kompresorji ida.pdf · referenzanlagen reference units comp trade austria feuerwehr- und...
TRANSCRIPT
Translation – letter from Dräger Austria on 18th of February 2002 COMP TRADE Breathing air compressors Dear Mr. Ing. Bös, herewith we confirm, that together with our daughter companies east Europe we already bought several Comp Trade breathing air compressors since we started our co-operation. These units are mainly used in fire fighting stations and are working perfectly and without any problems according our knowledge. In this connections we want to show up, the units delivered from Comp Trade are tailor made for the individual specifications and therefore made perfectly the individual needs of the particular fire stations. We hope to served you and remain with best regards Dräger Austria Ges.m.b.H. Sparte Sicherheitstechnik
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-04 CTP-F 250 Honda Model ERA
185 units of mobile high pressure breathing air compressors CTP-F 250 Petrol for Malaysian fire stations
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-04 CTP-F 250 Honda Model ERA
CTP - F 250 P This series for 185 units were designed to meet the special requirements of Malaysian fire fighting’s. It is compact in design, incorporates a filling ramp for 4 connections, filling pressure gauges and advanced filter-systems for int. breathing air standards as f.i. DIN 3188 / EN 12021 TECHNICAL DATA Reference unit CTP – F 250 P Model 250 Output lit/min 260 Speed rpm 1640 Max. pressure bar 350 Operating pressure bar 330 No. of stages / cylinders 3 / 3 Cooling by air No. of filling connections 4 x 300 bar Prime mover Petrol 4 Stroke Honda with electric start Power kW / HP 6,7 / 9 Dimensions LXWXH petrol cm 120 x 65 x 85 Weight kg 150 Optional equipment: oil level control with auto shut off temperature control with auto shut off auto stop at 300 bar with adjustable shut off pressure auto drain system spider for 5 additional cylinders on one outlet Presec Filter system with permanent control of cartridge penetration
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2
Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] Stand: 01-2007 008-05 CTP-F 250 E Mobil Fire Max
MOBIL HIGH PRESSUERE BREATHING AIR COMPRESSOR CTP - F 250
with filling ramp 2 X 200 bar + 2 x 300 bar and PRESEC filtercontrol
Reference : FIRE STATIONS AND NAVY - POLAND ( 48 units )
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
008-06 CTP-F450 Tallin Estland
REFERENZANLAGEN REFERENCE UNITS
BREATHING AIR COMPRESSOR CTP-F 450 With retractable filling panel 4 x 300 bar Reference : 5 Units Fire Stations Estland
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs
GesmbH A – 3052 Innerfurth 2
Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand. 01-2007 008-07 CTP-F 450 Truck mounted
BREATHING AIR COMPRESSOR CTP-F 450 With retractable filling panel
Reference Fire Station Taipei Compressor CTP-F 450 E truck-mounted with storage cylinders, external filling panel 2x200 bar + 2 x 300 bar, CO - Monitor
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs
GesmbH A – 3052 Innerfurth 2
Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand. 01-2007 008-07 CTP-F 450 Truck mounted
REFERENZANLAGEN REFERENCE UNITS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-08 CTP-F 450 Diesel TrailerCD-S.Pore A3
BREATHING AIR COMPRESSOR CTP-F 450 Diesel driven, Trailer-mounted
Reference Civil Defence Singapore
REFERENZANLAGEN REFERENCE UNITS
Stand: 01-2007 008-09 FW Atemluft-Trailer
FAHRBARE ATEMLUFT-FÜLLSTATION MIT KOMPRESSOR, SPEICHER UND FÜLLRAMPE MOBIL BREATHINGAIR FILLING STATION WITH COMPRESSOR, STORAGE AND FILLINGPANEL MOBILER BOOSTERKOMPRESSOR CTP – B 250 , SPEICHER 4 X 50 LIT / 300 BAR, FÜLLRAMPE 3 X 300 + 2 X 200 BAR MOBILE BOOSTERCOMPRESSOR CTP – B 250, STORAGE 4 X 50 LIT / 300 BAR, FILLING PANEL 3 X 300 + 2 X 200 BAR WERKSFOTO / PRODUCTION FOTO
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-10 CTP-Booster 250 BM Altr. Trailer f+b, e
REFERENZANLAGEN REFERENCE UNITS
Mobile Atemluft-Füllstation mit integrierter Boosterfunktion und Doppelantrieb E- Motor und Benzinmotor
Mobile Breathing air station with integrated booster function double powered by
electric and petrol engine
REFERENZ FÜLLSTATION ALTRICHTER / AUSTRIA
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-10 CTP-Booster 250 BM Altr. Trailer f+b, e
REFERENZANLAGEN REFERENCE UNITS
FUNCTION AND WORKING METHOD OF A FAST FILLING STATION WITH INTEGRATED BOOSTER
In automated compressor operation during idle periods, i.e. during the night, the storage systems are filled. During day time, when a large number of small tanks have to be filling within a short time, compressors are switched over to booster operation. This is effected by simply operating a high pressure valve. The high pressure stage of the multistage high pressure compressor is now directly connected to the storage system and the pre-compressed air from the storage system flows into the small tanks. As soon as there is a pressure balance in the system, the high pressure valve switches over to booster operation and the last compressor stage compresses up to requested final pressure. Operation of the switch-over valve will be carried out by electro-pneumatic remote control.
Outputs of CTP-B Units in l/min: Storage pressure / CTP-B 150 200 250 200 - 330 bar 1200 1200 1200 150 bar 950 1000 1100 100 bar 630 750 850 50 bar 400 500 600
BA - Bottle filling with high delivery rates independent from ambient air quality With 120.000 lit breathing air in the storage each filling application can be done in a very short
time.
Filling can be done by overflow first from storage system to air cylinder
Compressor in booster operation works in low load, because pressure ratio in the 3rd stage is
always smaller then in compressor-operation.
only ONE unit with ONE prime mover and ONE standard filter system
ONE filling ramp only where the small tanks can either be filled from the compressor directly or
from the storage and booster-system
Switching over from compressor to booster operation within seconds.
LOW PRICES ! The price of a CTP-B-unit is considerably lower than that of a breathing air
compressor with storage system plus a booster or a standard breathing air compressor with the
same filling time capacity.
An additional low pressure filling connection can be mounted to the filling ramp to supply low
pressure airline systems + venting/cooling the protection suits, to supply air for pneumatic rescue
tools, emergency pillows etc
Referenz - Anlagen / Reference Units
Professional Diving Training School - Vienna / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-11 CTP-B 250-2 auf Doppelachs Trailer
Mobile high pressure breathing air compressor with integrated booster function
Model CTP-F 250/2
Delivery in Compressor operation 500 lit/min Delivery in Booster – operation up to 1000 lit/min
independent from ambient air quality
2 Compressor blocks , each 250 lit/min, max pressure 350 bar
prime mover: 2 x 5,5 KW, 400V, 50/60 Hz
Cascade system : 6 x 50lit/300 bar storage cylinders ( 90.000 lit breathing air )
Filter system for Breathing air acc. DIN 1388 / EN 12021, reg. air vol. 1200 cbm with automatic filter control system
Referenz - Anlagen / Reference Units
Professional Diving Training School - Vienna / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-11 CTP-B 250-2 auf Doppelachs Trailer
2 compressor blocks CTP 250 mounted next to each other with auto drain system and auto stop at final filling / storage pressure.
