manual: ereg180 sm alpine en
TRANSCRIPT
JAP INE.
SERVICE MANUAL. 11-Band Graphic Equalizer
r ie 5 PPO ni
Fo. Fase leigiatetcialig
ER E-GUsSome
180
Contents
Specifications .....
Connections ...
Basic System .
Operation ....
Block Diagram 6
Parts Layout on P.C. Boards and Wiring Diagram (1/2) .7to9
Parts Layout on P.C. Boards and Wiring Diagram (2/2) . 10 to 12
Schematic Diagram (1/2)... . 13 to 15
Schematic Diagram (2/2) . 16 to 18
Electrical Parts List .19 to 23
Packing Assembly Parts List .... we 24
Packing Method View. ws 24
Exploded View (Cabinet) . 25 to 26
Cabinet Assembly Parts List ..... 227
Spare Schematic Diagram Inserted.
Specifications
Power Supply DC14.4V (11~16V)
Total Harmonic Distortion (2Vrms/Channel) wee 0.1%
Input Sensitivity (Ref. 2V Output)/Impedance 043dB/10k ohm
Output Impedance we 1K ohm
‘S/N Ratio (IHF-A) BBE OFF : 90dB
BBE ON : 85dB
Frequency Response (Ref. 1kHz, 30Hz~30kHz) 0+1dB
Channel Crosstalk Attenuation 60dB
Current Drain (2V/Channel) 550mA
Fader Control Effect 50¢B
Equalizer Band
Frequency Shaping Equalizer Controls
, 63, 125, 190, 250, 500, 1k, 2.2k, 4.5k, 9k, 18kHz
Boost : 11+3, -6dB
Cut : -11+3, -6dB
Channel Unbalance 0+3dB
Subwoofer Cut-off Frequency Response (20Hz, 2V Output, Ref. -3dB) 42+10Hz, 150+25Hz
Subwoofer Control Effect (at 20Hz, Input 200mV) 15+30dB
21 IC's, 36 Transistors, 17 Diodes, 5 Zener Diodes, 1 FET
Chassis : 178X25X 115mm.
Nose : 178X25X 17mm
0.64kg
Semi-Conductors
Dimensions (WX H XD)
Weight
NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.
'18C
ERE-G180
Connections/Connexions/Conexiones
© Remote On Lead (BLUEMWHITE) Connect this lead to the remote turn-on lead of your head unit. Applying (+)12V to this lead turns on the ERE-G180. If your head unit has a power antenna output that provides (+)12V when the unit power is turned on, you may use that lead to turn the ERE-G180 on.
Ground Lead (BLACK) ‘Connect this lead to a good chassis ground. ‘Verity this point o be a true ground by checking continulty between this point and the negative terminal of the vehicle's battery, For best results and immunity to vehicle induced noise, ground ail audio components, at the same ground point
NOTE: ‘Secure the ground lead of the unit to bare metal on the car chassis using a sheet metal screw.
© Battery Lead (YELLOW) ‘Connect this lead to the positive (+) post of the vehicle's battery
= ic)
Batterie
NOTE: +12V is required on this line to turn on the ERE-G180. If your head unit does not have a remote-on or power-antenna tum-on wire, a SPST switch must be connected between an ignition source and this terminal. Then, the ERE-G180 can be turned on.
Basic System/Systéme base/Sistema badsico
@ ee Tar | wonatoor ron TEE arr fessizon
fear bovo @)) 4 Cr © ise of @ he
TAT 7p rare a ‘ampltcateur || Arpitcateur Arpitiatour nie prope Amplificador Ampiificador | Amplificador Unidad principal
Front Rear Suowooters avant Aree Sub-wocters Delanero ——Trasero ‘Atvooes de tecvercas aba
‘Speakers/Haut-parleurs/Altavoces,
® Front Output Connector (to front speaker amplifier or signal processor)
9 Rear Output Connector (to rear speaker ampilier or signal processor)
© Subwoofer Output Connector (to subwoofer amplifier or signal processor)
‘© Input Connector
® PHASE Switch ‘The acoustical characteristics of different cars varies. When using subwoolers, standing waves may be produced at low frequencies. These standing waves can cause cancellation and loss of performance at the low end, To set the PHASE switch, listen to the system while switching the phase to 0 of 180°. Leave itn the position which provides the best bass response,
O "buns!
180" ot STEREO/MONO Switch It you have one subwoofer for your system, set the STEREO/MONO switch to the MONO position. When Using two or more subwooters, the switch may be set to either MONO or STEREO. In the STEREO mode, you may gain some sound separation (depending upon the music material). On the other hand, in the MONO position, the subwoofers will share the load more equally and can play louder. Experiment to see which sounds better for your application.
