manual service renault scenic 2 informatii generale 3
TRANSCRIPT
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 1/19
© Renault s.a.s. 2005
"The repair methods given by the manufacturer in this document are based on the technical
specifications current when it was prepared.
The methods may be modified as a result of changes introduced by the manufacturer in theproduction of the various component units and accessories from which his vehicles areconstructed."
All copyrights reserved by Renault.
The reproduction or translation in part of whole of the present document, as well as the useof the spare parts reference numbering system, are prohibited without the prior writtenconsent of Renault.
77 11 322 002 JUNE 2003 Edition Anglaise
X84, and J84
0 Vehicle general information
01AMECHANICAL SPECIFICATIONS OF THEVEHICLE
01D MECHANICAL INTRODUCTION
02A LIFTING
03A TOWING - LASHING
04B CONSUMABLES - PRODUCTS
05A DRAINING - REFILLING
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 2/19
Scénic II - Section 0
Contents
Page
Scénic II - Section 0ContentsPage
01AMECHANICAL SPECIFICATIONS OF THEVEHICLE
Vehicle identification 01A-1
Dimensions 01A-2
Engines - Gearboxes 01A-3
01D MECHANICAL INTRODUCTION
Computer locations 01D-1
02A LIFTING
Trolley jack - Axle stand 02A-1
Underbody lift 02A-2
03A TOWING - LASHING
All types 03A-1
04B CONSUMABLES - PRODUCTS
Capacities - Grades 04B-1
Packaging 04B-2
05A DRAINING - REFILLING
Engine 05A-1
Gearbox 05A-4
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 3/1901A-1
MECHANICAL SPECIFICATIONS OF THE VEHICLE
Vehicle identification 01ALOCATIONS OF VEHICLE IDENTIFICATIONPLATES
Plate (A):
100566
100565
A
B
19031
(1) Vehicle type mine and type num-ber; thi s information alsoappears on marking (B)
(2) MPAW (Vehicle's Maximum Per-missible All-up Weight)
(3) GTW (Gross train weight, vehi-
cle under load with trailer)(4) Maximum permissible front axle
load
(5) Maximum permissible rear axleload
(6) Vehicle technical specifications
(7) Paintwork reference number
(8) Equipment level
(9) Vehicle type
(10) Upholstery code
(11) Additional equipment details
(12) Fabrication number
(13) Interior tr im code
1
76
135 12
1111
4
A
10
3
9
2
8
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 4/1901A-2
MECHANICAL SPECIFICATIONS OF THE VEHICLE
Dimensions 01A
Dimensions in metres:
103196
- Scénic Scénic long version
A 0.851 0.851
B 2.685 2.736
C 0.723 0.906
D 4.259 4.493
E 1.514 1.506
F (unladen) 1.620 1.636
G 1.514 1.506
H 1.810 1.810
BA
D
G
EC
H
F
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 5/1901A-3
MECHANICAL SPECIFICATIONS OF THE VEHICLE
Engines - Gearboxes 01A
Vehicletype
Engine
Gearboxtype
Engine
type
Engine
suffi
x
Cubic
capacity(cc)
JM0B
JM0H
JM1A
K4J 730 1390 JH3
JM0C
JM0J
JM1B
K4M
761
1598
DP0
JM0Y 764
JR5JM0C
JM0J
JM1B
782
JM0U
JM05
JM1N
F4R
770
1998
ND0
JM0U
JM05
JM1N
JM1M
JM1U
771 DP0
JM0W
JM1T
776 ND0
JM0F
JM0T
K9K
722
1461JR5JM1F 724
JM02
JM13
728
JM1E 732 TL4
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 6/1901A-4
MECHANICAL SPECIFICATIONS OF THE VEHICLE
Engines - Gearboxes 01A
VEHICLE IDENTIFICATION
Example: JM0F
J: Bodywork type
- J: 5-door MPV
M: Project code
0F: Engine suffix
JM1D
JM14
JM15
JM17 F9Q
804
1870 ND0
JM0G
JM12
JM1G
812
JM1K M9R 700 1995 PK4
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 7/1901D-1
MECHANICAL INTRODUCTION
Computer locations 01D
103476
1 2 3 4 5 6 7 8 9 10
11121314151617181920212223
(1) Central communications unit
(2) Radio or CD changer
(3) Air conditioning
(4) Card reader
(5) Right-hand electric window con-trol
(6) Right side impact sensor
(7) Air bag computer
(8) Electric steering column lock
(9) Rain and light sensors
(10) Instrument panel
(11) CD multi-changer or surroundsound unit
(12) « Hands-free » opening aerial
(13) Left side impact sensor
(14) Left-hand electric window con-trol
(15) Electric power assisted steer ingcomputer
(16) UCH
(17) Protection and switching unit
(18) Engine management injection
(19) Battery
(20) Left-hand side discharge bulbhigh voltage module
(21) Automatic transmission
(22) Anti-lock braking system - elec-tronic stability program
(23) Right-hand side discharge bulbhigh voltage module
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 8/1902A-1
LIFTING
Trolley jack - Axle stand 02A
To mount the vehicle on axle stands, the entire vehicle
must be lifted on one side and axle stands must be pla-ced under the reinforcements provided for positioningthe tool kit jack (1) .