Remote controlled electro-pneumatic
switch over device for compressor – booster mode.
Filling ramp wit 4 hose connections
each with self venting lever filling valve
High pressure ball valve for storage decanting
Pressure gauges for storage
pressure, filling pressure , interstage pressure.
Referenz - Anlagen / Reference Units Fire Station St. Andrä / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
008-12 CTP-B 250 St.Andrä
Mobil Booster Compressor CTP-B 250 trailer mounted
Delivery in Compressor operation 250 lit/min Delivery in Booster – operation up to 1000 lit/min
independent from ambient air quality
Referenz - Anlagen / Reference Units Fire Station St. Andrä / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
008-12 CTP-B 250 St.Andrä
Compressorblock with integrated Booster Function mounted on Storage Cylinders, which are in horizontal position under the Compressor Compressor front with cooling, filter and removable
filling ramp
Filling Ramp with 3x300 bar and 3x200 bar self vented independent lever filling valves for simultaneously filling of 6 cylinders in both pressure ranges .
Pressure gauges for filling pressure 200bar and
300bar, Storage pressure and low pressure for air line system
• Indication lights for filter control
Referenz - Anlagen / Reference Units
Fire Training School Klagenfurt / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 6374 / E-Mail: [email protected] / www.comptrade.at
008-13 CTP-B 200 E Silent Truck munted
Mobile high pressure breathing air compressor with integrated booster function
Model CTP-B 250 E SILENT –TRUCK MOUNTED
Delivery in Compressor operation 250 lit/min Delivery in Booster – operation up to 1000 lit/min
independent from ambient air quality Filling Ramp
Complete Filling Station on slides with retractable filling ramp
Compressor blocks , 250 lit/min, max pressure 350 bar
Prime mover 5,5 KW, 400V, 50/60 Hz
Cascade system : 6 x 50lit/300 bar storage cylinders ( 90.000 lit breathing air )
Filter system for Breathing air acc. DIN 1388 / EN 12021, reg. air vol. 1200 cbm with automatic filter control PRESEC PS 41
Referenz - Anlagen / Reference Units
Fire Training School Klagenfurt / Austria
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 6374 / E-Mail: [email protected] / www.comptrade.at
008-13 CTP-B 200 E Silent Truck munted
Silent housing with noise level below 73 dB(A)
Mobile high pressure breathing air compressor with integrated booster function Model CTP-B 250 E SILENT –TRUCK MOUNTED
Filling Ramp with 3 x 300 bar and 3 x 200 bar self vented independent lever filling valves for simultaneously filling of 6 cylinders in both pressure ranges .
Pressure gauges for filling pressure 200bar, 300bar,
Storage pressure and low pressure for air line system
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-14 CTP-Booster 250 BM TOP
REFERENZANLAGEN REFERENCE UNITS
Mobile Atemluft-Füllstation mit integrierter Boosterfunktion und Doppelantrieb E- Motor und Benzinmotor
Mobile Breathing air station with integrated booster function double powered by electric
and petrol engine WERKSFOTO / FACTORY PICTURE
1 2 3 4 5 1 STARTBATTERIE STARTING BATTERIE 2 BENZINMOTOR PETROL ENGINE 3 SPEICHERFLASCHEN 50 LIT/300 BAR STORAGE CYLINDER 50 LIT/300 BAR 4 ELEKTROMOTOR ELECTRIC ENGINE 5 FÜLLRAMPE FILLING RAMP
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-14 CTP-Booster 250 BM TOP
REFERENZANLAGEN REFERENCE UNITS
Mobile Atemluft-Füllstation mit integrierter Boosterfunktion und Doppelantrieb E- Motor und Benzinmotor
Mobile Breathing air station with integrated booster function double powered by electric
and petrol engine
FÜLLRAMPE / FILLING RAMP 2 x 200 bar + 2 x 300 bar
1 2 3 4 5 6 1 FÜLLDRUCK 200 BAR FILLING PRESSURE 200 BAR 2 KIPPHEBEL FÜLLVENTIL 200 BAR LEVER FILLING VALVE 200 BAR 3 SCHUTZKAPPENHALTER HOLDER FOR PROTECTION CAP 4 FÜLLDRUCK 300 BAR FILLING PRESSURE 300 BAR 5 KIPPHEBEL FÜLLVENTIL 300 BAR LEVER FILLING VALVE 300 BAR 6 SPEICHERDRUCK STORAGE PRESSURE
REFERENZANLAGEN REFERENCE UNITS
Stand: 01-2007 008-15 CTP-B 250 Taiwan
MOBIL HIGH PRESSURE BREATHING AIR FAST FILLING STATION
WITH INTEGRATED BOOSTER FUNCTION
13 UNITS TO MINISTRY OF DEFENCE; HAZMAT OF CHEMICALS TAIPEI / TAIWAN
BOOSTER COMPRESSOR CTP – B 250 PETROL DRIVEN STORAGE CYLINDERS FOR 30.000 LIT BREATHING AIR REMOVABLE SAFETY FILLING ENCLOSURE WITH LIFTING DEVICE BREATHING AIR DELIVERY UP TO 1.000 LIT/MIN INDIPENDENT FROM
AMBIENT AIR QUALITY
REFERENZANLAGEN REFERENCE UNITS
Stand: 01-2007 008-15 CTP-B 250 Taiwan
SIDE VIEW WITH EXTRACTED SAFETY FILLING ENCLOSURE
SIDE VIEW WITH EXTRACTED SAFETY FILLING ENCLOSURE IN DOWN ( WORKING ) POSITION
SIDE VIEWFRONT VIEW
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-16 FW Mistel Fahrz. innen Gesamt
REFERENZANLAGEN REFERENCE UNITS
FAHRBARE ATEMLUFT-FÜLLSTATION MIT KOMPRESSOR, SPEICHER UND FÜLLRAMPE MOBIL BREATHING AIR FILLING STATION WITH COMPRESSOR, STORAGE AND FILLING PANEL INNENANSICHT WERKSFOTO / PRODUCTION FOTO
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-16 FW Mistel Fahrz. innen Gesamt
REFERENZANLAGEN REFERENCE UNITS
FAHRBARE ATEMLUFT-FÜLLSTATION MIT KOMPRESSOR, SPEICHER UND FÜLLRAMPE MOBIL BREATHINGAIR FILLING STATION WITH COMPRESSOR, STORAGE AND FILLINGPANEL SPEICHERFLASCHEN 50 LIT / 330 BAR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-17 FW Mistel Fahrzeugeinbau
REFERENZANLAGEN REFERENCE UNITS
FAHRBARE ATEMLUFT-FÜLLSTATION MIT KOMPRESSOR ,SPEICHER UND FÜLLRAMPE
MOBIL BREATHING AIR FILLING STATION WITH COMPRESSOR, STORAGE AND FILLING PANEL KOMPRESSOR MIT FILTER UND FEUCHTEMEßGERÄT
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2007 008-17 FW Mistel Fahrzeugeinbau
REFERENZANLAGEN REFERENCE UNITS
FAHRBARE ATEMLUFT-FÜLLSTATION MIT KOMPRESSOR,SPEICHER UND FÜLLRAMPE MOBIL BREATHINGAIR FILLING STATION WITH COMPRESSOR, STORAGE AND FILLINGPANEL
FÜLLRAMPE 200 + 300 BAR, ÜBERWACHUNGS- UND STEUERUNGSKOMPONENTEN
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 008 CTP-F 150-300
The Professionals
CTP - F 150 / 200 / 250 / 300 HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 008 CTP-F 150-300
CTP - F 150/200/250/300 This series was designed to meet the special requirements of fire fighting. It is compact in design, incorporates a filling ramp for 4 connections, filling pressure gauges, hour meter and advanced filter system for international breathing air standards as DIN3188 / EN12021.