NOTE: ‘The PHASE and STEREO/MONO switches should be set before the installation is completed,
24s
ERE-G180
Operation Operation English English
Turning Power On and Off Adjusting the Volume/Tone/ Fader Controls
“The ERE-G180 is tumed on and off automat ‘cally when your head units switched on and ot
Adjust the volume and tone controls of your ae head unt and the FADER control on the ERE-
Adjusting the Subwoofer ‘G180 to suit your listening preference. Level fol Regardless of he EQUALIZER DEFEAT Te ERE pts tse comet be f arnt, pe OUT LEVEL bees dip epet ear tate levels. The input signal level is controlled by Pedeelasbensiaihed duce petig eniat the volume contro of your head unit the crossover point is continuously adustable, input can be summed using the STEREO! ere ie ‘MONO switch and a PHASE switch provides 0 rege I tne reg ED lights Up: poninupusi spec the output ofthe ERE-G180 could be lial ans distorted. Reduce the input level using
the head units volume control. The red LED snoule only bght intermittent for
aoe The LED on te SUBWOOFER LEVEL conto! ne ‘optimum sound quay ot, will be off when the SUBWOOFER ON/OFF
Switch sin the “OF poston. n this mode, a the FRONT and REAR outputs will be full Ao:
Nee range signals wth no sigal othe SUB- t WOOFER output The LED onthe SUBWOOFER LEVEL contol
» wil luminate in arbor when the SUB- . WOOFER ONOFF switch is nthe “ON ton nhs mode, the FRONT and REAR
Chips wi be gh pase and ne SUS- Selecting the BBE Mode WOOFER output wil rectve tho low-pass signals. Note: Push he SUBWOOFER ON/OFF ewten
to sel the subwooler mode to ON. Push the swtch again ose he mode torr. Press the BBE swich to sat the ERE-G180 to
~ the BBE mode Saas With each press, the BBE is toggled On or Ot ae 120 Hz using the CROSSOVER Notes:
FREQUENCY. control ‘+ When the BBE switch is illuminated in lmber, the BBE isn fect. «CY + The BRE such wil be urinated amber
; vnhon tis inthe "ON" poston,
English ‘Adjusting the Equalizer and Defeat Controls
4 SEEREREEEEE
vse ‘The EQUALIZER DEFEAT switch wil bo fo uminated green when its in the “OFF*
position. In this mode, all the equalizer B ‘settings are in effect. The LED indicators on
the EQUALIZER controls will be on
‘Note: The EQUALIZER DEFEAT switch wit + be illuminated amber when itis inthe
ON" position. n ths mode, the equalizer sotings wit not effect the
as output (except for BBE if tuned on), uF ‘The LED incicators onthe EQUALIZER
conto wil be of.
2 oe
soe ‘oe “Ig9e~ 19607
e9e
‘z9e7
[
oat ry
‘wana
os zee~seeo 4
SNMOIMS],
_ 1v3s30%3
ises
44
°
. 1vas3q/03
mans
SNIMOLIMS
|
Bi
401s
did
VEO
7
eager
Ya400M
8S
aivaa
106s
SIE
ONIHOLIMS|
é
398
Lawl
TEI
Tied
38
oses
AG-
worvinoay
[*T
6080
:
oa
5
DNTHOLIMS|
“
7
BLOW3Y
ri:
wouvinoau
[*T
ZOE
TOGO
Grosionsu
B0ED
It
wana
Snow
[aun
«|
an
a
Casauiva
ize
‘ete
‘L1e
“poeD
soyeuuog
Aiddng
semog
“Assy
E0EL3
.081/
0
- SSVHd 2008
sure
37%
e120
T
Gar
defo
sna
(ua300m
ens)
mI
on)
vou
‘er
8 lusiuaani
one 95E01
OL
7
a
W3ZITWNOZ
OT
‘Old
Yu
(LNdLNO y
-dv3¥)
13.
ir)
YSXSTdILINN
DOWNY
3X3
TdILINN
DOWNY
vou
"per
¥a4ddNe
“TANNVHO-@
S1dIdL
TANNVHO-2
S1dI8L
sore
7
‘Z0SOl
‘80b
“Z0¥OI
2060!
Block Diagram
Parts Layout on P.C. Boards and Wiring Diagram (1/2) All P.C. Boards viewed from soldered side.
ET303 Assy., Power Supply Conne
fe Geyint se sora + cog || ago | qo
I S80 ! fo es ey d
I E201 E203 a +. 8 el ss a : 4+ 8
: oe + E162 | teppe * eli7 7 g
sy yoag YS . I £220. gig 21 © Sopp to LE a 2 Oe. _ 54040 5 2 3 ENG = E218 RE 1Se i
Ic301 1 a Bra |
1035"
Srv le
E106 E107 “Re,
£264 ©! c209 2 R as He Gite Bi gl . +e te C210 206 ie 1 < 8 0306-0308 eel an a fi = z E36 Bh, = S £304 Ss 2
pe aeu J a Pas = 1303 4g 3331 ER Cure. ssce! w SS Sl
We L504 See erent a © ee 9309
eeoeeeoeeceoon COCK CSOOCEECOEe ee0eeeo
Main P. C. Board Rear P. C. Boar
ERE-G180
m (1/2) All P.C. Boards viewed from soldered side.
