motor craft ford oils
DESCRIPTION
Information about Ford Motocraft Oils.What oil should use in what verhicle and where.Multigrade ... Synthetic ..... ATF .... and so on.TRANSCRIPT
| 1 |
Table of ContentsPhone Directory 2
Truckload Program 3
MSDS Information 5
Environmental Web Sites 7
Motor Oil 8
Transmission Fluid 15
Transaxle Fluid 20
Greases 23
Steering Fluid 27
A/C & Engine Cooling Products 28
Brake & Engine Performance Products 32
Collision & Body Repair 36
Exterior and Interior Vehicle Cleaners 40
Hand Care Products 47
Paint 50
Sealers & Adhesives 52
Quick Reference Charts- Verification Tests Required for the API Certification Mark (Starburst) & API SM- Oil-Quick Reference Oil Applications and Crankcase Capacities Chart- Axle Lubricants - Quick Reference Lubricant Application and Capacities Chart- Automatic Transmission Fluid Chart- Manual Transmission Fluid Chart - Ethylene Glycol-based Engine Coolant Protection Chart- Refrigerant Charge Capacities In Ounces- Refrigerant Oil Capacities In Fluid oz / cc- Service Coolant Usage Chart- 2004 - 2008 Interior Trim Parts — Plastic Types - Paint Charts- TSB Reference Chart
585962646566676869717291
Chek-Chart Lubrication Recommendation Guide 97
Index 163
| 2 |
Phone Directory
Ordering Information
Service Chemicals can be ordered for direct ship delivery via D.O.E.S. II or through your local Ford Authorized Distributor (FAD).
Parts Ordering Assistance: Parts and Service Page on FMC Dealer Web Site
To locate your local FAD on-line go to http://www.fmcdealer.dealerconnection.com and select:
Parts & Service FAD locator Your State
Service Chemical Direct Ship Distributors Customer Assistance
ConocoPhillips (800) 858-5576
Excelda Manufacturing (800) 550-4062
Other Contact Information
Material Safety Data Sheets (MSDSes) (800) 448-2063
Dealer Business Assistance Center (800) 962-3746
Poison Control (800) 959-3673
Online Service Chemical Catalog
For the on-line Service Chemical Catalog go to http://www.fmcdealer.dealerconnection.com and at the Brand Tab select:
Parts Information Chemicals & Lubricants Center Chemicals & Lubricants Catalog
Note: Information in this catalog is updated continually and the latest information can be found on www.motorcraft.com.
To continue to provide superior quality, Motorcraft reserves the right to change the composition of its products without notice.
Effective October 2006.
| 3 |
Truckload Ordering Assistance Ford Truckload Customer Service RepresentativeCustomer Service DepartmentExcelda ManufacturingPhone: (800) 550-4062 Fax: (800) 984-6874
Ordering InformationFADS- Order on-line at the MC Distributor website http://web.mcdistributor.dealerconnection.com - Select “Parts Information” - Select “Truckload Ordering Program”- Complete the order form that is found on the back of
this page and fax to Ford Truckload Customer Service Representative of Excelda at (800) 984-6874
Dealers- Complete the order form that is found on the back of
this page and fax to Ford Truckload Customer Service Representative of Excelda at (800) 984-6874
Receive an 18% discount off of your coolant purchase when you place a combined minimum order of 20 pallets from the items below. You may mix-and-match pallet product types but only coolants qualify for the 18% discount.
Part Number Description Unit Pack Pallet Size
ZC-32-CUltra Clear Windshield Washer Concentrate
Size: 55 Gallon Drum1 Drum 4 Unit Pack(s)
PM-1-CHigh Performance DOT3 Brake Fluid
Size: 12 fl oz Bottle1 Bottle
1296 Unit Pack(s)
18% Coolant Discount! VC-3
Specialty Orange Engine Coolant with Bitterant Size: 1 Gallon Bottle
1 Bottle 216 Unit Pack(s)
18% Coolant Discount! VC-5
Motorcraft Premium Engine Coolant with Bitterant Size: 1 Gallon Bottle
1 Bottle 192 Unit Pack(s)
18% Coolant Discount! VC-7-B
Motorcraft Premium Gold Engine Coolant with Bitterant Size: 1 Gallon Bottle
1 Bottle 192 Unit Pack(s)
XT-5-DMMERCON® V Automatic Transmission Fluid
Size: 55 Gallon Drum1 Drum 4 Unit Pack(s)
XT-5-GMMERCON® V Automatic Transmission Fluid
Size: 1 Gallon Bottle6 Bottles 32 Unit Pack(s)
XT-5-QMMERCON® V Automatic Transmission Fluid
Size: 1 qt Bottle12 Bottles 56 Unit Pack(s)
18% Coolant Discount! VC-5-B
Motorcraft Premium Engine Coolant with Bitterant Size: 55 Gallon Drum
1 Drum 4 Unit Pack(s)
18% Coolant Discount! VC-7-D
Motorcraft Premium Gold Engine Coolant with Bitterant Size: 55 Gallon Drum
1 Drum 4 Unit Pack(s)
PM-4-ABrake Parts Cleaner Size: 15 oz Aerosol
1 Can1080 Unit Pack(s)
PM-4-BBrake Parts Cleaner Size: 15 oz Aerosol
1 Can1080 Unit Pack(s)
YN-21R-134a Refrigerant Size: 30 lb Cylinder
40 Cylinders 1 Unit Pack
Truckload Program
| 4 |
Chemical Bulk Order FormName
Email Address
Phone Number
Ford Authorized Dealer Name
FAD Number (PA Code)
Your Purchase Order Number Please Note: The Shipping Address will be taken from your FAD or Dealer record. NO DROP SHIPS ARE ALLOWED.
Part Number Description Unit Pack Pallet Size # of Pallets
ZC-32-C Ultra Clear Windshield Washer Concentrate Size: 55 Gallon Drum 1 Drum 4 Unit
Pack(s)
PM-1-C High Performance DOT3 Brake Fluid Size: 12 fl oz Bottle 1 Bottle 1296 Unit
Pack(s)
18% Coolant Discount! VC-3
Specialty Orange Engine Coolant with Bitterant Size: 1 Gallon Bottle 1 Bottle 216 Unit
Pack(s)
18% Coolant Discount! VC-5
Motorcraft Premium Engine Coolant with Bitterant Size: 1 Gallon Bottle 1 Bottle 192 Unit
Pack(s)
18% Coolant Discount! VC-7-B
Motorcraft Premium Gold Engine Coolant with Bitterant Size: 1 Gallon Bottle 1 Bottle 192 Unit
Pack(s)
XT-5-DM MERCON® V Automatic Transmission Fluid Size: 55 Gallon Drum 1 Drum 4 Unit
Pack(s)
XT-5-GM MERCON® V Automatic Transmission Fluid Size: 1 Gallon Bottle 6 Bottles 32 Unit
Pack(s)
XT-5-QM MERCON® V Automatic Transmission Fluid Size: 1 qt Bottle 12 Bottles 56 Unit
Pack(s)
18% Coolant Discount! VC-5-B
Motorcraft Premium Engine Coolant with Bitterant Size: 55 Gallon Drum 1 Drum 4 Unit
Pack(s)
18% Coolant Discount! VC-7-D
Motorcraft Premium Gold Engine Coolant with Bitterant Size: 55 Gallon Drum 1 Drum 4 Unit
Pack(s)
PM-4-A Brake Parts Cleaner Size: 15 oz Aerosol 1 Can 1080 Unit
Pack(s)
PM-4-B Brake Parts Cleaner Size: 15 oz Aerosol 1 Can 1080 Unit
Pack(s)
YN-21 R-134a Refrigerant Size: 30 lb Cylinder 40 Cylinders 1 Unit Pack
Total Pallets (minimum of 20)
Fax your completed order form to: (800) 984-6874 • Attention: Ford Truckload Customer Service Representative
Truckload Program (Cont.)
| 5 |
Four Options
INTERNET Dealer:Log on to www.fmcdealer.dealerconnection.com. Change the brand to Ford or Lincoln Mercury. Click on the Parts & Service tab, then click on Parts Product Line Information on the left, and then click on MSDS (Material Safety Data Sheets).Distributors:Log on to www.fmcdealer.dealerconnection.com. Change the brand to MCDistributor. Click on Parts Information, then Motorcraft Parts Information Center and MSDS Contact Information.
E-MAIL E-mail your request to [email protected]. Include information requested on page 6.
FAX Copy and complete the form on page 6. Fax the form to 1-800-466-3753 (24 hours a day).
PHONE Call toll-free 1-800-448-2063 and speak to a Ford MSDS Hotline representative (8am to 5pm EST Monday thru Friday).
Contact InformationIf you require MEDICAL EMERGENCY INFORMATION:
Contact: POISON CONTROL at 1-800-959-3673 F O R D
Available 24 hours a day
Note: Material Safety Data Sheets are NOT available from the above phone number.
If you require a MATERIAL SAFETY DATA SHEET (MSDS)for a Ford or Motorcraft chemical or lubricant:
2
3
4
1
Medical Information and Material Safety Data Sheet (MSDS)
- Please Use This Form to Fax in Request for Material Safety Data Sheets -
Your Name:
Your Company: Are you a: Dealer Distributor Other
Your Street Address:
Your City, State, Zip:
Your Phone Number:
Your Fax Number:
Your E-mail Address:
Your preferred method of receiving MSDS: E-mail Fax U.S. Mail
Please fax completed form to:
Ford MSDS Hotline1-800-466-3753
24 hours a day
Or mail completed form to:
Ford Motor CompanyP.O. Box 1899
Dearborn, MI 48121Attn: Ford MSDS Hotline
Or call the Ford MSDS Hotline:
Ford MSDS Hotline1-800-448-2063
8am to 5pm EST Monday thru Friday
Material Safety Data Sheet - Request Form
1. Product Name: ______________________________________________________________Part Number: ______________________________________________________________
Tox/FIR Number: ______________________________________________________________Container Size: ______________________________________________________________
2. Product Name: ______________________________________________________________Part Number: ______________________________________________________________
Tox/FIR Number: ______________________________________________________________Container Size: ______________________________________________________________
3. Product Name: ______________________________________________________________Part Number: ______________________________________________________________
Tox/FIR Number: ______________________________________________________________Container Size: ______________________________________________________________
4. Product Name: ______________________________________________________________Part Number: ______________________________________________________________
Tox/FIR Number: ______________________________________________________________Container Size: ______________________________________________________________
| 6 |
| 7 |
There are numerous regulations applicable to the manufacturers, distributors, importers, employers, and employees regarding chemical products. Below are some addresses to web sites that may contain helpful regulatory information pertaining to the chemical products purchased and used by you. Ford Motor Company does not maintain these sites. This page is intended for informational purposes only and specific compliance requirements should be discussed with your own legal counsel.
Occupational Safety and Health Administration (OSHA) Home Page http://www.osha.gov
OSHA Hazard Communication Programhttp://www.osha.gov/SLTC/hazardcommunications/index.html
Environmental Protection Agency Home Pagehttp://www.epa.gov
Hazardous Waste FAQ’shttp://www.epa.gov/epaoswer/osw/basifact.htm#whatissolidwaste
Hazardous Waste Generators http://www.epa.gov/epaoswer/osw/gen_trans/generate.htm
Hazardous Waste Transporters http://www.epa.gov/epaoswer/osw/gen_trans/transport.htm
Department of Transportation (DOT) Home Pagehttp://www.dot.gov
Shipping Hazardous Material in Commercehttp://hazmat.dot.gov/pubs/do_you_know_Final_cropped.pdf
California Volatile Organic Compounds (VOCs) - Consumer Productshttp://www.arb.ca.gov/consprod/consprod.htm
California VOC Consumer Products Regulationshttp://www.arb.ca.gov/consprod/regs/regs.htm
Consumer Products Enforcement Programhttp://www.arb.ca.gov/enf/consprod.htm
Hazardous Substances and articles regulations (Product Labeling Requirements)http://www.access.gpo.gov/nara/cfr/waisidx_00/16cfr1500_00.html
California Proposition 65http://www.oehha.ca.gov/prop65/background/p65plain.html
National Institute of Occupational Safety and Health Pocket Guide to Hazardous Chemicalshttp://www.cdc.gov/niosh/npg/npg.html
Code of Federal Regulationshttp://www.access.gpo.gov/nara/cfr/cfr-table-search.html#page1
OZONE Transport Commission http://www.otcair.orghttp://www.otcair.org/governmental.asp
Health, Safety, & Environmental Web Sites
| 8 |
Mot
or O
il
Motor Oils
SAE 5W-20 Premium Synthetic Blend Motor Oil
Note: SAE 5W-20 Premium Synthetic Blend Motor Oil is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager, an approved Motorcraft® Bulk Oil Distributor, or www.Motorcraft.com for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XO-5W20-QSP WSS-M2C930-A 1 Qt. 12 (Case Qty.) 173219
XO-5W20-5QSP WSS-M2C930-A 5 Qt. 4 (Case Qty.) 173219
XO-5W20-DSP WSS-M2C930-A 55 U.S. gal 1 173219
Features:
• Motorcraft® SAE 5W-20 Premium Synthetic Blend Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-20 Premium Synthetic Blend Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic/hydroprocessed base oils and specially designed performance additives, which help minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust and corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 5W-30 and 10W-30 motor oils
• Motorcraft® SAE 5W-20 Premium Synthetic Blend Motor Oil dramatically outperforms and outprotects conventional solvent-refi ned motor oils
• This oil has been thoroughly evaluated by Ford Motor Company and has performed fl awlessly in all dynamometer and vehicle durability tests
• Refer to the Motorcraft® SAE 5W-20 Premium Synthetic Blend Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
SAE 5W-20 Full Synthetic Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W20-QFS WSS-M2C930-A 1 Qt. 12 (Case Qty.) 173414
XO-5W20-DFS WSS-M2C930-A 55 U.S. gal 1 173414
Features:
• Motorcraft® SAE 5W-20 Full Synthetic Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-20 Full Synthetic Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic base oils that provide good high temperature and low temperature performance. It helps minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust and corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 5W-30 and 10W-30 motor oils
• Refer to the Motorcraft® SAE 5W-20 Full Synthetic Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 9 |
Motor O
il
Motor Oils
SAE 5W-30 Premium Synthetic Blend Motor Oil
Note: SAE 5W-30 Premium Synthetic Blend Motor Oil is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager, an approved Motorcraft® Bulk Oil Distributor, or www.Motorcraft.com for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XO-5W30-QSP WSS-M2C929-A 1 Qt. 12 (Case Qty.) 173219
XO-5W30-5QSP WSS-M2C929-A 5 Qt. 4 (Case Qty.) 173219
XO-5W30-DSP WSS-M2C929-A 55 U.S. gal 1 173219
Features:
• Motorcraft® SAE 5W-30 Premium Synthetic Blend Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-30 Premium Synthetic Blend Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic/hydroprocessed base oils and specially designed performance additives, which help minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust and corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 10W-30 motor oils
• Motorcraft® SAE 5W-30 Premium Synthetic Blend Motor Oil dramatically outperforms and outprotects conventional solvent-refi ned motor oils
• This oil has been thoroughly evaluated by Ford Motor Company and has performed fl awlessly in all dynamometer and vehicle durability tests
• Refer to the Motorcraft® SAE 5W-30 Premium Synthetic Blend Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
Note: SAE 5W-30 Premium
SAE 5W-20 High Mileage Synthetic Blend Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W20-QHM WSS-M2C930-A 1 Qt. 12 (Case Qty.) 181150
Features:
• Motorcraft® SAE 5W-20 High Mileage Synthetic Blend Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. This oil has been specifi cally formulated for engines with over 75,000 miles. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-20 High Mileage Synthetic Blend Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic/hydroprocessed base oils and specially designed performance additives, which help reduce oil consumption and oil leaks, minimize engine deposits, protect against high-temperature oxidation, low-temperature gelling, rust, corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 5W-30 and 10W-30 motor oils
• Motorcraft® SAE 5W-20 High Mileage Synthetic Blend Motor Oil dramatically outperforms and outprotects conventional solvent-refi ned motor oils
• Refer to the Motorcraft® SAE 5W-20 High Mileage Synthetic Blend Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 10 |
Mot
or O
il
Motor Oils
SAE 5W-30 Full Synthetic Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W30-QFS WSS-M2C929-A 1 Qt. 12 (Case Qty.) 173414
XO-5W30-DFS WSS-M2C929-A 55 U.S. gal 1 173414
Features:
• Motorcraft® SAE 5W-30 Full Synthetic Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-30 Full Synthetic Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic base oils that provide good high temperature and low temperature performance. It helps minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust and corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 10W-30 motor oils
• Refer to the Motorcraft® SAE 5W-30 Full Synthetic Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
SAE 5W-30 High Mileage Synthetic Blend Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W30-QHM WSS-M2C929-A 1 Qt. 12 (Case Qty.) 181150
Features:
• Motorcraft® SAE 5W-30 High Mileage Synthetic Blend Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. This oil has been specifi cally formulated for engines with over 75,000 miles. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 5W-30 High Mileage Synthetic Blend Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic/hydroprocessed base oils and specially designed performance additives, which help reduce oil consumption and oil leaks, minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust, corrosion and foaming. The friction-reducing technology in this motor oil provides superior wear protection and energy-conserving characteristics, which result in signifi cant improvement in fuel economy when compared to SAE 10W-30 motor oils
• Motorcraft® SAE 5W-30 High Mileage Synthetic Blend Motor Oil dramatically outperforms and outprotects conventional solvent-refi ned motor oils
• Refer to the Motorcraft® SAE 5W-30 Premium Synthetic Blend Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 11 |
Motor O
il
Motor Oils
SAE 10W-30 Premium Synthetic Blend Motor Oil
Note: SAE 10W-30 Premium Synthetic Blend Motor Oil is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager, an approved Motorcraft® Bulk Oil Distributor, or www.Motorcraft.com for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XO-10W30-QSP GF-4 1 Qt. 12 (Case Qty.) 173219
XO-10W30-DSP GF-4 55 U.S. gal 1 173219
Features:
• Motorcraft® SAE 10W-30 Premium Synthetic Blend Motor Oil is a premium-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company where use of this viscosity grade is recommended. It is API Certifi ed for gasoline engine service ILSAC GF-4 and meets API SM/Energy Conserving
• Motorcraft® SAE 10W-30 Premium Synthetic Blend Motor Oil is manufactured with high-viscosity index, premium-quality, synthetic/hydroprocessed base oils and specially designed performance additives, which help minimize engine deposits and wear, protect against high-temperature oxidation, low-temperature gelling, rust and corrosion and foaming
• Motorcraft® SAE 10W-30 Premium Synthetic Blend Motor Oil is recommended for use in current and older domestic and import passenger cars, SUV’s, light-duty trucks, minivans and with normally aspirated, turbocharged and supercharged gasoline engines
• Refer to the Motorcraft® SAE 10W-30 Premium Synthetic Blend Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
Note: SAE 10W-30
SAE 10W-40 Premium Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-10W40-QP API Service SM 1 Qt. 12 (Case Qty.) 173219
XO-10W40-DP API Service SM 55 U.S. gal 1 173219
Features:
• Motorcraft® SAE 10W-40 Premium Motor Oil is a high-quality passenger car motor oil designed, engineered and recommended by Ford Motor Company where use of this viscosity grade is recommended. It meets API Service Category SM
• Refer to the Motorcraft® SAE 10W-40 Premium Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 12 |
Mot
or O
il
AP
I SERVICE CJ-4/S
M
Motor Oils
SAE 5W-50 Full Synthetic Motor Oil Part
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W50-QGT WSS-M2C931-B 1 Qt. 12 (Case Qty.) 178040
Features:
• Motorcraft® SAE 5W-50 Full Synthetic Motor Oil is designed, engineered and recommended by Ford Motor Company for use in the Ford GT and Shelby GT500. It meets API Service Category SM
• It is manufactured with high viscosity index, premium-quality synthetic base oils and performance additives to provide wear and oxidation protection under severe operating conditions. It is resistant to deposit formation, including supercharged and turbocharged applications. It provides quick fl ow to engine parts during start-up and lubricates effectively over a wide temperature range
• This oil is compatible with other synthetic and petroleum based formulations
SAE 15W-40 Super Duty Diesel Motor Oil
Note: SAE 15W-40 Super Duty Motor Oil is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager or an approved Motorcraft® Bulk Oil Distributor for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XO-15W40-QSD WSS-M2C171-E 1 Qt. 12 (Case Qty.) 178870
XO-15W40-5QSD WSS-M2C171-E 5 Qt. 4 (Case Qty.) 178870
XO-15W40-DSD WSS-M2C171-E 55 U.S. gal 1 178870
Features:
• Motorcraft® SAE 15W-40 Super Duty Motor Oil is a high-quality light and heavy-duty diesel engine oil designed, engineered, and recommended by Ford Motor Company. It is particularly recommended for use in Ford vehicles equipped with Power Stroke engines as in truck, bus, construction and other heavy-duty diesel engine applications. It meets API Service Category CJ-4, required for use in diesel engines designed to meet 2007 on-highway exhaust emission standards and requiring ultralow sulfur diesel fuel. Do not use in gasoline engines equipped with catalysts
• Motorcraft® SAE 15W-40 Super Duty Motor Oil is a high-quality diesel engine oil formulated with premium hydroprocessed base oils and unique additive technology. It satisfi es the warranty requirements of Ford Motor Company as well as most other domestic and import diesel engine manufacturers. It meets the requirements of International, Cummins CES 20081, Volvo VDS-4, Mack EO-O Premium Plus, Detroit Diesel 93K218 and Caterpillar ECF-3.
• Motorcraft® SAE 15W-40 Super Duty Motor Oil is designed for new generation, low emission diesel engines providing excellent soot control, protection against wear, deposits, rust and corrosion, foaming, sludge formation, high temperature oxidation and thickening, as well as protecting exhaust aftertreatment systems such as particulate fi lters. It also provides excellent performance in older-generation diesel engines operating on high-sulfur fuel.
• Motorcraft® SAE 15W-40 Super Duty Motor Oil can be used in older engines where the manufacturer recommended API Categories CD, CF-4, CG-4, CH-4, CI-4 and CI-4plus.
• Motorcraft® SAE 15W-40 Super Duty Motor Oil is suitable for powershift applications requiring Allison C-4 fl uid
• Refer to the Motorcraft® SAE 15W-40 Super Duty Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 13 |
Motor O
il
Motor Oils
SAE 5W-40 Full Synthetic Diesel Motor Oil Part
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-5W40-5QSD WSS-M2C171-E 5 Qt. 4 (Case Qty.) 180934
XO-5W40-DSD WSS-M2C171-E 55 U.S. gal 1 180934
Features:
• Motorcraft SAE 5W-40 Full Synthetic Diesel Motor Oil is a high-performance light and heavy-duty diesel engine oil designed, engineered, and recommended by Ford Motor Company. It is particularly recommended for use in Ford vehicles equipped with Power Stroke engines as in truck, bus, construction and other heavy-duty diesel engine applications. It meets API Service Category CJ-4, required for use in diesel engines designed to meet 2007 on-highway exhaust emission standards and requiring ultralow sulfur diesel fuel. Do not use in gasoline engines equipped with catalysts.
• Motorcraft® SAE 5W-40 Full Synthetic Diesel Motor Oil is a high-quality diesel engine oil formulated with synthetic base oils and unique additive technology. It satisfi es the warranty requirements of Ford Motor Company as well as most other domestic and import diesel engine manufacturers.
• Motorcraft® SAE 5W-40 Full Synthetic Diesel Motor Oil is designed for new generation, low emission diesel engines providing excellent soot control, protection against wear, deposits, rust and corrosion, foaming, sludge formation, high temperature oxidation and thickening, as well as protecting exhaust aftertreatment systems such as particulate fi lters. It also provides excellent performance in older-generation diesel engines operating on high-sulfur fuel.
• Motorcraft® SAE 5W-40 Full Synthetic Diesel Motor Oil can be used in older engines where the manufacturer recommended API Categories CD, CF-4, CG-4, CH-4, CI-4 and CI-4plus.
• Motorcraft® SAE 5W-40 Full Synthetic Diesel Motor Oil is recommended for use in Powerstroke® diesel engines over a wide temperature range, from -20°F (-29°C) to over 100°F (38°C).
• Refer to the SAE 5W-40 Full Synthetic Diesel Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063.
SAE 10W-30 Super Duty Diesel Motor Oil
Note: SAE 10W-30 Super Duty Diesel Motor Oil is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager, an approved Motorcraft® Bulk Oil Distributor, or www.Motorcraft.com for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XO-10W30-QSD WSS-M2C171-E 1 Qt. 12 (Case Qty.) 178870
XO-10W30-DSD WSS-M2C171-E 55 U.S. gal 1 178870
Features:
• Motorcraft® SAE 10W-30 Super Duty Motor Oil is a high-quality light- and heavy-duty diesel engine oil designed, engineered and recommended by Ford Motor Company. It is particularly recommended for use in Ford vehicles equipped with Power Stroke® engines, as well as, in other diesel engine applications. It meets API Service Category CJ-4, required for use in diesel engines designed to meet 2007 on-highway exhaust emission standards and requiring ultralow sulfur diesel fuel. Do not use in gasoline engines equipped with catalysts
• Motorcraft® SAE 10W-30 Super Duty Motor Oil is a high-quality diesel engine oil formulated with premium hydroprocessed base oils and unique additive technology. It satisfi es the warranty requirements of Ford Motor Company, as well as, most other domestic and import diesel engine manufacturers. It meets the requirements of International and Caterpillar ECF-3.
• Motorcraft® SAE 10W-30 Super Duty Motor Oil is designed for new generation, low emission diesel engines providing excellent soot control, protection against wear, deposits, rust and corrosion, foaming, sludge formation, high temperature oxidation and thickening, as well as protecting exhaust aftertreatment systems such as particulate fi lters. It also provides excellent performance in older-generation diesel engines operating on high-sulfur fuel
• Motorcraft® SAE 10W-30 Super Duty Motor Oil can be used in older engines where the manufacturer recommended API Categories CD, CF-4, CG-4, CH-4, CI-4 and CI-4plus.
• Motorcraft® SAE 10W-30 Super Duty Motor Oil is recommended for use in 7.3L and 6.0L Powerstroke® diesel engines down to -10°F (-23°C) and 6.4L Powerstroke® diesel engines down to 0°F (-18°C).
• Refer to the Motorcraft® SAE 10W-30 Super Duty Motor Oil specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
Note: SAE 10W-30
API SERVICE CJ-4/S
M
| 14 |
Mot
or O
il
Motor Oils
SAE 30 Super Duty Diesel Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XO-30-QSD API CF/CF-2 1 Qt. 12 (Case Qty.) 168395
Features:
• Motorcraft® SAE 30 Super Duty Motor Oil is a high-quality light- and heavy-duty diesel engine oil designed, engineered and recommended by Ford Motor Company. It is recommended for use in Ford vehicles equipped with diesel engines prior to 1995 model year
• Motorcraft® SAE 30 Super Duty Motor Oil is formulated for engines requiring a high-quality single weight oil and operated with an engine block heater or in outside temperatures no lower than 10°F (-12°C)
• Refer to the Motorcraft® SAE 30 Super Duty Motor Oil specifi cation sheet at www.Motorcraft.com and www.FMCDealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
SAE 0W-30 Super All Season Motor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
CXO-0W30-DAS WSS-M2C171-D 1 Liter 12 (Case Qty.) 167658
CXO-0W30-LAS12 WSS-M2C171-D 55 U.S. gal 1 167658
Features:
• Motorcraft® SAE 0W-30 Super All Season Synthetic Motor Oil is a high-quality diesel motor oil designed, engineered and recommended by Ford Motor Company, meeting warranty requirements. It is particularly recommended for Power Stroke® applications. It meets API Service Category CI-4/SM. Do not use in gasoline engines equipped with catalysts
• Motorcraft® Super All Season is manufactured with premium-quality synthetic base oil and unique additive technology. Because of its low viscosity it is particularly suited to operation in extremely low ambient temperatures. It provides excellent soot control, as well as, protecting against wear, deposit formation, rust and corrosion, foaming, and high-temperature oil oxidation and thickening
• It is formulated for today’s low emission, electronically controlled, normally aspirated and turbocharged diesel engines; while providing excellent performance in older generation diesel engines
API
SERVICE CF/CF2
SAE30
| 15 |
Transmission
Fluid
Transmission Fluid
MERCON® V Automatic Transmission and Power Steering Fluid
Note: MERCON® V Automatic Transmission Fluid is available in bulk quantities at substantial savings. Use of bulk oil products is environmentally proactive. Contact your FCSD Aftermarket Account Manager, an approved Motorcraft® Bulk Oil Distributor, or www.Motorcraft.com for details.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XT-5-QMC MERCON® V 1 Qt. 12 (Case Qty.) 173581
XT-5-QM MERCON® V 1 Qt. 12 (Case Qty.) 173581
XT-5-5QM MERCON® V 5 Qt. 4 (Case Qty.) 173581
XT-5-GM MERCON® V 1 U.S. gal 6 (Case Qty.) 173581
XT-5-DMC MERCON® V 55 U.S. gal 1 173581
XT-5-DM MERCON® V 55 U.S. gal 1 173581
Features:
• Motorcraft® MERCON® V is a premium-quality automatic transmission fl uid designed, engineered and recommended by Ford Motor Company for use in Ford, Lincoln and Mercury vehicles that require either MERCON® V or MERCON® type fl uid. This product also provides excellent performance in electronically controlled automatic transmissions.
• Motorcraft® MERCON® V is manufactured with high-viscosity index, premium-quality, hydroprocessed base oils and specially designed performance additives, which provide excellent shifting characteristics at high and low ambient temperatures, excellent thermal and oxidation resistance and good low temperature fl uidity. It provides wear protection and inhibits the formation of gum, sludge, lacquer and foam. It also provides protection against rust and corrosion. It is dyed red for ease of leak detection.
• Do not use in applications where MERCON® SP, MERCON® LV, Continuously Variable Chain Type Transmission Fluid, Motorcraft® Premium Automatic Transmission Fluid, FNR5 Automatic Transmission Fluid or Type F Automatic Transmission Fluid is recommended, or in transfer cases.
• Motorcraft® MERCON® V is suitable for use as a hydraulic oil in a wide variety of industrial applications that call for an ISO 46 or SAE 20W viscosity grade hydraulic oil
• Refer to the Motorcraft® MERCON® V specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
MERCON® SP Automatic Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-6-QSP MERCON® SP 1 Qt. 12 (Case Qty.) 175325
XT-6-DSP MERCON® SP 55 U.S. gal 1 175325
Features:
• Motorcraft® MERCON® SP is a premium-quality fl uid designed, engineered and recommended by Ford Motor Company specifi cally for use in Ford, Lincoln and Mercury vehicles that require MERCON® SP type fl uid. This product also provides excellent performance in electronically controlled automatic transmissions. Check Owner’s Guide or Workshop Manual for correct applications
• Motorcraft® MERCON® SP is manufactured with premium base oils and specially designed performance additives, which provide excellent shifting characteristics at high and low ambient temperatures, excellent thermal and oxidation resistance. It provides wear protection and inhibits the formation of gum, sludge, lacquer and foam. It also provides protection against rust and corrosion. MERCON® SP is friction modifi ed for smooth transmission operation while guarding against transmission shudder
• Specifi cally designed for improved durability and torque handling capacity in TorqShift™ transmissions
• Do not use in transmissions requiring MERCON® V, MERCON® LV, Continously Variable Chain Type Transmission Fluid, Motorcraft® Premium Automatic Transmission Fluid, FNR5 Automatic Transmission Fluid, or Type F Fluid
• Refer to the Motorcraft® MERCON® SP specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 16 |
Tran
smis
sion
Fl
uid
Transmission Fluid
MERCON® LV Automatic Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-10-QLV MERCON® LV 1 Qt. 12 (Case Qty.) 179895
Features:
• Motorcraft® MERCON® LV is a premium-quality automatic transmission fl uid designed, engineered and recommended by Ford Motor Company for use in Ford, Lincoln and Mercury vehicles that require MERCON® LV type fl uid. This product also provides excellent performance in electronically controlled automatic transmissions. Check Owner Guide and transmission fl uid charts for application.
• Motorcraft® MERCON® LV is manufactured with high-viscosity index, premium-quality, hydroprocessed base oils and specially designed performance additives, which provide excellent shifting characteristics at high and low ambient temperatures and guards against transmission shudder. This fl uid has excellent thermal, oxidation and shear stability and good low temperature fl uidity. It provides wear protection and inhibits the formation of gum, sludge, lacquer and foam. It also prevents against rust and corrosion. It is dyed red for ease of leak detection.
• Do not use in applications where MERCON® V, MERCON® SP, Continuously Variable Chain Type Transmission Fluid, Motorcraft® Premium Automatic Transmission Fluid, FNR5 Automatic Transmission Fluid or Type F Automatic Transmission Fluid is recommended, or in transfer cases.
• Refer to the Motorcraft® MERCON® LV specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063.
Synthetic MERCON® Multi-Purpose Automatic Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-2-QSM ESR-M2C163-A2 1 Qt. 12 (Case Qty.) 154936
Features:
• Motorcraft® Synthetic MERCON® Multi-Purpose Automatic Transmission Fluid is a high-quality synthetic automatic transmission fl uid designed, engineered and recommended by Ford Motor Company. It was developed for use in the newer electronically controlled automatic transmissions found in most domestic and import automobiles, trucks, SUV’s, minivans and buses built after 1989.
• Motorcraft® Synthetic MERCON® Multi-Purpose Automatic Transmission Fluid is formulated with synthetic base stock and unique additive technology. It is specifi cally formulated to provide improved shifting characteristics at high and low ambient temperatures, excellent thermal and oxidation resistance, and good low temperature fl uidity. It provides wear protection and inhibits the formation of gum, sludge, lacquer, and foam. It also provides protection against rust and corrosion
• It is especially effective in applications where high temperatures are a concern. Due to its excellent thermal, oxidative, and shear stability, this fl uid is required in manual transmission applications such as Mustang with G1 manual transmissions and F/E-Series with TR 3650 and ZF S5-47 manual transmissions
• It also provides for improved performance and shift quality in very low ambient temperature
• Do not use in applications where MERCON® V, MERCON® LV, MERCON® SP, Continously Variable Chain Type Transmission Fluid, Motorcraft® Premium Automatic Transmission Fluid, FNR5 Automatic Transmission Fluid or Type F Automatic Transmission Fluid is recommended
• Refer to the Motorcraft® Synthetic MERCON® Multi-Purpose Automatic Transmission Fluid specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
• While supplies last
| 17 |
Transmission
Fluid
Transmission Fluid
Premium Automatic Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-8-QAW WSS-M2C924-A 1 Qt. 12 (Case Qty.) 171914
Features:
• Motorcraft® Premium Automatic Transmission Fluid is a premium-quality fl uid designed, engineered and recommended by Ford Motor Company for use in the AW F21 6-speed transmission
• It has unique frictional characteristics specifi c to this transmission
• It has excellent high temperature thermal and oxidative stability, and protects against transmission shudder
• Do not use for applications recommending MERCON® LV, MERCON® V, MERCON® SP, Type F fl uid, Continously Variable Chain Type Transmission Fluid or FNR5 Automatic Transmission Fluid
Continuously Variable Chain Type Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-7-QCFT WSS-M2C933-A 1 Qt. 12 (Case Qty.) 171931
Features:
• Motorcraft® Continuously Variable Chain Type Transmission Fluid is a premium-quality fl uid designed, engineered and recommended by Ford Motor Company for use in the CFT-30 transmission
• It provides optimal frictional characteristics for this type of transmission. It provides good low temperature fl uidity, reduces wear and protects against sludge and varnish build-up
• This fl uid should be used ONLY in the CFT-30 transmission
FNR5 Automatic Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell PackMSDS / FIR
Number
XT-9-QMM5 Mazda M 5 1 Qt. 1 12 (Case Qty.) 175125
Features:
• Motorcraft® FNR5 Automatic Transmission Fluid is designed, engineered and recommended by Ford Motor Company for use in the FNR5 5-speed transmission
• It is manufactured with high-quality, high viscosity index base oils and specially designed performance additives, providing optimal shift quality over a wide range of conditions, including at low temperatures. Provides protection from wear and corrosion
• Use ONLY in FNR5 transmissions
• For use in the Fusion and Milan vehicles
Note: Use of other fl uids in the CFT30 transmission may cause internal damage. It is dyed blue for ease of leak detection
| 18 |
Tran
smis
sion
Fl
uid
Transmission Fluid
SAE 75W-90 API GL-4 Gear OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell PackMSDS / FIR
Number
XT-75W90-QGLWSS-M2C203-A1
and GL-4 1 Qt. 1 12 (Case Qty.) 175527
Features:
• For use in Manual Transmissions in Probe, Escape, Fusion and Milan
• Meets Warranty Requirements
Full Synthetic Manual Transmission FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-M5-QS WSD-M2C200-C 1 Qt. 12 (Case Qty.) 175246
Features:
• Motorcraft® Full Synthetic Manual Transmission Fluid is a premium-quality SAE 75W-90 gear oil designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is particularly recommended for MTX-75 and IB5 transmissions, and is also recommended for older transmissions including rear wheel drive that recommend GL-3 and GL-4 type gear oils
• Motorcraft® Full Synthetic Manual Transmission Fluid is manufactured with synthetic base oils and performance additives providing improved gear shifting at all ambient temperatures. Its wear protection extends the life of synchronizers and bearings
• Due to its excellent thermal, oxidative and shear stability, this fl uid meets Ford’s fi ll-for-life requirements. Reduced friction and optimal lubrication reduces operating temperatures, increases component life and improves effi ciency
Type F Automatic Transmission Fluid and Power Steering FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XT-1-QF ESW-M2C33-F 1 Qt. 12 (Case Qty.) 148095
Features:
• Motorcraft® ATF Type F is designed, engineered and recommended by Ford Motor Company. It is a high-static friction fl uid developed for Ford automatic transmissions manufactured during the 1970’s and earlier. The special frictional properties of Motorcraft® ATF Type F ensure proper shifting in Ford transmissions that require a fl uid meeting ESW-M2C33-F. It is also recommended for power steering systems in a wide variety of Ford Vehicles calling for a Type F fl uid, built prior to Model Years 1996-1998. Check Owner Guide for proper application
• Motorcraft® ATF Type F resists foaming and protects against rust, corrosion, wear and deposits. Its low viscosity makes it suitable not only for Ford power steering units, but also as a hydrostatic drive fl uid for many farm implements and certain industrial equipment applications
• Motorcraft® ATF Type F should not be used in newer transmissions requiring MERCON® LV, MERCON® V or MERCON® SP
• Refer to the Motorcraft® ATF Type F specifi cation sheet at www.motorcraft.com and www.fmcdealer.dealerconnection.com for additional information. For MSDS information call 1-800-448-2063
| 19 |
Transmission
Fluid
Transmission Fluid
SAE 75W-140 Synthetic Rear Axle Lubricant
Note: For a complete drain and refi ll, some limited-slip axles require addition of Friction Modifi er, Part Number XL-3. Refer to Workshop Manual or Owner’s Guide.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XY-75W140-QLWSL-M2C192-A
and GL-51 Qt. 12 (Case Qty.) 048396
Features:
• Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant is an excellent multi-purpose extreme pressure lubricant designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is recommended for conventional and limited-slip differentials of passenger cars, light trucks, vans and buses that operated under mild to severe service conditions
• Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant is manufactured using high-quality synthetic base oils and performance additives to provide improved high-temperature thermal and oxidative stability. It helps to reduce operating temperatures. It has enhanced wear protection for hypoid gears, excellent shear stability and protects from rust and corrosion. This product meets all fi ll-for-life requirements of Ford Motor Company
SAE 80W-90 Premium Rear Axle Lubricant
Note: For a complete drain and refi ll, some limited-slip axles require addition of Friction Modifi er, Part Number XL-3. Refer to Workshop Manual or Owner’s Guide.
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
XY-80W90-QLWSP-M2C197-A,
GL-5, MT-11 Qt. 12 (Case Qty.) 173576
XY-80W90-KLWSP-M2C197-A,
GL-5, MT-1120 Lbs.
(16 U.S. gal)1 173576
Features:
• Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant is an excellent multi-purpose extreme pressure lubricant designed, engineered and recommended by Ford Motor Company meeting warranty requirements. It is recommended for conventional and limited-slip differentials of passenger cars, light trucks, vans and buses that operate under mild to severe service conditions
• Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant is manufactured using premium quality hydroprocessed base oils and performance additives to provide thermal and oxidative stability and protection against gear wear, rust and corrosion. This product meets the requirements of MIL-PRF-2105E & Mack GO-J and is approved by Ford Engineering for use in passenger cars and light-duty trucks which originally specifi ed SAE 90
| 20 |
Tran
saxl
e Fl
uid
Transaxle Fluid
SAE 75W-90 Premium Synthetic Transaxle LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell PackMSDS / FIR
Number
XT-75W90-QGT GL-5 1 Qt. 1 12 (Case Qty.) 171872
Features:
• Motorcraft® SAE 75W-90 Premium Synthetic Transaxle Lubricant is a premium-quality lubricant designed, engineered and recommended by Ford Motor Company for use in the Ford GT transaxle
• It provides excellent gear change and synchromesh performance even at low temperatures
• It provides complete lubrications for reduced wear
• This fl uid is compatible with other synthetic and conventional mineral oil axle lubes
SAE 75W-90 Synthetic Transaxle LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell PackMSDS / FIR
Number
XT-75W90-QLSDANA ES-PM-
M2013 and GL-51 Qt. 1 12 (Case Qty.) 173036
Features:
• Motorcraft® 75W-90 Synthetic Axle Lubricant is a premium-quality gear lubricant designed, engineered and recommend by Ford Motor Company meeting warranty requirements and specifi cally recommended for use in the limited-slip differential of the DANA Model 80 rear axle to eliminate chatter
• Motorcraft® 75W-90 Synthetic Axle Lubricant is manufactured with high-quality synthetic base oil and unique performance additives. It is specifi cally formulated for improved high-temperature thermal and oxidative stability. This synthetic formula reduces operating temperatures. It has enhanced wear protection for hypoid gears, excellent shear stability and protection from rust and corrosion. This product meets all fi ll-for-life requirements of Ford Motor Company
Note: For a complete drain and fi ll, some limited-slip axles require addition of Friction Modifi er, Part Number XL-3. Refer to the Workshop Manual or Owner’s Guide.
Additive Friction Modifi erPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-3 EST-M2C118-A 4 fl uid oz 1 12 135454 97-8-1198-5a-2798-11-1004-16-1402-10-105-10-105-20-205-23-306-2-1606-4-406-5-1606-12-1107-22-8
Features:
• For use on certain limited-slip differentials to reduce chatter and hypoid gear noise levels
• Use according to Owner Guide recommendations
• Tapered neck applicator for easy use
| 21 |
Transaxle Fluid
Transaxle Fluid
Hypoid Gear Oil SAE 90Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XY-90-GL ESW-M2C105-A 1 U.S. gal 1 — 179773 N/A
Features:
• Protects axle gears against scoring, corrosion and abrasion
• For use in Dana M50/M60 Front axles (through Model Year 2002), M60SF,M70FF, M273 limited slip differentials and STEMCO front wheel seals/bearings
• Reduces chatter in Dana M60SF limited slip rear axles
SAE 75W-90 Specialty Power Transfer Unit FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XY-75W90-PTU GL-5 500 mL (1.05 pt) 1 2 174980 06-4-1106-9-6
Features:
• SAE 75W-90 Specialty Power Transfer Unit Fluid is designed, engineered and recommended by Ford Motor Company meeting warranty requirements
• It is manufactured with premium quality synthetic base oils and performance additives to provide excellent anti-wear protection and thermal and oxidative stability. Provides good performance at both high and low ambient temperatures
• Recommended for use only in the Power Transfer Unit in Five Hundred, Freestyle and Montego
XY-75W90-PTU
Features:
•
•
•
High Contrast Hypoid Gear Marking CompoundPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-14 N/A 3 oz 1 4 175211 05-20-205-23-3
Features:
• Specially formulated to be non-damaging to axle bearings
• Compatible with all Ford/Motorcraft hypoid gear lubricants
• Brush-on application
| 22 |
Tran
saxl
e Fl
uid
Transaxle Fluid
Transfer Case FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
MSDS / FIRNumber
XL-12 ESP-M2C166-H 1 Qt. 12 (Case Qty.) 179944
Features:
• Transfer Case Fluid is designed, engineered and recommended by Ford Motor Company for use in transfer cases driving front axles on Ford, Lincoln and Mercury AWD/4X4 vehicles. Do not use in AWD vehicles equipped with a transaxle.
• Motorcraft® Transfer Case Fluid is manufactured with high-viscosity index, premium-quality, hydroprocessed base oils and specially designed performance additives to provide increased protection against deposit, rust, corrosion, and wear and maintains proper viscosity at extreme temperatures.
• Do not use in automatic transmissions, manual transmissions, power take off units (PTU) or fl uid couplers.
| 23 |
Greases
Greases
Constant Velocity Joint Grease (High Temp)Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-5 WSS-M1C258-A1 90 g 1 — 158358/173532 N/A
Features:
• High-temperature grease required for service of constant velocity joints
• Designed to reduce shudder
High Contrast Hypoid Gear Marking CompoundPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-14 N/A 3 oz 1 4 175211 05-20-205-23-3
Features:
• Specially formulated to be non-damaging to axle bearings
• Compatible with all Ford/Motorcraft hypoid gear lubricants
• Brush-on application
High Temperature 4X4 Front Axle and Wheel Bearing GreasePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-11 ESA-M1C198-A 14 oz 1 — 023824 98-14-801-3-201-11-4Features:
• Required lubricant for 4X4 Ford Light Truck front axle spindle bearings, wheel bearings and U-joints
• Lithium complex, high-temperature grease
• 572°F (300°C) dropping point - will not run off at high temperatures
• NLGI grade #2
Electrical GreasePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-12 WSB-M1C239-A 3 oz 1 4 123929 97-24-1098-24-600-6-303-1-304-14-904-24-1206-9-306-21-12
Features:
• Lubricates and protects electrical connectors
• Provides a non-corrosive fi lm for electrical switches and contacts
• Protects connector metals from oxidation and corrosion
| 24 |
Gre
ases
Greases
Mini-Vent Window LubePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-10 ESF-M2C113-A 4 fl uid oz 1 4 153958 N/A
Features:
• Durable silicone-based lubricant specially formulated for reducing sliding efforts on mini-vent windows
High Temperature Nickel Anti-Seize LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-2 ESE-M12A4-A 8 oz 1 — 029083/174332 98-5a-598-1-405-19-1206-9-1006-15-207-16-107-21-408-4-7
Features:
• Provides high temperature lubrication up to 2552°F (1400°C)
• Prevents seizing and galling of metal parts
• Guards against rust and corrosion caused by chemicals and weathering
• For use when replacing oxygen sensors
Multi-Purpose GreasePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-5 ESB-M1C93-B 11.5 oz aerosol 1 12 164527 97-15-1403-23-104-2-305-16-7
XG-4 ESB-M1C93-B 4 oz tube 1 — 139377
Features:
• Outstanding general-purpose grease for use on metal surfaces such as door hinges, seat tracks and deck lid hinges
• Continues to lubricate long after application
• Not affected by wide temperature operating ranges
• Amber color
| 25 |
Greases
PTFE LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
D2AZ-19590-A ESB-M1C111-A 1 lb 1 — 001860/173865 97-13-2198-17-2100-25-804-1-604-26-605-26-10
XG-8 ESB-M1C111-B 3 oz tube 1 — 001860/173865
Features:
• For use with driveshaft slip yokes; especially where grunt-type noise is experienced
• Useful in eliminating squeaks between plastic parts
• For use on speedometer cables; stops squeaking, sticking and binding
Greases
Penetrating and Lock LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-1 N/A 12 oz aerosol 1 12 168705 02-17-12
Features:
• Displaces moisture
• Provides exceptional rust penetration
• Protects metal parts against corrosion
• Helps free rusty/seized parts
Premium Long-Life GreasePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-1-C ESA-M1C75-B 14 oz 1 40 046977 98-16-298-17-2198-21-701-3-202-19-107-24-1
XG-1-K ESA-M1C75-B 120 lb 1 — 046977
Features:
• Use on chassis, ball joints, U-joints, wheel bearings, brake self adjusting screws and steering gear
• Resists washout and component wear under extreme pressure
• Fights rust, abrasion and high-temperature breakdown
• Contains high-density polyethylene and molybdenum disulfi de
• 275°F (135°C) upper temperature limit; 350°F (177°C) dropping point
• NLGI Grade #2
| 26 |
Gre
ases
Silicone Spray LubricantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-6 ESR-M13P4-A12.25 oz aerosol
1 12 177167 98-11-800-26-304-22-1006-20-407-23-408-1-208-2-608-4-10
Features:
• Lubricates window channels and rubber hood strips
• Helps prevent battery terminal corrosion
• High silicone content
• Lubricates and helps prolong the life of rubber parts
Synthetic Supercharger FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XL-4 ESE-M99C115-A 4 fl uid oz 1 — 042166 N/A
Features:
• Required for top-off of fl uid level in superchargers on: - 89-96 3.8L Thunderbird SC - 99-03 5.4L Lightning F-150 - 02-03 5.4L Harley Davidson F-150 - 03-04 4.6L Mustang Cobra - 05-06 5.4L GT - 07-08 5.4L Shelby GT 500
• Tapered neck applicator bottle for easy use
Silicone Brake Caliper Grease and Dielectric CompoundPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-3-A ESE-M1C171-A 3 oz 1 12 014471 98-5a-1998-5a-2298-5a-2398-5a-2998-5-498-19-298-23-699-5-799-8-1000-6-991-22-403-7-203-22-604-21-604-22-13
05-10-2105-16-206-5-1406-7-406-7-607-9-807-11-207-11-807-12-407-13-507-14-407-19-307-22-107-26-8
Features:
Brake Application
• Lubricates disc brake caliper slide pins
• High resistance to water and heat
• Compatible with EPDM rubberIgnition System Applications
• Provides high voltage seal to secondary ignition wires
• Suppresses voltage leaks by coating inner distributor cap surface
Greases
Silicone Heat Transfer CompoundPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-6 ESF-M99G123-A 60 g 1 — 020289 N/A
Features:
• Aids heat transfer between fi tted components such as temperature sensors
• Approved for use in the Electric Ranger
| 27 |
SteeringFluid
Steering Fluid
Premium Power Steering FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
F7AZ-3F823-BA(DOESII)
MERCON®
12 fl uid oz 1 48 173533 98-5a-2204-24-10
XL-9(FAD)
MERCON®
12 fl uid oz 1 — 173533
Features:
• Recommended for all power steering systems which require MERCON® fl uid
Note: All power steering systems built after 1998 require the use of MERCON® fl uid.
While Supplies
Last
| 28 |
A/C
& E
ngin
e C
oolin
g P
rodu
cts
PAG Refrigerant Compressor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
YN-12-D WSH-M1C231-B 7 fl uid oz 1 12 173919 97-15-598-12-502-20-804-24-607-18-307-25-107-26-3
Features:
• Required in the majority of non-electric vehicle A/C systems equipped with R-134a refrigerant
• Use to replace compressor oil lost by leaks or by replacement of an A/C system part
• Use only where specifi ed. Use when YN-12-A, YN-12-B, YN-12-C, or YN-12-D is specifi ed
• For O.E. and Retrofi t A/C Systems equipped with R-134a refrigerant
A/C Cooling Coil CoatingPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
YN-29 N/A 4 fl uid oz 1 2 166422 03-5-6
Features:
• Combination acrylic resin and powerful antimicrobial formula eliminates A/C musty odor-causing conditions
• For use in all Ford, Lincoln and Mercury vehicles
• One application provides protection for 2 - 3 years
• Use with Rotunda Sure Shot Pressure Sprayer, Part Number 164-R4700, or Rotunda Flexible Applicator Tool Kit, Part Number 258-00004
• Refer to the applicable Workshop Manual or TSB for application instructions
A/C System Flushing SolventPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
YN-23 N/A 1 U.S. gal 1 4 173628 02-20-807-18-307-25-107-26-3
Features:
• New formulation has signifi cantly improved fl ushing performance and reduced odor
• Use to purge the A/C system in the event of contamination
• Use with Rotunda A/C Flusher, Part Number 219-00022
• Carefully follow all label and equipment directions
A/C & Engine Cooling Products
| 29 |
A/C
& E
ngine C
ooling P
roducts
Diesel Cooling System AdditivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-8 ESN-M99B169-A 16 fl uid oz 1 12 028397 N/A
Features:
• Use only where specifi ed
- Use in all heavy-duty, diesel engine cooling systems equipped with green-colored Motorcraft® Premium Engine Coolant meeting Ford Specifi cation ESE-M97B44-A
- Use in the cooling systems of heavy-duty trucks equipped with the Caterpillar 3126E engine equipped with yellow-colored Motorcraft® Premium Gold Engine Coolant meeting Ford Specifi cation WSS-M97B51-A1
• Designed to replace additives depleted between cooling changeouts
A/C & Engine Cooling Products
Cooling System Stop Leak PelletsPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-6 WSS-M99B37-B62 - 10 g
pellets per blister card
1 24 174711 N/A
Features:
• Seals and prevents minor leaks in the entire cooling system
• New formulation - does not produce coolant discoloration
• Safe for use with all automotive coolant types
• Use 1-2 pellets for cooling systems up to 8L (8.45 qts.) and 2-4 pellets for larger cooling systems
• Add to the cooling system once a year and at every coolant changeout
Note: Do not use this product in the Ford Edge or Lincoln MKX
R-134a RefrigerantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
YN-19 WSH-M17B19-A30 lb non-refi llable
cylinder1 — 045167 00-5-1
02-20-805-14-1106-14-307-18-307-25-107-26-3
YN-21 WSH-M17B19-A30 lb non-refi llable
cylinder40 — 045167
Features:
• Meets the A/C system recharge or replacement needs of model vehicles equipped with R-134a refrigerant
• Each cylinder is checked for compliance with Ford specifi cations for purity and for correct fi ll weight prior to shipment
| 30 |
A/C
& E
ngin
e C
oolin
g P
rodu
cts
Premium Cooling System FlushPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-1 ESR-M14P7-A 22 fl uid oz 1 12 166625 07-8-1007-23-1408-3-708-6-6
Features:
• New fast fl ush formulation - compatible with all coolant types and leaves no petroleum odor or residue
• Use to fl ush engine cooling system whenever coolant is changed or repairs are required
• Non-acid formulation does not require a neutralizer. Safe for aluminum water pump
Premium Engine Coolant with Bittering AgentPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-5 ESE-M97B44-A 1 U.S. gal 1 6 164315 98-8-601-11-601-23-6VC-5-B ESE-M97B44-A 55 U.S. gal 1 — 164315
Features:
• Green-colored, conventional, ethylene glycol-based, coolant formulation for use in gasoline and diesel engines
• Approved for engines with aluminum radiators and/or aluminum heads as well as conventional engines
• Provides year-round antifreeze, anti-boil and corrosion protection
• A 50/50 mixture of coolant and distilled water provides freeze protection down to -34°F (-36°C) and boiling protection up to 265°F (129°C)
• Use only where specifi ed. Do not use this coolant in cooling systems originally equipped with any orange-colored, extended-life coolant such as Motorcraft® Specialty Orange Engine Coolant, meeting Ford Specifi cation WSS-M97B44-D, or with the yellow-colored, longer-life coolant, Motorcraft® Premium Gold Engine Coolant, meeting Ford Specifi cation WSS-M97B51-A1
Heavy Truck PAG Refrigerant Compressor OilPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
YN-24 WST-M1C231-B2 7 fl uid oz 1 — 168868 N/A
Features:
• For use in heavy trucks equipped with Sanden compressors where SP-20 or SP-15 is specifi ed
• High viscosity PAG lubricant
• Use only where specifi ed - do not use as a substitute for YN-22 or YN-12-(A, B, C, or D)
A/C & Engine Cooling Products
| 31 |
A/C
& E
ngine C
ooling P
roducts
Specialty Orange Engine Coolant with Bittering AgentPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-3 WSS-M97B44-D 1 U.S. gal 1 6 165322 01-23-6
Features:
• Orange-colored, ethylene glycol-based, extended-life coolant
• Use only where specifi ed.
• Provides year-round antifreeze, anti-boil and corrosion protection
• A 50/50 mixture of coolant and distilled water provides freeze protection down to -34°F (-36°C) and boiling protection up to 265°F (129°C)
• Do not use this product in systems originally equipped with any green-colored, conventional engine coolant such as Motorcraft® Premium Engine Coolant, meeting Ford Specifi cation ESE-M97B44-A, or with the yellow-colored, longer-life Motorcraft® Premium Gold Engine Coolant, meeting Ford Specifi cation WSS-M97B51-A1
• Meets the requirements of WSS-M97B44-D, GM 6277M and ASTM D 3306-00a
• Compatible with DEX-COOL® engine coolant
Premium Gold Engine Coolant with Bittering AgentPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
VC-7-B WSS-M97B51-A1 1 U.S. gal 1 6 161635 01-23-602-3-402-23-708-6-6
VC-7-D WSS-M97B51-A1 55 U.S. gal 1 — 161635
Features:
• Yellow-colored, longer-life, ethylene glycol-based engine coolant for use in gasoline and diesel engines
• Provides year-round antifreeze, anti-boil and corrosion protection
• A 50/50 mixture of coolant and distilled water provides freeze protection down to -34°F (-36°C) and boiling protection up to 265°F (129°C)
• Use only where specifi ed. Do not use this product in systems originally equipped with any green-colored, conventional engine coolant such as Motorcraft® Premium Engine Coolant, meeting Ford Specifi cation ESE-M97B44-A (see usage chart for exceptions), or with any orange-colored, extended-life engine coolant such as Motorcraft® Specialty Orange Engine Coolant, meeting Ford Specifi cation WSS-M97B44-D
A/C & Engine Cooling Products
| 32 |
Brak
e &
Engi
ne
Per
form
ance
P
rodu
cts
Carburetor Tune-Up CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-2 N/A 18 oz aerosol 1 12 159419 01-19-704-19-206-18-307-16-107-21-407-24-808-1-908-4-7
PM-3 N/A 16 fl uid oz 1 12 159220
Features:
• Remove gums and other deposits from air/fuel induction systems of gasoline engines
• Free sticking valves and sluggish compression rings
• Purge excessive deposits from the combustion chambers
• Ideal for spray cleaning of varnished steel or cast iron parts normally hand cleaned on bench operations
• Not for use in diesel engines
Anti-Gel & Performance Improver (ULSD Compliant)Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-23-A N/A 20 fl uid oz 1 12 178695 07-22-508-1-508-2-7PM-23-ASU N/A 20 fl uid oz 1 6 178695
PM-23-GAL N/A 20 fl uid oz 1 4 178695
Note: This ultra-low sulfur formulation can be used in engines required to meet 2007 emissions requirements (e.g., Ford’s 6.4 L diesel engine) and is backward compatible as well (i.e., can be used in Ford’s 6.9 L, 7.3 L, and 6.0 L diesel engines).
Features:
• Ultra Low Sulfur Diesel (ULSD) Compliant
• Specially formulated for diesel engines to combat the effects of poor-quality diesel fuel
• Helps prevent gelling of diesel fuel in lines, fi lters, and tanks
• Improves starting ability in cold weather
• Smooths engine operation
• Improves fuel economy
• Adds lubricity to fuel to reduce engine wear
Brake & Engine Performance Products
| 33 |
Brake & Engine P
erformance
Products
Gas StabilizerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-16 ESE-M99C112-A 8 fl uid oz 1 12 037894 N/A
Features:
• Add to gasoline when vehicle will not be driven for 60 days or more
• Keeps fuel fresh - prevents premature oxidation
• Neutralizes harmful metallic catalysts
Cetane Booster & Performance Improver (ULSD Compliant)Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-22-A N/A 20 fl uid oz 1 12 178699 07-22-508-1-508-2-7PM-22-ASU N/A 20 fl uid oz 1 6 178699
PM-22-GAL N/A 20 fl uid oz 1 4 178699
Note: This ultra-low sulfur formulation can be used in engines required to meet 2007 emissions requirements (e.g., Ford’s 6.4 L diesel engine) and is backward compatible as well (i.e., can be used in Ford’s 6.9 L, 7.3 L, and 6.0 L diesel engines).
Features:
• Ultra Low Sulfur Diesel (ULSD) Compliant
• Specially formulated for diesel engines to combat the effects of poor-quality diesel fuel
• Boosts the Cetane Rating (fuel ignitability) of diesel fuel for improved starting performance
• Increases power
• Smooths engine operation
• Improves fuel economy
• Adds lubricity to fuel to reduce engine wear
Brake & Engine Performance Products
Choke and Linkage CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-14 WSS-M14P10-B11 oz
aerosol1 12 168654 N/A
Features:
• Sprays away grease, sludge, gum and varnish from the throttle plates, throttle bodies and other induction system components
• Helps clean oil and dirt from choke, carburetor linkage and manifold heat controls
• Not for use in diesel engines
| 34 |
Brak
e &
Engi
ne
Per
form
ance
P
rodu
cts
Metal Brake Parts CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-4-A N/A13 oz
aerosol1 12 175874 99-5-4
02-21-104-26-705-4-705-9-1005-13-1005-14-805-22-1907-3-107-5-1507-12-407-13-907-14-408-4-7
PM-4-B N/A13 oz (368 g)
aerosol1 12 175847
Features:
• Spray away grease and oil from metal brake parts
• Fast cleaning - fast drying
• Environmentally Friendly - contains No Chlorinated Solvents or Chlorofl uorocarbon (CFC) propellants
• PM-4-A is a Special Low Volatile Organic Compound Formula
High Performance DOT 3 Motor Vehicle Brake FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-1-C WSS-M6C92-A 12 fl uid oz 1 12 174922 98-5a-5099-1-6PM-1-Q WSS-M6C92-A 12 fl uid oz 1 12 174922
Features:
• For vehicles with disc, drum or ABS
• Factory-fi ll formulation
• Minimum dry boiling point of 500 °F (260 °C)
• Meets DOT 3, SAE J1703 and FMVSS 116 specifi cation
Power Flush Injector FluidPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-5 N/A 8 fl uid oz 1 12 158039 03-18-303-20-605-6-1305-9-1
Features:
• For use with injector cleaning equipment
• Fast action-cleans dirty injectors in minutes
• Reduces deposit-related engine knock
• Do not add to fuel tank
Brake & Engine Performance Products
| 35 |
Brake & Engine P
erformance
Products
Premium Fuel Injector CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-6 ESE-M14P16-A 12 fl uid oz 1 12 167146 N/A
Features:
• Pour in fuel tank to clean dirty injectors while you drive
• High-strength formulation - usually cleans injectors with one treatment
• Reduces deposit-related engine knock
• Removes intake valve deposits
Pressurized Fuel Injector CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
CM-1001 ESE-M14P17-A 10 oz 1 — 045361 N/A
Features:
• Helps restore fuel system components to factory-specifi cation performance with just one treatment
• Cleans entire fuel injection system
• Removes deposits from gasoline engine fuel injectors, intake valves, combustion chambers and the fuel induction system
• Use only with Fuel Injector Cleaner Application Kits, CM-1000 (Ford and Lincoln Mercury EFI vehicles and 95% of domestic and import vehicles) or CM-1002 (All Ford, Lincoln, and Mercury vehicles)
• For professional use only
Silicone Brake Caliper Grease and Dielectric CompoundPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
XG-3-A ESE-M1C171-A 3 oz 1 12 014471 98-5a-1998-5a-2298-5a-2398-5a-2998-5-498-19-298-23-699-5-799-8-1000-6-991-22-403-7-203-22-604-21-604-22-13
05-10-2105-16-206-5-1406-7-406-7-607-9-807-11-207-11-807-12-407-13-507-14-407-19-307-22-107-26-8
Features:
Brake Application
• Lubricates disc brake caliper slide pins
• High resistance to water and heat
• Compatible with EPDM rubberIgnition System Applications
• Provides high voltage seal to secondary ignition wires
• Suppresses voltage leaks by coating inner distributor cap surface
Brake & Engine Performance Products
| 36 |
Col
lisio
n &
B
ody
Rep
air
Isopropanol Cleaning KitPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-4 N/A 1 kit 1 — 159277 01-18-201-22-403-18-405-6-407-18-7
Features:
• Kit contains: one, 1 fl uid oz bottle of isopropyl alcohol and one cotton rag
• Use for ABS or metal surface preparation prior to adhesive application
• Removes dirt, oil and grease from metal surfaces
• For industrial use only
• Available only while supplies last
Manual Dual Cartridge Applicator GunPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-10 N/A N/A 1 — N/A 02-17-904-8-2
Features:
• For use with 10.1 oz. (300 ml) and 7.6 oz. (225 ml) cartridges
• Pre-confi gured to dispense 10.1 oz. (300 ml) 1:1 cartridges
• Easy conversion to 2:1 7.6 oz. (225 ml) cartridges (parts included)
• Features tempered, built-in nozzle cutter for easy controlled custom bead sizing
• For use with Motorcraft® Roof Ditch Sealer (TA-15) and the structural foam found in kits TA-12 and 4W73-5B118-AA
Anti-Corrosion CoatingPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
High Temperature Coating PM-13-A
N/A 16 fl uid oz 1 4 166329 03-26-404-4-104-21-804-25-1704-26-1604-26-1705-1-105-12-705-20-306-15-1106-20-12
Features:
• Excellent long-lasting corrosion protection and mar resistance
• For service temperatures exceeding 180°F (82°C)
• Apply with brush, roller or spray
• Surface must be free of oil, dirt and other foreign material (see product sheets for cleaning requirements unique to each product)
• Apply at 2.5 mil fi lm thicknessApproximately 300 sq. ft / gallon at 2.5 mil fi lm thickness
Collision & Body Repair
| 37 |
Collision &
Body Repair
Metal Bonding AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-1 N/A 1.7 fl uid oz 1 — 156626/161171 01-18-201-19-604-17-304-18-1104-24-104-26-1604-26-17
Features:
• Easy to use formula creates uniform bondline thickness every time despite differences in clamping techniques
• No welding needed
• Replacement of OEM structural adhesives when specifi ed in service publications
• Door skin replacement as specifi ed on www.FMCDealer.com
• Tough modifi ed acrylic formula
• For bonding cold rolled steel, galvanized steel, aluminum and scuffed e-coat as specifi ed in service publications
• Built-in color indicator turns from beige to green when initial set has been achieved
• Use applicator gun Rotunda Part Number 501-040
Metal Surface PrepPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-31-A N/A 16 fl uid oz 1 4 162886 02-11-402-21-1303-6-205-10-1005-10-1306-21-1007-16-1608-3-7
Features:
• Cleans and degreases metal surfaces. Removes light RTV residue
• Use as surface prepration prior to applying RTV silicones
• Gel formula permits use on vertical surfaces and extended soaking for heavy residue
• Not for use on plastic
Note: As described in TSB 02-11-4, the product is designed to be used with Motorcraft® Silicone Gasket Remover, ZC-30
Plastic Bonding AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-9 N/A 1.7 fl uid oz 1 — 01-18-204-8-504-16-904-19-905-8-306-21-12
Features:
• A structural adhesive for bonding a variety of plastics to plastics and plastics to primed, painted or e-coated metals
• Fast setting at room temperature
• Easy to gun, non-sag formula
• Also great for general purpose bonding of trim components
• High strength structural urethane adhesive
• No VOC’s, 100% solids
• Use applicator gun Rotunda Part Number 501-040
Collision & Body Repair
| 38 |
Col
lisio
n &
B
ody
Rep
air
Pneumatic Dual Cartridge Applicator GunPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
M.SDS / FIRNumber
TSB
TA-11 N/A N/A 1 — N/A 02-17-904-8-2
Features:
• For fast and easy application of long beads from 10.1 oz (300 ml) and 7.6 oz (225 ml) cartridges
• Pre-confi gured to dispense 7.6 oz (225 ml) 2:1 cartridges
• Includes conversion kit to enable dispensing of 10.1 oz (300 ml) 1:1 cartridges
• For use with Motorcraft® Roof Ditch Sealer (TA-15) and the structural foam found in kits TA-12 and 4W73-5B118-AA
Features:
•
Premium UndercoatingPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-25-A N/A 12 oz aerosol 1 4 178960 N/A
PM-25-B N/A 1.9 pints 1 4 179110
Features:
• Provides sound deadening and underbody chip resistance
• Restores factory appearance to underbody repair areas
• Provides excellent new car protection
• May be applied over the PM-24 rust inhibitor products for outstanding corrosion protection
• Available Rotunda equipment for quart application connects directly to the bottle
Roof Ditch SealerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-15 N/A 10.1 fl uid oz 1 — 02-21-404-26-405-13-307-1-11
Features:
• Two tubes required for typical repair
• Excellent self-leveling capabilities
• Ideal for matching factory fl ow grade seams on: drip rails, trunks, core support to aprons, roof seams, quarter panels to rear decks and water leaks
• Can be used over acid etch, urethane and epoxy primers
• Paintable after 30 - 60 seconds
Collision & Body Repair
| 39 |
Collision &
Body Repair
Seam Sealer Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-2 N/A 10.3 fl uid oz 1 — 156144 01-18-201-19-602-17-404-18-1104-26-404-26-1607-14-6
Features:
• Fast-curing
• Permanently fl exible
• Excellent bond strength
• Paintable in 10 minutes
• Will not shrink, crack or peel
• Bonds to all primed or painted metals, and most automotive plastics
• Heavy bodied, non-sag formula
• Immediately bakeable
• Typical applications include: Duplicating factory look on: standing cosmetic seams, truck bed seams, tooled door skin seams, fl oor pans, core supports. Anywhere a non-sag, cosmetic seam sealer is required.
• Available in 10.3 oz. (305 ml) aluminum caulk tubes
Rust InhibitorPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-24-A N/A 12 oz aerosol 1 4 179154 N/A
PM-24-B N/A 1.9 pints 1 4 179098
Features:
• Provides excellent rust inhibition and protection
• For use on all body repairs to unibody structure, underbody and frame repair
• Will help maintain proper structural integrity for body repairs
• Provides excellent protection for new vehicles/add on sales
• Available Rotunda equipment allows for different application options, including high pressure fan and 360° fog coverage
Trim and Weatherstrip AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-14-A N/A 8 fl uid oz 1 6 162590 03-15-1204-9-505-21-14
Features:
• Excellent “multi-purpose” bond. A must for every shop
• Bonds many plastics, steel, aluminum, fabrics, wood, vinyl trim and many other vehicle component surfaces without heat or curing
• Resistant to gasoline, kerosene, anti-freeze and most other solvents as well as excellent resistance to water
• Will withstand vibration and extreme temperature changes
• Typical applications include the bonding and repairing of body side molding, emblems, trim, bumper impact strips, carpeting, door and trunk
Collision & Body Repair
| 40 |
Ext
erio
r and
In
terio
r Veh
icle
C
lean
ers
Exterior and Interior Vehicle Cleaners
Acid NeutralizerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-1-A N/A 1 U.S. gal 1 4 152625 04-9-6
Features:
• Neutralizes acids which may have been deposited on the paint surface during transportation and storage
• Removes waxes and hard water spots
• Excellent pre-wash for body shop - removes silicones, waxes and other contaminants before sanding
• Saves time when applied to used vehicles - removes oxidation and reduces buff time
Note: This product is the fi rst step in the Ford-recommended neutralizing, cleaning, three-step process for automotive fi nishes as specifi ed per TSB 04-9-6. All three products must be used for complete neutralization.
Alkaline NeutralizerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-2-A N/A 1 U.S. gal 1 4 152570 04-9-6
Features:
• Deep cleans painted surfaces to remove alkaline deposits
• Dissolves ferrous metal particles while breaking their bond to the paint so that they safely and easily fl oat away
Note: This product is the second step in the Ford-recommended neutralizing, cleaning, three-step process for automotive fi nishes as specifi ed per TSB 04-9-6. All three products must be used for complete neutralization.
Bug and Tar RemoverPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-42 N/A 16 fl uid oz 1 12 167202 05-16-2
Features:
• Multiple deposit remover - cuts tar, asphalt, rust proofi ng, road oils and gummy materials, as well as, removes insects without excessive scrubbing
• Safe for use on all Ford, Lincoln and Mercury exterior production vehicle fi nishes
Note: For best results, wash the surface with Motorcraft® Detail Wash, ZC-3-A, after using Bug and Tar remover.
| 41 |
Exterior and
Interior Vehicle C
leaners
Exterior and Interior Vehicle Cleaners
Custom Bright Metal CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-15 ESR-M5B194-B 16 fl uid oz 1 12 002638 97-26-1398-1-1306-15-11Features:
• Removes rust from pitted chrome - takes off salt and road chemicals fast
• Helps restore shine to chrome, aluminum and brass
• Rub on, let dry and then wipe off. Fast dissolving action saves time
Note: Do not use on clear coated and painted surfaces
Custom Clear Coat PolishPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-8-A N/A 16 fl uid oz 1 12 128368 N/A
ZC-8-B N/A5 U.S. galBag-n-Box
1 — 128368
Features:
• Formulated especially for today’s clearcoat fi nishes
• Quick and easy application
• Modern polish technology employing benefi ts of both silicone and carnauba wax
• Mild formula won’t scratch clear coat fi nishes
• Use where deep gloss and shine are desired
• ZC-8-B available only while supplies last
Custom Vinyl ProtectantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-40-A N/A 16 fl uid oz 1 12 046698 N/A
Features:
• Adds a deep luster appearance to vinyl upholstery, vinyl roofs, tires, bumper rub strips and simulated wood trim
• Enhances the beauty of interior and exterior vinyl, rubber and plastic surfaces. Do not apply to upper instrument panel or other areas where a high gloss is undesirable
• Contains a premium silicone ingredient for a deep luster appearance
• Not for use on acrylic cloth convertible tops
| 42 |
Ext
erio
r and
In
terio
r Veh
icle
C
lean
ers
Exterior and Interior Vehicle Cleaners
Dash and Vinyl CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-38-A N/A 16 fl uid oz 1 12 164489 03-8-205-13-7
Features:
• Mild cleaner safe for use on dash and vinyl surfaces
• Formulated to effectively clean interior dashes and vinyl surfaces without causing glare
Deluxe Leather and Vinyl CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-11-A ESR-M14P4-A 8 fl uid oz 1 12 124337 N/A
Features:
• Cleans and protects coated leather and vinyl surfaces in one application
• Can be polished to high sheen with use of a clean, dry cloth
• Do not polish surfaces on which a high gloss is undesirable (i.e., upper instrument panel)
Deluxe Leather Care KitPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-11-D ESR-M14P4-A N/A 1 — 124337 N/A
Features:
• Quick and easy way to clean coated leather and vinyl seating surfaces
• For best results, use on high wear areas every 4-6 weeks
• Specially designed sponge will not damage today’s leather surfaces
• Each kit contains one, 8 fl uid oz bottle of Deluxe Leather and Vinyl Cleaner and one 3” x 6” Leather Cleaning Sponge
| 43 |
Exterior and
Interior Vehicle C
leaners
Exterior and Interior Vehicle Cleaners
Detail WashPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-3-A ESR-M14P4-A 1 U.S. gal 1 4 152626 03-10-104-9-6
Features:
• A great vehicle wash
• Returns paint to its original factory pH level
• Excellent for everyday use. The pH 7.0 (neutral) formula removes dirt without stripping waxes, polishes or sealants
Note: This product is the third step in the Ford-recommended neutralizing cleaning, three-step process for automotive fi nishes as specifi ed per TSB 04-9-6. All three products must be used to ensure complete neutralization.
Dusting ClothPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-24 ESR-M99H93-B 15” x 26.5” 124 (Display Package)
012267 05-13-7
Features:
• For use on interior and exterior vehicle surfaces
• Special wax treatment polishes surfaces as you clean them
• Acts like a magnet to attract dust and dirt - cleans car surfaces as well as offi ce and home furniture
• 24 pack shipped in countertop point-of-purchase display
Engine Shampoo and DegreaserPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-20 ESR-M14P3-A15 oz
aerosol1 12 172983
N/A
Features:
• Cleans grease, oil and road dirt from engine and engine compartment prior to painting or performing engine repair
• Use to clean transmission housings, hydraulic equipment, enclosed electric motors, generator housings, gear casings and hand tools
| 44 |
Ext
erio
r and
In
terio
r Veh
icle
C
lean
ers
Exterior and Interior Vehicle Cleaners
Premium Liquid WaxPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-53-A N/A 16 fl uid oz 1 12 170771 N/A
Features:
• Contains Carnauba wax for a deep, rich gloss
• Withstands detergent washes
• Fast and easy to use; no hard buffi ng required
• Safe for clear coat fi nishes
Premium Windshield Washer ConcentratePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-32-A WSB-M8B16-A2 16 fl uid oz 1 12 163339 N/A
ZC-32-B WSB-M8B16-A2 32 fl uid oz 1 12 163339
ZC-32-C WSB-M8B16-A2 55 U.S. gal 1 — 163339
Features:
• Concentrated formula - the product label displays a handy dilution chart providing the mix ratios of water and windshield washer fl uid. Use the dilution chart to obtain the appropriate freeze protection and volatile organic compound (VOC) concentration
• Cleans off bugs, dirt and road fi lm fast
• Contains a bittering agent (taste adversant)
• Use at full strength to remove wax build-up on windshield wiper blades
Important Note: This product must be diluted with water prior to use as windshield washer fl uid. Federal, state and/or local regulations limit the concentration of volatile organic compounds (VOCs) in windshield washer fl uid mixtures. Check the applicable regulations prior to mixing with water and reference the Motorcraft Premium Windshield Washer Concentrate Dilution Chart.
Professional Strength Carpet and Upholstery CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-54 N/A 18 oz aerosol 1 12 171146 N/A
Features:
• Aerosol system provides excellent delivery of foaming product for deep cleaning
• Use on all automotive velour and pile-type fabrics. Do not use on silk, velvet, vinyl or leather surfaces
• Removes dirt, grease and grime to restore a like-new appearance
| 45 |
Exterior and
Interior Vehicle C
leaners
Exterior and Interior Vehicle Cleaners
Spot and Stain RemoverPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-14 N/A 16 fl uid oz 1 12 124473 N/A
Features:
• Safely and effectively removes spots and stains on automotive upholstery
• Non-fl ammable, water-based formula
• Contains no chlorinated solvents
• Fast-acting and easy to use
• Great for use on grease, oil, stains and ground-in dirt
Tire Clean and ShinePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-28 N/A 13 oz aerosol 1 12 172767 N/A
Features:
• Cleans and shines lightly-soiled tires in one easy step
• Spray on and let dry - no rinsing, rubbing or buffi ng is necessary
• Gives tires a satin, light-gloss fi nish
• Apply a heavier volume to yield a higher gloss fi nish
Triple CleanPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-13 ESR-M14P4-A 16 fl uid oz 1 12 012197 01-22-4
Features:
• Use on convertible and vinyl tops as well as tires
• New trigger sprayer for easy application
• For exterior use only
| 46 |
Ext
erio
r and
In
terio
r Veh
icle
C
lean
ers
Exterior and Interior Vehicle Cleaners
Ultra-Clear Spray Glass CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-23 ESR-M14P5-A 15 oz aerosol 1 12 019761 04-24-505-13-707-16-11Features:
• Non-streaking, foaming cleaner
• Removes smudges, fi lm and smears
• Not harmful to painted surfaces
• Formulated for automotive use
• Great for new car/truck detailing - excellent for removing transit coating from all glass surfaces, including mirror glass
• Use only as directed. Do not use on surfaces other than glass and mirrors
Wheel and Tire CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-37-A N/A 16 fl uid oz 1 12 164646/176131 N/A
Features:
• The only tested and approved product for cleaning wheels on Ford Motor Company vehicles
• Effectively removes brake dust
• Spray-on, hose-off formula
• May require some agitation with sponge for heavier deposits
• Combination product safely cleans tires, including white-letters and white-walls
| 47 |
Hand C
are Products
Heavy Duty Hand CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-48 N/A 2000 ml 1 4 133965N/A
Features:
• Works on the heaviest grease and grime - including oil, asphalt and tar - without unnecessarily damaging the skin
• Contains a natural, non-irritating scrubbing medium that works to physically loosen and remove embedded soils
• Contains emollients and conditioner
• Waterless formula for use anywhere, anytime
• Rinses off quickly and completely
• Will not clog drains like other hand cleaners
• Motorcraft® Hand Care System Refi ll Cartridge for use with Motorcraft® 2000 ml Hand Cleaner Dispenser Part # ZC-51
Orange Pumice Hand CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-49 N/A 2000 ml 1 4 133964N/A
Features:
• Formulated with a natural, non-petroleum solvent that works fast to provide deep and effective cleaning
• Developed especially for removing soils encountered during automotive service and repair, including common grease, oil and grime
• Natural citrus ingredient leaves hands with a pleasant citrus scent
• Includes aloe, vitamin E and skin conditioners
• Features Fine Italian Pumice to help loosen stubborn, ingrained dirt
• Concentrated formula that contains no petroleum-based solvents
• Motorcraft® Hand Care System refi ll cartridge for use with Motorcraft® 2000 ml Hand Cleaner Dispenser Part # ZC-51
2000 ml Hand Cleaner DispenserPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-51 N/A 2000 ml 1 — N/AN/A
Features:
• Motorcraft® 2000 ml Dispenser is a key component of the all new Motorcraft® Hand Care System. The dispenser is used for Motorcraft® Heavy Duty (ZC-48) and Motorcraft® Orange Pumice (ZC-49)
• The dispenser mounts in minutes. Large display window makes it easy to see when it is time to refi ll
• Adjustible portion control dispensing saves up to 20% over other systems or portable products
• One hand “push” operation is easy to use; dispenser mounting is reinforced with each use
• Dispenser complies with ADA guidelines
• Lifetime Guarantee
Hand Care Products
| 48 |
Han
d C
are
Prod
ucts
Professional Skin ConditionerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-50 N/A 500 ml 1 6 169249 N/A
Features:
• Improves skin condition and maintains the skin’s natural protective barrier. Good skin condition is the best defense agaist harmful substances and moisture loss
• Heals and restores professional working hands
• Absorbs quickly without the greasy feeling of other creams
• Contains no silicones, oils or added fragrance
• Dermatologist tested
• Latex and Nitrile glove compatible
• Proven under actual workplace conditions
• For use with Motorcraft Professional Skin Conditioner Dispenser Part # ZC-52
Professional Skin Conditioner DispenserPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-52 N/A 500 ml 1 — N/A N/A
Features:
• Used for dispensing Motorcraft® Professional Skin Conditioner Part # ZC-50
• Easily mounts in minutes without the use of nails or screws
• One hand “push” operation is easy to use; dispenser mounting is reinforced with each use
• Display window makes it easy to see when it’s time to refi ll
• Dispenser complies with ADA guidelines
• Lifetime Guarantee
Nitrile Technician GlovesPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-55-L N/A100 Count
(Large)1 10 N/A 06-21-12
ZC-55-XL N/A100 Count (X-Large)
1 10 N/A
Features:
• More durable and puncture- and chemical-resistant than latex gloves
• Latex- and powder-free
• Comfortable fi t. Fully textured for a fi rm grip whether wet or dry
• Resistant against: antifreeze, transmission fl uid, paint thinners, adhesive removers, gasoline, diesel fuel, engine and gear oil, paint, lacquer, grease and many other similar chemicals
• Ideal for technicians when painting, performing auto body and mechanical repairs, and more
Hand Care Products
| 49 |
Hand C
are Products
Natural Citrus Hand CleanerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-22 N/A 1 U.S. gal 1 4 042357 N/A
Features:
• Removes most shop soils, including undercoating and urethane sealants and adhesives, from hands
• Has a fresh citrus scent and contains aloe, lanolin and jojoba oil to help soothe skin
• Rinses off cleanly
• Contains biodegradable surfactant; contains no petroleum solvents
• Includes a free pump
Hand Care Products
| 50 |
Pain
t
Argent Spray PaintPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-19K207-AA ESR-M2P92-A 13 oz aerosol 1 — 014479 N/A
Features:
• Excellent for reconditioning used vehicles
• Use to refi nish splash pans and other argent-colored (silver) metal body parts
• Valuable tool for touching up cars and trucks
Adhesion PromoterPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-19A316-AA N/A 6 oz aerosol 1 — 172183 03-15-1204-20-705-9-3Features:
• Quick-drying, clear plastic primer for use before color coating plastic interior trim parts
• Equipped with the EZ TOUCH® FANSPRAY® valve - requires 50% less fi nger pressure than a standard valve. Allows greater coverage with less overspray and manipulates like a professional spray gun
• Use only as recommended
• Can be used as a substitute for Dupli Color’s CP199
• Use to prime plastic interior trim surfaces before using any M4JZ-19M547-XXXXH color
• Use to prime hard plastic interior trim surfaces before using any PM-19M547-XXXXH color. Do NOT use on soft plastic interior trim surfaces before using any PM-19M547-XXXXH color. Reference the applicable TSB and 2004 - 2008 Interior Trim Parts - Plastic Types chart for additional information
• Meets current CARB MIR level requirements
Interior Spray LacquerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
M4JZ-19M547-XXXXH (XXXX = Color Code) ESR-M2P93-A 13 oz aerosol 1 — 009837
03-8-2
Features:
• Only colors associated with MY 1999 - 2003 vehicles are available in this formulation
• For specifi c vehicle applications, see the Touch-Up Paints Interior and Exterior - Part Booklet for the applicable Model Years
• Aerosol spray lacquer ideal for refi nishing or retouching interior trim components - great for ‘paint-to-match’ interior parts
• Requires the use of an adhesion promoter such as Motorcraft® Adhesion Promoter, PM-19A316-AA
• Do NOT repair or repaint air bag covers (doors)
• Available only while supplies last
Paint
| 51 |
Paint
Interior Spray PaintPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-19M547-XXXXH (XXXX = Color Code)
N/A 6 oz aerosol 1 — 17236704-20-705-9-3
Features:
• Quick-drying, premium interior plastic trim paint formulation
• UV stable and color fast
• Completely fl exible - will not crack, fl ake or peel when used as directed
• When used as directed, the original grain pattern of the plastic is maintained (remains visible)
• Ideal for repair or paint-to-match purposes
• Each 6 oz. can covers approximately 5-7 square feet of plastic surface
• Use only as recommended
• Use a plastic adhesion promoter such as Motorcraft® Adhesion Promoter before color coating hard plastic surfaces. Do NOT use a plastic adhesion promoter before color coating soft plastic surfaces. Reference the applicable TSB and 2004 - 2008 Interior Trim Parts - Plastic Types chart for more information
• Meets current CARB MIR level requirements
• Do NOT repair or repaint air bag covers (doors)
Paint
Part Number
Specifi cation Number
SizeUnit of Issue
MSDS / FIRNumber
PMP-19500-1000 ESR-M2P100-C 0.5 fl uid oz 1 040056
PMP-19500-6000 ESR-M2P100-C 0.5 fl uid oz 1 039975
PMP-19500-XXXXX ESR-M2P100-C 0.5 fl uid oz 1 009836
F4AZ-19503-C N/ASingle-Tier with
Ford logo1 N/A
F4MY-19503-C N/ASingle-Tier with
L/M logo1 N/A
F4AZ-19503-D N/A Extension Tray 1 N/A
Exterior Lacquer Touch-Up Paints — 2-in-1 Brush-in-Tube/Pen Tip
• Ideal for retouching nicks, chips and scratches during new car prep and customer use
• Built-in, full-width agitator thoroughly mixes paint for exact color match
• User friendly - equipped with two unique applicators, a pen tip for precise retouching of fi ne chips and scratches and a brush with a tapered tip for pin point or broad stroke use
• For specifi c vehicle applications, see the Touch-Up Paints - Interior and Exterior - Part Booklet for the applicable MYs
AVAILABLE 1000 - Primer 6000 - Clear Topcoat XXXXX = Color Code
Motorcraft® Full Color Touch-Up Paint Display
• Features eye-catching color graphics, self-fi lling construction
• Single-Tier display holds up to 66 Touch-Up Paint applicator tubes and is available with your choice of Ford or Lincoln Mercury logo
• Available Universal Extension Tray holds up to 66 additional Touch-Up Paint applicator tubes
Exterior Lacquer Touch-Up Paints – 2-in-1 Brush-in-Tube/Pen Tip
| 52 |
Seal
ers
& Ad
hesi
ves
Clear Silicone RubberPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-32 ESB-M4G92-A 3 fl uid oz 1 12 015016 97-7-1597-26-1403-12-104-9-504-14-804-15-304-21-2004-23-905-7-405-10-105-13-306-14-806-14-1007-1-1107-12-6
Features:
• Form-in-place gasket and multi-purpose adhesive/sealant
• Room-temperature acetic acid cure silicone rubber
• Many other uses such as sealing leaks, remounting trim and repairing torn weather stripping
• Dispenser nozzle can be custom-cut to desired bead size
• For replacing gaskets in approved applications
Silicone Gasket and SealantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-30 WSE-M4G323-A4 5 fl uid oz 1 12 174272 97-2-897-24-498-6-298-7-498-12-399-5-700-18-503-5-303-6-4
03-7-103-16-203-19-303-21-904-9-504-17-905-10-1007-24-6
Features:
• Recommend for all engine RTV gasketing applications (except 3.5L/3.7L and 7.3L Power Stroke®, 6.0L and 6.4 L diesel engine)
• Form-in-place gasket and multi-purpose adhesive/sealant
• Room temperature curing silicone rubber
• Does not release acetic acid during curing, non-corrosive
• Does not harm O2 sensors
• Cartridge fi ts standard caulking gun
Ultra Silicone SealantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-29 N/A 2.4 fl uid oz 1 12 174399 98-5-898-7-400-24-202-21-104-16-405-10-105-12-6
05-20-205-23-306-10-506-17-607-7-107-14-107-15-3
Features:
• RTV Silicone (gray) designed for rigid fl anges
• Resistant to oil, transmission fl uid, gear oils and coolant
• No odor, O2 Sensor safe
• For use on transmission pans and covers, axle cover plates and transfer case covers
Features:
• RTV Silicone (gray) designed for rigid fl anges
• Resistant to oil, transmission fl uid, gear oils and coolant
• No odor, O2 Sensor safe
• For use on transmission pans and covers, axle cover plates and transfer case covers
Sealers & Ahesives
| 53 |
Sealers & Adhesives
RTV Silicone SealantPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-31 N/A 5 fl uid oz 1 12 139293 98-18-1400-24-303-21-904-19-604-26-705-9-1007-3-107-5-15
Features:
• A specially designed Alkoxy-Cure RTV Sealant for high temperature applications
• Specifi cally recommended for use with the 7.3L Power Stroke®, 6.0L and 6.4L diesel engine
• Non-corrosive, high viscosity material which starts to cure in minutes
Silicone Gasket RemoverPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-30 N/A 5 fl uid oz 1 12 177152 02-11-402-21-1303-6-204-17-905-10-1005-10-1306-21-10
Features:
• Specifi cally formulated to soften cured RTV and residue left from multi-layer steel gaskets
• Allows removal of gasket residue with a plastic or wood scraper
• Safe for aluminum and cast iron gasket surfaces
• Assures a safe cleaning process without risk of damaging the sealing surface
• Eliminates the need for metal tools or abrasives for removing gasket residue
• Only Ford-approved product for removing multi-layer steel gaskets and RTV
Note: As described in TSB 02-11-4, this product is designed to be used with Motorcraft® Metal Surface Prep, ZC-31-A
Sealers & Adhesives
High Performance Engine RTV SiliconePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-357 WSE-M4G323-A6 5 fl uid oz 1 6 179193 N/A
Features:
• Required for use on all 3.5L/3.7L engine gasketing applications
• Cartridge fi ts standard caulking gun
| 54 |
Seal
ers
& Ad
hesi
ves
Metal Surface PrepPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-31-A N/A 16 fl uid oz 1 4 162886 02-11-402-21-1303-6-205-10-1005-10-1306-21-1007-16-1608-3-7
Features:
• Cleans and degreases metal surfaces. Removes light RTV residue
• Use as surface prepration prior to applying RTV silicones
• Gel formula permits use on vertical surfaces and extended soaking for heavy residue
• Not for use on plastic
Note: As described in TSB 02-11-4, the product is designed to be used with Motorcraft® Silicone Gasket Remover, ZC-30
Threadlock 262Part
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-26 WSK-M2G351-A6 0.2 fl uid oz 1 10 01539597-14-2197-21-1798-17-1503-21-4305-17-606-14-10
Features:
• High strength (red)
• Cures only when confi ned between surfaces
• Prevents loosening of nuts, bolts, screws and fi ttings
• Maintains clamp load
• May also be used on seat and door bolts, cup plugs, dip stick tubes, engine studs, ring gear bolts, bearing sleeves and bearing shafts
Thread Sealant with PTFEPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-24 WSK-M2G350-A2 0.2 fl uid oz 1 10 003737 N/A
Features:
• Instantly seals threaded fi ttings
• Resistant to engine and transmission fl uids
• Lubricates bolts and studs
• May also be used on fuel inlet fi ttings, hydraulic lines, water outlet plugs, rear axle fi ll plugs and transmission oil cooler lines
Sealers & Ahesives
| 55 |
Sealers & Adhesives
Stud and Bearing MountPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-27 WSK-M2G349-A1 0.2 fl uid oz 1 10 008175 02-21-1105-20-205-23-3Features:
• High strength (green); low viscosity
• Retaining compound and sealer-cures only when confi ned between surfaces
• Augments the strength of press fi t (or slip fi t) assemblies
• Deters rust build-up on studs and threads
• May also be used on engine studs, ring gear bolts and bearing sleeves and shafts
Threadlock and SealerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-25 WSK-M2G351-A5 0.2 fl uid oz 1 10 00375197-2-398-5a-2798-21-2000-5-103-15-1504-23-705-16-405-20-2
Features:
• Medium-strength threadlocker (blue)
• Working bond is formed in 5 minutes--no more waiting. Final bond forms in 24 hours
• Cures only when confi ned between surfaces
• Cures without cracking or shrinking
• Hand tool removable
• Prevents loosening of nuts, bolts, screws and fi ttings
Gasket MakerPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-16 WSK-M2G348-A5 0.2 fl uid oz 1 12 014716 91-13-705-10-10
Features:
• Flexible, anaerobic gasketing material (Red)
• Use on rigid machined fl anges with less than 0.010” gap
• Seals upon assembly, no waiting required
• Adheres well to aluminum, iron, steel and magnesium
• May also be used on automatic/manual transaxle cases, gear shift housings, dipstick tubes, water pumps and engine fl anges
Sealers & Adhesives
| 56 |
Seal
ers
& Ad
hesi
ves
Rear View Mirror AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-17 N/A0.10/0.02 fl uid oz
1 10 165960/175811 94-17-2
Features:
• New, faster, stronger formula
• Permanently remounts mirrors to windshields
• Achieves handling strength in seconds; mirror mounting strength in 15 minutes
• Superfast, high strength, instant adhesive may also be used to bond close-mated, smooth-surface parts
Sealers & Ahesives
Instant Gel AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
TA-19 WSK-M2G402-A4 .06 fl uid oz 1 12 041245 97-12-198-8-1198-20-1999-6-599-13-1002-25-1104-2-204-12-404-24-307-4-307-16-11
Features:
• Rapid curing instant adhesive
• Gel formula won’t run or drip
• Excellent humidity and weather resistance
• Use on metals, wood, paper, fabrics, leather, rubber, ceramics and most plastics
• May also be used on dashboard panels, vacuum lines, loose trim, emblems and loose vinyl body side moldings
Isopropanol Cleaning KitPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
ZC-4 N/A 1 kit 1 — 159277 01-18-201-22-403-18-405-6-407-18-7
Features:
• Kit contains: one, 1 fl uid oz bottle of isopropyl alcohol and one cotton rag
• Use for ABS or metal surface preparation prior to adhesive application
• Removes dirt, oil and grease from metal surfaces
• For industrial use only
• Available only while supplies last
| 57 |
Sealers & Adhesives
Rear View Mirror Button AdhesivePart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
F7AZ-17698-AA (small)
WSS-M2G389-A16mm x 33mm
1 — 137446 N/A
F7AZ-17698-BA (large)
WSS-M2G389-A21mm x 29mm
1 — 137446
Features:
• Found to adhere much longer in high temperature, high humidity environments under constant load
• Developed and sold only through Ford for service repair. Not available elsewhere
• Applicable to all Ford & Lincoln Mercury vehicles, and many other domestic vehicles
• Use with Rotunda applicator 164-R3925
Rear Window Defroster RepairPart
NumberSpecifi cation
NumberSize
Unit of Issue
Sell Pack
MSDS / FIRNumber
TSB
PM-11 ESB-M4J58-A 0.125 fl uid oz 1 — 172443 04-24-505-13-1005-22-19Features:
• Repairs small open-circuit breaks in electrically heated, grid-type rear window defrosters
• Tough, lasting repair. Minute quantity needed for each repair
• Brush-in-cap applicator. Reestablishes electrical continuity
Sealers & Adhesives
| 58 |
Qui
ck
Ref
eren
ce
Cha
rts
Verification Tests Required for the API Certification Mark (Starburst) and API SM
Ball Rust Test In this bench test a polished metal ball is subjected to an aqueous acid solution similar to acids normally found in engine oils. A digitized-optical image analyzer measures the amount of rust. It replaced the Sequence IID test. Sequence IIIG and IIIGAThe Sequence IIIG dynamometer test is designed to simulate high-speed trailer tow conditions. In fact, the engine is run hot enough the exhaust manifolds glow red. Its main purpose is to evaluate an engine oil’s performance in combating high-temperature oxidation, which causes oil thickening and varnish deposits. It also evaluates high temperature cam and tappet wear, and piston ring deposits. This test uses a GM 3.8L V6 and runs a total of 100 hours. The IIIGA test measures the low temperature performance of the oil after completion of the IIIG test.
Sequence IVAThe Sequence VIA is a dynamometer test used to evaluate low temperature cam and tappet wear. It uses a Nissan 2.4L I4 engine and runs a total of 100 hours. The cam wear is measured over seven positions on the cam lobe. Sequence VGThe Sequence VG dynamometer test simulates city stop-and-go driving, and moderate-speed freeway driving. It evaluates engine oil’s capability to prevent low- and moderate-temperature sludge and varnish formation. This test uses a Ford 4.6L V8. The engine also employs a specially designed rocker cover jacketed for water-cooling to help produce sludging conditions. Sequence VIBThe Sequence VIB dynamometer test measures the effect of engine oil on fuel economy by comparing candidate oils versus an industry standard reference oil. The test is run both on fresh oil and after aging, simulating approximately 4,000 miles of driving. The test uses a Ford 4.6L V8. Sequence VIIIPreviously referred to as the “L-38” test, the Sequence VIII dynamometer test evaluates an engine oil’s ability to combat copper-lead bearing corrosion. It also measures resistance to “thinning out” because of sheardown of it’s viscosity modifier. The test uses a single cylinder engine displacing 42.5 cubic inches, run with the following conditions held constant: speed, temperature and air/fuel ratio. The test is run a total of 40 hours. TEOST MHT-4The Thermo-Oxidation Engine Oil Simulation Test or TEOST is a bench test, which measures the amount of deposits formed on a heated rod. It simulates deposits formed in turbocharger bearings, piston ring lands and other high-temperature areas of the engine.
| 59 |
Quick
Reference C
harts
| 1 |Quick Reference Charts
Mot
orcr
aft O
il Q
uick
Ref
eren
ce O
il A
pplic
atio
ns a
nd C
rank
case
Cap
aciti
es C
hart
Rec
omm
end
Mot
orcr
aft S
AE
5W-2
0O
il R
efill
(Qts
) (1)
Oil
Filte
r19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
082.
0L -2
V Es
cort
(02)
/Tra
cer(
99)/F
ocus
(00-
04)
4.0
FL 4
00 S
2.0L
-4V
I4 F
ocus
4.5
FL 9
102.
0L -4
V Ze
tec
Esco
rt(0
0)/E
scor
t ZX2
(03)
(4)
4.5
FL 2
005
2.0L
-4V
Zete
c C
onto
ur(0
0)/M
ystiq
ue(0
0)/C
ouga
r (4)
4.5
FL 2
005
2.0L
-4V
Zete
c Fo
cus/
Esca
pe(0
1-04
) (4)
4.5
FL 4
00 S
2.3L
-4V
I4 E
scap
e H
ybrid
/Mar
iner
Hyb
rid4.
5FL
201
7 B
2.3L
-4V
I4 F
ocus
4.5
FL 9
102.
3L -4
V I4
Fus
ion/
Mila
n4.
5FL
201
7 B
2.3L
-4V
I4 E
scap
e/M
arin
er4.
5FL
910
2.3L
-4V
I4 R
ange
r4.
0FL
400
S2.
3L O
HC
Ran
ger/M
usta
ng(9
4)5.
0FL
1 A
2.5L
-4V
Cou
gar/C
onto
ur(0
0)/M
ystiq
ue(0
0)5.
8FL
820
S2.
5L O
HC
Ran
ger
4.5
FL 4
00 S
3.0L
-2V
Taur
us/S
able
(05)
/Win
dsta
r(00)
(2)
4.5
FL 4
00 S
3.0L
-2V
Ran
ger
4.5
FL 4
00 S
3.0L
-4V
Taur
us/S
able
(96-
03)5
.5/6
.5FL
820
S3.
0L -4
V R
FF E
scap
e(0
4)5.
5/6.
0FL
820
S3.
0L -4
V R
FF F
ive
Hun
dred
/Mon
tego
6.0
FL 8
20 S
3.0L
-4V
RFF
Mar
iner
/Fre
esty
le(0
7)6.
0FL
820
S3.
0L -4
V R
FF F
usio
n/M
ilan/
Zeph
yr(0
6 on
ly)
6.0
FL 8
20 S
3.0L
-4V
DA
MB
Lin
coln
LS
6.9
FL 4
00 S
3.5L
-4V
Edge
/MK
X/M
KZ
5.5
FL 4
00 S
3.5L
-4V
Taur
us/S
able
/Tau
rus
X5.
5FL
400
S3.
8L M
usta
ng5.
0FL
400
S3.
8L W
inds
tar
4.5
FL 4
00 S
3.8L
Win
dsta
r 5.
0FL
400
S3.
8L T
hund
erbi
rd/C
ouga
r(9
3-95
)5.0
/5.3
FL 4
00 S
3.8L
Win
dsta
r4.
5FL
400
S3.
9L -2
V Fr
eest
ar5.
0FL
400
S3.
9L -4
V Li
ncol
n LS
/Thu
nder
bird
6.0
FL 2
021
3.9L
-4V
Linc
oln
LS/T
hund
erbi
rd6.
9FL
202
14.
2L F
rees
tar/M
onte
rey
5.0
FL 4
00 S
4.2L
SPI
Eco
nolin
e/F-
150/
250(
99)
6.0
FL 4
00 S
4.6L
-2V(
05) -
3V E
xplo
rer/M
ount
aine
er(0
5)6.
0/6.
5FL
820
S
Con
tinue
d on
Nex
t Pag
e
| 60 |
Qui
ck
Ref
eren
ce
Cha
rts
| 2 | Quick Reference Charts
Mot
orcr
aft O
il Q
uick
Ref
eren
ce O
il A
pplic
atio
ns a
nd C
rank
case
Cap
aciti
es C
hart
(Con
t.)
Rec
omm
end
Mot
orcr
aft S
AE
5W-2
0O
il R
efill
(Qts
) (1)
Oil
Filte
r19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
08
4.6L
-2V
REP
Mus
tang
(02)
5.0/
6.0
FL 8
20 S
4.6L
-2V
F-15
0/25
0(99
) (un
der 8
500
GVW
onl
y)6.
0FL
820
S4.
6L -3
V M
usta
ng6.
0FL
820
S4.
6L -4
V M
arau
der(
04)/M
arkV
III(9
8)/A
viat
or(0
5)6.
0FL
820
S4.
6L -4
V M
usta
ng C
obra
/Mac
h 1
(als
o in
clud
es S
C)
6.0
FL 8
20 S
4.6L
-4V
Con
tinen
tal
6.0
FL 8
20 S
4.6L
-2V
Cro
wn
Vict
oria
/Gra
nd M
arqu
is(0
2)5.
0/6.
0FL
820
S4.
6L -2
V Ec
onol
ine
6.0
FL 8
20 S
4.6L
-2V
Expe
ditio
n6.
0FL
820
S4.
6L -2
V To
wn
Car
(02)
5.0/
6.0
FL 8
20 S
5.0L
Exp
lore
r/Mou
ntai
neer
5.0
FL 8
20 S
5.4L
-4V
Bla
ckw
ood
6.0
FL 8
20 S
5.4L
-2V
Econ
olin
e6.
0FL
820
S5.
4L -2
V Ex
curs
ion
6.0
FL 8
20 S
5.4L
-2V/
3V F
-Sup
er D
uty
7.0
FL 8
20 S
5.4L
-2V
Expe
ditio
n/Na
viga
tor(9
9)/F
-150
(Inc
ludi
ng S
C)6.
0FL
820
S5.
4L -2
V F-
Supe
r Dut
y6.
0FL
820
S5.
4L -4
V N
avig
ator
(02)
6.0/
7.0
FL 8
20 S
5.4L
-3V
Nav
igat
or/E
xped
ition
7.0
FL 8
20 S
5.4L
-3V
Mar
k LT
7.0
FL 8
20 S
5.4L
-3V
F-15
07.
0FL
820
S6.
8L -2
V Ec
onol
ine
6.0
FL 8
20 S
6.8L
-2V
Supe
r Dut
y (0
4)/E
xcur
sion
(00-
05)
6.0
FL 8
20 S
6.8L
-3V
Supe
r Dut
y 7.
0FL
820
S7.
5L A
ll Ve
hicl
es6.
0FL
1 A
Con
tinue
d on
Nex
t Pag
e
| 61 |
Quick
Reference C
harts
| 3 |Quick Reference Charts
Mot
orcr
aft O
il Q
uick
Ref
eren
ce O
il A
pplic
atio
ns a
nd C
rank
case
Cap
aciti
es C
hart
(Con
t.)
Rec
omm
end
Mot
orcr
aft S
AE
5W-3
0O
il R
efill
(Qts
) (1)
Oil
Filte
r19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
082.
0L H
P 4V
Zet
ec S
VT F
ocus
(4)
4.5
FL 2
005
3.0L
Vill
ager
4.2
FL 8
393.
3L V
illag
er4.
2FL
200
73.
4L S
HO
Tau
rus
6.5
FL 4
00 S
3.9L
Lin
coln
LS
6.0
FL 2
021
4.0L
OHV
Exp
lore
r/Mou
ntai
neer
/Ran
ger
5.0
FL 1
A4.
0L S
OH
C E
xplo
rer/M
ount
aine
er5.
0FL
820
S4.
0L S
OH
C V
6 M
usta
ng5.
0FL
820
S4.
0L S
OHC
Expl
orer
Spo
rt(03
)/Exp
lore
r Spo
rt Tr
ac/R
ange
r5.
0FL
820
S
Rec
omm
end
Mot
orcr
aft S
AE
5W-5
0O
il R
efill
(Qts
) (1)
Oil
Filte
r19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
085.
4L 4
V D
OH
C S
uper
char
ged
V8 -
GT
9.5
FL 2
033
5.4L
4V
DO
HC
Sup
erch
arge
d V8
- Sh
elby
GT5
006.
5FL
820
S
Rec
omm
end
Mot
orcr
aft S
AE
15W
-40
Oil
Refi
ll(Q
ts) (
1)O
il Fi
lter
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007
2008
4.5L
DIT
Die
sel V
ehic
les
LCF
15.0
FL 1
995
6.0L
DIT
Die
sel V
ehic
les
(3)
15.0
FL 2
016
7.3L
DIT
Die
sel V
ehic
les
(3)
15.0
FL 1
995
6.4L
DIT
Die
sel V
ehic
les
15.0
FL 2
016
Not
e (1
): A
ll ca
paci
ties
are
with
oil
filte
r.
Not
e (2
): Fo
r 199
3 - 1
998
Flex
Fue
l Veh
icle
use
oil
mee
ting
Spe
cific
atio
n W
SS
-M2C
909-
A.
SC
= S
uper
char
ged
Not
e (3
): C
heck
Ow
ner’s
Gui
de fo
r app
ropr
iate
vis
cosi
ty d
epen
ding
on
ambi
ent t
empe
ratu
re.
Not
e (4
): FL
400S
and
FL2
005
are
inte
rcha
ngab
le.
Vers
ion
2.3
Pub
lishe
d 7/
07
Ver
sion
2.3
Pub
lishe
d 7/
07
| 62 |
Qui
ck
Ref
eren
ce
Cha
rts
| 1 |Quick Reference Charts
App
licat
ion
Axl
eLo
catio
nFl
uid
Refi
ll(P
ints
) [1]
Axl
eD
escr
iptio
nFr
ictio
nM
odifi
er [3
]19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
08C
row
n Vi
ctor
ia/G
rand
Mar
quis
/Tow
n C
ar (A
ll)R
ear
3.8 (0
2) / 4
.5 (03
)8.
8XL
-3 fo
r LS
C
row
n Vi
ctor
ia P
olic
e (A
ll)R
ear
3
.8
4.5
8.8
XL-3
for L
S
Five
Hun
dred
/Mon
tego
Rea
r1.
5(06
)2.
4Ge
trag (
06)/M
160
N/A
Fusi
on/M
ilan/
MK
ZR
ear
2.4
M16
0N
/A
Li
ncol
n LS
(C)
Rea
r2.
98.
0N
/A
Li
ncol
n LS
(Spo
rt) (
C)
Rea
r2.
98.
0N
/A
Li
ncol
n Li
mo
(LS)
Rea
r4.
8(02
) / 4
.58.
8XL
-3
Mar
aude
r (LS
)R
ear
3.8
8.8
XL-3
Mar
k VI
II (C
)R
ear
2.9
8.8
N/A
Mus
tang
(All)
Rea
r
3.3
3.0
7.5
XL-3
for L
S
Mus
tang
GT
(All)
/ She
lby
GT5
00R
ear
3
.8
4.0
8.8
XL-3
for L
S
Mus
tang
Cob
ra (I
RS
w/L
S)R
ear
2.6
8.8
XL-3
Th
unde
rbird
(C)
Rea
r
2.9
2.5(0
3-06)
8.8
N/A
Avia
tor (
All)
Rea
r3.
58.
8XL
-3 fo
r LS
Av
iato
r (C
)Fr
ont
2.8
M30
(M18
6)N
/A
Edge
/MK
XR
ear
2.4
M16
0N
/A
Es
cape
/Mar
iner
(C)
Rea
r2.
6M
28(M
174)
N/A
5.0
Expl
orer
/Mou
ntai
neer
(Con
vent
iona
l, Be
am)
Rea
r5.
58.
8N
/A
4.0L
Exp
lore
r (C
onve
ntio
nal,
Bea
m)
Rea
r5.
58.
8N
/A
Ex
plor
er/M
ount
aine
er (L
S, B
eam
)R
ear
5.5(
00),5
.3 (0
1)8.
8XL
-3
Ex
plor
er/M
ount
aine
er (C
) (IR
S)R
ear
3.5
8.8
N/A
Expl
orer
/Mou
ntai
neer
(LS,
IRS)
Rea
r3.
38.
8XL
-3
Ex
plor
er S
port
(03)
/Spo
rt T
rac
(LS)
Rea
r5.
38.
8XL
-3
Expl
orer
Spo
rt/(0
3)Sp
ort T
rac
(C)
Rea
r5.
58.
8N
/A
Expl
orer
Spo
rt(0
3)/S
port
Tra
c (C
)Fr
ont
3.3
M35
(M19
4)N
/A
Expl
orer
(98-
01),
Expl
orer
(C)
Fron
t3.
3M
35(M
194)
N/A
Ex
plor
er/M
ount
aine
er (C
)Fr
ont
2.8
M30
(M18
6)N
/A
Expl
orer
(C)
Fron
t3.
3M
35(M
194)
N/A
Free
styl
eR
ear
1.5
159.
9N
/A
Rang
er (C
and
LS,
exc
ept L
evel
II)
Rea
r5.
07.
5/8.
8XL
-3 fo
r LS
Ra
nger
(4W
D O
ff Ro
ad, H
igh
Torq
ue, L
evel
II)(L
S)R
ear
5.3
8.8
XL-3
R
ange
r (4W
D)
Fron
t3.
3M
35 (M
194)
N/A
Ex
pedi
tion/
Nav
igat
or (C
) R
ear
5.5(
02)3
.58.
8/9.
75N
/A
Expe
ditio
n/N
avig
ator
(LS)
Rea
r5.
3(02
)3.3
8.8/
9.75
XL-3
F-
150/
Blac
kwoo
d (0
3) L
inco
ln M
ark
LT (0
6) (C
) R
ear
5.5
8.8/
9.75
N/A
F-
150/
Blac
kwoo
d (0
3) L
inco
ln M
ark
LT (0
6) (L
S)R
ear
5.3
7.0
8.8/
9.75
/10.
25XL
-3
F-
150/
250L
D/E
xped
ition
/Nav
igat
or (C
)Fr
ont
3.5
8.8
N/A
Mot
orcr
aft A
xle
Lubr
ican
ts -
Qui
ck R
efer
ence
Lub
rican
t App
licat
ions
and
Cap
aciti
es C
hart
(con
t.)
| 63 |
Quick
Reference C
harts
| 2 | Quick Reference Charts
Mot
orcr
aft A
xle
Lubr
ican
ts -
Qui
ck R
efer
ence
Lub
rican
t App
licat
ions
and
Cap
aciti
es C
hart
(con
t.)
App
licat
ion
Axl
eLo
catio
nFl
uid
Refi
ll(P
ints
) [1]
Axl
eD
escr
iptio
nFr
ictio
nM
odifi
er [3
]19
9819
9920
0020
0120
0220
0320
0420
0520
0620
0720
08F-
250H
D/3
50 (A
ll)R
ear
7.5
10.2
5 SF
/FF
XL-3
for L
S [4
]
F-25
0LD
(C)
Rea
r
7.5
6.9(0
2-04)
10.2
5 SF
N/A
F-25
0LD
(LS)
R
ear
7.5(
01)/6.5(
02)6
.5(03-0
4)10
.25
SF
XL-3
[4]
F-25
0HD
/350
(02)
/Exc
ursi
on (C
)Fr
ont
3.8
M50
(M22
9)N
/A
F-25
0/35
0/45
0/55
0 (C
)Fr
ont
5.9
M60
(M24
8)N
/A
F-25
0 (C
)/F-3
50/4
50 (A
ll)R
ear
8.0
M80
(M28
6)[2
] [4]
XL-
3 for
LS
F-45
0/55
0 (A
ll)R
ear
14.0
S110
/S13
0N
/A
F-55
0/E-
550
(03)
(All)
R
ear
24.5
26.7
[6]S1
35N
/A [5
]
E-15
0 (C
)R
ear
5.5
8.8/
9.75
N/A
E-
150
(LS)
Rea
r
5.4
5.3(0
3-06)
8.8/
9.75
XL-3
E-
150/
E-25
0/35
0 (C
)R
ear
6.3
M60
(M24
8)N
/A
E-15
0/E-
250/
350
(LS)
Rea
r5.
8M
60(M
248)
XL-3
[4]
E-
250/
350
(LS)
(DSO
)R
ear
5.8
M60
(M24
8)XL
-3 [4
]
E-35
0 C
hass
is/R
V/C
utaw
ay (C
) (D
SO)
Rea
r7.
4M7
0HD(
M273
HD)
N/A
E-35
0 C
hass
is/R
V/C
utaw
ay (C
)R
ear
6.6
M70
FF(M
267F
F)N
/A
E-35
0 C
hass
is/R
V/C
utaw
ay (L
S)R
ear
6.3
M70
FF(M
267F
F)XL
-3 [4
]
E-35
0 C
hass
is/R
V/C
utaw
ay (L
S)R
ear
6.6
M70
FF(M
267F
F)N
/A
E-
450
Cha
ssis
/RV/
Cut
away
(C)
Rea
r8.
3M7
0HD(
M273
HD)
N/A
E-
450
Cha
ssis
/RV/
Cut
away
(LS)
Rea
r7.
8M7
0HD(
M273
HD)
XL-3
[4]
E-
450
Cha
ssis
/RV/
Cut
away
(LS)
Rea
r8.
3M7
0HD(
M273
HD)
N/A
F-53
Mot
orho
me
(C)
Rea
r8.
0M
80(M
286)
N/A
F-53
Mot
orho
me
(All)
Rea
r14
.0S1
10/S
130
N/A
[5]
F-53
Mot
orho
me
(All)
Rea
r24
.5S1
35/S
145
N/A
[5]
XY
-80W
90-Q
L, W
SP-M
2C19
7-A,
SAE
80W
-90
Prem
ium
Rea
r Axl
e Lu
bric
ant
XY
-75W
140-
QL,
WSL
-M2C
192-
A, S
AE 7
5W-1
40 S
ynth
etic
Rea
r Axl
e Lu
bric
ant
XY
-75W
90-Q
LS, S
AE-7
5W-9
0 Sy
nthe
tic R
ear A
xle
Lubr
ican
t
XY-9
0-G
L, E
SW-M
2C10
5-A,
SAE
90
Hyp
oid
Gea
r Oil
-XL-
3, E
ST-
M2C
118-
A, A
dditi
ve F
rictio
n M
odifi
er
Not
es:
[1]
Oil
refil
l vol
ume
does
not
incl
ude
frict
ion
mod
ifier
. Do
not o
verfi
ll ab
ove
volu
mes
sh
own
(fric
tion
mod
ifier
sho
uld
be a
dded
firs
t).
[2]
Fric
tion
mod
ifier
requ
ired
in v
ehic
les
built
bef
ore
10/1
0/04
.[3
] 4
fl oz
of f
rictio
n m
odifi
er a
dded
unl
ess
othe
rwis
e sp
ecifi
ed.
[4]
Add
8 fl
oz
of fr
ictio
n m
odifi
er.
[5]
S10
0/13
0/13
5/14
5 Li
mite
d S
lip a
xles
do
not r
equi
re F
rictio
n M
odifi
er.
[6]
26.7
pin
ts in
E-5
50 o
nly.
All
othe
r veh
icle
rece
ive
24.5
.
- S
ee E
FC 0
5012
02 re
gard
ing
Pow
er T
rans
fer U
nit (
PTU
) Ser
vice
Req
uire
men
ts fo
r
2005
-200
7 Fi
ve H
undr
ed, F
rees
tyle
and
Mon
tego
.W
hen
fillin
g a
Lim
ited
Slip
axl
e re
quiri
ng F
rictio
n M
odifi
er, a
lway
s ad
d Fr
ictio
n M
odifi
er fi
rst,
befo
re fi
lling
with
th
e lu
bric
ant.
C =
Con
vent
iona
l Axl
eLS
= L
imite
d S
lip A
xle
FF =
Ful
l Flo
atin
gS
F =
Sem
i-Flo
atin
gH
D =
Hea
vy D
uty
(XX
) = T
he la
st m
odel
yea
r use
d[X
] = N
otes
M&S
pre
fix a
xle
desc
riptio
ns =
Dan
a Ax
les
Num
eric
des
crip
tions
= F
ord/
Vist
eon
Axl
es
Vers
ion
3.3
/ Pub
lishe
d 8/
07
| 64 |
Qui
ck
Ref
eren
ce
Cha
rts
| 1 |
Spe
cific
ser
vice
flui
ds (l
iste
d to
the
right
) are
cal
led
for d
epen
ding
on
the
type
of
trans
mis
sion
and
the
year
the
trans
mis
sion
was
bui
lt. It
is im
porta
nt to
use
the
corr
ect
fluid
, eac
h flu
id e
xhib
its d
iffer
ent p
rope
rties
and
sho
uld
be u
sed
only
in th
e tra
nsm
issi
on
for w
hich
they
wer
e de
sign
ed. T
he v
ehic
le o
wne
r or r
ebui
lder
sho
uld
use
the
type
of fl
uid
prin
ted
in th
e ow
ners
gui
de o
r on
the
auto
mat
ic tr
ansm
issi
on fl
uid
leve
l ind
icat
or. R
efer
to
your
sch
edul
ed m
aint
enan
ce g
uide
to d
eter
min
e th
e co
rrec
t ser
vice
inte
rval
. Fai
lure
to u
se
the
reco
mm
ende
d flu
id m
ay a
ffect
tran
smis
sion
per
form
ance
and
dur
abili
ty.
CA
UTI
ON
:D
O N
OT
US
E S
UP
PLE
ME
NTA
L TR
AN
SM
ISS
ION
FLU
ID A
DD
ITIV
ES
, TR
EAT
ME
NTS
OR
C
LEA
NIN
G A
GE
NTS
. The
use
of t
hese
mat
eria
ls m
ay a
ffect
tran
smis
sion
ope
ratio
n an
d re
sult
in d
amag
e to
inte
rnal
tran
smis
sion
com
pone
nts.
CA
UTI
ON
:M
ER
CO
N® S
P, M
ER
CO
N®
LV, M
otor
craf
t® P
rem
ium
Aut
omat
ic T
rans
mis
sion
Flu
id
and
Mot
orcr
aft®
FN
R5
ATF’
s ar
e un
ique
flui
ds a
nd M
US
T be
use
d in
app
licat
ions
re
com
men
ding
that
par
ticul
ar fl
uid.
Use
of a
ny o
ther
flui
d m
ay c
ause
redu
ced
func
tiona
lity
or tr
ansm
issi
on d
amag
e.
CA
UTI
ON
: Th
e fu
nctio
nal c
hara
cter
istic
s of
flui
ds fo
r the
CV
T tra
nsm
issi
ons
are
very
diff
eren
t tha
n th
ose
of o
ther
ATF
’s. U
se o
f a fl
uid
othe
r tha
n M
otor
craf
t® C
ontin
uous
ly V
aria
ble
Cha
in
Type
Tra
nsm
issi
on F
luid
or o
ne la
bele
d as
mee
ting
ME
RC
ON
® C
may
cau
se s
ever
e tra
nsm
issi
on d
amag
e.
FAIL
UR
E T
O U
SE
RE
CO
MM
EN
DE
D F
LUID
WIL
L A
FFE
CT
TRA
NS
MIS
SIO
N
PE
RFO
RM
AN
CE
. RE
FER
TO
OW
NE
RS
MA
NU
AL
AN
D/O
R F
LUID
LE
VE
L IN
DIC
ATO
R F
OR
PR
OP
ER
FLU
ID T
YP
E.
M
ERC
ON
® V
- P
art n
umbe
r XT-
5-Q
M (Q
uarts
) and
XT-
5-D
M (5
5 G
allo
n D
rum
) For
d S
peci
ficat
ion
is M
ER
CO
N®
V.
NO
TE: A
UTO
MAT
IC T
RA
NS
MIS
SIO
NS
RE
QU
IRIN
G M
ER
CO
N® V
SH
OU
LD
ON
LY B
E S
ER
VIC
ED
WIT
H M
ER
CO
N® V
.
MER
CO
N® S
P
- Par
t num
ber X
T-6-
QS
P (Q
uarts
) and
XT-
6-D
SP
(55
Gal
lon
Dru
m) F
ord
Spe
cific
atio
n is
ME
RC
ON
® S
P.
CO
NTI
NU
OU
SLY
VAR
IAB
LE C
HA
IN T
YPE
- P
art n
umbe
r XT-
7-Q
CFT
(Qua
rts).
PR
EMIU
M A
UTO
MAT
IC T
RA
NSM
ISSI
ON
FLU
ID
- P
art n
umbe
r XT-
8-Q
AW.
FN
R5
Aut
omat
ic T
rans
mis
sion
Flu
id
- Par
t num
ber X
T-9-
QM
M5.
MER
CO
N® L
V- P
art n
umbe
r XT-
10-Q
LV (Q
uarts
)
Aut
omat
ic T
rans
mis
sion
Flu
id C
hart
Vers
ion
1.2
Pub
lishe
d 7/
07
TRA
NS
MIS
SIO
NS
TRA
NS
AX
LES
TYP
E
M
OD
EL
YE
AR
C6
E
4OD
4R
100
5R11
0TO
RQ
S
HIF
TA
OD
AO
DE
4R70
W/
4R70
E4R
75W
/E
A4L
D4R
44E
4R55
E5R
55E
5R55
N5R
44E
5R55
W/
S6H
P26
6R60
/ 6R
75AT
XM
AZD
A AT
X
F4E
(4
EAT
)
4F
20E
C
D4E
4F27
EA
XO
D
* AX
4S
(AXO
DE)
4F50
N
(AX4
N)
CV
T
6 SP
EED
AUTO
AW
F-21
AW
EC
VT
FNR
56F
50
TYP
E
M
OD
EL
YE
AR
1988
VV
VV
VV
1988
1989
VV
VV
VV
VV
1989
1990
VV
VV
VV
VV
1990
1991
VV
VV
VV
VV
1991
1992
VV
VV
VV
VV
V19
9219
93V
VV
VV
VV
VV
VV
1993
1994
VV
VV
VV
VV
VV
VV
1994
1995
VV
VV
VV
VV
VV
VV
V19
9519
96V
VV
VV
VV
VV
VV
V19
9619
97V
VV
VV
VV
VV
V19
9719
98V
VV
VV
VV
VV
V19
9819
99V
VV
VV
VV
VV
1999
2000
VV
VV
VV
VV
VV
V20
0020
01V
VV
VV
VV
VV
VV
V20
0120
02V
VV
VV
VV
VV
VV
V20
0220
03V
SP
VV
VV
VV
VV
V20
0320
04V
VV
VV
VV
VV
V20
0420
05V
VV
VV
V
SP
VV
VC
VTP
V20
0520
06V
VV
VV
SPV
VV
CVT
PV
M5
2006
2007
VV
VV
VV
VV
CVT
PV
M5
V20
0720
08V
VV
VLV
PV
M5
V20
08M
OD
EL
YE
AR
TYP
EC
6
E
4OD
4R
100
5R11
0TO
RQ
S
HIF
TA
OD
AO
DE
4R70
W/
4R70
E4R
75W
/E
A4L
D4R
44E
4R55
E5R
55E
5R55
N5R
44E
5R55
W/
S6H
P26
6R60
/ 6R
75AT
XM
AZD
A AT
X
F4E
(4
EAT
)
4F
20E
C
D4E
4F27
EA
XO
D
* AX
4S
(AXO
DE)
4F50
N
(AX4
N)
CV
T
6 SP
EED
AUTO
AW
F-21
AW
EC
VT
FNR
56F
50
MO
DE
L Y
EA
R
TYP
E
V SP CVT P M5
LV
Quick Reference Charts
| 65 |
Quick
Reference C
harts
| 1 |
TRA
NS
AX
LES
TRA
NS
MIS
SIO
NS
TYP
E
MO
DE
L Y
EA
R
SE
EN
OTE
1F5
MG
5MM
FA60
MTX
- 1/3
/4M
T
SE
EN
OTE
2F5
MG
5MM
TX75
IB5
T50D
M5R
1/R
2M
5HD
M5O
/DT4
5TR
3650
SE
EN
OTE
3S
5-47
(ZF)
ZF6S
GET
-R
AG(2
21)
SEE
N
OTE
4
OTH
ER
MAN
-U
AL
TRAN
S.
GT
6 S
PE
ED
TRA
NS
.
1987
V
V
V
V
Fs/
GL-
419
88
V
1989
GL-
4
1990
1991
1992
V
1993
1994
1995
V
Fs
1996
Ms
1997
V19
9819
99
V
2000
Fs
2001
GL-
4M
sV
2002
GL-
420
03G
L-4
V
2004
GL-
420
05G
L-4
GT
2006
GL-
4G
L-4
GT
2007
GL-
4G
L-4
GT
2008
GL-
4G
L-4
FsM
OD
EL
YE
AR
TY
PE
SE
EN
OTE
1F5
MG
5MM
FA60
MTX
- 1/3
/4M
T
SE
EN
OTE
2F5
MG
5MM
TX75
IB5
T50D
M5R
1/R
2M
5HD
M5O
/DT4
5TR
3650
SE
EN
OTE
3S
5-47
(ZF)
ZF6S
GET
-R
AG(2
21)
SEE
N
OTE
4
OTH
ER
MAN
-U
AL
TRAN
S.
GT
6 S
PE
ED
TRA
NS
.
