LATAM 5 RUSSIA, INDIA 6 CHINA

REGION

AGING SETTING

Version : 1.00

DEFAULT


SYMPTOM: NO POWER


SYMPTOM: NO IMAGE / NO SOUND


SYMPTOM: THE DVD DRIVE DOES NOT WORK


SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY

SYMPTOM: NO SOUND FROM HEADPHONE

6. OVERALL BLOCK DIAGRAM

DC-DC:TP S 64200: 3.3VA P W 7078: 5V , + 15V , -8VA T1366: 1.2V

Li-P olym er B attery ChargerB Q 24103

DV 2.0 RF S ervo + M P E G 2 Decode + M icro- P rocessor

64M B i t S D R A ME M 638165T S -7G

16M B it F las hR omM 29W 160E T

TF TLCD B acklightDriving ICTP S 61042

E E P R O M24C 02

TOP

Board TFTConnector

DV D T raverseS DR087T

DV D M otor DriverA N41204

A udio A m plifie rA P A 2066S O 0_S

A udio D/ACS 4335

Crysta l 27M Hz

DIG IT A L V IDE O S IG NA L

TOP BoardSpeaker/Key

BoardConnector

5V /2A DC INP UT

S T E R E O S P E A K E R

V ID E O /A U D IOC O N N E C T O R

H E A D P H O N EC O N N E C T O R

TFT LCD960*240

TOP BoardSpeaker/Key

BoardConnector

B utton

B OTTO M B OA RDTO P B OA RD

3.3V , 5V , 15V , -8V

1.2V , 3 .3V

5V

S T E R E O H E A D P H O N ES IG N A L

A U D IO LIN E O U T

V ID E O

B attery

7. ELECTRICAL DIAGRAM

7.1 Electrical Diagram of Top PCBA

KEY_OUT0

ADA-VCC1

KEY_IN3

KEY_IN0

KEY_OUT0

TP12

G-KEY

SW9MPU12800MLB1

2 12 1

TP7RED-L

SP_R SPEAKER R

KEY_IN3SW8 MPU12800MLB1

2121

L-

R2 100/0805

21

R-

J2

CON17

1234567891011121314151617

SW1MPU12800MLB121

21

TP4IN0

TP5IN2

L+ L-

KEY_IN1

FPC 17 PIN 0.5 Pitch

R-

R+

TP2POWER-CON

KEY_IN2

TP11

IN3

RED-Light

SW4 MPU12800MLB121

21

PLAY-OK-POWER_ON

1

SW2 MPU12800MLB121

21

SETUP

2

TP1

DGND

SW6 MPU12800MLB121

21

DGND

CP3

GREEN-Light

TP3OUT0

D1

LG-170E/G-CT

CP1

6mm

KEY_IN2

4.0mm

GREEN-Light

KEY_IN1R

+

TP6PKEY

SW7MPU12800MLB1

2 12 1

SP_L SPEAKER L

3.0mm

CP4

KEY_OUT1

DGND

POWER-CON

TP8

ADA-VCC1

POWER-KEY

R1 100/080521

KEY_IN0

SW3MPU12800MLB121

21

STOP-POWER_OFF

ADA-VCC1

OSD

POWER-KEY

TP10

IN1

Connector Point : 1mm

SW5MPU12800MLB121

21

MANU

POWER-CON

TP9

OUT1

RED-Light

CP2

L+

KEY_OUT1

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

UD:H NORMALUD:L REVERSE

VSET:H EXTERNALVSET:L INTERNAL

IF1:H IF2:H CCIR656IF1:L IF2:H CCIR601

PANEL CONNECTOR

1.LED-2.LED+3.POL4./RESET5.SPENA6.SPCLK7.SPDAT8.DB09.DB110.DB211.DB312.DB413.DB514.DB615.DB716.DCLK17.UD18.Vdd+5V19.Vcc+3.3V20.LRC21.VSET22.DUMMY23.VGL24.DUMMY25.VGH26.V127.V828.Vcom29.DGND30.AGND

POLS

656-D5

656-D3

656-D1

656-D4

LED-

PANEL SPI-DATA

656-D3

VSET

656-D2

656-D2

656-D6656-D7

VCOM

656-D4

656-D8

656-D8

VCOM

656-D5

LED+

656-D7

VSET

PANEL SPI-ENABLEPANEL SPI-CLOCK

POLS

656-D6

656-D1

CCIR_D5 (4)CCIR_D4 (4)




PANEL SPI-DATA (4)

CCIR_CLK (4)

TFT-RESET (4)

PANEL SPI-CLOCK (4)

LED+ (11)

PANEL SPI-ENABLE (4)

LED- (11)

