parts reference manual - snap-on

MFX XTREME EETF103A ATX31000

Parts Reference Manual

July, 2004

All information contained or disclosed in this document is considered confidential and proprietary by Snap-on Tools Company. All manufacturing, use, reproduction, and sales rights are reserved by Snap-on Tools Company and the information contained herein shall not be used in whole or in part without the express written consent of Snap-on Tools Company.

Effective 07/2004 Page 1

PARTS

GENERAL

EETF103A (MFX XTREME ATX31000) This document describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description of the Serial Number. Serial # Location – Front Below the Service Access Panel. Example:

MIN S020155 Last 4 Digits indicate the number of the unit built for Snap-on NS: NOT SHOWN IN PICTORIAL

NOTE PARTS LISTED WITH AN * OR OTHERWISE NOTED ARE CONSIDERED SPECIAL ORDER PARTS AND WILL NOT BE STOCKED, OR LISTED, IN THE EQUISERV PARTS SYSTEM UNTIL ORDERED BY A TECHNICIAN. WHEN ORDERING THESE PARTS PLEASE NOTE THAT THESE ARE GOOD PART NUMBERS BUT PARTS WILL HAVE TO SET THEM UP IN THE SYSTEM BEFORE YOU CAN ORDER ONE AND THEREFORE AN EXTENDED LEAD TIME MAY APPLY.

EETF103A PARTS

Effective Page 2 07/2004

PARTS BY PICTORIAL

FRONT VIEW

EETF103A PARTS


FRONT VIEW CONTINUED:

NOTE A LATER PRODUCTION RUN OF THE ATX31000 (WHITE ONLY) WAS PRODUCED USING A DIFFERENT CONTROL BOARD WITH TANK LEVEL SENSING RODS MOUNTED IN THE TANKS. IF ORDERING PARTS FOR THIS LATER WHITE MODEL, THE CONTROL BOARD IS PART NUMBER NOR940472, THE LEVEL SENSING RODS ARE PART NUMBER: NOR9474

NOTE THE FOLLOWING PARTS LISTED ON THIS PAGE ARE LISTED FOR REFERENCE ONLY AND WILL NOT BE NOTED IN THE EQUISERV PARTS SYSTEM UNTIL A TECHNICIAN HAS ORDERED ONE. ORDERING ONE OF THE PARTS LISTED BELOW WILL BE CONSIDERED A SPECIAL ORDER AND AN EXTENDED LEAD-TIME MAY APPLY.

DESCRIPTION PART NUMBER DESCRIPTION PART NUMBER

Top Sink NOR940572 Caster Wheel (No Brake) NOR942137 Console NOR940751 Caster Wheel (w/Brake) NOR942118 Service Door w/Label NOR940833 Chassis NOR940750

EETF103A PARTS


SPARE PARTS:

PART NUMBER DESCRIPTION COMMENTS

NOR942155 Shur-Flow Pump (130psi) ATF Pump

NOR940551 Shur-Flow Pump Fill PSX

NOR942130 Shur-Flow Pump Drain PSX

NOR940832 (SUN) NOR940853 (WHITE)

NOR940472 (later WHITE used with

Level Sensing rods [Level Sensing

Rods: NOR9474])

Control Panel w/ Circuit Board

EETF103A PARTS



NOR940789 Wiring Harness

NOR940830 Battery Cable Assembly

NOR940843 Pressure Switch

NOR940838 NOR940839 NOR940840

Solenoid Valve

Old ~ Size 8, Qty 2 New ~ Size 8, Qty 1

New ~ Size 10, Qty 1

EETF103A PARTS



NOR940841 NOR940842

Coil w/ Spade Connector

Size 8 Size 10

NOR940796 Canister Filter

NOR940552 In-Line Filter

NOR942150 Used Fluid Screen

NOR942118 Locking Caster With Brake

EETF103A PARTS



NOR942137 Caster No Brake

NOR940781 90º Elbow Fitting ATF Pump (both sides)