Tran
smis
sion
Flu
id C
hart
Vers
ion
3.1
Pub
lishe
d 9/
07
NO
TE 1
:19
89 -
1997
Pro
be, 2
001
- 200
4 E
scap
e, 2
006-
2008
Fus
ion/
Mila
nN
OTE
2:
Esc
ort/T
race
rN
OTE
3:
1988
- 19
98 S
ervi
ce g
asol
ine
vehi
cles
with
ME
RC
ON
®V.
1996
- 19
98 S
ervi
ce d
iese
l veh
icle
s w
ith M
ER
CO
N®
synt
hetic
.19
99 -
2001
Ser
vice
all
vehi
cles
with
ME
RC
ON
®sy
nthe
tic.
NO
TE 4
: X
T-M
5-Q
S o
r XY-
75W
90-Q
GL
repl
aced
SA
E 8
0W m
anua
l tra
nsm
issi
on fl
uid
F2ZZ
-19C
547-
A.
CO
MM
ERC
IAL
NA
ME
SER
VIC
E PA
RT
NU
MB
ER U
.S.
SER
VIC
E PA
RT
NU
MB
ER C
AN
AD
AM
ER
CO
N® V
(QU
AR
TS)
XT-
5-Q
MX
T-5-
QM
CC
XT-
5-LM
12
SY
NTH
ETI
C M
ER
CO
N®
(QU
AR
TS)
XT-
2-Q
SM
XT-
2-Q
SM
ME
RC
ON
® V
(DR
UM
S)
XT-
5-D
MX
T-5-
DM
CC
XT-
5-D
MC
XT-
5-D
BM
ME
RC
ON
® L
VX
T-10
-QLV
XT-
10-Q
LV
TYP
E F
XT-
1-Q
FC
XT-
1-LF
12
SA
E 7
5W-9
0 A
PI G
L-4
GE
AR
OIL
(QU
AR
TS)
XY-
75W
90-Q
GL
XY-
75W
90-Q
GL
FULL
SY
NTH
ETI
C
MA
NU
AL
TRA
NS
MIS
-S
ION
FLU
ID (Q
UA
RTS
)X
T-M
5-Q
SX
T-M
5-Q
S
ME
RC
ON
® S
P(Q
UA
RTS
)X
T-6-
QS
PC
XT-
6-LS
P12
ME
RC
ON
® S
P(D
RU
MS
)X
T-6-
DS
PC
XT-
6-D
SP
PR
EM
IUM
AU
TOM
ATIC
TR
AN
SM
ISS
ION
FLU
IDX
T-8-
QAW
CX
T-8-
LAW
12
***
CV
T FL
UID
CH
AIN
TY
PE
XT-
7-Q
CFT
CX
T-7-
LCF1
2
FNR
5 A
UTO
MAT
ICTR
AN
SM
ISS
ION
FLU
IDX
T-9-
QM
M5
XT-
9-Q
MM
5
SA
E 7
5W-9
0 P
RE
MIU
M
SY
NTH
ETI
C T
RA
NS
-A
XLE
LU
BR
ICA
NT
XT-
75W
90-Q
GT
XT-
75W
90-Q
GT
U
SA A
ND
CA
NA
DA
OIL
AN
D T
RA
NSM
ISSI
ON
FLU
ID P
AR
T N
UM
BER
INTE
RC
HA
NG
E
*** C
ontin
uous
ly v
aria
ble
chai
n ty
pe tr
ansm
issi
on fl
uid
M
AN
UA
L TR
AN
SMIS
SIO
N F
LUID
CH
AR
T
MER
CO
N®
V- P
art n
umbe
r XT-
5-Q
M (Q
uarts
) and
XT-
5-D
M (5
5 G
allo
n D
rum
).
MER
CO
N® S
YNTH
ETIC
- Par
t num
ber X
T-2-
QS
M (Q
uarts
), Fo
rd s
peci
ficat
ion
ES
R-M
2C16
3-A
2.
FULL
SYN
THET
IC M
AN
UA
L TR
AN
SMIS
SIO
N F
LUID
- P
art n
umbe
r XT-
M5-
QS
(Qua
rts).
Ford
spe
cific
atio
n W
SD
-M2C
200-
C.
SAE7
5W-9
0 PR
EMIU
M S
YNTH
ETIC
TR
AN
SAXL
E LU
BR
ICA
NT
- Par
t num
ber X
T-75
W90
-QG
T (Q
uarts
).
SAE7
5W-9
0 A
PI G
L-4
GEA
R O
IL
- Par
t num
ber X
Y-75
W90
-QG
L. F
ord
spec
ifica
tion
WS
S-M
2C20
3-A
1.
FsV GL-
4
Ms
GT
Quick Reference Charts
| 66 |
Qui
ck
Ref
eren
ce
Cha
rts
CapacityCoolingSystem(Quarts)
PROTECTION CHARTQuarts of Engine Coolant Required for Protection to Temperatures (°F) Shown
2 3 4 5 6 7 8 9 10 11 12
6 0 -34 A 50/50 mixture (coolant/distilled water) is recommended as it provides freeze protection down to -34 °F (-36.7 °C) and boiling protection up to 265 °F (129 °C). DO NOT ALLOW the concentration of coolant to fall below 40% or exceed 60% as engine parts could become damaged or not work properly. Shaded blocks show 50% concentration to the next higher full quart.
7 6 -18 -54
8 10 -8 -34
9 14 0 -21 -50
10 16 4 -12 -34 -62
11 18 8 -6 -23 -47
12 19 10 0 -15 -34 -57
13 21 13 3 -9 -25 -45
14 22 15 6 -5 -18 -34 -54
15 23 16 8 0 -12 -26 -43
16 23 17 10 2 -8 -19 -34 -52
17 24 18 12 5 -4 -14 -27 -42
18 24 19 14 7 0 -10 -21 -34 -50
19 25 20 15 9 2 -7 -16 -28 -42
20 25 21 16 10 4 -3 -12 -22 -34 -48
21 22 17 12 6 0 -9 -17 -28 -41
22 22 18 13 8 2 -6 -14 -23 -34 -47
ETHYLENE GLYCOL HYDROMETER SCALE - For cooling systems larger than shown, use double the quantity required for a system one-half as large. For systems smaller than shown, use half the quantity required for a system twice as large.
Ethylene Glycol-Based Engine Coolant Protection Chart
| 67 |
Quick Reference
Charts
* Gulf Coast Consulate (GCC) - F-Series <8500 requires 49 ounces and Excursion requires 56 ounces** Export vehicles w/o aux require 32 ounces and w/aux require 46 ounces*** Explorer/Explorer Sport Trac/Mountaineer units built after 12/3/07 use the lower of the two values, those built before 12/3/07 use the higher value. Confirm with label on vehicle. Version 5.0 / Published 4/08
R-134a REFRIGERANT CHARGE CAPACITIES IN OUNCES
TRUCK 1998 1999 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009AVIATOR 46BLACKWOOD 37ECONOLINE DIESEL 44 42 40 32 36ECONOLINE DIESEL w/AUX 64 68 60 54ECONOLINE GAS 44 42 40 30ECONOLINE GAS w/AUX 64 68 60 54EDGE 19.4 21ESCAPE 32 25ESCAPE HEV (HYBRID) 41 38EXCURSION 42 45EXCURSION w/AUX 68*EXPEDITION 37 40 22EXPEDITION w/AUX 62 58 33EXPLORER 30 32** 31 31/27*** 27EXPLORER SPORT 30EXPLORER SPORT TRAC 30 31 31/27*** 27EXPLORER w/AUX 56** 47 47/44*** 44FLEX 38FREESTAR 36FREESTAR w/AUX 53FREESTYLE 29FREESTYLE w/AUX 38F-SERIES < 8500 GVW 33* 37 34 36 24F-SERIES > 8500 GVW 38 42 45 27F-SERIES F650-F750 42 40LCF 44MARK LT 34 36 24MKX 19.4 21MARINER 32 25MARINER HEV (HYBRID) 41 38MONTEREY 36MONTEREY w/AUX 53MOUNTAINEER 30 32 31 31/27*** 27MOUNTAINEER w/AUX 56** 47 47/44*** 44NAVIGATOR 37 40NAVIGATOR w/AUX 62 58 33RANGER 30 33TAURUS X 26TAURUS X w/AUX 36VILLAGER 32VILLAGER w/AUX 52WINDSTAR 44WINDSTAR w/AUX 56
CAR 1998 1999 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009CONTINENTAL 38CONTOUR 26COUGAR 26CROWN VICTORIA 38 38 27ESCORT 28 28* 28 24FIVE HUNDRED 29FOCUS 26 18FUSION 21GRAND MARQUIS 38 38 27GT 18LS 28MARK VIII 32MILAN 21MKS 26MKZ 21MONTEGO 29MUSTANG 34 31 26MYSTIQUE 26SABLE 34 26TAURUS 34 26THUNDERBIRD 28TOWN CAR 38 32 23TRACER (U.S.) 28ZEPHYR 21* = 99-00 2.0L ZETEC requires a charge of 24 ounces
| 68 |
Qui
ck
Ref
eren
ce
Cha
rts * Export vehicles require 4/14 - Gulf Coast Consulate (GCC) require 17/503** 2004 F-150 Heritage requires 9/266
REFRIGERANT COMPRESSOR OIL CAPACITIES IN FLUID OZ. / CC
TRUCK 1998 1999 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009AVIATOR 14/414BLACKWOOD 9/266ECONOLINE DIESEL 9/266 7/207ECONOLINE DIESEL w/AUX 13/384 11/325ECONOLINE GAS 9/266 8/237ECONOLINE GAS w/AUX 13/384 16/473EDGE 4/118ESCAPE 7/207 5/148ESCAPE HEV (HYBRID) 11/325EXCURSION 9/266EXCURSION w/AUX 14/414EXPEDITION 9/266 7/207EXPEDITION w/AUX 14/414 11/325 14/414 7/207EXPLORER 9/266EXPLORER SPORT 9/266EXPLORER SPORT TRAC 9/266 9/266EXPLORER w/AUX 13/384* 16/473FLEX 11/325FREESTAR 10/296FREESTAR w/AUX 12/355FREESTYLE 7/207FREESTYLE w/AUX 9/266F-SERIES < 8500 GVW 9/266 8/237** 8/237 6/178F-SERIES > 8500 GVW 11/325 9/266F-SERIES F650-F750 9/266LCF 9/266 7/207MARK LT 8/237 6/178MKX 4/118MARINER 7/207 5/148MARINER HEV (HYBRID) 11/325MONTEREY 10/296MONTEREY w/AUX 12/355MOUNTAINEER 9/266MOUNTAINEER w/AUX 13/384 16/473NAVIGATOR 9/266NAVIGATOR w/AUX 14/414 11/325 14/414 7/207RANGER 9/266TAURUS X 7/207TAURUS X w/AUX 9.5/281VILLAGER 7/207VILLAGER w/AUX 10/296 11/325WINDSTAR 10/296WINDSTAR w/AUX 14/414
CAR 1998 1999 2000 2001 2002 2003 2004 2005 2006 2007 2008 2009CONTINENTAL 7/207CONTOUR 7/207COUGAR 7/207CROWN VICTORIA 7.5/222 7/207ESCORT 6.6/195 7/207FIVE HUNDRED 7/207FOCUS 7/207 4/118FUSION 6/178GRAND MARQUIS 7.5/222 7/207GT 10/296LS 7/207MARK VIII 7/207MILAN 6/178MKS 7/207MKZ 6/178MONTEGO 7/207MUSTANG 8.6/254 7/207MYSTIQUE 7/207SABLE 6.6/195 7/207TAURUS 6.6/195 7/207THUNDERBIRD 7/207TOWN CAR 7.5/222 8/237 7/207TRACER (U.S.) 7/207ZEPHYR 6/178
Version 5.0 / Published 4/08Quick Reference Charts 1
| 69 |
Quick
Reference C
harts
| 1 |Quick Reference Charts
Service Coolant Usage Chart
Vehicle
Model Year
Pre-1999 1999-2001 2002 2003 2004 and forward
Ford
Crown Victoria G GY GYGY (prior to 7/15/02)
YY (from 7/15/02)
Econoline / E-Series (Lorain Plant)
G GYGY (prior to 1/7/02)
Y YY (from 1/7/02)
Electric Vehicle Ranger N/A GY GY N/A N/A
Escape** N/A GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Escort G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Excursion*** N/A GY Y Y Y
Expedition G GY GYGY (prior to 7/15/02)
YY (from 7/15/02)
Explorer, Explorer Sport, and Explorer Sport Trac
G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
F150 - F550 (Cuautitlan Plant)
G GYGY (prior to 2/4/02)
Y YY (from 2/4/02)
F650 - F750 (Cuautitlan Plant)
G GYGY (prior to 1/28/02)
Y YY (from 1/28/02)
F250 - F550 (Kentucky Truck Plant)
G GY Y Y Y
F150 - F750 (All other plants)
G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Freestar N/A N/A N/A N/A Y
Focus*** N/A GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Mustang (including Cobra) G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Ranger G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Super Duty F53 Stripped Chassis (Trumac)
G GY Y Y Y
Taurus G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Thunderbird N/A N/AGY (prior to 7/15/02)
Y YY (from 7/15/02)
Windstar G GY GYGY (prior to 7/15/02)
N/AY (from 7/15/02)
All other vehicles G GY N/A N/A Y
| 70 |
Qui
ck
Ref
eren
ce
Cha
rts
| 2 | Quick Reference Charts
Service Coolant Usage Chart
Vehicle
Model Year
Pre-1999 1999-2001 2002 2003 2004 and forward
Lincoln
Aviator N/A N/A N/A Y Y
Blackwood*** N/A GYGY (prior to 7/15/02)
N/A N/AY (from 7/15/02)
Continental G GYGY (prior to 7/15/02)
N/A N/AY (from 7/15/02)
LS*** N/A GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Navigator G GY GYGY (prior to 7/15/02)
YY (from 7/15/02)
Town Car G GY GYGY (prior to 7/15/02)
YY (from 7/15/02)
All other vehicles G N/A N/A N/A Y
Mercury
Cougar G O O N/A N/A
Grand Marquis G GY GYGY (prior to 7/15/02)
YY (from 7/15/02)
Sable G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
Marauder N/A N/A N/AGY (prior to 7/15/02)
YY (from 7/15/02)
Monterey N/A N/A N/A N/A Y
Mountaineer G GYGY (prior to 7/15/02)
Y YY (from 7/15/02)
All other vehicles G GY GY N/A Y
Usage Notes:G = Green-colored engine coolant meeting Ford Specification ESE-M97B44-A (Motorcraft Premium Engine Coolant with Bittering Agent, VC-5 and VC-5-B)GY = Factory filled with green-colored engine coolant. Service as normal with green-colored engine coolant, or service with yellow-colored engine coolant with the following important conditions:1. If the green-colored engine coolant is thoroughly flushed out of the cooling system and then the system is filled with yellow-colored engine coolant, the system maintenance (change-out) intervals of the yellow-colored engine coolant can be followed.2. If the green-colored engine coolant is not completely flushed out of the cooling system (e.g.. yellow-colored engine coolant is used to top off the system), then the service maintenance (change-out) intervals of the green-colored engine coolant must be followed.3. All pre-1999 vehicles, as well as all model years of Mercury Villager, must be serviced with the green-colored engine coolant.O = Orange-colored engine coolant meeting Ford specification WSS-M97B44-D (Motorcraft Specialty Orange Engine Coolant with Bittering Agent, VC-3)Y = Yellow-colored engine coolant meeting Ford specification WSS-M97B51-A1 (Motorcraft Premium Gold Engine Coolant with Bittering Agent, VC-7-B and VC-7-D)
** = Introduced with Model Year 2001
*** = Introduced with Model Year 2000
Revised 5/3/06
| 71 |
Quick
Reference C
harts
2004 - 2008 Interior Trim Parts — Plastic Types
Plastic Trim Part Vehicle Plastic TypeUse Adhesion
Promoter?
ConsolesAll 2004 - 2008 Ford, Lincoln, and Mercury vehicles Soft No
PillarsAll 2004 - 2008 Ford, Lincoln, and Mercury vehicles Hard Yes
Lower Door PanelsAll 2004 - 2008 Ford, Lincoln, and Mercury vehicles Hard Yes
Upper Door Panels
All 2004 - 2008 Ford and Mercury vehicles Hard YesAll 2004 - 2008 Lincoln vehicles Soft No
Instrument Panels*
2004 - 2005 Excursion2004 - 2008 Escape, Expedition, F150, F250-750, Focus, Mariner, and Mustang Hard YesAll other 2004 - 2008 vehicles** Soft No
* Note: Never repair or repaint airbag deployment covers (doors)** Note the following exceptions:(1) Do not use the adhesion promoter or paint on the Lincoln Mark LT, Edge, or MKX for paint-to-match or repair procedures
(2) Do not use the adhesion promoter or paint on the Freestyle and Taurus X for repair procedures
| 72 |
Qui
ck
Ref
eren
ce
Cha
rts
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Ford Division Lincoln Mercury Division
Curr
ent o
r Ne
w
Focu
s
Mus
tang
/Sh
elby
GT5
00
Crow
n Vi
ctor
ia
Fusi
on
Taur
us
Gran
d M
arqu
is
Mila
n
Sabl
e
Tow
n Ca
r
MKZ
(c) = Clear gloss improver. May darken basecoat.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
Step OneUnscrewblack capfrom tube.
Step TwoRemoveand discardorangeinsert.
Step ThreeScrew blackcap on tubeand shake penvigorously forproper colormatch.
Step FourActivate Roller Ballby pressing downon tip whilemoving pen.Practice techniquebefore doingrepair.
How to Activate the Roller Ball
D2 Moss/Moss Green ��Met. Moss Green PMP-19500-7192A N X X X
D3 Torch Red � Colorado Red � PMP-19500-7042A C X
DI Dark Blue Ink/Dark Ink Blue ��Met. Dark Ink Blue PMP-19500-7187A N X X X X X
DV Light Tundra � Met./Titanium Green ��Met. Light Tundra PMP-19500-7081A C X X
DX Dark Blue Pearl ��Met.� Dk. Pearl Blue PMP-19500-7083A C X
E4 Vermilion Red Vermilion Red � PMP-19500-6470A C X
FX Merlot � Met. Merlot PMP-19500-7087A C X X
G2 Vivid Red � Met./Redfire � Met. Redfire PMP-19500-7089A C X X X
G3 Light French Silk � Met. Pueblo Gold PMP-19500-7113A C X
G5 Alloy ��Met. Alloy PMP-19500-7116A C X X X
G9 Vista Blue � Met./Vista Blue Vista Blue PMP-19500-7147A C X X
HG Smokestone ��Met. Smokestone PMP-19500-7148A C X X
HH Dark Cherry ��Met. Dark Cherry PMP-19500-7149A C X
HP Performance White � High Performance White PMP-19500-7139A C X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X X X X X X
JV Dark Candy Apple Red � Met. Sangria Red PMP-19500-7197A N X
KR Norsea Blue ��Met. Norsea Blue PMP-19500-7111A C X X
LS Lt. Ice Blue � Met./Lt. Ice Blue Light Ice Blue � PMP-19500-7054A C X X X X X X
ND Dune Pearl � Met. Dune Pearl PMP-19500-7150A C X X X X X
NH Light Sage/Light Sage � Met. Light Sage PMP-19500-7146A C X X X X X
NZ Kiwi Green � Kiwi Green PMP-19500-7174A C X
P3 Windveil Blue � Met. Windveil Blue PMP-19500-7134A C X
P6 Moss/Moss Green � Met. Moss Green PMP-19500-7192A N X X X
PX Highland Green � Dark Highland Green PMP-19500-6920A C X
TS Silver Frost Silver Frost � PMP-19500-6720A C X
U3 Grabber Orange � Valencia PMP-19500-7178A C X
UA Black �/Ebony � Black PMP-19500-1724A C X X X X X X X X X X
WS White Suede � White Suede PMP-19500-7193A N X X X
WT Vibrant White � Performance White � PMP-19500-1028A C X X X
YN Silver ��Met. Light Charcoal Met. � PMP-19500-6041A C X
YZ Oxford White �/Oxford White White � PMP-19500-5920A C X X X
ZY Vapor ��Met./Vapor Silver ��Met. Vapor Silver PMP-19500-7195A N X X X X X
SPECIAL PAINTS �Primer (g) PMP-19500-1000 C X X X X X X X X X X
Clear Topcoat (c) PMP-19500-6000 C X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X
2008 PASSENGER CAR EXTERIOR PAINT CHART
| 2 |
| 73 |
Quick
Reference C
harts
BY Yellow � Chrome Yellow PMP-19500-1526A C X
CX Dark Shadow Grey � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X
D2 Moss Green � Met. Moss Green PMP-19500-7192A N X
D3 Torch Red �/Colorado Red Colorado Red � PMP-19500-7042A C X X (b) X
DI Dark Blue Ink ��Met. Dark Ink Blue PMP-19500-7187A N X X X
DV Titanium Green Met. Light Tundra PMP-19500-7081A C X
DX Dark Pearl Blue � Met. Dk. Pearl Blue PMP-19500-7083A C X X X X X X X
E4 Vermilion Red �/Bright Red ��Met. Vermilion Red � PMP-19500-6470A C X X X
F1 Red � Vermilion Red � PMP-19500-6470A C X
FL Toreador Red � Toreador Red � PMP-19500-6758A C X
FX Merlot ��Met. Merlot PMP-19500-7087A C X
G2 Redfire ��Met./Vivid Red ��Met. Redfire PMP-19500-7089A C X X X X X X X X X X X X
G3 Pueblo Gold � Met./Light French Silk � Met. Pueblo Gold PMP-19500-7113A C X (b) X X X X X X
G5 Alloy � Met. Alloy PMP-19500-7116A C X
G9 Vista Blue � Met. Vista Blue PMP-19500-7147A C X X
GG Forest Green � Met. Forest Green PMP-19500-7175A C X X X
GW Blazing Copper ��Met. Orange Crush Pearl PMP-19500-7110A C X
HH Dark Cherry ��Met. Dark Cherry PMP-19500-7149A C X X X
HR Vintage Copper Vintage Copper PMP-19500-7200A N (a) (a) (a)
HS Stone Green � Met. Earth PMP-19500-7190A N X X X X X X
HT Mahogany � Met. Cinnamon PMP-19500-7186A N X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X
JM Dark Toreador Red � Dk. Toreador Red PMP-19500-6771A C X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X
L2 True Blue True Blue PMP-19500-7023A C X
LS Lt. Ice Blue � Met. Lt. Ice Blue � PMP-19500-7054A C X X X X X
ND Dune Pearl ��Met. Dune Pearl PMP-19500-7150A C X
NH Light Sage ��Met. Light Sage PMP-19500-7146A C X X X
NL Orange Frost ��Met. Orange Frost PMP-19500-7172A C X X
NZ Kiwi ��Met./Kiwi Green � Kiwi Green PMP-19500-7174A C X X
P5 Aspen Green � Aspen Green � PMP-19500-7056A C X
P6 Moss Green ��Met. Moss Green PMP-19500-7192A N X
PH Crème Brulee � Crème Brulee PMP-19500-7176A C X X
PV White Sand Tri-Coat �/White Chocolate ��Tri-Coat White Chocolate Tricoat PMP-19500-7167A C X X X X X X X X
T5 Dark Copper � Met. Dark Copper PMP-19500-7133A C X X
T7 Dark Stone ��Met. Charcoal Beige PMP-19500-7136A C X
T8 Tungsten Grey ��Met. Tungsten Gray PMP-19500-7145A C X X
T9 Black Pearl Slate ��Met. Monterey Met. PMP-19500-7173A N X X
U3 Grabber Orange � Met. Valencia PMP-19500-7178A C X
UA Black ��Met./Ebony � Black PMP-19500-1724A C X X X X X X X X X X X X X X X
UD Black � Black PMP-19500-1724A C X
WS White Suede ��Met. White Suede PMP-19500-7193A N X X X X X
YN Silver Met. � Lt. Charcoal Met. � PMP-19500-6041A C X X X X X X X
YZ Oxford White � White � PMP-19500-5920A C X (b) (b) X X X X X X X
Z1 Oxford White � White � PMP-19500-5920A C X
Z3 Silver Met. Lt. Charcoal Met. � PMP-19500-6041A C X
ZY Vapor Silver ��Met. Vapor Silver PMP-19500-7195A N X X X X X X X
SPECIAL PAINTS �
Primer (g) PMP-19500-1000 C X X X X X X X X X X X X X X X
Clear Topcoat (c)� PMP-19500-6000 C X X X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X X X X X X
Med. Dark Platinum� PMP-19500-7060G C X X
Silver Eclipse PMP-19500-7128A N (a)
Page 3ORDER THROUGH YOUR D.O.E.S. II SYSTEM
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Curr
ent o
r Ne
w
Edge
Econ
olin
e
Expl
orer
Expl
orer
Spo
rt T
rac
Expe
ditio
n
Rang
er
F-Se
ries
Supe
r Du
ty
F-Se
ries
(F-1
50)
Esca
pe/H
ybrid
Taur
us X
MKX
Mar
iner
Mar
k LT
Navi
gato
r
Mou
ntai
neer
2008 TRUCK, VAN, SPORT UTILITY & CROSSOVERUTILITY VEHICLE EXTERIOR PAINT CHART
Ford Division LM Division
(a) = Accent color.(b) = Special vehicle option.(c) = Clear gloss improver. May darken basecoat.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
2008 TRUCK, VAN, SPORT UTILITY & CROSSOVER UTILITY VEHICLE EXTERIOR PAINT CHART
| 3 |
| 74 |
Qui
ck
Ref
eren
ce
Cha
rts
2 Light Graphite X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002H
4 Chamois X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
9 Charcoal X X Black PM-19M547-4149HBlack X X Charcoal Black PM-19M547-0001H
A Black X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
B Medium Flint/Black X X X Black PM-19M547-4149HEbony X Charcoal Black PM-19M547-0001HDove Grey X Lt. Flint PM-19M547-2003H
C Camel X X X X X X X X X X Black PM-19M547-4149HParchment X X X X X Charcoal Black PM-19M547-0001H
X X X X X X X X Camel PM-19M547-0003HX Cashmere PM-19M547-0004H
X X Lt. Camel PM-19M547-0005HX X X Med. Camel PM-19M547-0006H
X X Greystone PM-19M547-0007HX X X Sand PM-19M547-0009H
X X Dusk Gray PM-19M547-0013HX Med. Dark Camel PM-19M547-0014H
X King Ranch Red PM-19M547-0015HX Dark Foundry PM-19M547-0016H
X Dark Stone PM-19M547-2012HX Med. Satin Nickel PM-19M547-2015H
D Dove X X Black PM-19M547-4149HLight Camel X X Charcoal Black PM-19M547-0001H
X Camel PM-19M547-0003HX Lt. Camel PM-19M547-0005HX Greystone PM-19M547-0007HX Med. Satin Nickel PM-19M547-2015H
E Medium Flint X X Black PM-19M547-4149HX X Med. Flint PM-19M547-2001H
X Dark Flint PM-19M547-2002HX X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
F Medium Dark Flint X Black PM-19M547-4149HX Med. Dk. Flint PM-19M547-2004H
G Medium Light Stone X Black PM-19M547-4149HX Greystone PM-19M547-0007HX Med. Lt. Stone PM-19M547-2011HX Med. Satin Nickel PM-19M547-2015H
H Medium Parchment X X Black PM-19M547-4149HCamel X X Charcoal Black PM-19M547-0001H
X X Camel PM-19M547-0003HX Med. Camel PM-19M547-0006HX Sand PM-19M547-0009H
J Light Camel X X Black PM-19M547-4149HX X Camel PM-19M547-0003HX X Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006H
X Dusk Gray PM-19M547-0013HK Light Camel X Black PM-19M547-4149H
X Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006HX Med. Satin Nickel PM-19M547-2015H
L Stone X X X X X X X X X X Black PM-19M547-4149HMedium Light Stone X X X Charcoal Black PM-19M547-0001HEbony X Med. Dove PM-19M547-0002H
X X X X X Greystone PM-19M547-0007HX X X Lt. Stone PM-19M547-0008H
X Med. Dk. Flint PM-19M547-2004HX X X X X X X X X Med. Lt. Stone PM-19M547-2011H
X X Dusk Gray PM-19M547-0013HX X Med. Satin Nickel PM-19M547-2015H
N Charcoal Black X X Black PM-19M547-4149HCharcoal X X Charcoal Black PM-19M547-0001HBlack X Med. Satin Nickel PM-19M547-2015H
P Dark Pebble X Black PM-19M547-4149HMedium Pebble Tan X Med. Pebble PM-19M547-2016H
R Red Accent X X Black PM-19M547-4149HCrimson Red X X Charcoal Black PM-19M547-0001H
Page 4 ORDER THROUGH YOUR D.O.E.S. II SYSTEM
Fusi
on/M
ilan
Focu
s
Shel
by G
T500
Mus
tang
Taur
us
MKZ
Crw
n.Vi
c./G
nd.M
ar.
Tow
n Ca
r
Mou
ntai
neer
MKX
Navi
gato
r
Mar
k LT
Mar
iner
/Hyb
rid
Expe
ditio
n
Esca
pe/H
ybrid
Edge
F-Se
ries
(F-1
50)
F-Se
ries
Supe
r Du
ty
Rang
er
Taur
us X
Expl
orer
/Spo
rt T
rac
Econ
olin
e
Sabl
e
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks, Vans, Sport Utility & Crossover Vehicles
| 4 |
2008 INTERIOR PAINT AVAILABILITY CHART
2 Light Graphite X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002H
4 Chamois X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
9 Charcoal X X Black PM-19M547-4149HBlack X X Charcoal Black PM-19M547-0001H
A Black X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
B Medium Flint/Black X X X Black PM-19M547-4149HEbony X Charcoal Black PM-19M547-0001HDove Grey X Lt. Flint PM-19M547-2003H
C Camel X X X X X X X X X X Black PM-19M547-4149HParchment X X X X X Charcoal Black PM-19M547-0001H
X X X X X X X X Camel PM-19M547-0003HX Cashmere PM-19M547-0004H
X X Lt. Camel PM-19M547-0005HX X X Med. Camel PM-19M547-0006H
X X Greystone PM-19M547-0007HX X X Sand PM-19M547-0009H
X X Dusk Gray PM-19M547-0013HX Med. Dark Camel PM-19M547-0014H
X King Ranch Red PM-19M547-0015HX Dark Foundry PM-19M547-0016H
X Dark Stone PM-19M547-2012HX Med. Satin Nickel PM-19M547-2015H
D Dove X X Black PM-19M547-4149HLight Camel X X Charcoal Black PM-19M547-0001H
X Camel PM-19M547-0003HX Lt. Camel PM-19M547-0005HX Greystone PM-19M547-0007HX Med. Satin Nickel PM-19M547-2015H
E Medium Flint X X Black PM-19M547-4149HX X Med. Flint PM-19M547-2001H
X Dark Flint PM-19M547-2002HX X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
F Medium Dark Flint X Black PM-19M547-4149HX Med. Dk. Flint PM-19M547-2004H
G Medium Light Stone X Black PM-19M547-4149HX Greystone PM-19M547-0007HX Med. Lt. Stone PM-19M547-2011HX Med. Satin Nickel PM-19M547-2015H
H Medium Parchment X X Black PM-19M547-4149HCamel X X Charcoal Black PM-19M547-0001H
X X Camel PM-19M547-0003HX Med. Camel PM-19M547-0006HX Sand PM-19M547-0009H
J Light Camel X X Black PM-19M547-4149HX X Camel PM-19M547-0003HX X Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006H
X Dusk Gray PM-19M547-0013HK Light Camel X Black PM-19M547-4149H
X Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006HX Med. Satin Nickel PM-19M547-2015H
L Stone X X X X X X X X X X Black PM-19M547-4149HMedium Light Stone X X X Charcoal Black PM-19M547-0001HEbony X Med. Dove PM-19M547-0002H
X X X X X Greystone PM-19M547-0007HX X X Lt. Stone PM-19M547-0008H
X Med. Dk. Flint PM-19M547-2004HX X X X X X X X X Med. Lt. Stone PM-19M547-2011H
X X Dusk Gray PM-19M547-0013HX X Med. Satin Nickel PM-19M547-2015H
N Charcoal Black X X Black PM-19M547-4149HCharcoal X X Charcoal Black PM-19M547-0001HBlack X Med. Satin Nickel PM-19M547-2015H
P Dark Pebble X Black PM-19M547-4149HMedium Pebble Tan X Med. Pebble PM-19M547-2016H
R Red Accent X X Black PM-19M547-4149HCrimson Red X X Charcoal Black PM-19M547-0001H
Page 4 ORDER THROUGH YOUR D.O.E.S. II SYSTEM
Fusi
on/M
ilan
Focu
s
Shel
by G
T500
Mus
tang
Taur
us
MKZ
Crw
n.Vi
c./G
nd.M
ar.
Tow
n Ca
r
Mou
ntai
neer
MKX
Navi
gato
r
Mar
k LT
Mar
iner
/Hyb
rid
Expe
ditio
n
Esca
pe/H
ybrid
Edge
F-Se
ries
(F-1
50)
F-Se
ries
Supe
r Du
ty
Rang
er
Taur
us X
Expl
orer
/Spo
rt T
rac
Econ
olin
e
Sabl
e
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks, Vans, Sport Utility & Crossover Vehicles
| 4 |
2008 INTERIOR PAINT AVAILABILITY CHART
| 75 |
Quick
Reference C
harts
2008 INTERIOR PAINT AVAILABILITY CHART
Important Usage Information• When using any Ford Automotive Interior Spray Lacquer color M4JZ-19m547-XXXXH, Motorcraft Adhesion Promoter, PM-19A316-AA, or equivalent MUST be used according to the product’s direcitons to prime all plastic interior trim parts prior to color application.• When using Motorcraft Interior Spray Paint color, PM-19M547-XXXXH, refer to the Interior Spray Paint TSB for additional usage information and reference the 2004-2008 Interior Trim Parts - Plastic Types quick reference chart.
| 76 |
Qui
ckR
efer
ence
Cha
rts
Trim Code
Trim Color
Passenger Cars Trucks
Interior Paint Color Name
InteriorPaintPart
Number
Crw
n. V
ic./G
nd. M
ar.
Focu
s
Fusi
on/M
ilan
Mus
tang
Shel
by G
T500
Taur
us
Sabl
e
MK
Z
Tow
n C
ar
Econ
olin
e
Edge
Esca
pe/H
ybrid
Expe
ditio
n
Expl
orer
/Spo
rt T
rac
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Ran
ge
Taur
us X
Mar
iner
/Hyb
rid
Mou
ntai
neer
Mar
k LT
MK
X
Nav
igat
or
S Sand X X X X X Black PM-19M547-4149HStone X Charcoal Black PM-19M547-0001HMedium Stone X X Cashmere PM-19M547-0004H
X Med. Camel PM-19M547-0006HX X X X Graystone PM-19M547-0007HX Lt. Stone PM-19M547-0008H
X Sand PM-19M547-0009HX Dk. Foundry PM-19M547-0016H
X X X Med. Lt. Stone PM-19M547-2011HX Med. Satin Nickel PM-19M547-2015H
X X Med. Stone PM-19M547-2022HT Lt. Stone X Black PM-19M547-4149H
X Charcoal Black PM-19M547-0001HX Lt. Stone PM-19M547-0008HX Med. Satin Nickel PM-19M547-2015H
W Black X X X X X X X X X X X X X X Black PM-19M547-4149HCharcoal Black X X X X X X X X X X X X X X Charcoal Black PM-19M547-0001HDark Charcoal (b) X Camel PM-19M547-0003H
X Lt. Camel PM-19M547-0005HX X X Lt. Stone PM-19M547-0008H
X Sand PM-19M547-0009HX X X X X Med. Lt. Stone PM-19M547-2011H
X X X Med. Satin Nickel PM-19M547-2015HW Medium Pebble X Black PM-19M547-4149H
X Lt. Parchment PM-19M547-1076HX Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
W Tan X X Black PM-19M547-4149HLight Parchment X King Ranch Red PM-19M547-0015H
X X Lt. Parchment PM-19M547-1076HX X Med. Pebble PM-19M547-2016HX Dk. Pebble PM-19M547-2018H
(b) = Explorer only.
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
| 76 |
Qui
ck
Ref
eren
ce
Cha
rts
2007 PASSENGER CAR EXTERIOR PAINT CHART
| 77 |
Quick
ReferenceC
harts
(b) = Explorer only.
Trim Code
Trim Color
Passenger Cars Trucks
Interior Paint Color Name
InteriorPaintPart
Number
Crw
n. V
ic./G
nd. M
ar.
Focu
s
Fusi
on/M
ilan
Mus
tang
Shel
by G
T500
Taur
us
Sabl
e
MK
Z
Tow
n C
ar
Econ
olin
e
Edge
Esca
pe/H
ybrid
Expe
ditio
n
Expl
orer
/Spo
rt T
rac
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Ran
ge
Taur
us X
Mar
iner
/Hyb
rid
Mou
ntai
neer
Mar
k LT
MK
X
Nav
igat
or
S Sand X X X X X Black PM-19M547-4149HStone X Charcoal Black PM-19M547-0001HMedium Stone X X Cashmere PM-19M547-0004H
X Med. Camel PM-19M547-0006HX X X X Graystone PM-19M547-0007HX Lt. Stone PM-19M547-0008H
X Sand PM-19M547-0009HX Dk. Foundry PM-19M547-0016H
X X X Med. Lt. Stone PM-19M547-2011HX Med. Satin Nickel PM-19M547-2015H
X X Med. Stone PM-19M547-2022HT Lt. Stone X Black PM-19M547-4149H
X Charcoal Black PM-19M547-0001HX Lt. Stone PM-19M547-0008HX Med. Satin Nickel PM-19M547-2015H
W Black X X X X X X X X X X X X X X Black PM-19M547-4149HCharcoal Black X X X X X X X X X X X X X X Charcoal Black PM-19M547-0001HDark Charcoal (b) X Camel PM-19M547-0003H
X Lt. Camel PM-19M547-0005HX X X Lt. Stone PM-19M547-0008H
X Sand PM-19M547-0009HX X X X X Med. Lt. Stone PM-19M547-2011H
X X X Med. Satin Nickel PM-19M547-2015HW Medium Pebble X Black PM-19M547-4149H
X Lt. Parchment PM-19M547-1076HX Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
W Tan X X Black PM-19M547-4149HLight Parchment X King Ranch Red PM-19M547-0015H
X X Lt. Parchment PM-19M547-1076HX X Med. Pebble PM-19M547-2016HX Dk. Pebble PM-19M547-2018H
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
| 77 |
Quick
Reference C
harts
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X
BY Yellow � Chrome Yellow PMP-19500-1526A C X
CX Dark Shadow Grey � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X
D3 Torch Red � Colorado Red � PMP-19500-7042A C X
D6 Screaming Yellow � Screaming Yellow PMP-19500-7109A C X
DV Titanium Green ��Met./Titanium Green Met. Light Tundra PMP-19500-7081A C X X X X XLight Tundra ��Met.
DX Dark Pearl Blue � Met./Dark Blue Pearl � Met./ Dk. Pearl Blue PMP-19500-7083A C X X X X X X X XDark Blue Pearl �
E4 Vermilion Red �/Bright Red � Vermilion Red � PMP-19500-6470A C X X X
F1 Red � Vermilion Red � PMP-19500-6470A C X X
FL Toreador Red � Toreador Red � PMP-19500-6758A C X
FU Dark Green Satin � Met. Dk. Green Satin � PMP-19500-6862A C X
FW Dark Green Satin ��Met. Dk. Green Satin � PMP-19500-6862A C X
FX Merlot ��Met. Merlot PMP-19500-7087A C X
G2 Redfire � Met./Redfire Met./Red Fire ��Met./ Redfire PMP-19500-7089A C X X X X X X X X X X X X XVivid Red ��Met./Red Fire �
G3 Pueblo Gold/Light French Silk � Met./ Pueblo Gold PMP-19500-7113A C X X X X X X X XPueblo Gold � Met.
G5 Carbon Metallic/ Alloy � Met./Alloy �/ Alloy PMP-19500-7116A N X X X X X X X X X XCarbon � Met.
G9 Vista Blue � Met. Vista Blue PMP-19500-7147A C X X
GG Forest Green/Forest Green � Met. Forest Green PMP-19500-7175A N X X
GW Blazing Copper Met./Blazing Copper � Met. Orange Crush Pearl PMP-19500-7110A C X X
HH Dark Cherry ��Met. Dark Cherry PMP-19500-7149A C X X X
HJ Pewter Met./Pewter ��Met. Pewter Met. PMP-19500-7151A C X X X X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X X
JM Dark Toreador Red � Dk. Toreador Red PMP-19500-6771A C X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X X X X
L2 True Blue � Met. True Blue PMP-19500-7023A C X
LD Medium Wedgewood Blue � Met. Med. Wedgewood � PMP-19500-6763A C X
ND Dune Pearl Met./Dune Pearl ��Met. Dune Pearl PMP-19500-7150A C X X X X X X X
NH Light Sage Met. Light Sage PMP-19500-7146A C X X X
NL Orange Frost ��Met. Orange Frost PMP-19500-7172A N X X
P3 Windveil Blue ��Met. Windveil Blue PMP-19500-7134A C X X
P5 Aspen Green � Aspen Green � PMP-19500-7056A C X
PG Dark Amethyst Met./Dark Amethyst/ Dark Amethyst PMP-19500-7177A N X X X XDark Amethyst ��Met.
PH Crème Brulee �/Crème Brulee ��Met. Crème Brulee PMP-19500-7176A N X X
PV White Sand Tri-Coat Met./White Chocolate Tri-Coat/ White Chocolate Tricoat PMP-19500-7167A N X X X X X X XWhite Chocolate ��Tri-Coat/White Sand Tri-Coat
T5 Dark Copper � Met. Dark Copper PMP-19500-7133A C X X X
T7 Dark Stone �/Dark Stone ��Met./ Charcoal Beige PMP-19500-7136A C X X X X X XCharcoal Beige ��Met.
T8 Tungsten Grey ��Met./Tungsten Grey � Tungsten Gray PMP-19500-7145A C X X
TK Mineral Gray � Mineral Gray � PMP-19500-7020A C X
TS Silver Frost ��Met. Silver Frost � PMP-19500-6720A C X X
UA Black � Black PMP-19500-1724A C X X X X X X X X X X X X X X X X X
UD Black � Black PMP-19500-1724A C X
WT Vibrant White � Performance White � PMP-19500-1028A C X X
YN Silver Metallic �/Silver ��Met./Silver Met. ��Met. Lt. Charcoal Met. � PMP-19500-6041A C X X X X X X X
YZ Oxford White �/Oxford White White � PMP-19500-5920A C X X X X X X X X X X X X
Z1 Oxford White � White � PMP-19500-5920A C X
Z3 Silver Met. � Lt. Charcoal Met. � PMP-19500-6041A C X
SPECIAL PAINTS �
Primer (g) PMP-19500-1000 C X X X X X X X X X X X X X X X X X
Clear Topcoat (c)� PMP-19500-6000 C X X X X X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X X X X X X X X
Graphite � PMP-19500-7108A C (b)
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Curr
ent o
r Ne
w
Edge
Free
star
Econ
olin
e
Expl
orer
Expl
orer
Spo
rt T
rac
Expe
ditio
n
Rang
er
Esca
pe/H
ybrid
F-Se
ries
(F-1
50)
F-Se
ries
Supe
r Du
ty
Free
styl
e
Mon
tere
y
MKX
Mar
iner
/Hyb
rid
Mar
k LT
Navi
gato
r(&
Nav
igat
or L
)
Mou
ntai
neer
2007 TRUCK, VAN, SPORT UTILITY & CROSSOVERUTILITY VEHICLE EXTERIOR PAINT CHART
Ford Division LM Division
(b) = Cladding only.(c) = Clear gloss improver. May darken basecoat.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
UTILITY VEHICLE EXTERIOR PAINT CHART
| 7 |
2007 TRUCK, VAN, SPORT UTILITY & CROSSOVER UTILITY VEHICLE EXTERIOR PAINT CHART
| 78 |
Qui
ck
Ref
eren
ce
Cha
rts
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
2 Flint/Medium/ X X X Black PM-19M547-4149HDark Flint X Med. Flint PM-19M547-2001H
X Dark Flint PM-19M547-2002HX X Lt. Flint PM-19M547-2003H
X Lt. Graphite PM-19M547-4240HX Med. Graphite PM-19M547-4245HX Dk. Graphite PM-19M547-4253H
2 Light Graphite X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002HX Med. Dk. Dove Gray PM-19M547-0012H
4 Chamois X Black PM-19M547-4149H6 Flint/Lt. Flint X X Black PM-19M547-4149H
Charcoal X Charcoal Black PM-19M547-0001HX Med. Dk. Flint PM-19M547-2004HX X Med. Lt. Flint PM-19M547-2021HX X Dove Gray PM-19M547-2025H
7 Pebble X X X X Black PM-19M547-4149HX Lt. Parchment PM-19M547-1076H
X Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
X X X X Lt. Pebble PM-19M547-2019HX Med. Lt. Pebble PM-19M547-2020H
B Black/Ebony Black/ X X X X X X X Black PM-19M547-4149HCharcoal X X Charcoal Black PM-19M547-0001H
X Lt. Parchment PM-19M547-1076HX Dark Flint PM-19M547-2002H
X X Lt. Flint PM-19M547-2003HC Camel/Med. Camel/ X X X X X X X X Black PM-19M547-4149H
Parchment X X X X X X Camel PM-19M547-0003HX X Lt. Camel PM-19M547-0005H
X X X Med. Camel PM-19M547-0006HX Greystone PM-19M547-0007H
X X (b) X Sand PM-19M547-0009HX Dark Stone PM-19M547-2012H
X X Med. Satin Nickel PM-19M547-2015HD Dark Flint X Black PM-19M547-4149H
X Charcoal Black PM-19M547-0001HX Med. Flint PM-19M547-2001HX Lt. Flint PM-19M547-2003H
D Dove Grey/Dove X Black PM-19M547-4149HX Med. Dark Dove Grey PM-19M547-0012HX Dark Flint PM-19M547-2002H
E Medium Flint/ X X X Black PM-19M547-4149HDark Flint X Charcoal Black PM-19M547-0001H
X X X Med. Flint PM-19M547-2001HX Dark Flint PM-19M547-2002H
X X X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
F Medium Dark Flint X Black PM-19M547-4149HX Med. Dk. Flint PM-19M547-2004H
G Stone/Greystone X X Black PM-19M547-4149HX X Greystone PM-19M547-0007H
X Lt. Stone PM-19M547-0008HX X Med. Lt. Stone PM-19M547-2011HX X Med. Satin Nickel PM-19M547-2015H
H Pebble/Medium/ X X X X X X Black PM-19M547-4149HDark Pebble/ X Charcoal Black PM-19M547-0001HMedium Parchment/ X Med. Dove PM-19M547-0002HTan X X Camel PM-19M547-0003H
X Greystone PM-19M547-0007HX Med. Dark Dove Gray PM-19M547-0012H
X X X X Lt. Parchment PM-19M547-1076HX Med. Parchment PM-19M547-1077HX Med. Dk. Parchment PM-19M547-1086H
X X X X Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
X Lt. Pebble PM-19M547-2019HJ Light Camel X Black PM-19M547-4149H
X Camel PM-19M547-0003HX Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006H
K Light Camel X Black PM-19M547-4149HX Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006HX Med. Satin Nickel PM-19M547-2015H
L Stone/Med. Lt. Stone/ X X X X X X X X Black PM-19M547-4149HLight Stone/Dove Grey X Charcoal Black PM-19M547-0001H
X X Greystone PM-19M547-0007HX X Lt. Stone PM-19M547-0008H
X Med. Dk. Stone PM-19M547-0010HX Lt. Flint PM-19M547-2003H
X X X X X X Med. Lt. Stone PM-19M547-2011HX Med. Satin Nickel PM-19M547-2015H
X Med. Lt. Flint PM-19M547-2021H
2007 INTERIOR PAINT AVAILABILITY CHART
Focu
s
Five
Hun
dred
Mus
tang
Fusi
on/M
ilan
Shel
by G
T500
MKZ
Tow
n Ca
r
Crw
n.Vi
c./G
nd.M
ar.
Taur
us
Mou
ntai
neer
Mon
tere
y
Free
star
MKX
Navi
gato
r
Mar
k LT
Mar
iner
/Hyb
rid
Free
styl
e
Expe
ditio
n
Esca
pe/H
ybrid
Edge
F-Se
ries
(F-1
50)
F-Se
ries
Supe
r Du
ty
Rang
er
Expl
orer
/Spo
rt T
rac
Econ
olin
e
Mon
tego
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks, Vans, Sport Utility & Crossover Vehicles
(b)= Sport Trac only.
| 8 |
2007 INTERIOR PAINT AVAILABILITY CHART
| 79 |
Quick
Reference C
hartsPage 9ORDER THROUGH YOUR D.O.E.S. II SYSTEM
*Note: Never repair or repaint airbag deployment covers (doors).** Note the following exceptions:
1. Do not use the adhesion promoter or paint on the Mark LT, Edge, or MKX for paint-to-match or repair procedures.2. Do not use the adhesion promoter or paint on the Freestyle and Taurus X for repair procedures.
Plastic Trim Part Vehicle Plastic Type Use Adhesion Promoter?Consoles All 2004-2008 Ford, Lincoln, Soft No
and Mercury vehiclesPillars All 2004-2008 Ford, Lincoln, Hard Yes
and Mercury vehiclesLower Door Panels All 2004-2008 Ford, Lincoln, Hard Yes
and Mercury vehiclesUpper Door Panels All 2004-2008 Ford and Mercury vehicles Hard Yes
All 2004-2008 Lincoln vehicles Soft NoInstrument Panels* 2004-2005 Excursion Hard Yes
2004-2008 Escape, Expedition,F-150, F-250-750, Focus, Mariner, and MustangAll other 2004-2008 vehicles** Soft No
Important Usage Information• When using any Ford Automotive Interior Spray Lacquer color, M4JZ-19M547-XXXXH, Motorcraft Adhesion Promoter, PM-19A316-AA, or equivalent MUST be used according to the product’s
directions to prime all plastic interior trim parts prior to color application.• When using Motorcraft Interior Spray Paint color, PM-19M547-XXXXH, refer to the Interior Spray Paint TSB for additional usage information and see below.
2004-2008 Interior Trim Parts — Plastic Types
N Charcoal Black/Black X X Black PM-19M547-4149HX X Charcoal Black PM-19M547-0001H
X Med. Satin Nickel PM-19M547-2015HP Dark Pebble/ X X Black PM-19M547-4149H
Medium Pebble X Lt. Parchment PM-19M547-1076HX Med. Pebble PM-19M547-2016H
X Med. Dk. Pebble PM-19M547-2017HX Lt. Pebble PM-19M547-2019H
R Red Accent/ X X Black PM-19M547-4149HCrimson Red X Charcoal Black PM-19M547-0001H
X Med. Dove PM-19M547-0002HX Camel PM-19M547-0003H
S Sand X Black PM-19M547-4149HX Camel PM-19M547-0003HX Med. Camel PM-19M547-0006HX Sand PM-19M547-0009HX Med. Satin Nickel PM-19M547-2015H
S Dove X Black PM-19M547-4149HX Med. Satin Nickel PM-19M547-2015HX Shale PM-19M547-2024HX Dove Gray PM-19M547-2025H
T Shale/Light Stone X X X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
X X Med. Dove PM-19M547-0002HX Lt. Stone PM-19M547-0008HX Med. Satin Nickel PM-19M547-2015H
X X X Shale PM-19M547-2024HX X X Dove Gray PM-19M547-2025H
W Black/Charcoal Black X X X X X X X X X X X X X X Black PM-19M547-4149HDark Charcoal/ X X X X X X X X X X X X Charcoal Black PM-19M547-0001HCharcoal X Med. Dove PM-19M547-0002H
X X X X Lt. Stone PM-19M547-0008HX Med. Dk. Stone PM-19M547-0010H
X Med. Dk. Dove Grey PM-19M547-0012HX Midnight Black PM-19M547-1074H
X Lt. Parchment PM-19M547-1076HX X Med. Lt. Stone PM-19M547-2011H
X X X Med. Satin Nickel PM-19M547-2015HX Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
X X X Dove Gray PM-19M547-2025HW Medium Pebble X Black PM-19M547-4149H
X Lt. Parchment PM-19M547-1076HX Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
W Tan/Lt. Parchment X X Black PM-19M547-4149HX X Lt. Parchment PM-19M547-1076HX X Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
2007 INTERIOR PAINT AVAILABILITY CHART
Focu
s
Five
Hun
dred
Mus
tang
Fusi
on/M
ilan
Shel
by G
T500
MKZ
Tow
n Ca
r
Crw
n.Vi
c./G
nd.M
ar.
Taur
us
Mou
ntai
neer
Mon
tere
y
Free
star
MKX
Navi
gato
r
Mar
k LT
Mar
iner
/Hyb
rid
Free
styl
e
Expe
ditio
n
Esca
pe/H
ybrid
Edge
F-Se
ries
(F-1
50)
F-Se
ries
Supe
r Du
ty
Rang
er
Expl
orer
/Spo
rt T
rac
Econ
olin
e
Mon
tego
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks, Vans, Sport Utility & Crossover Vehicles
2007 INTERIOR PAINT AVAILABILITY CHART2007 INTERIOR PAINT AVAILABILITY CHART
| 9 |
| 80 |
Qui
ck
Ref
eren
ce
Cha
rts
| 10 |
2006 Passenger Car Exterior Paint Chart
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X X X
BZ Speed Yellow � Chrome Yellow PMP-19500-6675A C X
C2 Gold Ash � Met. Gold Ash PMP-19500-7065A C X
CX Dark Shadow Grey � Met./Liquid Grey ��Met. Dk. Shadow Gray PMP-19500-7039A C X X X
D3 Mark IV Red�/Torch Red � Colorado Red � PMP-19500-7042A C X X
D6 Screaming Yellow � Screaming Yellow PMP-19500-7109A C X X
DV Light Tundra � Met./Titanium Green � Met./ Light Tundra PMP-19500-7081A C X X X X X X X X X XTitanium Green Met.
DX Dark Blue Pearl ��Met./Dark Blue Pearl Met. � Dk. Blue Pearl PMP-19500-7083A C X X X X X X X
E4 Infra-Red � Vermilion Red � PMP-19500-6470A C X
F6 Ceramic White Pearlescent � Tri-Coat/ Ceramic White Tricoat PMP-19500-7085A C X XCeramic White Pearlescent ��Met. (Tri-Coat)
FX Merlot � Met. Merlot PMP-19500-7087A C X X X X X
G2 Redfire � Met./Red Fire ��Met./ Redfire PMP-19500-7089A C X X X X XVivid Red � Met.
G3 Pueblo Gold � Met./Light French Silk � Met. Pueblo Gold PMP-19500-7113A C X X X X X
G4 Cashmere � Tri-Coat Cashmere Tricoat PMP-19500-7118A C X X
G9 Vista Blue � Met. Vista Blue PMP-19500-7147A N X
GL Heritage Blue � Heritage Blue PMP-19500-7138A N X
HG Smokestone ��Met./Smokestone Smokestone PMP-19500-7148A N X X
HH Dark Cherry ��Met. Dark Cherry PMP-19500-7149A N X X
HJ Pewter ��Met. Pewter Met. PMP-19500-7151A N X X
HP Performance White � High Performance White PMP-19500-7139A C X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X
JP Silver Birch � Met./Silver Birch Silver Birch � PMP-19500-7052A C X X X X X X
LA Midnight Blue ��Met.� Med. Royal Blue PMP-19500-6504A C X
LS Light Ice Blue � Met. Lt. Ice Blue � PMP-19500-7054A C X X X
ND Dune Pearl � Met. Dune Pearl PMP-19500-7150A N X X X
NH Light Sage ��Met. Lt. Sage PMP-19500-7146A N X
P1 Legend Lime � Met. Lime Gold PMP-19500-7135A C X
P3 Windveil Blue � Met. Windveil Blue PMP-19500-7134A C X X
SN Sonic Blue � Sonic Blue PMP-19500-7095A C X
T3 Satellite Silver � Met. Satellite Silver PMP-19500-7130A C X X
T7 Charcoal Beige Met./Charcoal Beige ��Met. Charcoal Beige PMP-19500-7136A C X X X X X
T8 Tungsten ��Met./Tungsten Silver ��Met./ Tungsten Grey PMP-19500-7145A N X X X X X X X XTungsten Grey ��Met.
TL Satin Silver ��Met. Satin Silver PMP-19500-7049A C X
TS CD Silver � Met./Silver Frost �/ Silver Frost � PMP-19500-6720A C X X X X XSilver Frost � Met.
UA Black �/Pitch Black �/Mark II Black � Black PMP-19500-1724A C X X X X X X X X X X X X XWT Vibrant White ��Met./Vibrant White �/ Performance White � PMP-19500-1028A C X X X X X
Centennial White �
YZ Oxford White �/Cloud 9 White � White � PMP-19500-5920A C X X X X X X
SPECIAL PAINTS �Primer (g)� PMP-19500-1000 C X X X X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X X X
Page 2 ORDER THROUGH YOUR D.O.E.S. II SYSTEM
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Ford Division Lincoln Mercury Division
Curr
ent o
r Ne
w
Focu
s
Ford
GT
Mus
tang
Taur
us
Crow
n Vi
ctor
ia
Fusi
on
Ford
500
Gran
d M
arqu
is
Mila
n
Mon
tego
Linc
oln
LS
Tow
n Ca
r
Zeph
yr
(c) = Clear gloss improver. May darken basecoat.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
Step OneUnscrewblack capfrom tube.
Step TwoRemoveand discardorangeinsert.
Step ThreeScrew blackcap on tubeand shake penvigorously forproper colormatch.
Step FourActivate Roller Ballby pressing downon tip whilemoving pen.Practice techniquebefore doingrepair.
How to Activate the Roller Ball
| 81 |
Quick
Reference C
harts
| 11 |
2006 Truck, Van & SUV Exterior Paint Chart
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X X X X (b) X
BY Yellow � Chrome Yellow PMP-19500-1526A C X
C2 Gold Ash Met. Gold Ash PMP-19500-7065A C X X
CX Dark Shadow Grey � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X X X X X X
D3 Torch Red � Colorado Red � PMP-19500-7042A C X
D6 Blazing Yellow � Screaming Yellow PMP-19500-7109A C X X
DV Light Tundra ��Met./Titanium Green ��Met./ Light Tundra PMP-19500-7081A C X X X X XLight Tundra/Titanium Green Met.
DX Dark Blue Pearl � Met. Dk. Blue Pearl PMP-19500-7083A C X X X
E4 Bright Red �/Vermilion Red � Vermilion Red � PMP-19500-6470A C X X X
F1 Red � Vermilion Red � PMP-19500-6470A C X X
F6 Ceramic White Pearlescent ��Tri-Coat Ceramic White Tricoat PMP-19500-7085A C X
FL Toreador Red � Toreador Red � PMP-19500-6758A C X
FS Spruce Green � Met. Spruce Green � PMP-19500-6860A C X X
FU Dark Green Satin � Met. Dk. Green Satin � PMP-19500-6862A C X
FW Dark Green Satin ��Met. Dk. Green Satin � PMP-19500-6862A C X
FX Merlot �/Merlot ��Met. Merlot PMP-19500-7087A C X
G2 Redfire � Met./Red Fire � Met./Vivid Red ��Met. Redfire PMP-19500-7089A C X X X X X X X X
G3 Pueblo Gold � Met./Light French Silk � Met. Pueblo Gold PMP-19500-7113A C X X X X X
G4 Cashmere Tri-Coat � Met./Cashmere ��Tri-Coat Cashmere Tricoat PMP-19500-7118A C X X X X
GW Blazing Copper � Met. Orange Crush Pearl PMP-19500-7110A C X
HG Smokestone ��Met./Smokestone � Smokestone PMP-19500-7148A N X X X X
HH Dark Cherry ��Met. Dark Cherry PMP-19500-7149A N X
HJ Pewter ��Met./Pewter Pewter Met. PMP-19500-7151A N X X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X X X X
JM Dark Toreador Red � Dk. Toreador Red PMP-19500-6771A C X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X X X X X
KR Norsea Blue � Met. Norsea Blue PMP-19500-7111A C X X X
L2 True Blue � Met. True Blue PMP-19500-7023A C X X X
LD Medium Wedgewood Blue � Met. Med. Wedgewood � PMP-19500-6763A C X X X
P5 Aspen Green � Met. Aspen Green � PMP-19500-7056A C X X
RC Med. Platinum � Med. Platinum � PMP-19500-6454A C (a)
SN Sonic Blue � Met. Sonic Blue PMP-19500-7095A C X X
ST Estate Green � Met. Estate Green � PMP-19500-6918A C X
T1 Light Gunmetal Lt. Gunmetal Gray� PMP-19500-7124A C (b)
T3 Satellite Silver � Met. Satellite Silver PMP-19500-7130A C X X X X X
T5 Dark Copper � Met. Dark Copper PMP-19500-7133A C X X X
T7 Dark Stone ��Met./Dark Stone � Charcoal Beige PMP-19500-7136A C X X X X X X X XCharcoal Beige Met./Charcoal Beige � Met.
TC Charcoal Beige Charcoal Gray � PMP-19500-7050A C (b)
TK Mineral Grey � Met. Mineral Gray � PMP-19500-7020A C X X
UA Black � Black PMP-19500-1724A C X X X X X X X X X X X X X X
UD Black � Black PMP-19500-1724A C X X
WT Vibrant White � Performance White � PMP-19500-1028A C X X
YN Silver Metallic �/Silver Met. ��Met. Lt. Charcoal Met. � PMP-19500-6041A C X X X X X X X
YZ Oxford White � White � PMP-19500-5920A C X X X X X X X X X X X X
Z1 Oxford White � White � PMP-19500-5920A C X X
Z3 Silver Metallic � Lt. Charcoal Met. � PMP-19500-6041A C X
SPECIAL PAINTS �
Primer (g) PMP-19500-1000 C X X X X X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X X X
Graphite � PMP-19500-7108A C (b)
Med. Dk. Platinum PMP-19500-7060G C X X
Page 3ORDER THROUGH YOUR D.O.E.S. II SYSTEM
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Curr
ent o
r Ne
w
Free
star
Econ
olin
e
Expl
orer
Expe
ditio
n
Rang
er
Esca
pe
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Free
styl
e
Mon
tere
y
Linc
oln
LT
Mar
iner
Navi
gato
r
Mou
ntai
neer
Ford Division LM Division
(a) = Accent color.(b) = Cladding only.(c) = Clear gloss improver. May darken basecoat.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
All ALBZ-19500-XXXXX and PM-19500-XXXXX brush-in-tube colors are in the process of being converted to PMP-19500-XXXXX 2-in-1-Brush-in-Tube/Pen Tip colors. The changeover should be completed by July 1, 2006. Until that time, only certain colors will be PMP-19500-XXXXX parts.
| 82 |
Qui
ck
Ref
eren
ce
Cha
rts
| 12 |
2006 Interior Paint Availability Chart
Page 4 ORDER THROUGH YOUR D.O.E.S. II SYSTEM
2 Flint/Medium/ X X X Black PM-19M547-4149HDark Flint X Med. Flint PM-19M547-2001H
X Dark Flint PM-19M547-2002HX X Lt. Flint PM-19M547-2003H
X Lt. Graphite PM-19M547-4240HX Med. Graphite PM-19M547-4245HX Dk. Graphite PM-19M547-4253H
2 Light Graphite X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002H
6 Flint/Lt. Flint X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Lt. Parchment PM-19M547-1076H
X X Med. Flint PM-19M547-2001HX Med. Dk. Flint PM-19M547-2004HX X Med. Lt. Flint PM-19M547-2021HX X Dove Gray PM-19M547-2025H
7 Pebble X X X X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
X X X Lt. Parchment PM-19M547-1076HX X X X X Med. Pebble PM-19M547-2016H
X X Med. Dk. Pebble PM-19M547-2017HX X X X X Lt. Pebble PM-19M547-2019H
X Med. Lt. Pebble PM-19M547-2020HB Black/Ebony Black/ X X X X X X X X Black PM-19M547-4149H
Charcoal X X X Charcoal Black PM-19M547-0001HX Dark Flint PM-19M547-2002H
X X X Lt. Flint PM-19M547-2003HX Black Ink PM-19M547-2005H
C Camel X X X X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
X X X X X Camel PM-19M547-0003HX X Lt. Camel PM-19M547-0005H
X Med. Camel PM-19M547-0006HX Sand PM-19M547-0009H
X Lt. Parchment PM-19M547-1076HX Med. Lt. Stone PM-19M547-2011HX Dark Stone PM-19M547-2012H
X X Med. Satin Nickel PM-19M547-2015HD Dark Flint X Black PM-19M547-4149H
X Med. Flint PM-19M547-2001HX Dark Flint PM-19M547-2002H
D Dove Grey X Black PM-19M547-4149HX Dark Flint PM-19M547-2002HX Med. Satin Nickel PM-19M547-2015HX Granite PM-19M547-2023HX Dove Gray PM-19M547-2025H
E Medium Flint/ X X X X Black PM-19M547-4149HDark Flint/Medium X Charcoal Black PM-19M547-0001HFlint Grey X Midnight Black PM-19M547-1074H
X X X X Med. Flint PM-19M547-2001HX X X Dark Flint PM-19M547-2002H
X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
X Dove Gray PM-19M547-2025HF Medium Dark Flint X Black PM-19M547-4149H
X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
G Medium Light Stone X Black PM-19M547-4149HX Greystone PM-19M547-0007HX Med. Lt. Stone PM-19M547-2011H
H Pebble/Medium/ X X X X X X X Black PM-19M547-4149HDark Pebble Tan/ X Med. Dove PM-19M547-0002HMedium Parchment/ X Camel PM-19M547-0003HLight Parchment X Espresso PM-19M547-2006H
X X X X X Lt. Parchment PM-19M547-1076HX X Med. Parchment PM-19M547-1077HX Med. Dk. Parchment PM-19M547-1086H
X X X X Med. Pebble PM-19M547-2016HX X X Dark Pebble PM-19M547-2018H
J Light Camel/ X Black PM-19M547-4149HMedium Camel X Camel PM-19M547-0003H
X Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006H
K Light Camel X Black PM-19M547-4149HX Lt. Camel PM-19M547-0005HX Med. Camel PM-19M547-0006H
L Stone/Med. Lt. Stone/ X X X X Black PM-19M547-4149HLight Flint X X Charcoal Black PM-19M547-0001H
X Greystone PM-19M547-0007HX Lt. Stone PM-19M547-0008H
X Med. Dk. Stone PM-19M547-0010HX Lt. Flint PM-19M547-2003H
X X X Med. Lt. Stone PM-19M547-2011H
�������������������������������� �����
Focu
s
500
Ford
GT
Fusi
on/M
ilan
Mus
tang
Taur
us
Crw
n.Vi
c./G
nd.M
ar.
Linc
oln
LS
Tow
n Ca
r
Zeph
yr
Mou
ntai
neer
Mon
tere
y
Free
star
Navi
gato
r
Mar
iner
/Hyb
rid
Free
styl
e
Expe
ditio
n
Esca
pe/H
ybrid
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Rang
er
Expl
orer
Econ
olin
e
Mon
tego
Mar
k LT
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks
| 83 |
Quick
Reference C
harts
2006 Interior Paint Availability Chart
Trim Code
Trim Color
Passenger Cars Trucks
InteriorPaintColorName
InteriorPaintPart
Number
Crw
n. V
ic./G
nd. M
ar.
500
Focu
s
Fusi
on/M
ilan
Ford
GT
Mus
tang
Taur
us
Linc
oln
LS
Tow
n C
ar
Zeph
yr
Econ
olin
e
Esca
pe/H
ybrid
Expe
ditio
n
Expl
orer
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Free
star
Free
styl
e
Mar
iner
/Hyb
rid
Mar
k LT
Mon
tego
Mon
tere
y
Mou
ntai
neer
Nav
igat
or
Ran
ger
L Stone/Med. Lt. Stone./ X Dk. Stone PM-19M547-2012HLight Flint X Med. Lt. Flint PM-19M547-2021H
N Charcoal Black/ X X Black PM-19M547-4149HCharcoal/Black X X Charcoal Black PM-19M547-0001H
P Dark Pebble/ X X Black PM-19M547-4149HMedium Pebble Tan X X Lt. Parchment PM-19M547-1076H
X Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017HX Lt. Pebble PM-19M547-2019H
Q Light Sand Black PM-19M547-4149HLt. Oak PM-19M547-0011H
R Red Accent/Torch Red X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002HX Camel PM-19M547-0003H
Colorado Red PM-19M547-2008HS Dove/Shale X X Black PM-19M547-4149H
X X Shale PM-19M547-2024HX X Dove Gray PM-19M547-2025H
S Sand X Black PM-19M547-4149HX Med. Camel PM-19M547-0006HX Sand PM-19M547-0009HX Med. Satin Nickel PM-19M547-2015H
T Shale/Light Stone X X X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001H
X X X Med. Dove PM-19M547-0002HX Lt. Stone PM-19M547-0008HX Med. Satin Nickel PM-19M547-2015H
X X X Shale PM-19M547-2024HX X X Dove Gray PM-19M547-2025H
W Black/Charcoal Black X X X X X X X X X X X Black PM-19M547-4149HEbony Black/ X X X X X X X X X Charcoal Black PM-19M547-0001HBlack Ink/ X Med. Dove PM-19M547-0002HDark Charcoal X X Lt. Stone PM-19M547-0008H
X Midnight Black PM-19M547-1074HX Black Ink PM-19M547-2005H
X Med. Lt. Stone PM-19M547-2011HX X Med. Satin Nickel PM-19M547-2015H
X X X Dove Gray PM-19M547-2025HW Medium Pebble X Lt. Graphite PM-19M547-4240H
X Black PM-19M547-4149HX Midnight Black PM-19M547-1074HX Lt. Parchment PM-19M547-1076HX Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
W Tan/Lt. Parchment X X Black PM-19M547-4149HX X Lt. Parchment PM-19M547-1076HX X Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
Important Usage Information• When using any Ford Automotive Interior Spray Lacquer color M4JZ-19m547-XXXXH, Motorcraft Adhesion Promoter, PM-19A316-AA, or equivalent MUST be used according to the product’s direcitons to prime all plastic interior trim parts prior to color application.• When using Motorcraft Interior Spray Paint color, PM-19M547-XXXXH, refer to the Interior Spray Paint TSB for additional usage information and reference the 2004-2008 Interior Trim Parts - Plastic Types quick reference chart.
| 84 |
Qui
ckR
efer
ence
Cha
rts
| 84 |
Qui
ck
Ref
eren
ce
Cha
rts
| 14 |
2005 Passenger Car Exterior Paint Chart
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X X X X X
B7 Egg Yolk Yellow � Zinc Yellow � PMP-19500-7000A C X
BI Inca Gold � Inca Gold PMP-19500-7106A N X
BZ Screaming Yellow � Chrome Yellow PMP-19500-6675A C X
C2 Gold Ash � Met. Gold Ash PMP-19500-7065A C X X X X
CX Dark Shadow Gray � Met./Liquid Gray ��Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X
D3 Mark IV Red�/Torch Red �/Torch Red Colorado Red � PMP-19500-7042A C X X X
D6 Screaming Yellow � Screaming Yellow PMP-19500-7109A C X
DV Light Tundra � Met./Titanium Green � Met. Light Tundra PMP-19500-7081A C X X X X (f) X X X X X
DX Dark Blue Pearl ��Met./Dark Blue Pearl Met. � Dk. Blue Pearl PMP-19500-7083A C X X X
E4 Infra-Red � Vermilion Red � PMP-19500-6470A C X
F6 Ceramic White Pearlescent � Met. Ceramic White Tricoat PMP-19500-7085A C X X
FL Sangria Red � Met. Toreador Red � PMP-19500-6758A C X
FX Merlot � Met. Merlot PMP-19500-7087A C X X X X
G2 Vivid Red � Met./Red Fire � Met./Redfire � Redfire PMP-19500-7089A C X X X
G3 Light French Silk � Met./Pueblo Gold � Met. Pueblo Gold PMP-19500-7113A C X X X X
G4 Cashmere �/Cashmere � Tri-Coat Cashmere Tricoat PMP-19500-7118A C (f) X X
GW Blazing Copper � Met. Orange Crush Pearl PMP-19500-7110A N X
HP Performance White � High Performance White PMP-19500-7139A N X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X
JP Silver Birch � Met./Platinum Silver Silver Birch � PMP-19500-7052A C X X X X X
KR Norsea Blue � Met. Norsea Blue PMP-19500-7111A C X X X
LA Midnight Blue ��Met.� Med. Royal Blue PMP-19500-6504A C X
LS Lt. Ice Blue � Met. Lt. Ice Blue � PMP-19500-7054A C X X X
M9 French Blue � Met. French Blue � PMP-19500-7043A C X
P1 Legend Lime � Met. Lime Gold PMP-19500-7135A N X
P3 Windveil Blue � Met. Windveil Blue PMP-19500-7134A N X X X
SN Sonic Blue � Sonic Blue PMP-19500-7095A C X X
SP Medium Steel Blue Med. Steel Blue � PMP-19500-6966A C X
T2 Bronze � Met./Bronze Bronze PMP-19500-7132A N X X
T7 Charcoal Beige ��Met. Charcoal Beige PMP-19500-7136A N X X
TK Mineral Gray ��Met. Mineral Gray � PMP-19500-7020A C X
TL Quick Silver ��Met./Satin Silver ��Met. Satin Silver PMP-19500-7049A C X X
TS Silver Frost � Met./CD Silver � Met. Silver Frost � PMP-19500-6720A C X X X X X
TV Midnight Gray � Met. Midnight Gray Met. � PMP-19500-6852A C X X
UA Black �/Pitch Black �/Mark II Black �/ Black PMP-19500-1724A C X X X X X X X X X X X XEvening Black
WT Vibrant White ��Met./Centennial White � Performance White � PMP-19500-1028A C X X X X X X
YZ Oxford White �/Cloud 9 White � White � PMP-19500-5920A C X X X
SPECIAL PAINTS �Primer (g)� PMP-19500-1000 C X X X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X
Graphite � PMP-19500-7108A C
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Ford Division Lincoln Mercury Division
Curr
ent o
r Ne
w
Focu
s
GT Mus
tang
Taur
us
Crow
n Vi
ctor
ia
Ford
500
Thun
derb
ird
Sabl
e
Gran
d M
arqu
is
Mon
tego
Linc
oln
LS
Tow
n Ca
r
(c) = Clear gloss improver. May darken basecoat.(f) = Available as part of a special regional package or feature vehicle.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
Step OneUnscrewblack capfrom tube.
Step TwoRemoveand discardorangeinsert.
Step ThreeScrew blackcap on tubeand shake penvigorously forproper colormatch.
Step FourActivate Roller Ballby pressing downon tip whilemoving pen.Practice techniquebefore doingrepair.
How to Activate the Roller Ball
| 85 |
Quick
Reference C
harts
| 15 |
2005 Truck, Van & SUV Exterior Paint Chart
(a) = Accent color.(b) = Cladding only.(c) = Clear gloss improver. May darken basecoat.(e) = Explorer Sport Trac only.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
Page 7ORDER THROUGH YOUR D.O.E.S. II SYSTEM
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X (b) X X X (b) X
B2 Harvest Gold � Met. Harvest Gold � PMP-19500-6926A C (b)
BY Yellow � Chrome Yellow PMP-19500-1526A C X
C2 Gold Ash � Met./Gold Ash Met. Gold Ash PMP-19500-7065A C X X X
CX Dark Shadow Gray � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X X X X X
D6 Blazing Yellow � Screaming Yellow PMP-19500-7109A C X
DT Matador Red � Met. Matador Red � PMP-19500-7057A C X X
DV Light Tundra ��Met./Titanium Green ��Met. Light Tundra PMP-19500-7081A C X X X X
DX Dark Blue Pearl � Met. Dk. Blue Pearl PMP-19500-7083A C X X X X
E4 Bright Red � Vermilion Red � PMP-19500-6470A C (e) X X X
F1 Red � Vermilion Red � PMP-19500-6470A C X
FL Toreador Red � Met. Toreador Red � PMP-19500-6758A C X X X X
FS Spruce Green � Met. Spruce Green � PMP-19500-6860A C X X
FU Dark Green Satin � Met. Dk. Green Satin � PMP-19500-6862A C X
FW Dark Green Satin ��Met. Dk. Green Satin � PMP-19500-6862A C X
FX Merlot � Met. Merlot PMP-19500-7087A C X X
G2 Vivid Red ��Met./Redfire � Met./Red Fire � Met. Redfire PMP-19500-7089A C X X X X X X X X
G3 Light French Silk � Met./Pueblo Gold � Met. Pueblo Gold PMP-19500-7113A C X X X X X X X
G4 Cashmere Tri-Coat � Met. Cashmere Tricoat PMP-19500-7118A C X X
GW Blazing Copper � Met. Orange Crush Pearl PMP-19500-7110A N X
HC Ivory Parchment � Tri-Coat/Ivory Parchment Ivory Parchment PMP-19500-6944A C X X XTri-Coat ��Met. Tricoat
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X
JM Dark Toreador Red ��Met. Dk. Toreador Red PMP-19500-6771A C X X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X X X X X X
KR Norsea Blue � Met. Norsea Blue PMP-19500-7111A C X X X X
L2 True Blue � Met. True Blue PMP-19500-7023A C X X X X
LD Medium Wedgewood Blue � Met. Med. Wedgewood � PMP-19500-6763A C X X X X
P5 Aspen Green � Met. Aspen Green � PMP-19500-7056A C X X
PX Dark Highland Green � Met. Dk. Highland Green � PMP-19500-6920A C X
RC Platinum Med. Platinum � PMP-19500-6454A C (b) (a)
SN Sonic Blue � Met. Sonic Blue PMP-19500-7095A C X X X
SP Medium Steel Blue � Met. Med. Steel Blue � PMP-19500-6966A C X
ST Estate Green � Met. Estate Green � PMP-19500-6918A C X X X
T1 Lt. Gunmetal Gray Met. Lt. Gunmetal Gray� PMP-19500-7124A N (b) (a)
T3 Satellite Silver � Met. Satellite Silver PMP-19500-7130A N X X X X
T5 Dark Copper � Met. Dark Copper PMP-19500-7133A N X
T7 Charcoal Beige � Met./Darkstone ��Met. Charcoal Beige PMP-19500-7136A N X X X X X X X
TC Charcoal Gray/Charcoal Beige Charcoal Gray � PMP-19500-7050A C (b) (b)
TK Mineral Gray � Met. Mineral Gray � PMP-19500-7020A C X X X
TS Silver Frost � Met. Silver Frost � PMP-19500-6720A C X
UA Black � Black PMP-19500-1724A C X X X X X X X X X X X X X X X
UD Black � Black PMP-19500-1724A C X
WT Vibrant White � Performance White � PMP-19500-1028A C X X X
YN Silver Met. �/Silver ��Met./Silver � Lt. Charcoal Met. � PMP-19500-6041A C X X X X X X
YZ Oxford White � White � PMP-19500-5920A C X X X X X X X X X X X X X
Z1 Oxford White � White � PMP-19500-5920A C X
Z3 Silver � Met. Lt. Charcoal Met. � PMP-19500-6041A C X
SPECIAL PAINTS �
Primer (g)� PMP-19500-1000 C X X X X X X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X
Graphite � PMP-19500-7108A C (b) (b)
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Curr
ent o
r Ne
w
Free
star
Econ
olin
e
Excu
rsio
n
Expl
orer
Expe
ditio
n
Rang
er
Esca
pe
F-Se
ries
(F-1
50)
Free
styl
e
F-Se
ries
(Sup
er D
uty)
Mon
tere
y
Avia
tor
Mar
iner
Navi
gato
r
Mou
ntai
neer
Ford Division LM Division
All ALBZ-19500-XXXXX and PM-19500-XXXXX brush-in-tube colors are in the process of being converted to PMP-19500-XXXXX 2-in-1-Brush-in-Tube/Pen Tip colors. The changeover should be completed by July 1, 2006. Until that time, only certain colors will be PMP-19500-XXXXX parts.
| 86 |
Qui
ck
Ref
eren
ce
Cha
rts
| 16 |
2005 Interior Paint Availability Chart
Page 8 ORDER THROUGH YOUR D.O.E.S. II SYSTEM
2 Medium/Dark Flint X Black PM-19M547-4149HX Dark Flint PM-19M547-2002HX Lt. Flint PM-19M547-2003H
2 Light Graphite X X Black PM-19M547-4149HX Charcoal Black PM-19M547-0001HX Med. Dove PM-19M547-0002H
2 Medium Graphite X Black PM-19M547-4149HX Lt. Graphite PM-19M547-4240HX Med. Graphite PM-19M547-4245HX Dk. Graphite PM-19M547-4253H
6 Flint X X Black PM-19M547-4149HX X Med. Dk. Flint PM-19M547-2004HX X Med. Lt. Flint PM-19M547-2021H
X Dove Gray PM-19M547-2025HX Charcoal Black PM-19M547-0001H
7 Pebble X X X X X Black PM-19M547-4149HX Med. Pebble PM-19M547-2016HX X X X X Lt. Pebble PM-19M547-2019H
X X X Med. Lt. Pebble PM-19M547-2020HX Dove Gray PM-19M547-2025HX Charcoal Black PM-19M547-0001H
B Solid Ebony/Black Ink/ X X X X X X Black PM-19M547-4149HEbony Black/Black/ X Lt. Parchment PM-19M547-1076HCharcoal/Ebony Red/ X Lt. Flint PM-19M547-2003HEbony Blue/Med. Flint X X Med. Dk. Flint PM-19M547-2004H
X Black Ink PM-19M547-2005HX X Charcoal Black PM-19M547-0001H
B Medium Steel Blue X Black PM-19M547-4149HX Black Ink PM-19M547-2005H
C Camel X X X Black PM-19M547-4149HX X Lt. Parchment PM-19M547-1076H
X Dark Stone PM-19M547-2012HX Med. Satin Nickel PM-19M547-2015H
X Charcoal Black PM-19M547-0001HX X X Camel PM-19M547-0003H
C Light Flint X Black PM-19M547-4149HX Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
D Dark Flint X X Black PM-19M547-4149HX Med. Flint PM-19M547-2001HX Dark Flint PM-19M547-2002H
X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004HX Med. Lt. Flint PM-19M547-2021H
D Dove Gray X Black PM-19M547-4149HX Dark Flint PM-19M547-2002HX Med. Satin Nickel PM-19M547-2015HX Granite PM-19M547-2023HX Dove Gray PM-19M547-2025HX Charcoal Black PM-19M547-0001H
E Medium Flint/Medium X X X X X Black PM-19M547-4149HFlint Gray/Dark Flint X Midnight Black PM-19M547-1074H
X X X X X Med. Flint PM-19M547-2001HX X X Dark Flint PM-19M547-2002H
X Lt. Flint PM-19M547-2003HX Med. Dk. Flint PM-19M547-2004H
X Dove Gray PM-19M547-2025HX Charcoal Black PM-19M547-0001H
F Medium Dark Flint X X Black PM-19M547-4149HX Med. Dk. Flint PM-19M547-2004H
F Medium Dark X Black PM-19M547-4149HParchment/ X Lt. Parchment PM-19M547-1076HLight Parchment X Med. Dk. Parchment PM-19M547-1086H
G Dove Gray X Black PM-19M547-4149HX Granite PM-19M547-2023HX Dove Gray PM-19M547-2025H
H Medium Parchment X X X X X Black PM-19M547-4149HX X Lt. Parchment PM-19M547-1076H
X X X X Med. Parchment PM-19M547-1077HX X X Med. Dk. Parchment PM-19M547-1086H
X Espresso PM-19M547-2006HX Med. Dove PM-19M547-0002HX Camel PM-19M547-0003H
H Tan X Black PM-19M547-4149HX Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
H Medium/Dark Pebble/ X X X Black PM-19M547-4149HPebble X Lt. Parchment PM-19M547-1076H
X X X Med. Pebble PM-19M547-2016HX Med. Dark Pebble PM-19M547-2017HX Charcoal Black PM-19M547-0001H
L Charcoal/Light Flint X Black PM-19M547-4149HX Med. Lt. Flint PM-19M547-2021HX Lt. Flint PM-19M547-2003H
�������������������������������� �����
Focu
s
500
Mus
tang
/Cob
ra
Ford
GT
Taur
us/S
able
Thun
derb
ird
Crw
n.Vi
c./G
nd.M
ar.
Linc
oln
LS
Tow
n Ca
r
Avia
tor
Navi
gato
r
Mou
ntai
neer
Free
star
Rang
er
Mar
iner
Free
styl
e
Excu
rsio
n
Esca
pe
Expl
orer
/Spo
rt T
rac
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Expe
ditio
n
Econ
olin
e
Mon
tere
y
Mon
tego
TrimCode
InteriorPaintColorName
InteriorPaintPart
Number
TrimColor
Passenger Cars Trucks
| 87 |
Quick
Reference C
harts
2005 Interior Paint Availability Chart
Important Usage Information• When using any Ford Automotive Interior Spray Lacquer color M4JZ-19m547-XXXXH, Motorcraft Adhesion Promoter, PM-19A316-AA, or equivalent MUST be used according to the product’s direcitons to prime all plastic interior trim parts prior to color application.• When using Motorcraft Interior Spray Paint color, PM-19M547-XXXXH, refer to the Interior Spray Paint TSB for additional usage information and reference the 2004-2008 Interior Trim Parts - Plastic Types quick reference chart.
| 88 |
Qui
ckR
efer
ence
Cha
rts
Trim Code
Trim Color
Passenger Cars Trucks
Interior Paint Color Name
InteriorPaintPart
Number
Crw
n. V
ic./G
nd. M
ar.
500
Focu
s
Ford
GT
Mus
tang
/Cob
ra
Taur
us/S
able
Thun
derb
ird
Linc
oln
LS
Tow
n C
ar
Avia
tor
Econ
olin
e
Esca
pe
Excu
rsio
n
Expe
ditio
n
Expl
orer
/Spo
rt T
rac
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Free
star
Free
styl
e
Mar
iner
Mon
tego
Mon
tere
y
Mou
ntai
neer
Nav
igat
or
Ran
ger
M Midnight Gray X X Black PM-19M547-4149HX Dove Gray PM-19M547-2025H
P Medium Pebble Tan X Black PM-19M547-4149HX Med. Pebble PM-19M547-2016H
P Medium Parchment/ X X Black PM-19M547-4149HMedium Dark X X Lt. Parchment PM-19M547-1076HParchment X X Med. Dk. Parchment PM-19M547-1086H
P Light Pebble X Black PM-19M547-4149HX Lt. Parchment PM-19M547-1076HX Med. Dk. Pebble PM-19M547-2017HX Lt. Pebble PM-19M547-2019H
Q Light Sand X Black PM-19M547-4149HX Med. Light Stone PM-19M547-2011HX Dark Stone PM-19M547-2012H
R Dark Charcoal X Black PM-19M547-4149Hw/ Interior Color X Charcoal Black PM-19M547-0001H
X Med. Dove PM-19M547-0002HX Camel PM-19M547-0003H
R Torch Red X Black PM-19M547-4149HX Black Ink PM-19M547-2005H
S Shale/Dove X X Black PM-19M547-4149HX X Shale PM-19M547-2024HX X Dove Gray PM-19M547-2025H
T Graphite/Shale X X X X Black PM-19M547-4149HX X X Shale PM-19M547-2024HX X X X Dove Gray PM-19M547-2025H
X Dk. Graphite PM-19M547-4253HX Med. Dove PM-19M547-0002H
U Dark Stone/ X Black PM-19M547-4149HMedium Light Stone X Med. Light Stone PM-19M547-2011H
X Dark Stone PM-19M547-2012HW Dark Charcoal/ X X X X X X X X X X Black PM-19M547-4149H
Blank Ink/Black/ X X Midnight Black PM-19M547-1074HCharcoal Black/ X X X Black Ink PM-19M547-2005HEbony Black X X X X Dove Gray PM-19M547-2025H
X Lt. Graphite PM-19M547-4020HX X X X X Charcoal Black PM-19M547-0001H
X Med. Dove PM-19M547-0002HW Medium Pebble X X Black PM-19M547-4149H
X Midnight Black PM-19M547-1074HX Lt. Parchment PM-19M547-1076HX (b) Med. Pebble PM-19M547-2016HX Med. Dk. Pebble PM-19M547-2017H
(b) Dark Pebble PM-19M547-2018HW Tan X Black PM-19M547-4149H
X Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
TBD Stone X Cashmere PM-19M547-0004HX Med. Light Stone PM-19M547-2011HX Dark Stone PM-19M547-2012H
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
(b) = Explorer only.
| 88 |
Qui
ck
Ref
eren
ce
Cha
rts
| 18 |
2004 Passenger Car Exterior Paint Chart
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X X X X X
B7 Egg Yolk Yellow � Zinc Yellow � PMP-19500-7000A C X
C2 Gold Ash � Met. Gold Ash PMP-19500-7065A C X X X X
CX Liquid Grey � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X
CY Competition Orange � Competition Orange PMP-19500-7117A C X X
D3 Torch Red � Colorado Red � PMP-19500-7042A C X X
D6 Screaming Yellow � Screaming Yellow PMP-19500-7109A C X X
DV Light Tundra � Met. Light Tundra PMP-19500-7081A C X (f) X X
DX Dark Blue Pearl Met. � Dk. Blue Pearl PMP-19500-7083A C X X
E4 Infra-Red � Vermilion Red � PMP-19500-6470A C X
E9 Vintage Mint Green� Mint Green PMP-19500-7112A N X
F6 Ceramic White Tri-Coat � Met. Ceramic White Tricoat PMP-19500-7085A C X X
FL Toreador Red � Met./Sangria Red � Met. Toreador Red � PMP-19500-6758A C X
FS Spruce Green � Met. Spruce Green � PMP-19500-6860A C X X X X
FX Merlot � Met./Crimson Red Merlot PMP-19500-7087A C (f) X X X
G2 Red Fire � Met./Vivid Red � Met. Redfire PMP-19500-7089A C X X
G3 Light French Silk � Met. Pueblo Gold PMP-19500-7113A N X X
G4 Cashmere � Tri-Coat Cashmere Tricoat PMP-19500-7118A N X X
G6 Mystichrome � Mystichrome PMP-19500-7099A N X
GT Autumn Red � Met. Autumn Red � PMP-19500-6934A C X X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X
JP Silver Birch � Met./Platinum Silver Silver Birch � PMP-19500-7052A C X X X X X X
L2 True Blue � Met. True Blue PMP-19500-7023A C X X
L5 Azure Blue � Azure Blue PMP-19500-7091A C X
LS Lt. Ice Blue � Met. Lt. Ice Blue � PMP-19500-7054A C X X X
M9 French Blue � Met. French Blue � PMP-19500-7043A C X
MK Twilight Blue � Met. Twilight Blue � PMP-19500-6290A C X
RJ Medium True Blue � Met. Med. True Blue � PMP-19500-7055A C X X
SN Sonic Blue � Met. Sonic Blue PMP-19500-7095A C X X
SP Medium Steel Blue � Met. Med. Steel Blue � PMP-19500-6966A C X X
TC Charcoal Gray � Met. Charcoal Gray � PMP-19500-7050A C X X
TS Silver Frost � Met./CD Silver � Met. Silver Frost � PMP-19500-6720A C X X X
TV Midnight Gray � Met. Midnight Gray Met. � PMP-19500-6852A C X X
UA Black �/Pitch Black �/Evening Black Black PMP-19500-1724A C X X X X X X X X X X
WT Vibrant White � Performance White � PMP-19500-1028A C X X X X X
YN Silver � Met. � Lt. Charcoal Met. � PMP-19500-6041A C X
YZ Cloud 9 White � White � PMP-19500-5920A C X
Z1 Oxford White � White � PMP-19500-5920A C X
SPECIAL PAINTS �Primer (g)� PMP-19500-1000 C X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Ford Division Lincoln Mercury Division
Curr
ent o
r Ne
w
Focu
s
Mus
tang
Taur
us
Crow
n Vi
ctor
ia
Thun
derb
ird
Sabl
e
Gran
d M
arqu
is
Mar
aude
r
Linc
oln
LS
Tow
n Ca
r
(c) = Clear gloss improver. May darken basecoat.(f) = Available as part of a special regional package or feature vehicle.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
Step OneUnscrewblack capfrom tube.
Step TwoRemoveand discardorangeinsert.
Step ThreeScrew blackcap on tubeand shake penvigorously forproper colormatch.
Step FourActivate Roller Ballby pressing downon tip whilemoving pen.Practice techniquebefore doingrepair.
How to Activate the Roller Ball
| 89 |
Quick
Reference C
harts
2004 Truck, Van & Sport Utility Exterior Paint Chart
| 19 |
AQ Arizona Beige � Met. Arizona Beige � PMP-19500-6985A C X (b) X X X X
B2 Harvest Gold � Met. Harvest Gold � PMP-19500-6926A C (b)
B4 Chestnut Brown � Met. Chestnut � PMP-19500-6938A C X
BY School Bus Yellow � Chrome Yellow PMP-19500-1526A C X
C2 Gold Ash � Met. Gold Ash PMP-19500-7065A C X X X
CX Dark Shadow Gray � Met. Dk. Shadow Gray PMP-19500-7039A C X X X X X X X
CY Competition Orange � Competition Orange PMP-19500-7117A C (e)
D6 Blazing Yellow � Screaming Yellow PMP-19500-7109A C X
DT Matador Red � Met. Matador Red � PMP-19500-7057A C X X
DX Dark Blue Pearl � Met. Dk. Blue Pearl PMP-19500-7083A C X X X
E4 Bright Red � Vermilion Red � PMP-19500-6470A C X X X
F1 Red � Met. Vermilion Red PMP-19500-6470A C X
F6 Ceramic White Tri-Coat � Met. Ceramic White Tricoat PMP-19500-7085A C X X X
FL Toreador Red � Met./Medium Toreador Red � Met. Toreador Red � PMP-19500-6758A C X X X
FS Spruce Green � Met. Spruce Green � PMP-19500-6860A C X X
FU Dark Green Satin � Met. Dk. Green Satin � PMP-19500-6862A C X X
FW Dark Green Satin � Dk. Green Satin � PMP-19500-6862A C X
FX Merlot � Met. Merlot PMP-19500-7087A C X X
G2 Red Fire � Met./Vivid Red � Met. Redfire PMP-19500-7089A C X X X X X
G3 Pueblo Gold � Met./Light French Silk � Met. Pueblo Gold PMP-19500-7113A N X X X X X X
G4 Cashmere � Tri-Coat Cashmere Tricoat PMP-19500-7118A N X
JL Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X X X
JM Dark Toreador Red � Met. Dk. Toreador Red PMP-19500-6771A C X
JP Silver Birch � Met. Silver Birch � PMP-19500-7052A C X X X X X X X X
KR Norsea Blue V Met. Norsea Blue PMP-19500-7111A N X
L2 True Blue � Met. True Blue PMP-19500-7023A C X X X X X X X
LD Med. Wedgewood Blue � Met. Med. Wedgewood � PMP-19500-6763A C X X X X X
P5 Aspen Green � Met. Aspen Green � PMP-19500-7056A C X X X X X
PX Dark Highland Green � Met. Dk. Highland Green � PMP-19500-6920A C X
RC Platinum Med. Platinum � PMP-19500-6454A C (b) (b)
SN Sonic Blue � Met. Sonic Blue PMP-19500-7095A C X X
SP Medium Steel Blue � Met. Med. Steel Blue � PMP-19500-6966A C X
ST Estate Green � Met. Estate Green � PMP-19500-6918A C X X X X X X
TK Mineral Gray � Met. Mineral Gray � PMP-19500-7020A C (a) X X X X X
TL Satin Silver � Met. Satin Silver PMP-19500-7049A C X
UA Black � Black PMP-19500-1724A C X X X X X X X X X X X X X
UD Black � Black PMP-19500-1724A C X
WT Vibrant White � Performance White � PMP-19500-1028A C X
YN Silver � Met. Lt. Charcoal Met. � PMP-19500-6041A C X X X X
YZ Oxford White � White � PMP-19500-5920A C X X X X X X X X X X
Z1 Oxford White � White � PMP-19500-5920A C X
Z3 Silver � Met. Lt. Charcoal Met. � PMP-19500-6041A C X
SPECIAL PAINTS �Primer (g)� PMP-19500-1000 C X X X X X X X X X X X X X
Clear Topcoat (c) � PMP-19500-6000 C X X X X X X X X X X X X X
Charcoal � PMP-19500-6388G C X X X X X X X X X X X
Graphite � PMP-19500-7108A N (b)
VehicleCertificationLabel Code
Vehicle DivisionColor
Promotional Name
Customer ServiceDivision
Color NamePart
Number
Curr
ent o
r Ne
w
Free
star
Econ
olin
e
Excu
rsio
n
Expl
orer
Expe
ditio
n
Rang
er
Esca
pe
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Mon
tere
y
Avia
tor
Navi
gato
r
Mou
ntai
neer
Ford Division LM Division
(a) = Accent color.(b) = Cladding only.(c) = Clear gloss improver. May darken basecoat.(e) = Explorer Sport Trac only.(g) = Use PMP-19500-1000 Primer before color coat application.� = Clearcoat.
All ALBZ-19500-XXXXX and PM-19500-XXXXX brush-in-tube colors are in the process of being converted to PMP-19500-XXXXX 2-in-1-Brush-in-Tube/Pen Tip colors. The changeover should be completed by July 1, 2006. Until that time, only certain colors will be PMP-19500-XXXXX parts.
ORDER THROUGH YOUR D.O.E.S. II SYSTEM
| 90 |
Qui
ck
Ref
eren
ce
Cha
rts
2004 Interior Paint Availability Chart
Important Usage Information• When using any Ford Automotive Interior Spray Lacquer color M4JZ-19m547-XXXXH, Motorcraft Adhesion Promoter, PM-19A316-AA, or equivalent MUST be used according to the product’s direcitons to prime all plastic interior trim parts prior to color application.• When using Motorcraft Interior Spray Paint color, PM-19M547-XXXXH, refer to the Interior Spray Paint TSB for additional usage information and reference the 2004-2008 Interior Trim Parts - Plastic Types quick reference chart.
| 91 |
Quick
ReferenceC
harts
Trim Code
Trim Color
Passenger Cars Trucks
InteriorPaint Color Name
InteriorPaintPart
NumberFo
cus
Mus
tang
/Cob
ra
Taur
us/S
able
Thun
derb
ird
Crw
n. V
ic./G
nd. M
ar.
Linc
oln
LS
Mar
aude
r
Tow
n C
ar
Avia
tor
Nav
igat
or
Mou
ntai
neer
Free
star
(Win
dsta
r)
Ran
ger
Excu
rsio
n
Esca
pe
Expl
orer
/Spo
rt T
rac
F-Se
ries
(F-1
50)
F-Se
ries
(Sup
er D
uty)
Expe
ditio
n
Econ
olin
e
Mon
tere
y
P Medium Parchment/ X X Black PM-19M547-4149HMedium Dark Parchment X X Lt. Parchment PM-19M547-1076H
X X Med. Dk. Parchment PM-19M547-1086HP Medium Pebble X Black PM-19M547-4149H
X Med. Pebble PM-19M547-2016HP Ash X Black PM-19M547-4149H
X Dark Ash PM-19M547-2014HQ Light Sand X Black PM-19M547-4149H
X Black Ink PM-19M547-2005HR Torch Red X Black PM-19M547-4149H
X Black Ink PM-19M547-2005HS Shale/Dove X X Black PM-19M547-4149H
X X Shale PM-19M547-2024HX X Dove Gray PM-19M547-2025H
T Graphite/Dark Graphite X X Black PM-19M547-4149HX Dove Gray PM-19M547-2025HX X Dk. Graphite PM-19M547-4253H
U Dark Stone/Medium X X Black PM-19M547-4149HLight Stone X X Med. Light Stone PM-19M547-2011H
X X Dark Stone PM-19M547-2012HX Med. Stone PM-19M547-2022H
W Dark Charcoal X X X X X Black PM-19M547-4149HX X X X X Midnight Black PM-19M547-1074H
X Lt. Graphite PM-19M547-4240HW Medium Pebble X X Black PM-19M547-4149H
X X Lt. Parchment PM-19M547-1076HX X Med. Pebble PM-19M547-2016H
X Med. Dk. Pebble PM-19M547-2017HW Tan X Black PM-19M547-4149H
X Med. Pebble PM-19M547-2016HX Dark Pebble PM-19M547-2018H
W Midnight Black/w Midnight X X X X Black PM-19M547-4149HBlack/Black Ink X Midnight Black PM-19M547-1074H
X X X Black Ink PM-19M547-2005HZ Oxford White/ X X Black PM-19M547-4149H
Performance White X Midnight Black PM-19M547-1074HX Black Ink PM-19M547-2005H
Ford has adopted a new premium paint formulation for use onautomotive interior plastic trim parts. Motorcraft® Interior Spray Painthas significantly improved performance properties. When used asdirected, the paint provides the following benefits:• Preserves the original grain pattern of the plastic, i.e., the grain remains visible• UV stable and colorfast• Completely flexible — will not crack, flake, or peel• Quick drying — gets the job done in minutes• Ideal and convenient for both paint-to-match and repair procedures usage• Each 6 oz. can covers approximately 5-7 sq. ft. of plastic surface• Use only as recommended. Follow the important usage directions provided in TSB 05-9-3.
Interior Spray Paint
| 91 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick Reference
Charts
A/C Cooling Coil Coating YN-29 03-5-6
A/C System Flushing Solvent YN-23 02-20-8
07-18-3
07-25-1
07-26-3
Acid Neutralizer ZC-1-A 04-9-6
Additive Friction Modifier XL-3 97-8-11
98-5a-27
98-11-10
04-16-14
02-10-1
05-10-1
05-20-2
05-23-3
06-2-16
06-4-4
06-5-16
06-12-11
07-22-8
Adhesion Promoter PM-19A316-AA 03-15-12
04-20-7
05-9-3
Alkaline Neutralizer ZC-2-A 04-9-6
Anti-Corrosion Coating Low Temp PM-12-A 03-26-4
High Temp PM-13-A 04-4-1
04-21-8
04-25-17
04-26-16
04-26-17
05-1-1
05-12-7
05-20-3
06-15-11
06-20-12
Anti-Gel and Performance PM-23-A 07-22-5
Improver (ULSD Compliant) PM-23-ASU 08-1-5
PM-23-GAL 08-2-7
Bug and Tar Remover ZC-42 05-16-2
Carburetor Tune-Up Cleaner PM-2 01-19-7
PM-3 04-19-2
06-18-3
07-16-1
07-21-4
07-24-8
08-1-9
08-4-7
Cetane Booster and Performance PM-22-A 07-22-5
Improver (ULSD Compliant) PM-22-ASU 08-1-5
PM-22-GAL 08-2-7
Clear Silicone Rubber TA-32 97-7-15
97-26-14
03-12-1
04-9-5
04-14-8
04-15-3
04-21-20
04-23-9
05-7-4
05-10-1
05-13-3
06-14-8
06-14-10
07-1-11
07-12-6
Custom Bright Metal Cleaner ZC-15 97-26-13
98-1-13
06-15-11
Dash and Vinyl Cleaner ZC-38-A 03-8-2
05-13-7
| 92 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick
Re
feren
ce
Char
ts
Detail Wash ZC-3-A 03-10-1
04-9-6
Dusting Cloth ZC-24 05-13-7
Electrical Grease XG-12 97-24-10
98-24-6
00-6-3
03-1-3
04-14-9
04-24-12
06-9-3
06-21-12
Full Synthetic Manual XT-M5-QS 00-1-9
Transmission Fluid 01-15-7
Gasket Maker TA-16 91-13-7
05-10-10
High Contrast Hypoid Gear XG-14 05-20-2
Marking Compound 05-23-3
High Performance DOT 3 PM-1-C 98-5a-50
Motor Vehicle Brake Fluid PM-1-Q 99-1-6
High Temperature 4x4 Front Axle XG-11 98-14-8
and Wheel Bearing Grease 01-3-2
01-11-4
High Temperature Nickel XL-2 98-5a-5
Anti-Seize Lubricant 98-1-4
05-19-12
06-9-10
06-15-2
07-16-1
07-21-4
08-1-9
08-4-7
Instant Gel Adhesive TA-19 97-12-1
98-8-11
98-20-19
99-6-5
99-13-10
02-25-11
04-2-2
04-12-4
04-24-3
07-4-3
07-16-11
Interior Spray Lacquer M4JZ-19M547- 03-8-2
XXXXH
Interior Spray Paint PM-19M547- 04-20-7
XXXXH 05-9-3
Isopropanol Cleaning Kit ZC-4 01-18-2
01-22-4
03-18-4
05-6-4
07-18-7
Manual Dual Cartridge TA-10 02-17-9
Applicator Gun 04-8-2
MERCON SP Automatic XT-6-QSP 06-7-3
Transmission Fluid XT-6-DSP 06-14-4
MERCON V Automatic XT-5-QMC 98-3-6
Transmission and Power XT-5-QM 98-8-7
Steering Fluid XT-5-5QM 98-15-9
XT-5-GM 99-14-12
XT-5-DMC 99-16-5
XT-5-DM 99-16-6
99-17-1
99-18-4
99-18-9
00-15-1
00-24-2
02-10-9
| 93 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick Reference
Charts
MERCON V Automatic 02-19-1
Transmission and Power 02-20-3
Steering Fluid (con’t) 04-22-10
06-8-2
06-14-4
06-22-7
06-23-3
06-26-1
07-1-7
07-5-6
Metal Bonding Adhesive TA-1 01-18-2
01-19-6
04-17-3
04-18-11
04-24-1
04-26-16
04-26-17
Metal Brake Parts Cleaner PM-4-A 99-5-4
PM-4-B 02-21-1
04-26-7
05-4-7
05-9-10
05-13-10
05-14-8
05-22-3
05-22-19
07-3-1
07-5-15
07-12-4
07-13-9
07-14-4
08-4-7
Metal Surface Prep ZC-31-A 02-11-4
02-21-13
03-6-2
05-10-10
05-10-13
06-21-10
07-16-16
Metal Surface Prep (con’t) 08-3-7
Multi-Purpose Grease XL-5 97-15-14
XG-4 (FAD) 03-23-1
04-2-3
05-16-7
Nitrile Technician Gloves ZC-55-L 06-21-12
ZC-55-XL
PAG Refrigerant Compressor Oil YN-12-D 97-15-5
98-12-5
02-20-8
04-24-6
07-18-3
07-25-1
07-26-3
Penetrating and Lock Lubricant XL-1 02-17-12
Plastic Bonding Adhesive TA-9 01-18-2
04-8-5
04-16-9
04-19-9
05-8-3
06-21-12
Pneumatic Dual Cartridge TA-11 02-17-9
Applicator Gun 04-8-2
Power Flush Injector Fluid PM-5 03-18-3
03-20-6
05-6-13
05-9-1
Premium Cooling System Flush VC-1 07-8-10
07-23-14
08-3-7
08-4-14
Premium Engine Coolant with VC-5 98-8-6
Bittering Agent VC-5-B 01-11-6
| 94 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick
Re
feren
ce
Char
ts
Premium Engine Coolant with 01-23-6
Bittering Agent (con’t)
Premium Gold Engine Coolant VC-7-B 01-23-6
with Bittering Agent VC-7-D 02-3-4
02-23-7
08-4-14
Premium Long-Life Grease XG-1-C 98-16-2
XG-1-K 98-17-21
98-21-7
01-3-2
02-19-1
07-24-1
Premium Power Steering Fluid F7AZ-3F823-BA 98-5a-22
(DOES II) 04-22-10
XL-9 (FAD)
PTFE Lubricant D2AZ-19590-A 97-13-21
XG-8 98-17-21
00-25-8
04-1-6
04-26-6
05-26-10
R-134a Refigerant YN-19 00-5-1
YN-21 02-20-8
05-14-11
06-14-3
07-18-3
07-25-1
07-26-3
Rear View Mirror Adhesive TA-17 94-17-2
Rear Window Defroster Repair PM-11 04-24-5
05-13-10
05-22-19
Roof Ditch Sealer TA-15 02-21-4
04-26-4
Roof Ditch Sealer (con’t) 05-13-3
07-1-11
RTV Silicone Sealant TA-31 98-18-14
00-24-3
03-21-9
04-19-6
04-26-7
05-9-10
07-3-1
07-5-15
SAE 5W-20 Premium Synthetic XO-5W20-QSP 02-1-9
Blend Motor Oil XO-5W20-5QSP 05-15-8
XO-5W20-DSP
SAE 5W-30 Premium Synthetic XO-5W30-QSP 98-17-21
Blend Motor Oil XO-5W30-5QSP
XO-5W30-DSP
SAE 75W-140 Synthetic Rear XY-75W140-QL 04-24-20
Axle Lubricant 05-10-1
05-12-6
05-20-2
05-23-3
06-2-16
06-4-4
06-12-11
07-16-10
SAE 75W-90 API GL-4 Gear Oil XY-75W90-QGL 01-15-7
04-16-4
SAE 75W-90 Specialty Power XY-75W90-PTU 06-4-11
Transfer Unit Fluid 06-9-6
SAE 80W-90 Premium Rear Axle XY-80W90-QL 03-5-8
Lubricant XY-80W90-KL 05-6-20
05-10-1
Seam Sealer TA-2 01-18-2
01-19-6
| 95 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick Reference
Charts
Seam Sealer (con’t) 02-17-4
04-18-11
04-26-4
04-26-16
07-14-6
Silicone Brake Caliper Grease XG-3-A 98-5a-19
and Dielectric Compound 98-5a-22
98-5a-23
98-5a-29
98-5-4
98-19-2
98-23-6
99-5-7
99-8-10
00-6-9
01-22-4
03-7-2
03-22-6
04-21-6
04-22-13
05-10-21
05-16-2
06-5-14
06-7-4
06-7-6
07-9-8
07-11-2
07-11-8
07-12-4
07-13-5
07-14-4
07-19-3
07-22-1
07-26-8
Silicone Gasket and Sealant TA-30 97-2-8
97-24-4
98-6-2
98-7-4
98-12-3
99-5-7
Silicone Gasket and Sealant (con’t) 00-18-5
03-5-3
03-6-4
03-7-1
03-16-2
03-19-3
03-21-9
04-9-5
04-17-9
05-10-10
07-24-6
Silicone Gasket Remover ZC-30 02-11-4
02-21-13
03-6-2
04-17-9
05-10-10
05-10-13
06-21-10
Silicone Spray Lubricant XL-6 98-11-8
00-26-3
04-22-10
06-20-4
07-23-4
08-1-2
08-2-6
08-4-10
Specialty Orange Engine Coolant VC-3 01-23-6
with Bittering Agent
Stud and Bearing Mount TA-27 02-21-11
05-20-2
05-23-3
Synthetic MERCON Multi-Purpose XT-2-QSM 01-15-7
Automatic Transmission Fluid 07-1-2
Threadlock 262 TA-26 97-14-21
97-21-17
| 96 |
TSB Reference ChartPart Name Part Number TSB Part Name Part Number TSB
Quick
Re
feren
ce
Char
ts
Threadlock 262 (con’t) 98-17-15
03-21-43
05-17-6
06-14-10
Threadlock and Sealer TA-25 97-2-3
98-5a-27
98-21-20
00-5-1
03-15-15
04-23-7
05-16-4
05-20-2
Trim and Weatherstrip Adhesive TA-14-A 03-15-12
04-9-5
05-21-14
Triple Clean ZC-13 01-22-4
Ultra Silicone Sealant TA-29 98-5-8
98-7-4
00-24-2
02-21-1
04-16-4
05-10-1
05-12-6
05-20-2
05-23-3
06-10-5
06-14-6
06-17-06
07-7-1
07-14-1
07-15-3
Ultra-Clear Spray Glass Cleaner ZC-23 04-24-5
05-13-7
07-16-11
97
CHEK-CHART Lubrication Recommendations Guide2008 EDITION
MOTOR is a trademarkof Hearst Business Media
Published by MOTOR Information Systems,
Hearst Business MediaA Unit of Hearst Corporation
5600 Crooks Road Suite 200,Troy, MI 48098
Printed in the U.S.A. Copyright © 2008 Hearst Business Media
All rights reservedISBN 1-57932-555-6
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
98
AE Esso Type LT 71141 Automatic Transmission FluidAudi, Volkswagen: P/N G 052 162 (-A1, -A2)BMW: P/N 83 22 9 407 807Jaguar: P/N JLM 20238Porsche: P/N 999 917 547 00 (A2) or P/N 000 043 205 09 (20 liter container)
AF2 DEXRON®-II Automatic Transmission Fluid
AF3 DEXRON®-III Automatic Transmission FluidAGCO, Deutz-Allis, White: Power Fluid 411BMW: Power steering use AF3; Models with combined power steering, hydraulic brake booster, self-leveling suspension system use SLFMercedes-Benz: Use only manufacturer approved fluid
AF6 DEXRON®-VI Automatic Transmission Fluid
AP3 ATF+3® Automatic Transmission FluidChrysler, Dodge and Plymouth: Mopar ATF+3® (Type 7176E) P/N 4798233.Mitsubishi: Mitsubishi Diamond SP, P/N MS991156
AP4 ATF+4® Automatic Transmission FluidChrysler, Dodge, Dodge Trucks, Eagle, Jeep and Plymouth: Mopar ATF+4® (Type 9602), P/N 05013457AA (quart) and 05013458AA (gallon)
API★ Motor Oil certified by the American Petroleum Institute (Starburst Symbol)AM General: Use Engine oil which meets GM Standard GM6094MBuick: 2004-08 use engine oil which meets GM Standard GM6094MCadillac: 2004-08 CTS, CTS-V, SRX, XLR, 2005-08 STS, 2006-07 STS-V, XLR-V, 2008 DTS and Escalade only oil meeting GM Standard GM4718M. Other 2004-08 models use engine oil meeting GM Standard GM6094M.Chevrolet: 1997-08 Corvette, 2005-08 Cobalt 2.0L Supercharged, 2005-06 SSR, 2006-08 Trailblazer SS and 2008 HHR Turbocharged use only oil that meets GMStandard GM4718M.Other 2004-08 models use engine oil which meets GM Standard GM6094M.Chrysler, Dodge and Jeep: As noted use SAE 5W-20, SAE 5W-30 or 10W-30 meeting MS-6395. Use Full Synthetic SAE 10W-30 meeting MS-9615 in Viper. FFVengine oils must meet MS-9214. 300, Magnum, and Charger with 6.1L engine use SAE 0W-40 meeting MS-10725 as notedFord, Lincoln, Mazda Trucks, Mercury: As noted use SAE 5W-20, Spec WSS-M2C930-A (ILSAC GF-4), or SAE 5W-30, Spec WSS-M2C929-A (ILSAC GF-4). FFVuse, Spec. WSE-M2C909-AGMC: 2004-08 use engine oil meeting GM Standard GM6094MPontiac: 2005-06 GTO, 2007-08 Solstice Turbocharged and 2008 G5 Turbocharged only use engine oil meeting GM Standard GM4718MOther 2004-08 models use engine oil which meets GM Standard GM6094M.Saturn: 2004-07 Ion Redline and 2008 Saturn Sky Turbocharged only use engine oil meeting GM Standard GM4718MOther 2004-08 models use engine oil which meets GM Standard GM6094M.
BC Bar and Chain OilUse manufacturer’s packaged oils or equivalent
BTF Hydraulic Transmission FluidJohn Deere: BIO-HY-GARD
CF Motor Oil, API Service CF
CF-2 Motor Oil, API Service CF-2
CF-4 Motor Oil, API Service CF-4
CG-4 Motor Oil, API Service CG-4
CH-4 Motor Oil, API Service CH-4
CI-4 Motor Oil, API Service CI-4
CI-4+ Motor Oil, API Service CI-4 PLUS
CJ-4 Motor Oil, API Service CJ-4
CL Chassis Lubricant
CTF Cab Tilt FluidAll makes: Use manufacturer’s packaged oil or a MIL-H-5606 equivalent
CV Constant Velocity Joint GreaseFord, Lincoln and Mercury: Use P/N XG-5, Spec. WSS-M1C258-A
ECF-1 Motor oil, ECF 1Caterpillar: spec ECF1 motor oil suitable for Pre 2007 Caterpillar engines
ECF-3 Motor oil, ECF 3 Caterpillar: spec ECF3 motor oil suitable for Post 2007 Caterpillar engines (must meet API CJ-4)
EO-L Motor Oil, EO-LMack: Spec. EO-L
99
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
EO-L Plus Motor Oil, EO-L PlusMack: Spec. EO-L Plus
EO-M Motor Oil, EO-MMack: Spec. EO-M (must pass Mack T-8E and T-9 tests).
EO-M Plus Motor Oil, EO-M PlusMack: Spec. EO-M Plus (must pass Mack T-8E and T-9 tests and resistance to oxidation).
EO-N Plus Motor Oil, EO-N Premium PlusMack: Spec. EO-N Premium Plus (must pass Mack T-8E and T-10 tests).
EO-O Plus Motor oil, EO-O premium plusMack: Mack: spec EO-O premium plus (must meet Mack requirement in Mack T12 and Cummins ISB tests)
EP Extreme Pressure Gear OilFord, Mercury: Spec. M2C83C
FA Automatic Transmission Fluid, Type-FFord, Lincoln, Mercury, Ford Trucks: Spec. ESW-M2C-33F
GA Automatic Transmission Fluid, Type-G
GC Wheel Bearing Grease, NLGI Classification GCAGCO: P/N 79014730Bering: no. 1 (Ba AI BASE)Chrysler, Dodge and Jeep: P/N 05083149AA meeting MS-6560Freightliner: no. 2GM: P/N 1051344, Spec. no. 998525VInternational (Navistar): Optional synthetic grease P/N 2644067R1Isuzu: no. 2 or 3
GG Graphite Grease
GL-1 Gear oil, API Service GL-1
GL-2 Gear oil, API Service GL-2Meritor/Rockwell: Spec O-72 or O-73
GL-3 Gear Oil, API Service GL-3AM General: Manual Transmission: use SAE 75W-90 P/N 89021806 or equivalent.Cadillac: as noted SAE 75W-90, P/N 89021806 or equivalent.Chevrolet: as noted SAE 75W-90, P/N 89021806 or equivalent.Chevrolet Trucks: as noted SAE 75W-90, P/N 89021806 or equivalent.Dodge Truck, Jeep: as noted SAE 75W-90, P/N 04897622AA meeting MS-9684GMC Trucks: as noted SAE 75W-90, P/N 89021806 or equivalent.Isuzu: as noted SAE 75W-90, P/N 89021806 or equivalent.Pontiac: as noted SAE 75W-90, P/N 89021806 or equivalent.Saturn: as noted SAE 75W-90, P/N 89021806 or equivalent.
GL-4 Gear Oil, API Service GL-4Audi, Volkswagen: P/N G005 000 (G50); P/N G005 100 (G51), P/N G052 145 (-A1, -A2, -S2); P/N G 052 911(-A1), P/N G 052 171 (-A2) or P/N G 052 726 A2Dodge: NV 4500, Tremec T56 & 1997-2002 Viper manual transmission use Synthetic 75W-85, P/N 04874459 meeting MS-9070.Ford, Lincoln, Mazda, Mercury: SAE 75W-90, P/N F32Z-19C547-MA, Ford Spec. WSS-M2C203-A1, Mazda Spec. (MES) 115ANissan: Manual Transmission, SAE 75W-85, Nissan MTF HQ Multi 75W, P/N 999MP-MTF00P.Subaru: Manual Transmission: Justy, P/N K0324F0091
GL-5 Gear Oil, API Service GL-5AGCO: Gear Lube 715, SAE 80W-90AM General: Front and Rear Differential 2003-08 H2 and 2006-08 H3 use GM P/N 12378261, Spec. 9986115Buick: Front & Rear Differential Rainier 2004-08 use GM P/N 12378261, Spec. 9986115Cadillac: Rear Differential 2003-08 CTS and Front and Rear Differential 2004-08 SRX and 2005-08 STS Rear Differential, use GM P/N 12378261, Spec. 9986115.Escalade models see GM Trucks.Chevrolet: 1997 Camaro, P/N 12345977 or 80W-90 meeting Spec. 9985182. 1998-2002 Camaro use P/N 12378261 or Synthetic 75W-90 meeting Spec.9986115. Others may use P/N 1052271, Spec. 9985290Chrysler, Dodge and Jeep Use the following as noted: SAE 75W-90, P/N 05010320AA meeting MS-9763; SAE 80W-90, P/N 04874468 meeting MS-9020; SAE90, P/N 04874466 meeting MS-8987; or Synthetic SAE 75W-140, P/N 04874469 meeting MS-8985; With limited slip & models w/Quadra Drive or Vari-Lok (front& rear axles), add additive P/N 04318060AB as noted; 1997-08 Wrangler, TJ w/ Trailer Tow package & Liberty 8.25 axle w/ Trailer Tow package use synthetic75W-140 oil Mopar P/N 82200945.Deere: John Deere Extreme GuardEaton: Spec. MIL-PRF-2105EFabco and Marmon-Herrington: Front-wheel driving axles in Mack Trucks, Mack Spec. GO-JFord, Lincoln, Mazda Trucks, and Mercury: SAE 80W-90, P/N XY-80W90-QL used in all front axles. 2005-07 Five Hundred, Montego and Freestyle, Power Transfer Unit uses SAE 75W-90 P/N XY-75W90-PTU. 2007-08 Edge, MKX, MKZ, Fusion and Milan Power Transfer Unit uses SAE 75W-140 P/N XY-75W140-QL. Rear axles use SAE 80W-90, P/N XY-80W90-QL, Spec. WSP-M2C197-A; or Synthetic SAE 75W-140, P/N XY-75W140-QL, Spec. WSL-M2C192-A; or SyntheticSAE 75W-90, P/N XY-75W90-QLS, Spec. DANA ES-PM-M2013
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
100
GL-5 Gear Oil, API Service GL-5 (continued)GM Light Duty Trucks: 2001-05 P/N 1052271, Spec. 9985290 as noted. 1997-00 Front axles: S-Trucks, Vans & full-size trucks, 80W-90, P/N 1052271, Spec.9985290. Rear axles: 2000 full-size models, G-Vans with 8.6” axle, 1999 Silverado, and Sierra with 4.3L, 4.8L, 5.3L, or 6.0L engine, 75W-90 Synthetic P/N12378261, Spec. 9986115. 2006 Front and Rear Differential as noted use GM P/N 12378621. 1997-2000 HD 3500 with Dana 11” axle, 75W-140 Synthetic, P/N12346140, Spec. 9985991; Tracker & Sunrunner differential, 80W-90 P/N 12345977; Others, 80W-90, P/N 1052271, Spec. 9985290GM Medium & Heavy Duty Trucks: SAE 75W-90 Synthetic P/N 12345841, Synthetic P/N 12345724, or 80W-90 as notedGeo: Tracker, P/N 12345977Isuzu: Front and rear differential 2003-08 Ascender, 2006 I280 and I350, 2007-08 I290 and I370 use GM P/N 12378261, Spec. 9986115.International (tractors): Specification B-22Jaguar: Synthetic SAE 75W-140, Spec. M2C 192AMack: Transfer case, 1997-2001, GO-J, GO-J PLUS Transmission, 1997-2000, GO-J, GO-J PLUS, TO-A PLUS; 2001, TO-A PLUSMercedes-Benz: Front axle (4matic) and rear axle (Standard Differential): P/N 001 989 17 03 or approved products on MB Sheet 235.7 should be used. P/N 000989 28 03 or approved products on MB Sheet 235.0 may be usedMeritor/Rockwell: Spec. O-76A (85W-140), O-76D (80W-90), O-76E (75W-90), O-76J (75W), 0-76L (75W-140), O-76M (full synthetic 75W-140), O-76N (fullsynthetic 75W-90)Pontiac: Differential 1997 Firebird, GM P/N 12345977 or 80W-90 meeting Spec. 9985182. Differential 1998-2002 Firebird and 2006-08 Solstice use GM P/N12378261 or Synthetic 75W-90 meeting Spec. 9986115. Others may use P/N 1052271, Spec. 9985290Porsche: 1999-05 911: P/N 999 917 545 00 is preferred in differential and manual transmission; 1997-05 Boxster: G86/00 & G86/01 manual transmission useP/N N 052 911 CO; Boxster S: G86/20 manual transmission use P/N 999 917 546 00; 1997-05 Boxster and Boxster S: final drive of Tiptronic transmission useP/N 999 917 546 00Saab: Front and rear differential 2005 9-7X, use GM P/N 12378261, Spec. 9986115Saturn: MJ8 transfer case 2006-08 VUE use GM P/N 12378261. Differential 2007-08SKY use GM P/N 12378621.Subaru: P/N K0324AA093
GL-5★ GL-5 Gear Oil for Limited-Slip DifferentialsCadillac: Rear Differential CTS and XLR, P/N 12378261 or equivalent meeting Spec. 9986115 plus 4 oz. Additive P/N 1052358, Spec. 9035-P. Rear differentialSTS and SRX, P/N 12378261 or equivalent meeting Spec. 9986115 plus 3.4 oz. (rear cover removed) or 2.4 oz (drain plug removed) Additive P/N 1052358,Spec. 9035-P.Chevrolet: Camaro, 1997-98, and Corvette 1998 and earlier, P/N 12345977 or 80W-90 GL-5 meeting Spec. 9985182 plus 4 oz. Additive P/N 1052358. Camaro,Corvette, 1999-04, P/N 12378261 or equivalent meeting Spec. 9986115 plus 4 oz. Additive P/N 1052358, Spec. 9035-P. NOTE: For all applications Not usingsynthetic, with complete drain & refill add 4 oz. P/N 1052358, Spec. 9035-P.Chrysler, Dodge and Jeep: Use the following as noted: SAE 75W-90, P/N 05010320AA meeting MS-9763; SAE 80W-90, P/N 04874468 meeting MS-9020; SAE90, P/N 04874466 meeting MS-8987; or Synthetic SAE 75W-140, P/N 04874469 meeting MS-8985. All axles require 6.5% additive, P/N 04318060AB meetingMS-10111Ford, Lincoln, Mazda Trucks, Mercury: For rear use the following as noted: SAE 80W-90, P/N XY-80W90-QL, Spec. WSP-M2C197-A plus specified quantity ofadditive; or Synthetic SAE 75W-140, P/N XY-75W140-QL, Spec. WSL-M2C192-A plus specified quantity of additive; or Synthetic SAE 75W-90, P/N XY-75W90-QLS, Spec. DANA ES-PM-M2013 plus specified quantity of additive. Ford/Visteon axles with 7.5, 8.8 and 9.75 ring gears require 4 fl oz of friction modifier, P/NXL-3, EST-M2C118-A. Ford/Visteon axles with 10.25 and 10.50 ring gears and Dana M60, M70 and M80 axles require 8 fl oz of friction modifier, P/N XL-3, EST-M2C118-A.GM Trucks: P/N 1052271 (Canada, 740321), Spec. 9985290Isuzu: Use GL-5 Limited-Slip Differential Gear Lubricant plus 4 oz. Additive, Isuzu P/N 8-01052-358-0 or GM P/N 1052358Mercedes-Benz: Rear axle (Limited-slip Differential): P/N 001 989 17 03 or approved products on MB Sheet 235.7Mitsubishi: Genuine Gear Oil, P/N 8149630EX (90 GL-5)Peugeot: P/N 97.37Pontiac: Firebird, 1997-98, P/N 12345977 or 80W-90 GL-5 meeting Spec. 9985182 plus 4 oz. Additive P/N 1052358. Firebird, 1999-04, P/N 12378261 or equiv-alent meeting Spec. 9986115 plus 4 oz. Additive P/N 1052358, Spec. 9035-P and 2006-08 Solstice use GM P/N 12378261 or Synthetic 75W-90 meeting Spec.9986115. plus noted amount of Additive P/N 1052358. NOTE: For all applications not using synthetic, with complete drain & refill add 4 oz. P/N 1052358, Spec.9035-P.Volvo: With Eaton limited-slip axles GL-5 plus additive 1161329-6; with Dana limited-slip axles GL-5 plus 0.5 Liters Additive P/N 1161129-0
GLS Gear Lubricant, SpecialAcura: Manual Transmission: use Acura Manual Transmission Fluid, P/N 08798-9031A. Rear Differential 2001-06 MDX use VTM-4 differential fluid Acura P/N08200-9003AAM General: Transfer Case 2007 H2 and H3 use GM P/N 88861800.Audi: Haldex clutch TT Quattro: P/N G 052 175 (-A1). Manual transmission 02Q use P/N G052 171 (-A2)BMW: Differential, Castrol SAF-XO or BMW P/N 83 22 9 407 768; with multiplate limited-slip, Castrol SAF-XJ or BMW P/N 83 22 1 470 080. Manual transmis-sion with green label, use Mobil SHC630 Industrial Synthetic Gear Oil. Manual transmission with yellow label: Esso/Exxon MTF-LT-1, BMW P/N 83 22 9 408 942from model year 2004 some manual transmissions are filled with Castrol MTF-LT-2 which has the same properties as MTF-LT-1. The MTF-LT-1 fluid may bemixed and or substituted for the MTF-LT-2 manual transmission fluid. Manual Transmission 2006 325xi, 330xi, 525xi, and 530xi Manual Transmission useEsso/Exxon MTF-LT-3, BMW P/N 83 22 0 409 878 2001-2005 325XI and 330XI transfer case use Esso/Exxon MTF-LT-1, BMW P/N 83 22 9 408 942. 2004-05 X3and X5 with X-drive transfer case use BMW P/N 83 22 0 306 816. 2006 325xi, 330xi, 525xi, and 530xi Transfer case use BMW P/N 83 22 0 397 244 (TF0870)2006 M5 with SMG, 2006 M Coupe and M Roadster only use MTF-LT-2, BMW P/N 83 22 0 309 031.Cadillac: Manual transmission & transfer case applications use GM P/N 88861800.Chrysler: NVT350 (A578) manual transaxle use Mopar manual transmission fluid P/N 04874465 meeting MS-9417. 2004-06 Crossfire use Mopar P/N04761872AB or approved products as listed on MB 236.2.Chevrolet: Manual Transmission 1998-01 Metro, 1998-02 Prizm and 2004-06 Aveo use GM P/N 12346190;Manual Transmission 1997-99 Cavalier and 1997-01 Venture use GM P/N 12345349. All other manual transmission & transfer case applications use GM P/N 88861800.Chevrolet Trucks: Manual Trans. and transfer case 1998-2004 Tracker use GM part no. 12346190 NOTE for the 1999-2004 Tracker if the determination has beenmade that the 5-speed M59 TRANS synchronizers have been replaced, use GM part no. 12345349; Manual Trans NV1500 use GM part no. 12377916; ManualTrans. NV4500 use GM part no. 12346190; Manual Trans NV3500 use GM part no. 12345349; .5-speed manual transmission sectional case use GM part no.12345349 or 1052931; 4-speed manual transmission aluminum case use GM part no. 1052931. 4-speed manual transmission w/ iron case use GM part no.12345577. Manual transmission 2004-08 Colorado use GM part no 89021806. Transfer case 2004-08 Colorado use GM part no. 12345349. With Dana 11 inchring gear differential use GM part no. 12346140, Spec. 9985991. Dodge: NVT350 (A578) manual transaxle use Mopar manual transmission fluid P/N 04874465 meeting MS-9417.Dodge Trucks: NV1500, -3500, -3550, -5600, manual trans. use Mopar P/N 04874464 meeting MS-9224.