GL -8V

GL -8V

GNDP

PGNDA

+5V_TFT

+5V_TFT

PGNDA

PGNDA

PGNDA

PGNDA

DGND

DGND

DGND

DGND

PGNDA

GH +15V

PGNDAGL -8V

+3.3V_SYS

+5V_TFT

+5V_SYS

PGNDA

PGNDA

PGNDA

PGNDA

DGND

PGNDA

GNDM

J8

CON30

123456789

101112131415161718192021222324252627282930

U13

APC558

1

2

3

4 5

6

7

8OUT1

-IN1

+IN1

VEE +IN2

-IN2

OUT2

VCC

C211

220P/50V

12

R27522K

2

1

TP92 656-D2

TP82+3.3V_SYS

TP97 656-D5

R233 10K/J21

C208

10U/6.3V

12

TP89VCOM

C228NC;;;0.1U/16V

RP1

33/J

1234 5

678

C218

220P/50V

12

TP79PANEL SPI-ENABLE

R2788.2K

2

1

TP91 656-D3

TP83+5V_TFT

R27630K

2

1

R232

10K/J

2

1

L24 1A/600 OHM1 2

TP96 656-D6

TP85 GH +15V

L23 1A/600 OHM1 2

TP90656-D4

C199 10U/6.3V1 2

R247

12K2

1

TP81CCIR_CLK

L20 1A/600 OHM1 2

TP95 656-D7

R27747K

2

1

C214

220P/50V

12

C207

0.1U/16V

12

R2401K

2

1

R2748.2K

2

1

R273330

2

1

TP94 656-D8

C216

220P/50V

12

C202

2.2U/25V

12

R242 10K/J2 1

FB460

TP78PANEL SPI-CLOCK

TP87PGNDA

C205 10U/6.3V1 2

R244 10K/J2 1

R24520K

2

1

R193 33

C212

220P/50V

12

L25 01 2

C213

220P/50V

12

C206

10U/6.3V

1 2

C215

220P/50V

12

R256 20K21

TP77PANEL SPI-DATA

C198 0.1U/16V1 2

VR1 NC50K

1 2

3

TP88VSET

R2461K

2

1

C217

220P/50V

12

R241

10K/J2

1

R257

33K2

1

C201

0.1U/16V

12

R2431K

2

1

TP76POLS TP80 7.2 Electrical Diagram

TFT-RESET of Bottom PCBA

L22

1A/600 OHM12

C200

0.1U/16V

12

L26 01 2

TP93 656-D1

TP84 GL -8V

C210

2.2U/25V

12

C2290.1U/16V

RP2

33/J

1234 5

678

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

LED+

LED-BL-Power control(4)

LED+ (12)

LED- (12)

VIN_SYS

GNDP

GNDP GNDP

GNDP

GNDP

GNDP

TP74

LED+

D32MBR0520LT1G

U12

TPS61042

3

5

6

4

8

7

1

2

9

VIN

CTRL

GND

FB

SW

OVP

LED

Rs

GN

D

D36

M2J728

AC

C1974.7U/16V

C196

2.2uF/25V

L21 4.7UH

C23110U/6.3V

C2270.1U/16V

R269390K

TP75

LED+

R229

13R/F

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

1.2V350mv

GNDPGNDPGNDP

GNDP

+5V_SYSD+1.2V

R211150KR

+

C160NC;;TAN 47U/6.3V

12

FB131A/600 OHM U10

AT1366

4

125

3VIN

RUNG

ND

FB

SW

C2250.1U/16V

L17 SDC43-4R7M

C22610U/6.3V

C159

47P

C1560.1U/16V

R209

75KR C15810U/6.3V

FB351A/600 OHM

R262

1MR

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Vout=0.5X(1+R4/R5)

1 2

3BAT54S

到ESD-GND

GNDM

GNDRF

+5V_RF

+5V_SYS

GNDP

GNDP

GNDP

GNDP GNDP

GNDP

GNDPGNDP

GNDP

GNDP

GNDP GNDP

GL -8V

GH +15V

VIN_SYS

+5V_SYS

GNDP

+5V_M

GNDRF

GNDP

GNDP

AGND

GNDP GNDP

GNDA

R199 10R/0805

C148

0.1U/16V

FB111A/600 OHM

D18

Zenor/8.2V

21C224

0.1U/16V

+TC6TAN 47U/6.3V

12

C1471U/6.3V

D23

MBRA340T3G

2 1

C153

220P

FB28 0

R202NC

D19Zenor/15V

21

D17

BAT54S/SOT3

1

2

C142 2.2uF/25V

D20

BAT54S/SOT3

1

2

+C145

TAN 100U/6.3V

C243NC 4.7uF/25V

+ C143

NC 10U/6.3V

C1520.47U/10V

L16

10uH/3A

C140

1U/25V

C1501U/6.3V

D22BAT54S/SOT3

12

Q30APM2300AG

DS

R204 10K/J

D21BAT54S/SOT3

12

FB171A/600 OHM

R2036.8K

FB121A/600 OHM

C154NC

R20618K

R205

165K

C141

1U/25V

C1380.1U/16V

FB36 0

U9

APW7078

1234 5

678INV

SCPVDDCTL OUT

GNDOSC

FB

C151

270p

C136 1U/25V

C1551U/6.3V

C137

1U/25V

+TC7

TAN 47U/6.3V

12

C1354.7U/16V

C134 1U/25V

R200 10R/0805

R201

0

C1391U/25V

C146

10U/6.3V

C1440.1U/16V

C149

0.1U/16V

FB27 0

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

SDRAM

3.3V/600mA

+3.3V_SD

D+3.3V

+3.3V_SYS

A+3.3V

DGND

DGNDGNDP

AGND

GNDP

GNDP

GNDP

GNDP

+3.3V_SYS

GNDP

GNDP

+5V_SYS

GNDP

FB18 0

L15 SDC43-150M

C12010U/6.3V

C130

4.7PFD16

MBRS120T3

21

C1210.1U/16V

SG

D

Q29

APM2301R194 0

C2300.1U/16V

C1290.1U/16V

C12310U/6.3V

FB91A/600 OHM

C1260.1U/16V

FB101A/600 OHM

C1220.1U/16V

C12710U/6.3V

M14EMI-PAD

FB81A/600 OHM

C1280.1U/16V

R254

100mOHM

FB341A/600 OHM

U8

TPS64200DBV

1

2

3 4

5

6/EN

GND

FB SENSE

VIN

SW

R197

619K

R198

360K

+

C131TAN 47U/6.3V

12

C12510U/6.3V

C13210U/6.3V

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

KEY_OUT0

KEY_OUT1

KEY_IN3

KEY_IN1

KEY_IN0

KEY_IN2

L+L-R+

R- R+ (6)

L+ (6)L- (6)

R- (6)

KEY_IN2 (4,5)KEY_IN1 (4,5)KEY_IN0 (4,5)

POWER-KEY (1)GREEN-Light (1)

KEY_OUT1 (4,5)KEY_OUT0 (4,5)

KEY_IN3 (4,5)

RED-Light (1)

