manual 200 dgfc spec n 960-0297c
TRANSCRIPT
GenSet ModelDGFA (Spec P−S)DGFB (Spec P−S)DGFC (Spec L−N)DGFS (Spec A−C)
Printed in U.S.A. 960−0297C 1-2007
Parts Catalog
with PowerCommand® ControlPCC2100
The following symbols are used in Cummins PowerGeneration manuals to alert users to the potentiallydangerous conditions relating to maintenance ofequipment and replacement of parts. Please readand observe.
This symbol warns of immediatehazards which will result in severepersonal injury or death.
This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or death.
This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or prod-uct or property damage.
This catalog covers models produced under theCummins®/Onan® and Cummins Power Genera-tion brand names.
To avoid errors or delay in filling your parts order, al-ways give the MODEL, SPEC NO. and SERIAL NO.from the Cummins Power Generation nameplate.
For handy reference, insert your nameplate in-formation in the spaces below.
MODEL AND SPEC NO.
SERIAL NO.
DIGITAL CONTROL SOFTWARE VERSIONAND DATE (IF APPLICABLE)
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USAstate agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engineoils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state agen-cies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all neces-sary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilationand wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified bya United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVETOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation andwear protective gloves, masks and protective clothing!
PSP-1
Service and repair of Cummins Power Generation equipment must be performed by trained, experiencedpersonnel only. Improper service or repair may result in property damage, severe personal injury ordeath. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANTSAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
1
Introduction
This catalog applies to the standard generator models DGFA, DGFB, DGFC and DGFS as listed in the GeneratorSet Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a referencenumber corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwisementioned in the description or page heading, parts are interchangeable between models. Throughout this catalogleft and right sides are determined by facing the engine end (front) of the set.
Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All otherengine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer’snameplate and supplying all available information. Contact your nearest engine parts distributor for assistance inordering replacement parts.
Replacement EngineCummins Power
GenerationGenerator Model
CumminsEngine Model
CumminsEngine Model WithMOH Certification
DGFA 6CTA8.3−G2 6CTAA8.3−G3
DGFB 6CTA8.3−G2 6CTAA8.3−G3
DGFC 6CTAA8.3−G3 6CTAA8.3−G3
DGFS 6CTAA8.3−G2 6CTAA8.3−G2
Generator Set Data TableModel/
S ifi tiElectrical Data Battery
Specification Watts Volts Hertz Wire PhaseBatteryVoltage
140DGFA* 140,000 # 50 4,6,12 1 or 3 12 VDC
150DGFA* 150,000 # 60 4,6,12 1 or 3 12 VDC
150DGFB* 150,000 # 50 4,6,12 1 or 3 12 VDC
175DGFB* 175,000 # 60 4,6,12 1 or 3 12 VDC
176DGFC* 176,000 # 50 4,6,12 1 or 3 12 VDC
200DGFC* 200,000 # 60 4,6,12 1 or 3 12 VDC
230DGFS* 230,000 # 60 4,6,12 1 or 3 12 VDC
* − The Specification number denotes customer requested options or deviations from the standard model. The Specification letter advances with major manufacturing changes.
# − Broad Range Reconnectible.
Copyright�2001 Cummins Power Generation. All rights reserved.
Index
2
AActuator, Electronic Governor − DGFA, DGFB Without MOH,
47Actuator, Electronic Governor − DGFC, DGFS or DGFA, DGFB
With MOH, 48Adapter, Duct − Radiator − DGFA, DGFB, DGFC, 22Adapter, Duct − Radiator − DGFS, 23Adapter, Exhaust, 16Adapter, Exhaust − Standard, 15Adapter, Generator, 57Adapter, Stator, 57Alarm, Basin, 14Alarm, Low Fuel, 13Alarm, Trip, 77Alternator, 46
BBar, Neutral − Circuit Breaker Box − 700−1000 Amp, 75Barrier, Sound, 43Bell, End, 58Bell, End − Generator, 57Belt, Fan − Radiator − DGFA, DGFB Without MOH, 25Block, Terminal − Generator, 57Block, Terminal − Generator Heater, 51Board, Printed Circuit − Bargraph, 63Board, Printed Circuit − Base, 63Board, Printed Circuit − Fuel Tank Control, 12Board, Printed Circuit − LED, 63Board, Printed Circuit − Lonworks, 63Box, Circuit Breaker − 10−630 Amp, 73Box, Circuit Breaker − 700−1000 Amp, 75Box, Control, 63Box, Control − Fuel Tank, 12Box, Entrance, 49Box, Terminal − Generator Heater, 51Bracket, Air Cleaner Charger − Radiator − DGFA, DGFB,
DGFC With MOH, 27Bracket, Belt Guard − Remote Radiator − DGFA, DGFB, 30Bracket, Bottle − Radiator − DGFA, DGFB Without MOH, 25Bracket, Bottle − Radiator − DGFA, DGFB, DGFC With MOH,
27Bracket, Control Mounting − Control Housing, 50Bracket, Electronic Governor − DGFA, DGFB Without MOH,
47Bracket, Electronic Governor − DGFC, DGFS or DGFA, DGFB
With MOH, 48Bracket, Heater − Water Heater, 20Bracket, Mounting − Air Cleaner, 9Bracket, Mounting − Circuit Breaker Box − 10−630 Amp, 73Bracket, Mounting − Circuit Breaker Box − 700−1000 Amp, 75Bracket, Mounting − Generator, 57Bracket, Pump − Fuel, 11Bracket, Shroud − Radiator − DGFS, 29
Breaker, Circuit, 76Breaker, Circuit − AC − Fuel Tank Control, 12Breaker, Circuit − DC − Fuel Tank Control, 12
CCable, Heater − Oil Heater, 21Cap, Fill − Fuel Tank, 10Cap, Radiator − DGFA, DGFB Without MOH, 25Cap, Radiator − DGFA, DGFB, DGFC With MOH, 27Cap, Rain − Muffler − Critical − Housed Sets, 18Cap, Rain − Muffler − Standard, 17Cap, Vent Pipe − Fuel Tank, 10Cartridge, Heater − Generator, 51Clamp, Stator − PMG, 52Cleaner, Air, 9Clevis, Governor − DGFA, DGFB Without MOH, 47Clevis, Governor − DGFC, DGFS or DGFA, DGFB With MOH,
48Cock, Drain − Radiator − DGFA, DGFB Without MOH, 25Cock, Drain − Radiator − DGFA, DGFB, DGFC With MOH, 27Contact, Auxiliary, 77Control, 63Control, Day Tank, 11Control, Fuel Tank − Components, 12Cooler, Air Charger − Radiator − DGFA, DGFB, DGFC With
MOH, 27Cover, Adapter − Generator, 57Cover, Belt Guard − Remote Radiator − DGFA, DGFB, 30Cover, Box − Fuel Tank Control, 12Cover, Circuit Breaker Box − 10−630 Amp, 73Cover, Circuit Breaker Box − 700−1000 Amp, 75Cover, End Bell, 52Cover, Fuel Tank − Sound Barrier, 43Cover, Housing − Control, 50Cover, Shroud − Radiator − DGFA, DGFB Without MOH, 25Cover, Shroud − Radiator − DGFA, DGFB, DGFC With MOH,
27Cover, Stator − Generator, 57Cover, Stub Up − Skid Pan, 42Cushion, Vibration Isolating − Skid, 44
DDisc, Drive − Generator, 57Display, Digital − Control, 63Drain, Oil, 8Drain, Radiator − DGFA, DGFB, DGFC, 32Drain, Radiator − DGFS, 33
EElement, Air Cleaner, 9External Engine Parts, 7
Index
3
FFan, Alternator, 46Fan, Radiator − DGFA, DGFB Without MOH, 25Fan, Radiator − DGFA, DGFB, DGFC With MOH, 27
GGauge, Liquid Level − Fuel Tank, 10Generator, 55Governor, Electronic − DGFA, DGFB Without MOH, 47Governor, Electronic − DGFC, DGFS or DGFA, DGFB With
MOH, 48Grille − Radiator − DGFA, DGFB Without MOH, 25Grille − Radiator − DGFA, DGFB, DGFC With MOH, 27Guard, Alternator − Radiator − DGFA, DGFB Without MOH, 25Guard, Alternator − Radiator − DGFA, DGFB, DGFC With
MOH, 27Guard, Belt − Remote Radiator − DGFA, DGFB, 30Guard, Fan − Generator, 57Guard, Fan − Radiator − DGFA, DGFB Without MOH, 25Guard, Fan − Radiator − With MOH, 27
HHarness, Wiring − AC, 66Harness, Wiring − Engine, 65Harness, Wiring − Fuel Tank Control, 12Harness, Wiring − Low Coolant Level Sender − DGFA, DGFB,
DGFC, 19Harness, Wiring − PMG, 52Heater, Control, 60Heater, Engine Coolant, 20Heater, Oil, 21Hose, Fuel − Pump to Tank, 11Hose, Radiator − DGFA, DGFB Without MOH, 25Hose, Radiator − DGFA, DGFB, DGFC With MOH, 27Hose, Radiator − DGFS, 29Housing, Control, 50Housing, Generator Set − Quiet Site First Stage, 39Housing, Generator Set − Quiet Site Second Stage, 41Housing, Generator Set − Standard Weather Protective −
DGFA, DGFB, DGFC, 35Housing, Generator Set − Standard Weather Protective −
DGFS, 37
IIndicator, Service − Air Cleaner, 9
LLabels, Miscellaneous, 70Lamp, Indicator − Replacement − Fuel Tank Control, 12
Lever, Governor Control − Electronic Governor − DGFC,DGFS or DGFA, DGFB With MOH, 48
Lever, Stop − Electronic Governor − DGFA, DGFB WithoutMOH, 47
Light Assembly, Indicator − Fuel Tank Control, 12Line, Fuel, 10Link, Terminal − Control Housing, 50Lug, Solderless − Circuit Breaker Box − 10−630 Amp, 73Lug, Solderless − Circuit Breaker Box − 700−1000 Amp, 75Lug, Solderless − Entrance Box, 49
MModule, Alarm, 67Muffler − Critical − Housed Sets, 18Muffler − Standard, 17
PPaint, 5Pan, Skid, 42Pin, Parallel − PMG, 52Plate, Clamping − Remote Radiator − DGFA, DGFB, 30Pulley, Fan − Radiator − DGFA, DGFB Without MOH, 25Pump, Fuel, 11