101
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
GLS Gear Lubricant, Special (continued)Eagle: Manual Transmission 1997-98 Vision and 1997-98 Talon with non-Turbo engine use Mopar P/N 04874465 meeting MS-9417.Ford: 2005-2007 Five Hundred and Freestyle, Fluid coupler uses Volvo P/N 1161641GMC Trucks: 2004-08 Canyon use GM P/N 89021806.NV1500 manual transmission use GM P/N 12377916, NV3500 manual Trans. use GM P/N 12345349,Manual Transmission NV4500 use GM part no. 12346190. 5-speed manual transmission sectional case use GM part no. 12345349 or 1052931; 4-speed manualtransmission aluminum case use GM part no. 1052931. 4-speed manual transmission w/ iron case use GM part no. 12345577. Transfer case 2004-08 Canyonuse GM P/N 12345349. Manual Transfer case 2007 Silverado use GM P/N 88861800; With Dana 11 inch ring gear differential use GM P/N 12346140, Spec.9985991. Other differentials use GM P/N 12378557.Geo: Manual Transmission 1997 Metro, 1997 Prizm, and 1997 Tracker use GM P/N 12346190. Transfer Case 1997 Tracker use GM P/N 12346190.Honda: Manual Transmission: use Honda Manual Transmission Fluid, P/N 08798-9031. Rear differential 2003-2008 Honda Pilot and 2006-08 Ridgeline useHonda VTM-4 differential fluid, P/N 08200-9003.Isuzu: NV1500 manual transmission in 1997-2000 Hombre use GM P/N 12377916; NV3500 manual transmission in 1997-2000 Hombre use GM P/N 12345349.Manual transmission in 1997-99 Oasis use Honda Manual Transmission Fluid, P/N 08798-9016; Transfer Case 2006 I280 and I350, 2007-08 I290 and I370 useGM P/N 12345349Jaguar: Differential 1998-03 XJ8, 1998-04 XJR, 1998-06 XK8 and 2000-06 XKR use Shell Spirax TS 90Jeep: NSG370, NV1500, -3500, -3550, -5600, T4, T5 and T176 manual transmissions, P/N 04874464 meeting MS-9224.Land Rover: Range Rover Manual Trans R380 1997-2002: use Texaco MTF 94; Transfer case: 1999-04 Discovery, use Texaco Multi-gear 75W-90R or CastrolSynthetic 75W-90R. Transfer Case 2002-05 Freelander: use Texaco S5 Full Synthetic SAE 75W-90. Transfer Case 2003-05 Range Rover: Use Castrol BOT 26 FMB1. Transfer Case 2005-06 LR3 and 2006-07 Range Rover use Shell TF 0753. Differential 2002-05 Freelander use Texaco S5 Full Synthetic SAE 75W-90.Differential 2005 LR3 and 2004-07 Range Rover use Castrol SAF-XO. 2006-07 LR3 and 2006-07 Range Rover Sport use Castrol SAF-XO in the Standard differ-ential and Castrol SAF Carbon Mod Plus in the Electronic differential. 2008 LR2 Front differential and transfer case use BOT118 Plus 75W-90, P/N LR003137.2008 LR2 rear differential use Castrol EPX 80W-90 P/N LR003156.Mercedes-Benz: 6-Speed Manual transmission use P/N 001 989 2603 or approved products listed on MB Sheet 235.10. All others manual transmissions use asnoted P/N 000 989 2603 or approved products on MB Sheet 236.2. Rear Differential 2008 S63 AMG and 2008 S65 AMG use Fuchs Titan EG 5010 D.Mercury: 2005-2007 Montego, Fluid coupler uses Volvo P/N 1161641Merkur: Manual Transmission use Ford spec. ESD-M2C175-AMINI: Manual Transmission: up to 7/2004 production R65 5 Speed & Getrag 285 6 Speed use Texaco MTF94 Lifetime Fluid, P/N 83 22 0 140 516, from 7/2004production Getrag 252 5 Speed and 285 6 Speed use MTF LT-3 Lifetime Fluid, P/N 83 22 7 533 818.Mitsubishi: use Texaco MTX Fluid FMOldsmobile: Manual Transmission use GM P/N 12345349.Plymouth: Manual transaxles 1997-2001 Neon and 1997-2000 Breeze use P/N 04874465 meeting MS-9417.Pontiac: Manual transmission 1997-2001 Firefly, 1997 Sunrunner and 2003-07 Vibe use, GM P/N 12346190; Manual transmission 2007-08 G5 use GM P/N88861800; Transfer Case 1997 Sunrunner use GM P/N 12346190; all other 5-speed manual trans. use GM P/N 12345349. Pontiac 2007-08 Torrent Carrierassembly use GM P/N 89021677Porsche: Cayenne final drive without limited slip use Burmah SAF-AG4, Porsche P/N 000 043 205 30, Cayenne final drive with limited slip use Burmah SAFCarbon Mod, Porsche P/N 000 043 300 37.Saturn: Manual Transmission 2007 VUE and ION use GM P/N 88861800. Transfer Case 2008 VUE use GM P/N 89021677Subaru: P/N 003304300. Differential 2004-06 Impreza WRX STi use Subaru P/N K0904AA080Toyota: V160 Gear Oil, P/N 08885-01306Volkswagen: 2004 Touareg, with VIN 7L_4D000014 to 7L_4D060119 (USA) and 7L4D000039 to 7L_4D059806 (Canada) use Volkswagen P/N G 052 196 A2 infinal drive with differential lock.Volvo: Manual Trans. 1997 850 and 1998-2005 C70, S70, V70 use P/N 11 61 423-7; Manual Trans. 2001-05 S40, S60 use P/N 11 61 745; Manual Transmission2006-07 C70, S40, S60, S60R, V50, and V70 use P/N 11 61 745; Transfer Case use P/N 1161513-5. Differential 2006 S60, S80, V70m XC70, and XC90 useVolvo P/N 1161620-8. Manual Transmission 2008 S60 use MTF97309.
GO-H/S Gear Oil, GO-H/SMack: Spec. GO-H/S
GO-J Gear Oil, GO-JMack: Spec. GO-J
GO-J PLUS Gear Oil, GO-J PlusMack: Spec. GO-J PLUS
HB Hydraulic Brake Fluid, SAE J1703Hydraulic Brake Fluid, DOT 3 or 4Acura: Heavy Duty Brake Fluid DOT-3, Acura P/N 08798-9008A.BMW: DOT 4 only Note: Models with hydraulic brake booster and self leveling suspension use SLFChrysler, Dodge and Jeep: DOT 3, P/N 04318080AB meeting MS-4574GM: Brake system, P/N 12377967, Spec. 9986121 or equivalent DOT 3; clutch system, P/N 12345347, Spec. 9985642 preferred or equivalent DOT 3Honda: DOT-3, Honda P/N 08798-9008Lexus: DOT-3, DOT-4, or SAE J1703Mini: DOT 4 fluid, Mini P/N 81 22 0 146 735Saab: Use fluid meeting DOT 4 requirements
HBH Hydraulic Brake Fluid, Extra Heavy DutyBering: DOT 4Chrysler, Dodge and Jeep: DOT 4, P/N 04549625 meeting MS-9971Ford, Lincoln, Mazda Trucks, Mercury: High Performance DOT 3, P/N PM-1 or PM-1-C, Spec. WSS-M6C92-A, ex. 2000-01 Focus w/manual transaxle use SuperDOT 4, P/N YS4Z-19542-AA, Spec. ESD-M6C57-AJaguar: up to 2002 Castrol-Girling Universal; 2002-2005 ITT Super DOT 4; 2006-2007 Shell ESL Super DOT4.Land Rover: Shell Donax YB DOT-4 ESL Fluid. (if fluid is not available use a low viscosity DOT-4 meeting ISO 4925 class 6 and Land Rover LRES22BF03Mercedes-Benz: Use MB P/N 000 989 08 07 -01 (1 liter), MB P/N 000 989 08 07 -11 (5 liter) or MB approved productsPeugeot: Hydraulic Brake Fluid, DOT 3 or 4Porsche: DOT 4 Type 200Volvo: Hydraulic Brake Fluid, DOT4+, P/N 9437433
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
102
HF Type C-4 FluidCase: TCH Fluid
HG High Temperature Grease: Clay, complex, or polyurea thickenedCaterpillar: no. 2 Polyurea GreaseDeere: HG, use complex or polyurea EP no. 2 Spec. JDM J13E4. Use MIL-G-10924F below -22°F (-30°C) Moly HG, use complex with Moly and EP, Spec. JDMJ25Ford, Lincoln, Mazda Trucks, Mercury: P/N XG-11, Spec. ESA-M1C198-AGM: NLGI #3, P/N 12345777
HOA Antiwear Hydraulic OilKubota: VG 32, may use inhibited formulation
HP Hypoid Gear OilFord Trucks: Use as noted XY-90-GL, Spec no. ESW-M2C105-A. Requires 4 fl oz of friction modifier, P/N XL-3, EST-M2C118-A for limited slip applications.
HTF Tractor Hydraulic FluidAGCO, Deutz-Allis, White: Power Fluid 821-XLCase, Case IH: Hy-Tran Plus®, Spec. MS-1207; Hy-Tran Ultra, Spec. MS-1209, as noted.Deere: Hy-Gard®, Spec. JDM J20C or J20DHesston Fiat (tractors): Oliofiat Tutela Multi-FKubota: Super UDT FluidLandini, Massey Ferguson: PERMATRAN®-III Fluid. As noted use Spec. M1135, M1143 or M1144New Holland, Ford: 134 Hydraulic Fluid, Spec. ESN-M2C134-D. As noted use Spec. F200-A in cold weather
HY Hydraulic OilNew Holland, Ford: Hydraulic Oil 41, P/N 1QM2C41, Spec. ESN-M2C41-B
LB Chassis Grease, NLGI Classification LBAM General: GM P/N U.S. 12377985, in Canada 88901242 or lubricant meeting requirements of NLGI #2, Category LB or GC-LB.Chrysler, Dodge and Jeep: P/N 04897841AA meeting MS-4178 GM: P/N 12377985Mack: Semi-fluid grease, Mobil® SHC® 007 or equivalent
LM Lithium Multipurpose GreaseEP LM: Lithium Grease with EPAGCO: Lithium II, P/N 79014728.Bering: NLGI no. 2.Case IH: Spec 251H-EPDeere: Capable of operating above 302ºF (150ºC).International (trucks): Fleetrite® EP2 Moly Grease.Freightliner, Kenworth, Peterbilt, Sterling: EP grease with lithium 12-hydroxy stearate base.GM: P/N 12377985Mack: Spec. MG-CMassey Ferguson: Spec M-1105.Mercedes-Benz: Use only manufacturer approved products.New Holland, Ford (tractors): P/N 9613310, Spec. ESN-M1C137-B.White GMC: EP+Moly grease preferred.
Moly LM: Lithium Grease with MolyMoly Poly LM: Lithium Grease with Polyethylene and MolyFord, Lincoln, Mazda Trucks, Mercury: P/N XG-1-C, Spec. ESA-M1C75-BToyota: Trucks: Front drive shaft thrust bearings, synthetic oil and NLGI no. 1 chassis grease; Propeller shafts, Moly LM.
LS Steering Gear LubricantGM: P/N 1052182; Canada 992710 except Corvette manual steering gear housing, P/N 1052084.Saab: P/N 30 08 703.
MA MERCON® Automatic Transmission FluidFord, Ford Light Duty Trucks, Lincoln, Mazda Trucks, Mercury: Beginning immediately all automatic and manual transmission / transaxle applications that pre-viously required requiring MERCON® should can now be serviced using MERCON®V or MERCON Automatic Transmission Fluid or dual usage fluids labeledMERCON/MERCON-V. After July 1, 2007, MERCON Automatic Transmission Fluid will no longer be manufactured, therefore, availability of this fluid will only con-tinue for however long it takes to deplete what remains in inventory. The manufacture of MERCON® Automatic Transmission Fluid was discontinued on July 1,2007 therefore, availability will only continue until the remaining inventory is depleted. Manual transmissions: 2001-2002 Mustang w/TR3650, 1997-1998 dieseltrucks and 1999-2004 trucks w/ S5-47 ZF, use Synthetic MERCON® ATF, P/N XT-2-QSM, Spec. ESR-M2C163-A2.
MA5 MERCON® V Automatic Transmission FluidFord, Jaguar, Lincoln, Mazda Trucks, Mercury: P/N XT-5-QM. Do not use MERCON® SP or MERCON®LV in applications calling for this fluid.
MIL Military Specification
MLV MERCON® LV Automatic Transmission FluidFord: P/N XT-10-QLV. Automatic Transmission 2008 Focus, do not use MERCON®V or MERCON®SP in applications for this fluid 2008
MO Motor Oil, Any API Service Classification
103
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
MSP MERCON® SP Automatic Transmission FluidFord Light Duty Trucks, and Mercury: MERCON SP Automatic Transmission Fluid P/N XT-6-QSP. Do not use MERCON, MERCON® V or MERCON® LV SyntheticMERCON® in applications calling for this fluid
MT-1 Gear Oil, API Service MT-1
OL Outboard Gear OilUse manufacturer’s packaged oils or equivalent
PO Penetrating Oil
PS Power Steering FluidAcura: Power Steering, Acura P/N 08206-9002AAudi: Power steering or hydraulic system, P/N G002000.AM General: 2003 models use P/N 1052884, Spec. 9985010. 2004-08 models use P/N 89021184.Buick: 1997-03 models use P/N 1052884, Spec. 9985010. 2004-08 models use P/N 89021184.Cadillac: 1997-03 models use P/N 1052884, Spec. 9985010. 2004-08 models use P/N 89021184.Chevrolet: 1997-03 models except 1997-98 Corvette use P/N 1052884, Spec. 9985010; 1997-98 Corvette, use P/N 12345866, Spec. 9985835 2004-08 modelsuse P/N 89021184.Chevrolet Trucks: 1997-03 Models use P/N 1052884, Spec. 9985010. 2004-08 Models use P/N 89021184.Chrysler, Dodge and Jeep: 2004-05 Crossfire use Pentosin CHF 11S P/N 05127381AA; 2003-06 Sprinter use Mercedes-Benz P/N 000 989 88 03 or approvedproducts listed on MB Sheet 236.3. 2008 Commander use Mopar Hydraulic System Power Steering Fluid P/N 05142893AA meeting MS-10838. Other models,use P/N 04883077 meeting MS-5931 Note: Original factory fill MS-9933 which was used in some 1998-2001 models is superseded by AP4, Mopar ATF+4®(MS-9602). AP4, Mopar ATF+4® (MS-9602) should NOT be mixed or used as a topping off fluid on systems requiring MS-5931. Freightliner, Sterling: Condor models may use Fleetrite® PSF or Texaco TL-1833GMC: 1997-03 models use P/N 1052884, Spec. 9985010. 2004-08 models use P/N 89021184.Honda: PS Fluid Type S or V, P/N 08206-9002PEHyundai: Hyundai PSF-3 type fluidInternational: 1000-8000, 9600, 9700 series, Sheppard & Ross Power Steering Gears use Fleetrite® power steering fluid P/N Ch990625Isuzu: Hombre: See GM; Oasis: See HondaKia: Kia PSF-3 type fluidLand Rover: Texaco Cold Climate PAS fluid 14315, GM P/N 12345866 (32 oz.) or GM P/N 12345867 (16 oz.), Spec. 9985835. 2008 LR2 Pentosin CHF202.Mercedes-Benz: SL-Class (baumuster 230) 2003-04, S-Class (baumuster 220) 2000-04,CL-Class (baumuster 215) 2001-04, E-Class (baumuster 211) 2003-04,CLK-Class (baumuster 209) 2003-04 & C-Class (baumuster 203) 2001-04 use Pentosin CHF 11S, Mercedes-Benz P/N A 001 989 24 03 or approved productslisted on MB Sheet 345.0, All other models use Mercedes-Benz P/N 000 989 88 03 or approved products listed on MB Sheet 236.3MINI: use Pentosin CHF11S, MINI P/N 82 11 0 148 132Mitsubishi: Mitsubishi PS Fluid or Diamond SP, SPIIINissan: use Nissan PSF-IIOldsmobile: 1997-03 models use P/N 1052884, Spec. 9985010. 2004 models use P/N 89021184.Peugeot: GM P/N 1050017 (1 qt.) or equivalentPorsche: P/N 000.043.203.33, Pentosin CHF 11SSaab: 1997, P/N (45) 30 09 800 or GM P/N 1050017; 1998-06 P/N 30 32 380 Pentosin CHF 11SSaturn: Use Saturn P/N 21007583 or GM P/N 89021184.Subaru: P/N K0209A0080Toyota: Toyota PSF Type EH, P/N 008886-01Volkswagen: P/N G002000 or G002012 as notedVolvo: Volvo synthetic power steering fluid (Pentosin CHF 11S) P/N 1161529 or equivalent
SEO Special Engine OilAcura: 2007-08 Acura RDX only use oil that meets Acura standard HTO-06.Audi: Use only engine oil meeting Volkswagen Oil Standard 502 00 in the1997-2004 A4 1.8L turbo & 2003-04 Cabriolet 1.8L turbo. Engine oil meetingVolkswagen Oil Standard 502 00 must always be used in the engines fitted in model year 2005-07. Use always engine oil meeting Volkswagen Oil Standard 50501 with viscosity 5W-40 in the 2003-04 RS6BMW: S54 engine except Z4 M Coupe and Roadster, S62 engine up to Feb. 2000 and S85 engine use High Performance Synthetic Oil, SAE 5W-30, BMW partNo. 07 51 0 017 866 or equivalent or High Performance Mineral Oil, SAE 15W-40, BMW part No. 07 51 0 017 868 or equivalent. S62 engine from Feb 2000, useBMW High Performance Synthetic Oil 5W-30, part No. 07 51 0 017 866 or equivalent, or Castrol RS (Motorsport) Synthetic Oil SAE 10W-60, part No. 07 51 0009 420 or equivalent. Z4 M Coupe and Roadster, use Castrol RS (Motorsport) Synthetic Oil SAE 10W-60 part No. 07 51 0 009 420 or equivalent.Chrysler, Dodge and Jeep: 2004-07 Crossfire: Use only synthetic engine oils meeting MB 229.3 or MB 229.5.2003-06 Sprinter: Use engine oils meeting MB 228.3, MB 228.5, MB 229.3, MB 229.52007 Sprinter W/ Gasoline engine: use engine oil meeting MB 229.3, MB229.31, MB229.5 or 229.512007 Sprinter W/ Diesel Engine: engine oil meeting MB 228.51 MB 229.31 or MB 229.51Mercedes-Benz: 2007-08: Gasoline engines use only synthetic engine oil meeting MB Sheet 229.5 or MB Sheet 229.51. Diesel engines use only synthetic engineoil meeting MB Sheet 229.512005-06: Use only synthetic engine oil meeting MB Sheet 229.5 or MB Sheet 229.51; 1998-2004: Use only synthetic engine oil meeting MB Sheet 229.3, MBSheet 229.5 or MB Sheet 229.51Prior to 1997: Gasoline and Diesel engines use engine oil meeting MB Sheet 229.3 or MB Sheet 229.5.Porsche: In Cayenne models with V6 engine use engine oil meeting Volkswagen OilStandard 503 00 for extended oil change service change intervals.Volkswagen: 1998-2005 1.8L Turbo gasoline engine use only engine oil meeting Volkswagen Oil Standard VW 502 002004-2005 1.9 TDI–PD and 5.0L TDI-PD use only engine oil meeting Volkswagen Oil Standard VW 505 012004-05 All gasoline engines except 1.8L Turbo use engine oil meeting VW oil standard VW502 00, VW500 00 or VW 501 01 2006-07 Gasoline engines use engine oil meeting VW oil standard VW502 002006-07 5.0 TDI-PD engines use only engine oil meeting VW 504 00/507 00
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
104
SH Motor Oil, API Service SH
SJ Motor Oil, API Service SJ
SL Motor Oil, API Service SL
SLF Special Lubricant-FluidAcura: Automatic transmission: Honda ATF-Z1, P/N 08200-9001A. Rear differential 2005-08 RL, 2007-08 MDX and 2007-08 RDX use Honda ATF-Z1, P/N 08200-9001AAGCO, Massey Ferguson, White: LHM Mineral Brake Fluid (green), P/N 3405 389 M1 (HSMO)Allison: Castrol TranSynd Fluid, or TES 295 equivalent, applies to series: 1000; 2000; 2000MH; 2400; AT500; B3/4/500; HD4000; HT 700; MD 3000; MT 600Audi: Final drive w/ Multronic CVT use P/N G 052 190 (-A2); Automatic transmission 09A use P/N G 052 990 (A2); Automatic transmission 02E, use P/N G 052182 (A2); Automatic transmission 09L use P/N G 055 005 A2. 2004-05 09E transmission use P/N G 055 005 A2, 2006 09E transmission in combination with 8-cylinder engine use P/N G 055 005 A2, 2006 09E transmission in combination with 12-cylinder engine use P/N G 055 162 A6.BMW: Automatic transmission: 1998-2005 3-series w/ A5S 360R & A5S 390R (5L40-E/GM5): the transmission oil pan will be labeled with either Texaco ETL-7045 or DEXRON III please fill or top off with the proper fluid.; 1999-2000 5-series w/ A5S 360R (GM 5L40-E) use Texaco 7045-E or BMW P/N 83 22 0 026 922;2000-05 5-Series and X5 series w/ A5S 390R (GM5) use Texaco ETL-8072 B or BMW P/N 83 22 0 024 359; 2004-08 X3 Series w/ GM5: the transmission oil panwill be labeled with either Texaco ETL-7045 or DEXRON III please fill or top off with the proper fluid. 2002-08 3-series, 5-series, X5-series, 6-series or 7-serieswith 6-speed Automatic transmission GA6HP19Z, GA6HP26Z, GA6HP32Z, or S6S53BZ use Shell ATF M-1375.4 or P/N 83 22 0 142 516 Power steering,Hydraulic Brake booster, Self-leveling suspension system E32 since 9/91: Use only Pentosin CHF 11S, BMW P/N 82 11 1 468 041; Self-leveling suspension sys-tem E34 since 9/91: Use only Pentosin CHF 11S, BMW P/N 82 11 1 468 041Buick: Transfer case & rear differential, 2002-06 Rendezvous and 2005-06 Terraza use Versatrak fluid P/N 12378514; Transfer case 2004-07 Rainier, use P/N12378508Cadillac: Transfer case, use P/N 12378508Caterpillar: Caterpillar MTO (SAE 10W-30), P/N 105-3335Chevrolet: Transfer case & rear differential, 2002-05 Venture AWD and 2005-06 Uplander use Versatrak fluid P/N 12378514; 2005-07 Cobalt manual transmis-sion MU3 use GM P/N 21018899Chevrolet Light Trucks: Automatic Transfer Case Fluid, beginning with models produced starting late June, 1999, use only P/N 12378508, Spec. 9986186, whichis blue. Transfer case 2005-07 Equinox use Versatrak fluid P/N 12378514; 2001-06 ZF 6-Speed manual transmission: Synthetic Transmission Fluid, P/N12378515.Chrysler: Automatic transmission 2004-06 Crossfire use Shell 3403 ATF; 2001-05 Sebring Coupe with Mitsubishi automatic transmission use MitsubishiDiamond SP-III Automatic Transmission Fluid Transfer case MS140 2005-08 300: Mopar Transfer Case Lubricant LX P/N 05170055AADodge: 2001-05 Stratus Coupe with Mitsubishi automatic transmission use Mitsubishi Diamond SP-III Automatic Transmission Fluid. Transfer case MS1402005-08 Magnum and 2006-08 Charger use Mopar Transfer Case Lubricant LX P/N 05170055AADodge Light Trucks: 2003-06 Sprinter Automatic transmission use Shell 3403 ATF. Pickups with 6-speed automatic transmission AS68RC use Mopar AS68RCautomatic transmission fluid.Eagle: 1997-98 Talon with Mitsubishi automatic transmission use Mitsubishi Diamond SP-III Automatic Transmission Fluid.Fendt: Synthetic Mineral Oil, Pentosin CHF 11SFord, Mercury: Manual Transmission/Transaxles: 1997-2000 Contour/Mystique and 2000-08 Focus use XT-M5-QS, Spec WSS-M2C200-C. 1989-1997 Probe,2001-08 Escape/Mariner and 2006-08 Fusion/Milan use XY-75W90-QGL F32Z-19C547-MA, WSS-M2C203-A1. 2005-06 Ford GT and 2007-08 Shelby GT500 useXT-75W90-QGT. 2006-08 Fusion/Milan with FNR5 automatic transmission use FNR5 Automatic transmission Fluid, P/N XT-9-QMM5, spec Mazda MES MN 117C(ATF M-V). Supercharged engine use XL-4, spec ESE-M99C115-A in supercharger; Transfer cases use XL-12GMC: Automatic Transfer Case Fluid, beginning with models produced starting late June, 1999, use P/N 12378508, Spec. 9986186, which is blue. 2001-06 ZF 6-Speed manual transmission: Synthetic Transmission Fluid, P/N 12378515.Honda: Automatic transmission: Honda ATF-Z1, P/N 08200-9001Hyundai: 1996-2002 Genuine Hyundai SP-II Automatic Transmission Fluid; 2003-08 Genuine Hyundai SP-III Automatic Transmission Fluid.Infiniti: Active Suspension: Nissan Fluid A. Transmission: Nissan ATF Matic Fluid J, P/N 999MP-MTJ00PIsuzu: Transfer case 2003-07 Ascender use P/N 12378508, Spec. 9986186 Hombre: Automatic Transfer Case Hombre, beginning with models produced startinglate June, 1999 only uses P/N 12378508, Spec. 9986186, which is blue. Other models should also use this part number, although mixing of this blue fluid withthe red Autotrac fluid, P/N 12378396, Spec. 9986152, for top off is permitted; Automatic transmission Oasis: use Honda automatic transmission fluid: HondaATF-Z1, P/N 08200-9001; Automatic Transmission 2004 Axiom, Rodeo W/ 3.5L use Isuzu Genuine ATF Automatic Transmission Fluid.Jaguar: Power steering: Hydraulic System Mineral Oil (HSMO). 1998-2003.5 XJ series Automatic Transmission with 4.0L supercharged engine, use Shell ATF3403 M115; 2003.5 and onwards XJ series Automatic Transmission with 3.0L, 3.5L, 4.2L and 4.2L supercharged engine, use Shell M1375.4; 1998-2003 XKseries Automatic Transmission with 4.0L supercharged engine, use Shell ATF 3403 M115; 2003 and onwards XK series Automatic Transmission with 4.2L and4.2L supercharged engine, use Shell M1375.4; Automatic Transmission 2004-2006 XKR use Shell ATF 3403 M115; Automatic transmission 2002.5-06 S-Type,use Shell ATF M-1375.4; Automatic Transmission 2001.5-06 X-Type use automatic transmission fluid ATF IDEMITSU K17 (Jatco 3100 PL085) ManualTransmission 2002-05 X-Type use oil meeting specification WSS-M2C200-CJeep: Transfer Case NV146 Use Castrol BOT89 M1 fluid;1999-2004 Transfer case NV147 and NV247 use P/N 05016796AA meeting MS-10216 or Mobilfluid® 424;2005-08 Transfer case NV245 and NV247 use Mopar Transfercase Fluid P/N 05016796AB; 2004 Grand Cherokee W/ NAG1 Automatic transmission use Shell3403 Automatic transmission fluid;Kia: 2005-08 Kia Sorrento use only KIA Red-1 P/N UM040 CH020 in automatic transmission. All other models use Kia Automatic Transmission Fluid, SP-III.Landini: Legend Series use Spec. MF R 12640, SAE J71R1 (red). As noted use LHM Mineral Brake Fluid (green), P/N 3405 389 M1 (HSMO)Land Rover: Jatco Automatic Transmission 2002-05 Freelander, use Texaco N402; 2003-05 Range Rover with GM Auto trans uses Texaco ETL-7045E; ZF6HP26Automatic Transmission 2005-07 LR3 and 2006-07 Range Rover, Range Rover Sport use Shell ATF M-1375.4;Lexus: LX470 Active Height Control Suspension, Toyota Suspension Fluid, AHCLincoln: 2006 Zephyr and 2007-08 MKZ with FNR5 automatic transmission use FNR5 Automatic transmission Fluid, P/N XT-9-QMM5, spec Mazda MES MN117C (ATF M-V).Mazda: Automatic transmission 2003-08 Mazda6, 2004-08 Mazda3, 2006-08 Mazda5 use ATF M-V.Mercedes-Benz: 5-speed Automatic Transmission and Transfer Case use Mercedes-Benz P/N 001 989 21 03 10 (Shell ATF 3403-M 115). 7-speed Automatictransmission use Fuchs ATF 3353.In Level control use MB P/N 000 989 91 03 10Mitsubishi: Mitsubishi Diamond SP-III Automatic Transmission FluidNissan: Automatic transmission 2004-06 Altima, Maxima and 2004-07 Quest use NISSAN Matic K transmission fluid, P/N 99MP-MTK00P;Automatic transmission 2003-07 350Z, 2004 Pathfinder Armada, 2005-08 Armada, 2005-08 Xterra, 2005-08 Frontier, 2005-08 Pathfinder and 2004-08 Titan useNISSAN Matic J transmission fluid P/N 999MP-MTJ00P. Automatic Transmission 2008 Altima Hybrid use NISSAN Matic W transmission fluid
105
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
SLF Special Lubricant-Fluid (continued)Oldsmobile: Transfer case & rear differential, 2002-04 Silhouette use Versatrak fluid P/N 12378514; 1997-04 Bravada Automatic Transfer Case, beginning withmodels produced starting late June, 1999, use only P/N 12378508, Spec. 9986186, which is blue. Other models should also use this part number, although mix-ing of this blue fluid with the red Autotrac fluid, P/N 12378396, Spec. 9986152, for top off is permitted.Plymouth: With Mitsubishi automatic transmission use Mitsubishi Diamond SP-III Automatic Transmission Fluid.Pontiac: Transfer case & rear differential 2001-05 Aztek, 2003-05 Montana, 2005-06 Montana SV6 and Transfer Case 2006-07 Torrent use Versatrak fluid P/N12378514; Manual Transmission 2007 G6 use GM P/N 21018899Porsche: use Shell ATF 3403-M115, Porsche P/N 000 043 204 41Saab: Manual Transmission 1997-98 P/N 87 48 733; Manual transmission 1999-early 2002 P/N 400 108 247; Beginning with VIN 22023982 (9-3 Trollhattan),27007452 (9-3 Finland) & VIN 23027675 (9-5), all 2002-06 manual transmissions are factory filled with SAAB MTF 0063 synthetic, P/N 12799117. MTF 0063synthetic is NOT to be mixed with other manual gearbox fluid including Saab Synthetic Manual Transmission fluid that has been used since 1996. In addition,manual transmissions for 1994 and later models that have been rebuilt in Sweden will have MTF 0063 synthetic added. These transmissions will be identified bya label marked “MTF 0063” attached to these transmissions. 2005-08 9-3 with 6-speed Automatic Transmission use Saab P/N 93 165 147. Transfer Case 2005-08 9-7X use GM P/N 12378508Saturn: Trans: L-Series, Saturn P/N 21018899; S-Series, 1997-99 AF3 or Saturn P/N 21005966; 2000-02, AF3. Manual transmission 2004-07 ION use SaturnP/N 21018899; 2004-07 VUE 5-spd automatic transmission use only Honda ATF-Z1, Saturn P/N 22717466. 2002-08 VUE and 2005-08 Relay, Rear Drive Module& Power Transfer, use Versatrak fluid, P/N 12378514. NVG 900 Transfer case 2006-07 VUE use Versatrak fluid, P/N 12378514.Subaru: Subaru ATF, P/N K0140Y0700 (IDEMITSU ATF HP)Suzuki: Transfer case 2007-08 XL-7 use synthetic lubricant P/N 89021677.Toyota: MR2 with sequential MTX system, Sequential MT Fluid, P/N 08886-02206;Volkswagen: 09A 5-speed Automatic Transmission use P/N G 052 990 (A2), 02E Automatic transmission use G 052 182; 09D 6-speed Automatic Transmissionuse P/N G 052 025; 09L Automatic Transmission use G055 005 A.09M Automatic Transmission use P/N G 052 025Volvo: 2005-07 W/ Automatic On demand Clutch (Haldex unit) use Volvo P/N 11 61 641
SLG Special Lubricant-GreaseGM: P/N 12345879, spec 998530
SLS Special Lubricant-SprayAudi, Volkswagen: Silicone SprayCase IH, International (tractors): P/N 407 492 R1Ford, Lincoln, Mazda Trucks, Mercury: Multipurpose Grease Spray, P/N XG-4, Spec. ESB-M1C93-B
SLS Special Lubricant-SprayKenworth, Peterbilt: Multipurpose Spray Lubricant
SM Motor Oil, API Service SM (Current)
SP Speedometer Cable LubricantChrysler, Dodge and Jeep: P/N 04318078Ford, Lincoln, Mazda Trucks, Mercury: As noted us P/N XG-8, Spec.ESB-M1C111-BFreightliner, Kenworth, Peterbilt, Sterling: Lubriplate aero extreme low temperature grease or equivalent
TC Two-Cycle Oil for Air-Cooled EnginesIncludes oils with ash-producing additives. Use manufacturer’s packaged oils or equivalent
TC-W Two-Cycle Oil, NMMA (BIA) TC-WUse manufacturer’s packaged oils or equivalent
TC-WII Two-Cycle Oil, NMMA (BIA) TC-WIIUse manufacturer’s packaged oils or equivalent
TC-W3 Two-Cycle Oil, NMMA (BIA) TC-W3Use manufacturer’s packaged oils or equivalent
TIV JWS 3309 Automatic Transmission FluidAudi: P/N G 055 025Chevrolet: AC Delco T-IV, GM P/N 88900925Chevrolet Light Trucks: AC Delco T-IV, GM P/N 88900925Ford: P/N XT-8-QAW, Spec WSS-M2C924-A, 2005-07 Five HundredLincoln: P/N XT-8-QAW, Spec WSS-M2C924-A, 2006 Zephyr and 2007-08 MKX, MKZ. Lexus: ATF Type T-IV, Toyota P/N 08886-81015Mazda: W/ 6-spd Automatic use TIVMercury: P/N XT-8-QAW, Spec WSS-M2C924-A, 2005-07 MontegoMINI: 6-Spd Automatic Transmission GA6F21WA use MINI ATF JWS 3309, P/N 83 22 0 402 413.Pontiac: AC Delco T-IV, GM P/N 88900925Porsche: Esso JWS 3309, Porsche P/N 000 043 205 28Saab: Saab 3309 mineral based oil.Saturn: Saturn T-IV Fluid, Saturn P/N 88900925 (USA) 22689186 (CAN)Scion: ATF Type T-IV, Toyota P/N 08886-81015Suzuki: Suzuki ATF 3317 or Mobil ATF 3309Toyota: ATF Type T-IV, Toyota P/N 08886-81015Volvo: P/N 1161540-8Volkswagen: P/N G 055 025
2008-09 LUBRICATION RECOMMENDATIONS GUIDEKEY TO LUBRICANT SYMBOLS
106
TO-4 Transmission Oil, TO-4Caterpillar: Transmission Drive Train Oil (TDTO)
TO-A Manual Transmission FluidMack: SAE 50 synthetic oil passing Mack Spec. TO-A PLUS
TTA Type T Automatic Transmission FluidToyota: ATF Type T, P/N 08886-00405
TU Super Tractor Oil Universal (STOU)Deere: Spec. no. JDM J27AMassey Ferguson: Spec. M1139
VDS Motor Oil, VDSVolvo: Volvo Drain Specifications
VDS-2 Motor Oil, VDS-2Volvo: Volvo Drain Specifications 2
VDS-3 Motor Oil, VDS-3Volvo: Volvo Drain Specifications 3 (must complete extended field trial and meet API CI-4 plus)
VDS-4 Motor Oil, VDS-4Volvo: Volvo Drain Specifications 4 (must complete extended field trial and meet API CJ-4 plus)
VTA Variable Transmission Fluid AdditiveSaturn: DEX-CVT® Fluid, Saturn P/N 22697447
VTF Variable Transmission FluidAudi: CVT Transmission Fluid, P/N G 052 180 (-A2)Chrysler: use Mopar CVT+4Dodge: use Mopar CVT+4Ford, Mercury: P/N XT-7-QCFT, Spec. WSS-M2C933-A. 2005-07 Five Hundred, Montego and Freestyle with CFT30 transmission only.Honda: CVT use Genuine Honda CVT Fluid; Rear differential 1997-01 CR-V use Genuine Honda CVT Fluid; Rear differential 2002-08 CR-V and 2003-08 HondaElement use Honda Dual Pump FluidJeep: use Mopar CVT+4Mercury: P/N XT-7-QCFT, Spec. WSS-M2C933-A. (CFT30 Transmission only)MINI: W/ ECVT use Esso CVT EZL 799 Fluid, MINI P/N 83 22 0 136 376Mitsubishi: Use CVT fluid CVTF-J1Nissan: CVT use genuine Nissan CVT fluid NS-2Saturn: DEX-CVT® Fluid, Saturn P/N 22688912
WG Waterproof Grease
WS JWS 3324 Automatic Transmission FluidLexus, Toyota, Scion: Toyota Genuine ATF WS (JWS3324 or NWS9638)
ACURA1997-2000 ALL MODELS EXCEPTNSX; SLX—SEE ISUZU TROOPERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 20°F (–7°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill1: Liters QtIntegra:
1.8L ex. VTEC . . . . . . . . . . . . . . . . . 3.8 4.01.8L VTEC . . . . . . . . . . . . . . . . . . . . 4.0 4.2
2.2CL, 2.3CL, 2.5TL . . . . . . . . . . . . . . 4.3 4.53.0CL . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.63.2TL:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01999-2000 . . . . . . . . . . . . . . . . . . . . 4.4 4.6
3.5RL . . . . . . . . . . . . . . . . . . . . . . . 4.6 4.91 Capacity shown includes filter. After refill, check oil level.2 Preferred
TRANSAXLE, Automatic . . . . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters QtIntegra . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.92.2CL . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.52.3CL . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.62.5TL . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.93.0CL . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.13.2TL
1997-98 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.21999-2000 . . . . . . . . . . . . . . . . . . . . 2.7 2.9
3.5RL . . . . . . . . . . . . . . . . . . . . . . . 3.0 3.21 With engine at operating temperature, shift transmission through all
gears. Turn engine off and check fluid level within one minute
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtIntegra,
1997-98 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.61999-2000 . . . . . . . . . . . . . . . . . . . . 2.3 4.8
2.2CL, 2.3CL . . . . . . . . . . . . . . . . . . . . 1.9 4.2FINAL DRIVE1997-98 2.5L, 3.2TL;1997-2000 3.5RL . . . . . . . . . . . . . . .GL-4, GL-5Above 0°F (–18°C), . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (–18°C), . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters Pt2.5TL, w/MT & AT . . . . . . . . . . . . . . . . 1.0 2.23.2TL, 1997-98 . . . . . . . . . . . . . . . . . . 1.1 2.33.5RL . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . . .PS
2001-08 ALL MODELSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★3.2CL, 3.2TL, TL . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20MDX, RDX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20RSX Ex. TypeS . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-203.5RL, RL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20NSX:
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . .10W-301
Below 0°F (–18°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30All Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill2: Liters QtIntegra:
1.8L ex. VTEC . . . . . . . . . . . . . . . . . 3.8 4.01.8L VTEC . . . . . . . . . . . . . . . . . . . . 4.0 4.2
MDX: 2001-02 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02003-08 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
RDX . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.5RL, RL:
2001-04 . . . . . . . . . . . . . . . . . . . . . . 4.6 4.92005-08 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
3.2CL:2001-03 . . . . . . . . . . . . . . . . . . . . . . 4.4 4.6
3.2TL, TL:2001-03 . . . . . . . . . . . . . . . . . . . . . . 4.4 4.62004-08 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
RSX: All, ex. Type S . . . . . . . . . . . . . . . . . 4.2 4.4Type S . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
NSX . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3TSX . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.41 Preferred2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .SLF1
CAPACITY, Initial Refill2: Liters QtIntegra . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.9MDX:
2001-02 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22003-06 . . . . . . . . . . . . . . . . . . . . . . 2.7 2.92007-08 . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0
NSX . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1RSX:
2002-05 . . . . . . . . . . . . . . . . . . . . . . 2.7 2.92006 . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
RDX . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5TSX:
2004-05 . . . . . . . . . . . . . . . . . . . . . . 2.9 3.12006-08 . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0
CAPACITY, Initial Refill2: Liters Qt3.2CL . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.13.2TL, TL:
2001-03 . . . . . . . . . . . . . . . . . . . . . . 2.9 3.12004-06 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22007-08 . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
3.5RL, RL:2001-04 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22005-08 . . . . . . . . . . . . . . . . . . . . . . 2.7 2.9
1 Use Honda Automatic Transmission Fluid (ATF)-Z1. Using a non-Honda ATF can affect shift quality.
2 With engine at operating temperature, shift transmission through allgears. Turn engine off and check fluid level within one minute.
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtIntegra . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6NSX . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7RSX . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2TSX . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.23.2TL . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6TRANSFER CASE . . . . . . . . . . . .GL-4, GL-5MDX, RDX, 3.5RL, RL . . . . . . . . . . . . . . . . . . .90, 80W-90 CAPACITY, Refill: Liters PtMDX, RDX, 3.5RL, RL . . . . . . . . . . . . . 0.4 0.8FINAL DRIVE . . . . . . . . . . . . . . . GL-4, GL-53.5RL, RL:
Above 0°F (–18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (–18°C) . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters Pt3.5RL . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1REAR DIFFERENTIAL2005-08 RL, 2007-08 RDX . . . . . . . . . . . . . .SLFAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtMDX . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5RDX . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.33.5RL, RL . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . . .PS
AM GENERAL2003-08 HUMMER H2, H3CRANKCASE . . . . . . . . . . . . . . . . . . . .API★2003-04 H2 Above 0°F(-18°) . . . . . . . . . . . . . . . .10W-303
All temperatures . . . . . . . . . . . . . . . . . . .5W-301, 3
2005-08 H2 All temperatures . . . . . . . . . . . . . . . .5W-303
2006-08 H3 All temperatures . . . . . . . . . . . . . . .5W-301, 3
CAPACITY, Refill2: Liters QtH2, H3 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
1 Preferred2 Capacity shown includes filter. After refill, check oil level.3 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.7 4.9
1 With the engine at operating temperature, shift transmission throughall gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed. Do not overfill.
TRANSMISSION, ManualH3 . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-3
CAPACITY, Refill: Liters PtH3:
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.64WD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8
TRANSFER CASEH2, H3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Refill: Liters Pt2003-05 H2 . . . . . . . . . . . . . . . . . . . . . 1.4 2.92006 H2 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02007-08 H2 . . . . . . . . . . . . . . . . . . . . . 1.4 2.92006-08 H3 . . . . . . . . . . . . . . . . . . . . . 1.5 3.2DIFFERENTIAL . . . . . . . . . . . . . . . . . GL-5All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters Pt
Front: H22003-05 . . . . . . . . . . . . . . . . . . 0.8 1.72006-08 . . . . . . . . . . . . . . . . . . 1.7 3.6
H3 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Rear:
H2 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5H3 . . . . . . . . . . . . . . . . . . . . . . . 1.6-1.81 3.4-3.81
1 Fill no higher then 0.4” below plug hole
OTHER COMPONENTSBrake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . .HBClutch Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . .HBPower Steering Fluid . . . . . . . . . . . . . . . . . . . .PS
AUDI1997CRANKCASE1997 All . . . . . . . . . . . . . . . . . . . . . . . . . . . .API★
1997 1.8L Turbo:All temps . . . . . . . . . . . . . . . . . .0W-40, 5W-30, 5W-402
1997 All:With Energy Conserving Oil:
All temps . . . . . . . .5W-30, 5W-40, 10W-30, 10W-40Except Energy Conserving Oil:
All temps . . . . . . . . . . . . . . .5W-50, 10W-50, 10W-60Below 59°F (15°C) . . . . . . . . . . . . . . .5W-30, 5W-40,
10W-30, 10W-40Above 5°F (-15°C) . . . . . . . . . . . . .15W-40, 15W-50,
20W-40, 20W-50CAPACITY, Refill1: Liters Qt1.8L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72.8L Two Valve . . . . . . . . . . . . . . . . . . 5.0 5.32.8L 4 Valve . . . . . . . . . . . . . . . . . . . . . 5.2 5.53.7, 4.2L . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0
1 Capacity shown includes filter. To prevent overfilling at oil changes,add approx. 0.5L (0.5 qt) less than capacity shown, start engine, letrun until engine operating temperature is approx. 60°C (140°F),switch engine off, wait approx. 3 minutes, check dipstick, fill to fullmark as indicated on dipstick (may be more or less than 0.5L (0.5qt) depending on model).
2 Use only engine oil meeting Audi/Volkswagen Oil Standard 502.00in the 1997 A4 1.8L Turbo
TRANSMISSION, Automatic . . . . . . . . . .AECAPACITY, Initial Refill1,2: Liters QtCabriolet, w/01N . . . . . . . . . . . . . . . . . 5.4 5.73,4
A4 & A4 Quattro . . . . . . . . . . . . . . . . . 2.6 2.7A6, A6 Quattro . . . . . . . . . . . . . . . . . . 2.6 2.7A8 . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.7A8 Quattro . . . . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.2S6 . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.91 Capacity does not include final drive.2 Vehicle is not equipped with a transmission dipstick,
special tools and procedure required, see manufacturer’s serviceliterature.
3 Filled for life no change required under normal service.4 Total or dry fill shown.
TRANSAXLE, Manual1 . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtA4 . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8A4 Quattro . . . . . . . . . . . . . . . . . . . . . . 2.8 5.8A6 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7A6 Quattro . . . . . . . . . . . . . . . . . . . . . . 2.9 6.11 Includes final drive & transfer case
FINAL DRIVE, Auto. Trans . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90 CAPACITY, Refill: Liters PtCabriolet . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1A4, A6, A8 . . . . . . . . . . . . . . . . . . . . . . 0.8 1.6CENTER DIF, Auto. Trans . . . . . . . . . .GL-4 All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90 CAPACITY, Refill: Liters PtA4 Quattro . . . . . . . . . . . . . . . . . . . . . . 0.8 1.6A6 Quattro . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2A8 Quattro . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9REAR DIFFERENTIALA6 w/01A trans . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90All Others . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtA4 Quattro . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0A6 Quattro . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6A8 Quattro . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
1998-2007CRANKCASE1998-2004 A4 1.8L Turbo . . . . . . . . . . . . . . .SEO2003-04 Cabriolet 1.8L Turbo . . . . . . . . . . .SEO2003-04 RS6 4.2L . . . . . . . . . . . . . . . . . . . .SEO2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEOOthers 1998-2004 . . . . . . . . . . . . . . . . . . . .API★1998-2004 1.8L Turbo
All temps . . . . . . . . . . . . . . . . . .0W-40, 5W-30, 5W-402
2003-2004 RS6 4.2L: All temps . . . . . . . . . . . . . . .5W-401998-2004 Others:
Energy Conserving Oil:All temps . . . . . . . .5W-30, 5W-40, 10W-30, 10W-40
Except Energy Conserving Oil:All temperatures . . . . . . . . .5W-50, 10W-50, 10W-60Below 59°F (15°C) . . . . . . . . . . . . . . .5W-30, 5W-40,
10W-30, 10W-40Above 5°F (-15°C) . . . . . . . . . . . . .15W-40, 15W-50,
20W-40, 20W-502005-07
All temperatures . . . . . . . . . . . . .5W-40, 5W-30, 0W-40CAPACITY, Refill1: Liters QtA3:
2.0L: . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.83.2L: . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.8
A4, S4, RS4:1.8L Turbo:
1998-2001 . . . . . . . . . . . . . . . . . . 3.5 3.72002-03 . . . . . . . . . . . . . . . . . . . 3.9 4.12004-05 . . . . . . . . . . . . . . . . . . . . 4.1 4.3
2.0L:2005-07 . . . . . . . . . . . . . . . . . . . . 4.5 4.8
2.7L: . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.92.8L:
1998-99 . . . . . . . . . . . . . . . . . . . . 6.0 6.32000-03 . . . . . . . . . . . . . . . . . . . . 5.7 6.0
107
CARS & LIGHT TRUCKSACURA • AM GENERAL • AUDI
CAPACITY, Refill1: Liters Qt3.0L:
2005-06 . . . . . . . . . . . . . . . . . . . . 6.4 6.8All others . . . . . . . . . . . . . . . . . . . 5.4 5.7
3.2L:2005 . . . . . . . . . . . . . . . . . . . . . . . 8.1 8.62006-07 . . . . . . . . . . . . . . . . . . . . 6.5 6.7
4.2L:RS4 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5All Others . . . . . . . . . . . . . . . . . . . 9.0 9.5
A6, S6, Allroad:2.7L:
2000-03 . . . . . . . . . . . . . . . . . . . . 6.5 6.92004 . . . . . . . . . . . . . . . . . . . . . . . 6.9 7.32005 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
2.8L:1998-99 . . . . . . . . . . . . . . . . . . . . 6.0 6.32000-01 . . . . . . . . . . . . . . . . . . . . 5.7 6.0
3.0L . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.33.2L:
2005 . . . . . . . . . . . . . . . . . . . . . . . 8.1 8.62006 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
4.2L:A6 2005-2006 . . . . . . . . . . . . . . . 8.8 9.3A6 2007 . . . . . . . . . . . . . . . . . . . . 8.4 8.9Allroad 2005 . . . . . . . . . . . . . . . . . 8.0 8.5All others . . . . . . . . . . . . . . . . . . . 7.6 8.0
5.2L . . . . . . . . . . . . . . . . . . . . . . . 10.0 10.5A8, S8:
3.7L . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.94.2L:
1998-99 . . . . . . . . . . . . . . . . . . . . 7.5 8.02000-01 . . . . . . . . . . . . . . . . . . . . 7.2 7.62002-05 . . . . . . . . . . . . . . . . . . . . 7.5 7.9
5.2L . . . . . . . . . . . . . . . . . . . . . . . 10.0 10.56.0L:
2005-06 . . . . . . . . . . . . . . . . . . . . 12.5 13.2TT:
1.8L Turbo . . . . . . . . . . . . . . . . . . 4.5 4.83.2L . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.8
Cabriolet 2.8L . . . . . . . . . . . . . . . . . . . 5.0 5.3Q7:
3.6L . . . . . . . . . . . . . . . . . . . . . . . 6.9 7.34.2L . . . . . . . . . . . . . . . . . . . . . . . 9.2 9.7
1 Capacity shown includes filter; add 0.5 liters (0.5 qt) less than spec-ified amount, run engine to operating temperature. Recheck leveland correct as necessary.
2 Use only engine oil meeting Audi/Volkswagen Oil Standard 502.00in the 1998 - 2004 A4 1.8L Turbo and the 2003 – 2004 Cabrioletw/1.8L Turbo
TRANSMISSION, AutomaticMultitronic CVT . . . . . . . . . . . . . . . . . . . . . . .VTFTT, A3: 2003-07 09G . . . . . . . . . . . . . . . . . . .TIV
2003-07 02E . . . . . . . . . . . . . . . . . . . . . . . .SLFQ7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AE
09L, 09E . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Initial Refill1,2: Liters Qt1998-99:
Cabriolet . . . . . . . . . . . . . . . . . . . . . 5.4 5.7A4 . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.7A6, S4 . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.7A8 . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.8
2000-01: All . . . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.22002-04: A42002-03: S4
1.8L, 2.7L FWD 01V . . . . . . . . . . . 2.6-3.0 2.7-3.23.0L FWD CVT 01J . . . . . . . . . . . 4.5-5.0 4.8-5.33.0L AWD 01V . . . . . . . . . . . . . . . 2.6-3.0 2.7-3.2
2002-04 A6, S6, Allroad:2.7L, 4.2L
01L trans. . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.201V trans. . . . . . . . . . . . . . . . . . 2.6-3.5 2.7-3.7
3.0L 01J trans CVT . . . . . . . . . . . 4.5-5.0 4.8-5.32002-04 A8, S8:
01L trans. . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.201V trans. . . . . . . . . . . . . . . . . . . . 2.6-3.5 2.7-3.709E trans (Total Fill) . . . . . . . . . . . 10.4 11.0
2003-04 TT:02E trans. (Total Fill) . . . . . . . . . . . 7.0 7.409G trans. (Total Fill) . . . . . . . . . . 7.0 7.4
2005-06:Allroad
01V trans. . . . . . . . . . . . . . . . . . . . 2.6-3.0 2.7-3.201L trans. . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.4
TT09G trans. (Total Fill) . . . . . . . . . . 7.0 7.402E trans. . . . . . . . . . . . . . . . . . . . 6.0 6.3
A3, Quattro02E trans. . . . . . . . . . . . . . . . . . . . 6.0 6.3
A401V trans. . . . . . . . . . . . . . . . . . . . 2.6-3.0 2.7-3.202J trans. . . . . . . . . . . . . . . . . . . . 4.5-5.0 4.8-5.3
A602J trans. . . . . . . . . . . . . . . . . . . . 4.5-5.0 4.8-5.309L trans. . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.2
A809E trans. (Total Fill) . . . . . . . . . . . 10.4 11.0
S409L trans. . . . . . . . . . . . . . . . . . . . 3.5-4.0 3.7-4.2
2007:A3, Quattro
02E trans. . . . . . . . . . . . . . . . . . . . 7.2 7.6
CAPACITY, Initial Refill1,2: Liters QtA4, Quattro
01J trans. . . . . . . . . . . . . . . . . . . . 7.5 7.909L trans. . . . . . . . . . . . . . . . . . . . 9.8 10.4
A6, Quattro01J trans. . . . . . . . . . . . . . . . . . . . 7.5 7.909L w/V8 . . . . . . . . . . . . . . . . . . . 9.8 10.409L w/V6 . . . . . . . . . . . . . . . . . . . 9.0 9.5
A8 Quattro09E trans. . . . . . . . . . . . . . . . . . . . 10.4 11.009L trans. . . . . . . . . . . . . . . . . . . . 9.8 10.4
Q70AT trans. . . . . . . . . . . . . . . . . . . . 9.0 9.509D trans. . . . . . . . . . . . . . . . . . . 9.0 9.5
S4 . . . . . . . . . . . . . . . . . . . . . . . 9.8 10.4S6 . . . . . . . . . . . . . . . . . . . . . . . 10.4 11.0S8
09G trans. . . . . . . . . . . . . . . . . . . 7.0 7.409E trans. . . . . . . . . . . . . . . . . . . . 10.4 11.0
1 Vehicle is not equipped with a transmission dipstick,special tools and procedure required, see manufacturer’s serviceliterature.
2 Capacity does not include final drive or center differential
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill1: Liters PtA4, S4:
1998-99 . . . . . . . . . . . . . . . . . . . . . . 2.7 5.72000-01: 5-speed . . . . . . . . . . . . . . 2.7 5.7
6 speed . . . . . . . . . . . . . . . . . . . . 2.3 4.92000-04: 5-speed FWD . . . . . . . . . . 2.3 4.9
AWD . . . . . . . . . . . . . . . . . . . . . . 2.7 5.76 speed . . . . . . . . . . . . . . . . . . . . 2.5 5.3
A6:5 speed 01A . . . . . . . . . . . . . . . . . . 2.7 5.76 speed 01E (-EDU) . . . . . . . . . . . . . 2.5 5.3
S6, Allroad 01E (-EHS) . . . . . . . . . . . . 2.5 5.3S6, Allroad 01E (-EEY) . . . . . . . . . . . . . 3.6 7.6TT 02J . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2TT Quattro 02M . . . . . . . . . . . . . . . . . . 2.6 5.42005:
A4 w/01V trans. . . . . . . . . . . . . . . . . 3.0 6.3A4,A6 w/02X trans. . . . . . . . . . . . . . 3.0 6.3A4,S4 w/0A3 trans. . . . . . . . . . . . . . 3.2 6.7Allroad w/01E trans. . . . . . . . . . . . . 3.6 7.6TT, Quattro w/02M trans. . . . . . . . . . 2.6 5.5
2006-07: A3 w/02Q trans. . . . . . . . . . . . . . . . 2.3 4.9A4 w/01X trans. . . . . . . . . . . . . . . . . 3.0 6.3A4 w/02X trans. . . . . . . . . . . . . . . . . 3.5 7.4A4,S4 w/0A3 trans. . . . . . . . . . . . . . 3.2 6.7TT w/02Y trans. . . . . . . . . . . . . . . . . 2.6 5.4
1 Includes final drive & center differential
FINAL DRIVE, Auto. Trans.All Models
ex. CVT . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90 w/CVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF
CAPACITY, Refill: Liters PtA4, S4
1998-2001 . . . . . . . . . . . . . . . . . . . . 0.8 1.72002-07 w/01V . . . . . . . . . . . . . . . . 0.8 1.72002-07 w/01J . . . . . . . . . . . . . . . . 1.3 2.7
A6, S6, Allroad w/01L trans. . . . . . . . . . . . . . . . . . . 1.3 2.7w/01V trans. . . . . . . . . . . . . . . . . . . 0.8 1.7
A6 w/09L . . . . . . . . . . . . . . . . . . . . . . 1.3 2.72002-05 w/01J . . . . . . . . . . . . . . . . 1.3 2.7
A8, S8 w/01L trans. . . . . . . . . . . . . . . . . . . 1.3 2.7w/01V trans. . . . . . . . . . . . . . . . . . . 0.8 1.7w/09E trans. . . . . . . . . . . . . . . . . . . 1.2 2.5
TT . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Q7 front . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1CENTER DIF, Auto. TransTT with Haldex clutch . . . . . . . . . . . . . . . . . .GLSAll Others . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtA4, S4
1998-2007 . . . . . . . . . . . . . . . . . . . . 0.8 1.7A6, S6, Allroad
w/01L trans. . . . . . . . . . . . . . . . . . . 0.8 1.7w/01V trans. . . . . . . . . . . . . . . . . . . 0.8 1.7w/09L trans. . . . . . . . . . . . . . . . . . . 0.9 1.9
A8, S8 w/01L trans. . . . . . . . . . . . . . . . . . . 0.9 1.9w/01V trans. . . . . . . . . . . . . . . . . . . 0.8 1.7w/09E trans. . . . . . . . . . . . . . . . . . . 1.1 2.3w/09L trans. . . . . . . . . . . . . . . . . . . 0.9 1.9
TT (Haldex clutch) . . . . . . . . . . . . . . . . 0.2 0.4Q7 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7REAR DIFFERENTIALEx, 2002-07 A4, S4 . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-902002-07 A4, S4 . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtCabriolet . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1A4:
1998-2001 . . . . . . . . . . . . . . . . . . . . 1.8 3.82002-04 01R diff . . . . . . . . . . . . . . . 1.5 3.2
S4:1998-2001 . . . . . . . . . . . . . . . . . . . . 1.8 3.8
CAPACITY, Refill: Liters Pt2002-04:
01R diff . . . . . . . . . . . . . . . . . . . . 1.5 3.201V diff . . . . . . . . . . . . . . . . . . . . . 1.8 3.8w/ MT 01A-01R diff . . . . . . . . . . . 1.9 4.0w/ MT 01H . . . . . . . . . . . . . . . . . 1.5 3.2
A6, S6, Allroad:A/T . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0M/T . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
A8, S8 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2TT:
2001-02 . . . . . . . . . . . . . . . . . . . . . . 1.0 2.12003-04:
01R diff . . . . . . . . . . . . . . . . . . . . 1.5 3.201V diff . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
2005-07:A4,S4 w/AT 01R . . . . . . . . . . . . . . . 1.5 3.2
w/MT 01R . . . . . . . . . . . . . . . . . . 1.9 4.0w/MT 012/01W . . . . . . . . . . . . . . 2.3 4.9
A6 w/AT . . . . . . . . . . . . . . . . . . . . . 1.5 3.2w/MT . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0
A8 w/02R . . . . . . . . . . . . . . . . . . . . 1.5 3.2Allroad w/AT . . . . . . . . . . . . . . . . . . 1.9 4.0
w/MT . . . . . . . . . . . . . . . . . . . . . 1.5 3.2TT w/02D diff . . . . . . . . . . . . . . . . . 1.0 2.1
Q7 . . . . . . . . . . . . . . . . . . . . . . . 1.25 2.6OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake & Clutch Master Cylinder . . . . . . . . . . .HBDriveshaft, Quattro . . . . . . . . . . . . . . . . . . . . .LM
BMW1997-2000CRANKCASEStandard Performance 2 and 4 valve engines:
1997-98 . . . . . . . . . . . . . . . . . . . . .SJ, SL, SM1999-2000 . . . . . . . . . . . . . . . . . . .SJ, SL, SM1
High Performance S54,S62 & S85 engines . . . . . . . . . . . . . . . . .SEO2
Standard. Performance 2 & 4 Valve engines: . .1High Performance Mineral Oil:
Above 5°F (-15°C) . . . . . . . . . . . . . . . . . . . . .15W-40-5° to 68°F (-20° to 20°C) . . . . . . . . . . . . . . . .10W-405° to 50°F (-20° to 0°C) . . . . . . . . . . . . . . . . .10W-30Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .5W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
High Performance Synthetic Oil:All Temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-40
High Performance S54, S62 & S85 engines2
Special Engine Oil (SEO)All Temperatures:Except Castrol RS (Motorsport) . . . . . . . . . . . .5W-30Castrol RS (Motorsport) . . . . . . . . . . . . . . . . .10W-60
CAPACITY, Refill2: Liters QtM Coupe & Roadster . . . . . . . . . . . . . 6.5 7.0M3 . . . . . . . . . . . . . . . . . . . . . . . 6.5 7.0M5 . . . . . . . . . . . . . . . . . . . . . . . 6.5 7.0X5 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5Z3: 1.9L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.25
2.3L, 2.8L . . . . . . . . . . . . . . . . . . . . 6.5 7.0Z8 . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0318 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.25323, 325, 328 . . . . . . . . . . . . . . . . . . . 6.5 7.0525 . . . . . . . . . . . . . . . . . . . . . . . 5.75 6.0528 . . . . . . . . . . . . . . . . . . . . . . . 6.5 7.0530 . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0540 . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0740 . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0750 . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5840 . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0850: 5.4L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5
5.6L . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.01 To prevent potential engine damage, use only BMW High
Performance Synthetic Oil part No 07 51 0 017 866 or equivalent.Refer to engine compartment oil change decal.
2 Use ONLY BMW High Performance Synthetic Oil part No. 07 51 0017(5W-30) or part No. 07 51 0 009 420 (Castrol RS 10W 60 orCastrol TWS Motorsport 10W 60) to avoid engine damage.
TRANSMISSION, AutomaticGM THMRI (A4S310R) . . . . . . . . . . . . . . . . .AF3GM THMRI (A4S270R) . . . . . . . . . . . . . . . . .AF3GM 5L40-E (A5S360R) . . . . . . . . . . . . . . . . .SLFZF 5HP18 (A5S310Z):
530i, iT . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3M3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AE
ZF 5HP24 (A5S440Z) . . . . . . . . . . . . . . . . . . .AEZF 5HP30 (A5S560Z):
540 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF740, 750 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AE840 to 12/95 . . . . . . . . . . . . . . . . . . . . . . . .SLF840 from 12/95 . . . . . . . . . . . . . . . . . . . . . . .AE850 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AE
CAPACITY, Initial Refill1: Liters QtGM THMRI (A4S310R) . . . . . . . . . . . . 3.1 3.2GM THMRI (A4S270R) . . . . . . . . . . . . 3.0 3.1GM 5L40-E (A5S360R) . . . . . . . . . . . . 3.1 3.2ZF 5HP18 (A5S310Z) . . . . . . . . . . . . . 3.2 3.3ZF 5HP24 (A5S440Z) . . . . . . . . . . . . . 3.3 3.4
CARS & LIGHT TRUCKS
108
AUDI Continued • BMW
CAPACITY, Initial Refill1: Liters QtZF 5HP30 (A5S560Z) . . . . . . . . . . . . . 5.5 5.81 With engine at operating temperature, shift transmission through all
gears. Check level in PARK and add fluid as needed
TRANSMISSION, Manual1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31998-00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt318, 320, 325 . . . . . . . . . . . . . . . . . . . 1.1 2.4323, 328 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.6M3 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.6M Roadster and Coupe . . . . . . . . . . . . 1.2 2.6M5 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Z3: w/ 1.9L, 2.5L . . . . . . . . . . . . . . . . . 1.0 2.1
w/ 2.8L . . . . . . . . . . . . . . . . . . . . . . 1.2 2.6525i, 540i . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5840Ci, 850Ci, 850CSi . . . . . . . . . . . . . 2.3 4.8TRANSFER CASENV125 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3All others . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV125 . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1ATC500 . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt318i . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.4323, 328 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0325, 525i, 530i . . . . . . . . . . . . . . . . . . . 1.7 3.6528i . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5M3: 1997-00 . . . . . . . . . . . . . . . . . . . . 1.4 3.0M5 . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.4Z3 . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.0M Roadster & Coupe . . . . . . . . . . . . . 1.4 3.0540i w/ 220K Axle . . . . . . . . . . . . . . . . 1.2 2.5540i: 1997-2000 . . . . . . . . . . . . . . . . . 1.2 2.5740, 750 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5840, 850 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0X5: Front . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.2
Rear . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5
2001-08CRANKCASEStandard. Performance 2 & 4 Valve engines:
All . . . . . . . . . . . . . . . . . . . . . . .SJ, SL, SM1
High Performance S54, S62& S85 engines: . . . . . . . . . . . . . . . . . . .SEO2, 3
Standard. Performance 2 & 4 Valve engines: . .1High Performance Mineral Oil:
Above 5°F (-15°C) . . . . . . . . . . . . . . . . . . . . .15W-40-5° to 68°F (-20° to 20°C) . . . . . . . . . . . . . . . .10W-405° to 50°F (-20° to 0°C) . . . . . . . . . . . . . . . . .10W-30Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .5W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
High Performance Synthetic Oil:All Temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-40
High Performance S54 (except Z4 M coupe andRoadster), S62 & S85 engines: . . . . . . . . . . . . .2
All TemperaturesExcept Castrol RS (Motorsport) . . . . . . . . . . . .5W-30Castrol RS (Motorsport) . . . . . . . . . . . . . . . . .10W-60
Z4 M Coupe and Roadster: 3All Temperatures
Castrol RS (Motorsport) . . . . . . . . . . . . . . . . .10W-60CAPACITY, Refill4, 5: Liters Qt325
2001-05 RWD . . . . . . . . . . . . . . . . . 6.5 6.9AWD . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9
2006-07 . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9330: RWD . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
AWD . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9328 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9330 2001-05 RWD . . . . . . . . . . . . . . . 6.5 6.9
AWD . . . . . . . . . . . . . . . . . . . . . . 7.5 7.92006-07 . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
335 . . . . . . . . . . . . . . . . . . . . . . . 6.9 6.5525 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9528 . . . . . . . . . . . . . . . . . . . . . . . 6.9 6.5530 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9535 . . . . . . . . . . . . . . . . . . . . . . . 6.9 6.5540 . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9550 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9545 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5645 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5650 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9650 . . . . . . . . . . . . . . . . . . . . . . . 8.5 8.0740 . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9745 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5750 . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5760 . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0M3: 2001-06 . . . . . . . . . . . . . . . . . . . . 5.5 5.8
2008 . . . . . . . . . . . . . . . . . . . . . . . 8.8 9.3M5 2001-03 . . . . . . . . . . . . . . . . . . . . 6.5 6.9
2006-07 . . . . . . . . . . . . . . . . . . . . . . 9.3 9.8M6 . . . . . . . . . . . . . . . . . . . . . . . 9.3 9.8X3: 2004-06 . . . . . . . . . . . . . . . . . . . . 6.2 6.6
2007-08 . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9X5: 3.0L . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.6
4.4L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.54.6L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.54.8L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5
CAPACITY, Refill4, 5: Liters QtZ3: Except M Coupe/Roadster
2.5L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.33.0L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3M Coupe/Roadster . . . . . . . . . . . . . 5.0 5.3
Z4 Except M Coupe/Roadster . . . . . . 6.5 6.9M Coupe/Roadster . . . . . . . . . . . . . 5.5 5.8
Z8 . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.91 From 1999, when using the Extended (15000 mile) Oil Change
Interval, to prevent potential engine damage, use only BMW HighPerformance Synthetic Oil, SAE 5W-30, part No. 07 51 0 017 866or equivalent. Refer to engine compartment decal.
2 Use ONLY BMW High Performance Synthetic Oil part No. 07 51 0017(5W-30) or part No. 07 51 0 009 420 (Castrol RS 10W 60 orCastrol TWS Motorsport 10W 60) to avoid engine damage.
3 Use ONLY BMW High Performance Synthetic Oil part No. 07 51 0009 420 (Castrol RS 10W 60 or Castrol TWS Motorsport 10W 60) toavoid engine damage.
4 Capacity shown includes filter. After refill, check oil level. Additionaloil may be needed if oil cooler is drained
5 Some models use electronic oil level checking and do not have adipstick. Refer to the owner's manual for procedure.
TRANSMISSION, AutomaticGM5L40E . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFGM 5L50E . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFGM 6L80E . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6GM 6L45E . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6ZF 5HP-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AEZF 5HP-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AEZF 5HP-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AEZF 6HP-19 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFZF 6HP-26 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFZF 6HP-32 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters Qt325Ci: ZF5 HP19Z . . . . . . . . . . . . . . . 4.02 4.22
325i: 2001-05 ZF5 HP19 . . . . . . . . . . . 4.02 4.22
2006 ZF6 HP19Z . . . . . . . . . . . . . . . 4.02 4.22
325xi: 2001-05 5L40E . . . . . . . . . . . . . 4.02 4.22
2006 ZF6 HP19Z . . . . . . . . . . . . . . . 4.02 4.22
330Ci: ZF5 HP19 . . . . . . . . . . . . . . . . . 4.02 4.22
330i: 2001-05 ZF5 HP19 . . . . . . . . . . . 4.02 4.22
2006 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
330xi: 2001-05 ZF5 HP19 . . . . . . . . . . 4.02 4.22
2006 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
525i: 2001-03 ZF5 HP19 . . . . . . . . . . . 4.02 4.22
2004 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
2005-06 ZF6 HP26 . . . . . . . . . . . . . 4.02 4.22
2007 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
525xi: 2006 ZF6 HP26 . . . . . . . . . . . . 4.02 4.22
2007 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
530i: 2001-03 ZF5 HP19 . . . . . . . . . . . 4.02 4.22
2004-06 ZF6 HP26 . . . . . . . . . . . . . 4.02 4.22
2007 ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
530xiT: ZF6 HP19 . . . . . . . . . . . . . . . . 4.02 4.22
540i: ZF5 HP24 . . . . . . . . . . . . . . . . . 4.02 4.22
545i: ZF6 HP26 . . . . . . . . . . . . . . . . . . 4.02 4.22
550i: ZF6 HP26 . . . . . . . . . . . . . . . . . . 4.02 4.22
645Ci: ZF6 HP26 . . . . . . . . . . . . . . . . . 4.02 4.22
650Ci: ZF6 HP26 . . . . . . . . . . . . . . . . . 4.02 4.22
650i: ZF6 HP26 . . . . . . . . . . . . . . . . . . 4.02 4.22
740i & iL: ZF5 HP24 . . . . . . . . . . . . . . 4.02 4.22
745i & iL: ZF6 HP26 . . . . . . . . . . . . . . 4.02 4.22
750i: ZF6 HP26 . . . . . . . . . . . . . . . . . . 4.02 4.22
ZF6 HP32 . . . . . . . . . . . . . . . . . . . . 5.02 5.32
750iL: ZF5 HP24 . . . . . . . . . . . . . . . . . 4.02 4.22
ZF5 HP30 . . . . . . . . . . . . . . . . . . . . 5.52 5.82
750Li: ZF6 HP26 . . . . . . . . . . . . . . . . . 4.02 4.22
ZF6 HP32 . . . . . . . . . . . . . . . . . . . . 5.02 5.32
760i & Li: ZF6 HP26 . . . . . . . . . . . . . . 4.02 4.22
ZF6 HP32 . . . . . . . . . . . . . . . . . . . . 5.02 5.32
X3: 5L40E . . . . . . . . . . . . . . . . . . . . . . 4.02 4.22
6L45E . . . . . . . . . . . . . . . . . . . . . . . 6.22 6.52
X5:2001-03
W/ 3.0L: 5L40E . . . . . . . . . . . . . . 4.02 4.22
W/ 4.4 & 4.6L: ZF5 HP24 . . . . . . 4.02 4.22
2004-06 W/ 3.0L: 5L40E . . . . . . . . . 4.02 4.22
W/ 4.4 & 4.8L: ZF6 HP26 . . . . . . . 4.02 4.22
Z3: 5L40E . . . . . . . . . . . . . . . . . . . . . . 4.02 4.22
Z4: ZF5 HP19Z . . . . . . . . . . . . . . . . . . 4.02 4.221 With engine at operating temperature, shift transmission through all
gears. Remove fill plug, check level in PARK and add fluid as need-ed, install fill plug
2 Approximate, fill to level of fill plug.
TRANSMISSION, Manual2001-08 . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt325i, 325i Sportwagon, 325ci, 325xi
W/ 5-Spd S5D 250G . . . . . . . . . . . . 1.2 2.5W/ 6-Spd GS6S37BZ & GS6X37BZ 1.6 3.4
328i: W/ 6-Spd GS6S37BZ . . . . . . . . . 1.6 3.4330i, 330i Sportwagon 330ci 330xi:
w/ 5-Spd S5D 310Z & S5D 320Z . . . 1.2 2.5W/ 6-Spd GS6S37BZ & GS6X37BZ 1.6 3.4
525i, 525i Sportwagon, 525xi:w/ 5-Spd S5D 310Z & S5D 320Z . . . 1.2 2.5W/ 6-Spd GS6S17BZ . . . . . . . . . . . 1.3 2.7
GS6S37BZ . . . . . . . . . . . . . . . . . . 1.6 3.4GS6X37BZ . . . . . . . . . . . . . . . . . . 1.5 3.2
530i, 530xi:W/ 5-Spd S5D 310Z & S5D 320Z . . 1.2 2.5W/ 6-Spd GS6S37BZ . . . . . . . . . . . 1.6 3.4
GS6X37BZ . . . . . . . . . . . . . . . . . 1.5 3.2
CAPACITY, Refill: Liters Pt540i: W/ 6-Spd S6S 420G . . . . . . . . . . 1.7 3.6545i: W/6-Spd GS6S53BZ . . . . . . . . . 1.6 3.4550i: W/6-Spd GS6S53BZ . . . . . . . . . 1.5 3.2645ci: W/6-Spd GS6S53BZ . . . . . . . . 1.6 3.4650i: W/6-Spd GS6S53BZ . . . . . . . . . 1.5 3.2M3, M5: W/ 6-Spd S6S 420G . . . . . . . 1.7 3.6M5: W/ 7-Spd GS7S47BG . . . . . . . . . 2.5 5.3X3: W/ 6-Spd GS6X37BZ . . . . . . . . . . 1.5 3.2X5: W/ 5-Spd S5D 280Z . . . . . . . . . . . 1.0 2.1
W/ 6-Spd GS6S37BZ . . . . . . . . . . . 1.5 3.2Z3: / 5-Spd S5D 250G
W/ 2.5L . . . . . . . . . . . . . . . . . . . . 1.0 2.1W/ 3.0L . . . . . . . . . . . . . . . . . . . . 1.2 2.5M Roadster & Coupe . . . . . . . . . . 1.2 2.5
Z4: ex. 6-Spd GS6S37BZ . . . . . . . . . . 1.0 2.1W/ 6-Spd GS6S37BZ . . . . . . . . . . . 1.5 3.2
Z8: W 6-Spd GS6S420G . . . . . . . . . . . 1.9 4.01 Contact BMW for fluid type
TRANSFER CASENV 125 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3All others . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt325, 328, 330 & 335 xi & xiT W/ AWD:
NV 121 . . . . . . . . . . . . . . . . . . . . . . 0.16 0.3328, 330, 525, 528, 530 & 535 xi & xiT W/ X-Drive:
ATC 300 . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1X3 W/ X-Drive:
ATC 400 . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5X5 W/ X-Drive:
ATC 500 . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7X5 except X-Drive:
Up to 02/2005 NV 125 . . . . . . . . . . . 0.5 1.1From 02/2005 LWX 500 . . . . . . . . . . 0.5 1.1
DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt3 Series ex. M32001-05
325i & Ci . . . . . . . . . . . . . . . . . . . . . 1.0 2.1330i & Ci . . . . . . . . . . . . . . . . . . . . . 1.0 2.1325xi, 330xi:
Front Differential . . . . . . . . . . . . . 0.6 1.3Rear Differential . . . . . . . . . . . . . . 1.0 2.1
2006-08328i & Ci . . . . . . . . . . . . . . . . . . . . . 1.0 2.1330i & Ci . . . . . . . . . . . . . . . . . . . . . 1.0 2.1335i & 335i Coupe . . . . . . . . . . . . . . 1.2 2.332xi, 330xi:
Front Differential . . . . . . . . . . . . . 0.6 1.3Rear Differential . . . . . . . . . . . . . . 1.0 2.1
5 Series, ex. M5:2001-03:
525i, 530i . . . . . . . . . . . . . . . . . . . . . 1.0 2.1540i . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9
2004-08: 525i, 530i . . . . . . . . . . . . . . . . . . . . . 1.2 2.3545i, 550i . . . . . . . . . . . . . . . . . . . . . 1.4 2.9525xi, 530xi:
Front Differential . . . . . . . . . . . . . 0.6 1.3Rear Differential . . . . . . . . . . . . . . 1.2 2.3
6 Series, Ex. M6 . . . . . . . . . . . . . . . . . 1.4 2.97 Series:2001
740 & 750 i & iL . . . . . . . . . . . . . . . . 1.4 2.92002-07
745i & 750i & Li . . . . . . . . . . . . . . . . 1.4 2.9760i & Li . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
M3 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5M5 & M6 . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3X3: Front Differential . . . . . . . . . . . . . . 0.7 1.5
Rear Differential: 2.5L . . . . . . . . . . . 0.9 1.93.0L . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1
X5: Front Differential . . . . . . . . . . . . . . 0.6 1.3Rear Differential: . . . . . . . . . . . . . . . 1.2 2.5
3.0L, 4.4L, 4.6L . . . . . . . . . . . . . . 1.2 2.54.8L . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
Z3 ex. M Coupe & Roadster:2.5L . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.93.0L . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5M Coupe & Roadster . . . . . . . . . . . 1.2 2.5
Z4 ex. M Coupe & Roadster:2003-05 . . . . . . . . . . . . . . . . . . . . . . 1.0 2.12006-07:
2.5L . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.73.0L . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1
M Coupe & Roadster . . . . . . . . . . . 1.2 2.5Z8 . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9 OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3
w/Hydroboost . . . . . . . . . . . . . . . . . . . . . . .SLFw/Self-leveling suspension . . . . . . . . . . . .SLF
Brake & Clutch Master Cylinder . . . . . . . . . . .HBSMG Operating Unit . . . . . . . . . . . . . . . . . . .SLFThrottle Linkage; Door, Hood
& Trunk Latch . . . . . . . . . . . . . . . . . . . . . . .LMFront Wheel Bearings . . . . . . . . . . . . . . . . . . .GC
109
CARS & LIGHT TRUCKSBMW Continued
BUICK1997-2008 ALL EX. RENDEZVOUS,RAINIER, TERRAZA - SEECHEVROLET, GMC TRUCKS;ENCLAVE - SEE SATURNCRANKCASE . . . . . . . . . . . . . . . . . . .API★3.8L V6 Codes 1, K:1997-2003 Above 0°F (-18°C) . . . . . . . . . . . . . . .10W-302
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-302004-08 All temperatures . . . . . . . . . . . . . . . . . .5W-302,3
All others:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-302,3
2005-08 Below -20°F (-29°C) . . . . . . . . . . . . . .Synthetic 5W-30 or 0W-303
CAPACITY, Initial Refill1: Liters Qt2.4L, 3.1L . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.6L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.53.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.54.6L . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.55.3L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Capacity shown is with filter. Recheck oil level after filling.2 Preferred3 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
TRANSMISSION/TRANSAXLEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
CAPACITY, Initial Refill1: Liters Qt1997-99:
4T60 . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41997-99:
4T65E . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.42000-06, All . . . . . . . . . . . . . . . . . . . . . 7.0 7.42007-08:
Lucerne W/4.6 . . . . . . . . . . . . . . . . . 6.6 7.0Others . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.4
1 With the engine at operating temperature, shift transmissionthrough all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed. Do not overfill.
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake & Clutch Master Cylinder . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB
CADILLAC1997-2008 ALL EX. ESCALADE -SEE CHEVROLET, GMC TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★2008All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-305
2004-07All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
1997-2003Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-302
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30All temperatures, others . . . . . . . . . . . . . . . . . . . .5W-303
CAPACITY, Refill4: Liters Qt2.6L . . . . . . . . . . . . . . . . . . . . . . . 4.8 5.12.8L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.03.0L . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.13.2L . . . . . . . . . . . . . . . . . . . . . . . 4.8 5.13.6L, CTS, SRX, STS . . . . . . . . . . . . . . 5.7 6.04.4L, STS . . . . . . . . . . . . . . . . . . . . . . 8.55 9.05
4.4L, XLR . . . . . . . . . . . . . . . . . . . . . . 7.65 8.05
4.6L All Ex DTS . . . . . . . . . . . . . . . . . . 7.6 8.04.6L DTS . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.55.7L, 2004-05 . . . . . . . . . . . . . . . . . . . 6.25 6.55
6.0L . . . . . . . . . . . . . . . . . . . . . . . 5.75 6.051 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M
2 Preferred 3.0L, 3.2L, 4.6L (1997-99)3 Preferred 3.2L, 3.6L, 4.6L, 5.7L, 6.0L (2000-03)4 Capacity shown is with filter. Add oil as necessary5 Synthetic oil required GM Standard GM4718M.
TRANSMISSION/TRANSAXLE,Automatic
All . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4T80E . . . . . . . . . . . . . . . . . . . . . . . 7.02 7.42
5L50-E . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.32007 5L40-E . . . . . . . . . . . . . . . . . . . 7.0 7.46L50-E (2007) . . . . . . . . . . . . . . . . . . . 6.9 7.26L50-E (2008) . . . . . . . . . . . . . . . . . . . 6.3 6.76L80-E . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5RWD ex. Catera . . . . . . . . . . . . . . . . . 4.7 5.0Catera . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.01 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for at least 3 min-utes. Check fluid level and add fluid as needed.
2 Remove drain plug in case after pan removal. Replace scavengingscreens.
TRANSMISSION/TRANSAXLE,Manual
AY6 . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-3M35, Tremec (2003-06) . . . . . . . . . . . . . . . . .GLSTremec (2007) . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Initial Refill: Liters QtAY6 . . . . . . . . . . . . . . . . . . . . . . . 1.8 1.9M35 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.6Tremec 6-Speed . . . . . . . . . . . . . . . . . 3.5 3.7DIFFERENTIALCTS, SRX, STS . . . . . . . . . . . . . . . . . . . . .GL-52
CTS, XLR Limited-Slip . . . . . . . . . . . . GL-5★★2, 3
2008 STS, SRX Limited-Slip . 75W-90 GL-5★★2, 4
LimousinesLimited-Slip . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtRWD, limousine . . . . . . . . . . . . . . . . . . 2.6 5.5RWD, others:
ex. Catera, SRX, STS . . . . . . . . . . . 2.0 4.3Catera . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.62008 CTS
Front . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.4Rear
w/ Limited Slip . . . . . . . . . . . . . . . 1.2 2.5w/o Limited Slip . . . . . . . . . . . . . . 1.3 2.7
2003-07 CTS . . . . . . . . . . . . . . . . . . . . 1.3 2.72004-06 SRX, STS: Front . . . . . . . . . . 0.7 1.4
Rear . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.72007 SRX, STS: Front . . . . . . . . . . . . . 1.0 2.0
Rear W/drain plug removed . . . . . 1.0 2.0Rear W/cover removed . . . . . . . . 1.2 2.5
2008:Front:
SRX . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.4STS . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.0
Rear:SRX:
w/ Limited-Slip:w/ Cover removed . . . . . . . . 1.2 2.5w/ Drain plug removed . . . . . 1.0 2.0w/o Limited-Slip:w/ Cover removed . . . . . . . . 1.3 2.7w/ Drain plug removed . . . . . 1.1 2.3
STS:W/ Limited-Slip . . . . . . . . . . . 1.2 2.5W/o Limited-Slip . . . . . . . . . . 1.3 2.7
2004-07 XLR . . . . . . . . . . . . . . . . . . . . 1.6 3.32008 . . . . . . . . . . . . . . . . . . . . . . . 1.86 3.91 Controlled Slip (CS) IDENTIFICATION: tag under cover-attaching
bolt. 2 Synthetic gear oil is required.3 Add 4oz. of Limited-Slip lubricant additive, GM part No. 1052358 or
equivalent.4 Add 3.38oz of Limited-Slip additive GM part No 1052358 or equiv-
alent with rear cover removed with drain plug removed add 2.37oz.
TRANSFER CASEAll ex. 2007 . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt2003-06 SRX, STS BW4476 . . . . . . . . 0.5 1.02007 First Design . . . . . . . . . . . . . . . . 0.5 1.0
Second Design . . . . . . . . . . . . . . . . 0.8 1.72008 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7OTHER COMPONENTSPower Steering, Catera . . . . . . . . . . . . . . . . .AF3Power Steering, ex. Catera . . . . . . . . . . . . . . .PSBrake & Clutch Master Cylinder . . . . . . . . . . .HBFront Suspension & Steering Linkage,
Parking Brake Cable Guides . . . . . . . . . . . .LBFront Wheel Bearings, RWD
ex. Catera . . . . . . . . . . . . . . . . . . . . . . . . . .GC
CHEVROLET1997-2008 ALL FWD MODELS EX.LUMINA APV, VENTURE,UPLANDER - SEE CHEVROLET,GMC TRUCKS; GEO, NOVA,SPECTRUM, SPRINT - SEEGEO/CHEVROLET/ASUNACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★3.4L Code X, 1997-2002 3.8L:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-301
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below -20°F (-29°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Others:
Aveo All temperatures . . . . . . . . . . . . . . . . . .5W-303, 4
Cobalt 2.2L,2.4L L4 All temperatures . . . . . . .5W-303, 4
2.0L L4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-303,5
HHR All temperatures . . . . . . . . . . . . . . . . . . .5W-303, 4
2003 Monte Carlo Impala Malibu All temperatures . . . . . . . . . . . . . . . . . . . . .5W-301, 3
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . .10W-303
2004 Monte Carlo Impala Malibu All temperatures . . . . . . . . . . . . . . . . . . .5W-301, 3, 4
2008 Impala All temperatures . . . . . . . . . . . . . . . . . . . . .5W-303, 4
Below -20°F (-29°C) . . . . . . . . . . . . . . . . .10W-303, 4
2005-07 Monte Carlo Impala Malibu All temperatures . . . . . . . . . . . . . . . . . . . . .5W-303, 4
CAPACITY, Refill2: Liters Qt1.6L 2004-07 Aveo . . . . . . . . . . . . . . . 3.8 4.02.0L VIN P . . . . . . . . . . . . . . . . . . . . . . 5.75 6.05
2.2L VIN D . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02.2L VIN F . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02.2L ex. VIN F . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L VIN B . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L 2006-08 VIN B . . . . . . . . . . . . . . . 4.7 5.02.4L ex. VIN B . . . . . . . . . . . . . . . . . . . 4.7 5.03.1L VIN J . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.4L VIN X . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.5L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.03.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.05.3L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Preferred2 Capacities include filter change3 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.4 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.5 Synthetic oil required, GM Standard GM4718M
TRANSAXLE, Automatic1997-2008 except AISIN (81-40LE) . . . . . .AF6
AISIN (81-40LE) . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Initial Fill1: Liters Qt125 (3T40) . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04T40E, 4T45E2 . . . . . . . . . . . . . . . . . . 6.5 6.92008 Cobalt, HHR 4T45E . . . . . . . . . . 6.6 7.02006 Cobalt 4T40E . . . . . . . . . . . . . . . 6.6 7.0AISIN (81-40LE)Total fill . . . . . . . . . . . . 5.8 6.2440-T4, (4T60) . . . . . . . . . . . . . . . . . . . 5.7 6.04T65E 2006 Malibu only . . . . . . . . . . . 6.5 6.94T60E, 4T65E . . . . . . . . . . . . . . . . . . . 7.0 7.44T65E AWD . . . . . . . . . . . . . . . . . . . . . 7.4 7.81 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed. Do not overfill.
2 Has no fluid level indicator. Not owner serviceable.
TRANSAXLE, Manual1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2004-08 Aveo W/D 16 . . . . . . . . . .75W-90 GL-3W/YM4 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-852000-05 ex. 2004-06 Aveo
& 2005-06 MU3 . . . . . . . . . . . . . . . . . . . . .GLS2005-07 MU3 . . . . . . . . . . . . . . . . . . . . . . . .SLF2007 Allex MU3 . . . . . . . . . . . . . . . . . . . . . .GLS2008 Cobalt, HHR . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Refill: Liters PtGETRAG 5 speed . . . . . . . . . . . . . . . . 1.7 3.62007 GETRAG . . . . . . . . . . . . . . . . . . 1.6 3.32008 Cobalt, HHR . . . . . . . . . . . . . . . . 1.6 3.3D16 Aveo . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8Y4M Aveo . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4MU3 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.01997-99 All others . . . . . . . . . . . . . . . . 1.9 4.0OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBFront Suspension & Steering Linkage,
Parking Brake Cable Guides, Shift Linkage, Clutch Cross Shaft . . . . . . . .LB
Front Wheel Bearings, Caprice . . . . . . . . . . .GC
1997-2008 RWD MODELSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Corvette engines:Below -20°F (-29°C) . . . . . . . . . . . . . . . . . . . . . . .0W-301
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301, 2
3.8L Code K:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-302
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . . . .5W-305.7L Camaro:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters Qt3.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.55.7L Code G, S, Corvette . . . . . . . . . . 6.1 6.45.7L Code G, Camaro . . . . . . . . . . . . . 5.2 5.56.0L Corvette ex. Z51 . . . . . . . . . . . . . 5.2 5.56.0L Corvette Z51 . . . . . . . . . . . . . . . . 5.7 6.06.2L w/oil cooler . . . . . . . . . . . . . . . . . 5.7 6.06.2L w/o oil cooler . . . . . . . . . . . . . . . . 5.2 5.57.0L Corvette . . . . . . . . . . . . . . . . . . . 7.6 8.01 Engine oil must also meet GM spec 4718M. API★★ oil not meeting
GM Spec 4718M may be used for top off only.2 Preferred.3 Capacity shown is with filter. Recheck oil level after filling.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
CARS & LIGHT TRUCKS
110
BUICK • CADILLAC • CHEVROLET
CAPACITY, Initial Refill1: Liters Qt4L60, 4L60-E . . . . . . . . . . . . . . . . . . . 4.7 5.06L80-E . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.51 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed. Do not overfill.
TRANSMISSION, ManualCamaro all; Corvette, 1997-06 . . . . . . . . . . .GLSCorvette, 2007-08 . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtCorvette:
1997-2003 . . . . . . . . . . . . . . . . . . . . 3.9 8.22004-05 . . . . . . . . . . . . . . . . . . . . . . 3.8 8.02006 . . . . . . . . . . . . . . . . . . . . . . . 3.9 8.22007-08: Base . . . . . . . . . . . . . . . . . 3.5 7.3
W/Z51 . . . . . . . . . . . . . . . . . . . . . 4.0 8.4Z06 . . . . . . . . . . . . . . . . . . . . . . . 4.3 9.0
Camaro: 5-speed . . . . . . . . . . . . . . . . 3.2 6.86-speed . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0
DIFFERENTIALStandard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★CAPACITY, Refill: Liters PtCamaro . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.61997-07:
Corvette ex. 2006-07, Z06 . . . . . . . . 1.6 3.4Corvette 2006-07, Z06 . . . . . . . . . . 2.5 5.3
2008:Corvette: ex. Z06 . . . . . . . . . . . . . . . 1.86 3.9
Z06 . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3LIMITED-SLIP IDENTIFICATION:Tag under rear cover-attaching boltOTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBFront Suspension & Steering Linkage,
Parking Brake Cable Guides, Shift Linkage, Clutch Cross Shaft . . . . . . . .LB
Front Wheel Bearings, Caprice . . . . . . . . . . .GC
CHEVROLET & GMCTRUCKS
1997-2008 BUICK RENDEZVOUS,TERRAZA; CHEVROLET EQUINOX,VENTURE, UPLANDER, LUMINAAPV; OLDSMOBILE SILHOUETTE; PONTIAC AZTEK, MONTANA,MONTANA SV6, TRANS SPORT,TORRENTCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All EnginesAbove 0°F (-18°C) (1997-2008) . . . . . . . . . . . . . .10W-304
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt3.4L: 1997-03 All . . . . . . . . . . . . . . . . . 4.3 4.5
2004 Silhouette, Montana . . . . . . . . 3.8 4.02005 Montana . . . . . . . . . . . . . . . . . 4.3 4.52004-05 Aztek, Venture, Rendezvous 4.3 4.52005-08 Equinox . . . . . . . . . . . . . . . 3.8 4.02006 Torrent . . . . . . . . . . . . . . . . . . 4.3 4.52007-08 Torrent . . . . . . . . . . . . . . . . 3.8 4.0
3.5L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.03.6L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.53.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
2 Preferred.3 Capacity shown is with filter. After refill, check oil level.4 Not recommended for Uplander & Torrent.
TRANSAXLE, AutomaticAll Ex. AF33-5 . . . . . . . . . . . . . . . . . . . . . . . AF6AF33-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Initial Refill1: Liters Qt3T40 (3-speed) . . . . . . . . . . . . . . . . . . 3.8 4.01997-2008 ex. AWD . . . . . . . . . . . . . . 7.0 7.42001-06 AWD . . . . . . . . . . . . . . . . . . . 7.4 7.8AF33-5 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.36T70 2008 Equinox, Torrent (6-speed) 6.0 6.31 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed. Do not overfill.
TRANSFER CASE . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAWD
ex. Equinox, Torrent . . . . . . . . . . . . . 0.3 0.6Terraza, Uplander . . . . . . . . . . . . . . 0.3 0.6Equinox, Torrent . . . . . . . . . . . . . . . 0.5 1.0
DIFFERENTIAL . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAWD
ex. Terraza, UplanderEquinox, Torrent . . . . . . . . . . . . . . 0.3 0.3
Terraza, Uplander . . . . . . . . . . . . . . 1.9 4.0
CAPACITY, Refill: Liters PtEquinox, Torrent
2005-06 . . . . . . . . . . . . . . . . . . . . 0.7 1.52007-08 . . . . . . . . . . . . . . . . . . . . 0.5 1.0
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
1997-2000 ISUZU HOMBRE;1997-2001 JIMMY;1997-2004 BRAVADA, SONOMA,S10, S-SERIES;1997-2005 ASTRO, SAFARI CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301, 2
CAPACITY, Refill: Liters QtAll Models . . . . . . . . . . . . . . . . . . . . . 4.3 4.5Includes filter. After refill, check oil level.1 Preferred2 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4L60/65-E . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSMISSION, ManualNV1500, 4-cyl.. . . . . . . . . . . . . . . . . . . . . . . .GLSNV3500, V6. . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Initial Fill: Liters PtNV1500 . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7NV3500 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2TRANSFER CASEBW4401, 4470, 4472 . . . . . . . . . . . . . . . . . .GLSNV136, 236, 246 . . . . . . . . . . . . . . . . . . . . . .SLFNV231, 233 . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtBW4401, 4470 . . . . . . . . . . . . . . . . . . 1.2 2.5BW4472 Astro, Safari . . . . . . . . . . . . . 1.4 3.0BW4472 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5NV136, 236, 246 . . . . . . . . . . . . . . . . . 1.9 4.0NV231, 233 . . . . . . . . . . . . . . . . . . . . . 1.0 2.1DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90Rear:
Conventional:1997-2000 All . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-902001-05 . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Astro, SafariAll temperatures . . . . . . . . . . .Synthetic 75W-90
Jimmy, Sonoma, S10All temperatures . . . . . . . . . . . . . . . . . . .80W-90
Limited Slip & Locking:1997-2000 All . . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-902001-05 . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Astro, SafariAll temperatures . . . . . . . . . . .Synthetic 75W-90
Jimmy, Sonoma, S10All temperatures . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.6Rear:
Astro, Safari & 7.625” axle . . . . . . . . 1.7 3.68.6 “ axle . . . . . . . . . . . . . . . . . . . . . 1.9 4.0
1 Do not add limited slip additive.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
1997-2000 C, G, K, P GASOLINE &DIESEL MODELS; 1998-2000 CADILLAC ESCALADECRANKCASE
All Gasoline Models . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . .5W-301, 5
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30All Diesels . . . . . . . .CG-41,2 CH-41,2,SH/CF-4
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . .15W-402
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . .30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . .10W-30
CAPACITY, Refill3: Liters QtAll Gasoline Models
4.3L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.54.8L, 5.3L, 6.0L . . . . . . . . . . . . . . . . 5.7 6.05.0L, 5.7L . . . . . . . . . . . . . . . . . . . . 4.84 5.04
7.4L, 1997 . . . . . . . . . . . . . . . . . . . . 6.64 7.04
7.4L, 1998-2000, short filter . . . . . . 6.3 6.6
CAPACITY, Refill3: Liters Qt7.4L, 1998-2000, long filter . . . . . . . 6.6 7.0
All Diesel Models:6.5L
1997 . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.01998-2000 . . . . . . . . . . . . . . . . . . 7.6 8.0
1 Preferred.2 1998-2000, CG-4 or CH-4 required; 1997 preferred. 3 Includes filter. After refill level must be checked.4 Add 1 qt. (0.9L) additional for: CNG; large crankcase option;
3500HD installation5 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4L60E . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04L80E . . . . . . . . . . . . . . . . . . . . . . . 7.3 7.71 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSMISSION, ManualNV3500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSNV4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV3500 . . . . . . . . . . . . . . . . . . . . . . . 2.01 4.41
NV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.01 Approximate, fill to level of fill plug
TRANSFER CASE1
NV236, 246, Automatic . . . . . . . . . . . . . . . . .SLFNV149-NP one-speed automatic . . . . . . . . .GLSNV263-NP1 selectable . . . . . . . . . . . . . . . . .GLSOthers, Manual . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV243 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4BW4401 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2BW4470 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2NV236, 246, 261 . . . . . . . . . . . . . . . . . 1.9 4.01 To identify, see tag on case
DIFFERENTIAL Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-51,2
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90Rear: C/K ex. 3500 HD with Dana 11” Axle
Conventional: 1997-98 . . . . . . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-901999:
GMT 400 C, K 10-30 . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . .80W-90GMT 800 Codes C, K 15-25 . . . . . . .GLS1
All temperatures . . . . . . . . . . .Synthetic 75W-902000 . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS1
All temperatures . . . . . . . . . . . . .Synthetic 75W-90Limited Slip:
1997-98 . . . . . . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-901999-2000:
GMT 400 C, K 10-30 . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . .80W-90GMT 800 C, K 15-25 . . . . . . . . . . . . . .GLS
All temperatures . . . . . . . . . . .Synthetic 75W-90Locking: 4
1997-98 . . . . . . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-901999-2000
GMT 400 C, K 10-30 . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . .80W-90GMT 800 C, K 15-25 . . . . . . . . . . . . . .GLS
All temperatures . . . . . . . . . . .Synthetic 75W-903500 HD Dana
80 Axle . . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . . .Synthetic 75W-140
G & P Series: Conventional . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90Limited Slip & Locking . . . . . . . . . . . . .GL-53
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtFront:
Escalade, K1, K2 . . . . . . . . . . . . . . . 1.7 3.6K3 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4
Rear:Escalade, C, K Series, 3500 HD:
8.5”, 8.6” . . . . . . . . . . . . . . . . . . . 2.0 4.29.5” . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.510.5” . . . . . . . . . . . . . . . . . . . . . . 3.0 6.311” . . . . . . . . . . . . . . . . . . . . . . . 4.0 8.5
G Series: 8.5” . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.28.6” . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.99.5”
1997 . . . . . . . . . . . . . . . . . . . . . 2.6 5.51998-2000 . . . . . . . . . . . . . . . . 2.8 5.9
10.5” 1997 . . . . . . . . . . . . . . . . . . . . . 3.4 7.21998-2000 . . . . . . . . . . . . . . . . 3.0 6.3
111
CARS & LIGHT TRUCKSCHEVROLET Continued • CHEVROLET& GMC TRUCKS
CAPACITY, Refill: Liters PtP Series:
10.5” . . . . . . . . . . . . . . . . . . . . . . 3.4 7.211” . . . . . . . . . . . . . . . . . . . . . . . 4.0 8.5
1 1997-99 models Do not use synthetic lubricant in axles using RTVsealant. Synthetic lubricant will chemically attack RTV sealant.American Axle has only approved the use of Synthetic Lubricant75W-90 GM part no. 12378261, as follows:a. All 8.6" rear axles are compatible.b. All 9.5" rear axles built before mid-February 1998 (RTV sealantused to seal cover pan) are not compatiblec. All 9.5" rear axles built after mid-February 1998 (equipped W/cover pan & gasket) are compatible.d. All 10.5" rear axles built prior to March 3, 1999 are compatible ifaxle shaft hub RTV sealer is replaced W/ GM gasket part no.327739.
2 In cold climates when excessive shift effort to shift to 4WD isencountered, use GM Part No. 12345836.
3 Do not add limited slip additive
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2001-08 ENVOY;2002-08 TRAIL BLAZER;2003-08 ISUZU ASCENDER;2004-07 RAINIERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C)(2001-2004) . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2,4
CAPACITY, Refill3: Liters Qt.4.2L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.05.3L, 6.0L . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Preferred.2 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.3 Includes filter. After refill, check oil level.4 2006-08 Trail Blazer w/6.0L requires GM4718M Synthetic or equiv-
alent
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt.4-speed . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in Park with parking brakeapplied and add fluid as needed.
TRANSFER CASE . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Refill: Liters Pt.NV120, 126, 226 . . . . . . . . . . . . . . . . . 1.8 3.81 Auto-Trac II Fluid.
DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-902006-08 Trailblazer SS w/6.0L . . . . . .75W-90 GL-5★★1
CAPACITY, Refill: Liters Pt.Front:
2001-08 . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Rear:
2001-03 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02004-08:
4.2L . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.65.3L . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.36.0L . . . . . . . . . . . . . . . . . . . . . . . 2.61 5.51
1 Add GM Part No. 1052358 or equivalent 2006 4.0oz, 2007-08 5.5oz.
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBFront Axle Propshaft Spline,
or One-Piece Propshaft Spline(2WD w/auto. Trans.) . . . . . . . . . . . . . . . . .SLG
Suspension & Steering Linkage, Rear Driveline Center Splines, Parking Brake Cable Guides, Shift Linkage. . . . . . . . . . . . .LB
Universal CV Joint, 4WD . . . . . . . . . . . . . . . . .LBFront Wheel Bearings . . . . . . . . . . . . . . . . . . .GC
2004-08 CHEVROLET COLORADO& GMC CANYON;2006 ISUZU I-280, I-3502007-08 ISUZU I-290, I-370CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
Above 0°F (-18°C)(2004) . . . . . . . . . . . . . . . . . . . .10W-30CAPACITY, Refill3: Liters Qt2.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02.9L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.7L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.03.5L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Preferred2 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M
3 Capacity shown is with filter change. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4-speed . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSMISSION, Manual . . . . .75W-90 GL-3CAPACITY, Refill: Liters PtAISIN AR5 (RWD) . . . . . . . . . . . . . . . . 2.2 4.6AISIN AR5 (4WD) . . . . . . . . . . . . . . . . 2.3 4.9TRANSFER CASE . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtT150 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7DIFFERENTIALFront & Rear Axle: . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtFront Axle . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Rear Axle . . . . . . . . . . . . . . . . . . . . . . 1.6-1.8 3.4-3.8OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2003-08 C, G, K, GASOLINE,DIESEL & 3500 HD MODELS; 2002-08 CADILLAC ESCALADE;2003-06 SSR; 2003-08 H SERIESVANSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All Gasoline Models:
All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301, 2
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All Diesel Models:
2001-02 . . . . . . . . . . . . . . . .CI-4, CH-4, CG-42003-06 . . . . . . . . . . . . . . . . . . . . . .CI-4, CH-42007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .CJ-4
6.5L: Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .15W-401
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . .30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . .10W-30
6.6L: Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .15W-401
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .5W-40
CAPACITY, Refill3: Liters QtAll Gasoline Models
4.3L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.54.8L, 5.3L, 6.0L . . . . . . . . . . . . . . . . 5.7 6.05.0L, 5.7L . . . . . . . . . . . . . . . . . . . . 4.8 5.16.2L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.08.1L, 3500 HD . . . . . . . . . . . . . . . . . 6.3 6.78.1L, Others . . . . . . . . . . . . . . . . . . . 6.1 6.4
All Diesel Models6.5L . . . . . . . . . . . . . . . . . . . . . . . 7.6 8.06.6L . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.0
1 Preferred2 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.3 Includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4L60/65-E/70-E . . . . . . . . . . . . . . . . . 4.7 5.04L80/85-E . . . . . . . . . . . . . . . . . . . . . . 7.3 7.76L80-E . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.06L90-E . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.3Allison 1000, 2000 . . . . . . . . . . . . . . . . 7.0 7.41 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSMISSION, ManualNV3500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSNV4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSZF 6-speed transmission . . . . . . . . . . . . . . .SLFTremec 6-speed . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV3500, 2001-03 . . . . . . . . . . . . . . . . 2.0 4.2NV3500:
2004-06 . . . . . . . . . . . . . . . . . . . . 2.3 4.92007
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.94WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
NV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.7 7.8ZF 6 . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.7Tremec 6-speed . . . . . . . . . . . . . . . . . 3.5 7.4TRANSFER CASEH Series Vans:
2003-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
K Series: 2001-03
Manual Transfer Cases . . . . . . . . . . . . .GLSAutomatic Transfer Cases . . . . . . . . . . . . .SLF
2004-06:NV236, NV296 Automatic . . . . . . . . . . .SLF
NV149 Series . . . . . . . . . . . . . . . . . . . . . . .GLSNV261-NP2 . . . . . . . . . . . . . . . . . . . . . . . .GLSNV263-NP1 selectable . . . . . . . . . . . . . . .GLSNP8 only . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFBorg Warner . . . . . . . . . . . . . . . . . . . . . . . .GLS
2007:All ex. New Silverado:Manual Transfer Cases . . . . . . . . . . . . . . .GLSAutomatic Transfer Cases . . . . . . . . . . . . .SLFNew Silverado:MP 1222/1225/1226-NQG, MP
1625/1626-NQF, MP 3023/3024-NQH . . .AF6CAPACITY, Refill: Liters PtK Series: NV236, 246, NP8 . . . . . . . . . 1.9 4.0
NV-149-NP 2001-02 . . . . . . . . . . . . 2.3 4.9NV-149-NP3 2002-07 . . . . . . . . . . . 2.1 4.4NV-261-NP2 . . . . . . . . . . . . . . . . . . 1.9 4.0NV-263-NP1 . . . . . . . . . . . . . . . . . . 1.9 4.0MP 1222/1225/1226-NQG,
MP 1625/1626-NQF, MP 3023/3024-NQH . . . . . . . . . . 1.5 3.2
Borg Warner . . . . . . . . . . . . . . . . . . . . 1.4 3.02003-08 H Series Vans . . . . . . . . . . . . 1.4 3.0DIFFERENTIALFront Axle:
2001-02:8.25” S4WD Axle . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-908.25” F4WD Axle, 9.25” . . . . . . . . . . . .GL-5
2003-05K-Series . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-902006-08 K-Series and
Escalade AWD . . . . . . . . . . . . . .75W-90 GL-51500:All temperatures . . . . . . . . . . . . . . .Synthetic 80W-901500HD, 2500, 2500HD, 3500:All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
H Series . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .Synthetic 75W-90
Rear Axle:Excalade, C, K Series:
ex. 3500 HD Dana 80 Axle2001 All . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . .Synthetic 75W-902002-08
ex. steerable . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . .Synthetic 75W-90
2002-06steerable . . . . . . . . . . . . . . . . . . . . .GLS1
All temperatures . . . . . . . . . . .Synthetic 75W-903500 HD Dana
80 Axle . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . .Synthetic 75W-90
SSR . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .Synthetic 75W-90
G, H Series: 8.6” . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . .Synthetic 75W-909.5”, 10.5”:
Conventional . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . .80W-90
Limited Slip & Locking . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . .80W-902005-08 . . . . . . . . . . . . . . . .75W-90 GL-5
CAPACITY, Refill: Liters PtFront Axle:
Escalade, K Series 8.25”:
2001-03 . . . . . . . . . . . . . . . . . . 1.7 3.62004-08 . . . . . . . . . . . . . . . . . . 1.4 3.0
9.25”: 2001-08 . . . . . . . . . . . . . . . . . . 1.7 3.6
H Series . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear Axle:
Escalade, C, K Series:8.6”:
2001-02 . . . . . . . . . . . . . . . . . . 2.3 4.92003-08 . . . . . . . . . . . . . . . . . . 2.0 4.2
9.5” . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.59.75” . . . . . . . . . . . . . . . . . . . . . . 2.8 5.910.5” . . . . . . . . . . . . . . . . . . . . . . 2.6 5.511.5”:
2001-05 . . . . . . . . . . . . . . . . . . 3.6 7.62006-08 . . . . . . . . . . . . . . . . . . 3.0 6.3
3500 HD Dana 80 . . . . . . . . . 4.0 8.5G, H Series (2001-05):
8.6” . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.29.5” . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.59.75” . . . . . . . . . . . . . . . . . . . . . . 3.0 6.310.5”:
2001-02 . . . . . . . . . . . . . . . . . . 2.6 5.52003-05 . . . . . . . . . . . . . . . . . . 3.2 6.8
G, H Series:2006-08:
8 5/8” ring gear . . . . . . . . . . . . . 2.0 4.49 3/4” ring gear . . . . . . . . . . . . . 2.8 5.910 1/2” ring gear . . . . . . . . . . . . 2.6 5.5
SSR:2003 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02004 . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
CARS & LIGHT TRUCKS
112
CHEVROLET & GMC TRUCKS Continued
CAPACITY, Refill: Liters Pt2005-06 (w/ AT) . . . . . . . . . . . . . . 2.0 4.22005-06 (w/ MT) . . . . . . . . . . . . . . 2.6 5.5
1 Do not add friction modifier.2 Do not add limited slip additive.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .PS11 For hybrid Silverado 1500 use GM. Part No. 88901975 (Canada
Part No. 88901976).
CHRYSLER, DODGE,PLYMOUTH
1997 INCLUDES CARAVAN, TOWN& COUNTRY, VOYAGER, ANDEAGLE VISION EXCEPT VIPER, PROWLER,SEBRING COUPE & AVENGER2007-08 CHRYSLER ASPEN, SEEDODGE TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
All eng. above 0°F (-18°C) . . . . . . . . . . . . . . . . . .10W-302
1997 below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . .5W-301997 below 100°F (32C) . . . . . . . . . . . . . . . . . . . .5W-303
CAPACITY, Refill4: Liters Qt2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.3L, Concorde, Intrepid, Vision . . . . . 4.7 5.03.5L, All . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5All others . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 Flexible fuel engine oil must meet DaimlerChrysler Standard MS-
92142 Preferred in all Turbo, 2.5L Van & 3.5L3 Not recommended for 3.5L engine above 32°F (0°C). For these
applications: above 0°F (-18°C), 10W-30 preferred4 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, Automatic1
Caravan, Town & Country, Voyager . . . . . . .AP3Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP42
CAPACITY, Initial Refill3: Liters QtAll w/transverse engine . . . . . . . . . . . . 3.8 4.0All w/longitudinal engine . . . . . . . . . . . 4.2 4.51 All w/longitudinal eng., does not include final drive2 Chrysler Corp. recommends that all vehicles with Chrysler auto-
matic transmissions/transaxles except 1999 earlier Caravan, Town& Country, and Voyager models, be serviced with ATF+4®Automatic Transmission Fluid.
3 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in PARK and add fluid as need-ed
TRANSAXLE, ManualNVT 350 (A578) . . . . . . . . . . . . . . . . . . . . . . .GLSOthers . . . . . . . . . . . . . . . . . . . . . .5W-30 API★★CAPACITY, Refill: Liters Pt5-speed NV T350 (A578) . . . . . . . . . . . 2.1 4.45-speed A523, A543, A568 . . . . . . . . . 2.1 4.4FINAL DRIVEAll w/longitudinal engine . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.91 Synthetic gear lubricants should be avoided.
AWD MINI VANPower Transfer Unit & Drive Module . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90Overrunning Clutch . . . . . . . . . . . . . . . . . . . .AP3CAPACITY, Refill: Liters PtPower Transfer Unit . . . . . . . . . . . . . . . 1.1 2.3Drive Module . . . . . . . . . . . . . . . . . . . . 1.9 4.0Overrunning Clutch . . . . . . . . . . . . . . . 0.4 0.8OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB
1998-2000 INCLUDES CARAVAN, TOWN & COUNTRY, AND VOYAGER EXCEPT VIPER, PROWLER,SEBRING COUPE & AVENGERCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-302
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30CAPACITY, Refill3: Liters Qt2.4L, 2.7L, 3.2L, 3.5L . . . . . . . . . . . . . 4.7 5.0All others . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 Flexible fuel engine oil must meet DaimlerChrysler Standard MS-
9214.2 Not recommended for 3.2L/3.5L engine above 32°F (0°C). For these
applications: above 0°F (–18°C) 10W-30 preferred.3 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, AutomaticCaravan, Town & Country, Voyager . . . . . . .AP3Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP41
CAPACITY, Initial Refill2: Liters QtAll w/transverse engine . . . . . . . . . . . . 3.8 4.0All w/longitudinal engine . . . . . . . . . . . 4.2 4.41 Chrysler Corp. recommends that all vehicles with Chrysler auto-
matic transmissions/transaxles except 1999 earlier Caravan, Town& Country, and Voyager models, be serviced with ATF+4®Automatic Transmission Fluid.
2 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSAXLE, Manual NV T350 (A578) . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4FINAL DRIVE . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt1998-99 . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.92000 . . . . . . . . . . . . . . . . . . . . . . . 0.72 1.521 Synthetic gear lubricants should be avoided.2 42LE transaxles built after 7-26-99 fill to 3/8” (9mm) below fill hole.
AWD MINI VANPower Transfer Unit & Drive Module . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90Overrunning Clutch . . . . . . . . . . . . . . . . . . . .AP3CAPACITY, Refill: Liters PtPower Transfer Unit . . . . . . . . . . . . . . . 1.1 2.3Drive Module . . . . . . . . . . . . . . . . . . . . 1.9 4.0Overrunning Clutch . . . . . . . . . . . . . . . 0.4 0.8OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB2001-07 INCLUDES ALLCHRYSLER, DODGE, AND PLY-MOUTH PASSENGER CARS &VANS EXCEPT VIPER, PROWLER,SEBRING COUPE & STRATUSCOUPECRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
2001-04 ex. Crossfire3.2L and 3.5L . . . . . . . . . . . . . . . . . . . . . . . . . .10W-305
ex. 3.2L and 3.5L . . . . . . . . . . . . . . . . . . . . . . . .5W-305
2004 Crossfire . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-404
2005:2.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-205
2.4L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-305
2.7L . . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-302
3.2L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-404
3.3L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202
3.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-302
3.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202
3.8L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202
5.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202, 3
6.1L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-407
2006: 2.4L . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
2.7L . . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-302
3.3L . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
3.5L Pacifica . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
ex. Pacifica . . . . . . . . . . . . . . . . . . . . . . . . . .10W-302
3.8L Pacifica . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301, 2
ex. Pacifica . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
5.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202, 3
6.1L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-407
20071.8L . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
2.0L . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
2.4L Sebring, Avenger . . . . . . . . . . . . . . . . . . . .5W-202
ex Sebring, Avenger . . . . . . . . .5W-202 or 5W-301, 2
2.7L Sebring, Avenger . . . . . . . . . . . . . . . . . . . .5W-202
ex. Sebring, Avenger . . . . . . . . . . . . . . . . . . . .10W-302
3.3L . . . . . . . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
3.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-302
3.8L Pacifica . . . . . . . . . . . . . . . . . . .5W-30 or 10W-30ex. Pacifica . . . . . . . . . . . . . . . .5W-202 or 5W-301, 2
4.0L . . . . . . . . . . . . . . . . . . . . . . .5W-30 or 10W-305
5.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202, 3
6.1L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-407
CAPACITY, Refill6: Liters Qt2001-06
2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L, 2.7L, 3.3L, 3.5L, 3.8L . . . . . . . 4.7 5.02005-06 300 W/2.7L, 3.5L . . . . . . . . 5.7 6.03.5L Code 4 . . . . . . . . . . . . . . . . . . . 5.2 5.53.2L 2001 . . . . . . . . . . . . . . . . . . . . 4.7 5.0
2004 . . . . . . . . . . . . . . . . . . . . . . . 5.6 6.02005-06 . . . . . . . . . . . . . . . . . . . . 8.0 8.5
5.7L, 6.1L . . . . . . . . . . . . . . . . . . . . 6.6 7.02007
1.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L Caliber . . . . . . . . . . . . . . . . . . . 4.3 4.5
Town & Country, Caravan . . . . . . . 4.7 5.0
CAPACITY, Refill6: Liters QtPT Cruiser . . . . . . . . . . . . . . . . . . 4.8 5.1
2.7L Sebring, Avenger . . . . . . . . . . . 5.2 5.5300, Charger, Magnum . . . . . . . . 5.7 6.0
3.3L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.2L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.53.5L Sebring, Avenger . . . . . . . . . . . 5.2 5.5
300, Charger, Magnum . . . . . . . . 5.7 6.03.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.0L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.55.7L, 6.1L . . . . . . . . . . . . . . . . . . . . 6.6 7.0
1 Flexible fuel engine oil must meet Chrysler Standard MS-9214.2 Check oil cap for proper usage.3 With 5.7L Multiple Displacement System must use 5W-20 oil.4 Must be synthetic oil, meeting specification MB 229.3 or MB 229.55 Preferred.6 Capacity shown includes filter. After refill, check oil level.7 Must be synthetic oil, meeting specification MS-10725
TRANSMISSION/TRANSAXLE,Automatic1
All NAG1 . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill2: Liters QtNAG1 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3All w/transverse engine
w/4 Speed . . . . . . . . . . . . . . . . . . . . 3.8 4.0w/5 Speed . . . . . . . . . . . . . . . . . . . . 5.2 5.5
All w/longitudinal engine . . . . . . . . . . . 4.3 4.51 All w/longitudinal eng., does not include final drive.2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
TRANSMISSION/TRANSAXLE, Manual Except Crossfire:
NV T350: 2001 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2002 Ex. PT Cruiser . . . . . . . . . . . . . . . .AP42002 PT Cruiser . . . . . . . . . . . . . . . . . . .GLS2003-07 . . . . . . . . . . . . . . . . . . . . . . . . . .AP4
NVT355 . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4NV T850 . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4Getrag 288 . . . . . . . . . . . . . . . . . . . . . . . . .AP4BG6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4
Crossfire . . . . . . . . . . . . . . . . . . . . . . . . . . API★★1
All Temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill: Liters PtNV T350, T355, T850 . . . . . . . . . . . . . 2.4-2.7 5.1-5.7Getrag 288 . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
w/o Turbo . . . . . . . . . . . . . . . . . . . 2.4 5.1BG6 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2Crossfire . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.81 Use fluid approved to MB236.2. Such as Mopar Part No.
04761872AB
FINAL DRIVEAll w/longitudinal engine . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.72 1.621 Synthetic gear lubricants should be avoided.2 42LE transaxles fill to 3/8” (9mm) below fill hole.
OVERRUNNING CLUTCH, POWER TRANS-FER UNIT, TRANSFER CASEPower Transfer Unit:
Pacifica . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-52004 All temperatures . . . . . . . . . . . . . . . . . .80W-902005-07 All temperatures . . . . . . . . . . . . . . .75W-90
Mini Van: . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
Caliber: . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
Overrunning Clutch . . . . . . . . . . . . . . . . . . . .AP4Transfer Case:
Chrysler 300 . . . . . . . . . . . . . . . . . . . . . . . .SLFDodge Charger, Magnum . . . . . . . . . . . . . .SLF
CAPACITY, Refill: Liters PtPacifica:
Power Transfer Unit:2004-06 . . . . . . . . . . . . . . . . . . . . 1.0 2.12007 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7
Overrunning Clutch . . . . . . . . . . . . . 0.6 1.3Mini Van:
Power Transfer Unit . . . . . . . . . . . . . 1.1 2.3Overrunning Clutch . . . . . . . . . . . . . 0.6 1.3
Caliber:Power Transfer Unit . . . . . . . . . . . . . 0.5 1.1
Chrysler 300, Dodge Charger, Magnum:
Transfer CaseMS140 . . . . . . . . . . . . . . . . . . . . . 0.6 1.3
REAR CARRIER/DRIVE ASSEMBLY & FRONT& REAR DIFFERENTIALCrossfire:
2004 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . .75W-140
2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .Synthetic 75W-85
Charger, Magnum, 300:Front Differential . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-90
113
CARS & LIGHT TRUCKSCHEVROLET & GMC TRUCKS Continued •CHRYSLER, DODGE, PLYMOUTH
Rear Differential . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . .Synthetic 75W-140
Pacifica . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-52004 All temperatures . . . . . . . . . . . . . . . . . .80W-902005-07 All temperatures . . . . . . . . . . . . . . .75W-90
Mini Van: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
Caliber: . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters Pt Crossfire . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7CAPACITY, Refill: Liters Pt Mini Van:
Driveline Module . . . . . . . . . . . . . . . 0.7 1.5Pacifica:
Rear Carrier Unit . . . . . . . . . . . . . . . 0.7 1.5Caliber:
Rear Drive Assembly . . . . . . . . . . . . 0.5 1.1Charger, Magnum, 300:
Front . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3Rear: 198mm . . . . . . . . . . . . . . . . . . 1.4 2.9
210mm . . . . . . . . . . . . . . . . . . . . 1.6 3.4215mm . . . . . . . . . . . . . . . . . . . . 1.2 2.5
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PS
1997-2000 STEALTH, SEBRINGCOUPE, AVENGERCRANKCASE . . . . . . . . . . . . . . . . . . . . . . .API★★Turbo Models:
Above 32°F (0°C) . . . . . . . . . . . . . . . . .20W-40Above -10°F (-23°C) . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . .5W-30
2.0L:Above -10°F (-23°C) . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . .5W-301
Others:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L:
Non-Turbo . . . . . . . . . . . . . . . . . . . . 4.3 4.5Turbo . . . . . . . . . . . . . . . . . . . . . . . 4.6 4.9
1 Preferred.2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE,Automatic
Sebring, Avenger . . . . . . . . . . . . . . . . . . . . .AP41
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP3CAPACITY, Initial Refill2: Liters QtStealth . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8Sebring, Avenger . . . . . . . . . . . . . . . . 3.8 4.01 Chrysler Corp. recommends Avenger and Sebring Coupe automat-
ic transaxles be serviced with ATF+4® Automatic TransmissionFluid.
2 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in NEUTRAL and add fluid asneeded.
TRANSMISSION/TRANSAXLE, ManualSebring, Avenger . . . . . . . . . . . . . . . . . . . . .GLSOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All Temperatures . . . . . . . . . . . . . . . . .75W, 85W, 75W-90CAPACITY, Refill: Liters PtSebring, Avenger . . . . . . . . . . . . . . . . 2.0 4.2Stealth:
FWD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9AWD . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.1
TRANSFER CASE . . . . . . . . . . . . . . . .GL-4All Temperatures . . . . . . . . . . . . . . . . .75W, 85W, 75W-90CAPACITY, Refill: Liters Pt
Stealth:5-speed . . . . . . . . . . . . . . . . . . . . 0.31 0.61
6-speed . . . . . . . . . . . . . . . . . . . . 0.3 0.61 Fill no higher than 7/16 - 1/2” below fill hole.
REAR CARRIER & DIFFERENTIALLimited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★Standard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above -10°F (-23°C) . . . . . . . . . . . .90, 85W-90, 80W-90-30° to -10°F (-34° to -23°C) . . . . . . . . . . . .80W, 80W-90Below -30°F (-34°C) . . . . . . . . . . . . . . . . . . . . . . . . . .75WCAPACITY, Refill: Liters PtStealth . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB
2001-05 SEBRING COUPE,STRATUS COUPECRANKCASE . . . . . . . . . . . . . . . . . . . .API★2001-02 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
2003-04Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
2005Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . .5W-20 or 5W-301
CAPACITY, Refill2: Liters Qt2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 Preferred2 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters Qt
2001-04 . . . . . . . . . . . . . . . . . . . . . . 5.52 5.82
CAPACITY, Initial Refill1: .Liters Qt2005:
4-cyl . . . . . . . . . . . . . . . . . . . . . . . 7.73 8.13
6-cyl . . . . . . . . . . . . . . . . . . . . . . . 8.43 8.931 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded
2 Approximate.3 Total Capacity.
TRANSAXLE, Manual . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.63.0L . . . . . . . . . . . . . . . . . . . . . . . 2.8 5.9OTHER COMPONENTSPower Steering,
2001 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF22002-05 . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS1
Brake & Clutch Master Cylinder . . . . . . . . . . .HBSuspension & Steering Linkage . . . . . . . . . . .LB1 Mitsubishi Diamond ATF PS Fluid.