+3.3V_SYS

VIN_SYS1

DGND

ADA-VCC1

GNDP

GNDP

R249 1K2 1

R251

47K

2

1

TP63PIN5

TP59

L+

TP72 Green-light

TP64PIN6

FB30 1A/600 OHM

TP70 Key_in3

TP73 RED-Light

R252

47K

2

1

R253

47K

2

1TP69 Key_in2

TP68 Key_in1

TP66 Key_out1

TP60L-

TP65 Key_out0

TP71 Power-key

TP61R+

R248 1K2 1

TP62R-

R250

47K

2

1

J10

CON15

1234567891011121314151617

FB29 1A/600 OHM

TP67 Key_in0

FB381A/600 OHM

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

H:MUTE

Headphone-JACK

G V R L CLOSE JACK

SHUT-DOWN:4.35VNORMAL:480mV

DAC Interface

Hi:MUTELo:Active

Speaker AMP

Video Output Circuit

Audio Output circuit

OUTPUT Unit

Hold Keyboard Switch

ESD-GND

ESD-GND

SE/BTAL_SEL3

R+

AUDIO_MR R-

SE/BTAL_SEL

MIXL

AUDIO_ML

VD_OUT

AUDIO-DAC_ML

SE/BTAL_SEL

L+

SE/BTAL_SEL3

R+

L-

MIXR

SE/BTAL_SEL3

VD_OUT

HP-LOUT

A_HP-LOUT

A_HP-ROUT

SE/BTAL_SELHP-ROUT

MIXRAUDIO_MR

APOWER-CON

F_AUDIO-AMP_MUTE

AUDIO_MRAUDIO-DAC_MR

AUDIO-DAC_MLAUDIO_ML

AUDIO-DAC_MRAU_XCK

AU_BCKAU_LRCK

AU_D0

HOLD

OFF

AUDIO_ML

A_HP-ROUT

F_AUDIO-AMP_MUTE

HP-LOUT

L+

AUDIO-AMP_MUTE

AUDIO-AMP_MUTE

A_HP-LOUT

MIXL

HP-ROUT

APOWER-CON

CVBS(TVDAC0) (4)

R- (7)

TV_JACK-IN (4)

AU_D0(4)

AU_LRCK(4)AU_XCK(4)

L- (7)

AU_BCK(4)

R+ (7)

SE/BTAL_SEL(4)

AUDIO_MUTE(4)

BEEP(4)

HOLD (4)

L+ (7)

+5V_SYS

DGND

+5V_AUDGNDA

VIN_SYS

+5V_AUD

GNDP

+5V_OP

GNDP

GNDP

+5V_SYS

GNDV

GNDA

GNDA

GNDA

GNDA

GNDV

GNDA

GNDA

GNDA

GNDA

GNDA

GNDVGNDA

AGND

+5V_SYS

GNDA

+5V_AUD

GNDA

+5V_AUD

+5V_AUD

GNDA

GNDA

GNDA

GNDA

+5V_AUD

D+3.3V

GNDAGNDA

GNDP

GNDP

GNDA

GNDA

GNDA

GNDRF-P

AGND

AGND

+

C119

E 47U/6.3V

C98 18P/50V1 2

R222 2.2M21

EC8

2.2uF/6.3V

R1721.5k

2 1

C172

390P

1

2

+

C100

DIP 330U/6.3V

+ EC4E 220U/6.3V

FB31A/600 OHM

R271NC 47K

2

1

FB48FBM-160808-601

C173

390P

1

2

R142 20K

R1831.5k

21 C1141N/50V

1

2

C1091N/50V

1

2

R168220

2 1

D34

0R/0805

2 1

FB2

0

+

-

U11AAPC558

3

21

R1861K

2

1

R1881K

2

1

C97

0.1U/16V

D35 MA2J728

A C

R141

100K

M15EMI-PAD

R21647K

2

1

FB311A/600 OHM

R143 20K

Q27

MMBT39061

32

R149

1K

FB470

R218 47K21

J5PJ-362

12

3

45

67

L141.8UH

D33 MA2J728A C

R187150

21

D14MA2J111

A C

Q362SD13281

32

R272 NC 1K2 1

C168

390P

1

2

R220 47K21

+

-

U11BAPC558

5

67

R146

100K

FB20 FBM-160808-601

M10EMI-PAD

FB5NC-0

R18247K

2

1

C170

390P

1

2

FB16 0

+C118

E 47U/6.3V

R1451KMute

SE/BTL

Lout-

Lout+Shutdown

Lin

Rin

RBypass

LBypass

Rout-

Rout+

RVdd

Gnd

Gnd

Gnd

LVdd

U6

APA2066SO0_S

11

12

3

1

2

134 5

10

8

7

6

14

15

16 9

17

C164 33P/50V12

R19110K/J

21

SG

D

Q37NC APM2301

J6 PJ-328-5

65743

R2671.5K

21

J4

SKY-12F06-G1.5-OA

123

Q24MMBT3904

1

32

Q26MMBT3906

1

32

FB43NC 0

C169

390P

1

2

R189

10K/J

2

1

Q20

MMBT3904

R140 20K

Q25MMBT3904

1

32

C162 33P/50V12

R144 20K

+C108

TAN 47U/6.3V

1 2

R153

1K

C24282P

+EC7

E 220U/6.3VEC52.2uF/6.3V

R19210K/J

21

C1030.1U/16V

R150NC

2

1

R26675

21

FB24 FBM-160808-601

R217 47K21

R190100K

21

C163 330P12

R163

10K/J

R21547K

2

1

C1660.1U/16V

R17147K

2

1

FB26 FBM-160808-601

TP581

R1690

2 1

+C161

E 47U/6.3V

R26575

21

C99 10U/6.3V

12

FB22 FBM-160808-601

R2681.5K

21

R214100K

2

1

FB40

EC62.2uF/6.3V

R154NC

2

1

FB23 FBM-160808-601

EC2 1U/25V

C101

33P/50V

12

R219 2.2M21

EC9

2.2uF/6.3V

R178220

21

FB21 FBM-160808-601

C165 330P12

R18510

21

EC3 1U/25V

M13EMI-PAD

Q352SD1328

1

32

+

C113 TAN 47U/6.3V

1 2

C209

10U/6.3V

1

2

C171

390P

1

2

R1474.7K/J

2

1

M9EMI-PAD

R213100K

2

1

R1790

21

Q38NC MMBT3904

FB440

U7 CS43351234 5

678SDATA

DEM/SCLKLRCKMCLK AOUTR

AGNDVA

AOUTL

U11CAPC558

84

D30

BAV70

3

1 2

R161

10K/J

D15MA2J111

AC

M11EMI-PAD

+

TC5TAN 47U/6.3V

12

R157

150

2

1

C102

22P/50V

12

R148 5.62 1

Q28MMBT3904

1

32

R221 47K21

+

EC1TAN 47U/6.3V

12

C167

390P

1

2

FB25 FBM-160808-601

R155

180

2

1

FB1

NC 0

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

ONBORD_DBG-1/2 ONBORD_DBG-2/2

I2C ADDR = 0XA0

EXTRG0(4)