RRadiator − DGFA, DGFB Without MOH, 25Radiator − DGFA, DGFB, DGFC With MOH, 27Radiator − DGFS, 29Radiator, Remote − DGFA, DGFB, 30Relay − Fuel Tank Control, 12Relay, Control, 59Rotor, PMG, 52Rotor, Wound − Exciter, 57Rotor, Wound − Generator, 57
SScreen, Air Inlet − Generator, 57Sealant, Thread, 5Sender, Low Coolant Level − DGFA, DGFB, DGFC, 19Shield, Rain − Muffler − Critical − Housed Sets, 18Shield, Rain − Standard − MOH Engine, 17Shroud − Radiator − DGFA, DGFB Without MOH, 25Shroud − Radiator − DGFA, DGFB, DGFC With MOH, 27Skid, 44Starter, 45Stator, Generator, 55Stator, PMG, 52Stator, Wound − Exciter, 57Strap, Ground − Skid, 44Support, Engine − Skid, 44Switch, Basin − Basin Alarm, 14
Index
4
Switch, Basin − Low Fuel Alarm, 13Switch, Float − Fuel Pump, 11Switch, Key Operator, 69Switch, Rocker − Fuel Tank Control, 12
TTank, Coolant Recovery − Radiator − DGFA, DGFB Without
MOH, 25Tank, Coolant Recovery − Radiator − DGFA, DGFB, DGFC
With MOH, 27Tank, Expression − DGFS, 31Tank, Fuel, 10
Transformer, Current, 71Tray, Battery, 68Trip, Shunt, 77Tube, Outlet − Radiator − DGFA, DGFB Without MOH, 25Tube, Outlet − Radiator − DGFA, DGFB, DGFC With MOH, 27Tube, Water Heater, 20
VValve, Shutoff − Oil Drain, 8Valve, Shutoff − Radiator Drain − DGFA, DGFB, DGFC, 32Varistor − Generator, 57
5
Abbreviations
Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating CurrentAmp AmpereA/R As RequiredAVR Automatic Voltage RegulatorAWG American Wire GaugeDeg DegreeDC Direct CurrentEFC Electronic Fuel ControlET External ToothEIT External/Internal ToothGFI Ground Fault InterrupterID Inside DiameterIT Internal ToothIEC International Electrotechnical CommissionkW KilowattLPG Liquid Petroleum GasLT LeftM(meter Number) Meter
mm MillimeterMOH Mobile Off HighwayNFS Not For SaleNPT National Pipe ThreadOD Outside Diameteroz. OuncePMG Permanent Magnet GeneratorPh PhasePC Printed CircuitRFI Radio Frequency InterferenceRT RightSpec SpecificationThk ThickUL Underwriters Laboratories Inc.UNC Union National CoarseUNF Union National FineVAC Volts Alternating CurrentVDC Volts Direct CurrentW/(ET, IT, EIT) With
Paint and Thread Sealant
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
Onan Green Enamel(Non-Metallic)
525−0305 − 12 oz. PressurizedSpray Can
525−0306 − Quart Can525−0304 − Gallon Can
518−0601 − Sealant, Thread (6 ml Tube)
6
External Engine Parts
138
2
4
5
13
910
11610
11
1314
1218
15
151516
16
16
17
1717
1920
1920
1920
212122
3
24
25
26
2728
7
7
External Engine Parts
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 856−0013 2 Washer, Lock − W/EIT (1/2)2 416−1093 1 Cable, Battery3 800−2111 3 Screw, Cap − Hex Head (M12 x
1.75 x 25)4 416−1019 1 Boot, Battery − Red5 416−1084 1 Boot, Starter − Red6 102−1356 1 Gasket, Oil Drain7 870−2065−02 4 Nut, Hex − Flange (M6 x 1) −
DGFS8 526−2140 1 Washer, Flat (M12)9 505−0019 1 Bushing, Reducer (1/2 x 3/8)
10 193−0529−01 1 Sensor, Temperature11 193−0444 1 Sender, Oil Pressure12 502−0199 1 Elbow, Male − Inverted 45°13 149−2508 1 Solenoid, Fuel Pump14 821−6002−03 2 Screw, Hex Head (M6 x 1 x 16)15 332−3196 3 Clamp, J
16 821−2033 3 Screw, Lock − Flange Head(M6 x 1 x 16)
17 870−2054 3 Nut, Lock − Flange (M6 x 1)18 502−0802 1 Bushing, Reducer (1/2 x 1/4)19 332−2634 A/R Clamp, J20 821−6004−01 A/R Screw, Hex (M10 x 1.5 x 20)21 338−4238−02 2 Bracket, Harness22 821−2048 1 Screw, Lock − Flange Head
(M8 x 1.25 x 30)23 332−2921 1 Clamp, J (Not Illustrated)24 150−2201 1 Sensor, Magnetic Speed25 416−1092 1 Cable, Battery26 333−0709−02 1 Bracket, Solenoid − DGFS27 821−2045 2 Screw, Lock − Flange (M8 x 1 x
16) − DGFS28 333−0708 1 Solenoid − DGFS
8
Oil Drain Extension
6
3 4
1
7
2
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 503−2433−06 − Hose, Drain − Bulk (Order By The Foot − 4 Feet Required)
2 102−1237 1 Adapter, Oil Drain3 505−0050 1 Elbow, Street (1/2 NPT x 90°)4 504−0011 1 Valve, Shutoff
5 505−0827 1 Hose, Barb (1/2 x 3/4)6 503−0197 1 Clip, Hose − Corbin7 518−0548−02 1 Clamp, Hose
9
Air Cleaner
2
7
6
4
7
6
11
1
9 312
8 10
5
13
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 140−2239−03 1 Bracket, Mounting − Air Cleaner2 140−1973 2 Band, Mounting3 140−3112 1 Cleaner, Air4 526−2140 3 Washer, Flat (M12)5 503−2067 1 Elbow, Air Cleaner6 850−2012 3 Washer, Lock − Spring (M12)7 800−2110 3 Screw, Cap − Hex Head
(M12 x 1.75 x 20)
8 140−1548 1 Indicator, Service9 821−2060 4 Screw, Self-Locking − Hex
Washer Head (M10 x 20)10 503−1870−08 2 Clamp, Hose11 870−2056 4 Nut, Lock − Flange (M10)12 140−3117 1 Element, Air Cleaner13 502−0175 1 Adapter, Pipe
10
Fuel Tank
17
16
18
19
20
21
15
14
9
8
8
1312
10
1
10
2
4
3
7
5
6
2
11
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Tank, Fuel159−1475−01 1 125 Gallon159−1474 1 173 Gallon159−1473 1 336 Gallon
2 Cap, Vent − Pipe159−1371−05 2 125, 173 Gallon Tank (3”)159−1371−06 2 336 Gallon (4”)
3 Coupling, Pipe505−0327 1 125, 173 Gallon Tank (3”)505−0411 1 336 Gallon (4”)
4 Nipple, Pipe505−0679 1 125, 173 Gallon Tank (3”)505−0732 1 336 Gallon (4”)
5 505−0203 1 Coupling, Pipe (2” NPT)6 505−0401 1 Nipple, Pipe (2” NPT x 6” long)7 415−0043 1 Cap, Fill − Fuel (2”)8 505−0027 2 Coupling, Pipe (1/4” NPT)9 505−0007 1 Bushing, Reducer
(1/4” NPT x 1/8” NPT)
10 505−0359 2 Plug, Square Head (1−1/4” NPT)
11 505−0110 1 Plug, Square Head (3/8” NPT)12 Gauge, Liquid Level
415−0565−09 1 125 Gallon Tank415−0565−18 1 173 Gallon Tank415−0565−19 1 336 Gallon Tank
13 501−0627−03 1 Line, Fuel − In (Includes Fuel Filter 149−2441)
14 501−0480−02 1 Line, Fuel − Out15 503−0685 1 Clamp, Hose16 526−0399−66 4 Washer, Flat (M16)17 800−3017−73 4 Screw, Cap − Hex Head
(M16 x 2 x 45)18 850−0114−57 4 Washer, Lock (M16)19 862−0026−58 4 Nut, Hex (M16)20 159−1378 8 Shim, Fuel Tank21 332−0941 1 Tie, Cable
11
Fuel Pump and Control
A
A Section A−A1 23
45
67
8
8
9
8 101112
7
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 159−1468 1 Bracket, Pump2 625−2141−02 1 Control, Day Tank
(See Separate Page for Components)
3 399−0117−01 1 Pump4 502−0942 1 Elbow, Hose − 90°5 502−0943 1 Connector, Hose
(3/8 NPT x 5/8 ID Hose)6 503−1660−04 1 Hose, Fuel − Pump to Tank
7 503−0183 2 Clamp, Hose8 821−2033 12 Screw, Lock − Flange
(M6 x 1 x 16)9 870−2054 4 Nut, Lock − Flange (M6 x 1)
10 Switch, Float308−0913−10 1 173 Gallon Tank308−0913−11 1 336 Gallon Tank
11 098−5387 1 Label, Danger12 338−2397 1 Harness, Wiring
12
Fuel Tank Control
213
12
13
9
8
5
41
17
7 6
18
103
14
11
16
15
20
19
21
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
625−2141−02 1 Control, Fuel Tank − Complete(Includes Parts Listed Below)
1 319−0486 1 Box, Control2 319−0485 1 Cover, Box3 307−2677−02 1 Relay, Pump (K130)4 322−0403−02 1 Light, Assembly, Indicator −
7 Light (Includes WiringHarness)
5 322−0369−02 1 Lamp, Indicator − Replacement6 308−0912 1 Switch, Rocker (On/Off/
Emergency Run) (S102)7 308−0852 1 Switch, Rocker (Reset/Off/Test)
(S111)8 320−1653 1 Breaker, Circuit − DC (Single
Pole) (CB107)9 320−1654 1 Breaker, Circuit − AC (Double
Pole) (CB101)
10 300−3464 1 Board, Printed Circuit11 870−0458 4 Spacer, Board − Printed Circuit12 338−2382 1 Harness, Wiring − Control Box13 815−0350 5 Screw, Self−Tapping − Slotted
Hex Washer Head (#10−32 x3/8”)
14 812−0075 2 Screw, Machine − Round Head(#8−32 x 1/4”)
15 815−0385 2 Screw, Machine − Round Head(#6−32 x 1/2”)
16 332−2605 2 Jumper, Terminal17 331−0027 2 Connector, Romex18 331−0042 1 Connector, Knockout 19 856−0002 1 Washer −EIT (#8)20 315−0687 1 Transformer (T105)21 860−0008 1 Nut, Hex (#8−32)
13
Low Fuel Alarm
1
2
3
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 308−0963−01 1 Switch, Basin (S8)2 505−0026 1 Coupling (1/8)3 Nipple, Pipe (1/8)
505−0753 1 173 Gallon Tank505−1458−05 1 336 Gallon Tank
4 505−1050−01 1 Plug, Pipe − Square Head (Modified)
14
Basin Alarm
4
3
2
1
5
6
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 308−0916−01 1 Switch, Basin2 505−0026 1 Coupling, Pipe3 Nipple, Pipe
505−1458−14 1 70 gallon tank505−1458−05 1 140 gallon tank
4 505−1050 1 Plug, Pipe − Square Head(Modified)
5 332−1992 1 Terminal, Receptacle (.25)(#22−18)
6 332−2430 1 Terminal, Tab (.25) (#22−18)
15
Exhaust AdapterStandard
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 155−3163 1 Adapter, Exhaust 2 155−2570 1 Clamp, V-Band
16
Exhaust Adapter
1
2
3
4
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 155−3172 1 Adapter, Exhaust2 155−2570 1 Clamp, V-Band3 155−3175 1 Brace, Exhaust
4 505−0180 1 Plug, Countersunk5 821−2061 4 Screw, Locking − Flange
(M10 x 1.5 x 25)
17
Muffler − Standard
1
2
3
4
5
6
7
8
9
10 11
121314
15
16
17
18
19
20
21