ET303 Assy., Power Supply Connector
. HE ENT
So te ENB E218
gets E36 Bh, S304
2 Eee 08 ee 8 © PB R308
0309
Rear P. C. Board
Blue Color Pattern —_: Foil Side Pattern
7 4 G | H | | [A | K |
ERE-G180 ERE-G180 ERE-G180
All P.C. Boards viewed from soldered side. Parts Layout on P.C. Boards and Wiring Diagram (2/2)
P. C. Board Front
P. C. Board Control
| iseail @ | | e@ 202
zocor
Volume F
-1- F B -i0-
ERE-G180 ERE-G180
All P.C. Boards viewed from soldered side. n (2/2)
‘eee tee
gvor
813
1¢23 — Fl ‘ al °
Ih 4
Pasi
Gh fe
“¢ceq1 4
P. C. Board Control
< S 3 a oO a w (= = ° >
Orange Color Pattern : Component Side Pattern Blue Color Pattern : Foil Side Pattern
-1-F
Schematic Diagram (1/2) Tet Terar ra ic ica tee ae sins
Transistor (@) hee ota 0308 0309 oies a3 a5 omog__o306 axl oo
ifalneh SU Boocd se em aoe Se eee Ss hl lg ora eee aN eo ct ss oa eat he et i te
!
1 l H L
| eu me, P 1 mie 3 mis gi Ne 2 TF 1 4m 2/6 Bs 24 (CeD_oR i Oia zs fone we | Six | & 1
to & ‘ H cay ais 100 Ls sO“ g
I tc30t outPar +} Hy toe Be
! INPUT_TSOLATOR} i Pi a am I (WOTING - >} Beare hed
+.
| 4K O-O-O ®
1 201
| 28 201326] ne nate | R219 | 28 20 er _| tos vm | x
ae aS # TRIPLE 2-CHANNEL
I 58 28 PCASTOHA 10302 6040598 |4NALoG HULTIPLENER|
af 5 a Hy 1 En 5S r
| a i ay g "
Geetesscs tog 470 tw 308 2s0tes7 JREGULATOR-9V es
: 1 = i‘
Rear PiC.Bo0rd aurPoT ak | § |, | ston I xo 7 x Paiers stan
: {Jack RCA 3 “be 5\o CINPUT. § | +
; UR) ES] S| ome 7 7 ste SLR | tom ae Ae | | sx |e 7 [el Le
Vock ,RCA +4 = 7 (FRONT 0309 2581243 [REGULATOR-9V] pion
} OUTPUT 44) —= Oy Gren] (0304 OTA g | Sloane ry Ce ated
3 1 x1o3 7! z 4] BE gags i: 2 orasziek
pean R129 150K iz 02 5) _krozoses & lp lveRl
(REAR- a 2 V output | 132 1500 = + 1 LR 4 so02 2 0303
1 6 fpaeene| | § ro
: I xtor 7! cig : Voock RCA w ay i Bp Q)
- VWoorer oe = 1 L/R}
~
Lt 1309 £222 uPCASTOHA 10/16
7 ~ x a | To Control P.C.Boord (C8308)
Front P.C.Board __ #7 ao aH ia = Se
] + 1 wet wet Be
x I B82 88 & — ' & 5 aa, 2@ 8 1g] FE i 4 5 g| Be 82 88 32
| ial twal| foie Ey ty EO He - # ge 3 yg 1 PP ary | pay ey ap see baw 86
1 1 1
_ lL____------~-~-----—-— a ee
ERE-G180 ERE-G180 ERE-G180
Schematic Diagram (2/2) ie Tea 1s roy
1os02 1c310 ‘ail iat Tee = Tow Teste
Transistor (0) ogg BAT BT HT a
‘ae ts i 02 OH oot a
Control P.C.Board pees
1 1 : ae t
| 2 ¢ ain | / cae ee
sk |s 1303 1¢305 3 . ia 22
ct
| 2] [8 bla uPCASTONA ia ey
1
\ 8 5 She - : ors nae ene
! 12710716 5 z APCASTONA g x sms
1 +H (MUTE #
1 [oR vER|
gx na2s
| e232 10/16 85 x 10716
Ht -
Pp oL 120-1000 | i
A 0312 | mate 0321
bail OTCISAEK
as eng 4.7/0 a8 240K Scie
52 AM —} TRIPLE 2-CHANNEL
gc + R803 1K ANALOG MULTIPLEXER] oy
= : ds a 0313 E312 10716
td pes HS }2801 2254
e228 4 8/8 ES frosts wessca|
i \- 1 caa3.0.007 | | Ra
j ms 7 amet f
a | ic ze _ ]
KS |
ozs oe Letlgon rel
16 fags 2k FILTER i 4 Li + | 28C2412K o }
1¢502 G
hi 1
ee oxo! ms % z g rt eae er [se | |
SOIC sg 8 #5 1314 z 1c306 8 Saat By8 | |
8 uPCASTOHA uPCASTOHA VU Sasa 322 = #8 !
pee LL On d-5-6-6-0-0-6 \ IKTC4368 co02 0.047, | H
(contro. | e (2/209 1
Le aa oe, :
ra Bl ice ax | vee] 10305 ce] _ FP a ae 3 4 “uPCASTOHA ae 1 1¢408 GD4053B | I
a AW x BBE | !