NRST(3,4)

SDATA(4)

TRCST(4,7)

TRCDATA3(4,7)

TRCDATA1(4,7)

TRCDATA0(4,7)

TRCCLK(4,7)

SCLOCK(4) TRCDATA2(4,7)

I2C_DATA (4)I2C_CLK (4)

D+3.3V

DD+3.3V

DGND

DGND

DGND

R136 0

TP107

DD+3.3V

R1381K

2

1

R1391K

2

1

C960.1U/16V

TP105

NRST

TP108

SCLOCK

TP110

DGND

U5 24C02N1234 5

678A0

A1A2GND SDA

SCLWP

VCC

TP106

EXTRG0

TP109

SDATA

CN1

K1MN10A00030

5

234

1

6789

10111213

GND

TRCCLKGNDTRCDADA0

GND

TRCDATA1GNDTRCDATA2GNDTRCDATA3GNDTRCSTGND

R137 0

CN2K1MN10A00030

5

234

1

6789

10

DGND3

SDATADGND2EXTRG

DGND1

SCLOCKDGND4RESETVDDNC

R134

10K/J

R135

10K/J

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

CCIR656

AUDIO INTERFACE DEBUG INTERFACE

NOT USED

KEY MATRIX

VIN

4RF

FDT1

2

VIN4RF

DR

V2

MA

1

VIN

3RF

MA

9

DRV7

MD

Q7

MDQ12

MDQ10

DR

V1

MA

10

VIN

1RF

DRV0

FDT1

5

DRV1

FDT0

VIN5RF

VIN[1:10]

VIN

2RF

VIN

5RF

FDT2

MD

Q6

FODRV

MDQ4

MA

6

MDQ14

MA

3

LPCO2

CVBS(TVDAC0)

VREFH

FDT1

0

MDQ1

RFI

NPD

RV

0

FDT8

LPC[1:2]

LPC

1FD

T5

FDT3

VIN3RF

FDT1

DD+1.2V

MDQ2

MDQ3

CLOCK-IN

MA

2

MD

Q8

FDT6

VIN2RF

FDT1

1

DR

V4

MA

8

MDQ9

VIN1RF

DRV8

TRDRV

MA

11

FDT7

LPC

2

DD+1.2V

VR

EFH

FDT1

4

FDT9

MA

5

FODRV

MDQ0

FDT1

3

MDQ13

LPCO2

DR

V8

MDQ11

CCIR_D5

FDT4

DR

V7

LPCO1LPC1

LPC2

LPCO1

MDQ15

MDQ5

MA

7

TRDRV

DRV4

MA

0

RFINP

MA

4

FADR4

FADR6

FADR18

FADR7

FADR1

FADR10

DD+3.3V

FADR3

FADR0

FADR2

FADR11

FADR17

FADR14

FADR8

FADR5FADR9

FADR15

FADR12

FADR16

FADR19

FADR13

27MHZ

CLOCK-IN

CCIR_D1

CCIR_D4

CCIR_D2

CCIR_D7

CCIR_D0

CCIR_D6

CCIR_D3

CCIR_D5DD+1.2V

VIN4VIN3

VIN1

VIN5

VIN10

VIN1

VIN5VIN4

VIN8

VIN6

VIN7

VIN9

VIN9

VIN8

VIN2

VIN2

VIN

6RF

VIN7

VIN6

VIN10

VIN3

VIN[1:6]RF

VIN6RF

CCIR_D1

CCIR_D3

CCIR_D0

CCIR_D2

CCIR_D7CCIR_D6

CCIR_D4

DD+3.3V

I2C_CLK(5)

I2C_DATA(5)

TFT-RESET(12)

VIN3RF(2)

VIN8(2)

VIN4RF(2)

BMS(2)

NCE(3)

VIN2(2)

SDATA (5)

VIN5RF(2)

VIN3(2)

DRIVER_MUTE(2)

MA[0:11](3)

SCLOCK (5)

LPC2(2)

DVD/CD_SW(2)

FG(2)

EXTRG0 (5)

VIN9(2)

LPC1(2)

VIN10(2)

VIN6RF(2)

SPDRV(2)

VIN4(2)

VREFH(2)

VIN5(2)

VIN1RF(2)

TRSDRV(2)

FODRV(2)

LPCO2(2)

VIN2RF(2)

TRDRV(2)

VIN1(2)

FDT[0:15](3)

NWR(3)

LPCO1(2)

VIN6(2)

RFINP(2)

MDQ[0:15](3)

VIN7(2)

DQM1(3)DQM0(3)NWE(3)

NCAS(3)NRAS(3)MCK(3)

NCSM(3)BA0(3)BA1(3)

NOE(3)

FADR[0:19](3)

PANEL SPI-CLOCK(12)PANEL SPI-DATA(12)

PANEL SPI-ENABLE(12)

BL-Power control(11)

AUDIO_MUTE(6)

AU_LRCK (6)AU_BCK (6)AU_D0 (6)

AU_XCK (6)

NRST(3,5)

KEY_OUT1 (5,7)

KEY_OUT0 (5,7)

CCIR_D5(12)

CCIR_D0(12)

CCIR_D2(12)

CCIR_D7(12)

CCIR_D3(12)

CCIR_D4(12)

CCIR_D1(12)

CCIR_D6(12)

BATT_TYPE(1)

TRCST (5,7)

TRCDATA0 (5,7)TRCDATA1 (5,7)

TRCCLK (5,7)

TRCDATA2 (5,7)TRCDATA3 (5,7)

TV_JACK-IN(6)

HOLD(6)

POWER/ON(1)

PLAY-OK(1)

TOP-COVER_SENSER(2)

CCIR_CLK (12)

CVBS(TVDAC0) (6)

BEEP(6)

KEY_IN3 (5,7)KEY_IN2 (5,7)KEY_IN1 (5,7)KEY_IN0 (5,7)

SE/BTAL_SEL(6)

DD+3.3V

AA+3.3V

DD+3.3V

A+3.3V

AA+3.3V

DGND

AA+3.3V

D+1.2V

VHALF

DD+3.3V

DGND

D+3.3V

VIN_SYS

DD+3.3V

DGND

DGND

DGND

DGND

DD+3.3V

VHALF

AGND

AGND

AGND

AGND

AGND

DGND

DGND

AGND

R103 6.821

C590.1U/16V

1

2

RN5 100 x 4

R991A/600 OHM

R123 4.7K21

TP48 1

C2341000P

1

2

C236

0.1U/16V1

2

C56 1U/6.3V1 2

R258 100K21

C79

33N

/10V

1

2

R12

67.

