ministry of defence · assembly to the chassis, is fitted to prevent the drive train becoming live...
TRANSCRIPT
UNCLASSIFIED
DE&S Secretariat Land Equipment
Ministry of Defence
DESSEC-PolSec [email protected]
Defence Equipment & Support Maple Oa #2043
MOD Abbey Wood Bristol BS34 8JH
3-Nov-17 Our Reference:F012017/09738
Thank you for your e-mail dated 9 October 2017, requesting the following information:
As written in your reply, I want to specify the information:
Please have a look within the AESP 2320-D-128-302 and there specific within the ELECTRICAL section. There must be included wiring-diagrams about the Land Rover Defender, to be more specific, regarding the wiring of the light switch.
I am treating your correspondence as a request for information under the Freedom of Information Act 2000(FOIA).
A search for the information has now been completed within the Ministry of Defence, and I can confirm that information in scope of your request is held. The information you have requested can be found attached.
If you have any queries regarding the content of this letter, please contact this office in the first instance.
If you wish to complain about the handling of your request, or the content of this response, you can request an independent internal review by contacting the Information Rights Compliance team, Ground Floor, MOD Main Building, Whitehall, SW1A 2HB (e-mail [email protected]). Please note that any request for an internal review should be made within 40 working days of the date of this response.
If you remain dissatisfied following an internal review, you may raise your complaint directly to the Information Commissioner under the provisions of Section 50 of the Freedom of Information Act. Please note that the Information Commissioner will not normally investigate your case until the MOD internal review process has been completed. The Information Commissioner can be contacted at: Information Commissioner's Office, Wycliffe House, Water Lane, Wilmslow, Cheshire, SK9 5AF. Further details of the role and powers of the Information Commissioner can be found on the Commissioner's website at https://ico.org.ukt.
Yours Sincerely
DE&S Secretariat Land Equipment
1
UNCLASSIFIED
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION
CHAPTER 13-1
ELECTRICAL SYSTEMS
CONTENTS
Para
1 Introduction 2 General 3 Electrical systems 4 Engine harness assembly 6 Chassis harness assembly 8 Main cable assembly harness 10 How to use the circuit diagrams 11 Power distribution 12 Headers, splices and centre taps 13 Wire attributes 14 Connectors 15 Earth distribution 16 Line types 18 Components 19 Earth points 20 Fuses and diodes
Fig
1 2 3 4 5 6
Engine harness layout
Chassis harness layout
Main cable assembly harness layout
Power distribution
Connectors
Line types I
Page
11 13 15 16 17 17
7 Line types ii .1 7 I /
8 Components 18
9 Earth points 18
10 Fuses and diodes 18
11 Earth distribution I - Non EEGR 19
12 Earth distribution II - Non EEGR 20
13 Header joints - Non EEGR 21
14 Instruments I - Non EEGR 22
15 Instruments II - Non EEGR 23
16 Power distribution 1- Non EEGR 24
17 Power distribution II - Non EEGR 25
18 Power distribution III - Non EEGR 26
19 Splices and centre taps 1- Non EEGR 27
20 Splices and centre taps II - Non EEGR 28
21 Splices and centre taps III - Non EEGR 29
22 Charging and starting 1- Non EEGR 30
23 Charging and starting II - Non EEGR 31
24 Interior illumination - Non EEGR 32
25 Indicators and Hazards 1— Non EEGR 33
26 Indicators and Hazards 11— Non EEGR 34
27 Earth distribution 1- EEGR 35
28 Earth distribution 11- EEGR 36
(continued)
Chap 13-1
Aug 00 (Amdt 1) Page 1
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
CONTENTS (continued)
Fig Page
29 Header joints - EEGR 37 30 Instruments I - EEGR 38 31 Instruments II - EEGR 39 32 Power distribution I - EEGR 40 33 Power distribution II - EEGR 41 34 Power distribution III - EEGR 42 35 Splices and centre taps I - EEGR 43 36 Splices and centre taps II - EEGR 44 37 Splices and centre taps III - EEGR 45 38 Splices and centre taps IV - EEGR 46 39 Charging and starting I - EEGR 47 40 Charging and starting II - EEGR 48 41 Interior illumination - EEGR 49 42 Indicators and Hazards I - EEGR 50 43 Indicators and Hazards II - EEGR 51 44 EEGR 52 45 Brake reverse lamps 53 46 Fog lamps 54 47 Headlamp levelling 55 48 Horn 56 49 Trailer socket 57 50 Head, side and number plate lamps I 58 51 Head, side and number plate lamps II 59 52 Wipers and washers — front 60 53 Heater 61 54 Interior lamps 62
INTRODUCTION
1 This chapter gives a Technical Description for the 24 volt electrical system as fitted to the Truck Utility Light (TUL) HS, and Truck Utility Medium (TUM) HS.
General
2 The information given is applicable to both LH and RH drive vehicles.
ELECTRICAL SYSTEMS
3 The electrical systems on the TUL and TUM are made up of three main harnesses: Engine harness, Chassis harness and Main cable assembly harness. In addition, five supplementary harnesses/cables, covering vehicle battery, inter vehicle socket, convoy lamp, rear body com ponents and fuel system are fitted. Connected together these harnesses form the vehicle harness, which supplies power to the instrument panel, switches and controls, interior and exterior lighting. Each harness can be disconnected and separated individually.
Engine harness assembly
4 The engine harness assembly connects the various electrical components fitted on the engine to the vehicle batteries and main cable assembly harness (Fig 1).
4.1 When the starter switch is turned to position III, an electrical current is sent from the battery to the starter motor, which cranks the engine over.
Chap 13-1 Page 2 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION
4.2 When the engine is running, the single drive belt at the front of the engine turns the alternator,
which generates electricity to maintain operation of the vehicle and ancillary equipment.
4.3 The engine harness assembly is made up of the following items:
4.3.1 Alternator ECU Feed (FFR).
4.3.2 Twin alternator interlink (FFR).
4.3.3 Reverse switch.
4.3.4 Diff lock switch.
4.3.5 Fuel shut-off switch.
4.3.6 Oil pressure switch.
4.3.7 Water temperature switch.
4.3.8 Alternator connections.
4.4 There are various ancillary leads within the engine bay area that are not part of the engine
harness assembly, but functional to the engine itself. There are also leads supplying other
components within the electrical system, but will be mentioned in this paragraph.
4.5 Earth lead (part of negative earth cable). The earth lead, which connects the engine/gearbox
assembly to the chassis, is fitted to prevent the drive train becoming live and, therefore, prevent
electric shocks.
4.6 Low brake fluid level indicator. The lead runs from the top of the brake fluid reservoir to the main
cable harness and operates the brake warning light in the instrument panel should the fluid level
become low.
4.7 Brake pedal stop switch. The lead runs from the switch mounted on top of the brake pedal box
to the main cable assembly harness. The switch operates the stop lights at the rear of the vehicle
when the brake pedal is depressed.
5 The following list identifies the electrical components location and their harness route within the
engine bay area:
5.1 Water temperature switch lead. Routes from the thermostat housing through the engine
harness to the main cable assembly harness. Colours: Green/blue.
5.2 Engine harness leads (5 off). Routes from the starter solenoid to the main cable assembly
harness. Colours: White/red, Brown (4 off) Brown/light green (FFR).
5.3 Heater plug lead (2 off). Routes from the main cable assembly harness to No.1 heater plug on
the RH side of the cylinder head. Colours: Brown /red.
5.4 Heater plug connecting leads (3 off). Route from No.4 cylinder heater plug to the three other
heater plugs. Colours: Yellow/black.
5.5 Alternator leads (2 off). Route from the rear of the alternator through the engine harness
assembly to the main cable assembly harness. Colours: Brown/yellow, Brown.
5.6 Fuel cut-off solenoid lead. Routes fromt the fuel injection pump through the engine harness
assembly to the main cable assembly harness. Colours: White.
Chap 13-1
Aug 00 (Amdt 1) Page 3
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
5.7 Oil pressure switch lead. Routes from the oil filter housing through the engine harness assembly to the main cable assembly harness. Colours: White/brown.
5.8 Positive battery cable. Routes from the starter motor to the vehicle battery and inter vehicle socket. Colour: Red.
5.9 Negative earth cable. Routes from vehicle battery to inter vehicle socket and transfer box casing via chassis earthing point. Colour: Black.
5.10 Battery link cable. Links both batteries, negative to positive. Colour: Red.
5.11 Low brake fluid level indicator lead (3 off). Route from the brake fluid reservoir to the main cable assembly harness. Colour: Black/white, Black.
5.12 Brake pedal stop switch leads. Route to / from the pedal box to the main cable assembly harness. Colour: Green/purple, Green.
Chassis harness assembly
6 The chassis harness (Fig 2) connects the rear lamps and fuel tank to the main cable assembly harness. The stop lights and number plate lamp are connected directly to the chassis harness but the side, indicator, fog, and reverse lamps, share supplementary rear body harnesses. The convoy lamp and fuel tank have separate harnesses.
6.1 The chassis harness assembly is made up to connect to the following items:
6.1.1 Stop lights.
6.1.2 Convoy lamp.
6.1.3 Trailer socket.
6.1.4 Number plate lamp.
6.1.5 Rear lamps.
6.1.6 Rear fuel tank connection, (TUM and Field Ambulance only).
7 The following list identifies the electrical components location and their harness route along the chassis.
7.1 Stop lights. Route from stop lights to the main cable assembly harness. Colours: Green/purple, black.
7.2 Convoy lamp harness leads (2 off). One routing from the convoy lamp to the chassis harness 6 way connector, the other to earth. Colours: Red/brown, Black.
7.3 Trailer socket leads (12 off). Route from the rear chassis cross member to the chassis harness connecting on the inside of the vehicle. Colours: Unipren (yellow) with lettered identification tags to ensure correct connection to chassis harness leads as follows:
7.3.1 A - Red/brown, B - Green/purple, C - Red/brown, D - Black, E - Red/orange, F - Red/yellow, H - Red/brown, J - Green/purple, K - Purple, L - Black, M - Green/purple, N - Green/purple.
7.4 Number plate lamp leads (2 off). Route from the number plate lamp to bullet connectors on the chassis harness. Colours: Red/orange, black.
Chap 13-1 Page 4 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION
7.5 Gearbox earth leads (3 off). Colour: Black.
7.6 Rear tank leads (2 off, TUM only). Route from the fuel tank to the chassis harness via the 6 way
connector. Colours: Green/Black, black.
7.7 Chassis harness main connections. Connects the various electrical components, by way of
moulded connectors, to the main cable assembly.
7.7.1 Plug 1 (black) . Colours: Red/orange, Red/brown, Red/yellow, Green/red,
Green/white, Green/purple.
7.7.2 Plug 2 (white). Green/brown, White/black, Green, Brown/light green, Red/light
green, Purple.
7.8 Rear lamp harnesses. Separate harnesses, for LH and RH lamps, which connect to the chassis
harness assembly via two 6 way connectors. Colours: LH - Red/yellow, Green/red, Red/orange,
Black; RH - Green/brown, Red/yellow, Green/white, Red/orange, Black.
Main cable assembly harness
8 The main cable assembly harness connects to the front lamps, chassis harness, engine harness and
the various instruments, switches and indicators within the vehicle (Fig 3).
8.1 The main cable assembly harness is made up to connect to the following items:
8.1.1 Warning light panel.
8.1.2 Instrument panel.
8.1.3 Windscreen washer pump.
8.1.4 Wiper motor.
8.1.5 Horn/indicator/Dip switch.
8.1.6 ignition switch.
8.1.7 Hazard warning switch.
8.1.8 Rear fog switch.
8.1.9 Heater/blower motor.
8.1.10 Map reading lamp.
8.1.11 Main lighting switch.
8.1.12 Inspection sockets.
8.1.13 Relays.
8.1.14 Headlamp levelling switch.
8.1.15 Headlamps and side lamps.
8.1.16 Headlamp levelling motors.
8.1.17 Indicators.
Chap 13-1
Aug 00 (Amdt 1) Page 5
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
8.1.18 Brake fluid level switch.
8.1.19 Glow plug timer.
8.1.20 Main fuse box.
8.1.21 Side tank connections.
9 The following list identifies the electrical components, their location and harness route within the vehicle and engine bay area:
9.1 In-line resistors and diodes. Integral within the main cable assembly harness and are replaceable.
9.1.1 Diode leads (2 off). Colours: Brown/yellow, Yellow/brown.
9.1.2 In-line resistor leads (2 off). Colours: Yellow/blue, Blue/yellow.
9.2 Warning light leads. Grouped into two housings, which are plugged into the rear of the instrument binnacle and routed, to the main cable assembly harness.
9.3 Plug 1 (natural).
9.3.1 Oil pressure. Colours: White/brown, White, Brown/blue.
9.3.2 Ignition. Colours: Yellow/brown.
9.3.3 Brake circuit. Colours: Black/white.
9.3.4 Direction indicators. RH - Green/white, LH - Green/red.
9.4 Plug 2 (natural).
9.4.1 Trailer. Colours: Light green/purple.
9.4.2 Earth. Colours: Black.
9.4.3 Side lights. Colours: Red/black.
9.4.4 Fog lights. Colours: Red/yellow.
9.4.5 Main beam. Colours: Blue/white, Brown/light green.
9.4.6 Differential lock. Colours: Black/blue, White.
9.4.7 Glow plug. Colours: Yellow/black.
9.5 Wash/wipe switch. Located on the steering column and routed to the main harness assembly. (6 way moulded connector) Colours: Blue/light green, Light green/black, White/green, Yellow/light green, Red/light green, Green.
9.6 Horn, directional indicators, Dipswitch. Located on the steering column and routed to the main harness assembly. (8 way moulded connector) Colours: Blue, Green/white, Light green/brown, Green/red, Blue/white, Blue/red, Purple, Purple/black.
9.7 Hazard switch. Located on the fascia in the auxiliary switch panel, plugged into the rear of the panel and routed to the main harness assembly. (8 way black connector) Colours: Black/red, Light green/Brown, Green/red, Green/white, Light green, Purple, Green/yellow.