TECHNICAL DATA STANDARD UNIT Model CTP-F 150 200 250 300
Output acc. bottle filling standard in lit/min 150 210 260 300 Speed 1300 1300 1640 1850
Max. pressure 350 bar operating pressure 225 or 330 bar
No. of stages/cylinder 3 / 3 Cooling By air
No. of filling connections 4 Prime movers 3 – phase E-Motor 400 V / 50 Hz Power required 4 kW 4 kW 5,5 kW 7,5 kW Dimensions L x W x H in cm Weight in kg E – Motor 90 x 60 x 87 153 155 180 185 NEW ALU-LINE ® E – Motor 90 x 60 x 87 143 145 170 175 ® Complete frame made in New Aluminium Technology The heart of the system is a 3 / stage air-cooled compressor block, which utilises super efficient intercoolers, aftercooler, condensate separators and safety valves after each stage. All models are designed for continuous operation at 350 bar We reserve the right to modify technical design without further notice
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 009 CTP-S 150-300 The Soundless One.doc
THE SOUNDLESS ONE
CTP – S SUPER-SILENT
WITH NOISE LEVEL 70 - 73 DB(A)
FOR HIGH PRESSURE BREATHING AIR COMPRESSORS MODEL CTP-S 150 / 200 / 250 / 300
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 009 CTP-S 150-300 The Soundless One.doc
Silent Line CTP – S 150/200/250/300
These sets share all the features and benefits of our standard range plus a specially designed acoustic enclosure, reducing noise levels to 70 -73 dB(A) at operating distance which complies with the majority of known requirements or legislation. A large range of accessories ensures fully automated and comfortable operation. Model charging rate Pressure Motor Filtercap. Dimensions Weight lit/min – cfm bar – psig KW cbm l x w x h (cm) kg CTP-S 150 150 5,3 350-5000 4 1200 105x70x123 230
CTP-S 200 210 7,4 350-5000 4 1200 105x70x123 240
CTP-S 250 260 9,2 350-5000 5,5 1200 105x70x123 240
CTP-S 300 300 10,6 350-5000 7,5 1200 105x70x123 240 We reserve the right to modify technical design without further notice The heart of the system is a multi- stage air cooled compressor block, which utilises super efficient intercoolers, aftercooler, condensate separators and safety valves after each stage. All models are designed for continuous operation at 350 bar / 5000 PSI.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 010 CTP-S 550-650-750 The Soundless One
THE SOUNDLESS ONE
CTP – S SUPER-SILENT
WITH NOISE LEVEL 70 DB(A)
FOR HIGH PRESSURE BREATHING AIR COMPRESSORS MODEL CTP – S 550 / 650 / 750
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 010 CTP-S 550-650-750 The Soundless One
Silent Line CTP – S 550 / 650 / 750
These sets share all the features and benefits of our standard range plus a specially designed acoustic enclosure, reducing noise levels to 70 dB(A) which complies with the majority of known requirements or legislation. A large range of accessories ensures fully automated and comfortable operation. Model charging rate Pressure Motor Filter cap. Dimensions Weight lit/min – cfm bar – psig KW cbm l x w x h (cm) kg CTP-S 550 550 19,5 350-5000 11 2400 136x80x180 450
CTP S 650 650 23 350-5000 15 2400 136x80x180 450
CTP-S 750 750 26,5 350-5000 18 2400 136x80x180 480
We reserve the right to modify technical design without further notice The heart of the system is a multi- stage air cooled compressor block , which utilises super efficient intercoolers, aftercooler, condensate separators and safety valves after each stage. All models are designed for continuous operation at 350 bar / 5000 PSI.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 011 CTP-F 550-650-750 The Powerful One
THE POWERFUL ONE
CTP – F 550 / 650 / 750
HIGH PRESSURE BREATHING AIR COMPRESSORS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 011 CTP-F 550-650-750 The Powerful One
CTP – F 550 / 650 / 750 Advanced technology has perfected these economical, compact, safe, reliable and easily maintained units. A complete line of accessories is available to meet your requirements. External Filling ramps up to 12 filling connections 200 and/or 300 bar
TECHNICAL DATA STANDARD UNIT Model CTP-F 550 650 750
Output acc. bottle filling standard in lit/min 550 650 750 Speed 950 1100 1250
Max. pressure 350 bar operating pressure 225 or 330 bar
No. of stages/cylinder 4 / 4 Cooling By air
No. of filling connections 4 Prime movers 3 – phase E-Motor 400 V Power required 11 kW 15 kW 18 kW Dimensions L x W x H in cm Weight in kg E – Motor 135 x 80 x 110 345 365 375 This multi - stage air-cooled system offers users of larger air compressors an economical way to produce 500 up to 700 lit/min of air in an efficient operating system. Like the smaller 3-stage counterpart these machines feature intercoolers, aftercoolers, auto-drain system, safety valves after each stage. All models are designed for continuous operation at 350 bar. * We reserve the right to modify technical design without further notice.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 012 CTP 750-E3 - N2
THE POWERFUL ONE
CTP – 550/650/750 E3-N2
HIGH PRESSURE GAS COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 012 CTP 750-E3 - N2
CTP-550/650/750 E3-N2 Advanced technology has perfected these economical, compact, safe, reliable and easily maintained units. A complete line of accessories is available to meet your requirements.
TECHNICAL DATA STANDARD UNIT Model CTP 550 650 750
Output acc. bottle filling standard in lit/min 550 650 750 Speed 950 1100 1250
Max. pressure 350 bar operating pressure 225 or 330 bar
No. of stages/cylinder 4 / 4 Cooling By air
Prime movers E - Motor 3 – phase E-Motor 400 V*
Power required 11 kW 15 kW 18 kW Dimensions L x W x H in cm Weight in kg
135 x 80 x 110 345 365 375 ** special voltage on request This multi - stage air-cooled system offers users of larger air compressors an economical way to produce 500 up to 700 lit/min of air in an efficient operating system. Like the smaller 3-stage counterpart these machines feature intercoolers, aftercoolers, auto-drain system, safety valves after each stage. All models are designed for continuous operation at 350 bar. * We reserve the right to modify technical design without further notice.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 013 CTL 300 Low pressure
The Portable One
CTL 300 LOW PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 013 CTL 300 Low pressure
CTL 300 WHEN A PORTABLE OR MOBILE SOURCE OF LOW PRESSURE BREATHING AIR IS REQUIRED,
COMP TRADE OFFERS GASOLINE, DIESEL OR ELECTRIC POWERED ENGINE UNITS. THESE ARE
DESIGNED FOR EASY OPERATION AND MAINTENANCE.