2008 PT CRUISERCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill2: Lters Qt2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Meeting specification standard MS-6395.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4Capacity, Refill Liters PtNV T350 . . . . . . . . . . . . . . . . . . . . . . . 2.4-2.7 5.1-5.7Getrag 288 . . . . . . . . . . . . . . . . . . . . . 1.8 3.81 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
OTHER COMPONETSBrake/ Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
2008 AVENGER, SEBRING SEDAN,SEBRING CONVERTIBLECRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
2.4L, 2.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-203.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-30CAPACITY, Refill2: Liters Qt2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.7L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.53.5L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Meeting specification standard MS-6395.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt41TE/41AE . . . . . . . . . . . . . . . . . . . . . 3.8 4.062TE . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtNV T355 . . . . . . . . . . . . . . . . . . . . . . . 2.4-2.7 5.1-5.7BG6 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.21 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . .AP4
2008 PACIFICACRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
3.8LAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
4.0LAll temperatures . . . . . . . . . . . . . . . . . . . . . . . .10W-30
CAPACITY, Refill2: Liters Qt3.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.0L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Meeting specification standard MS-6395.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt4-speed . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.06-speed . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
REAR CARRIER, POWER TRANSFER UNIT &OVERRUNNING CLUTCH AWDRear Carrier & Power Transfer Unit . . . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtRear Carrier Unit . . . . . . . . . . . . . . . . . 0.7 1.5Power Transfer Unit . . . . . . . . . . . . . . . 0.8 1.7Overrunning clutch . . . . . . . . . . . . . . . 0.6 1.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . .AP4
2008 300, MAGNUM, CHARGERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2.7L, All temperatures . . . . . . . . . . . . . . . . . . . . . .5W-201
3.5L, All temperatures . . . . . . . . . . . . . . . . . . . . .10W-301
5.7L, All temperatures . . . . . . . . . . . . . . . . . . . . . .5W-201
6.1L, All temperatures . . . . . . . . . . . . . . . . . . . . . .0W-402
CAPACITY, Refill3: Liters Qt2.7L, 3.5L . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L, 6.1L . . . . . . . . . . . . . . . . . . . . . . 6.6 7.01 Meeting specification standard MS-6395.2 Meeting specification standard MS-10725.3 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt42RLE 4-speed . . . . . . . . . . . . . . . . . . 3.8 4.0NAG1 5-speed . . . . . . . . . . . . . . . . . . 5.0 5.21 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3FRONT DIFFERENTIALAll . . . . . . . . . . . . .Synthetic 75W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3REAR DIFFERENTIALAll . . . . . . . . . . . .Synthetic 75W-140 GL-5CAPACITY, Refill: Liters Pt198MM . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9210MM . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4215MM . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
2008 CALIBERCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Meeting specification standard MS-6395.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFCAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill Liters PtNVT355 . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7BG6 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2Getrag DMT6 . . . . . . . . . . . . . . . . . . . 1.8 3.81 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
REAR CARRIER, POWER TRANSFER UNITAll . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . .AP4
2008 TOWN & COUNTRY, GRANDCARAVANCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1
3.3L, 3.8L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-204.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-30CAPACITY, Refill2: Liters Qt3.3L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.0L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Flexible fuel engine oil must meet MS-9214.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt4XTE . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.062TE . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
CARS & LIGHT TRUCKS
114
CHRYSLER, DODGE, PLYMOUTH Continued
DODGE TRUCKSNITRO, SEE JEEP
1997-99 ALL GASOLINE MEDIUM& HEAVY DUTY EMISSIONMODELS1997-98 ALL DIESEL MODELSCRANKCASEGasoline Models . . . . . . . . . . . . . . . . . . . . .API★★
Above 0°F (-18°C) . . . . . . . . . . . . . . .10W-30 PreferredBelow 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
Diesel Models . . . . . . . . . . . . . . . . .CG-4, CH-4Above 10°F (-12°C) . . . . . . . . . . . . . . . . . . . . . .15W-400° to 30°F (-18° to -1°C) . . . . . . . . . . . . . . . . . .10W-30-10° to 0°F (-23° to -18°C) . . . . . . . . . . . . . . . .10W-301
Below 0°F (-18°C) . . . . . . . . . . . . . . . .5W-30 SyntheticCAPACITY, Refill: Liters QtGasoline Models2:
5.2L, 5.9L . . . . . . . . . . . . . . . . . . . . 4.7 5.08.0L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.0
Diesel Models3:5.9L . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.0
1 With block heater2 Capacity shown is with filter. After refill, check oil level.3 Capacity shown is without filter. When replacing filter, fill it with oil
before installing. Run engine and check dipstick, additional oil maybe needed. Must let oil settle for 5 minutes before checking
TRANSMISSION, Automatic . . . . . . . . .AP41
CAPACITY, Initial Refill2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 1.43 1.531 Chrysler Corp. recommends that all vehicles with Chrysler auto-
matic transmissions be serviced with ATF+4® AutomaticTransmission Fluid.
2 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in NEUTRAL and add fluid asneeded
3 Add 1.5 qts. of fluid. Start engine & operate at idle. With service &parking brake applied, shift transmission through all gears. Withtransmission in Neutral, check fluid level. Fluid level should be atMin. mark on dipstick. Allow transmission fluid to reach operatingtemperature. See Note 1.
TRANSMISSION, ManualNV4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-85NV5600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0NV5600 . . . . . . . . . . . . . . . . . . . . . . . 4.5 9.5TRANSFER CASE . . . . .AP3, AF2, AF3, MACAPACITY, Refill: Liters PtNV241 (1997-99) . . . . . . . . . . . . . . . . . 2.7 5.7NP241 HD, NV241 HD . . . . . . . . . . . . 3.1 6.6NV241 HD w/PTO . . . . . . . . . . . . . . . . 4.9 10.4PTO ADAPTER . . . . . . .AP3, AF2, AF3, MACAPACITY, Refill: Liters PtNV021 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4DIFFERENTIALGasoline Models:
Dana rear:Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90All Others except Dana Rear:1998-99:
Van:Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . .80W-90Pickup, Truck:
Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . .75W-901997:
Standard & all Dana . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★Anti-Spin, Limited-Slip, Powr-Loc,
Sure-Grip, Trac-Loc ex. Dana . . . .GL-5★1
All temperatures . . . . . . . . . . . . . . . . . . .80W-90Diesel Models:
1997-98 60 & 70 Dana rear:Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90Others:
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill2: Liters PtGasoline Models:
Front: Dana 60 (248):
1997-99 . . . . . . . . . . . . . . . . . . 3.6 7.6
CAPACITY, Refill2: Liters PtRear:
Dana 60 (248):2WD . . . . . . . . . . . . . . . . . . . . . 3.0 6.34WD . . . . . . . . . . . . . . . . . . . . . 3.4 7.2
Dana 70 (267):2WD . . . . . . . . . . . . . . . . . . . . . 3.3 7.04WD . . . . . . . . . . . . . . . . . . . . . 3.6 7.6
Dana 80 (286):2WD . . . . . . . . . . . . . . . . . . . . . 3.2 6.84WD . . . . . . . . . . . . . . . . . . . . . 4.8 10.1
Diesel Models:Front:
Dana 60 (248):1997-98 . . . . . . . . . . . . . . . . . . 3.6 7.6
Rear: Dana 60 (248):
2WD . . . . . . . . . . . . . . . . . . . . . 3.0 6.34WD . . . . . . . . . . . . . . . . . . . . . 3.4 7.1
Dana 70 (267):2WD . . . . . . . . . . . . . . . . . . . . . 3.3 7.04WD . . . . . . . . . . . . . . . . . . . . . 3.6 7.8
Dana 80 (286):2WD . . . . . . . . . . . . . . . . . . . . . 3.2 6.84WD . . . . . . . . . . . . . . . . . . . . . 4.8 10.1
1 Rear axles with limited slip & locking differentials include 6.5% fric-tion modifier additive. Part No. 4318060
2 Note: Lubricant level in axles must not come up to the fill plugopening. The level must be below the opening as follows: Front: Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6mm) Rear:
9.25" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5/8" (16 mm)Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3/4" (19 mm)
OTHER COMPONENTSBrake & Clutch Master Cylinder . . . . . . . . . . .HBSuspension & Steering Linkage . . . . . . . . . . .LBWheel Bearings,
Transmission Linkage . . . . . . . . . . . . .(EP) GCPower Steering Reservoir . . . . . . . . . . . . . . . .PS
1997-99 ALL REAR-WHEEL DRIVE& 4-WHEEL DRIVE LIGHT DUTYGASOLINE EMISSION MODELSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-301
Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill2: Liters Qt2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.43.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.05.2L, 5.9L . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Preferred2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .AP41
CAPACITY, Initial Refill2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 1.43 1.531 Chrysler Corp. recommends that all vehicles with Chrysler auto-
matic transmissions be serviced with ATF+4® AutomaticTransmission Fluid.
2 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in NEUTRAL and add fluid asneeded
3 Add 1.5 qts. of fluid. Start engine & operate at idle. With service &parking brake applied, shift transmission through all gears. Withtransmission in Neutral, check fluid level. Fluid level should be atMin. mark on dipstick. Allow transmission fluid to reach operatingtemperature. See Note 2.
TRANSMISSION, ManualNV1500 HD, NV3500 . . . . . . . . . . . . . . . . . .GLSAX-15:
1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-51998-99 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-3All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90
NV4500 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-85
CAPACITY, Refill: Liters PtAX-15 . . . . . . . . . . . . . . . . . . . . . . . 3.1 6.6NV1500 HD . . . . . . . . . . . . . . . . . . . . . 2.2 4.7NV3500 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2NV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0TRANSFER CASEAll . . . . . . . . . . . . . . . . .AP3, AF3, AF2, MACAPACITY, Refill: Liters PtNP231, NV231 HD . . . . . . . . . . . . . . . 1.2 2.5NV241 (1997-99) . . . . . . . . . . . . . . . . . 2.7 5.7NV242 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5DIFFERENTIAL1998-99:
Front:7.25” C205F . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90Rear 8.25” & 9.25”:
Vans: Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited Slip . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . .80W-90Pickup, Truck:
Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . .75W-90
1997-99:Dana rear:
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .901997 Others:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90Anti-Spin, Limited-Slip, Powr-Loc, Sure-Grip, Trac-Loc
ex. Dana . . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill2: Liters PtFront: 4-wheel drive 7.25” . . . . . . . . . . 1.4 3.0
Model 194 FIA . . . . . . . . . . . . . . . . . 1.4 3.0C205F . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Dana 44 (216) 1997-98 . . . . . . . . . . 3.2 6.8
1999 . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9Dana 60 (248) 1997-99 . . . . . . . . . . . . 3.6 7.6Rear: 7.25” . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
8.25” . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.49.25” . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8Dana 60 (248) 2WD . . . . . . . . . . . . . 3.0 6.3
4WD . . . . . . . . . . . . . . . . . . . . . . 3.4 7.21 Rear axles with limited slip & locking differential include 6.5% fric-
tion modifier additive. Part No. 43180602 Note: Lubricant level in axles must not come up to the fill plug
opening. The level must be below the opening as follows: Front: 7.25” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3/4” (19 mm)
Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6 mm)Rear: 7.25” & 8.25” . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6 mm)
9.25” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5/8” (16 mm)Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3/4” (19 mm)
OTHER COMPONENTSBrake & Clutch Master Cylinder . . . . . . . . . . .HBSuspension & Steering Linkage . . . . . . . . . . .LBWheel Bearings,
Transmission Linkage . . . . . . . . . . . . .(EP) GCPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2003-06 SPRINTERCRANKCASE . . . . . . . . . . . . . . . . . . . .SEO1
All temperatures . . . . . . . . . . . . . . . . . . .0W-301, 5W-301
All temperatures . . . . . . . . . . . .0W-401, 5W-401, 5W-501
Above -4ºF (-20ºC) . . . . . . . . . . . . . . . . . . . . . . .10W-301
Above -4ºF (-20ºC) . . . . . . .10W-401, 10W-501, 10W-601
Above +5ºF (-15ºC) . . . . . . . . . . . . . . .15W-401, 15W-501
Above +23ºF (-5ºC) . . . . . . . . . . . . . . .20W-401, 20W-501
CAPACITY, Refill2: Liters Qt2003-06 . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.51 Must use oil meeting Spec. MB 228.3, 228.5, 229.3 and 229.5.2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters QtNAG1 5 Speed . . . . . . . . . . . . . . . . . . 5.0 5.31 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded
DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
CAPACITY, Refill: Liters Pt2003-06: Sprinter . . . . . . . . . . . . . . 1.8 4.0
2007-08 SPRINTERCRANKCASE:
w/ Gasoline engine . . . . . . . . . . . . . . . . .SEO1
w/ Diesel engine . . . . . . . . . . . . . . . . . . . .SEO2
CAPACITY, Refill3: Liters Qt3.0L Diesel . . . . . . . . . . . . . . . . . . . . . 12.5 13.23.5L . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.01 Must use oil meeting specification MB 229.3, 229.31, 229.5, and
229.51.2 Must use oil meeting MB 288.51, 229.31, 299.51 or Mopar
68001334AA Mobil 1 ESP Formula.3 Capacity includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Initial Refill2: Liters QtNAG1 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.31 Must meet specification MB 236.10, 236.12 or Mopar p/n
05127382AB Shell ATF 3603/M-115 Shell ATF 3353 or equivalent.2 Remove locking pin with a suitable tool and press out the pin
remaining in the cap downwards. Remove cap. Start engine and letrun at idle speed. Shift through all gears several times. Check theoil level with the engine running. Insert the oil dipstick 8863B up tothe stop on the electro hydraulic unit, check oil level in park andadd fluid if necessary. The dipstick has indicator marks every 10mm. At 100º F the oil level should be at the 30 mm mark on the dip-stick. At 180º F the oil level should be at the 60 mm mark on thedipstick. After the oil level is correct, install a new dipstick tube capand lock pin.
DIFFERENTIALAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1CAPACITY, Refill: Liters Pt8 1/2” . . . . . . . . . . . . . . . . . . . . . . . 1.8 4.01 Must meet specification MB 236.3.
115
CARS & LIGHT TRUCKSDODGE TRUCKS
2000-07 ALL GASOLINE MEDIUM& HEAVY DUTY EMISSIONMODELS;1999-2007 ALL DIESEL MODELSEXCEPT SPRINTERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All Gasoline Models:
5.2L, 5.9L, 8.0L,Above 0°F (-18°C) . . . . . . . . . . . . .10W-30 PreferredBelow 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . .5W-30
5.7L:2003-04:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . .5W-30
2005-06: All temperatures . . . . . . . . . . . . . . . .5W-208.3L (SRT): All Temps . . . . . . . . . . . . .Synthetic 0W-401
All Diesel Models except SprinterEngine Code C:
1999-2002 . . . . . . . . . . . . . . . . .CG-4, CH-4Below 19°F (-7°C) . . . . . . . . . . . . . . . . . . . . .5W-300° to 30°F (-18° to -1°C) . . . . . . . . . . . . . . .10W-30-10° to 0°F (-23° to -18°C) . . . . . . . . . . . .10W-302
Above 10°F (-12°C) . . . . . . . . . . . . . . . . . .15W-402003-07 . . . . . . . . . . . . . . . . . . . . . . . . .CI-4
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .15W-40All Temps . . . . . . . . . . . . . . . . . . .Synthetic 5W-40
Engine Code 61998-2005 . . . . . . . . . . . .CG-4, CH-4, CI-4
Above 10°F (-12°C) . . . . . . . . . . . . . . . . . .15W-400° to 30°F (-18° to -1°C) . . . . . . . . . . . . . . .10W-30-10° to 0°F 1998-2003 (-23° to -18°C) . . . . . . . . . . . .10W-302
2004-2005-10° to 0°F (-23° to -18°C) . . . . . . . . . . . . .5W-30 synthetic3
Engine VIN A . . . . . . . . . . . . . . . . . . . . . . . . .CI-4All Temps . . . . . . . . . . . . . . . . . . . . . . . . . .15W-40
CAPACITY, Initial Refill: Liters QtAll Gasoline Models4:
4.7L . . . . . . . . . . . . . . . . . . . . . . . 5.6 6.05.2L, 5.9L . . . . . . . . . . . . . . . . . . . . 4.7 5.05.7L, 8.0L . . . . . . . . . . . . . . . . . . . . 6.6 7.08.3L (SRT) . . . . . . . . . . . . . . . . . . . . 8.2 8.7
All Diesel Models except Sprinter5: 1999-2003 . . . . . . . . . . . . . . . . . . . . 9.5 10.02004-07 (Inc filter) . . . . . . . . . . . . . . 11.4 12.0
1 Must meet Chrysler specification MS-10725 requirements.2 With block heater3 Without block heater4 Capacity shown includes filter. After refill, check oil level.5 Capacity shown is without filter. When replacing filter, fill it with oil
before installing. Run engine and check dipstick, additional oil maybe needed. Must let oil settle for 5 minutes before checking
TRANSMISSION, AutomaticAll ex. AS68RC . . . . . . . . . . . . . . . . . . . . . . .AP4AS68RC . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Initial Refill2: Liters QtA45RFE, 545RFE, 68RFE
2WD3 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
AS68RC . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.2Others . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Mopar® AS68RC Automatic Transmission Fluid.2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded
3 DTC’s may be set, reset with the DRBIII®, if necessary
TRANSMISSION, ManualGetrag 238, G56 . . . . . . . . . . . . . . . . . . . . . .AP4NV4500, T-56 . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-85NV5600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtG56 Diesel . . . . . . . . . . . . . . . . . . . . 5.6 11.8G56 5.7L . . . . . . . . . . . . . . . . . . . . . 4.7 10.0Getrag 238, T56 . . . . . . . . . . . . . . . . . 2.2 4.6NV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0NV5600 . . . . . . . . . . . . . . . . . . . . . . . 4.5 9.5TRANSFER CASE1999-2000 . . . . . . . . . . . . . . . . . . . . . .AP3, AF32001-07 ex. NV246 . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtNV241 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6NV241 HD . . . . . . . . . . . . . . . . . . . . . . 3.1 6.5NV241 HD w/PTO . . . . . . . . . . . . . . . . 4.9 10.4NV241/244 GENII, NV243 . . . . . . . . . 1.6 3.4NV246, NV271, NV273 . . . . . . . . . . . . 1.9 4.0PTO ADAPTER1999-2000 . . . . . . . . . . . . . . . . . . . . . .AP3, AF32001-02 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtNV021 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.6DIFFERENTIALFront:
1999-2002 . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
2003-06 . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . . . . . .Synthetic 75W-90
2007 C205F . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-859.25” AA, AA EL . . . . . . . . . . . . . . . . . . .GLS
All temperatures . . . . . . . . . . . . .Synthetic 75W-90Rear:
Dana:Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .909.25 AA”,10.5” AA, 11.5” . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill2: Liters PtFront:
Dana 60 (248) 1999 . . . . . . . . . . . . . . . . . . . . . . . 3.6 7.62000-02 . . . . . . . . . . . . . . . . . . . . 4.0 8.5
9.25” AA: 2003-05 . . . . . . . . . . . . . . . . . . . . 2.3 4.82006-07 . . . . . . . . . . . . . . . . . . . . 2.2 4.6
AA EL 2006-07 . . . . . . . . . . . . . . . . 2.0 4.2C205FD . . . . . . . . . . . . . . . . . . . . . . 1.6 3.3
Rear:Dana 60 (248):
1999-2003: 2WD . . . . . . . . . . . . . . . . . . . . . 3.0 6.34WD . . . . . . . . . . . . . . . . . . . . . 3.4 7.3
2004-06) . . . . . . . . . . . . . . . . . . . 2.8 5.9Dana 70 (267):
2WD . . . . . . . . . . . . . . . . . . . . . 3.3 7.04WD . . . . . . . . . . . . . . . . . . . . . 3.6 7.8
Dana 80 (286): 2WD . . . . . . . . . . . . . . . . . . . . . 3.2 6.84WD . . . . . . . . . . . . . . . . . . . . . 4.8 10.1
9.25” . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.410.5” AA, AA-EL
2003-04 . . . . . . . . . . . . . . . . . . 2.3 4.82005-07 . . . . . . . . . . . . . . . . . . 2.5 5.3
11.5” AA2003-05 . . . . . . . . . . . . . . . . . . . . 3.6 7.72006-07:
Trac-Rite . . . . . . . . . . . . . . . . . . 4.0 8.4Open . . . . . . . . . . . . . . . . . . . . 4.2 8.8
1 Rear axles with limited slip & locking differentials include 6.5% fric-tion modifier additive. Part No. 4318060
2 Note: Lubricant level in axles must not come up to the fill plugopening. The level must be below the opening as follows: Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6mm)Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3/4” (19 mm)
OTHER COMPONENTSBrake & Clutch Master Cylinder . . . . . . . . . . .HBSuspension & Steering Linkage . . . . . . . . . . .LBWheel Bearings,
Transmission Linkage . . . . . . . . . . . . .(EP) GCPower Steering Reservoir:
2002-07 1500, 2500, 3500 . . . . . . . . . . .AP4Others . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
2000-07 ALL REAR-WHEEL DRIVE& 4-WHEEL DRIVE GASOLINELIGHT DUTY EMISSION MODELSINCL. CHRYSLER ASPENCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
2000-02: Above 0°F (-18°C) . . . . . . . . . . . . . . .10W-301
Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . .5W-302003-04:
Dakota, Durango, and Ram VanAbove 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . .5W-30
Ram Pickup . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
2005-06:3.7L, 4.7L, 8.1L . . . . . . . . . . .5W-30 or 10W-301, 2, 3
5.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-201, 4
2007: All Engines . . . . . . . . . . . . . . .5W-306 or 5W-201
CAPACITY, Refill5: Liters Qt2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04.7L . . . . . . . . . . . . . . . . . . . . . . . 5.6 6.05.7L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.03.7L, 5.2L, 5.9L . . . . . . . . . . . . . . . . . . 4.7 5.01 Preferred.2 Check oil cap for proper usage3 5W-30 is preferred for Flexible Fuel Vehicles4 With 5.7L Multiple Displacement System must use 5W-20 oil.5 Capacity shown includes filter. After refill, check oil level.6 5W-30 is only an option for the Light Duty Ram Trucks.
TRANSMISSION, AutomaticAll ex. AS68RC . . . . . . . . . . . . . . . . . . . . . . .AP4AS68RC . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Initial Refill2: Liters QtA45RFE, 545RFE, 68RFE
2WD3 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
AS68RC . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.2Others . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Mopar® AS68RC Automatic Transmission Fluid.2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded
3 DTC’s may be set, reset with the DRBIII®, if necessary
TRANSMISSION, ManualGetrag 238, G56 . . . . . . . . . . . . . . . . . . . . . .AP4NV1500, NV3500 . . . . . . . . . . . . . . . . . . . . .GLS1
NV4500, T-56 . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-85
NV5600 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtG56 . . . . . . . . . . . . . . . . . . . . . . . 4.7 10.0Getrag 238, T-56 . . . . . . . . . . . . . . . . . 2.2 4.6NV1500 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6NV3500 2000-01 Dakota, Durango . . . 2.0 4.2NV3500 2WD . . . . . . . . . . . . . . . . . . . 2.3 4.8NV3500 4WD . . . . . . . . . . . . . . . . . . . 2.0 4.2NV4500 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0CAPACITY, Refill: Liters PtNV5600 . . . . . . . . . . . . . . . . . . . . . . . 4.5 9.51 2000 NV 1500, include 0.2pt (0.1L) friction modifier
TRANSFER CASE2000 . . . . . . . . . . . . . . . . . . . . . . . . .AP3, AF32001-07 ex. NV246 . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtMP140, MP143 . . . . . . . . . . . . . . . . . . 0.9 1.9NV133, NV231 HD, NV233 . . . . . . . . . 1.2 2.5NV144 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7NV241 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6NV241/244 GENII, NV243 . . . . . . . . . . 1.6 3.4NV242, NV244 . . . . . . . . . . . . . . . . . . 1.3 2.7NV271, NV273, NV246 . . . . . . . . . . . . 1.9 4.0DIFFERENTIALFront:
C205F . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
9.25” AA, AA EL . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . . . . . .Synthetic 75W-90
Dana 44 (216) . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
Rear:7.25” axles
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-908.25”, 9.25” axles:
2000-02: Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . .75W-902003-04 Dakota, Durango
Standard . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . .75W-90trailer tow . . . . . . . . . . . . . . . . . . . . . . .GLS
2005-07 Dodge Dakota, Durango; ChryslerAspen . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . .Synthetic 75W-1402003-06 Ram Pickup/Truck . . . . . . . . . .GLS
All temperatures . . . . . . . . . . . .Synthetic 75W-140Dana axles:
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .909.25, 10.5, 11.5 Ram Pickup/Truck Axles:
All . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5★★3
All temperatures . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill2: Liters PtFront:
9.25” AA . . . . . . . . . . . . . . . . . . . . . 2.3 4.99.25” AA EL . . . . . . . . . . . . . . . . . 2.0 4.2
C205F . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.6Dana 44 (216) . . . . . . . . . . . . . . . . . 2.3 4.9Dana 60 (248) . . . . . . . . . . . . . . . . . 4.0 8.5186 FIA (Model 30) . . . . . . . . . . . . . 1.2 2.6
Rear: 7.25” . . . . . . . . . . . . . . . . . . . . . 1.4 3.08.25” 2000-04 . . . . . . . . . . . . . . . . 2.1 4.4
2005-07 . . . . . . . . . . . . . . . . . . . . 2.0 4.29.25” 2000-04 . . . . . . . . . . . . . . . . 2.3 4.9
2005-07 . . . . . . . . . . . . . . . . . . . . 2.1 4.41 Rear axles with limited slip & locking differentials include 6.5% fric-
tion modifier additive. Part No. 43180602 Note: Lubricant level in axles must not come up to the fill plug
opening. The level must be below the opening as follows:Front: C205F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/8” (3 mm)
Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6 mm)Rear: 7.25” & 8.25” . . . . . . . . . . . . . . . . . . . . . . . . . . .1/4” (6 mm)
9.25“ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5/8” (16 mm)Dana . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3/4” (19 mm)
3 Trac-Lok® differentials require Limited Slip Additive in the lubricant.Trac-Rite™ / Trac-Rite EL™ differentials DO NOT require LimitedSlip Additive.
OTHER COMPONENTSBrake & Clutch Master Cylinder . . . . . . . . . . .HBSuspension & Steering Linkage . . . . . . . . . . .LBWheel Bearings,
Transmission Linkage . . . . . . . . . . . . .(EP) GCPower Steering Reservoir:
2002-07 2500, 3500 . . . . . . . . . . . . . . . . . .AP42002-07 1500 . . . . . . . . . . . . . . . . . . . . . . .AP4
CARS & LIGHT TRUCKS
116
DODGE TRUCKS Continued
2002-07 Dodge Dakota, Durango; Chrysler Aspen . . . . . . . . . . . . . . . . . . . .AP4
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
2008 RAM PICKUPSCRANKCASEAll Gasoline . . . . . . . . . . . . . . . . . . . . . . . . .API★★All Diesel:
w/ 5.9L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3w/ 6.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
3.7L, 4.7L, 5.7L,All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-201,2
5.9L HO Diesel:Above 0ºF (-18ºC) . . . . . . . . . . . . . . . . . . . . .15W-403,8
All temperatures . . . . . . . . . . . . . . . . .Synthetic 5W-407
6.1L, All temperatures . . . . . . . . . . . . . . . . . . . . . .0W-404
6.7L HO Diesel:Above 0ºF (-18ºC) . . . . . . . . . . . . . . . . . . . . .15W-405,8
All temperatures . . . . . . . . . . . . . . . . .Synthetic 5W-407
CAPACITY, Refill6: Liters Qt3.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.7L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.05.9L . . . . . . . . . . . . . . . . . . . . . . . 11.4 12.06.7L . . . . . . . . . . . . . . . . . . . . . . . 11.4 12.01 Meeting specification standard MS-6395.2 For 2500/3500 pickups with a gross combined weight greater than
14,000 lbs use 5W-30.3 Use API CJ-4/SM that meets Chrysler LLC Standards.4 Use API SM or SM/CF meeting specification standard MS-10725.5 Use API CJ-4 oil that meets specification standard MS-10902. Oil
meeting Cummins CES 20081 standards may also be used. Lowash diesel engine oil is required.
6 Capacity shown includes filter. After refill, check oil level.7 Preferred when minimum temperatures consistently fall below 5ºF (-
15ºC).8 Preferred.
TRANSMISSION, AutomaticAll Ex. AS68RC . . . . . . . . . . . . . . . . . . . . . . .AP4AS68RC . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Initial Refill2: Liters Qt42RLE, 48RE . . . . . . . . . . . . . . . . . . . 3.8 4.045RFE, 545RFE, 68RFE:
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
AS68RC . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.21 Use Mopar® AS68RC Automatic Transmission Fluid.2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded.
TRANSMISSION, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtGetrag 238 . . . . . . . . . . . . . . . . . . . . . 2.2 4.6G56:
w/ Diesel engine . . . . . . . . . . . . . . . 5.9 12.4w/ 5.7L . . . . . . . . . . . . . . . . . . . . . . 5.1 10.7
TRANSFER CASEAll Ex. NV246 . . . . . . . . . . . . . . . . . . . . . . . .AP4NV246 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
CAPACITY, Refill: Liters PtNV241, NV243, NV244 . . . . . . . . . . . . 1.6 3.4NV246 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0NV271, NV273 . . . . . . . . . . . . . . . . . . 1.89 4.01 Mopar NV246 Transfer case fluid.DIFFERENTIALStandard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Limited Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★Front:
Corporate Axles:C205F . . . . . . . . . . . . . . . . . . . . . .Standard 75W-90C200F . . . . . . . . . . . . . .Standard Synthetic 75W-140C200FE Limited Slip . . . . . . . . . .Synthetic 75W-1401
Dana Axles . . . . . . . . . . . . . . . . . . . .Synthetic 80W-90American Axles . . . . . . . . . . . . . . . . .Synthetic 75W-90Magna Axles . . . . . . . . . . . . . . . . . . .Synthetic 75W-90
Rear:Corporate Axles:
Standard . . . . . . . . . . . . . . . . . . .Synthetic 75W-140Limited Slip . . . . . . . . . . . . . . . .Synthetic 75W-1401
Dana Axles:226 RBI w/o trailer tow . . . . . . . . . . . . . . . . .80W-902
226 RBI w/ trailer tow . . . . . . . . .Synthetic 75W-1402
226 RIA . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90302 RBI Synthetic 75W-90
American Axles . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtFront:
Corporate Axles:C205F Standard . . . . . . . . . . . . . . . . . 1.6 3.38
C200F Standard . . . . . . . . . . . . . 1.7 3.59C200FE Limited Slip . . . . . . . . . . 1.7 3.59
Dana Axles:186 FBI Standard . . . . . . . . . . . . . 1.0 2.11186 FIA Standard . . . . . . . . . . . . . 1.24 2.62216 FBI Limited Slip . . . . . . . . . . . 1.3 2.74
American Axles:9.25” Standard . . . . . . . . . . . . . . . 2.2 4.649.25” Limited Slip . . . . . . . . . . . . . 2.0 4.22
Magna Axles:275 FBI Standard . . . . . . . . . . . . . 5.1 10.77
CAPACITY, Refill: Liters PtRear:
Corporate Axles:8.25” Standard . . . . . . . . . . . . . . . 2.08 4.398.25” Limited Slip . . . . . . . . . . . . . 2.1 4.439.25” Standard . . . . . . . . . . . . . . . 2.2 4.649.25” Limited Slip . . . . . . . . . . . . . 2.1 4.43C213R Standard . . . . . . . . . . . . . 2.07 4.37C213RE Limited Slip . . . . . . . . . . 2.24 4.73
Dana Axles:226 RBI . . . . . . . . . . . . . . . . . . . . 2.25 4.75226 RIA . . . . . . . . . . . . . . . . . . . . 1.35 2.85302 RBI . . . . . . . . . . . . . . . . . . . . 6.6 13.94
American Axles:10.5” . . . . . . . . . . . . . . . . . . . . . . 2.5 5.2811.5” Standard . . . . . . . . . . . . . . . 4.2 8.8711.5” Limited Slip . . . . . . . . . . . . . 4.0 8.45
1 Require the addition of 4 oz. (118 ml) of Mopar® limited slip addi-tive.
2 Require the addition of 3.4 oz. of Mopar® limited slip additive.
OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
2008 DAKOTA, DURANGOCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
CAPACITY, Refill2: Liters Qt3.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.7L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.01 Use oil meeting specification standard MS-6395.2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill:1 Liters Qt42RLE . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0545RFE:
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
1 With the engine at operating temperature, shift transmission throughall gears. Check fluid level in NEUTRAL and add fluid as needed.
TRANSMISSION, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtG238 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtNV140 . . . . . . . . . . . . . . . . . . . . . . . 0.85 1.8NV244 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Rear . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-1401
CAPACITY, Refill: Liters PtFront:C205F2 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4Rear:
8 1/4”3 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.29 1/4”4 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4
1 Limited slip axles require 4 oz. (118 ml) Mopar® limited slip additive(MS-10111).
2 Fill 20 mm ± 6 mm from bottom of fill hole.3 Fill 22 mm ± 6 mm from bottom of fill hole.4 Fill 31 mm ± 6 mm from bottom of fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
DAEWOO1999-2002 NUBIRA, LEGANZACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above -5°F (-22°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-30Above -21°F (-30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 Includes filter. After refill, check oil level.
TRANSAXLENubira: to 11/01 (THM) . . . . . . . . . . . . . . . . .AF3
from 11/01 (ZF) . . . . . . . . . . . . . . . . . . . . . .AELeganza . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Total Refill: Liters QtNubira: to 11/01 . . . . . . . . . . . . . . . . . 11.51 12.01
from 11/01 . . . . . . . . . . . . . . . . . . . . — —Leganza:
1999 . . . . . . . . . . . . . . . . . . . . . . . 6.5-7.0 6.9-7.42000-02 . . . . . . . . . . . . . . . . . . . . . . 7.0-7.6 7.4-8.0
1 Nubira does not have a dipstick. Refer to manufacturer procedure.
TRANSAXLE, Manual . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W, 80WCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . . .AF31999-2002 LANOSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
1999-2000:Above 0°F (-20°C) . . . . . . . . . . . . . . . . . . . . . . .10W-50All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
2001-02:Above -5°F (-22°C) . . . . . . . . . . . . . . . . . . . . . .10W-30Above -21°F (-30°C) . . . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters QtLanos (total fill) . . . . . . . . . . . . . . . . . . 11.5 12.21 With engine at operating temperature, shift transmission through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W, 80WCAPACITY, Refill: Liters PtLanos . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, AF3
EAGLE1997-98 TALONVISION—SEE CHRYSLER, DODGE,PLYMOUTHCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★CAPACITY, Refill1: Liters Qt1.5L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.71.8L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02.0L Non-Turbo . . . . . . . . . . . . . . . . . . 4.3 4.52.0L Turbo . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5Turbo Models:
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . .20W-40Above –10°F (–23°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30
All Other Models:Above 0°F (–18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-302
1 Capacity shown includes filter. After refill, check oil level.2 Preferred
TRANSAXLE Automatic1997-98 Talon . . . . . . . . . . . . . . . . . . . . . . .AP41
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP3CAPACITY, Initial Refill2: Liters QtSummit Wagon:
FWD . . . . . . . . . . . . . . . . . . . . . . . 6.13 6.53
AWD . . . . . . . . . . . . . . . . . . . . . . . 6.53 6.93
CAPACITY, Initial Refill2: Liters QtTalon:
Non-Turbo . . . . . . . . . . . . . . . . . . . . 3.8 4.0Turbo 1997 . . . . . . . . . . . . . . . . . . . 6.73 7.13
Turbo 1998 . . . . . . . . . . . . . . . . . . . 5.0 5.31 Chrysler Corp. recommends Talon automatic transaxles be serv-
iced with ATF+4® Automatic Transmission Fluid.2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in Neutral (ex. Talon w/o-turbo,check in PARK) and add fluid as needed
3 Total capacity. For service refill, fill to cold mark on dipstick. Startengine & idle for 2 minutes. Apply service & parking brake, thenmove gear selector through all positions ending in Neutral. Checkif fluid level is at lower hot mark on dipstick
TRANSAXLE ManualTalon Non-Turbo . . . . . . . . . . . . . . . . . . . . . .GLSOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90CAPACITY, Refill: Liters PtSummit Wagon:
1.8L FWD & Summit . . . . . . . . . . . . 1.8 3.82.4L FWD & All AWD . . . . . . . . . . . . 2.3 4.8
Talon:FWD . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2AWD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
TRANSFER CASE . . . . . . . . . . . . . . . . .GL-4All . . . . . . . . . . . . . . . . . . . . . . .75W, 85W, 75W-90CAPACITY, Refill: Liters PtSummit Wagon AWD . . . . . . . . . . . . . 0.6 1.3Talon AWD . . . . . . . . . . . . . . . . . . . . . 0.5 1.1DIFFERENTIALLimited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★Standard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above -10°F (-23°C) . . . . . . . . . . . . .90, 85W-90, 80W-90-30° to -10°F (-34° to -23°C) . . . . . . . . . . . .80W, 80W-90Below -30°F (-34°C) . . . . . . . . . . . . . . . . . . . . . . . . . .75WCAPACITY, Refill: Liters PtSummit Wagon AWD . . . . . . . . . . . . . 0.7 1.5Talon AWD . . . . . . . . . . . . . . . . . . . . . 0.8 1.8OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . .AF2, AF3Brake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Master Cylinder . . . . . . . . . . . . . . . . . .HB
117
CARS & LIGHT TRUCKSDODGE TRUCKS Continued • DAEWOO • EAGLE
FORD, LINCOLN,MERCURY
PASSENGER CARSINCLUDING FWD VANS
1997-2008 FORD CROWNVICTORIA; 1997-2007 LINCOLNTOWN CAR; 1997-2008MERCURY GRAND MARQUIS;2003-04 MERCURY MARAUDERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill: Liters Qt4.6L:
1997-2002 . . . . . . . . . . . . . . . . . . . . 4.71 5.01
2003-08 . . . . . . . . . . . . . . . . . . . . . . 5.71 6.011 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, Automatic1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1
1998-2008 . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Total Fill2, 3: Liters Qt1997-98 All . . . . . . . . . . . . . . . . . . . . . 13.2 13.9Crown Victoria, Grand Marquis
1999-20024 . . . . . . . . . . . . . . . . . . . 13.1 13.92004 . . . . . . . . . . . . . . . . . . . . . . . 12.1 12.82005-084 . . . . . . . . . . . . . . . . . . . . . 13.1 13.9
Marauder2003-04 . . . . . . . . . . . . . . . . . . . . . . 12.1 12.8
Town Car1999-2006 . . . . . . . . . . . . . . . . . . . . 12.1 12.82007 . . . . . . . . . . . . . . . . . . . . . . . 13.1 13.9
1 Ford Motor Co. recommends use of MERCON-V® in AODE/5R70WTransmissions which experience vibration or shudder under light tomoderate acceleration above 35 mph (56 Km/h) or transmissionbreakdown. When chaing to MERCON-V®, drain all transmissionfluid including torque converter, cooler & lines.
2 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
3 Total or dry fill shown, use less fluid when refilling.4 Police or handling package refill 12.1L (12.8 qts).
DIFFERENTIAL1997-2001
Standard . . . . . . . . . . . . . . . . . . .80W-90 GL-5Limited-Slip . . . . . . . . . . . . . .80W-90 GL-5★★1
2002-08Standard . . . . . . . . . . . . . . . . . .80W-90 GL-53
Limited-Slip . . . . .Synthetic 75W-140 GL-5★★1
Police/Limousine . . .Synthetic 75W-140 GL-5★★1
CAPACITY, Refill: Liters Qt1997-2002 . . . . . . . . . . . . . . . . . . . . . 1.82 3.82
2003-2008 . . . . . . . . . . . . . . . . . . . . . 2.42 5.02
1999-2007 Town Car Limousine . . . . . 2.2 4.61 Add 4 oz. of friction modifier Part No. EST-M2C118-A or equivalent
for complete refill of a limited-slip axle.2 Fill to 1/4”-9/16” (6-13mm) below fill hole.3 If equipped with trailer tow option or 4:10 ratio use synthetic 75W-
140.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir
1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
1997 FORD THUNDERBIRD,MERCURY COUGAR,1997-98 LINCOLN MARK VIIICRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997-98 3.8L,
4.6L, All temperatures . . . . . . . . . . . . . . . . . . . .5W-20 CAPACITY, Refill1,2: Liters QtV8 4.6L SOHC . . . . . . . . . . . . . . . . . . . 4.7 5.0V8 4.6L DOHC . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter. After refill, check oil level.2 Some V8 engines have two oil drain plugs.
TRANSMISSION, Automatic1997 AODE, 4R70W . . . . . . . . . . . . . . . . . . .MA1
All others . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1998 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Initial Refill2: Liters Qt1997-98 All . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Ford Motor Co. recommends use of MERCON-V® in AODE/5R70W
Transmissions which experience vibration or shudder under light tomoderate acceleration above 35 mph (56 Km/h) or transmissionbreakdown. When chaing to MERCON-V®, drain all transmissionfluid including torque converter, cooler & lines.
2 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
REAR DIFFERENTIAL1997-98 Standard . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters Pt7.5” ring gear . . . . . . . . . . . . . . . . . . . 1.4 3.08.8” ring gear: Mark VIII . . . . . . . . . . . 1.42 3.02
Others . . . . . . . . . . . . . . . . . . . . . . . 1.52 3.221 Traction-Lok axles: Add 4 oz. of friction modifier. 2 Fill to 1/4”–9/16” (6-13mm) below fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MASupercharger fluid . . . . . . . . . . . . . . . . . . . . .SLF
1997-2004 FORD MUSTANGCRANKCASE . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt3.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01997-2001 4.6L SOHC . . . . . . . . . . . . 4.7 5.02002-04 4.6L SOHC . . . . . . . . . . . . . . 5.7 6.04.6L DOHC Cobra . . . . . . . . . . . . . . . . 5.7 6.01 Capacity includes filter. After refill, check oil level.
TRANSMISSION, Automatic1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1
1998-2004 . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Initial Refill2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Ford Motor Co. recommends use of MERCON-V® in AODE/5R70W
Transmissions which experience vibration or shudder under light tomoderate acceleration above 35 mph (56 Km/h) or transmissionbreakdown. When chaing to MERCON-V®, drain all transmissionfluid including torque converter, cooler & lines.
2 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid
TRANSMISSION, Manual1997-2000 . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2001-04: V6 . . . . . . . . . . . . . . . . . . . . . . . . . .MA
V8: w/T45 (2001) . . . . . . . . . . . . . . . . . . . . .MAw/TR3650 (2001-02) . . . . . . . .Synthetic MAw/TR3650 (2003-04) . . . . . . . . . . . . . . . .MA
2004 V8 Ex. Cobra . . . . . . . . . . . . . . . . . . . . .MA2004 Cobra . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1CAPACITY, Refill: Liters Pt3.8L V6 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.64.6L V8
1997-2000 . . . . . . . . . . . . . . . . . . . . 3.1 6.62001-03 . . . . . . . . . . . . . . . . . . . . . . 3.8 8.02004 . . . . . . . . . . . . . . . . . . . . . . . 3.7 7.8
1 2004 Cobra 6-Speed fluid type listed on transmission label.
DIFFERENTIAL1997-2001 except 2001 Mustang Cobra:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-902001 Mustang Cobra:
Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . .Synthetic 75W-1402002-04:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill2: Liters PtAll w/7.5” ring gear . . . . . . . . . . . . . . . 1.5 3.21997-2003 8.8” ring gear . . . . . . . . . . 1.8 3.82004 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.21 Traction-Lok axles add 4 oz. of friction modifier. 2 Fill to 1/4” (6 mm) below bottom of fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
2005-08 FORD MUSTANGCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★4.0L, All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-304.6L, All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-205.4L, All temperatures . . . . . . . . . . . . . . .Synthetic 5W-50CAPACITY, Refill1: Liters Qt4.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.6L . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.4L . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.51 Capacity includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Total Refill1: Liters Qt5R55S . . . . . . . . . . . . . . . . . . . . . . . 11.2 11.81 Transmission has no dipstick, refer to procedures in Automatic
Transmission Service Guide.
TRANSMISSION, Manual2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
CAPACITY, Refill: Liters PtV6 w/ 5-speed T5 . . . . . . . . . . . . . . . . 2.6 5.5V8 w/ 5-speed TR3650 . . . . . . . . . . . . 3.0 6.3V8 w/ 6-speed TR6060 . . . . . . . . . . . . 3.4 7.2DIFFERENTIALAll w/8.8” ring gear:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-140
CAPACITY, Refill2: Liters Pt7.5” ring gear . . . . . . . . . . . . . . . . . . . 1.5 3.28.8” ring gear: 2005 . . . . . . . . . . . . . . . 2.0 4.2
2006-07 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02008 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
1 Traction-Lok axles add 4 oz. of friction modifier.2 Fill to 1/4” (6 mm) below bottom of fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir
2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
2002-05 FORD THUNDERBIRD,2000-06 LINCOLN LSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2000-01 LS w/3.9L, All temperatures . . . . . . . . . . .5W-302000-01 All Others, All temperatures . . . . . . . . . . .5W-202002-06 All temperatures . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt3.0L V6: 2000 . . . . . . . . . . . . . . . . . . . 5.7 6.0
2001-05 . . . . . . . . . . . . . . . . . . . . . . 6.5 6.93.9L V8: 2000-03 . . . . . . . . . . . . . . . . . 5.7 6.0
2004-05 . . . . . . . . . . . . . . . . . . . . . . 6.2 6.62006 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
2002 Thunderbird . . . . . . . . . . . . . . . . 5.7 6.02003-05 Thunderbird . . . . . . . . . . . . . 6.2 6.61 Capacities include filter change. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . .MA5CAPACITY, Total Fill: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 11.21 11.811 Total fill, fill to bottom of fill hole. Transmission does not have a dip-
stick; refer to procedures in the Automatic Transmission FluidService Guide.
TRANSMISSION, Manual . . . . . . . . . . . .MACAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-52000-01 Lincoln LS, All temperatures . . . . . . . . . .80W-90All Others, All temperatures . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters Pt2000-05 . . . . . . . . . . . . . . . . . . . . . . . 1.41 3.01
2006 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.71 Fill to 1/8”–3/16” (3-15mm) below fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHHydraulic Engine Cooling Fan . . . . . . . . . . . .MAPower Steering Reservoir . . . . . . . . . . . . . . .MA2005-07 FORD FIVE HUNDRED,FREESTYLE2005-07 MERCURY MONTEGOCRANKCASE . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt3.0L V6 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacities include filter change. After refill, check oil level.
TRANSMISSION, Automatic6-speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFCAPACITY,Total Fill: Liters QtCVT:
2005 . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.02006-07 . . . . . . . . . . . . . . . . . . . . . . 9.6 10.1
6-speed:2005-07 . . . . . . . . . . . . . . . . . . . . . 7.0 7.4
TRANSFER CASE . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . 75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSRear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . 80W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
1996-2007 FORD TAURUS;MERCURY SABLE; 1996-2002 LINCOLNCONTINENTAL; 1996-2003 FORDWINDSTAR; 2004-07 FORDFREESTAR, MERCURY MONTEREYCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997-98 3.0L Flex Fuel . . . . . . . . . . . . . . . . . . . . .10W-301997-98 3.4L SHO . . . . . . . . . . . . . . . . . . . . . . . . .5W-301997-2007 All others . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
CARS & LIGHT TRUCKS
118
FORD, LINCOLN, MERCURY
CAPACITY, Refill1: Liters Qt3.0L ex. DOHC & SHO . . . . . . . . . . . . 4.3 4.53.0L DOHC:
1997-2004 . . . . . . . . . . . . . . . . . . . . 5.2 5.52005 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.02006 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
3.0L SHO, 3.2L SHO . . . . . . . . . . . . . . 4.7 5.03.4L SHO . . . . . . . . . . . . . . . . . . . . . . 6.2 6.53.8L:
1997-98 . . . . . . . . . . . . . . . . . . . . . 4.3 4.51999-2003 . . . . . . . . . . . . . . . . . . . . 4.7 5.0
3.9L, 4.2L . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.6L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter.
TRANSAXLE, Automatic1997 All . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1998 Windstar: To 9/9/97 . . . . . . . . . . . . . . . .MA
From 9/9/97 . . . . . . . . . . . . . . . . . . . . . . . .MA51998-2007 All others . . . . . . . . . . . . . . . . . .MA5CAPACITY,Total Fill1: Liters Qt3-speed . . . . . . . . . . . . . . . . . . . . . . . 7.92 8.32
AXOD . . . . . . . . . . . . . . . . . . . . . . . 12.23 12.93
AX4S . . . . . . . . . . . . . . . . . . . . . . . 11.63 12.33
CAPACITY,Total Fill1: Liters QtAX4N (4F50N): 2001-07 . . . . . . . . . . . 12.83 13.53
1997-98 Continental . . . . . . . . . . . . . . 12.93 13.63
1999-2002 Continental . . . . . . . . . . . . 13.03 13.73
Windstar: 1997-98 . . . . . . . . . . . . . . . 11.63 12.33
1999-2000 . . . . . . . . . . . . . . . . . . . . 11.53 12.23
2001-02 . . . . . . . . . . . . . . . . . . . . . . 13.03 13.73
Freestar & Monterey:2004-05 . . . . . . . . . . . . . . . . . . . . . . 13.03 13.73
2006-07 . . . . . . . . . . . . . . . . . . . . . . 11.63 12.331 When servicing transmission, use less fluid to refill.2 Initial refill: with engine at operating temperature, shift transmission
through all gears. Check fluid level in Park and add fluid as need-ed.
3 Total (dry) fill. Approximate, make final check with dipstick. Fortransaxle, drain or refill, measure amount drained & add approxi-mately same amount. Do not overfill. See Note 2.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir
(All Models 1997-2007 ex.1997 Windstar) .MAPower Steering Reservoir
(Windstar 1997) . . . . . . . . . . . . . . . . . . . . . .FA
2007-08 FORD EDGE, LINCOLNMKX; 2008 FORD TAURUS,TAURUS X, MERCURY SABLECRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Capacity, Refill: Liters Qt3.5L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5Capacity, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.0DifferentialAll . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Capacity, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.15 2.43POWER TRANSFER UNITAll . . . . . . . . . . . .Synthetic 75W-140 GL-5CAPACITY, Refill: Liters PtEdge, MKX . . . . . . . . . . . . . . . . . . . . . 0.35 0.74Taurus, Taurus X, Sable . . . . . . . . . . . . 0.53 1.12OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . .MA5
1997 FORD ASPIRECRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.61 Capacity includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . . .MACAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01 With engine at operating temperature, shift transaxle through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . . .FA1997-2000 FORD CONTOUR,MERCURY MYSTIQUE,1999-2002 MERCURY COUGARCRANKCASE . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.5L . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.81 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . . .MACAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.7 4.01 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.4OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
1997-2002 . . . . . . . . . . . . . . . . . . . . . . . . . .MA1997-99 MERCURY TRACER1997-2002 FORD ESCORT1998-2003 FORD ZX22000-2008 FORD FOCUSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Escort, ZX2, Tracer, Focus:
1997-2001 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-202002-04: SVT Focus (2.0L HP) . . . . . . . . . . . . . .5W-302002-08 Others . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill1: Liters Qt1.8L,1.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02.0L Ford SOHC . . . . . . . . . . . . . . . . . 3.8 4.02.0L Ford DOHC:
2005-08 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.3L:
2005-07 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticEscort, ZX2, Tracer . . . . . . . . . . . . . . . . . . . . .MAFocus
2000-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .MA52008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MLV
CAPACITY, Total Fill: Liters QtEscort, ZX2, Tracer . . . . . . . . . . . . . . . 3.91 4.11
Focus2000-05 . . . . . . . . . . . . . . . . . . . . . . 6.62 6.92
2006-07 . . . . . . . . . . . . . . . . . . . . . . 6.72 7.02
2008 . . . . . . . . . . . . . . . . . . . . . . . 6.62 6.921 Initial refill. With engine at operating temperature, shift transmission
through all gears. Check fluid level in park and add fluid as needed.2 Total or dry fill capacity shown. Approximate, make final check with
dipstick. For transaxle drain & refill, measure amount of fluiddrained and add approximately same amount. Do not overfill. SeeNote 1.
TRANSAXLE, ManualEscort, Tracer . . . . . . . . . . . . . . . . . . . . . . . .MAFocus . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtEscort, ZX2, Tracer . . . . . . . . . . . . . . . 3.3 7.0Focus: SOHC . . . . . . . . . . . . . . . . . . . 2.31 4.91
DOHC; 5-speed . . . . . . . . . . . . . . . . . 1.9 4.06-speed . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6
1 Level must be no higher than 3/16 in. (5mm) below fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .FA1998-2007 . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
1997 FORD PROBECRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72.5L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 Capacity shown includes filter. Afterrefill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . . .MACAPACITY, Total Fill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.51 Total or dry fill capacity shown. Approximate, make final check with
dipstick. For drain & fill, measure amount drained & refill with sameamount. Initial refill with engine at normal operating temperature.
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
1997-2002 MERCURY VILLAGERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters Qt3.0L, 3.3L . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticVillager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.7
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .FA1998-2002 . . . . . . . . . . . . . . . . . . . . . . . . . .MA
2006-08 FORD FUSION, MERCURY MILAN2006 LINCOLN ZEPHYR2007-08 LINCOLN MKZCRANKCASE . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt2.3L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.03.5L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticFNR5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF6-speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total Fill1: Liters QtFNR5 . . . . . . . . . . . . . . . . . . . . . . . 6.7 7.16-Speed . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.8 5.9POWER TRANSFER UNIT . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters Pt2007-08 . . . . . . . . . . . . . . . . . . . . . . . 0.35 0.74DIFFERENTIAL . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters Pt2007-08 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir
2006-07 ex 2007 MKZ . . . . . . . . . . . . . . . .MA2007-08 MKZ . . . . . . . . . . . . . . . . . . . . . .MA52008 Fusion, Milan . . . . . . . . . . . . . . . . . .MA5
Clutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBH
FORD TRUCKS1997 FORD RANGER,1997 MAZDA B2300, B3000,B4000,1997 AEROSTARCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30 All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt2.3L, 4.0L . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSMISSION, ManualAll ex. Aerostar . . . . . . . . . . . . . . . . . . . . . . . .MAAerostar:
5-speed . . . . . . . . . . . . . . . . . . . . . . . . . . . .MAOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF
CAPACITY, Refill: Liters PtAll ex Aerostar: 4-speed . . . . . . . . . . . 1.4 3.0
Mazda . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5Aerostar . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5TRANSFER CASE . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters PtWarner 1350 . . . . . . . . . . . . . . . . . . . . 1.4 3.0Warner 1354 . . . . . . . . . . . . . . . . . . . . 1.2 2.5Warner 4405 . . . . . . . . . . . . . . . . . . . . 1.4 3.0Spicer TC-28 . . . . . . . . . . . . . . . . . . . . 2.11 4.511 Fill no higher than 1/8 or 1/4” (3-6 mm) below fill plug.
DIFFERENTIALFront: All ex. Aerostar . . . . . . . . . . . . . . . . .GL-5
w/Auto-locking hubs . . . . . . . . . . . . . . . . . . .75W-90Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90
Aerostar . . . . . . . . . . . . . . . . . . . . . . . . . . . .MARear: Conventional . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtAll ex Aerostar:
FrontAll ex Dana 35 . . . . . . . . . . . . . . . 1.4 3.0Dana 35 . . . . . . . . . . . . . . . . . . . . 1.7 3.6
Rear . . . . . . . . . . . . . . . . . . . . . . . 2.42 5.02
119
CARS & LIGHT TRUCKSFORD, LINCOLN, MERCURY Continued • FORD TRUCKS
CAPACITY, Refill: Liters PtAerostar
Front . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Rear: 8.8” ring gear . . . . . . . . . . . . . 2.43 5.03
Dana axle . . . . . . . . . . . . . . . . . . . 1.2 2.5All others . . . . . . . . . . . . . . . . . . . 1.73 3.53
1 Traction-Lok axles add friction modifier. For complete axle fill: ex.Ford 10.25” axle add 4 oz.; Ford 10.25” axle add 8 oz.
2 Fill to no more than 1/4” - 9/16” below fill plug hole.3 Fill no higher than 1/2” (12 mm) below fill plug.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
1998-2008 FORD RANGER,1998-2008 MAZDA B2300, B2500,B3000, B4000CRANKCASE4.0L . . . . . . . . . . . . . . . . . . . . . .5W-30 API★All others . . . . . . . . . . . . . . . . . . . . .5W-20 API★CAPACITY, Refill1: Liters QtB Series: 2.3L . . . . . . . . . . . . . . . . . . . 3.8 4.0
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.54.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
Ranger:2.3L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L:
1998-2006 . . . . . . . . . . . . . . . . . . 4.3 4.52007 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
4.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .MA5CAPACITY, Initial Refill1: Liters Qt1998 . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01999-2001 . . . . . . . . . . . . . . . . . . . . . 3.7 4.02002-08:
2.3L . . . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
3.0L, 4.0L 2WD . . . . . . . . . . . . . . . . 9.52 10.02
3.0L, 4.0L 4WD . . . . . . . . . . . . . . . . 9.82 10.321 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Total dry fill shown.
TRANSMISSION, Manual . . . . . . . . . . . .MACAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5TRANSFER CASE1998-2007 . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters Pt All . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Rear: All w/o FX4 . . . . . . . . . . . . .80W-90 GL-51
All w/ FX4 . . . . . . .Synthetic 75W-140 GL-5★1
CAPACITY, Refill: Liters PtFront:
B-Series:1998-2002 . . . . . . . . . . . . . . . . . . 1.7 3.62003-06 . . . . . . . . . . . . . . . . . . . . 1.5 3.2
Ranger:1998: 2.5L, 3.0L . . . . . . . . . . . . . . 1.4 3.0
4.0L . . . . . . . . . . . . . . . . . . . . . 1.7 3.61999-2008 . . . . . . . . . . . . . . . . . . 1.7 3.6
Rear2, 3:Ranger, B-Series:
1998-2003 . . . . . . . . . . . . . . . . . . 2.4-2.5 5.0-5.32004-08 w/o FX4 . . . . . . . . . . . . . 2.4-2.5 5.0-5.3
w/ FX4 . . . . . . . . . . . . . . . . . . . 2.5-2.6 5.2-5.51 Add 4 oz. of friction modifier meeting Ford Spec. EST-M2C118-A
for complete refill of traction-lok axles.2 Fill no more than [1/4][“]-[9/16][“] below fill plug hole.3 Traction-lok axles use 2.2-2.4L (4.75-5.0 pts) of fluid.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir: 1998-2007 . . . . . .MA
2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
1997-2005 ECONOLINE VANSCRANKCASE:Gasoline . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Diesel:
1997-2005 . . . . . . .CI-4/ SL, CH-4, CG-4/SHAbove 10°F (-12°C) . . . . . . . . . . . . . . . . . .15W-401, 3
-10°F to 90°F 9-23°C to 32°C) . . . . . . . . . . . .10W-302
Below 30°F(-1°C) . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .0W-30
CAPACITY, Refill4: Liters Qt.All Gasoline . . . . . . . . . . . . . . . . . . . . . 5.7 6.0Diesel:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 13.2 14.01999-2005 . . . . . . . . . . . . . . . . . . . . 14.2 15.0
1 Preferred above 30°F (-1°C)2 Preferred from -10°F to 30°F (-23°C to -1°C)3 15W-40 recommended for above 50°F (10°C), and must be used
when towing a trailer or heavy duty driving.
4 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1998-2005 4R70/75 E-W . . . . . . . . . . . . . . .MA52004-05 Torqshift . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initial Refill1: Liters Qt.1997 E4OD . . . . . . . . . . . . . . . . . . . . 6.1 6.51998-2005 4R70/75 E-W . . . . . . . . . . 4.7 5.01999-2004 4R100 . . . . . . . . . . . . . . . . 6.1 6.5Torqshift 5-speed:
2004-05 . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 With engine at operating temperature, shift transmission through all
gears.
DIFFERENTIALDana axles:
1997-2002:ex. 80 & E-350 w/ 4.10 Ratio:
Conventional . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-9080 & E-350 w/ 4.10 Ratio:
Conventional . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . .Synthetic 75W-1402003-05:
M60-IU:Conventional . . . . . . . . . . . . . . . . . .GL-51
Traction-Lok . . . . . . . . . . . . . . . . . .GL-51,3
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90ex. M60-IU
Conventional . . . . . . . . . . . . . . . . . . .GL-51
Traction-Lok . . . . . . . . . . . . . . . . .GL-5★★1,3
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90Ford axles:
1997-2002:Conventional . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . . . .Synthetic 75W-1402006: Visteon axles
Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★4
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-1402006: Dana axles
E350 w/M70 (M248) . . . . . . . . . . . . . . . .GL-54
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-140E350 w/M70 HD limited slip . . . . . . . .GL-5★★3
Others w/limited slip . . . . . . . . . . . . . .GL-5★★4
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Others w/conventional . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . .Synthetic 80W-90
Visteon axles:Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★4
All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtFord 8.8”, 9.75” . . . . . . . . . . . . . . . . . . 2.6-2.7 5.5-5.8Visteon 8.8”, 9.75” . . . . . . . . . . . . . . . 2.6-2.7 5.8-5.8Dana:
M60-IU . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3M70-2U . . . . . . . . . . . . . . . . . . . . . . 3.1 6.6M70-1HD . . . . . . . . . . . . . . . . . . . . . 3.5 7.580:
1998 . . . . . . . . . . . . . . . . . . . . . . . 3.5 7.51999-2001 . . . . . . . . . . . . . . . . . . 3.9 8.25
M70FF . . . . . . . . . . . . . . . . . . . . . . . 3.2 6.8M60 . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3M70HD:
E-350 DSO . . . . . . . . . . . . . . . . . . 3.5 7.4E-450 . . . . . . . . . . . . . . . . . . . . . . 3.9 8.3
1 Axles subject to frequent trailer towing particularly in hot or hillyarea, use synthetic 75W-140 GL-5.
2 Traction-Lok axles, add friction modifier. For complete axle fill, Ford8.8” add 4 oz. Ford 10.25” axle & dana axles add 8 oz.
3 Add 8 oz. of friction modifier. For complete axle fill.4 Add 4 oz. of friction modifier. For complete axle fill.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
1997-05 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA
2006-08 ECONOLINE VANSCRANKCASE:Gasoline . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Diesel:
2006-07 . . . . . . . . . . . .CI-4+1, CI-4/ SL, CH-42008 . . . . . . . . . . . . . . . . . . .CJ-4, CJ-4/ SM
2006-08Above 10°F (-12°C) . . . . . . . . . . . . . . . . . . . . . .15W-402, 3
-10°F to 90°F (-23°C to 32°C) . . . . . . . . . . . .10W-304
Below 30°F (-1°C) . . . . . . . . . . . . . . . . .5W-30, 5W-40Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .0W-30
CAPACITY, Refill5: Liters Qt.All Gasoline . . . . . . . . . . . . . . . . . . . . . 5.7 6.0Diesel . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0
1 Preferred2 Preferred above 30°F (-1°C).3 Recommended for trailer towing.4 Preferred from -10°F to 30°F (-23°C to -1°C)
TRANSMISSION, Automatic4R70/75 E-W . . . . . . . . . . . . . . . . . . . . . . . .MA5Torqshift . . . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initial Refill1: Liters Qt.4R70/75 E-W:
2006-2007 . . . . . . . . . . . . . . . . . . . . 4.7 5.02008 . . . . . . . . . . . . . . . . . . . . . . . 13.12 13.92
Torqshift 5-speed:2006-07 . . . . . . . . . . . . . . . . . . . . . . 7.0 7.42008 . . . . . . . . . . . . . . . . . . . . . . . 17.72 18.82
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
2 Total dry fill capacity.
DIFFERENTIAL2006:
Visteon 8.8”, 9.75”Conventional . . . . .Synthetic 75W-140 GL-5Traction-Lok . . .Synthetic 75W-140 GL-5★★1
Dana Axles Ex. E-350 w/ Dana M70 (M248)Conventional . . . . . . . . . . . . . .80W-90 GL-5Limited Slip . . . . . . . . . . . . . . . . .90 GL-5★★2
E-350 w/ Dana M70 (M248)Conventional . . . . .Synthetic 75W-140 GL-5Limited Slip . . . .Synthetic 75W-140 GL-5★★2
2007-08:Dana Axles Ex. E-350 w/ Dana M60 (M248)4.10 axle ratio
Conventional . . . . . . . . . . . . . .80W-90 GL-5Limited Slip . . . . . . . . . . . . . . . . .90 GL-5★★3
E-350 w/ Dana M60 (M248) 4.10 axle ratioConventional . . . . .Synthetic 75W-140 GL-5Limited Slip . . . .Synthetic 75W-140 GL-5★★3
CAPACITY, Refill4: Liters PtVisteon 8.8”, 9.75” . . . . . . . . . . . . . . . 2.6 5.5Dana M70 . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3Dana M70HD . . . . . . . . . . . . . . . . . . . 3.9 8.3Dana M70FF:
2006:Limited Slip . . . . . . . . . . . . . . . . . 3.2 6.8Conventional . . . . . . . . . . . . . . . . 3.1 6.6
2007-08 . . . . . . . . . . . . . . . . . . . . . . 3.1 6.6Dana M60:
2006 . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.32007-08 . . . . . . . . . . . . . . . . . . . . . . 2.8 5.9
1 Add 4 oz. of friction modifier meeting Ford specification EST-M2C118-A or equivalent.
2 Dana limited-slip axles (E-250, E-350) add 8 oz. of friction modifiermeeting Ford specification EST-M2C118-A or equivalent.
3 Only for Dana (M60) limited-slip axles add 8 oz. of friction modifiermeeting Ford specification EST-M2C118-A or equivalent.
4 Fill 1/4" to 9/16" (6 mm to 14 mm) below bottom of fill hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
2006-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
1997 F150-350 2WD, EX. 1997F150 & 250LDCRANKCASEGasoline . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★Diesel . . . . . . . . . . . . . .CH-4/SJ, CH, CI-4/SLGasoline:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Diesel:
Above 30°F (-1°C) . . . . . . . . . . . . . . . . . . . . . . .15W-40-10°F (-23°C) to 30°F (-1°C) . . . . . . . . . . . . . . . .10W-30Below -10°F (-23°C) . . . . . . . . . . . . . . . . . . . . . .0W-30Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .15W-401
-10° to 90°F (-23° to 32°C) . . . . . . . . . . . . . . . .10W-30Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill2: Liters QtGasoline . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0Diesel: All w/DI . . . . . . . . . . . . . . . . . . 13.2 14.01 Preferred above 30°F (-1°C).2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . . .MACAPACITY, Initial Refill1: Liters QtC6: Deep pan . . . . . . . . . . . . . . . . . . . 5.6 6.0
Shallow pan . . . . . . . . . . . . . . . . . . . 4.7 5.0E40D . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.54R70W . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSMISSION, Manual5-speed ZF S5-42/47
w/7.3 Diesel . . . . . . . . . . . . . . . .Synthetic MAAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters Pt4-speed: B.W. T18, T19 . . . . . . . . . . . 3.3 7.05-speed: Mazda M50D-R2 . . . . . . . . . 3.6 7.6ZF S5-42/47 . . . . . . . . . . . . . . . . . . . . 3.2 6.8
CARS & LIGHT TRUCKS
120
FORD TRUCKS Continued
DIFFERENTIALDana axles
ex. 80:Conventional . . . . . . . . . . . . . . . . . . . . GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
80:Conventional . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . .Synthetic 75W-140Ford axles:
Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
F150 4.10:1 axle ratio . . . . . . . . . . . . . . .GL-5★★1
F150 Lightning . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFord w/8.8”, 9.0” ring gear2 . . . . . . . . 2.63 5.53
Ford w/10.25 ring gear2 . . . . . . . . . . . 3.5 7.4Dana 60 & 61 ex. 60-IU . . . . . . . . . . . . 2.8 6.0Dana 60-IU . . . . . . . . . . . . . . . . . . . . . 3.04 6.34
Dana 70 ex. HD . . . . . . . . . . . . . . . . . . 3.14 6.54
Dana 70HD . . . . . . . . . . . . . . . . . . . . . 3.54 7.44
Dana 80 . . . . . . . . . . . . . . . . . . . . . . . 3.94 8.24
1997 F250 HD, F350 . . . . . . . . . . . . . . 3.1 6.51997 F Super Duty . . . . . . . . . . . . . . . 4.0 8.51 Traction-Lok axles, add friction modifier Ford. For complete axle fill,
Ford 8.8” add 4 oz., Ford 10.25 axle & Dana axles add 8 oz.2 8.8” & 10.25” have removable cover.3 Fill 1/4” to 9/16” below fill hole.4 Fill 1/4” to 3/4” below fill hole.
LIMITED-SLIP OR TRACTION-LOKIDENTIFICATIONID number on label on door lock pillar includes a letter.OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir: . . . . . . . . . . . . . .MA
1997 F-150-350 4WD, BRONCO EX. 1997 F150 & 250LDCRANKCASEGasoline . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★Diesel . . . . . . . . . .CH-4/SJ, CH-4/SL, CI-4/SLGasoline:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Diesel:
Above 30°F (-1°C) . . . . . . . . . . . . . . . . . . . . . . .15W-40-10°F (-23°C) to 30°F (-1°C) . . . . . . . . . . . . . . .10W-30Below -10°F (-23°C) . . . . . . . . . . . . . . . . . . . . . .0W-30
CAPACITY, Refill1: Liters QtGasoline . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0Diesel: All w/DI . . . . . . . . . . . . . . . . . . 13.2 14.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . . .MACAPACITY, Initial Refill1: Liters QtC6: Deep pan . . . . . . . . . . . . . . . . . . . 5.6 5.9
Shallow pan . . . . . . . . . . . . . . . . . . . 4.7 5.0E40D . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.54R70W . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSMISSION, Manual5-speed ZF S5-42/47
w/7.3 Diesel . . . . . . . . . . . . . . . .Synthetic MAAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters Pt5-speed: Mazda M50D-R2 . . . . . . . . . 3.6 7.6ZF S5-42/47 . . . . . . . . . . . . . . . . . . . . 3.2 6.8TRANSFER CASE . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters PtWarner 1356 . . . . . . . . . . . . . . . . . . . . 1.9 4.0w/PTO . . . . . . . . . . . . . . . . . . . . . . . 5.8 12.3DIFFERENTIALFront:
Bronco, F150, F250 . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90F350 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90Rear: Dana axles ex. 80:
Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-901997 Ford axles & Dana 80:
Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
Ford, w/8.8” ring gear . . . . . . . . . . . 1.6 3.4Dana 44 . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Dana 50 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8Dana 60 . . . . . . . . . . . . . . . . . . . . . 2.7 5.71997 F250HD, F350 . . . . . . . . . . . . 2.8 5.9
CAPACITY, Refill: Liters PtRear:
Ford w/8/8”, 9.0” ring gear2 . . . . . . . 2.63 5.53
Ford w/10.25 ring gear2 . . . . . . . . . . 3.5 7.4Dana 60 & 61 ex. 60-IU . . . . . . . . . . 2.8 5.9Dana 60-IU . . . . . . . . . . . . . . . . . . . 3.04 6.34
Dana 70 ex. HD . . . . . . . . . . . . . . . . 3.14 6.54
Dana 70HD . . . . . . . . . . . . . . . . . . . 3.54 7.44
Dana 80 . . . . . . . . . . . . . . . . . . . . . . 3.94 8.24
1997 F250 HD, F350 . . . . . . . . . . . . 3.1 6.51997 F Super Duty . . . . . . . . . . . . . . 4.0 8.5
1 Traction-Lok axles, add friction modifier. For complete axle fill, Ford8.8” add 4 oz., Ford 10.25 axle & Dana axles add 8 oz.
2 8.8” & 10.25” have removable cover.3 Fill 1/4” to 9/16” below fill hole.4 Fill 1/4” to 3/4” below fill hole.
LIMITED-SLIP OR TRACTION-LOKIDENTIFICATIONID number on label on door lock pillar includes a letter.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir: . . . . . . . . . . . . . .MA
1997-2008 FORD F-150, 1997-99FORD F250LD, 2006-08 LINCOLNMARK LT, 2002 LINCOLNBLACKWOODCRANKCASEAll . . . . . . . . . . . . . . . . . . . . . .5W-20 API★★CAPACITY, Refill1: Liters QtVin Code 5 2004-07 . . . . . . . . . . . . . . 6.6 7.0All others . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLEAutomatic
1997 All . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA1998-2004 E4OD, 4R100 . . . . . . . . . . . . . .MA1998-2008 4R70/75 E-W . . . . . . . . . . . . .MA5
CAPACITY, Total Fill1, 2: Liters Qt1997-2001
4R70W . . . . . . . . . . . . . . . . . . . . . . 13.1 13.9E4OD, 4R100 (4x2) . . . . . . . . . . . . . 15.0 15.9E4OD, 4R100 (4x4) . . . . . . . . . . . . . 15.5 16.4
2002-04 Heritage4R100 (4x2) . . . . . . . . . . . . . . . . . . . 16.1 17.04R100(4x4) . . . . . . . . . . . . . . . . . . . 16.7 17.74R70/75 E-W . . . . . . . . . . . . . . . . . . 13.2 13.9
2004-08 4R70/75 E-W . . . . . . . . . . . . . . . . . . 13.2 13.9
Manual1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
CAPACITY, Refill: Liters Pt5-speed . . . . . . . . . . . . . . . . . . . . . . . 3.5 7.41 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Total (dry) capacity. Approximate, make final check with dipstick.
TRANSFER CASE1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0DIFFERENTIALFront:
1997-2003 . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
2004-08 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperature . . . . . . . . . . . . . . . . . . . . . . .80W-90
Rear:Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★1997-2008
All temperatures . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
1997 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.51998-99 . . . . . . . . . . . . . . . . . . . . . . 1.8-2.0 3.5-3.72000-07 . . . . . . . . . . . . . . . . . . . . . . 2.0 3.72008 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.5
Rear:8.8”, 9.75”
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.61 5.51
1998-2000 . . . . . . . . . . . . . . . . . . 2.6-2.71 5.5-5.81
2001-08 . . . . . . . . . . . . . . . . . . . . 2.61 5.51
10.25”1997 . . . . . . . . . . . . . . . . . . . . . . . 3.32 7.02
1998-2000 . . . . . . . . . . . . . . . . . . 3.3-3.82 7.5-8.02
2001-03 . . . . . . . . . . . . . . . . . . . . 3.32 6.92
2004 . . . . . . . . . . . . . . . . . . . . . . . 3.31 6.91
2005-08 . . . . . . . . . . . . . . . . . . . . 3.32 6.921 Add 4 oz of friction modifier, Ford specification EST-M2C118-A for
complete refill of traction-lok axles.2 Add 8 oz of friction modifier, Ford specification EST-M2C118-A for
complete refill of traction-lok axles.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBH
Power Steering Reservoir:1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
1997-2008 FORD EXPEDITION,LINCOLN NAVIGATORCRANKCASEAll . . . . . . . . . . . . . . . . . . . . . .5W-20 API★★CAPACITY, Refill1: Liters QtVin Code 5: 2004-08 . . . . . . . . . . . . . . 6.6 7.0All others . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLEAutomatic1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA4R70E, 4R70W 1998-2006 . . . . . . . . . . . . .MA54R100, E4OD . . . . . . . . . . . . . . . . . . . . . . . . .MA6HP26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MSP6R75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initiall Refill1: Liters Qt4R70W, 4R70E . . . . . . . . . . . . . . . . . . 4.7 5.04R100, E4OD . . . . . . . . . . . . . . . . . . . 6.1 6.56HP26:
2005-06 . . . . . . . . . . . . . . . . . . . . . . 4.72 5.02
2007 . . . . . . . . . . . . . . . . . . . . . . . 9.02,3 9.52,3
6R75 . . . . . . . . . . . . . . . . . . . . . . . 10.53 11.031 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Transmission has no dipstick, refer to procedures in Automatic
Transmission Fluid Service Guide.3 Total or dry fill.
TRANSFER CASE1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90Rear1:
Conventional . . . . . . . . . . . . . . . . . . . . . . .GL-5Traction-Lok . . . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.81999-2008 . . . . . . . . . . . . . . . . . . . . 1.7 3.6
Rear:1997-98 Ford 8.8”, 9.75”3 . . . . . . . . 2.64 5.54
Ford 10.25”3 . . . . . . . . . . . . . . . . . . 3.5 7.41999-2002 . . . . . . . . . . . . . . . . . . . . . 2.7 5.82003-04:
8.8” Conventional . . . . . . . . . . . . . . 1.7 3.68.8”, 9.75” Traction-Lok . . . . . . . . . . 1.8 3.89.75” Conventional . . . . . . . . . . . . . 1.9 4.0
2005-06:9.75” . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
2007-08:9.75” Conventional . . . . . . . . . . . . . 2.1 4.59.75” Traction-Lok . . . . . . . . . . . . . . 2.0 4.2
1 2003, All temperatures use Synthetic 75W-90.2 Add 4oz. of friction modifier for complete axle refill.3 8.8”, 10.25” have removable cover.4 Fill 1/4 to 9/16” below fill hole.
OTHER COMPONETSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir:
1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
2001-2005 FORD EXPLORERSPORT; 2001-05 & 2007 SPORTTRAC; 1997-2001 FORDEXPLORER, MERCURYMOUNTAINEER;CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures:
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill1: Liters Qt4.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.6L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic1997 Explorer, Mountaineer w/V6 . . . . . . . .MA51997 All others . . . . . . . . . . . . . . . . . . . . . . . .MA1998-2005 All . . . . . . . . . . . . . . . . . . . . . . . .MA52007 6R60 . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initial Refill1: Liters Qt4R70W w/5.0L . . . . . . . . . . . . . . . . . . 4.7 5.01997-98 All others . . . . . . . . . . . . . . . . 2.8 3.01999-2001 All others . . . . . . . . . . . . . . 3.7 4.0
121
CARS & LIGHT TRUCKSFORD TRUCKS Continued
CAPACITY, Initial Refill1: Liters Qt2002 Explorer Sport/Sport Trac:
2WD . . . . . . . . . . . . . . . . . . . . . . . 9.52 10.02
4WD . . . . . . . . . . . . . . . . . . . . . . . 9.82 10.32
2007 Explorer Sport Trac:6R60 . . . . . . . . . . . . . . . . . . . . . . . 10.62 11.22
5R55S . . . . . . . . . . . . . . . . . . . . . . . 11.72 12.42
2002-07 4.0L: 2WD . . . . . . . . . . . . . . . . . . . . . . . 9.52 10.02
4WD . . . . . . . . . . . . . . . . . . . . . . . 9.82 10.321 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Total fill shown.
TRANSMISSION, Manual . . . . . . . . . . . .MACAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5TRANSFER CASE . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters Pt1997-2007 Explorer, Mountaineer
w/4WD . . . . . . . . . . . . . . . . . . . . . . 1.4 3.01997-2001 Explorer, Mountaineer
w/AWD . . . . . . . . . . . . . . . . . . . . . . 1.3 2.62001-03 Explorer Sport/Sport-Trac . . . 1.3 2.62004-05 All . . . . . . . . . . . . . . . . . . . . . 1.2 2.52007 Explorer Sport Trac . . . . . . . . . . 1.4 3.0DIFFERENTIALFront:
1997 Explorer,Mountaineer . . . . . . . . . . . . . . . . . . . . . .GL-5
1997-2007 others . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90
Rear:Conventional:
1997-98 Explorer, Mountaineer w/5.0L,4.0L SOHC, 4.0L w/3.73 or
4.10-axle ratio . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . .Synthetic 75W-140
1999-2001 Explorer, Mountaineerw/5.0L . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . .Synthetic 75W-140
1997-2007 All others . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90
Traction-Lok1997-98 Explorer, Mountaineer w/5.0L,
4.0L SOHC, 4.0L w/3.73 or 4.10 axle ratio . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . .Synthetic 75W-1401999-2001 Explorer, Mountaineer
w/5.0L . . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . .Synthetic 75W-1401997-07 All others . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-902004-05 & 2007
Sport Trac . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
Explorer, Mountaineer:1998-2002 . . . . . . . . . . . . . . . . . . 1.7 3.62003-05 . . . . . . . . . . . . . . . . . . . . 1.5 3.2
Explorer Sport Trac:2001-04 . . . . . . . . . . . . . . . . . . . . 1.7 3.62005 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.22007 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
Rear:Explorer, Mountaineer:
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.63 5.53
1998-2001 . . . . . . . . . . . . . . . . . . 2.73 5.73
Explorer Sport/Sport Trac . . . . . . . . 2.63 5.53
Sport Trac 2005:Conventional . . . . . . . . . . . . . . 2.33 4.93
Traction-Lok . . . . . . . . . . . . . . . 2.43 5.13
Sport Trac 2007: . . . . . . . . . . . . . 1.73 3.631 Add 4 oz. of friction modifier for complete axle refill.2 Add 4 oz. of friction modifier Ford Spec ES-4L3W-M2C196-BA3 Fill to no more than 1/4” - 9/16” below fill plug hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA1998-2006 F250 HD, F350, F450,F550, EXCURSIONCRANKCASEGasoline . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★Diesel . . . . . . . . . . . . . . . . . .CH-4, CI-4, CI-4+Gasoline:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Diesel:
Above 30°F (-1°C) . . . . . . . . . . . . . . . . . . . . .15W-40-10° to 30°F (-23° to -1°C) . . . . . . . . . . . . . . .10W-30Below -10°F (-1°C) . . . . . . . . . . . . . . . . . . . . . .0W-30
CAPACITY, Refill1: Liters QtGasoline
1998-2004 . . . . . . . . . . . . . . . . . . . . 5.7 6.0
CAPACITY, Refill1: Liters Qt2005-06:
Code 5, 5.4L . . . . . . . . . . . . . . . . 6.6 7.0Code V, Y, 6.8L . . . . . . . . . . . . . . . 6.6 7.0
Diesel . . . . . . . . . . . . . . . . . . . . . . . 14.1 14.91 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic4R100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5R110W . . . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initial Refill1: Liters Qt4R100 . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.55R110W . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.51 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSMISSION, Manual5-speed ZF 1998-2001 . . . . . . . . .Synthetic MAAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters Pt5-speed ZF S5-47 . . . . . . . . . . . . . . . . 3.2 6.86-speed ZF S6-650 w/o oil cooler . . . 5.5 11.6
w/oil cooler . . . . . . . . . . . . . . . . . . . 6.0 12.7TRANSFER CASE . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters PtNV271 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0DIFFERENTIALFront:
1998:F250 HD . . . . . . . . . . . . . . . . . . . . . . .GL5★★
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90F350 . . . . . . . . . . . . . . . . . . . . . . . . . . .GL5★★
All temperatures . . . . . . . . . . . . . . . . . . . . .80W-901999-2001 . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-902002-06 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .90Rear:
Conventional:1998:
Ford axles & Dana 80 axle . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . .Synthetic 75W-140
Dana axles ex. Dana 80 . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .80W-90
1999-06:Dana 80 . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . .Synthetic 75W-90Ford axles . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . .Synthetic 75W-1401999-2001 Dana 135 . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-902002-06:
Dana S110, 130, 135 . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . .Synthetic 75W-140
Traction-Lok:1998:
Ford axles & Dana 80 axle . . . . . .GL-5★★2
All temperatures . . . . . . . . . .Synthetic 75W-140Dana axles ex. Dana 80 . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . . . . . . . . . .80W-901999-2006:
Dana 80 . . . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . . .Synthetic 75W-90Ford axles . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . .Synthetic 75W-1401999-2001:
Dana 135 . . . . . . . . . . . . . . . . . . .GL-5★★1,2
All temperatures . . . . . . . . . . . . . . . . . . .80W-902002-04:
Dana 135 . . . . . . . . . . . . . . . . . . . .GL-5★★2
All temperatures . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
1998 F250HD, F350 . . . . . . . . . . . . 2.8 5.9Excursion, F250-550 Super Duty:
1999-2000 . . . . . . . . . . . . . . . . . . 2.8 5.92000-04 Dana 50 . . . . . . . . . . . . . 1.8 3.82000-04 Dana 60 . . . . . . . . . . . . . 2.7 5.82005 Excursion . . . . . . . . . . . . . . 2.8 5.92005-06 All Others . . . . . . . . . . . . 3.0 6.3
Rear:1998 F250HD, F350 . . . . . . . . . . . . 3.1 6.51998 F Super Duty . . . . . . . . . . . . . . 4.0 8.51999-06 F250-550 SD:
Ford 10.5” . . . . . . . . . . . . . . . . . . 3.3 6.9Dana 80
Conventional . . . . . . . . . . . . . . 4.03 8.53
Trac-Lok . . . . . . . . . . . . . . . . . . 3.83 8.03
Dana S110, S130 . . . . . . . . . . . . . . 7.64 16.04
Dana 135 . . . . . . . . . . . . . . . . . . . . . 14.6 24.51999-2005 Excursion . . . . . . . . . . . 3.3 6.9
1 Axles subject to frequent trailer towing particularly in hot or hillyarea, use Synthetic 75W-140 GL-5
2 Add friction modifier for complete axle refill. 1998 Ford axles, add 4oz. 1999-2004 Ford axles, add 8 oz. 1998-2006 Dana axles, add 8oz.
3 Fill to 1/4 to 3/4” below fill hole.
4 The lube capacity will vary upon the housing mounting angle. Thecapacity given is for an angle of 4 degrees. The lube must be levelwith the fill hole.
LIMITED-SLIP OR TRACTION-LOKIDENTIFICATIONID number on label on door lock pillar includes a letter.OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
2007-08 F250-550CRANKCASEGasoline . . . . . . . . . . . . . . . . . . . . .5W-20 API★★Diesel:
2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .CI-4Above 10°F (-12°C) . . . . . . . . . . . . . . . . . . .15W-401
-10°F to 90°F 9-23°C to 32°C) . . . . . . . . . . .10W-302
Below 30°F(-1°C) . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .0W-30
2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .CJ-4Above 20°F (-7°C) . . . . . . . . . . . . . . . . . . . .15W-404
0°F to 50°F (-18°C to 10°C) . . . . . . . . . . . . . .10W-30Above -20°F (-29°C) . . . . . . . . . . . . . . . . . . . .5W-404
Below 50°F (10°C) . . . . . . . . . . . . . . . .0W-40/ 0W-30CAPACITY, Refill3: Liters QtGasoline . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.0Diesel . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.01 Preferred above 30°F (-1°C)2 Preferred from -10°F to 30°F (-23°C to -1°C)3 Capacity shown includes filter. After refill, check oil level.4 15W-40 and 5W-40 oils are recommended for above 50°F (10°C),
and must be used when towing a trailer or heavy duty driving.
TRANSMISSION/TRANSAXLEAutomaticLubricant . . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 7 .1 7.5Manual2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters Pt6-speed . . . . . . . . . . . . . . . . . . . . . . . 5.5 11.61 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MACAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Rear:
Dana 80 . . . . . . . . . . .Synthetic 75W-90 GL-5Dana S110/ S130 . . .Synthetic 75W-140 GL-5
10.5” axle . . . . . . . . .Synthetic 75W-140 GL-5★★CAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 2.8 5.8Rear:
10.5” axle . . . . . . . . . . . . . . . . . . . . 3.31 6.91
Dana S110, S130 . . . . . . . . . . . . . . 6.6 14.0Dana 80 . . . . . . . . . . . . . . . . . . . . . . 4.0 8.5
1 Add 8 oz. friction modifier Ford spec Est-M2C118-A for completeaxle fill.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Fluid:
2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
2001-08 FORD ESCAPE2001-06 MAZDA TRIBUTE2005-08 MERCURY MARINERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt2.0L, 2.3L . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52001-2004 3.0L . . . . . . . . . . . . . . . . . . 5.2 5.52005-08: 3.0L . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic2001-06 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5CAPACITY, Initial Refill1: Liters QtCD4E:
2001-04 . . . . . . . . . . . . . . . . . . . . . . 3.7 3.92005-08 . . . . . . . . . . . . . . . . . . . . . . 9.52 10.02
ECVT Hybrid . . . . . . . . . . . . . . . . . . . . 5.02 5.321 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Approximate. Total dry fill
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt2001-04 FWD . . . . . . . . . . . . . . . . . . . 2.7 5.7
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
CARS & LIGHT TRUCKS
122
FORD TRUCKS Continued
CAPACITY, Refill: Liters Pt2005-07 FWD . . . . . . . . . . . . . . . . . . . 2.3 4.9
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.12008 . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.1POWER TAKEOFF (Center Differential)
4WD w/AT . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . .Synthetic 75W-140
4WD w/MT . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.4 0.8DIFFERENTIAL, Rear . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.41 3.011 Fill to no higher than 1/4” - 9/16” below fill plug hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .MA
2002-07 FORD EXPLORER4-DOOR (EXCEPT SPORT-TRAC)2008 FORD EXPLORER,SPORT-TRAC2002-08 MERCURYMOUNTAINEER2003-05 LINCOLN AVIATORCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★4.0L: All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-30 4.6L: All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt4.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.6L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic 5R55W, 5R55S . . . . . . . . . . . . . . . . . . . . . . .MA56R60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MSPCAPACITY, Total fill1: Liters Qt5R55W:
2002-05 . . . . . . . . . . . . . . . . . . . . . . 12.02 12.72
5R55S2006 . . . . . . . . . . . . . . . . . . . . . . . 12.3 13.02007-08 . . . . . . . . . . . . . . . . . . . . . . 11.7 12.4
6R60 . . . . . . . . . . . . . . . . . . . . . . . 10.52 11.021 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Total fill shown. Transmission does not have a dipstick.
TRANSMISSION, Manual . . . . . . . . . . . .MACAPACITY, Refill: Liters PtMazda M50D-R4 . . . . . . . . . . . . . . . . 2.4 5.0TRANSFER CASE2002-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SLFCAPACITY, Refill: Liters PtExplorer . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Mountaineer:
2002 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.72003-04 AWD . . . . . . . . . . . . . . . . . 1.3 2.7
4WD . . . . . . . . . . . . . . . . . . . . . . 1.4 3.02005-08 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
DIFFERENTIALFront: . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90Rear:
ex. Limited-Slip . . . . . . . . . . . . . . . . . . . . .GL-5Limited-Slip . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All temperatures . . . . . . . . . . . . . . . . .Synthetic 75W-140CAPACITY, Refill: Liters PtFront:
Explorer:2002-05 . . . . . . . . . . . . . . . . . . . 1.7 3.62006-08 . . . . . . . . . . . . . . . . . . . 1.3 2.7
Mountaineer:2002 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.62003-08 . . . . . . . . . . . . . . . . . . . 1.3 2.7
Aviator . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Rear: Conventional . . . . . . . . . . . . . . . 1.72 3.62
Traction-Lok . . . . . . . . . . . . . . . . . . 1.72 3.621 Add 4 oz. of friction modifier for complete axle fill.2 Fill to 1/4” below fill plug hole.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir
2002-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA5
GEO, CHEVROLET-PONTIAC
1997-98 FIREFLY, METRO; 1998-2001 CHEVROLET METROCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt1997-01 . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.51 Preferred.2 1997-01, at temperatures below -20°F (-29°C), 5W-30 synthetic, or
0W-30 should be considered3 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 1.5 1.61 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . . GLSCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.0
1997-2002 PRIZMCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1.6L Code 6:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . .5W-301,2
1.8L Code 8:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt1.6L . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.21.8L . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.91 Preferred2 1997-02 all, at temperatures below -20°F (-29°C), 5W-30 synthetic,
or 0W-30 should be considered3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters Qt3-speed2 . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.64-speed . . . . . . . . . . . . . . . . . . . . . . . 3.13 3.331 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 to 5 minutes.Check fluid level and add fluid as needed.
2 3-speed final drive serviced separately3 Includes differential.
TRANSAXLE, Manual . . . . . . . . . . . . . . GLS CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0FINAL DRIVE . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Refill: Liters Pt3-speed AT . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
1997-2004 TRACKER,SUNRUNNERCRANKCASE . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt2.0L Code C . . . . . . . . . . . . . . . . . . . . 5.2 5.52.5L Code 4 . . . . . . . . . . . . . . . . . . . . 5.5 5.8All others . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.51 Temperatures below -20°F (-29°C), 5W-30 synthetic, or 0W-30
should be considered.2 Preferred.3 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters Qt3-speed . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.04-speed: 4WD . . . . . . . . . . . . . . . . . . . 2.5 2.6
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01 With the engine at operating temperature, shift transmission
through all gears. Let engine slow idle in PARK for 3 minutes ormore. Check fluid level and add fluid as needed.
TRANSMISSION, Manual . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt2-wheel drive:
1997-04 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.04-wheel drive . . . . . . . . . . . . . . . . . . . 1.5 3.2TRANSFER CASE . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6DIFFERENTIAL . . . . . . . . . . . . . . . . . . GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Rear . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
HONDA1997-2000 ACCORD, CIVIC, CR-V,DEL SOL, ODYSSEY, PRELUDE:INCLUDES ISUZU OASIS;PASSPORT—SEE ISUZUCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Accord:
1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
1998-2000 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
Civic ex. Si . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
Civic Si . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CR-V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
Del Sol DOHC VTEC . . . . . . . . . . . . . . . . . . . . . .10W-301
Del Sol Others . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
Odyssey . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
Prelude . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtAccord:
4-cyl:1997:
F22B1 eng. . . . . . . . . . . . . . . . . 4.3 4.5F22B2 eng. . . . . . . . . . . . . . . . . 3.8 4.0
1998-2000 . . . . . . . . . . . . . . . . . . 4.3 4.5V6 . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.6
Civic: D16Y7 eng. . . . . . . . . . . . . . . . . . . . 3.6 3.8D16Y5, D16Y8 eng. . . . . . . . . . . . . . 3.3 3.5B16A2 eng. . . . . . . . . . . . . . . . . . . . 4.0 4.2
CR-V . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0Del Sol:
ex. B16A2 eng . . . . . . . . . . . . . . . . . 3.3 3.5B16A2 eng. . . . . . . . . . . . . . . . . . . . 4.0 4.2
Odyssey, Oasis: 1997 . . . . . . . . . . . . . . . . . . . . . . . 3.3 4.01998-2000 . . . . . . . . . . . . . . . . . . . . 4.4 4.6
Prelude:2.2L: ex. VTEC . . . . . . . . . . . . . . . . . 3.8 4.0
VTEC . . . . . . . . . . . . . . . . . . . . . . 4.8 5.12.3L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
1 Preferred2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticCVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill1: Liters QtAccord:
4-cyl. . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.5V6:
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.91998-2000 . . . . . . . . . . . . . . . . . . 2.9 3.1
Civic, Del Sol:ex. CVT . . . . . . . . . . . . . . . . . . . . . . 2.7 2.9CVT . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
CR-V:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.94WD . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
Odyssey, Oasis: 1997-98 . . . . . . . . . . . . . . . . . . . . . . 2.4 2.51999-2000 . . . . . . . . . . . . . . . . . . . . 2.9 3.1
Prelude . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.51 With the engine at operating temperature, shift transmission
through all gears. Turn engine off and check fluid level within 1minute
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtAccord . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Civic, Del Sol:
ex. VTEC . . . . . . . . . . . . . . . . . . . . . 1.8 3.8VTEC . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
CR-V . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Prelude:
ex. VTEC . . . . . . . . . . . . . . . . . . . . . 1.9 4.0VTEC . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4
DIFFERENTIAL, RearCR-V . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTF
CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HB2001-08 ACCORD, 2001-08ODYSSEY, 2001 PRELUDE,2001 CR-V, 2000-06 INSIGHT,2000-08 S2000CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Accord & 2002-07 Odyssey:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
CR-V, Prelude:Above 15°F (-10°C) . . . . . . . . . . . . . . . . . . . . . .10W-30Below 95°F (35°) . . . . . . . . . . . . . . . . . . . . . . . .5W-304
Insight:All temperatures . . . . . . . . . . . . . . . . . . . . . . .0W-202, 4
2001 Odyssey:Above 20°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-304
123
CARS & LIGHT TRUCKSFORD TRUCKS Continued • GEO • HONDA
S2000:Above -5°F (-20°C) . . . . . . . . . . . . . . . . . . . . .10W-304
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-40CAPACITY, Refill3: Liters QtAccord:
2.3L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.4L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.43.0L:
2001-02 . . . . . . . . . . . . . . . . . . . . 4.4 4.62003-08 . . . . . . . . . . . . . . . . . . . . 4.3 4.5
CR-V . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0Insight . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6Odyssey . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5Prelude, S2000 . . . . . . . . . . . . . . . . . . 4.8 5.11 5W-30 may be used only if 5W-20 is not available2 5W-20 or 5W-30 may be used only if 0W-20 is not available3 Capacity shown includes filter. After refill, check oil level.4 Preferred
TRANSAXLECVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill1: Liters QtAccord:
2001-02:4-cyl. . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6V6 . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
2003-06:4-cyl. . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0V6 . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
2007:4-cyl. . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1V6 . . . . . . . . . . . . . . . . . . . . . . . 3.0 3.2
2008:4-cyl. . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0V6 . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5
CR-V:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.94WD . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
Insight . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5Odyssey:
2001 . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.12002-04 . . . . . . . . . . . . . . . . . . . . . . 3.3 3.52005-08 . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
Prelude . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.61 With the engine at operating temperature, shift transmission
through all gears. Turn engine off and check fluid level within 1minute
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtAccord:
2001-02 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02003-08:
4-cyl . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.06-cyl . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7
CR-V . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Insight . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Prelude . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4S2000:
2000-03 . . . . . . . . . . . . . . . . . . . . . . 1.5 3.22004-08 . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
DIFFERENTIAL, RearCR-V . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFS2000 . . . . . . . . . . . . . . . . . . . . . . .GL-5, GL-6All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtCRV . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2S2000 . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . .HB
2001-08 CIVIC, 2002-08 CR-V,2003-08 CIVIC HYBRID, 2003-08ELEMENT, 2003-08 PILOT, 2006-08 RIDGELINE, 2007-08 FITCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Civic (ex. SI), CR-V, Element, Pilot, Fit, Ridgeline:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
Civic SI:2002-05 All temperatures . . . . . . . . . . . . . . . . . .5W-202006-08 All temperatures . . . . . . . . . . . . . . . . . .5W-30
Hybrid:All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .0W-20
CAPACITY, Refill2: Liters QtCivic:
2001-02: D17A1 eng. . . . . . . . . . . . . . . . . . 3.0 3.2D17A2 eng. . . . . . . . . . . . . . . . . . 3.3 3.5
2003-05: . . . . . . . . . . . . . . . . . . . . . 4.2 4.4D17A2, D17A6 eng. . . . . . . . . . . 3.5 3.7D17A1 eng. . . . . . . . . . . . . . . . . . 3.2 3.4
2006-08:1.3L Hybrid . . . . . . . . . . . . . . . . . 3.2 3.41.8L . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.92.0L . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.6
CR-V . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4Element . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4Pilot:
2003-04 . . . . . . . . . . . . . . . . . . . . . . 4.8 5.12005-08 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
CAPACITY, Refill2: Liters QtFit . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.8Ridgeline . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51 5W-30 may be used only if 5W-20 is not available2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticCVT . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill1: Liters QtCivic:
2001-2005:ex. CVT . . . . . . . . . . . . . . . . . . . . 2.7 2.9CVT . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
2006-08 . . . . . . . . . . . . . . . . . . . . . . 2.4 2.5Hybrid . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1
CR-V:2002-06
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.14WD . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
2007-082WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.84WD . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.7
Element:2003-04:
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.14WD . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
2005-06:2WD . . . . . . . . . . . . . . . . . . . . . . . 3.2 3.44WD . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
2007-082WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.84WD . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.7
Pilot:2003-04 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22005 . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.92006-08:
2WD . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04WD . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5
Fit . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.5Ridgeline . . . . . . . . . . . . . . . . . . . . . . . 3.1 3.31 With the engine at operating temperature, shift transmission
through all gears. Turn engine off and check fluid level within 60-90seconds
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtCivic:
ex. Hybrid:2001-04 . . . . . . . . . . . . . . . . . . . . 1.5 3.42005-07 . . . . . . . . . . . . . . . . . . . . 1.5 3.4
Hybrid . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.4CR-V:
2002:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.44WD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8
2003-08 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Element . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Fit . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2TRANSFER CASE . . . . . . . . . . . .GL-4, GL-5Pilot, Ridgeline:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtPilot, Ridgeline . . . . . . . . . . . . . . . . . . 0.4 0.91 To identify, see tag on case
DIFFERENTIAL, RearCR-V, Element . . . . . . . . . . . . . . . . . . . . . . . .VTFPilot, Ridgeline . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt
CR-V:2001-02 . . . . . . . . . . . . . . . . . . . . 1.1 2.32003-06 . . . . . . . . . . . . . . . . . . . . 1.0 2.12007-08 . . . . . . . . . . . . . . . . . . . . 1.2 2.5
Element . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Pilot, Ridgeline . . . . . . . . . . . . . . . . 2.6 5.5
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . .HB
HYUNDAI1997-2008 ALL MODELSCRANKCASE . . . . . . . . . . . . . . . . .SL, API★1997-2004
Above 32°F (0°C) . . . . . . . . . . . . . . . .20W-40, 20W-50Above -10°F (-23°C) . . . . . . .10W-30, 10W-40, 10W-50Below 95°F (35°C) . . . . . . . . . . . . . . . . . .5W-30, 5W-40
2005-06:Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . .5W-20, 5W-302008 All . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
2007 Accent, Elantra, Santa FeAbove 20°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .20W-50Above 10°F (-13°C) . . . . . . . . . . . . . . . . . . . . . .15W-40Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . .5W-20, 5W-30
2007 TiburonAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
Azera, SonataAll temperatures . . . . . . . . . . . . . . . . . .5W-201, 5W-30
TucsonBelow 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 68°F (20°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-40Below -13° - -40°F (-25° - 40°C) . . . . . . . . . . . .10W-30Above -13°F (-25°C) . . . . . . . . . . . . . .10W-40, 10W-50
1 PreferredCAPACITY, Refill1: Liters QtAccent . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5Azera:
2006 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.02007 . . . . . . . . . . . . . . . . . . . . . . . 5.9 6.22008 . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.4
Elantra:1997-2003 . . . . . . . . . . . . . . . . . . . . 4.0 4.22004 . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02005-08 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
Entourage: . . . . . . . . . . . . . . . . . . . . . 5.2 5.5Santa Fe:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.7L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.73.3L . . . . . . . . . . . . . . . . . . . . . . . 5.9 6.23.5L:
2003 . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.62004-08 . . . . . . . . . . . . . . . . . . . . 4.3 4.5
Sonata: 2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.4L:
1999-03 . . . . . . . . . . . . . . . . . . . . 4.0 4.22004-05 . . . . . . . . . . . . . . . . . . . . 4.3 4.52006-08 . . . . . . . . . . . . . . . . . . . . 4.0 4.2
2.5L, 2.7L . . . . . . . . . . . . . . . . . . . . 4.5 4.73.0L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.23.3L
2006-07 . . . . . . . . . . . . . . . . . . . . 5.9 6.22008 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5
Tiburon:1.8L, 2.0L, 2.4L . . . . . . . . . . . . . . . . 4.0 4.22.7L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.7
XG 300, XG350 . . . . . . . . . . . . . . . . . . 4.3 4.5Tucson:
2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.7L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.7
Veracruz . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters QtAll Models:
1997-2000 . . . . . . . . . . . . . . . . . . . . 4.0 4.2Accent:
2001-08 (total fill): . . . . . . . . . . . . . . 6.1 6.5Azera . . . . . . . . . . . . . . . . . . . . . . . 10.9 11.5Elantra:
2001-06 . . . . . . . . . . . . . . . . . . . . . . 7.8 8.22007-08 . . . . . . . . . . . . . . . . . . . . . . 6.2
6.5Entourage . . . . . . . . . . . . . . . . . . . . . . 10.9 11.5Santa Fe:
2001-02: All (total fill) . . . . . . . . . . . . . . . . . . 8.5 8.9
2003-04:2.4L . . . . . . . . . . . . . . . . . . . . . . . 7.8 8.2
2003:2.7L . . . . . . . . . . . . . . . . . . . . . . . 8.5 8.93.5L . . . . . . . . . . . . . . . . . . . . . . . 10.4 11.0
2004:2.7L . . . . . . . . . . . . . . . . . . . . . . . 7.8 8.23.5L . . . . . . . . . . . . . . . . . . . . . . . 8.5 8.9
2005-06 . . . . . . . . . . . . . . . . . . . . . . 8.5 8.92007-08:
2.7L . . . . . . . . . . . . . . . . . . . . . . . 7.8 8.23.3L . . . . . . . . . . . . . . . . . . . . . . . 10.9 11.5
Sonata (total fill) . . . . . . . . . . . . . . . . . 7.8 8.22006-08:
4-Spd . . . . . . . . . . . . . . . . . . . . . . 7.8 8.25-Spd . . . . . . . . . . . . . . . . . . . . . . 10.9 11.5
XG300, XG350 (total fill) . . . . . . . . . . . 8.5 8.9Tiburon:
2001 (total fill) . . . . . . . . . . . . . . . . . 6.6 6.92003-08 . . . . . . . . . . . . . . . . . . . . . . 7.8 8.2
Tucson (total fill) . . . . . . . . . . . . . . . . 7.8 8.22007-08 . . . . . . . . . . . . . . . . . . . . . . 5.9 6.2
1 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in NEUTRAL and add fluid asneeded.
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90CAPACITY, Refill: Liters PtAccent:
1997-2005 . . . . . . . . . . . . . . . . . . . . 2.2 4.62006 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02007-08 . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
Elantra:2001-06 . . . . . . . . . . . . . . . . . . . . . . 2.1 4.42007-08 . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
Santa Fe:2001-02 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.92003:
2.4L, 2.7L . . . . . . . . . . . . . . . . . . . 2.1 4.53.5L . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.2
2004 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.52005 . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.92006-08 . . . . . . . . . . . . . . . . . . . . . . 2.1 4.5
CARS & LIGHT TRUCKS
124
HONDA Continued • HYUNDAI
CAPACITY, Refill: Liters PtSonata:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.81999-2005 . . . . . . . . . . . . . . . . . . . . 2.1 4.52006 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02007 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.52008 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.7
Tiburon:1997-2004 . . . . . . . . . . . . . . . . . . . . 2.2 4.62005-08:
w/ 5-speed . . . . . . . . . . . . . . . . . . 2.1 4.5w/ 6-speed . . . . . . . . . . . . . . . . . . 2.2 4.6
Tucson . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.6TRANSFER CASE . . . . . . . . . . . . . . . . .GL-5Veracruz . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtSanta Fe, Tucson, Veracruz . . . . . . . . . 0.8 1.7DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5Veracruz . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtRear:
Santa Fe . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Tucson . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5Veracruz . . . . . . . . . . . . . . . . . . . . . 0.9 2.0
OTHER COMPONENTSPower Steering:
1999-2008 . . . . . . . . . . . . . . . . . . . . . . . . . .PS1997-98 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF2
Brake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Master Cylinder . . . . . . . . . . . . . . . . . .HBWheel Bearings . . . . . . . . . . . . . . . . . . . . . . .LM
INFINITI1997-2006 ALL MODELS2007 G35, M35, M452007-08 FX35, FX45, QX562008 G37 2003-04 QX4—SEE NISSANCRANKCASE . . . . . . . . . . . . . . . . .SL, API★1997 J30:
Above 0°F (-18°C) . . . . . . . . . . . . . . .10W-301, 10W-40Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . .5W-301
Others:All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters QtFX35 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0FX45:
2003 . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.02004-05 . . . . . . . . . . . . . . . . . . . . . . 6.4 6.72006-08 . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
G20 . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.6G35 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0G37 . . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2M30 . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.6M35 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0M45:
2003-04 . . . . . . . . . . . . . . . . . . . . . . 5.6 5.92006-07 . . . . . . . . . . . . . . . . . . . . . . 5.5 5.8
I30 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2I35 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2J30 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5Q45:
1997-2002 . . . . . . . . . . . . . . . . . . . . 5.3 5.62003-06 . . . . . . . . . . . . . . . . . . . . . . 5.6 5.9
QX56 . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.61 Preferred for J30 2 Preferred for all others3 Capacity shown is with filter. After refill, check oil level
TRANSMISSION, TRANSAXLE, AutomaticG35, FX35, FX45, 2002-06 Q45,
QX56, M35, M45 . . . . . . . . . . . . . . . . . . . .SLF1
2007-08 FX35, FX45, QX56, M35, M45 . . .SLF1
2008 G37 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
All Others . . . . . . . . . . . . . . . . . . . . . . .AF2, AF32
CAPACITY Total Fill3: Liters QtFX35, FX45 . . . . . . . . . . . . . . . . . . . . . 10.3 10.5G20 . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.4G35, M35, M45 . . . . . . . . . . . . . . . . . . 10.3 10.9G37 . . . . . . . . . . . . . . . . . . . . . . . 10.3 10.5I30 . . . . . . . . . . . . . . . . . . . . . . . 9.4 9.9I35:
2002-03 . . . . . . . . . . . . . . . . . . . . . . 9.4 9.92004 . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0
J30 . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.8Q45:
1997-2001 . . . . . . . . . . . . . . . . . . . . 10.5 11.12002 . . . . . . . . . . . . . . . . . . . . . . . 10.1 10.72003-06 . . . . . . . . . . . . . . . . . . . . . . 10.3 10.9
QX56 . . . . . . . . . . . . . . . . . . . . . . . 10.6 11.21 Using automatic transmission fluid other than Genuine Nissan
Matic J ATF will cause deterioration in driveability and durability,and may damage transmission. which is not covered by the Infinitinew vehicle limited warranty.
2 1998-04 Continental USA & Alaska use Nissan Matic D, Canada useNissan ATF. Dexron III®-Mercon® maybe used as alternatives.
3 Total (dry) fill shown. When refilling measure amount drained & refillwith equal amount of new fluid. Start engine & allow transmissionto reach operating temperature. Move gearshift through all gearpositions ending with park. Check fluid level with dipstick.
TRANSAXLE, Manual1997 All . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-41
Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . .14030° to 100°F (-1° to 38°C) . . . . . . . . . . . . . . . . . . . . . .9010° to 85°F (-12° to 29°C) . . . . . . . . . . . . . . . . . . . .85WBelow 100°F (38°C) . . . . . . . . . . . . . . .75W-90, 80W-90Below 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . .80WBelow 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . .75W
1998-2001: I30, 2002 G20, G35 . . . . . . . . . . . . . .80W-90 GL-4
1999-2001: G20, G35 . . . . . . . . . .75W-90 GL-42003-07 G35 . . . . . . . . .75W-85, 75W-90 GL-4
G37 . . . . . . . . . . . . . .75W-85, 75W-90 GL-4CAPACITY, Refill: Liters PtG20:
1999-2002 . . . . . . . . . . . . . . . . . . . . 3.6 7.6G35 . . . . . . . . . . . . . . . . . . . . . . . 2.9 6.1G37 . . . . . . . . . . . . . . . . . . . . . . . 2.93 6.2I30:
1997-99:MT RS5F50V . . . . . . . . . . . . . . . . 4.3-4.5 9.1-9.5MT RS5F50A . . . . . . . . . . . . . . . . 4.5-4.8 9.5-10.1
2000-01 . . . . . . . . . . . . . . . . . . . . . . 4.5 9.51 At temperatures below 104°F (40°C) 75W-90 GL-4 preffered.
TRANSFER CASEFX35, FX45, QX56, M35 . . . . . . . . . . . . . . .AF31
CAPACITY, Refill: Liters PtFX35, FX45 . . . . . . . . . . . . . . . . . . . . . 1.2 2.5M35 . . . . . . . . . . . . . . . . . . . . . . . 1.25 2.64QX56 . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.31 Use Genuine Nissan Matic D ATF, or equivalent.
DIFFERENTIAL, Front . . . . . . .80W-90 GL-5 CAPACITY, Refill: Liters PtFX35, FX45 . . . . . . . . . . . . . . . . . . . . . 0.7 1.5M35 . . . . . . . . . . . . . . . . . . . . . . . 0.65 1.37G37 . . . . . . . . . . . . . . . . . . . . . . . 0.65 1.37QX56 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4DIFFERENTIAL, Rear . . . . . . . . . . . . .GL-51
Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .14030° to 100°F (-1° to 38°C) . . . . . . . . . . . . . . . . . . . . . . .9010° to 85°F (-12° to 29°C) . . . . . . . . . . . . . . . . . . . . . .85WBelow 100°F (38°C) . . . . . . . . . . . . . . . .75W-90, 80W-90Below 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .80WBelow 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .75W2007 FX35, FX45 . . . . . . . . . . . . . . . . . . . . . . . . .80W-902
2007 M35, M45, QX56, G35 . . . . . . . . . . . . . . . .80W-902
2008 QX56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-902008 G37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-902
CAPACITY, Refill: Liters PtFX35, FX45 . . . . . . . . . . . . . . . . . . . . . 1.4 3.0G35 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0M30 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7J30 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Q45:
1997-02 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.72003-06 . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
QX56 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.81 At temperatures above 104°F (40°C) 80W-90 GL-5 preferred.2 For hot climates SAE 90 is suitable for temperatures above 32°F
(0°C).
OTHER COMPONENTSPower Steering
1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . .AF32008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
Brake Master Cylinder . . . . . . . . . . . . . . . . . .HBActive Suspension System . . . . . . . . . . . . . .SLFLocks, Hinges, Door Latches . . . . . . . . . . . . .LM
ISUZU1997 RODEO, TROOPER,VEHICROSS; INCLUDES ACURASLX & HONDA PASSPORTHOMBRE—SEE CHEVROLET S10;OASIS—SEE HONDA ODYSSEYCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Trooper, SLX:
Above 5°F (-15°C) . . . . . . . .15W-40, 20W-40, 20W-5032° to 100°F (0° to 38°C) . . . . . . . . . . . . . . . . . . . . . .30-13°C to 100°F (-25° to 38°C) . . . . . . . . . . . . . .10W-305° to 60°F (-15° to 15°C) . . . . . . . . . . . . . . . . . . . . .20W-13° to 32°F (-25° to 0°C) . . . . . . . . . . . . . . . . . . . .10WBelow 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . . .5W-30
Amigo, Rodeo, Passport:Above 40°F (4°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .30Above 10°F (-12°C) . . . . . . . .15W-40, 20W-40, 20W-50Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill1: Liters Qt2.6L . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.13.2L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Capacity shown is without filter. When replacing filter, additional oil
may be needed.
TRANSMISSION, Automatic . . . . . . . . .AF3
CAPACITY, Total Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 8.7 9.21 Transmission does not have a dipstick.
TRANSMISSION, ManualBorg Warner T-5 . . . . . . . . . . . . . . . . . . . . . .AF3Others . . . . . . . . . . . . . . . . . . . . . . . . . . .SJ, SLAbove 90°F (32°C) . . . . . . . . . .15W-40, 20W-40, 20W-50All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill: Liters PtBorg Warner T-5 . . . . . . . . . . . . . . . . . 2.1 4.4Others . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.31 Preferred
TRANSFER CASE . . . . . . . . . . . .SJ, SL, SMAbove 90°F (32°C) . . . . . . . . . . . . . . . . .15W-40, 20W-40,
5W-30, 20W-50Capacity, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2DIFFERENTIAL1997 Trooper, SLX; front . . . . . . . . . . . . . . .GL-5Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .1400° to 90°F (-18° to 32°C) . . . . . . . . . . . . . . . . . . . . . . . .90Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .80WW/Saginaw rear axle . . . . . . . . . . . . . . . . . GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90All w/Limited-Slip Diff. . . . . . . . . . . . . . . .GL-5★★All Others . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .1400° to 90°F (-18° to 32°C) . . . . . . . . . . . . . . . . .80W-90, 90Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Rear . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8All w/Saginaw axle . . . . . . . . . . . . . . . 1.91 4.011 Saginaw axle has removable rear cover without fill plug.
1998-2004 AMIGO, RODEO,RODEO SPORT, TROOPER,VEHICROSS; INCLUDES ACURASLX & HONDA PASSPORT, 2002-04 AXIOM; HOMBRE—SEECHEVROLET S10; OASIS—SEEHONDA ODYSSEY2003-08 ASCENDER-SEECHEVROLET TRAILBLAZER2006-08 I280, I290, I350, I370—SEE CHEVROLET, GMC TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 40°F (4°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .301998-2004:
Above 10°F (-12°C) . . . . . . . .15W-40, 20W-40, 20W-50Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill1: Liters Qt2.2L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.43.2L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.23.5L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 Capacity shown is without filter. When replacing filter, additional oil
may be needed.
TRANSMISSION, Automatic1998-2003 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32004 Rodeo w/3.5L . . . . . . . . . . . . . . . . . . . .SLF2004 Others . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Total Refill: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 8.71 9.211 Transmission does not have a dipstick.
TRANSMISSION, ManualBorg Warner T-5 . . . . . . . . . . . . . . . . . . . . . .AF3Others . . . . . . . . . . . . . . . . . . . . . . . SJ, SL, SM
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Above 90°F (32°C) . . . . . . . . . .15W-40, 20W-40, 20W-50CAPACITY, Refill: Liters PtBorg Warner T-5 . . . . . . . . . . . . . . . . . 2.1 4.4Trooper, SLX . . . . . . . . . . . . . . . . . . . . 2.7 5.7Others . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3TRANSFER CASE1
All w/T.O.D. system . . . . . . . . . . . . . . .AF2, AF32WD Trooper & SLX . . . . . . . . . . . . . . .AF2, AF3Others . . . . . . . . . . . . . . . . . . . . . . .SJ, SL, SM
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Above 90°F (32°C) . . . . . . . . . .15W-40, 20W-40, 20W-50Capacity, Refill: Liters PtTrooper & SLX, 2WD . . . . . . . . . . . . . . 0.2 0.4Trooper, SLX, VehiCROSS
w/TOD . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Axiom . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Rodeo, Rodeo Sport . . . . . . . . . . . . . . 1.3 2.7Others . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.21 Extension gearbox on rear of transmission
DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 50°F (10°C) . . . . . . . . . . . . . .80W-90, 80W-140Below 90°F (30°C) . . . . . . . . . . . . . . . . . . . . . .75W-90
w/Saginaw rear axle . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90
125
CARS & LIGHT TRUCKSHYUNDAI Continued • INFINITI • ISUZU
All w/Limited-Slip Diff. . . . . . . . . . . . . . . .GL-5★★Others, rear . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . .1400° to 90°F (-18° to 32°C) . . . . . . . . . . . . . . .80W-90, 90Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtTrooper, SLX:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Rear . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3
VehiCROSS: Front . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Rear . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
CAPACITY, Refill: Liters PtRodeo, Rodeo Sport:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Rear . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8All w/Saginaw axle . . . . . . . . . . . . . 1.91 4.01
Others: Front . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Rear . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
1 Saginaw axle has removable rear cover without fill plug.
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . .AF2, AF3Brake & Clutch Master Cylinder . . . . . . . . . . .HBBrake, Clutch, Accelerator Linkage . . . . . . . .MOSuspension & Steering Linkage . . . . . . . . . . .LMUniversal Joints & Slip Yokes, 4WD . . . . . . . .LMWheel Bearings . . . . . . . . . . . . . . . . . . . . . . .GC
JAGUAR1997 XJ6, XJRCRANKCASE . . . . . . . . . . . . . . . . . . . .API★Above 32°F (0°C) . . . . . . . . . . . . . . . . . .15W-40, 15W-50,
20W-40, 20W-50Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-60-4° to 105°F (-20° to 40°C) . . . . . . . . . . .10W-30, 10W-40,
10W-50Above -25°F (-30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-50Below 105°F (40°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-40Below 52°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 15°F (-10°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters Qt1997:
XJ6 & XJR . . . . . . . . . . . . . . . . . . . . 7.5 7.91 Capacity shown includes filter, after refill check oil level.
TRANSMISSION, AutomaticXJ6 & XJS . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY: Liters Qt1997:
XJ6 4.0L Normally Aspirated:Drain & Refill . . . . . . . . . . . . . . . . 4.0 4.2
XJ6 4.0L Supercharged:Drain & Refill . . . . . . . . . . . . . . . . 7.3 7.7
TRANSMISSION, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0DIFFERENTIAL1997:
Standard Differential . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .90
Locking Differential . . . . . .Jaguar approved lubricant
CAPACITY, Refill: Liters Pt1997: XJ6. . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4OTHER COMPONENTSPower Steering:
XJ6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFXJS . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3
Brake Master Cylinder . . . . . . . . . . . . . . . . .HBH1997-2008 S-TYPE, XJ & XKSERIES, X-TYPECRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997:
Above 32°F (0°C) . . . . . . . . . . . . . . . .15W-40, 15W-50,20W-40, 20W-50
Above -4°F . . . . . . . . . . . . . . . . . . . . . .(-20°C) 10W-60-4° to 105°F (-20° to 40°C) . . . . . . . . . . . . . . . . 10W-30,
10W-30, 10W-40, 10W-50Above -25°F (-30°C) . . . . . . . . . . . . . . . . . . . . . .5W-50Below 105°F (40°C) . . . . . . . . . . . . . . . . . . . . . . .5W-40Below 52°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 15°F (-10°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
1998-99:13° to 127°F (-10° to 50°C) . . . . . . . . . . . . . . . .15W-40-5° to 127°F (-20° to 50°C) . . . . . . . . . . . . . . . .10W-30-24° to 127°F (-30° to 50°C) . . . . . . . . . . . . . . . .5W-30
2000-06:-22° to 122°F (-30° to 50°C) . . . . . . . . . . . . . . . .0W-30,
5W-301, 0W-40, 5W-402007 All Temperatures . . . . . . . . . . . . . . . . . . . . .5W-302008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
Meeting Spec:S-Type, XJ . . . . . . . . . . . . . . . . . . . .WSS-M2C-912AXK . . . . . . . . . . . . . . . . . . . . . . . . .WSS-M2C-913B
CAPACITY, Refill2: Liters Qt1997-99:
XK8:Less Oil Cooler . . . . . . . . . . . . . . 6.5 6.9w/Oil Cooler . . . . . . . . . . . . . . . . . 7.3 7.7
2000-02:XJ8 & XK8 . . . . . . . . . . . . . . . . . . . 6.5 6.9XKR . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9S-Type:
3.0 . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.34.0L . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
2001-02 XJR . . . . . . . . . . . . . . . . . . . . 7.5 7.92003:
XJ8 & XJR 4.0L . . . . . . . . . . . . . . . . 7.0 7.4XJR & XKR . . . . . . . . . . . . . . . . . . . . 7.5 7.9S-Type:
3.0L . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94.2L . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.3
XK Series 4.2L . . . . . . . . . . . . . . . . . 7.0 7.4X-Type 2.5L & 3.0L . . . . . . . . . . . . . 5.8 6.1
2004-08:S-Type:
3.0L . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94.2L:
2004-05 . . . . . . . . . . . . . . . . . . 6.0 6.32006-08 . . . . . . . . . . . . . . . . . . 6.5 6.9
XK Series 4.2L . . . . . . . . . . . . . . . . . 7.0 7.4X-Type:
2.5L & 3.0L2004-05 . . . . . . . . . . . . . . . . . . 5.8 6.1
3.0L2006-08 . . . . . . . . . . . . . . . . . . 5.9 6.22008 . . . . . . . . . . . . . . . . . . . . . 5.9 6.2
2004-07:XJ8 . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.2XJR . . . . . . . . . . . . . . . . . . . . . . . 7.6 8.0
2008:XJ Series . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
1 Preferred.2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, Automatic1997-2002:
XK Series:4.0L Normally Aspirated . . . . . . . . . . . . . .AE4.0L Supercharged . . . . . . . . . . . . . . . . .SLF
2003-07:XK Series: . . . . . . . . . . . . . . . . . . . . . . . . . SLF
1998-2003.5:XJ:
4.0L Normally Aspirated . . . . . . . . . . . . . .AE4.0L Supercharged . . . . . . . . . . . . . . . . .SLF
1999-2002.5 S-Type . . . . . . . . . . . . . . . . . . .MA52001-2007 X-Type . . . . . . . . . . . . . . . . . . . . .SLF2002.5-2007 S-Type . . . . . . . . . . . . . . . . . . .SLF2002-2003 XK8 . . . . . . . . . . . . . . . . . . . . . . . .AE2003.5-2007:
XJ: . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF2008 XK, XKR, XJ . . . . . . . . . . . . .Shell M1375.42008 S-Type . . . . . . . . . . . . . . . . .Shell M1375.42008 X-Type . . . . . . . . . . . . . .WSS-M2C922-A1CAPACITY, Initial Refill: Liters Qt1997 XK8 . . . . . . . . . . . . . . . . . . . . . . 1 1
1998:XJ8: Normally Aspirated . . . . . . . . . 10.0 10.6
Supercharged . . . . . . . . . . . . . . . 9.5 10.0XK8 . . . . . . . . . . . . . . . . . . . . . . . 1 1
1999:XJ8 . . . . . . . . . . . . . . . . . . . . . . . 10.0 10.6XK8: Normally Aspirated . . . . . . . . . 10.0 10.6
Supercharged . . . . . . . . . . . . . . . 9.5 10.0S-Type . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.5
2000:XJ8, XKR & XK8 . . . . . . . . . . . . . . . . 1 1
S-Type . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.52001:
S-Type . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.5X-Type . . . . . . . . . . . . . . . . . . . . . . . 8.8 9.3
2002-08:S-Type . . . . . . . . . . . . . . . . . . . . . . . 10.02 10.62
2001-03XK8 Normally Aspirated . . . . . . . . . 10.0 10.6
2002-08: X-Type . . . . . . . . . . . . . . . . . 8.82 9.32
2004-08: XJ Series 4.2L: . . . . . . . . . . . . . . . . 10.02 10.52
XK Series 4.2L:2003-08:w/o Supercharger . . . . . . . . . . . . 9.52 10.02
w/ Supercharger . . . . . . . . . . . . . 10.02 10.621 “Filled for life” design. No routine inspection is required, nor is a
dipstick provided.Fill to bottom of filler plug hole w/transmission atoperating temperature.
2 Capacities shown are total fill.
TRANSMISSION, Manual2002-05 X-Type . . . . . . . . . . . . . . . . . . . . . . .SLF2007-08 S-Type . . . . . . . . . . . . .WSS-M2C932-ACAPACITY, Maximum fill: Liters Pt2002-07: X-Type . . . . . . . . . . . . . . . . . 1.8 3.82007-08 S-Type . . . . . . . . . . . . . . . . . 1.6 3.4
DIFFERENTIAL1997: XK8 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .901998-99: XJ & XK8 . . . . . . . . . . . . . . . . . . . .GLS2000-03:
XJ & XK8 . . . . . . . . . . . . . . . . . . . . . . . . . .GLSS-Type . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . .Synthetic 75W-140X-Type . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . .Synthetic 75W-1402002-07:
S-Type . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . .Synthetic 75W-140
2000-05 XK8 . . . . . . . . . . . . . . . . . . . . . . . . .GLS2000-05: XKR . . . . . . . . . . . . . . . . . . . . . . . .GLS2007: XK series . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-1402002-06: X-Type . . . . . . . . . . . . . . . . . . . . ..GL-5
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-1402004-07: XJ8 & XJR . . . . . . . . . . . . . . . . . . GL-5
All temperatures . . . . . . . . . . . . . . .Synthetic 75W-1402008 All . . . . . . . . . . . .Synthetic 75W-140 GL-5CAPACITY, Refill: Liters Pt1997: XK8 . . . . . . . . . . . . . . . . . . . . . . 1.6 3.41998-2003.5 XJR & XJ8 . . . . . . . . . . . 1.9 4.01998-99: XJ8 . . . . . . . . . . . . . . . . . . . . 1.9 4.0
XK8 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.82000: XJ8 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0
XKR & XK8 . . . . . . . . . . . . . . . . . . . 1.8 3.8S-Type . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2001-02: XKR & XK8 . . . . . . . . . . . . . . 1.8 3.8S-Type . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2002-08: X-Type . . . . . . . . . . . . . . . . . 1.2 2.52003-08: S-Type . . . . . . . . . . . . . . . . . 1.3 2.72003.5-08: XJ8 & XJR . . . . . . . . . . . . . 1.3 2.72003-06: XK Series . . . . . . . . . . . . . . . 1.9 4.02007-08: XK Series . . . . . . . . . . . . . . . 1.3 2.7Transfer Case . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .SAE 75W-140CAPACITY: Liters PtX-Type 2.5L & 3.0L . . . . . . . . . . . . . . . 0.5 1.05OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3Brake Master Cylinder . . . . . . . . . . . . . . . . .HBH
JEEP1997-2001 CHEROKEE;2006-07 COMMANDER;
1997-2007 GRAND CHEROKEE;1997-2006 TJ, 1997-2007WRANGLERCRANKCASE . . . . . . . . . . . . . . . . . . .API★★2.4L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
2.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-301
3.0L Diesel: 2007 All Temperatures . . . . . . . . . . . . .5W-303.7L: 2005-06 All Temperatures . . . . . . . . . . . . . . .5W-30
2007 All Temperatures . . . . . . . . . . . . . . . . . . . . .5W-204.0L 2001-04: Above 0°F (-18°C) . . . . . . . . . . . . .10W-30
Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-304.7L ex. H.O.