NOR942140 90º Elbow Fitting PSX Drain Pump

NOR940197

NOR940782

Brass Flare Fitting

90º Elbow Fitting Bottom of Tanks

NOR940774 Elbow Fitting Bottom of Sensor Tubes

EETF103A PARTS


ADAPTER HOSES

Standard Hoses PART NUMBER DESCRIPTION COMMENTS

-

Green- 5/8”-18 [F] NOR941801

Hose #51 (Mates with #52)

SAE 45° Flare - Swivel Chrysler (1993 & Newer)

Green- 5/8”-18 [M] NOR941802

Hose #52 (Mates with #51) SAE 45° Flare

Chrysler

Blue- 5/8”-18 [M]

NOR941803 Hose #53

(Mates with #57) SAE 45° Flare - Swivel

(General Motors with 3/8" Tube Diameter Lines - All

Years)

Black- 3/8” Dia Hose [F]

NOR941805 Hose #55

(Mates with Step Fitting) Open End Hose w/Clamp

(Import - 1987 & Newer)

Blue- 5/8”-18 [F]

NOR941807 Hose #57

(Mates with #53) SAE 45° Inverted

(General Motors with 3/8” Tube Diameter Lines -

1997 and Newer)

Black- 1/2” Dia Hose [F]

NOR941809 Hose #59


(Import)

Black- 11/16”-18 [M]

NOR941808 Hose #58 SAE 90° Inverted

(BMW O-Ring Adapter- 1987 & Newer)

Black 5/16” Dia Hose [F]

NOR941813 Hose #63


(Import)

Green- 1/4”-18 [M]

NOR941815 Hose #65

(Mates with #75) NPTF

(Jeep Cherokee 1980-1986)

Red- 1/2”-20 [F]

NOR941816 Hose #66

(Mates with #67) SAE 45° Inverted

(Chrysler, Ford Aerostar, Jaguar, Mercedes,&

Cadillac-1985 and Newer) * Needs Ford Slide Tool

940140 for Aerostar / Windstar

Red- 1/2”-20 [M]

NOR941817 Hose #67

(Mates with #66) SAE 45°

(Chrysler and Ford)

Red- 5/8”-18 [M]

NOR941818 Hose #68

(Mates with #69) SAE Inverted - Swivel

(Ford With Large Nut Adapter - 1980 & Newer)

Red- 5/8”-18 [F]

NOR941819 Hose #69

(Mates with #68) SAE Inverted

(Ford)

Blue- 1/2”-20 [M]

NOR941820 Hose #70

(Mates with #71) SAE 90° Inverted - Swivel

(General Motors with 5/16" Tube Diameter

Lines - All Years)

Blue- 1/2”-20 [F] NOR941821


SAE Inverted (General Motors)

EETF103A PARTS


Red- 1/2”-20 [F]

NOR941822 Hose #72

(Mates with #73) SAE Inverted

(Ford)

Red- 1/2”-20 [M]

NOR941823 Hose #73

(Mates with #72) SAE 90° Inverted - Swivel

(Ford 5/16" Small / Long Nut Adapter - 1980 and

Newer)

Green- M14 x 1.5 [F]

NOR941825 Hose #75

(Mates with #65) Swivel O-ring

(Jeep Cherokee, Ford Escort - 1980-1986)

Red- M14 [F]

NOR940874 Hose #78

(Mates with #79) Banjo Fitting

Jeep Cherokee, Ford Escort - 1980-1986

Red- M14 x 1.5 [M]

NOR940875 Hose #79

(Mates with #78) Bolt w/2 washers

Ford Escort – 1994 and Newer

Black- ¼” [M]

NOR941828 Hose #80

(Mates with #81) Universal Bump Fitting

Import

Black- ¼” Hose [F]

NOR941829 Hose #81

(Mates with #80) Open end hose clamp

Import

Black- 5/16” [M]

NOR941830 Hose #82


Infiniti, Lexus, and BMW - 1980 and Newer

Black- 3/8” [M]

NOR941831 Hose #83


Toyota, Nissan, Honda, Ford and Chrysler - 1975 and Newer

Black- ½” [M]

NOR941832 Hose #84


Toyota, Nissan and Honda - 1980 and Newer

Green- 9/16” – 18 [M]