raziK | SWITCHING 1
= 333310 OTCIMMEK 100, H t
aa im
tc3 g
aie ! \
10 8 rm
uPCASTOHA a st oa Il |
a0 i t + H H
8 (a 5 : x = + tk H
sal a R135 et = = R330 47K & ee |
a3| a ml? ox 10 E| 4&8 25 IC501_M51958AL ei. x S 0320 i +
= 8| fg = g| #3 8 sa 8 [a gy orcisaek Ly
3° 8 i Fy Hy =
= | TWWERTER] a t EQ/OEFEAT) | H
Pas | | SWITCHING + |
& s | ——~L]_ [Sub wooreR} | ae
! eos =| __04d2 Tee rRINe | |
1 att | orci” Lele o 1 1] 032s | |
I z 238 191 geet | | [2satogne !
1 E 2 10716 ic pemet g i t
! a 8 a sl ga l | Ht
\ Boa ons ay 8] 3 I H
1 Tat PE he rae \ y Hl £253 10/16 r Ic312 TC4ataP DTCI44EK Svirestns: | ane
I alg I i+ Icatt TCs013 | OTA
I Et oe | | (ouAL 0
1 2\3 (SUB WOOFER| L | |FLIP_FLOP|
i
1 tm SWITCHING rrr
i
Hl CONTROL. DTCI44NK |
I
|
1 L
>
ERE-G180 ERE-G180
fo Tair Te506 Teor Tee 1os0t cate Bs wa Ge Ta
316 0322. 0310 0323 a331 0224 0302 0315 0602 oa20 oa77 ons 0309 209 0206 090
posite e eee ea Re are eR ee ee eg i304 joie - cde) - eto
200 1k H 7 pow [tp ne |(t] ne | [a] no toe 2 [| vev | {2| sav | [2] ow | [2] ow
Tia 1 2 316 | osv | [a] ow |[s] ow | [a] ow A\S w [wv [fa] w | [4] ow |e] ow
\c30s ara wesreit | £310 100/16 A |SS 7 aerh ts {anv [scan bs] oar “svce| #PC4STOHA al a 8 3 | as oi go A ck | csv | fe} ow |{e] ow |le| om
: ENO s 3S 3 a ) 2 7 Ia/258 1250 ‘eas | wai (ean = a | aw ov | {7 | oe | [7] ow
—1-O, . rae e309 12 @ [os |e] sav | fe] ww |fe] ow
1c3t4 ‘Gat 47K 188193, 100K te ps | ew |{s| ew |[o] ow ws x aPCasToHA pare] |zsaroan ; I
ma eat an tH 1 10311 Ic312 10314
one. tons 1 1] 367 [8] sev ][7] no [e] ae |(1] xo
Tn ox 1c407 40538 i 2| aev [e| aw |{2| nc |o| aw |j2| +2v
Pee ee ene : 3[_w iol sav |{s] ev [| ow |[s| ow
T Volume P.C.Board ' a[ sev |u| vaov |{«] env |v] wer |[*] ow ene Re BROT I =| ew |] ew |{s| aw [a] aw |[s| av
ogo : = o TRIPLE 2-CHANNEL O86 i a. G ANALOG MUCT [PLEYER| 1 ODE | a
aig E312 10716 Rast 1 7[ se [al ew |[7| sev [wl ow | [7] cov
Ah oR $ psoi22s aman mw) | op aa Bir pis 3 mate WSC. l Ic4o7_ 1C408 —IC501 | ea
# gome Onc a att ao eee ad TP ow] [| oa] [| ow 1 1e we ‘ amin ao al 2[ aw |[2] ow | [2] sav | ane eae Ig I oma arctan | | 3] ow |{s] oa | [a] sav L-----------8 (V.STABILIZER = ora EY | a{_nc |{] no | [4] sav
S| 11 ilo sf ow |{s| ow | [5] ow = | 6] ow [fe] oa a I \ il wt Oa a pees soso
! = is Pad Q e[ ow |[e[ ow | PY 318 ox | S| OW {2} 8 | Sea orciaaw | ef av {fof wav]
teats pea bcd oma «= ET | ai] tev | [it] 18 uPCASTOHA 1322 real | | 5 | sav
KTC4368 can2 0.047, | ow | fe] ow |
a> =e ef anv | fra] ov | [= eas ater pabew] FEL
0 rec] 0228 | 18 75| aw | [15] oav x Tc408 6040538 = | le fas 910 staal teten | Le
nk Sp : [SWITCHING bred
0310 OTCISAEK 109 3 =[°] 8 =T°] 2 3 vaav | simv | asv | ome | sav | ow | ov
rate s cav | wv | ew | om | sev | ov | ao 1 P nav | vay | ev | cer | osv | w | sav
3 Ce 1 6 an | wav | ov osv | ew | ov
= ra IK 330 o ee TCSO1_NS1958AL 3 OTCIAAEK 5 sev | vay | aev | Gam | sev | w | sev
2 r — é aav_[ sav | ow | cow | av | av | a7 [SWI TCHING| 8 ov | av | wow | ow | aw | rev | ow
if [SUB WOOFER] bas ov | ov | ev | ome | sav | ev | an
rire areaNe aw | oev [sev | ows | sev | vow | ae OTCH4ANK iixx
— [Measuring Conditions] + Power Supply Voltage: DC14.4V