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 155−3253 1 * Box, Air2 140−3143 1 * Tube, Air Inlet3 155−3271 1 * Bracket, Air Inlet4 155−2175 1 * Clamp, Muffler5 140−3143 1 * Tube, Air Inlet6 140−3148−01 1 * Hose, Air Inlet7 155−3258−01 1 Muffler8 155−3182 1 Bracket, Exhaust9 821−6003−02 1 Screw, Hex Head (M8 x 20)
10 526−2106 1 Washer, Flat (M8)11 862−0026−55 1 Nut, Hex (M8)12 526−0399−42 2 Washer, Flat (Hardened) (M10)13 850−0114−55 1 Washer, Lock − Split (M10)14 800−3017−38 1 Screw, Cap − Hex Head (M10 x
30)
15 155−3292 1 Connection, Exhaust16 155−2305 1 Clamp, Muffler17 815−0829−04 2 * Screw, Hex Washer Head −
Thread Forming (M8 x 16)18 155−3180−01 1 Shield, Rain19 Cap, Rain
155−2062−05 1 Unhoused Sets155−2062−13 1 Housed Sets
20 155−2570 1 Clamp, V-Band21 503−1870−05 1 * Clamp, Hose
* − Parts Used With Wastegate Turbo
18
Muffler − CriticalHoused Sets
1
2
3
4
5
6
7
8
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 155−3150−04 1 Muffler, Critical2 Pipe, Exhaust
155−3164−01 1 DGFA, DGFB, DGFC155−3164−05 1 DGFS
3 155−2305 1 Clamp, Muffler
4 155−2570 1 Clamp, V-Band5 821−6003−02 2 Screw, Cap − Hex Head6 155−3180−01 1 Shield, Rain7 155−2062−13 1 Cap, Rain8 155−3219 2 Gasket, Muffler
19
Low Coolant Level SenderDGFA, DGFB, DGFC
2
1
3
45
6
78
9
10
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Sender, Low Coolant Level (S7)193−0468 1 DGFA, DGFB (Illustrated)193−0558 1 DGFC
2 332−1389 3 Tie, Cable3 338−4178−01 1 Harness, Low Coolant Level
Sender (30.00”) (Includes theFollowing Parts)
4 332−3388 1 Tie, Cable5 323−1494 1 Connector, Receptacle6 323−1502 1 Wedge, Receptacle7 323−1491 3 Pin, Contact (S7)8 323−1709 4 Socket, Contact9 323−1708 4 Seal, Cable
10 323−1765 1 Housing, Connector (4 Pin)
20
Water Heater
1
2
3
3
3
3
4
5
5
6
6
7
8
8
8
8
9
9
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 333−0615 1 Bracket, Heater2 Heater, Engine Coolant
333−0588−03 1 120 Volt333−0588−04 240 Volt
3 503−1634−02 4 Hose, Silicon Rubber (5/8 x 2.5)4 130−4719 1 Tube, Water Heater5 502−0943 2 Connector, Hose (3/8 NPT x 5/8
Hose)
6 505−0019 2 Bushing, Reducer (3/8 x 1/2)7 130−4720 1 Tube − Water Heater8 503−2157−01 8 Clamp, Hose9 821−6006−01 4 Screw, SEMS − Hex Head
(M6 x 1.0 x 16)
21
Oil Heater
2
1
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Heater, Oil333−0429−01 1 120 Volt333−0429−02 1 240 Volt
2 Cable, Heater − Oil335−0168−01 1 120 Volt335−0168−02 1 240 Volt
22
Duct AdapterDGFA, DGFB, DGFC
1 2
3
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−4622 2 Adapter, Duct2 130−4734 2 Adapter, Duct − Side
3 818−0231−02 4 Rivet, Pop
23
Duct AdapterDGFS
1
2
34
4
4
4
3
5
6
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 405−8291−02 1 *^ Panel, Enclosure2 130−6221−02 2 ~^ Adapter, Duct − Sides3 130−6220−02 2 ~^ Adapter, Duct − Top and
Bottom4 821−6007−02 A/R Screw, Hex Head (M8 x 1.25 x
20)
5 818−0231−02 4 ~^ Rivet, Pop6 526−0451 A/R Washer, Flat (M8)
* − Used with Discharge Grille~ − Used with Duct Adapter^ − Used with Grille and Adapter
24
RadiatorDGFA, DGFBWithout MOH
25
2616
27
281
4
1213 22
23
17
19
20
21
14
15
3
24
7
9
10
8
2
5
11
29
6
33
32
18
30
3134
8
35
25
RadiatorDGFA, DGFBWithout MOH
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−4694 2 Side, Housing2 130−4693 1 Cover, Shroud − Bottom3 Radiator
130−4691−01 1 All except 175 DGFB 50° Centigrade
130−4691−02 1 175 DGFB 50° Centigrade4 130−4700 1 Cover, Shroud − Top5 Shroud
130−4698 1 All Except 175 DGFB 40° Centigrade
130−4698−01 1 175 DGFB 40° Centigrade6 130−4697 1 Guard, Fan − LH7 130−4695 1 Guard, Fan − RH8 821−6003−02 37 Screw, SEMS − Hex Head
(M8 x 1.25 x 20)9 130−4716 1 Guard, Alternator
10 130−3216−01 1 Spacer, Fan11 Fan, Radiator
130−4733 1 All Except 175 DGFB 40° Centigrade
130−3208 1 175 DGFB 40° Centigrade12 526−2120 4 Washer, Flat (M10)13 800−2099 4 Screw, Cap − Hex Head
(M10 x 90)14 130−4750 1 Bracket, Bottle
15 503−2045 1 Tube, Outlet − Radiator16 503−2044 1 Hose, Inlet − Radiator17 130−4735 1 Grille (Unhoused Sets)18 130−3984 1 Tank, Coolant Recovery19 821−6002−03 4 Screw, SEMS − Hex Head
(M6 x 1 x 16)20 503−1554 1 Hose, Radiator21 503−0365 3 Clamp, Hose22 818−0231−02 2 Rivet, Pop23 502−1162 1 Fitting, Barbed − Hose24 503−1408−01 1 Hose25 503−0446 2 Clamp, Hose26 504−0003 1 Cock, Drain27 503−0465 2 Clamp, Hose28 503−0685 1 Clamp, Hose29 898−1195−02 − Tubing, Convoluted − Bulk
(Order By The Foot − 4 Feet Required)
30 130−3721−01 1 Cap, Radiator (15 PSI)31 332−1389 2 Tie, Cable32 512−0191 1 Pulley, Fan33 511−0161−16 1 Belt, V − Ribbed34 526−0399−13 4 Washer, Flat35 821−6007−02 6 Screw, Hex Head (M8 x 1.25 x
20)
26
RadiatorDGFA, DGFB, DGFC With MOH
9
14
20
33
34
26
2524
3540
21
4143
394229
38 3
2928
29
1933
6
1
511
12
2
10
8
36
3027
32
1732
22
31
7
3122
32
183223
32
37
14
1315
16
44
27
RadiatorDGFA, DGFB, DGFC With MOH
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−4694 2 Side, Housing2 130−4693 1 Cover, Shroud − Bottom3 130−4691−02 1 Radiator4 130−4700 1 Cover, Shroud − Top5 130−4692 1 Shroud6 130−4699 2 Bracket, Charger Air Cleaner7 154−3021 1 Cooler, Air − Charger8 130−4697 1 Guard, Fan − LH9 130−4695 1 Guard, Fan − RH
10 821−6003−02 41 Screw, SEMS − Hex Head (M8 x 1.25 x 20)
11 130−4716 1 Guard, Alternator12 818−0231−02 2 Rivet, Pop13 130−3216−01 1 Spacer, Fan14 130−4733 1 Fan, Radiator15 526−2120 4 Washer, Flat (M10)16 800−2099 4 Screw, Cap − Hex Head
(M10 x 90)17 502−1290 1 Tube, Connector − Turbo (3.5”)18 502−1291 1 Tube, Charge Air Cleaner19 503−2045 1 Tube, Radiator Outlet20 503−2044 1 Hose, Radiator Inlet21 130−4735 1 Grille (Unhoused sets)22 502−1292 2 Connector, Turbo Tube23 502−1293 1 Connector, Turbo Tube24 130−4750 1 Bracket, Bottle
25 130−3984 1 Tank, Coolant Recovery26 821−6002−03 4 Screw, SEMS − Hex Head
(M6 x 1 x 16)27 502−1294 1 Connector, Turbo Tube28 503−1554 1 Hose, Radiator29 503−0365 3 Clamp, Hose30 503−1872−05 1 Clamp, Hose31 503−1872−07 2 Clamp, Hose32 503−1872−06 5 Clamp, Hose33 503−0465 2 Clamp, Hose34 503−0685 1 Clamp, Hose35 898−1195−02 − Sleeving, Convoluted − Bulk
(Order By The Foot − 4 Feet Required)
36 526−0113 4 Washer, Flat (5/16”)37 800−2059 4 Screw, Cap − Hex Head
(M8 x 30)38 504−0003 1 Cock, Drain39 332−1389 2 Tie, Cable40 130−3721−01 1 Cap, Radiator (15 PSI)41 502−1162 1 Connector, Hose42 503−1408−01 1 Hose43 503−0446 2 Clamp, Hose44 821−6007−02 6 Screw, Hex Head (M8 x 1.25 x
20)
28
RadiatorDGFS
1
2
3
4
5
5
5
5
67
7
5 58
9
10
11
12
1314
1514
1617
18
19
20
21
22
22
22
23
2425
26
27
28
29
30
31
32333435
36
28
37
29
RadiatorDGFS
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−6206−02 1 Bracket, Shroud2 130−6205−02 1 Bracket, Shroud3 130−6126−02 2 Baffle, Air − Shroud4 154−3178 1 Cooler, Charge Air5 821−6007−02 38 Screw, Hex Head (M8 x 1.25 x
20)6 130−6208−02 1 Shroud, Fan7 895−0381 − Seal, Weather − Bulk (Order by
the Foot − 11 Feet Required)8 130−6207−02 2 Bracket, Radiator9 508−1196 2 Bushing
10 130−5996−01 1 Radiator11 508−1197 2 Bushing12 130−6211−02 1 Bracket, Radiator13 130−4695 1 Guard, Fan − Right14 821−6003−01 13 Screw, Hex Head (M8 x 1.25 x
16)15 130−4697 1 Guard, Fan − Left16 130−4716 1 Guard, Alternator17 818−0231−02 2 Rivet, Pop18 130−6212−02 1 Cover, Shroud
19 502−1293 1 Connect, Turbo Tube20 130−6236 1 Tube, Heat Exchanger21 502−1294 1 Connect, Turbo Tube22 503−1872−06 5 Clamp, Hose23 503−1872−05 1 Clamp, Hose24 503−2515 1 Hose, Radiator25 503−0465 1 Clamp, Hose26 130−6219−02 1 Bracket, Radiator27 503−2538 1 Hose, Radiator28 503−1141 2 Clamp, Hose29 503−0365 2 Clamp, Hose30 503−2517 1 Hose, Air31 128−0154−06 1 Insulation, Foam32 130−3216−01 1 Spacer, Fan33 130−4733 1 Fan, Radiator34 526−2120 4 Washer, Flat (M10)35 800−2099 4 Screw, Cap − Hex Head (M10 x
1.5 x 90)36 502−1520 1 Coupling, Hose37 098−7451−01 1 Label, Caution
30
Remote RadiatorDGFA, DGFB
2 10
10
6
10
1
10
4
5
8
9
10
10
10
3
7
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−4708 1 Guard, Belt2 130−4709 1 Guard, Belt3 130−4712 1 Bracket, Guard − Belt4 130−4710 1 Bracket, Guard − Belt (LH)5 130−4711 1 Bracket, Guard − Belt (RH)6 130−4707 1 Cover, Guard − Belt7 800−2110 4 Screw, Cap − Hex Head
(M12 x 1.75 x 20)
8 130−3582 1 Plate, Clamping9 821−2061 4 Screw, Lock − Flange
(M10 x 1.5 x 25)10 821−6003−02 27 Screw, SEMS − Hex Head
(M8 x 1.25 x 20)
31
Expansion TankDGFS
1
2
34
56
78
9
1011
56
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−6319 1 Tank, Expansion2 130−3929 1 Cap, Filler3 505−0055 1 Plug, Square Head (Without
Low Coolant Switch)4 193−0558 1 Sensor, Level (With Low
Coolant Switch)5 503−0304 − Hose − Bulk (Order by the Foot
− 3 Feet Required)6 503−1134 4 Clamp, Hose
7 503−2079 − Hose − Bulk (Order by the Foot− 5 Feet Required)
8 503−1137 2 Clamp, Hose9 503−0276 − Hose, Breather − Bulk (Order
by the Foot 5 Feet Required)10 526−0333 1 Washer, Flat11 800−2072 1 Screw, Cap − Hex Head (M8 x
1.25 x 100)
32
Radiator DrainDGFA, DGFB, DGFC
12
3
46