AIR QUALITY ACCORDING DIN 3188 OR EN 12021 IS A MUST
TECHNICAL DATA STANDARD UNIT
OUTPUT 300 LIT/MIN
SPEED ( COMPRESSOR ) 1100 RPM
MAX. PRESSURE 10 BAR
OPERATING PRESSURE 8 BAR
PRIME MOVERS: HONDA 4-STROKE PETROL 4 KW
KUBOTA DIESEL 4,1 KW
1-PHASE E-MOTOR 220 VOLT / 2 KW
3-PHASE E-MOTOR 380 VOLT / 3 KW
DIMENSIONS L X W X H WEIGHT MODEL WITH
90 X 40 X 52 CM 52 KG HONDA PETROL
115 X 50 X 65 CM 65 KG KUBOTA DIESEL
80 X 40 X 54 CM 55 KG ELECTRIC ENGINE
ALTHOUGH ATTRACTIVELY DESIGNED TO BE AS LIGHT AS POSSIBLE, NO COMPROMISE HAS BEEN
MADE TO RAGGEDNESS AND DURABILITY, MAKING THESE SETS SUITABLE FOR THE TOUGHEST
DUTIES.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 014 Filter Presec F60 Konsole d+e
PRESEC FILTER CONTROL with automatic control of cartridge saturation
regenerating air volume up to 2000 m³ (1110 BA-cylinders 6 lit/300 bar)
PRESEC Filter mit automatische Kontrolle der Patronen – Sättigung
aufbereitbare Luftmenge bis 2000 m³ (1110 AL-Flaschen 6 lit/300 bar)
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 014 Filter Presec F60 Konsole d+e
PRESEC SIGNALLING DEVICE
General Description Compliance with breathing air quality and thus dryness of the air is essential for the safety of the diver or the fire-fighter. However, air quality will only be as good as the maintenance of the filter systems and the timely exchange of cartridges. In all breathing-air Compressors, the useful life of the cartridges is specified as operating hours of the compressor or as the number of the breathing-air bottles to be tilled or as the treatable maximum quantity of air.
However, all specifications are related to a standard ambient air temperature of 200C.
With higher temperatures, the useful life of the filter cartridges is reduced considerably.
E.g., if a filter has a useful life of the cartridge of 25 operating hours at 200C ambient temperature, this will be only half in case of an increase of 100C, that means 14,25 operating hours. The useful life changes depending on the ambient air temperature as set forth in the table below: C F Correction Factor 50 122 0.2 40 104 0.34 30 86 0.57 20 68 1 10 50 1.85 5 41 2.6 0 32 3.8 Since it is nearly impossible to measure these different temperatures and exactly determine the precise useful life or the saturation period of the cartridge. COMP -TRADE has developed an automatic monitoring system of the degree of saturation of the cartridge i.e. the PRESEC SYSTEM. This system is used to automatically check the condition of the cartridge, its approaching of the saturated condition, and in the event of saturation the compressor will be turned off. This helps ensure that only properly dry air may get into the breathing-air bottles. The PRESEC SYSTEMS may be mounted directly on the COMP - TRADE Compressor in the factory, or be mounted on a console and connected at the downstream end of each compressor system.
PRESEC* - FILTERKONTROLLSYSTEME Allgemeine Funktionsbeschreibung: Die Einhaltung der Atemluftqualität und damit der Trockenheit der Luft ist für die Sicherheit des Tauchers oder Feuerwehrmannes von eminenter Wichtigkeit. Die Luftqualität ist aber nur so gut wie die Wartung der Filtersysteme und wie der rechtzeitige Patronenwechsel. Bei allen Atemluftkompressoren sind die Standzeiten der Patronen in Betriebsstunden des Kompressors oder der Anzahl der zu füllenden Atemluftflaschen oder in der maximal aufbereitbaren Luftmenge angegeben. Alle die Angaben beziehen sich jedoch auf eine
Standard- Umgebungstemperatur von 20° C. Bei höheren Temperaturen verkürzen sich die
Standzeiten der Filterpatronen drastisch. Hat z.B. eine Filterpatrone bei 20° C Umgebungstemperatur eine Standzeit von 25 Betriebsstunden, so verkürzt sich diese bei einen Temperaturanstieg von nur 10° C schon auf knapp die Hälfte, nämlich 14,25 Betriebsstunden. (Siehe Tabelle linke Spalte) Da es nahezu unmöglich ist, diese unterschiedlichen Temperaturen zu messen und damit die genaue Standzeit bzw. den Sättigungszeit der Patrone genaue zu bestimmen, bietet. COMP - TRADE eine automatische Überwachung des Sättigungszustandes der Patrone, das PRESEC SYSTEM an Mit Hilfe dieses Systems wird automatisch der Patronenzustand kontrolliert, das Annähern an den Sättigungszustand angezeigt bzw. bei Sättigung der Kompressor abgeschaltet wird. Somit ist gewährleistet, dass immer nur einwandfreie trockene Luft in die Atemluftflaschen gelangt. Die PRESEC SYSTEME Können entweder werksseitig direkt auf dem COMP - TRADE Kompressor aufgebaut, oder aber auf einer Konsole montiert jeder Kompressoranlage nachgeschaltet werden.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs- GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 015 Filter cartridge with opt. control d+e
Filter Cartridges with optical indication of saturation for Breathing Air Quality acc. DIN 3188/EN 12021
Filter - Patronen mit optischer Sättigungsanzeige
für Atemluftqualität nach DIN 3188 / EN 12021
Transparent tube Durchsichtiges Patronengehäuse
Indicator strip Anzeige-Streifen
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs- GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 015 Filter cartridge with opt. control d+e
S A F E and E F F I C I E N T
In compliance with breathing air quality and thus dryness of the air is essential for the safety of the diver or the fire fighter. However, air quality will only be as good as the maintenance of the filter systems and the timely exchange of cartridges. In all breathing-air Compressors, the useful life of the cartridges is specified as operating hours of the compressor or as the number of the breathing-air bottles to be tilled or as the treatable maximum quantity of air. However, all specifications are related to a standard ambient air temperature of 20°C. With higher temperatures, the useful life of the filter cartridges is reduced considerably. E.g., if a filter has a useful life of the cartridge of 25 operating hours at 20°C ambient temperature, this will be only half in case of an increase of 10°C, that means 14,25 operating hours. The useful life changes depending on the ambient air temperature as set forth in the table below: °C °F Korrekturfaktor 50 122 0,2 40 104 0,34 30 86 0,57 20 68 1 10 50 1,85 5 41 2,6 0 32 3,8 Since it is nearly impossible to measure these different temperatures and exactly determine the precise useful life or the saturation period of the cartridge, the condition of the cartridge is shown by an indicator strip, which changes the colour from blue to brown according the humidity in the Molecular Sieve. Advantage: you can check periodically the condition of the cartridge and can use it until it is completely saturated.