5K2

1

L5BLM18PG121SN1D

1 2

C86

1U/6

.3V

1

2

C63100P/50V

1

2

L6 BK1608TS102-T1 2

C66100P/50V

1

2

R12

57.

5K 2

1

R121 10K/J21

R119 100K21

R114 021

C187

0.1U/16V1

2

L12

BK

1608

HS

102-

T1

2

C73

0.1U

/16V

1

2

C182

0.1U/16V1

2

C77

0.1U

/16V

1

2

C930.1U/16V

1

2

R101 1A/600 OHM

R110 10K/J21

C83

0.1U

/16V

1

2

C80

0.1U

/16V

1

2

C62 0.1U/16V1 2

R10710K/J

21

C941U/6.3V

1

2

R106 2K2 1

C9222U/6.3V

1

2

C190

0.1U/16V1

2

+C46TAN 47U/6.3V

TP39EXADR20

+ C58

TAN 100U/6.3V

R97 10021

R115 10K/J21

C194

0.1U/16V1

2

L10BK1608TS102-T

1 2

C520.1U/16V

1

2

C91 0.1U/16V1 2

R127

15K/F

2

1

TP401

C710.1U/16V1 2

C183

0.1U/16V1

2

C23322P

1

2

C239

0.1U/16V1

2

TP38

1

C2351000P

1

2

L7BK1608TS102-T

1 2

C76

0.1U

/16V

1

2

TP46 1

L13

BK

1608

HS

102-

T1

2

C69OPEN

1

2

C60 0.1U/16V12

C81

100P

/50V

1

2

L4BLM18PG121SN1D

1 2

C67150P

1

2

C85

1U/6

.3V

1

2

L8BLM18PG121SN1D

1 2

R12910K/J

2 1

R122 4.7K21

C500.1U/16V

1

2

C64150P

1

2

R113 021

C237

0.1U/16V1

2

IC3

DV2.1

123456789

10111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364

65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 99 100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

121

122

123

124

125

126

127

128

256

255

254

253

252

251

250

249

248

247

246

245

244

243

242

241

240

239

238

237

236

235

234

233

232

231

230

229

228

227

226

225

224

223

222

221

220

219

218

217

216

214

213

212

211

210

209

208

207

206

205

204

203

202

201

200

199

198

197

196

195

194

193

192191190189188187186185184183182181180179178177176175174173172171170169168167166165164163162161160159158157156155154153152151150149148147146145144143142141140139138137136135134133132131130129

98

215

MDQ9MDQ5VSSMDQ10MDQ4VDD33MDQ11MDQ3VSSMDQ12MDQ2VDD33MDQ13MDQ1MDQ14VSSMDQ0MDQ15VDD33VSSEXADR20NEXWEEXADT0EXADT4EXADT8VDD12EXADT12VDD33VSSEXADR16EXADR18EXADT14EXADT10VDD33VSSEXADT6EXADT2NEXCEEXADT1EXADT5EXADT9EXADT13EXADR17VDD12EXADR19EXADT15EXADT11VDD33VSSEXADT7EXADT3NEXOEP15P14P13P12P11P10P9P8P7VDD33MMODVSS