Chap 13-1 Page 6 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
9.8 In line resistor (4) 2.7k 0.5 watt. Located behind the fascia and routed into the main harness assembly. Colours: Yellow blue, Blue yellow.
9.9 Flash. (2 way natural connector) Colours: Green/red, green/white.
9.10 Rear fog switch. (5 way black connector) Located on the fascia in the auxiliary switch panel, plugged into the rear of the panel and routed to the main harness assembly. Colours: Blue/purple, Red/yellow.
9.11 Headlight level switch. (5 way natural connector) Located on the fascia in the auxiliary switch panel and routed to the main harness assembly. Colours: Blue/black, Yellow/blue, Green/blue.
9.12 Ignition switch. (4 single natural connectors) Located on the steering column and routed to the main harness assembly. Colours: Brown, Brown, White, White/orange, White/red.
9.13 In line resistor (1) 0.5 watt. Colours: blue/green, green/blue.
9.14 Instruments. Located on the fascia and plugged into the rear of the instrument binnacle. Routed to the main harness assembly (8 way connector natural connector). Colours: Green/blue, White/black, Black, Green, Green, Red/orange, Green/black, Purple.
9.15 Heater fan switch. Located on the fascia on the side of the instrument binnacle and plugged into the rear of the binnacle. Routed to the main harness assembly (3 way black connector). Colours: Green/slate, Green/yellow, Black.
9.16 Inspection sockets. Located in the centre panel of the fascia and plugged into the rear of the panel (2 single black connectors). Colours: Black, Brown.
9.17 Wiper motor. Located behind the fascia lower panel and plugged into the wiper motor. Routed to the main harness assembly (5 way grey connector). Colours: Black, Brown/light green, Blue/light green, Green, Green, Red/light green.
9.18 Blackout lighting. Located in the fascia centre panel, plugged into the rear of the panel and routed to the main harness assembly. (2 off 4 way connectors).
9.18.1 Plug 1 (black). Colours: Brown, Brown/white, Green/purple, Green/purple.
9.18.2 Plug 2 (natural). Colours: Red, Blue, Red, Red/brown.
9.19 Map reading light. (2 way natural connector) Located on the fascia in the centre panel, plugged into the rear of the panel and routed to the main harness assembly. Colours: Purple/white, Black,
9.20 Map reading light switch. (5 way black connector) Located on the fascia in the centre panel, plugged into the rear of the panel and routed to the main harness assembly. Colours: Purple/white, Purple,
9.21 Relays. Located below the fascia behind the fusebox cover. Routed into the main harness assembly.
9.21.1 Brake check relay (Green). Colours: Black, Black, White/red, White/yellow.
9.21.2 Start relay (Yellow). Colours: White/red, White/red, Black, Brown, Brown.
9.21.3 Ignition cont. relay (Red). Colours: White/yellow, White, Black, Brown/white.
9.21.4 Hazard/DI unit (Black) . Colours: Light green/purple, Light green, Black, Light green/Brown.
Chap 13-1 Aug 00 (Amdt 1) Page 7
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
9.21.5 Front wipe delay (Black). Colours: White/green, Yellow/light green, Black, Brown/light green, Light green/black, Green, Green.
9.22 Fusebox (20 way). Located below the fascia under the fusebox cover, routed into the main harness assembly. Colours: 1 Brown/white; 2 Brown/white; 3 White; 4 White/yellow; 5 White/orange: 6 Red/brown; 7 Brown; 8 Brown; 9 Brown; 10 Blue; 11 Blue/red; 12 Blue/red; 13 Blue/white; 14 Blue/white; 15 Red; 16 Red; 17 Blue/red; 18 Brown; 19 Purple/light green; 20 Purple.
9.23 Brake fluid level. (2 single natural connectors) Located in the engine compartment plugged into the top of the brake fluid reservoir, and is routed to the main harness assembly. Colours: Black, Black/white.
9.24 Stop light switch. (2 single natural connectors) Located on the brake pedal box and is routed to the main harness assembly. Colours: Green/yellow, Green/purple.
9.25 Heater motor. (4 way black connector) Located in the engine compartment local to the heater motor and routed to the main harness assembly. Colours: Green/ slate, Green/yellow, Purple/green.
9.26 Wash pump. (2 way natural connector, 2 way black connector) Located under the bonnet local to the windscreen wash reservoir and routed to the main harness assembly. Colours: Black, Black/light green, Light green/black.
9.27 Glow plug timer. (6 way black connector) Located under the bonnet on the bulkhead. Routed to the main harness assembly. Colours: White/red, Yellow/black, White, Black, Brown, Black/yellow.
9.28 Radio. Located inside the vehicle, routed to the main harness assembly. Colours: Black, Red.
9.29 Main fuses. Located under the bonnet against the bulkhead. Routed to the main harness assembly. Colours: Brown, Brown, Brown and Brown.
9.30 L.H Repeater. Located under the L.H wing, routed back to the main cable harness assembly. Colours: Green/red, Black.
9.31 L.H Sidelamp. (2 way white connector) Located in the L.H wing, plugged into rear of sidelamp assembly. Routed back to the main harness assembly. Colours: Red/black, Black.
9.32 L.H Headlamp level. (3 way black connector) Located in L.H wing, plugged into rear of headlamp assembly. Routed back to the main harness assembly. Colours: Blue/yellow, Black, Blue/green.
9.33 L.H Headlamp. (4 way black connector) Located in L.H wing, plugged into rear of headlight assembly. Routed back to main harness assembly. Colours: Blue/slate, Blue/pink and Black.
9.34 L.H Indicator. (2 way red connector) Located in L.H wing, plugged into rear of indicator assembly. Routed back to main harness assembly. Colours: Green/red, Black.
9.35 Horn. (2 single natural connectors) Located behind radiator grille plugged into horn. Routed back to main harness assembly. Colours: Purple/black, Black.
9.36 Glow plug. (Terminal) Located under the bonnet local to glow plugs. Routed back to the main harness assembly. Colours: Black/yellow.
9.37 Starter solenoid. (2 way natural connector) Located under the bonnet local to the starter, motor, routed back to the main harness assembly. Colours: White/red.
Chap 13-1 Page 8 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION
9.38 Side Tank connections. (3 way black connector) Located under bonnet local to bulkhead.
Routed to main harness assembly. Colours: Green/black, Black.
9.39 Chassis connections (2 off 6 way). Located under the bonnet local to the bulkhead. Routed
to the main harness assembly.
9.39.1 Plug 1 (6 way black connector) Colours: Red/orange, Red/brown, Red/yellow,
Green/red, Green/white, Green/purple.
9.39.2 Plug 2 (6 way white connector) Colours: Green/brown, White/black, Green,
Brown/light green, Red/Light green, Purple.
9.40 Engine connections. (12 Way black connector). Located under the bonnet local to the
bulkhead. Routed to main harness assembly. Colours: White/brown, Green/blue, Brown/yellow,
White, Green/yellow, Green/brown, Black/blue, Black, Brown/yellow.
9.41 R.H Repeater. Located in the R.H wing routed back to the main harness assembly. Colours:
Green/white, Black.
9.42 R.H Sidelamp. (2 way white connector) Located in the R.H wing plugged into the rear of the
side lamp assembly. Routed back to the main harness assembly. Colours: Red/black, Black.
9.43 R.H Indicator. (2 way red connector) Located in the R.H wing plugged into the rear of the
indicator assembly. Routed back to the main harness assembly. Colours: Green/white, Black.
9.44 R.H Headlamp. (4 way black connector) Located in the R.H wing plugged into the rear of
the headlamp assembly. Routed back to the main harness assembly. Colours: Blue/orange,
Blue/black, Black.
9.45 R.H Headlamp Levelling. (3 way Black connector) Located in the R.H wing plugged into the
rear of the headlamp assembly. Routed back to the main harness assembly. Colours: Blue/yellow,
Black, Blue/green.
Chap 13-1
Aug 00 (Arndt 1) Page 9
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
KEY TO FIG 1
1 Alternator connections 13 Starter solenoid connections (positive) 2 Oil pressure switch connection 14 Differential lock switch connections 3 Water temperature switch connection 15 Reverse switch connection 4 Heater plug harness 16 Earth bonding lead, rack to bodyside 5 Fuel shut off switch connection 17 Earth bonding lead, rear body to chassis 6 Earth bonding lead, door to "A" post 18 Earth bonding lead, rear body to body 7 Earth bonding lead, bonnet to bulkhead 19 Transfer box earth connection 8 Twin alternator link (FFR only) 20 Battery link cable 9 Alternator ECU feed (FFR only) 21 Vehicle batteries 10 Main harness connection 22 Earth bonding lead, door to "A" post 11 Main harness starter solenoid connection 23 Intervehicle starter socket connections 12 Starter solenoid connection 24 Earth bonding lead, toe box to chassis
Chap 13-1 Page 10 Aug 00 (Amdt 1)
ARMY EQUIPMENT SUPPORT PUBLICATION
2320-D-128-302
MIL0367
Chap 13-1 Page 11 Aug 00 (Amdt 1)
Fig 1 Engine harness layout
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
KEY TO FIG 2
1 Main harness connection 10 Trailer socket 2 Main harness connection 11 LH body harness connection 3 Main harness connection 12 Number plate light 4 Gearbox earth connection 13 Rear stop light connection (LH) 5 Convoy light harness 14 Reverse light connection 6 Rear body harness 15 Fog light connection 7 Rear stop light connection (RH) 16 Direction indicator light connection 8 Trailer socket connections 17 Tail light connection 9 RH body harness connection 18 Rear fuel tank connections (TUM only)
Chap 13-1 Page 12 Aug 00 (Amdt 1)
ARMY EQUIPMENT SUPPORT PUBLICATION
2320-D-128-302
MIL0368
Aug 00 (Amdt 1)
Fig 2 Chassis harness layout
Chap 13-1 Page 13
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
KEY TO FIG 3
1 Headlamp connection (RH) 19 Map reading light connectors 2 Headlamp levelling connection (RH) 20 Heater/blower motor connector 3 Indicator connector (RH) 21 Wiper motor connections 4 Side repeater connection (RH) 22 Glow plug timer 5 Side light connector (RH) 23 Earth point 6 Brake fluid level switch connections 24 Engine/Chassis harness connections 7 Brake light switch connections 25 No. 1 glow plug connector 8 Headlamp levelling switch connector 26 Starter solenoid connection 9 Hazard warning switch connector 27 Fuse box connections 10 Rear fog switch connector 28 Relays 11 Warning light panel connections 29 Main fuse box 12 Instrument panel connections 30 Windscreen washer pump connections 13 Horn/indicator/dip switch connections 31 Side light connector (LH) 14 Ignition switch connector 32 Side repeater connection (LH) 15 Inspection sockets 33 Headlamp connection (LH) 16 Main lighting switch 34 Indicator connector (LH)
1 17 Radio connectors 35 Headlamp levelling connection (LH) 18 Side fuel tank connectors (TUL only) 36 Horn connections
Chap 13-1 Page 14 Dec 13 (Amdt 3)
MIL0369
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
Fig 3 Main cable assembly harness
Chap 13-4 Aug 00 (Amdt 1) Page 15
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
FUSE BOX-PASSENGER COMPARTMENT HEADER 0285 C0550-4 P1 5 00285-5 CO285-3 R1 0
SWITCH-COLUMN 01042-7 P1 5 CO285-4 00285-7 P,1 0
MIL 01738
Fig 5 Connectors
Earth distribution
15 The ground distribution section comprises a numbero of Headers, Splices and centre taps circuits. These are used in a similar manner to those in Power distribution; to narrow the search area by checking for fault symptoms in associated circuits.
Line types
16 Fig 7 means that the wire connects to another circuit.
HEATED REAR SCREEN RELAY MIL 01743
Fig 6 Line types I
17 The "cup and ball" symbol indicates the male and female halves of the connector (refer to Fig 8).
17.1 Plug on lead, fly lead (Fig 8 (A)), wired directly to the component.
17.2 Connector plugs directly into circuit (Fig 8 (B)).
A 3
B
PAIL 01742
Fig 7 Line types II
Components
18 The name, or description of the component is shown. A dotted outline indicates that the component is not shown in its entirety.
Chap 13-1 Aug 00 (Amdt 1) Page17
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
6 OR 7 WAY LIGHTING SWITCH f == = = == =1 C1085-1
5,-ammi=s
C1082-1 0 C1086-1 krimstis
0 C1087-1 [fc' 0 C1083-1
u C1084-1 u6:Amommim
= = = = MIL 01739
Fig 8 Components
Earth points
19 Earth points are identified with an eyelet symbol and a connector number, except where components are grounded through their fixings, when only the eyelet is shown.
C0556-1 Gt
SWITCH-OIL PRESSURE
EARTH VIA FIXINGS
MIL01740
Fig 9 Earth points
Fuses and diodes
20 Fusible links (refer to Fig 11 (A)) and current fuses (B ), are identified as shown. The direction of the arrow in a diode symbol (C) indicates the direction of flow. The Zener diode (D) prevents current flow until a precise voltage is reached.