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 502−0047 1 Nipple, Pipe (1/4)2 502−0802 Bushing, Flush (1/4 x 1/2)3 504−0011 1 Valve, Shutoff (1/2)
4 502−0827 1 Hose, Barb (1/2 x 3/4)5 503−0098 1 Hose (24”)6 503−0197 1 Clamp, Hose
33
Radiator DrainDGFS
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 503−1408−01 1 Hose 2 503−1134 1 Clamp, Hose
34
HousingStandard Weather Protective
DGFA, DGFB, DGFC
11
92425
109
3
5
2
12
1
4
15
16
13
8
6
17
6
1918
715
23
21
20
21
22
14
1426
27
28
29
35
HousingStandard Weather Protective
DGFA, DGFB, DGFC
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 405−5908 2 Panel, Side − Radiator Housing2 405−5909 1 Panel, Front − Radiator Housing3 405−5926 1 Roof4 405−5744 4 Post, Housing − Center5 405−5915 1 Angle, Roof6 405−5916 2 Post, Corner − Housing7 128−0154−02 1 Insulation, Foam8 406−0831 14 Hinge, Door9 155−3238 3 Cover, Exhaust
10 098−4730 1 Label, Warning11 098−5429 1 Label, Coolant Fill12 098−4500 2 Label, Prototype Tested13 818−0231−02 98 Rivet, Pop (3/16)14 821−6007−02 36 Screw, Hex Head
(M8 x 1.25 x 20)15 405−5832 6 Door, Housing16 406−0972−01 7 Latch, Door17 Door, Housing
405−5903 1 Sets With Control Window405−5902 1 Sets W/O Control Window
18 895−0363 − Weatherstrip − Window − Bulk (Order By The Foot − 4 Feet Required)
19 319−2653 1 Window, Control (If Equipped)20 895−0382 14 Bumper, Door21 405−5917 2 Panel, End − Roof22 818−0237−01 6 Rivet, Pop (1/8)23 128−0154−01 1 Insulation, Foam24 870−0504 2 Nut, Captive Floating (M6 x 1.0)25 821−6006−01 2 Screw, Hex Head (M6 x 16)26 526−0451 2 Washer, Flat − Stainless Steel
(M8)27 098−4732 2 Label, Warning28 098−7902−03 2 Label, Logo29 098−7868 1 Label
36
HousingStandard Weather Protective
DGFS
11
92425
109
3
5
2
12
4
15
16
13
8
6
17
6
1918
715
23
21
20
21
22
14
1426
27
28
1
29
37
HousingStandard Weather Protective
DGFS
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−7868 1 Label2 405−8291−02 1 Panel, Front − Radiator Housing3 405−5926 1 Roof4 405−5744 4 Post, Housing − Center5 405−5915 1 Angle, Roof6 405−5916 2 Post, Corner − Housing7 128−0154−02 1 Insulation, Foam8 406−0831 14 Hinge, Door9 155−3238 3 Cover, Exhaust
10 098−4730 1 Label, Warning11 098−5429 1 Label, Coolant Fill12 098−4500 2 Label, Prototype Tested13 818−0231−02 100 Rivet, Pop (3/16)14 821−6007−02 36 Screw, Hex Head
(M8 x 1.25 x 20)15 405−5832 6 Door, Housing16 406−0972−01 7 Latch, Door17 Door, Housing
405−5903 1 Sets With Control Window405−5902 1 Sets W/O Control Window
18 895−0363 − Weatherstrip − Window − Bulk (Order By The Foot − 4 Feet Required)
19 319−2653 1 Window, Control (If Equipped)20 895−0382 14 Bumper, Door21 405−5917 2 Panel, End − Roof22 818−0237−01 4 Rivet, Pop (1/8)23 128−0154−01 1 Insulation, Foam24 870−0504 2 Nut, Captive Floating (M6 x 1.0)25 821−6006−01 2 Screw, Hex Head (M6 x 16)26 526−0451 2 Washer, Flat − Stainless Steel
(M8)27 098−4732 2 Label, Warning28 098−7902−03 2 Label, Logo29 098−7451−01 1 Label, Caution
38
HousingQuiet Site First Stage
214661
218
9
37
29
50
60
50
32
49
59
37
742
39
58
28
44
24
27
45
2523
2026 41
727
33
51
1
3436
631
15
27
42
22
4011
19
18
10
1314
4813
1448
16
5
2 20
124
54
5 1757
56
53
55
43
38
43
13
41
30
35
47
52
62
47
3
39
HousingQuiet Site First Stage
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 405−8312 1 Retainer, Insulation2 895−0385 7 Weather Seal − Side3 098−7868 1 Label4 895−0363 − Weather Strip − Window − Bulk
(Order By The Foot − 4 Feet Required)
5 895−0384 14 Weather Seal − Top & Bottom6 405−6001−01 2 Insulation7 098−7913 2 Label, Logo8 098−5429 1 Label, Coolant Fill9 098−4730 1 Label, Caution
10 098−4500 2 Label, Prototype Tested11 098−7451 2 Label, Caution12 319−2653 1 Window, Control13 405−5734 6 Insulation, Door14 405−5744 4 Post, Housing − Center15 405−5841 3 Fiberglass16 Door, Housing
405−5902 6 Sets W/Control Window405−5902 7 Sets WO/Control Window
17 405−5903 1 Door W/Window Cutout18 405−5908 2 Panel, Side − Radiator Housing19 Panel, Front − Radiator Housing
405−5909 1 DGFA, DGFB, DGFC405−8291−02 1 DGFS
20 405−5916 2 Post, Corner − Housing21 155−3238 3 Cover, Exhaust22 405−5952 1 Extension, Front23 405−5953 1 Extension, Rear24 405−5954 2 Baffle, Air25 405−8304 2 Retainer, Insulation26 405−5956 1 Duct, Support27 405−5957 5 Angle, Support28 405−8305 2 Retainer, Insulation29 405−5962 1 Baffle, Air − Discharge
30 405−8306 1 Retainer, Insulation31 405−8307 3 Retainer, Insulation32 405−5963 1 Fill Neck − Radiator33 405−5966 1 Box, Muffler34 405−5986 1 Cover, Exhaust Inlet35 405−6109 1 Insulation36 526−0011 2 Washer, Flat37 405−5917 2 Panel, End − Roof38 517−0138−07 2 Plug39 405−5950 1 Extension, Side − RH40 405−5951 1 Extension, Side − LH41 405−5997 2 Insulation42 405−5998 2 Support, Muffler43 517−0322 4 Plug44 405−6000−02 2 Insulation45 405−6000−03 2 Insulation46 821−6006−01 2 Screw, Hex Head (M6 x 16)47 821−6007−02 54 Screw, Hex Head (M8 x 20)48 405−6001−02 4 Insulation49 405−6002 1 Barrier, Air Flow50 405−6003 2 Box, Radiator Fill51 405−6005 1 Insulation52 818−0237−01 39 Rivet (1/8)53 818−0231−02 164 Rivet (3/16)54 895−0386 7 Weather Seal55 517−0131 3 Plug56 406−0972−01 7 Latch, Door57 406−0831 14 Hinge, Door58 405−8311 2 Retainer, Insulation59 405−5926 1 Roof60 405−5959 1 Baffle, Recirculation − Muffler61 870−0504 2 Nut, Captive Floating (M6 x 1.0)62 526−0451 4 Washer, Flat − Stainless Steel
(M8)
40
HousingQuiet Site Second Stage
7776
75
43
75
53
52
216761
21
21 89
78
37
46
29
50
60
50
32
49
59
78
7 42
39
58
28
44
2427
45
2523
20 26 41
727
33
51
81
3479
63115
27
42
22
4011
19
1810
131448
1314
48
16
157
38
46
35
56
36
47
5
2 20
124
545
1762
63
64
55
73
687269
687170
74
13
41
30
80
82
66
66
83
3
84
41
HousingQuiet Site Second Stage
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 405−8313 4 Retainer, Insulation2 895−0385 7 Weather Seal − Side3 098−7868 1 Label4 895−0363 − Weather Strip − Window − Bulk
(Order By The Foot − 4 Feet Required)
5 895−0384 14 Weather Seal − Top & Bottom6 405−6001−01 2 Insulation7 098−7913 2 Label, Logo8 098−5429 1 Label, Coolant Fill9 098−4730 1 Label, Caution
10 098−4500 2 Label, Prototype Tested11 098−7451 2 Label, Caution12 319−2653 1 Window, Control13 405−5734 6 Insulation, Door14 405−5744 4 Post, Housing − Center15 405−5841 3 Insulation16 Door, Housing
405−5902 6 Sets W/Control Window405−5902 7 Sets WO/Control Window
17 405−5903 1 Door W/Window Cutout18 405−5908 2 Panel, Side − Radiator Housing −
DGFA, DGFB, DGFC19 Panel, Front − Radiator Housing
405−5909 1 DGFA, DGFB, DGFC405−8291−02 1 DGFS
20 405−5916 2 Post, Corner − Housing21 155−3238 3 Cover, Exhaust22 405−5952 1 Extension, Front23 405−5953 1 Extension, Rear24 405−5954 2 Baffle, Air25 405−8304 2 Retainer, Insulation26 405−5956 1 Duct, Support27 405−5957 5 Angle, Support28 405−5954 2 Retainer, Insulation29 405−5962 1 Baffle, Air − Discharge30 405−8306 1 Retainer, Insulation31 405−8307 3 Retainer, Insulation32 405−5963 1 Fill Neck − Radiator33 405−5966 1 Box, Muffler34 405−5986 1 Cover, Exhaust Inlet35 405−9022−02 2 Bottom, Discharge36 405−5990 1 Cover, Air Discharge37 405−5991−01 2 Side, Discharge − RH38 405−5991−02 2 Side, Discharge − LH39 405−5950 1 Extension, Side − RH
40 405−5951 1 Extension, Side − LH41 405−5997 2 Insulation42 405−5998 2 Support, Muffler43 405−6000−01 2 Insulation44 405−6000−02 2 Insulation45 405−6000−03 2 Insulation46 405−6000−04 4 Insulation47 405−6000−07 1 Insulation48 405−6001−02 4 Insulation49 405−6002 1 Barrier, Air Flow50 405−6003 2 Box, Radiator Fill51 405−6005 1 Insulation52 405−5989 1 Cover, Discharge53 405−6010 1 Cover, Discharge54 895−0386 7 Weather Seal55 517−0131 3 Plug56 405−6013 1 Retainer, Insulation57 405−8310 4 Retainer, Insulation58 405−8311 2 Retainer, Insulation59 405−5926 1 Roof60 405−5959 1 Baffle, Recirculation − Muffler61 870−0504 2 Nut, Captive Floating (M6 x 1.0)62 406−0831 14 Hinge, Door63 406−0972−01 7 Latch, Door64 818−0231−02 162 Rivet (3/16)65 818−0237−01 105 Rivet (1/8)66 821−6007−02 102 Screw, Hex Head (M8 x 20)67 821−6006−01 2 Screw, Hex Head (M6 x 16)68 517−0322 4 Plug69 517−0138−07 2 Plug70 405−6923−03 2 Insulation71 405−6923−04 2 Insulation72 405−6924 1 Insulation73 405−6925 2 Insulation74 405−6008 1 Adapter, Battery Tray75 405−5994 2 Retainer, Insulation76 405−5992 1 Panel, Center77 405−5993 1 Cover, Duct78 405−5917 2 Panel, End − Roof79 526−0011 2 Washer, Flat80 405−6109 1 Insulation81 405−8312 1 Retainer, Insulation82 405−8314 1 Retainer, Insulation83 526−0451 4 Washer, Flat − Stainless Steel
(M8)84 405−9023−02 2 Panel, Access
42
Skid Pan
4
3
2
1
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 403−4183 1 Pan, Skid2 403−4110 12 Clamp3 821−6002−03 42 Screw, SEMS − Hex Head
(M6 x 1 x 16)
4 403−4215 2 Cover, Stub up5 403−4116 1 Cover, Stub up
43
Sound Barrier
12