2001-04 Above 0°F (-18°C) . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . .5W-30
2005-06 All Temperatures . . . . . . . . . . . . . . . . . .5W-302007 All Temperatures . . . . . . . . . . . . . . . . . . . . .5W-20
4.7L H.O. 2002-04: Above 0°F (-18°C) . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
5.2L, 5.9L: Above 0°F (-18°C) . . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30
5.7L 2005-07: All Temperatures . . . . . . . . . . . . . . .5W-206.1L 2006-07: All Temperatures . . . . . . . . . . . . . . .0W-402
Wrangler . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30, 5W-203
CAPACITY, Refill2: Liters Qt2.4L: 1997-2005 . . . . . . . . . . . . . . . . . 3.8 4.0
2006 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02.5L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.03.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.8L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.04.0L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.04.7L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L, 6.1L . . . . . . . . . . . . . . . . . . . . . . 6.6 7.05.2L, 5.9L . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Preferred2 Capacity shown includes filter. After refill, check oil level.3 Check Oil cap for correct oil viscosity.
TRANSMISSION, Automatic1997-2001 AW-4 . . . . . . . . . . . . . . . . . . . . . .MA1997-2003 All others . . . . . . . . . . . . . . . . . .AP41
2004 Grand Cherokee w/NAG1 . . . . . . . . . .SLF2
2004 All Others . . . . . . . . . . . . . . . . . . . . . . .AP42005 -06 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill3: Liters Qt1998-2001 Cherokee w/AW-4 . . . . . . . 1.9 2.01999-2001 45RFE4 . . . . . . . . . . . . . . . 4.7 5.02002-07 545RFE4 2WD . . . . . . . . . . . 5.2 5.5
CARS & LIGHT TRUCKS
126
ISUZU Continued • JAGUAR • JEEP
CAPACITY, Initial Refill3: Liters Qt545RFE4 4WD . . . . . . . . . . . . . . . . . . 6.2 6.62003 Grand Cherokee W5J400 . . . . . . 5.0 5.32004-07 NAG1 . . . . . . . . . . . . . . . . . . 5.0 5.3All others . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 DaimlerChrysler Corp. recommends that 32RH automatic transmis-
sion be serviced with ATF+4® automatic transmission fluid.2 DaimlerChrysler recommends Shell Part No. 3403 automatic trans-
mission fluid.3 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK or NEUTRAL and add fluid asneeded.
TRANSMISSION, Manual1997: Cherokee . . . . . . . . . . . . . . . . . . . . .GL-3
All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90All others . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-901998-2003:
All ex. NV3550 . . . . . . . . . . . . . . . . . . . . .GL-3All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
NV3550 . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2004-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt1997 2WD . . . . . . . . . . . . . . . . . . . . . . 3.3 7.01998-2000 2WD . . . . . . . . . . . . . . . . . 3.5 7.41996-2000 4WD . . . . . . . . . . . . . . . . . 3.3 7.02001-02 All . . . . . . . . . . . . . . . . . . . . . 3.3 7.01997-99 AX15 . . . . . . . . . . . . . . . . . . . 3.2 6.82000-01 NV3550: Cherokee . . . . . . . . 3.1 6.62000-02 Wrangler, TJ . . . . . . . . . . . . . 2.3 4.92003-05 Wrangler, TJ NV3500 . . . . . . 2.0 4.22004-05 NV1500 . . . . . . . . . . . . . . . . . 2.3 4.92005-07 NSG370 . . . . . . . . . . . . . . . . 1.5 3.1TRANSFER CASE1997-2000 ex. NV247 . . . . . . . . . .AF3, AP3, MA1999-2003 NV247 . . . . . . . . . . . . . . . . . . . . .SLF2001-03 ex. NV247 . . . . . . . . . . . . . . . . . . . .AP42004-07:
NV146, NV147, NV245, NV247 . . . . . . . . .SLFNV140, NV231, NV241, NV242 . . . . . . . . .AP4
CAPACITY, Refill: Liters Pt1998 Cherokee . . . . . . . . . . . . . . . . . . 1.3 2.7Model 140, 146 . . . . . . . . . . . . . . . . . . 0.6 1.3Model 145 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8Model 231 . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Model 241 . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2Model 242 . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Model 245 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8Model 147, 247, 249 . . . . . . . . . . . . . . 1.6 3.4DIFFERENTIALAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All w/Class III or IV hitch, Wrangler w/Trailer
Tow Pkg., Grand Cherokee w/Vari-Lok or Quadra Drive, 2005-06 Jeep Rubicon w/226 Axle Rear and Grand Cherokee . . .Synthetic 75W-1401
All Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-902007: Commander, Grand Cherokee . . . . . . . . .75W-140Wrangler: Ex w/towing package . . . . . . . . . . . . . .80W-90
w/towing package . . . . . . . . . . . . . . . . . . . .75W-140CAPACITY, Refill2: Liters PtFront:
Commander . . . . . . . . . . . . . . . . . . 1.73 3.63
Cherokee: 1997 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.71998-2001 Cherokee w/181 . . . . 1.5 3.2
Grand Cherokee: 1997-2003 . . . . . . . . . . . . . . . . . . 1.2 2.52004 . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.32005-07 . . . . . . . . . . . . . . . . . . . . 1.7 3.6
Wrangler, TJ 1997 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.41998-2006
w/181 . . . . . . . . . . . . . . . . . . . . 1.2 2.5w/216 . . . . . . . . . . . . . . . . . . . . 1.9 4.0
2007: w/186 . . . . . . . . . . . . . . . . . . 1.0 2.2w/216 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
Rear: Cherokee 4 w/8.25” axle . . . . . . . . . 2.0 4.2
1997-20018.25” axle2 . . . . . . . . . . . . . . . . 2.3 4.9Others . . . . . . . . . . . . . . . . . . . 1.2 2.5
Grand Cherokee, Commander1997
Model 94 . . . . . . . . . . . . . . . . . 1.6 3.4Model 216 . . . . . . . . . . . . . . . . 2.3 4.9
2004 186 . . . . . . . . . . . . . . . . . . . 1.1 2.32005-07 . . . . . . . . . . . . . . . . . . . . 1.7 3.6
198 RBI . . . . . . . . . . . . . . . . . . 1.7 3.6213R . . . . . . . . . . . . . . . . . . . . 2.0 4.2213RE . . . . . . . . . . . . . . . . . . . 2.2 4.6216 RBA, 226 RBA . . . . . . . . . . 2.3 4.9
Wrangler, TJ:1997-2006
216 RBI . . . . . . . . . . . . . . . . . . 1.9 4.0194, 198 RBI . . . . . . . . . . . . . . 1.7 3.6Others . . . . . . . . . . . . . . . . . . . 1.2 2.5
2007198 RBI . . . . . . . . . . . . . . . . . . 1.8 3.8226 RBI . . . . . . . . . . . . . . . . . . 2.3 4.9
1 Mopar Synthetic Gear Oil. All with limited-slip axles & GrandCherokee models w/Quadra Drive (front & rear axles), add 6.5%additive.
2 1997-2007 Models, fluid level must be 1/2” below fill plug opening.3 Commander with C200FE axle Add 4 oz of MOPAR Trac-Lok addi-
tive part No.4318060.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2008 COMMANDER, GRANDCHEROKEECRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★3.0L Diesel, All temperatures . . . . . . . . . . . . . . . . .5W-301
3.7L, 4.7L, 5.7L, All temperatures . . . . . . . . . . . . .5W-202
6.1L, All temperatures . . . . . . . . . . . . . . . . . . . . . .0W-403
CAPACITY, Refill4: Liters Qt3.0L . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.03.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.7L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.06.1L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.01 Meeting specification standard MS-11106 or Mercedes Benz MB
229.51.2 Meeting specification standard MS-6395.3 API SM or SM/CF meeting specification standard MS-10725.4 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt545RFE:
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.6
NAG1 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.31 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK or NEUTRAL and add fluid asneeded.
TRANSFER CASENV140 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4NV146 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFNV245 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtNV140, NV146 . . . . . . . . . . . . . . . . . . 0.65 1.4NV245 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8DIFFERENTIALAll . . . . . . . . . . . .Synthetic 75W-140 GL-5CAPACITY, Refill: Liters PtFront:
C200F . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6C200FE . . . . . . . . . . . . . . . . . . . . . . 1.71 3.61
Rear:C213R . . . . . . . . . . . . . . . . . . . . . . . 2.07 4.37C213RE . . . . . . . . . . . . . . . . . . . . . . . 2.241 4.7311 Add 4 oz. (118 ml) of friction modifier.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .PS11 Mopar® Hydraulic System Power Steering Fluid P/N 05142893 AA
or equivalent meeting standard MS-10838.
2002-08 LIBERTY, 2007-08 DODGE NITROCRANKCASEAll Gasoline . . . . . . . . . . . . . . . . . . . . . . . . .API★★2005-06 Diesel . . . . . . . . . . . . . . . .SL/CF API★★1
Gasoline2002-06
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-302
2007-083.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-203
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10W-303
DieselAll temperatures . . . . . . . . . . . . . . . . . .Synthetic 0W-404
CAPACITY, Refill5: Liters Qt2.8L Diesel . . . . . . . . . . . . . . . . . . . . . 6.0 6.33.7L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.04.0L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Meeting specification standard MS-10725.2 Preferred.3 Meeting specification standard MS-6395.4 If 0W-40 is not available, 5W-40 can be used.5 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt45RFE, 545RFE . . . . . . . . . . . . . . . . . . 4.7 5.042RLE . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0NAG1 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.31 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK or NEUTRAL and add fluid asneeded.
TRANSMISSION, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtNV1500 . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8NV3550 Ex. 2004 . . . . . . . . . . . . . . . . 2.3 4.8NV3550 2004: 2WD . . . . . . . . . . . . . . 2.2 4.6
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2NSG370 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.17TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4
CAPACITY, Refill1: Liters PtMP130, MP140, MP143 . . . . . . . . . . . 0.85 1.8NV231 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0NV241 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2NV242 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.3MP1522 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8CAPACITY, Refill1: Liters PtMP3022 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.01 Approximate dry fill, or fill to bottom of fill plug hole.
DIFFERENTIALFront:2002-03 . . . . . . . . . . . .Synthetic 75W-140 GL-52004-08 . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Rear1:2002-06:
w/o trailer towing . . . . . . . . . . . . . . . . .75W-90 GL-5w/ trailer towing Synthetic . . . . . . . .75W-140 GL-5
2007-08 . . . . . . . . . . . .Synthetic 75W-140 GL-5CAPACITY, Refill: Liters PtFront:
186 FIA (Model 30) . . . . . . . . . . . . . 1.24 2.6Rear:
198 RBI (Model 35) . . . . . . . . . . . . . 1.78 3.768 1/4” . . . . . . . . . . . . . . . . . . . . . . . 2.08 4.4
1 Models equipped with Trac-lok axles, add 4.0 oz. of limited slipadditive to the lubricant.
OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AP4
2007-08 COMPASS, PATRIOTCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . .5W-20, 5W-301,2
CAPACITY, Refill3: Liters Qt2007 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52008 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Meeting specification standard MS-6395.2 Check oil cap for proper engine oil viscosity usage.3 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTFCAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill Liters PtNVT355 . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7BG6 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2Getrag DMT6 . . . . . . . . . . . . . . . . . . . 1.8 3.81 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
REAR CARRIER, POWER TRANSFER UNITAll . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . .AP4
2008 WRANGLERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
CAPACITY, Refill2: Liters Qt3.8L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Meeting specification standard MS-6395.2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Initial Refill1: Liters Qt45RFE, 545RFE:
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
42RLE . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSMISSION, ManualNSG 370 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill1: Liters PtNSG 370 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.171 Approximate dry fill, or fill to bottom of fill plug hole.
TRANSFER CASENV241 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtNV241 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Rear1:
w/ towing pkg. . . . . . . . . . . . . . . . . .Synthetic 75W-140w/o towing pkg. . . . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtFront:
186 FBI (Model 30) . . . . . . . . . . . . . 1.0 2.1216 FBI (Model 44) . . . . . . . . . . . . . 1.3 2.7
Rear . . . . . . . . . . . . . . . . . . . . . . . 2.25 4.751 Models equipped with Trac-lok axles, add 3.4 oz. of limited slip
additive to the lubricant.
OTHER COMPONENTSBrake/Clutch Fluid Reservoir . . . . . . . . . . . . .HBPower Steering Fluid Reservoir . . . . . . . . . .AP4
127
CARS & LIGHT TRUCKSJEEP Continued
KIA1997-2001 SEPHIA2000-08 SPECTRACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2004-08 Spectra 2.0L:
Above 14°F(-10°C) . . . . . . . . . . . . . . . . . . . . . .15W-40-13°F to 104°F(-25°C to 40°C) . . . . . . . . . . . . . .10W-30Above -13°F (-25°C) . . . . . . . . . . . . . . . . . . . . .10W-40Below 68°F (20°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-40Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
1997-2001 Sephia, 2000-04 Spectra 1.8L:Above 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .40Above 15°F (-9°C) . . . . . . . . . . . . . . . .20W-40, 20W-50Above -15°F (-25°C) . . . . . . . . . . . . . .10W-40, 10W-5032° to 105°F (0° to 39°C) . . . . . . . . . . . . . . . . . . . . .30W15° to 65°F (-9° to 20°C) . . . . . . . . . . . . . . . . . .20W-20-15° to 85°F (-25° to 29°C) . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below -5°F (-20°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill: Liters Qt1997 Sephia: 1.6L . . . . . . . . . . . . . . . . 3.01 3.21
1.8L . . . . . . . . . . . . . . . . . . . . . . . 3.61 3.81
1998-2008 Sephia & Spectra . . . . . . . 4.02 4.221 Capacity shown does not include filter. When replacing filter, addi-
tional oil may be needed.2 Capacity includes filter.
TRANSAXLE, Automatic:1997-2000 Sephia . . . . . . . . . . . . . . . . .AF3, MA2001 Sephia . . . . . . . . . . . . . . . . . . . . . . . . .SLFSpectra . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY,Total Fill1: Liters Qt1997 Sephia: 1.6L . . . . . . . . . . . . . . . . 5.8 6.1
1.8L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.31998-2004 Sephia & Spectra 1.8L . . . 5.4 5.72004-05 Spectra w/2.0L . . . . . . . . . . . 7.8 8.22006-08 Spectra . . . . . . . . . . . . . . . . . 6.2 6.51 Total or dry fill capacity shown, use less fluid when refilling.
TRANSAXLE, Manual1997-2001 Sephia . . . . . . . . . . . . . . .GL-4, GL-52000-08 Spectra . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtSephia & Spectra w/1.8L . . . . . . . . . . 2.7 5.72004-08 Spectra w/2.0L . . . . . . . . . . . 2.2 4.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
1996-2001 . . . . . . . . . . . . . . . . . . . . . . . . .AF32002-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
1997-2002, 2005-07 SPORTAGE;2003-08 SORENTOCRANKCASE . . . . . . . . . . . . . . . . . . .API★★1997-2002 Sportage:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Above 0°F (-18°C) . . . . . . . . . . . . . . . .10W-30, 10W-40
2005-07 Sportage:All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Above 9°F (-13°C) . . . . . . . . . . . . . . . . . . . . . . .15W-40Above 19°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .20W-50
2003-06 Sorento:Above 14F (-10) . . . . . . . . . . . . . . . . .20W-40, 20W-50Above 5°F (-15°C) . . . . . . . . . . . . . . . .15W-50, 15W-40Above -13F (-25°C) . . . . . . . . . . . . . . .10W-40, 10W-50-15° to 104°F (-25° to 40°F) . . . . . . . . . . . . . . . .10W-30Below 68°F (20°C) . . . . . . . . . . . . . . . . . . . . . . .5W-401
Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . .5W-301
Below 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . .5W-201,2
2007-08 Sorento:All temperatures . . . . . . . . . . . . . . . . . .5W-203, 5W-30Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Above 9°F (-13°C) . . . . . . . . . . . . . . . . . . . . . . .15W-40Above 19°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .20W-50
1 Restricted by driving condition and environment.2 Not recommended for sustained high speed vehicle operation.3 Preferred.CAPACITY, Refill1: Liters QtSportage:
1997-2002 . . . . . . . . . . . . . . . . . . . . 4.2 4.42005-07:
2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.7L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8
Sorento:2003-06 . . . . . . . . . . . . . . . . . . . . . . 4.4 4.72007-08 . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
1 Capacity includes filter.
TRANSAXLE, AutomaticSportage: 1997-2002 . . . . . . . . . . . . . . . . . . AF3
2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . SLFSorento: 4 speed . . . . . . . . . . . . . . . . . . . . . AF2
5 speed . . . . . . . . . . . . . . . . . . . . . . . . . . . SLFCAPACITY,Total Fill1: Liters Qt1997 Sportage . . . . . . . . . . . . . . . . . . 6.6 7.01998-2000 Sportage . . . . . . . . . . . . . . 6.3 6.7
CAPACITY,Total Fill1: Liters Qt2001-02 Sportage . . . . . . . . . . . . . . . . 6.8 7.22005-07 Sportage . . . . . . . . . . . . . . . . 7.8 8.22003-04 Sorento . . . . . . . . . . . . . . . . . 10.2 10.82005-06 Sorento . . . . . . . . . . . . . . . . . 10.0 10.62007 Sorento . . . . . . . . . . . . . . . . . . . 10.9 11.52008 Sorento . . . . . . . . . . . . . . . . . . . 10.0 10.61 Total or dry fill capacity shown, use less fluid when refilling.
TRANSAXLE, Manual . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90
2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-85 CAPACITY, Refill: Liters PtSportage:
1997-2002:2WD . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.04WD . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5
2005-07 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7Sorento:
2WD . . . . . . . . . . . . . . . . . . . . . . . 3.2 6.84WD . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7
TRANSFER CASE1997-2002 . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-902003-05 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32006-07 Sportage . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtSportage:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.81999-2002 . . . . . . . . . . . . . . . . . . . . 1.7 3.62005-07 . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7
Sorento . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0DIFFERENTIAL, 4WD . . . . . . . . . . . . . .GL-52008 Sorento
w/o Limited slip . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90w/ Limited slip . . . . . . . . . . . . . . . . . . . . . . . . . .85W-90
All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90, 90CAPACITY, Refill: Liters PtSportage:
1997-2002:Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2005-07 Rear . . . . . . . . . . . . . . . . . 0.8 1.7Sorento:
2008 Rear . . . . . . . . . . . . . . . . . . . . 1.6 3.4OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
1997-2001 . . . . . . . . . . . . . . . . . . . . . . . . .AF32002-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
2004-08 AMANTI;2001-08 OPTIMA;2002-08 SEDONA;2007-08 RONDOCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2002-05 Sedona, 2001-06 Optima (Old Body Style), 2004-06 Amanti:
Above 14F (-10) . . . . . . . . . . . . . . . . .20W-40, 20W-50Above 5°F (-15°C) . . . . . . . . . . . . . . . .15W-50, 15W-40Above -13F (-25°C) . . . . . . . . . . . . . . .10W-40, 10W-50-15° to 104°F (-25° to 40°F) . . . . . . . . . . . . . . . .10W-30Below 68°F (20°C) . . . . . . . . . . . . . . . . . . . . . . .5W-401
Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . .5W-301
Below 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . .5W-201,2
2007-08 Amanti, Rondo:All temperatures . . . . . . . . . . . . . . . . . .5W-203, 5W-30Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30
2006-08 Sedona:All temperatures . . . . . . . . . . . . . . . . . .5W-203, 5W-30Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30
2006-08 Optima (New Body Style) 2.4L:All temperatures . . . . . . . . . . . . . . . . . .5W-203, 5W-30Above 20°F (-7°C) . . . . . . . . . . . . . . . .20W-40, 20W-50Above 10°F (-13°C) . . . . . . . . . . . . . . .15W-40, 15W-50Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30
2006-08 Optima (New Body Style) 2.7L:All temperatures . . . . . . . . . . . . . . . . . .5W-203, 5W-30Above 20°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .20W-50Above 10°F (-13°C) . . . . . . . . . . . . . . . . . . . . . .15W-40Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30
CAPACITY, Refill: Liters QtAmanti:
2004-06 . . . . . . . . . . . . . . . . . . . . . . 4.34 4.54
2007-08 . . . . . . . . . . . . . . . . . . . . . . 5.2 5.52001-06 Optima:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.34 4.54
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.25 4.45
2.7L . . . . . . . . . . . . . . . . . . . . . . . 4.84 5.14
2007-08 Optima:2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.7L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.7
2007-08 Rondo: 2.4L . . . . . . . . . . . . . 4.34 4.54
2.7L . . . . . . . . . . . . . . . . . . . . . . . 4.24 4.44
2002-05 Sedona: . . . . . . . . . . . . . . . . 4.35 4.55
2006-08 Sedona: . . . . . . . . . . . . . . . . 5.26 5.561 Restricted by driving condition and environment.2 Not recommended for sustained high speed vehicle operation.
3 Preferred.4 Capacity includes filter.5 Capacity shown does not include filter. When replacing filter, addi-
tional oil may be needed.6 Manufacturer does not specify if capacity includes filter.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Total Fill1: Liters Qt2007-08 Rondo: 2.4L . . . . . . . . . . . . . 7.8 8.2
2.7L . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.02002-06 Amanti . . . . . . . . . . . . . . . . . 8.5 9.02007-08 Amanti . . . . . . . . . . . . . . . . . 10.9 11.52001-06 Optima . . . . . . . . . . . . . . . . . 7.8 8.22007-08 Optima . . . . . . . . . . . . . . . . . 9.5 10.02002-05 Sedona . . . . . . . . . . . . . . . . . 8.5 9.02006-08 Sedona . . . . . . . . . . . . . . . . . 10.9 11.51 Total or dry fill capacity shown, use less fluid when refilling.
TRANSAXLE, Manual . . . . . . . . GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt2001-06 Optima . . . . . . . . . . . . . . . . . 2.1 4.42007-08 Optima . . . . . . . . . . . . . . . . . 2.0 4.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
2001 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32002-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
2001-2007 RIO, RIO CINCOCRANKCASE . . . . . . . . . . . . . . . . . . .API★★2006-07 Rio, Rio5:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-201
Above 20°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .20W-50Above 10°F (-13°C) . . . . . . . . . . . . . . . . . . . . . .15W-40Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30
2001-05 Rio, Rio Cinco:Above 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .40Above 15°F (-9°C) . . . . . . . . . . . . . . . .20W-40, 20W-50Above -15°F (-25°C) . . . . . . . . . . . . . .10W-40, 10W-5032° to 105°F (0° to 39°C) . . . . . . . . . . . . . . . . . . . . . .3015° to 65°F (-9° to 20°C) . . . . . . . . . . . . . . . . . .20W-20-15° to 85°F (-25° to 29°C) . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below -5°F (-20°C) . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill: Liters Qt2001-05 . . . . . . . . . . . . . . . . . . . . . . . 3.22 3.42
2006-07 . . . . . . . . . . . . . . . . . . . . . . . 3.32 3.521 Preferred.2 Capacity includes filter.
TRANSAXLE, Automatic . . . . . . . . . . . .SLFCAPACITY, Total Fill1: Liters Qt2001-05 . . . . . . . . . . . . . . . . . . . . . . . 5.9 6.22006-07 . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.51 Total or dry fill capacity shown, use less fluid when refilling.
TRANSAXLE, Manual . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90
2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-85CAPACITY, Refill: Liters Pt2001-05 . . . . . . . . . . . . . . . . . . . . . . . 2.8 5.92006 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02007 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
LAND ROVER1997 DEFENDERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
Above 14°F (-10°C) . . . . . . . .10W-40, 10W-50, 10W-60Below 122°F (50°C) . . . . . . . . . . . . . . . . .5W-40, 5W-50Below 95°F (35°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30 -4° -95°F (-20° to 35°C) . . . . . . . . . . . . . . . . . . 10W-30
CAPACITY, Refill1: Liters QtDefender . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.91 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .AF3CAPACITY, Refill1: Liters QtDefender . . . . . . . . . . . . . . . . . . . . . . . 9.1 9.61 Dry or total fill shown, use less fluid when refilling.
TRANSMISSION, ManualDefender . . . . . . . . . . . . . . . . . . . . . . . . . . . . .FACAPACITY, Refill: Liters PtDefender . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7TRANSFER CASEDefender . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL5All temperatures . . . . . . . . . . . . . . . . . . . . . .80W, 80W-90CAPACITY, Refill: Liters PtDefender . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.8DIFFERENTIAL . . . . . . . . . . . . . . . . . . . .EPAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtDefender:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Rear . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3
CARS & LIGHT TRUCKS
128
KIA • LAND ROVER
Brake Master Cylinder . . . . . . . . . . . . . . . . .HBHFront Axle Hubs . . . . . . . . . . . . . . . .GL-4, GL-5
Above -4°F (-20°C), . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . .80W
Steering & Suspension Fittings . . . . . . . . . . .LM
1997-2000 DISCOVERY & RANGEROVER, 2001-03 DISCOVERY,2001-07 RANGE ROVER, 2006-07RANGE ROVER SPORT, 2002-05FREELANDER, 2005-07 LR3CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997-2000 DISCOVERY, RANGE ROVER:
1997-2000:Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . .10W-40,
10W-50, 10W-60Below 122°F (50°C) . . . . . . . . . . . . . . .5W-40, 5W-50Below 95°F (35°C) . . . . . . . . . . . . . . . . . . . . . .5W-30-4° to 95°F (-20° to 35°C) . . . . . . . . . . . . . . . .10W-30
2001-03 DISCOVERY:All temperatures . . . . . . . . . . . . . . . . . . .5W-40, 5W-50Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-60Above -4°F (-20°C) . . . . . . . . . . . . . . .10W-40, 10W-50Below 95°F (35°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30-4° to 95°F (-20° to 35°C) . . . . . . . . . . . . . . . . .10W-30
2001-07 RANGE ROVER, 2006-07 RANGE ROVERSPORT:
2001-02:All temperatures . . . . . . . . . . . . . . . . . . . . . . ., 5W-50Above 32°F (0°C) . . . . . . . . . . . . . .15W-40, 15W-50,
20W-40, 20W-50Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . .10W-40,
10W-50, 10W-6014° to 95°F (-10° to 35°C), . . . . . . . . . . . . . . . .10W30Below 113°F (45°C) . . . . . . . . . . . . . . . . . . . . .5W-40Below 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . .5W-20
2003:All temperatures . . . . . . . . . . . . . . . . .5W-40, 5W-50Above -4°F (-20°C) . . . . . . . . . . . . .10W-40, 10W-50-4° to 95°F (-20° to 35°C) . . . . . . . . . . . . . . . .10W-30Below 95°F (35°C), . . . . . . . . . . . . . . . . . . . . . .5W-30Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . .10W-60
2004-06:All temperatures . . . . . . . . . . .5W-40, 5W-50, 0W-40-30°C to 35°C (-22°F to 95°F) . . . . . . . . . . . . .0W-30Below 35°C (95°F) . . . . . . . . . . . . . . . . . . . . . .5W-30Above -20°C(-4°F) . . . . . . . . . . . . . . . . . . . . .10W-40
2007: All temperatures . . . . . . . . . . . . . . . . . . . .5W-302002-07 FREELANDER:
All temperatures . . . . . . . . . . . . . . . . . . .0W-40, 0W-50,0W-60, 5W-40, 5W-50, W-60
Below 35°C(95°F) . . . . . . . . . . . . . . . . . .0W-30, 5W-30-20°C to 35°C(-4°F to 95°F) . . . . . . . . . . . . . . . .10W-30Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-40,
10W-50, 10W-602005-07 LR3:All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . 5W-30CAPACITY, Refill1, 2 Liters Qt2002-05: Freelander w/ Oil Cooler . . . 5.2 5.5LR3:
2005-06 . . . . . . . . . . . . . . . . . . . . . . 7.5 7.92007 4.0L . . . . . . . . . . . . . . . . . . . . 5.7 6.02007 4.4L . . . . . . . . . . . . . . . . . . . . 7.7 8.1
Range Rover & Range Rover Sport:
1997-2000 4.0L . . . . . . . . . . . . . . 5.8 6.11997-2002 4.6L . . . . . . . . . . . . . . 5.8 6.12003-05 4.4L . . . . . . . . . . . . . . . . 8.5 9.02006-07:
4.2L . . . . . . . . . . . . . . . . . . . . . 7.7 8.14.4L . . . . . . . . . . . . . . . . . . . . . 7.7 8.1
1997-2003: Discovery: w/ Oil Cooler . . . . . . . . . . . . . . . . . . 6.2 6.6ex. Oil Cooler . . . . . . . . . . . . . . . . . . 5.8 6.1
1 Capacity shown is with filter. After refill, check oil level. Capacitiesshown are approximate and provided as a guide only. All oil levelsmust be checked using the dipstick or level plugs as applicable.
2 Manufacturer recommends the use of synthetic oils only.
TRANSMISSION, Automatic2002-05 Freelander . . . . . . . . . . . . . . . . . . . .SLF2003-05 Range Rover:
ZF Auto Gearbox . . . . . . . . . . . . . . . . . . . . .AEGM Auto Gearbox . . . . . . . . . . . . . . . . . . .SLF
2006-07 Range Rover, Range Rover Sport .SLF2006-07 LR3 . . . . . . . . . . . . . . . . . . . . . . . . .SLFOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Refill1, 2 Liters Qt2002-04 Freelander . . . . . . . . . . . . . . . 8.6 9.11997-2003 Discovery . . . . . . . . . . . . . 9.3 9.82005-07 LR3 . . . . . . . . . . . . . . . . . . . . 9.5 10.0Range Rover & Range Rover Sport:
1997-05 . . . . . . . . . . . . . . . . . . . . 9.9 10.52006-07 . . . . . . . . . . . . . . . . . . . . 9.5 10.0
1 Capacities shown are approximate and provided as a guide only. Alloil levels must be checked using the dipstick or level plugs as appli-cable.
2 Dry or total fill shown, use less fluid when refilling. With engine atoperating temperature, shift through all gears. Check fluid level inPARK and add fluid as needed.
TRANSMISSION, Manual1997-98 Discovery . . . . . . . . . . . . . . . . .FA, AF31997 All others . . . . . . . . . . . . . . . . . . . .FA, AF31997-2000 All others . . . . . . . . . . . . . . . . . . . .FACAPACITY, Refill: Liters Pt1997-98 Discovery . . . . . . . . . . . . . . . 2.7 5.7TRANSFER CASEFreelander, LR3 . . . . . . . . . . . . . . . . . . . . . . .GLS1997-98 Discovery . . . . . . . . . . . . . . . . . . .GL-51999-2003 Discovery . . . . . . . . . . . . . . . . . .GLS1997-2002 Range Rover . . . . . . . . . . . . . . . .AF32003-07 Range Rover, Range Rover Sport .GLSCAPACITY, Refill: Liters Pt2002-05 Freelander . . . . . . . . . . . . . . . 1.1 2.32005-07 LR3 . . . . . . . . . . . . . . . . . . . . 1.5 3.2Range Rover & Range Rover Sport:
1997-2002 . . . . . . . . . . . . . . . . . . 2.0 4.12003-05 NV225 . . . . . . . . . . . . . . 1.0 2.02006-07 . . . . . . . . . . . . . . . . . . . . 1.5 3.2
Discovery: 1997-98 . . . . . . . . . . . . . . . 2.3 4.81999-2005 . . . . . . . . . . . . . . . . . . . . 2.0 4.1
DIFFERENTIAL, FRONT & REAR2005-07 LR3 . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . 75W-902007 Range Rover, Range Rover Sport . . . .GLS1999-2006 ex LR3 . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-901997-98 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . EPAll temperatures . . . . . . . . . . . . . . . . . . 80W, 90, 80W-90CAPACITY, Refill: Liters Pt2005-07 LR3: Front . . . . . . . . . . . . . . . 0.6 1.3
Rear, Open diff . . . . . . . . . . . . . . . . . 1.1 2.3Electronic torque . . . . . . . . . . . . . 1.5 3.2
2002-05 Freelander1, rear . . . . . . . . . . 0.8 1.71997-03 Discovery, front & rear . . . . . . 1.6 3.4Range Rover:
1997-2002 Front & rear . . . . . . . . . . . . . . . . . 1.7 3.6
2003-06:Front . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Rear . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1
2007 Front . . . . . . . . . . . . . . . . . . . . 0.8 1.7Rear:
Open Diff . . . . . . . . . . . . . . . . . 1.1 2.3Electronic Torque . . . . . . . . . . . 1.6 3.4
2006 Range Rover Sport:Front . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.1Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2007 Front . . . . . . . . . . . . . . . . . . . . . 0.6 1.1Rear
Open Diff . . . . . . . . . . . . . . . . . . . 1.1 2.3Electronic Torque . . . . . . . . . . . . . 1.5 3.2
1 Front Differential is incorporated in the Intermediate ReductionDrive.
OTHER COMPONENTSPower Steering: 1997-98 All . . . . . . . . . . . . . . . . . . . . . . . . . .AF32002-05 Freelander . . . . . . . . . . . . . . . . . . . .AF32005-07 LR3 . . . . . . . . . . . . . . . . . . . . . . . . . .PS1999-2002 Range Rover . . . . . . . . . . . . . . . .AF32003-07 Range Rover . . . . . . . . . . . . . . . . . . .PS2006-07 Range Rover Sport . . . . . . . . . . . . . .PSDiscovery . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HB1
Front Axle Hubs . . . . . . . . . . . . . . . .GL-4, GL-5Above -4°F (-20°C), . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 50°F (-10°C) . . . . . . . . . . . . . . . . . . . . . . . .80W
Steering & Suspension Fittings . . . . . . . . . . .LM1 Use fluid meeting DOT 4 requirements.
2008 LR2CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .0W-301CAPACITY, Refill2: Liters Qt3.2L . . . . . . . . . . . . . . . . . . . . . . . 7.7 8.11 Meeting ACEA A5 or B5 specification.2 Capacity shown is with filter. After refill, check oil level. Capacities
shown are approximate and provide as a guide only. All oil levelsmust be checked using the dipstick or level plugs as applicable.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV CAPACITY, Total Fill1,2: Liters QtAWF21 6-speed . . . . . . . . . . . . . . . . . 7.0 7.41 Capacity show is dry/total fill.2 Capacity shown is with filter. After refill, check oil level. Capacities
shown are approximate and provide as a guide only. All oil levelsmust be checked using the dipstick or level plugs as applicable.
TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.75 1.3DIFFERENTIALFront: . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSRear: . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtFront: . . . . . . . . . . . . . . . . . . . . . . . 0.75 1.3Rear: . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.2OTHER COMPONENTS
Brake Fluid Reservoir . . . . . . . . . . . . . . . . .HBH1
Power Steering Reservoir . . . . . . . . . . . . . . . .PS1 If the fluid shown is not available, use a low viscosity DOT 4 brake
fluid meeting ISO 4925 Class 6 and Land Rover LRES22BF03requirements.
LEXUS1997-2007 GS300, GS400,GS430, IS250, IS300, IS350,IS35C, LS400, LS430, SC300,SC400, SC430; 1997-2003 ES300; 2004-06 ES330; 2007-08 ES350,GS350, GS450H, LS460, LS600HCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
2008 LS460, LS600H . . . . . . . . . . . . . . . .5W-20, 0W-202
1998-2008:All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtGS300:
1997-2005 . . . . . . . . . . . . . . . . . . . . 5.4 5.72006:
2WD . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.74WD . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.8
GS3502WD . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.74WD . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.8
IS250:2WD . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.6AWD . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.8
IS300, IS350 . . . . . . . . . . . . . . . . . . . . 5.4 5.7IS350 . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.6GS400, GS430 . . . . . . . . . . . . . . . . . . 5.2 5.5GS450H . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.7SC300 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5SC400 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0SC430:
2002-08 . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5LS400:
1997 . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.41998-2000 . . . . . . . . . . . . . . . . . . . . 5.6 5.9
LS430 . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8LS460, LS600H . . . . . . . . . . . . . . . . . . 8.6 9.1ES300, ES330 . . . . . . . . . . . . . . . . . . . 4.7 5.0ES350 . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.41 Preferred.2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, Automatic:1997 SC300 . . . . . . . . . . . . . . . . . . . . . . . . . .AF31997-99 ES300 . . . . . . . . . . . . . . . . . . . . . . .AF32004-06 LS430 . . . . . . . . . . . . . . . . . . . . . . . .WS2007 ES350, GS350, GS430, GS450H,
IS250, IS350 . . . . . . . . . . . . . . . . . . . . . . . .WS2008 All . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WSAll Others . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Initial Refill1: Liters QtES300 . . . . . . . . . . . . . . . . . . . . . . . 3.52 3.72
SC300:1997 . . . . . . . . . . . . . . . . . . . . . . . 1.6 1.71998-00 . . . . . . . . . . . . . . . . . . . . . . 1.9 2.0
SC400, SC430:1997-2000 . . . . . . . . . . . . . . . . . . . . 1.9 2.02002-05 . . . . . . . . . . . . . . . . . . . . . . 1.8 1.92006-08 . . . . . . . . . . . . . . . . . . . . . . 1.33 1.43
IS2502006:
2WD . . . . . . . . . . . . . . . . . . . . . . . 1.5 1.6AWD . . . . . . . . . . . . . . . . . . . . . . 2.7 2.8
2007:2WD . . . . . . . . . . . . . . . . . . . . . . . 1.8 1.9AWD . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0
2008:2WD . . . . . . . . . . . . . . . . . . . . . . . 1.0 1.1AWD . . . . . . . . . . . . . . . . . . . . . . 1.5 1.6
IS300, IS350 . . . . . . . . . . . . . . . . . . . . 2.4 2.52005 IS300 . . . . . . . . . . . . . . . . . . . 2.0 2.1
IS3502006 . . . . . . . . . . . . . . . . . . . . . . . 1.7 1.82007 . . . . . . . . . . . . . . . . . . . . . . . 1.8 1.9
GS300, GS400:1997-2000 . . . . . . . . . . . . . . . . . . . . 1.9 2.02001-04 . . . . . . . . . . . . . . . . . . . . . . 2.0 2.12005 GS300 . . . . . . . . . . . . . . . . . . 1.8 1.92006 GS300:
A760h . . . . . . . . . . . . . . . . . . . . . 1.63 1.73
A960e . . . . . . . . . . . . . . . . . . . . . 1.13 1.23
GS350:2WD . . . . . . . . . . . . . . . . . . . . . . . 1.8 1.94WD . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0
GS430:2001-05 . . . . . . . . . . . . . . . . . . . . . . 1.8 1.92006 . . . . . . . . . . . . . . . . . . . . . . . 1.33 1.43
2007 . . . . . . . . . . . . . . . . . . . . . . . 1.7 1.8GS450H: . . . . . . . . . . . . . . . . . . . . . . . 5.4 5.7LS400 . . . . . . . . . . . . . . . . . . . . . . . 1.9 2.0
129
CARS & LIGHT TRUCKSLAND ROVER Continued • LEXUS
CAPACITY, Initial Refill1: Liters QtLS430:
1997-2003 . . . . . . . . . . . . . . . . . . . . 1.8 1.92004-06 . . . . . . . . . . . . . . . . . . . . . . 1.73 1.83
LS460, LS600H . . . . . . . . . . . . . . . . . . 3.2 3.4ES330 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7ES350 . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed.
2 Final Drive is serviced separately in ES3003 Top up as needed.
TRANSMISSION/TRANSAXLE, ManualIS300, IS250 . . . . . . . . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90SC300 . . . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . .75W-90, 80W-90CAPACITY, Refill: Liters PtSC300, IS300 . . . . . . . . . . . . . . . . . . . 2.6 5.4IS250 . . . . . . . . . . . . . . . . . . . . . . . 1.8 1.9FINAL DRIVE . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Refill: Liters Pt1997-99 ES300 . . . . . . . . . . . . . . . . . . 0.9 2.0DIFFERENTIAL2004-08 LS430, SC430 w/ CS, GS300,
GS430 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-90
IS250 AWD . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90
IS350, IS250 2WD . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . .Synthetic 75W-85
G450H, LS460, LS600H . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-85
All Others . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtIS300, IS350 . . . . . . . . . . . . . . . . . . . . 1.1 2.3GS350:
Front . . . . . . . . . . . . . . . . . . . . . . . 0.70 1.48Rear . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
GS450H . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0IS250:
Front . . . . . . . . . . . . . . . . . . . . . . . 0.70 1.48Rear:
2WD . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5AWD . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3
IS350 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0All other RWD ex. 2006 GS300 . . . . . . 1.4 3.0
2006 GS300:Front . . . . . . . . . . . . . . . . . . . . . . 0.70 1.48Rear:
2WD . . . . . . . . . . . . . . . . . . . . . 1.2 2.54WD . . . . . . . . . . . . . . . . . . . . . 1.1 2.3
LS460, LS600HFront . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AF3
1998-2008 GX470, LX470, RX300,RX330, RX350, RX400H LX450—SEE TOYOTA LANDCRUISERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2008 RX400H . . . . . . . . . . . . . . . . . . . . . .5W-20, 0W-201
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .10W-30All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtRX300, RX330 . . . . . . . . . . . . . . . . . . . 4.7 5.0RX350 . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4RH400H . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0LX470 . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.2GX470 . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.61 Preferred2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, AutomaticRX300, RX330 . . . . . . . . . . . . . . . . . . . . . . . .TIVRX400H . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WSLX470:
1998-2002 . . . . . . . . . . . . . . . . . . . . . . . . .AF32003 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2004-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .WS
LS430, GX470:2001-03 . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2004-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .WS
RX350 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WSCAPACITY, Initial Refill1: Liters QtRX300:
1999-2002:2WD . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.74WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
2003 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7
CAPACITY, Initial Refill1: Liters QtRX330:
2004:w/ U151E Trans. . . . . . . . . . . . . . . 3.5 3.7w/ U151F Trans. . . . . . . . . . . . . . . 3.6 3.8
2005-06 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7RX350 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7RX400H:
Front:w/o Towing . . . . . . . . . . . . . . . . . 3.9 4.1w/ Towing . . . . . . . . . . . . . . . . . . 4.2 4.4
Rear (AWD only) . . . . . . . . . . . . . . . 2.0 2.12007-08 . . . . . . . . . . . . . . . . . . . . 1.8 1.9
GX470:2003-05 . . . . . . . . . . . . . . . . . . . . . . 1.72 1.82
2006-08 . . . . . . . . . . . . . . . . . . . . . . 1.32 1.42
LX470: 1998-2002 . . . . . . . . . . . . . . . . . . . . 1.9 2.02003-05 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22006-07 . . . . . . . . . . . . . . . . . . . . . . 1.72 1.82
1 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in PARK and add fluid as need-ed.
2 Top up as needed.
TRANSFER CASERX300, RX330, RX350 . . . . . . . . . . . . . . . . .GL-5
Above 0°F (-18°C), . . . . . . . . . . . . . . . . . . . . . . . . . .90below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90
LX470 . . . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5GX470 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtRX300, RX330, RX350 . . . . . . . . . . . . 0.9 1.9LX470 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7GX470 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0DIFFERENTIALLX470:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above 0°F (-18°C), . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90Limited-slip . . . . . . . . . . . . . . . . . . . . . .GL-5★★
RX300, RX330, RX350 . . . . . . . . . . . . . . . . .GL-5GX470 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 0°F (-18°C), . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90
CAPACITY, Refill: Liters PtGX470:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Rear . . . . . . . . . . . . . . . . . . . . . . . 3.1 6.6
RX300, RX330, RX350 . . . . . . . . . . . . 0.9 1.9LX470:
Front:1998-1999 . . . . . . . . . . . . . . . . . . 1.7 3.62000-07 . . . . . . . . . . . . . . . . . . . . 1.6 3.4
Rear:1998-2004
w/o: locking diff . . . . . . . . . . . . 3.2 6.8w/locking diff . . . . . . . . . . . . . . 3.3 7.0
2005-07 . . . . . . . . . . . . . . . . . . . . 3.3 7.0OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3Brake & Clutch Master Cylinder . . . . . . . . . . .HBActive Height Control
Suspension Fluid . . . . . . . . . . . . . . . . . . . .SLF
MAZDA1997-2002 MAZDA 6261997 MAZDA MX-6FOR NAVAJO & B2300, B2500,B3000, B4000 SEE FORD TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above -13°F (-25°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters Qt1997-2002: 2.0L . . . . . . . . . . . . . . . . . 3.7 3.9
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.41 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic2.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MA2.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Total Fill1: Liters Qt2.0L: 1997-2000 . . . . . . . . . . . . . . . . . 8.3 8.8
2001 . . . . . . . . . . . . . . . . . . . . . . 8.7 9.22002 . . . . . . . . . . . . . . . . . . . . . . . 8.9 9.4
2.5L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.51 Total or dry fill capacity shown. Approximate, make final check with
dipstick. For drain & fill, measure amount drained & refill with sameamount. Initial refill with engine at normal operating temperature.
TRANSAXLE, ManualMX6 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90626 . . . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . 80W-90
CAPACITY, Refill: Liters PtTurbo . . . . . . . . . . . . . . . . . . . . . . . 3.7 7.81997-2002 . . . . . . . . . . . . . . . . . . . . . 2.7 5.7
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
Mazda, 1997-2002 . . . . . . . . . . . . . . .AF2, MA
1997-98 & 2000-06 MPVCRANKCASE1997-98 . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★
Above -15°F (-26°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
2000-06 . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★All temperatures:
2000-01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-302002-06 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill1: Liters Qt1997-98 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.32000-03 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.52004-06 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Capacity shown includes filter.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters Qt
1997-98 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22000-01 . . . . . . . . . . . . . . . . . . . . . . 8.0 8.42002-06 . . . . . . . . . . . . . . . . . . . . . . 9.7 10.2
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
TRANSFER CASE . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . 80WCAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, MA
1997-2008 MIATACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997-2004:
Above -15°F (-25°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
2005-08:All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20
CAPACITY, Refill1: Liters Qt1997 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21999-2005 . . . . . . . . . . . . . . . . . . . . . 4.0 4.22006-07 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
2008 w/6-speed manual . . . . . . . . . 4.5 4.8Others . . . . . . . . . . . . . . . . . . . . . 4.4 4.7
1 Capacity shown includes filter.
TRANSMISSION, Automatic1997-2005 . . . . . . . . . . . . . . . . . . . . . . . . .AF32006-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
CAPACITY, Total Refill1: Liters Qt1997:
Pan Only . . . . . . . . . . . . . . . . . . . . . 4.0 4.2Total . . . . . . . . . . . . . . . . . . . . . . . 6.7 7.1
1999 . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.82000-05 . . . . . . . . . . . . . . . . . . . . . . . 6.7 7.12006-08 . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.81 Total refill shown. With engine at operating temperature, shift trans-
mission through all gears. Check fluid level in PARK and add fluidas needed.
TRANSMISSION, Manual1997-2004 . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . 75W-90Above 50ºF (10ºC) . . . . . . . . . . . . . . . . . . . . . . 80W-90
2005-08:5-speed . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . 75W-90Above 50ºF (10ºC) . . . . . . . . . . . . . . . . . . . . 80W-90
6-speed . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . 75W-90
CAPACITY, Refill: Liters Pt5-speed . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.26-speed:
2004-05 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.82006-08 . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4
DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W2007-08 . . . . . . . . . . . . . . . .90, 80W-90, 75W-90 GL-52004-06 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 GL-5CAPACITY, Refill: Liters Pt1997-99 . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.12000 . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.92001-04 . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.12005:
w/traction control . . . . . . . . . . . . . . 0.8 1.7w/o traction control . . . . . . . . . . . . . 1.0 2.1
2006-08 . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3
CARS & LIGHT TRUCKS
130
LEXUS Continued • MAZDA
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, MA
1997-2002 MILLENIACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above -15°F (-25°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters Qt2.3L:
1997 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.51998 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21999 . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42000-02 . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
2.5L:1997-98 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.41999 . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52000-02 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4
1 Capacity shown is with filter.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Total Fill1: Liters Qt1997 All . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.51999:
2.3L . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.32.5L . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.8
2000-02:2.3L . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.82.5L . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.3
1 Total or dry fill shown. Use less fluid when refilling transaxle.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, MA
1997-2003 MAZDA PROTEGÉ,PROTEGÉ5; 2004-08 MAZDA32003-08 MAZDA6, 2006-08MAZDA5, 2007-08 CX-7, CX-9CRANKCASE . . . . . . . . . . . . . . . . . . .API★★Protegé:
Above -15°F (-25°C) . . . . . . . . . . . . . . . . . . . .10W-301
Below 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Mazda3, 5, 6:
All temperatures Ex. Turbo . . . . . . . . . . . . . . . . .5W-201
w/ Turbo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CX-7:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CX-9:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill2: Liters Qt1997-03
1.5L . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.61.6L:
1999 . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.12000-2001 . . . . . . . . . . . . . . . . . . 3.4 3.6
1.8L1997-98 . . . . . . . . . . . . . . . . . . . . 3.8 4.01999-2000 . . . . . . . . . . . . . . . . . 3.5 3.7
2.0L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72004-08 All:
2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.3L:
ex Turbo . . . . . . . . . . . . . . . . . . . . 4.3 4.5Turbo . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
3.0L:2003-05: . . . . . . . . . . . . . . . . . . . 5.2 5.52006-08 . . . . . . . . . . . . . . . . . . . . 5.7 6.0
3.7L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Preferred.2 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticProtegé . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3Mazda3, 5, 6, CX-7
ex. Mazda6 w/6-speed . . . . . . . . . . . . . . .SLFMazda6 w/6-speed . . . . . . . . . . . . . . . . . . . .TIVCX-7, CX-9 . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total Fill1: Liters QtAll ex. Mazda6, Mazda3, CX-7:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 5.4 5.71999-2007 . . . . . . . . . . . . . . . . . . . . 7.2 7.6
CX-7, CX-9 . . . . . . . . . . . . . . . . . . . . . 7.0 7.4Mazda3:
2004-08 FN4A-EL . . . . . . . . . . . . . . 7.2 7.62006-08 FS5A-EL . . . . . . . . . . . . . . 8.1 8.6
Mazda5:2006-07 . . . . . . . . . . . . . . . . . . . . . . 7.2 7.62008 . . . . . . . . . . . . . . . . . . . . . . . 8.1 8.5
Mazda6:2003-04 w/2.3L . . . . . . . . . . . . . . . . 7.2 7.62003-04 w/3.0L . . . . . . . . . . . . . . . . 9.2 9.72005:
4-speed . . . . . . . . . . . . . . . . . . . 7.2 7.66-speed . . . . . . . . . . . . . . . . . . . . 7.0 7.4
2006-08:5-speed . . . . . . . . . . . . . . . . . . . 8.1 8.56-speed . . . . . . . . . . . . . . . . . . . . 7.0 7.4
1 Total or dry fill capacity shown. Approximate, make final check withdipstick. For transaxle drain & refill, measure amount. Do not over-fill.
TRANSAXLE, Manual . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtProtegé: 1997-98 . . . . . . . . . . . . . . . . 2.6 5.5
1999 . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.72000 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.52001-03 . . . . . . . . . . . . . . . . . . . . . . 2.7 5.7
Mazda6, Mazda3, Mazda5:G35M-R . . . . . . . . . . . . . . . . . . . . . 2.9 6.1A65M-R . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9A26MX-R . . . . . . . . . . . . . . . . . . . . . 2.6 5.52007-08 A26M-R . . . . . . . . . . . . . . . 2.5 5.3
POWER TAKE-OFF UNIT . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtCX-7 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5TRANSFER CASE . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .75W-140CAPACITY, Refill: Liters PtCX-9 . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.0DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtCX-7, CX-9 . . . . . . . . . . . . . . . . . . . . . 1.0 2.1 OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, MA
2004-08 MAZDA RX8CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.71 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, Automatic All ex. SJ6A-EL . . . . . . . . . . . . . . . . . . . . . . .AF3SJ6A-EL . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Total Fill1: Liters QtRC4A-EL . . . . . . . . . . . . . . . . . . . . . . . 8.7 9.2SJ6A-EL . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.41 Total or dry fill capacity shown. Approximate, make final check with
dipstick. For transaxle drain & refill, measure amount of fluiddrained and add approximately same amount. Do not overfill.
TRANSMISSION, Manual . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt2004-08 . . . . . . . . . . . . . . . . . . . . . . . 1.75 3.6DIFFERENTIAL . . . . . . . . . . . . . . . . . .GL-52004-05 All temperatures . . . . . . . . . . . . . . . . . . . . . .90W2006-08 . . . . . . . . . . . . . . . . . . . . . . . .90, 80W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB
MERCEDES-BENZ1997-99 ALL MODELS WITHOUTFLEXIBLE SERVICE SYSTEM(FSS)CRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEOGasoline & Diesel:
All Temps . . . . . .0W-30, 5W-30, 0W-40, 5W-40, 5W-50Above -4°F (-20°C) .10W-30, 10W-40, 10W-50, 10W-60Above 5°F (-15°C) . . . . . . . . . . . . . . . .15W-40, 15W-50Above 23°F (-5°C) . . . . . . . . . . . . . . . .20W-40, 20W-50
CAPACITY, Refill1: Liters QtGasoline Models:
4-cyl.:2.3L:
Ex supercharged . . . . . . . . . . . 6.2 6.5Supercharged:
1998 . . . . . . . . . . . . . . . . . . . 5.6 5.91999 . . . . . . . . . . . . . . . . . . . 5.8 6.1
6-cyl.:2.6L . . . . . . . . . . . . . . . . . . . . . 6.0 6.32.8L:
1997 . . . . . . . . . . . . . . . . . . . 7.0 7.41998-99 . . . . . . . . . . . . . . . . 8.0 8.5
3.0L SOHC:ex. 4MATIC . . . . . . . . . . . . . . 6.0 6.34MATIC . . . . . . . . . . . . . . . . . 6.5 6.9
3.0L DOHC . . . . . . . . . . . . . . . . 7.5 7.93.2L:
1997 . . . . . . . . . . . . . . . . . . . 7.0 7.41998-99 S320 . . . . . . . . . . . . 7.0 7.4ex. S320 . . . . . . . . . . . . . . . . 8.0 8.5
3.6L: 1997 . . . . . . . . . . . . . . . . . . . 7.0 7.4
8-cyl.:C43 AMG . . . . . . . . . . . . . . . . 7.5 7.9E55 AMG . . . . . . . . . . . . . . . . . 7.5 7.9All other models . . . . . . . . . . . . 8.0 8.5
12-cyl:1998-99 CL600 . . . . . . . . . . . . 10.0 10.61997-99 SL600 . . . . . . . . . . . . 10.0 10.61997-99 S600 . . . . . . . . . . . . . 10.0 10.6
CAPACITY, Refill1: Liters QtDiesel Models:
6-cyl.: 1997-99 3.0L . . . . . . . . . . . . . . 7.0 7.41997 E300 . . . . . . . . . . . . . . . . 6.0 6.31998-99 E300 . . . . . . . . . . . . . . 7.1 7.5
1 All capacities shown include filter. On models with oil cooler, addi-tional oil may be needed when cooler is drained. Wait 5 minutesafter refilling or turning off engine to check oil level. V12 with oil fil-ter on top: use wrench Part No. 103589020900.
TRANSMISSION, Automatic1997-99 5-speed . . . . . . . . . . . . . . . . . . . . . .SLF
W5A580 model 722.6CAPACITY, Initial Refill1: Liters QtGasoline Models:
C Class:C36:
1997 . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
C43:1998-99 . . . . . . . . . . . . . . . . . . 9.42 9.92
C220 . . . . . . . . . . . . . . . . . . . . . . 5.5 5.8C230 . . . . . . . . . . . . . . . . . . . . . . 7.52 7.92
C280:1997 . . . . . . . . . . . . . . . . . . . . . 7.52 7.92
1998-99 . . . . . . . . . . . . . . . . . . 9.42 9.92
CL500, CL600:1997 . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
1998-99 . . . . . . . . . . . . . . . . . . 9.1 9.6CLK320 . . . . . . . . . . . . . . . . . . . . 7.32 7.72
CLK430 . . . . . . . . . . . . . . . . . . . . 9.4 2 9.92
E Class:E320:
1997-99 . . . . . . . . . . . . . . . . . . 7.52 7.92
E420:1997 . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
E430 . . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
ML Class:ML320 . . . . . . . . . . . . . . . . . . . . . 7.52 7.92
ML430 . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
S Class:S320:
1997-99 . . . . . . . . . . . . . . . . . . 7.12 7.52
S420:1997-99 . . . . . . . . . . . . . . . . . . 8.62 9.12
S500 . . . . . . . . . . . . . . . . . . . . . . 9.42 9.92
S600:1997-99 . . . . . . . . . . . . . . . . . . 8.62 9.12
SL Class:SL320:
1997 . . . . . . . . . . . . . . . . . . . . . 7.12 7.52
SL500:1997-99 . . . . . . . . . . . . . . . . . . 8.22 9.92
SLK Class:SLK230 . . . . . . . . . . . . . . . . . . . . 7.12 7.52
Diesel Models1997 E300 . . . . . . . . . . . . . . . . . . . . 6.0 6.31998-99 E300 . . . . . . . . . . . . . . . . . 7.1 7.5
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
2 Total fill, add less fluid when refilling.
TRANSMISSION, Manual . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtSLK 230 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2TRANSFER CASE . . . . . . . . . . . . . . . . .AF3CAPACITY, Refill: Liters PtML320, ML430 . . . . . . . . . . . . . . . . . . 1.5 3.2E320 . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2DIFFERENTIALGasoline Models
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . . .85W-90, 90Rear:
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . .85W-90, 90
Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90
Diesel ModelsStandard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . .85W-90, 90Limited-Slip . . . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtGasoline Models:
C220, C230, C280 . . . . . . . . . . . . . . 1.1 2.4C36 AMG, C43 AMG . . . . . . . . . . . . 1.3 2.8CL320 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.8CL500, CL600 . . . . . . . . . . . . . . . . . 1.4 3.0CLK320, CLK430 . . . . . . . . . . . . . . 1.3 2.8E320:
Front: All . . . . . . . . . . . . . . . . . . . 0.5 1.0 Rear:
Coupe, Cabriolet . . . . . . . . . . . 1.3 2.8Sedan: . . . . . . . . . . . . . . . . . . . 1.3 2.8Wagon . . . . . . . . . . . . . . . . . . . 1.3 2.8
E420, E430 . . . . . . . . . . . . . . . . . . . 1.3 2.8ML320, ML430:
Front . . . . . . . . . . . . . . . . . . . . . . 1.1 2.4Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
S320, S420 . . . . . . . . . . . . . . . . . . . 1.3 2.8S430, S500, S600 . . . . . . . . . . . . . . 1.4 3.0SL500, SL600: . . . . . . . . . . . . . . . . . 1.4 3.0SL320 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.8SLK230 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.8
131
CARS & LIGHT TRUCKSMAZDA Continued • MERCEDES BENZ
CAPACITY, Refill: Liters PtDiesel Models:
1997-99 E300 . . . . . . . . . . . . . . . . . 1.1 2.41 For initial new fill of 4Matic front axle.
LIMITED-SLIP IDENTIFICATION:Metal plate on rear of differential, near fill plugOTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . .HBHClutch Master Cylinder . . . . . . . . . . . . . . . . .HB1
Engine Control Linkage & 300TD Level Control . . . . . . . . . . . . . . . . .SLF
Body & Sunroof Rails . . . . . . . . . . . . . . . . . . .LM1 Fluid meeting DOT 4 plus requirements.
1998-2007 ALL MODELSWITH FLEXIBLE SERVICE SYSTEM(FSS)CRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEOAll temperatures . . . . . . . . . . . . . . . . . . . .0W-30, 5W-30,
0W-40, 5W-40, 5W-50Above 5°F (-15°C) . . . . . . . . . . . . . . . . . .15W-40, 15W-50Above 23°f (-5°C) . . . . . . . . . . . . . . . . . .20W-40, 20W-50Above -4°F (-20°C) . . . . . . . . . . . . . . . .10W-30, 10W-40,
10W-50, 10W-60CAPACITY, Refill1: Liters Qt4-cyl.:
1.8L . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.82.3L ex. Supercharged . . . . . . . . . . 6.2 6.62.3L Supercharged: 1998 . . . . . . . . 5.6 5.9
1999-01 . . . . . . . . . . . . . . . . . . . . 5.6 5.92002-04 . . . . . . . . . . . . . . . . . . . . 5.5 5.8
2.5L C230 . . . . . . . . . . . . . . . . . . . . 8.0 8.56-cyl.:
2.4L, 2.8L . . . . . . . . . . . . . . . . . . . . 8.0 8.53.0L Diesel . . . . . . . . . . . . . . . . . . . . 7.0 7.43.0L C280, SLK280 . . . . . . . . . . . . . 8.0 8.53.2L: 1998 . . . . . . . . . . . . . . . . . . . . 7.0 7.4
1999-04 . . . . . . . . . . . . . . . . . . . . 8.0 8.52005-06 E320 CDI . . . . . . . . . . . . 7.3 7.72007 E320 Bluetec . . . . . . . . . . . . 8.5 9.0
3.5L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.53.7L . . . . . . . . . . . . . . . . . . . . . . . 8.0 8.5
8-cyl.:1998-00 C43 AMG . . . . . . . . . . . . . 7.5 7.92005-06 C55 AMG . . . . . . . . . . . . . 8.5 9.01999-03 CLK430 . . . . . . . . . . . . . . . 8.0 8.51998-06 CL500 . . . . . . . . . . . . . . . . 8.0 8.52007 CL550 . . . . . . . . . . . . . . . . . . . 8.5 9.02001-06 CL55 AMG . . . . . . . . . . . . 7.5 7.92003-06 CLK500 . . . . . . . . . . . . . . 7.5 7.92001-02 CLK55 AMG . . . . . . . . . . . 7.5 7.92003-06 CLK55 AMG . . . . . . . . . . . 8.5 9.02007 CLK550 . . . . . . . . . . . . . . . . . 8.5 9.02007 CLK63 AMG . . . . . . . . . . . . . . 8.8 9.32006 CLS500 . . . . . . . . . . . . . . . . . 7.5 7.92007 CLS550 . . . . . . . . . . . . . . . . . 8.5 9.02006 CLS55 AMG . . . . . . . . . . . . . . 8.5 9.02007 CLS63 AMG . . . . . . . . . . . . . . 8.8 9.32003-04 E500 . . . . . . . . . . . . . . . . . 8.0 8.52005-06 E500 . . . . . . . . . . . . . . . . . 7.5 7.91999-02 E55 AMG . . . . . . . . . . . . . . 7.5 7.92004-06 E55 AMG . . . . . . . . . . . . . . 8.5 9.02007 E550 . . . . . . . . . . . . . . . . . . . . 8.5 9.02007 E63 AMG . . . . . . . . . . . . . . . . 8.8 9.32002-07 G500 . . . . . . . . . . . . . . . . . 8.0 8.5 2003-04 G55 . . . . . . . . . . . . . . . . . . 7.5 8.2005-07 G55 . . . . . . . . . . . . . . . . . . 8.5 9.02007 GL450 . . . . . . . . . . . . . . . . . . . 8.5 9.02002-05 ML500 . . . . . . . . . . . . . . . . 8.0 8.52006-07 ML500 . . . . . . . . . . . . . . . . 8.5 9.02000-03 ML55 AMG . . . . . . . . . . . . 7.5 7.92007 ML63 AMG . . . . . . . . . . . . . . . 9.7 10.22006-07 R500 . . . . . . . . . . . . . . . . . 8.5 9.02007 R63 AMG . . . . . . . . . . . . . . . . 9.6 10.12000-06 S430 . . . . . . . . . . . . . . . . . 8.0 8.51998-06 S500 . . . . . . . . . . . . . . . . . 8.0 8.52001-06 S55 AMG . . . . . . . . . . . . . . 7.5 7.92007 S550 . . . . . . . . . . . . . . . . . . . . 8.5 9.01998-02 SL500 . . . . . . . . . . . . . . . . 8.0 8.52003-06 SL500 . . . . . . . . . . . . . . . . 7.5 7.92003-07 SL55 . . . . . . . . . . . . . . . . . 8.5 9.02007 SL550 . . . . . . . . . . . . . . . . . . 8.5 9.02006-07 SLK55 AMG . . . . . . . . . . . 8.0 8.5
12-cyl:2002 CL600: . . . . . . . . . . . . . . . . . . 9.5 10.02003-07 CL600 . . . . . . . . . . . . . . . . 9.0 9.52006 CL65 AMG . . . . . . . . . . . . . . . 10.5 11.12002-07: S600 . . . . . . . . . . . . . . . . . 9.0 9.52006 S65 AMG . . . . . . . . . . . . . . . . 10.5 11.12007 S65 AMG . . . . . . . . . . . . . . . . 9.0 9.51998-01 ex. SL600 . . . . . . . . . . . . . 10.0 10.61998-01 SL600 . . . . . . . . . . . . . . . . 9.0 9.52002 SL600 . . . . . . . . . . . . . . . . . . . 10.0 10.62004-07 SL600 . . . . . . . . . . . . . . . . 8.0 8.52005-07 SL65 AMG . . . . . . . . . . . . . 8.0 8.5
1 Capacity shown includes filter. On models with oil cooler, addition-al oil may be needed when cooler is drained. Allow 5 minutes afterrefilling or turning engine off before checking oil Level. V12 with oilfilter on top: use wrench Part No. 103589020900.
TRANSMISSION, Automatic . . . . . . . . .SLFCAPACITY, Total Fill1: Liters QtC Class:
1998 C230, C280 . . . . . . . . . . . . . . 7.5 7.91999-05 C230, C240, C280 . . . . . . . 8.0 8.52006-07 C230, C280, C350 . . . . . . . 8.5 9.02002-05 C32 AMG . . . . . . . . . . . . . 8.0 8.52002-05 C320 . . . . . . . . . . . . . . . . . 8.0 8.51998-00 C43 AMG . . . . . . . . . . . . . 9.4 9.92005-07 C55 AMG . . . . . . . . . . . . . 8.7 9.2
CL Class:1998-01 CL500, CL600 . . . . . . . . . . 9.1 9.62002-04 CL500 . . . . . . . . . . . . . . . . 8.0 8.52005-06 CL500 . . . . . . . . . . . . . . . . 9.0 9.52007 CL550 . . . . . . . . . . . . . . . . . . . 9.0 9.52002 CL600 . . . . . . . . . . . . . . . . . . . 9.1 9.62003-07 CL600 . . . . . . . . . . . . . . . . 7.5 7.92001-06 CL55 AMG . . . . . . . . . . . . 9.1 9.62005-06 CL65 AMG . . . . . . . . . . . . 7.5 7.9
CLK Class:1998 CLK320 . . . . . . . . . . . . . . . . . 6.2 6.61999-04 CLK320 . . . . . . . . . . . . . . . 8.0 8.52006-07 CLK350 . . . . . . . . . . . . . . . 9.0 9.51999-03 CLK430 . . . . . . . . . . . . . . . 9.1 9.62003-06 CLK500 . . . . . . . . . . . . . . . 9.1 9.62007 CLK550 . . . . . . . . . . . . . . . . 9.1 9.62001-07 CLK55 AMG . . . . . . . . . . . 9.1 9.6
CLS Class:2006-07 CLS500
w/o code A25 . . . . . . . . . . . . . . . . 9.0 9.5w/ code A25 . . . . . . . . . . . . . . . . . 6.7 7.1
2006-07 CLS55 AMG . . . . . . . . . . . 8.7 9.2E Class:
1998 E300 . . . . . . . . . . . . . . . . . . . . 7.5 7.91999 E300 . . . . . . . . . . . . . . . . . . . . 8.0 8.51998-06 E320 . . . . . . . . . . . . . . . . . 7.5 7.92005-06 E320 CDI . . . . . . . . . . . . . . 9.1 9.62007 E320 Bluetec . . . . . . . . . . . . . 9.2 9.72006 E350 . . . . . . . . . . . . . . . . . . . . 8.0 8.42007 E350 . . . . . . . . . . . . . . . . . . . . 9.2 9.71998-00 E430 . . . . . . . . . . . . . . . . . 9.1 9.62001-02 E430
(RWD) . . . . . . . . . . . . . . . . . . . . . 8.6 9.1(4WD) . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0
2003-05 E500 . . . . . . . . . . . . . . . . . 7.5 8.02006 E500 . . . . . . . . . . . . . . . . . . . . 8.0 8.4
4 Matic . . . . . . . . . . . . . . . . . . . . . 6.5 6.82007 E550 4 Matic . . . . . . . . . . . . . . 8.1 8.52007 E550 . . . . . . . . . . . . . . . . . . . . 9.2 9.71998-02 E55 AMG . . . . . . . . . . . . . . 9.1 9.62004-06 E55 AMG . . . . . . . . . . . . . . 7.5 8.02007 E63 AMG . . . . . . . . . . . . . . . . 8.5 9.0
G Class:2002-07 G500 . . . . . . . . . . . . . . . . . 8.5 9.02003-07 G55 . . . . . . . . . . . . . . . . . . 8.5 9.0
GL Class:2007 GL450 . . . . . . . . . . . . . . . . . . . 9.0 9.5
ML Class:1998-01 ML320 . . . . . . . . . . . . . . . . 7.5 7.92002 ML320 . . . . . . . . . . . . . . . . . . 8.0 8.52003-07 ML350 . . . . . . . . . . . . . . . . 9.0 9.51999-01 ML430, ML55 AMG . . . . . . 9.4 9.92002-06 ML500 . . . . . . . . . . . . . . . . 9.1 9.62007 ML500 . . . . . . . . . . . . . . . . . . 9.0 9.52002-03 ML55 AMG . . . . . . . . . . . . 9.1 9.62007 ML63 AMG . . . . . . . . . . . . . . . 9.0 9.5
R Class:2006-07 R350, R63 AMG . . . . . . . . 9.0 9.52006-07 R500 . . . . . . . . . . . . . . . . . 9.0 9.5
S Class:1998-99 S320 . . . . . . . . . . . . . . . . . 6.0 6.32006 S350 . . . . . . . . . . . . . . . . . . . . 7.5 7.91998 S420, S500 . . . . . . . . . . . . . . . 9.4 9.91999-00 S430, S500 . . . . . . . . . . . . 9.1 9.62001-06 S430,
S500, S55 AMG . . . . . . . . . . . . . . 9.1 9.62007 S550 . . . . . . . . . . . . . . . . . . . . 9.0 9.51998-02 S600 . . . . . . . . . . . . . . . . . 9.1 9.62003-07 S600, S65 AMG . . . . . . . . 7.5 7.9
SL Class:1998-99 SL320 . . . . . . . . . . . . . . . . 6.0 6.31998-01 SL500, SL600 . . . . . . . . . . 9.4 9.92002-06 SL500 . . . . . . . . . . . . . . . . 9.1 9.62007 SL550 . . . . . . . . . . . . . . . . . . . 9.0 9.52007 SL55 AMG Evo . . . . . . . . . . . . 8.7 9.22003-06 SL55 AMG . . . . . . . . . . . . . 8.0 8.52002 SL600 . . . . . . . . . . . . . . . . . . . 9.1 9.62004-07 SL600, SL65 AMG . . . . . . . 7.5 7.9
SLK Class:1998 SLK230 . . . . . . . . . . . . . . . . . . 7.1 7.51999-04 SLK230 . . . . . . . . . . . . . . . 8.0 8.5
2006-07 SLK280 . . . . . . . . . . . . . 9.0 9.52002-04 SLK32 AMG . . . . . . . . . . . 8.0 8.52001-04 SLK320 . . . . . . . . . . . . . . . 8.0 8.52005-07 SLK350 . . . . . . . . . . . . . . . 9.0 9.52005-07 SLK55 AMG . . . . . . . . . . . 9.0 9.5
1 Total fill, add less fluid when refilling.
TRANSMISSION, Manual . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtC230:
1998-00 & 2002 . . . . . . . . . . . . . . . . 1.5 3.22003-07 . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5
C240 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5C280, C350 . . . . . . . . . . . . . . . . . . . . . 1.5 3.2C320 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
CAPACITY, Refill: Liters PtCLK350 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.22006-07 E320 . . . . . . . . . . . . . . . . . . 1.3 2.7SLK230, SLK320, SLK280, SLK350 . . 1.5 3.2TRANSFER CASEG500, G55 . . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtC240, C280, C320, C350 . . . . . . . . . . 0.6 1.3E320: 2001-02 . . . . . . . . . . . . . . . . . . 1.0 2.1
2003 . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.92004-05 . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3
E350 2006-07 . . . . . . . . . . . . . . . . . . . 0.6 1.3E430 2001-02 . . . . . . . . . . . . . . . . . . . 1.0 2.1E500 2003-06 . . . . . . . . . . . . . . . . . . . 0.6 1.3E550 2007 . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3G500, G55 . . . . . . . . . . . . . . . . . . . . . 2.8 5.9ML320, ML430,ML55 AMG,
ML350,ML500, GL450:Single speed . . . . . . . . . . . . . . . . 0.5 1.1Double speed . . . . . . . . . . . . . . . 1.5 3.2
R350, R500 . . . . . . . . . . . . . . . . . . . . . 0.5 1.1S430, S500 . . . . . . . . . . . . . . . . . . . . . 0.6 1.3DIFFERENTIALFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .85W-90, 90Rear:
2005-07 SL65 AMG . . . . . . . . . . . . . . . . .GLS1
2007 E63 AMG, CLS63 AMG:w/Performance Pkg . . . . . . . . . . . . . . .GLS1
w/o Performance Pkg . . . . . . .85W-90 GL-52003-07 SL55 AMG:
w/Performance Pkg . . . . . . . . . . . . . . .GLS1
w/o Performance Pkg . . . . . . .85W-90 GL-52006 CLS55 AMG:
w/Performance Pkg . . . . . . . . . . . . . . .GLS1
w/o Performance Pkg . . . . . . .85W-90 GL-5All Others:
Standard . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . .85W-90, 90
Limited-Slip . . . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .90
CAPACITY, Refill: Liters PtC Class:
1998-00: C43 AMG . . . . . . . . . . . . . 1.3 2.71998-02: C230, C280, E300 . . . . . . 1.1 2.32003-05:
C230 . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1C240: Front . . . . . . . . . . . . . . . . . 0.5 1.1
Rear . . . . . . . . . . . . . . . . . . . . . 1.0 2.1C32 AMG . . . . . . . . . . . . . . . . . . . 1.6 3.4C320: Front . . . . . . . . . . . . . . . . . 0.5 1.1
Rear . . . . . . . . . . . . . . . . . . . . . 1.2 2.52005-06: C55 AMG . . . . . . . . . . . . . 1.2 2.52006-07:
Front:All 4Matic . . . . . . . . . . . . . . . . . 0.5 1.1
Rear:C280, C350: . . . . . . . . . . . . . . . 1.1 2.3C230, C280 4Matic,
C350 4Matic: . . . . . . . . . . . . 1.0 2.1CL Class:
2002-06: CL500 . . . . . . . . . . . . . . . 1.6 3.42001-02: CL55 AMG . . . . . . . . . . . . 1.6 3.42003-04: CL55 AMG . . . . . . . . . . . . 2.0 4.22005-06: CL55 AMG . . . . . . . . . . . . 1.9 4.01998-99: CL600 . . . . . . . . . . . . . . . 1.6 3.42002: CL600 . . . . . . . . . . . . . . . . . . 1.6 3.42003-06: CL600 . . . . . . . . . . . . . . . 1.9 4.02005-06: CL65 AMG . . . . . . . . . . . . 1.9 4.02007 CL550, CL600: 215mm . . . . . 1.2 2.5
240mm . . . . . . . . . . . . . . . . . . . . 1.6 3.4CLK Class:
1998-02: CLK320 . . . . . . . . . . . . . . 1.3 2.72003-05: CLK320 . . . . . . . . . . . . . . 1.2 2.52006-07: CLK350 . . . . . . . . . . . . . . 1.1 2.31999-03: CLK430 . . . . . . . . . . . . . . 1.2 2.52003-06: CLK500 . . . . . . . . . . . . . . 1.6 3.42007 CLK550 . . . . . . . . . . . . . . . . . 1.1 2.32002: CLK55 AMG . . . . . . . . . . . . . 1.3 2.72004-06: CLK55 AMG . . . . . . . . . . . 1.6 3.42007 CLK 63 AMG . . . . . . . . . . . . . 1.1 2.3
CLS Class:2006:
CLS500, CL55 AMG w/o code 030:187mm . . . . . . . . . . . . . . . . . 1.0 2.1198mm . . . . . . . . . . . . . . . . . 1.1 2.3210mm . . . . . . . . . . . . . . . . . 1.6 3.4215mm . . . . . . . . . . . . . . . . . 1.2 2.5
CLS55 AMG w/ code 030 . . . . . . 1.2 2.52007:
CLS550: 198mm, 200mm . . . . . . 1.1 2.3CLS55, CLS55 AMG,
CLS63 AMG: 215mm . . . . . . . . 1.2 2.5E Class:
1998-01: E320 Front . . . . . . . . . . . . . . . . . . . . . . 0.5 1.0Rear . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
1998-00: E430 Front . . . . . . . . . . . . . . . . . . . . . . 0.5 1.0Rear . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7
CARS & LIGHT TRUCKS
132
MERCEDES BENZ Continued
CAPACITY, Refill: Liters Pt1999-06: E55 AMG . . . . . . . . . . . . . 1.3 2.7E320:
Front:2002-03 . . . . . . . . . . . . . . . . . . 0.5 1.12004-05 . . . . . . . . . . . . . . . . . . 0.6 1.3
E350: 2006 . . . . . . . . . . . . . . . . . . . 0.6 1.32007 . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.42001-02 E430 . . . . . . . . . . . . . . . 0.5 1.12004-06 E500 . . . . . . . . . . . . . . . 0.6 1.32007 E550 . . . . . . . . . . . . . . . . . . 1.6 3.4
E320:Rear:
2002 . . . . . . . . . . . . . . . . . . . . . 1.3 2.72003 . . . . . . . . . . . . . . . . . . . . . 1.0 2.12003 Wagon, 4Matic . . . . . . . . 1.3 2.72004 . . . . . . . . . . . . . . . . . . . . . 1.3 2.72004-05 Wagon, 4Matic . . . . . . 1.0 2.12005-06 CDI . . . . . . . . . . . . . . . 1.3 2.72007 Bluetec . . . . . . . . . . . . . . 1.3 2.7
E350:2006-07 . . . . . . . . . . . . . . . . . . . . 1.0 2.12006 Wason, 4Matic . . . . . . . . . . 1.0 2.12007 Wason, 4Matic . . . . . . . . . . 1.6 3.42001-02 E430 . . . . . . . . . . . . . . . 1.3 2.72003-06 E500 . . . . . . . . . . . . . . . 1.3 2.72001-06 E55 AMG . . . . . . . . . . . . 1.3 2.72007 E550 . . . . . . . . . . . . . . . . . . 1.3 2.72007 E550 4Matic . . . . . . . . . . . . 1.6 3.42007 E63 AMG . . . . . . . . . . . . . . 1.2 2.5
G Class:G500, G55 Front . . . . . . . . . . . . . . . 1.4 3.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8GL Class:
GL450 2006:Front . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Rear:
195mm HAM w/o differential lock . . . . . . 1.1 2.3
230mm HAMw/ differential lock . . . . . . . 1.6 3.4
ML Class:ML320, ML430
Front . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2002: ML320 Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.65 3.5
2003-05: ML350 Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
2002-05: ML500 Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.65 3.5
2000-01: ML55 AMG Front . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
2002-03: ML55 AMG Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
2006-07:ML350, ML500:
Front . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Rear:
195mm HAM w/o differential lock . . . . . . 1.1 2.3
230mm HAMw/ differential lock . . . . . . . 1.6 3.4
R Class:2006-07:
Front . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Rear:
R350, R500 195mm HAM w/o differential lock . . . . . . . . 1.1 2.3
S Class:2002-05: S430, S500:
Front . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3Rear . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
2002: S55 AMG . . . . . . . . . . . . . . . . 1.6 3.42003-05: S55 AMG . . . . . . . . . . . . . 2.0 4.21998-99: S600 . . . . . . . . . . . . . . . . . 1.4 3.02001-06: S600 . . . . . . . . . . . . . . . . . 1.9 4.02006:
Front All 4Matic . . . . . . . . . . . . . . 0.6 1.3Rear:
S350, S430 4Matic, S500 4Matic . . . . . . . . . . . . . 1.1 2.3
S430, S500 . . . . . . . . . . . . . . . . 1.6 3.4S55 AMG, S65 AMG . . . . . . . . 1.9 4.0
2007:Front:
All 4Matic . . . . . . . . . . . . . . . . . 0.6 1.3Rear:
200mm . . . . . . . . . . . . . . . . . . . 1.1 2.3215mm . . . . . . . . . . . . . . . . . . . 1.2 2.5240mm 240FE . . . . . . . . . . . . . 1.6 3.4240mm 240V . . . . . . . . . . . . . . 1.9 4.0
SL Class:1998-01: SL500 . . . . . . . . . . . . . . . . 1.4 3.02002: SL500 . . . . . . . . . . . . . . . . . . 1.6 3.42003-05: SL500, SL55 . . . . . . . . . . . 1.4 3.01998-02: SL600 . . . . . . . . . . . . . . . . 1.4 3.02004-05: SL600 . . . . . . . . . . . . . . . . 1.4 3.0
CAPACITY, Refill: Liters Pt2006:
SL500, SL600,SL55 AMG w/o code 030:
198mm . . . . . . . . . . . . . . . . . 1.1 2.3210mm . . . . . . . . . . . . . . . . . 1.6 3.4215mm . . . . . . . . . . . . . . . . . 1.2 2.5240mm . . . . . . . . . . . . . . . . . 1.9 4.0
SL55 AMG w/ code 030, SL65 AMG . . . . . . . . . . . . . . . . 1.2 2.5
2007: SL550, SL600:
198mm . . . . . . . . . . . . . . . . . 1.1 2.3210mm . . . . . . . . . . . . . . . . . 1.6 3.4215mm . . . . . . . . . . . . . . . . . 1.2 2.5240mm . . . . . . . . . . . . . . . . . 1.9 4.0
SL55 AMG, SL65 AMG 215mm . . . . . . . . . . . . . . . . . 1.2 2.5
SLK Class:SLK230 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.72002-05: SLK32 AMG, SLK320 . . . . 1.2 2.52005-07: SLK55 AMG . . . . . . . . . . 1.2 2.52005-07: SLK350 . . . . . . . . . . . . . . 1.1 2.32006-07: SLK280 . . . . . . . . . . . . . . 1.0 2.1
1 Use Castrol SAF-XJ
LIMITED-SLIP IDENTIFICATION:Metal plate on rear of differential, near fill plugOTHER COMPONENTSPower Steering:
1998-00 C-Series, 1998-99 CL-Series, 1998-03 CLK-Series, 1998-03 E-series, 2007 GL-series, 1998-07 ML-series, 2006-07 R-Series, 1998-99 S-Series,1998-02 SL-series, 1998-04 SLK-series .PS1
2001-07 C-series, 2000-07 CL-series,2003-07 CLK-series, 2006-07 CLS-series,2003-07 E-series, 2000-07 S-series, 2003-07 SL-series, 2005-07 SLK-series . . . . . . . . . . . . . . . .SLF1
2002-05 G-Series: . . . . . . . . . . . . . . . . . . .SLFBrake Master Cylinder . . . . . . . . . . . . . . . . .HBHClutch Master Cylinder . . . . . . . . . . . . . . . .HB2Engine Control Linkage & 300TD Level
Control . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFBody & Sunroof Rails . . . . . . . . . . . . . . . . . . .LM1 For 2003 model year, CLK-series with designation 208 is PS, CLK-
series with designation 209 is SLF, E-series with designation 210 isPS, and E-series with designation 211 is SLF.
2 Fluid meeting DOT 4 plus requirements.
2008 ALL MODELSWITH FLEXIBLE SERVICE SYSTEM(FSS)CRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEO
All Temps . . . . . .0W-30, 5W-30, 0W-40, 5W-40, 5W-50Above -4°F (-20°C) .10W-30, 10W-40, 10W-50, 10W-60Above 5°F (-15°C) . . . . . . . . . . . . . . . .15W-40, 15W-50Above 23°F (-5°C) . . . . . . . . . . . . . . . .20W-40, 20W-50
CAPACITY, Refill1 Liters QtC Class:
C300, C300 Sport 2008 . . . . . . . . . . 8.0 8.5C300 4Matic, C300 4MATIC Sport 2008 8.0 8.5C350, C350 Sport, C350 4MATIC 2008 8.0 8.5C350 4MATIC Sport 2008 . . . . . . . . 8.0 8.5CL550 2008 . . . . . . . . . . . . . . . . . . . 8.5 9.0CL600 2008 . . . . . . . . . . . . . . . . . . . 9.0 9.5CL63 AMG 2008 . . . . . . . . . . . . . . . 8.75 9.2CLK350 2008 . . . . . . . . . . . . . . . . . 8.0 8.5CLK550 2008 . . . . . . . . . . . . . . . . . 8.5 9.0CLK63 AMG 2008 . . . . . . . . . . . . . . 8.8 9.3CLS550 2008 . . . . . . . . . . . . . . . . . 8.5 9.0CLS63 AMG 2008 . . . . . . . . . . . . . . 8.8 9.3
E Class:E320 2008 . . . . . . . . . . . . . . . . . . . . 8.5 9.0E350 2008 . . . . . . . . . . . . . . . . . . . . 8.0 8.5E550 2008 . . . . . . . . . . . . . . . . . . . . 8.5 9.0E63 AMG 2008 . . . . . . . . . . . . . . . . 8.8 9.3
GL Class:GL 320 CDI 2008 . . . . . . . . . . . . . . . 8.5 9.0GL 450 2008 . . . . . . . . . . . . . . . . . . 9.0 9.5GL 550 2008 . . . . . . . . . . . . . . . . . . 9.0 9.5
ML Class:ML 320 CDI 2008 . . . . . . . . . . . . . . 8.5 9.0ML 350 2008 . . . . . . . . . . . . . . . . . . 8.0 8.5ML 550 2008 . . . . . . . . . . . . . . . . . . 9.0 9.5ML 63 AMG 2008 . . . . . . . . . . . . . . 9.7 10.3
R Class:R 320 CDI 4MATIC 2008 . . . . . . . . . 8.5 9.0R 350 2008 . . . . . . . . . . . . . . . . . . . 8.0 8.5R 350 4MATIC 2008 . . . . . . . . . . . . 8.0 8.5R 550 4MATIC 2008 . . . . . . . . . . . . 9.0 9.5
S Class:S550 2008 . . . . . . . . . . . . . . . . . . . . 8.5 9.0S550 4MATIC 2008 . . . . . . . . . . . . . 8.5 9.0S600 2008 . . . . . . . . . . . . . . . . . . . . 9.0 9.5S63 AMG 2008 . . . . . . . . . . . . . . . . 8.75 9.2S65 AMG 2008 . . . . . . . . . . . . . . . . 10.5 11.0SL55 AMG 2008 . . . . . . . . . . . . . . . 8.5 9.0SL550 2008 . . . . . . . . . . . . . . . . . . . 8.5 9.0
CAPACITY, Refill1 Liters QtSL600 2008 . . . . . . . . . . . . . . . . . . . 8.0 8.5SL65 AMG 2008 . . . . . . . . . . . . . . . 8.0 8.5SLK280 2008 . . . . . . . . . . . . . . . . . . 8.0 8.5SLK350 2008 . . . . . . . . . . . . . . . . . . 8.0 8.5SLK55 AMG 2008 . . . . . . . . . . . . . . 8.0 8.5
1 Includes filter. On Models with oil coolers, additional oil may beneeded when oil cooler is drained. Allow 5 minutes after refilling orturning engine off before checking oil level.
TRANSMISSION/TRANSAXLEAutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill1, 2 Liters QtC Class:
C300, C300 Sport 2008 . . . . . . . . . . 9.0 9.5C300 4Matic, C300 4MATIC Sport 2008 9.7 10.2C350 2008 . . . . . . . . . . . . . . . . . . . . 9.0 9.5C350 4Matic, C350 4MATIC Sport 2008 9.7 10.2C350 Sport 2008 . . . . . . . . . . . . . . . 9.0 9.5CL550 2008 . . . . . . . . . . . . . . . . . . . 9.8 10.0CL600 2008 . . . . . . . . . . . . . . . . . . . 7.7 8.1CL63 AMG 2008 . . . . . . . . . . . . . . . 8.75 9.25CLK350 2008 . . . . . . . . . . . . . . . . . 8.5 9.0CLK550 2008 . . . . . . . . . . . . . . . . . 9.0 9.5CLK63 AMG 2008 . . . . . . . . . . . . . . 8.7 9.2CLS550 2008 . . . . . . . . . . . . . . . . . 9.2 9.7CLS63 AMG 2008 . . . . . . . . . . . . . . 8.5 9.0
E Class:E320 2008 . . . . . . . . . . . . . . . . . . . . 9.2 9.7E350, E550 2008 . . . . . . . . . . . . . . . 9.2 9.7E350, E550 4Matic 2008 . . . . . . . . . 8.1 8.6E63 AMG 2008 . . . . . . . . . . . . . . . . 8.8 9.3
GL Class:GL 320, GL450, GL550 2008 . . . . . . 9.0 9.5
ML Class:ML 320 CDI, ML 350, ML550 2008 . 9.0 9.5ML 63 AMG 2008 . . . . . . . . . . . . . . 9.2 9.7
R Class:R 320 CDI 4MATIC 2008 . . . . . . . . . 9.0 9.5R 350 2008 . . . . . . . . . . . . . . . . . . . 9.0 9.5R 350 4MATIC 2008 . . . . . . . . . . . . 9.0 9.5R 550 4MATIC 2008
S Class: . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.5S550 2008 . . . . . . . . . . . . . . . . . . . . 9.8 10.3S550 4MATIC 2008 . . . . . . . . . . . . . 9.6 10.1S600 2008 . . . . . . . . . . . . . . . . . . . . 7.7 8.1S63 AMG 2008 . . . . . . . . . . . . . . . . 8.75 9.2S65 AMG 2008 . . . . . . . . . . . . . . . . 8.7 9.2SL55 AMG 2008 . . . . . . . . . . . . . . . 8.6 9.1SL550 2008 . . . . . . . . . . . . . . . . . . . 9 9.5SL600 2008 . . . . . . . . . . . . . . . . . . . 7.5 7.9SL65 AMG 2008 . . . . . . . . . . . . . . . 7.5 7.9
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
2 Total capacity shown. Add less fluid when refilling.
TRANSMISSION/TRANSAXLE MANUALAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill Liters PtC300, C300 Sport 2008 . . . . . . . . . . . 1.5 3.2SLK280 2008 . . . . . . . . . . . . . . . . . . . 1.5 3.2SLK350 2008 . . . . . . . . . . . . . . . . . . . 1.5 3.2TRANSFER CASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill Liters PtC300 4MATIC, C300 4MATIC Sport 2008 NS NSC350 4MATIC 2008 . . . . . . . . . . . . . . . NS NSE350, E550 4MATIC 2008 . . . . . . . . . . 0.5 1.0GL320 CDI 2008 single speed . . . . . . 0.5 1.1GL320 CDI 2008 double speed . . . . . . 1.5 3.2GL450 2008 single speed . . . . . . . . . . 0.5 1.1GL450 2008 double speed . . . . . . . . . 1.5 3.2ML320 CDI 2008 . . . . . . . . . . . . . . . . . 0.5 1.1ML350 2008 . . . . . . . . . . . . . . . . . . . . 0.5 1.1DIFFERENTIALFront . . . . . . . . . . . . . . . . . . .85W-90. 90 GL-5Rear, Conventional . . . . . . . . .85W-90. 90 GL-5Rear, Limited-slip . . . . . . . . . . . . . . . .90 GL-5★★Rear S63, S65 AMG . . . . . . . . . . . . . . . . . . GLS1
SL65 AMG . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2
SL55 AMG, E63 AMG, CLS63 AMG:w/ Performance Pkg . . . . . . . . . . . . . . . GLS2
w/oPerformance Pkg . . . . . . . . .85W-90 GL-5CAPACITY, Refill Liters PtFront
C300 4MATIC,C300 4MATIC Sport 2008 . . . . . . 1.0 2.1
C350 4MATIC,C350 4MATIC Sport 2008 . . . . . . 1.1 2.3
E350 4MATIC 2008 . . . . . . . . . . . . . 1.6 3.3E550 4MATIC 2008 . . . . . . . . . . . . . 1.6 3.3GL, ML, R Series 2008 . . . . . . . . . . . 1.1 2.3
REARC300, C300 Sport 2008 . . . . . . . . . . 1.0 2.1C300 4MATIC,
C300 4MATIC Sport 2008 . . . . . . 1.0 2.1C350, C350 Sport 2008 . . . . . . . . . . 1.1 2.3C350 4MATIC 2008 . . . . . . . . . . . . . 1.1 2.3CL550 2008 . . . . . . . . . . . . . . . . . . . 1.2 2.5CL600 2008 . . . . . . . . . . . . . . . . . . . 1.6 3.4CL63 AMG 2008 . . . . . . . . . . . . . . . 1.2 2.5CLK350 2008 . . . . . . . . . . . . . . . . . 1.1 2.3CLK550 2008 . . . . . . . . . . . . . . . . . 1.2 2.5
133
CARS & LIGHT TRUCKSMERCEDES BENZ Continued
CAPACITY, Refill Liters PtCLK63 AMG 2008 . . . . . . . . . . . . . . 1.2 2.5CLS550 2008 . . . . . . . . . . . . . . . . . 1.3 2.7CLS63 AMG 2008 . . . . . . . . . . . . . . 1.2 2.5E320 2008 . . . . . . . . . . . . . . . . . . . . 1.3 2.7E350, E550 2008 . . . . . . . . . . . . . . . 1.3 2.7E350, E550 4MATIC 2008 . . . . . . . . 1.6 3.4E63 AMG 2008 . . . . . . . . . . . . . . . . 1.2 2.5GL320 CDI 2008
Without Differential lock . . . . . . . . 1.1 2.3With Differential lock . . . . . . . . . . 1.6 3.4
GL450 2008 Without Differential lock . . . . . . . . 1.1 2.3With Differential lock . . . . . . . . . . 1.6 3.4
GL550 2008 Without Differential lock . . . . . . . . 1.1 2.3With Differential lock . . . . . . . . . . 1.6 3.4
ML 320 CDI 2008 . . . . . . . . . . . . . . 1.1 2.3ML 350 2008 . . . . . . . . . . . . . . . . . . 1.1 2.3ML 550 2008 . . . . . . . . . . . . . . . . . . 1.1 2.3ML 63 AMG 2008 . . . . . . . . . . . . . . 1.1 2.3R 320 CDI 4MATIC 2008 . . . . . . . . . 1.1 2.3R 350 2008 . . . . . . . . . . . . . . . . . . . 1.1 2.3R 350 4MATIC 2008 . . . . . . . . . . . . 1.1 2.3R 550 4MATIC 2008 . . . . . . . . . . . . 1.1 2.3S 550 2008 . . . . . . . . . . . . . . . . . . . 1.2 2.5S 550 4MATIC 2008 . . . . . . . . . . . . . 1.8 3.8S 600 2008 . . . . . . . . . . . . . . . . . . . 2.0 4.2S 63 AMG 1 2008 . . . . . . . . . . . . . . . 1.2 2.5S 65 AMG 1 2008 . . . . . . . . . . . . . . . 1.6 3.4SL 55 2008 . . . . . . . . . . . . . . . . . . . 1.2 2.5SL 550 2008 . . . . . . . . . . . . . . . . . . 1.2 2.5SL 600 2008 . . . . . . . . . . . . . . . . . . 1.2 2.5SL 65 AMG 2008 . . . . . . . . . . . . . . . 1.2 2.5SLK280 2008 . . . . . . . . . . . . . . . . . . 1.0 2.1SLK350 2008 . . . . . . . . . . . . . . . . . . 1.1 2.3SLK55 AMG 2008 . . . . . . . . . . . . . . 1.2 2.5
1 Use Fuchs Titan EG 5010 D or equivalent.2 Use Castrol SAF-XJ.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . . .PSClutch Master Cylinder . . . . . . . . . . . . . . . .HBH
MINI2002-08 COOPER, COOPER SCRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEOCAPACITY, Refill1: Liters Qt2002-08 1.6L (W10) . . . . . . . . . . . . . . . 4.5 4.82002-08 1.6L Super Charged (W11) . . 4.8 5.12007-08 1.6L (N12) . . . . . . . . . . . . . . . 4.2 4.42007-08 1.6L Turbo (N14) . . . . . . . . . . 4.2 4.41 Capacity shown includes filter. After refill check oil level.
TRANSAXLE, AutomaticECVT (Electronic Continuously
Variable Transmission) . . . . . . . . . . . . . . . .VTF6-Speed AT GA6F21WA . . . . . . . . . . . . . . . . .TIVCAPACITY, Refill: Liters Qt2004-08 ECVT . . . . . . . . . . . . . . . . . . . 5.0 5.32005-08 6-Speed GA6F21WA
(Pan removal) . . . . . . . . . . . . . . . . . . 4.0 4.2TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters QtCooper (R50) 2002-06:
Up to 7/2004 Production . . . . . . . . . 2.0 4.2From 7/2004 Production . . . . . . . . . 1.7 3.6
Cooper (R56) 2007-08 . . . . . . . . . . . . . 1.7 3.6Cooper S Convertible (R52) 2005-08 . 1.7 3.6Cooper S (R53) 2002-06 . . . . . . . . . . . 1.7 3.6Cooper S (R56) 2007-08 . . . . . . . . . . 1.9 4.0OTHER COMPONENTSBrake fluid reservoir . . . . . . . . . . . . . . . . . . . .HBClutch fluid reservoir . . . . . . . . . . . . . . . . . . . .HBPower Steering reservoir . . . . . . . . . . . . . . . . .PSWheel Bearings . . . . . . . . . . . . . . . . . . . . . . .LM
MITSUBISHI1997-99 ALL MODELS EXCEPTPICKUP, MONTERO, MONTEROSPORTCRANKCASE: . . . . . . . . . . . . . . . . . . .API★★Diamante, Expo & Mirage:
Above 0°F (18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
Eclipse:1997-99:
2.0L Non-Turbo:Above -10°F (-23°C) . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . .5W-301
2.0L Turbo:Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . .20W-40Above -10°F (-23°C) . . . . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . . .5W-302
2.4L:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . .5W-301
Galant:1997-99:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . .5W-301
3000 GT:3.0L Non-Turbo:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . .5W-301
3.0L Turbo:Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . .20W-40Above -10°F (-23°C) . . . . . . . . . . . . . . . . . . . .10W-30Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters QtDiamante:
3.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
Eclipse:2.0L Non-Turbo . . . . . . . . . . . . . . . . 4.3 4.52.0L Turbo . . . . . . . . . . . . . . . . . . . . 4.4 4.72.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
Expo:1.8L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
Galant:2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.0L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
Mirage:1.5L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.51.8L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0
3000 GT:3.0L Non-Turbo . . . . . . . . . . . . . . . . 4.3 4.53.0L Turbo . . . . . . . . . . . . . . . . . . . . 4.6 4.9
1 Preferred.2 SAE 5W-30 may be used in cold climate areas where lowest tem-
perature is below -10°F (-23°C).3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, Automatic1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF
CAPACITY, Initial Refill1: Liters QtDiamante:
1997-99 . . . . . . . . . . . . . . . . . . . . . . 8.53 9.03
Eclipse:2.0L Non-Turbo . . . . . . . . . . . . . . . . 3.8 4.02.0L Turbo:
1997 . . . . . . . . . . . . . . . . . . . . . . . 6.72 7.12
1998-99 . . . . . . . . . . . . . . . . . . . . 2.53 2.63
2.4L:1997 . . . . . . . . . . . . . . . . . . . . . . . 6.12 6.52
1998-99 . . . . . . . . . . . . . . . . . . . . 3.8 4.0Expo:
FWD . . . . . . . . . . . . . . . . . . . . . . . 6.12 6.52
AWD . . . . . . . . . . . . . . . . . . . . . . . 6.52 6.92
Galant:1997 . . . . . . . . . . . . . . . . . . . . . . . 6.02 6.42
1998-99 . . . . . . . . . . . . . . . . . . . . . . 3.53 3.83
Mirage:1997-99 . . . . . . . . . . . . . . . . . . . . . . 3.53 3.83
3000 GT:1997 . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.81998-99 . . . . . . . . . . . . . . . . . . . . . . 3.03 3.23
1 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in NEUTRAL and add fluid asneeded.
2 Total capacity. When refilling, add ATF until fluid level is at coldmark on dipstick. Start engine & allow transmission/transaxle toreach operating temperature, then refer to Note 1.
3 Initial refill capacity when transmission is drained BOTH throughcooler line with engine running and then plug on bottom of trans-mission with engine off.
TRANSAXLE, Manual1997-99 Eclipse, 2.0L Non-Turbo . . . . . . . .GLS1
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All Temperatures . . . . . . . . . . . . . . . . .75W-90, 75W, 85WCAPACITY, Refill: Liters PtEclipse:
FWD . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2AWD:
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.71998-99 . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Expo:1.8L FWD . . . . . . . . . . . . . . . . . . . . 1.8 3.82.4L FWD . . . . . . . . . . . . . . . . . . . . 2.3 4.9AWD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Galant:2.4L
1997-99 . . . . . . . . . . . . . . . . . . . . 2.2 4.73.0L . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0
Mirage:1997-99
1.5L . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.41.8L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7
3000 GT: FWD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9AWD . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.1
1 Texaco MTX Fluid FM
TRANSFER CASE . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . .75W-90, 75W-85W CAPACITY, Refill: Liters PtExpo . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3Eclipse . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.13000GT . . . . . . . . . . . . . . . . . . . . . . . 0.3 0.6
DIFFERENTIAL, AWD REAR . . . . . . . . .GL-5Above -10°F (-23°C), . . . . . . . . . . . .90, 85W-90, 80W-90-30° to -10°F (-34° to -23°C) . . . . . . . . . . . .80W, 80W-90Below -30°F (-34°C) . . . . . . . . . . . . . . . . . . . . . . . . . .75WCAPACITY, Refill: Liters PtExpo . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5Eclipse . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.93000GT . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2000-08 ALL MODELSEXCEPT PICKUP, MONTERO,MONTERO SPORT, OUTLANDER,ENDEAVOR, RAIDERCRANKCASE: . . . . . . . . . . . . . . . .SL, API★★2000-04:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
2005-08 ex. Turbo:
Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . .5W-201
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30with Turbo
All temperatures . . . . . . . . . . . . . . . . . . . . . .10W-301
CAPACITY, Refill2: Liters QtDiamante, Eclipse, Galant:
ex. 2004-08 3.8L . . . . . . . . . . . . . . . 4.3 4.52004-08 3.8L . . . . . . . . . . . . . . . . . . 4.6 4.9
Lancer ex. Lancer Evolution III:2.0L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02.4L, 2008 2.0L . . . . . . . . . . . . . . . . 4.3 4.5
Evolution III 2.0L:2003-05 . . . . . . . . . . . . . . . . . . . . . . 5.13 5.43
2006 . . . . . . . . . . . . . . . . . . . . . . . 5.33 5.63
Mirage:1.5L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.51.8L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0
1 Preferred.2 Capacity shown includes filter. After refill, check oil level.3 Use 10W-30 fully synthetic engine oils. Use of conventional motor
oils may cause engine or turbocharger damage.
TRANSAXLE, Automatic2008 Lancer . . . . . . . . . . . . . . . . . . . . . . . . .VTFAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill1: Liters QtMirage 2000-02 . . . . . . . . . . . . . . . . . . 3.52 3.72
Galant:2000-03 . . . . . . . . . . . . . . . . . . . . . . 3.52 3.72
2004-08:2.4L . . . . . . . . . . . . . . . . . . . . . . . 7.73 8.13
3.8L . . . . . . . . . . . . . . . . . . . . . . . 8.43 8.93
Eclipse:2.4L . . . . . . . . . . . . . . . . . . . . . . . 7.73 8.13
3.0L, 3.8L . . . . . . . . . . . . . . . . . . . . 8.43 8.93
Diamante . . . . . . . . . . . . . . . . . . . . . . . 8.43 8.93
Lancer . . . . . . . . . . . . . . . . . . . . . . . 7.73 8.131 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded.
2 Initial refill capacity when transmission is drained BOTH throughcooler line with engine running and then plug on bottom of trans-mission with engine off.
3 Total capacity. When refilling, add ATF until fluid level is at coldmark on dipstick. Start engine & allow transmission/transaxle toreach operating temperature, then refer to Note 1.
TRANSAXLE, Manual2006-07 Eclipse . . . . . . . . . . . . . . . . . . . . . .GL-3Others . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures
2005-06 Lancer w/ 6-speed . . . . . . . . . . . . . .75W-85W2006-07 Eclipse . . . . . . . . . . . . . . . . . . . . . . . .75W-80All Others . . . . . . . . . . . . . . . . . . . . .75W-90, 75W-85W
CAPACITY, Refill: Liters PtMirage:
1.5L . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.41.8L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7
Galant:2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.73.0L . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0
Eclipse:2000-05
2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.73.0L . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0
2006-08 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7Lancer ex. Lancer Evolution III
2000-07 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.72008 . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
Lancer Evolution III:5-speed:
2003-04 . . . . . . . . . . . . . . . . . . . . 2.8 6.02005-06 . . . . . . . . . . . . . . . . . . . . 2.2 4.7
6-speed . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0Diamante . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0TRANSFER CASE . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtLancer Evolution III . . . . . . . . . . . . . . . 0.6 1.3DIFFERENTIAL, rear . . . . . . . . . . . . .GL-5★★
CARS & LIGHT TRUCKS
134
MERCEDES BENZ Continued • MINI • MITSUBISHI
Above -10°F (-23°C) . . . . . . . . . . . . .90, 85W-90, 80W-90-30 to -10°F (-34 to -23°C) . . . . . . . . . . . . . .80W, 80W-90Below -30°F (-34°C) . . . . . . . . . . . . . . . . . . . . . . . . . .75WCAPACITY, Refill: Liters PtLancer Evolution III . . . . . . . . . . . . . . . 0.6 1.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
1997-08 PICKUP, MONTERO,MONTERO SPORT, OUTLANDER,ENDEAVOR, RAIDERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997-2004:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
2005-08 ex. RaiderAbove 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . . . .5W-201
RaiderAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill:2 Liters Qt2.4L:
1997-2006 . . . . . . . . . . . . . . . . . . . . 4.3 4.63.0L:
Montero . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2Montero Sport . . . . . . . . . . . . . . . . . 4.5 4.8Outlander . . . . . . . . . . . . . . . . . . . . 4.3 4.6
3.5L:Montero . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2Montero Sport . . . . . . . . . . . . . . . . . 4.6 4.9
3.7L:Raider . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
3.8L:Montero . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2Endeavor . . . . . . . . . . . . . . . . . . . . . 4.3 4.6
4.7L:Raider . . . . . . . . . . . . . . . . . . . . . . . 5.6 6.0
1 Preferred.2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, Automatic1997-98 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF21999:
Montero . . . . . . . . . . . . . . . . . . . . . . . . . . .AF2Montero Sport:
4AT Trans. . . . . . . . . . . . . . . . . . . . . . . . .AF2INVECS-II 4AT Trans. . . . . . . . . . . . . . . .SLF
2000:Montero . . . . . . . . . . . . . . . . . . . . . . . . . . .AF2Montero Sport . . . . . . . . . . . . . . . . . . . . . .SLF
2001-07 All . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Initial Refill1: Liters QtMontero:
1997-2000 . . . . . . . . . . . . . . . . . . . . 5.5 5.82001-02 . . . . . . . . . . . . . . . . . . . . . . 2.0 2.12003-05 . . . . . . . . . . . . . . . . . . . . . . 9.32 9.82
2006 . . . . . . . . . . . . . . . . . . . . . . . 9.72 10.22
Pickup . . . . . . . . . . . . . . . . . . . . . . . 1.9 2.0Montero Sport . . . . . . . . . . . . . . . . . . . 9.72 10.22
Outlander:FWD . . . . . . . . . . . . . . . . . . . . . . . 7.72 8.12
AWD . . . . . . . . . . . . . . . . . . . . . . . 8.12 8.62
Endeavor:FWD . . . . . . . . . . . . . . . . . . . . . . . 8.42 8.92
AWD . . . . . . . . . . . . . . . . . . . . . . . 8.82 9.32
Raider:42RLE . . . . . . . . . . . . . . . . . . . . . . . 3.83 4.03
545RFE 2WD . . . . . . . . . . . . . . . . . . 5.23 5.53
545RFE 4WD . . . . . . . . . . . . . . . . . . 6.23 6.631 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in NEUTRAL and add fluid asneeded.
2 Total capacity. When refilling, add ATF until fluid level is at coldmark on dipstick. Start engine & allow transmission/transaxle toreach operating temperature, and then refer to Note 1.
3 Service fill capacity. When refilling, add ATF until fluid level is at coldmark on dipstick. Start engine & allow transmission/transaxle toreach operating temperature, and then refer to Note 1.
TRANSMISSION, ManualAll ex. Raider
All temperatures . . . . . .75W-90, 75W-85 GL-4Raider . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4CAPACITY, Refill: Liters PtMontero:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 3.2 6.8Montero Sport:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.91999:
R5M21 trans. . . . . . . . . . . . . . . . . 2.3 4.9V5MT1 trans. . . . . . . . . . . . . . . . . 2.5 5.3
Raider G238 trans . . . . . . . . . . . . . . . . 2.2 4.7Pickup/Truck:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.93.0L . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
Outlander: FWD . . . . . . . . . . . . . . . . . 2.2 4.7AWD . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
TRANSFER CASEEndeavor & Outlander . . . . . . . . . . . . . . . . .GL-5
All Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
Raider . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4All Others . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4
All Temperatures . . . . . . . . . . . . . . . . .75W-90, 75W-85CAPACITY, Refill: Liters PtEndeavor . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.2Outlander . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1Montero:
1997-2000 . . . . . . . . . . . . . . . . . . . . 2.5 5.32001-06 . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0
Montero Sport:1997-98 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.91999:
w/MT . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9w/AT . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
2000-04 . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3Pickup/Truck . . . . . . . . . . . . . . . . . . . . 2.3 4.9Raider:
NV233 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5NV244 . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9
DIFFERENTIALSAll ex. Raider
Limited-Slip . . . . . . . . . . . . . . . . . . . . . .GL-5★★Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above -10°F (-23°C), . . . . . . . . . . .90, 85W-90, 80W-90-30° to -10°F (-34° to -23°C) . . . . . . . . . . .80W, 80W-90Below -30°F (-34°C) . . . . . . . . . . . . . . . . . . . . . . . .75W
RaiderFront . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSAll temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-140
CAPACITY, Refill: Liters PtFront:
Montero: 1997-2000 . . . . . . . . . . . . . . . . . . 1.1 2.32001-06 . . . . . . . . . . . . . . . . . . . . 1.2 2.6
Montero Sport: 1997-99 3.0L . . . . . . . . . . . . . . . . 1.1 2.31999 3.5L . . . . . . . . . . . . . . . . . . . 0.9 1.92000-04 . . . . . . . . . . . . . . . . . . . . 0.9 1.9
Pickup/Truck . . . . . . . . . . . . . . . . . . 1.1 2.3Raider . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6
Rear:Endeavor . . . . . . . . . . . . . . . . . . . . . 1.1 2.3Outlander . . . . . . . . . . . . . . . . . . . . 0.5 1.1Montero:
1997-2000 . . . . . . . . . . . . . . . . . . 3.2 6.82001-06 . . . . . . . . . . . . . . . . . . . . 1.6 3.4
Montero Sport: 2.4L . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.23.0L . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.53.5L . . . . . . . . . . . . . . . . . . . . . . . 3.2 6.8
Pickup/Truck: 2WD . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.24WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5
Raider:8 1/4” axle . . . . . . . . . . . . . . . . . . 2.01 4.41
9 1/4” axle . . . . . . . . . . . . . . . . . . 2.11 4.511 For limited slip, add 4 oz Limited Slip Additive MS-10111.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF22000-08
All ex. Raider . . . . . . . . . . . . . . . . . . . . . . .PSRaider . . . . . . . . . . . . . . . . . . . . . . . . . . .AP4
Suspension & Steering Linkage, Propeller Shaft, Wheel Bearings . . . . . . . . .LM
NISSAN1997-99 ALL MODELS EXCEPT FRONTIER, PICKUPTRUCK, PATHFINDER, XTERRACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .10W-301
Below 60°F (16°C), 300ZX . . . . . . . . . . . . . . . . . . . .5W-30All temperatures, Others . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters QtAltima:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 3.9 4.11999 . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.6
Maxima . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2Quest:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21999 . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0
Sentra:1.6L:
1997-98 . . . . . . . . . . . . . . . . . . . . 3.2 3.41999 . . . . . . . . . . . . . . . . . . . . . . . 3.0 3.2
2.0L . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.6200SX . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.6240SX . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Preferred for 300ZX2 Preferred3 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, TRANSAXLE, Automatic 1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
CAPACITY Refill2: Liters QtAltima, Quest, Stanza . . . . . . . . . . . . . 9.4 10.0Maxima:
SOHC . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.8DOHC . . . . . . . . . . . . . . . . . . . . . . . 9.4 9.9
Sentra, 200SX: 3-speed . . . . . . . . . . . . . . . . . . . . . . 6.3 6.64-speed . . . . . . . . . . . . . . . . . . . . . . 7.0 7.3
240SX . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.71 Continental USA & Alaska, use NissanMatic D. Canada use Nissan
ATF. Dexron III®/Mercon® may be used as alternative.2 Total (dry) fill shown. When refilling, measure amount drained &
refill with equal amount of new fluid. Start engine & allow transmis-sion to reach operating temperature. With service & parking brakeapplied, move gear shift through all gear positions ending withpark. Check fluid level with dipstick.
TRANSMISSION/TRANSAXLE, Manual All . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-41998-99 Sentra, 200SX, Altima, Maxima:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90All Others:
Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . .14030° to 100°F (-1° to 38°C) . . . . . . . . . . . . . . . . . . . . . .9010° to 85°F (-12° to 29°C) . . . . . . . . . . . . . . . . . . . .85WBelow 100°F (38°C) . . . . . . . . . . . . . .75W-90, 80W-901
Below 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . .80WBelow 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . .75W
1 75W-90 preferred, RWD, 80W-90 preferred, FWDCAPACITY, Refill: Liters PtAltima:
1997 RS5F50A . . . . . . . . . . . . . . . . . . . 4.82 10.12
RS5F50V . . . . . . . . . . . . . . . . . . . 4.52 9.52
1998-99 . . . . . . . . . . . . . . . . . . . . . . 4.82 10.12
Maxima: 1997-99:
RSF50A, RS5F50A . . . . . . . . . . . 4.82 10.12
RSF50V, RS5F50V . . . . . . . . . . . . . . . 4.52 9.52
Sentra, 200SX:4-speed . . . . . . . . . . . . . . . . . . . . . . 2.7 5.85-speed
1.6L:1997 . . . . . . . . . . . . . . . . . . . . . 3.0 6.31998-99 . . . . . . . . . . . . . . . . . . 3.02 6.42
2.0L:1997 . . . . . . . . . . . . . . . . . . . . . 3.8 8.01998-99 . . . . . . . . . . . . . . . . . . 3.62 8.02
Stanza . . . . . . . . . . . . . . . . . . . . . . . 4.7 10.0240SX:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 2.5 5.21 75W-90 preferred, RWD, 80W-90 preferred, FWD2 To prevent overfilling at oil changes, add 0.5 liter (0.5 quart) less
than capacity shown, start engine, let run until engine operatingtemperature is approximately 60°C (140°F). Switch engine off, wait3 minutes, check fluid level. May be more or less than 0.5 liter (0.5quart) depending on the model.
DIFFERENTIALLimited-Slip . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . .80W-901, 2
Standard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . .80W-901, 2
CAPACITY, Refill: Liters Pt240SX:
1997-98 . . . . . . . . . . . . . . . . . . . . . . 1.3 2.71 Preferred2 Other viscosities see Transmission/Transaxle Manual. Above
above 0°F (-18°C) 90W may be used
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, AF3
2000-08 ALL MODELS EXCEPTARMADA, FRONTIER, MURANO,PATHFINDER, TITAN, PICKUPTRUCK, XTERRACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . .10W-30, 10W-40All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtAltima:
2.4L 2000-01 . . . . . . . . . . . . . . . . . . 3.4 3.62.5L:
2002 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22003-06 . . . . . . . . . . . . . . . . . . . . 4.2 4.4
3.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42007-08 . . . . . . . . . . . . . . . . . . . . . . 4.6 4.9
Maxima:2000-01 . . . . . . . . . . . . . . . . . . . . . 4.0 4.22002-08 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4
Quest: 2000-02 . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02004-08 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
Sentra: 1.8L . . . . . . . . . . . . . . . . . . . . . . . 2.7 2.92.0L
1998-2001 . . . . . . . . . . . . . . . . . . 3.4 3.62007-08 . . . . . . . . . . . . . . . . . . . . 3.9 4.1
135
CARS & LIGHT TRUCKSMITSUBISHI Continued • NISSAN
CAPACITY, Refill2: Liters Qt2.5L:
2002 . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42003-06 . . . . . . . . . . . . . . . . . . . . 4.0 4.22007-08 . . . . . . . . . . . . . . . . . . . . 4.3 4.5
350Z2003-06 . . . . . . . . . . . . . . . . . . . . 4.7 5.02007 . . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2
Versa . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.11 Preferred2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION, TRANSAXLE,Automatic
Altima:2000-04 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
2005-06: w/ 4-cyl . . . . . . . . . . . . . . . . . . . . . . . . .AF31
w/ 6-cyl . . . . . . . . . . . . . . . . . . . . . . . . . .SLF2007-08 w/CVT ex. Hybrid . . . . . . . . . . . .VTF3
2007-08 Hybrid . . . . . . . . . . . . . . . . . . . . .VTFMaxima:
2000-03 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
2004-06: w/ 4-speed . . . . . . . . . . . . . . . . . . . . . . .AF31
w/ 5-speed . . . . . . . . . . . . . . . . . . . . . . .SLF2007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .VTF3
Quest:2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
2004-06: w/ 4-speed . . . . . . . . . . . . . . . . . . . . . . .AF31
2004-08w/ 5-speed . . . . . . . . . . . . . . . . . . . . . . .SLF
350Z . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFVersa
Automatic . . . . . . . . . . . . . . . . . . . . . . . . . .SLFw/CVT . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTF3
Sentra:2000-06 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
2007-08 CVT . . . . . . . . . . . . . . . . . . . . . . .VTFCAPACITY Refill2: Liters QtAltima:
2000-01 . . . . . . . . . . . . . . . . . . . . . . 9.4 9.92002-04 . . . . . . . . . . . . . . . . . . . . . . 9.2 9.72005-06:
w/ 4-cyl . . . . . . . . . . . . . . . . . . . . 9.2 9.7w/ 6-cyl . . . . . . . . . . . . . . . . . . . . 7.3 7.7
2007-08 CVT ex. Hybrid2.5L . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.83.5L . . . . . . . . . . . . . . . . . . . . . . . 10.2 10.8
2007-08 Hybrid . . . . . . . . . . . . . . . . 4.1 4.3Maxima:
2000-03 . . . . . . . . . . . . . . . . . . . . . . 8.5 9.02004-06:
w/ 4-speed . . . . . . . . . . . . . . . . . . 9.2 9.7w/ 5-speed . . . . . . . . . . . . . . . . . . 7.3 7.7
2007-08 CVT . . . . . . . . . . . . . . . . . . 10.0 10.6Quest:
2000-02 . . . . . . . . . . . . . . . . . . . . . . 9.4 9.92004-07:
w/ 4-speed . . . . . . . . . . . . . . . . . . 8.9 9.4w/ 5-speed . . . . . . . . . . . . . . . . . . 7.3 7.7
2008 . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.8Sentra:
2000-061.8L, 2.0L . . . . . . . . . . . . . . . . . . . 7.0 7.42.5L . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0
2007-08 CVT . . . . . . . . . . . . . . . . . . 8.3 8.8350Z . . . . . . . . . . . . . . . . . . . . . . . 10.3 10.9Versa:
Automatic . . . . . . . . . . . . . . . . . . . . 7.9 8.3w/CVT . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.8
1 Continental USA & Alaska, use NissanMatic D. Canada use NissanATF. Dexron III®/Mercon® may be used as alternative. 2004-07,350Z Using automatic transmission fluid other than Genuine NissanMatic J ATF will cause deterioration in driveability and durability,and may damage transmission. which is not covered by the Nissannew vehicle limited warranty.
2 Total (dry) fill shown. When refilling, measure amount drained & refillwith equal amount of new fluid. Start engine & allow transmissionto reach operating temperature. With service & parking brakeapplied, move gear shift through all gear positions ending withpark. Check fluid level with dipstick.
3 Using transmission fluid other than genuine Nissan CVT fluid NS2will damage the CVT transmission, which is not covered by the NIS-SAN new vehicle limited warranty.
TRANSMISSION/TRANSAXLE, ManualAltima, Maxima: . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures
2000 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-902001-02 . . . . . . . . . . . . . . . . . . . . . . .75W-85, 75W-902003 . . . . . . . . . . . . . . . . . . . . . . . . .75W-85, 80W-902004-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-85
Sentra . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures
2000-01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90 2002-03 . . . . . . . . . . . . . . . . . . . . . . .75W-85, 80W-902004-06:
w/ 1.8L . . . . . . . . . . . . . . . . . . . . . .75W-90, 80W-90w/ 2.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-85
2007-08:w/ 2.0L . . . . . . . . . . . . . . . . . . . . . . . .75W-80 GL-4w/ 2.5L . . . . . . . . . . . . . . . . . . . . . . . .75W-85 GL-4
350Z . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures
2003-07 . . . . . . . . . . . . . . . . . . . . . . .75W-85, 75W-90Versa . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-42007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75W80CAPACITY, Refill: Liters PtAltima:
2000-01 . . . . . . . . . . . . . . . . . . . . . . 4.5-4.8 9.5-10.12002 . . . . . . . . . . . . . . . . . . . . . . . 3.2 6.82003-04 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.82005-06 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.62007 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6
Maxima: 2000-01 . . . . . . . . . . . . . . . . . . . . . . 4.5 9.52002-04 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.92005-07 . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
Sentra: 2000-01 . . . . . . . . . . . . . . . . . . . . . . 3.0 6.32002-06: 1.8L . . . . . . . . . . . . . . . . . 3.0 6.3
2.5L . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.92007-08 . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
350Z:2003-07 . . . . . . . . . . . . . . . . . . . . . 2.9 6.1
Versa . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2DIFFERENTIAL . . . . . . . . . . . . . . . . . . GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90350Z:
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90temperatures above 32°F (0°C) . . . . . . . . . . . . . . . . .90
CAPACITY, Refill: Liters Pt350Z . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir
2000-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
1997 PICKUP, PATHFINDER,TRUCK, XTERRA; INCLUDES 1997INFINITI QX4CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . .10W-30, 10W-40All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt2.4L:
2WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.14WD . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5
3.0L: 2WD . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.24WD . . . . . . . . . . . . . . . . . . . . . . . 3.4 3.6
3.3L . . . . . . . . . . . . . . . . . . . . . . . 3.7 4.01 Preferred2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31
CAPACITY, Total Fill2: Liters QtPathfinder, QX4:
1997:2WD . . . . . . . . . . . . . . . . . . . . . . . 8.3 8.74WD . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0
Pickup, Truck:1997 . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.3
1 Continental USA & Alaska, use NissanMatic D. Canada use NissanATF. Dexron III®/Mercon® may be used as alternative.
2 Total (dry) fill shown. When refilling, measure amount drained & refillwith equal amount of new fluid. Start engine & allow transmissionto reach operating temperature. With service & parking brakeapplied, move gear shift through all gear positions ending withpark. Check fluid level with dipstick.
TRANSMISSION, Manual . . . . . . . . . . .GL-4Above 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .14030° to 100°F (-1° to 38°C) . . . . . . . . . . . . . . . . . . . . . . .9010° to 85°F (-12° to 29°C) . . . . . . . . . . . . . . . . . . . . . .85WBelow 100°F (38°C) . . . . . . . . . . . . . . .75W-901, 80W-902
Below 85°F (29°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .80WBelow 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .75WCAPACITY, Refill: Liters PtPathfinder:
1997:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.14WD . . . . . . . . . . . . . . . . . . . . . . . 5.0 10.7
Pickup, Truck:1997:
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.24WD . . . . . . . . . . . . . . . . . . . . . . . 4.9 10.4
1 Preferred in MT2 Preferred in differential
TRANSFER CASE . . . . . . . . . . . . .AF2, AF3CAPACITY, Refill: Liters PtPart time . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.7All-mode . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.2DIFFERENTIALLimited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . .90 may be used
Standard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-51
1 See Transmission, Manual for viscosityCAPACITY, Refill: Liters PtPathfinder, QX4:
Front:1997 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.3
Rear . . . . . . . . . . . . . . . . . . . . . . . 2.7 5.8Pickup, Truck:
Front: 2.4L . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.73.0L . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.1
Rear: 3.0L:
1997: axle H190A . . . . . . . . . . . . . . 1.5 3.1axle C200 . . . . . . . . . . . . . . . 1.3 2.7axle H233B . . . . . . . . . . . . . . 2.7 5.8
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . .AF2, AF31998-2008 ARMADA, FRONTIER,MURANO, PATHFINDER, TITAN,XTERRA; INCLUDES 1998-2003 INFINITI QX4CRANKCASE . . . . . . . . . . . . . . . . . . . API★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . .10W-30, 10W-40All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtArmada . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.6Frontier
2000-03: 2.4L:
2WD . . . . . . . . . . . . . . . . . . . . . 3.5 3.74WD . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
3.3L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.52004:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.73.3L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5
2005-08:2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.9 5.24.0L . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.4
Murano . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2Pathfinder:
3.3L . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.93.5L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.34.0L . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.45.6L . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.6
QX-4: 3.3L . . . . . . . . . . . . . . . . . . . . . . . 3.7 4.63.5L . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3
Titan . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.6Xterra:
2000-03: 2.4L
2WD . . . . . . . . . . . . . . . . . . . . . 3.5 4.04WD . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
3.3L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.52004:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.73.3L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5
2005-06:4.0L . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.4
1 Preferred2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, AutomaticMurano . . . . . . . . . . . . . . . . . . . . . . . . . . . . .VTF2
Titan 2004-07 . . . . . . . . . . . . . . . . . . . . . . . .SLF3
All Others Models ex. Murano,Titan 1998-2004 . . . . . . . . . . . . . . . . . . . . . . . . .AF31
2005-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF3
CAPACITY, Total Fill4: Liters QtArmada, . . . . . . . . . . . . . . . . . . . . . . 10.6 11.2Frontier, Xterra:
1998-2004:2.4L . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.33.3L
2WD . . . . . . . . . . . . . . . . . . . . . 8.3 8.84WD . . . . . . . . . . . . . . . . . . . . . 8.5 9.0
2005-08 . . . . . . . . . . . . . . . . . . . . . . 10.3 10.9Pathfinder:
1998-2004:2WD:
1998-99 . . . . . . . . . . . . . . . . . . 8.3 8.82000 . . . . . . . . . . . . . . . . . . . . . 8.1 8.62001-04 . . . . . . . . . . . . . . . . . . 8.5 9.0
4WD . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.02005-07 . . . . . . . . . . . . . . . . . . . . . . 10.3 11.02008:
4.0L . . . . . . . . . . . . . . . . . . . . . . . 10.3 10.95.6L . . . . . . . . . . . . . . . . . . . . . . . 10.6 11.2
Infinity QX4:2WD:
1998-99 . . . . . . . . . . . . . . . . . . 8.3 8.82000 . . . . . . . . . . . . . . . . . . . . . 8.1 8.62001-03 . . . . . . . . . . . . . . . . . . 8.5 9.0
4WD . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0Murano, CVT . . . . . . . . . . . . . . . . . . . . 10.2 10.8Titan . . . . . . . . . . . . . . . . . . . . . . . 10.6 11.21 Continental USA & Alaska, use NissanMatic D. Canada use Nissan
ATF. Dexron III®/Mercon® may be used as alternative.