A LINK FUSE
AMP AMP AMP
C D
MIL 01741
Fig 10 Fuses and diodes
Chap 13-1 Page 18 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
RELAY-STARTER 8364 8360
r C0151 868 0 A366 fl.1.0 SJ6 BA 0 C0556-1
— UNIT-DIRECTION INDICATOR/ HAZARD WARNING
C0547-868.05
L
SVVITCHAAAPER DELAY C0303-4 8.0.5
RELAY- BRAKE CHECK
805 C1012-85
8.0,5 C10122-30
RELAY-IGNITION — 7 CO218-86 B.05
'
SWITCH-BLOWER MOTOR C0058-3 8,1 0
SOCKET-RADIO CHARGING MAJA 01011-1
LAM P-MAP B.20 A228 6.05 01111-2
, . SOCKET-INSPECTION
8.20 01106-1 -
SOCKET-ACCESSORY 620 C1031-1
MOTOR-VMPER-WNDSCREEN C0030-1 B20
A367 6368 4368
5 A370 8 1 5 A369 El 0 5
LAMP-SIDE REPEATER -FRONT-R H
00012-2
HEADLAMP-LH 8 1 5 C0009-3
LAMP-SIDE REPEATER- A372 FRONT-LH 4373
C0013-2 KO 5 A374
HORN — 00004 1 9,1 0
LAMP-SIDE-FRONT-LH C05382 8,0.5
8373
UNIT-TIMER- 8.1 5 4376 B 1 5
GLOW PLUG C0189-4 0,0 5
PUMP-WASHER-NNNDSCREEN C0008-1 8,0 5
DIFFERENTIAL LOCK UNIT — —I 00307-1 6 0 5 00192-800448-8 8.1 0
UNIT-FUEL TANK __., 00113-1 8,05 01187-200391-2_ 13 1 0 (90)
MOTOR-HEADLAMP LEVELLING-RH C0070-2 8,0,5
LAMP-DIRECTION INDICATOR/HAZARD WARNING-FRONT-RH C0002-2 B_0 5
WARNING LAMP-HAZAR 01036-18 0 5
INSTRUMENT PACK CO233-2 B.1.5
RESISTOR 1 01007-1 . TUL
RESISTOR01
960-1 B 05 TUM
LAMP-SIDE-FRONT-RH 6.05 00537-2
HEADLAMP-RH 9.1 5 00011-
GAUGE-COOLANT TEMPERATURE
3 8.05 01058-1
8,0 5
C1059-
GAUGE-FUEL 8.0 5 01057-2
01006-1
8.0 5
8.00 010612. SPEEDOMETER
A322 8.1.5 A323 8,0.5 01040-301048-3 8.1.0
01507-2 01500-2 9.1 0
LAMP-DIRECTION INDICATOR/HAZARD WARNING-FRONT-LH
805
MOTOR-HEADLAMP LEVELLING-LH
805 00071-2
SNATCH-BRAKE FLUID LEVEL
6.0 5
8,05 01060-2
Fig 11 Earth distribution I — Non EEGR
Aug 00 (Amdt 1) Chap 13-1
Page 19
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
LAMP-CONVOY-RH 00808-1 B4O5 C1522-2 C1521-2 8.0 75 AS B.20 00557-1
01519-5 C1518-5 B 20 LAMP-DIRECTION INDICATCR/
REAR- H HAZARD WARNING-R 0 1 0 SJ1 0,075 03928-1
LAMP-TAIL-RH LAMP-FOG GUARD-REAR-RH -0 C0121-1 8,075 0075 00515-1
LAMP-BRAKE-RH LAMP-REVERSE-RH 120490 -1 &075 012 BA 75 8015
LAMP-REAR NUMBER PLATE-RH
C0138-2 B 0 75
UNIT-FUEL TANK — C0114-2 8 1 0 A21 0.2 0 00558.1
C1519-5 C1517-5
LAMP-TAIL-LH • • • i• C0121-1 15.0 75
LAM P-BRAKE-LH
II 00490-1 8.075 012 8.075
8.2 0 I LAMP-DIRECTION INDICATOR!
HAZARD WARNING-REAR-LH B 1 0 SJ1 B 0 70 00928-1
LAMP-FOG GUARD-REAR-LH B 0 75 (0515-1
LAMP-REAR NUMBER PLATE-LH
11 ' 00138 B 0 75 TRAILER PICK-UP C0499-0 B 1 0 C0-561-1
00499-L 810
Fig 12 Earth distribution II — Non EEGR
Chap 13-1 Page 20 Aug 00 (Andt 1)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
FUSE BOX-PASSENGER COMPARTMENT co5ao-4 5,1 5 CO285-0
HEADER 0285 5.10 51040-851048.8 P 0 0
SOCKET-ACCESSORY 51138-2 - CO280-3
SWITCH-COLUMN '1 C1042-7 P15 00285-4
•
1. 00285-7 P10 SOCKET-ACCESSORY
51030-1
FUSE BOX-PASSENGER UNIT-TIMER-GLOW PLUG COMPARTMENT
L: 1.0109-3
• W2.0 50285-9 50560-5 00785-n W2.0 A441 W2.0
INSTRUMENT PACK SWTCH-IGNITION 50233-9
i ;gyp p 502304
W2.0
WOO
CO285-12
50286-19 C0036-1 6920
W.20 00094-1
SOLENOID-FUEL RELAY-IGNITION CUT-OFF , CO218-85 W20 00285-13 : CO235-16 WOO C0448-4 C0162-4 W20 C0198-1
Fig 13 Header joints—Non EEGR
Chap 13-1 . Aug 00 (Amdt 1) Page 21
FUSE BOX-ENGINE COMPARTMENT
LINK 2
OH
,1 c0570-2 N,6,0 A243 9,60
—0A.!
C0632-1 r LINK 1 005701 N30
G0.5
C1048-4 41111=11111111M
2320-0-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION
BATTERY R.25.0 00192-1 ' C0045-1 5,40.0 EARTH
STARTER MOTOR C0823-1 - —
HEADER 0285 00285-17 00285-19 33W2.0.560
NV1.12 0
R,0 75
uE
CO285-11 , 00285-12 44W2.0.560 6
UNIT'
UNIT
SENSOR TEMPERATURE
-ENGINE COOLANT (ECT)
C0169-1 GU 0 5 •
-FUEL TANK 00115-1 013.0.5 01187-1 C0379-1 013.0.5 TU L
-FUEL TANK • 00114-1 GB 1 0 00393-1 00379. I GB,0 TUM
INSTRUMENT PACK
5J1 G05 C1054-1! 01055-1 09.0 5 01048-7 C10407
G05 C1052-1 C1048-101040-1 GU.0.5 C0448-2 C0162-2 1320.5
01058.1 805 8.13 R.1 0 01048-3 01040-3 3235 0 5 710
! 01056-1 0.05 1 SWITCH-WASH/NAPE WINDSCREEN
01040-4 GO 75 00278-6
1 57 N.30 01080-1 01018-1
N45 SJ3
SWITCH IGNITION
00028.1 00094-1 W2.0 A441 W.2.0
W2.0
W2.0 6 OR 7 WAY LIGHTING SWITCH
01085-1 R.0 5 C1079-1 C1017-1
01082-1 01087-1 905.2 0 01080-20101E12
FUSE BOX-PASSENGER COMPARTMENT A331•
C0680-5 I I FUSE 3 C0580-6 G2.0 A333 GI 0
00580-291 FUSE 15 ! C0580-30 RR. 075 A213 218R9 0 5,1200
C0580-1 I
HEADER 0285 SWITCH-COLUMN
C0580-3 ! FUSE 2 C0580-4 91.5 CO285-5 !!! CO285-4 s 1.5 01042-7' '`, !! C1042-5 168UW2.0.145 1—C1><OH 7
Fig 14 Instruments I - Non EEGR
Chap 13-1
Page 22 • Dec 13 (Arndt 3)
NW10
00233-10 Y0,05
CO230-3 WN 05 00445.1 00162-1 WN 05
A376 B.1.5 SJ6 6.40 00556,1 00230-6 5010 5 C0031 C0026-1 8.05
ALTERNATOR/ GENERATOR
57,0 5 C0446-3 C0162-3 NY.0 75 00185-1 EARTH VIA FIXINGS
SWITCH-COLUMN GR,0 75 C1042,4
SWITCH-HAZARD WARNING GR,15 C0095-3 =
GVV, 1 5 C0096-4
SWITCH-COLUMN GVV,0 75 C1042-2
RELAY-HAZARD WARNING
C0547-30
DIFFERENTIAL LOCK UNIT
co3osi
UNIT-TIMER-GLOW PLUG C0189-2
SWITCH-OIL PRESSURE C.0187-1
EART FIXINGS
INSTRUMEN1 PACK
RB,0.5 00233-3
A IA/ 2 0 CO230-4
13 W2.0 00233-9
SWITCH-FOG GUARD LAMP-REAR 00233-4 07.0 5 00064-3
SWITCH-BRAKE FLUID LEVEL 8373
8168 9189 UW 2 0 00233-5
0322 A323 6. 15 00233-2 B 1 5 E UW2 0
DIODE 00230-5 YN.0 5 C0118- ' C0118-2
•Lp --r
CO230-10 GR 0 5 5316
I
0310
CO233-1 LGP,O S
CO233,8 BU .0 5 00448,7 C0162-7 BUO 5
CO230-9 C3VV.0
C 6,0.5
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
Fig 15 Instruments II - Non EEGR
Chap 13-1 Aug 00 (Arndt 1) Page 23
02823 RELAY -IGNITION • • G0218-1 MAL 0
00218-30 WY: 0
6 OR 7 WAY LIGHTING SWITCH C1083-1 RNO 5 C1079-4 C1017-4 RN.0 75 00580-11 •• FUSE 0 C0580-12 RN 075 C0376-2 C0390-2 A
BATTERY Cr>"40 R.25.6 C0192-1 F C0045-1 6,40.0 EARTH 1 SWITCH-HAZARD
STARTER MOTOR
FUSE BOX-PASSENGER COMPARTMENT
WARNING N.30 C1082-1 • .1, C1087-1 NVV.2.0 C1080-2 C1018-2 NV4.2 0 00580-1 ,
0
FUSE
><
1 I C0580-2 6.2 0 C0096-7
NVV.1 0 --H-
I •
FUSE BOX-ENGINE COMPARTMENT (P108)
LINK 1 00570-1 5.3 0 C1018-1 C1090-
50570-2 N 0 0 A243
N.50
SWITCH-IGNITION
- C00981
N,4.5 fi
~
M41
C0020-1 VVH 1 0 II0
SOCKET-INSPECTION N.2 0 C1064-1 •
RELAY-STARTER N 3 0 00151-81 50151-85 F? 1 0 A47
UNIT-11M ER-GLOW PLUG 00180-5 C0180-1 WR 0 5
N 2 0 50580-13 FUSE 7 C0580-14 R MAJA
C>.(0 SWITCH-MAP LAMP
N.20 C0580-35 • FUSE 18 C0580-36 P.0 5 C1515-3
35051 5 700
MOTOR-BLOWS R -FRONT
W0.1 0 60580 8 FUSES I 00580.10 10,1 0 50006-3 F. '
ID-T-E 1 1
W 2 0 50:18041 F USE 3 1 C Y380-6 C 3 0 ,.
HEADER 0285 W.2.0 CO285-11 ,
W2.0 50288.17
RELAY-BRAKE CHECK 1.4/5 0 5 5101286
C0632-1 I
ALTERNATOR/GENERATOR 00183-1 N,8.5 C0178-1
li R,100 00824-1
C0580-3 I FUSE 2 00580-4 F.1 5
I
40%.<0 SWITCH-HAZARD WARNING
10580- FUSE 4 50580-8 GY 1 5 50091-8
GY.1 5 C,
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
Fig 16 Power distribution I - Non EEGR
Chap 13-1 Page 24 Dec 13 (Arndt 3)
INSTRUMENT PACK 01054.1 Ci,0 5
F. C1052-1 00 5
521 605 01048 4 claw 4 (3075
I
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
HEADER 0285 SOCKET-ACCESSORY B 1421 1 5 640 130285-5 CO285-3 P.1 0 01040-8 01048-8 P 0 5 C1138-2
CO285-7 P 1 0 SOCKET-ACCESSORY
C1030-1
CO285-4 P15 SWITCH-COLUMN
C1042-7
SWITCH-BRAKE PEDAL 122GY,1 5 900 C0029-
G8,0 75 'SWITCH-REVERSE LAMP
00448-5 00162-5 GO 5 00167-2
SOCKET-RADIO CHARGING D 3619 MAJA 4:401853-1
LAMP-CONVOY-RH A RN,0 75 836 RN 0 75 C1521-1 C1522-1 RN 0 01065-1 t"
iiinimmm•mmmume
TRAILER PICK-UP Rt4.0 75 A36 RN 075 C1305-2 C1300-2 RN.1 0 C0499-A
85,375 C1305-301306-3 95-1.0 00499-C
RNA] 75 C1305-4 131306-4 RN.1.0 00499-H
E P1.5 00377-6 130391-6 P 2 0 131305-5 01306-0 P.10 130499-K
A331 MOTOR-W PER-WINDSCREEN G 3336.2 0.190 A333 620 130030-4
SWITCH-WIPER DELAY G 1 0 00303-8
SWITCH-WASH/WIPE-WINDSCREEN G10 CO278-6
Fig 17 Power distribution II - Non EEGR
Chap 13-1 Aug 00 (Amdt 1) Page 25
1, ,*\
LAMP-REAR NUMBER PLATE-RH
00138-1 R0.0.75 C1518-4 C1519-4 RO 0 75 All ROO 75
SWITCH-COLUMN C1042-6 UR 2 0
• A341 UR.2 0 C0580-21
FUSE BOX-PASSENGER COMPARTMENT
UB 2 0 C0580-22 FUSE 11
0><0
UR 10 C0580-23 FUSE 12 C0680-24 UK 2 0
II UR.1 0 C0580-33 FUSE 17 C0500.34 UG1 0 A378
C›<)-
0
I II
A168 II '1, 01042-5 UVV2.0 A189 UVV.2 U 01.1580 25 FUSF 13 00580-26 1.70
IFfl
INSTRUMENT PACK CO233-5 UW2.0 UVV,2 0 COUBO-27 FUSE 14 C0580-28 U.5.2.0
T.