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 159−1482 1 Cover, Fuel Tank 2 821−6003−02 6 Screw, SEMS − Hex Head (M8 x 1.25 x 20)
44
Skid
8
7
3
9
514
4
1
12
11
5
6
8
13
104
514
4
2
9
15
15
16
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Skid403−4188−03 1 Basic (F177) (Illustrated)403−4154−04 1 Housing Compatible (F179)
2 402−0779−05 1 Cushion, Vibration Isolating3 Cushion, Vibration Isolating
402−0779−06 2 Standard Duty402−0779−07 2 Severe Duty
4 526−0433 10 Washer, Hardened (M12)5 Screw, Cap − Hex Head
800−2543−02 8 Standard Duty (M12 x 25)800−2543−03 8 Severe Duty (M12 x 30)
6 403−4218 1 Support, Engine7 526−0238−01 4 Washer, Flat (3/4)
8 800−0607 3 Screw, Cap − Hex Head (3/4−10 x2) (Grade 8)
9 862−0044 3 Nut, Hex (3/4−10)10 800−2124 4 Screw, Cap − Hex Head
(M12 x 1.75 x 90)11 856−0013 2 Washer, Lock − EIT (1/2)12 337−0090 1 Strap, Ground13 526−0443 1 Washer, Flat − Hardened (3/4)14 800−2543−03 8 Screw, Cap − Hex Head − Severe
Duty (M12 x 30)15 850−0117 6 Washer, Lock − Spring − Severe
Duty − Hardened (M12)16 517−0094 2 Plug, Plastic
45
Starter
1
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 191−2347 1 Starter
46
Alternator
1
23
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 191−2326−01 1 Alternator2 191−2330 1 Fan, Alternator
3 860−2031 1 Nut, Flange (M16 x 1.5)
47
Electronic GovernorDGFA, DGFBWithout MOH
9
2
1
12
13
9
74
68
9
7
1110
45
7
11
10
11
10
3
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 150−2679 1 Bracket, Governor2 151−0708−01 1 Actuator, Governor3 150−2682 1 Clevis, Governor4 150−2120 2 End, Rod5 520−0939 1 Stud 6 868−0001 2 Nut, Hex (1/4−28)7 526−0018 4 Washer, Flat (1/4)8 150−2681 1 Lever, Stop − Governor
9 800−0007 6 Screw, Cap − Hex Head (1/4−20 x 1)
10 850−0040 6 Washer, Lock (1/4)11 862−0001 6 Nut, Hex (1/4−20)12 850−2010 2 Washer, Lock − Spring (M10)13 802−2507 2 Screw, Cap − Socket Head
(M10 x 1.5 x 25)
48
Electronic GovernorDGFC, DGFS or DGFA, DGFB With MOH
1
2
3
4
4
5
6
6
6
7
7
7
8
9
9
9
10
10
10
11
11
11
12
13
10
14
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 150−2794−02 1 Bracket, Governor2 151−0708−01 1 Actuator, Governor3 150−2682 1 Clevis, Governor4 150−2120 2 Rod, End5 150−2763−04 1 Rod, Threaded (1/4−28 x 5.75)6 868−0001 3 Nut, Hex (1/4−28)7 526−0018 4 Washer, Flat (1/4)8 150−2761−04 1 Lever, Governor Control
9 800−0007 6 Screw, Cap − Hex Head(1/4−20 x 1.00)
10 850−0040 8 Washer, Lock (1/4)11 862−0001 6 Nut, Hex (1/4−20)12 850−2010 4 Washer, Lock − Spring (M10)13 802−2507 4 Screw, Cap − Socket Head
(M10 x 1.50 x 25)14 800−3017−02 2 Screw, Cap − Hex Head (M6 x
1.0 x 12)
49
Entrance Box
1
2
3
4
5
786
44
4
4
4
4
2
1
4 9
10
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−3072 2 Panel, Box − Top and Bottom2 319−2978 2 Panel, Box − Side3 319−2979−02 1 Cover, Entrance Box4 821−6002−03 24 Screw, Self−Locking − Hex
Washer Head (M6 x 1 x16mm)
5 508−0239 − Edging − Bulk (Order By TheFoot − 2 Feet Required)
6 856−0008 1 Washer, Lock − EIT (5/16”)7 821−6003−02 1 Screw, Self−Locking − Hex
Washer Head (M8 x 1.25 x20mm)
8 332−1473 1 Lug, Solderless9 319−2996 1 Cover, Control Housing
10 098−6537 1 Label, Ground
50
Control Housing
1
2
3
4
4
5
6
7
8
19
11
11
8
10
22
9
1022
12
13
14
20
2115
1617
18
23
24
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Panel, Housing − Control319−3208 1 Sets With UCD22
Generator319−2967 1 Sets With UC27 Generator
2 319−3207 1 Bracket, Control Mounting −Sets With UCD22 Generator
3 Cover, Housing − Control319−2996 3 Generator Sets Without
Circuit Breaker or Entrance Box
319−2996 2 Generator Sets With Circuit Breaker or Entrance Box
319−2996 1 Generator Sets With Two Circuit Breakers
4 Screw, Hex Head (M6 x 16)821−6002−03 4 Sets With UC27 Generator821−6002−03 9 Sets With UCD22
Generator5 319−4456−02 1 Bracket, Control6 856−0010 1 Washer, Lock − W/EIT (3/8)7 337−0049 1 Strap, Bond8 821−6003−01 3 Screw, Hex Head (M8 x 1.25 x
16)
9 Washer, Lock − W/EIT856−0012 1 UCD22 (7/16)856−0013 1 UC27 (1/2)
10 800−2052 4 Screw, Cap − Hex Head (M8 x1.25 x 12)
11 508−0305−02 − Edging − Bulk (Order By TheFoot − 3 Foot Required)
12 319−4457 1 Panel, Control13 815−0943−02 6 Screw, Hex Washer Head −
Thread Forming (1/4−10 x .5)14 517−0135 1 Plug, Hole15 332−2987 4 Link, Terminal16 526−2120 8 Washer, Flat (M10)17 850−2010 8 Washer, Lock (M10)18 860−2009 8 Nut, Hex (M10 x 1.5)19 819−1144 1 Screw, Pan Head − Cross
Recessed (M6 x 8)20 332−3740 1 Clamp, Strain21 814−2150 3 Screw, Flat Head − Cross
Recessed (M3 x 0.5 x 10)22 526−2100 4 Washer, Flat (M8)23 098−5347−01 1 Label, Danger24 821−6001−02 2 Screw, Hex Head
51
Generator Heater
1 2
3
4
5
6
78
9
10
1112
13
1415
16
17185
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Cartridge, Heater333−0438−07 1 110−125 Volt333−0438−08 1 220−260 Volt
2 332−3024−11 2 Clamp, Loop3 822−3075 6 Screw, Pan Head (M4 x 16)4 860−2005 2 Nut, Hex (M4)5 850−2004 4 Washer, Lock (M4)6 526−2050 2 Washer, Flat (M4)7 330−0142 1 Box, Terminal − Heater8 332−3023 1 Block, Terminal9 508−0228 1 Grommet
10 098−7281 1 Label, Warning − Heater11 822−3047 1 Screw, Pan Head (M3 x 20)12 850−2003 1 Washer, Lock (M3)13 800−3034 1 Screw, Cap − Hex Head
(M4 x .7 x 12)14 332−3228 1 Mount, Tie − Cable15 870−2064−01 1 Nut, Nylon16 332−1389 1 Tie, Cable17 815−0792−04 2 Screw, Countersunk − Pan
Head (M4 x .7 x 12)18 517−0021 1 Plug, Dot − Button
52
Permanent Magnet Generator
4
2
5
3
6
7
10
8
11
9
1
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 775−0049 1 Pin, Parallel2 815−0761−01 1 Bolt, Mounting − PMG3 201−3446 1 Rotor, PMG4 220−4233 1 Stator, PMG5 232−3972 4 Clamp, Stator6 234−0875−02 1 Cover, End Bell
7 232−3462−02 4 Spacer, Cover8 821−6001−01 4 Screw, Hex Head (M5 x 10)9 850−2010 1 Washer, Lock (M10)
10 338−3011 1 Harness, PMG11 850−2006 4 Washer, Lock (M6)
53
This Page Intentionally Left Blank.
54
27
7
40
42
1
17
16
37
38
39
41
36
2631
25
19
2221
20
35
34
44
2122
434421
46
45
29
28 30
21
22
18
20 24
23
12
13
811
9
32
35
5 3
49
4847
61452
2
50
4
15
33 35
10
Generator
54
53
51
Continued...
55
Generator
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Stator60 Hz, 12 Lead, Upper Broad
Range Reconnectible, 150C220−4448−16 1 DGFA220−4448−18 1 DGFB, DGFC, DGFS
60 Hz, 3 Phase, 347/600 Volt, 150C
220−4448−33 1 DGFA220−4448−35 1 DGFB220−4448−36 1 DGFC, DGFS
60 Hz, 12 Lead, Lower Broad Range Reconnectible, 150C
220−4448−23 1 DGFA220−4448−24 1 DGFB, DGFC, DGFS
60 Hz, 12 Lead, Upper Broad Range Reconnectible, 125C
220−4448−17 1 DGFA220−4448−18 1 DGFB220−4448−39 1 DGFC, DGFS
60 Hz, 12 Lead, Broad Range Reconnectible, Full 1 Phase, 125C
220−4448−39 1 DGFA60 Hz, 4 Lead, 1 Phase, 125C
220−4448−11 1 DGFA220−4448−38 1 DGFB
60 Hz, 3 Phase, 347/600 Volt, 125C
220−4448−34 1 DGFA220−4448−35 1 DGFB220−4448−36 1 DGFC, DGFS
60 Hz, 12 Lead, Lower Broad Range Reconnectible, 125C
220−4448−23 1 DGFA220−4448−24 1 DGFB220−4448−40 1 DGFC, DGFS
60 Hz, 12 Lead, Upper Broad Range Reconnectible, 125C
220−4448−17 1 DGFA220−4448−18 1 DGFB220−4448−39 1 DGFC, DGFS
60 Hz, 4 Lead, 1 Phase, 105C220−4448−38 1 DGFA
60 Hz, 3 Phase, 347/600 Volt, 105C
220−4448−34 1 DGFA220−4448−36 1 DGFB220−4448−42 1 DGFC, DGFS
60 Hz, 12 Lead, Lower Broad Range Reconnectible, 105C
220−4448−23 1 DGFA220−4448−24 1 DGFB
50 Hz, 12 Lead, Broad Range Reconnectible, 150C
220−4448−17 1 DGFA220−4448−18 1 DGFB220−4448−39 1 DGFC, DGFS
50 Hz, 12 Lead, Upper Broad Range Reconnectible, 125C
220−4448−17 1 DGFA220−4448−18 1 DGFB220−4448−39 1 DGFC, DGFS
50 Hz, 12 Lead, Broad Range Reconnectible, Full 1 Phase, 125C
220−4448−39 1 DGFA50 Hz, 12 Lead, Broad
Range Reconnectible, 105C220−4448−39 1 DGFA, DGFB, DGFS
56
27
7
40
42
1
17
16
37
38
39
41
36
2631
25
19
2221
20
35
34
44
2122
434421
46
45
29
28 30
21
22
18
20 24
23
12
13
811
9
32
35
5 3
49
4847
61452
2
50
4
15
33 35
10
Generator
54
53
51
57
Generator
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
Continued...2 Rotor, Wound
201−3474−05 1 UCD22 201−3497−01 1 UC27 Core Length 165201−3497−02 1 UC27 Core Length 190201−3497−03 1 UC27 Core Length 230201−3497−04 1 UC27 Core Length 285201−3497−05 1 UC27 Core Length 335201−3497−06 1 UC27 Core Length 375201−3561−07 1 UCD27
3 850−2005 2 Washer, Lock (M5)4 526−2060 2 Washer, Flat (M5)5 515−0298−03 1 Key, Exciter6 Rotor, Wound − Exciter
201−3434−02 1 UCD22201−3434−03 1 UC27, UCD27
7 509−0266−02 1 O−Ring8 Adapter, Generator
231−0370 1 UCD22231−0317 1 UC27 SAE2231−0325 1 UC27 SAE3231−0373 1 UCD27
9 800−2090 6 Screw, Cap − Hex Head (M10 x 45)
10 800−2088 4 Screw, Cap − Hex Head (M10 x 35)
11 850−2010 10 Washer, Lock (M10)12 720−1123 8 Screw, Cap − Hex Head (M16 x
60)13 232−3699 3 Disc, Drive − Generator14 357−0091 1 Rectifier − Forward15 526−0259 8 Washer, Flat 16 Adapter, Stator
231−0319 1 UC27231−0374 1 UCD27
17 508−0139 A/R Seal Edging − Bulk (786mm req.)