CARS & LIGHT TRUCKS
136
NISSAN Continued
2 Using transmission fluid other than Genuine Nissan CVT Fluid NS-2 will damage the CVT transmission, which is not covered by theNISSAN new vehicle limited warranty.
3 Using automatic transmission fluid other than Genuine NissanMatic J ATF will cause deterioration in driveability and durability,and may damage transmission. which is not covered by the Nissannew vehicle limited warranty.
4 Total (dry) fill shown. When refilling, measure amount drained & refillwith equal amount of new fluid. Start engine & allow transmissionto reach operating temperature. With service & parking brakeapplied, move gear shift through all gear positions ending withpark. Check fluid level with dipstick.
TRANSMISSION, ManualAll Models: 1998-2008 . . . . . . . . . . . . . . . .GL-4
All temperatures1998-2001 . . . . . . . . . . . . . . . . . . . . . . . . .75W-902002-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .75W-85
CAPACITY, Refill: Liters PtFrontier, Xterra:
1998-20032.4L
2WD . . . . . . . . . . . . . . . . . . . . . 2.0 4.24WD . . . . . . . . . . . . . . . . . . . . . 4.8 10.1
3.3L 2WD . . . . . . . . . . . . . . . . . . . . . 2.8 6.04WD . . . . . . . . . . . . . . . . . . . . . 5.1 10.8
2004 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.22005-07:
Frontier:5-Speed . . . . . . . . . . . . . . . . . . 2.9 6.16-Speed:
2WD . . . . . . . . . . . . . . . . . . . 4.0 8.54WD . . . . . . . . . . . . . . . . . . . 4.2 8.8
Xterra:2WD . . . . . . . . . . . . . . . . . . . . . 4.0 8.54WD . . . . . . . . . . . . . . . . . . . . . 4.2 8.8
Pathfinder, Armada, QX4:1998-2003
2WD 1998-2000 . . . . . . . . . . . . . . . . 2.4 5.12001-03 . . . . . . . . . . . . . . . . . . 2.8 5.9
4WD . . . . . . . . . . . . . . . . . . . . . . . 5.0 10.62004-05 . . . . . . . . . . . . . . . . . . . . . . 5.1 10.8
TRANSFER CASEAll ex. Murano . . . . . . . . . . . . . . . . . . . . . . .AF31
Murano . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtArmada: . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3Frontier, Pathfinder, Xterra
Part Time1998-2004 . . . . . . . . . . . . . . . . . . 2.2 4.62005-08 . . . . . . . . . . . . . . . . . . . . 2.0 4.2
All Mode . . . . . . . . . . . . . . . . . . . . . 3.0 6.3Titan . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2Murano . . . . . . . . . . . . . . . . . . . . . . . 0.3 0.61 Continental USA & Alaska, use NissanMatic D. Canada use Nissan
ATF. Dexron III®/Mercon® may be used as alternative.
DIFFERENTIALLimited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . . . . . .80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . .90 may be used
Standard:1998-2003
All except 2003 Murano . . . . . . . . . . . .GL-50°F to 100°F (-1 to 38°C) . . . . . . . . . . . . . . . . . . .9010°F to 84°F (-12 to 29°C) . . . . . . . . . . . . . . . .85WAbove 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .140Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .75WBelow 84°F (29°C) . . . . . . . . . . . . . . . . . . . . . .80WBelow 100°F (38°C) . . . . . . . . . . .75W-90, 80W-90
2003-07 Murano . . . . . . . . . . . . . . . . . . . .GL-5Above 89°F (32°C) . . . . . . . . . . . . . . . . . . . . . . . . .90Below 89°F (32°C) . . . . . . . . . . . . . . . . . . . . .80W-90
2004-08 All ex. Armada & Murano . . . . . . . . . . .GL-5Front:
Frontier, Titan, Xterra . . . . . . . . . . . . . . . . .80W-90Pathfinder
Above 89°F (32°C) . . . . . . . . . . . . . . . . . . . . . .90Below 89°F (32°C) . . . . . . . . . . . . . . . . .80W-90
Rear:Frontier, Xterra
C200 axle . . . . . . . . . . . . . . . . . . . . . . . .75W-90M226 axle . . . . . . . . . . . . . . . . . . . . . . .75W-140
Pathfinder . . . . . . . . . . . . . . . . . .Synthetic 75W-902004-08 Titan . . . . . . . . . . . . . .Synthetic 75W-140
2005-08 Armada . . . . . . . . . . . . . . . . . . . .GL-5Front
Above 89°F (32°C) . . . . . . . . . . . . . . . . . . . . . .90Below 89°F (32°C) . . . . . . . . . . . . . . . . .80W-90
Rear . . . . . . . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtArmada:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.3Rear . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
CAPACITY, Refill: Liters PtFrontier, Xterra:
Front:Frontier
2.4L . . . . . . . . . . . . . . . . . . . . . 1.3 2.73.3L
1999-2002 . . . . . . . . . . . . . . 1.5 3.22003-04 . . . . . . . . . . . . . . . . 1.7 3.62005-07 . . . . . . . . . . . . . . . . 0.9 1.8
2008 . . . . . . . . . . . . . . . . . . . . . 0.9 1.8Xterra
2000-04 . . . . . . . . . . . . . . . . . . 1.7 3.62005-08 . . . . . . . . . . . . . . . . . . 0.9 1.8
Rear:Frontier
2.4L 1998-2000 axle H190A axle . . . . . . . . . . 1.5 3.2axle C200 axle . . . . . . . . . . . 1.3 2.7axle H233B axle . . . . . . . . . . 2.8 5.92001-04 . . . . . . . . . . . . . . . . 1.3 2.7
3.3L . . . . . . . . . . . . . . . . . . . . . 2.8 5.94.0L. 2005-07
axle C200 axle . . . . . . . . . . . 1.6 3.4axle M220 axle . . . . . . . . . . . 2.0 4.2axle M226 axle . . . . . . . . . . . 2.0 4.2
2008:C200 axle . . . . . . . . . . . . . . . 1.6 3.3M226 axle . . . . . . . . . . . . . . . 2.0 4.2
Xterraaxle C200 axle . . . . . . . . . . . 3.3 7.0axle M226 axle . . . . . . . . . . . 4.2 8.8
2006-08 C200 . . . . . . . . . . . . . 1.6 3.4M226 . . . . . . . . . . . . . . . . . . 2.0 4.2
Murano . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.3Pathfinder, QX4:
1998-2004Front: . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8Rear: . . . . . . . . . . . . . . . . . . . . . . 2.8 5.9
2005-07Front: . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Rear: . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
2008Front:
4.0L . . . . . . . . . . . . . . . . . . . . . 0.85 1.75.6L . . . . . . . . . . . . . . . . . . . . . 1.6 3.4
Rear:4.0L . . . . . . . . . . . . . . . . . . . . . 1.4 3.05.6L . . . . . . . . . . . . . . . . . . . . . 1.75 3.7
Titan:Front: . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4Rear:
2004 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.72005-06 . . . . . . . . . . . . . . . . . . . . 2.0 4.22007 . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.42008 . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir
1998-2007 . . . . . . . . . . . . . . . . . . . . . . . . .AF32008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
OLDSMOBILE1997-2004 BRAVADA, SILHOUETTE - SEECHEVROLET, GMC TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★3.8L All, 4.0L 1997-1999:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .10W-301
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30Others:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301,3
CAPACITY, Refill2: Liters Qt2.2L 2002-04 . . . . . . . . . . . . . . . . . . . . 4.8 5.03.1L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.4L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.5L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.03.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.54.0L . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.5Others . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Preferred2 Capacity shown is with filter. Recheck oil level after filling.3 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
TRANSAXLE, Automatic:All . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt3T40 . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04T40E . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94T45E . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94T60E 1997-98 . . . . . . . . . . . . . . . . . . 7.0 7.44T65E . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.44T80E . . . . . . . . . . . . . . . . . . . . . . . 10.42 11.021 With engine at operating temperature, shift transmission through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed. Do not overfill.
2 Both pan and drain plug removed.
TRANSAXLE, Manual1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2000-04 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt1997-99 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02000-04 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBSuspension & Steering Linkage, Parking
Brake Cable Guides, Shift Linkage, Clutch Cross Shaft . . . . . . . . . . . . . . . . . . . .LB
Wheel Bearings . . . . . . . . . . . . . . . . . . . . . . .GC
PONTIAC1997-2008 ALL EXCEPT: FIREFLY - SEE GEO ASUNA,CHEVROLET, PONTIAC; AZTEK,MONTANA, MONTANA SV6,TRANS SPORT, TORRENT- SEECHEVROLET/GMC TRUCKSCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★3.4L Code X, 3.8L:
Above 0°F (–18°C) . . . . . . . . . . . . . . . . . . . . . .10W-301
Below 60°F (16°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30All temperatures 2004-06 GTO . . . . . . . . . . . . .5W-303
All temperatures 2007-08 Solstice 2.0L . . . . . .5W-306
Others: Above 0°F (–18°C) 1997-2004 . . . . . . . . . . . . . .10W-30All temperatures 1997-2003 . . . . . . . . . . . . . .5W-301,5
All temperatures 2004-07 . . . . . . . . . . . . . . . .5W-304,5
CAPACITY, Refill2: Liters Qt1.8L:
2003-06 Code 8 . . . . . . . . . . . . . . . 3.7 3.92003 Code 8 . . . . . . . . . . . . . . . . . . 4.2 4.42003-06 Code L . . . . . . . . . . . . . . . 4.4 4.6
2.0L:Turbo Code X . . . . . . . . . . . . . . . . . 4.7 5.0
2.2L:2002-08 Code F . . . . . . . . . . . . . . . 4.7 5.01996-2003 Code 4, . . . . . . . . . . . . . 4.3 4.5
2.4L:1997-2002 . . . . . . . . . . . . . . . . . . . . . 4.3 4.52006-2008 . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
3.1L:1997-99 Code M . . . . . . . . . . . . . . . 4.3 4.52000-03 Code J . . . . . . . . . . . . . . . . 4.3 4.5
3.4L:DOHC . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5SOHC . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52007-08 . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0
3.5L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.03.6L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.53.8L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.9L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04.6L . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.55.3L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.05.7L:
1997 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01998-2003 . . . . . . . . . . . . . . . . . . . . 5.2 5.52004 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
6.0L 2005-06 . . . . . . . . . . . . . . . . . . . . 6.2 6.61 Preferred2 Capacities include filter change. Recheck oil level after refilling.3 2004- use oil meeting standard GM6094M.2005-06 use oil meet-
ing standard GM4718M.4 Use oil meeting standard GM6094M.5 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
6 Use synthetic oil GM standard GM4718M.
TRANSMISSION/TRANSAXLE, Automatic 1997-2008 Ex. Vibe . . . . . . . . . . . . . . . . . . . .AF62003-08 Vibe . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Initial Refill1: Liters QtMU4 (FWD) 2008 . . . . . . . . . . . . . . . . . 3.0 3.2MU4 (FWD) . . . . . . . . . . . . . . . . . . . . . 3.1 3.3MU5 (AWD) . . . . . . . . . . . . . . . . . . . . . 2.9 3.13T40 . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.04T40E2 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94T45E . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.94T45E 2008 . . . . . . . . . . . . . . . . . . . . . 6.6 7.04T60E . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.44T65E . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.44L60E, 4L65E . . . . . . . . . . . . . . . . . . . 4.7 5.06T70E . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.35L40-E . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 All except 4T40E, with the engine at operating temperature, shift
transmission through all gears. Let engine slow idle in PARK for 3minutes or more. Check fluid level and add fluid as needed. Donot overfill
2 Has no fluid level indicator. Not owner serviceable.
TRANSMISSION/TRANSAXLE, ManualFWD:
1997-99 . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS2000-05 ex. Vibe . . . . . . . . . . . . . . . . . . . .GLS
137
CARS & LIGHT TRUCKSNISSAN Continued • OLDSMOBILE • PONTIAC
G5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSG6 2006-07 . . . . . . . . . . . . . . . . . . . . . . . .GL-4Vibe, 2003-07 . . . . . . . . . . . . . . . . . . . . . .GLSVibe, 2008 . . . . . . . . . . . . . . . . . .75W-90 GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-80
RWD:Firebird . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3GTO 2004-06 . . . . . . . . . . . . . . . . . . . . . . .AF3Solstice . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-3All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-902008 Vibe . . . . . . . . . . . . . . . . . .75W-90 GL-5
CAPACITY, Refill: Liters PtVibe:
5-speed . . . . . . . . . . . . . . . . . . . . . . 1.9 4.06-speed . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
FWD:1997-99 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02000-05 . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6
G5: MU3 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0GETRAG . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.3
G6 . . . . . . . . . . . . . . . . . . . . . . . 2.9 6.1RWD, Firebird:
5-speed . . . . . . . . . . . . . . . . . . . . . . 3.2 6.86-speed . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0
GTO, 2004-06 . . . . . . . . . . . . . . . . . . . 4.4 9.3Solstice:
2006 . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.62007-08 . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5
TRANSFER CASE (AWD)Vibe . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtVibe . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7DIFFERENTIALGTO 2004-06 . . . . . . . . . . . . . . . . . . . . . GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .75W-140Firebird
Standard . . . . . . . . . . . . . . . . . . . . . . . . . GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90Limited-Slip . . . . . . . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . .80W-90
Solstice:Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Limited-Slip . . . . . . . . . . . . . . . . . . . . . GL-5★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90
CAPACITY, Refill: Liters PtFirebird . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Vibe . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1GTO 2004-06 . . . . . . . . . . . . . . . . . . . 1.6 3.42006-08: Solstice
Drain plug removed . . . . . . . . . . . . . 1.11 2.31
w/limited slip . . . . . . . . . . . . . . . . 1.2 2.5w/o limited slip . . . . . . . . . . . . . . . 1.3 2.7
1 With limited slip add 3.38 oz with rear cover removed, with drainplug removed 2.37 oz - GM PIN 1052358 or equivalent
OTHER COMPONENTSPower Steering Ex GTO, Vibe . . . . . . . . . . . .PSPower Steering GTO, Vibe . . . . . . . . . . . . . .AF3Power Steering Vibe 2006-08 . . . . . . . . . . .AF6Brake Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBSuspension & Steering Linkage, Parking
Brake Cable Guides, Shift Linkage,Clutch Cross Shaft . . . . . . . . . . . . . . . . . . . .LB
Wheel Bearings ex. 1997-2002 Firebird . . . . . . . . . . . . . . . .GC
PORSCHE1997-98 911 SERIESCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Mineral Oils: Above 14°F (-10°C) . . . . . . . . . . . . . .15W-40Synthetic Oils (Preferred):
Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . . .15W-50-4° to 95° (-20° to 38°C) . . . . . . . . . . . . . . . . . . .10W-30Below 95°F (38°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-30All temperatures . . . . . . . . . . . . . . . . . . .5W-40, 5W-50
CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 9.4 10.01 Air cooled engines: Fill the oil reservoir with 6.1 liters (6.5 quarts).
Run the engine at idle and add another 3.0 liters (3.2 quarts). Withengine warm and running, check the reservoir dipstick. DO NOTFILL TO MAX level. Oil level must be between the MIN and MAXgradients. Includes filter. Draining time is 20 minutes.
TRANSAXLE, Automatic . . . . . . . . . . .AF31
CAPACITY, Initial Refill2: Liters QtCarrera 2 (total capacity) . . . . . . . . . . . 9.5 10.01 Final drive serviced separately2 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtCarrera 4 . . . . . . . . . . . . . . . . . . . . . . . 3.8 8.0Carrera 2 . . . . . . . . . . . . . . . . . . . . . . . 3.6 7.6Turbo: 1997-98 . . . . . . . . . . . . . . . . . . 4.3 9.0
FINAL DRIVE w/AT . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtCarrera . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9FRONT DIFFERENTIAL . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtCarrera 4:
1997-98 . . . . . . . . . . . . . . . . . . . . . 0.6 1.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HB1
Clutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB1
Power Steering:1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF31998 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
1 Use fluid meeting DOT 4 requirements
1997-2007 BOXSTER, 1999-2007 911,2006-07 CAYMAN,2001-06 911 TURBO, 2002-05 911 GT2 & GT3, 2003-06 CAYENNECRANKCASE . . . . . . . . . . . .Synthetic API★★Cayenne 3.2L:
All temperatures, . . . . . . . . . . . . . . . . . .0W-30, 0W-40 Above -13°F (-25°C) . . . . . . . . . . . . . . . .5W-40, 5W-50
Others:All temperatures, . . . . . . . . . . . . . . . . . . . . . . . .0W-40Above -13°F (-25°C) . . . . . . . . . . . . . . . .5W-40, 5W-50
CAPACITY, Refill1, 2: Liters QtBoxster: 1997-98 . . . . . . . . . . . . . . . . 8.3 8.8
1999-2002 . . . . . . . . . . . . . . . . . . . . 8.8 9.32003-04 . . . . . . . . . . . . . . . . . . . . . . 8.3 8.82005-07 . . . . . . . . . . . . . . . . . . . . . . 7.8 8.2
9111999-2001 3.4L . . . . . . . . . . . . . . . . 8.3 8.82001-05 All ex. 2001 w/3.4L . . . . . . 8.8 9.32002-05 GT3, GT2 . . . . . . . . . . . . . . 8.8 9.32005-07 Carrera 3.8L . . . . . . . . . . . 8.5 9.02005-07 Carrera 3.6L . . . . . . . . . . . 8.3 8.8
Cayman: 2006-07 . . . . . . . . . . . . . . . . 7.8 8.2Cayenne: 3.2L . . . . . . . . . . . . . . . . . . . 6.3 6.6
4.5L . . . . . . . . . . . . . . . . . . . . . . . 8.8 9.31 A drain down time of 20 minutes is required to attain accurate level
on dipstick. 911 Turbo, no dipstick installed on engine. Use elec-tronic display on instrument panel.
2 Oil capacity listed in Owner’s Manual may differ from listed amount.In such cases, use amount listed in Owner’s Manual.
TRANSAXLE, Automatic1
Boxster, Boxster S . . . . . . . . . . . . . . . . . . . . .AECayman, Cayman S . . . . . . . . . . . . . . . . . . . .AE911 Turbo, 911 GT2 . . . . . . . . . . . . . . . . . . .SLF911: 1999-2005 . . . . . . . . . . . . . . . . . . . . . . . .AE
2006-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF3
Cayenne . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Initial Refill2: Liters QtBoxster, Boxster S . . . . . . . . . . . . . . . 3.5 3.7Cayman, Cayman S . . . . . . . . . . . . . . 3.5 3.7Cayenne:To Trans 09D00036D, G or H . . . . . . . . 8.5 9.0From Trans 09D00037D, G or H . . . . . 9.6 10.1911 Turbo, 911 GT2, GT3:
1999-2001 . . . . . . . . . . . . . . . . . . . . 4.0 4.22002-07 . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8
1 Final drive serviced separately2 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed3 Porsche Part No. 000 043 30400
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-5All Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill1: Liters PtBoxster, Cayman . . . . . . . . . . . . . . . . . 2.2 4.6Boxster S, Cayman S . . . . . . . . . . . . . 2.8 5.9911: 1999-2004 . . . . . . . . . . . . . . . . . . 2.7 5.7
2005-07 . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5911 Turbo . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3GT2 . . . . . . . . . . . . . . . . . . . . . . . 3.6 7.6GT3: 2004 . . . . . . . . . . . . . . . . . . . . . . 2.4 5.11 Includes final drive
FINAL DRIVE, w/AT . . . . . . . . . . . . . . .GL-5All Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtBoxster, Boxster S . . . . . . . . . . . . . . . 0.8 1.7911 . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9911 Turbo, 911 GT2 . . . . . . . . . . . . . . 1.2 2.5DIFFERENTIAL, FRONT911 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90Cayenne . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt911 . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Cayenne . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1DIFFERENTIAL, REARCayenne . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS
CAPACITY, Refill: Liters PtCayenne:
Except V6:w/o locking differential . . . . . . . . . 1.4 3.0w/locking differential . . . . . . . . . . 1.6 3.4
V6 w/MT:w/o locking differential . . . . . . . . . 1.3 2.7w/locking differential . . . . . . . . . . 1.6 3.4
TRANSFER CASE . . . . . . . . . . . . . . . . . .AE1
CAPACITY, Refill: Liters PtCayenne . . . . . . . . . . . . . . . . . . . . . . . 0.75 1.61 The factory fill is blue in color. The AE for topping off/adjusting or
changing is red in color.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HB1
Clutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HB1
Power Steering1999-2007 All . . . . . . . . . . . . . . . . . . . . . . . .PS1997-98: Boxster . . . . . . . . . . . . . . . . . . . . .PS
All Others . . . . . . . . . . . . . . . . . . . . . . . . .AF31 Use fluid meeting DOT 4 requirements.
SAAB1997-98 9000, 1996-98 9001999-2007 9-3, 9-5CRANKCASE1997-2002 . . . . . . . . . . . . . . . . . . . . . . . . .API★★1
2003-08 . . . . . . . . . . . . . . . . . . . . . . . . . .API★★2,3
1997-98:All temperatures,
Mineral oils . . . . . . . . . . . . . . . . . .10W-30, 10W-404
Synthetic oils . . . . . .0W-20, 0W-50, 5W-30, 5W-405
1999-2002:Above 10°F (15°C) . . . . . . . . . . . . . .15W-50, 20W-505
Below -4°F (-20°C) . . . . . . . . . . . . . . . .5W-30, 5W-405
All temperatures . . . . . . . . . . . . . . . .10W-30, 10W-402
2003:9-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-307
9-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-303
2004-07:9-3, 9-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0W-307
2008 . . . . . . . . . . . . .0W-30, 0W-40, 5W-30, 5W-407
CAPACITY, Refill6: Liters Qt2.0L, 2.3L, 2.3L Turbo . . . . . . . . . . . . . 4.0 4.22007-08 2.3L
w/oil cooler . . . . . . . . . . . . . . . . . . . 5.4 5.1w/o oil cooler . . . . . . . . . . . . . . . . . . 4.0 4.2
2.0L Turbo:1997-98 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22003-05 . . . . . . . . . . . . . . . . . . . . . . 6.0 6.32006-07 . . . . . . . . . . . . . . . . . . . . . . 6.8 7.12008 w/oil cooler . . . . . . . . . . . . . . . 6.8 7.1
w/o oil cooler . . . . . . . . . . . . . . . . 6.0 6.32.3L:
900 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.29000 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52.8L . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.43.0L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.81 Preferred2 Saab Turbo Engine Oil or oil meeting API-SL/SM or ILSAC GF-3
requirements.3 Engine oil meeting API-SL/SM or ILSAC GF-3 requirements.4 1997-98, in extremely hot climates 15W-40, 15W-50, 20W-50.5 Must be full or semi synthetic oil.6 Capacity shown includes filter, after refill check oil level. 7 Synthetic meeting specification GM-LL-A 025.
TRANSAXLE, AutomaticAll to 2001 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32002:
9-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF39-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
2003-08: 9-3:
5-speed . . . . . . . . . . . . . . . . . . . . . . . . . .TIV6-speed . . . . . . . . . . . . . . . . . . . . . . . . . .SLF
9-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY Initial Refill: Liters Qt1997-98:
900 . . . . . . . . . . . . . . . . . . . . . . . 7.01 7.41
9000 . . . . . . . . . . . . . . . . . . . . . . . 8.41 8.91
1999-2001, 9-3 & 9-5 . . . . . . . . . . . . . 3.22 3.42
2002-03:9-3 . . . . . . . . . . . . . . . . . . . . . . . 3.22 3.42
9-5 . . . . . . . . . . . . . . . . . . . . . . . 7.33 7.73
2004:9-3 . . . . . . . . . . . . . . . . . . . . . . . 4.02 4.22
9-5 . . . . . . . . . . . . . . . . . . . . . . . 7.03 7.43
2005-07:9-3:
5-speed . . . . . . . . . . . . . . . . . . . . 7.23 7.63
6-speed . . . . . . . . . . . . . . . . . . . . 2.82 3.02
9-5 . . . . . . . . . . . . . . . . . . . . . . . 7.03 7.43
2008:9-3:
5-speed . . . . . . . . . . . . . . . . . . . . 7.22 7.63
6-speed . . . . . . . . . . . . . . . . . . . . 2.52 2.62
9-5 . . . . . . . . . . . . . . . . . . . . . . . 7.03 7.43
CARS & LIGHT TRUCKS
138
PONTIAC Continued • PORSCHE • SAAB
1 Total (dry) fill shown. Use less fluid when refilling.2 Initial refill capacity.3 Total capacity including torque converter and oil cooler shown.
When refilling, use less fluid than specified.
TRANSAXLE, Manual1997 . . . . . . . . . . . . . . . . . . . . .SL, SM, API★★All temperatures . . . . . . . . . . . . . . . . . . .10W-30, 10W-40
Caution: Do not use synthetic oils
1998-2004 . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1
2005-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF1 May use Synthetic AF3 for topping up only when SLF is not avail-
able.CAPACITY, Refill: Liters Pt1997-98:
900 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.69000 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
1999-2004:9-3 . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.89-3 w/6-speed . . . . . . . . . . . . . . . . . 3.0 6.3
CAPACITY, Refill: Liters Pt2005-08: 9-3
5-speed . . . . . . . . . . . . . . . . . . . . . . 1.9 4.05-speed model F17 . . . . . . . . . . . . . 1.6 3.46-speed . . . . . . . . . . . . . . . . . . . . . . 2.4 5.1
1999-2008 9-5 . . . . . . . . . . . . . . . . . . 2.0 4.2OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2005-06 9-2XCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 Capacity shown includes filter. After refill check oil level.
TRANSMISSION, Automatic 2005 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32006 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY Total Refill: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 9.51 10.011 Total (dry) fill shown. Use less fluid when refilling.
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 3.5 7.4DIFFERENTIALRear . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtFront w/AT . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Rear . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBHClutch Fluid Reservoir . . . . . . . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS
2005-08 9-7XCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301,3
CAPACITY, Refill2: Liters Qt4.2L . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.05.3L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.01 Preferred2 Capacity shown includes filter. After refill check oil level.3 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
TRANSMISSION, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
CAPACITY lnitial Refill: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0TRANSFER CASE . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8DIFFERENTIALStandard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90Limited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtFront . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Rear: 6-cyl . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6
8-cyl . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .PS
SATURN1997-2002 S SERIESCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
Above 40°F (4°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .301
Above 20°F (-7°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.01 Use only if other viscosities are not available. Use SJ oil.2 Preferred.3 Capacity shown is with filter
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF
CAPACITY, Initial Refill1,2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 With the engine at operating temperature, shift transaxle through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed.
2 With pressure filter change.
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2000-05 L SERIESCRANKCASE . . . . . . . . . . . . . . . . . . .API★★2000-02: Above 20°F (-7°C) . . . . . . . . . . . . . . . .10W-303
Below -20°F (-29°C) . . . . . . . .Synthetic 5W-30, 0W-302003-05: All temperatures . . . . . . . . . . . . . . .5W-301, 3, 4
CAPACITY, Refill2: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Preferred.2 Capacity shown is with filter.3 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.4 Where temperature falls below -20°F (-29°C) it is recommended
that you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oilmeeting GM standard GM6094M.
TRANSAXLE, Automatic . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.91 With the engine at operating temperature, shift transaxle through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .PS2002-08 VUE2003-07 IONCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Except 2004-07 VUE 3.5L:2002-04 Above 0°F (-18°C) . . . . . . . . . . . . . .10W-302, 4, 5
2002-08 All temperatures . . . . . . . . . . . . . .5W-301, 2, 4, 5
2004-07 VUE 3.5L . . . . . . . . . . . . . . . . . . . . . . . . . .5W-20CAPACITY, Refill3: Liters Qt2.0L Supercharged:
2004 . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.72005-07 . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
2.2L, Code F, D . . . . . . . . . . . . . . . . . . 4.7 5.02.4L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.5L . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.53.5L 2008 . . . . . . . . . . . . . . . . . . . . . . 3.8 4.03.6L 2008 . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Preferred.2 Supercharged engine synthetic oil must be used.3 Capacity shown is with filter.4 Where temperature falls below -20°F (-29°C) it is recommended that
you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.5 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.
TRANSAXLE, Automatic CVTVT25-E (M16/M75)
(no dip stick) . . . . . . . . . . . . . . . . . . .VTF, VTA1
CAPACITY, Refill2: Liters QtVT25-E (M16/M75) Total fill . . . . . . . . . 8.0 8.51 Use variable Transmission Fluid. Add every 50,000 miles Variable
Transmission Fluid Additive, or when variable Transmission Fluid ischanged.
2 See appendix for fluid level checking procedure
TRANSAXLE, Automatic AF33-5, AF23-5
(with dip stick) . . . . . . . . . . . . . . . . . . . . . . TIV1
4T45-E, 4T40-EAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6
5AT-5-speed VUE . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill2: Liters QtAF23-5, AF33 (M45) . . . . . . . . . . . . . . 4.0 4.25AT-5-speed VUE:
FWD . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8AWD . . . . . . . . . . . . . . . . . . . . . . . 4.1 4.3
4T45-E, 4T40-E . . . . . . . . . . . . . . . . . . 6.5 6.91 Do not use any other fluids.2 With engine at operating temperature, shift transmission through all
positions. With lever in park at idle, check level.
TRANSAXLE, ManualAll ex. ION w/MU3 Trans . . . . . . . . . . . . . . .GLSMU3 Trans . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll ex. MU3 . . . . . . . . . . . . . . . . . . . . . 1.7 3.6MU3 Trans . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0POWER TRANSFER UNITGetrag 760 2008 . . . . . . . . . . . . . . . . . . . . . .GLS
NVG900 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFMJ8 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5CAPACITY, Refill: Liters Pt2008 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7VUE: NVG900 . . . . . . . . . . . . . . . . . . . 0.5 1.1MJ8 . . . . . . . . . . . . . . . . . . . . . . . 0.4 0.8REAR DRIVE MODULE2002-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF2008 . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtVUE 2002-07 . . . . . . . . . . . . . . . . . . . 0.8 1.72008 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2005-07 RELAYCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302, 3
CAPACITY, Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.51 Capacity shown is with filter.2 Where temperature falls below -20°F (-29°C) it is recommended that
you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.3 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt2005 FWD . . . . . . . . . . . . . . . . . . . . . . 7.0 7.42005-06 AWD . . . . . . . . . . . . . . . . . . . 8.3 8.72006-07 ALL . . . . . . . . . . . . . . . . . . . . 7.0 7.41 With the engine at operating temperature, shift transaxle through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed.
POWER TRANSFER UNIT . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.3 0.6REAR DRIVE MODULE . . . . . . . . . . . . .SLFCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2007-08 AURACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302, 3
CAPACITY, Refill1: Liters Qt2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.5L . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.53.6L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Capacity shown is with filter.2 Where temperature falls below -20°F (-29°C) it is recommended that
you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.3 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters Qt4T45 . . . . . . . . . . . . . . . . . . . . . . . 6.6 7.06T702 . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.31 With the engine at operating temperature, shift transaxle through all
gears. Let engine slow idle in PARK for 3 minutes or more. Checkfluid level and add fluid as needed.
2 Start engine and operate until the Transmission fluid reaches 180°-200°F(82°-93°C). Apply parking brake, depress the brake pedal andmove the shift lever slowly through all gears, pausing approximate-ly 3 seconds in each range. Return lever to PARK position and turnengine off. Pull the transmission level indicator from the transmis-sion in order to check the proper fluid level on the gauge.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
2007-08 SKYCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.72 5.02
2.4L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.01 Capacity shown includes filter. 2 Synthetic oil required GM standard GM4718M.
TRANSAXLE, Automatic . . . . . . . . . . . .AF6CAPACITY Total Refill1: Liters Qt5L40-E . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.01 With the engine running check level through check fill plug.
TRANSAXLE, Manual . . . . . . . . .75W-90 GL-3CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5DIFFERENTIALStandard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All Temperatures . . . . . . . . . . . . . . . . . . . . . .75W-90Limited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★1
All Temperatures . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Ptw/ Limited Slip . . . . . . . . . . . . . . . . . . 1.21 2.51
w/o Limited Slip . . . . . . . . . . . . . . . . . 1.3 2.7w/ Drain plug removed . . . . . . . . . . . . 1.1 2.3
139
CARS & LIGHT TRUCKSSAAB Continued • SATURN
1 Add limited slip additive GM PN. 1052358 or equivalent. With rearcover removed add 3.38 oz, with drain plug removed add 2.37 oz.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .PS
2007-08 OUTLOOK,2008 BUICK ENCLAVE,GMC ACADIACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All temperatures . . . . . . . . . . . . . . . . . . . . . . . . 5W-302, 3
CAPACITY, Refill1: Liters Qt3.6L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Capacity shown is with filter.2 Where temperature falls below -20°F (-29°C) it is recommended that
you use either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil.3 Only engine oil meeting GM standard GM6094M and showing the
API certified for gasoline engines starburst symbol.
TRANSAXLE, AUTOMATICAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.31 Start engine and operate until the Transmission fluid reaches 180°-
200°F (82°-93°C). Apply parking brake, depress the brake pedaland move the shift lever slowly through all gears, pausing approxi-mately 3 seconds in each range. Return lever to PARK position andturn engine off. Pull the transmission level indicator from the trans-mission in order to check the proper fluid level on the gauge.
TRANSFER CASE . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7REAR DRIVE MODULE . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .HB
SCION2004-06 SCION XA, XB;2005-08 SCION TC;2008 SCION XB;2008 SCION XDCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2004-06 All temperatures . . . . . . . . . . . . . . . . . . . .5W-302007-08 All temperatures . . . . . . . . . . . . .5W-20, 0W-201
CAPACITY, Refill2: Liters Qt2004-06 xA, xB . . . . . . . . . . . . . . . . . . 3.7 3.92005-08 tC, . . . . . . . . . . . . . . . . . . . . . 3.8 4.02008 xB . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.52008 xD . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.41 Preferred2 Capacity shown includes filter. After refill check oil level.
TRANSMISSION/TRANSAXLEAutomatic2004-06 All . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2007-08 All . . . . . . . . . . . . . . . . . . . . . . . . . . .WSCAPACITY, Initial Refill1: Liters Qt2004-06 xA, xB . . . . . . . . . . . . . . . . . . 2.9 3.12005-07 tC . . . . . . . . . . . . . . . . . . . . . 3.5 3.72008 All . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7ManualAll . . . . . . . . . . . . . . . . . . . . . .75W-90 GL-5CAPACITY, Refill: Liters PtxA, xB, xD . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0tC . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.31 With the engine at operating temperature, shift transmission through
all gears. Check fluid level in PARK and add fluid as needed.
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3
SUBARU1997-2008CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★GRADE/VISCOSITY:1997-08:
Warm climate & HD applications . . . . . . . . . . . . .30, 40,10W-50, 20W-40, 20W-50
Above -4°F (-20°C) . . . . . . . . . . . . . . .10W-30, 10W-40Below 105°F (40°C) . . . . . . . . . . . . . . . . . . . . . .5W-301
Above -4°F (-20°C) . . . . . . . . . . . . . . .10W-30, 10W-40All Temperatures . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtImpreza:
1997-982200cc . . . . . . . . . . . . . . . . . . . . . 4.0 4.22500cc . . . . . . . . . . . . . . . . . . . . . 4.5 4.8
1999-2001 . . . . . . . . . . . . . . . . . . . . 4.0 4.22002-04:
Turbo 2.0L . . . . . . . . . . . . . . . . . . 4.5 4.82.5L & STi . . . . . . . . . . . . . . . . . . 4.0 4.2
2005-06 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
CAPACITY, Refill2: Liters Qt2007-08:
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42.5L Turbo . . . . . . . . . . . . . . . . . . 4.3 4.5
Legacy:1997-2000
2200cc . . . . . . . . . . . . . . . . . . . . . 4.0 4.22500cc . . . . . . . . . . . . . . . . . . . . . 4.5 4.8
2001-06 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22007-08:
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42.5L Turbo . . . . . . . . . . . . . . . . . . 4.3 4.5
Outback:1997-99 . . . . . . . . . . . . . . . . . . . . . . 4.5 4.82000-01 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.5L:
2002-06 . . . . . . . . . . . . . . . . . . . . 4.0 4.22007-08: . . . . . . . . . . . . . . . . . . . 4.2 4.4Turbo . . . . . . . . . . . . . . . . . . . . . . 4.3 4.5
3.0L: 2002 . . . . . . . . . . . . . . . . . . . . . . . 6.8 7.22003-04 . . . . . . . . . . . . . . . . . . . . 5.6 5.92005-06 . . . . . . . . . . . . . . . . . . . . 5.5 5.82007-08 . . . . . . . . . . . . . . . . . . . . 5.7 6.0
SVX:1997 . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.3
Forester:1998 . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.81999-2006 . . . . . . . . . . . . . . . . . . . . 4.0 4.22007-08:
2.5L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42.5L Turbo . . . . . . . . . . . . . . . . . . 4.3 4.5
Baja:2003-05 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
B9 Tribeca:2006 . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.82007 . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.02008 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.9
1 Preferred2 Manufacturer does not state if shown capacity is with or without oil
filter change. When replacing oil filter additional oil MAY be need-ed. After refill, check oil level.
TRANSAXLE, Automatic1
2005-08 Impreza, Legacy, OutbackForester, Tribeca ex. 2005 Forester . . . . . .SLF
All others . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Initial Refill2: Liters QtForester (Total Capacity): . . . . . . . . . . 9.33 9.83
Impreza (Total Capacity): 2.0L . . . . . . . . . . . . . . . . . . . . . . . 9.33 9.83
2.2L . . . . . . . . . . . . . . . . . . . . . . . 8.43 8.93
2.5L:1999-2001 . . . . . . . . . . . . . . . . . . 9.33 9.83
2002 . . . . . . . . . . . . . . . . . . . . . . . 9.53 10.03
2003-08 . . . . . . . . . . . . . . . . . . . . 9.33 9.83
B9 Tribeca . . . . . . . . . . . . . . . . . . . . . . 9.63 10.13
Legacy/Outback, Baja Pickup (Total Capacity):
2.2L . . . . . . . . . . . . . . . . . . . . . . . 8.43 8.93
2.5L . . . . . . . . . . . . . . . . . . . . . . . 9.33 9.83
3.0L . . . . . . . . . . . . . . . . . . . . . . . 9.33 9.83
2005-08 5-Speed . . . . . . . . . . . . . . 9.83 10.43
All Others 1997-98 . . . . . . . . . . . . . . . 2.5 2.61 Final drive serviced separately.2 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed3 Total capacity. When refilling, add ATF until ATF level is at cold
mark on dipstick. Start engine & allow transaxle to reach operatingtemperature.
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . GL-5
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Above -20°F (-30°C) . . . . . . . . . . . . . . . . . . . . . . . .85WBelow 90°F (32°C) . . . . . . . . . . . . . . . . . . . . . . . . .80WAll temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90
CAPACITY, Refill: Liters PtForester . . . . . . . . . . . . . . . . . . . . . . . 3.5 7.4Impreza:
FWD:1997 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.41998-08 . . . . . . . . . . . . . . . . . . . . 3.5 7.4
4WD Ex. WRX, STi . . . . . . . . . . . . . . . . 3.5 7.4WRX, STi . . . . . . . . . . . . . . . . . . . 4.1 8.7
Legacy, Outback: FWD
1997 . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.01998-2006 . . . . . . . . . . . . . . . . . . 3.5 7.4
AWD 1997 . . . . . . . . . . . . . . . . . . . . 3.5 7.42007-08: 5-Spd . . . . . . . . . . . . . . . . . . 3.5 7.4
6-Spd . . . . . . . . . . . . . . . . . . . . . . . 4.1 8.7FINAL DRIVE Front w/AT . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Above -20°F (-30°C) . . . . . . . . . . . . . . . . . . . . . . . .85WBelow 90°F (32°C) . . . . . . . . . . . . . . . . . . . . . . . . .80WAll temperatures 1997-2003 . . . . . . . . . . . . . . .80W-90All temperatures 2004-08 . . . . . . . . . . . . . . . . .75W-90
CAPACITY, Refill: Liters PtAll ex. 2005-08 Outback, B9 . . . . . . . . 1.2 2.52005-06 Outback . . . . . . . . . . . . . . . . 1.4 3.02007-08 Outback:
w/4-Spd . . . . . . . . . . . . . . . . . . . . . 1.2 2.5w/5-Spd . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
B9 Tribeca . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
CAPACITY, Refill: Liters Pt2006-08 Legacy:
Non-Turbo . . . . . . . . . . . . . . . . . . . . 1.2 2.5Turbo . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
DIFFERENTIAL, Rear1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . GL-51998-2008:
ex. WRX STi . . . . . . . . . . . . . . . . . . . . . .GL-5WRX STi . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Above -20°F (-30°C) . . . . . . . . . . . . . . . . . . . . . . . . . .85WBelow 90°F (32°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .80WAll temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtAll models ex. SVX, STi . . . . . . . . . . . . 0.8 1.6SVX . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.8STi
2004 . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.82005-08 . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF3Brake & Clutch Master Cylinder . . . . . . . . . . .HB
SUZUKI1997-2002 ESTEEM; 1997-2001 SWIFT;2002-07 AERIO, AERIO SXCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Aerio, Aerio SX:
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
Esteem:1997-98:
Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . .20W-50Above 0°F (-18°C) . . . . . . . . . . . . . .15W-40, 15W-50Above -4°F (-20°C) . . . . . . . . . . . . .10W-40, 10W-50-4°F to +86°F (-20°C to +30°C) . . . . . . . . . .10W-301
Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . .5W-301999-2002:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301
Swift:1997:
Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . .20W-50Above 0°F (-18°C) . . . . . . . . . . . . . .15W-40, 15W-50Above -4°F (-20°C) . . . . . . . . . . . . .10W-40, 10W-50-4°F to +86°F (-20°C to +30°C) . . . . . . . . . . .10W-30Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . .5W-301
1998-2001:Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt1.3L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.51.6L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.51.8L . . . . . . . . . . . . . . . . . . . . . . . 4.7 4.92.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 4.92.3L . . . . . . . . . . . . . . . . . . . . . . . 4.7 4.91 Preferred.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3Capacity, Initial Refill1: Liters QtAerio, Aerio SX:
2002-03 . . . . . . . . . . . . . . . . . . . . . . 2.9 3.02004-07 . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8
Esteem . . . . . . . . . . . . . . . . . . . . . . . 2.6 2.7Swift . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.71 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add Fluid as need-ed.
TRANSAXLE, Manual . . . . . . . . . . . . .GL-41
All temperatures . . . . . . . . . . . . . . . . . . .75W-80, 75W-90 Above 5°F (-15°C) . . . . . . . . . . . . . . . . . . . . . . . . .80W-902007: All temperatures . . . . . . . . . . . . . .75W-85, 75W-90 Above 4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Initial Refill: Liters PtAerio, Aerio SX:
2002-03 . . . . . . . . . . . . . . . . . . . . . . 2.0 4.22004-07 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Esteem:1.6L . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.11.8L . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
Swift . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.01 Recommended.
TRANSFER CASE . . . . . . . . . . . . . . . .GL-41
All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90CAPACITY, Refill: Liters PtAerio, Aerio SX . . . . . . . . . . . . . . . . . . 0.7 1.51 Recommended
DIFFERENTIAL, rear . . . . . . . . . . . . . .GL-52003-04 All temperatures . . . . . . . . . . . . . . . . . . .80W-902005-07 All temperatures . . . . . . . . . . . . . . . . . . .80W-90Above 32°F (-0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtAerio, Aerio SX . . . . . . . . . . . . . . . . . . 0.7 1.5
CARS & LIGHT TRUCKS
140
SATURN Continued • SCION • SUBARU • SUZUKI
1997-98 SIDEKICK & X-90CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997:
Above 14°F (-10°C) . . . . . . . . . . . . . . . . . . . . . .20W-50Above 0°F (-18°C) . . . . . . . . . . . . . . . .15W-40, 15W-50Above -4°F (-20°C) . . . . . . . . . . . . . . .10W-40, 10W-50-4°F to +86°F (-20°C to +30°C) . . . . . . . . . . . .10W-301
Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301998:
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt1.6L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.41.8L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Preferred.2 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION, Automatic . . . . . . . . .AF3Capacity, Initial Refill1: Liters QtSidekick, X90:
3-speed . . . . . . . . . . . . . . . . . . . . . . 2.8 3.04-speed . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6
1 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in PARK and add Fluid as need-ed.
TRANSMISSION, Manual . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90Above 5°F (-15°C) . . . . . . . . . . . . . . . . . . . . . . . . .80W-90TRANSFER CASE . . . . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90Above 5°F (-15°C) . . . . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtSidekick, X90: 2WD . . . . . . . . . . . . . . 2.2 4.6
4WD . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6DIFFERENTIAL . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtSidekick, X90:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Rear . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering . . . . . . . . . . . . . . . . . . .AF2, AF3Clutch Linkage Pivots &
Gear Shift Lever . . . . . . . . . . . . . . . . . . . . .LM
1999-2008 GRAND VITARA,VITARA & XL-7CRANKCASEAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .API★★1999-2008 All:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .10W-301
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill3: Liters Qt1.6L . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42.0L . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5Grand Vitara:
1999-2005 . . . . . . . . . . . . . . . . . . . . 5.5 5.82006-08 . . . . . . . . . . . . . . . . . . . . . . 4.8 5.1
XL-7:2001-06 . . . . . . . . . . . . . . . . . . . . . . 5.5 5.82007-08 . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5
1 Do not use 10W-30 in the 2007-08 XL-7.2 Preferred.3 Capacity shown includes filter. After refill, check oil level.
TRANSMISSION/TRANSAXLEAutomatic1999-2005 All Ex. Tracker . . . . . . . . . . . . . . .AF3
Tracker . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF6Grand Vitara:
2006-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVXL-7:
2006 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32007-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
CAPACITY, Intial Refill1: Liters Qt1999-2005: 2WD . . . . . . . . . . . . . . . . . 2.8 3.0
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6Grand Vitara:
2006-08 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.2XL-7:
2006 . . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22007-08 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add fluid as needed.
ManualTracker . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSVitara, Grand Vitara, XL-7 . . . . . . . . . . . . . .GL-4
All temperatures . . . . . . . . . . . . . . . .75W-85, 75W-901
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .80W-901 75W-90 preferred.CAPACITY, Refill: Liters PtVitara:
1999-2002 . . . . . . . . . . . . . . . . . . . . 1.5 3.22003-04 . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5
Grand Vitara:1999-2005 . . . . . . . . . . . . . . . . . . . . 2.6 5.52006-08 . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0
CAPACITY, Refill: Liters PtXL-7:
2002-03 . . . . . . . . . . . . . . . . . . . . . . 2.5 5.32004-06 . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Tracker: 1999-20042WD . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.04WD . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
TRANSFER CASETracker . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLSVitara . . . . . . . . . . . . . .75W-80, 75W-90 GL-4Grand Vitara, XL-7:
1999-2004 . . . . . . . . . . . . . . . .75W-80, 75W-90 GL-42005-06 w/ motor shift . . . . . . . . . . . . . .75W-90 GL-4
w/ lever shift . . . . . . . . . . . .75W-85, 75W-90 GL-41
Grand Vitara:2007-08: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . .75W-85, 75W-90Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . .80W-902
XL-7: 2007-08 . . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt1999-2004 . . . . . . . . . . . . . . . . . . . . . 1.7 3.62005:
Lever Shift 2WD . . . . . . . . . . . . . . . 2.2 4.6Lever Shift 4WD . . . . . . . . . . . . . . . 1.7 3.6Motor Shift . . . . . . . . . . . . . . . . . . . 1.7 3.6
2006:XL-7 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Grand Vitara . . . . . . . . . . . . . . . . . . 1.5 3.1
2007-08:XL-7 . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.8Grand Vitara:
Motor Shift . . . . . . . . . . . . . . . . . . 1.5 3.1Lever Shift . . . . . . . . . . . . . . . . . . 1.6 3.4
1 Above -4°F (-20°C) 80W-90.2 Preferred.
DIFFERENTIALSTracker . . . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Vitara . . . . . . . . . . . . . .75W-80, 75W-90 GL-5Grand Vitara, XL-7:
1999-2004 . . . . . . . . . . . . . . . .75W-80, 75W-90 GL-52005-06: Front . . . . . . . . . . . . .75W-80, 75W-90 GL-5
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-902007-08:
Grand Vitara . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temps . . . . . . . . . . . . . . . . . . . . . . . . . . .80W-901
Above 32°F (0°C) . . . . . . . . . . . . . . . . . . . . . . . . . .90XL-7: Rear . . . . . . . . . . . . . . . .Synthetic 75W-90 GLS
CAPACITY, Refill: Liters PtFront:
All Ex. XL-7 . . . . . . . . . . . . . . . . . . . 1.0 2.1XL-7 . . . . . . . . . . . . . . . . . . . . . . . 1.25 2.6
Rear:1999-2005 All Ex. XL-7 . . . . . . . . . . 2.2 4.6XL-7:
2001-06 . . . . . . . . . . . . . . . . . . . . 2.5 5.52007-08 . . . . . . . . . . . . . . . . . . . . 0.5 1.0
Grand Vitara:2006-07
2WD . . . . . . . . . . . . . . . . . . . . . 0.9 1.94WD . . . . . . . . . . . . . . . . . . . . . 0.8 1.8
20082WD . . . . . . . . . . . . . . . . . . . . . 0.8-1.0 1.7-2.14WD . . . . . . . . . . . . . . . . . . . . . 0.8-0.9 1.7-1.9
1 Preferred.
OTHER COMPONETSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir:
1999-2007 . . . . . . . . . . . . . . . . . . . . . . . . .AF3
2004-06 VERONA, 2004-08FORENZA, 2005-08 RENOCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All ex. 2004-06 Verona:
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
2004–06 Verona:Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-40All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22.5L . . . . . . . . . . . . . . . . . . . . . . . 6.4 6.81 Preferred.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . . .AECAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.21 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80WCAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AF3
2007-08 SX4 CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .10W-30All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters Qt2.0L . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.81 Preferred.2 Capacity shown includes filter. After refill, check oil level.
TRANSAXLE, Automatic . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.81 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.
TRANSAXLE, Manual . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90
Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .80W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.2TRANSFER CASE . . . . . . . . . . . . . . . .GL-51
All temperatures . . . . . . . . . . . . . . . . . . .75W-85, 75W-90Above -4°F (-20°C) . . . . . . . . . . . . . . . . . . . . . .80W-90
CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.6 1.21 Recommended
DIFFERENTIAL, rear . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .80W-90Above 32°F (-0°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . .AF3
TOYOTA1997-1999 ALL MODELSEX. LAND CRUISER, PICKUPS,PREVIA VAN, 4RUNNER, RAV4CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★Avalon & Corolla:
1997:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C), . . . . . . . . . . . . . . . . . . . .5W-301
1998-99:-20°F (-29°C) to above 100°F (38°C) . . . . . . .5W-301
Camry:1997:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . .5W-301
1998-99:-20°F (-29°C) to above 100°F (38°C) . . . . . . .5W-301
Celica, Paseo, Tercel:1997:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . . . .5W-301
1998-99:-20°F (-29°C) to above 100°F (38°C) . . . . . . .5W-301
Supra:1997:
Non-Turbo:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C) . . . . . . . . . . . . . . . . . .5W-301
Turbo:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . .5W-30
1998-99:Non-Turbo:
-20°F (-29°C) to above 100°F (38°C) . . . . . .5W-301
Turbo:Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . .10W-30Below 50°F (10°C) . . . . . . . . . . . . . . . . . . . .5W-30
CAPACITY, Refill2: Liters QtAvalon . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0Camry:
2.2L . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.83.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
Celica:1997
1.8L . . . . . . . . . . . . . . . . . . . . . 3.7 3.92.2L . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
1998 . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.81999 . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
Corolla:1997
1.6L . . . . . . . . . . . . . . . . . . . . . 3.0 3.21.8L . . . . . . . . . . . . . . . . . . . . . 3.7 3.9
1998-99 . . . . . . . . . . . . . . . . . . . . 3.7 3.9Paseo . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0Sienna . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0Solara:
2.2L . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.83.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
Supra:Non-Turbo . . . . . . . . . . . . . . . . . . 5.2 5.5Turbo . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3
Tercel . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.01 Preferred2 Capacity shown is with filter.
141
CARS & LIGHT TRUCKSSUZUKI Continued • TOYOTA
TRANSMISSION/TRANSAXLE, AutomaticSupra Turbo . . . . . . . . . . . . . . . . . . . . . . . . . .TIVAll others1 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Initial Refill2: Liters QtAvalon, Camry, Solara:
4-cyl. . . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6V6:
1997-98 . . . . . . . . . . . . . . . . . . . . 3.5 3.71999 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
Celica:1.8L . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.52.2L:
1997-99 . . . . . . . . . . . . . . . . . . . . 2.5 2.6Corolla:
3-speed:1997 . . . . . . . . . . . . . . . . . . . . . . . 2.3 2.41998-99 . . . . . . . . . . . . . . . . . . . . 2.5 2.6
4-speed . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3Sienna . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7Supra:
Non Turbo . . . . . . . . . . . . . . . . . . . . 1.6 1.7Turbo . . . . . . . . . . . . . . . . . . . . . . . 1.9 2.0
Tercel, Paseo:3-speed . . . . . . . . . . . . . . . . . . . . . . 2.5 2.64-speed . . . . . . . . . . . . . . . . . . . . . . 3.1 3.3
1 Differential is serviced separately in: 1997-98 Avalon, Camry,Corolla, Sienna, Tercel 3-speed and Celica 2.2L; 1999 Camry &Solara 4-cyl., Corolla & Tercel 3-speed, Sienna
2 With the engine at operating temperature, shift transmissionthrough all gears. Check fluid level in PARK and add fluid as need-ed
TRANSMISSION/TRANSAXLE, Manual1All ex Supra 6–speed . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90Supra 6-speed . . . . . . . . . . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters PtSupra:
Non Turbo . . . . . . . . . . . . . . . . . . . . 2.6 5.4Turbo . . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8
Camry, Solara:4-cyl.:
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.61998-99 . . . . . . . . . . . . . . . . . . . . 2.2 4.6
V6 . . . . . . . . . . . . . . . . . . . . . . . 4.2 8.8Celica:
1.8L . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.02.2L
1997 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.61998-99 . . . . . . . . . . . . . . . . . . . . 2.2 4.6
Corolla . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Tercel, Paseo . . . . . . . . . . . . . . . . . . . . 1.9 4.01 FWD, includes front differential
FINAL DRIVE, FWD w/AT . . . . . . . . . . . .AF3CAPACITY, Refill: Liters PtAvalon, Camry, Solara,
4-cyl. . . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4V6, 1997-98 . . . . . . . . . . . . . . . . . . . 0.9 2.0
Corolla, Tercel . . . . . . . . . . . . . . . . . . . 1.4 3.0Celica, 2.2L . . . . . . . . . . . . . . . . . . . . . 1.6 3.4Sienna . . . . . . . . . . . . . . . . . . . . . . . 0.9 2.0DIFFERENTIAL, RearLimited-Slip . . . . . . . . . . . . . . . . . . . . . . .GL-5★★Standard . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90
CAPACITY, Refill: Liters PtSupra . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . .AF2, AF3Brake & Clutch Master Cylinder . . . . . . . . . . .HBWheel Bearings, 4WD Steering
Knuckle & Propeller Shafts . . . . . . . . . . . .LM
2000-08 ALL MODELSEX. HIGHLANDER, LAND CRUISER,PICKUPS, 4RUNNER, RAV4,SEQUOIA, TACOMACRANKCASE . . . . . . . . . . . . . . . . . . . .API★★
2000-02 All temperatures . . . . . . . . . . . . . . . . . . . . . . .5W-301
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .10W-302008 Solara, Camry 4-cyl. . . . . . . . . . . .5W-20, 0W-201
2003-08 All others . . . . . . . . . . . . . . . . . . . . . . .5W-301
CAPACITY, Refill2: Liters QtAvalon:
2000-04 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02005-08 . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4
Camry, Solara:4-cyl:
2000-01 . . . . . . . . . . . . . . . . . . . . 3.6 3.82002-06 . . . . . . . . . . . . . . . . . . . . 3.8 4.02007-08 . . . . . . . . . . . . . . . . . . . . 4.3 4.5
3.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.3L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.03.5L . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4
Celica: 1.8L . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.91.8L H.O. . . . . . . . . . . . . . . . . . . . . 4.5 4.8
CAPACITY, Refill2: Liters QtCorolla:
2000-05 . . . . . . . . . . . . . . . . . . . . . . 3.7 3.92006-08 1ZZ-FE . . . . . . . . . . . . . . . 4.2 4.42006 2ZZ-FE . . . . . . . . . . . . . . . . . . 4.4 4.6
Echo:2000-03 . . . . . . . . . . . . . . . . . . . . . . 3.6 3.82004-05 . . . . . . . . . . . . . . . . . . . . . . 3.7 3.9
Matrix: 2003-06
Std. . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.9H.O. . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.7
2007-08 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4MR2 . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.9Prius:
2001-03 . . . . . . . . . . . . . . . . . . . . . . 3.6 3.82004-08 . . . . . . . . . . . . . . . . . . . . . . 3.7 3.9
Sienna2000-07 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02008 . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4
Yaris . . . . . . . . . . . . . . . . . . . . . . . 3.7 3.91 Preferred2 Capacity shown is with filter. After refill, check oil level.
TRANSMISSION/TRANSAXLE, AutomaticExcept:
Avalon, 2005-08 . . . . . . . . . . . . . . . . . . . .WS3
Echo, 2000-05 . . . . . . . . . . . . . . . . . . . . .TIV4
Camry, 2000-06 . . . . . . . . . . . . . . . . . . . .TIV4
2007-08 . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Celica, 2000-05 . . . . . . . . . . . . . . . . . . . . .TIV4
Corolla1, 2003-08 . . . . . . . . . . . . . . . . . . .TIV4
Matrix , 2003-08 . . . . . . . . . . . . . . . . . . . .TIV4
Prius2001-03 . . . . . . . . . . . . . . . . . . . . . . . . .TIV4
2004-08 . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Sienna1, 2004-06 . . . . . . . . . . . . . . . . . . .TIV4
Sienna, 2007-08 . . . . . . . . . . . . . . . . . . . .WS3
Solara 4-cyl., 2002-07 . . . . . . . . . . . . . . . .TIV4
Solara 4-cyl., 2008 . . . . . . . . . . . . . . . . . . .WS3
Solara 6-cyl., 2008 . . . . . . . . . . . . . . . . . . .TIV4
Yaris . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
All others1 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Initial Refill2: Liters QtCamry:
2000-01:4-cyl. . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6V6 . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
2002-05: 4-cyl . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1V6 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7
2006 All: . . . . . . . . . . . . . . . . . . . . . 3.5 3.72007-08:
4-cyl . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7V6 . . . . . . . . . . . . . . . . . . . . . . . 2.8 3.0Hybrid . . . . . . . . . . . . . . . . . . . . . 3.8 4.0
Avalon2000-04 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02005-08 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7
Celica: 2000-05
1.8L . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.11.8L H.O.
2000-02 . . . . . . . . . . . . . . . . . . 4.0 4.22003-05 . . . . . . . . . . . . . . . . . . 3.5 3.7
Corolla: 3-speed1 . . . . . . . . . . . . . . . . 2.5 2.64-speed . . . . . . . . . . . . . . . . . . . . . . 3.0 3.22007 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72008 . . . . . . . . . . . . . . . . . . . . . . . 3.0 3.2
Echo . . . . . . . . . . . . . . . . . . . . . . . 2.9 3.1Matrix:
2003, 2WD (U240E) . . . . . . . . . . . . . 4.1 4.32003-06 2WD (A246E) . . . . . . . . . . . 3.0 3.22003-06 AWD (U341F) . . . . . . . . . . . 2.1 2.22007-08 (U246E) . . . . . . . . . . . . . . . 3.0 3.2
Prius: 2001-03 . . . . . . . . . . . . . . . . . . . 4.6 4.92004 . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.82005-06 . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02007-08 . . . . . . . . . . . . . . . . . . . . . . 3.6 3.8
Sienna1: 2000 . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72001-03 . . . . . . . . . . . . . . . . . . . . . . 4.7 5.02004-05
2WD . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.74WD . . . . . . . . . . . . . . . . . . . . . . . 3.6 3.8
2006-08 All . . . . . . . . . . . . . . . . . . . 3.5 3.7Solara:
2000-01 . . . . . . . . . . . . . . . . . . . . . . 2.5 2.62002-03:
2.4L . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.13.0L . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
2004-08 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7Yaris:
2007-08 . . . . . . . . . . . . . . . . . . . . . . 2.5 2.61 Differential is serviced separately in: Corolla 3-speed, Sienna2 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed
3 Use Toyota Type WS ATF, or equivalent.4 Use Toyota ATF Type T-IV Part No. 08886-81015 or equivalent.
TRANSMISSION/TRANSAXLE, ManualEx MR2 Sequential
MTX System . . . . . . . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90
MR2 Sequential MTX System Unit . . . . . . . .SLFCAPACITY, Refill: Liters PtCamry, Solara:
4-cyl.,2000-01 . . . . . . . . . . . . . . . . . . . . 2.2 4.62002-08 . . . . . . . . . . . . . . . . . . . . 2.5 5.3
3.0L;2000-03 . . . . . . . . . . . . . . . . . . . 4.2 8.82004-06 . . . . . . . . . . . . . . . . . . . . 2.5 5.3
3.3L . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.3Celica: 1.8L . . . . . . . . . . . . . . . . . . . . . 1.9 4.0
H.O. . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9Corolla:
5-speed . . . . . . . . . . . . . . . . . . . . 1.9 4.06-speed . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Echo . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0MR2
Standard transmission:w/limited slip . . . . . . . . . . . . . . . . 1.8 3.8w/o limited slip . . . . . . . . . . . . . . . 1.9 4.0
Sequential transmission:w/limited slip . . . . . . . . . . . . . . . . 2.1 4.4w/o limited slip . . . . . . . . . . . . . . . 2.3 4.9
Matrix:5-speed . . . . . . . . . . . . . . . . . . . . . . 1.9 4.06-speed . . . . . . . . . . . . . . . . . . . . . . 2.3 4.9
Yaris . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0TRANSFER CASEMatrix, Sienna . . . . . . . . . . . . . . . . . . . . . . .GL-52008 Sienna:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90
All others . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90CAPACITY, Refill: Liters PtMatrix . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Sienna . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9FINAL DRIVE, FWD w/AT . . . . . . . . . . . .AF3CAPACITY, Refill: Liters PtCamry & Solara, 4-cyl. . . . . . . . . . . . . 1.6 3.4Corolla . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Sienna 2000-03 . . . . . . . . . . . . . . . . . . 0.9 1.9Avalon 2000-03 . . . . . . . . . . . . . . . . . . 1.6 3.4DIFFERENTIALMatrix . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 0F (-18C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 Below 0F (-18C) . . . . . . . . . . . . . . . . . .80W or 80W-90
SiennaCenter & Front . . . . . . . . . . . . . . . . . . . . . . .TIVRear . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 0F (-18C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90 Below 0F (-18C) . . . . . . . . . . . . . . . . .80W or 80W-90
CAPACITY, Refill: Liters PtMatrix . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.1Sienna:
Center & Front . . . . . . . . . . . . . . . . . 0.9 1.9Rear . . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9
OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering:
Except MR2 . . . . . . . . . . . . . . . . . . . .AF2, AF3MR2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
1997-99 PREVIA, RAV4, TACOMA,4RUNNER, T100, LAND CRUISERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★All 1997
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .10W-30Below 100°F (38°C), . . . . . . . . . . . . . . . . . . . . . .5W-30
All 1998-99,All temperatures . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill1: Liters Qt4Runner:
4-cyl. . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3V6 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5
Tacoma: 4-cyl.
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.44WD . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3
V6:2WD . . . . . . . . . . . . . . . . . . . . . . . 5.1 5.44WD . . . . . . . . . . . . . . . . . . . . . . . 4.9 5.2
Previa . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1Oil tank (underhood) . . . . . . . . . . . . 2.0 2.1
RAV4 . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1T100:
4-cyl. . . . . . . . . . . . . . . . . . . . . . . . 5.3 5.6V6:
2WD . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0
Land Cruiser: 1997 . . . . . . . . . . . . . . . . . . . . . . . 7.2 7.51998-99 . . . . . . . . . . . . . . . . . . . . . . 6.8 7.2
1 Capacity shown is with filter.2 Preferred.
CARS & LIGHT TRUCKS
142
TOYOTA Continued
TRANSMISSION, AutomaticRAV4, 4WD . . . . . . . . . . . . . . . . . . . . . . . . . .TTAAll others . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters Qt4Runner:
2WD . . . . . . . . . . . . . . . . . . . . . . . 1.6 1.74WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.1
Tacoma: 2WD
2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.52.7L, 3.4L . . . . . . . . . . . . . . . . . . . 1.6 1.7
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.1Previa:
Except Supercharged . . . . . . . . . . . 2.4 2.5Supercharged . . . . . . . . . . . . . . . . . 1.6 1.7
RAV4 . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.5T100:
2WD . . . . . . . . . . . . . . . . . . . . . . . 1.6 1.74WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.2
Land Cruiser . . . . . . . . . . . . . . . . . . . . 3.5 3.71 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed
TRANSMISSION, ManualRAV4, 4WD . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90All others . . . . . . . . . . . . . . . . . . . . . .GL-4, GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtTacoma, 4Runner:
4-cyl.:2.4L . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.42.7L . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.2
V6:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.44WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
Previa: 2WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.64WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.4
RAV4: 2WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 8.24WD . . . . . . . . . . . . . . . . . . . . . . . 5.0 10.6
T100:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.44WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
TRANSFER CASE . . . . . . . . . . . .GL-4, GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtTacoma, 4Runner
ex. Electronic type . . . . . . . . . . . . . 1.0 2.2Electronic type . . . . . . . . . . . . . . . . . 1.2 2.6
Previa . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.8RAV41 . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.4T100 . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.4Land Cruiser . . . . . . . . . . . . . . . . . . . . 1.3 2.81 RAV 4, applies to models w/AT only
DIFFERENTIAL4WD Tacoma, 4Runner, T100
w/Auto. Disc. Diff. . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-90Land Cruiser w/limited-slip . . . . . . . . . . .GL-5★★Others1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . .80W, 80W-90
CAPACITY, Refill: Liters PtTacoma, 4Runner:
Front ex. A.D.D. . . . . . . . . . . . . . . . . . . . 1.1 2.3w/A.D.D.1 . . . . . . . . . . . . . . . . . . 1.2 2.4
Rear2.4L . . . . . . . . . . . . . . . . . . . . . . . 1.4 2.82.7L, 3.4L:
ex w/locking diff. . . . . . . . . . . . 2.8 5.8w/locking diff. . . . . . . . . . . . . . . 3.0 6.2
4WD X-longex. locking diff. . . . . . . . . . . . . . 2.1 4.2w/locking diff. . . . . . . . . . . . . . . 3.0 6.2
Previa:Front . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.2Rear . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2
RAV42 . . . . . . . . . . . . . . . . . . . . . . . 0.9 2.0T100:
Front . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0Rear:
1997-982WD . . . . . . . . . . . . . . . . . . . . . 2.8 6.04WD . . . . . . . . . . . . . . . . . . . . . 3.0 6.2
Land Cruiser: Front . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.6Rear
ex. limited-slip . . . . . . . . . . . . . . . 3.2 6.8w/limited-slip . . . . . . . . . . . . . . . . 3.3 7.0
1 Models with Automatic Disconnecting Differential do not have lock-ing hubs
2 RAV 4, applies to models w/AT only
OTHER COMPONENTSPower Steering
Except RAV4 EV . . . . . . . . . . . . . . . . . . . . .AF3RAV4 EV . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
Brake & Clutch Master Cylinder . . . . . . . . . . .HB
Wheel Bearings, 4WD Steering Knuckle & Propeller Shafts . . . . . . . . . . . .LM
2000-08 HIGHLANDER, RAV4,LAND CRUISER, SEQUOIA,TACOMA, TUNDRA, 4RUNNER, FJCRUISERCRANKCASE . . . . . . . . . . . . . . . . . . . .API★★2007-08 Tundra 5.7L . . . . . . . . . . . . . . . . .5W-20, 0W-202
2008 RAV4, Tacoma 4-cyl. . . . . . . . . . . . .5W-20, 0W-202
2008 Land Cruiser, 2008 Sequoia 5.7L . . . .0W-20, 5W-20All others: Above 0°F (-18°C) . . . . . . . . . . . . . . . .10W-30
All temperatures . . . . . . . . . . . . . . . . . . . . . . . . .5W-302
CAPACITY, Refill1: Liters Qt4Runner:
4-cyl . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.3V6 . . . . . . . . . . . . . . . . . . . . . . . 5.2 5.5V8 . . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5
Tacoma: 2.4L:
2001-032WD . . . . . . . . . . . . . . . . . . . . . 5.1 5.44WD & PreRunner . . . . . . . . . . 5.4 5.7
2004 . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.82.7L:
2000-03:2WD . . . . . . . . . . . . . . . . . . . . . 5.1 5.44WD & PreRunner . . . . . . . . . . 5.4 5.7
2004 . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.82005-08 . . . . . . . . . . . . . . . . . . . . 5.8 6.0
3.4L:2000-04 2WD . . . . . . . . . . . . . . . . 5.4 5.72000-04 4WD . . . . . . . . . . . . . . . . 5.2 5.5
4.0L:2005-08 2WD . . . . . . . . . . . . . . . 4.5 4.82005-08 4WD & 2WD PreRunner 5.2 5.5
RAV4: 2000 . . . . . . . . . . . . . . . . . . . . . . . 4.1 4.32001-03 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.62004-05 . . . . . . . . . . . . . . . . . . . . . . 3.8 4.02006-08:
4-cyl . . . . . . . . . . . . . . . . . . . . . . . 4.3 4.56-cyl . . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4
Highlander: 4-cyl. . . . . . . . . . . . . . . . . . . . . . . . 3.8 4.0V6 3.3L . . . . . . . . . . . . . . . . . . . . . . 4.7 5.0V6 3.5L . . . . . . . . . . . . . . . . . . . . . . 6.1 6.4
Land Cruiser2000-07 . . . . . . . . . . . . . . . . . . . . . . 6.8 7.22008 . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.4
Tundra, Sequoia: V6
2000-04 . . . . . . . . . . . . . . . . . . . . 5.2 5.52005-08 . . . . . . . . . . . . . . . . . . . . 4.5 4.8
V8 4.7L . . . . . . . . . . . . . . . . . . . . . . 6.2 6.5V8 5.7L . . . . . . . . . . . . . . . . . . . . . . 7.0 7.4
FJ Cruiser . . . . . . . . . . . . . . . . . . . . . . 5.2 5.51 Capacity shown includes filter. After refill, check oil level.2 Preferred.
TRANSMISSION, Automatic4-Runner
2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32003-04
w/ 4-speed . . . . . . . . . . . . . . . . . . . . . . .TIV2
2004w/ 5-speed . . . . . . . . . . . . . . . . . . . . . . .WS3
2005-08 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Highlander2000-07 ex. 2006-07 Hybrid . . . . . . . . . . .TIV2
2006-07 Hybrid . . . . . . . . . . . . . . . . . . . . .WS3
2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Land Cruiser2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32003 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2004-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
RAV42000:
FWD . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF34WD . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2001-05 . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2006-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Sequoia2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3
2003-04 . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Tacoma2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32003-04
2.4L . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32.7L, 3.4L . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
20084-spd . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
5-spd . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
Tundra2000-02 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32003-04 . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2
2005-08 . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
FJ Cruiser . . . . . . . . . . . . . . . . . . . . . . . . . . .WS3
CAPACITY, Initial Refill1: Liters Qt4Runner:
2000-02:2WD . . . . . . . . . . . . . . . . . . . . . . . 1.6 1.74WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.1
2003-04:4-speed . . . . . . . . . . . . . . . . . . . . 2.0 2.15-speed . . . . . . . . . . . . . . . . . . . . 3.0 3.2
2005-08:5-speed . . . . . . . . . . . . . . . . . . . . 3.0 3.2
Tacoma, 2000-01: 2WD, 2.4L . . . . . . . 2.4 2.52.7L, 3.4L . . . . . . . . . . . . . . . . . . . 1.6 1.7
4WD . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.1Tacoma:
2002-04:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.4 2.54WD & PreRunner . . . . . . . . . . . . 2.0 2.1
2005-08 4-speed . . . . . . . . . . . . . . . 2.0 2.12005-08 5-speed . . . . . . . . . . . . . . . 3.0 3.2
RAV4:2000 . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.52001-03:
2WD . . . . . . . . . . . . . . . . . . . . . . . 3.3 3.54WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
2004-08 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7Highlander:
2001-03, 2WD . . . . . . . . . . . . . . . . . 3.3 3.54WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.1
2004-08 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7Highlander Hybrid:
Front:W/ Towing Package . . . . . . . . . . . 4.2 4.4W/o Towing Package . . . . . . . . . . 3.9 4.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 2.0 2.1Land Cruiser:
2000-02 . . . . . . . . . . . . . . . . . . . . . . 3.5 3.72003-08 . . . . . . . . . . . . . . . . . . . . . . 3.0 3.2
Tundra, Sequoia 2003-04 . . . . . . . . . . 2.0 2.1Tundra 2005-08 . . . . . . . . . . . . . . . . . . 3.0 3.2Sequoia 2005-07 . . . . . . . . . . . . . . . . 3.0 3.21 With the engine at operating temperature, shift transmission
through all gears. Check fluid level in PARK and add fluid as need-ed
2 Use Toyota ATF Type T-IV Part No. 08886-81015 or equivalent.3 Use Toyota Type WS ATF, or equivalent.
TRANSMISSION, ManualAll ex. 2000 RAV4 4WD . . . . . . . . . . .GL-4, GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90RAV4 4WD 2000 . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters PtTacoma, 4Runner:
2.4L:2000-03: . . . . . . . . . . . . . . . . . . . 2.6 5.52004:
2WD . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
2.7L:2000-03: . . . . . . . . . . . . . . . . . . . 2.5 5.32004-05:
2WD . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
2006-08:2WD . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
3.4L: 2000-2002:
2WD . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
4.0L:2005:
2WD . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . 2.5 5.3
2006-08: . . . . . . . . . . . . . . . . . . . 1.8 3.8RAV4:
2000:2WD . . . . . . . . . . . . . . . . . . . . . . . 3.9 8.24WD . . . . . . . . . . . . . . . . . . . . . . . 5.0 10.6
2001-05:2WD . . . . . . . . . . . . . . . . . . . . . . . 2.5 5.34WD . . . . . . . . . . . . . . . . . . . . . . . 3.4 7.2
Tundra: 2000-04:
2WD . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.54WD . . . . . . . . . . . . . . . . . . . . . . . 2.2 4.6
2005-06 . . . . . . . . . . . . . . . . . . . . . . 1.8 3.8FJ Cruiser:
2007-08: . . . . . . . . . . . . . . . . . . . . . 1.8 3.8TRANSFER CASE2000 RAV4 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-902007-08 FJ Cruiser with Part Time 4WD . .GL-3All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . .75W-902001-08 RAV4 4WD & Highlander . . . . . . .GL-51
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . 90Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . 80W, 80W-90
143
CARS & LIGHT TRUCKSTOYOTA Continued
All Others . . . . . . . . . . . . . . . . . . . . .GL-4, GL-51
All temperatures . . . . . . . . . . . . . . . . . . . . . . . .75W-90CAPACITY, Refill: Liters Pt4Runner:
2000-02 Standard . . . . . . . . . . . . . . 1.0 2.1Electronic type . . . . . . . . . . . . . . . 1.2 2.5
2003-08 . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0Highlander . . . . . . . . . . . . . . . . . . . . . 0.9 1.9Land Cruiser . . . . . . . . . . . . . . . . . . . . 1.3 2.7RAV4:
2000 . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.52001-08 . . . . . . . . . . . . . . . . . . . . . . 0.9 1.9
Sequoia2001-04 . . . . . . . . . . . . . . . . . . . . . . 1.2 2.52005-07 . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0
Tacoma:Standard . . . . . . . . . . . . . . . . . . . . . 1.0 2.1Electronic type . . . . . . . . . . . . . . . . . 1.2 2.5
Tundra . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1FJ Cruiser:
2007:Part Time . . . . . . . . . . . . . . . . . . . 1.0 2.1Full Time . . . . . . . . . . . . . . . . . . . 1.4 3.0
2008:w/ AT . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2w/ MT . . . . . . . . . . . . . . . . . . . . . . 1.4 2.9
DIFFERENTIAL4Runner:
2000-01:Front:
w/o A. D. D. . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .80W, 80W-90
w/A. D. D.1 . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . .75W-90
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .80W, 80W-90
2002:Front
w/o A. D. D.: . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .90
w/ A. D. D.1 . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . .75W-90
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . .80W, 80W-90
2003-08:Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-85Rear
w/ Limited Slip . . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . .75W-85
w/o Limited Slip . . . . . . . . . . . . . . .GL-5★★All temperatures . . . . . . . . . . . . . . . . . . .75W-85
FJ Cruiser:2003-08:
Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .75W-85
Rearw/ Limited Slip . . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . .75W-85w/o Limited Slip . . . . . . . . . . . . . . .GL-5★★
All temperatures . . . . . . . . . . . . . . . . . . .75W-85Highlander:
2001-08 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . .90
Land Cruiser:2000 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . .80W-90, 902001:
Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90
Rear: . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .90
2002-07:Front: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .90Above 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90
Rear:w/ Limited Slip: . . . . . . . . . . . . . . . .GL-5★★
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . .80W, 80W-90
w/o Limited Slip: . . . . . . . . . . . . . . . .GL-5Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . .80W, 80W-90
2008All temperatures . . . . . . . . . . . . . . . .75W-85, GL-5
2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . .90
RAV42
2000 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . .80W-90, 90
2001-06 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . .90
2007 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . .85W-90
2008 . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . . . .90
Sequoia2001
Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Below 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .90
2002-07Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . .Synthetic 75W-140Tacoma:
2000:Front:
Less A. D. D. . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . .80W, 80W-90
w/A. D. D.1 . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . .75W-90
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90
2001Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90Rear: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Below 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .90
2002-08:Front: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90Rear: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Below 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . .90
Tundra:2000-03:
Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . .75W-90Rear: . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Below 0°F (-18°C) . . . . . . . . . . . . . . .80W, 80W-90Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . . 90
2004-08Front . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
All temperatures . . . . . . . . . . . . . . . . . . . . .75W-90Rear:
w/o Limited Slip . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . .Synthetic 75W-140
w/ Limited Slip . . . . . . . . . . . . . . . .GL-5★★Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . .90Below 0°F (-18°C) . . . . . . . . . . . . .80W, 80W-90
CAPACITY, Refill: Liters Pt4Runner:
2000-03:Front
4WD ex. A. D. D. . . . . . . . . . . . 1.1 2.3w/A. D. D.1 . . . . . . . . . . . . . . 1.2 2.5
Rear2WD . . . . . . . . . . . . . . . . . . . . . 2.8 5.94WD ex. locking diff. . . . . . . . . 2.5 5.3
w/locking diff . . . . . . . . . . . . 2.8 5.92004-05:
Front6-cyl . . . . . . . . . . . . . . . . . . . . . 1.5 3.28-cyl . . . . . . . . . . . . . . . . . . . . . 1.4 2.8
Rear . . . . . . . . . . . . . . . . . . . . . . . 3.1 6.42006-08:
Front . . . . . . . . . . . . . . . . . . . . . . 1.4 2.8Rear . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.3
Tacoma: Front:
2000-03:w/o A. D. D. . . . . . . . . . . . . . . . 1.1 2.3w/ A. D. D. . . . . . . . . . . . . . . . . 1.2 2.5
2004Ex Pre runner . . . . . . . . . . . . . . 1.2 2.5
2005-07 . . . . . . . . . . . . . . . . . . . . 1.5 3.2Rear:
2000-04:2.4L 2WD Ex Prerunner . . . . . . 1.4 2.82.7L Short wheelbase:
Standard . . . . . . . . . . . . . . . . 2.6 5.5Limited slip . . . . . . . . . . . . . . 2.7 5.6
CAPACITY, Refill: Liters Pt2.7L Extra long wheelbase:
Standard . . . . . . . . . . . . . . . . 2.5 5.3Limited slip . . . . . . . . . . . . . . 3.0 6.2
3.4L 2WD Ex Pre runner . . . . . . 2.6 5.52005-08:
2WD Ex Pre runner . . . . . . . . . . 3.3 7.04WD & Pre runner
w/o locking diff. . . . . . . . . . . 2.8 5.9w/locking diff . . . . . . . . . . . . 3.0 6.2
RAV4 ex. 20072, Highlander . . . . . . . . 0.9 1.920072 RAV4 . . . . . . . . . . . . . 0.5 1.05
Land Cruiser: 2000-04:
Front . . . . . . . . . . . . . . . . . . . . . . 1.6 3.4Rear
w/o locking diff. . . . . . . . . . . . . 3.3 7.0w/limited-slip . . . . . . . . . . . . . . 3.2 6.8
2005-07:Front . . . . . . . . . . . . . . . . . . . . . . 1.6 3.6Rear . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.0
2008:Front . . . . . . . . . . . . . . . . . . . . . . 1.9 2.0Rear . . . . . . . . . . . . . . . . . . . . . . . 4.2 4.4
Tundra: Front . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear
2WD w/o limited slip . . . . . . . . . . . . . 3.8 8.0w/limited slip . . . . . . . . . . . . . . 3.2 6.8
4WD w/o limited slip . . . . . . . . . . . . . 3.5 7.4w/limited slip (2000-05) . . . . . . 3.0 6.2w/limited slip (2006) . . . . . . . . . 2.9 6.1
Double Cab:w/o limited slip . . . . . . . . . . . . . . . 4.0 8.4w/ limited slip . . . . . . . . . . . . . . . . 3.3 7.0
Sequoia:2001-04:
Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear . . . . . . . . . . . . . . . . . . . . . . . 3.7 7.8
2005-07:Front . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5Rear:
2WD . . . . . . . . . . . . . . . . . . . . . 3.9 8.24WD . . . . . . . . . . . . . . . . . . . . . 3.7 7.8
FJ Cruiser:Front
Part Time 4WD . . . . . . . . . . . . . . . 1.5 3.2Full Time 4WD . . . . . . . . . . . . . . . 1.4 3.0
Rear:With LSD . . . . . . . . . . . . . . . . . . . 2.9 6.1Without LSD . . . . . . . . . . . . . . . . 3.0 6.2
1 Models with Automatic Disconnecting Differential do not have lock-ing hubs
2 RAV 4, applies to 4WD models only
OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . .AF2, AF3Brake & Clutch Master Cylinder . . . . . . . . . . .HBWheel Bearings, 4WD Steering
Knuckle & Propeller Shafts . . . . . . . . . . . .LM
VOLKSWAGEN1997-2006 ALL DIESEL MODELS2007 TOUAREGCRANKCASE1997-03 . . . . . . . . . . . . . . . . . . . . . .CF-4, CG-42004-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEO1997-04:
Except Energy conserving oils:All temperatures . . . . . . . . .5W-50, 10W-50, 10W-60Above 5°F (-15°C) . . . . . . . . . . . . .15W-40, 15W-50,
. . . . . . . . . . . . . . . . . . . . . . . . .20W-40, 20W-50Below 60°F (15°C) . . . . . . . . . . . . . . .5W-30, 5W-40,
. . . . . . . . . . . . . . . . . . . . . . . . .10W-30, 10W-40Energy conserving oils:
All temperatures . . . . . . . . . . . . . . . . .5W-30, 5W-40, . . . . . . . . . . . . . . . . . . . . . . . . .10W-30, 10W-40
2004-07: All temperatures . . . . . . . . . . . . . . . . . . . .5W-40CAPACITY, Refill1: Liters QtOthers . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.7Touareg . . . . . . . . . . . . . . . . . . . . . . . 11.5 12.01 Capacity shown includes filter. After refill, check oil level. To prevent
overfilling, add approximately .5 qt. less than capacity. Start engine& operate until temperature is approximately 140°F (60°C). Turn offignition switch & wait 3 minutes. Check oil level with dipstick. Addoil as necessary.
TRANSAXLE, AutomaticTouareg . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFO9A Trans . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AE1
CAPACITY, Initial Refill2: Liters QtTouareg (Total Fill) . . . . . . . . . . . . . . . . 9.0 9.5O9A Trans . . . . . . . . . . . . . . . . . . . . . . 2.5 2.6Except O9A Trans . . . . . . . . . . . . . . . . 3.0 3.21 Final drive serviced separately2 Add specified quantity. With engine at operating temperature, 1997
w/096 transmission temperature must be 140°F (60°C), shift trans-mission through all gears. Check level in PARK and add fluid asneeded. All models do not have a dipstick
CARS & LIGHT TRUCKS
144
TOYOTA Continued • VOLKSWAGEN
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-41
All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.21 VW Part No. G005000, G052911 1A, if not available 80W GL-4 may
be used.
FINAL DRIVE w/ATAll models . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtAll FWD w/AT . . . . . . . . . . . . . . . . . . . 0.8 1.6DIFFERENTIALTouareg . . . . . . . . . . . . . . . . . . . . . . . . . . . GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.0TRANSFER CASE . . . . . . . . . . . . . . . . . . AECAPACITY, Refill: Liters PtTouareg . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7
1997-2007 ALL GASOLINEMODELSCRANKCASE1998-04
1.8 Passat 1.8L turbo . . . . . . . . . . . . . . . .SEOAll Others
Except 2004 with VIN code Rand Phaeton . . . . . . . . . . . . . . . . . . . . .API★★
2004 VIN code R and Phaeton . . . . . . . . . .SEO2005-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEO1997-99 :
Above 68°F (20°C) . . . . . . . . . . . . . . . . . . . . . . . . . . .4032° to 86°F (0° to 30°C) . . . . . . . . . . . . . . . . . . . . . . .30Below 23°F (-5°C) . . . . . . . . . . . . . . . . . . . . . . . . . .10W14° to 50°F (-10° to 10°C) . . . . . . . . . . . . . . . . .20W-20Above 14°F (-10°C) . . . . . . . . . . . . . . .20W-40, 20W-50Above 14°F (-10°C) 1998 . . . . . . . . . .15W-40, 15W-50Above 5°F (-15°C) 1997 . . . . . . . . . . .15W-40, 15W-50All temperatures . . . . . . . . . . .5W-50, 10W-50, 10W-60Below 60°F (15°C) . . . . . . . . . . . . . . . . .5W-30, 5W-40,
10W-30, 10W-402000-03:
All temperatures . . . . . . . . . . . . . . . . . . .5W-30, 5W-402004-07:
All temperatures . . . . . . . . . . .Synthetic 5W-40, 5W-30CAPACITY, Refill1: Liters Qt1.8L Turbo:
Golf, Jetta, New Beetle, GTI:1998-99 . . . . . . . . . . . . . . . . . . . . 3.5 3.72000 . . . . . . . . . . . . . . . . . . . . . . . 4.4 4.62001-04 . . . . . . . . . . . . . . . . . . . . 4.5 4.82005:
Beetle . . . . . . . . . . . . . . . . . . . . 4.2 4.4Others . . . . . . . . . . . . . . . . . . . 4.5 4.8
2006 . . . . . . . . . . . . . . . . . . . . . . . 4.5 4.8Passat:
1998-99 . . . . . . . . . . . . . . . . . . . . 3.5 3.72000-02 . . . . . . . . . . . . . . . . . . . . 3.7 3.92003 . . . . . . . . . . . . . . . . . . . . . . . 3.9 4.32004 . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22005 . . . . . . . . . . . . . . . . . . . . . . . 4.1 4.3
2.0L:1997-99 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22000: . . . . . . . . . . . . . . . . . . . . . . . 4.0 4.2
Golf, Jetta, New Beetle . . . . . . . . 4.2 4.42003-04 . . . . . . . . . . . . . . . . . . . . . . 4.0 4.22005-07 . . . . . . . . . . . . . . . . . . . . . . 4.2 4.42006-07 W/ BPY engine . . . . . . . . . 6.0 6.3
2.5L:2006-07 . . . . . . . . . . . . . . . . . . . . . . 6.0 6.3
2.8L:Eurovan:
1997-99 . . . . . . . . . . . . . . . . . . . . 5.7 6.02000-03 . . . . . . . . . . . . . . . . . . . . 5.5 5.7
Golf, GTI, Jetta:1997-03 . . . . . . . . . . . . . . . . . . . . 5.8 6.1
GTI , Jetta:2004-05 . . . . . . . . . . . . . . . . . . . . 5.5 5.8
Passat:1997 . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.71998-99:
ex. 3rd generation wheel . . . . . 5.7 6.03rd generation wheel . . . . . . . . 6.0 6.3
2000-02 . . . . . . . . . . . . . . . . . . . . 6.2 6.52003 . . . . . . . . . . . . . . . . . . . . . . . 5.0 5.72004:
FWD . . . . . . . . . . . . . . . . . . . . . 6.0 6.3AWD . . . . . . . . . . . . . . . . . . . . . 5.0 5.7
2005 . . . . . . . . . . . . . . . . . . . . . . . 6.0 6.34.0L W8 . . . . . . . . . . . . . . . . . . . . . . 8.3 9.4
Phaeton:V-8 . . . . . . . . . . . . . . . . . . . . . . . 7.5 7.9W-12 . . . . . . . . . . . . . . . . . . . . . . . 11.8 12.5
Touareg:V-6 . . . . . . . . . . . . . . . . . . . . . . . 6.3 6.7V-8:
2004 . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.02005-07 . . . . . . . . . . . . . . . . . . . . 7.6 8.0
CAPACITY, Refill1: Liters Qt3.2L:
EOS . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.83.6L:
2006-07 . . . . . . . . . . . . . . . . . . . . . . 6.0 6.31 Capacity shown includes filter. After refill, check oil level. To prevent
overfilling add approximately .5 qt. less than capacity. Start engine& operate until temperature is approximately 140°F (60°C). Turn offignition switch and wait 3 minutes. Check oil level with dipstick.Add oil as necessary.
TRANSMISSION/TRANSAXLE, Automatic1
02E trans. . . . . . . . . . . . . . . . . . . . . . . . . . . .SLFGolf, Jetta 5-speed 09A trans. . . . . . . . . . . .SLFBeetle, Golf, GTI, Jetta Rabbit 09G trans . . .TIVPhaeton 09L trans . . . . . . . . . . . . . . . . . . . . .SLFTouareg 6-speed 09D trans . . . . . . . . . . . . . .TIVOthers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AECAPACITY, Initial Refill2: Liters QtEuroVan . . . . . . . . . . . . . . . . . . . . . . . 3.5 3.7Golf, Jetta:
5-speed 09A trans. . . . . . . . . . . . . . 2.5 2.64-speed 01M3 . . . . . . . . . . . . . . . . . 5.3 5.6
Passat:1998-99 1.8L Turbo . . . . . . . . . . . . . 2.6 2.71998-99 2.8L . . . . . . . . . . . . . . . . . . 3.5 3.72000-05 . . . . . . . . . . . . . . . . . . . . . . 2.6 2.7
Beetle 02E 2005 . . . . . . . . . . . . . . . . . 4.5 4.7Beetle, Jetta, GTI, Golf,
09G 20053 . . . . . . . . . . . . . . . . . . . . 7.0 7.4Phaeton3 . . . . . . . . . . . . . . . . . . . . . . . 9.8 10.3Touareg3 . . . . . . . . . . . . . . . . . . . . . . . 9.0 9.5All other models . . . . . . . . . . . . . . . . . 3.0 3.22006-07:
Golf, GTI, w/ 01M . . . . . . . . . . . . . . 3.0 3.2Beetle, Jetta w/ 02E . . . . . . . . . . . . 5.2 5.5Golf, GTI, w/ 09A . . . . . . . . . . . . . . . 7.0 7.43
Touareg w/ 09D . . . . . . . . . . . . . . . . 9.0 9.53
Beetle, Jetta, Passat EOS, Rabbit W/ 09G . . . . . . . . . . . . . . . . . 7.0 7.43
1 Final drive serviced separately2 All models do not have a dipstick3 Total fill
TRANSAXLE, Manual1997-2007 . . . . . . . . . . . . . . . . . . . . . . . . .GL-41
All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtNew Beetle 1.8L Turbo . . . . . . . . . . . . 2.3 4.8Passat . . . . . . . . . . . . . . . . . . . . . . . 2.3 4.82005-07:
Golf, GTI, Jetta EOS 02M . . . . . . . . 2.3 4.8Golf, GTI, Jetta 02J . . . . . . . . . . . . . 2.0 4.2
Others . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.21 VW Part No. G005000, G052911A, if not available 80W GL-4 may
be used
FINAL DRIVE, w/AT (ex. 09A Trans.)All models . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtAll FWD w/AT . . . . . . . . . . . . . . . . . . . 0.75 1.6EuroVan . . . . . . . . . . . . . . . . . . . . . . . 1.1 2.4Touareg . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.2TRANSFER, GEARBOX Passat . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90Touareg . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AECAPACITY, Refill: Liters PtPassat . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7Touareg . . . . . . . . . . . . . . . . . . . . . . . 0.8 1.7REAR DIFFERENTIAL, 4WDPassat . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Touareg . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-4All temperatures . . . . . . . . . . . . . . . . . .Synthetic 75W-90CAPACITY, Refill: Liters PtPassat . . . . . . . . . . . . . . . . . . . . . . . 1.5 3.2Touareg . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.1OTHER COMPONENTSBrake Fluid Reservoir . . . . . . . . . . . . . . . . . . .HBClutch Fluid Reservoir . . . . . . . . . . . . . . . . . .HBPower Steering Reservoir . . . . . . . . . . . . . . . .PS
VOLVO1997-98CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★1997:
Above 0°F (-18°C) . . . . . . . . . . . . . . . . . . . . . . .15W-40Below 68°F (20°C . . . . . . . . . . . . . . . . . . . . . . .5W-301
1998:-4° to 104°F (-20° to 40°C) . . . . . . . . . . . . . . . .10W-301
Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . .5W-301
Below 104°F (40°C) . . . . . . . . . . . . . . . . . . . . . . .5W-40CAPACITY, Refill2: Liters Qt4-cyl. 2.3L, DOHC . . . . . . . . . . . . . . . . 3.8 4.05-cyl.:
1997 . . . . . . . . . . . . . . . . . . . . . . . 5.3 5.61998 . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
CAPACITY, Refill2: Liters Qt6-cyl.:
2.5L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.02.9L . . . . . . . . . . . . . . . . . . . . . . . 5.7 6.0
1 Preferred2 Capacity shown is with filter. After refill, check oil level. On models
with oil cooler, additional oil may be needed if cooler is drained
TRANSMISSION/TRANSAXLE, Automatic850, 960; 70, 90 Series . . . . . . . . . . . . .AF3, MA940 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3CAPACITY, Initial Refill1: Liters Qt850; C, S, V70:
AW50-42 . . . . . . . . . . . . . . . . . . . . . 3.0 3.2940, 960; S, V90:
AW30-34 . . . . . . . . . . . . . . . . . . . . . 3.0 3.2AW40, AW43 . . . . . . . . . . . . . . . . . . 3.0 3.2
940, 960:AW70, AW71, AW72 . . . . . . . . . . . . 3.9 4.1
1 With engine at operating temperature, shift transmission through allgears. Check fluid level in PARK and add oil as needed
TRANSAXLE, Manual850:
FWD . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS4WD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SJ
All temperatures . . . . . . . . . . . . . . . .Synthetic 5W-30 C, S & V70 . . . . . . . . . . . . . . . . . . . . . . . . . .GLS940, 960, S90, V90 . . . . . . . . . . . . . . . . . .FA, GACAPACITY, Refill: Liters PtAll Ex 960 . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4960:
4-Spd . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.55-Spd:
Early . . . . . . . . . . . . . . . . . . . . . 1.3 2.7Late . . . . . . . . . . . . . . . . . . . . . 1.6 3.3
TRANSFER CASE . . . . . . . . . . . . . . . . .GL5All temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80WCAPACITY, Refill: Liters Pt850 4WD . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4DIFFERENTIAL850 4WD . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Others:
Standard . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Eaton Automatic Lock . . . . . . . . . . . . . .GL-5★★Dana Limited-Slip . . . . . . . . . . . . . . . . .GL-5★★
Above 14°F (-10°C), . . . . . . . . . . . . . . . . . . . . 80W-90, 90Below 14°F (-10°C) . . . . . . . . . . . . . . . . . . .80W-90, 80WCAPACITY, Refill: Liters Pt850 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0940: Type 1030 . . . . . . . . . . . . . . . . . . 1.3 2.7
Type 1031, 1041 . . . . . . . . . . . . . . . 1.6 3.4Type 1035, 1045 . . . . . . . . . . . . . . . 1.4 3.0
960 All, 1997 . . . . . . . . . . . . . . . . . . . . 1.3 2.7S & V90 . . . . . . . . . . . . . . . . . . . . . . . 1.3 2.7OTHER COMPONENTSPower Steering:
1997 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .FA1998 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PS
Brake Master Cylinder . . . . . . . . . . . . . . . . .HBH
1999-2007CRANKCASE . . . . . . . . . . . . . . . . . . . .API★★-4° to 104°F (-20° to 40°C) . . . . . . . . . . . . . . . . . .10W-30Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30Below 104°F (40°C), S40 & V40 . . . . . . . . . . . . . . .5W-402007 V50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5W-30CAPACITY, Refill1: Liters QtC70, 5-cyl. . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
2006: w/oil level sensor . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . . . 5.8 6.12007: . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
S40, V40:1.9L Turbo. . . . . . . . . . . . . . . . . . . . 5.4 5.72.4L w/oil level sensor . . . . . . . . . . . 5.5 5.82.5L:
Ex. Turbo . . . . . . . . . . . . . . . . . . . 5.8 6.1Turbo:
w/oil level sensor . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . 5.8 6.1
2007: . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1S60:
2001-04:Non-Turbo . . . . . . . . . . . . . . . . . . 5.5 5.8Turbo . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
2005-06:w/oil level sensor . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
2007: . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1S60R
2004 2.5L Turbo . . . . . . . . . . . . . . . 5.2 5.52005-06 w/oil level sensor . . . . . . . . 5.5 5.8
w/o oil level sensor . . . . . . . . . . . 5.8 6.12007: . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.8
S70:1999-2000 . . . . . . . . . . . . . . . . . . . . 5.8 6.1
S80:1999 . . . . . . . . . . . . . . . . . . . . . . . 6.5 6.92000-03 . . . . . . . . . . . . . . . . . . . . . . 6.9 7.3
145
CARS & LIGHT TRUCKSVOLKSWAGEN Continued • VOLVO
CAPACITY, Refill1: Liters Qt2004-06 2.5L Turbo:
w/oil level sensor . . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
2007: 3.2L . . . . . . . . . . . . . . . . . . . . 7.7 8.14.4L . . . . . . . . . . . . . . . . . . . . . . . 6.7 7.1
2005 2.9L . . . . . . . . . . . . . . . . . . . . 6.7 7.1V50:
2005-06 2.4L, 2.5L Turbo;w/oil level sensor . . . . . . . . . . . . . 5.5 5.8wo oil level sensor . . . . . . . . . . . . 5.8 6.1
2007: . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1V70:
1999-2004:Non-Turbo . . . . . . . . . . . . . . . . . . 5.5 5.8Turbo . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1
2005-06:w/oil level sensor . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
2007: . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.1V70R:
2004: 2.5L Turbo . . . . . . . . . . . . . . . 5.2 5.52005:
w/oil level sensor . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
2006-07: . . . . . . . . . . . . . . . . . . . . . 5.5 5.8XC70:
2003: 2.5L Turbo . . . . . . . . . . . . . . . 5.2 5.52004: 2.5L Turbo . . . . . . . . . . . . . . . 5.8 6.12005-07:
w/oil level sensor . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
XC90:2003-04: 2.5L Turbo . . . . . . . . . . . . 6.6 7.02003-04: 2.9L Turbo . . . . . . . . . . . . 7.2 7.62005:
w/oil level sensor . . . . . . . . . . . . 5.5 5.8w/o oil level sensor . . . . . . . . . . . 5.8 6.1
2006: 4.4L . . . . . . . . . . . . . . . . . . . . 6.6 7.02007: 4.4L . . . . . . . . . . . . . . . . . . . . 6.7 7.1
1 Capacity shown includes filter. After refill, check oil level. On mod-els with oil cooler, additional oil may be needed if cooler is drained
TRANSMISSION/TRANSAXLE, AutomaticC70:
1999-2000 . . . . . . . . . . . . . . . . . . . . .AF3, MA2001-07 . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
S40, V40: 2000 AW50-42 . . . . . . . . . . . . . . . . . .AF3, MA2001-07 AW55-50/SI SN . . . . . . . . . . . . . . .TIV
S60, S60R: AW55-50SN . . . . . . . . . . . . . . . . . . . . . . . . .TIVAW50AWD . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
S70: AW50-42 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3AW55-50SN . . . . . . . . . . . . . . . . . . . . . . . . .TIVAW42AWD . . . . . . . . . . . . . . . . . . . . . . . . .AF3
S80:4T65EV . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF32005-06 AW50/51 AWD . . . . . . . . . . . . . . .TIV2005-06 AW55-50SN . . . . . . . . . . . . . . . . .TIV2007 TF-80SC . . . . . . . . . . . . . . . . . . . . . . .TIV
V50, V70, V70R, XC70:1999-2000 AW42AWD . . . . . . . . . . . . . . . .AF31999-2000 AW50-42 . . . . . . . . . . . . . . . . . .MA1999-2007 AW50AWD . . . . . . . . . . . . . . . .TIV1999-2007 AW55-50SN . . . . . . . . . . . . . . .TIV2007 TF-805C . . . . . . . . . . . . . . . . . . . . . . .TIV
XC90: 4T65AWD . . . . . . . . . . . . . . . . . . . . . . . . . .AF3AW50AWD . . . . . . . . . . . . . . . . . . . . . . . . . .TIV2006-07 TF80SCAWD . . . . . . . . . . . . . . . . .TIV
CAPACITY, Initial Refill1: Liters QtC70:
1999-2000 AW50-42 . . . . . . . . . . . 7.62 8.02
2001-07 AW55-50 . . . . . . . . . . . . . 7.62 8.02
S40:2006-07 . . . . . . . . . . . . . . . . . . . . . . 7.62 8.02
S60:2001-03
AW55-50SN . . . . . . . . . . . . . . . . . 3.0 3.2AW55-50 . . . . . . . . . . . . . . . . . . . 7.52 7.92
2004-05 AW55-50 . . . . . . . . . . . . . 7.22 7.62
2006-07 AW55-50/51 . . . . . . . . . . . 7.12 7.52
S60R:2004-05
AW55-50 . . . . . . . . . . . . . . . . . . . 7.22 7.62
AW50 . . . . . . . . . . . . . . . . . . . . . . 7.12 7.52
2006-07 TF-80SCAWD . . . . . . . . . 6.72 7.12
S70: 1999-2000
AW50-42 . . . . . . . . . . . . . . . . . . . 7.62 8.02
AW55-50SN . . . . . . . . . . . . . . . . 3.0 3.2AW42AWD . . . . . . . . . . . . . . . . . 7.62 8.02
S80:2005:
4T65EV-GT . . . . . . . . . . . . . . . . . 11.92 12.52
AW50/51AWD . . . . . . . . . . . . . . . 7.22 7.62
AW55-50SN . . . . . . . . . . . . . . . . . 7.22 7.62
CAPACITY, Initial Refill1: Liters Qt2006:
AW50/51AWD . . . . . . . . . . . . . . . 7.22 7.62
AW55-50SN . . . . . . . . . . . . . . . . . 7.22 7.62
TF-80SC . . . . . . . . . . . . . . . . . . . 6.72 7.12
1999-2004 4T65EV . . . . . . . . . . . .. 7.52 7.92
1999-2003 4T65EV-GT . . . . . . . . . . 7.52 7.92
V50:2005:
AW55-50 . . . . . . . . . . . . . . . . . . . 7.62 8.02
AW50/51AWD . . . . . . . . . . . . . . . 7.22 7.62
2006-07 . . . . . . . . . . . . . . . . . . . . . . 7.62 8.02
V70: 1999-2000:
AW50-42 . . . . . . . . . . . . . . . . . . . 7.62 8.02
AW55-50SN . . . . . . . . . . . . . . . . . 3.0 3.2AW42AWD . . . . . . . . . . . . . . . . . 7.62 8.02
AW50AWD . . . . . . . . . . . . . . . . . . 7.62 8.02
2001-04 AW55-50 . . . . . . . . . . . . . 7.52 7.92
2005-07 . . . . . . . . . . . . . . . . . . . . . 7.12 7.52
V70R: 2004 AW55-50 . . . . . . . . . . . . . . . . 7.52 7.92
2005 AW55-50 . . . . . . . . . . . . . . . . 7.12 7.52
2006-07 TF80SC . . . . . . . . . . . . . . . 6.72 7.12
XC70: 2003-04 . . . . . . . . . . . . . . . . . . . . . 7.52 7.92
2005 . . . . . . . . . . . . . . . . . . . . . . . 7.22 7.62
2006 . . . . . . . . . . . . . . . . . . . . . . . 7.12 7.52
XC90: 2003 . . . . . . . . . . . . . . . . . . . . . . 7.52 7.92
2004-05AW50/51AWD . . . . . . . . . . . . . . . 7.22 7.62AW55-50SN . . . . . . . . . . . . . . . . . 7.22 7.62
4T65AWD . . . . . . . . . . . . . . . . . . 11.92 12.52
2006-07:AW50/51AWD . . . . . . . . . . . . . . . . . 7.12 7.52
AW55-50/51 . . . . . . . . . . . . . . . . . 7.12 7.52
TF-80SCAWD . . . . . . . . . . . . . . . . . 6.72 7.121 With engine at operating temperature, shift transmission through all
gears. Check fluid level in PARK and add fluid as needed.2 Total capacity
TRANSAXLE, Manual . . . . . . . . . . . . . .GLSCAPACITY, Refill: Liters Pt5-Speed . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.46-Speed . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2TRANSFER CASE, 4WD . . . . . . . . . . . .GLSAWD bevel gearCAPACITY, Refill: Liters Pt1999-2000 S, V70 . . . . . . . . . . . . . . . . 0.8 1.62005-07 w/AOC . . . . . . . . . . . . . . . . . 0.8 1.6DIFFERENTIAL4WD Rear . . . . . . . . . . . . . . . . . . . . . . . . .GL-5★★CAPACITY, Refill: Liters Pt1999-2004 S70, V70 . . . . . . . . . . . . . . 1.4 3.02007 S60 . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.52006 S60, S80 . . . . . . . . . . . . . . . . . 0.7 1.52003-07 XC70 . . . . . . . . . . . . . . . . . . . 0.7 1.52005-07 V70 . . . . . . . . . . . . . . . . . . . . 0.7 1.5OTHER COMPONENTSPower Steering . . . . . . . . . . . . . . . . . . . . . . . .PSBrake Master Cylinder . . . . . . . . . . . . . . . . .HBH
2008 C70, S40, V50CRANKCASE . . . . . . . . . . . . . . . . .SL, API★★Above 86°F (30°C) . . . . . . . . . . . . . . . . . . .5W-40, 0W-40Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 5.8 6.11 Preferred.2 Synthetic oils meeting 0W-30 or 0W-40 are recommended for diving
in extreme temperatures (hot or cold), when towing a trailer overlong distances, and when driving in mountainous areas.
3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total fill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 7.75 8.21 Total or dry fill shown.
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS1
CAPACITY, Refill: Liters Ptw/ turbo . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.2w/o turbo . . . . . . . . . . . . . . . . . . . . . . 2.1 4.41 MTF 97309-10
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS11 WSS M2C204-A
2008 S60CRANKCASE . . . . . . . . . . . . . . . . .SL, API★★Above 86°F (30°C) . . . . . . . . . . . . . . . . . . .5W-40, 0W-40Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 5.5 5.81 Preferred.2 Synthetic oils meeting 0W-30 or 0W-40 are recommended for diving
in extreme temperatures (hot or cold), when towing a trailer overlong distances, and when driving in mountainous areas.
3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticAll . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIV
CAPACITY, Total fill1: Liters QtAll . . . . . . . . . . . . . . . . . . . . . . . 7.2 7.61 Total or dry fill shown.
TRANSAXLE, ManualAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GLS1
CAPACITY, Refill: Liters PtAll . . . . . . . . . . . . . . . . . . . . . . . 2.0 4.21 MTF 97309
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS11 Volvo synthetic power steering fluid (Pentosin CHF 11S) P/N
1161529
2008 S80CRANKCASE . . . . . . . . . . . . . . . . .SL, API★★Above 86°F (30°C) . . . . . . . . . . . . . . . . . . .5W-40, 0W-40Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt3.0L . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.83.2L . . . . . . . . . . . . . . . . . . . . . . . 7.3 7.7V8 . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 Preferred.2 Synthetic oils meeting 0W-30 or 0W-40 are recommended for diving
in extreme temperatures (hot or cold), when towing a trailer overlong distances, and when driving in mountainous areas.
3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticTF-80SC . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total fill1: Liters QtTF-80SC . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 Total or dry fill shown.
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS11 WSS M2C204-A2
2008 XC70CRANKCASE . . . . . . . . . . . . . . . . .SL, API★★Above 86°F (30°C) . . . . . . . . . . . . . . . . . . .5W-40, 0W-40Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt3.0L . . . . . . . . . . . . . . . . . . . . . . . 7.4 7.83.2L . . . . . . . . . . . . . . . . . . . . . . . 7.3 7.71 Preferred.2 Synthetic oils meeting 0W-30 or 0W-40 are recommended for diving
in extreme temperatures (hot or cold), when towing a trailer overlong distances, and when driving in mountainous areas.
3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticTF-80SC . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total fill1: Liters QtTF-80SC . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 Total or dry fill shown.
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS11 WSS M2C204-A2
2008 XC90CRANKCASE . . . . . . . . . . . . . . . . .SL, API★★Above 86°F (30°C) . . . . . . . . . . . . . . . . . . .5W-40, 0W-40Below 86°F (30°C) . . . . . . . . . . . . . . . . . . . . . . . .5W-301,2
CAPACITY, Refill3: Liters Qt3.2L . . . . . . . . . . . . . . . . . . . . . . . 7.3 7.7V8 AWD . . . . . . . . . . . . . . . . . . . . . . . 6.7 7.11 Preferred.2 Synthetic oils meeting 0W-30 or 0W-40 are recommended for diving
in extreme temperatures (hot or cold), when towing a trailer overlong distances, and when driving in mountainous areas.
3 Capacity shown is with filter. After refill, check oil level.
TRANSAXLE, AutomaticTF-80SC . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIVCAPACITY, Total fill1: Liters QtTF-80SC . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 Total or dry fill shown.
OTHER COMPONENTSBrake/ Clutch Fluid Reservoir . . . . . . . . . . .HBHPower Steering Reservoir . . . . . . . . . . . . . . .PS11 Volvo synthetic power steering fluid (Pentoain CHF 11S) P/N
1161529
CARS & LIGHT TRUCKS
146
VOLVO Continued
147
MEDIUM & HEAVY TRUCKS
BERINGLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . . .CF-4, CG-4, CH-4, CI-4
5° to 122°F (15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-401
-22° to 86°F (-30° to 30°C), 5W-301
-40° to 104°F (-40° to 40°C), 0W-401
-40° to 86°F (-40° to 30°C), 0W-301
-40° to 50°F (-40° to 10°C), 0W-201
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur contentexceeds 1.5%, choose an oil with the highest TBN in CF-4, CG-4, orCH-4 categories.
Cummins. . . . . . . . . . . . . . . . .CG-4, CH-4, CI-4Above 5ºF (-15° C), 15W-40 Preferred-5° to 68°F (-21° to 20°C), 10W-301
Below 68°F ( 20°C), 5W-301
Below -10°F (-23°C), Synthetic 5W-201 or 5W-301
Detroit Diesel: up to 2001 . .15W-40 CH-4, CI-4from 2002 onwards . . . . . . . . . . .15W-40 CI-4Note: At ambient temperatures below -4°F (-20°C), when crankingspeed cannot start engine, 5W-30, 5W-40, 10W-30 or 10W-40 may beused provided they have demonstrated field performance in DDCengines.
TRANSMISSIONAllison . . . . . . . . . . . . . . . . . . . . . . . . . .AF3, HF
Use HF for off-highway operation or where operating temperature isconsistently above 230°F (110°C)
Eaton/Fuller 14909MLL:See Manufacturers’ Recommendations at the end
of the Medium & Heavy Truck section.ZF . . . . . . . . . . . . . . . . . . . . . . . . . .50 GL-2DIFFERENTIALAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 86°F (30°C), 1405°F to 86°F (-15° to 30°C), 80W-90
1 Avoid unnecessary use of low-viscosity oils.
OTHER LUBRICATION POINTSBrake & Clutch Reservoir . . . . . . . . . . . . . . .HBH
DOT 4
Chassis Grease Fittings . . . . . . . . . . . . . . . . .LMNLGI No. 2
Power Steering . . . . . . . . . . . . . . . . . . . . . . . .PSPSF-3 type fluid
Wheel Bearings . . . . . . . . . . . . . . . . . . . . . . .GCNLGI No. 1 (Ba AI BASE)
CAPACITYCRANKCASE Liters QtCapacities include standard factory filters only. (Approximate)Caterpillar:C-10, C-12 . . . . . . . . . . . . . . . . . . . . . 34.0 36.0Cummins:ISB . . . . . . . . . . . . . . . . . . . . . . . 16.4 17.0ISC . . . . . . . . . . . . . . . . . . . . . . . 18.9 20.0ISM . . . . . . . . . . . . . . . . . . . . . . . 36.9 39.0Detroit Diesel:638 . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0TRANSMISSION Liters QtAllison AT-542 (Drain/Refill):3.8 inch pan . . . . . . . . . . . . . . . . . . . . 8.5 9.05.3 inch pan . . . . . . . . . . . . . . . . . . . . 15.0 16.0Eaton/Fuller 14909MLL . . . . . . . . . . . . 13.0 13.7ZF . . . . . . . . . . . . . . . . . . . . . . . 7.1 7.5DIFFERENTIAL Liters PtLD . . . . . . . . . . . . . . . . . . . . . . . 4.5 9.5MD . . . . . . . . . . . . . . . . . . . . . . . 6.5 13.8MX, Front . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.9 25.2
CHEVROLET/GMCIncludes Medium Duty chassis
LUBRICANT GRADECRANKCASEGASOLINE ENGINES . . . . . . . . . . .SJ, SL, API★2003-96 All ex. W-Series
Above 0°F (-18°C), 10W-30All temperatures, 5W-30, preferred*
2003-99 W3500, W45001998-96 W4/4000
Above 77°F (25°C), 40, 50Above 5°F (-15°C), 15W-40, 20W-40, 20W-5032° to 86°F (0° to 30°C), 305° to 59°F (-15° to 15°C), 20W-20-22° to 86°F (-30° to 30°C), 10W-30-22° to 32°F (-30° to 0°C), 10W
* 2003-97, for temperatures below -20°F (-29°C), consider using a 5W-30synthetic or 0W-30 oil
DIESEL ENGINESCaterpillar 3126, 2003-99 . . . .CG-4, CH-4, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22° to 104°F (-30° to 40°C), 5W-40-22° to 86°F (-30° to 30°C), 5W-30
Caterpillar 1998-96 . . . .CF-4, CG-4, CH-4, CI-45° to 122°F (-15° to 50°C), 15W-40
-4° to 104°F (-20° to 40°C), 10W-30Cummins A-Series . . . . . . . . . . . . .CF-41, SF/CE
Above 14°F (-10°C), 20W-40, 20W-50Above 5°F (-15°C), 15W-40-4°F to 86°F (-20° to 30°C), 10W-30Below 77°F (25°C), 5W-202, 5W-302
Consistently below -10°F (-23°C)3
Cummins L10 & N14 Series . . . . . . . . .CF-4, CG-4, CH-4, CI-4Above 12°F (-11°C), 15W-40-10° to 68°F (-23° to 20°C), 10W-302
Below 68°F (20°C), 5W-302
Consistently below -10°F (-23°C),3
Detroit Diesel:53, 71, 92 Series engines . . . . . . . . . . . . . .CF-21
Continuous high temperature operations8, 50All temperatures, 40-25° to 0°F (-31° to -18°C)4, 309, 15W-409
8.2L Series 60, 1999 . . . . . . . . . . . .15W-40 CI-48.2L, Series 60 1998-96 . . . . . . . . .15W-40 CI-4
Note: At ambient temperatures below -4°F (-20°C), when crankingspeed cannot start engine, 5W- or 10W-30 or 40 may be used provid-ed they have demonstrated field performance in DDC engines.
Deutz Diesel BF6L 913 . . . . . . . . . . . . . . .CF, SHAbove 77°F (25°C), 40Above 14°F (-10°C), 15W-4041° to 86°F (5° to 30°C), 3014° to 77°F (-10° to 25°C), 15W-3014° to 50°F (-10° to 10°C), 20W-204° to 68°F (-20° to 20°C), 10W-30
GM, 2003-99 DURAMAX . . . .CG-4, CH-4, CI-4GM 2002-97 6.5L . . . . . . . . . .CG-4, CH-4, CI-4
Above 32°F (0°C), 30Above 0°F (-16°C), 15W-40 preferredBelow 32°F (0°C), 10W-30
Isuzu (W3500, W4500, W5500, W-4/4000, W-5/5000, W-6/6000, W-7/7000 & HV)
2002-99 W3500, -4500, -5500 . . . .CG-4, CH-4, CI-4Others . . . . . . . . . . . . . . . . . . . . . . . . . . .CF5
2003-95 W5 . . . . . . . . . . . . . . . . . . . . . . . . .CF2005 W5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .CFAbove 77°F (25°C), 40, 50Above 5°F (-15°C), 15W-40, 20W-40, 20W-5032° to 86°F (0° to 30°C), 305° to 59°F (-15° to 15°C), 20W-20-22° to 86°F (-30° to 30°C), 10W-30-22° to 32°F (-30° to 0°C), 10W
TRANSMISSIONFor Transmissions not listed see ManufacturersRecommendations at the end of Medium & Heavy Trucksection.AutomaticAllison . . . . . . . . . . . . . . . . . . . . . . . . . .AF3, HF
Use HF for off-highway operation or where operating temperature isconsistently above 230°F (110°C). AT, HT, MT Transmissions may alsouse TransSynd fluid.
Electromatic (W4) . . . . . . . . . . . . . . . . . . . . .AF3Manual2003-96All ex. W-series Tiltmaster/Forward . . . . . . .GLS6
W-Series Tiltmaster/ForwardW3500/4500/5500, 2001-99 . . . . . . . . .SJ, SLW-4/4000, 1998-96 . . . . . . . . . . . . . . . .SJ, SLAbove 90°F (32°C), 40Below 90°F (32°C), 5W-30
W-5/5000, 1998-96 . . . . . . . . . . . . . . . . . . .GL-5U.S., 90W; Canada, 80
W-6/6000, W-7/7000 & HV, 1996 . . . . . . . .GL-5U.S., 90W; Canada, 80
Fuller, Spicer . . . . . . . . . . . . . . . . . . . . . . . . . .CFAbove 0°F (-18°C), 30, 40, 50Below 0°F (-18°C), 30
DIFFERENTIAL2002-99 W3500, W4500, W5500 . . . . . .90 GL-51998-96 W4, W5 . . . . . . . . . . . . . . . . . .90 GL-52003-97 B7 Chassis, C-Series,
T-series . . . . . . . . . . . . . . . . .Synthetic 75W-90GM Part No. 12345841
1998 P12 Chassis . . . . . . . . . . . . .80W-90 GL-5GM Part No. 1052271
1996 Eaton . . . . . . . . . . . . . . . . . . . . . . . . .GL-57
OTHER LUBRICATION POINTSAxle Shifter, 2003-98 . . . . . . . . . . . . . . . . . . .RO
GM P/N 5416 959
Axle Shifter, Air, or electric, 1997-96 . . . . . . . . . . . . . . . . . .10W RO, AF3
Do not mix RO and AF3.
Brake Master Cylinder . . . . . . . . . . . . . . . . . .HBCab Tilt Hydraulic System ex. 1999-97 . . . .CTFChassis Grease Fittings . . . . . . . . . . .LB, GC-LBClutch Release Bearing . . . . . . . . . . . . . . . . .HGExhaust Brake Ball Joint Cap . . . . . . . . . . . . .HG
Hydraulic Clutch System . . . . . . . . . . . . . . . .HBGM Part No. 12345347 preferred
Multi-Pac Air Cylinder . . . . . . . . . . . . . . . . . . .VOOil Cups . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MOProp. Shaft Slip Joint . . . . . . . . . . . .GC, GC-LBProp. Shaft U-Joints . . . . . . . . . . . . .GC, GC-LBPower Steering:
W4, W5, W3500, W4500, W5500 . . . . . . .AF3Except W Series . . . . . . . . . . . . . . . . . . . . . .PS
Spring Brake Hydraulic Pump . . . . . . . . . . . .AF3Steering Gearbox . . . . . . . . . . . . . . . . . . . . . .LSWater Pump Bearing . . . . . . . . . . . . . . . .EP LMWheel Bearings:
Grease Lubricated . . . . . . . . . . . . .GC, GC-LBOil lubricated W-series . . . . . . . . . . . . . .90 GL-5
Canada, 80
Oil lubricated, ex. W-Series . . . . . . . . . . . . .GLS7
1 Preferred.2 Continuous use of low viscosity oils can lead to increased engine wear.3 Arctic conditions where heating aids are not available during shut-
down, use 5W-30 synthetic, and observe note 2.4 Temperature range may be extended up to 32°F (0°C), where starting
aids are unavailable.5 Do not use synthetic oils.6 Synthetic Manual Transmission Fluid GM Part No. 12345724.7 2003-96 75W-90 synthetic GM Part No. 12345841.8 Coolant outlet temperature over 200°F (95°C).9 Replace with 40 as soon as ambient conditions permit.
CAPACITYNote: See TRUCK TRANSMISSION and DIFFERENTIAL pages forcapacities not shown below.
CRANKCASE Liters QtGASOLINE ENGINESMedium-Duty Models:
2003-99 W3500/4500/5500 5.7L . . . 4.75 5.05
1998-96 W4/4000 5.7L . . . . . . . . . . 4.75 5.05
2002-01 B7, C-Series, T-Series:8.1L . . . . . . . . . . . . . . . . . . . . . . . 7.5 8.0
2004-03 8.1L . . . . . . . . . . . . . . . . . . 6.55 7.05
2000-99 7.4L . . . . . . . . . . . . . . . . . . 6.55 7.05
1998-96 6.0L, 7.0L . . . . . . . . . . . . . 7.51 8.01
DIESEL ENGINESCaterpillar:
2005-03 3126 . . . . . . . . . . . . . . . . . 28.07 30.07
2004-99 3126, shallow pan . . . . . . . 215 225
deep pan . . . . . . . . . . . . . . . . . . . 285 305
1998-96 3116, shallow pan . . . . . . . 20 21deep pan . . . . . . . . . . . . . . . . . . . 32 34
Cummins:A-Series, see engine data plate near oil fill cap.
10L Some . . . . . . . . . . . . . . . . . . 34.0 36.010L Some . . . . . . . . . . . . . . . . . . 26.5 28.0NH-230, NHC-250 . . . . . . . . . . . . 26.5 28.0NHCT-270 . . . . . . . . . . . . . . . . . . 18.9 20.0
Detroit Diesel/GM:Series 60 . . . . . . . . . . . . . . . . . . . . . 36.06,7 38.06,7
3-53 . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.04-53 . . . . . . . . . . . . . . . . . . . . . . . 13.2 14.06-71 . . . . . . . . . . . . . . . . . . . . . . . 21.0 22.06-71N, -NE . . . . . . . . . . . . . . . . . . . 20.8 22.06V-71 . . . . . . . . . . . . . . . . . . . . . . . 17.0 18.06V-53, -53T . . . . . . . . . . . . . . . . . . . 13.2 14.08V-92: 12V-71N . . . . . . . . . . . . . . . . 32.2 34.06.0 Liter Vortec . . . . . . . . . . . . . . . . 5.47 5.757
6.6 Liter Duramax . . . . . . . . . . . . . . 5.47 5.757
8.1 Liter . . . . . . . . . . . . . . . . . . . . . . 6.27 6.57
8.2 Liter NA & Turbo . . . . . . . . . . . . 9.54 10.04
Deutz, BF6L913 . . . . . . . . . . . . . . . . . 14.04 15.04
GM 1999-97 6.5L . . . . . . . . . . . . . . . . 7.55 8.05
4BD1-T (3.9L) . . . . . . . . . . . . . . . . . . . 8.06 8.56
4BD2-TC . . . . . . . . . . . . . . . . . . . . . . . 11.45 12.05
4HE1-TC . . . . . . . . . . . . . . . . . . . . . . . 13.05 13.65
6BD1-T, 6BG1-NA, 6BG1,6BG1-TC . . . . . . . . . . . . . . . . . . . 14.75 15.55
6HE1-TC 1996 . . . . . . . . . . . . . . . . . . 14.06 14.86
6HK1-TC . . . . . . . . . . . . . . . . . . . . . . . 14.06 14.86
6SA1-T (8.4L) . . . . . . . . . . . . . . . . . . . 16.0 16.9ISUZU: 2004-03 6.6L . . . . . . . . . . . . . 13.8 14.6
2004-03 7.8L . . . . . . . . . . . . . . . . . . 13.7 14.51 Without filter change.2 When replacing filter, run engine, stop and add oil to FULL mark.3 With filter change.4 With main and partial filter change.5 Typical capacity. Refer to operator’s manual and dipstick reading for
exact amount.