SWITCH-COLUMN (r- 01042-1 U.2 0 1
A334 U,2 0 C0580-19 FUSE 10 C058020 UP.1 .0
6 OR 7 WAY LIGHTING SWITCH C1079-201017-2 U 20
t 01085-1 R.05 01079-1 C1017-1 R,0 75 C0580-29 FUSE 15 C0580-30 ROD 75 A213
RR 0 7//
01086-1 R05 01070-3 01011-3 R,0 75 CO580-31 FUSE 16 00580-32 R0.1 5 003/0e1 C0390-1 RO 1 0
R0.0.5
GAUGE-COOLANT TEMPERATURE ,r C1059-1 RVVO 5 012 RVV 0 C1048-501040-5 ROD 5 A351
LAMP-TAIL-RH RO 0 75 C0121-2
LAMP-TAIL-LI-1 50.0.76 0151/-4 01519.4 R0.0.7.5 All ROD 75 C0121-2
LAMP-REAR NUMBER PLATE-LH
RO 0 75 C0138-1
I
HEADLAMP-RH co511-2
HEADLAMP-LH
LI
MOTOR-HEADLAMP LEVELLING-RH UGO 5 C0070.3
MOTOR-HEADLAMP LEVELLING-LH UGO 5 C0071-3
HEADLAMP-RH 00011-1
HEADLAMP-LH C0009-1
SWITCH-FOG GUARD LAMP-REAR C0064-2
INSTRUMENT PACK 0 5 0.0231-3
LAMP-SIDE-FRONT-RH 80 .0 75 00037-1
LAMP-SIDE-FRONT-LH C0538-1
TRAILER PICK-UP Al 50.1 0 01305-1 C1306-1 50,1 0 C0499-E
C0099-2
SPEEDOMETER
III C1060-1 RWO 5 II
11 C106 RVV,0 5
GAUGE-FUEL C1057-1 RWO 5
II
SOCKET-ACCESSORY ;: 01027-1 ROD 75
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION
Fig 18 Power distribution III - Non EEGR
Chap 13-1
Page 26 Dec 13 (Arndt 3)
C0001-2 GR,0.75 6316 06,1 5 8316 GR,1.5 A 168/A189 (UW) MAIN
FUSE BOX-PASSENGER COMPARTMENT 6168 SWITCH-COLUMN INSTRUMENT PACK
C0580-25UW,2 0 A189 UVV,2 0 C1042-5
A191 (LGN) MAIN
UNIT-DIRECTION INDICATOR/ HAZARD WARNING
LGN,1.0 0004/8/
SWITCH- COLUMN LGN,1 5 C1042-3
SWITCH-HAZARD WARNING
C0096-2 LGN 1 5 6191
Chap 13-1
Page 27 Dec 13 (Amdt 3)
LAMP-SIDE REPEATER- FRONT-LH
C0013-1 GR,0 5 00333-1 00420-1 06.0.75
- - LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-LH
00928-2 GR 1 5 00376-4 C0390.4 GR . 1 0
ARMY EQUIPMENT SUPPORT PUBLICATION
A213 (RB) MAIN RB,0 5 A47 (WR) MAIN h
SWITCH-IGNITION RELAY-STARTER F C0090-1 WR,1 0 A47 VVR 1 0 00151 85 FUSE BOX-PASSENGER
COMPARTMENT C0580-30 R 6,0 75 A213 RB,0 75
RELAY UNIT-TIMER- BRAKE CHECK
u 01012-86WR.0.5 WR,0 GLOW PLUG
00189-1 A316 B316 (GR) MAIN
2320-D-128-302
LAMP-DIRECTION INDICATOR/HAZARD WA RNING-FRONT-LH
INSTRUMENT PACK UW.2 0 CO233-5
II ,
LAMP-DIRECTION INDICATOR/HAZARD WA RNING-FRONT-RH SWITCH-HAZARD WARNING
- 00002-2 GW 0 75 A310 GW 1 5 6310 GFi 1 5 00096-4
0W0.75
SWITCH-DIRECTION INDICATOR
01042 2
A334 (U) MAIN
FUSE BOX-PASSENGER COMPARTMENT
0058019 U-2 0 A334
„
A341 (UR) MAIN)
SWITCH-COLUMN 01042-6 UR,2 0
6 OR 7 WAY LIGHTING SWITCH
U,2 0 C1017-201079-2 11 , 20 01084-1
SWITCH-COLUMN U20 C1042-1
FUSE BOX-PASSENGER COMPARTMENT
IF2 2 0 C0580-21 '
UR,1 0 C0580-33
A341 UR,1 0 C0580-23
A310 B310 (GW) MAIN
LAMP-SIDE REPEATER-FRONT-RH
C.,W,0 00333-2 C0420-2 OW,0.75 0002-1
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-RH
GW,1 5 00376-5 C0390-5 GW,1 0 • C0837
INSTRUMENT PACK GVV,0 75 CO230-9
Fig 19 Splices and centre taps I - Non EEGR
SWITCH-HAZARD WARNING
00096-3 —
INSTRUMENT PACK CO233-3
LA MP-SIDE-FRONT-RH
C0537.2
CO230-10
SWITCH-DIRECTION INDICATOR
0104?-4 GR,0 75 C0580-27 LJW.2 o
SPEEDOMETER r-' 4 74, C1060.1 RW,0 5
01081.1 RWO 5 lIoo o
SJ2 RW1 0 C1048-501040 GAUGE-FUEL
RW 0 5 0135/.1 T. '
GAUGE-COOLANT TEMPERATURE
RW,0 5 C1059-1 r
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
A331 A333 (G) MAIN SJ1 (G) INSTRUMENT A378 (UG) MAIN
FUSE BOX-PASSENGER COMPARTMENT
FUSE BOX-PASSENGER MOTOR-WIPE R- COMPA RTMENT A331 WINDSCREEN
00580-16 G,2.0 A333 G,2 0 C0030-4
14—
SWITCH-WIPER DELAY
-L C0303-8 0,10 -
G 0 75 C1040-401048-4 G,05
L --J
SWITCH-WASHNVIPE -WINDSCREEN
CO278-6 G,1 0
GAUGE-FUEL rr~ 7 01054-1 0,0 5
—1141 4 101702-1 G,1 0
A243/A350 (N) MAIN SJ3 (N) MAIN
FUSE BOX-ENGINE COMPARTMENT A243
00570,2 N,8 0 8350
N,6 0
SWITCH-IGNITION C0028-1 N,4.5 SJ3
SOCKET-INSPECTION ' —74 01064-1 N,2 0
II Irl N 3 0
A351 (RO) MAIN ; 1 11 SJ2 (RW) INSTRUMENT 1 .,
1 'I , '
FUSE BOX-PASSENGER MOTOR-HEADLAMP COMPARTMENT LEVELLING-RH
00560-34 110,1 0 A378 00,0 5 00070.3
RESISTOR C0036-2 00,1.0 UG,0 5 C0071.3
J •
I. A381 air MAIN 0805 00071
RESISTOR 4 O 00037-2 1180 8381 MO 5 00070-1
A384 (GU) MAIN' GU ,1 0 C0038-1
SWITCH-HEADLAMP LEVELLING
00093:5 0111 0 5384 GUJ 0 01506-301507-3 00,05 01963.1
A441 (GR)MAIN
SWITCH-IGNITION : 1 C0094 1 W2 0 6441 W.2 0 00580-5
-
/ HEADER 0285 " CO285 11 W2 0
SJ1
0,0 5 01052.1
01095-30
N.2 0 00580.0
N 1 0 C0580-17
N,2 0 00580-35
'T
C0151 87
-
RELAY-STARTER T
GAUGE-COOLANT TEMPERATURE
— 7
RELAY-IGNITION WARNING LAMP
MOTOR-HEADLAMP LEVELLING-LH
I
MOTOR-HEADLAMP LEVELLING-LH
MOTOR-HEADLAMP LEVELLING-RH
RESISTOR —
RESISTOR
FUSE BOX-PASSENGER COMPARTMENT
CO285-17 W20
FUSE BOX-PASSENGER HEADER-BULLET COMPARTMENT 1027 CG — 7 C0580-32 RO 0 5 5351 RO 0 /5 01027-1 r" — 1
RO 0 5 A10 (RY) CHASSIS
SWITCH-FOG GUARD LAMP-REAR
00064 3 851 5 00376.3003903 8510 610 681 0
LAMP-FOG GUA RD-REAR-LH
00515 2
LAMP-FOG GUA RD-REAR-RH
85,0 75 00512-2 -
Fig 20 Splices and centre taps II - Non EEGR
Chap 13-1 Page 28 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
A6 (GP) CHASSIS 1 SJ3 (UB) RESISTOR PACK1
GP 1 0 A6 GP,1 0 C0490-2 LAMP-TAIL-LH
A
SWITCH-HEADLAMP LEVELLING RESISTOR
LAMP-TAIL-RH 00093-2 UB 1 0 01506-1 C150/-1 UB,05 SJ3 UB.0 5 C1962-2 •
C0390-6 C0376-6 GP,1 5 GP 1 0 00489.2 — •
C1516-3 C1018-3
SWITCH-BRAKE PEDAL RESISTOR GP 1 0 C1516-4 C1018-4 GP,1 0 C0075-1 •- •••'•• U0 0 5 C1963 2 ••••
Al (RO) CHASSIS A5 (NW) AMBULANCE INTERFACE
6 OR 7 WAY FUSE BOX-PASSENGER COMPARTMENT
LAMP-REAR NUMBER PLATE-LH
HOLDER-FUSE C1875-1 NW 1 0 AS NVV,2 0 01877 7 01080 7 NW,7 0 01087
LIGHTING SWITCH
C0580-32 R0,1 5 00376-1 C0390-1 RO 1 0 Al R0,0 75 C0138-1'; •
LAMP-TAIL-RH FUSE BOX-PASSENGER LAMP-TAIL-LH C0121-2 90 1 0 90075 C0125-2 • HOLDER-FUSE COMPARTMENT
C1876-1 NW 1 0 NW.2 0 C1516-2 C1018-2 NW20 00580-
A48 (W) ENGINE
HEADER 0285 CO285-16 W,2.0 C0448-400162.4 W2.0 A48 W,1.0
W,2.0
ECU-EGR C0032-3
SOLENOID-FUEL CUT-OFF
C0198.1
All (PW) AMBULANCE INTERFACE
HOLDER-FUSE ‘1. 01876-7 PW,10 All PW,1 0 01874.30
RELAY-BEACON •• • •.'
PW 0 5 01869-1 SWITCH-BEACON •—•
SJ1 (KB) ENGINE
SENSOR-TH ROTTLE ECU-EGR POSITION (TP) A6 A36 (N)AMBULANCE INTERFACE
C0032-1 KB4O.5 SJ1 KB4O.5 C0175-1 RELAY-IGNITION
HOLDER-FUSE AS WARNING LAMP • 01878-1 N,1 0 A35 N,1 C189566 •
SOLENOID-EGR SENSOR-TEMPERATURE -EGR
-1 C0191-2 KB4O.5 KB4O.5 C0027-2 •
INSTRUMENT PACK BUZZER C1743-1 N 1 0 N,1 0 C0520-87 —
SJ2 (RB) ENGINE
SENSOR-THROTTLE ECU-EGR POSITION (TP) -
C1862-2 RB,0 .5 SJ2 RB,0 5 00175-3 r--- 11,
SOLENOID-EGR RB 0 5 001910:
Fig 21 Splices and centre taps III - Non EEGR
Dec 13 (Amdt 3) Chap 13-1
Page 29
N.8.5 C0183-1 STARTER MOTOR
C0849-1
R.25.0 C0192-1 1, ;I C0045-1 8,400 EARTH BATTERY
C0523-1
ALTERNATOR/GENERATOR
• ••.^
R,10.0 C0824-1
00179-1 'i
FUSE BOX-ENGINE COMPARTMENT
LINK 3 c0570-3 3N,6 0.460
'D"." -13 t •
EARTH VIA FIXINGS
" t•••
C.0448-3 C0162-3 NY 0 75 C0185-1 1 I — 14 . • EARTH VIA
XINGS
DIODE NY 0 5 00118.2 C0118-1 03YN 0 5 445
C0632-1 - LINK 2 c670-7 N 0 A243 N 6 0 WH 3 0 CO203-1 C0449-1
N,45 SJ3
RELAY-STARTER
N.3 0 C0151-87 , CO151-30 1AR 3 0
A47 0019.1 0 C015185 .•• I C015186 3658.1.0.170
SWITCH-IGNITION 75WR.0 5.630
00090-1 NOR 1 0
HEADER 0285 C0028-1 C0094 1 W2 N A441 W 2.0 CO28511 CO280.9 29W2 0.860
C
0
CO285.12
W 2.0 CO285-17 , CO285-19
CO285-16
44W2 0 560
33W2.0.560
W20
SOLENOID-FUEL CUT-OFF 00448-4 00162-4 W 2 0 C0198-1 `-_---
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
Fig 22 Charging and starting I - Non EEGR
Chap 13-1 Page 30 Aug 00 (Amdt 1)
'ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
INSTRUMENT PACK
A YN.0 5 00230-6
C0476-1 GLOW PLUG 1
EARTH VIA • -----
W20 CO230-4
GLOW PLUG 2 Y H 0 004// 1
EARTH VIA r . FIXINGS
F W2.0 CO233-9 00233-10
GLOW PLUG 3 B5.30 00478-1
. EARTH VIA • --- • FIXINGS
UNIT-TIMER- GLOW PLUG
WR.0 h C0169-1 P,i 00189-2 Y8.0.5 GLOW PLUG 4 YH.30 00479-1 •
EARTH VIA IT FIXINGS
W20 C.:0189-3 00189-6 HY 6 C1039-1
8373 N 6 0 00189-5 C0189.4 B 0 5 93/6 B 1 5 0.16 0 4 0 00556-1
A364 9365
B 10 A366 B 1 0
Fig 23 Charging and starting II - Non EEGR
Chap 13-1 Aug 00 (Amdt 1) Page 31
SPEEDOMETER
SJ2 RW0.5 01060-1 01060-2 8.05 SJ3 B 1 0 01048-3 C1040-3 8.05
RVV,0 5 01061 01061-2 8,0.5
GAUGE-FUEL 01056-1 B4O.5
RW 0 T C1057-1 01057-2 605
GAUGE-COOLANT TEMPERATURE
01055.1 8 0 5
1,351013 01058 1 01059 2 80.5
RW,1.0 C1048-5010405
STARTER MOTOR C0823-1
R.10.0 C0824-1 '.'