SICHER und GRÜNDLICH
Die Einhaltung der Trockenheit der Luft und damit der Atemluftqualität nach DIN 3188 / EN 12021 ist für die Sicherheit des Tauchers oder Feuerwehrmannes von eminenter Wichtigkeit. Die Luftqualität ist aber nur so gut wie die Wartung der Filtersysteme und dem rechtzeitigen Patronenwechsel. Bei allen Atemluftkompressoren sind die Standzeiten der Patronen in Betriebsstunden des Kompressors oder der Anzahl der zu füllenden Atemluftflaschen oder in der maximal aufbereitbaren Luftmenge angegeben. Alle Angaben beziehen sich jedoch auf eine Standard- Umgebungstemperatur von 20° C. Bei höheren Temperaturen verkürzen sich die Standzeiten der Filterpatronen drastisch. Hat z.B. eine Filterpatrone bei 20° C Umgebungstemperatur eine Standzeit von 25 Betriebsstunden, so verkürzt sich diese bei einem Temperaturanstieg von nur 10°C schon auf knapp die Hälfte, nämlich 14,25 Betriebsstunden. Die Standzeit der Patrone verändert sich in Abhängigkeit der Umgebungstemperatur des Kompressors laut Tabelle linker Spalte: Da es nahezu unmöglich ist, diese unterschiedlichen Temperaturen zu messen und damit die genaue Standzeit bzw. den Sättigungszeit der Patrone genaue zu bestimmen, bietet COMP-TRADE eine Filterpatrone mit eingelegtem Indikatorstreifen an, mit Hilfe dessen Sie jederzeit den Sättigungszustand der Patrone ersehen und die Patrone kurz vor Sättigung tauschen können. Patronen sind für alle gängigen Atemluftkompressoren erhältlich.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 016 Fillingr. ext 3x200+3x300+HC1 d+e
EXTERNAL FILLING RAMP
3 x 300 BAR AND 3 x 200 BAR WITH HUMIDITY CONTROL HC 1 Pre-adjusted pressure reducing valve 225 bar replaces a manual change over system 200 to 300 bar and permits a simultaneously filling of all 200 and/or 300 bar cylinders. Safety valve 225 bar limits the pressure in case of miss-function of pressure reducing valve. The Humidity control shows the water content in the breathing air permanently in mg / cbm
EXTERNE FÜLLRAMPE 3 x 300 BAR UND 3 x 200 BAR UND FEUCHTEKONTROLLE HC 1
Voreingestelltes Druckreduzierventil 225 bar ersetzt das manuelle Umschalten auf den 2. Druckbereich und ein gleichzeitiges Befüllen aller angeschlossenen Atemluft-Hochdruckflaschen 200 und 300 bar ist ohne zusätzliche Bedienung gewährleistet. Ein ebenfalls in der Füllrampe montiertes Sicherheitsventil 225 bar sichert gegen Überfüllung der 225 bar Atemlut-Flaschen bei Fehleinstellung oder Fehlfunktion des Reduzierventiles. Die Feuchtekontrolle HC 1 zeigt permanent den Wassergehalt der Atemluft in mg / cbm HUMIDITY CONTROL FILLING PRESSURE 300 BAR FILLING PRESSURE 200 BAR
LEVER VALVE PROT. COVER HOLDER FOR PROT. COVER SAFETY VALVE 225 BAR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 016 Fillingr. ext 3x200+3x300+HC1 d+e
HC 1 HUMIDITY CONTROL SYSTEM
Technical description A high-pressure resistant sensor is integrated in the air tube leading from the compressor or storage station to the filling ramp. A control line leads from the sensor casing to the display unit. In addition to the display, visual control is ensured by three LED’s: green LED = filter cartridge okay orange LED = filter cartridge too humid red LED = Switch off compressor NOTE: The system can be used for filling pressures between 10 bar and 300 bar. The highest degree of accuracy with a tolerance of ± 2 mg/m³ is achieved at 20° C and humidity ranging between 10 to 30 mg/m³. After start-up or after filter change, the values displayed may be too high or too low. this is due to the delay in filter action or caused by the low pressure in the system. The amount of adaptation air may thus be as high as 2000 l (~10 l bottle 200 bar). Standards and Filling Authorisation The European EN 12021 regulation stipulates the following with regard to the use of air in breathing apparatuses: The water content of the air supplied by the compressor for filling 200 bar or 300 bar gas cylinders should not exceed 25 mg/m³. The owner of the compressor and the person in charge of filling the bottles are responsible for ensuring that this limit is not exceeded. Bottles may only be filled by persons listed as authorised persons in the compressor check book.
HC 1 FEUCHTEKONTROLLE
Technische Beschreibung Ein hochdruckfester Sensor wird einfach in die Luftleitung zwischen Verdichter und Füllrampe eingebaut. Vom Sensorgehäuse führt eine beliebig lange Steuerleitung zum Anzeigegerät. Am Display des Anzeigegerätes kann sowohl der Betreiber der Füllstation als auch der Anwender der Atemluft während des Füllvorganges den Wassergehalt numerisch in mg/m³ ablesen. Zu Ihrer eigenen Sicherheit und der Ihres Kunden. Die kontinuierliche Überwachung der Feuchte in der Atemluft während des Füllvorganges war bisher nur durch aufwendige elektronische Patronenzustandsmessgeräte möglich, der Austausch dieser Patronen teuer. Zusätzliche optische Kontrolle durch LED-Anzeige. Grünes Licht = Filterpatrone in Ordnung Gelbes Licht = Patronentausch empfohlen Rotes Licht = Patrone muss getauscht werden Die Sicherheit für Ihren Füllvorgang: Das europäische Regelwerk EN 12021sowie die deutsche Norm DIN 3188 schreiben für die Verwendung von Luft in Atemgeräten einen Wassergehalt – Höchstwert von 30 mg/m³ bei 200 bar Geräten bzw. 50 mg/m³ bei 300 bar Geräten vor. Eine externe Überwachungsschaltung mit Fremdspannungsversorgung bis 220 Volt kann über ein eingebautes Relais angeschlossen werden. Durch eine kleine Abänderung der Füllrampe kann auch die Feuchtekontrolle einer angeschlossenen Flasche einfach und digital ablesbar durchgeführt werden.
SICHERHEITSFÜLLANSCHLÜSSE
SAFETY VALVE CONNECTORS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 017 App. Flow stop d+e
Für 200 und 300 bar DIN477 / G 5/8“
Pressluftanschlüsse
200 bar Viele Unfälle mit zum Teil schwersten Verletzungen wurden durch unbeabsichtigt geöffnete Füllventile, welche die Füllanschlüsse peitschenartig schleuderten, verursacht. Kipphebel Füllventile, die im Gegensatz zu Drehventilen fast schlagartig die hoch komprimierte Pressluft freigeben, sind deshalb in diesem Zusammenhang besonders gefürchtet. Wir haben das Problem auf sehr einfache, robuste und preiswerte Art gelöst.
200 bar Sicherheits-Füllanschluss Ein aus dem Füllanschluss vorstehender Kolben wird beim Anschließen an die Pressluftflasche nach innen gedrückt und gibt erst nach dem Anschließen die Pressluft frei. Bei nicht montiertem Füllanschluss und geöffnetem Füllventil tritt etwas Pressluft aus. Damit wird angezeigt, dass der Füllschlauch unter Druck steht und vor dem Anschließen erst druck los gemacht werden muss. 300 bar Sicherheits-Füllanschluss Der 300 bar DIN Füllanschluss wurde konstruktiv geändert, sodass auch dieser rückstossfrei bleibt, sofern versehentlich unter Druck geöffnet wird.
Available in 200 bar (3000 psi) or 300 bar (4500 psi) DIN versions
300 bar Unintentionally opening a filling valve when the filling hose is not connected to a tank can cause severe injury. The escaping high pressure air flows in large volumes through the filling hose causing it to whip around violently. We have looked at this daily risk problem and found a simple and inexpensive solution. 200 bar (3000 psi) DIN safety filling connector The connector has a small one way valve incorporated which is only opened when the connector is correctly screwed into a tank valve. No air can flow through the connector unless it is properly connected to the tank valve. A small orifice does however allow a small amount of air to flow harmlessly through the connector thus preventing a pressure build up in the filling hose.