RESET] | + Measuring Meter + Digital Multi Voltmeter —— Measuring Point Reference: Between Ground
DAO i5 [SUB WOOFER] arctan : FLIP FLOP] 1e312 Tes0t 3 OTCI44EK [SWITCHING ie: ee + Measuring Conditions: No Signal Input
(OULD FLIP FLOP I
i} ; H NOTE: a a aaa | 1. All resistance values are in ohms. K = 1,000 1
1 2. All capacitance values are in microfarads. P = p59 909 J P 7,000,000
eee |
ERE-G180
Tei Tea Tee To ais 1202 1909 TOT ORT ‘nz aate 208 0309 cr a20s
103 o203 a5 oma 204 1a
----------- $5 5 5 5 nat 8 Ic101 Ic102 10201 '¢§ +] 20 [a] 2] [1] 26 Jo] no] [1] 2a [un] 2a
Be ele ie 2| 2av |12| 35v 2| 2av |10) NC 2] 2a |12] 35v
ge sf an a] sar] [stan fee] fs] ar pa] aa city jar 38 af aw ful aa | [a] aw fe] rav | [e| ea [ral sav
tone £ s[ ear fs] sav] [s| an fa] ow | [s| aa [is] a0v es we “eee z = 5 e| ev fw] sav] [6] av fe] w_| |e] av |] av
a ks = 2 On is] ON 7| 2 |i7] 3sv OCci/ayfurcasrova] este we] wis | B 1c313 81403N 7[ 2a [a] ow | [7] 20 [x 2 foie ao | aK | | aw [| aw | [el] 2 |e] ov | fo] sav [re] aw
RING 104 3 ‘ai oe’ 2] 2ev [re] ov | ev |e] cov ee SF} a vo sev [ao] sev vo} sev [zo] a9
1c202 Ic301__ 1C302 228 2P s 1] 26 [9] nc | [a] w ] [1] o5v [eo] osv ate 5 2[ aw [wl no | [2] ow | [2] os [wo]
& spew [nf xe | fs] w | fs] ow [nf <O ie noe OCA Feaq7_| torte 0 [am fel av | [a| ae | [@[ ne |e] anv
Os + TRIPLE 2-CHANNEL Be Coreen e302 co40s3e [TRIPLE 2 CHANNEL 3 [am fs ea | [5] ov | [5] ov |i] csv ef av fel wv | [fe] aav| [e] ov |r| osv 7[ 267 [w[ on | [7] sav | [7] ev [sl ov
x ef] 2w fre] eov | [a] eev | [se] osv [| w
“grey PE ccs 5 Oar] wPcestana ste. e135 208 2so1057 [REGHLATORSST] 26, ga Ic307__ 1308 IC309_—«10313
<3 TP [ene] [se] [prev nh ro ia es zp en |e; 7] [2p 7a [a] av 130 22° fread EB 3 ap av | fa} za] fa] aw] [a] 7a
C219 S30 ° afew |[4| ve | la] za | [a] var rato 1K 7 5] sav | [5] sev 5] av s| wv
SB fs ef ae | {ef va | [fe] va] fe] ev wast 18 a baer |. sbiona 7p av | [7] 7a | [7] za] [7 [ov
GPa [He | Be = A | = 10308 3 oc70c OLO< B04 Poe eal of aw | {ef ew | fe] ew | fo] aw Nee} ‘uPCASTOHA
ret 9 2881243, = was 0309 25 REGULATOR-WV Cn 1C309 e122 V. = air | ow | ow | cov
“ht HPCASTOHA 10/18 8 |STABIL IZER] 0304 | ‘ane | ow | ow | oo i @Cr2if | aio ome net acs | osv | osv | wv I
<@ 2x] 2 3) xrozose [oi veel“ — |. jREWOrE aa [on | on] 220 i R129 19K 5 [SWITCHING] we Pow fon | on C132. 1500P 3 Ul cata aes | osv | asv ov
2 oot 0302 2 KTK2t1 2K 2 ocor | aay | ae | ov 3 : cae | wf av | ov = rot coor [vay | ow | av
oo ld ia = aorta {ar {on 8 ose | ov | ov] ov
bc on car | w | av | oa ican ae og a CO osm 2e one | ev | o5v | oa
fourruT] i Si 6 ]o°] Ss [ANP e coos | sev | tai | os
QEOCEGO00" ee ee ee nn nn TH
[Measuring Conditions]
gO00GGG00 + Power Supply Voltage: DC14.4V + Measuring Meter + Digital Multi Voltmeter « Measuring Point Reference: Between Ground
1 1 \ + Measuring Conditions : No Signal Input
! 1 ' REMOTE-ON
1 I BATTERY * ! £1303 NOTE: | Assy. ,Power Supply Connector 1. All resistance values are in ohms. K = 1,000 1 dette ee eee lee ee ee ee ee eee == 2. All capacitance values are in microfarads. P = 7,000,000
G I H I be dre I . |
Electrical Parts List Resistor: Carbon resistors under 1/4 watts are not mentioned in the parts list, please confirm them by schematic diagram.