NOR941835 Hose #87

(Mates with #88) JIC 37° Flare - Inverted

Dodge Durango/Dakota - All Years

Green- 9/16” – 18 [F]

NOR941836 Hose #88

(Mates with #87) JIC 37° Flare – Inverted

Dodge Durango/Dakota - All Years

Black- ¾” – 16 [M]

NOR941841 Hose #89

(Mates with #90) SAE O-Ring

Chevy DuraMax w/Allison Transmission – 2001 & Newer

Black- ¾” – 16 [F]

NOR941842 Hose #90

(Mates with #89) SAE O-Ring Adapter

Chevy DuraMax w/Allison Transmission – 2001 & Newer

¾” – 18 [M]

NOR940888 Hose #124

(Mates with #142) 90° Inverted SAE45 Swivel

Ford Torqueshift /250SD / 550SD / Econoline / Excursion

¾” – 18 [F] NOR940398


Inverted SAE 45°Straight

Ford Torqueshift /250SD / 550SD / Econoline / Excursion

NOR942165 Step Fitting

EETF103A PARTS


ALLISON HOSES – Optional PART NUMBER DESCRIPTION COMMENTS

Black- ¾” – 16 [M]

NOR941844 Hose #134


MD3060, MD3066, & MD3560 Series

Black- ¾” – 16 [F]

NOR941845 Hose #135


MD3060, MD3066, & MD3560 Series

Black- ¾” – 16 [M]

NOR941846 Hose #136


1000, 2000 & 3000 Series

Black- ¾” – 16 [F]

NOR941847 Hose #137


1000, 2000 & 3000 Series

Black- ¾” – 16 [F]

NOR941848 Hose #138


HD4060 & HD4560 Series

Black- ¾” – 16 [M]

NOR941849 Hose #139


HD4060 & HD4560 Series

Black- ¾” – 16 [F]

NOR941850 Hose #140


AT545 Series

Black- ¾” – 16 [M]

NOR941851 Hose #141


AT545 Series

12” Tube with Air Nipple

NOR940837 Tube, Mates with PSX Service Hoses All Vehicles

Adapter Fittings NOR940328 Adapter, ½”

NOR940329 Adapter, 3/8”

NOR940334 Adapter, 5/16”

NOR942162 Quick Disconnect Tool

NOR942163 Adapter, GM

NOR940769 Nipple, Female

(Master Connector)

NOR940831 Nipple, Male

(Master Connector)

EETF103A PARTS


INTERNAL FITTINGS AND HOSES

PSX Drain

(To Sensors on Board)

New ATF Tank Used ATF Tank

ATFPump

Filter

To Vehicle(RED)

From Vehicle(BLACK) Filter

PSX Fill

PressureSwitch

Power Steering Reservoir

FilterPSX Fill Pump

PSX DrainPump

S2

12 3

S1

PressureSide 1Manifold

4 5

67

8

910

1112

1314

15

16

17

NOTE COMMON FITTINGS ARE GENERALLY PURCHASED LOCALLY AND SPECIAL FITTINGS RARELY NEED REPLACEMENT. FOR THAT REASON COMMON AND SPECIAL FITTINGS LISTED ON THIS PAGE MAY NOT BE IN STOCK UNTIL THE FIRST ORDER BY A TECHNICIAN.

ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1a Fitting, Elbow NOR940241 9 Hose, PS out 1 NOR940795 1b Washer NOR501149 10 Hose, S NOR940980 1c Nut, Bulkhead NOR940242 11 Hose, PS in 1 NOR940861 2 Hose, F NOR940979 12 Fitting, Elbow See Page 7 3 Hose, t NOR940978 13 Fitting, Elbow See Page 7 4 Hose, P NOR940797 14 Hose, PS in 2 NOR940863 5 Hose, PS out 3 NOR940862 15 Hose, New Tank NOR940981 6 Fitting, Elbow NOR940189 16 Hose, Used Tank NOR940982 7 Connector, Barb Elbow NOR940559 17 Fitting, Elbow NOR940195 8 Hose, PS out 2 NOR940863 NS Fitting, Sensor Tube NOR940774