300 bar (4500 psi) DIN safety filling connector
By modifying the existing nose of the 300 bar DIN connector and diverting the air flow out of the connector, a whipping effect is avoided.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 018 Filling hose distributor d+e
Filling hose distributor for 200 bar or 300 bar to
charge up to 6 bottles simultaneously
Füll-Verteiler 200 bar oder 300 bar zum gleichzeitigen Befüllen von 1 bis 6 Atemluftflaschen
Main connection from compressor with filling hose Haupt-Luftanschluß von Kompressor mit Füllschlauch
Bottle filling connection with airtight protection cap Part number CTP 635-329 Flaschenfüllanschluß mit luftdichter Schutzkappe Teil Nummer CTP 635-329
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 018 Filling hose distributor d+e
Filling hose with safety valve 225 bar, to charge 200 bar cylinders from a 300
bar filling connection ( either from filling ramp with direct connection or filling hose )
Füllschlauch mit Sicherheitsventil 225 bar, um 200 bar Zylinder von einem 300 bar Füllanschluss zu befüllen.
( entweder von Füllrampe mit Direktanschluss oder Füllschlauch.)
1 Füllrohr 200 bar 4 Sicherheitsventil 225 bar
Filling pipe 200 bar Safety valve 225 bar
2 Handrad 200 bar 5 Adapter für Anschluß an 300 bar Handwheel 200 bar Adapter for connection to 300 bar
3 Hochdruckschlauch 350 bar, 0,5 m Länge High pressure hose 350 bar , 0,5 m length
BESTELLNUMMER / PART NUMBER CTP 635-328
SPEICHER – SYSTEME STORAGE – SYSTEMS
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 019 Speicherflaschen e+d
Speicherflaschen bis 300 bar Fülldruck Auf Wunsch mit TÜV – Abnahme. Für Kaskadenfüllbetrieb empfehlen wir eine spezielle Füllleiste. (Infoblatt anfordern) Unsere Kompressoren können mit einer Steuerung ausgestattet werden. Dabei schaltet die Anlage bei Unter- oder Überdruck automatisch ein oder aus. Somit werden volle Speicherflaschen garantiert.
Storage Tanks for max. 300 bar (4500 psi) Supplied with Austrian TÜV test certificate if desired. We also offer specially designed filling ramps for cascade filling operations. Ask for details. Our compressor can also be equipped with automatic controls for activating the compressor when a preset storage tank pressure is reached ensuring easy operation and filling.
2 x 50 ltr. Flaschen 300 bar / 4350 psi
(~ 30 m³)
6 x 50 ltr. Flaschen 300 bar / 4350 psi
(~90 m³)
3 x 50 ltr. Flaschen 300 bar / 4350 psi
(~45 m³)
HIGHEST QUALITY
FROM AUSTRIA with new aluframe
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 020 Aircheck engl.
AIR CHECK UNIT
for the quantitative analysis of water vapour, oil contents, carbon monoxide, carbon dioxide,
(ACCORDING BREATHING AIR QUALITY STANDARD DIN 3188 / EN 12021 )
Timer A
Flushing Valve
Outlet A
Timer B
Testing Tubes
Indication LED’S
Display
Outlet B Adapter tube breaker
Manometer
HIGHEST QUALITY
FROM AUSTRIA with new aluframe
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 020 Aircheck engl.
AIRCHECK – UNIT
Technical description: The newly developed COMP TRADE Air check – unit is an automatic measuring device for air
quality and permits the precise determination of the quantitative contents of CO, CO2, water
vapour and oil in air or other gaseous media. The analysis of air can thus be carried out either from
high pressure cylinders or in a direct way from a compressor.
Basically the COMP TRADE Air check consists of the following components:
1. Humidity Control unit HC 1 for checking the water vapour 2. Regulating and operating automation with pressure reducing system, timer, receiver for test
tubes, adapters and high pressure connection hose. 3. Solid, light metal brief case with locking device housing, all components mentioned under 1
and 2 in a very space saving and practical way. 4. Dräger test tubes for oil, CO and CO ( 10 tubes each )
ad 1.) A high-pressure resistant sensor is situated in the air stream.A control line leads from the sensor casing to the display unit. When the air flow is started, the green LED should light up and the display should show the amount of water vapour in mg/m³. In addition to the display, visual control is ensured by three LED’s: green LED = air quality regarding water vapour okay orange LED = humidity penetration next to the limits red LED = air too wet ad 2.) The regulating and operating automatic incorporates a precise pressure reducing and control valve as well as calibrated timers for the checking outlets. Testing tubes for Oil, CO and CO2 must be placed into tube holders and placed into the outlets. During testing procedure the chemical charges in the testing tubes change colour when the air pass through. The higher the decolourisation, the higher the degree of contamination. Each package of test tubes contains a scale according to which the
analysis can be recorded numerically. A detailed operation
instruction is displayed directly on the front of the testing device.
Main Data’s: Operation voltage: 230 Volt / 50 Hz
Dimensions: 47 x 34 x 16 cm Weight : 10 kg
HIGHEST QUALITY
FROM AUSTRIA with new aluframe
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 021 Airline trolley with hose reels
SELF CONTAINING BREATHING APPARATUS WITH
HOSE REELS FOR LONG TERM BREATHING AIR SUPPLY
350 BAR / 5000 PSI BREATHING AIR TECHNOLOGY
HIGHEST QUALITY
FROM AUSTRIA with new aluframe
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 021 Airline trolley with hose reels
WHEN A PORTABLE OR MOBILE
SOURCE OF LOW PRESSURE
BREATHING AIR IS REQUIRED,
COMP – TRADE OFFERS
VARIOUS BREATHING AIR SYSTEMS
FOR EASY OERATION AND
MAINTENANCE.
FIG. SHOWS 3 HOSE REELS WITH
40 METER AIR LINE HOSES EACH
AND THE FACE MASK WITH DEMAND
VALVE
TECHNICAL DATA
MODEL
AT 3
MAX. AIR CAPACITY 60.000 LIT MAX. PRESSURE - STORAGE 300 BAR NO. OF HOSE REELS 3 OPERATING PRESSURE 40 BAR ( ADJUSTABLE ) FACE MASK AND DEMAND VALVE 3 DIMENSIONS L X W X H 2000 X 1085 X 1360 MM WEIGHT 800 KG Although attractively designed to be as light as possible, no compromise has been made to raggedness and durability, making these sets suitable for the toughest duties.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 022 Compact anlage
The Fast-Filling Station
CTP – B 150 / 200 / 250 / 300 compact
HIGH PRESSURE BREATHING AIR COMPRESSOR with integrated booster function
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 022 Compact anlage
CTP 100 WHEN A PORTABLE OR MOBILE SOURCE OF HIGH PRESSURE BREATHING AIR IS REQUIRED, COMP – TRADE OFFERS GASOLINE OR ELECTRIC POWERED ENGINE UNITS. THESE UNITS ARE DESIGNED FOR EASY OERATION AND MAINTENANCE. AIR QUALITY ACC. DIN 3188 OR EN 12021 is a must. FIG. SHOWS FILLING CON. TO CHARGE BA – CYLINDERS 200 AND 300 BAR SIMULTANEOUSLY TECHNICAL DATA STANDARD UNIT Model
CTP 100
OUTPUT 100 LIT/MIN ACC. BOTTLE FILLING STANDARD SPEED 2300 RPM MAX. PRESSURE 350 BAR OPERATING PRESSURE 225 OR 330 BAR NO. OF STAGES/CYLINDER 3/3 COOLING BY AIR NO. OF FILLING CONNECTIONS 1 ( 2ND CONNECTION OPTIONAL ) PRIME MOVERS HONDA 4-STROKE PETROL ENGINE 1 – PHASE E-MOTOR 220 VOLT / 2,2 KW 2 – PHASE E-MOTOR 380 VOLT / 2,2 KW DIMENSIONS L X W X H HONDA VERSION 70 X 36 X 47 CM ELECTRIC VERSION 63 X 36 X 47 CM WEIGHT E-VERSION 48 KG H-VERSION 45 KG ALTHOUGHT ATTRACTIVELY DESIGNED TO BE AS LIGHT AS POSSIBLE, NO COMPROMISE HAS BEEN MADE TO RAGGEDNESS AND DURABILITY, MAKING THESE SETS SUITABLE FOR THE TOUGHEST DUTIES.