18 Cover, Stator − Top234−0936−03 1 UCD22234−0937−01 1 UC27 Stack Length 165234−0937−02 1 UC27 Stack Length 190234−0937−03 1 UC27 Stack Length 230234−0937−04 1 UC27 Stack Length 285234−0937−05 1 UC27 Stack Length 335234−0937−05 1 UCD27
19 Cover, Stator − Bottom232−3819−03 1 UCD22232−3820−01 1 UC27 Stack Length 165232−3820−02 1 UC27 Stack Length 190232−3820−03 1 UC27 Stack Length 230232−3820−04 1 UC27 Stack Length 285232−3820−05 1 UC27 Stack Length 335232−3820−05 1 UCD27
20 800−3017−54 10 Screw, Cap − Hex Head (M12 x 30)
21 850−0114−56 10 Washer, Lock (M12)22 526−0399−64 10 Washer, Flat (M12)23 508−1057 1 Grommet24 232−3421 1 Block, Terminal25 517−0135 1 Plug, Hole26 526−0423 6 Washer (M10)27 800−3017−38 6 Screw, Cap − Hex Head
(M10 x 30)28 850−2008 3 Washer, Lock (M8)29 800−2060 3 Screw, Cap − Hex Head
(M8 x 1.25 x .35)30 526−2100 3 Washer, Flat (M8)31 850−0114−55 6 Washer, Lock (M10)32 Guard, Fan
234−0980 2 UCD22234−0867 2 UC27234−0983 2 UCD27
33 Cover, Adapter234−0981 2 UCD22234−0984 2 UCD27
34 234−0879 2 Screen, Air Inlet35 821−6001−02 24 Screw, SEMS (M5 x 12)36 211−0423 1 Bell, End37 526−0423 6 Washer (M10)38 850−0114−55 6 Washer, Lock (M10)39 800−3017−38 6 Screw, Cap − Hex Head
(M10 x 30)40 850−2006 4 Washer, Lock (M6)41 800−2046 4 Screw, Cap − Hex Head (M6)42 Stator, Wound − Exciter
220−4293−05 1 UCD22, UC27 Core Length 40220−4293−06 1 UC27, UCD27 Core Length 60
43 Bracket, Mounting − Generator232−3940 2 UCD22232−3925 2 UC27
44 800−3017−56 8 Screw, Cap − Hex Head (M12)45 526−0399−64 8 Washer, Flat (M12)46 232−3730−04 4 Spacer, Mounting Foot47 510−0164 1 Bearing, Ball48 518−0083 1 Ring, Split − External49 304−0807 1 Varistor50 860−2006 2 Nut, Hex (M5 x .8)51 805−0015 8 Bolt, Place (3/8−16 x .75)52 357−0092 1 Rectifier − Reverse53 232−3695 1 Hub, Drive − Generator
(UC27 Generator)54 526−0174 8 Washer, Flat (3/8)55 200−3140−01 1 Generator, Complete − DGFS (Not
Illustrated)
58
End Bell
1
2
3
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 526−2080 8 Washer, Flat (M6)2 232−3462−01 4 Spacer, Cover3 234−0875−01 1 Cover, End Bell
4 821−6001−01 4 Screw, Hex Head (M5 x 0.8 x10)
59
Control Relay
1
2
2
3
4
4
5 6
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 332−3842−01 1 Rail, Terminal Block2 819−1154 2 Screw, Pan Head − Cross
Recessed (M5)3 307−2873 3 Relay, Control − 12V (K10, K11,
K12)
4 332−2878 2 Bracket, End − Terminal5 338−4438 1 Harness, Relay6 305−1009 3 Suppresor, Voltage
60
Control Heater
1
23
23
4
5
6
78
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Heater, Control333−0661−01 1 120V333−0661−02 1 240V
2 332−2420 3 Mount, Cable Tie3 332−1445 3 Tie, Cable4 335−0173 1 Cable, Control Heater − 120V5 335−0173−01 1 Cable, Control Heater − 240V
6 Tag, Heater098−6927 1 120V098−6928 1 240V
7 098−6195 1 Label, Caution8 323−2003−02 1 Strain Relief
61
This Page Intentionally Left Blank.
62
Control
1
2
3
4
5
6
7
8
9
1011
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
2626
27
28
29
30
31
32
33
34
35
ÂÂ
ÂÂ
36
63
Control
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−4487 1 Box, Control2 319−4488 1 Door Control3 300−5467 1 Display, Digital4 332−3896 4 Clamp, Cable5 300−5180 1 Board, Printed Circuit −
Bargraph6 300−5383 1 Board, Printed Circuit − LED7 819−1137−02 4 Screw, Pan Head − Cross
Recessed (M3 x 8)8 098−7904 2 Label, Danger9 338−3991 1 Harness, Control − Door
10 402−0764−01 4 Mount, Isolator11 406−0845 1 Pin, Hinge12 322−0491 3 Lamp, LED13 327−1379−01 1 Board, Printed Circuit − Base
(Includes Fuses)321−0321−01 1 2A321−0321−04 1 5A321−0321−06 1 10A
14 319−4497 1 Guard, Electrical15 517−0356 1 Plug, Hole (Fits 22.5mm DIA.
Hole)16 517−0357 1 Plug, Hole (Fits 38mm DIA.
Hole)17 517−0355 2 Plug, Hole (Fits 16mm DIA.
Hole)18 815−0792−02 2 Screw, Machine − Pan Head
(M4 x 0.7 x 8)
19 819−1144 2 Screw, Pan Head − CrossRecessed (M6 x 8)
20 Panel, Membrane300−5446 1 With Bargraph300−5447 1 Without Bargraph
21 332−2420 2 Mount, Cable Tie22 327−1275 1 Board, Printed Circuit − NCM23 870−2213−02 4 Standoff, Hex Threaded − With
NCM24 338−3994 1 Harness, Panel Light25 322−0488 3 Lens, LED26 Screw, Pan Head − Cross
Recessed (M3 x 6)819−1137−01 9 Without Bargraph819−1137−01 15 With Bargraph
27 335−0189 1 Cable, Ribbon28 332−1445 3 Tie, Cable29 098−7918 1 Label, Information30 098−7961−01 1 Label, Information − Panel
Insert31 098−7989 1 Label, Instruction − Torque32 308−0999 1 Switch, Emergency Stop33 308−1085 1 Switch, Selector34 098−8057 1 Label, Information − Rating35 098−6984 1 Label, UL36 337−0049 1 Strap, Bond
64
Engine Wiring Harness
1
2
3
4 5
6
7 8
9
1011
12
13
14
15
16
17 18
19
20
21
2223
65
Engine Wiring Harness
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Harness, Wiring − Engine toControl
DGFA, DGFB, DGFC338−4231 1 Tier II (Includes Parts
Marked *)338−4227 1 Non−Tier II (Includes
Parts Marked #)338−4506 1 DGFS (Includes Parts
Marked ^)2 307−2968−03 2 *#^ Relay, Power3 307−2982−02 2 *#^ Bracket, Relay4 323−1492 3 *# Socket, Contact5 323−1493 1 *# Connector, Plug6 323−1503 1 *# Wedge, Plug7 323−1525 1 *#^ Connector − 36 Pin8 323−1755 2 *#^ Connector, Socket9 332−0604 1 *#^ Block, Terminal
10 332−1043 4 *#^ Jumper11 815−0538 2 *#^ Screw, Cross Recessed − Pan
Head − W/ET (#8−32 x .50)
12 319−2006−05 1 *#^ Bracket, Terminal Mounting13 332−3792−01 1 *#^ Cover, Terminal Block (Includes
Spring Clips)14 416−1021−02 1 *#^ Boot15 812−0079 4 *#^ Screw (#8−32 x .5)16 870−0221 4 *#^ Nut, Hex − W/ET (#8−32)17 323−1667 A/R *#^ Socket, Terminal18 323−1666 A/R *#^ Connector, Socket19 321−0371 1 *#^ Holder, Fuse20 321−0340 1 *#^ Fuse − 15 Amp21 338−3794−01 1 * Module, Timer (12V)22 323−1637 1 * Connector, Socket23 323−1576 2 * Seal, Cable
* − Parts Included in 338−4231 Wiring Harness# − Parts Included in 338−4227 Wiring Harness^ − Parts Included in 338−4506 Wiring Harness
66
AC Wiring Harness
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Harness, Wiring − AC (IncludesPlug)
338−4180 1 PMG338−4185 1 Shunt
2 323−1523 1 Plug, Connector (24 Place)
67
Alarm Module
14
3
2
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 300−3998−02 1 Module, Alarm (12V)2 800−0006 2 Screw, Cap − Hex Head
(1/4−20 x 7/8)
3 850−0040 2 Washer, Lock (1/4)4 862−0001 2 Nut, Hex (1/4−20)5 323−2003−01 1 Strain Relief
68
Battery Tray
12
3 45
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 403−4522−02 1 Tray, Battery2 821−6007−02 3 Screw, Hex Head (M8 x 20)3 416−1033 1 Hold Down, Battery
4 416−0993−02 2 Rod, Hold Down − Battery5 865−0030 2 Nut, Wing (M6)
69
Operator Switch
12
3
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 308−1045 1 Switch, Key Operator2 308−1046 2 Key − Spare
3 308−1085 1 Switch, Selector
70
Miscellaneous Labels
211
1
2
345
56
7
8
9
1011 12
13
14
15
1617
18
19
20
20
22
2324
25
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−4730 2 Label, Warning (Not usedW/Remote Radiator)
2 098−4732 2 Label, Warning3 098−5842 1 Label, Caution4 098−4798 1 Label, Warning5 098−5347 3 Label, Danger6 098−7047 1 Tag, Water Fill (Not used
W/Remote Radiator)7 098−6074−02 1 Label, Warning8 098−4500 1 Label, Prototype9 098−6030 1 Tag, Caution
10 098−7450 1 Label, Coolant11 098−7048 1 Tag, Oil Fill12 098−2124 1 Tag, Caution
13 098−6460 1 Tag, Battery14 098−5759 1 Tag, Battery15 098−5822 1 Label, Warning16 501−0480−02 1 Line, Flexible Fuel17 098−3171 1 Tag, Fuel Line18 098−3172 1 Tag, Fuel Line19 503−0685 1 Clamp, Hose20 098−7902−03 3 Label, Logo21 098−2304 1 Label, Warning (Used W/Circuit
Breaker Only)22 501−0627−03 1 Line, Flexible Fuel23 098−7877 1 Label, Battery Warning24 098−8445 1 Label, Information25 098−8205 1 Label, Information − DGFC
71
Current Transformer
1
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current302−2057−14 A/R Ratio 518/1 or 1036/1302−2058−27 A/R Ratio 362/1302−2058−28 A/R Ratio 422/1302−2057−47 A/R Ratio 604/1 or 1208/1302−2057−48 A/R Ratio 694/1 or 1388/1302−2057−24 A/R Ratio 946/1 or 1892/1
72
Circuit Breaker Box10 − 630 Amp
3
412
11 13
142
1
16
15
14
176 9
87
5
10
14
18
73
Circuit Breaker Box10 − 630 Amp
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−3072 2 Panel, End − CB Box2 319−2978 2 Panel, Side − CB Box3 Bracket, Mounting − CB
319−5390−02 1 600 Volt Breaker319−3243 1 240 Volt Breaker
4 098−2304 1 Label, Warning5 508−0239 − Edging − Bulk (Order By The
Foot − 2 Feet Required)6 332−2744−07 1 *Standoff, Insulator7 800−0048 2 *Screw, Cap − Hex Head
(3/8−16 x .75)8 850−0050 2 *Washer, Lock (3/8)9 526−0029 1 *Washer, Flat (3/8)
10 098−5854−04 1 *Label, Bus − Warning11 332−1473 1 Lug, Solderless12 856−0008 1 Washer, Lock − EIT (5/16)13 821−6003−02 1 Screw, SEMS − Hex Head
(M8 x 1.25 x 20)14 821−6002−03 24 Screw, SEMS − Hex Head
(M6 x 1 x 16)15 319−3151 1 Cover, CB Box
16 Cutout, CB BoxUL
319−3150 1 600 Volt, 300−630 Amp, 3 Pole
319−3240 1 240 Volt, 300−400 Amp, 2/3 Pole
319−3241 1 600 Volt, 10−100 Amp, 3 Pole319−3242 1 240 Volt, 100−250 Amp,
2/3 Pole319−3304 1 600 Volt, 125−600 Amp,
3 PoleIEC
319−3150 1 750 Volt, 300−630 Amp, 3/4 Pole
319−3241 1 660 Volt, 10−100 Amp, 3 Pole319−3242 1 750 Volt, 70−250 Amp,
3/4 Pole319−3304 1 660 Volt, 125−600 Amp,
3 Pole17 818−0231−02 4 Rivet, Pop18 319−2996 1 Cover, Housing − Control
* = UL Rated Breakers only.