IMPORTANT
If a trolley jack is used, appropriate axle standsmust always be used.
WARNING
- The subframe of this vehicle is protected by pro-ducts providing a 12-year anti-perforation war-ranty.
- Never use equipment not fitted with rubber pads,to avoid direct metal on metal contact that couldattack the original protective material.
- The vehicle must not be raised by support points
under the front suspension arms or under the rearaxle.
- To raise a front or rear wheel, use the jack at(1) .
101536
1
101535
1
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 9/1902A-2
LIFTING
Underbody lift 02A
I - SAFETY ADVICE REMINDER
- If it is necessary to remove heavy components fromthe vehicle, it is preferable to use a four post lift.
- On a two post lift, once this type of component hasbeen removed (e.g.: engine and transmission assem-bly, rear axle, fuel tank, etc.), there is the risk of thevehicle tipping.
- When the vehicle is raised on an underbody two postlift, fit (safety belt) part number 77 11 172 554available from the Parts Department.
II - FITTING THE STRAPS
Example of a a vehicle secured at the front
- For safety reasons, the straps must always be in per-fect condition; replace them if they are damaged.
- When fitting the straps, check that the protectors (forthe seats and fragile parts of the vehicle) are properly
positioned.- Thread the straps under the lift arms and loop them
back through the vehicle.
- Do not overtighten the straps.
Equipment required
safety belt
14894
14893
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 10/1902A-3
LIFTING
Underbody lift 02AIII - POSITIONING OF LIFTING ARMS
Front
Rear
101534
101537
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 11/1903A-1
TOWING - LASHING
All types 03AI - FRONT
II - REAR
Equipment required
diagnostic tool
WARNING
- For towing, refer to the current legislation in eachcountry.
- Never use the drive shafts as attachment points.
- The towing points may only be used for towing onthe road.
- Never use the towing points for removing the vehi-cle from a ditch or to lift the vehicle, either directlyor indirectly.
- Screw in and lock the towing ring before towing.
- Vehicles fitted with automatic transmission:
• tow the vehicle using a back-plate or by lifting thefront wheels. If this is not possible, in exceptionalcircumstances, the vehicle may be towed at aspeed below 12 mph (20 km/h) over a maximumdistance of 19 miles (30 km) (lever in N posi-tion),
• if the vehicle has a battery failure, the steeringcolumn remains locked. In this case, refit a bat-
tery or an electrical power source to lock the airbag computer using the (diagnostic tool) ( (see88C, Airbag and Pretensioners) ), which willunlock the steering column,
• If it is not possible to unlock the air bag compu-ter, the front of the vehicle must be lifted.
103195
103194
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 12/1904B-1
CONSUMABLES - PRODUCTS
Capacities - Grades 04B
(1) Engine fitted with particle filter.
Engine type
Average oil capacity
(check with dipstick) (l)
Oilchange
Oil change and
replacement
of oil filter
K4J4.7 4.8
K4M
F4R 5.25 5.4
K9K 4.4 4.5
F9Q4.5 4.6
4.7 (1) 4.8 (1)
M9R 6.4 6.7
Engine type
Average oil capacity
(check with dipstick) (l)
Oil
change
Oil change and
replacement
of oil filter
Component Capacity (l) Grade
Brake circuit Anti-lock braking system: 1
Normal: 0.7
SAE J 1703 and DOT 4
(low viscosity when cold)
Fuel tank Approximately 60 Unleaded petrol
Diesel
Note:
Brake fluids must be approved by the TechnicalDepartment.