FUSE BOX-ENGINE COMPARTMENT
C0632-1 LINK 1 00570-1 N30 01018-101080-1
N3 0
6 OR 7 WAY LIGHTING SWITCH
01086 1 R05 C1082-1
80.76
01075 3 01017 3
FUSE BOX-PASSENGER COMPARTMENT (P101)
C0580-31 00580-3? ROOT A3T1 ROOT
0><0
A322 A323 8.15 SJ6 0.4 0
• 60550. 1
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
BATTERY R.250 C0102-1 l
l_ 00C 45-1 8.400 EARTH
Fig 24 Interior illumination - Non EEGR
Chap 13-1 Page 32 Dec 13 (Amdt 3)
00006-5 LG1
C0096-8
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
310GW.1 5.400 A
C0045-1 6.400 EARTH SW1TCH-HAZARD WARNING
00096-4 GW 1 5 8310 GW1 5 A31D 314GW.0.752120
BATTERY R,25.0 C0192
R.10.0
GW0.75
GINO 75
315GW0 75 1670
3166-9.1 5 340
STARTER MOTOR C0823-1 "I
C0824-1 u
FUSE BOX-ENGINE COMPARTMENT
I INK 7 00-5702 N.6.0 A243 N,6.0
C0632-1 I INK 1 005701 N.3.0
N,3.0 01080-1 01018-1
N,4 5 SJ3
SWITCH-IGNITION
00006-7
C0028 [.
• C0094-1 08,2.0 A441 W2 0
I. C0096-3 GR. 1.5
C0096-1 8R.0.5
C0096-2 LGN 1 5
6316 GR.1 5 A316
GRO 5
GR 0 75
LGN.10
C1042 3
320GR,0.75,2240
321GR,0 75,1790
SWITCH-COLUMN
LH C1042-4
7 RH.: 010422
HEADER 0285 CO285-17 , 00285-13 70.2.0
6 OR 7 WAY LIGHTING SWITCH
01082-1 - 01087-1 MAU 0 INSTRUMENT PACK
11W2 0 010182 01080-2
RELAY-IGNITION 1
WY2 0 0021830 I
FUSE BOX-PASSENGER COMPARTMENT
Go580_7 h FUSE 4 00218-87 I . _
C0580-1 I-USE 1 00580-2 P 2.0
RELAY-HAZARD WARNING
0.0230-9
CO233-2 0,15 00230-10
C1037-1
I'
01036-1 005
LGP.0.5 00233-1
00547 86 9,05
00218-85
00518-86
00547-87 00547-30
00547-85
A364 A365
8,05 A366
I' C0580-8 GY.1 5
00580-3 NW2.0
NW 0 36:13,1.0.220
Fig 25 Indicators and Hazards I — Non EEGR
Dec 13 (Amdt 3) Chap 13-1
Page 33
A33 LJ GR.1 5 003/6-4 00390-4 GR 1 0
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-RH
5322 A323 0.1.5
I G 3220.1,5,400
H 3238.0.5.370
LAMP-SIDE REPEATER-FRONT-LH
00513-1 . C0013-2 8.0 5
LAMP-DIRECTION INDICATOR! HAZARD WARNING-REAR-LH
00928-2 00928-1 80.75
F GR,0 75
GR.0.75 01517-3 01519-3 G0.75 521 8,1.0 01519-5 01517-5 B.2.0 A21 B.2.0 C0558-1
GR,1 o TRAILER PICK-UP
(0929-1 61260-1 GR 1 0 60499-M
GW,1 0 00929-2 C1260-2 GVV 1 0 60459-N
01518-, C1519-3 G075 00928-2 00928,1 8,0./5 SA 8.1.0 01519-5 01718-5 8.20
LAMP-SIDE REPEATER- FRONT-RH A387
A368 5368 GVV,0.75 06012-1 . 00012-2 8.0 5 A369 5 1 5 A.370
immommemmin , 0,1 5 8J0
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-FRONT-RH
GWO.75 00002-1 C0002-2 B
C
8
58 8.20 C0551-
0.4 0 00555-1
B,1
A GVV.1.5 C0376-5 C0390-5 GW,1 0 516
GWO75
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-FRONT-LH
E GR.0.76 00001.1 I C0001 2 8,0
A3/2 A373 5374 8.1.5
0373 A376 8,15
Fig 26 Indicators and Hazards II — Non EEGR
Chap 13-1 Page 34 Aug 00 (Amdt 1)
8.05
010592
GAUGE-FUEL 005
51055 1
8.05
SPEEDOMETER 5.0.5 01061-22 PEEDOMETER
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
RELAY-STARTER 00151-86 5,1 0
doe UNIT-DIRECTION INDICATOR/ HAZARD WARNING
C0547 86B4O 5
SWITCH-WIPER DELAY C0303-4 8,05
,
RELAY-IGNITION CO218-865,0.5
__u
A364 5365 5366 0.10 0J6
RELAY- BRAKE CHECK 5,05 C1012-85
B 0 5
C1012-
SOCKET- RADIO CHARGING 5.MAJA 01011-1
SOCKET-INSPECTION 8.20 51105-1
SOCKET-ACCESSORY
6.4 o 00556.-1
• LAMP-MAP 13.2.0 A228 0,05 C1111-2 '----
8,20
5367 LAMP-SIDE REPEATER 0368 A368 -FRONT-RH A370 5.1 A369 B.0.5 1.17012-2
.1C )
5,1.5
MOTOR-WIPER-WINDSCREEN r C0030-1 5.2.0 • I;
DIFFERENTIAL LOCK UNI C0307-1 5,0.5 HORN,
C0004-1 5.1 0
LAMP-SIDE-FRONT-LH 1 C0538-1 8.05
1.
UNIT-TIMER- GLOW PLUG ij 00189-4 B.0
lj
PUMP-WASHER-WINDSCREEN C0008-1 5,0 5
8L..
a-- —2,
Aug 00 (Amdt 1)
LAMP-DIRECTION INDICATOR/HAZARD WARNING-FROM-LH 005 C0001-1
MOTOR-HEADLAMP LEVELLING-LH 8.05 C0071-2
B373 5,15 A3/5 8.15
SWITCH-BRAKE FLUID LEVEL 805 C0026-1 "
UNIT-FUEL TANK 00113-1 8.05 TUL C1187-2 C0391-2 B 1 0
LAMP-DIRECTICN INDICATOR/HAZARD WARNING-FRONT-RH 00002-1 5.0 5
GAUGE-COOLANT TEMPERATURE 01040-3 01048-3 5,1 0 SJ3 8 0 .5 01050-1 '
WARNING LAMP-HAZARD 01036-1 8 0
INSTRUMENT PACK CO233-2 8,1 5
_ . RESISTOR C1097-1 8,0.5
G1107-2 01506-2
B 0 5 C1060-2
Chap 13-1 Page 35
LAMP-SIDE REPEATER-FRONT-LH C0013-2 5,05
A3T2 6373 53/4
HEADLAMP-LH 0.15 C0009-3
ECU-EGR , 000324 8,10 A33 5.1.0 C0162 8 00448-8 5.1 0
HEADLAMP-RH 8,15 C0011-3
MOTOR-HEADLAMP B 0 5 LEVELLING-RH
00010-2
LAMP-SIDE-FRONT-RH 5.0 5
A322 5.1.5 A323 5,05
RESISTOR cissai 8 0 5 TUM
Fig 27 Earth distribution I - EEGR
TUL
8,1 0
SWITCH-BLOWER MOTOR 1 , 00058-3 5,1,0
0.
LAMP-FOG GUARD-REAR-LH G0f1f/-1
TRAILER PICK-UP 00499-0 B.1 0 00561-1
B 015
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
LAMP-CONVOY-RH 00808.1 5.0.5 01522-2 C1521-2 80..(5 A8 B.2.0 0(Y./h/-1
01519-501518-5 8,20 LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-RH
B.1 0 5.11 B.0 75 00928-1
LAMP-TAIL-RH LAMP-FOG GUARD-REAR-RH C0121-1 8.075 B 0 75 00515-1
LAMP-BRAKE-RH LAMP-REVERSE-RH f"--'I 00498-1 5,0./5 912 5,015 /h 0045
LAMP-REAR NUMBER PLATE-RH
00138-2 80.75
UNIT-FUEL TANK C0114-2 8.1.0 A21 8.2.0 C0558-1
C1515-50151/-5 5.20 LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-LH
8,1.0 5J1 0.0.75 00928- LAMP-TAIL-LH
C0121-1 0.0.75
LAMP-BRAKE-LH C0490-1 0.075 912 B4O 75
LAMP-REAR NUMBER PLATE-LH
C0138-2 8.075 1
00499-L 5.10
SCREEN ' ' 1122-SCGCR,MCA 00007-t
Fig 28 Earth distribution II - EEGR
Chap 13-1 Page 36 Aug 00 (Amdt 1)
FUSE BOX-PASSENGER COMPARTMENT — Ca580-4 P 1 5
HEADER 0285 CO285-0 C0785-3 P I 0
SWITCH-COLUMN 01042-7 P I 5 00285-4 CO285 7 P 1.0
UNIT-TIMER-GLOW PLUG C0189-3 V1/.2.0 002859 CO285-11 W.2.0
INSTRUMENT PACK CO233-9 W2.0 CO285-12
CO230.4 W 2 0 00285.19 .00285-1/ W 20
RELAY-IGNITION 00218-85 W2 0 CO285.13 00285-16 W2 0
SOCKET-ACCESSORY 01040-8 C1048-8 P (;1138-2
SOCKET-ACCESSORY C1030-1
FUSE BOX-PASSENGER COMPARTMENT
A441 W.2.0 C0680-5 51,
SWITCH-IGNITION W2.0 00094.1
SOLENOID-FUEL CUT-OFF
004484 C0162-4 A48 W 2 0 00198-1
ECU-EGR w 1.0 C0032-3 :-- • '
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
Fig 29 Header joints - EEGR
Aug 00 (Arndt 1) Chap 13-1
Page 37
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
BATTERY 8,25.0 C0192-1 I C0045-1 0,400 EARTH
STARTER MOTOR C0823-1
R,10 0 C0824-1
77 L HEADER 0285
FUSE BOX-ENGINE COMPARTMENT 00285-17 00785-19 33W20.580 A
LINK 2 00570-2 5.60 A243 N.6 0
C0632-1 It
03285-11 00285-12 44W.20.560
LINK 1 C0570-1 N 3 0
SENSOR-ENGINE COOLANT N 3 0 01080-1 C1018-1 TEMPERATURE (ECT)
C0169-1 GUT/5
N.45 SJ3
SWITCH-IGNITION UNIT-FUEL TANK 00115-1 GB 0 5
it 01187-100379-1 GB 05 TUL
C0028-1 C0094-1 W.20 A441 W20 UNIT-FUEL TANK TUM C0114-1 GB 1 0 C0393-1 C0379-1 GB 0 5
W20
W20 INSTRUMENT PACK 6 OR 7 WAY LIGHTING SWITCH G05 SJ1 G.05 01054-1 01055-1 013,0 5 01048-701040-7
01079-1 C1017-1 L .
C1087.1 NVV.2.0 01080-2 01018-2 01052-1
. • 4- 00.5 C1052-1 t 01053-1 GU.0.5 01048-101040-1 GU 0.5 00448-2 00162-2
NW? 0 C10r8-1 B 0 0 SJ3 1410 C1040-301040-3 37380 5 710 C.
R.0.75 I C1656-1 E3,0,5
NW, 10
FUSE BOX-PASSENGER COMPARTMENT •
00580_5 FUSE 3 A331
01048 4 C1040 4
1. 00580-6 13.2 0 0333 130 70
00580-75 II FUSE 15
0><>
0A2180-30 4B0 75 A713 718011 0 5.1760 LL
C0580-1
// HEADER 0285 SWITCH-COLUMN
05580-3 I. FUSE 2 I00580-4 P 1 5 00285-5 „ CO285-4 P 1 5 168U05 2 0.200
t-C1><CH
Fig 30 Instruments I - EEGR
Chap 13-1 Page 38 Dec 13 (Arndt 3)
Jo 00230-0 GW,0 75
UNIT-TIMER-GLOW PLUG
SWTCH-OIL PRESSURE ,
LAN1N VIA 618)11C,"
Chap 13-1 Page 39 .Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
INSTRUMENT PACK
C0118-2 55.00 C0448-3 C0162-3 NYC) 75 C0185-1
(35.075
GR 15 C0096-3
GW 1 5 00086.4
GW 0 75 C1047
CO233-1 LGP.0 C0547-30
CO233-8 BU.0.5 C0448-7 C0162.7 BU 0.5 C0306- I
(0233.10 86.05 00189 2
00230-3 VVN,0 5 00448-1 00162-1 WN 0 5 00187-1
CO233-4 RY.0 5
SWITCH-FOG GUARD LAMP-REAR C0064-3
B373 A376 6,1 5 036 CO230-I3 BM 5
SWITCH-BRAKE FLUID LEVEL 00031-1 rI 00026-1 8.05
CO233-2 8,1.5
8122 A323 8,1.5 .
C B.0.5
Fig 31 Instruments II - EEGR
A168 E UVV.2.0 A109 UVV,2.0 CO233-5
ALTERNATOR/ GENERATOR -
EARTHVIA FIXINGS
SNATCH-COLUMN
SW TCH-HAZARD WARNING -
SNATCH-COLUMN
RELAY-HAZARD WARNING
DIFFERENTIAL LOCK UNIT
DIODE CO230-5 5505 00118- 1
, 1.4
CO230.10 UR 0 5 5:15
8.40 00556-I
D RB 0 5 CO233-3
A W.2.0 CO230-4
B W.20 C01:3:1
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
6 OR 7 WAY LIGHTING SWITCH FUSE BOX-PASSENGER COMPARTMENT
C1083-1 RN.0 5 C1079-4 C1017-4 RN 0 75 C0580-11 11 FUSE 6 L_(:><0_,
C0580.12 RN.0.75 C0376-2 C0390-2 A BATTERY
SWITCH-HAZARD R.25.0 C0192- 1
C0045-1 8,400 EARTH WARNING
N.3.0 C1082- ! C1087-1 NVV.2.0 C1080-2 C1018-2 NW2.0 C0580-1 FUSE 1 C05802 P2.0 C0096-7
0><> NVV,1 0
STARTER MOTOR C0580-3 C0823-1 C05802 -4 P
RELAY-IGNITION ' CO218.87
(
FUSE
>4:0
ALTERNATOR/GENERATOR NW 20 SWITCH-HAZARD
7 C0183-1 N 8 5 00849-1
VVY 2 0 00580-7 FUSE 4 50580-8 GY 1 5 WARNING
50096-8 100 03824-1 .