EETF103A PARTS


PARTS IN ALPHABETICAL ORDER DESCRIPTION PART NUMBER COMMENTS Adapter, ½” NOR940328 See page 10 Adapter, 3/8” NOR940329 See page 10 Adapter, 5/16” NOR940334 See page 10 Adapter, GM NOR942163 See page 10 Adapter, Step Fitting NOR942165 See page 9 Cable Assembly, Battery NOR940830 See page 3 Cap, Tank NOR942113 See page 3 Caster Wheels, w/Locks NOR942118 See page 3 Caster Wheels, w/o Locks NOR942137 See page 3 Chassis NOR940750 See page 3 Connector, Barb Elbow NOR940559 See page 11 Console NOR940751 See page 3 Control Panel Assembly (SUN, see comments)

NOR940832 See page 3, for use with Sun Branded units

Control Panel Assembly (WHITE, see comments) NOR940853 See page 3, for use with capillary tubes

Control Panel Assembly (WHITE, see comments)

NOR940472 See page 3, for use with Level Sensor Rods

Filter, Canister NOR940796 See page 6 Filter, Inline NOR940552 See page 6 Fitting, 90º Elbow NOR940781 See page 7, ATF Pump (both sides) Fitting, 90º Elbow NOR942140 See page 7, PSX Drain Pump Fitting, 90º Elbow NOR940782 See page 7, bottom of tanks Fitting, Brass Flange NOR940197 See page 7 Fitting, Elbow NOR940241 See page 11 Fitting, Elbow NOR940189 See page 11 Fitting, Elbow NOR940195 See page 11 Fitting, Elbow NOR940774 Fitting on Bottom of Sensor Tubes Hose #124 (Mates with #142) 90° Inverted SAE45 Swivel

NOR940888 See page 9

Hose #134 (Mates with #135) SAE O-Ring














EETF103A PARTS


DESCRIPTION PART NUMBER COMMENTS Hose #141 (Mates with #140) SAE O-Ring


Hose #142 (Mates with #124) Inverted SAE 45°Straight

NOR940398 See Page 9

Hose #51 (Mates with #52) SAE 45° Flare - Swivel


Hose #52 (Mates with #51) SAE 45° Flare


Hose #53 (Mates with #57) SAE 45° Flare - Swivel


Hose #55 (Mates with Step Fitting) Open End Hose w/Clamp


Hose #57 (Mates with #53) SAE 45° Inverted


Hose #58 SAE 90° Inverted NOR941808 See page 8





Hose #65 (Mates with #75) NPTF


Hose #66 (Mates with #67) SAE 45° Inverted


Hose #67 (Mates with #66) SAE 45°


Hose #68 (Mates with #69) SAE Inverted - Swivel


Hose #69 (Mates with #68) SAE Inverted


Hose #70 (Mates with #71) SAE 90° Inverted - Swivel






Hose #73 (Mates with #72) SAE 90° Inverted - Swivel


EETF103A PARTS


DESCRIPTION PART NUMBER COMMENTS Hose #75 (Mates with #65) Swivel O-ring


Hose #78 (Mates with #79) Banjo Fitting


Hose #79 (Mates with #78) Bolt w/2 washers


Hose #80 (Mates with #81) Universal Bump Fitting


Hose #81 (Mates with #80) Open end hose clamp








Hose #87 (Mates with #88) JIC 37° Flare - Inverted


Hose #88 (Mates with #87) JIC 37° Flare – Inverted




Hose #90 (Mates with #89) SAE O-Ring Adapter


Hose, F NOR940979 See page 11 Hose, New Tank NOR940981 See page 11 Hose, P NOR940797 See page 11 Hose, PS in 1 NOR940861 See page 11 Hose, PS in 2 NOR940863 See page 11 Hose, PS out 1 NOR940795 See page 11 Hose, PS out 2 NOR940863 See page 11 Hose, PS out 3 NOR940862 See page 11 Hose, S NOR940980 See page 11 Hose, Service, black, ATF NOR940785 See page 3 Hose, Service, black, PSX NOR940787 See page 2 Hose, Service, red, ATF NOR940786 See page 3 Hose, Service, red, PSX NOR940788 See page 2 Hose, t NOR940978 See page 11 Hose, Used Tank NOR940982 See page 11 Magnet NOR940667 See page 2 Nipple, Female (Master Connector) NOR940769 See page 10