HIGHEST QUALITY FROM AUSTRIA
NEW: ALULINE
Stand: 01-2008 001 CTP Gesamt front
350 BAR / 5000 PSI BREATHING AIR TECHNOLOGY ACC. TO INTERNATIONAL QUALITY STANDARDS
HIGHEST QUALITY FROM AUSTRIA
NEW: ALULINE
Stand: 01-2008 001 CTP Gesamt front
HIGH PRESSURE BREATHIG AIR COMPRESSORS
MAX. 350 BAR / 5000 PSI
PRODUCT RANGE
MODEL PRIME MOVER OUTPUT lit/min / cfm
POWER kW / HP
CTC 100 E 1 or 3 phase el. motor 80-100 / 2,8 – 3,5 2,2 / 3 CTC 100 P 4 stroke Petrol 100 / 3,5 4 / 5,5 CTP 100 E 1 or 3 phase el. motor 100 / 3,5 2,2 / 3 CTP 100 P 4 stroke Petrol 100 / 3,5 4 / 5,5 CTP 150 E 3 phase el. Motor 150 / 5,3 4 / 5,5 CTP 150 P 4 stroke Petrol 150 / 5,3 6,7 / 9 CTP 150 D Dieselmotor 150 / 5,3 4,4 / 6 CTP 200 E 3 phase el. Motor 210 / 7,4 4 / 5,5 CTP 200 P 4 stroke Petrol 210 / 7,4 6,7 / 9 CTP 200 D Dieselmotor 210 / 7,4 4,4 / 6 CTP 250 E 3 phase el. Motor 260 / 9,2 5,5 / 7,5 CTP 250 P 4 stroke Petrol 260 / 9,2 8 / 12 CTP 250 D Dieselmotor 260 / 9,2 7,5 / 10 CTP 300 E 3 phase el. Motor 300 / 10,6 7,5 / 10 CTP 300 P 4 stroke Petrol 300 /10,6 10 / 13,6 CTP 300 D Dieselmotor 300 /10,6 10 / 13,6 CTP 550 - 750 E CTP 550 – 750 D
3 phase el. Motor Dieselmotor
550-750 / 19,5-26,5 550-750 / 19,5-26,5
11 / 18 13 / 20
COMPRESSOR WITH INTEGRATED BOOSTERFUNCTION CTB(M) – B 150 3 phase motor and/or 150 / 5,3 4 / 5,5 Petrol or Diesel up to 1200 / 42,4 CTB(M) – B 200 3 phase el. Motor and/or 210 / 7,4 4 / 5,5 Petrol or Diesel up to 1200 / 42,4 CTB(M) – B 250 3 phase el. Motor and/or 260 / 9,2 5,5 / 7,5 Petrol or Diesel up to 1200 / 42,4 CTB(M) – B 300 3 phase el. Motor and/or 300 / 10,6 7,5 / 10 Petrol or Diesel up to 1200 / 42,4
HIGHEST QUALITY FROM AUSTRIA
NEW: ALULINE
HIGH PRESSURE COMPRESSORS FOR BREATHING AIR ACCORDING QUALITY STANDARD DIN 3188 / EN 12021
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs- GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: o1-2008 002 POSTER
STORAGE SYSTEM
up to 12 x 50 l / 350 bar
TRAILER MOUNTED UNITS
All Models with electric or petrol / diesel drive
EXTERNAL FILLING RAMPS
With self venting filling valves 2 pressure ranges 200 & 300 bar
THE PORTABLE ONE
Model CTC 100 80-100 l/min, 350 bar
THE ALLROUNDERS
Model CTP 150 / 200 / 250 / 300 150 –300 l/min, 350 bar
THE PROFESSIONAL mobile
Model CTP-F 250 250 l/min – 350 bar
THE SOUNDLESS ONE
Model CTP-S 150 –750 150 – 700 l/min, 350 bar
THE PROFESSIONAL stationary
Model CTP-F 150-300 150-300 l/min – 350 bar
THE POWERFULL ONE
Model CTP-F 550 / 650 / 750 550 - 750 l/min - 350 BAR
BREATHING AIR FILLING STATION WITH INTERGRIERTER BOOSTER FUNCTION
ATEMFÜLLSTATION MIT
INTEGRIERTER BOOSTR FUNKTION
MODELL CTP - B 150 / 200 / 250 / 300
COMPRESSION 150 lit/min to 1000 lit/min REGENERATING AIR QUAL. ACC DIN 3188 EN 12021 STORING/SPEICHER 1 - 8 X 50 LIT/300 bar 15.000 - 120.000 lit air FILLING/BEFÜLLTUNG integrated and external Filling Ramps 200 and 300 bar
BOOSTER FUNKTION
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 1 / 6 003-2 Describtion with integrated Booster Function
BREATHING AIR COMPRESSOR WITH INTEGRATED BOOSTER FUNCTION 1. WORKING METHOD: In automated compressor operation during idle periods, i.e. during the night, the storage
systems are filled. During day time, when a large number of small tanks have to be
filling within a short time, compressors are switched over to booster operation.
This is effected by simply operating a high pressure valve.
The high pressure stage of the multistage high pressure compressor is now directly
connected to the storage system and the pre-compressed air from the storage system
flows into the small tanks. As soon as there is a pressure balance in the system, the
high pressure valve switches over to booster operation and the last compressor stage
compresses up to requested final pressure.
Operation of the switch-over valve will be carried out by electro-pneumatic remote
control.
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 2 / 6 003-2 Describtion with integrated Booster Function
2. THE ADVANTAGES OF THESE SYSTEM ARE:
With 60.000 lit air in the storage each filling application can be done in a very
short time.
Filling can be done by overflow first from storage system to aircylinder /
accumulators / shock struts / tyres / emergency air pillows etc.
Compressor in booster operation works in low load, because pressure ratio in the
3rd stage is always small then in compressor-operation.
BA – Bottle filling with high delivery rates independent from ambient air quality.
Only ONE unit with ONE prime mover and ONE standard filter system.
ONE filling ramp only where the small tanks can either be filled from the
compressor directly or from the storage and booster-system.
Switching over from compressor to booster operation within seconds.
LOW PRICES !
The price of a CTP-B-unit is considerably lower than that of a breathing air
compressor with storage system plus a booster or a standard breathing air
compressor with the same filling time capacity.
An additional low pressure filling connection can be mounted to the filling ramp to
supply low pressure airline systems + venting / cooling the protection suits, to
supply air for pneumatic rescue tools, emergency pillows etc..