0O218-30
GY 1 5
(P108) FUSE BOX-ENGINE COMPARTMENT
LINK 1 03570-1 N 3 0 01018-1 C1080-1
C0632-1 LINK 2 00570-2. N,6.0 A243 N.2.0 00580-13 FUSE 7 c058014 R.MAJA -CD..110
N00 SWITCH-MA P LAMP
N 0 00580-35
0.>FUSE
0
18 00580-36 PO 5 01515-3
Ns 3.590 1 5 705 - ___ - -
SWITCH-IGNITION MOTOR-BLOWER -FRONT
00090-1 VV0.1 0 c0580-0 FUSE 5 C0580-10 VG 1 0 C0056-3 "
533 N.4.5 C0020-1 1 C0094-1 0.2.0 8441 it
' •• C0090-1 VVR.1.0 W.2.0 co5ao-5 FUSE 3 C05806 G2.0 0><0
SOCKET-INSPECTION N,20 C1064- HEADER 0285
W20
W2 0
CO285-11
00285-17
'"
RELAY-STARTER N 3 0 50151-87 C0151-85 VVR 1 0 A47 I,
RELAY BRAKE CHECK UNIT-TIMER-GLOW PLUG
LINK 3 055703 N00 00189.5 00189 1 VVR 0 5 VVR.0 5 C1012.86
Fig 32 Power distribution I - EEGR
Chap 13-1 Page 40 Dec 13 (Amdt 3)
II00448-5 C0162-5 G05
SWITCH-BRAKE PEDAL 122(37.1 5.900 (0029-1
7-SWITCH-REVERSE LAMP 00167-2
Fig 33 Power distribution II - EEGR
Aug 00 (Amdt 1) Chap 13-1 Page 41
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
HEADER 0285 B 22P 1 5.640 0285-5 00285-3 P1 0 01040-8 01048-8 P 0.5 01138-2
SOCKET-ACCESSORY
SOCKET-ACCESSORY CO285-7 P 1.0 C1030
swicH-COLUMN CO285-4 P,1.5 01042-7
SOCKET-RADIO CHARGING 361R MAJA.42401853 4. '
A RN 0 75 830 RN.0 75 01521-101522-1 RN 05
RN.075 A36 RN0.7.5 01305.201306-2 RNA 0
RND 75 01305.301306-3 RN, 1 0
RN 0 75 01305-4 01306-4 RN 1 0
' E P,1.5 C0377-6 C0391-6 P20 01305-5.01306-5 P.10
5331 G 333G 2 0.190 A313 020
LAMP-CONVOY-RH (1 065-1
TRAILER PICK-UP 10499-A Ammo
00499-0 -
(.0403-H
00499-K
MOTOR-WIPER-WINDSCREEN 00030-4
SWITCH-WIPER DELAY 151 0 00303-8 -
(1
SWITCH-WASH/WIPE-WINDSCREEN G1 0 00278-5 '
GY.0 75
INSTRUMENT PACK
•01054-1 GO 5 651 GO 5 01045-401040-4 GO 75
01002-1 CO 5
SWITCH-COLUMN FUSE BOX-PASSENGER COMPARTMENT
HEADLAMP-RH
A351 GAUGE-COOLANT TEMPERATURE , C1059-1 RWO 5 SJ2 RW1 0 C1048-501040-5 ROSS
SPEEDOMETER
A378
4213
00376-100390.1
7-C1042-6 UR 2 0 A341 UR.2.0 C0580-21 FUSE 11
FUSS 12
I, C0580-22 U8.2 0
I I
u
C1042-5 UVV.2 0 A168 A189
UR.1 0 00680-23 C0580-24 UK2 0
UR.1.0 C0580-33 =
FUSE 17 03680-34 U01.0
07020 C0580-25 FUSS 12
FUSS 14
CO580-26 00,2 0
INSTRUMENT PACK 03233-5 UVV2 0 UVV2 0 00580-27 00580-28 US 2 0
J%
SWITCH-COLUMN C1042-1 U 2 0 9334 U,20 00580-19 FUSE 10 C0580-20 UP .1 5
[ 6 OR 7 WAY LIGHTING SWITCH n"---1 01084-1 U20 G10/9-2 tA01/-2 U10
7-1 9.0 75 00580-29
r--0>•<-3
FUSE 15 !, 00580.30 RB 075 01 C1085.1 505 01079-1 0101
fl
it 01086-1 R 05 01078-3 01017 3 R 0 75 00580-31 FUSE 16
0›,(0
RB .0 75
03580-32 RO 1 5
ROC 5
01060-1 RWO 5
II p C1061-1 RWOS fl II, fl
GAUGE-FUEL C1057-1 RVVO 5
tl
SOCKET-ACCESSORY C1027-1 50,0.75
C0011.2
00009-2
UG.0.5 C0070-3
11(005 C0071-3
00011
00009-1
00064-2
RR 05 00233-3
88 0 /5 00537-2
9010 Al 9010 01305.101306.1 90,10
MOTOR-HEADLAMP LEVELLING-RH
MOTOR-HEADLAMP LEVELLING-LH
SWITCH-FOG GUARD LAMP-REAR
LAMP-SIDE-FRONT-RH
HEADLAMP-LH
HEADLAMP-RH
HEADLAMP-LH
INSTRUMENT PACK "
-. - LAMP-SIDE-FRONT-LH
00499-F TRAILER PICK-UP
LAMP-REAR NUMBER
I PLATE-RH 50.0 75 01515-401519-4 RU.0 /5 All 80,015 C0138-1 '' ..-
om molm7Ino
RO 0 75 01517 401519 4 50.075 All 90075
I LAMP-TAIL-RH R0.0./5 00121-, 1--
R0,0.75 C0138
LAMP-TAIL-LH C0121.2
LAMP-RFAR NUMBER PLATE-LH
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION
Fig 34 Power distribution III - EEGR
Chap 13-1 Page 42 Dec 13 (Arndt 3)
ARMY EQUIPMENT - 2320-D-128-302 SUPPORT PUBLICATION
Al (RO) CHASSIS , All (RO) BODY
FUSE BOX-PASSENGER COMPARTMENT I, '-'''' C0580.32 R0,1 5 C0376-1 C0390-1 RO 1 0 Al RO 1 0 01305-1 01306-1 il 11 il' II ,_. 11
LAMP-TAIL-LH 17' '' --ii 00121-2 00,0.75 All 00,0.75 01519401517-4 00.0.75 00.0.75 01010-4 01519-4
tl '.
LAMP-REAR NUMBER PLATE-LH
C0138-1 RO 0 75
TRAILER PICK-UP RO 1 0 C0499 -F
LAMP-TAIL-RH 50,015 All 50.0 00121-2
LAMP-REAR NUMBER PLATE-RH
RO 0 75 03138-1
,111 A6 + B6 (GP) CHASSIS
SWITCH-BRAKE PEDAL TRAILER PICK-UP C0075-1 GP.1 0 01018-401080-4 GP 0 5 01080-3 01018-3 GP 1 5 00376-6 C0390-6 GP 1 0 86 GP 10 A6 GP 1 0 00929-3 01260-3 GP 1.0 C0499-9
GP 1.0 00929-4 C1260-4 0P,1.0 00499-J LAMP-BRAKE-RH -'" ' • C0490-2 GP.0 75 01519601518-6 GP 0 75
LAMP-BRAKE-LH 000.75 01517-6 C1519-6 GPO 75 00490-2
!i A10 (RY) CHASSIS
LAMP-FOG GUARD- SWITCH-FOG GUARD LAMP-REAR REAR-OH
00064-3 50.1 5 C0376-3 00390-3 RY 1 0 A10 RY 0 75 01517-201519-2 R0075 00515-2 -
TRAILER PICK-UP C0490-F RY.1 0 01301:601305-6 8010 LAMP-FOG GUAR D-
REAR-RH 00,0 /5 015152 01519.2 50.0.75 00515-2
Al6 (GW) CHASSIS A310 + B310 (GW) MAIN
LAMP-DIRECTION INDICATOR/ SWITCH-HAZARD WARNING HAZARD WARNING-FRONT-RH
00096-4 OR.1 5 9310 nw 1 5 0310 nvv.o 75
INSTRUMENT PACK ii 00230-9 GW0.75 LAMP-SIDE RE PEATER-
FRONT-RH GVVO 75 00012-1
SWITCH-DIRECTION INDICATOR
C1042-2 GVV 0 70 LAMP-DIRECTION INDICATOR/ HAZARD WARNING-REAR-RH
GVV 1 5 00376-5 00390-5 GW 1 0 A16 000 0 75 01518-3 01519-3 GO 75 00928-2
TRAILER PICK-UP GVV 1.0 C0929-2 C1260-2 GW 1 0 C0499-N
Fig 35 Splices and centre taps I - EEGR
Aug 00 (Amdt 1) Chap 13-1
Page 43
2320—D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
A33 (GR)CHASSISI: is A316 + 13316 (GR) MAIN
GR.() 75 C0001-2
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-FRONT-LH SWITCH-HAZARD WARNING
00096-3 GR.1 5 8316 GR 1 5 A316
II ;
INSTRUMENT PACK LAMP-SIDE REPEATER- CO230-10 GR 0 5 FRONT-LH
GR.0 75 C0013-1
SWITCH-DIRECTION 1- - INDICATOR LAMP-DIRECTION INDICATCR/
C1042-4 GR0.75 J HAZARD WARNING-REAR-LH
II II" GR,1 5 C0376-4 C0390 4 GR 1 0 GR 0 75 01517-3 C1519 3 00 75 00928-2 L
TRAILER PICK-UP A36 + B36 (RN) CHASSIS ! GR 1 0 00929-101260-1 GR 1 0
FUSE BOX-PASSENGER COMPARTMENT TRAILER PICK-UP
u C0580-12 RN 0 75 C0376-2 C0390-2 RN 0 75 B36 RN 075 A36 RN.0 75 01305-2 C1306-2 RNLI 0 C0499-A
RN .0. 75 C1300-3 C1306-3 RN,1.0 00450-0
LAM P-CON VOY-R H 145-0 (11305-4 01306-4 RN 1 0 00450-H irr ---- '71 (1:1065-1 RN 0 5 01522-1 C1521-1 RN 0 /5
II
A 168/A109 (UW) MAIN
L,447 (WR)MAIN
SWITCH-IGNITION RELAY-STARTER FUSE BOX-PASSENGER COMPARTMENT
A165 I II 00580-25 UN/ 2 0 A185 UW2 0 01042 5
SWITCH-COLUMN
03090-1 WR.1.0 A47 VVR 10 CO151-85 1. (
00580-27 UVV.2 0 INSTRUMENT PACK RELAY-BRAKE CHECK UNIT-TIMER-GLOW PLUG UVV2 0 00233'
C1012-86 WR.0.5 VVR,0 5 00189
1';
L A191 (LGN) MAIN
!! A48 (W) ENGINE RELRANYI-NI-r RD
SOLENOID-FUEL CUT-OFF
SW TCH-HAZARD WARNING 00096-2 LGN.1 5 AI91 1 5
WALGN HEADER 0285
285-16 W 2000 0 C0448-4 00162-4 042 0 A40 552 0 C0198-1
SWITCH-COLUMN
ECU-EGR I GN 1 9 01042.3
W 1 0 C0032-3 f„ 11 A213 (RB)MAIN , LAMP-SIDE-
FUSE BOX-PASSENGER COMPARTMENT FRONT-RH ;, 00580-30 RB 075 A213 RB.0 75 00531
:INSTRUMENT PACK RB 0 5 CO233-3 1
Fig 36 Splices and centre taps II - EEGR
Chap 13-1 Page 44 Aug 00 (Amdt 1)
Chap 13-1 Page 45 Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
Fig 37 Splices and centre taps III - EEGR
SUPPORT PUBLICATION
G0.75 GAUGE-COOLANT TEMPERATURE
01040-401048-4 G056.11 00.5 01052-I 7 --
ril GO 5 C1054
GAUGE-FUEL SOCKET-ACCESSORY C1136-3 G05
4370 UCi0 5
A378 (0G) MAIN
FUSE BOX-PASSENGER COMPARTMENT
C0580-34 1X01 0
MOTOR-HEADLAMP LEVELLING-RH
C0070-3
RESISTOR • C0038-2 UG 1 0
MOTOR-HEADLAMP LEVELLING-LH
000 5 /1
RIA/ 0 F., 01134 .,SOCKET-ACCESSORY
N60
RELAY-STARTER
A243 (N)MAIN SJ3 (N)
FUSE BOX-ENGINE COMPARTMENT 1 03570-2 N 6.0
A341 (UR) MAIN
FUSE BOX-PASSENGER FUSE BOX-PASSENGER COMPARTMENT SWITCH-COLUMN COMPARTMENT
4243 5.20 C0580-13 ' ; 01042-6 U62 0 4141 06.2 0 C058021
UR 1 0 00580-23
111111 UR 1.0 00580-33
A351 (RO) MAIN SJ2 (RW) INSTRUMENT
FUSE BOX-PASSENGER COMPARTMENT SOCKET-ACCESSORY 00580-32 50,05 1351 60.075 01027-1
SWITCH IGNITION 1- C0028-1 N,4 5 SJ3 N,2 0 03580-35
SOCKET-INSPECTION 01064-1 N 2 0 N 3 0 03151-87
I A331+ A333 (G) MAIN SJ1 (G) INSTRUMENT
FUSE BOX-PASSENGER COMPARTMENT 4331 C05806 G20 A333 G20 00030-4
SWITCH-WIPER DELAY
, 00303-8 01 D G1 0 00278-6
MOTOR-WIPER-WINDSCREEN
11 R0,05 01040-5 C1048-5
SJ2 608.1 0 GAUGE-COOLANT TEMPERATURE
0-080 0 01050-1
SPEEDOMETER 01060-1 R-V40 5
GAUGE-FUEL SWITCH-VIASHAMPE 01087-i RIN,0 -WINDSCREEN
01061-1 4/40 5
FUSE BOX-PASSENGER COMPARTMENT SWITCH-COLUMN 01580-19 U,2 0 A334 1.1 .2 0 01042
020 C1017-201070-2 U,20 C1084-1 .6 957 WAY LIGHTING SWITCH
. d A381 (U Y) MAIN A334 (U)MAIN MOTOR-HEADLAMP
• RESISTOR LEVELLING-RH 00037-2 411(0.5 A381 UY.0.5 00070-1
MOTOR-HEADLAMP LEVELLING-LH
0105 00071-1
LAW 0 RESISTOR
C1960 2 I SJ1 (KB) ENGINE
SENSOR-TEMPERATURE-EGR 00027-2 KB4O 5 SJ1 KB 0 5 00175-
SENSOR-THROTTLE POSITION (TP)
Chap 13-1 Page 46 Aug 00 (Amdt 1)
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
SJ2 (RB)ENGINC A.3134 (GU) MAIN '
98,05
SENSOR-THROTTLE POSITION (TP)
C01/5-3 SWITCH-HEADLAMP LEVELUNG
Li 000935 GU 1 0
fr?,
RESISTOR '71 CC038-1 GU.1 0
TUM G"-° 5
TUL G" 05
RESISTOR C1061-1
RESISTOR C1098 1
ECU-EGR 01862-2 98.05
SOLENOID-EGR RB 0 5 00191-1
A384 GU 1 0 01506-301507-3
fl 4441(W) MAIN
SWITCH-IGNITION 00094-1 W2 0 A441 W20
a —
W20
W2.0
SJ1 + SJ2 (UB) RESISTOR PACK
SWITCH-HEADLAMP LEVELLING
TUL 00,0 5 SJ1 UB05 i
o-- -̀ Li 00093-2 US 1 0 01506-1 01507-1 110 0 5
TUM UB 05 SJ2 uB.oS
SOLENOID-EGR
Fig 38 Splices and centre taps IV - EEGR
FUSE BOX-PASSENGER COMPARTMENT
00580-5
HEADER 0285 00285-11 1
CO285-17 ,
RESISTOR 01095-2
RESISTOR 01007-2
RESISTOR 01961-2
K0,0 5 ECU-EGR
00032-1 K805
Chap 13-1 Page 47 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
BATTERY 00192-1 C0045-1 6,400 EARTH STARTER MOTOR
C0849-1 r C0823-1
C0824-1
C0179-1 1
R.25.0
R,100
H
C0632-1 LINK 00570-2 N.6.0 A243 N,6.0
FUSE BOX-ENGINE COMPARTMENT
LINK 3 , 00370-3 3N 6 0 460 r_cf.N...a_.