P6

P5

P4

P3

P2

P1

P0

FG NR

ST

VS

SD

RV

0D

RV

1D

RV

2D

RV

3D

RV

4D

RV

5D

RV

6D

RV

7D

RV

8V

DD

33P

16P

17V

SS

MO

NI7

V D

D12

MO

NI6

MO

NI5

MO

NI4

VS

SM

ON

I3M

ON

I2M

ON

I1M

ON

I0

PLF

IL1

AV

SS

DV

RE

FH7

VR

EFM

7V

RE

FL7

CC

AP

AA

VS

SC

CD

ATA

AV

DD

CA

NA

MO

NI1

AN

AM

ON

I2R

FIN

NR

FIN

PV

IN6R

FV

IN5R

FV

IN4R

FV

IN3R

FV

IN2R

FV

IN1R

FA

VD

DB

VR

EFH

5V

RE

FM5

VR

EFL

5A

VS

SB

LPC

1LP

CO

1LP

C2

LPC

O2

VR

EFH

VH

ALF

MD

Q6

VD

D33

MD

Q8

VS

SM

DQ

7D

QM

1V

SS

DQ

M0

NW

EV

SS

VD

D33

NC

AS

NR

AS

MC

KV

SS

MC

KI

NC

SM

VD

D33

MA

9M

A11

VD

D12

VS

SB

A0

MA

8B

A1

VD

D33

MA

10V

SS

MA

7M

A0

MA

6V

DD

33M

A1

MA

5V

SS

MA

2M

A4

VD

D12

VS

SM

A3

VD

D33

DQ

M3

VS

SM

DQ

16M

DQ

31M

DQ

17V

DD

33M

DQ

30M

DQ

18M

DQ

29V

SS

MD

Q19

MD

Q28

VD

D33

VS

SM

DQ

20M

DQ

27M

DQ

21M

DQ

26V

DD

33M

DQ

22M

DQ

25M

DQ

23

MDQ24VSS

VDD33TRCST

TRCDATA3TRCDATA2TRCDATA1TRCDATA0

TRCCLKEXTRG1

SDATAEXTRG0SCLOCK

VSSVDD33

IECOUTADOUT0ADOUT1ADOUT2

VSSVDD12

ADOUT3SRCKLRCK

EXTCKVDD33OSCOOSCIVSS

DACCKAVSSGAVDDGAVSSEAVDDE

DAC5OUTAVSSF

DAC4OUTCOMPIREF1VREF

DAC3OUTDAC2OUT

AVDDFDAC1OUT

PWM0PWM1VCOF

AVSSHVREFH10

AD0VREFL10

AVDDHAD1AD2

VIN1VIN2VIN3VIN4VIN5VIN6VIN7VIN8VIN9

VIN10

AV

DD

D

DQ

M2

C72

0.1U

/16V

1

2

C78

0.1U

/16V

1

2

R105 3.3K21

C193

0.1U/16V1

2

R13110K/J

21

C189

0.1U/16V1

2

R283 NC 021

R111 20K21

R112 8.2K/J21

C177

0.1U/16V1

2

C480.1U/16V

12

C74

0.1U

/16V

1

2

R116 021

+C57

TAN 47U/6.3V

R96

272

1

C188

0.1U/16V1

2

TP49 1

R259 47K21

C185

0.1U/16V1

2

R109 47K21

FB420

C191

0.1U/16V1

2

C68150P

1

2

C65150P

1

2

C192

0.1U/16V1

2

L11 BK1608TS102-T1 2

C61 0.1U/16V1 2 TP41

1

TP47 1

U4 NC7WZ04

123 4

56A1

GNDA2 Y2

VCCY1

C490.1U/16V1 2

C84

0.1U

/16V

1

2

C186

0.1U/16V1

2

C88

10U

/6.3

V

1

2

R132 4.7K21

C87

10U

/6.3

V

1

2

C240

0.1U/16V1

2

C70OPEN

1

2

C90 0.1U/16V1 2

R120 10K/J21

C82

0.1U

/16V

1

2

C51 0.1U/16V1 2

R280 10021

R118 10K/J21

R128 47K21

OSC1

OSC27MHZ

1

2 3

4EN

GNDOUT

VCC

C951U/6.3V

1

2

+C45TAN 47U/6.3V

C75

18N

/16V

1

2 R124 12K/F21

C238

0.1U/16V1

2

C8910N/16V

1

2

Q19MMBT3904

1

32

R10820K

21

C184

0.1U/16V1

2

R104 22K21

C470.1U/16V

1

2

D5MA2J111

AC

C550.1U/16V

1 2

R117 021

L9BK1608TS102-T

1 2

R1335.6K

2

1

R130 47K21

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

DQ[0:15]

DQ14

FDT3

FADR15

DQ14

MDQ13

DQ8

DQ9

FADR16

FADR12

FADR14

FADR8

DQ8

DQ9

DQ2

MDQ8

MDQ14

DQ3

MA6

FADR7

FDT6

DQ0

FDT8

DQ6

DQ2

DQ10

FDT7

MA3

DQ7

FADR1

MDQ9

DQ15DQ0

MA10

DQ15

FDT0

FDT1

MDQ11

MDQ2DQ4

FADR13

MDQ7

MDQ12

MA2

MDQ3

FADR2

FADR19

MDQ0

DQ13

DQ4

FDT15

MA4

MA7

FDT5

FDT10FADR18

MDQ1

DQ5

FADR5

DQ1

MA1

FDT9FDT2

MDQ5

MDQ6

FDT12

DQ3

DQ7

FDT4

DQ11

FADR6

DQ13DQ11

FDT14FADR9

MDQ4

FADR17

FADR0

FADR11

FADR4

DQ6

FDT11

MA5

DQ12

MA9

DQ10

DQ5

FADR10

MDQ15

MA11

MDQ10

MA0

FDT13

DQ12

FADR3

DQ1

MA8

NRST(4,5)

NOE (4)

NWR(4)

NCAS(4)NRAS(4)

NWE(4)

NCSM(4)MCK (4)DQM1 (4)

FDT[0:15] (4)

FADR[0:19] (4)

MA[0:11] (4)

DQM0(4)

MDQ[0:15] (4)

NCE (4)

BA0(4)BA1(4)

DGND

+3.3V_SD

D+3.3V

C420.1U/16V

12

IC1EM638165TS-7G

123456789

101112

1413

15161718192021222324252627 28

2930313233343536373839404142434445464748495051525354VDD

DQ0VDDQDQ1DQ2VSSQDQ3DQ4VDDQDQ5DQ6VSSQ

VDDDQ7

LDQM/WE/CAS/RAS/CSBA0BA1A10/APA0A1A2A3VDD VSS

A4A5A6A7A8A9

A11NC

CKECLK

UDQMNC

VSSDQ8

VDDQDQ9

DQ10VSSQDQ11DQ12VDDQDQ13DQ14VSSQDQ15

VSS

C390.1U/16V

12

IC2M29W160ET

123456789

101112131415161718192021222324 25

2627282930313233343536373839404142434445464748A15

A14A13A12A11A10A9A8A19A20XWEXRESETNCXWP/ACCPDY/XBUSYA18A17A7A6A5A4A3A2A1 A0

XCEGNDXOEIO0IO8IO1IO9IO2

IO10IO3

IO11VCCIO4

IO12IO5

IO13IO6

IO14IO7

IO15/A-1GND

XBYTEA16

R93 2221

C410.1U/16V

12

R94 2221

C380.1U/16V

12

RN1 82 x 4

RN3 82 x 4

RN2 82 x 4

C430.1U/16V

12

C370.1U/16V

12

RN4 82 x 4C400.1U/16V

12

C440.1U/16V

12

R9547

21

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

1.Fo+2.Tr-3.Tr+4.Fo-5.NC6.NC7.LD(DVD)8.GND(LD)9.LD(CD)10.MD11.VR(DVD)12.VR(CD)13.GND(PD)14.Vc15.Vcc16.E17.F18.RF19.CD/DVD SW20.A/a21.B/b22.C/c23.D/d24.NC