Nipple, Male (Master Connector) NOR940831 See page 10

Nut, Bulkhead NOR940242 See page 11 Panel, Service Door, w/label NOR940833 See page 3

EETF103A PARTS


DESCRIPTION PART NUMBER COMMENTS Pendant Assembly NOR940834 See page 2 Pump, ATF NOR942155 See page 4 Pump, PSX Fill NOR940551 See page 4 Pump, PSX, Drain NOR942130 See page 4 Quick Disconnect Tool NOR942162 See page 10 Screen, Used Fluid NOR942150 See page 6 Sensors, Level, Rod NOR9474 See page 3, used in tanks of later production

runs Sink, top NOR940572 See page 3 Solenoid Valve, new, size 10 NOR940840 See page 5 Solenoid Valve, new, size 8 NOR940839 See page 5 Solenoid Valve, old, size 8 NOR940838 See page 5 Solenoid, Coil, size 10 NOR940842 See page 6 Solenoid, Coil, size 8 NOR940841 See page 6 Switch, Pendant NOR940668 See page 2 Switch, Pressure, 5 PSI NOR940843 See page 5 Tank, New Fluid NOR940573 See page 3 Tank, Used Fluid NOR940574 See page 2 Tube, Mates with PSX Service Hoses NOR940837 See page 10 Washer NOR501149 See page 11 Wiring Harness NOR940789 See page 5

EETF103A PARTS


PARTS IN NUMERICAL ORDER PART NUMBER DESCRIPTION COMMENTS NOR501149 Washer See page 11 NOR940189 Fitting, Elbow See page 11 NOR940195 Fitting, Elbow See page 11 NOR940197 Fitting, Brass Flange See page 7 NOR940241 Fitting, Elbow See page 11 NOR940242 Nut, Bulkhead See page 11 NOR940328 Adapter, ½” See page 10 NOR940329 Adapter, 3/8” See page 10 NOR940334 Adapter, 5/16” See page 10 NOR940398 Hose #142

(Mates with #124) Inverted SAE 45°Straight

See Page 9

NOR940472 Control Panel Assembly (WHITE, see comments)

See page 3, for use with Level Sensor Rods

NOR940551 Pump, PSX Fill See page 4 NOR940552 Filter, Inline See page 6 NOR940559 Connector, Barb Elbow See page 11 NOR940572 Sink, top See page 3 NOR940573 Tank, New Fluid See page 3 NOR940574 Tank, Used Fluid See page 2 NOR940667 Magnet See page 2 NOR940668 Switch, Pendant See page 2 NOR940750 Chassis See page 3 NOR940751 Console See page 3

NOR940769 Nipple, Female (Master Connector)

See page 10

NOR940774 Fitting, Elbow See Page 7, Fittings on Sensor Tubes NOR940781 Fitting, 90º Elbow See page 7, ATF Pump (both sides) NOR940782 Fitting, 90º Elbow See page 7, bottom of tanks NOR940785 Hose, Service, black, ATF See page 3 NOR940786 Hose, Service, red, ATF See page 3 NOR940787 Hose, Service, black, PSX See page 2 NOR940788 Hose, Service, red, PSX See page 2 NOR940789 Wiring Harness See page 5 NOR940795 Hose, PS out 1 See page 11 NOR940796 Filter, Canister See page 6 NOR940977 Hose, P See page 11 NOR940830 Cable Assembly, Battery See page 3

NOR940831 Nipple, Male (Master Connector)

See page 10

NOR940832 Control Panel Assembly (SUN, see comments)

See page 3, for use with Sun Branded units

NOR940833 Panel, Service Door, w/label See page 3 NOR940834 Pendant Assembly See page 2 NOR940837 Tube, Mates with PSX Service Hoses See page 10 NOR940838 Solenoid Valve, old, size 8 See page 5 NOR940839 Solenoid Valve, new, size 8 See page 5 NOR940840 Solenoid Valve, new, size 10 See page 5 NOR940841 Solenoid, Coil, size 8 See page 6 NOR940842 Solenoid, Coil, size 10 See page 6 NOR940843 Switch, Pressure, 5 PSI See page 5