v
0011.3.0 00203-1 C0449-1
NA 5 0J3
RELAY-STARTER
N 30 C0151-87 , - 00151-30 WR 30
00090-1 VON 10 T HEADER 0285 1 00094-1 W20 A441 W20 00285-11 ' 00255-0 2900,2 0 86(1
CO285-12 44W20.560 . ..
W20 CO285-17 ' , 00285-10 33002 0 560 ' -
CO285-16 W2.0 0)448-4 C0162-4 W.20 A48 W.20 SOLENOID-FUEL CUT-OFF 4'0 coase-i
00028-1
C
F
EARTH VIA FIXINGS
A47 WR 1 0 00151-85 00151-86 3658.10.170
rt̀14-- "•
SWITCH-IGNITION 75WR,0 5.630
I N.6.5 00183-1
ALTERNATOR/GENERATOR
• r_.1
(-0448-300162-3 NY.0 C0185-1 FARTH VIA FIXINGS
DIODE NY0 5 00118-2 ' 00110-1 030N 0 5 445 A
Fig 39 Charging and starting I - EEGR
SUPPORT PUBLICATION
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION
INSTRUMENT PACK GLOW PLUG 1
C0476-1 EARTH VIA
• A YN.0 5 CO230-5 FIXINGS
W2.0 UU2,35-4 GLOW PLUG 2
YB.3 0 C0477-1 • ,._H• CARTS VIA
FIXINGS
W20 CO233-9 4 CO233-10
GLOW PLUG 3 BY .3 0 C0478-I
EARTH VIA FIXINGS
UNIT-TIMER- GLOW PLUG
WR,0 5 00189.1 C0189-2 YB 05 GLOW PLUG 4 YB 3 0 C0479-1 71
r-,,iTHt.ierA -4' C1035-1 W, 0 C0189-3 • 1 C0189-6 85.6 0
H373
N,6.0 C0189-5 C0189-4 8.0 . 5 A376 B.I.5 SJ6 8,4.0 C0556- I
9384 A365
8.1.0 A366 B.1.0
Fig 40 Charging and starting II - EEGR
Chap 13-1 Page 48 Aug 00 (Amdt 1)
STARTER MOTOR C082,1
R100 COB2.1-1 sPEECOME TER
G11..11 111 ,..10408,.:10.40-3 11 0, B 4 0 „ (7
%NO 8, (:10611 ^
1210610 SoS
BATTERY R 250 c019, ' 20045 1 B400 030531
FUSE BOX-ENGINE COMPARTMENT
uNrct 0,05761 N30 810181 c.
GAUGE-FUEL C10861 80 8,
R1,NO 8- 8105%1 21051- B.0
1130
6 OR 7 WAY LIGHTING SWITCH
N1088-1 R ns
NO 78
GAUGE-COOLANT TEMPERATURE
C1088-1 B 0 5
• 01005 12105E81 8.21259-0 B05
RW10 [1040,, r FUSE BOX-PASSENGER COMPARTMENT
CU.°, ,._ '6'6 6 1_0:8032 0008 0051 0005
I
AMMETER
80010 01021 1 81712 1 ROO 5 01153-1 211532 808 8.12 8103 1 8 20 A228 0 2 0
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
Fig 41 Interior illumination - EEGR
Chap 13-1 Dec 13 (Amdt 3) Page 49
2320-D-128:302
R,250 C01921 ! 31413W 0 75.2120
3 JJAW0.75.1670
BATTERY SWITCH-HAZARD WARNING 00045B.400 EARTH 111 00096-4 GVV 1 5 R310 GVV 1 5 A310
GWO 75 STARTER MOTOR
00823-1 '1--
D 3 6GR 1 5,340
320GR,0 75.2240 00096-3 GR, 1 5 9316 GR,1 5 A310
32109,075.1790
GR.0 5
GR 0 75
SWITCH-COLUMN 1:0096-1 BR.0 5
N C1042-4 IAN 1 b 121042-3 ! 00096-2 LGN 1 5 A191
01042-2 C0096-5 LG1 5
INSTRUMENT PACK
CO230-9
CO230-10
01037 RELAY-HAZARD WARNING
A364 A365 A366 3658.1 0.220
GW,0 75
6 OR 7 WAY LIGHTING SWITCH • CO285-1/ CO285-13 70 20
C0,17-87 • 1 00547-30 LGP05 00733-1
C0547-86 8.0 5
B.0.5
C0547-85 !
• 1-
Fig 42 Indicators and Hazards I - EEGR
Chap 13-1 Page 50
Dec 13 (Amdt 3)
HEADER 0285 LAN. I5
C0028-1
- V
RELAY-IGNITION
CO218-05
CO218-R3
1 CO233-2 8 15 10
C1036-I 905 H
R,10.0 00824-1
FUSE BOX-ENGINE COMPARTMENT
C0632-1
LINK 2 1
LINK 1 1
00570-2 N 6 0 A243 N.6 I)
C0070 N 3 0
N.30 C1080-1 C1018-1
N 4 5 SJ3
SWITCH-IGN I I ION
ARMY EQUIPMENT SUPPORT PUBLICATION
310GV1/ 1 5 400 A
01082-1 C1087-1 NW2 0
NVV,2.0 G101&201060-2
1AN.2 0 CO218-30
FUSE BOX-PASSENGER COMPARTMENT
00580-7 FUSE 4 00218-87
C0580-3 NVV.2 0
Nss. NW 1 0
OR 075
LAMP-SIDE REPEATER-FRONT-LH
ram, 0001, 130 5
A G. l (0770 5 20600 5 GIA/ 10 070 I LAMP-DIRECTION INDICATOR, HAZARD WARNING-REAR-AR
c.11.1856.1010, :00202 0110211, 0010. 001 0I0 015100010100 000 A0 0 2 0
,63 Amie 0160 6 11-
6'01A
LAMP-CIRECTION INDICATOR, HAZARD WARNINGREAR-LH
67.072,1 00926.1 11 0 15 001 B 1 0 (I1,17.5 R .0 021 B '2 0 G1,56-.1
D GR I 5 CO.04 C0000-4 I GR 10 A33 III
GR 10 001720!.1-'00.1 GH TRAILER PICK-UP
GW10 U19,-2111.00., GIN 0 1.6100-0
LAMP-SIDE REPEATE R-FRONT-RH
4.001B.1 000122 001, G Gv010 7'6
040
LAMP-DIRECTION INDICATOR, HAZARD WARNING-FRONT-RH
G0002— CIX10..•1 u u 5
A.122 G 1210.15400
11 ,051 0 5 0B
J 010
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
LAMP-DIRECTION INDICATOR/ HAZARD WARNING-FRONT-LH 0072
113, GR 0 75 (0001 2 00001 1 R05 A014 1115 .170 0.t5
Fig 43 Indicators and Hazards II - EEGR
Chap 13-1 Aug 00 (Amdt 1) Page 51
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
ECU-EGR ALTERNATOR/GENERATOR C1862,1 008.0 78 C1863-1
I. I—
MODULATOR-EGR 1 C1721-A G10 CO270-1
BATTERY 01721-B 1 0 00270-2
1 ;' 00345-1 8,400 EARTH
35CR.5CR.1640
SOLENOID-EGR
00807-1
C1862-3 813.0.5 C0191-3 :: C0191-2
STARTER MOTOR C0823-1 j
00191-
R 10.0 C0824-1
C1862-2 RBO 5 SJ2 80.0 5
80.05
SENSOR-THROTTLE FUSE BOX-ENGINE COMPARTMENT POSITION (TP)
01862-4 R 0 5 00175-2 r 00175-3
00637-1 LINK 2
00570-? N60 A1,43 N.A 05175.1 dmaraimierair
SENSOR-TEMPERATURE -EGR N 4 5 SJ3 00032-2 GU .0 5 00027-1 1 00027-2
KR 05
SWI TCH-IGNI I ION 00332 I 80,02 5J1
00028-1 ----- C0094-1 W_20 A441 W.2.0 KB 05
13360
W I 0 C0082-3 00032-4 0.1 0 A33 B 1 0 00102-8 00448-8 B.1 0 8370 0.1 5 0J6 040 00758-1
HEADER 0285 CO285-17 CO285-16
L - W2 0 00448-4 00162-4 802.0 A48
Fig 44 EEGR
Chap 13-1 Page 52 Aug 00 (Amdt 1)
8,25.0 00192-1
ARMY EQUIPMENT SUPPORT PUBLICATION
R.25.0 03192 BATTERY
STARTER MOTOR
C0045-1 B.40.0
C0823 "
R,100 00824-1
FUSE BOX-ENGINE COMPARTMENT LINK 2 00.570.2 N 60
036321 LINK 1 ' C0570.1 14.3.0
N 3 0
N45
EARTH
A243 N.6 0
01018-1 01080.1
SJ3
C0376-6 C0390-6 GP, 1 0 B6 GP.1 0
GP 1 5 C1018-3 C1080-3 GPO 5
GP,075
GPO 75
2320-D-128-302
A6 GP 1.0 TRAILER
C0929-3 C1260-3 GP 1 0 PICK-UP
GP1.0 C0929-4 C1260-4 GP,1.0 00499-2
LAMP-BRAKE-LH '
01517-6015136 GPO C0490-2 C0490-1 B.0 /5 Al2 9.075 SJ1 8,10
10 1 B.? 0 C151/-5 C:1519 ti
2 0 00558-1
A8 B 2 0 C0557-1
2 0 01518-501519-5 LAMP-BRAKE-RH
21518-6.21519-6 GPO 75 20490-2 , : 20490-1 8.075 Al2 B 0 75 SJ1 0.10
LAMP-REVERSE-RH
GN 075 C0455-2 I C0455-1 B 0 75
SWITCH-IGNITION , .
00028-1 C0094.1
60R!WAY LIGHTING SWITCH
C1082-1 01007-1 NW.2 0
HEADER 0285 W20 A441 W.20 00285-17 CO285.13
V
NW.2 0 01018-2 C1080-2 RELAY-IGNITION
WY ? 0 CO218-30 !