Testpointposition

Test point position

RED rectangular : AddGreen rectangular : Adjust

24 PIN 0.5 Pitch 下接板

13 PIN 1.0 Pitch 上接板

SWAP TWO I/O

VIN2

DRIVER_MUTE

VIN6

FODRV

VIN1

SPDRV

VIN10

DRIVER_MUTE

BMS

VIN8

DVD/CD_SW

VIN6RF

FG FG

TOP-COVER_SENSER

BMS

LD-DVD

LPCO2

VIN5RF

LPC1

LPC2

VIN5

SPDRV

A3

RFINP

VREFH

VIN9

LPCO2

LPCO1

LPCO1

VIN10

LPC1

LD-CD

VIN8

VIN4

RO4

LPC2

LD-DVD

VIN1

FODRV

VIN3

RFINP

VIN7 DVD/CD_SW

LD-CD

TRSDRV

VIN9

Q607

TRDRV TRDRV

Q608Q606

A1

FO4

A2

VIN4

VIN2VIN3

VIN5

VIN6VIN7

VIN1

VIN4RF

VIN2RF

VIN3

VIN4

VIN1RF

VIN3RF

VIN2

VIN6RF(4)

FG(4)

VIN4(4)

VIN5RF(4)

LPC1(4)

VIN6(4)

VIN5(4)

VIN7(4)

VIN2(4)

VIN10(4)

VIN9(4)

VIN3(4)

VIN1(4)

VIN8(4)

RFINP(4)

LPC2(4)

TOP-COVER_SENSER(4)

DVD/CD_SW(4)

LPCO2(4)

LPCO1(4)

VREFH(4)

FODRV(4)TRDRV(4)

TRSDRV(4)BMS(4)

SPDRV(4)

DRIVER_MUTE(4)

VIN2RF(4)

VIN3RF(4)

VIN1RF(4)

VIN4RF(4)

GNDRF

VHALF

VREFH

VHALF

GNDRF

VHALF

GNDM

GNDM

GNDM

GNDMGNDM

GNDRF

GNDRF

GNDRF

GNDRF

GNDRF-P GNDRF-P

GNDRF-P

+5V_M

+5V_M

+5V_M

+5V_M+5V_M

+5V_RF

+5V_SYS

+5V_RF

DD+3.3V

GNDM

+5V_M

GNDM

GNDRF-P

GNDRF-P GNDP

AGND

AGND

GNDM

GNDMGNDRF

DGND

GNDRF-P

DGND

GNDRF

DGND GNDM

Q162SD601A

1

32

TP31 RFINP

TP4

HV+

TP14

FO1

R8556

1 2

+C24

TAN 47U/6.3V

C284.7U

12

C16 0.1U/16V1 2

TP23

FO1

TP100 CD/DVD

TP10

HW+

R842.2

12

TP3

H-

TP18

SPD

TP30 F

TP6

HV-

TP34B

+C30E 47U/6.3V

C35NC 0.1U/16V

12

FB150

TP13

HU-

C7

0.1U/16V

12

R3810K/J

12

R4547K

12

Q172SB1115B

EC

TP16

TRSDRV

SW1DTS-03

3 54 6

FB400

R58 91

R7827[1/2W]

12

C34820P

12

C23 0.1U/16V1 2

R47 22K

12

TP26

TR+

+C20TAN 47U/6.3V

Q132SD1819

1

32

FB450

FB39 0

C190.1U/16V

12

R7310K/J

12

M12EMI-PAD

C33

NC 0.1U/16V1

2

R370.22[2W]

R59 91

TP28 VR(CD)

C17 0.1U/16V1 2

C13

0.01

U/1

6V1

2

C250.1U/16V

12

C264.7U

12

TP17

MUTE3

C110.01U/16V

12

R49 220

L3FBM2125MH330-T

1 2

C36 0.1U/16V12

C210.1U/16V

12

C22 0.1U/16V1 2

R822.2

12

TP98 LPC

+C27E 47U/6.3V

M7

EMI-PADR74100K

21

TP20

FG

R43 0 12

TP5

H+

R88 01 2

C223NC;;;0.1U/16V

12

FB140

FB410

R89 01 2

TP8

W

TP2

SLED-

R54

1.5K

12

TP36LD-DVD

TP7

U

R8333K

1 2

C120.01U/16V

12

TP15

FO1

+C8TAN 47U/6.3V

R53

1.5K

12

Q142SK19581

32

TP99 VREFH

C31

NC 1U

12

R77470

12

R71 012

TP9

SLED+

R7510K/J

21

TP24

RO1

Q15 2SD601A

1

32

C90.1U/16V

12

C29

NC 1U

12

R46 27K12

C195 100P/50V1 2

AN41204

U3

AN41204A 13

123456789

101112

14 15 16 17 18 19 20 21 22 23 24

252627282930313233343536

48 47 46 45 44 43 42 41 40 39 38 3749FB

3

GNDSFGFGECECRIN5IN4IN3IN2IN1FB1FB2

FB4

FB5

VREF

BMS

STBY

RO

3FO

3PG

ACVM

ACR

O2

FO2

RO1FO1VDDH1HH1LH2HH2LH3HH3LVH

VMSP1CS

RO

5FO

5PG

STR

O4

FO4

VMST

VMSP

2R

CS2 A3 A2

RC

S1 A149

R90 0

1 2

R86 01 2

TP27 VR(DVD)

TP19

TRD

R92470

12

R40 012

C14

0.01

U/1

6V1

2

L2FBMJ2125HM330-T

12

R8022K

12

TP21

BMS

TP11

HU+

TP12

HW-

R7610K/J

21

C15

0.01

U/1

6V1

2

J3TopRay

2625

1716151413121110

987654321

18192021222324

+C6

TAN 47U/6.3V

R87 56

1 2

R41 1.5K12

Q182SB1115

B

EC

R3910K/J12

TP29 E

TP37LD-CD

R7927[1/2W]

12

TP1

V

R42 100

TP35A

+TC32

TAN 47U/6.3V

12

+C18TAN 47U/6.3V

TP22

FOD

TP32D

TP25

TR-

R55

1.5K

12

R91470

12

R72 0

12

TP33C

U2

52207-1385

123456

14

789

10111213

15

H-HW-HW+HV-HV+HU-

GND

HU+H+UVWSLED-SLED+

GND

C100.1U/16V

R44 NC 30K 12

Q122SK19581

32

R81470

12

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

DETECT-PIN 47K-PULL-LOW_POLYMERGND_ALKALINE

H:ENABLEL:DISABLE

OPERATIION CHARGE 0.33ASTANDBY CHARGE 1.33A

L

CHARGE TIME: 8.66hr

H

DTOP

S+5V

G

PLAY-OK

POWER-ON/OFF

POWER/ON

CHARGER-ENABLE

CHARGE-SEL

CHARGE-SEL

TEMP PROTECTION

RED-Light GREEN-Light

VIN_SYS

TEMP PROTECTION

POWER-ON/OFF

Battery-power

CHARGER-ENABLE

CHARGER-ENABLE

Battery-power

POWER-KEY

RED-Light (7)