Capacitor : pF=microfarads, pF=picofarads
Ne!
Abbreviations Resistor CAP.= Capacitor Carbon Film EL Electrolytic Metal Film CER.= Ceramic 48T68829F01 | 15S133 Metal Oxide Film MyYI Mylar 48T68829F01 | 185133 Metal Plate TA! Tantalum 48T25664W01 | RB100A. Transistor POLY.= Polystyrol 48125664W01 | RB100A Transformer PI Polypropylene 48T25664W01 | RB100A, Chip PLI Polyethylene
PF.= Polyester Film 48T25664W01 | RB100A.
48E20758S01 | 11ES2
48E20758501 | 11ES2 48T25766W26 | Zener, HZS9C3L
51T74296F01
51T84232F01 51T74296F01 51T84232F01 51E22491S01
Mi5229P Moae Coils / Transformer M5227P 2522496501 | Choke, Trans. NJM2082L 25£22497501 | Choke
24622531501 | Inducctor, 100¥H GD40538 24£22531S01 | Inducctor, 100uH HPCAS70HA, 25€22495501 | Transformer, Power (EI-1309) uPCas70HA yPCa570HA 181403N
51E22492S01
51T83403F03 51T83403F03 51T83403F03 51E22493S01
Switches
40E22502S01 40E22502S01
Slide, HS-2211 (STEREO / MONO) Slide, HS-2211 (PHASE - 0°/ 180°)
Transistors
48T63788F01 48763788F01 48T63788F01 48T63788F01
48T63788F01
., 25D 1328 CP., 2SD1328
CP., 2801328 CP., 25D1328
., 28D1328
Capacitors
23E09402S02 08E22510S01 2309402502 08E20991S01 23£09402S02
ELY,, 10nF / 16V oP, 180pF ELY,, 10pF / 16V Pr., 0.12uF ELY., 10uF / 16V
48T63788F01 48E22513S01 48E22514S01 48E22515S01
48E22092S01
CP., 25D1328
CP., DTA123YK. ., DTC123YK
FET, CP. KTK211 CP., DTA124EK
08E22526S01
23E09402S02 08E22524S01
23E09402S14 08E22084S01
Pr, 0.082yF ELY., 10pF / 16V Pr, 0.056yF ELY., 0.47 uF /50V oP, 0.015pF
48E22494S01
48T55057W01 48T55057W01
48E22789501 48E09399801
KTD2058A 2801857
2SD1857
28D1857
2SB1243 23E09402513 08E22086S01
23E22519801 08E20991S01 23E09402501
ELY., 2.2uF / SOV cP, 0.033,F ELY., 0.22yF / 50V
PF., 0.12uF ELY., AF /50V
08E22525801 23E09402S14
08E22089501 23E09402S16 08E08577S04
0.068uF ELY., 0.47) / 50V cP. 6800pF ELY., 0.33pF / 50V c., 0.027yF
Diodes
D301 48E22529501 0302 48E22529801
~19-
180
ERE-G180
me"
23E22521S01 08E22084S01 23609402802 08E20767S01 23£09402S02
08E21165S01
08E08577S02 08E22512S01 23£09402$11
08E22511S01
23E09402S02 08E22079S01 23E09402511 23E09402S02
23E09402511
23£09402S02 08E20550S01 08E20550S01 08E08577S02 23E09402S02
23E09402S02 23€09402S09 23E22520S01
23£09402S02 23£09402S02
08E22510S01 23£09402S02 08E20991S01 23E09402S02
08E22526801
23E09402S02 08E22524501 23E09402814 08E22084S01
23E09402S13
08E22086S01 23E22519S01
08E20991S01 23E09402S01 08E22525S01
23E09402514 08E22089S01 23E09402516 08E08577S04
23E22521S01
08E22084S01 23£09402S02 08E20767S01 23E09402S02 08E21165S01
0808577802
08£22512S01
Description
0.27uF /50V 0.015pF
10uF / 16V 3300pF
10uF/ 16V
8200pF 1500pF 3900pF
22yF/ 16V 820pF
10pF / 16V 330pF
22pF / 16V 10pF / 16V 22uF / 16V
10pF / 16V 22pF 22pF
1500pF 10pF / 16V
1OpF /16V 100uF / 10V 10pF / 16V 10pF / 16V 10pF / 16V
180pF 10pF / 16V
0.12pF 10pF / 16V
0.082pF
10pF / 16V 0.056pF
0.47 uF / 50V 0.015pF
2.2uF / 50V
0.033yF 0.22yF / SOV
0.12pF 1F /50V 0.068yF
0.47pF / 50V.