74
Circuit Breaker Box700 − 1000 Amp
26
7
222125
15 14
17 16
2 18
1419
27
12
6
5
4
1
3
1113
16
2023
8
9
10
24
75
Circuit Breaker Box700 − 1000 Amp
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−3136 1 Box, Circuit Breaker2 319−3135 1 Bracket, Mounting − CB3 319−3072 1 Panel, End − CB Box4 319−3236 1 Box, Output5 319−3237 1 End, Box − Output (Units with
Single Breaker Only)6 319−3238 1 Cover, Box − Output7 319−3137 1 Cover, Box − CB8 319−3134 1 Cutout, Box − CB9 818−0231−02 4 Rivet, Pop
10 821−6002−03 46 Screw, SEMS − Hex Head (M6 x 1 x 16)
11 856−0008 1 Washer, Lock − EIT (5/16)12 332−2001 1 Lug, Solderless13 821−6003−02 1 Screw, SEMS − Hex Head
(M8 x 1.25 x 20)14 850−0114−06 4 *Washer, Lock − Split (5/16)15 800−0025 2 *Screw, Cap − Hex Head
(5/16−18 x 5/8)
16 332−2305 2 *Standoff, Insulator17 337−2974 1 *Bar, Neutral18 526−0399−16 2 *Washer, Flat (5/16)19 800−0029 2 *Screw, Cap − Hex Head
(5/16−18 x 1−1/8)20 332−2660 2 *Lug, Solderless21 850−0040 4 *Washer, Lock (1/4)22 822−0085 2 *Screw, Pan Head (1/4−20 x 5/8)23 822−0091 2 *Screw, Pan Head
(1/4−20 x 1−1/2)24 098−2304 1 *Label, Warning25 098−5854−04 1 *Label, Bus − Warning26 098−6537 1 Label, Ground27 508−0305−02 − Edging − Bulk (Order By The
Foot − 4 Feet Required)
* = Used with 3 pole breaker only.
76
Circuit Breaker
1
345
6
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Breaker, Circuit3 Pole (UL & IEC)
320−2346−10 1 70 Amp (H-Frame)320−2346−09 1 80 Amp (H-Frame)320−2346−08 1 90 Amp (H-Frame)320−2346−07 1 100 Amp (H-Frame)320−2346−06 1 125 Amp (H-Frame)320−2346−05 1 150 Amp (H-Frame)320−2347−04 1 175 Amp (J-Frame)320−2347−03 1 200 Amp (J-Frame)320−2347−02 1 225 Amp (J-Frame)320−2347−01 1 250 Amp (J-Frame)320−1960−06 1 * 300 Amp320−1960−05 1 * 350 Amp320−1960−04 1 * 400 Amp320−1960−03 1 * 450 Amp320−1960−02 1 * 500 Amp320−1960−01 1 * 600 Amp320−2261−02 1 * 800 Amp320−2262−02 1 * 1200 Amp
4 Pole (IEC)320−1960−10 1 * 320 Amp320−1960−09 1 * 400 Amp320−1960−08 1 * 500 Amp320−1960−07 1 * 630 Amp
* − Includes Mounting Hardware
Continued...
77
Circuit Breaker
1
345
6
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
Continued...
2 Package, Hardware − CircuitBreaker Mounting (IncludesScrews, Nuts and LockWashers)
320−1986−07 1 Used With 320−1960−XX Circuit Breakers
(Screws Only)320−1986−01 1 Used With 320−1964−XX
Circuit BreakersAccessories, Circuit Breaker:
The following are used on320−1960−XX CircuitBreakers
3 320−1981−02 1 Trip, Shunt (12V)4 320−1981−01 2 Switches − Used as an
Auxiliary Contact or Trip Alarm
Accessories, Circuit Breaker:The following are used on R& P Circuit Breakers
5 320−2196−03 1 Trip, Shunt (12V)
6 Lead (Quantity Used AsRequired)
226−0893 1 3/8” Ring Terminal End to 1” Stripped End − No Markings (33”) (#1/0 Wire)
226−3505−01 1 3/8” Ring Terminal End to 1” Stripped End − No Markings (30”) (#4 Wire)
226−3505−03 1 3/8” Ring Terminal End to 3/8” Ring Terminal End − Marked “LO” (30”) (#4 Wire)
226−3505−04 1 3/8” Ring Terminal End to 3/8” Ring Terminal End − Marked “LO” (30”) (#1/0 Wire
* − Includes Mounting Hardware
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
78
098−2124, 70
098−2304, 70, 73, 75
098−3171, 70
098−3172, 70
098−4500, 35, 37, 39, 41, 70
098−4730, 35, 37, 39, 41, 70
098−4732, 35, 37, 70
098−4798, 70
098−5347, 70
098−5347−01, 50
098−5387, 11
098−5429, 35, 37, 39, 41
098−5759, 70
098−5822, 70
098−5842, 70
098−5854−04, 73, 75
098−6030, 70
098−6074−02, 70
098−6195, 60
098−6460, 70
098−6537, 49, 75
098−6927, 60
098−6928, 60
098−6984, 63
098−7047, 70
098−7048, 70
098−7281, 51
098−7450, 70
098−7451, 39, 41
098−7451−01, 29, 37
098−7868, 35, 37, 39, 41
098−7877, 70
098−7902−03, 35, 37, 70
098−7904, 63
098−7913, 39, 41
098−7918, 63
098−7961−01, 63
098−7989, 63
098−8057, 63
098−8205, 70
098−8445, 70
102−1237, 8
102−1356, 7
128−0154−01, 35, 37
128−0154−02, 35, 37
128−0154−06, 29
130−3208, 25
130−3216−01, 25, 27, 29
130−3582, 30
130−3721−01, 25, 27
130−3929, 31
130−3984, 25, 27
130−4622, 22
130−4691−01, 25
130−4691−02, 25, 27
130−4692, 27
130−4693, 25, 27
130−4694, 25, 27
130−4695, 25, 27, 29
130−4697, 25, 27, 29
130−4698, 25
130−4698−01, 25
130−4699, 27
130−4700, 25, 27
130−4707, 30
130−4708, 30
130−4709, 30
130−4710, 30
130−4711, 30
130−4712, 30
130−4716, 25, 27, 29
130−4719, 20
130−4720, 20
130−4733, 25, 27, 29
130−4734, 22
130−4735, 25, 27
130−4750, 25, 27
130−5996−01, 29
130−6126−02, 29
130−6205−02, 29
130−6206−02, 29
130−6207−02, 29
130−6208−02, 29
130−6211−02, 29
130−6212−02, 29
130−6219−02, 29
130−6220−02, 23
130−6221−02, 23
130−6236, 29
130−6319, 31
140−1548, 9
140−1973, 9
140−2239−03, 9
140−3112, 9
140−3117, 9
140−3143, 17
140−3148−01, 17
149−2441, 10
149−2508, 7
150−2120, 47, 48
150−2201, 7
150−2679, 47
150−2681, 47
150−2682, 47, 48
150−2761−04, 48
150−2763−04, 48
150−2794−02, 48
151−0708−01, 47, 48
154−3021, 27
154−3178, 29
155−2062−05, 17
155−2062−13, 17, 18
155−2175, 17
155−2305, 17, 18
155−2570, 15, 16, 17, 18
155−3150−04, 18
155−3163, 15
155−3164−01, 18
155−3164−05, 18
155−3172, 16
155−3175, 16
155−3180−01, 17, 18
155−3182, 17
155−3219, 18
155−3238, 35, 37, 39, 41
155−3253, 17
155−3258−01, 17
155−3271, 17
155−3292, 17
159−1371−05, 10
159−1371−06, 10
159−1378, 10
159−1468, 11
159−1473, 10
159−1474, 10
159−1475−01, 10
159−1482, 43
191−2326−01, 46
191−2330, 46
191−2347, 45
193−0444, 7
193−0468, 19
193−0529−01, 7
193−0558, 19, 31
200−3140−01, 57
201−3434−02, 57
201−3434−03, 57
201−3446, 52
201−3474−05, 57
201−3497−01, 57
201−3497−02, 57
201−3497−03, 57
201−3497−04, 57
201−3497−05, 57
201−3497−06, 57
201−3561−07, 57
211−0423, 57
220−4233, 52
220−4293−05, 57
220−4293−06, 57
220−4448−11, 55
220−4448−16, 55
220−4448−17, 55
220−4448−18, 55
220−4448−23, 55
220−4448−24, 55
220−4448−33, 55
220−4448−34, 55
220−4448−35, 55
220−4448−36, 55
220−4448−38, 55
220−4448−39, 55
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
79
220−4448−40, 55
220−4448−42, 55
226−0893, 77
226−3505−01, 77
226−3505−03, 77
226−3505−04, 77
231−0317, 57
231−0319, 57
231−0325, 57
231−0370, 57
231−0373, 57
231−0374, 57
232−3421, 57
232−3462−01, 58
232−3462−02, 52
232−3695, 57
232−3699, 57
232−3730−04, 57
232−3819−03, 57
232−3820−01, 57
232−3820−02, 57
232−3820−03, 57
232−3820−04, 57
232−3820−05, 57
232−3925, 57
232−3940, 57
232−3972, 52
234−0867, 57
234−0875−01, 58
234−0875−02, 52
234−0879, 57
234−0936−03, 57
234−0937−01, 57
234−0937−02, 57
234−0937−03, 57
234−0937−04, 57
234−0937−05, 57
234−0980, 57
234−0981, 57
234−0983, 57
234−0984, 57
300−3464, 12
300−3998−02, 67
300−5180, 63
300−5383, 63
300−5446, 63
300−5447, 63
300−5467, 63
302−2057−14, 71
302−2057−24, 71
302−2057−47, 71
302−2057−48, 71
302−2058−27, 71
302−2058−28, 71
304−0807, 57
305−1009, 59
307−2677−02, 12
307−2873, 59
307−2968−03, 65
307−2982−02, 65
308−0852, 12
308−0912, 12
308−0913−10, 11
308−0913−11, 11
308−0916−01, 14
308−0963−01, 13
308−0999, 63
308−1045, 69
308−1046, 69
308−1085, 63, 69
315−0687, 12
319−0485, 12
319−0486, 12
319−2006−05, 65
319−2653, 35, 37, 39, 41
319−2967, 50
319−2978, 49, 73
319−2979−02, 49
319−2996, 49, 50, 73
319−3072, 49, 73, 75
319−3134, 75
319−3135, 75
319−3136, 75
319−3137, 75
319−3150, 73
319−3151, 73
319−3207, 50
319−3208, 50
319−3236, 75
319−3237, 75
319−3238, 75
319−3240, 73
319−3241, 73
319−3242, 73
319−3243, 73
319−3304, 73
319−4456−02, 50
319−4457, 50
319−4487, 63
319−4488, 63
319−4497, 63