PLAY-OK (4)

GREEN-Light (7)

BATT_TYPE (4)

POWER/ON (4)

POWER-KEY (7)

VIN_SYS1

GNDP

+3.3V_SYS

GNDP

GNDP

GNDP

ADA-VCC1

ADA-VCC1

VTSB

VTSB

VIN_SYS

GNDP

GNDP

GNDP

GNDP

GNDP

GNDP

GNDP

GNDP

VIN_SYS1

ADA-VCC1GNDP

GNDP ADA-VCC1

DGND

DGND DGND DGND DGND DGND GNDPGNDP

GNDP

R6

100K1

2

M6

EMI-PAD

TC4

1U/25V

FB370 OHM

R7100K

12

F2 467003.NR

D28 1N4148

R105.1K

12

SG

D

Q4APM2301

TP111OVER_VOLTAGE

VCCGND

PROTECTDETECT-PIN

J1

BAT_CON

12

43

F1 467004.NR

D2Zenor/5.6V

21

TP102 GNDP

D29

MBRA340T3G

21

Q62SD601A

D26 MBRA340T3G2 1

Q31

MMBT3904B

EC

R14

100K

12

TP103 CHARGER-ENABLE

R1910K/J

12

R9

3.3K

12

+TC3

10U/6.3V

12

U1

BQ24103

1

23456789

10 11

1213141516171819

20

21O

UT

STAT1ININPGVCCTTCISET1ISET2

VSS

VTSB

TSNC

BATSNS/CE

PGNDPGNDSTAT2

OU

T

21

R25

47K

12

SG

D

Q2APM2305A

C232

NC 0.1U/16V

TP104 TEMP PROTECTION

R18NC 100K

12

R24 1K

1 2

R284NC 360K

12

R2 100K/J12

R4 0.1R/F1 2

Q72SD601A

C219

NC;;0.1U/16V

C3

0.1U/16V

C2

0.1U/16V

12

C4

0.2U/16V

C222

10U/6.3V

Q34MMBT3904

B

EC

R3 10K/J12

Q82N7002

D

G

S

M2EMI-PAD

M3EMI-PAD

C220NC;;10U/6.3V

R1322K

12

L1 SCD0403T-4R7M-N

R12

22K/J

12

C221

0.1U/16V

C2410.1U/16V

M5EMI-PAD

R282 0.1R/F1 2

R15 5.6k1 2

J2 DJ-0708

321

R8

120R

12

R16

22K

12

+TC2

NC_10U/6.3V12

R28110K

12

TP101 Battery

+ C1

TAN 100U/6.3V

M8

EMI-PAD

C244100p

M4EMI-PAD

L18NC-IRO0840-6R5N

R261FBM-11-201209-121A40T

1 2

Q11MMBT3904

B

EC

D27 1N4148

C5

0.1U/16V

R260FBM-11-201209-121A40T

1 2

R112.2M

12

R279

1K

12

+TC1

TAN 47U/6.3V

12

C245100p

R17

10K/J

12

M1EMI-PAD

8. COMPONENT LAYOUT

8.1 Component layout of Bottom PCBA

8. COMPONENT LAYOUT

8.2 Component layout of Top PCBA

Top Side

Bottom Side

9. EXPLODED VIEW DIAGRAM & SERVICE PART LIST

MECHANICAL PARTS 101 9940 000 03854 Housing Top Case 102 9940 000 03843 Top PCBA 103 9940 000 03844 LCD 104 9940 000 03855 Middle Cabinet 105 9940 000 03841 Driver 106 9940 000 03842 Bottom PCBA 107 9940 000 03856 Housing Bottom Case 108 9940 000 03845 Battery

MISCELLENEOUS 9940 000 03846 AV Cable 9940 000 03847 Adaptor-US (PET320/37) 9940 000 03848 Adaptor-EU (PET320/00) 9940 000 03849 Adaptor-UK (PET320/05) 9940 000 03851 Car Adaptor 9940 000 03852 Ear Phone 9940 000 03853 Pouch

101

102

103

104

105

106

107

108

9. EXPLODED VIEW DIAGRAM & SERVICE PART LIST

Philips Service 12NC Model # Supplier name Accessory description

994000003841 PET320 QSI Driver 994000003842 PET320 QSI Bottom PCBA 994000003843 PET320 QSI Top PCBA 994000003844 PET320 QSI LCD 994000003845 PET320 QSI Battery 994000003846 PET320 QSI AV cable 994000003847 PET320/37 QSI Adaptor-US 994000003848 PET320/00 QSI Adaptor-EU 994000003849 PET320/05 QSI Adaptor-UK 994000003851 PET320 QSI Car Adaptor 994000003852 PET320 QSI Ear Phone 994000003853 PET320 QSI Punch 994000003854 PET320 QSI Housing Top Case 994000003855 PET320 QSI MIDDLE_CABINT 994000003856 PET320 QSI Housing Buttom Case 994000003857 PET320 QSI SCREW 1.7-0.64x5.0 994000003858 PET320 QSI SCREW 1.7-0.50x3.0 994000003859 PET320 QSI SCREW 1.7-0.64x3.8 994000003861 PET320 QSI SCREW 1.7-0.50x4.6 994000003862 PET320 QSI SCREW 1.7-0.64x3.7 994000003863 PET320 QSI FFC TOP BOARD_17PIN 994000003864 PET320 QSI DOOR_HINGE_SPRING 994000003865 PET320 QSI DOOR_HINGE_PIN_LONG 994000003866 PET320 QSI DOOR_HINGE_PIN_SHORT

10. REVISION LIST

Version 1.0 (3141 785 30840) • Initial release PET320/00/05/37

pet-320

Documents