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 13/1904B-2
CONSUMABLES - PRODUCTS
Packaging 04B
DESCRIPTION PACKAGING PART NUMBER
MECHANICAL SEALANTS
Z LOCTITE 518
For sealing the gearbox casing
24 ml syringe 77 01 421 162
Z Leak detector Aerosol 77 11 143 071
ADHESIVES
Z LOCTITE-FRENETANCH
Stops bolts slackening and enables them to bereleased
24 cc bottle 77 01 394 070
Z LOCTITE-FRENBLOC
For locking bolts
24 cc bottle 77 01 394 071
Z LOCTITE SCELBLOC
For bonding of bearings
24 cc bottle 77 01 394 072
LUBRICANT CLEANERS
Z NETELEC
Unseizing agent, lubricant
Aerosol 150 ml 77 11 171 287
Z Injector cleaner Can weighing 355 ml 77 01 423 189
Z Super-concentrated unseizing agent 500 ml aerosol 77 01 408 466
Z DECAPJOINT
To clean the aluminium cylinder head faces
Aerosol 77 01 405 952
Z Brake cleaning product 400 ml aerosol 77 11 171 911
GREASES
Z FLUORINATED GREASE
For the inside edge of the high voltage cover
100 g tube 82 00 168 855
Z MOLYKOTE « BR2 »
For:
- main bearing journal faces,
- lower arm bearings,
- torsion bar splines,
- driveshaft splines.
1 kg tin 77 01 421 145
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 14/1904B-3
CONSUMABLES - PRODUCTS
Packaging 04B
Z MOLYKOTE « 33 MEDIUM »
For:
- the tubular rear axle bushes,
- the anti-roll bar bushes.
100 g tube 77 01 028 179
Z ANTI-SEIZE
(high temperature grease) for turbochargers, etc.
80 ml tube 77 01 422 307
Z « MOBIL CVJ » 825 BLACK STAR OR MOBIL
EXF57C
For the drive joints.
180 g sachet 77 01 366 100
ZMULTIFUNCTION GREASE
Wheel sensor.Aerosol 77 01 422 308
MECHANICAL SEALANTS
Z MASTIC
For sealing exhaust pipe unions.
1.5 kg tin 77 01 421 161
Z RHODORSEAL 5661 100 g tube 77 01 404 452
Z HARDENER KIT (RHODORSEAL 5661)
For side sealing bearing caps.
Kit 77 01 421 080
LACQUER
Z « CIRCUIT PLUS »
Lacquer for repairing rear screen de-icer.
Bottle 77 01 421 135
BRAKE
Z « Low viscosity » brake fluid. DOT4 0.5 l bottle 77 11 218 589
DESCRIPTION PACKAGING PART NUMBER
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 15/1905A-1
DRAINING - REFILLING
Engine 05A
Use a square (oil draining wrench) (8 mm) .
Use a square (oil draining wrench) (8 mm) .
Equipment required
oil draining wrench
Essential equipment
8 mm square oil change wrench
K4J or K4M
18749
101530
1
(1) Drain plug
(2) Filler plug
F4R
19120
102739
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 16/1905A-2
DRAINING - REFILLING
Engine 05A
Use a square (oil draining wrench) (8 mm) .Use a square (oil draining wrench) (8 mm) .
(1) Drain plug
(2) Filler plug
K9K
101533
101531
(1) Drain plug
(2) Filler plug
1
F9Q
19120
101529
(1) Drain plug
(2) Filler plug
1
2
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 17/1905A-3
DRAINING - REFILLING
Engine 05A
Use a square (oil draining wrench) (8 mm) .
M9R
114651
114770
(1) Drain plug
(2) Filler plug
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 18/1905A-4
DRAINING - REFILLING
Gearbox 05A
JH3 or JR5
18749
(1) Drain plug
(2) Filler plug
ND0
101532
2
1
2
1
(1) Drain plug
(2) Filler plug
DP0
103406
103407
1
2
7/28/2019 Manual service Renault Scenic 2 Informatii Generale 3
http://slidepdf.com/reader/full/manual-service-renault-scenic-2-informatii-generale-3 19/19
DRAINING - REFILLING
Gearbox 05A
(1) Drain plug
(2) Filler plug
PK4
114652
114772
(1) Drain plug
(2) Filler plug