6800pF 0.33yF / 50V
0.027,F 0.27pF / 50V
0.015yF 10pF / 16V
3300pF 10pF / 16V
8200pF
1500pF 3900pF
23E09402S11 08E22511S01 23E09402S02 08E22079S01 2309402511
2309402502 23E09402511 23E09402S02 08E20550S01 08E20550S01
08E08577S02
23E09402S09 23E09402S02 23E09402S02 08E20755S01
23E09402S02 08E22087S01 23609551807 08E22087S01
23E09402S02
23E22522S01 23E22523S01 23E22523S01 23E22522S01 23E22522S01
23E09402S02 23E09402S02 23E09402S07 23E09402S02
Resistors (All ri
~20-
Per unless otherwise note:
06E22055S01 06E22055S01 06E22055S01 06E22055S01 06E22055S01
06E22055S01
06E22062S01 06E22048S01 06E22062S01 06E22054S01
06E22054S01 06E20903S01
06E22507S01 06E20903S01 06E22505S01
06E22062S01 06E22508S01
are ch
820pF 10uF / 16V
330pF 22pF / 16V
10uF / 16V 22pF / 16V 10uF / 16V
22pF 22pF
1500pF 100pF / 10V 1OUF / 16V 10uF / 16V 0.033 F
10uF/ 16V 0.047yF
1000uF / 16V 0.047 pF
10UF / 16V
330pF / 16V 220pF / 16V 220pF / 16V 330pF / 16V 330pF / 16V
10pF / 16V 10pF/ 16V 22uF / 10V 10pF / 16V
1/jowt5%
06E20903S01 06E22065S01 06E22505S01 06E22054S01 06E22505S01
06E22062S01 06E22508S01 06E20903S01
06E22065S01 06E22505S01
06E22054S01
06E22505S01 06E22062S01 06E22509501 06E22504S01
06E22065S01 06E22062S01 06E22048S01 06E22062S01 06E22054s01
06E22054S01 06E20903S01 06E22507S01 06E20903S01 06E22505S01
06E22062S01 06E22508S01 06E20903S01 06E22065S01 06E22505S01
06E22054S01
06E22505S01 06E22062S01 06E22508S01 06E20903S01
06E22065S01 06E22505S01 06E22054S01 06E22505S01 06E22062S01
06E22509S01 06E22051S01 06E22065S01 06E22060S01 06E20903S01
06E22518S01 06E22048S01 06E22048S01 06E22048S01 06E22048S01
06E22048S01 06E20903S01
Description
06E22506S01 06E22508S01 06E22062S01 06E22062S01 06£22062S01
06E22062S01 06E22041S01 06E21164S01
06E21164S01
Description
ERE-G18C
Control P. C. Board
-21-
51T55203W01 51T83403F03 51T83403F03 51T83403F03 51T40391U01
51T40391U01 51T83403F03 51E22492S01 51£22492S01 51T93352F03
51783403F03
48E22555801 48T63420F01 48E22555S01 48T63085F02 48E22554S01
48E22555801
48E22555S01 48E22554S01 48E22532S01 48E22553S01
48E22552S01 48E22553S01 48E22552S01
48E22553S01 48E22552S01 48£22553S01 48E22552S01 48E22552S01
XRi071 HPC4570HA PC4S70HA BPC4570HA T¢4013P
7¢4013P PC4S70HA GD4053B GD4053B M51958AL
HPC4570HA
CP., DTC144EK
CP., DTC144EK CP., DTC144EK
., DTA143XK
., DTC144WK
., 2SA1037K ., DTCI44WK
, DTA143XK ., DTCI44WK
., DTA143XK
., DTC144WK , DTAI43XK ., DTC144WK
., DTCI44WK
ERE-G180
48E22552S01 48E22552S01
48E22529801 48E22529S01 48E22529S01
48170933F01 48T70933F01 48783128F 13 48783128F26 48783128F26
48783128F29
08E22077S01 08E22077S01 23E22562S01 23E22562S01 08E08578S04
08E20767S01 08E20767S01 08E22510S01 23E09402S02
08E22549801
23E22519S01 08E20756S01
23E09402S02 08E20756S01 23£09402S14
23E09402S02 23E22562S01
23£09402S14 23609402802
23£09402S02
08E20550S01
23E09402S02 23E09402S02 23€09402S02 23E09402S02
23E09402S07 23£09402S02 23E09402S02 23£09402S02
Description
CP., DICI44WK cp, DTCI44WK
VEZ
11E2 11E2 18$133 1$8133
185136 188136 Zener, HZS7B1L
Zener, HZS9C2L Zener, HZS9C2L
Zener, HZS11A2L
47pF ATpF
4.7uF / 50V 47UF /50V
1000pF
3300pF
3300pF 180pF
10pF/ 16V 68pF
0.22uF / 50V 0.15pF
10pF / 16V 0.15pF
0.47 pF / SOV
10UF / 16V 4.7\F / SOV 0.47)F / SOV 10pF/ 16V 10pE/ 16V
220pF 10pF / 16V 10pF / 16V 10pF / 16V 10pF / 16V
22uF/10V 10pF/ 16V 10pF / 16V 10pF / 16V
—22-
23E22562S01 23E22562S01 08E22081S01
08E20767S01 08E20767S01
08E22510S01 23£09402S02 08E22549S01 23E22519501 08E20756S01
23E09402S02
08E20756S01 23E09402S14
23E22560S01 2322562501
23E09402514 23E09402S02 23E09402S02 23£09402S02 08E20550S01
23E09402S02 23E09402S02 23£09402S02
23E09402S07 23E22561S01
23E22561S01 23E09402S02 23E09402S02 23E09402S01
23E09402S02
23£09402S02 2309402801 23£09402S01 08E22088S01 08E22087S01
08E22087S01
08E22550S01
4.7uF/50V 4.7uF /50V
1000pF 3300pF 3300pF
180pF 10pF / 16V
68pF 0.22yF /50V
0.15pF :
10pF / 16V 0.15pF
0.47pF / 50V y (BP) 3.3pF/50V
4.74 / 50V
0.47pF / 50V 10pF / 16V 10pF / 16V 10pF / 16V
220pF
10pF / 16V 10pF / 16V 10pF / 16V 22pF / 10V 100pF / 16V
100pF / 16V 10pF / 16V 10pF / 16V AF /50V 10pF / 16V
10pF / 16V 1pF/50V 1F/50V
0.1pF 0.047yF
0.047ypF 0.047pF
Resistors (All cesistors are chip 1 OWE a unless otl
06E22065S01 06E22062S01
06E22060S01 06E22060S01
06E22540S01
06E22061S01 06E22055S01 06E22060S01 06E22060S01
erwise note
Symbol at
Part No.