BERING • CHEVROLET/GMC
148
MEDIUM & HEAVY TRUCKS
AUTOMATIC TRANSMISSION Liters QtPan Removal.Initial fill after service.GM Forward (Isuzu built):
2003-99 W3500, W4500 gasoline . . 12.8 13.5W3500, W4500, W5500diesel . . . . . . . . . . . . . . . . . . . . . 13.5 14.3
W4/4000 with 5.7L gas . . . . . . . . 12.8 13.6W4/4000 with Diesel . . . . . . . . . . 13.5 14.3
1998-96 AT 542 . . . . . . . . . . . . . . . . 10.3 10.8AT 545 . . . . . . . . . . . . . . . . . . . . . 15.0 16.0
B7 Chassis, C-Series, P-Series, T-Series:2003-02
AT545 Shallow Pan . . . . . . . . . . . . . 12.6 13.5deep pan . . . . . . . . . . . . . . . . . . 19.0 20.0
2000 & 2400 series . . . . . . . . . . . . . 13.5 14.3MD3060P, -3560P . . . . . . . . . . . . . . 24.6 26.0MT 643, 653 . . . . . . . . . . . . . . . . . . 17.0 18.0
2003-97AT 542 . . . . . . . . . . . . . . . . . . . . . . . 14.0 15.0AT 545 shallow pan . . . . . . . . . . . . . 8.5 9.0
deep pan . . . . . . . . . . . . . . . . . . . 15.0 16.0LCT2000, LCT2400 shallow pan . . . 12.0 13.0
standard pan . . . . . . . . . . . . . . . . 14.0 15.0MD3060, 3060P, 3080, 3080P . . . . . 18.0 19.0MD3550P, 3560P, 3580, 3580P . . . . 18.0 19.0MT643D, G . . . . . . . . . . . . . . . . . . . 11.0 12.0653DRG . . . . . . . . . . . . . . . . . . . . . 14.0 15.0
Topkick, Kodiak, others:AT 542, 1996 . . . . . . . . . . . . . . . . . . 14.0 15.0AT 545, 1996 . . . . . . . . . . . . . . . . . . 19.0 20.0MT643, 653, 1996 . . . . . . . . . . . . . . 17.0 18.0
MANUAL TRANSMISSION Liters PtFS4205A, -B, -C . . . . . . . . . . . . . . . . . 5.3 11.2FS5205A, -C . . . . . . . . . . . . . . . . . . . . 5.5 11.6FS5406, -6305A, -B, -6406 . . . . . . . . . 8.7 18.4FS8206 . . . . . . . . . . . . . . . . . . . . . . . 9.5 20.1FS8406 . . . . . . . . . . . . . . . . . . . . . . . 8.8 18.6RT8908LL . . . . . . . . . . . . . . . . . . . . . . 13.8 29.2Isuzu MZZ . . . . . . . . . . . . . . . . . . . . . . 4.4 9.32003-99 W3500, W4500 gasoline . . . . 3.2 6.8
W5500 . . . . . . . . . . . . . . . . . . . . . . . 5.3 11.2W4, 1998-97 . . . . . . . . . . . . . . . . . . . . 3.2* 6.8** Varies based on transmission angle.W4/4000 MSA5D . . . . . . . . . . . . . . . . 2.6 5.5W5, 1998-97, 6-speed . . . . . . . . . . . . 6.51 13.81
W5/5000, 5-speed . . . . . . . . . . . . . . . 5.01 10.61
W6/6000, W7/W7000 & HV:5-speed (MBG) . . . . . . . . . . . . . . . . 5.01 10.61
5-speed (MLH) . . . . . . . . . . . . . . . . 9.8 21.06-speed (MLD) . . . . . . . . . . . . . . . . . 6.51 13.81
Fuller FS6106 . . . . . . . . . . . . . . . . . 9.0 19.0Spicer SST9072H . . . . . . . . . . . . . . 19.4 41.0
1 With PTO, add 1.4 pints (0.7 liter).DIFFERENTIAL Liters PtIsuzu differentials:
2003-99 All . . . . . . . . . . . . . . . . . . . 9.7 20.5W4, 1998-97 . . . . . . . . . . . . . . . . . . 9.7 20.5W-4/4000 1996, R036 . . . . . . . . . . . 9.0 19.0R065 131/2” . . . . . . . . . . . . . . . . . . 5.5 12.0R074 141/2” . . . . . . . . . . . . . . . . . . 6.5 14.0R095 151/2” . . . . . . . . . . . . . . . . . . 9.0 19.0R095 Twin speed Eaton 1722.1 . . . . 21.0 44.0R105 16.5” . . . . . . . . . . . . . . . . . . . 24.0 51.0
Spicer two-speed M220 T . . . . . . . . . . 21.0 44.0Eaton 230655 . . . . . . . . . . . . . . . . . . . 15.8 33.5GM:
19060S . . . . . . . . . . . . . . . . . . . . . . 13.0 28.023080S . . . . . . . . . . . . . . . . . . . . . . 19.0 40.023431 . . . . . . . . . . . . . . . . . . . . . . . 19.0 40.026085P . . . . . . . . . . . . . . . . . . . . . . 19.5 41.030105S . . . . . . . . . . . . . . . . . . . . . . 25.5 54.015040T . . . . . . . . . . . . . . . . . . . . . . 11.0 24.019060T . . . . . . . . . . . . . . . . . . . . . . 16.0 34.019060T 2005 . . . . . . . . . . . . . . . . . . 13.2 28.0DS344 front . . . . . . . . . . . . . . . . . . . 14.5 31.0
rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0DS454 front . . . . . . . . . . . . . . . . . . . 15.1 28.0
rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0DT402P front . . . . . . . . . . . . . . . . . . 16.5 35.0
rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
FORD 600 THRU 9500 MODELSLUBRICANT GRADECRANKCASEGASOLINE ENGINESFord . . . . . . . . . . . . . . . . . . . . . . . . .SL, API★1999-96
Above 10°F (-12°C), 15W-40Above 0°F (-18°C), 10W-30 PreferredBelow 60°F (16°C), 5W-30
DIESEL ENGINESCaterpillar . . . . . . . . . .CF-4, CG-4, CH-43, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-404
-22° to 86°F (-30° to 30°C), 5W-304
-40° to 104°F (-40° to 40°C), 0W-404
-40° to 86°F (-40° to 30°C), 0W-304
-40° to 50°F (-40° to 10°C), 0W-204
Use Caterpillar DEO oil or equivalent quality when fuel sulfur contentexceeds 1.5%, choose an oil with the highest TBN in CF-4, CG-4, or
CH-4 categories.
Cummins . . . . . . . . . . . . . . . .CG-4, CH-43, CI-4Above 5°F (-15°C), 15W-40 Preferred
-5° to 68°F (-21° to 20°C), 10W-304
Below 68°F (20°C), 5W-304
Below 32°F (0°C), 0W-301,4
Detroit Diesel: 60 Series: up to 2001 . . . . . . . . . . . . . . . . . .15W-40 CI-4From 2002 onwards . . . . . . . . . . . . . . . . . .CI-4
Ford, Navistar:7.3L Power Stroke . . . . . . .CH-4/SL, CH-4/SJ
2003-00Above 10°F (-12°C), 15W-40*-10° to 90°F (-12° to 32°C), 10W-30**Below 30°F (-1°C), 5W-30Below 0°F (-18°C), 0W-30
* Preferred Above 30°F (-1°C)** Preferred -10° to 30°F (-23° to -°C)
Ford/Cummins Diesel:FD1060 (B5.9L), FD1460 (C8.3L) . . . . . . . . .CH-4/SL, CH-4/SJ
1999-96Above 14°F (-10°C), 15W-40-13° to 68°F (-25° to 20°C), 10W-304
Below 68°F (20°C), 5W-304
Ford 6.6L & 7.8LTurbo diesel . . . . . . . . . . . .CH-4/SL, CH-4/SJ
TRANSMISSIONFor Transmissions not listed see ManufacturersRecommendations at the end of Medium & Heavy Trucksection.600 and up, Manual and Auxiliary . . . . . .SJ, SL
Above 0°F (-18°C), 50; below 0°F (-18°C), 30Transfer Case . . . . . . . . . . . . . . . . . . . . . .SJ, SLAbove 0°F (-18°C), 50; below 0°F (-18°C), 30Allison AT, HT, MD, MT, 2000, 2400 . . . . . . .AF3Torqshift 5 speed . . . . . . . . . . . . . . . . . . . . .MSPDIFFERENTIALFor Differentials not listed see ManufacturersRecommendations at the end of Medium & Heavy Trucksection.2003-00 F650, -750 . . . . . . . . . . . .80W-90 GL-52003-01 option . . . . . .Synthetic 75W-140 GL-56
1999-96 600 thru 9500
ex. Eaton, Rockwell . . . . . . . . . .80W-90 GL-58
OTHER LUBRICATION POINTSAir Cleaner, oil bath . . . . . . . . . . . . . . . . . . . .MO
Above 32°F (0°C), 30; below 32°F (0°C), 20WFord engines, use crankcase grade
Axle Shifter, Louisville,Aeromax . . . . . . . . . . . . . . . . . .10W-30 SJ, SLOthers . . . . . . . . . . . . . . . . . . . . . .10W SJ, SLBelow 0°F (-18°C), mix 25% kerosene
Body Hinges & Latches . . . . . . . . . . . . . . . .SLSBrake Camshaft (S-Cam Air Brakes)
& Slack Adjusters . . . . . . . . . . . . . . . . .EP LMBrake & Clutch Master Cylinders . . . . . . . . .HBHBrake Torque Plate Rails . . . . . . . . . . . . . . . . .BLCab Lift Pump . . . . . . . . . . . . . . . . . . . . . . . .CTFChassis Grease Fittings7 . . . . . . . . . . . . . .EP LMDriveshaft U-joints, Slip Yokes,
Power Steering Gear Output Shaft2 . . . . . .HGHydro-Max Booster Pump . . . . . . . . . . . . . . .MA
Below 0°F (-18°C), use hydraulic oil VG 22Parking Brake, Speedometer,
Tachometer Cables . . . . . . . . . . . . . . . . . . .SPPower Steering Pump . . . . . . . . . . . . . . . . . .MASpring Leaves, Transmission Linkage Pivots,
Brake/Clutch Pedal Pivots & Clevis,Transmatic Detent Stop, Starter Motor . . . . . . . . . . . . . .10W-30 SJ, SL
Steering Gearbox (Manual)Synthetic . . . . . . . . . . . . . . . . . .75W-90 GL-5
Wheel Bearings:Grease lubricated . . . . . . . . . . . . . . . . . .EP LMOil lubricated
2003-96 . . . . . . . . . . . . . . . . . .80W-90 GL-52002-01 option . . .Synthetic 75W-140 GL-56
1 API-III synthetics are recommended where ambient conditions areconsistently Below -13°F (-25°C). API-III 0W-30 synthetic may be usedwhere ambient temperatures never exceed 32°F (0°C), but highercylinder wear may be expected. Do not use friction-modified oil with-out evidence of satisfactory performance in Cummins engines.
2 Do not use automatic or power grease guns on the power steeringgear output shaft.
3 Preferred.4 Continuous use of low viscosity engine oils can lead to increased
engine wear.5 NOTE: At ambient temperatures Below -4°F (-20°C), when cranking
speed cannot start engine, 5W-30, 5W-40, 10W-30 or 10W-40 may beused provided they have demonstrated field performance in DDCengines.
6 Part No. XY-75W140-QL.7 Except driveshaft U-joints, slip yokes, and power steering gear output
shaft.8 For Eaton, Rockwell axles GL-5 is minimum requirement, serviced by
Ford with 80W-90 GL-5.
CAPACITYCRANKCASE Liters QtGASOLINE ENGINES5.4L . . . . . . . . . . . . . . . . . . . . . . . 5.79 6.09
6.8L . . . . . . . . . . . . . . . . . . . . . . . 5.79 6.09
7.0L . . . . . . . . . . . . . . . . . . . . . . . 7.610 8.010
DIESEL ENGINESCaterpillar:
C-7 ACERT 7.2L shallow pan . . . . . 21.08 22.08
C-7 ACERT 7.2L F650 F750 . . . . . . . . 28.48 30.08
3126B w/ small pan . . . . . . . . . . . . . 19.18 21.08
w/ large pan . . . . . . . . . . . . . . . . . 31.28 33.08
C-9 . . . . . . . . . . . . . . . . . . . . . . . 35.08 37.08
C-11, C-13 . . . . . . . . . . . . . . . . . . . 34.18 12 36.08 12
C-11, C-13 . . . . . . . . . . . . . . . . . . . 39.78 13 42.08 13
C-15 . . . . . . . . . . . . . . . . . . . . . . . 38.08 11 40.08 11
C-15 . . . . . . . . . . . . . . . . . . . . . . . 49.28 13 52.08 13
3176 Series 1998-96 . . . . . . . . . . . . 24.61 26.01
3306 C Series 1997-96 . . . . . . . . . . 36.06 38.06
3406C, 3406E 1997-96:L-Series . . . . . . . . . . . . . . . . . . . . 34.11 36.01
Louisville, Aeromax . . . . . . . . . . . 30.31 32.01
3406 E 1998 . . . . . . . . . . . . . . . . . . 34.01 36.01
Cummins:ISL 8.9L . . . . . . . . . . . . . . . . . . . . . . 21.08 22.08
ISB(B5.9L) F750 . . . . . . . . . . . . . . . 14.28 15.08
ISB(B5.9L) . . . . . . . . . . . . . . . . . . . . 14.28 15.08
2004 deep pan . . . . . . . . . . . . . . . 16.08 17.08
shallow pan . . . . . . . . . . . . . . . 14.28 15.08
L10 . . . . . . . . . . . . . . . . . . . . . . . 34.04 36.04
N-14, NTC, PT & Formula Series:1998-96 . . . . . . . . . . . . . . . . . . . . 36.03 38.03
M11 1997-96 . . . . . . . . . . . . . . . . . . 34.14 36.04
1998 . . . . . . . . . . . . . . . . . . . . . . . 34.17 36.07
Detroit Diesel 1998-96 60 Series . . . . . 30.32 32.02
60 Series(12.7L, 14L) 2004-2005 . . . 36.08 38.08
Ford/Cummins/Navistar:2004 Ford 6.0L . . . . . . . . . . . . . . . . 14.28 15.08
2003-00 7.3L Power Stroke . . . . . . . 18.05 19.05
1999-95 FD-1060 (B 5.9L) . . . . . . . . 17.05 18.05
1999-95 FD-1460 (C 8.3L) . . . . . . . . 21.55 23.05
Mercedes Benz:7.2 L . . . . . . . . . . . . . . . . . . . . . . . 29.0 31.06.4 L . . . . . . . . . . . . . . . . . . . . . . . 28.315 29.915
12.8 L . . . . . . . . . . . . . . . . . . . . . . . 36.08 38.08
1 For engine filter, add 3.8 4.02 For engine filter, add 5.7 6.03 For combination filter, add 5.7 6.04 For combination filter, add 4.7 5.05 Includes oil filter.6 For engine filter, add 2.8 3.07 For combination filter, add 2.8 3.08 Typical crankcase capacity. Refer to engine Manufacturers manual for
exact capacity.9 Includes filter.10 Dry capacity shown. Fill only between ADD and FULL
marks at normal operating temperature.11 Front sump without brakesaver or rear sump.12 Standard deep oil sump.13 With brake saver & front sump.AUTOMATIC TRANSMISSION Liters QtAllison: AT-540 . . . . . . . . . . . . . . . . . . 14.0 14.8
AT-542 . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0AT-545 . . . . . . . . . . . . . . . . . . . . . . . 18.9 20.0
HD Series 1998 . . . . . . . . . . . . . . . . . . 48.2 51.0HT-740, -750 . . . . . . . . . . . . . . . . . . . . 28.4 30.0MT Series . . . . . . . . . . . . . . . . . . . . . . 17.0 18.0MD-3060, -3560:
1997 L-Series . . . . . . . . . . . . . . . 17.0 18.01997 Cargo . . . . . . . . . . . . . . . . . 18.0 19.01996 . . . . . . . . . . . . . . . . . . . . . . . 18.0 19.0
MD Series 2003-98 . . . . . . . . . . . . . 27.4 29.0Torqshift 5 S (initial fill) . . . . . . . . . . . . . 7.12 7.52Torqshift 5 S ( total fill) . . . . . . . . . . . . . 18.52 19.52
2000/2400 Seriesw/standard sump . . . . . . . . . . . . . . 10.01 10.61
w/shallow sump . . . . . . . . . . . . . . . 7.02 7.42
1 Approximate. Does not include external lines and cooler hose.2 Approximate. Make final inspection with dipstick.
MANUAL TRANSMISSIONSee Manufacturers Recommendations at the end of Medium& Heavy Truck section.
DIFFERENTIALSee Manufacturers Recommendations at the end of Medium& Heavy Truck section.
FREIGHTLINERLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . .CF-4, CG-4, CH-41, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-402
-22° to 86°F (-30° to 30°C), 5W-302
-40° to 104°F (-40° to 40°C), 0W-402
-40° to 86°F (-40° to 30°C), 0W-302
-40° to 50°F (-40° to 10°C), 0W-202
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur content exceeds 1.5%, choose an oil with the highestTBN in CF-4, CG-4, or CH-4 categories.
CHEVROLET/GMC Continued • FORD • FREIGHTLINER
149
MEDIUM & HEAVY TRUCKS
Cummins . . . . . . . . . . . . . . . .CG-4, CH-41, CI-4Above 5°F (-15°C), 15W-40 preferred-5° to 68°F (-21° to 20°C), 10W-302
Below 68°F (20°C), 5W-302
Below 32°F (6°C), 0W-302,3
Detroit Diesel 71, 92 Seriesengines . . . . . . . . . . . . . . . . . . . . . . . . . . .CF-2Continuous high temperature operation4, 50All temperatures, 40-25° to 0°F (-31° to -18°C), 305, 15W-405
50. 55 & 60 Series: up to 2001 . . . . . . . . . . . . .15W-40 CH-4, CI-4From 2002 onwards . . . . . . . . . . . . . . . . . .CI-4Note: At ambient temperatures below -4°F (-20°C), when crankingspeed cannot start engine, 5W-30, 5W-40, 10W-30 or 10W-40 maybeused provided they have demonstrated field performance in DDCengines.
Dodge:8.0L (V-10) & V8 . . . . . . . . . . . . . . . . . . . .API★Above 0°F (-18°C), 10W-30 preferredBelow 32°F (0°C), 5W-30
Mercedes-Benz:MBE900 . . . . . . . . . . . . . . . .CG-4, CH-4, CI-4Above 68°F (20°C), 40Above 23°F (-5°C), 20W-40Above 5° (-15°C), 15W-40 PreferredAbove -4°F (-20°C), 10W-40 41° to 77°F (5° to 25°C), 3014° to 59°F (-10° to 15°C), 20W-20-4° to 32°F (-20° to 0°C), 10WBelow 59°F (15°C), 5W-30All Temperatures, 5W-40OM 366LA . . . . . . . .CG-4/SH, CH-4/SJ, CI-4Above 41°F (5°C), 30Above 14°F (-10°C), 15W-405° to 68°F (-15° to -20°C), 10W-30-4° to 32°F (-20° to 0°C), 10W
TRANSMISSIONFor Transmissions not listed see ManufacturersRecommendations at the end of Medium & Heavy Trucksection.Allison . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3Chrysler 46RH . . . . . . . . . . . . . . . . . . . . . . . .AP4DIFFERENTIALSee Manufacturers Recommendations at the end of Medium& Heavy Truck section.
OTHER LUBRICATION POINTSAxle Shifter . . . . . . . . . . . . . . . . . . .10W SJ, SL7
Below 0°F (-18°C), mix w/25% keroseneBearing Cap (Sheppard Power
Steering) . . . . . . . . . . . . . . . . . . . . . . . . .EP LMBrake Slack Adjusters, 2003-96
Meritor/Rockwell: . . . . . . . . . . . . . . . . . .EP HGGunite:
-40° to -20°F (-40° to -29°C), Lubriplate AeroAbove -20°F (-29°C), Mobil Grease No. 77
Haldex/Eaton:-20°F (-29°C) and above . . . . . . . . . . . . . . . . .EP LMBelow -20°F (-29°C), Low Temp . . . . . . . . . . .EP LM
Cargo Models . . . . . . . . . . . . . . . . . . . .EP HGuse a high temp. water-proof grease. (NLGI grade 1)
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .LMBrake Camshaft Bracket Bushings . . . . .EP LMCab Tilt Pump . . . . . . . . . . . . . . . . . . . . . . . .CTFChassis Grease Fittings . . . . . . . . . . . . . .EP LMClutch Master Cylinder (Cargo) . . . . . . . . . . .HBClutch Release Bearing . . . . . . . . . . . . . . . . .HG** Meritor/Rockwell use NLGI No. 3. Others use No. 1 or 2.
Door Hinges & Latches . . . . . . . . . . . . . . . . .MOFan Clutch (Evans) . . . . . . . . . . . . . . . . . . . . .HGLincoln Multiluber
Above 32°F (0°C), 90 or 140 GL-5Below 32°F (0°C), 30 SJDo not use SCL gear oil
Moisture Ejection Valve: Bendix . . . . . .10W MOPower Steering:
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . . .MAOthers:2003-96: Ross, Sheppard, TRW . . . .AF3, PS8
With engine oil installed6 10W-40 Union, Texaco, Mobil or Chevron;15W-40 Union; 30W Shell Rotella T. Condor models: With hydraulicfluid installed use Chevron Torque 5 or Exxon Nuto H32. Do not mixlubricant types.
Others . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3Speedometer & Tachometer Cables
2003-96 . . . . . . . . . . . . . . . . . . . . . . . . . . .SP
Steering Driveline Deck Bearing(FLA, FLB only) . . . . . . . . . . . . . . . . . . . . . .MO
Steering Gearbox, Manual . . . . . . . . . . . . . .GL-5Above 30°F (-1°C), 90Below 30°F (-1°C), 75
Stewart-Warner Oil Mist . . . . . . . . . . . . . . . . .SJSummer, 30; winter, 10W
Universal Joints & Splines . . . . . . . . . . . .EP LMWedge Brake . . . . . . . . . . . . . . . . . . . . . . . . .LMWheel Bearings:
Grease Lubricated . . . . . . . . . . . . . . . . . . . .GCOil Lubricated . . . . . . . . . . . . . . . . . . . . . .GL-5
Same viscosity as differential.Windshield Wiper MotorDow-Corning No. 200 or equivalent.1 Preferred.2 Continuous use of low viscosity oils can lead to increased engine wear.3 API-III synthetics are recommended where ambient conditions are
consistently below -13°F (-25°C). API-III 0W-30 synthetic may be usedwhere ambient temperatures never exceed 32°F (0°C), but higher cylin-der wear may be expected. Do not use friction-modified oil withoutevidence of satisfactory performance in Cummins engines.
4 Coolant outlet temperature over 200°F (95°C).5 Replace with 40 as soon as ambient conditions permit.7 Sulfated ash content must not exceed 1.85%. May also use AF3 for all
temperatures. Do not mix kerosene or engine oil with ATF.8 Condor may use Fleetrite® PSF or Texaco TL-1833.
CAPACITYCRANKCASE Liters Qt
Crankcase capacities include full-flow but not bypass filters.On models equipped with, Fleetguard LF 750 bypass oil filter, add anadditional 11.3 liters (11.9 qts) of oil.On models equipped with, Luber-finer 750 CT bypass oil filter, add anadditional 13.2 liters (13.9 qts) of oil.
Caterpillar:3126B w/small pan . . . . . . . . . . . . . 19.11 21.01
w/large pan . . . . . . . . . . . . . . . . . 30.31 32.01
3176 . . . . . . . . . . . . . . . . . . . . . . . 28.5 30.03306 . . . . . . . . . . . . . . . . . . . . . . . 23.5 25.03306C . . . . . . . . . . . . . . . . . . . . . . . 38.8 41.03406 . . . . . . . . . . . . . . . . . . . . . . . 34.0 36.0W/Brake Saver . . . . . . . . . . . . . . . . 24.61 26.01
3408 . . . . . . . . . . . . . . . . . . . . . . . 41.6 44.0CL112 . . . . . . . . . . . . . . . . . . . . . . . 39.71 2 42.01 2
CL112 . . . . . . . . . . . . . . . . . . . . . . . 34.01 3 36.01 3
CL112 . . . . . . . . . . . . . . . . . . . . . . . 37.94 6 40.04 6
CL112 . . . . . . . . . . . . . . . . . . . . . . . 49.24 5 52.04 5
C10, C12:w/deep pan or center sump . . . . . 34.0 36.0w/shallow pan . . . . . . . . . . . . . . . 30.0 32.0
CFE . . . . . . . . . . . . . . . . . . . . . . . 29.31 31.01
Cummins:ISB . . . . . . . . . . . . . . . . . . . . . . . 16.11 17.01
ISC . . . . . . . . . . . . . . . . . . . . . . . 18.91 20.01
B-Series . . . . . . . . . . . . . . . . . . . . . 16.4 17.3C-Series . . . . . . . . . . . . . . . . . . . . . 22.2 23.5L10 . . . . . . . . . . . . . . . . . . . . . . . 34.11 36.01
M11 . . . . . . . . . . . . . . . . . . . . . . . 34.11 36.01
N14 . . . . . . . . . . . . . . . . . . . . . . . 36.01 38.01
Fleet, Formula, NTC, PowerTorque 855 . . . . . . . . . . . . . . . . . . 41.6 44.0
Big Cam III, IV . . . . . . . . . . . . . . . . . 39.0 41.0Detroit Diesel:
6-71 . . . . . . . . . . . . . . . . . . . . . . . 22.7 24.06L-71 . . . . . . . . . . . . . . . . . . . . . . . 20.81 22.01
6V-71 . . . . . . . . . . . . . . . . . . . . . . . 18.9 20.06V-92 . . . . . . . . . . . . . . . . . . . . . . . 20.8 22.08V-71 . . . . . . . . . . . . . . . . . . . . . . . 23.7 25.08V-92 . . . . . . . . . . . . . . . . . . . . . . . 21.81 23.01
Series 60 . . . . . . . . . . . . . . . . . . . . . 30.31 32.01
Series 55 . . . . . . . . . . . . . . . . . . . . . 21.31 22.51
Series 50 . . . . . . . . . . . . . . . . . . . . . 20.81 22.01
Dodge:5.9L (V-8) . . . . . . . . . . . . . . . . . . . . . 4.7 5.08.0L (V-10) . . . . . . . . . . . . . . . . . . . . 6.6 7.0
Mercedes-Benz:MBE900 series:
4 cyl. (4.3L) . . . . . . . . . . . . . . . . . . . 15.8 17.06 cyl. (6.4L) . . . . . . . . . . . . . . . . . . . 29.3 31.0
CL112 . . . . . . . . . . . . . . . . . . . . . . . 36.01 38.01
OM 366LA . . . . . . . . . . . . . . . . . . . . . . 15.0 15.9Canister Filter, add . . . . . . . . . . . . . 2.5 2.6Spin-on Filter, add . . . . . . . . . . . . . . 1.8 1.9Injection Pump, add . . . . . . . . . . . . 0.5 0.5All engines: With Fleetgard bypass filter:
Spin-on, add . . . . . . . . . . . . . . . . 2.8 3.0Bolt-on, add . . . . . . . . . . . . . . . . . 10.8 11.5
Note: Centrifugal bypass filter does not require additional oil.1 Typical crankcase capacity. Refer to engine Manufacturers manual for
exact capacity.2 Shallow oil sump.3 Stand deep oil sump.4 Approximate crankcase sump capacity including standard factory
installed oil filters.Engines with auxiliary oil filters or equipment will require differing
amounts of oil.5 With BrakeSaver & Front Sump6 Front sump without BrakeSaver, or rear sump.AUTOMATIC TRANSMISSION Liters QtAllison: AT-542 . . . . . . . . . . . . . . . . . . . . . . . 15.1 16.0AT-545 ex. School Bus . . . . . . . . . . . . 15.0 16.0
AUTOMATIC TRANSMISSION Liters QtSchool Bus . . . . . . . . . . . . . . . . . . . . . 19.9 21.0HD-4060, -4560:
w/ shallow sump . . . . . . . . . . . . . . . 38.0 40.0w/ standard sump . . . . . . . . . . . . . . 45.0 48.0
MD-CR (incl. filter) . . . . . . . . . . . . . . . . 16.4 17.5MD-WR (incl. filter) . . . . . . . . . . . . . . . 16.4 17.5MD-3060, -3066 Condor . . . . . . . . . . . 27.0 29.0MD-3060 P/PR ex. Condor . . . . . . . . . 16.5 17.5MT-40, -41, -42 . . . . . . . . . . . . . . . . . . 8.5 9.0MT-643 School bus . . . . . . . . . . . . . . . 18.0 19.0Others: . . . . . . . . . . . . . . . . . . . . . . . 14.0 15.0
MT653 . . . . . . . . . . . . . . . . . . . . . . . 14.0 15.0MT-654 CR . . . . . . . . . . . . . . . . . . . . . 8.0 8.5HT-740D, HT-740FS . . . . . . . . . . . . . . 12.3 13.0HT-740T . . . . . . . . . . . . . . . . . . . . . . . 12.3 13.0HT-750CRD, HT-750DRD . . . . . . . . . . 29.3 31.0HT-754CR . . . . . . . . . . . . . . . . . . . . . . 29.3 31.0Chrysler 46RH* . . . . . . . . . . . . . . . . . . 10.3 10.9Quantities listed are approximate. * With engine at operating temperature, shift transmission through all
gears. Check fluid level in NEUTRAL and add fluid as needed (Chryslertransmissions only).
MANUAL TRANSMISSIONSee Manufacturers Recommendations at end of Medium &Heavy Truck section.
DIFFERENTIALSee Manufacturers Recommendations at end of Medium &Heavy Truck section.
HINOLUBRICANT GRADECRANKCASEHino engines . . . . . . . . .CF-4, CG-4, CH-4, CI-4
Above 50°F (10°C), 40WAbove -10°F (-23°C), 15W-4032° to 90°F (0° to 32°C), 30W-10° to 70°F (-23° to 21°C), 20W-20Below 32°F (0C°), 10W-304
Note: SAE 30 is preferred.
TRANSMISSIONAllison Automatic . . . . . . . . . . . . . . . . . . . . .AF3
Above 86°F (30°C): 30 HFFuller Manual . . . . . . . . . . . . . . . . .CF, SJ, GL-1
Above 10°F (-12°C), 40, 50, 90Below 10°F (-12°C), 30, 80WAll temperatures, 50 synthetic
Hino Manual . . . . . . . . . . . . . . . . . . . . . . . .GL-4Above 90°F (32°C), 140W10° to 90°F (-12° to 32°C), 90W
Aisin Automatic . . . . . . . . . . . . . . . . . . . . . . .AF3DIFFERENTIALAll . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 90°F (32°C), 140W10° to 90°F (-12° to 32°C), 90W
OTHER LUBRICATION POINTSBrake & Clutch Fluid . . . . . . . . . . . . . . . . . . . .HBBrake Adjusters & Cam Brackets . . . . . . . . . .HGBrake Slack Adjusters . . . . . . . . . . . . . . . . . .HGChassis Grease Fittings . . . . . . . . . . . . . .EP LMClutch Shaft & Release: 2003-00 use No. 2 LM; 1999-96 use HG
Manual Steering Box . . . . . . . . . . . . . . .90 GL-4Power Steering Fluid . . . . . . . . . . . . . . . . . . .AF2Starter Bearings: 1997-96 . . . . . . . . . . . . . . .HG1
2004-98 . . . . . . . . . . . . . . . . . . . .No. 2 EP LMTie Rods, Drag Link, Steering Shaft
U-Joint & Spline . . . . . . . . . . . . . . . . .Moly LMWater Pump . . . . . . . . . . . . . . . . . . . . . . . . . .HGWheel Bearings . . . . . . . . . . . . . . . . . . . . .EP LM1 Polyurea grease preferred.
CAPACITYCRANKCASE Liters QtIncludes filters FA, FB 1999-96 . . . . . . . . . . . . . . . . . . 9.5 10.1
2003-00 . . . . . . . . . . . . . . . . . . . . . . 8.9 9.52004-96 FD, FE, FF . . . . . . . . . . . . . . . 13.5 14.3
SG . . . . . . . . . . . . . . . . . . . . . . . 13.5 14.3AUTOMATIC TRANSMISSION Liters QtAisin 450-43LE . . . . . . . . . . . . . . . . . . 1 2 1 2
Allison Automatic (Total Fill)MD3060 . . . . . . . . . . . . . . . . . . . . . . . 24.62 26.02
2400: Standard Pan . . . . . . . . . . . . . . 14.22 15.02
Shallow Pan . . . . . . . . . . . . . . . . . . 12.32 13.02
Allison Automatic (Initial Refill)MD3060 . . . . . . . . . . . . . . . . . . . . . . . 18.02 19.02
2400: Standard Pan . . . . . . . . . . . . . . 9.9 2 10.52
Shallow Pan . . . . . . . . . . . . . . . . . . 7.12 7.52
FA, FB . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.02003-96 FD . . . . . . . . . . . . . . . . . . . . . 8.5 9.0
FE, FF5H . . . . . . . . . . . . . . . . . . . . . 15.0 15.9FF4H . . . . . . . . . . . . . . . . . . . . . . . 11.0 11.7
SF, SG . . . . . . . . . . . . . . . . . . . . . . . 11.0 11.7
FREIGHTLINER Continued • HINO
150
MEDIUM & HEAVY TRUCKS
MANUAL TRANSMISSION Liters PtFA, FB . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.7FD, FE, FF, GC:
LF Series 5-speed . . . . . . . . . . . . . . 6.0 12.7LF Series 6-speed . . . . . . . . . . . . . . 7.0 14.8LJ Series 6-speed . . . . . . . . . . . . . . 8.0 17.0MF Series 6-speed . . . . . . . . . . . . . 11.5 24.4MG Series 6-speed . . . . . . . . . . . . . 9.5 20.1
SF, SG:LF Series 6-speed . . . . . . . . . . . . . . 7.0 14.8LJ Series 6-speed . . . . . . . . . . . . . . 8.0 17.0MF Series 6-speed . . . . . . . . . . . . . 11.5 24.3MG Series 6-speed . . . . . . . . . . . . . 9.5 20.1Fuller RT-6610 Series . . . . . . . . . . . 6.0 12.7RT-8609 Series . . . . . . . . . . . . . . . . 7.0 14.8
DIFFERENTIAL Liters PtMS12-113 . . . . . . . . . . . . . . . . . . . . . . 6.6 14.0RS13-120 . . . . . . . . . . . . . . . . . . . . . . 8.7 18.4RS17-145 . . . . . . . . . . . . . . . . . . . . . . 15.9 33.6RS19-145 . . . . . . . . . . . . . . . . . . . . . . 15.7 33.2RS21-145 . . . . . . . . . . . . . . . . . . . . . . 15.3 32.3FA, FB: 1997-96 . . . . . . . . . . . . . . . . . 3.5 7.4
2003-98 . . . . . . . . . . . . . . . . . . . . . . 3.7 7.8GC . . . . . . . . . . . . . . . . . . . . . . . 3.7 7.82003-98 FD, FE . . . . . . . . . . . . . . . . . . 5.5 11.7
FF, SG . . . . . . . . . . . . . . . . . . . . . . . 10.0 21.31997-96 SG (Truck) . . . . . . . . . . . . . . . 10.0 21.2
(Truck Tractor) . . . . . . . . . . . . . . . . . 7.0 14.81997-96 FD . . . . . . . . . . . . . . . . . . . . . 5.5 11.7
FE, FF . . . . . . . . . . . . . . . . . . . . . . . 10.0 21.21 Pan capacity, 5.2 qts.(4.9L) Overhaul capacity 14.3 qts. (13.5L)2 Approximate. Make final inspection with dipstick.
INTERNATIONAL (NAVISTAR)LUBRICANT GRADECRANKCASECaterpillar 3306, 3176, 3176B,
3208, 3406C, 3406E . . . . .CH-4, CG-41, CF-45° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30
Cummins 6CTA83, L10, M11, N14 . . . . . . . . . . . . . . . . . . . .CF-4, CG-4Above 5° (-15°C), 15W-40 preferred-5° to 68°F (21° to 20°C) 10W-30Below 68°F (20°C), 5W-30Below 32°F (0°C), 0W-30API-III synthetics are recommended where ambi-ent conditions areconsistently below -13°F (-25°C).API-III 0W-30 synthetic may be used where ambient temperaturesnever exceed 32°F (0°C), but higher cylinder wear may be expected.Do not use friction modified oil without evidence of satisfactory per-formance.
Detroit Diesel:71, 92 Series engines . . . . . . . . . . . . . . . .CF-2Continuous high temperature operation2, 50All temperatures, 40-25° to 0°F (-31° to -18°C), 303,15W-403
60 Series, 2001-99 . . . . . . . . . . . . . . . . . .CI-460 Series, Other years . . . . . . . .15W-40, CI-4Note: At ambient temperatures below -4°F (-20°C) when crankingspeed cannot start engine, 5W- or 10W-30 or 40 may be used provid-ed they have demonstrated field performance in DDC engines.
International . . . . . . . . . .CH-4, CG-4/SJ, CH-4,CI-4 Plus,CI-4/SL
Above 20°F (-8°C), 15W-408
-10° to 90°F (-23° to -33°C), 10W-309
-20° to 50°F (-29° to 10°C), 5W-30Below 50°F (10°C), 0W-30
International engines: Do not use oils specified for stationary, marine, orrailroad engines. Do not use “Energy Conserving” oil containingmolybdenum dithiophosphate. Do not use with the starburst symbolspecified for gasoline engines.
LP-Gas, Natural Gas . . . . . . . . . . . . . . .CF-4/SJAbove 30°F (-1°C), 305
Above 10°F (-12°C), 20W-40Above 0°F (-18°C), 15W-401,6
-10° to 90°F (-23° to 32°C), 10W-30, 10W-40-20° to 50°F (-29° to 10°C), 5W-30Below 50°F (10°C), 0W-30
TRANSMISSIONFor Transmissions not listed see ManufacturersRecommendations at the end of Medium & Heavy Trucksection.Allison:AT500 Series, HD 4000 Series,HT 700 Series, MD 3000 SeriesTorqshift 5 speed . . . . . . . . . . . . . . . . . . . . .MSPMT 600 Series, B 3/4/500 . . . . . . . . . . .AF37, HFCLT, CLBT models . . . . . . . . . . . . . . . . . . . . .HF
Main case: Consistently above 86°F (30°C), 30Other conditions, 10WDrop box: All temperatures, 30
Manual Transmissions:Clark, 1995 and earlier:
Above 20°F (-7°C), 50 SJ, SL, 90W . . . . . . . . . . . .GL-1Above -20°F (-29°C), 80W-90 . . . . . . . . . . . . . . . .GL-5-20° to 60°F (-29° to 16°C), 30W SJ, 80W . . . . . . .GL-1Below 0°F (-18°C), 75W . . . . . . . . . . . . . . . . . . . . .GL-5
Eaton-Fuller2003-96 . . . . . . . . . . . . . . . . .SJ, SL, CF, GL-1All temperatures, 50 synthetic4
Above 10°F (-12°C), 80W-90, 50Below 10°F (-12°C), 75W, 40
Dana Spicer . . . . . . . . . . . . . . . . . . . . .CF-4, CENew Process, 1995 and earlier . . . . . . . . . .GL-1
Consistently above 90°F (32°C), 140Above 0°F (-18°C), 90Below 0°F (-18°C), 80WConsistently below 0°F (-18°C), 75W
SpicerSee Transmission Manufacturers Lubricant Recommendations and Capacities at the end of this section.
TRANSFER CASE, FABCO . . . . . . . . .as notedAbove 10°F (-12°C), 50, SAE 90, ML-L2104E 50, MIL-L2104E SAE 90 except sulfur chlorine-lead type.Below 10°F (-12°C), 30, 80Below 0°F (-18°C), 20W
Note: Under certain conditions, use of extreme pressure lubricants willcause carbon deposits to form on internal parts causing malfunctionsand premature wear. Consider using mineral gear oil or heavy dutyengine oil.
DIFFERENTIALEaton
See Differential Manufacturers Lubricant Recommendations and Capacities at the end of this section.
Meritor/RockwellSee Differential Manufacturers Lubricant Recommendations and Capacities at the end of this section.
Other Differentials . . . . . . . . . . . . . . . . . . . .GL-59
Above 40°F (4°C), 140Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-140Above -40°F (-40°C), 75W-14010° to 100°F (-12° to 38°C), 90-15° to 100°F (-26° to 38°C), 80W-90-40° to 100°F (-40° to 38°C), 75W-90
Power divider, use same lubricant as differential.
Other Lubrication PointsBrake & Clutch Master Cylinders . . . . . . . . . .HBBrake Shoe Anchor Pins . . . . . . . . . . . . .EP LMCab Hydraulic Tilt Pump:
Cargostar . . . . . . . . . . . . . . . . . . . . . . . . . .CTFCO-5870, -9670 . . . . . . . . . . . . . . . . . . . . . .AF
Chassis Grease Fittings . . . . . . . . . . . . . .EP LMInput Shaft Bearing Cap,
Sheppard Power Steering . . . . . . . . . . .EP LMManual Steering Box:
International . . . . . . . . . . .90W, 85W-140 GL-5Nissan . . . . . . . . . . . . . . . . .trans. grade GL-4
Power Divider Lock Shift Motor . . . . . .10W MOPower Steering:
Nissan . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3Saginaw . . . . . . . . . . . . . . . . . . . . . . . . . . . .PSSheppard & Ross:1000-8000, 9600, 9700 Series . . . . . . . . . . .PS5000, 9100, 9200, 9500, 9500
Series . . . . . . . . . . . . . . . . . .15W-40 SJ/CDOutput Shaft Seal . . . . . . . . . . . . . . . . .EP LM
Slack Adjusters . . . . . . . . . . . . . . . . . . . . .EP LMSpeedometer & Tachometer Cables . . . . .EP LMSteering Column Flex Coupling . . . . . . . .EP LMTransmission Air Cylinder
Linkage . . . . . . . . . . . . . . . . . . . . . . .10W MO8
Wheel Bearings:Grease lubricated . . . . . . . . . . . . . . . . . . . .GCOil lubricated . . . . . . . . . . . . . . . . . . . . . .GL-5Same viscosity as differential. Front axle may use 50 MO or 50 syn-thetic transmission oil.
1 Preferred.2 Coolant outlet temperature over 200°F (95°C).3 Replace with 40 as soon as ambient conditions permit.4 Should be used when temperature frequently exceeds 250°F (120°C).5 Preferred viscosity for above 20°F (-8°C).6 Preferred viscosity for 0° to 30°F (-18° to -1°C).7 Use HF, or SLF for off-highway and severe duty operation or when
ambient temperature is consistently above 86°F (30°C).8 Below 0°F (-18°C), mix with 25% kerosene.9 For traction equalizer axles, add 2/3 oz. friction modifier additive per
pint of GL-5 (.42 ml per liter).
CAPACITYNote: See TRUCK TRANSMISSION and DIFFERENTIAL pages for
capacities not shown below.CRANKCASE Liters QtGASOLINE ENGINESInternational:V-345, -392 . . . . . . . . . . . . . . . . . . . . . 7.61 8.01
V-537 . . . . . . . . . . . . . . . . . . . . . . . 9.5 10.0VS-478, -549 . . . . . . . . . . . . . . . . . . . . 9.5 10.0DIESEL ENGINESInternational:2003-96: DT408, DT-466, -466HT . . . . 22.7 24.0
T444E . . . . . . . . . . . . . . . . . . . . . . . 18.0 19.5530E . . . . . . . . . . . . . . . . . . . . . . . 22.7 24.0
DT-466 w/front sump . . . . . . . . . . . . . 21.02 22.02
DT-466 w/rear sump . . . . . . . . . . . . . . 19.02 20.02
2005 DT466 . . . . . . . . . . . . . . . . . . . . 26.55 28.05
2004-02 DT530 . . . . . . . . . . . . . . . . . . 26.22 28.02
2005-03 VT365 . . . . . . . . . . . . . . . . . . 18.05 19.05
V-800 (4070 Series) . . . . . . . . . . . . . . . 36.12 38.02
V-800 (5070 Series) . . . . . . . . . . . . . . . 30.42 32.02
6.9L . . . . . . . . . . . . . . . . . . . . . . . 10.42 11.02
7.3L . . . . . . . . . . . . . . . . . . . . . . . 15.02 16.02
9.0L . . . . . . . . . . . . . . . . . . . . . . . 13.32 14.02
With Fleetgard by-pass filter, add . . 11.3 12.0With Luberfiner 750 by-pass
filter, add . . . . . . . . . . . . . . . . . . . 13.2 14.0Caterpillar:C-10 2005-00 deep pan . . . . . . . . . . . 34.2 36.0
shallow pan . . . . . . . . . . . . . . . . . . . 30.4 32.0C-12 2005-00 deep pan . . . . . . . . . . . 34.2 36.0
shallow pan . . . . . . . . . . . . . . . . . . . 30.4 32.0C-11, C-13 2005-04 . . . . . . . . . . . . . . 39.75 6 42.05 6
C-11, C-13 2005-04 . . . . . . . . . . . . . . 34.25 7 36.05 7
C-15 2005-03 . . . . . . . . . . . . . . . . . . . 37.93 40.03
. . . . . . . . . . . . . . . . . . . . . . . 49.24 52.04
3176 . . . . . . . . . . . . . . . . . . . . . . . 28.52 30.02
3208 . . . . . . . . . . . . . . . . . . . . . . . 11.4 12.03306, -DID, -PCT, -PCTA, -T . . . . . . . . 23.7 25.03406, -DIT, -DITA, -PCT, -PCTA . . . . . . 34.2 36.0
Without brake saver . . . . . . . . . . . . 24.6 26.03406B-DITA . . . . . . . . . . . . . . . . . . . . 34.2 36.03406C, E . . . . . . . . . . . . . . . . . . . . . . . 38.8 40.0Cummins: L10, M11, M11 plus . . . . . . 34.2 36.0
LTA-10 . . . . . . . . . . . . . . . . . . . . . . . 26.2 28.0ISK 2005-03 9200 9400 Series . . . . . . 45.4 48.0ISK 2005-01 9900 Series . . . . . . . . . . 30.4 32.0ISK 2005-03 5500I, 5600I, 5900I . . . . . 45.4 48.0ISM 2005-00 . . . . . . . . . . . . . . . . . . . . 37.02 39.02
PT-240, Formula 240 . . . . . . . . . . . . . . 26.6 28.0PTC-240 . . . . . . . . . . . . . . . . . . . . . . . 34.2 36.0PT-270 ex. Big Cam III . . . . . . . . . . . . . 30.4 32.0PT-270, Formula 270 Big Cam III . . . . 34.2 36.0N14, 1996; N14 plus, 1996 . . . . . . . . . 36.0 38.0N14 2004-00 . . . . . . . . . . . . . . . . . . . . 38.62 40.82
NTC NTCC-290, Formula290, C290 . . . . . . . . . . . . . . . . . . . . 30.4 32.0
NTCC-300, Formula C300 . . . . . . . . . 34.2 36.0NTC-300, Formula 300 Big Cam III . . . 34.2 36.0
Big Cam IV . . . . . . . . . . . . . . . . . . . 32.2 34.0With by-pass filter . . . . . . . . . . . . . . 39.7 42.0
NTC, NTCC-350, HT . . . . . . . . . . . . . . 34.2 36.0Formula 350, C350, HT ex. Big
Cam III, IV . . . . . . . . . . . . . . . . . . . . 32.8 34.5NTC-350, Formula 350 big Cam III . . . 34.2 36.0
Big Cam IV . . . . . . . . . . . . . . . . . . . 32.2 34.0With by-pass filter . . . . . . . . . . . . . . 39.7 42.0
NTA, NTC, NTCC-400 ex.Big Cam II, III . . . . . . . . . . . . . . . . . . 32.8 34.5
NTC, NTCC-400 Big Cam II, III . . . . . . 34.2 36.0Formula 400 Big Cam III . . . . . . . . . . . 34.2 36.0
Big Cam IV . . . . . . . . . . . . . . . . . . . 32.2 34.0With by-pass filter . . . . . . . . . . . . . . 39.7 42.0
Signature 600 2004 . . . . . . . . . . . . . . . 27.52 29.02
Detroit Diesel: 6-71, -N, -TT . . . . . . . . 28.5 30.06V-71N . . . . . . . . . . . . . . . . . . . . . . . 28.5 30.06V-92TT, -TTA, -TTAC . . . . . . . . . . . . . 17.1 18.06V-92TA, -TAC . . . . . . . . . . . . . . . . . . 17.1 18.08V-71, -T . . . . . . . . . . . . . . . . . . . . . . . 25.61 27.01
8V-71TA, -TTA . . . . . . . . . . . . . . . . . . . 22.81 24.01
8V-92T, -TA, -TAC . . . . . . . . . . . . . . . . 22.8 24.08V-92TT, -TTA, -TTAC . . . . . . . . . . . . . 22.8 24.01 With special oil pans, add 3.8L (4.0 qt) to 9.5L (10.0 qt).2 Capacity includes engine mounted filters.3 W/brake saver & rear sump.4 W/brake saver & front sump.5 Approximate. Crankcase capacity may vary due to filter equipment &
other accessories. Make final inspection with dipstick.6 Shallow oil sump.7 Standard deep oil sumpAUTOMATIC TRANSMISSION Liters QtAllison:1998:AT-542 . . . . . . . . . . . . . . . . . . . . . . . 7.9 8.4AT-545 . . . . . . . . . . . . . . . . . . . . . . . 14.7 15.5HD-4060P, 4560P . . . . . . . . . . . . . . . . 29.8 31.5HD-4060PR, 4560PR . . . . . . . . . . . . . 30.8 32.5HT-740OD, DR, RS . . . . . . . . . . . . . . . 32.4 32.9MD-3060P w/pto prov . . . . . . . . . . . . 14.8 15.6MD-3060 4&5 speed . . . . . . . . . . . . . . 14.8 15.6MD-3560P w/pto prov . . . . . . . . . . . . 14.8 15.6MD-3066P w/pto prov . . . . . . . . . . . . 14.8 15.6MT-653DR . . . . . . . . . . . . . . . . . . . . . . 10.0 10.5MT-654 . . . . . . . . . . . . . . . . . . . . . . . 18.8 20.0
HINO Continued • INTERNATIONAL (NAVISTAR)
151
MEDIUM & HEAVY TRUCKS
Capacity is approximate and can vary with different cooling systems.AUTOMATIC TRANSMISSION Liters Qt1997-96:AT-540, -545 . . . . . . . . . . . . . . . . . . . . 21.0 22.0AT-545 w/external filter . . . . . . . . . . . . 21.03 22.03
AT-540 (400, 500, 600 Trucks) . . . . . . . 19.0 20.1AT-542 . . . . . . . . . . . . . . . . . . . . . . . 12.3 13.0CLBT-750, Main . . . . . . . . . . . . . . . . . 33.1 35.0
w/Drop Box ADD . . . . . . . . . . . . . . . 2.5 2.6HT-740, HT-740RS . . . . . . . . . . . . . . . 32.4 34.3HT-740D, -750DRO . . . . . . . . . . . . . . . 33.1 35.0HT-740RS, -750DRD, -754CRD . . . . . 30.41 32.01
HT-740DRD . . . . . . . . . . . . . . . . . . . . . 33.0 34.9HT-750, -DRDB, Main . . . . . . . . . . . . . 28.4 30.0
Drop Box . . . . . . . . . . . . . . . . . . . . . 2.5 2.6MD-3060, -3560 . . . . . . . . . . . . . . . . . 27.6 29.0MT-643, -643DR, -654 . . . . . . . . . . . . 18.9 20.0MT-653, -653DR, -654CR . . . . . . . . . . 20.02 21.02
MT-643 (700, 900 Trucks) . . . . . . . . . . 17.0 18.0MT8-653DR . . . . . . . . . . . . . . . . . . . . 21.2 22.41 Total capacity shown.2 With external filter.3 Capacity varies with cooling system.MANUAL TRANSMISSION Liters PtClark: CL-455 . . . . . . . . . . . . . . . . . . . 5.7 12.0Dana Spicer:
ES066-7B . . . . . . . . . . . . . . . . . . . . 10.4 22.0ES53-5A . . . . . . . . . . . . . . . . . . . . . 6.0 13.0
Fuller: RT-6610 (700, 900 Series) . . . . . 6.0 13.0International:ES52-7A . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0ESO65-7 . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0AS series . . . . . . . . . . . . . . . . . . . . . . . 8.0 17.0ASO series . . . . . . . . . . . . . . . . . . . . . 8.0 17.0LAS series . . . . . . . . . . . . . . . . . . . . . . 8.0 17.0LLPS series . . . . . . . . . . . . . . . . . . . . . 8.0 17.0LLPSO series . . . . . . . . . . . . . . . . . . . 8.0 17.0LPS series . . . . . . . . . . . . . . . . . . . . . . 8.0 17.0LPSO series . . . . . . . . . . . . . . . . . . . . 8.0 17.0PSO series . . . . . . . . . . . . . . . . . . . . . 8.0 17.0PSX series . . . . . . . . . . . . . . . . . . . . . . 8.0 17.01997 and earlier:AS0150-10S . . . . . . . . . . . . . . . . . . . . 12.3 13.0ES52-7A,ES-65-7 . . . . . . . . . . . . . . . . 9.9 21.0ES52-7A . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0PS95-9A . . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0PS9VPD . . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0PS125-9A . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0PS140-9A . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0PS09VPD, PS010VPD . . . . . . . . . . . . . 12.3 26.0PS0125-9A, PS0140-9, 9A . . . . . . . . . 12.3 26.0PS0150-9A, -10S; PS0165-10S . . . . . 12.3 26.0Nissan:400, 500 Series: 5-speed . . . . . . . . . . 5.3 11.2
6-speed . . . . . . . . . . . . . . . . . . . . . . 4.8 10.2600 Series: 6-speed . . . . . . . . . . . . . . 6.8 14.4700, 900 Series: 5-speed . . . . . . . . . . 7.5 16.0
6-speed . . . . . . . . . . . . . . . . . . . . . . 7.0 15.0For transmissions not listed, see Manufacturers Recommendations atend of Medium & Heavy Truck section.
DIFFERENTIAL Liters PtDana Spicer:S110 . . . . . . . . . . . . . . . . . . . . . . . 5 5
S23-170 . . . . . . . . . . . . . . . . . . . . . . . 5 5
S150-S . . . . . . . . . . . . . . . . . . . . . . . 11.67 24.57
S135-S . . . . . . . . . . . . . . . . . . . . . . . 11.67 24.57
Nissan:400, 500 Series . . . . . . . . . . . . . . . . . . 4.0 8.4600 Series . . . . . . . . . . . . . . . . . . . . . . 12.0 25.0700, 900 Series: Single speed . . . . . . . 12.0 25.0
Two speed . . . . . . . . . . . . . . . . . . . . 16.0 34.0Meritor :RS-23-186 . . . . . . . . . . . . . . . . . . . . . 18.56 39.06
Differentials By International Code: 14029 . . . . . . . . . . . . . . . . . . . . . . . 11.0 24.014036, 14044 . . . . . . . . . . . . . . . . . 18.0 37.014040 . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.014046 . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.014047 . . . . . . . . . . . . . . . . . . . . . . . 15.01 32.01
14051, 14057 . . . . . . . . . . . . . . . . . 16.0 35.014052 . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.014087 . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014088 . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.014095, 14097, 14131, 14133 . . . . . . 18.0 39.014096 . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014130 . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.014132 . . . . . . . . . . . . . . . . . . . . . . . 18.0 39.0
14308, 14309: Front . . . . . . . . . . . . . . 15.02 32.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014345: Front . . . . . . . . . . . . . . . . . . . . 18.0 38.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.014350: Front . . . . . . . . . . . . . . . . . . . . 19.0 40.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014357, 14465: Front . . . . . . . . . . . . . . 19.04 40.04
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.014437 . . . . . . . . . . . . . . . . . . . . . . . 15.03 31.03
14455: Front . . . . . . . . . . . . . . . . . . . . 19.0 40.0Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0
14472: Front . . . . . . . . . . . . . . . . . . . . 16.01,3 34.01,3
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.0 23.014474: Front . . . . . . . . . . . . . . . . . . . . 17.01 36.01
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.0 23.014495, 14495, 14496: Front . . . . . . . . 15.02 32.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.0 28.0
DIFFERENTIAL Liters Pt14498: Front . . . . . . . . . . . . . . . . . . . . 15.0 32.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014502: Front . . . . . . . . . . . . . . . . . . . . 18.0 38.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.014ACB, 14ACC . . . . . . . . . . . . . . . . . . 12.0 25.014ACD . . . . . . . . . . . . . . . . . . . . . . . 18.0 37.014ACG . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.014ADA, 14ADE, 14ADJ . . . . . . . . . . . . 11.0 24.014ADB, 14ADC, 14ADH . . . . . . . . . . . 14.0 29.014ADL, 14ADM, 14ADV, 14ADY . . . . . 16.0 34.014ADN, 14ADP . . . . . . . . . . . . . . . . . . 12.0 25.014ADR, 14ADU, 14AEL . . . . . . . . . . . . 23.0 48.014ADW, 14AEU . . . . . . . . . . . . . . . . . . 18.0 38.014AED . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014AEE, 14AEH, 14ADK . . . . . . . . . . . . 16.0 34.014AEG, 14AEL . . . . . . . . . . . . . . . . . . 23.0 48.013AEJ, 14AEK . . . . . . . . . . . . . . . . . . . 19.0 40.014AET, 14AEW . . . . . . . . . . . . . . . . . . 13.0 28.014AEP . . . . . . . . . . . . . . . . . . . . . . . 22.0 46.014AEX, 14AEZ, 14AGB . . . . . . . . . . . . 19.0 40.014AEY, 14AGA . . . . . . . . . . . . . . . . . . 14.3 28.014AGC . . . . . . . . . . . . . . . . . . . . . . . 20.0 43.014ARA . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.014ARB . . . . . . . . . . . . . . . . . . . . . . . 19.0 40.014ARC, 14ARD, 14ARE, 14 ARS . . . . . 22.0 47.014ARG . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.014ARH . . . . . . . . . . . . . . . . . . . . . . . 16.0 33.014ARK . . . . . . . . . . . . . . . . . . . . . . . 18.0 37.014CDA . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.014CDB . . . . . . . . . . . . . . . . . . . . . . . 17.0 35.014CDD . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.014CEA . . . . . . . . . . . . . . . . . . . . . . . 18.0 39.014CEB, 14CEJ, 14CEK, 14EEC . . . . . 17.0 36.014EEH . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.014ERA, 14ERB . . . . . . . . . . . . . . . . . . 28.0 59.014GDA, 14GDC, Front . . . . . . . . . . . . 14.01 30.01
14GEB, 14GEC, 14GED: Front . . . . . . 23.02 48.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.014GEE: Front . . . . . . . . . . . . . . . . . . . 21.02 44.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 21.0 43.014GEH: Front . . . . . . . . . . . . . . . . . . . 23.0 48.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.014GEJ: Front . . . . . . . . . . . . . . . . . . . . 15.02 32.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.014GEK: Front . . . . . . . . . . . . . . . . . . . 21.02 44.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.014GEL: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.014GEM: Front . . . . . . . . . . . . . . . . . . . 18.0 39.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.014GEN: Front . . . . . . . . . . . . . . . . . . . 15.0 32.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.014GRA, 14GRB, 14GRC: Front . . . . . . 12.0 26.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.014GRD: Front . . . . . . . . . . . . . . . . . . . 18.0 37.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.014GRE, 14GRG, 14GRH: Front . . . . . . 26.0 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 21.0 45.014GRJ, 14GRK, 14GRL, 14GRM:
Front . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.0Rear . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.0
14GRN: Front . . . . . . . . . . . . . . . . . . . 12.0 26.0Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0
14GRP: Front . . . . . . . . . . . . . . . . . . . 18.0 37.0Rear . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.0
14GRR, 14GRS: Front . . . . . . . . . . . . . 19.0 36.0Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 35.0
14GRU, 14GRW: Front . . . . . . . . . . . . 14.0 29.0Rear . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.0
14GRV . . . . . . . . . . . . . . . . . . . . . . . 27.0 56.0Rear . . . . . . . . . . . . . . . . . . . . . . . 28.0 58.0
14GRY, 14GSB: Front . . . . . . . . . . . . . 15.0 31.0Rear . . . . . . . . . . . . . . . . . . . . . . . 13.0 27.0
14GRZ: Front . . . . . . . . . . . . . . . . . . . 12.0 25.0Rear . . . . . . . . . . . . . . . . . . . . . . . 11.0 23.0
14GSA: Front . . . . . . . . . . . . . . . . . . . 21.0 44.0Rear . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0
14GSC: Front . . . . . . . . . . . . . . . . . . . 29.0 62.0Rear . . . . . . . . . . . . . . . . . . . . . . . 18.0 37.0
14GSE, 14GSH . . . . . . . . . . . . . . . . . . 27.0 56.0Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
14GSG . . . . . . . . . . . . . . . . . . . . . . . 14.0 30.0Rear . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.0
14GST: Front . . . . . . . . . . . . . . . . . . . . 27.0 57.0Rear . . . . . . . . . . . . . . . . . . . . . . . 28.0 59.0
14GTB, 14GTC: Front . . . . . . . . . . . . . 22.0 48.0Rear . . . . . . . . . . . . . . . . . . . . . . . 22.0 48.0
14GSU . . . . . . . . . . . . . . . . . . . . . . . 21.0 44.0Rear . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0
14GSX . . . . . . . . . . . . . . . . . . . . . . . 14.0 30.0Rear . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.0
14GTD . . . . . . . . . . . . . . . . . . . . . . . 18.0 37.014GVA: Front . . . . . . . . . . . . . . . . . . . 17.0 36.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0For differentials not listed, see Manufacturers Recommendations atthe end of Medium & Heavy Truck section.
1 Add 2 pints (.95L) of forward rear differential capacity total to inter-axledifferential.
2 Add an additional 2 pints (.95L) of gear lube to inter-axle differentialforward rear axle.
3 Add 1 pint (.47L) of this total at pinion cage plug on single or tandemrear axles.
4 Fill forward rear and rear axle through fill hole located on side of carri-er housing.
5 Fill to bottom edge of fill plug hole. When refilling axle, ensure thatvehicle is parked on a level surface.
6 Capacity are for standard track axles that have been measured at var-ious common drive pinion angles. Quantities listed include enough oilfor both wheel ends. These will change if track or drive pinion angle isdifferent.
7 Always use filler hole as a final reference. If lube level is even with bot-tom of filler hole, axle is properly filled. If wheel ends were removed,additional fluid may be required. Fill capacity is approximate and willvary based on the angle at which the axle is installed in the vehicle.Ensure that the vehicle is on a level surface when adding fluid.
ISUZULUBRICANT GRADECRANKCASEDIESEL,2003-99 FSR, FTR, FVR . . . . .CG-4, CH-4, CI-4Others . . . . . . . . . . . . . . . . . . . . . . . . .CF, CF-4GASOLINE . . . . . . . . . . . . . . . . . . . . . . . .SJ, SLDiesel and Gasoline viscosities1
Above 77°F (25°C), 40, 50Above 5°F (-15°C), 15W-40, 20W-40, 20W-5032° to 86°F (0° to 30°C), 305° to 59°F (-15° to 15°C), 20W-20-22° to 86°F (-30° to 30°C), 10W-30-22° to 32°F (-30° to 0°C), 10WDiesel: Do not use synthetic oils.
AUTOMATIC TRANSMISSIONFRR, NPR & NQR, 2002-99 . . . . . . . . . . . . .AF3FSR, FTR, FVR (Allison),
2004-2005 . . . . . . . . . . . . . . . . . . . . . . . . .AF32003-99 . . . . . . . . . . . . . . . . . . . . . . . .AF3, HF1998-96 . . . . . . . . . . . . . . . . . . . . . . . .AF2, HF
NPR, NRR (JATCO), 1998-95 . . . . . . . . . . . .AF2AT 500 Series . . . . . . . . . . . . . . . . .AF3, HT, SLFMANUAL TRANSMISSIONFRR 2003-98 . . . . . . . . . . . . . . . . . . . . .90 GL-5FSR, FTR, FVR,
2002-97 . . . . . . . . . . . . . . . . . . . .80W-90 GL-5Canada 8W-90 GL-5
EVR, FSR, FTR, FVR:Fuller . . . . . . . . . . . . . . . . . . . . . . . . . . .SF, SGAll temperatures, 40W
Isuzu: 1996 . . . . . . . . . . . . . . . . . . . . . .GL-5U.S., 90; Canada, 80W
Isuzu MZZ 6 speed . . . . . . . . . . . . . . . . . . . . .SFNPR, NQR,
2003-96 . . . . . . . . . . . . .CF, CF/SH, CF-4/SHAbove 90°F (32°C), 40Below 90°F (32°C), 5W-30
NRR, 1995 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5U.S., 90; Canada, 80W
DIFFERENTIALNPR, NQR . . . . . . . . . . . . . . . . . . .SAE 90 GL-5FRR . . . . . . . . . . . . . . . . . . . . . .SAE 90 GL-5
Canada, 80 GL-5FSR, FTR, FVR,
2003-97 . . . . . . . . . . . . . . . .Synthetic 75W-901996-96 . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5U.S., 90W; Canada, 80W
OTHER LUBRICATION POINTSBrake Master Cylinder . . . . . . . . . . . . . . . . . .HBBrake Slack Adjusters & Camshafts . . . . .EP LMChassis Grease Fittings . . . . . . . . . . . . . .EP LMPower SteeringNPR, NQR, 2003-99, Diesel, FRR . . . . . . . . .AF3NPR, NPR HD, 1999, gas . . . . . . . . . . . . . . .AF2NPR, 1998-95 . . . . . . . . . . . . . . . . . . . . . . . .AF2FSR, FTR, FVR, 2003-97 . . . . . . . . . . . . . . . . .PSWater Pump Bearing . . . . . . . . . . . . . . . .EP LMWheel Bearings:
Grease lubricated . . . . . . . . . . . . . GC, GC-LBOil lubricated, 2003-97 . . . .Synthetic 75W-90Oil lubricated, 1996 . . . . . . . . . . . . . . . . .GL-5U.S., 90; Canada, 80W
1 Do not use viscosities other than those listed. May use energy con-serving oils.
2 Not recommended for sustained high-speed operation.
CAPACITYCRANKCASE3 Liters QtFTR Series . . . . . . . . . . . . . . . . . . . . . 13.74 14.54
FVR Series . . . . . . . . . . . . . . . . . . . . . 13.74 14.54
FXR Series . . . . . . . . . . . . . . . . . . . . . 13.74 14.54
4BD1-T . . . . . . . . . . . . . . . . . . . . . . . 8.01 8.51
4BD2-TC . . . . . . . . . . . . . . . . . . . . . . . 11.22 11.82
4HE1-TC . . . . . . . . . . . . . . . . . . . . . . . 13.0 13.66BDT1-NA, -T, 6BG1-NA, 6BG1-TC . . 14.72 15.52
6HE1-TC, 6HK1, 6HK1-TC . . . . . . . . . 14.01 14.81
6SA1-T (8.4L) . . . . . . . . . . . . . . . . . . . 16.0 16.96.0L Vortec . . . . . . . . . . . . . . . . . . . . . 5.42 5.752
5.7L Gasoline . . . . . . . . . . . . . . . . . . . 4.72 5.02
1 Includes main & bypass filters.
INTERNATIONAL (NAVISTAR) Continued • ISUZU
152
MEDIUM & HEAVY TRUCKS
2 Includes oil filter.3 After adding oil, wait 5 minutes before starting engine.4 Approximate. Crankcase capacity may vary due to filter equipment &
other accessories. Make final inspection with dipstick.AUTOMATIC TRANSMISSION1 Liters QtNPR, NPR-HD, NQR Diesel . . . . . . . . 13.5 14.3NPR Gasoline . . . . . . . . . . . . . . . . . . . 12.8 13.6Aisin A450-43LE . . . . . . . . . . . . . . . . . 2 3 2 3Allison MD3550 . . . . . . . . . . . . . . . . . . 24.63 26.03
Allison MD3050 . . . . . . . . . . . . . . . . . . 24.63 26.03
Allison RDS-3000 . . . . . . . . . . . . . . . . 24.63 26.03
Allison 2500 . . . . . . . . . . . . . . . . . . . . 16.63 17.53
AT 542 . . . . . . . . . . . . . . . . . . . . . . . 10.3 11.0AT 545, shallow pan . . . . . . . . . . . . . . 8.5 9.0AT 545, deep pan . . . . . . . . . . . . . . . . 15.0 16.0S1000 . . . . . . . . . . . . . . . . . . . . . . . 7.0 7.41 Oil pan filter change.2 Pan capacity, 5.2 qts Overhaul capacity 14.3 qts3 Approximate. Make final inspection with dipstick.MANUAL TRANSMISSION Liters PtEVR, FSR, FTR, FVR:
5-speed (MBG) . . . . . . . . . . . . . . . . 5.01 10.61
5-speed (MLH) . . . . . . . . . . . . . . . . 9.8 21.06-speed (MLD) . . . . . . . . . . . . . . . . . 6.51 13.71
Fuller 6-speed . . . . . . . . . . . . . . . . . 9.0 19.0Spicer 7-speed . . . . . . . . . . . . . . . . 9.4 21.5NPR, NPR-HD . . . . . . . . . . . . . . . . . 3.2 6.86-speed (SPD) . . . . . . . . . . . . . . . . . 4.4 9.3NQR . . . . . . . . . . . . . . . . . . . . . . . 5.3 11.2
1 With PTO, add 1.4 pints (0.7 liters).DIFFERENTIAL Liters PtDana Spicer:
DS404S . . . . . . . . . . . . . . . . . . . . . . 1 1
19060S . . . . . . . . . . . . . . . . . . . . . . 13.31 28.01
23090S . . . . . . . . . . . . . . . . . . . . . . 18.91 40.01
FRR, 2003-98 . . . . . . . . . . . . . . . . . . . 5.5 12.0NQR, 2003-99 . . . . . . . . . . . . . . . . . . . 9.7 20.5NPR, NPR-HD 2003-96 . . . . . . . . . . . 9.7 20.5EVR, FSR, FTR, FVR 1996-95:
R065 13 1/2” . . . . . . . . . . . . . . . . . . 5.5 12.0R077 14 1/2” . . . . . . . . . . . . . . . . . . 6.5 14.0R095 15 1/2” . . . . . . . . . . . . . . . . . . 9.0 19.0Eaton 23065S . . . . . . . . . . . . . . . . . 15.8 33.5
Eaton/FullerSee Differential Manufacturers Lubricant Recommendations andCapacities at the end of this section.
1 Always use filler hole as a final reference. If lube level is even with bot-tom of filler hole, axle is properly filled. If wheel ends were removed,additional fluid may be required. Fill capacity is approximate and willvary based on the angle at which the axle is installed in the vehicle.Ensure that the vehicle is on a level surface when adding fluid
KENWORTHLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . .CF-4, CG-4, CH-41, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-402
-22° to 86°F (-30° to 30°C), 5W-302
-40° to 104°F (-40° to 40°C), 0W-402
-40° to 86°F (-40° to 30°C), 0W-302
-40° to 50°F (-40° to 10°C), 0W-202
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur content exceeds 1.5%, choose an oil with the high-est TBN in CF-4, CG-4, or CH-4 categories.
Cummins . . . . . . . . . . . . . . . . .CG-4, CH-4, CI-4Above 5°F (-15°C), 15W-40-5° to 68°F (-21° to 20°C), 10W-302
Below 68°F (20°C), 5W-302
Below 32°F (0°C), 0W-302,3
Detroit Diesel 60 Series . . . . . . . .15W-40 CH-47
TRANSMISSION & TRANSFER CASEFor Transmissions not listed see Manufacturers Recommendations at the end of Medium & Heavy Truck Section.
Automatic & Converters:Allison, Fuller, Clark . . . . . . . . . . . . . . .AF2, HFAbove -10°F (-23°C), 10WManual & Transfer Cases:
Eaton-Fuller, Fabco, Spicer, Rockwell, . . . . . . . . . . . . . . . . . . .CF, CF-48,9
Above 10°F (-12°C), 50Above -40°F (-40°C), 50 synthetic10
TRANSFER CASES:Dana 738 . . . . . . . . . . . . . . . . . . . . . . . .50 CF-4Fabco TC-65, TC-110, TC-140,
TC-800 . . . . . . . . . . . . . . . . .CF-4, GL-1, GL-5Above 10°F (-12°C), 50W, 90Below 10°F (-12°C), 30W, 80W
Kenworth TC-8, TC-9, TC-12 . . . . . . .80W GL-5Rockwell T-226, T-228 . . . . . . . . . . . .140W GL-1DIFFERENTIALEaton, Rockwell, Clark, Fabco . . . . . . . . . .GL-5
-15° to 100°F (-26° to 38°C), 80W-90-40° to 100°F (-40° to -38°C), 75W-90 synthetic11
OTHER LUBRICATION POINTSCam Brake Camshaft Splines, Disc Brake Shaft Splines &Slide Pin Retainers,
Brake Clevis Pins . . . . . . . . . . . . . . . . . . . .BL12
Brake Camshaft Bushings . . . . . . . .No.2 EP LMBrake Treadle . . . . . . . . . . . . . . . . . . . . .10W MOCab Tilt Pump . . . . . . . . . . . . . . . . . . . . . . . .CTFChassis Grease Fittings . . . . . . . . . . . . . .EP LM
NLGI No. 2
Clutch Master Cylinder . . . . . . . . . . . . . . . . . .HBClutch Release Bearing . . . . . . . . . . . . . . . .HG13
Driveline Center Bearing 2001-97 . . . . . . . .HG13
1996-95 . . . . . . . . . . . . . . . . . . . . . . . . .EP LMDriveshaft U-Joints . . . . . . . . . . . . . . . . . .EP LMFan Clutch or Hub . . . . . . . . . . . . . . . . . .EP LMPedal Pivots (Mid-Ranger) . . . . . . . . . . . . . .SLSPower Steering:2001-97 . . . . . . . . . . . . . . . . . . . . . . . . . . . . AF2
Cold climate conditions:Above -22°F (-30°C), ATF Type ABelow -22°F (-30°C), ATF Type B
1996:Garrison or Vickers with Ross
Gear . . . . . . . . . . . . . . . . . . . . . . . . .AF2, FARoss Integral . . . . . . . . . . . . . . . . . . . . . . .AF2Sheppard Integral . . . . . . . . . . . . . .10W-30 SFSlack Adjusters (automatic) . . . . . . . . .EP HG14
Including Wedge Brake Components & DiscBrake Caliper
(manual) . . . . . . . . . . . . . . . . . .No.2 EP LMSpeedo & Tach Drive Cables . . . . . . . . . . . .SP
Steering Gearbox . . . . . . . . . . . . . .80W-90 GL-5Wheel Bearings:
Grease lubricated . . . . . . . . . . . . .No.2 EP LMOil lubricated . . . . . . . . . . . . . . .80W-90 GL-5
2001-97 models may use Synthetic 75W-90 GL-5
Winch: Braden . . . . . . . . . . . . . . . . . . .140 GL-2Carco, Tulsa . . . . . . . . . . . . . . . . . . . .140 GL-5
1 Preferred.2 Continuous use of low viscosity oils can lead to increased engine
wear.3 API-III synthetics are recommended where ambient conditions are
consistently below -13°F (-25°C).API-III 0W-30 synthetic may be used where ambient temperaturesnever exceed 32°F (0°C), but higher cylinder wear may be expected.Do not use friction modified oil without evidence of satisfactory per-formance in Cummins engines.
4 Coolant output temperature over 200°F (95°C).5 Replace with 40 as soon as ambient conditions permit.6 Conoco DN-600 synthetic oil or equivalent.7 Note: At ambient temperatures below -4°F (-20°C), when cranking
speed cannot start engine, 5W-30, 5W-40, 10W-30 or 10W-40 may beused provided they have demonstrated field performance in DDCengines.
8 Do not use GL-5.9 Spicer PSO 160-10S & PSO 150-10S transmissions require synthetic
lubricant.10May also use an equivalent synthetic trans. fluid meeting MIL-L-2104D
and Eaton PS-081 specifications.11Meeting MIL-L-2105D & Eaton PS-037 specifications.12Antiseize grease, Meritor/Rockwell spec. 0-637.13Chevron SRI Mobil Grease HP, Texaco Multifax 2, or equivalent.14Texaco Thermotex EP-1, Shell Darina EP-1, Mobilith AW-1,
Meritor/Rockwell 0-616A, or equivalent.
CAPACITYNote: See TRUCK TRANSMISSION and DIFFERENTIAL pages for capac-
ities not shown below.CRANKCASE Liters QtCapacities do not include filters unless noted.DIESEL ENGINESCaterpillar:3126B w/small pan . . . . . . . . . . . . . . . 19.12 21.02
w/large pan . . . . . . . . . . . . . . . . . . . 31.22 33.02
3176 Series . . . . . . . . . . . . . . . . . . . . . 28.5 30.03208 Series . . . . . . . . . . . . . . . . . . . . . 18.9 20.03306 Series . . . . . . . . . . . . . . . . . . . . . 26.5 28.03306 C . . . . . . . . . . . . . . . . . . . . . . . 38.8 41.03406, 3408 Series . . . . . . . . . . . . . . . . 37.9 40.0C-10, C-12:
w/deep pan or center snap . . . . . . . 34.01 36.01
w/shallow pan . . . . . . . . . . . . . . . . . 30.01 32.01
C-15, C-26, 3406E:w/o brake saver . . . . . . . . . . . . . . . . 38.01 40.01
w/brake saver & rear sump pan . . . . 38.01 40.01
w/brake saver & front sump pan . . . 49.01 52.01
Cummins: 6BTA 5.9, ISB (B 5.9L) . . . . . . . . . . . 16.12 17.02
6CTA 8.3 (Mid-Ranger) . . . . . . . . . . 22.43 23.73
ISC (C 8.3L) . . . . . . . . . . . . . . . . . . . 18.92 20.02
ISC (C 8.3L) 2005-98 . . . . . . . . . . . . 19.92 21.02
15L, 15M . . . . . . . . . . . . . . . . . . . . . 22.72 24.02
ISX . . . . . . . . . . . . . . . . . . . . . . . 45.42 48.02
ISM . . . . . . . . . . . . . . . . . . . . . . . 37.03 39.03
L10 . . . . . . . . . . . . . . . . . . . . . . . 34.02 36.02
LTA-240, -270, 300LSC . . . . . . . . . . 26.5 28.0M11 . . . . . . . . . . . . . . . . . . . . . . . 34.12 36.02
N14 . . . . . . . . . . . . . . . . . . . . . . . 36.02 38.02
NTC, NTCC-240, -270, -300,-350, -400 . . . . . . . . . . . . . . . . . . 34.0 36.0
CRANKCASE Liters QtNTC-475 . . . . . . . . . . . . . . . . . . . . . 34.0 36.0KT-450 . . . . . . . . . . . . . . . . . . . . . . . 41.6 44.0KTA-525, -600 . . . . . . . . . . . . . . . . . 41.6 44.0Signature 600 . . . . . . . . . . . . . . . . . 45.43 48.03
VT-300 . . . . . . . . . . . . . . . . . . . . . . . 26.5 28.0Detroit Diesel: 6L-71 Series . . . . . . . . . 18.9 20.0
60 Series 11.1L, 12.7L . . . . . . . . . . . 36.0 38.050, 55, 60 Series . . . . . . . . . . . . . . . 38.83 41.03
1 Capacity including full-flow but not bypass filters.2 Typical crankcase capacity.
Refer to engine Manufacturers manual for exact capacity.3 Includes filter.AUTOMATIC TRANSMISSION Liters QtAllison: AT-540, -545 . . . . . . . . . . . . . . 15.2 16.0
AT-650 . . . . . . . . . . . . . . . . . . . . . . . 14.3 15.0CLBT-754 . . . . . . . . . . . . . . . . . . . . 25.6 27.0CLT-754 . . . . . . . . . . . . . . . . . . . . . . 25.6 27.0HD-4060P, -4560P
w/shallow sump . . . . . . . . . . . . . . 38.0 40.0w/standard sump . . . . . . . . . . . . . 45.0 48.0
HT-740, -750DRD, -754CRD . . . . . . 30.4 32.0MT-653 . . . . . . . . . . . . . . . . . . . . . . 15.2 16.0MT-654CR . . . . . . . . . . . . . . . . . . . . 21.8 23.0
DIFFERENTIALMeritor 11 Always use filler hole as a final reference. If lube level is even with bot-
tom of filler hole, axle is properly filled. If wheel ends were removed,additional fluid may be required. Fill capacity is approximate and willvary based on the angle at which the axle is installed in the vehicle.Ensure that the vehicle is on a level surface when adding fluid.
MACKLUBRICANT GRADECRANKCASECaterpillar 3406C . . . . . . . . . .CF-4, CG-4, CH-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22° to 104°F (-30° to 40°C), 5W-40-22° to 86°F (-30° to 30°C), 5W-30-40° to 86°F (-40° to 30°C), 0W-30-40° to 50°F (-40° to 10°C), 0W-20
Cummins ISC Series . . . . . . . . . . . . . . . .OE/SGAll temperatures, 15W-40
Cummins ISL . . . . . . . . . . . . . . . . . .CG-4, CH-4All temperatures, 15W-40
Cummins ISX . . . . . . . . . . . . . . . . . . . . .CF-4/SGAll temperatures, 15W-40
Cummins 6CTA8.3, L10,M11, N14 . . . . . . . . . . . . . . . . . . . .CF-4, CG-4Above 5°F (-15°C), 15W-40 preferred-5° to 68°F (-21° to 20°C), 10W-301
Below 68°F (20°C), 5W-301
Below 32°F (0°C), 0W-30API-III synthetics are recommended where ambient conditions areconsistently below -13°F (-25°C). API-III 0W-30 synthetic may be usedwhere ambient temperatures never exceed 32°F (0°C), but highercylinder wear may be expected.Do not use friction modified oil without evidence of satisfactory per-formance in Cummins engines.
Cummins N14 Plus Series . . .CG-4, CH-4, CI-4All seasons, 15W-40 preferredWinter conditions, -18° to 68°F (-15° to 20°C),
10W30Arctic conditions, below 68°F (20°C), 5W-30
Do not use special break-in oils, synthetic or semi-synthetic oils dur-ing break in.
Detroit Diesel: 60 Seriesengines . . . . . . . . . . . . . . . . . . . . .15W-40 CI-4
Scania . . . . . . . . . . . . . . . . . . . .CD/SC, CD/SFAbove 50°F (10°C), 3014° to 50°F (-10° to 10°C), 20WBelow 14°F (-10°C), 10W2
Mack . . . . . . . . . . . . . . . . . . . . . . .EO-N PLUSMack 2003 . . . . . . . . . . . . . . . . . . . .EO-N PLUSMack 2002-00 . . . . . . . . . . . . . . . . .EO-M PLUSMack 1999-98 . . . . . . . . . . .EO-M, EO-M PLUS2003
Above 0°F (-18°C), 15W-40, 5W-40 syntheticBelow 0°F (-18°C), 10W-40, 5W-40 synthetic
1998-02Above 0°F (-18°C), 15W-40, 5W-40 syntheticBelow 0°F (-18°C), 10W-30, 5W-40 synthetic
Keep engine warm during layovers.Mack 1997-96 . . . . . . . . . .EO-L or EO-L PLUS
1995 and later, oil must meet Mack EO-L engine MIL specification. Oilmust receive at least 110 merits using Mack T-6 test, and must passMack T-8 test.
1997-96Above 0°F (-18°C), 15W-40Below 0°F (-18°C), 10W-30All temperatures, 5W-40 synthetic
TRANSMISSIONAllison Automatic: 2003-00:
On Highway . . . . . . . . . . . . . . . . . . .AF34, SLFSevere service . . . . . . . . . . . . . . . . . .HF4, SLF
Allison Automatic: 1999-98 . . . . . . . . . . . . .AF34
1997-96 . . . . . . . . . . . . . . . . . . . . . . . . . . .AF24
ISUZU Continued • KENWORTH • MACK
153
MEDIUM & HEAVY TRUCKS
Flywheel Power Take-Off, Mack . . . . . . . . .GL-5All temperatures: Mineral based: 2001-97, 90, 80W-90, 80W-140,
85W-140, 140; 1996,80W-90, 80W-140, 85W-140Synthetic: 75W-90, 75W-140; 80W-140 (2001-97 only)
Fuller CeematAbove 0°F (-18°C), 10W CD or AF3Below 0°F (-18°C), 0W-20 (MIL-L-46167-B)
Fuller Manual . . . . . . . . . . . . . . . .CF-4/SJ, GL-1Above 10°F (-12°C), 40, 50, or 90Below 10°F (-12°C), 30 or 80WAll temperatures, 50 synthetic
Mack 2003-01 . . . . . . . .GO-J Plus, TO-A PLUS2000-96 . . . . . . . . . . . . . . . .GL-5, TO-A PLUSMineral: 90, 140, 80W-90, 80W-140, 85W-140Synthetic: 75W-90, 75W-140, 80W-140TO-A PLUS: A 50W synthetic meeting Mack
specification TO-A Plus.Rockwell . . . . . . . . . . . . . . . . .SG, CD, CE, GL-1
Above 10°F (-12°C), 40, 50, 90Below 10°F (-12°C), 30, 80WAll temperatures, 50 synthetic
Meritor . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-1Above -40°F, synthetic 506
Above 10°F (-12°C), 90Above -15°F (-26°C), 80
Spicer Auxiliary, 1996 . . . . . . . . . . . . . .CF, CF-4Above 0°F (-18°C), 30, 40, 50Below 0°F (-18°C), 30
Fuller Auxiliary, 1996 . . . . . . . . . . . . . . . . .SJ, CFAbove 10°F (-12°C), 40, 50Below 10°F (-12°C), 30
TRANSFER CASEEaton . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-140Above -40°F (-40°C), 75W-140-15° to 100°F (-26° to 38°C), 80W-90-40° to 100°F (-40° to 38°C), 75W-90-40° to -15°F (-40° to -26°C), 75WAll temperatures, Synthetic 75W-90Use 80W-140 for high ambient temperatures, or extra heavy off-high-way loads.
Mack . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Mineral: 90, 140, 80W-90, 80W-140, 85W-140Synthetic: 75W-90, 75W-140, 80W-140
DIFFERENTIALRockwell . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-55
Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-90Above -40°F (-40°C), 75W-90, 75W-140-40° to 35°F (-40° to 2°C), 75WAbove -40°F (-40°C), synthetic 75W-90, 75W-140
Other axles . . . . . . . . . . . . . . . . . . . . . . . . .GL-55
All temperatures: Mineral based: 90, 80W-90, 80W-140, 85W-140, 140Synthetic: 75W-90, 75W-140, 80W-140
OTHER LUBRICATION POINTSAccelerator Hinge Pin . . . . . . . . . . . . . . . . . .MOBrake Treadle Hinge Pin . . . . . . . . . . . . . . . .MOCab Tilt System . . . . . . . . . . . . . . . . . . . . . .CTFChassis Grease Fittings . . . . . . . . . . . . . .EP LMClutch Release Bearing . . . . . . . . . . . . . .EP LMDynamax (oil) Clutch . . . . . . . . . . . . . . . . . . . .AFPower Steering . . . . . .10W-30, 10W-40, SF/CERadiator Shutter Control Bar
and Vane Bearings . . . . . . . . . . . . . . . . . . .MOShift Tower WL, WS . . . . . . . . . . . . . . . . . . .GL-5Slack Adjusters . . . . . . . . . . . . . . . . . . . . .EP LMSpeedometer Adapter . . . . . . . . . . . . . . . . . . . . .3
Spring Trunnion Oil Plug . . . . . . . . . . . . . . .GL-5Steering Gearbox . . . . . . . . . . . . . . . . . . . .GL-5Tachometer Adapter, Mack V-8 . . . . . . . . . . . . .3
Wheel Bearings: Grease lubricated . . . . .EP LMOil lubricated . . . . . . . . . . . . . . . . . . . . . .GL-5Semi-fluid grease lubricated . . . . . . . . . . . .LB
Note: Where GL-5 is specified, use same viscosity and quality as differ-ential.
1 Continuous use of low viscosity oils can lead to increased enginewear.
2 Arctic conditions. Where heating aids are not available during shut-down, use 5W-30 synthetic, and observe note 2.
3 Anderol 766 or equivalent.4 Below -30°F (-34°C),oil must be preheated to above -30°F (-24°C)5 Mack specifies EO-H and EO-H/S oil for all axles in its trucks.6 Meeting Meritor Spec 0-81.
CAPACITYCRANKCASE Liters Qt
Capacities include filters, cooler and piping unless otherwise noted. Allcapacities shown are approximate.
Mack: Series AC, AI, AMI . . . . . . . . . . 38.04 40.04
Series ESI . . . . . . . . . . . . . . . . . . . . . . 32.0 33.5Series ESI-PLUS . . . . . . . . . . . . . . . . . 55.0 58.5E-Tech . . . . . . . . . . . . . . . . . . . . . . . 31.7 33.5E3-210 2005-02 . . . . . . . . . . . . . . . . . 21.0 22.2
E3-210 2005 . . . . . . . . . . . . . . . . . . . . 21.0 22.2E7-728 Series . . . . . . . . . . . . . . . . . . . 32.0 33.53
E9-998 Series . . . . . . . . . . . . . . . . . . . 53.2 56.23
RVI (Renault Vehicules Industriels):06.02.12: 14-liter pan . . . . . . . . . . . . . 16.0 16.9
19-liter pan . . . . . . . . . . . . . . . . . . . 21.0 22.206.02.26 . . . . . . . . . . . . . . . . . . . . . . . 21.0 22.206.02.30 . . . . . . . . . . . . . . . . . . . . . . . 24.0 25.406.20.45 . . . . . . . . . . . . . . . . . . . . . . . 26.0 27.5Caterpillar: 3208 . . . . . . . . . . . . . . . . . 11.4 12.03406C 2000-96 . . . . . . . . . . . . . . . . . . 38.0 40.03406C Others . . . . . . . . . . . . . . . . . . . 34.1 36.0Cummins:6CTA8.3 . . . . . . . . . . . . . . . . . . . . . . . 23.8 25.1ISC-Series . . . . . . . . . . . . . . . . . . . . . . 19.9 20.0ISL-Series . . . . . . . . . . . . . . . . . . . . . . 23.7 25.0ISX-Series . . . . . . . . . . . . . . . . . . . . . . 49.2 52.0ISX Series 2005-03 . . . . . . . . . . . . . . . 45.4 48.0L10 Series . . . . . . . . . . . . . . . . . . . . . . 36.6 38.0230/240, 250/270, 290/300,
350/400 . . . . . . . . . . . . . . . . . . . . . . 41.6 44.0KT 450, 525 . . . . . . . . . . . . . . . . . . . . . 58.7 62.0Detroit Diesel: 60 Series . . . . . . . . . . . 39.02 41.02
Scania: E(D)TZ 4771 . . . . . . . . . . . . . . 17.1 18.0E4-2101 . . . . . . . . . . . . . . . . . . . . . . . 17.1 18.0DS-8 Series . . . . . . . . . . . . . . . . . . . . . 17.1 18.01 Mack designation.2 Approximate. Refer to engine Manufacturers manual for exact capac-
ity.3 Add 1 qt (1L) when equipped with Mack rear engine power take-off.4 Approximate. Crankcase capacity may vary due to filter equipment &
other accessories. Make final inspection with dipstick.Note: Fill filters with new engine oil as much as possible before installa-
tion, to reduce oil pressure lag time at crank up.AUTOMATIC TRANSMISSION Liters QtAllison:Refill Capacities include external circuits.MD 3060/3560P . . . . . . . . . . . . . . . . . 22.0 23.0MT-40, 41, 42 . . . . . . . . . . . . . . . . . . . 17.1 18.0HT-70 . . . . . . . . . . . . . . . . . . . . . . . 33.0 35.0HD 4060/4560B, standard pan . . . . . . 40.0 42.0
shallow pan . . . . . . . . . . . . . . . . . . . 33.0 34.0HD 4060P/4560P/R standard pan . . . . 43.0 45.0
shallow pan . . . . . . . . . . . . . . . . . . . 35.0 37.0MT-640, 643 . . . . . . . . . . . . . . . . . . . . 19.9 21.0MT-644, 654 . . . . . . . . . . . . . . . . . . . . 16.1 17.0MT-650, 653 . . . . . . . . . . . . . . . . . . . . 20.0 21.0HT-740, 750, 754:
With 4 1/2” deep pan . . . . . . . . . . . . 29.0 30.0With 6” or 7” deep pan . . . . . . . . . . 31.0 33.0With 8 1/2” deep pan . . . . . . . . . . . . 35.0 37.5
HT(B)-741, -755:With 4.5” deep pan . . . . . . . . . . . . . 26.2 28.0With 6” or 7” deep pan . . . . . . . . . . 22.6 24.0With 8.5” deep pan . . . . . . . . . . . . . 34.7 37.0
AT-545 . . . . . . . . . . . . . . . . . . . . . . . 20.822.0Fuller Ceemat: RTO-11109AT . . . . . . . 34.0 36.0RTO-12109AT-13109AT, -14109AT . . . 34.0 36.0MANUAL TRANSMISSION Liters PtMack:T308 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T-2050, T20E0A, T2060A . . . . . . . . . . 9.5 20.0T-2060, -2070, -2080, -2090,
-2100 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T2070A, -B, -D . . . . . . . . . . . . . . . . . . 14.2 30.0T2070C, -F . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T2080C . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T2080B, -D . . . . . . . . . . . . . . . . . . . . . 14.2 30.0T2090B, L, R, . . . . . . . . . . . . . . . . . . . 11.4 24.0T2100 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T2110B, C . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T2110B . . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0T2130B, L, L . . . . . . . . . . . . . . . . . . . . 14.2 30.0T2180A, B . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0TR-722(0) . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0TRDL-107(0) . . . . . . . . . . . . . . . . . . . . 10.4 22.0TRDLG-1070 . . . . . . . . . . . . . . . . . . . . 10.4 22.0TRDXL-10780 . . . . . . . . . . . . . . . . . . . 13.2 28.0TRL-1076(0), -1078(0) . . . . . . . . . . . . . 10.4 22.0TRTXL-1070(B) . . . . . . . . . . . . . . . . . . 13.2 28.0TRXL-107(0)(A) . . . . . . . . . . . . . . . . . . 10.4 22.0TRXL-1071(0)(A) . . . . . . . . . . . . . . . . . 10.4 22.0Dynamax (oil) clutch:
Right side mounting . . . . . . . . . . . . 6.2 14.0Left side mounting . . . . . . . . . . . . . . 9.5 20.0
RVI (Renault Vehicules Industriels):BDSL 2152 . . . . . . . . . . . . . . . . . . . . . 11.5 24.0BDSL 2053-2R . . . . . . . . . . . . . . . . . . 16.1 34.0BDSL 2142R . . . . . . . . . . . . . . . . . . . . 16.1 34.0BDSL 181 . . . . . . . . . . . . . . . . . . . . . . 13.0 27.6B5-85 . . . . . . . . . . . . . . . . . . . . . . . 11.5 24.3B5-85P2 . . . . . . . . . . . . . . . . . . . . . . . 11.5 24.3MANUAL TRANSMISSION Liters PtB6-85 . . . . . . . . . . . . . . . . . . . . . . . 13.5 28.5B9-85 . . . . . . . . . . . . . . . . . . . . . . . 16.0 33.84106 (Eaton) . . . . . . . . . . . . . . . . . . . . 6.5 13.7Meritor: MO-13G9B-M13 . . . . . . . . . . 9.7 20.5MO-14G9B-M13 . . . . . . . . . . . . . . . . . 9.7 20.5MO-14G9B-M15 . . . . . . . . . . . . . . . . . 9.7 20.5MO-14G10A-M14 . . . . . . . . . . . . . . . . 9.7 20.5MO-13G10A-M13 . . . . . . . . . . . . . . . . 9.7 20.5M-14G10A-M14 . . . . . . . . . . . . . . . . . 9.7 20.5MO-13G10A-M16 . . . . . . . . . . . . . . . . 9.7 20.5M-13G10A-M15 . . . . . . . . . . . . . . . . . 9.7 20.5
TRANSFER CASE Liters PtMack: TC15(0), 151(0), 152(0),
TC-25, TC-35 . . . . . . . . . . . . . . . . . 9.5 20.0FLYWHEEL POWER TAKE-OFF Liters PtMack . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.0DIFFERENTIAL Liters PtDifferentials listed by Mack code number.Front: FAS-605(1)W . . . . . . . . . . . . . . . . . . . . 16.6 35.0FAS-615(1)W . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-1807 RDH . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-1807 RSA . . . . . . . . . . . . . . . . . . 14.2 30.0RF21-155, -160, -355 . . . . . . . . . . . . . 13.2 28.0Fabco:SDA-16 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0SDA-18, -20, -21, -2100 . . . . . . . . . . . 14.2 30.0SDA-23, -2300 . . . . . . . . . . . . . . . . . . 16.1 34.0RT-40-145 . . . . . . . . . . . . . . . . . . . . . . 14.3 30.2RT-46-160 . . . . . . . . . . . . . . . . . . . . . . 18.6 39.4MT-23 (Marmon-Herrington):
Differential . . . . . . . . . . . . . . . . . . . . 8.0 17.0Wheel hubs, each . . . . . . . . . . . . . . 0.8 1.7
Rear, Mack:23105D, S (Eaton) . . . . . . . . . . . . . . . . 22.6 48.0RA-23 (CRD-95A) . . . . . . . . . . . . . . . . 13.2 28.0
(CRD-201, 203) . . . . . . . . . . . . . . . . 16.3 34.5RAD-23C (RAD-529) . . . . . . . . . . . . . . 15.1 32.0RAD-231C (RAD-530C) . . . . . . . . . . . . 15.1 32.0
With street elbow . . . . . . . . . . . . . . . 23.7 50.0RAD-29C (RAD-707C) . . . . . . . . . . . . . 15.1 32.0RA-30 (CRD-201) . . . . . . . . . . . . . . . . 16.3 34.5RAD-38C (RAD-708C) . . . . . . . . . . . . . 15.1 32.0S30-S (Spicer) . . . . . . . . . . . . . . . . . . . 23.1 48.8S440 . . . . . . . . . . . . . . . . . . . . . . . 35.5 75.0SS58 . . . . . . . . . . . . . . . . . . . . . . . 27.9 59.0S38 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0SB38 . . . . . . . . . . . . . . . . . . . . . . . 32.6 69.0RAS-23C (RAS-512C, -W) . . . . . . . . . 13.2 28.0RS-21-145 . . . . . . . . . . . . . . . . . . . . . 13.7 29.0RS-23-160 . . . . . . . . . . . . . . . . . . . . . 16.6 35.0RS-23-160 2005 . . . . . . . . . . . . . . . . . 19.8 42.0RS-23-161 . . . . . . . . . . . . . . . . . . . . . 17.6 37.2RS-23-180 . . . . . . . . . . . . . . . . . . . . . 20.8 44.0RS-23-186 . . . . . . . . . . . . . . . . . . . . . 18.5 39.0RT-46-160 . . . . . . . . . . . . . . . . . . . . . . 16.3 34.4RT-40-145 . . . . . . . . . . . . . . . . . . . . . . 12.2 25.8DS462P (Dana Spicer) . . . . . . . . . . . . 18.9 40.023105S (Dana Spicer) . . . . . . . . . . . . . 26.5 56.04WD DOUBLE REDUCTION
Quantities listed include interaxle power divider, both bevel gear hous-ings and both axle housings. Oil level is best determined by checkingoil level with respect to fill hole.
S34 & SAL34 CRD(LP)(PC)92(1)/CRD(L)95(1) . . . . . . . . . . . . . . 32.6 69.0CRD(P)202(1)/CRD203(1) . . . . . . . . 33.3 70.5
S(-)(B)38 & SAL38 CRD(LP)(PC)92(1)/CRD(L)95(1) . . . . . . . . . . . . . . 32.6 69.0CRD(P)202(1)/CRD203(1) . . . . . . . . 33.3 70.5
S(-)440 & SAL440CRDPC92(1)/CRD95(1) . . . . . . . . . . 32.6 69.0CRDP202910/CRD203(1) . . . . . . . . 33.3 70.5
S(-)440C CRDPC92(1)CRD95 . . . . . . . 35.5 75.0CRDP202/CRD203 . . . . . . . . . . . . . 35.9 76.0
S(-)441 CRDPC92(1)/CRD95(1) . . . . . . 32.6 69.0CRDP202(1)/CRD203(1) . . . . . . . . . 33.3 70.5
S(-)501 CRDPC112/CRD113 . . . . . . . 32.6 69.0CRDP200/CRD201 . . . . . . . . . . . . . 33.3 70.5
S(-)58 CRDPC112(1)/CRD113(1) . . . . . 32.6 69.0CRDP200/CRD201 . . . . . . . . . . . . . 33.3 70.5
S(-)65 CRD(P)95/CRD96 . . . . . . . . . . . 35.0 74.0SR70 & SR80 P1532/PMA
1532 Housing . . . . . . . . . . . . . . . . . 29.3 62.0Hub reduction ends . . . . . . . . . . . . . 9.0 19.0
S, 34C, W, 38C, W . . . . . . . . . . . . . . . 32.6 69.0S, 342C, W . . . . . . . . . . . . . . . . . . . . . 32.2 68.0S(-)440C CRD(PC)92(1)/CRD9 . . . . . . 35.5 75.0S(-)440C CRDP202/CRD203 . . . . . . . 35.9 76.1S(-)441 CRD(PC)922(1)
CRD95(1) . . . . . . . . . . . . . . . . . . . . . 26.0 55.0S(-)441 CRDP202/CRD203 . . . . . . . . . 26.4 56.0441C, 442C . . . . . . . . . . . . . . . . . . . . . 26.0 56.050C . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.058, C . . . . . . . . . . . . . . . . . . . . . . . 27.9 59.0S(-)65, 65C, W; 80W . . . . . . . . . . . . . . 35.0 74.0S501 CRDPC112(1)/CRD113(1) . . . . . 31.6 67.0S501 CRDP200/CRD201 . . . . . . . . . . 32.0 68.0S58 CRDPC112(1)/CRD113(1) . . . . . . 27.9 59.0S58 CRDP200/CRD201 . . . . . . . . . . . 28.3 60.0SR70, SR80, housing . . . . . . . . . . . . . 34.0 62.0
Hub reduction ends (total) . . . . . . . . 9.0 19.0SAL 34-C, W, D . . . . . . . . . . . . . . . . . . 32.6 69.0SB38-C, SAL 38-C, W, D . . . . . . . . . . 32.6 69.0DIFFERENTIAL Liters PtSS 440C . . . . . . . . . . . . . . . . . . . . . . . 35.5 75.0SW 440C . . . . . . . . . . . . . . . . . . . . . . . 27.9 59.0SWA-, SWC-, SWW-57C, W . . . . . . . . 27.9 59.0SWC-562C, W . . . . . . . . . . . . . . . . . . 27.4 58.0SWP-800 . . . . . . . . . . . . . . . . . . . . . . 56.8 120.0SWP-801 . . . . . . . . . . . . . . . . . . . . . . 56.8 120.0SWS-, SWW-571(1)C . . . . . . . . . . . . . 23.2 49.0SWS-592C . . . . . . . . . . . . . . . . . . . . . 35.0 74.0SWT(L)-56C, W . . . . . . . . . . . . . . . . . . 27.9 59.0SWW-562C, W . . . . . . . . . . . . . . . . . . 27.4 58.0SWW-573(1)C, W . . . . . . . . . . . . . . . . 23.2 49.0
MACK Continued
154
MEDIUM & HEAVY TRUCKS
M070S6 6-speed . . . . . . . . . . . . . . . 8.12 17.22
10 Speed . . . . . . . . . . . . . . . . . . . . . 17.03 35.83
M036S5 . . . . . . . . . . . . . . . . . . . . . . . 3.4 7.6TRANSFER CASE Liters PtFG 2003-98 . . . . . . . . . . . . . . . . . . . . . 3.0 6.4DIFFERENTIAL Liters PtMitsubishi:
R080T . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0F200TW . . . . . . . . . . . . . . . . . . . . . . 3.0 6.4R035T,R033T . . . . . . . . . . . . . . . . . . 4.5 9.6R060T . . . . . . . . . . . . . . . . . . . . . . . 6.5 13.8
FE, FM, 2003-96 . . . . . . . . . . . . . . . . . 4.5 9.6FG Front 2003-98 . . . . . . . . . . . . . . . . 3.0 6.4FH, 2003-96 . . . . . . . . . . . . . . . . . . . . 4.5 9.6FK, FM 2003-02 . . . . . . . . . . . . . . . . . 6.5 13.8FK, 2002-96: . . . . . . . . . . . . . . . . . . . . 4.5 9.4FM,2003-96 . . . . . . . . . . . . . . . . . . . . 6.5 13.81 Includes oil filter.2 For PTO, add 0.5 qt. (0.5 L).3 For PTO, add 1 qt. (1 L).4 For PTO, add 0.2 qt. (0.2 L).5 Use Mobil ATF 3309.
PETERBILTLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . .CF-4, CG-4, CH-41, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-402
-22° to 86°F (-30° to 30°C), 5W-302
-40° to 104°F (-40° to 40°C), 0W-402
-40° to 86°F (-40° to 30°C), 0W-302
-40° to 50°F (-40° to 10°C), 0W-202
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur contentexceeds 1.5%, choose an oil with the highest TBN in CF-4, CG-4, orCH-4 categories.
Cummins . . . . . . . . . . . . . . . .CG-4, CH-41, CI-4Above 5°F (-15°C), 15W-40-5° to 68°F (-21° to 20°C), 10W-302
Below 68°F (20°C), 5W-302
Below 32ºF (0ºC), 0W-302,3
Detroit Diesel 60 Series . . . . . . . . .15W-40 CI-4Detroit Diesel 53, 71, 92
Series engines . . . . . . . . . . . . . . . . . . . . .CF-2Continuous high temperature operation4, 50WAll temperatures, 40-25° to 0°F (-31° to -18°C), 305, 15W-405
TRANSMISSION For Transmissions not listed see Manufacturers Recommendations atthe end of Medium & Heavy Truck section.
Allison . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3For off-highway operation, use 10W or 30 HF.Use 30 above 86°F (30°C).
ZF Economat . . . . . . . . . . . . . . . . . . . . . . . .AF26
TRANSFER CASERockwell . . . . . . . . . . . . . . . . . .80W or 90 GL-1DIFFERENTIAL
See Manufacturer’s Recommendations at the end of the Medium &Heavy Truck section.
OTHER LUBRICATION POINTSBrake Anchor Pins & Cam Bearings . . . . . . .HG7
Brake Treadle Valve . . . . . . . . . . . . . . . .10W MOCab Tilt System . . . . . . . . . . . . . . . . . . . . . .CTFChassis Fittings . . . . . . . . . . . . . . . . . . . .EP LMClutch Release Bearing . . . . . . . . . . . . . . . . .HGDriveshaft . . . . . . . . . . . . . . . . . . . . . . . . .EP LMFan Hub/Water Pump . . . . . . . . . . . . . . . . . . .HG2000-1996 models ex. 330
Front Driving Axle Bearings& U-Joints . . . . . . . . . . . . . . . . . . . . . . .EP LM
Pedal Pivots (Mid-Ranger) . . . . . . . . . . . . . .SLSPower Steering Reservoir . . . . . . . . . . . . . . . .HFSlack Adjusters . . . . . . . . . . . . . . . . . . . . .EP LMSpeedometer & Tachometer
Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SPSteering Gearbox: Model 330 . . . .80W-90 GL-5Wheel Bearings: Grease
lubricated . . . . . . . . . . . . . . . . . . . . . . . .EP LMOil lubricated 2003-96 . . . . . . . .80W-90 GL-5
Some models may use synthetic 75W-90 GL-5
Windshield Wiper MotorDow Corning 200, Sprague Wiper Lube, or equivalent
1 Preferred.2 Continuous use of low viscosity oils can lead to increased engine
wear.3 API-III synthetics are recommended where ambient conditions are
consistently below -13ºF (-25ºC). API-III 0W-30 synthetic may be usedwhere ambient temperatures never exceed 32ºF (0ºC), but highercylinder wear may be expected. Do not use friction modified oil with-out evidence of satisfactory performance in Cummins engines.
4 Coolant outlet temperature over 200°F (95°C).5 Replace with 40 as soon as ambient conditions permit.6 Check current ZF approved fluid list before adding or refilling.7 High Temp. grease, Timken Spec. 0-616.
CAPACITYCRANKCASE Liters QtCapacities include engine-mounted filters.
Caterpillar:3116 . . . . . . . . . . . . . . . . . . . . . . . 19.9 21.03126B:
w/ small pan . . . . . . . . . . . . . . . . . . 19.91 21.01
w/ large pan . . . . . . . . . . . . . . . . . . . 31.21 33.01
3176 . . . . . . . . . . . . . . . . . . . . . . . 23.71 25.01
3306B . . . . . . . . . . . . . . . . . . . . . . . 22.21 23.51
3306C . . . . . . . . . . . . . . . . . . . . . . . 38.8 41.03406B . . . . . . . . . . . . . . . . . . . . . . . 34.1 36.03406E . . . . . . . . . . . . . . . . . . . . . . . 37.8 40.03408 . . . . . . . . . . . . . . . . . . . . . . . 45.4 48.03406T, -TA . . . . . . . . . . . . . . . . . . . . . . 34.1 36.03406TB, -TAB . . . . . . . . . . . . . . . . . . . 41.6 44.0C-7 ACERT . . . . . . . . . . . . . . . . . . . . . 20.84 22.04
C-11 . . . . . . . . . . . . . . . . . . . . . . . 20.84 22.04
C-11 . . . . . . . . . . . . . . . . . . . . . . . 34.03 4 36.03 4
C-11 . . . . . . . . . . . . . . . . . . . . . . . 39.72 4 42.02 4
C-105, C-125:w/deep pan or center sump . . . . . . 34.0 36.0w/shallow pan . . . . . . . . . . . . . . . . . 30.0 32.0
C-15, C-16, 3406E:w/o BrakeSaver . . . . . . . . . . . . . . . . 38.0 40.0w/BrakeSaver & rear sump pan . . . . 38.0 40.0w/BrakeSaver & front sump pan . . . 49.0 52.0
Cummins: Big Cam IV Series . . . . . . . . . . . . . . . . 41.6 44.06BTA 5.9, ISB (B 5.9L) . . . . . . . . . . . . . 16.11 17.01
6CT 8.3 . . . . . . . . . . . . . . . . . . . . . . . 18.91 20.01
ISL ( 8.9L) 2005 . . . . . . . . . . . . . . . . . . 27.41 29.01
ISC (C 8.3L) 2005 . . . . . . . . . . . . . . . . 19.91 21.01
ISC (C 8.3L) . . . . . . . . . . . . . . . . . . . . . 18.91 20.01
ISL . . . . . . . . . . . . . . . . . . . . . . . 27.61 29.21
ISM . . . . . . . . . . . . . . . . . . . . . . . 34.01 36.01
ISX . . . . . . . . . . . . . . . . . . . . . . . 45.41 48.01
KT, KTA Series . . . . . . . . . . . . . . . . . . . 54.9 58.0L10 . . . . . . . . . . . . . . . . . . . . . . . 34.01 36.01
LT10A . . . . . . . . . . . . . . . . . . . . . . . 34.1 36.0M11 . . . . . . . . . . . . . . . . . . . . . . . 34.11 36.01
N14 . . . . . . . . . . . . . . . . . . . . . . . 36.01 38.01
NTC(C) Series . . . . . . . . . . . . . . . . . . . 41.6 44.0Signature Series . . . . . . . . . . . . . . . . . 45.41 48.01
VT Series . . . . . . . . . . . . . . . . . . . . . . . 40.7 43.0335 . . . . . . . . . . . . . . . . . . . . . . . 19.95 21.05
Detroit Diesel: 60 Series . . . . . . . . . . . 36.0 38.08V-71 . . . . . . . . . . . . . . . . . . . . . . . 23.7 25.08V-71N, -NE, -T, -TT, -TAC,
-TTAC, -TA, -TTA . . . . . . . . . . . . . . . 21.8 23.06V-53 . . . . . . . . . . . . . . . . . . . . . . . 15.1 16.06V-92T, -TT, -TAC, -TTAC . . . . . . . . . . 17.0 18.06V-53N, -H . . . . . . . . . . . . . . . . . . . . . 13.2 14.08V-53 . . . . . . . . . . . . . . . . . . . . . . . 20.8 22.08V-92, -N, -T, -TT, -TAC,
-TTAC, -TA, -TTA . . . . . . . . . . . . . . . 21.8 23.0Note: All engines, with optional Peterbilt or
Luberfiner bypass filter, add . . . . . . 13.2 14.01 Typical crankcase capacity. Refer to engine Manufacturers manual for
exact capacity.2 shallow oil sump.3 stand deep oil sump.4 Total capacity will vary due to differences in engine selection, cooler
and chassis type.5 Approximate. Crankcase capacity may vary due to filter equipment &
other accessories. Make final inspection with dipstick.AUTOMATIC TRANSMISSION Liters QtCapacity varies with installation angle and use of filter.
Allison HD-4060P, -4560Pw/ shallow sump . . . . . . . . . . . . . . . 38.0 40.0w/ standard sump . . . . . . . . . . . . . . 45.0 48.0
Allison MD3000R . . . . . . . . . . . . . . . . 24.610 26.010
Allison HT-700 . . . . . . . . . . . . . . . . . . . 28.4 30.0Allison MT-640, -643, -650, -653 . . . . . 16.1 17.0Allison MT-654 . . . . . . . . . . . . . . . . . . 16.1 17.0ZF Economat . . . . . . . . . . . . . . . . . . . 17.0 18.0
MANUAL TRANSMISSIONSee Manufacturers’ Recommendations at the end of the Medium &Heavy ruck Section.
STERLINGLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . . CF-4, CG-4, CH-41, CI-4
5° to 122°F (15º to 50ºC), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-402
SWW-592C, W . . . . . . . . . . . . . . . . . . 35.0 74.0SWW-68(1)C, W . . . . . . . . . . . . . . . . . 26.0 55.0SWW-69W . . . . . . . . . . . . . . . . . . . . . 35.0 74.0SWW-76C, W . . . . . . . . . . . . . . . . . . . 45.9 97.0SWW-762C, W . . . . . . . . . . . . . . . . . . 45.4 96.06WD TRI-AXLE
Quantities listed include interaxle power dividers, bevel gear housings,and all axles.
EW-48C, W . . . . . . . . . . . . . . . . . . . . . 41.6 88.0EW-, ES-60C . . . . . . . . . . . . . . . . . . . . 35.0 74.0EWD-79, -791 . . . . . . . . . . . . . . . . . . . 68.6 145.0EWD-81, -811, -812, -813 . . . . . . . . . . 68.6 145.0
MITSUBISHI-FUSOLUBRICANT GRADECRANKCASEAll engines . . . . . . . . . . . . . . . . . . .CF-4, SJ, SL
Above 86°F (30°C), 40Above 5°F (-15°C), 15W-4023° to 104°F (-5° to 40°C), 305° to 59°F (-15° to 15°C), 20W-20Below 32°F (0°C), 10W-30
TRANSMISSIONAutomatic: FE-FG, 2003-99 . . . . . . . . . . . . .AF3
Allison, 2005-99 . . . . . . . . . . . . . . . . .AF3, HFAllison . . . . . . . . . . . . . . . . . . . . . . . . .AF3, HFAisin M036A6 . . . . . . . . . . . . . . . . . . . . . . . . . .5
Chrysler, JATCO, 1998-96 . . . . . . . . . .AF2, HFUse HF for off-highway operation or where operating temperature isconsistently above 230°F (110°C).
Manual, all . . . . . .CF-4, CF/SJ, SL, GL-3, GL-4General use . . . . . . . . . . . . . . . . . . .80W GL-3Warm region . . . . . . . . . . . . . . . . . . . .90 GL-3Tropical region . . . . . . . . . . . . . . . . . . .90 GL-4High speed service, sustained . . . . . . . .30, 40Do not use EP rated gear oil.
TRANSFER CASEFG . . . . . . . . . . . . . . . . . . . . . . .GL-3, GL-4
General use . . . . . . . . . . . . . . . . . . .80W GL-3Warm region . . . . . . . . . . . . . . . . . . . .90 GL-3Tropical region . . . . . . . . . . . . . . . . . . .90 GL-4
DIFFERENTIAL . . . . . . . . . . . . . . . . . . . . . .GL-5Above 104°F (40°C), 140Below 104°F (40°C), 90For continuous heavy load above 50°F (10°C), 140
DIFFERENTIAL, limited slip . . . . . . . . . . .GL-5★Use P/N 8149630EX
OTHER LUBRICATION POINTSBrake & Clutch Master Cylinders . . . . . . . . . .HBChassis Grease Fittings . . . . . . . . . . . . . . . . .LBDriveshaft Center Bearing . . . . . . . . . . . .EP LMDriveshaft U-Joints & Splines . . . . . . . . . .EP LMKingpins . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .LBPower Steering . . . . . . . . . . . . . . . . . . . . . . .AF2Slack Adjusters: FK, FM . . . . . . . . . . . . . .EP LMWheel Bearings . . . . . . . . . . . . . . . . . . . . .EP LMCAPACITYCRANKCASE Liters QtFE, FG, 2005 . . . . . . . . . . . . . . . . . . . . 10.0 10.6FE, FG, 2003-96 . . . . . . . . . . . . . . . . . 9.01 9.51
FH, 2003-98 . . . . . . . . . . . . . . . . . . . . 10.51 11.11
FH, 1997-96 . . . . . . . . . . . . . . . . . . . . 10.01 10.6FK & FM, 2005 . . . . . . . . . . . . . . . . . . 13.6 14.4FK & FM, 2003-97 . . . . . . . . . . . . . . . . 13.31 14.01
FK & FM, 1996 . . . . . . . . . . . . . . . . . . 13.11 13.81
AUTOMATIC TRANSMISSION Liters QtFE/FG, 2003-99 . . . . . . . . . . . . . . . . . 4.5 4.8FE: JATCO 4-speed 1998-96 . . . . . . . 6.72 7.02
Allison LCT 1000 . . . . . . . . . . . . . . . . . 6 7 6 7Allison LCT 2400 . . . . . . . . . . . . . . . . . 6 8 6 8Aisin M036A6 . . . . . . . . . . . . . . . . . . . 5 6 5 6AT 542 . . . . . . . . . . . . . . . . . . . . . . . 8.5 9.0AT 545 . . . . . . . . . . . . . . . . . . . . . . . 15.0 16.0MD3060 . . . . . . . . . . . . . . . . . . . . . . . 18.0 19.0MD3060 2005 . . . . . . . . . . . . . . . . . . . 6 9 6 9MANUAL TRANSMISSION Liters PtFE, 2003-00 . . . . . . . . . . . . . . . . . . . . 3.74 7.84
FE, 1999-96 . . . . . . . . . . . . . . . . . . . . 3.14 6.64
FG, 2003-98 . . . . . . . . . . . . . . . . . . . . 3.42 7.22
FH211C, 2002-97 . . . . . . . . . . . . . . . . 5.42 11.42
FH, 1996 . . . . . . . . . . . . . . . . . . . . . . . 5.7 12.0FH, 2003-01 . . . . . . . . . . . . . . . . . . . . 6.5 13.8M036S6 . . . . . . . . . . . . . . . . . . . . . . . 4.4 9.2MANUAL TRANSMISSION Liters PtFH, 1996 . . . . . . . . . . . . . . . . . . . . . . . 5.7 12.0FK, FM, 1996: M060S5 . . . . . . . . . . . . 6.0 12.6
M060S6 . . . . . . . . . . . . . . . . . . . . . . 7.3 15.4M070S6 . . . . . . . . . . . . . . . . . . . . . . 8.1 17.2M8S2X5 . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0
FK, FM 2002-01, M060 6-speed . . . . . . . . . 6.72 14.22
M070 6-speed . . . . . . . . . . . . . . . 8.12 17.22
10-speed . . . . . . . . . . . . . . . . . . . 17.03 36.03
FK, FM, 2001-97 5-speed . . . . . . . . . . 5.62 11.82
M060S6 6-speed . . . . . . . . . . . . . . . 6.72 14.22
MACK Continued • MITSUBISHI-FUSO • PETERBILT • STERLING
155
MEDIUM & HEAVY TRUCKS
-22° to 86°F (-30° to 30°C), 5W-302
-40° to 104°F (-40° to 40°C), 0W-402
-40° to 86°F (-40° to 30°C), 0W-302
-40° to 50°F (-40° to 10°C), 0W-202
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur contentexceeds 1.5%, choose an oil with the highest TBN in CF-4, CG-4, orCH-4 categories.
Cummins. . . . . . . . . . . . . . . . .CG-4, CH-41, CI-4Above 5ºF (-15° C), 15W-40 Preferred-5° to 68°F (-21° to 20°C), 10W-302
Below 68°F ( 20°C), 5W-302
Below 32°F (0°C), 0W-302,3
Detroit Diesel: 60 Series . . . . . . . .15W-40 CI-4Mercedes Benz: MBE900 . . . .CG-4, CH-4, CI-4Above 68°F (20°C), 40Above 23°F (-5°C). 20W-40Above 5°F (-15°C), 15W-40 PreferredAbove -4°F (-20°C), 10W-4041° to 77°F (5° to 25°C), 3014° to 59°F (-10° to 15°C), 20W-20-4° to 32°F (-20° to 0°C), 10WBelow 59°F (15°C), 5W-30
All temperatures, 5W-40
TRANSMISSIONFor transmissions not listed see Manufacturers Recommendations atthe end of Medium & Heavy Truck section.
Allison . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AF3DIFFERENTIAL
See Manufacturers Recommendations at the end of the Medium &Heavy Truck section.
OTHER LUBRICATION POINTSAxle Shifter . . . . . . . . . . . . . . .....SAE 10 SJ, SL6
Below 0°F (-18°C), mix w/25% Kerosene.
Brake Camshaft (S-Cam Air Brakes) . . . . . . . . . . . . . . . .EP LM
Brake Slack Adjusters:Gunite:-40° to -20°F (-40° to -29°C), LubriplateAerogrease
Above -20°F (-29°C), Mobil Grease No.77Haldex/Eaton:
20°F (-29°C) and above, .... . . . . . . . . . . . . . .EP LM6
Below -20°F (-29°C), Low Temp., . . . . . . . . . .EP LMMeritor . . . . . . . . . . . . . . . . . . . . . . . . . .EP HG
Use a high temp. water-proof grease. (NLGI grade 1)
Chassis Grease Fittings . . . . . . . . . . . . . .EP LMincluding clutch fittings
Clutch Master Cylinder . . . . . . . . . . . . . . . . . .HBCargo models
Clutch Release Bearing . . . . . . . . . . . . . . . . .HGDoor Hinges & Latches . . . . . . . . . . . . . . . . . MODriveshaft U-Joints & Slip Yokes . . . . . . .EP LMPower Steering Gear Output Shaft . . . . .EP LM4
Power Steering Reservoir: Cargo . . . . . . . . . .MAOthers . . . . . . . . . . . . . . . . . . . . . . . . .*AF3, PS7
* With engine oil installed5, 10W-40 Union, Texaco, Mobil or Chevron;15W-40 Union; 30 Shell Rotella T. Condor Models: With Hydraulic fluidinstalled use Chevron Torque 5 or Exxon Nuto H32. Do not mix lubri-cant types.
1 Preferred2 Continuous use of low-viscosity engine oils can lead to increased
engine wear.3 API-III synthetics are recommended where ambient conditions are
consistently below -13°F (-25°C). API-III OW-30 synthetic may be usedwhere ambient temperatures never exceed 32°F (0°C), but higher cylin-der wear may be expected. Do not use friction-modified oil without evi-dence of satisfactory performance in Cummins engines.
4 DO NOT USE automatic or power grease guns.5 Do not mix motor oil w/ATF6 Sulfated ash content must not exceed 1.85%. May also use AF3 for all
temperatures. Do not mix kerosene or engine oil with ATF.7 Condor may use Fleetrite® PSF or Texaco TL-1833.8 Approximate. Make final inspection with dipstick.
CAPACITYCRANKCASE Liters QtCapacities do not include filters, unless noted.Caterpillar:3126B w/small pan . . . . . . . . . . . . . . . 19.11 21.01
w/large pan . . . . . . . . . . . . . . . . . . . 30.31 32.01
3306C . . . . . . . . . . . . . . . . . . . . . . . 35.0 37.0C-7 ACERT . . . . . . . . . . . . . . . . . . . . . 20.9 22.01
C-9 . . . . . . . . . . . . . . . . . . . . . . . 35.0 37.02
C-11, w/shallow pan . . . . . . . . . . . . . . 34.0 36.0w/deep pan . . . . . . . . . . . . . . . . . . . 39.7 42.0
C-13, w/standard deep oil sump . . . . . 34.0 36.0w/shallow oil sump . . . . . . . . . . . . . 39.7 42.0
C-10, C-12:w/deep pan or center sump . . . . . . 34.02 36.02
w/shallow pan . . . . . . . . . . . . . . . . . 30.02 32.02
C-15, C-16, 3406E:w/o BrakeSaver . . . . . . . . . . . . . . . . 38.02 40.02
w/BrakeSaver & rear sump pan . . . . 38.02 40.02
w/BrakeSaver & front sump pan . . . 49.02 52.02
CFE . . . . . . . . . . . . . . . . . . . . . . . 29.31 31.01
CRANKCASE Liters QtCummins:ISB (B5.9L) 2005 . . . . . . . . . . . . . . . . . 16.4 17.3ISB (B5.9L) . . . . . . . . . . . . . . . . . . . . . 16.1 17.0ISC (C 8.3L) . . . . . . . . . . . . . . . . . . . . . 18.9 20.0ISC (C 8.3L) 2005 . . . . . . . . . . . . . . . . 19.1 21.0ISL (8.9L) . . . . . . . . . . . . . . . . . . . . . . . 27.4 29.0ISL . . . . . . . . . . . . . . . . . . . . . . . 27.6 29.2ISM . . . . . . . . . . . . . . . . . . . . . . . 34.0 36.0ISX . . . . . . . . . . . . . . . . . . . . . . . 41.6 44.0M11 . . . . . . . . . . . . . . . . . . . . . . . 34.1 36.0N14 . . . . . . . . . . . . . . . . . . . . . . . 36.0 38.0Detroit Diesel:60 Series . . . . . . . . . . . . . . . . . . . . . . . 30.0 32.0Mercedes-Benz1:MBE900 series:
4 cyl. (4.3L) incl. filter . . . . . . . . . . . . 15.82 17.02
6 cyl. (6.4L) incl. filter . . . . . . . . . . . . 29.32 31.02
6 cyl. (7.2L) incl. filter . . . . . . . . . . . . 29.32 31.02
6 cyl. (12.8L) incl. filter . . . . . . . . . . . 42.02 44.42
1 Typical crankcase capacity. Refer to engine Manufacturers manual forexact capacity.
2 Capacity includes full-flow but not bypass filters.AUTOMATIC TRANSMISSION Liters QtAllison;AT-542 . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0AT-545: Cargo, Acterra . . . . . . . . . . . . 15.0 16.0
Others . . . . . . . . . . . . . . . . . . . . . . . 18.9 20.0HD Series . . . . . . . . . . . . . . . . . . . . . . 48.2 51.0HT-700 Series . . . . . . . . . . . . . . . . . . . 28.4 30.0MD Series: Cargo, Acterra . . . . . . . . . 16.5 17.5
Others . . . . . . . . . . . . . . . . . . . . . . . 27.4 29.0MT-600 . . . . . . . . . . . . . . . . . . . . . . . 16.1 17.0MT-643, -653 Cargo, Acterra . . . . . . . 14.0 15.0Quantities listed are approximate.
MANUAL TRANSMISSIONSSee Manufacturers Recommendations at end of Medium & HeavyTruck section.
DIFFERENTIALSee Manufacturers Recommendations at end of Medium & HeavyTruck section.
UD/NISSANLUBRICANT GRADECRANKCASEAll engines . . . . . . . . . .CF-4, CG-4, CH-4, CI-4
Above 86°F (30°C), 40W41° to 104°F (4° to 40°C), 30W20° to 104°F (-7° to 40°C), 20W-4020° to 77°F (-7° to 25°C), 20W-2010° to 104°F (-12° to 40°C), 15W-400° to 77°F (-18° to 25°C), 10W-300° to 50°F (-18° to 10°C), 10W
TRANSMISSIONAllison Automatic . . . . . . . . . . . . . . . . . .AF3, HF1
Above 32°F (0°C), 30, 15W-40Above 10°F (-12°C), 10W, 10W-30Above -10°F (-23°C), 5W-20 . . . . . . . . . . . . . . . . . .AF3Below indicated temperatures, preheat oil
MANUAL TRANSMISSIONS1100, 1200, 1300, 1400, 1800CS . . . . . . . .GL-4
Above 50°F (10°C), 14032° to 104°F (0° to 40°C), 9013° to 86°F (-10° to 30°C), 85WBelow 104°F (40°C), 75W-90, 80W-90Below 86°F (30°C), 80WBelow 50°F (10°C), 75W
Other models . . . . . . . . . . . . . . . . . . . . . . . .GL-412° to 122°F (-10° to 50°C), 9012° to 104°F (-10° to 40°C), 85W-90-13° to 104°F (-25° to 40°C), 80W-90Below 95°F (35°C), 80W
DIFFERENTIAL1100, 1200, 1300, 1400, 1800CS . . . . . . . .GL-5
Above 50°F (10°C), 14032° to 104°F (0° to 40°C), 9013° to 86°F (-10° to 30°C), 85WBelow 104°F (40°C), 75W-90, 80W-90Below 86°F (30°C), 80WBelow 50°F (10°C), 75W
Other models . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above 32°F (0°C), 14014° to 104°F (-10° to 40°C), 85W-14013° to 95°F (-10° to 35°C), 90-13° to 95°F (-25° to 35°C), 80W-140-13° to 86°F (-25° to 30°C), 80W-90
OTHER LUBRICATION POINTSBrake & Clutch Master Cylinders . . . . . . . . . .HBChassis Grease Fittings . . . . . . . . . . . . . .EP LM
NLGI No.2 or 3.