319−5390−02, 73
320−1653, 12
320−1654, 12
320−1960−01, 76
320−1960−02, 76
320−1960−03, 76
320−1960−04, 76
320−1960−05, 76
320−1960−06, 76
320−1960−07, 76
320−1960−08, 76
320−1960−09, 76
320−1960−10, 76
320−1981−01, 77
320−1981−02, 77
320−1986−01, 77
320−1986−07, 77
320−2196−03, 77
320−2261−02, 76
320−2262−02, 76
320−2346−05, 76
320−2346−06, 76
320−2346−07, 76
320−2346−08, 76
320−2346−09, 76
320−2346−10, 76
320−2347−01, 76
320−2347−02, 76
320−2347−03, 76
320−2347−04, 76
321−0321−01, 63
321−0321−04, 63
321−0321−06, 63
321−0340, 65
321−0371, 65
322−0369−02, 12
322−0403−02, 12
322−0488, 63
322−0491, 63
323−1491, 19
323−1492, 65
323−1493, 65
323−1494, 19
323−1502, 19
323−1503, 65
323−1523, 66
323−1525, 65
323−1576, 65
323−1637, 65
323−1666, 65
323−1667, 65
323−1708, 19
323−1709, 19
323−1755, 65
323−1765, 19
323−2003−01, 67
323−2003−02, 60
327−1275, 63
327−1379−01, 63
330−0142, 51
331−0027, 12
331−0042, 12
332−0604, 65
332−0941, 10
332−1043, 65
332−1389, 19, 25, 27, 51
332−1445, 60, 63
332−1473, 49, 73
332−1992, 14
332−2001, 75
332−2305, 75
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
80
332−2420, 60, 63
332−2430, 14
332−2605, 12
332−2634, 7
332−2660, 75
332−2744−07, 73
332−2878, 59
332−2921, 7
332−2987, 50
332−3023, 51
332−3024−11, 51
332−3196, 7
332−3228, 51
332−3388, 19
332−3740, 50
332−3792−01, 65
332−3842−01, 59
332−3896, 63
333−0429−01, 21
333−0429−02, 21
333−0438−07, 51
333−0438−08, 51
333−0588−03, 20
333−0588−04, 20
333−0615, 20
333−0661−01, 60
333−0661−02, 60
333−0708, 7
333−0709−02, 7
335−0168−01, 21
335−0168−02, 21
335−0173, 60
335−0173−01, 60
335−0189, 63
337−0049, 50, 63
337−0090, 44
337−2974, 75
338−2382, 12
338−2397, 11
338−3011, 52
338−3794−01, 65
338−3991, 63
338−3994, 63
338−4178−01, 19
338−4180, 66
338−4185, 66
338−4227, 65
338−4231, 65
338−4238−02, 7
338−4438, 59
338−4506, 65
357−0091, 57
357−0092, 57
399−0117−01, 11
402−0764−01, 63
402−0779−05, 44
402−0779−06, 44
402−0779−07, 44
403−4110, 42
403−4116, 42
403−4154−04, 44
403−4183, 42
403−4188−03, 44
403−4215, 42
403−4218, 44
403−4522−02, 68
405−5734, 39, 41
405−5744, 35, 37, 39, 41
405−5832, 35, 37
405−5841, 39, 41
405−5902, 35, 37, 39, 41
405−5903, 35, 37, 39, 41
405−5908, 35, 39, 41
405−5909, 35, 39, 41
405−5915, 35, 37
405−5916, 35, 37, 39, 41
405−5917, 35, 37, 39, 41
405−5926, 35, 37, 39, 41
405−5950, 39, 41
405−5951, 39, 41
405−5952, 39, 41
405−5953, 39, 41
405−5954, 39, 41
405−5956, 39, 41
405−5957, 39, 41
405−5959, 39, 41
405−5962, 39, 41
405−5963, 39, 41
405−5966, 39, 41
405−5986, 39, 41
405−5989, 41
405−5990, 41
405−5991−01, 41
405−5991−02, 41
405−5992, 41
405−5993, 41
405−5994, 41
405−5997, 39, 41
405−5998, 39, 41
405−6000−01, 41
405−6000−02, 39, 41
405−6000−03, 39, 41
405−6000−04, 41
405−6000−07, 41
405−6001−01, 39, 41
405−6001−02, 39, 41
405−6002, 39, 41
405−6003, 39, 41
405−6005, 39, 41
405−6008, 41
405−6010, 41
405−6013, 41
405−6109, 39, 41
405−6923−03, 41
405−6923−04, 41
405−6924, 41
405−6925, 41
405−8291−02, 23, 37, 39, 41
405−8304, 39, 41
405−8305, 39
405−8306, 39, 41
405−8307, 39, 41
405−8310, 41
405−8311, 39, 41
405−8312, 39, 41
405−8313, 41
405−8314, 41
405−9022−02, 41
405−9023−02, 41
406−0831, 35, 37, 39, 41
406−0845, 63
406−0972−01, 35, 37, 39, 41
415−0043, 10
415−0565−09, 10
415−0565−18, 10
415−0565−19, 10
416−0993−02, 68
416−1019, 7
416−1021−02, 65
416−1033, 68
416−1084, 7
416−1092, 7
416−1093, 7
501−0480−02, 10, 70
501−0627−03, 10, 70
502−0047, 32
502−0175, 9
502−0199, 7
502−0802, 7, 32
502−0827, 32
502−0942, 11
502−0943, 11, 20
502−1162, 25, 27
502−1290, 27
502−1291, 27
502−1292, 27
502−1293, 27, 29
502−1294, 27, 29
502−1520, 29
503−0098, 32
503−0183, 11
503−0197, 8, 32
503−0276, 31
503−0304, 31
503−0365, 25, 27, 29
503−0446, 25, 27
503−0465, 25, 27, 29
503−0685, 10, 25, 27, 70
503−1134, 31, 33
503−1137, 31
503−1141, 29
503−1408−01, 25, 27, 33
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
81
503−1554, 25, 27
503−1634−02, 20
503−1660−04, 11
503−1870−05, 17
503−1870−08, 9
503−1872−05, 27, 29
503−1872−06, 27, 29
503−1872−07, 27
503−2044, 25, 27
503−2045, 25, 27
503−2067, 9
503−2079, 31
503−2157−01, 20
503−2433−06, 8
503−2515, 29
503−2517, 29
503−2538, 29
504−0003, 25, 27
504−0011, 8, 32
505−0007, 10
505−0019, 7, 20
505−0026, 13, 14
505−0027, 10
505−0050, 8
505−0055, 31
505−0110, 10
505−0180, 16
505−0203, 10
505−0327, 10
505−0359, 10
505−0401, 10
505−0411, 10
505−0679, 10
505−0732, 10
505−0753, 13
505−0827, 8
505−1050, 14
505−1050−01, 13
505−1458−05, 13, 14
505−1458−14, 14
508−0139, 57
508−0228, 51
508−0239, 49, 73
508−0305−02, 50, 75
508−1057, 57
508−1196, 29
508−1197, 29
509−0266−02, 57
510−0164, 57
511−0161−16, 25
512−0191, 25
515−0298−03, 57
517−0021, 51
517−0094, 44
517−0131, 39, 41
517−0135, 50, 57
517−0138−07, 39, 41
517−0322, 39, 41
517−0355, 63
517−0356, 63
517−0357, 63
518−0083, 57
518−0548−02, 8
518−0601, 5
520−0939, 47
525−0304, 5
525−0305, 5
525−0306, 5
526−0011, 39, 41
526−0018, 47, 48
526−0029, 73
526−0113, 27
526−0174, 57
526−0238−01, 44
526−0259, 57
526−0333, 31
526−0399−13, 25
526−0399−16, 75
526−0399−42, 17
526−0399−64, 57
526−0399−66, 10
526−0423, 57
526−0433, 44
526−0443, 44
526−0451, 23, 35, 37, 39, 41
526−2050, 51
526−2060, 57
526−2080, 58
526−2100, 50, 57
526−2106, 17
526−2120, 25, 27, 29, 50
526−2140, 7, 9
625−2141−02, 11, 12
720−1123, 57
775−0049, 52
800−0006, 67
800−0007, 47, 48
800−0025, 75
800−0029, 75
800−0048, 73
800−0607, 44
800−2046, 57
800−2052, 50
800−2059, 27
800−2060, 57
800−2072, 31
800−2088, 57
800−2090, 57
800−2099, 25, 27, 29
800−2110, 9, 30
800−2111, 7
800−2124, 44
800−2543−02, 44
800−2543−03, 44
800−3017−02, 48
800−3017−38, 17, 57
800−3017−54, 57
800−3017−56, 57
800−3017−73, 10
800−3034, 51
802−2507, 47, 48
805−0015, 57
812−0075, 12
812−0079, 65
814−2150, 50
815−0350, 12
815−0385, 12
815−0538, 65
815−0761−01, 52
815−0792−02, 63
815−0792−04, 51
815−0829−04, 17
815−0943−02, 50
818−0231−02, 22, 23, 25,27, 29, 35, 37, 39, 41, 73,75
818−0237−01, 35, 37, 39, 41
819−1137−01, 63
819−1137−02, 63
819−1144, 50, 63
819−1154, 59
821−2033, 7, 11
821−2045, 7
821−2048, 7
821−2060, 9
821−2061, 16, 30
821−6001−01, 52, 58
821−6001−02, 50, 57
821−6002−03, 7, 25, 27, 42,49, 50, 73, 75
821−6003−01, 29, 50
821−6003−02, 17, 18, 25,27, 30, 43, 49, 73, 75
821−6004−01, 7
821−6006−01, 20, 35, 37,39, 41
821−6007−02, 23, 25, 27,29, 35, 37, 39, 41, 68
822−0085, 75
822−0091, 75
822−3047, 51
822−3075, 51
850−0040, 47, 48, 67, 75
850−0050, 73
850−0114−06, 75
850−0114−55, 17, 57
850−0114−56, 57
850−0114−57, 10
850−0117, 44
850−2003, 51
850−2004, 51
850−2005, 57
850−2006, 52, 57
850−2008, 57
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
82
850−2010, 47, 48, 50, 52, 57
850−2012, 9
856−0002, 12
856−0008, 49, 73, 75
856−0010, 50
856−0012, 50
856−0013, 7, 44, 50
860−0008, 12
860−2005, 51
860−2006, 57
860−2009, 50
860−2031, 46
862−0001, 47, 48, 67
862−0026−55, 17
862−0026−58, 10
862−0044, 44
865−0030, 68
868−0001, 47, 48
870−0221, 65
870−0458, 12
870−0504, 35, 37, 39, 41
870−2054, 7, 11
870−2056, 9
870−2064−01, 51
870−2065−02, 7
870−2213−02, 63
895−0363, 35, 37, 39, 41
895−0381, 29
895−0382, 35, 37
895−0384, 39, 41
895−0385, 39, 41
895−0386, 39, 41
898−1195−02, 25, 27
Cummins Power Generation1400 73rd Avenue N.E.Minneapolis, MN 554321-800-888-6626763-574-5000 International UseFax: 763-528-7229
Cummins is a registered trademark of Cummins Inc.