06E22656S01 06E22056S01 06E22055S01 06E22062501 06E22065S01
06E22062S01 06E22060S01 06E22060S01 06E22061S01 06£22540S01
06E22060S01 06£22056S01 06£22056S01 06£22062501 06E22068501
06E22545S01 06E22547S01 06E22058501 06E22065S01 06E22055S01
06E22065S01 06E22545S01 06£22546801 06£22111S01 06E22041S01
06£22067S01 06E22062S01 06E22539S01 06E22062S01 06E22062501
06E22067S01 06E22067S01 06E22540S01 06E22060S01 06E22060S01
06E22548S01 06E22542S01 06E22044S01 06E22543501 06E22544S01
06E22548S01 06E22064S01 06E20851S01 06E22065S01 06£22065S01
06E22541S01 06E22541S01 06E22050S01 06E22062501 06E22062S01
06E22062S01 06E22048S01
6.8K 6.8K 47K 47K 100K
47K 22K 22K 33K 47K
22K 6.8K 6.8K ATK
1M
2K 680K 12K
100K 47K
100K 2K
51K 5.6K 100
470K ATK 22K 47K
47K
470K 470K 47K 22K 22K
470 20
430 39
750
470 68K 43K 100K 100K
100K 100K 1.8K 47K
47K
ark 1K
Description
ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm chm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm ohm ohm ohm
ohm ohm
-23-
Description
06E22067S01 470K ohm 06E22067S01 470K ohm
Miscellaneous
01£22503501 | Assy., Power Supply Connector 09622565501 , RCA (INPUT L/R) 09£22565801 RCA (FRONT - OUTPUT L/R) 0922565801 RCA (REAR - OUTPUT L/R) 09E22565S01 RCA (SUB WOOFER L/R)
48T55661W01 AABG4607K (GRN / ORG)
48T55661W01 AABG4607K (GRN/ ORG) 48751833F02 PR4524K (RED) 48T51833F01 PY4524K (YEL) 48751833F01 PY4524K (YEL)
48T51833F03 BG4524K (GRN) 48T51833F03 BG4524K (GRN) 18T75339W01 | Rotary Volume
(CROSSOVER / SUB W.)
Packing Assembly Parts List
Description
68P61487W40 | Owner's Manual 68P61487W42 | Owner's Manual
03E09554S02 03E09694S01 64£22804S01
07£22805S01 75E22806S01
Screw, Tapping (M520) Screw, MCH (M4x8) Face, Plate
Bracket, Mounting U Sheet, Pad
NOTE : O:For North American Model Only, Others : Common.
Packing Method View
-24-
A: For General Foreign Model Only,
F -2-
ERE-G180 ERE-G180
B -2-
Exploded View (Cabinet)
Cabinet Assembly Parts List
13B70978W01 36A70980W01 36E22581S01 41A63556F02
03E22117S01
03£22575S01
03E22576S01 03E22577S01
03E22579S01 03E22580S01
47E22449S01 18T75337W01
30E22568S01
15B70979W01 30E22567S01
‘Assy., Nosepiece Knob, Slide Knob, Cross Spring, Knob Insert Screw, MCH-TPT (M2.6x8)
Screw, TPT (M2.6Xx5) Screw, TPT (M2.6X5) Screw, TPG-TPT (M3X8) Screw, MCH (M2xS5) Screw, MCH (M2.6x5)
Stud, Main Shaft Slide Variable Resistor
(included VR350~362, LD350~361(GRN), 362(ORG), S350(BBE), 351(EQ/DEFEAT), R351~356) Wire, Flat 13P Cover, LED Wire, Flat 6P
-27-
ERE-G180