NOR940853 Control Panel Assembly (WHITE, see comments) See page 3, for use with capillary tubes

NOR940861 Hose, PS in 1 See page 11

EETF103A PARTS


PART NUMBER DESCRIPTION COMMENTS NOR940862 Hose, PS out 3 See page 11 NOR940863 Hose, PS out 2 See page 11 NOR940863 Hose, PS in 2 See page 11

NOR940874 Hose #78 (Mates with #79) Banjo Fitting

See page 9

NOR940875 Hose #79 (Mates with #78) Bolt w/2 washers

See page 9

NOR940888 Hose #124 (Mates with #142) 90° Inverted SAE45 Swivel

See Page 9

NOR940978 Hose, t See page 11 NOR940979 Hose, F See page 11 NOR940980 Hose, S See page 11 NOR940981 Hose, New Tank See page 11 NOR940982 Hose, Used Tank See page 11

NOR941801 Hose #51 (Mates with #52) SAE 45° Flare - Swivel

See page 8

NOR941802 Hose #52 (Mates with #51) SAE 45° Flare

See page 8

NOR941803 Hose #53 (Mates with #57) SAE 45° Flare - Swivel

See page 8

NOR941805 Hose #55 (Mates with Step Fitting) Open End Hose w/Clamp

See page 8

NOR941807 Hose #57 (Mates with #53) SAE 45° Inverted

See page 8

NOR941808 Hose #58 SAE 90° Inverted

See page 8


See page 8


See page 8

NOR941815 Hose #65 (Mates with #75) NPTF

See page 8

NOR941816 Hose #66 (Mates with #67) SAE 45° Inverted

See page 8

NOR941817 Hose #67 (Mates with #66) SAE 45°

See page 8

NOR941818 Hose #68 (Mates with #69) SAE Inverted - Swivel

See page 8

NOR941819 Hose #69 (Mates with #68) SAE Inverted

See page 8

EETF103A PARTS



NOR941820 Hose #70 (Mates with #71) SAE 90° Inverted - Swivel

See page 8


See page 8


See page 9

NOR941823 Hose #73 (Mates with #72) SAE 90° Inverted - Swivel

See page 9

NOR941825 Hose #75 (Mates with #65) Swivel O-ring

See page 9

NOR941828 Hose #80 (Mates with #81) Universal Bump Fitting

See page 9

NOR941829 Hose #81 (Mates with #80) Open end hose clamp

See page 9


See page 9


See page 9


See page 9

NOR941835 Hose #87 (Mates with #88) JIC 37° Flare - Inverted

See page 9

NOR941836 Hose #88 (Mates with #87) JIC 37° Flare – Inverted

See page 9

NOR941841 Hose #89 (Mates with #90) SAE O-Ring

See page 9

NOR941842 Hose #90 (Mates with #89) SAE O-Ring Adapter

See page 9


See page 10


See page 10


See page 10


See page 10


See page 10

EETF103A PARTS




See page 10


See page 10


See page 10

NOR942113 Cap, Tank See page 3 NOR942118 Caster Wheels, w/Locks See page 3 NOR942130 Pump, PSX, Drain See page 4 NOR942137 Caster Wheels, w/o Locks See page 3 NOR942140 Fitting, 90º Elbow See page 7, PSX Drain Pump NOR942150 Screen, Used Fluid See page 6 NOR942155 Pump, ATF See page 4 NOR942162 Quick Disconnect Tool See page 10 NOR942163 Adapter, GM See page 10 NOR942165 Adapter, Step Fitting See page 9 NOR9474 Sensors, Level, Rod See page 3, used in tanks of later production

runs

EETF103A PARTS


355 EXCHANGE AVE CONWAY, ARKANSAS 72032

TEETF103A3 Rev. E (07/2004) 2004 EquiServ Printed in U.S.A.

parts reference manual - snap-on

Documents