FUSE BOX-PASSENGER COMPARTMENT c62113-85 W 2 0
! NNE 0 CO218-87
-
CO218-86 805
SWITCH-BRAKE PEDAL C0580-8 67 1 5 C0029-1 00()75-1 661 0 010184 01085-4
00162-5 05448-5 GY.0.75
SWITCH-REVERSE LAMP GO 5 00167-2 , 00167-1 GN 0 5 00162-600448-6 GN,10
:
A364 6365 6366 B 1 0 SJE. B 4 0 50555-1
C037/-1 00301-1 GN.1 0 01518-1 01519-1
00580-7 FUSE 4
C0580-1
NW.1.0
Fig 45 Brake reverse lamps
Chap 13-1 Dec 13 (Amdt 3) Page 53
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
LAMP-FOG GUARD-REAR-LH
RY 0 75 01517-2 01519-2 RY,0 75 00515-2 I, 00515-1 B.075 SJ1 B 10 C1519-501517-5 B.20 A21 B.20 03558-1
BATTERY 0,25.0 C0192-1 r I - 00045-1 8.400 EARTH
STARTER MOTOR 03823-1 °
R,10.0 00824-1
01018.101080-1 A10
FUSE BOX-ENGINE COMPARTMENT
03632-1 LINK 1 - C0570-1 N,30 RY,1 0 01305-6 01306-6 00,1 0 TRAILER PICK-UP
00490-F
N.3 0
6 OR 7 WAY LIGHTING SWITCH
C1082-1 [1 " 01084-1 U.2 0 C1079-2 C1017-2
LAMP-FOG GUARD-REAR-RH
07,0 75 C1518-2 01519-2 RY,0 75 00515-2 . • C0515-1 RO 75 SJ1 13.1 0 C1519-5 C1518-5 B 20 A8 0.2 0 00557-I .10 •1•11k"
RY.1 0
U,2.0 A334 U 0
FUSE BOX-PASSENGER COMPARTMENT SWITCH-FOG GUARD LAMP-REAR
00580.19 FUSE 10 00580-20 UP 1 5 00064-2 00064-3 RY 1 5 03376-300390-3 . .
INSTRUMENT PACK
A322 RY,0 5 00233-4 1 CO233-2 8.1 5 6323 5.1 5 026 BA 0 Wr66.1
Fig 46 Fog lamps
Chap 13-1 Page 54
Dec 13 (Amdt 3)
FUSE BOX-ENGINE COMPARTMENT 6 OR 7 WAY LIGHTING SWITCH
BATTERY 00192-1 00045-1 6.40 0 EARTH R.25 0
CE632-1 LINK 1
00570-1 N 3.0 C1018-1 01080-1 N 30 C1092-1 1 C1084-1 U20
STARTER MOTOR 00823-1
ARMY EQUIPMENT SUPPORT PUBLICATION
2320-D-128-302
SWITCH-COLUMN
C1079-2 C1017-2 U.2.0 6334 U.20 C1042-1
UR 10 A341 UR.2 0
FUSE BOX-PASSENGER COMPARTMENT
CO580-33 FUSE 17 . C0580-34 UG 1 0
SWITCH-HEADLAMP LEVELLING '! 000935 Gu.1 0 6384 GU,1.0 Guam
MOTOR-HEADLAMP LEVELLING-RH A378 0100 5 00070-
A367 A368 0368
UY.0 5 00070-1 C0070-2 B.0 5 A369 0.1 5 A370 B 1 5 SJ6 0.4 0 03579- 1
RESISTOR MOTOR-HEADLAMP LEVELLING-LH 000382 UG1 0 ue,o C00/13
A372 RESISTOR A373 8373 00037-2 UY,0 5 A381 U5.05 00071-1 000 /1-2 6.0.7 A374 6.1 5 A376 8.1
RESISTOR
. /stassmsossaismr
TUL UE0.5 SJ1 LJB.0 5 C1097-2 C1097-1 0.05 TUL
01507-2 01506-2 0.1.0 A322 A323 B 1 5
TUM
TUM
RESISTOR 06.0.5 SJ2 U8.0.5 01960-2 :: :' 01960-1 6,0
RESISTOR TUM GU.0 5 01961-1 '""" - — 0106 US 0 5
RESISTOR TUL GU,0 01098-4 r 01098-2 UB,0
C0093-4 50.1 0 00037-1
710093-2 UBT 0
C 30E6 C1507-1 =MN
G0,10 C1506-3 C1507-3
Fig 47 Headlamp levelling
Dec 13 (Arndt 3) Chap 13-1 Page 55
R.10.0
C0632-1 LINK 1 C0510-1 N 3 0 01018-1 C1080-1
N.3,0
6 OR 7 WAY LIGHTING SWITCH HORN A372
6373 6373
C1082-1 '1 C1087-1 NW2 0 01080-201018-2 PB 10 C0003-1 00004-1 B 10 A375 8,15 A376 B 15 SJ6 B,40 56- 1C05
NV1.12 0
FUSE BOX-PASSENGER COMPARTMENT C0580-1
HEADER 0285 00590-3 FUSE 2 C0580.4 CO205-5 00285-4 P.1 5 01042-7 r 01042-0 u
NVV.1.0 SWITCH-COLUMN
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
BATTERY C0045-1 Fl 40 0 FAR] FI
• “.tH
STARTER MOTOR C0823-1
FUSE BOX-ENGINE COMPARTMENT
Fig 48 Horn
Chap 13-1 Page 56
Dec 13 (Arndt 3)
ARMY EQUIPMENT SUPPORT PUBLICATION 2320-D-128-302
BATTERY 8,25.0 00192-1 C0045-1 B.400 EARTH
STARTER MOTOR C0823-1 R,10.0 C0524-1
V
FUSE BOX-ENGINE COMPARTMENT LINK I C0570-1 0.30 C1018-1 C1080-1 N 30
00632-1 . L INK 2 L 00570_2 N,60 A243 N 6 0
N 2 0 SJ3
6 OR 7 WAY LIGHTING SWITCH
01086-1 R0.5 01079-3 C1017-3 0.0.75 C1082-1' C1083-1 RN 05 01079401017-4 911.0 75
FUSE BOX-PASSENGER COMPARTMENT
00580-31 FUSE 16 00580-32 R0.1 5 00376-1 00390-1 R0.1 0 •
TRAILER PICK-UP Al 80,10 01305 1 01306-1 00,1 0 C0499 -E RN,0 75 01305-2 C1306-2 Rut 0 00499-A ,1
00580-1I "'SI- 6 j 00580-12 RN 075 00376-2 00390-2 RN.0 75 01305-3 01306-3 RN 10 836 RN.0 75 A36 00.0 75 C1305-4 C1306-4 RN 1 0 00499-H
imisumniminme.
RN.0 75 00499-C
00580-35 FUSE 18 00580-36 P 1 5 00377-6 00391-6 P 2 0 01300-5C1306-5 P.1 0 00499-K 00499-D 8.1000361-1
SWITCH-FOG GUARD LAMP-REAR 00064-3 127.15 00376-300390.3 RYA 0 A10 RY 10 01305-6 C1306-6 RY 1 0 C0499-1
C04991 8.1.0
SWITCH-BRAKE PEDAL 00075-1 GR1 0 01018-4 01080-4 GP .0 5 01080-3 01018-3 GP 1 5 00376-6 00390-6 GP 1 0 a
06 GP 1.0 06 GR1 0 00929-3 01260-3 GR1 0 00499-6 GP 1 0 00029-4 01260-4 GP.1 0 00499-J
SWITCH-COLUMN 0104-4
WO 75 B316 00.1 5 A316 GR. 15 C03704 00380-4 GR.1 0 A33 00,1 0 00926-101760-i GR 1 0 00499-M
SWITCH-HAZARD WARNING C0096-3 GR 1 5
C0096-4 GW1 5 B310 GW1 5 A310 GW 1 5 C0376-500390.5 ON 1 0 A16 GW 1 0 00929-201260-2 1376 1 0 00499-N 01042-2 e, GWO 75
Fig 49 Trailer socket
Dec 13 (Amdt 3) Chap 13-1 Page 57
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
BATTERY R.250 00192-1 C0045-1
•-•t—L • •-•Ht-: B 400 EARTH
STARTER MOTOR C0823-1
R.10.0 C0824-1 ;
FUSE BOX-ENGINE COMPARTMENT FUSE BOX-PASSENGER COMPARTMENT
C0632-1, LINK 1 t; C0570-1 N.3 0 C 1018-1 01080-1
00580-29 h FUSE 10 c0580-30 21499,0.75,2190 A
_ _ h N,3 0 RB 0 75 A213 213R9 0 75 1750
6 OR 7 WAY LIGHTING SWITCH 00500-31 FUSE 16 C0580-32 00, 1.5 C0376-1 C0390-1 150,1.0,3900 C1085-1 0.05 C1079-1 01017-1 9075 0:><C)
01082- • 01086-1 9,0 5 C1079-3 01017-3 R,0 75
C1083-1 RN.00 C1079-4 C1017-4 RN.0 75 00580-11 1 6
0
FUSE C0580-12 RN 075 C0376-2 C0390-2 36RN.0 75.3810
- ><C) C1084-1 U.2.0 01079-201017-2
3,2,0 A334 U 2.0
UR,1 00580-23 FUSE 12 06580-34 3905 K,20,2360
SWITCH-COLUMN
C1042-6 UR 2.0 A341 UR 2 0 C0580-21= FUSE 11 ; C0580_22 39255.2 0,2440 n C1042-1
#."-•
A168 ;, 01042 5 11W2 5 A189 1102 0 00580-25 FUSE 13 C0080.26 3911102 0 2440
of
UW2S 00580-27 FUSE 14 00580.28 389502 0,2360
INSTRUMENT PACK
513 0 5 CO233-3 00233-2 6.15 A322 32213,15,510 mimommomnimm,
U702 0 CO233-5
Fig 50 Head, side and number plate lamps I
Chap 13-1 Page 58 Dec 13 (Arndt 3)
TRAILER PICK-UP RN.1 0 C0499-A C1305-2 C1306-2
C1305-3 C1306-3 RN,1 0 C0499-0
01305-4.C1306-4 RN,1 0 C0499-H
C1305-1 C1306-1 RO 1 0 C0499-0 ,
SJ1
SJ1 1
A367 A368 A369
B36 A36 RN,0 75 RN,0 75 RN 0 75
RN.0.75
RN,0 75
RO 10
LAMP-CONVOY-RH
RN,0 75 C1521-1 01522-1 RN 05 01065-1 , , 00808-1 8 0 5
NUMBER PLATE-U-1 LAMP-REAR
0 75 C1517-401519-4 R0,075 All R0075 C0138-1 I, 00138-2 B.0 75 Al2 h-- ,, ----0, .wimiiiis d
B4O 75
LAMP-TAIL-LH
RO 0 75 001212 C0121-1 B 0 75
LAMP-TAIL-RH
R0.075 C1515-401519.4 RO 0 75 All R0075 C0121-2 ' ", 00121- SO 75 , ---i4.
LAMP-REAR NUMBER PLATE-RH ,
60,075 00138-1 d , 00138-2 0.075 012 •, 13,0.75 11 ,•„„ ....S.
..i
HEADLAMP-RH :1. •
U0 2 0 00011-1 Sta=gg
C0011-3 615
UB 2 0 C0011-2
LAMP-SIDE-FRONT-RH
R8075 00537- C0537-2 8.05 11-
LAMP-SIDE-FRONT-LH
185,0.75 C0538-1 ; , 00538-2 5,0.5
HEADLAMP-LH '
U5.2.0 C0009-1 :00009-3 B,1.5
UK 2 0
, :, C0009.2 J,
B.1 5
01522-2 C1521-2 8075
13.1 0 C1519-5 C1517-5 13.2 0 A21 B.20 ODS55- 1
8 1 0 01519-5 01518-5 5.20
2
AA 8.20 crf,57. I
B 1 5 8368 A370 6.1 5 516 B A 0 M550. I
A372 A373 A374 8,1 5
8373 A376 8,1,5
R0,1.0
A
H
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
Fig 51 Head, side and number plate lamps II
Aug 00 (Amdt 1) Chap 13-1
Page 59
SWITCH-WASH/WI PE- WINDSCREEN
CO2/8-3
FUSE BOX-PASSENGER COMPARTMENT
C0580-5 FUSE 3
0(680-6 G2 0
CO278-2
411 0027£1,1 A331
A333 G.10 CO278-6
BATTERY
R,25 0 C0192-1 .1 00045-1 8.400 EARTH
STARTER MOTOR
!]— R,10.0 C0824-1
FUSE BOX-ENGINE COMPARTMENT
LINK 2 C0632-1 , C05/0-2 N 6 0 8243 N 6 0
N 4.5 SJ3
SWITCH-IGNITION
C0028-1 • 00094-1 W.20 8441 W20
C0823-1
C0303-6 L68.0.5
60,303-2 YLG1 0
00303-1 V1G1 0
G,1.0 00303-8 C0303-5 NLG,1.0
ECU-DELAY-WINDSCREEN WIPER 00303-4 13 0
A364 0365 A366 (3.10 SJ6 6,40 00509.1
PUMP-WASHER- WINDSCREEN
, 6373
C0008-2 00008-1 8,0,5 A376 6,1.0
00278-4
68,0 5
00278-5
6,20 C0030-4 •
MOTOR-WI PER- WINDSCREEN
000305 RLG.1.0
C0030-3 ULG,1.0
C0030-2
SWITCWPARK 000301 8.2.0 WNDSCRE EN
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION
Fig 52 Wipers and washers — front
Chap 13-1 Page 60 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302 SUPPORT PUBLICATION
BATTERY R,25 0 00192-1 00045-1 0.40 0 EARTH
STARTER MOTOR 00823-1 —
FUSE BOX-PASSENGER COMPARTMENT
S16 B 4 0 C0556-1
5.100 C0824-1
FUSE BOX-ENGINE COMPARTMENT
C0632 1 LINK_ C0570-2 8,60 A243 N 6 0 SJ3 N 4 5
SWITCH-IGNITION
coo.,8-1 c0w9-1 WO 1 0
MOTOR-BLOWER-FRONT SIMTCH-BLOMR MOTOR 00056-1 GS.1 0 00058-1 .•
......,_.; 00058-3 0 1 0 ,itL--0><:0--.4. coot,6-2 GO.1 0 C0580-9 , FUSE 5 , 00580-10 PG 1 0 00058-3 i
;_,
Fig 53 Heater
Chap 13-1 Aug 00 (Amdt 1) Page 61
N20 SJ3
2320-D-128-302 ARMY EQUIPMENT SUPPORT PUBLICATION
BATTERY R.25 0 C0192-1 C0045-1 B 40 0 EARTH
STARTER MOTOR 00623-1
R,10.0 C0824-1 ._4
FUSE BOX-ENGNE COMPARTMENT
C0632-1 LINK 2 , 00570-2 N 6 0 A243 N.6 0
—Tscr\4)-
FUSE BOX-PASSENGER COMPARTMENT
C0580-d5 FUSE iS L C.21,80-: PO 5 C1b15-3
---(1,-<..)-- . 4 -1‘-` ' C1515 2 pwas 011111 C1111-2 B 0 5 A228 8.20 SJ6 0 4 0 035.56 1
, . . --H
Fig 54 Interior lamps
Chap 13-1 Page 62 Aug 00 (Amdt 1)
SWITCH-MAP LAMP LAM P-MAP