Power Steering . . . . . . . . . . . . . . . . . . . . . . .AF2Wheel Bearings . . . . . . . . . . . . . . . . . . . . .EP LM1 For severe duty, or ambient temperatures consistently above 86°F
(30°C), use 30 HF.
CAPACITYCRANKCASE Liters QtIncludes filter unless noted:2003-99: 1200, 1400, 1800CS . . . . . . 10.1 10.6
Others . . . . . . . . . . . . . . . . . . . . . . . 17.0 18.01998-96:
1300, 1400 . . . . . . . . . . . . . . . . . . . 14.3 15.1600-T, 3000HD, 3300 . . . . . . . . . . . 19.0 20.11800, 2000, 2300, 2600,
2800, 3000SD . . . . . . . . . . . . . . . 15.0 15.9AUTOMATIC TRANSMISSION Liters Qt
1100 . . . . . . . . . . . . . . . . . . . . . . . 12.5 13.2With PTO . . . . . . . . . . . . . . . . . . . . . 12.8 13.5
1200, 1400 (2003-01)Air-cooled . . . . . . . . . . . . . . . . . . . . 13.1 13.9Water-cooled . . . . . . . . . . . . . . . . . . 12.9 13.6
1200, 1400 (2000-99)109 inch wheelbase . . . . . . . . . . . . . 13.7 14.5132 inch wheelbase . . . . . . . . . . . . . 13.1 13.9
1300, 1400 (1996-95) . . . . . . . . . . . . . 12.8 13.5With PTO . . . . . . . . . . . . . . . . . . . . . 13.1 13.9
1400 (1998-97) w/o PTO109 inch wheelbase . . . . . . . . . . . . . 12.8 13.5132/150 inch wheelbase . . . . . . . . . 12.0 12.6w/PTO109 inch wheelbase . . . . . . . . . . . . . 13.1 13.9132/150 inch wheelbase . . . . . . . . . 12.3 13.01800, 2000, 2300, 2600, 2800, 3000:Aisin A450-43L . . . . . . . . . . . . . . . .Aisin 45043L: 2001 . . . . . . . . . . . . . 13.5 14.3
2000 & earlier . . . . . . . . . . . . . . . . 17.1 18.1Allison LCT 2400P . . . . . . . . . . . . . . 1, 2 1, 2
Allison AT 542 . . . . . . . . . . . . . . . . . 14.2 15.0Allison AT 545 . . . . . . . . . . . . . . . . . 19.0 20.1
3000, 3300:Allison MT 643, MT653DR . . . . . . . . 17.0 18.0
MANUAL TRANSMISSION Liters Pt1100, 1200, 1300, 1400 . . . . . . . . . . . 3.9 8.22001-99: 1800CS w/o PTO . . . . . . . . . 4.7 10.0
3300 . . . . . . . . . . . . . . . . . . . . . . . 7.0 14.8w/PTO . . . . . . . . . . . . . . . . . . . . . 7.7 16.2
All others ex. 1200, 1400 . . . . . . . . . 6.2 13.0w/PTO . . . . . . . . . . . . . . . . . . . . . 6.7 14.2
1998-96:All ex. 1400 . . . . . . . . . . . . . . . . . . . 6.2 13.0with PTO . . . . . . . . . . . . . . . . . . . . . 6.7 14.2
DIFFERENTIAL Liters Pt2003-1996: 1200, 1400 . . . . . . . . . . . . 6.0 12.8
1800, 2000, 2300 LP . . . . . . . . . . . . 7.0 14.82300, 2300 DH . . . . . . . . . . . . . . . . 9.0 19.02600, 3000, 3300 . . . . . . . . . . . . . . . 13.0 27.5
1 Approximate. Make final inspection with dipstick.2 Pan capacity, 5.2 qts. Overhaul capacity 14.3 qts.
WHITE GMC/VOLVO, VOLVOAUTOCAR, VOLVO TRUCKS-
NORTH AMERICALUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . . .CF-4, CG-4, CH-4, CI-4
5 to 122°F(-15 to 50°C), 15W-40-4 to 104°F(-20 to 40°C), 10W-30-22 to 104°F(-30 to 40°C), 5W-40-22 to 86°F(-30 to 30°C), 5W-30-40 to 86°F(-40 to 30°C), 0W-30-40 to 50°F(-40 to 10°C), 0W-20
Cummins 6CTA8.3, L10 .CF-4, CG-4, CH4, CI-4Above 5°F (-15°C), 15W-40 preferred-5° to 68°F (-21° to 20°C), 10W-30Below 68°F (20°C), 5W-30Below 32°F (0°C), 0W-30API-III synthetics are recommended where ambient conditions areconsistently below -13°F (-25°C).API-III 0W-30 synthetic may be used where ambient temperaturesnever exceed 32°F (0°C), but higher cylinder wear may be expected.Do not use friction modified oil without evidence of satisfactory per-formance in Cummins engines.
Cummins ISM, ISX, M11, N14 . . . . . . . .CF-4, CG-4, CH-4, CI-4
Above 5°F (-15°C), 15W-40-5° to 105°F (-20° to 40°C), 10W-30-20° to 85°F (-30° to 30°C), 5W-30-20° to 105°F (-30° to 40°C), 5W-40Below 50°F (10°C), 0W-20
Cummins N14 Plus Series . . . . . . . . . . .CF-4, CG-4, CH-4, CI-4
All seasons, 15W-40 preferred.Winter conditions, -18° to 68°F (-15° to 20°C), 10W-30Arctic conditions, below 68°F (20°C), 5W-30Do not use special break in oils, synthetic or semi-synthetic oils dur-ing break in.
International . . . . . . . . . . . .CI-4+, CI-4, CI-4/SLDo not use oils labeled as only SL or SJ. Multi-grade oil such as CH-4 and CH-4/SH/SJ are used only when CI-4 Plus, CI-4 and CI-4/SL arenot available.
Detroit Diesel Series 60 . . . . . . . . . . . . . . . .CI-4Above 5°F (-15°C), 15W-40-20° to 70°F (-30° to 20°C), 10W-30Below 70°F (20°C), 5W-30
Note: At ambient temperatures below -4°F (-20°C) when cranking speed
STERLING Continued • UD/NISSAN • WHITE GMC/VOLVO
156
MEDIUM & HEAVY TRUCKS
Power Steering . . . . . . . . . . . . . . . . . . . . . . .AF3Wheel Bearings: Grease lubricated . . . . .EP LM
Oil lubricated:Front, 2003-97
Above -15°F (-25°C), 30, 15W-40 . . . . . . . . . . . .MOAbove -40°F (-40°C), 75W-90 . . . . . . . . . . . . . .GL-5
Front, 1996 . . . . . . . . . . . . . . . . .SAE 90 GL-4Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Use differential lubricant1 Volvo Drain Specification quality.
CAPACITYCRANKCASE Liters QtCaterpillar: Including engine-mounted filter3116 . . . . . . . . . . . . . . . . . . . . . . . 19.9 21.0Cummins:ISM . . . . . . . . . . . . . . . . . . . . . . . 37.0 39.0ISC 8.3L . . . . . . . . . . . . . . . . . . . . . . . 19.9 21.0ISL 8.9L . . . . . . . . . . . . . . . . . . . . . . . 21.0 22.0ISX . . . . . . . . . . . . . . . . . . . . . . . 39.0 41.0M11 . . . . . . . . . . . . . . . . . . . . . . . 37.0 39.0N14 . . . . . . . . . . . . . . . . . . . . . . . 39.0 41.0Detroit Diesel: Series 6011.1L, 12.7L . . . . . . . . . . . . . . . . . . . . 36.0 38.0Volvo Including filters and cooler:2003-02
VE345, VE385, VE425, VE465 . . . . . 35.0 37.0VED12 . . . . . . . . . . . . . . . . . . . . . . . 33.0 34.0
2001-96VED7,VED7C . . . . . . . . . . . . . . . . . . 21.0 22.0VED12,VED12A, VED12B . . . . . . . . 35.0 37.0
AUTOMATIC TRANSMISSION Liters Qt1996: MT643/653 . . . . . . . . . . . . . . . . 17.0 18.0
MT654CR . . . . . . . . . . . . . . . . . . . . 17.0 18.0HT740D . . . . . . . . . . . . . . . . . . . . . . 28.0 30.5HT740RS . . . . . . . . . . . . . . . . . . . . . 41.0 43.5HT750CR . . . . . . . . . . . . . . . . . . . . 29.0 30.5HT754CR . . . . . . . . . . . . . . . . . . . . 29.0 30.5MD3060P, MD3560P . . . . . . . . . . . . 18.0 19.6
MANUAL TRANSMISSION Liters Pt1998-96Volvo3:VT809 . . . . . . . . . . . . . . . . . . . . . . . 9.51 20.01
VT1209 . . . . . . . . . . . . . . . . . . . . . . . 12.02 27.02
VT1214 . . . . . . . . . . . . . . . . . . . . . . . 13.02 28.02
Fuller:2000-97: 9-speed . . . . . . . . . . . . . . . . 12.0 27.0
10-, 13-, 15-, 18-speed . . . . . . . . . . 13.0 28.01996
FS6306 . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0FS7206 . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0RTO-11609A,-B . . . . . . . . . . . . . . . . 12.0 27.0RTO-11708LL . . . . . . . . . . . . . . . . . 13.0 28.0
Meritor/Rockwell:2001-99: 9-, 10, 13-speed . . . . . . . . . 10.0 10.51998-97: 9-, 10-, 13-speed . . . . . . . . . 10.5 11.0Spicer:ES53-5A,-5D . . . . . . . . . . . . . . . . . . . . 11.0 24.0PS140-7A . . . . . . . . . . . . . . . . . . . . . . 23.0 48.0
F7 . . . . . . . . . . . . . . . . . . . . . . . 8.5 18.0FE6, FE7: 5-speed . . . . . . . . . . . . . . 3.5 8.0
6-speed . . . . . . . . . . . . . . . . . . . . 9.5 20.08-speed . . . . . . . . . . . . . . . . . . . . 8.8 18.6
FE42: Volvo 9-speed . . . . . . . . . . . . 10.0 21.2Fuller 6-speed . . . . . . . . . . . . . . . 8.8 18.5Spicer 5-speed: ES 52-5A . . . . . . 8.5 18.0ES 52-5D . . . . . . . . . . . . . . . . . . . 6.2 13.0
N10, N12: 8-speed . . . . . . . . . . . . . 12.41 26.21
9-speed, 14-speed . . . . . . . . . . . 10.01 21.21
16-speed . . . . . . . . . . . . . . . . . . . 14.71 31.01
Volvo VT1209 . . . . . . . . . . . . . . . . . 12.01 27.01
Volvo VT1214 (SR1700) . . . . . . . . . . 13.01 28.01
DIFFERENTIAL Liters Pt1996-95: 21065D, S . . . . . . . . . . . . . . 16.1 34.0
23070D, S . . . . . . . . . . . . . . . . . . . . 18.9 40.023085S/D . . . . . . . . . . . . . . . . . . . . 19.0 40.023105S/D . . . . . . . . . . . . . . . . . . . . 23.0 48.026105S/D . . . . . . . . . . . . . . . . . . . . 23.0 48.0DS402, 402P: Forward . . . . . . . . . . 18.0 39.0
Rear . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DS461P: Forward . . . . . . . . . . . . . . 20.0 43.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0DS521P: Forward . . . . . . . . . . . . . . 20.0 43.0
Rear . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0RS21-145 . . . . . . . . . . . . . . . . . . . . 12.8 27.0RS23-160 . . . . . . . . . . . . . . . . . . . . 18.8 39.0RS23-180 . . . . . . . . . . . . . . . . . . . . 17.0 37.0RS26-180 . . . . . . . . . . . . . . . . . . . . 17.0 37.0RS30-180 . . . . . . . . . . . . . . . . . . . . 17.0 37.0RT40-145, -145P: Forward . . . . . . . 15.0 31.0
Rear . . . . . . . . . . . . . . . . . . . . . . 16.0 35.0RT44-145, -145P: Forward . . . . . . . 14.0 30.0
Rear . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0RT46-160, -160P: Forward . . . . . . . 18.0 39.0
Rear . . . . . . . . . . . . . . . . . . . . . . 18.0 39.0RT46-157: Front . . . . . . . . . . . . . . . 15.0 32.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.0RT48-180: Forward . . . . . . . . . . . . 26.0 54.0
Rear . . . . . . . . . . . . . . . . . . . . . . 17.0 37.0
DIFFERENTIAL Liters PtRT52-180: Forward . . . . . . . . . . . . 25.0 52.0
Rear . . . . . . . . . . . . . . . . . . . . . . 17.0 37.0RT58-180: Forward . . . . . . . . . . . . 24.0 51.0
Rear . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0VBT4012R: Forward . . . . . . . . . . . . 19.0 42.0
Rear . . . . . . . . . . . . . . . . . . . . . . 9.0 19.0VBT4018: Forward . . . . . . . . . . . . . 20.0 42.0
Rear . . . . . . . . . . . . . . . . . . . . . . 9.0 19.0VBT4618: Forward . . . . . . . . . . . . . 20.0 42.0
Rear . . . . . . . . . . . . . . . . . . . . . . 9.0 19.0VR2312, 2314 . . . . . . . . . . . . . . . . . 9.5 20.0
1 Add 1 qt (1 liter) for oil cooler.2 Add 0.5 qt (.47 liter) for oil cooler.
WESTERN STARLUBRICANT GRADECRANKCASECaterpillar . . . . . . . . . .CF-4, CG-4, CH-41, CI-4
5° to 122°F (-15° to 50°C), 15W-40-4° to 104°F (-20° to 40°C), 10W-30-22°F to 104°F (-30° to 40°C), 5W-402
-22° to 86°F (-30° to 30°C), 5W-302
-40° to 104°F (-40° to 40°C), 0W-402
-40° to 86°F (-40° to 30°C), 0W-302
-40° to 50°F (-40° to 10°C), 0W-202
Use Caterpillar DEO oil or equivalent quality. When fuel sulfur contentexceeds 1.5%, choose an oil with the highest TBN in CF-4, CG-4, orCH-4 categories.
Cummins . . . . . . . . . . . . . . . .CG-4, CH-41, CI-4Above 5°F (-5°C), 15W-40-5° to 68°F (-21° to 20°C), 10W-302
Below 68°F (20°C), 5W-302
Below 32°F (0°C) 0W-302,3
Detroit Diesel 60 Series . . . . . . . . .15W-40 CI-4Detroit Diesel 71, 92 Series
engines . . . . . . . . . . . . . . . . . . . . . . . . . . .CF-2Consistent high temperature operation4, 50WAll temperatures, 40-25° to 0°F (-31° to -18°C)5, 30W5, 15W-405
TRANSMISSIONAllison MT, HT Automatic . . . . . . . . . . . .AF3, HF2003-96:
Above 50°F (10°C), 40Above 5°F (-15°C), 15W-4032° to 95°F (0° to 35°C), 30-4° to 59°F (-20° to 15°C), 10W-13° to 77°F (-25° to 25°C), AF3Below 77°F (25°C), 0W-20 Artic Oil
DIFFERENTIALSee Manufacturers Recommendations at the end of Medium & HeavyTrucks section.
OTHER LUBRICATION POINTSBrake Camshafts . . . . . . . . . . . . . . . . . . .EP LMBrake Foot Valve . . . . . . . . . . . . . . . . . .10W MOClutch Release Bearing . . . . . . . . . . . . . . . . .HGChassis Grease Fittings . . . . . . . . . . . . . .EP LMFan Clutch & Hub . . . . . . . . . . . . . . . . . . . . . .HGInteraxle Differential . . . . . . . . . . . . . . . . . . .GL-5
Same viscosity as differential
Lincoln Multi-Luber System . . . .GL-1 or SJ, SLAbove 90°F (32°C), 50Above 70°F (21°C), 14070° to 95°F (21° to 35°C), 4060° to 86°F (16° to 30°C), 3050° to 95°F (10° to 35°C), 9020° to 65°F (-7° to 18°C), 20WBelow 30°F (-1°C), 10W
Power Steering:2003-96 Single steering axle . . . . . . . . . . .AF2
Twin Steering axle . . . . . . . . . . . . . . . .30 SJRear Spring Bushings, Pins
& Slippers . . . . . . . . . . . . . . . . . . . . . . .EP LMSlack Adjusters . . . . . . . . . . . . . . . . . . . . .EP LMSpeedometer & Tachometer
Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GGSpring Seat Bearings
(oil lubricated) . . . . . . . . . . . . . .140, 250 GL-2Steering Column U-Joint & Slip-Joint . . .EP LMThrottle Return Spring . . . . . . . . . . . . . . . . . .PO1996 & later.
Wheel Bearings: Grease lubricated . . . . . . . . . . . . . . . . . . . .GCOil lubricated, front . . . . . . . . . . . . . . .90 GL-5
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Same viscosity as differential1 Preferred.2 Continuous use of low viscosity oils can lead to increased engine wear.3 API-III synthetics are recommended where ambient conditions are
consistently below -13°F (-25°C). API-III 0W-30 synthetic may be usedwhere ambient temperatures never exceed 32°F (0°C), but highercylinder wear may be expected. Do not use friction modified oil with-out evidence of satisfactory performance in Cummins engines.
4 Coolant outlet temperature over 200°F (95°C).5 Replace with 40 as soon as ambient conditions permit.
cannot start engine, 5W-, or 10W-30 or 40 may be used provided theyhave demonstrated field performance in DDC engines.
Mercedes Benz . . . . . . . . . . . . . . . . . . . . . . .CI-4Volvo D7C, D12, 2000 . . . . . . . . .CH-4+, VDS-2
Above 5°F(-15°C), 15W-40Above -5°F(-20°C), 10W-40Above -40°, 5W-40-5 to 85°F(-20 to 30°C), 10W-30All temperatures, 5W-30 Synthetic
Volvo D7C, D12 . . . . .VDS, VDS-2, CF-4, CG-4,CH-4, CH-4+, VDS-2
1999 and earlier Above 5°F(-15°C), 15W-40Above -5°F(-20°C), 10W-40-5 to 85°F(-20 to 30°C), 10W-30All temperatures, 5W-40Above 32° (0°C), 30Above 50°F (10°C), 40For viscosities 5W-40 and 10W-40 use only VDS-2 oil.For viscosity 5W-30 use only completely synthetic and/or VDS or VDS-2 oils.
Volvo engines, others . . . . . .VDS-2, VDS, CF-4, CG-4, CH-41996 All temperatures, 15W-401998-96 Above 10°F (-15°C), 15W-4015° to 85°F (-10° to 30°C), 20W-30-5° to 85°F (-20° to 30°C), 10W-30Below 85°F (30°C), 5W-30 Synthetic
TRANSMISSIONAllison Automatic, all . . . . . . . . . . . . . . . . . . .AF3
Use HF for off-highway operation or where operating temperature isconsistently above 230°F (110°C). HD 4000 Series, HT 700 Series, MD3000 Series, may use SLF.
Manual TransmissionsVolvo 1998-97VT809, VT1309, VT1414 . . . . . . . . . . . . . . . . .CF
Above -5°F (-20°C), 40Use oil cooler above 90°F (32°C)Below 32°F (0°C), 30Use heat exchanger below -15°F (-25°C)
2003-96 Fuller . . . . . . . . . . . . .SJ, SL, CF, GL-1All temperatures SAE 75W, or 50 Synthetic*Above 15°F (-10°C), 50, or 80W-90Above -5°F (-20°C), 40Above -20°F (-30°C), 30* Eaton Road ranger CD50 or equivalent
Meritor/Rockwell9,10, & 13 speed . . . . . . . . . . .SJ, SL, CF, GL-1
All temperatures, Synthetic 50, 40Above 50°F (10°C), 50Above -12°F (-15°C), 30, 80WAll temperatures 40Above 15°F (-10°C), 90See Manufacturers Lubricant Recommendation and Capacities at theend of this section for other models.
1996Spicer
PS0-175-18AAll temperatures, Synthetic 50, 40Above 50°F (10°C), 50Above 15°F (-10°C), 90
Above -12°F (-25°C), 30, 80WSee Transmission Manufacturers Lubricant Recommendations andCapacities at the end of this section for other models.
ES 53-5A, -5D (Spicer) . . . . . . . . .40 CD/CE/CFConventional Series:
VT-1209, -1214 (Volvo) . . . . . . . . . . . . . . .GL-1Xpeditor Series: VT809 (Volvo) . . . . . . . . . .GL-1
RTO-11609A, -11609B,11708LL (Fuller) . . . . . . . .GL-1, GL-4, GL-5
DIFFERENTIAL2003-97
Volvo Tandem CT EV87 . . . . . . . . . . . . . .GL-5All temperatures, 80W-140Above 32°F (0°C), 140WAbove 15°F (10°C), 85W-140Above 85°F (30°C), 90W
1996, all . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-90Above -40°F (-40°C), 75W-90-40° to 35°F (-40° to 2°C), 75WAbove -40°F (-40°C), synthetics: 75W-90,
75W-140Rockwell only
OTHER LUBRICATION POINTSBrake Cams (air brakes) . . . . . . . . . . . . . . . . .LMBrake Master Cylinders . . . . . . . . . . . . . . . . .HBBrake Pedal Shaft (N10, N12) . . . . . . . . . .30 MOChassis Grease Fittings . . . . . . . . . . . . . .EP LMClutch Hydraulic System . . . . . . . . . . . . . .DOT4Clutch Release Bearing . . . . . . . . . . . . . . . . .HGClutch Release Shaft . . . . . . . . . . . . . . . . . . .LMDrive Shaft Pillow Block . . . . . . . . . . . . . . . . .LM
WHITE GMC/VOLVO Continued • WESTERN STAR
157
MEDIUM & HEAVY TRUCKSWESTERN STAR Continued
CAPACITYCRANKCASE Liters QtCaterpillar:3126B: w/small pan . . . . . . . . . . . . . . 19.11 21.01
w/large pan . . . . . . . . . . . . . . . . . . . 31.21 33.01
3176 . . . . . . . . . . . . . . . . . . . . . . . 24.61 26.01
CRANKCASE Liters Qt3208 . . . . . . . . . . . . . . . . . . . . . . . 16.0 17.0
3306 . . . . . . . . . . . . . . . . . . . . . . . 21.0 22.03406 . . . . . . . . . . . . . . . . . . . . . . . 34.0 36.0With brake saver . . . . . . . . . . . . . . . 42.0 44.0
C-10, C-12:w/deep pan or center sump . . . . . . 34.02 36.02
w/shallow pan . . . . . . . . . . . . . . . . . 30.02 32.02
C-15, C-16, 3406E:w/o BrakeSaver . . . . . . . . . . . . . . . . 38.02 40.02
w/BrakeSaver & rear sump pan . . . . 38.02 40.02
w/BrakeSaver & front sump pan . . . 49.02 52.02
CRANKCASE Liters QtCummins: 6CTA 8.3 . . . . . . . . . . . . . . 18.7 19.8
C-Series . . . . . . . . . . . . . . . . . . . . . 22.4 23.7Big Cam Series . . . . . . . . . . . . . . . . 26.0 28.0L10, M11 . . . . . . . . . . . . . . . . . . . . . 34.01 36.01
N14 . . . . . . . . . . . . . . . . . . . . . . . 36.01 38.01
KT Series . . . . . . . . . . . . . . . . . . . . . 38.0 40.0VT-225 . . . . . . . . . . . . . . . . . . . . . . . 19.0 20.0Form 300, NTC 400 . . . . . . . . . . . . . 35.4 37.4
Detroit Diesel: 6-71N . . . . . . . . . . . . . . 21.0 22.06V-92 . . . . . . . . . . . . . . . . . . . . . . . 19.0 20.08V-71 . . . . . . . . . . . . . . . . . . . . . . . 22.0 23.08V-92 . . . . . . . . . . . . . . . . . . . . . . . 22.0 23.060-Series . . . . . . . . . . . . . . . . . . . . . 36.0 38.0
1 Typical crankcase capacity. Refer to engine Manufacturers manual forexact capacity.
2 Capacity includes full-flow but not bypass filters.
AUTOMATIC TRANSMISSION Liters QtHT-740D . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0HT-750CR . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0HT-750DR . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0MT-643 . . . . . . . . . . . . . . . . . . . . . . . 15.1 16.0MT-644 . . . . . . . . . . . . . . . . . . . . . . . 14.2 15.0MT-653 . . . . . . . . . . . . . . . . . . . . . . . 15.1 16.0MT-654 . . . . . . . . . . . . . . . . . . . . . . . 16.1 17.0 MANUAL TRANSMISSION & DIFFERENTIAL
See Manufacturers Recommendations at the end of Medium & HeavyTrucks section.
158
MEDIUM & HEAVY TRUCKS
TRANSMISSION MANUFACTURERS LUBRICANT RECOMMENDATIONS AND CAPACITIESThe estimated capacities and lubricant recommendations given below are those of the unit manufacturer and may not agree with those of the truck manufacturer.
Capacities may not agree with those of the truck manufacturer due to variations in individual installations.
AUTOMATIC/AUTOMATED MANUAL Liters PtSuper 10 Top 2 automated manualsRTL-11710-T2 . . . . . . . . . . . . . . . . . . . 13.0 28.0TRLO-11610-16619-T2 . . . . . . . . . . . 14.6 31.0Super 13 Top 2 automated manualsRTLO-14/16713-T2 . . . . . . . . . . . . . . . 13.0 27.0RTLO-18913-T2 . . . . . . . . . . . . . . . . . 13.0 18.0Super 18 Top 2 automated manualsRTLO-14/16718-T2 . . . . . . . . . . . . . . . 13.0 27.0RTLO-18918-T2 . . . . . . . . . . . . . . . . . 13.0 28.0CEEMAT automated manuals11/13/14109-AT . . . . . . . . . . . . . . . . . 41.6 88.011/13/14/16100-ATE . . . . . . . . . . . . . . 42.1 89.0AutoSelect automated manualsRTAO-10/12/14/16710-AC . . . . . . . . . 12.0 26.0AutoShift automated manualsRTAO-10/12/14/16710-AS . . . . . . . . . 12.0 16.0AUXILIARY TRANSMISSIONS Liters PtAT-1202 . . . . . . . . . . . . . . . . . . . . . . 5.0 11.02-A-92 . . . . . . . . . . . . . . . . . . . . . . 6.012.0MID-RANGE TRANSMISSIONSFS-4005 . . . . . . . . . . . . . . . . . . . . . . 4.6 9.5FS-4006 . . . . . . . . . . . . . . . . . . . . . . 4.6 9.5FS-4205 . . . . . . . . . . . . . . . . . . . . . . 6.5 12.5FS-4205A . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5FS-4205A 2005 . . . . . . . . . . . . . . . . . . 5.21 11.01
FS-5005 . . . . . . . . . . . . . . . . . . . . . . 4.9 10.5FS-5006 . . . . . . . . . . . . . . . . . . . . . . 5.0 10.5FS-5105A . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5FS-5205 . . . . . . . . . . . . . . . . . . . . . . 5.0 10.5FS-5205A . . . . . . . . . . . . . . . . . . . . . . 2.51 5.31
FS-5306A . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5FS-5406 . . . . . . . . . . . . . . . . . . . . . . . 9.21 19.51
FS-5406A . . . . . . . . . . . . . . . . . . . . . . 5.71 12.01
FS-6406A . . . . . . . . . . . . . . . . . . . . . . 5.71 12.01
FS-6105/6005 . . . . . . . . . . . . . . . . . . . 9.0 19.0FS-6205/6305 . . . . . . . . . . . . . . . . . . . 9.0 19.0FS-6206/6206A . . . . . . . . . . . . . . . . . . 8.5 18.0FS-1506 . . . . . . . . . . . . . . . . . . . . . . 9.0 18.0FS-5306 . . . . . . . . . . . . . . . . . . . . . . 9.0 18.0FS-6106 . . . . . . . . . . . . . . . . . . . . . . 9.0 19.0FS-6206 . . . . . . . . . . . . . . . . . . . . . . 9.0 18.0FS6306 . . . . . . . . . . . . . . . . . . . . . . 9.0 18.0FS6305A,B . . . . . . . . . . . . . . . . . . . . . 9.0 19.0FS-7206 . . . . . . . . . . . . . . . . . . . . . . . 10.0 20.0FS-8206 . . . . . . . . . . . . . . . . . . . . . . 9.5 20.0FS-8209 . . . . . . . . . . . . . . . . . . . . . . . 8.5 18.0TWIN COUNTERSHAFT MODELS Liters Pt5 Speeds: 905 . . . . . . . . . . . . . . . . . . . 10.0 22.011605 . . . . . . . . . . . . . . . . . . . . . . . 10.0 22.06 Speeds: 955AL . . . . . . . . . . . . . . . . . 12.0 25.0906 . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.01065AA . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.011606 . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.07 Speeds: 95ALL . . . . . . . . . . . . . . . . . 13.0 28.08/11/14607 . . . . . . . . . . . . . . . . . . . . . 17.0 36.08 Speeds: 1157DL . . . . . . . . . . . . . . . 13.0 27.011607L . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.09508 . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.011608 . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.014608 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.014908 . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.016908 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.09 Speeds: 909, 9509 . . . . . . . . . . . . . . 12.0 25.011509/1209 . . . . . . . . . . . . . . . . . . . . . 12.0 25.01157DLL . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.06609 . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.08609 . . . . . . . . . . . . . . . . . . . . . . . 7.0 15.08709 . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.08608L . . . . . . . . . . . . . . . . . . . . . . . 13.0 27.011607LL . . . . . . . . . . . . . . . . . . . . . . . 15.0 31.011707LL/11707DLL . . . . . . . . . . . . . . 13.0 28.013707DLL/13707MLL . . . . . . . . . . . . . 13.0 28.011609-14609 . . . . . . . . . . . . . . . . . . . 13.0 27.011709-16709 . . . . . . . . . . . . . . . . . . . 13.0 27.014909 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.010 Speeds: 9/1258LL . . . . . . . . . . . . . 13.0 28.07608LL . . . . . . . . . . . . . . . . . . . . . . 9.0 19.511/14608LL . . . . . . . . . . . . . . . . . . . . . 14.0 29.011708LL . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.014708LL . . . . . . . . . . . . . . . . . . . . . . . 14.0 29.08/11/14/16908LL . . . . . . . . . . . . . . . . 13.0 28.012510 . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.0610 . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.06610 . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.0910 . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.01110 . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.011610-14610 . . . . . . . . . . . . . . . . . . . 12.0 26.0RTLO-11610-16610 . . . . . . . . . . . . . . 13.0 28.09710 . . . . . . . . . . . . . . . . . . . . . . . 12.0 26.0RTL-11710-14710 . . . . . . . . . . . . . . . . 13.0 28.011710-16710 . . . . . . . . . . . . . . . . . . . 12.0 26.011210-16210 . . . . . . . . . . . . . . . . . . . 11.0 23.511 Speeds: 11/14709MLL . . . . . . . . . . 13.0 28.011/14909MLL . . . . . . . . . . . . . . . . . . . 13.0 28.013 Speeds: 613/6613 . . . . . . . . . . . . . 8.0 16.0913, 9513 . . . . . . . . . . . . . . . . . . . . . . 13.0 27.012513 . . . . . . . . . . . . . . . . . . . . . . . 13.0 27.0
TWIN COUNTERSHAFT MODELS Liters Pt11613-15613 . . . . . . . . . . . . . . . . . . . 14.0 29.011813-15613 . . . . . . . . . . . . . . . . . . . 14.0 29.0RTLO-14613 . . . . . . . . . . . . . . . . . . . . 13.0 28.0RTLO-12/14/16713 . . . . . . . . . . . . . . . 13.0 28.0RTLO-14/18913 . . . . . . . . . . . . . . . . . 13.0 28.015 Speeds: 915 . . . . . . . . . . . . . . . . . . 13.0 28.012515 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.011615 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.014/15615 . . . . . . . . . . . . . . . . . . . . . . . 14.0 30.011/14/15715 . . . . . . . . . . . . . . . . . . . . 13.0 28.014/16915 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.018 Speeds: 15618 . . . . . . . . . . . . . . . . 13.0 28.0RTLO-14/16618 . . . . . . . . . . . . . . . . . 13.0 28.0RTLO-14/16/18718 . . . . . . . . . . . . . . . 13.0 28.0RTLO-20918 . . . . . . . . . . . . . . . . . . . . 13.0 28.0OTHER MODELS:T-8607AIB . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0TA-4510 . . . . . . . . . . . . . . . . . . . . . . . 11.8 25.0RT-RTX-13710B . . . . . . . . . . . . . . . . . 12.1 25.5T-14607A, -14607B . . . . . . . . . . . . . . . 13.8 29.0T/TX14607 Series . . . . . . . . . . . . . . . . 17.0 36.0FRO-13210C . . . . . . . . . . . . . . . . . . . . 11.11 23.51
RT-, RTF-, RTO-14613 . . . . . . . . . . . . 13.7 29.0RT-, TRX-14710B . . . . . . . . . . . . . . . . 12.1 25.5RTX-, TRXF-14710C . . . . . . . . . . . . . . 12.8 27.0RT-, TROF-14813 . . . . . . . . . . . . . . . . 13.7 29.0FR-13210B . . . . . . . . . . . . . . . . . . . . . 11.11 23.51
RT-16716 series . . . . . . . . . . . . . . . . . 13.0 28.01 Fill transmission until fluid is even with bottom of fill hole.
ZF MERITOR/ROCKWELLTransmissions2 . . . . . . . . . . .CF, CF-4, SJ1, GL-1Transfer Cases2 . . . . . . .CF, CF-4, SJ, SL1, GL-1Above 10 F (-12 C), gear oil 90Above 10 F (-12 C), heavy duty motor oil, 40, 50Above -12 F (-26 C), heavy duty motor oil, 30Above -15 F (-26 C), gear oil 80WAbove -40 F (-40 C), full synthetic oil3,4
1 Current designations are acceptable.2 Do not use GL-5 or SP GL-5 gear oil.3 Synthetic oil meeting ZF Mertor specification O-81.4 Use synthetic oil only if transfer case was initially filled with synthetic oil.
Transmission, change lubricant:Petroleum lubricant, every 50,000 miles (80,000 km);Synthetic lubricant,
1998 and later, every 500,000 miles (800,000 km)1997 and earlier, every 250,000 miles (400,000 km).
Transfer case, change lubricant:On-highway, first 2,500 miles (4000 km), then every 12,000-25,000 miles
(19,000-40,000 km)Off-highway, first 40-100 hours, then every 200-300 hours.Synthetic oilOn-highway, every 25,000 miles (40,000 km) or twice a year.Off-highway, every 3000 hours or twice a year.Severe serviceOn-highway, every 10,000 miles (16,000 km) or 3 times a year.Off-highway, 3 time a year
CAPACITIESTRANSFER CASES
Capacities are for reference only. Fill to top of stand pipe or fill hole.Drive vehicle 1/4 mile (.4km). Top off level. Ensure sump temperaturedoes not exceed 225 F (107 C)
Liters PtT-32 . . . . . . . . . . . . . . . . . . . . . . . 0.9 2.0T-50 . . . . . . . . . . . . . . . . . . . . . . . 4.5 8.0T-59 . . . . . . . . . . . . . . . . . . . . . . . 1.0 2.0T-70, T-73 . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0T-76 . . . . . . . . . . . . . . . . . . . . . . . 1.9 4.0T-77 . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.0T-79 . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.0T-96 . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.0T-98 . . . . . . . . . . . . . . . . . . . . . . . 21.6 46.0T-99 . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.5T-136, T-138 . . . . . . . . . . . . . . . . . . . . 6.6 14.0T-152 . . . . . . . . . . . . . . . . . . . . . . . 2.4 5.0T-154 . . . . . . . . . . . . . . . . . . . . . . . 4.5 8.5T-167 . . . . . . . . . . . . . . . . . . . . . . . 4.7 10.0T-179 . . . . . . . . . . . . . . . . . . . . . . . 0.7 1.5T-180, T-212 . . . . . . . . . . . . . . . . . . . . 1.0 2.0T-215 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0T-221 . . . . . . . . . . . . . . . . . . . . . . . 1.8 4.0T-223 . . . . . . . . . . . . . . . . . . . . . . . 2.3 5.0T-226 . . . . . . . . . . . . . . . . . . . . . . . 3.0 6.5T-228 . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0T-232 . . . . . . . . . . . . . . . . . . . . . . . 2.9 6.2T-236 . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0T-282 . . . . . . . . . . . . . . . . . . . . . . . 9.0 19.0T-600 . . . . . . . . . . . . . . . . . . . . . . . 2.9 6.2T-2111 . . . . . . . . . . . . . . . . . . . . . . . 1.4 3.0T-2111-HD, T-2111-HT . . . . . . . . . . . . 2.3 5.0T-2111-PD . . . . . . . . . . . . . . . . . . . . . . 4.7 10.0T-2111-SD . . . . . . . . . . . . . . . . . . . . . . 2.3 5.0T-2119 . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.0T-2120 . . . . . . . . . . . . . . . . . . . . . . . 1.8 4.0T-2120-RS . . . . . . . . . . . . . . . . . . . . . . 3.1 6.5TG-2213 . . . . . . . . . . . . . . . . . . . . . . . 3.1 6.5MTC-4208, MTC-4210, MTC-4213 . . . 4.3 9.0
ALLISON1000/2000/2400 . . . . . . . . . . . . . . . . . .AF3, SLF2000MH . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SLF3000MH/4000MH . . . . . . . . . . . . . . . . .AF3, SLFAT545 . . . . . . . . . . . . . . . . . . . . . .AF3, HF, SLFB300/B400/B500 . . . . . . . . . . . . . . . . .AF3, SLFDP8000 . . . . . . . . . . . . . . . . . . . . . . .15W-40 HFEVS . . . . . . . . . . . . . . . . . . . . . . . . .AF3, SLFHD4060,HD4560 (P)(R) . . . . . . . . . . . . .AF3, SLFM5610, M6610, M9600 . . . . . . . . . . .15W-40 HFMD3060/MD3066/MD3560 . . . . . .AF3, HF, SLFMT643/MT647/MT648 . . . . . . . . . .AF3, HF, SLFMTB643/MTB647 . . . . . . . . . . . . . .AF3, HF, SLF
When both AF3 and/or SLF and HF are specified, use HF for seversservice.
CAPACITIES Liters QT1000/2000/2400 Series initial fill
Deep pan . . . . . . . . . . . . . . . . . . . . . 14.0 15.0Shallow pan . . . . . . . . . . . . . . . . . . . 12.0 13.0
2000MH initial fill . . . . . . . . . . . . . . . . 14.0 15.03000/3500EVS
Deep sump . . . . . . . . . . . . . . . . . . . 27.0 29.0Shallow sump . . . . . . . . . . . . . . . . 25.0 26.0
3000MH initial fillDeep sump . . . . . . . . . . . . . . . . . . . 27.0 29.0Shallow sump . . . . . . . . . . . . . . . . . 25.0 26.0
4000/4500EVS Deep sump w/PTO . . . . . . . . . . . . . 48.0 51.0Deep sump w/o PTO . . . . . . . . . . . . 45.0 48.0Shallow sump w/PTO . . . . . . . . . . . 41.0 43.0Shallow sump w/o PTO . . . . . . . . . . 38.0 40.0
4000MH Deep sump w/PTO . . . . . . . . . . . . . 48.0 51.0Deep sump w/o PTO . . . . . . . . . . . . 45.0 48.0Shallow sump w/PTO . . . . . . . . . . . 41.0 43.0Shallow sump w/o PTO . . . . . . . . . . 38.0 40.0
AT545(R)Deep pan . . . . . . . . . . . . . . . . . . . . . 18.9 20.0Shallow pan . . . . . . . . . . . . . . . . . . . 14.2 15.0
B300/B400(P)(R)Deep pan . . . . . . . . . . . . . . . . . . . . . 27.0 29.0Shallow pan . . . . . . . . . . . . . . . . . . . 25.0 26.0
B500(P)(R) SeriesDeep pan w/PTO . . . . . . . . . . . . . . . 48.0 51.0Deep pan w/o PTO . . . . . . . . . . . . . 45.0 48.0Shallow pan w/PTO . . . . . . . . . . . . . 41.0 43.0Shallow pan w/o PTO . . . . . . . . . . . 38.0 40.0
DP8000 . . . . . . . . . . . . . . . . . . . . . . . 79.0 84.0HD4060/HD4560(P)(R)
Deep sump w/PTO . . . . . . . . . . . . . 48.0 51.0Deep sump w/o PTO . . . . . . . . . . . . 45.0 51.0Shallow sump w/PTO . . . . . . . . . . . 41.0 43.0Shallow sump w/o PTO . . . . . . . . . . 38.0 40.0
HT740/HT747/HT750/HT754 initial fill4.5-inch pan . . . . . . . . . . . . . . . . . . 32.2 34.06 & 7-inch pans . . . . . . . . . . . . . . . . 28.4 30.08.5-inch pan . . . . . . . . . . . . . . . . . . 40.7 43.0
M5610/M6610 . . . . . . . . . . . . . . . . . . 68.0 52.0M9600 . . . . . . . . . . . . . . . . . . . . . . . 79.0 84.0MD3060/MD3066/MD3560(P)(R)
Deep sump . . . . . . . . . . . . . . . . . . . 27.0 29.0Shallow sump . . . . . . . . . . . . . . . . . 25.0 26.0
MT (except MT643)4.5-inch pan . . . . . . . . . . . . . . . . . . 11.0 12.05.1-inch pans . . . . . . . . . . . . . . . . . 14.0 15.07.0-inch pan . . . . . . . . . . . . . . . . . . 16.0 17.0
MT643(DR)(R)Deep pan . . . . . . . . . . . . . . . . . . . . . 14.0 15.0Shallow pan . . . . . . . . . . . . . . . . . . . 11.0 12.0
MTB643 . . . . . . . . . . . . . . . . . . . . . . . 16.0 17.0MT647/MTB647/MT648 . . . . . . . . . . . 15.1 16.0
FULLER, CLARK/FULLER,EATON/FULLER
All transmissions . . . . . . . . . .Cat TO-41,2, MT-11,3
EatonRoadranger . . . . . . . . . . . . . . . . . . .CD-504
Above 10°F (-12°C), 40, 50, 80W-90 Below 10°F (-12°C), 30, 75WCEEMAT® . . . . . . . . . . . . . . . . . . . . . . . .HF, AF3
Above 0°F (-18°C), 10W, HF, AF3Below 0°F (-18°C), 0W-20 Arctic Oil
Never mix engine oil with gear oil.1 General service.2 Or heavy duty engine oil meeting MIL-L-2104D.3 MT-1 meeting MIL-PRF-2105E.4 Eaton-approved lubricant.Change Intervals
Change general service lubricant every; on highway, 60,000 miles(37,200 km); severe on highway, 500 hours; off highway, 1000 hours. Change Eaton-approved lubricant every: on highway, 250,000 miles(155,000km), severe on highway, 1000 hours, off highway, 2000 hours.
Note: Transmission factory-filled with Eaton-approved lubricant mayoperate 500,000 miles (310,000km) before change.
159
MEDIUM & HEAVY TRUCKSTRANSMISSION MANUFACTURERS LUBRICANT RECOMMENDATIONS AND CAPACITIES Continued
MANUAL Liters PtRS10-135A, RS10-145A,
RS10-155A . . . . . . . . . . . . . . . . . . . 9.7 20.5RSX10-115A, RSX10-125A . . . . . . . . . 9.4 20.5RSX10-135A, RSX10-145A . . . . . . . . . 9.7 20.5RSX10-135C, RSX10-145C . . . . . . . . 9.7 20.5RSX10-155A, RSX10-165A . . . . . . . . . 9.7 20.5RSX10-155C, RSX10-165C . . . . . . . . 9.7 20.5RSO13-145A . . . . . . . . . . . . . . . . . . . . 9.7 20.5S-14F10A-M16 . . . . . . . . . . . . . . . . . . 9.7 20.5S6-650 . . . . . . . . . . . . . . . . . . . . . . . 6.0 12.7SO-14F10A-M16, S0-14F10C-M16 . . 9.7 20.5SO-16F10C-M18 . . . . . . . . . . . . . . . . 9.7 20.5
TRANSMISSION TECHNOLOGIES(DANA/SPICER)
Transmissions2003-00
Non-Synchronized .CF, CF-4, SJ, SL, TO-4, GL-12
All temperatureSynthetic transmission oil 50
Above 0 F (-18 C)HD engine oil 50Gear oil 80W-90
Below 0 F (-18 C) HD engine oil 30Gear oil 75W
Synchronized .CF, CF-4, SJ, SL, TO-4, Gl-1, GL-22
All temperatureSynthetic transmission oil 30, 50Gear oil 80W
Above 0 F (-18 C) 30, 50Below 0 F (-18 C) 30
1999-96Non-Synchronized . .CD, CE. SF, TO-4, MT-1Synchronized . . . .CF, CF-4, SJ, SL, SG, TO-4, Gl-1EP not recommended for operating temperature above 230 F(110 C).All temperature,
SynchronizedHD engine oil 30, 40Gear oil 80W
Non-synchronizedHD engine oil 50Synthetic gear oil, 75W-90
Above 0 F (-18 C)Synchronized 30, 40Non-synchronized
HD engine oil 50Gear oil, 80W-90
Below 0 F (-18 C)Synchronized 30Non-synchronized
HD engine oil 30Gear oil, 75W
1 Synthetic CD50 required for tractors w/Aerodynamic package unlessoil cooler is specified.
2 Synthetic transmission oil meeting Spicer MS-961-T specifications.
Transmission, change lubricant:2003-00
Petroleum lubricant, every 100,000 miles (160,900 km) or annuallySemi-synthetic, every 250,000 miles (400,000 km) or every two yearsSynthetic, every 500,000 miles (800,000 km) or every five years
1999-96Petroleum lubricant, every 100,000 miles (160,900 km) or annuallySemi-synthetic, every 250,000 miles (400,000 km) or every two yearsSynthetic, every 250,000 miles (400,000 km) or every three years
CAPACITIESTRANSMISSIONS
Capacities are approximate. Exact amount depends on angle of instal-lation. Fill to level of filter opening.
AUTOMATIC/AUTOMATED MANUAL Liters PtAMT-7 automated mechanical . . . . . . 10.4 22.0
ASO56-7B, ASO66-7BAutomate-2 . . . . . . . . . . . . . . . . . . . . . 8.5 18.0
9-speed automated mechanicalAS125-9, AS135-9A, AS140-9AASO125-9A, ASO135-91, ASO140-9A,ASO145-9A, ASO150-9A, LAS125-9A, LAS140-9A, LASO125-9A, LASO140-9A,LASO150-9A
10-speed automated mechanical . . 8.5 18.0AS100-10D, AS125-10D, AS135-10D, AS145-10D, ASO100-10S, ASO125-10S,ASO140-10S, ASO150-10S, ASO165-10S,LAS100-10D, LAS125-10D, LAS135-10D,LAS145-10D, LASO125-10S, LASO140-10S,
LASO150-10S, LLAS100-10D, LLAS125-10D,LLAS135-20S, LLAS145-10D, LLASO125-10S,LLASO140-10S, LLASO150-10S
MANUAL Liters PtEasy-Shift
5-Speed (Synchronized) . . . . . . . . . 5.7 12.0ES42-5A, ES43-5, ES43-5D, ES46-5A,ES46-5D, ES53-5, ES53-5A. RS53-5D,ES56-5A, ES56-5DES62-5, ES62-5A, ES62-5D, ES67-5,ES67-5A, ES67-5D . . . . . . . . . . . 8.0 17.0ED70-5, ES70-5A, ES70-5D . . . . 8.5 18.0
7-speed (Synchronized) . . . . . . . . . . 10.4 22.0ES-52-7B, ES56-7B, ESO66-7B
Pro-Shift5- & 6-Speed . . . . . . . . . . . . . . . . . . 19.3 41.0
PS130-5A, PS130-6B, PSO140-6A7-speed . . . . . . . . . . . . . . . . . . . . . . 19.4 48.0
PS110-7A, PS110-7B, PS145-7A8-speed . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0
PSO120-8LL9-speed . . . . . . . . . . . . . . . . . . . . . . 8.5 18.0
PS95-9A, PS125-9A, PS140-9A,PSO125-9A, PSO140-9A, PSO150-9A,LPS125-9A, LPSO125-9A, LPS140-9A,LPSO140-9A, LPSO150-9A, LLPS125-9A,LLPS140-9A, LLPSO125-9A, LLPSO140-9A,LLPSO150-9A, PS9-VPD, POS9-VPD,LPS9-VPD, LPSO0-VPD
10-speed . . . . . . . . . . . . . . . . . . . . . 8.5 18.0PS100-10D, PS125-10D, PS135-10D,PS145-10D, PSO100-10S, PSO125-10S,PSO140-10S, PSO150-10S, PS165-10S.PSO10-VPD, LPS100-10D, LPS125-10D,LPS135-10D, LPS145-10D, LPSO100-10S,LPSO125-10S, LPSO140-10S, LPSO150-10S,LPSO165-10S, LPSO10-VPD, LLPS100-10D,LLPS125-10D, LLPS135-10D, LLPS145-10S,LLPSO100-10S, LLPSO125-10S,LLPSO140-10S, LLPSO150-10S,LLPSO165-10S, LLPS010-VPD
Vocational 10-speed . . . . . . . . . . . . 8.5 18.0PS86-10V, PSO115-10V, PSO125-10V,PS0145-10V
16-speed . . . . . . . . . . . . . . . . . . . . 14.5 30.0PSO150-16B, PSO165-16B, PSO175-16B,PSO175-16M, PSO175-16SM
18-speed . . . . . . . . . . . . . . . . . . . . . 14.5 30.0PSO165-18B, PSO175-18B, PSO175-18M,PSO175-18SM
CAPACITIES Liters PtHeavy Duty
6-speed . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0PS130-6L, 9505-2B
7-speed . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0PS105-7LL, 9505-2A
12-speed . . . . . . . . . . . . . . . . . . . . . 12.0 29.5PSO140-12B
18-speed . . . . . . . . . . . . . . . . . . . . . 14.5 30.0PSDO165-18, PSDO185-18, PSDO205-18”
AUXILIARY Liters PtAMO1750-4C, APO1750-4C,
AMO1750-4D, . . . . . . . . . . . . . . . . . 6.6 14.0APO1750-4D, ATO1750-4C, ATO1750-4D,
MO1000-4C, AMO1000-4D, APO1000-4C,APO1000-4D, ATO1000-4C, AATO1000-4DAMO610-4L, ARO610-4L . . . . . . . . 5.6 12.0
TRANSFER CASES Liters Pt738 . . . . . . . . . . . . . . . . . . . . . . . 5.2 11.0
TRANSMISSIONSCapacities are approximate. Fill to bottom of fill plug hole. For unitswith oil pump and/or oil cooler, run engine for five minutes after fill andcheck oil level.
AUTOMATIC/AUTOMATED MANUAL Liters Pt9- & 10-Speed ESS automated manuals . . . . . . . . . . . . . . 9.7 20.5
M-11G9A-X11, M-12G9A-X12, M-12G9A-X13 M-14G9A-X14, M-15G9A-X15, MO-12G91-X12, MO-13G9A-X13, MO-14G9A-X14, MO-11G9B-X11, MO-12G9B-X12, MO-14G9B-X14, MO-15G9B-X15, M-11G10A-X11, M-12G10A-X12, M-13G10A-X13, M-14G10A-X14, M-15G10A-X15, MO-11G10A-X11, MO-12G10A-X12, MO-13G10A-X13,MO-14G10A-X14, MO-15G10A-X15, MO-14G10A-E16, MO-16G10A-X16. MO-16G10A-E18, MO-11G10A-X11, MO-12G10A-X12, MO-13G10A-X13, MO-14G10A-X14, MO-15G10A-X15, MO-14G10A-E16,MO-16G10A-X16.MO-16G10A-E18, MO-11G10C-X11, MO-12G10C-X12, MO-13G10C-X13, MO-14G10C-X14, MO-15G10C-X15, MO-14G10C-E16, MO-16G10C-X16. MO-16G10C-E18, MO-11G10C-X11,MO-12G10C-X12, MO-13G10C-X13, MO-14G10C-X14, MO-15G10C-X15, MO-14G10C-E16, MO-16G10C-X16, MO-16G10C-E18, MO-17G10C-E17, MO-17G10C-E19, MO-18G10C-E18, MO-18G10C-X20
9- & 10-Speed SureShift automated manuals . . . . . . . . . . . . . . 9.7 20.5
M-11G9A-S11, M-12G9A-S12, M-13G9A-S13, M-14G9A-S14, M-15G9A-S15, MO-12G9A-S12, MO-13G9A-S13, M0-14G9A-S14, MO-12G9B-S11, MO-12G9B-S12, MO-13G9B-S13, M0-14G9B-S14, MO-15G9B-S15, M-11G10A-S11, M-12G10A-S12, M-13G10A-S13, M-14G10A-S14, M-15G10A-S15, M-14G10A-S16, MO-11G10C-S11,MO-12G10C-S12, MO-13G10C-S13, MO-14G10C-S14, MO-15G10C-S15, MO-16G10C-S16, MO-15G10C-S16, MO-16G10C-S18, MO-17G10C-S17, MO-17G10C-S19, MO-18G10C-S18, MO-18G10C-S20
12-Speed FreedomLine automated manuals . . . . . . . . . . . . . . 11.0 23.2
M-13Z12A-A14, M-14Z12A-A14, MO-14Z12A-A14, MO-15Z12A-15,MO-16Z12A-16
16-Speed FreedomLine automated manuals . . . . . . . . . . . . . . 11.8 25.0
MO-14Z16A-A14, MO-15Z16A-A15, MO-16Z166A-A16MANUAL Liters PtExcept Platform “F”9 & 10-Speed . . . . . . . . . . . . . . . . . . . 9.7 20.513-Speed . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0Platform “F”M-14F10A-M16 . . . . . . . . . . . . . . . . . 9.7 20.5MO-14F10A-M16, MO-14F10C-M16 . 9.7 20.5MO-16F10C-M18 . . . . . . . . . . . . . . . . 9.7 20.5RD10-145A . . . . . . . . . . . . . . . . . . . . . 9.7 20.5RM9-115A, RM9-125A . . . . . . . . . . . . 9.4 20.0RM9-135A, RM9-145A, RM9-155A . . 9.7 20.5RMO9-115B, RMO9-125B . . . . . . . . . 9.4 20.0RMO9-125A . . . . . . . . . . . . . . . . . . . . 9.4 20.0RMO9-135A, RMO9-145A . . . . . . . . . 9.7 20.5RMO9-135B, RMO9-145B . . . . . . . . . 9.7 20.5RMX9-115R, RMX9-125R . . . . . . . . . . 9.4 20.0RMX9-125A . . . . . . . . . . . . . . . . . . . . 9.4 20.0RMX9-135A, RMX9-145A . . . . . . . . . . 9.7 20.5RMX9-135B, RMX9-145B,
RMX9-155B . . . . . . . . . . . . . . . . . . . 9.7 20.5RMX9-135R, RMX9-145R . . . . . . . . . . 9.7 20.5RM10-115A, RM10-125A . . . . . . . . . . 9.4 20.0RM10-135A, RM10-145A,
RM10-155A . . . . . . . . . . . . . . . . . . . 9.7 20.5RMX10-115A, RMX10-125A . . . . . . . . 9.4 20.5RMX10-115C, RMX10-125C . . . . . . . . 9.7 20.5RMX10-135A, RMX10-145A . . . . . . . . 9.7 20.5RMX10-135C, RMX10-145C . . . . . . . . 9.7 20.5RMX10-155A, RMX10-165A . . . . . . . . 9.7 20.5RMX10-155C, RMX10-165C . . . . . . . . 9.7 20.5RMO13-145A . . . . . . . . . . . . . . . . . . . 9.7 20.5RS9-115A, RS9-125A . . . . . . . . . . . . . 9.4 20.0RS9-135A, RS9-145A, RS9-155A . . . . 9.7 20.5RSO9-115B, RSO9-125B . . . . . . . . . . 9.4 20.0RSX9-115R, RSX9-125R . . . . . . . . . . 9.4 20.0RS09-135A, RS09-145A . . . . . . . . . . . 9.7 20.5RSX9-125A . . . . . . . . . . . . . . . . . . . . . 9.4 20.0RSX9-135A, RSX9-145A . . . . . . . . . . . 9.7 20.5RSX9-135B, RSX9-145B,
RSX9-155B . . . . . . . . . . . . . . . . . . . 9.7 20.5RSX9-135R, RSX9-145R . . . . . . . . . . 9.7 20.5RS10-115A, RS10-125A . . . . . . . . . . . 9.4 20.0RSX10-115C, RSX10-125C . . . . . . . . 9.7 20.5
160
DIFFERENTIAL MANUFACTURERS LUBRICANT RECOMMENDATIONS AND CAPACITIESThe capacities and lubricant recommendations given below are those of the unit manufacturer and may not agree with those of the truck manufacturer.
Capacities may not agree with those of the truck manufacturer due to variations in individual installations.
CAPACITIES Liters Pt17221, 17321 . . . . . . . . . . . . . . . . . . . 16.1 34.018200, 18220, 18802-3 . . . . . . . . . . . . 13.7 29.018221, 18321 . . . . . . . . . . . . . . . . . . . 16.1 34.019200-1, 19502-3 . . . . . . . . . . . . . . . . 16.1 34.019220-1, 19800-1 . . . . . . . . . . . . . . . . 16.1 34.020200, 20502-3 . . . . . . . . . . . . . . . . . . 18.0 38.020220, 20800-1, 22221 . . . . . . . . . . . . 18.0 38.023080P . . . . . . . . . . . . . . . . . . . . . . . 20.24 42.04
23080T . . . . . . . . . . . . . . . . . . . . . . . 20.84 44.04
23221, 23321, 23421 . . . . . . . . . . . . . 19.4 41.026220-1 . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.035327 . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
2-SPEED & PLANETARY DOUBLE REDUCTIONSINGLE DRIVE AXLESCAPACITIES Liters PtE2300S . . . . . . . . . . . . . . . . . . . . . . . 22.7 48.015 . . . . . . . . . . . . . . . . . . . . . . . 11.0 23.016 . . . . . . . . . . . . . . . . . . . . . . . 15.6 33.017, 18 . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.021, 22 . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.023,26 . . . . . . . . . . . . . . . . . . . . . . . 19.4 41.030, 35 . . . . . . . . . . . . . . . . . . . . . . . 19.4 41.015040, 15040T/P . . . . . . . . . . . . . . . . 11.4 24.015060S . . . . . . . . . . . . . . . . . . . . . . . 14.6 31.015201, 15301 . . . . . . . . . . . . . . . . . . . 11.0 23.016244, 16344 . . . . . . . . . . . . . . . . . . . 15.6 33.017201, 17221, 17301, 17321 . . . . . . . 17.5 37.018201, 18221, 18301, 18321 . . . . . . . 17.5 37.019050, 19050T/P . . . . . . . . . . . . . . . . 16.8 35.619055T/P . . . . . . . . . . . . . . . . . . . . . . 16.5 35.019060T . . . . . . . . . . . . . . . . . . . . . . . 18.0 38.019060T/P . . . . . . . . . . . . . . . . . . . . . . 16.5 35.021060S . . . . . . . . . . . . . . . . . . . . . . . 14.6 31.021060T . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.021060T/P . . . . . . . . . . . . . . . . . . . . . . 16.5 35.021065, 21065T/P . . . . . . . . . . . . . . . . 16.0 33.522060T . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.022065T/P . . . . . . . . . . . . . . . . . . . . . . 16.5 35.022221, 22321 . . . . . . . . . . . . . . . . . . . 17.5 37.023070, 23070T/P . . . . . . . . . . . . . . . . 18.5 39.023080P . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.023080T . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.023085T/P . . . . . . . . . . . . . . . . . . . . . . 19.4 41.023221, 23321, 26080T/P . . . . . . . . . . . 19.4 41.026085 . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.026221, 26321 . . . . . . . . . . . . . . . . . . . 19.4 41.030055P . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.030227, 30327 . . . . . . . . . . . . . . . . . . . 19.4 41.030505P . . . . . . . . . . . . . . . . . . . . . . . 21.8 46.035055P . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.035327 . . . . . . . . . . . . . . . . . . . . . . . 19.4 41.0
PLANETARY DOUBLE REDUCTION AXLESCAPACITIES Liters Pt350, 3800, 3802, 15301 . . . . . . . . . . . 9.0 19.06600-1, 16320, 6802-3 . . . . . . . . . . . . 11.4 24.017300-1, 17320-1, 7800-1 . . . . . . . . . 13.7 29.018300-1, 18320-1, 8802-3 . . . . . . . . . 13.7 29.019300-1, 9502-3, 19320, 9800-1 . . . . 16.1 34.020300-1, 0502-3, 20320, 0800-1 . . . . 18.0 38.026321 . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.035327 . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0
. . . . . . . . . . . . . . . . . . . . . . . 8.0 38.0
SINGLE REDUCTION TANDEM DRIVE AXLESCAPACITIES Liters PtDD/DS404: Front . . . . . . . . . . . . . . . . . 14.7 31.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0DD/DS/RS340-341 . . . . . . . . . . . . . . . 18.5 39.0DS/DA344 . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0DS380P, DS381P . . . . . . . . . . . . . . . . 18.5 39.0DS400-401-402 . . . . . . . . . . . . . . . . . 18.5 39.0DS/DD/DA404P . . . . . . . . . . . . . . . . . 15.0 32.0RS/DR/RA404 . . . . . . . . . . . . . . . . . . . 13.0 28.0DS/DD/DA405P . . . . . . . . . . . . . . . . . 15.0 32.0RS/DR/RA405 . . . . . . . . . . . . . . . . . . . 13.0 28.0DS/RD/RS451P . . . . . . . . . . . . . . . . . . 18.5 39.0DS/DD/DA454P . . . . . . . . . . . . . . . . . 15.0 32.0DS460P . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0DS/DD461P, DS480P . . . . . . . . . . . . . 32.0 49.0RS/RD461 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0DS/DD462P . . . . . . . . . . . . . . . . . . . . 22.0 46.0RS/RD462 . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0DS/DD463P . . . . . . . . . . . . . . . . . . . . 22.0 49.0RS/RD463 . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0DS/DD521P . . . . . . . . . . . . . . . . . . . . 22.5 49.0RS/RD521 . . . . . . . . . . . . . . . . . . . . . . 19.5 40.0DS/DD581P . . . . . . . . . . . . . . . . . . . . 22.5 48.0RS/RD581 . . . . . . . . . . . . . . . . . . . . . . 19.5 40.0
TANDEM DRIVE AXLESCAPACITIES Liters Pt30DS, DT, DP, D-3 . . . . . . . . . . . . . . . . 14.21 30.01
30RS, RT, R-3, RP . . . . . . . . . . . . . . . . 12.8 27.034, 38DS: Front . . . . . . . . . . . . . . . . . . 18.53 39.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.034DS, D3, D3C: Front, Rear . . . . . . . . 18.4 39.0
Differential Lock . . . . . . . . . . . . . . . . 0.9 2.034DSC, RSC . . . . . . . . . . . . . . . . . . . . 18.53 39.03
34DTC, RTC . . . . . . . . . . . . . . . . . . . . 17.53 37.03
34RS, RT, R-3, RP . . . . . . . . . . . . . . . . 13.7 29.0
CAPACITIES Liters Pt34, 38DT/DP: Front . . . . . . . . . . . . . . . 16.13 34.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.038DSC, RSC . . . . . . . . . . . . . . . . . . . . 18.53 39.03
38DTC, RTC . . . . . . . . . . . . . . . . . . . . 17.53 37.03
38RS, RT, R-3, RP; 50RT, RP . . . . . . . 13.7 29.042DT, D-3, DP . . . . . . . . . . . . . . . . . . . 14.71 31.01
42RT, R-3, RP . . . . . . . . . . . . . . . . . . . 13.7 29.044DS, DT, DP . . . . . . . . . . . . . . . . . . . 20.4 43.044RS, RT, RP . . . . . . . . . . . . . . . . . . . 16.1 34.044DSM . . . . . . . . . . . . . . . . . . . . . . . 20.4 43.044RSM . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.050DT, DP . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0
HIGH TORQUE TANDEM AXLESCAPACITIES Liters Pt185S4, 185T4/P4 . . . . . . . . . . . . . . . . 17.3 36.5220S4 . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.0220T4/P4 . . . . . . . . . . . . . . . . . . . . . . 16.8 35.5230S4 . . . . . . . . . . . . . . . . . . . . . . . 20.6 43.5230T4/P4 . . . . . . . . . . . . . . . . . . . . . . 19.6 41.5260S4, 300S4 . . . . . . . . . . . . . . . . . . . 20.8 44.0260T4/P4, 300T4/P4 . . . . . . . . . . . . . . 19.4 41.0300P, -DS, -DSC: Front . . . . . . . . . . . . 14.23 30.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0DS340: Front . . . . . . . . . . . . . . . . . . . . 18.53 39.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP340: Front . . . . . . . . . . . . . . . . . 16.13 34.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0RS340 . . . . . . . . . . . . . . . . . . . . . . . 18.53 39.03
RT340 . . . . . . . . . . . . . . . . . . . . . . . 17.53 37.03
RP340 . . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0DS342, -3800, -381: Front . . . . . . . . . 18.53 39.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DS404, -404P, -454, -454P:
Front . . . . . . . . . . . . . . . . . . . . . . . 15.14 32.04
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.74 31.04
DS454 (rear) . . . . . . . . . . . . . . . . . . . . 13.2 28.0DS346-P . . . . . . . . . . . . . . . . . . . . . . . 18.7 39.5DT/DP346-P . . . . . . . . . . . . . . . . . . . . 16.3 34.5350S4 . . . . . . . . . . . . . . . . . . . . . . . 18.4 39.0350T4/P4 . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DS380, 380P: Front . . . . . . . . . . . . . . . 18.53 39.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP380, 380P: Front . . . . . . . . . . . . 16.13 34.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0RS380 . . . . . . . . . . . . . . . . . . . . . . . 18.53 39.03
RT380 . . . . . . . . . . . . . . . . . . . . . . . 17.53 37.03
RS, RT, RP380 . . . . . . . . . . . . . . . . . . 13.7 29.0DS/DT381: Front . . . . . . . . . . . . . . . . . 14.0 29.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0DS386-P . . . . . . . . . . . . . . . . . . . . . . . 18.2 38.5DT/DP386-P . . . . . . . . . . . . . . . . . . . . 15.8 33.5DP400 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0DS400P: Front . . . . . . . . . . . . . . . . . . 18.53 39.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP400P: Front . . . . . . . . . . . . . . . . 16.13 34.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0DT401P: Front and Rear . . . . . . . . . . . 18.53 39.03
RT400P . . . . . . . . . . . . . . . . . . . . . . . 17.53 37.03
RP400 . . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0DS/DT401P: Front . . . . . . . . . . . . . . . . 14.0 29.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0DS406-P . . . . . . . . . . . . . . . . . . . . . . . 18.7 39.5DT402P: Front . . . . . . . . . . . . . . . . . . . 17.54 38.64
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.64 35.04
DT/DP406-P . . . . . . . . . . . . . . . . . . . . 16.3 34.5DS440P: Front . . . . . . . . . . . . . . . . . . 22.03 46.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.4 43.0DT/DP440P: Front . . . . . . . . . . . . . . . . 21.33 45.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.0RS440 . . . . . . . . . . . . . . . . . . . . . . . 21.33 45.03
RT440P . . . . . . . . . . . . . . . . . . . . . . . 19.43 41.03
DS446-P . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0DT/DP446-P . . . . . . . . . . . . . . . . . . . . 21.3 45.0DS/DT460P . . . . . . . . . . . . . . . . . . . . . 21.03 44.03
RS460 . . . . . . . . . . . . . . . . . . . . . . . 20.0 43.0RT460 . . . . . . . . . . . . . . . . . . . . . . . 18.0 37.0DS480P: Front . . . . . . . . . . . . . . . . . . 20.43 43.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 21.4 43.0W/Controlled Traction Differential:
Front . . . . . . . . . . . . . . . . . . . . . . . 20.43 43.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 19.4 41.0DT/DP480P: Front . . . . . . . . . . . . . . . . 20.83 44.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0RS480 . . . . . . . . . . . . . . . . . . . . . . . 20.43 43.03
RT480P . . . . . . . . . . . . . . . . . . . . . . . 19.43 41.03
DS486-P, DT/DP486-P . . . . . . . . . . . . 20.6 43.5DP580P: Front . . . . . . . . . . . . . . . . . . 20.0 43.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0DS586-P . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0DT/DP586-P . . . . . . . . . . . . . . . . . . . . 20.8 44.0DS656-P . . . . . . . . . . . . . . . . . . . . . . . 19.4 41.0DT/DP656-P . . . . . . . . . . . . . . . . . . . . 19.9 42.0
DUAL RANGE PLANETARY DOUBLE REDUC-TION & CONTROLLED TRACTION (CTD) TAN-DEM DRIVE AXLESCAPACITIES Liters PtDC/DT/DP341 . . . . . . . . . . . . . . . . . . . 16.5 35.0RC/RT/RP341 . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP401-P . . . . . . . . . . . . . . . . . . . . 16.5 35.0RT/RP402 . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
CLARKAll axles . . . . . . . . . . . . . . . . . . . . . . . . . . . .GL-5
Above 100°F (38°C), 85W-140Above -10°F (-23°C), 80W-1400° to 100°F (-18° to 38°C), 90-10° to 100°F (-23° to 38°C), 80W-90-10° to 0°F (-23° to 0°C), 80WBelow -10°F (-23°C), 75W
CAPACITIES Liters PtBD-50-60 (each) . . . . . . . . . . . . . . . . . 8.5 18.0
Planetary hubs (each) . . . . . . . . . . . 3.8 8.0BD-50-70 (each) . . . . . . . . . . . . . . . . . 14.2 30.0
Planetary hubs (each) . . . . . . . . . . . 3.8 8.0BD-22500 (each) . . . . . . . . . . . . . . . . . 8.5 18.0
Planetary hubs (each) . . . . . . . . . . . 3.8 8.0BD-66000 (each) . . . . . . . . . . . . . . . . . 14.2 30.0
Planetary hubs (each) . . . . . . . . . . . 3.8 8.0BD-70000 (each) . . . . . . . . . . . . . . . . . 14.2 30.0
Planetary hubs (each) . . . . . . . . . . . 8.5 18.0BD-90000 (each) . . . . . . . . . . . . . . . . . 14.2 30.0
Planetary hubs (each) . . . . . . . . . . . 8.5 18.0
EATON/FULLERAll differentials . . . . . . . . . . . . . . . . . . . . . .GL-51
Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-140Above -40°F (-40°C), 75W-140-15° to 100°F (-26° to 38°C), 80W-90-40° to 80°F (-40° to 21°C), 75W-80-40° to 100°F (-40° to 38°C), 75W-90-40° to -15°F (-40° to -26°C), 75WNormal ambient temperatures, 75W-90 synthetic High ambient temperatures, 80W-140 synthetic
For severe service, use 85W-140 or 80W-140.Do not mix types or brands. Use approved brands.1 Must meet spec. MIL-PRF-2105E.
SINGLE REDUCTION SINGLE DRIVE AXLESCAPACITIES Liters Pt
Approximate capacities based on zero degree angle. Use fill hole asfinal reference.
1315, 13100 . . . . . . . . . . . . . . . . . . . . 11.0 23.015040S . . . . . . . . . . . . . . . . . . . . . . . 10.0 21.015050S . . . . . . . . . . . . . . . . . . . . . . . 12.84 27.015060S . . . . . . . . . . . . . . . . . . . . . . . 14.64 31.015101 . . . . . . . . . . . . . . . . . . . . . . . 10.9 23.01614-5, 16120, 1618-9 . . . . . . . . . . . . 11.4 24.016121, 16122 . . . . . . . . . . . . . . . . . . . 17.0 36.016224, 16244 . . . . . . . . . . . . . . . . . . . 15.5 33.017100, 18100 . . . . . . . . . . . . . . . . . . . 18.0 38.017120, 1790A-1A . . . . . . . . . . . . . . . . 13.7 29.017101, 17103 . . . . . . . . . . . . . . . . . . . 17.5 37.017120, 17121, 17123, 18121 . . . . . . . 17.5 37.017201, 17209, 17221, 17301 . . . . . . . 17.0 36.017401-17421 . . . . . . . . . . . . . . . . . . . 17.5 37.018120, 1880-1, 1862-3 . . . . . . . . . . . . 13.7 29.018201, 18301 . . . . . . . . . . . . . . . . . . . 17.0 36.018221, 1893 . . . . . . . . . . . . . . . . . . . . 13.7 29.019050S . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.019055S/D . . . . . . . . . . . . . . . . . . . . . . 16.0 33.519060D/S/A . . . . . . . . . . . . . . . . . . . . 13.0 28.019060D . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.019100-1, 1910-1, 19120-1 . . . . . . . . . 16.1 34.01918-9, 19201, 19221, 19420-1-6 . . . 16.1 34.020100, 2010-1, 20120, 2018-9 . . . . . . 18.0 38.021060A/D/S . . . . . . . . . . . . . . . . . . . . 13.0 28.021065D, 21065S/A . . . . . . . . . . . . . . . 16.0 34.021080A/D/S . . . . . . . . . . . . . . . . . . . . 19.0 40.022060A/D/S . . . . . . . . . . . . . . . . . . . . 13.0 28.022065D/S . . . . . . . . . . . . . . . . . . . . . . 16.0 34.022080A/D/S . . . . . . . . . . . . . . . . . . . . 19.0 40.022121D . . . . . . . . . . . . . . . . . . . . . . . 20.5 43.022221, 22321 . . . . . . . . . . . . . . . . . . . 17.5 37.022065S . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.023070S/D . . . . . . . . . . . . . . . . . . . . . . 19.0 40.023080S/D/A . . . . . . . . . . . . . . . . . . . . 19.0 40.023085C/S/D . . . . . . . . . . . . . . . . . . . . 19.0 40.023105, 26105 . . . . . . . . . . . . . . . . . . . 26.5 56.023105A/D/S . . . . . . . . . . . . . . . . . . . . 26.5 56.023121, 26121 . . . . . . . . . . . . . . . . . . . 16.0 34.0
20.8 44.023221, 26221, 26321, 26421 . . . . . . . 19.4 41.023431 . . . . . . . . . . . . . . . . . . . . . . . 20.84 44.026080P . . . . . . . . . . . . . . . . . . . . . . . 20.84 44.026085P . . . . . . . . . . . . . . . . . . . . . . . 19.5 41.026105C . . . . . . . . . . . . . . . . . . . . . . . 25.5 54.026105A/D/S . . . . . . . . . . . . . . . . . . . . 26.5 56.026420-6 . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.030105C . . . . . . . . . . . . . . . . . . . . . . . 24.6 52.030105S/D . . . . . . . . . . . . . . . . . . . . . . 25.5 54.030105S . . . . . . . . . . . . . . . . . . . . . . . 21.8 46.0
2-SPEED AXLESCAPACITIES Liters Pt1350, 13600, 13802 . . . . . . . . . . . . . . 9.0 19.015201 . . . . . . . . . . . . . . . . . . . . . . . 11.0 23.015301 . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.016244, 16344 . . . . . . . . . . . . . . . . . . . 15.6 33.016600-1 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.016220-1, 16802-3 . . . . . . . . . . . . . . . . 11.4 24.017200, 17220, 17800-1 . . . . . . . . . . . . 13.7 29.017201, 17202, 17222 . . . . . . . . . . . . . 17.5 37.0
MEDIUM & HEAVY TRUCKS
CAPACITIES Liters PtDT/DP451-P . . . . . . . . . . . . . . . . . . . . 16.5 35.0RC/RT/RP451 . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP461-P . . . . . . . . . . . . . . . . . . . . 22.0 46.0RC/RT/RP461 . . . . . . . . . . . . . . . . . . . 18.5 39.0DC462-P . . . . . . . . . . . . . . . . . . . . . . . 22.0 46.0RC462 . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0DT/DP463-P . . . . . . . . . . . . . . . . . . . . 20.0 42.0RT/RP463 . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0DT/DP521-P . . . . . . . . . . . . . . . . . . . . 21.0 45.0RC/RT/RP521 . . . . . . . . . . . . . . . . . . . 18.0 38.0DP581-P . . . . . . . . . . . . . . . . . . . . . . . 21.0 45.0RP581 . . . . . . . . . . . . . . . . . . . . . . . 18.0 38.0DP601-P . . . . . . . . . . . . . . . . . . . . . . . 20.0 42.0RP601 . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0DP651-P . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0RP651 . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.0DP652-P . . . . . . . . . . . . . . . . . . . . . . . 19.0 41.0RP652 . . . . . . . . . . . . . . . . . . . . . . . 17.5 37.0
550, 650 SERIES TANDEM DRIVE AXLESCAPACITIES Liters PtDP550, DP650, TP550, SP550 . . . . . . 20.42 43.02
RP550, RP650 . . . . . . . . . . . . . . . . . . 16.12 34.02
DP580, 650P: Front . . . . . . . . . . . . . . . 19.43 41.03
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0SP/TP580, 650 . . . . . . . . . . . . . . . . . . 19.43 41.03
1 With Torque Selector Unit:add to forward unit...................................... 0.9 2.0
2 DP/TP forward axles, SP rear axles:add to forward unit...................................... 0.9 2.0
3 Add to power divider................................... 0.9 2.04 Includes 1.5L (3.1 pt) to fill hub cavities.
MERITOR/ROCKWELLDifferentials . . . . . . . . . . . . . . . . . . . . . . . . GL-51
1 Must meet MIL-L-2105D or MIL-PRF-2105E.Use Meritor-approved fluids.
Above 10ºF (-12ºC), 85W-140Above -15ºF (-26ºC), 80W-90Above -40ºF 75W-90, 75W-140Above -40ºF (-12ºC), 75W-90 synthetic-40º to 35º (-40º to 2ºC), 75W
Spring Seats . . . . . . . . . . . . . . . . . . . . .250 GL-2May use 140W if 250 is not available.
SINGLE REAR DRIVECAPACITIES Liters PtA-150 . . . . . . . . . . . . . . . . . . . . . . . 2.6 5.5B-100 . . . . . . . . . . . . . . . . . . . . . . . 4.7 10.0B-140 . . . . . . . . . . . . . . . . . . . . . . . 5.7 12.0B-150 . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.5C-100 . . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5D-100 . . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5D-140 . . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5E-100 . . . . . . . . . . . . . . . . . . . . . . . 7.1 15.0E-105 . . . . . . . . . . . . . . . . . . . . . . . 5.9 12.5E-150 . . . . . . . . . . . . . . . . . . . . . . . 4.3 9.0F-100 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0F-106 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0F-120 . . . . . . . . . . . . . . . . . . . . . . . 7.1 15.0F-121 . . . . . . . . . . . . . . . . . . . . . . . 7.1 15.0F-140 . . . . . . . . . . . . . . . . . . . . . . . 6.6 14.0F-3110 . . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0F-7910, FS-4711 . . . . . . . . . . . . . . . . . 15.1 32.0G-161 . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0G-340 . . . . . . . . . . . . . . . . . . . . . . . 11.41 24.01
G-341 . . . . . . . . . . . . . . . . . . . . . . . 10.41 22.01
G-361 . . . . . . . . . . . . . . . . . . . . . . . 12.31 26.01
H-100 . . . . . . . . . . . . . . . . . . . . . . . 9.5 20.0H-110, H-135 . . . . . . . . . . . . . . . . . . . 5.9 12.5H-140 . . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0H-150 . . . . . . . . . . . . . . . . . . . . . . . 5.2 11.0H-162 . . . . . . . . . . . . . . . . . . . . . . . 9.5 20.0H-170, H-172, H-173, H-175 . . . . . . . 12.7 27.0H-200 . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0H-240 . . . . . . . . . . . . . . . . . . . . . . . 10.41 22.01
H-262 . . . . . . . . . . . . . . . . . . . . . . . 10.9 23.0H-300 . . . . . . . . . . . . . . . . . . . . . . . 12.31 26.01
H-340 . . . . . . . . . . . . . . . . . . . . . . . 10.41 22.01
H-350, H-360, H-362, H-370 . . . . . . . 12.31 26.01
L-100 . . . . . . . . . . . . . . . . . . . . . . . 10.9 23.0L-140, -155 . . . . . . . . . . . . . . . . . . . . . 11.4 24.0L-155 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0L-172 . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0L-200 . . . . . . . . . . . . . . . . . . . . . . . 14.71 31.01
L-240, L-340 . . . . . . . . . . . . . . . . . . . . 10.41 22.01
L-300 . . . . . . . . . . . . . . . . . . . . . . . 13.71 29.01
L-350 . . . . . . . . . . . . . . . . . . . . . . . 11.41 24.01
L-362 . . . . . . . . . . . . . . . . . . . . . . . 12.3 26.0L-370 . . . . . . . . . . . . . . . . . . . . . . . 15.21 32.01
L-600 . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0M-172 . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0Q-100 . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0Q-145 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0Q-200, Q-245 . . . . . . . . . . . . . . . . . . . 16.11 34.01
Q-300, Q-345 . . . . . . . . . . . . . . . . . . . 15.11 32.01
Q-350, Q-370 . . . . . . . . . . . . . . . . . . . 16.11 34.01
Q-380, Q-390 . . . . . . . . . . . . . . . . . . . 17.11 36.01
QT-140 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0R-100 . . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0R-140 . . . . . . . . . . . . . . . . . . . . . . . 13.3 28.0R-155 . . . . . . . . . . . . . . . . . . . . . . . 13.3 28.0R-160 . . . . . . . . . . . . . . . . . . . . . . . 13.3 28.0R-163 . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.0
CAPACITIES Liters PtR-170 . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0R-200 . . . . . . . . . . . . . . . . . . . . . . . 17.11 36.01
R-230 Shallow cover . . . . . . . . . . . . . . 17.61 36.01
R-270 . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.0R-300 . . . . . . . . . . . . . . . . . . . . . . . 16.11 34.01
R-330 Shallow cover . . . . . . . . . . . . . . 16.61 35.01
RL-170 . . . . . . . . . . . . . . . . . . . . . . . 22.7 48.0RS-13-120 . . . . . . . . . . . . . . . . . . . . . 8.7 18.4RS-15-120 . . . . . . . . . . . . . . . . . . . . . 8.7 18.4RS-15-210 . . . . . . . . . . . . . . . . . . . . . 6.8 14.3RS-17-140 . . . . . . . . . . . . . . . . . . . . . 13.5 28.6RS-17-145 . . . . . . . . . . . . . . . . . . . . . 15.9 33.6RS-17-220 . . . . . . . . . . . . . . . . . . . . . 14.5 30.7RS-19-145 . . . . . . . . . . . . . . . . . . . . . 15.7 33.2RS-19-220 . . . . . . . . . . . . . . . . . . . . . 14.7 31.0RS-21-145 (Ford) . . . . . . . . . . . . . . . . 15.3 32.3RS-21-145 (ex. Ford) . . . . . . . . . . . . . . 13.7 29.0RF-21-155, RF21-355 . . . . . . . . . . . . . 18.3 25.0RS-21-230 . . . . . . . . . . . . . . . . . . . . . 18.4 38.9RS-22-160 . . . . . . . . . . . . . . . . . . . . . 21.8 46.0RS-23-160 . . . . . . . . . . . . . . . . . . . . . 18.7 39.5RS-23-161 . . . . . . . . . . . . . . . . . . . . . 17.6 37.2RS-23-180, -185 . . . . . . . . . . . . . . . . . 22.4 47.3RS-23-186 . . . . . . . . . . . . . . . . . . . . . 22.4 47.3RS-23-240 . . . . . . . . . . . . . . . . . . . . . 17.7 37.4RS-23-380 . . . . . . . . . . . . . . . . . . . . . 30.1 63.6RS-25-160 . . . . . . . . . . . . . . . . . . . . . 17.0 37.0RS-26-160 . . . . . . . . . . . . . . . . . . . . . 22.5 47.5RS-26-180, RS-26-185 . . . . . . . . . . . . 22.0 46.6RS-26-380 . . . . . . . . . . . . . . . . . . . . . 27.5 58.2RS-30-180, RS-30-185 . . . . . . . . . . . . 22.0 46.6RS-30-380 . . . . . . . . . . . . . . . . . . . . . 27.5 58.2RS-38-380 . . . . . . . . . . . . . . . . . . . . . 25.1 53.1RT-240, -340 . . . . . . . . . . . . . . . . . . . . 15.11 32.01
S-170 . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0U-140 . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0U-170 . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0U-200, -240 . . . . . . . . . . . . . . . . . . . . . 18.01 38.01
U-270 . . . . . . . . . . . . . . . . . . . . . . . 26.1 55.0U-300, -340 . . . . . . . . . . . . . . . . . . . . . 18.51 39.01
W-170 . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0W-270 . . . . . . . . . . . . . . . . . . . . . . . 26.0 55.059722, 59723 . . . . . . . . . . . . . . . . . . . 14.4 30.559732 . . . . . . . . . . . . . . . . . . . . . . . 14.4 30.559733 . . . . . . . . . . . . . . . . . . . . . . . 14.4 30.559843 . . . . . . . . . . . . . . . . . . . . . . . 14.4 30.561142 . . . . . . . . . . . . . . . . . . . . . . . 19.8 42.061143 . . . . . . . . . . . . . . . . . . . . . . . 19.3 41.0
TANDEM AXLESCAPACITIES Liters PtMT-40-143MA-N: Front . . . . . . . . . . . . 14.3 30.2
Rear . . . . . . . . . . . . . . . . . . . . . . . 12.2 25.8RT-34-140: Front . . . . . . . . . . . . . . . . . 12.3 26.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0RT-34-144: Front . . . . . . . . . . . . . . . . . 14.0 30.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.0RT-34-145: Front . . . . . . . . . . . . . . . . . 14.0 29.6
Rear: . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.4RT-34-145P: Front . . . . . . . . . . . . . . . . 12.1 25.7
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.1 23.4RT-34-145P: Front . . . . . . . . . . . . . . . . 12.1 25.7
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.1 23.4RT-40-140: Front . . . . . . . . . . . . . . . . . 14.3 30.2
Rear . . . . . . . . . . . . . . . . . . . . . . . 10.8 22.8RT-40-145: Front . . . . . . . . . . . . . . . . . 14.3 30.2
Rear . . . . . . . . . . . . . . . . . . . . . . . 12.2 25.8RT-40-145P: Front . . . . . . . . . . . . . . . . 12.0 25.2
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.0 22.9RT-40-149: Front . . . . . . . . . . . . . . . . . 14.0 30.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 12.0 25.0RT-40-160: Front . . . . . . . . . . . . . . . . . 18.5 39.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.3 39.4RT-40-169: Front . . . . . . . . . . . . . . . . . 18.0 39.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0RT-44-145: Front . . . . . . . . . . . . . . . . . 13.9 29.3
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.9 25.1RT-46-160: Front . . . . . . . . . . . . . . . . . 18.5 39.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.3 34.4RT-46-160P: Front . . . . . . . . . . . . . . . . 18.6 39.3
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.4 34.7RT-46-164: Front . . . . . . . . . . . . . . . . . 18.5 39.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.3 39.4RT-46-164EH/P: Front . . . . . . . . . . . . . 18.0 38.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 33.0RT-46-169: Front . . . . . . . . . . . . . . . . . 18.0 39.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 16.0 34.0RT-48-1803: Front . . . . . . . . . . . . . . . . 28.9 61.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.4 36.8RT-48-180: Front . . . . . . . . . . . . . . . . . 28.9 61.13
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.4 36.8RT-48-380: Front . . . . . . . . . . . . . . . . . 28.9 61.13
Rear . . . . . . . . . . . . . . . . . . . . . . . 30.1 63.6RT-48-3803: Front . . . . . . . . . . . . . . . . 28.9 61.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 30.1 63.6RT-50-160: Front . . . . . . . . . . . . . . . . . 18.0 38.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 33.0RT-52-160: Front . . . . . . . . . . . . . . . . . 20.9 44.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 19.5 41.2RT-52-160P: Front . . . . . . . . . . . . . . . . 20.9 44.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 19.5 41.2RT-52-180: Front . . . . . . . . . . . . . . . . . 26.5 56.13
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1
CAPACITIES Liters PtRT-52-1803: Front . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1RT-52-185: Front . . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1RT-52-3803: Front . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 27.5 58.2RT-58-1801: Front . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1RT-58-185: Front . . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1RT-58-3801: Front . . . . . . . . . . . . . . . . 26.5 56.1
Rear . . . . . . . . . . . . . . . . . . . . . . . 27.5 58.2RT—70-3801: Front . . . . . . . . . . . . . . 25.7 54.4
Rear . . . . . . . . . . . . . . . . . . . . . . . 25.1 53.1SFD-4600, SFD-4700 . . . . . . . . . . . . . 13.2 28.0SFDD-4600, SFDD-4700 . . . . . . . . . . 13.2 28.02
SFDD-4640 . . . . . . . . . . . . . . . . . . . . . 13.2 28.0SHHD Front, Rear . . . . . . . . . . . . . . . . 12.32 26.02
SFHD:Front . . . . . . . . . . . . . . . . . . . . . 8.0 17.0Rear . . . . . . . . . . . . . . . . . . . . . . . 7.8 16.5
SLD . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0SLDD . . . . . . . . . . . . . . . . . . . . . . . 13.22 28.02
SLHD: Front . . . . . . . . . . . . . . . . . . . . 15.3 32.5Rear . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0
SLHP, SLHR . . . . . . . . . . . . . . . . . . . . 15.1 32.0SL-100: Front . . . . . . . . . . . . . . . . . . . 18.7 39.6
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.8 37.7SQD . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0SQDD . . . . . . . . . . . . . . . . . . . . . . . 10.42 22.02
SQHD: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0Rear . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0
SQHP: Front . . . . . . . . . . . . . . . . . . . . 18.92 40.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.0SQ-100:Front . . . . . . . . . . . . . . . . . . . 18.7 39.6
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.8 37.7SQ-100A: Front . . . . . . . . . . . . . . . . . . 18.6 39.3
Rear . . . . . . . . . . . . . . . . . . . . . . . 17.8 37.6SQR-100P: Front . . . . . . . . . . . . . . . . 18.9 40.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0SRD . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0SRDD . . . . . . . . . . . . . . . . . . . . . . . 10.42 22.02
SRHD: Front . . . . . . . . . . . . . . . . . . . . 18.5 39.0Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.0
SRHD: Front . . . . . . . . . . . . . . . . . . . . 18.5 39.0Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
SRHD: Front . . . . . . . . . . . . . . . . . . . . 18.5 39.0Rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0
SR-100: Front . . . . . . . . . . . . . . . . . . . 26.1 55.0Rear . . . . . . . . . . . . . . . . . . . . . . . 20.4 43.0
SR-170: Front . . . . . . . . . . . . . . . . . . . 26.0 55.0Rear . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0
SR-270, -280: Front . . . . . . . . . . . . . . 26.1 55.0Rear . . . . . . . . . . . . . . . . . . . . . . . 26.1 55.0
SSHD: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0Rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0
SSHD: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0Rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0
STDD: Front . . . . . . . . . . . . . . . . . . . . 21.72 46.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0STHD: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0ST-170: Front . . . . . . . . . . . . . . . . . . . 26.0 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0ST-170: Front . . . . . . . . . . . . . . . . . . . 26.0 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0SUD: Front . . . . . . . . . . . . . . . . . . . . . 21.7 46.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0SUDD: Front . . . . . . . . . . . . . . . . . . . . 21.72 46.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0SUHD: Front . . . . . . . . . . . . . . . . . . . . 16.0 34.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0SU-170: Front . . . . . . . . . . . . . . . . . . . 26.0 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0SU-270, -280: Front . . . . . . . . . . . . . . 24.0 51.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 26.1 55.0SW-170: Front . . . . . . . . . . . . . . . . . . . 26.0 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0SW-170: Front . . . . . . . . . . . . . . . . . . . 26.1 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 20.4 43.0SW-270, -280: Front . . . . . . . . . . . . . . 26.1 55.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 26.1 55.0
PLANETARY DRIVE AXLE HOUSINGCAPACITIES Liters PtEPRC-1356: front . . . . . . . . . . . . . . . . 15.1 32.0
middle . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0rear . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0
PR-53 . . . . . . . . . . . . . . . . . . . . . . . 15.6 33.0 PR-60 . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0PR-100 . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0PR-108 . . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0PR-111 . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0PR-112 . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PR-145 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0PR-150 . . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0PR-151 . . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0PR-153 . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0PR-200 . . . . . . . . . . . . . . . . . . . . . . . 18.9 40.0PR-205 . . . . . . . . . . . . . . . . . . . . . . . 21.8 46.0 PR-207 . . . . . . . . . . . . . . . . . . . . . . . 21.3 45.0PR-208 . . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0PR-209 . . . . . . . . . . . . . . . . . . . . . . . 26.4 56.0PR-251 . . . . . . . . . . . . . . . . . . . . . . . 19.9 42.0PR-253 . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.0
161
MEDIUM & HEAVY TRUCKSDIFFERENTIAL MANUFACTURERS LUBRICANT RECOMMENDATIONS AND CAPACITIES Continued
162
MEDIUM & HEAVY TRUCKSDIFFERENTIAL MANUFACTURERS LUBRICANT RECOMMENDATIONS AND CAPACITIES Continued
OIL CAPACITIES Liters PtPR-256 . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PR-270 . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PR-350 . . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0PR-400 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0PR-500 . . . . . . . . . . . . . . . . . . . . . . . 26.5 56.0PR-501 . . . . . . . . . . . . . . . . . . . . . . . 30.3 64.0PR-502 . . . . . . . . . . . . . . . . . . . . . . . 29.3 62.0PR-700 . . . . . . . . . . . . . . . . . . . . . . . 30.3 64.0PRC-184 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0PRC-264 . . . . . . . . . . . . . . . . . . . . . . . 7.5 16.0PRC-755 . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0PRC-864 . . . . . . . . . . . . . . . . . . . . . . . 14.1 30.0PRC-867 . . . . . . . . . . . . . . . . . . . . . . . 22.7 48.0PRC-1925 . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0PRC-3795 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0PRC-3796 . . . . . . . . . . . . . . . . . . . . . . 22.7 48.0PRC-3805 . . . . . . . . . . . . . . . . . . . . . . 27.4 58.0PRC-4805 . . . . . . . . . . . . . . . . . . . . . . 28.3 60.0PRC-5324 . . . . . . . . . . . . . . . . . . . . . . 37.8 80.0PRC-5334 . . . . . . . . . . . . . . . . . . . . . . 37.8 80.0PRC-7314 . . . . . . . . . . . . . . . . . . . . . . 34.0 72.0PRLC-344 . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PRLC-675 . . . . . . . . . . . . . . . . . . . . . . 26.5 56.0PRLC-823 . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PRLC-1756 . . . . . . . . . . . . . . . . . . . . . 18.5 39.0PRLC-1757 . . . . . . . . . . . . . . . . . . . . . 18.5 39.0PRLC-1925 . . . . . . . . . . . . . . . . . . . . . 34.0 72.0PRLM-855 . . . . . . . . . . . . . . . . . . . . . 13.2 28.0PRM-672 . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0PRM-673 . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0PRM-676 . . . . . . . . . . . . . . . . . . . . . . 21.8 46.0PRM-677 . . . . . . . . . . . . . . . . . . . . . . 21.8 46.0PRM-1314 . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PRM-1315 . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PRM-1615 . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PRM-1756 . . . . . . . . . . . . . . . . . . . . . 20.3 43.0PRM-1757 . . . . . . . . . . . . . . . . . . . . . 20.3 43.0PRTA-134 . . . . . . . . . . . . . . . . . . . . . . 6.6 14.0PRTC-203 . . . . . . . . . . . . . . . . . . . . . . 8.9 19.0PRS-16 . . . . . . . . . . . . . . . . . . . . . . . 12.8 27.0PS-100 . . . . . . . . . . . . . . . . . . . . . . . 9.5 20.0PS-150 . . . . . . . . . . . . . . . . . . . . . . . 10.4 22.0PS-200 . . . . . . . . . . . . . . . . . . . . . . . 18.0 38.0PS-260 . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PS-270 . . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PS-310 . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0PS-500 . . . . . . . . . . . . . . . . . . . . . . . 27.4 58.0PSC-204 . . . . . . . . . . . . . . . . . . . . . . . 13.7 29.0PSC-593 . . . . . . . . . . . . . . . . . . . . . . . 13.0 28.0PSC-1615 . . . . . . . . . . . . . . . . . . . . . . 18.9 40.0PSC-1617 . . . . . . . . . . . . . . . . . . . . . . 18.9 40.0PSC-1875 . . . . . . . . . . . . . . . . . . . . . . 26.4 56.0PSC-4564 . . . . . . . . . . . . . . . . . . . . . . 27.4 58.0PSM-826 . . . . . . . . . . . . . . . . . . . . . . . 19.9 42.0PSM-1044 . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PSM-1045 . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PSM-1614 . . . . . . . . . . . . . . . . . . . . . . 20.8 44.0PSTM-824 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0SPRC-1356: w/85 inch track . . . . . . . . 15.1 32.0
w/90 inch track . . . . . . . . . . . . . . . . 15.9 33.5w/100 inch track . . . . . . . . . . . . . . . 17.0 36.0
SPRC-1357: front . . . . . . . . . . . . . . . . 15.1 32.0rear . . . . . . . . . . . . . . . . . . . . . . . 15.9 33.5
SPRC-1357: w/85 inch track . . . . . . . . 15.1 32.0w/90 inch track . . . . . . . . . . . . . . . . 15.9 33.5w/100 inch track . . . . . . . . . . . . . . . 17.0 36.0
SPRC-1735: w/85 inch track . . . . . . . . 15.1 32.0w/90 inch track . . . . . . . . . . . . . . . . 15.9 33.5w/100 inch track . . . . . . . . . . . . . . . 17.0 36.0
SPRC-1736: front . . . . . . . . . . . . . . . . 17.0 36.0
rear . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0SPRC-1736: w/85 inch track . . . . . . . . 15.1 32.0
w/90 inch track . . . . . . . . . . . . . . . . 15.9 33.5w/100 inch track . . . . . . . . . . . . . . . 17.0 36.0
SPRC-1926 . . . . . . . . . . . . . . . . . . . . . 15.1 32.0SPRC-4806: standard . . . . . . . . . . . . . 31.0 64.0
wide track . . . . . . . . . . . . . . . . . . . . 34.0 72.0
TRIPLE AXLESCAPACITIES Liters PtELHD: Front, Middle . . . . . . . . . . . . . . 15.42 32.52
Rear . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0ERLHD: Front . . . . . . . . . . . . . . . . . . . 18.5 39.0
Middle . . . . . . . . . . . . . . . . . . . . . . . 15.4 32.5Rear . . . . . . . . . . . . . . . . . . . . . . . 15.1 32.0
ERQHD:Front, Middle . . . . . . . . . . . . . 18.5 39.0Middle . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.0Rear . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0
EQHD: Front, Middle . . . . . . . . . . . . . . 16.12 34.02
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0ESQHD: Front , Middle . . . . . . . . . . . . 16.1 34.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 14.7 31.0RZ-166: Front . . . . . . . . . . . . . . . . . . . 18.5 39.1
Middle . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.1Rear . . . . . . . . . . . . . . . . . . . . . . . 16.3 34.4
RZ-186: Front . . . . . . . . . . . . . . . . . . . 26.5 56.1Middle . . . . . . . . . . . . . . . . . . . . . . . 18.5 39.1Rear . . . . . . . . . . . . . . . . . . . . . . . 16.3 34.4
RZ-188: Front . . . . . . . . . . . . . . . . . . . 26.5 56.1Middle . . . . . . . . . . . . . . . . . . . . . . . 26.5 56.1Rear . . . . . . . . . . . . . . . . . . . . . . . 17.1 36.1
TORQUE DIVIDERCAPACITIES Liters PtT-50 . . . . . . . . . . . . . . . . . . . . . . . 4.0 8.5T-70 . . . . . . . . . . . . . . . . . . . . . . . 11.43 24.03
FRONT DRIVE AXLESCAPACITIES Liters PtFDS-78 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0FDS-85 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0FDS-90 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0FDS-93 . . . . . . . . . . . . . . . . . . . . . . . 6.2 13.0FDS-750 . . . . . . . . . . . . . . . . . . . . . . . 6.5 13.9FDS-1600 . . . . . . . . . . . . . . . . . . . . . . 9.9 21.0FDS-1800 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-1805 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-1807 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-1808 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-2100 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-2101 . . . . . . . . . . . . . . . . . . . . . . 13.2 28.0FDS-2102 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0FDS-2107 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0FDS-2110 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0FDS-2111 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0MX-10-120 . . . . . . . . . . . . . . . . . . . . . 9.0 20.0MX-12-120 . . . . . . . . . . . . . . . . . . . . . 9.0 20.0MX-14-120 . . . . . . . . . . . . . . . . . . . . . 9.0 20.0MX-16-120 . . . . . . . . . . . . . . . . . . . . . 9.0 20.0MX-23-160 . . . . . . . . . . . . . . . . . . . . . 20.0 43.0FDS-2117 . . . . . . . . . . . . . . . . . . . . . . 20.3 43.0RF-7-1061 . . . . . . . . . . . . . . . . . . . . . . 6.6 14.0RF-7-120 . . . . . . . . . . . . . . . . . . . . . . 7.0 15.0RF-9-1061 . . . . . . . . . . . . . . . . . . . . . . 6.6 14.0RF-9-120, RF-12-120 . . . . . . . . . . . . . 7.0 15.0RF-12-1251 . . . . . . . . . . . . . . . . . . . . . 7.2 15.3RF-16-1451 . . . . . . . . . . . . . . . . . . . . . 17.2 36.4RF-21-1551 . . . . . . . . . . . . . . . . . . . . . 13.2 27.9RF-21-1561 . . . . . . . . . . . . . . . . . . . . . 13.2 27.9RF-21-1601 . . . . . . . . . . . . . . . . . . . . . 20.7 43.7RF-21-3551 . . . . . . . . . . . . . . . . . . . . . 13.2 28.0RF-22-166 . . . . . . . . . . . . . . . . . . . . . . 20.0 43.0RF-23-1801 . . . . . . . . . . . . . . . . . . . . . 18.6 39.3
Oil capacities are for standard track axles that have been measured atvarious common drive pinion angles. The quantities listed includeenough oil for both wheel ends. These oil capacities will change if thetrack or the driven pinion angle is different.
1 Following overhaul, add to pinioncage through plug ....................................... 0.9 2.0
2 When new or reconditioned drive unit is installed, add to inter-axle differential .................................................... 0.9 2.0
3 Forward carrier with oil pump system.
SPICER/DANAStandard Differentials . . . . . . . . . . . . . . . . .GL-5Limited-Slip Differentials . . . . . . . . . . . . . .GL-5★
Above 40°F (4°C), 140Above 10°F (-12°C), 85W-140Above -15°F (-26°C), 80W-14010° to 100°F (-12° to 38°C), 90-15° to 100°F (-26° to 38°C), 80W-90-15° to 70°F (-26° to 21°C), 80W-40° to 32°F (-40° to 0°C), 75WAll temperatures for GM medium duty synthetic
75W-90CAPACITIES Liters PtD135-S . . . . . . . . . . . . . . . . . . . . . . . 8.5 18.0F155-S . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0G175-T . . . . . . . . . . . . . . . . . . . . . . . 11.8 25.0G185-S . . . . . . . . . . . . . . . . . . . . . . . 14.2 30.0G190-S . . . . . . . . . . . . . . . . . . . . . . . 14.0 30.0G190-T . . . . . . . . . . . . . . . . . . . . . . . 17.0 36.0G400-S: Front . . . . . . . . . . . . . . . . . . . 15.9 32.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 10.6 23.0J170-S . . . . . . . . . . . . . . . . . . . . . . . 11.4 24.0J175-S . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.0J190-S . . . . . . . . . . . . . . . . . . . . . . . 16.1 34.0J220-S . . . . . . . . . . . . . . . . . . . . . . . 15.0 32.0J340-S: Front . . . . . . . . . . . . . . . . . . . 15.0 32.0
Rear . . . . . . . . . . . . . . . . . . . . . . . 11.3 24.0J380-S: Front . . . . . . . . . . . . . . . . . . . 14.5 30.6
Rear . . . . . . . . . . . . . . . . . . . . . . . 10.7 22.0M-50F . . . . . . . . . . . . . . . . . . . . . . . 2.1 4.4M185-T . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.0M190-T, 220-S, 220-T . . . . . . . . . . . . . 16.6 35.0S-150S . . . . . . . . . . . . . . . . . . . . . . . 13.01 27.61
W230-S . . . . . . . . . . . . . . . . . . . . . . . 16.6 35.028 . . . . . . . . . . . . . . . . . . . . . . . 0.5 1.030, 30F . . . . . . . . . . . . . . . . . . . . . . . 1.2 2.544, 44-1, 44-3 . . . . . . . . . . . . . . . . . . . 1.4 3.044-1F . . . . . . . . . . . . . . . . . . . . . . . 1.7 3.560, 61 . . . . . . . . . . . . . . . . . . . . . . . 2.8 6.060-IU . . . . . . . . . . . . . . . . . . . . . . . 3.3 7.070, 70F . . . . . . . . . . . . . . . . . . . . . . . 3.2 6.870HD . . . . . . . . . . . . . . . . . . . . . . . 3.5 7.480 . . . . . . . . . . . . . . . . . . . . . . . 3.9 8.31 Includes 1.5L (3.1 pt) to fill hub cavities.
| 163 |
Index by Product Name
Index
Symbols
2000 ml Hand Cleaner Dispenser ............................47
A
A/C Cooling Coil Coating ..........................................28A/C System Flushing Solvent ...................................28Acid Neutralizer ........................................................40Additive Friction Modifier ..........................................20Adhesion Promoter ...................................................50Alkaline Neutralizer ..................................................40Anti-Corrosion Coating .............................................36Anti-Gel & Performance Improver
(ULSD Compliant) ..........................................32Argent Spray Paint ...................................................50
B
Bug and Tar Remover ...............................................40
C
Carburetor Tune-Up Cleaner ....................................32Cetane Booster & Performance Improver
(ULSD Compliant) ..........................................33Choke and Linkage Cleaner .....................................33Clear Silicone Rubber ..............................................52Constant Velocity Joint Grease (High Temp) ............23Continuously Variable Chain Type
Transmission Fluid .........................................17Cooling System Stop Leak Pellets ...........................29Custom Bright Metal Cleaner ...................................41Custom Clear Coat Polish ........................................41Custom Vinyl Protectant ...........................................41
D
Dash and Vinyl Cleaner ............................................42Deluxe Leather and Vinyl Cleaner ............................42Deluxe Leather Care Kit ...........................................42Detail Wash ..............................................................43Diesel Cooling System Additive ................................29Dusting Cloth ............................................................43
E
Electrical Grease ......................................................23Engine Shampoo and Degreaser .............................43Exterior Lacquer Touch-Up Paints –
2-in-1 Brush-in-Tube/Pen Tip .........................51
F
FNR5 Automatic Transmission Fluid ........................17Full Synthetic Manual Transmission Fluid ................18
G
Gasket Maker ...........................................................55Gas Stabilizer ...........................................................33
H
Heavy Duty Hand Cleaner ........................................47Heavy Truck PAG Refrigerant Compressor Oil ........30High Contrast Hypoid Gear Marking
Compound ................................................21, 23High Performance DOT 3 Motor Vehicle
Brake Fluid .....................................................34High Performance Engine RTV Silicone ...................53High Temperature 4X4 Front Axle and
Wheel Bearing Grease ...................................23High Temperature Nickel Anti-Seize Lubricant .........24Hypoid Gear Oil SAE 90 ...........................................21
I
Instant Gel Adhesive ................................................56Interior Spray Lacquer ..............................................50Interior Spray Paint ...................................................51Isopropanol Cleaning Kit ....................................36, 56
M
Manual Dual Cartridge Applicator Gun .....................36MERCON® LV Automatic Transmission Fluid ..........16MERCON® SP Automatic Transmission Fluid .........15MERCON® V Automatic Transmission
and Power Steering Fluid ...............................15Metal Bonding Adhesive ...........................................37Metal Brake Parts Cleaner .......................................34Metal Surface Prep .............................................37, 54Mini-Vent Window Lube ............................................24Multi-Purpose Grease ..............................................24
N
Natural Citrus Hand Cleaner ....................................49Nitrile Technician Gloves ..........................................48
O
Orange Pumice Hand Cleaner .................................47
P
PAG Refrigerant Compressor Oil .............................28Penetrating and Lock Lubricant ................................25Plastic Bonding Adhesive .........................................37Pneumatic Dual Cartridge Applicator Gun ................38Power Flush Injector Fluid ........................................34Premium Automatic Transmission Fluid ...................17Premium Cooling System Flush ...............................30
| 164 |
Index by Product Name
Index
Premium Engine Coolant with Bittering Agent ..........30Premium Fuel Injector Cleaner .................................35Premium Gold Engine Coolant
with Bittering Agent .........................................31Premium Liquid Wax ................................................44Premium Long-Life Grease ......................................25Premium Power Steering Fluid .................................27Premium Undercoating .............................................38Premium Windshield Washer Concentrate ...............44Pressurized Fuel Injector Cleaner ............................35Professional Skin Conditioner ..................................48Professional Skin Conditioner Dispenser .................48Professional Strength Carpet and
Upholstery Cleaner .........................................44PTFE Lubricant ........................................................25
R
R-134a Refrigerant ...................................................29Rear View Mirror Adhesive .......................................56Rear View Mirror Button Adhesive ............................57Rear Window Defroster Repair ................................57Roof Ditch Sealer .....................................................38RTV Silicone Sealant ................................................53Rust Inhibitor ............................................................39
S
SAE 0W-30 Super All Season Motor Oil ...................14SAE 10W-30 Premium Synthetic Blend Motor Oil ....11SAE 10W-30 Super Duty Diesel Motor Oil ...............13SAE 10W-40 Premium Motor Oil ..............................11SAE 15W-40 Super Duty Diesel Motor Oil ...............12SAE 30 Super Duty Diesel Motor Oil ........................14SAE 5W-20 Full Synthetic Motor Oil ...........................8SAE 5W-20 High Mileage Synthetic
Blend Motor Oil .................................................9SAE 5W-20 Premium Synthetic Blend Motor Oil ........8SAE 5W-30 Full Synthetic Motor Oil .........................10SAE 5W-30 High Mileage Synthetic
Blend Motor Oil ...............................................10SAE 5W-30 Premium Synthetic Blend Motor Oil ........9SAE 5W-40 Full Synthetic Diesel Motor Oil ..............13SAE 5W-50 Full Synthetic Motor Oil .........................12SAE 75W-140 Synthetic Rear Axle Lubricant ...........19SAE 75W-90 API GL-4 Gear Oil ...............................18SAE 75W-90 Premium Synthetic
Transaxle Lubricant ........................................20SAE 75W-90 Specialty Power Transfer Unit Fluid ....21SAE 75W-90 Synthetic Transaxle Lubricant .............20SAE 80W-90 Premium Rear Axle Lubricant .............19Seam Sealer .............................................................39Silicone Brake Caliper Grease and
Dielectric Compound ................................26, 35
Silicone Gasket and Sealant ....................................52Silicone Gasket Remover .........................................53Silicone Heat Transfer Compound ...........................26Silicone Spray Lubricant ...........................................26Specialty Orange Engine Coolant
with Bittering Agent .........................................31Spot and Stain Remover ..........................................45Stud and Bearing Mount ...........................................55Synthetic MERCON® Multi-Purpose
Automatic Transmission Fluid ........................16Synthetic Supercharger Fluid ...................................26
T
Threadlock 262 .........................................................54Threadlock and Sealer .............................................55Thread Sealant with PTFE .......................................54Tire Clean and Shine ................................................45Transfer Case Fluid ..................................................22Trim and Weatherstrip Adhesive ..............................39Triple Clean ..............................................................45Type F Automatic Transmission Fluid and
Power Steering Fluid ......................................18
U
Ultra-Clear Spray Glass Cleaner ............................. 46Ultra Silicone Sealant .............................................. 52
W
Wheel and Tire Cleaner ........................................... 46
| 165 |
Index by Part NumberC
CM-1001 ................................................................... 35CXO-0W30-DAS....................................................... 14CXO-0W30-LAS12 ................................................... 14
D
D2AZ-19590-A .......................................................... 25
F
F4AZ-19503-C .......................................................... 51F4AZ-19503-D .......................................................... 51F4MY-19503-C ......................................................... 51F7AZ-17698-AA ........................................................ 57F7AZ-17698-BA ........................................................ 57F7AZ-3F823-BA ....................................................... 27
M
M4JZ-19M547-XXXXH ............................................. 50
P
PM-1-C ..................................................................... 34PM-1-Q ..................................................................... 34PM-11 ....................................................................... 57PM-13-A ................................................................... 36PM-14 ....................................................................... 33PM-16 ....................................................................... 33PM-19A316-AA ......................................................... 50PM-19K207-AA ......................................................... 50PM-19M547-XXXXH ................................................ 51PM-2 ....................................................................... 32PM-22-A ................................................................... 33PM-22-ASU .............................................................. 33PM-22-GAL ............................................................... 33PM-23-A ................................................................... 32PM-23-ASU .............................................................. 32PM-23-GAL ............................................................... 32PM-24-A ................................................................... 39PM-24-B ................................................................... 39PM-25-A ................................................................... 38PM-25-B ................................................................... 38PM-3 ....................................................................... 32PM-4-A...................................................................... 34PM-4-B ..................................................................... 34PM-5 ....................................................................... 34PM-6 ....................................................................... 35PMP-19500-1000 ..................................................... 51PMP-19500-6000 ..................................................... 51PMP-19500-XXXXX ................................................. 51
T
TA-1 ....................................................................... 37TA-10 ....................................................................... 36TA-11 ....................................................................... 38TA-14-A ..................................................................... 39TA-15 ....................................................................... 38TA-16 ....................................................................... 55TA-17 ....................................................................... 56TA-19 ....................................................................... 56TA-2 ....................................................................... 39TA-24 ....................................................................... 54TA-25 ....................................................................... 55TA-26 ....................................................................... 54TA-27 ....................................................................... 55TA-29 ....................................................................... 52TA-30 ....................................................................... 52TA-31 ....................................................................... 53TA-32 ....................................................................... 52TA-357 ...................................................................... 53TA-9 ....................................................................... 37
V
VC-1 ....................................................................... 30VC-3 ....................................................................... 31VC-5 ....................................................................... 30VC-5-B ...................................................................... 30VC-6 ....................................................................... 29VC-7-B ...................................................................... 31VC-7-D ...................................................................... 31VC-8 ....................................................................... 29
X
XG-1-C ..................................................................... 25XG-1-K...................................................................... 25XG-11 ....................................................................... 23XG-12 ....................................................................... 23XG-14 ................................................................. 21, 23XG-3-A ................................................................ 26, 35XG-4 ....................................................................... 24XG-5 ....................................................................... 23XG-6 ....................................................................... 26XG-8 ....................................................................... 25XL-1 ....................................................................... 25XL-10 ....................................................................... 24XL-12 ....................................................................... 22XL-2 ....................................................................... 24XL-3 ....................................................................... 20XL-4 ....................................................................... 26XL-5 ....................................................................... 24XL-6 ....................................................................... 26XL-9 ....................................................................... 27
Index
| 166 |
Index by Part NumberXO-10W40-DP ...........................................................11XO-5W30-QHM ........................................................ 10XO-10W30-DSD ....................................................... 13XO-10W30-DSP ........................................................11XO-10W30-QSD ....................................................... 13XO-10W30-QSP ........................................................11XO-10W40-QP ..........................................................11XO-15W40-5QSD ..................................................... 12XO-15W40-DSD ....................................................... 12XO-15W40-QSD ....................................................... 12XO-30-QSD .............................................................. 14XO-5W20-QHM .......................................................... 9XO-5W20-5QSP ......................................................... 8XO-5W20-DFS ........................................................... 8XO-5W20-DSP ........................................................... 8XO-5W20-QFS ........................................................... 8XO-5W20-QSP ........................................................... 8XO-5W30-5QSP ......................................................... 9XO-5W30-DFS ......................................................... 10XO-5W30-DSP ........................................................... 9XO-5W30-QFS ......................................................... 10XO-5W30-QSP ........................................................... 9XO-5W40-5QSD ....................................................... 13XO-5W40-DSD ......................................................... 13XO-5W50-QGT ......................................................... 12XT-1-QF .................................................................... 18XT-10-QLV ................................................................ 16XT-2-QSM ................................................................. 16XT-5-5QM ................................................................. 15XT-5-DM ................................................................... 15XT-5-DMC ................................................................. 15XT-5-GM ................................................................... 15XT-5-QM ................................................................... 15XT-5-QMC ................................................................ 15XT-6-DSP ................................................................. 15XT-6-QSP ................................................................. 15XT-7-QCFT ............................................................... 17XT-75W90-QGL ........................................................ 18XT-75W90-QGT ........................................................ 20XT-75W90-QLS ........................................................ 20XT-8-QAW ................................................................ 17XT-9-QMM5 .............................................................. 17XT-M5-QS ................................................................. 18XY-75W140-QL ......................................................... 19XY-75W90-PTU ........................................................ 21XY-80W90-KL ........................................................... 19XY-80W90-QL ........................................................... 19XY-90-GL .................................................................. 21
Y
YN-12-D.................................................................... 28YN-19 ....................................................................... 29YN-21 ....................................................................... 29YN-23 ....................................................................... 28YN-24 ....................................................................... 30YN-29 ....................................................................... 28
Z
ZC-1-A ...................................................................... 40ZC-11-A .................................................................... 42ZC-11-D .................................................................... 42ZC-13 ....................................................................... 45ZC-14 ....................................................................... 45ZC-15 ....................................................................... 41ZC-2-A ...................................................................... 40ZC-20 ....................................................................... 43ZC-22 ....................................................................... 49ZC-23 ....................................................................... 46ZC-24 ....................................................................... 43ZC-28 ....................................................................... 45ZC-3-A ...................................................................... 43ZC-30 ....................................................................... 53ZC-31-A .............................................................. 37, 54ZC-32-A .................................................................... 44ZC-32-B .................................................................... 44ZC-32-C .................................................................... 44ZC-37-A .................................................................... 46ZC-38-A .................................................................... 42ZC-4 ................................................................. 36, 56ZC-40-A .................................................................... 41ZC-42 ....................................................................... 40ZC-48 ....................................................................... 47ZC-49 ....................................................................... 47ZC-50 ....................................................................... 48ZC-51 ....................................................................... 47ZC-52 ....................................................................... 48ZC-53-A .................................................................... 44ZC-54 ....................................................................... 44ZC-55-L .................................................................... 48ZC-55-XL .................................................................. 48ZC-8-A ...................................................................... 41ZC-8-B ...................................................................... 41
Index
| 167 |
Index by TopicA
A/CA/C Cooling Coil Coating ...................................... 28A/C System Flushing Solvent ............................... 28
AdditiveAdditive Friction Modifier ....................................... 20Diesel Cooling System Additive ............................ 29
AdhesiveInstant Gel Adhesive ............................................. 56Metal Bonding Adhesive ....................................... 37Plastic Bonding Adhesive ...................................... 37Rear View Mirror Adhesive ................................... 56Rear View Mirror Button Adhesive ........................ 57Trim and Weatherstrip Adhesive ........................... 39
Applicator GunManual Dual Cartridge Applicator Gun ................. 36Pneumatic Dual Cartridge Applicator Gun ............ 38
Automatic Transmission FluidFNR5 Automatic Transmission Fluid ..................... 17MERCON® LV Automatic Transmission Fluid ...... 16MERCON® SP Automatic Transmission Fluid ...... 15Premium Automatic Transmission Fluid ................ 17Synthetic MERCON® Multi-Purpose Automatic
Transmission Fluid ........................................ 16Type F Automatic Transmission Fluid and Power
Steering Fluid ................................................ 18
B
Bittering AgentPremium Engine Coolant with Bittering Agent ...... 30Premium Gold Engine Coolant
with Bittering Agent ........................................ 31Specialty Orange Engine Coolant
with Bittering Agent ........................................ 31Brake
High Performance DOT 3 Motor Vehicle Brake Fluid .................................................... 34
Metal Brake Parts Cleaner .................................... 34Silicone Brake Caliper Grease and Dielectric
Compound ............................................... 26, 35
C
Cleaner2000 ml Hand Cleaner Dispenser ......................... 47Carburetor Tune-Up Cleaner ................................ 32Choke and Linkage Cleaner ................................. 33Custom Bright Metal Cleaner ................................ 41Dash and Vinyl Cleaner ........................................ 42Deluxe Leather and Vinyl Cleaner ........................ 42Heavy Duty Hand Cleaner .................................... 47Metal Brake Parts Cleaner .................................... 34
Natural Citrus Hand Cleaner ................................. 49Orange Pumice Hand Cleaner .............................. 47Premium Fuel Injector Cleaner ............................. 35Pressurized Fuel Injector Cleaner ......................... 35Professional Strength Carpet and
Upholstery Cleaner ........................................ 44Ultra-Clear Spray Glass Cleaner .......................... 46Wheel and Tire Cleaner ........................................ 46
CoolingA/C Cooling Coil Coating ...................................... 28Cooling System Stop Leak Pellets ........................ 29Diesel Cooling System Additive ............................ 29Premium Cooling System Flush ............................ 30
D
DieselDiesel Cooling System Additive ............................ 29SAE 10W-30 Super Duty Diesel Motor Oil ............ 13SAE 15W-40 Super Duty Diesel Motor Oil ............ 12SAE 30 Super Duty Diesel Motor Oil .................... 14SAE 5W-40 Full Synthetic Diesel Motor Oil .......... 13
DustingDusting Cloth ........................................................ 43
G
GasGas Stabilizer ........................................................ 33
GasketGasket Maker ........................................................ 55Silicone Gasket and Sealant ................................. 52Silicone Gasket Remover ..................................... 53
Gear OilHypoid Gear Oil SAE 90 ....................................... 21SAE 75W-90 API GL-4 Gear Oil ........................... 18
GlassUltra-Clear Spray Glass Cleaner .......................... 46
GreaseConstant Velocity Joint Grease (High Temp) ........ 23Electrical Grease ................................................... 23High Temperature 4X4 Front Axle and
Wheel Bearing Grease .................................. 23Multi-Purpose Grease ........................................... 24Premium Long-Life Grease ................................... 25Silicone Brake Caliper Grease and
Dielectric Compound ............................... 26, 35
H
Hand Cleaner2000 ml Hand Cleaner Dispenser ......................... 47Heavy Duty Hand Cleaner .................................... 47Natural Citrus Hand Cleaner ................................. 49Orange Pumice Hand Cleaner .............................. 47
Index
| 168 |
Index by TopicHypoid
High Contrast Hypoid Gear Marking Compound ................................. 21, 23
Hypoid Gear Oil SAE 90 ....................................... 21
L
LeatherDeluxe Leather and Vinyl Cleaner ........................ 42Deluxe Leather Care Kit ........................................ 42
LubricantHigh Temperature Nickel Anti-Seize Lubricant ...... 24Penetrating and Lock Lubricant ............................ 25PTFE Lubricant ..................................................... 25SAE 75W-140 Synthetic Rear Axle Lubricant ....... 19SAE 75W-90 Premium Synthetic
Transaxle Lubricant ....................................... 20SAE 75W-90 Synthetic Transaxle Lubricant ......... 20SAE 80W-90 Premium Rear Axle Lubricant ......... 19Silicone Spray Lubricant ....................................... 26
M
Manual Transmission FluidFull Synthetic Manual Transmission Fluid ............. 18
MERCONMERCON® LV Automatic Transmission Fluid ...... 16MERCON® SP Automatic Transmission Fluid ...... 15MERCON® V Automatic Transmission
and Power Steering Fluid .............................. 15Synthetic MERCON® Multi-Purpose
Automatic Transmission Fluid ....................... 16Metal
Custom Bright Metal Cleaner ................................ 41Metal Bonding Adhesive ....................................... 37Metal Brake Parts Cleaner .................................... 34Metal Surface Prep ......................................... 37, 54
Motor OilSAE 0W-30 Super All Season Motor Oil ............... 14SAE 10W-30 Premium Synthetic Blend Motor Oil 11SAE 10W-30 Super Duty Diesel Motor Oil ............ 13SAE 10W-40 Premium Motor Oil .......................... 11SAE 15W-40 Super Duty Diesel Motor Oil ............ 12SAE 30 Super Duty Diesel Motor Oil .................... 14SAE 5W-20 Full Synthetic Motor Oil ....................... 8SAE 5W-20 High Mileage Synthetic
Blend Motor Oil ................................................ 9SAE 5W-20 Premium Synthetic Blend Motor Oil .... 8SAE 5W-30 Full Synthetic Motor Oil ..................... 10SAE 5W-30 High Mileage Synthetic
Blend Motor Oil .............................................. 10SAE 5W-30 Premium Synthetic Blend Motor Oil .... 9SAE 5W-40 Full Synthetic Diesel Motor Oil .......... 13SAE 5W-50 Full Synthetic Motor Oil ..................... 12
N
NeutralizerAcid Neutralizer ..................................................... 40Alkaline Neutralizer ............................................... 40
P
PAGHeavy Truck PAG Refrigerant Compressor Oil ..... 30PAG Refrigerant Compressor Oil .......................... 28
PaintArgent Spray Paint ................................................ 50Exterior Lacquer Touch-Up Paints –
2-in-1 Brush-in-Tube/Pen Tip ........................ 51Interior Spray Paint ............................................... 51
PlasticPlastic Bonding Adhesive ...................................... 37
Power Steering FluidMERCON® V Automatic Transmission
and Power Steering Fluid .............................. 15Premium Power Steering Fluid ............................. 27Type F Automatic Transmission Fluid
and Power Steering Fluid .............................. 18PTFE
PTFE Lubricant ..................................................... 25Thread Sealant with PTFE .................................... 54
R
Rear Axle LubricantSAE 75W-140 Synthetic Rear Axle Lubricant ....... 19SAE 80W-90 Premium Rear Axle Lubricant ......... 19
RefrigerantHeavy Truck PAG Refrigerant Compressor Oil ..... 30PAG Refrigerant Compressor Oil .......................... 28R-134a Refrigerant ............................................... 29
S
Sealant/SealerRoof Ditch Sealer .................................................. 38RTV Silicone Sealant ............................................ 53Seam Sealer ......................................................... 39Silicone Gasket and Sealant ................................. 52Threadlock and Sealer .......................................... 55Thread Sealant with PTFE .................................... 54Ultra Silicone Sealant ............................................ 52
T
ThreadThreadlock 262 ..................................................... 54Threadlock and Sealer .......................................... 55Thread Sealant with PTFE .................................... 54
Index
| 169 |
Index by TopicTire
Tire Clean and Shine ............................................ 45Wheel and Tire Cleaner ........................................ 46
TransaxleSAE 75W-90 Premium Synthetic
Transaxle Lubricant ....................................... 20SAE 75W-90 Synthetic Transaxle Lubricant ......... 20
TransmissionContinuously Variable Chain Type
Transmission Fluid ........................................ 17FNR5 Automatic Transmission Fluid ..................... 17Full Synthetic Manual Transmission Fluid ............. 18MERCON® LV Automatic Transmission Fluid ...... 16MERCON® SP Automatic Transmission Fluid ...... 15MERCON® V Automatic Transmission
and Power Steering Fluid .............................. 15Premium Automatic Transmission Fluid ................ 17Synthetic MERCON® Multi-Purpose
Automatic Transmission Fluid ....................... 16Type F Automatic Transmission Fluid
and Power Steering Fluid .............................. 18
V
VinylCustom Vinyl Protectant ....................................... 41Dash and Vinyl Cleaner ........................................ 42Deluxe Leather and Vinyl Cleaner ........................ 42
W
WindshieldPremium Windshield Washer Concentrate ........... 44
Index