More then 100 Reference stations for compressor system with integrated booster
function in fire brigades and airports, 4 Mobil booster units on trailer, powered by
diesel + electric at civil defence Singapore.
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 3 / 6 003-2 Describtion with integrated Booster Function
3. Outputs of CTP-B-Units in l/min
Storage pressure CTP-B 150 200 250 300 200 – 300 bar 1200 1200 1200 1200
150 bar 950 1000 1100 1100
100 bar 630 750 850 900
50 bar 400 500 600 700
4. Technical description
3-stage, 3-cylinder aircooled high pressure compressor with interstage coolers and
aftercooler, safety valve after each stage, 2nd stage separator, 3rd stage separator with
final safety valve, purifier for breathing air acc. to DIN 3188, with molecular/active
carbon cartridges and attached pressure maintaining valve with autodrain system,
silencer and trap.
The switch-over from compressor to booster operation is effected by a pneumatic
remote controlled switching unit, activated by a electric button on the filling ramp
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 4 / 6 003-2 Describtion with integrated Booster Function
5. Main Components:
Comboost block, connected by one V-belt for the electric motor
Pneumatic switch-over set for booster operation.
Filling ramp: with 4 x 225 bar / 3300 PSI
or 4 x 300 bar / 4850 PSI filling valves,
which can be separately vented with lever filling valves,
connection R 5/8 “ outside, protecting covers and central
pressure gauge.
6. Storage System:
consisting of 4 x 50 litre, 330 bar high pressure cylinders complete in a steel frame and
includes condensate drain valves as well as all fittings and shut off valves.
Cylinders are with German and/or Austrian TÜV certifications
The above mentioned system can be mounted very easy in a truck or a trailer
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 5 / 6 003-2 Describtion with integrated Booster Function
7. AIR FLOW/DIAGRAMS
schematic airflow for a compressor with integrated booster function
( Modell COMP TRADE CTP – B 150/200/250 )
150
200 up to 1000 lit / min 250
COMP – TRADE Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Februar 2008 Page 6 / 6 003-2 Describtion with integrated Booster Function
A. Air inlet B. Condensate draining - Outlet 1 Air intake filter 2 Interstage cooler 1st /2nd stage 3 Safety valve 1st stage 4 Interstage cooler 2nd /3rd stage 5 interstage oil and water separator 6 Safety valve 2nd stage 7 Aftercooler 8 Oil and Water separator 9 Final separator 10 Safety valve 330 bar 11 Back pressure valve 12 Pressure switch for auto Stopp 13 Temperature switch
14 Pressure gauge 2nd stage 15 Pressure maintaining valve 16 3 way high pressure bal valve 17 Pneumatic rotating switch 18 5/2 ways magnetic valve 19 2 ways high pressure bal valve 20 Sinter filter 21 Condensate automatic 22 2 ways high pressure bal valve /filling ramp 23 2 ways high pressure bal valve for 2nd pressure range 24 Pressure gauge /filling pressure 25 Pressure switch 26 safety valve 220 bar 27 filling hoses with manometer 2x 200 2x 300 bar
28 2 way ball valve / storage 29 Back pressure valve 30 Pressure gauge – Storage Tank 31 Pressure reducing valve 32 2 way high-pressure ball valve – overflow (decanting) 33 storage cylinders 50 l geometry volume each 34 pressure switch 35 savety valve storage I 1st Stage II 2nd Stage III 3rd Stage
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 003 CTC 100 ALU.doc
The Portable One
CTC 100 HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 003 CTC 100 ALU.doc
CTC 100 WHEN A PORTABLE OR MOBILE SOURCE OF HIGH PRESSURE BREATHING AIR IS REQUIRED, COMP – TRADE OFFERS GASOLINE OR ELECTRIC POWERED ENGINE UNITS. THESE UNITS ARE DESIGNED FOR EASY OERATION AND MAINTENANCE. AIR QUALITY ACC. DIN 3188 OR EN 12023 is a must. FIG. SHOWS FILLING CONNECTION TO CHARGE BA - CYLINDERS 200 AND 300 BAR SIMULTANEOUSLY ( OPTION ) TECHNICAL DATA STANDARD UNIT Model
CTC 100
Output 80 - 100 lit/min acc. bottle filling standard Speed 2300 rpm Max. pressure 350 bar operating pressure 225 or 330 bar No. of stages/cylinder 4 / 4 Cooling by air No. of filling connections 1 ( 2nd connection optional ) Prime movers Honda 4-stroke petrol engine 1 – phase E-Motor 220 Volt / 2,2 KW 3 – phase E-Motor 380 Volt / 3 KW Dimensions L x W x H Honda version 73 x 37 x 41 cm Electric version 73 x 37 x 41 cm Weight H-version 55 kg E-version 52 kg NEW ALU-LINE ® Design with E – Motor 46 kg Design with Honda engine 49 kg ® Complete frame made in New Aluminium Technology Although attractively designed to be as light as possible, no compromise has been Made to raggedness and durability, making these sets suitable for the toughest duties.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 004 CTC-S 100
The Portable One
CTC 100 Silent HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 004 CTC-S 100
CTC 100 WHEN A PORTABLE OR MOBILE SOURCE OF HIGH PRESSURE BREATHING AIR IS REQUIRED, COMP – TRADE OFFERS GASOLINE OR ELECTRIC POWERED ENGINE UNITS. THESE UNITS ARE DESIGNED FOR EASY OERATION AND MAINTENANCE. AIR QUALITY ACC. DIN 3188 OR EN 12023 is a must. TECHNICAL DATA STANDARD UNIT Model
CTC 100 Silent
Output 100 lit/min acc. bottle filling standard Speed 2300 rpm Max. pressure 350 bar operating pressure 225 and / or 330 bar No. of stages/cylinder 4 / 4 Cooling by air No. of filling connections 2nd connection Prime movers Honda 4-stroke petrol engine 1 – phase E-Motor 220 Volt / 2,2 KW 2 – phase E-Motor 380 Volt / 2,2 KW Dimensions L x W x H Electric version 70 x 40 x 450cm Weight E-version 53 kg Although attractively designed to be as light as possible, no compromise has been Made to raggedness and durability, making these sets suitable for the toughest duties.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 005 CTP 100
The Portable One
CTP 100 HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 005 CTP 100
CTP 100 WHEN A PORTABLE OR MOBILE SOURCE OF HIGH PRESSURE BREATHING AIR IS REQUIRED, COMP – TRADE OFFERS GASOLINE OR ELECTRIC POWERED ENGINE UNITS. THESE UNITS ARE DESIGNED FOR EASY OERATION AND MAINTENANCE. AIR QUALITY ACC. DIN 3188 OR EN 12021 is a must. FIG. SHOWS FILLING CON. TO CHARGE BA – CYLINDERS 200 AND 300 BAR SIMULTANEOUSLY TECHNICAL DATA STANDARD UNIT Model
CTP 100
OUTPUT 100 LIT/MIN ACC. BOTTLE FILLING STANDARD SPEED 2300 RPM MAX. PRESSURE 350 BAR OPERATING PRESSURE 225 OR 330 BAR NO. OF STAGES/CYLINDER 3/3 COOLING BY AIR NO. OF FILLING CONNECTIONS 1 ( 2ND CONNECTION OPTIONAL ) PRIME MOVERS HONDA 4-STROKE PETROL ENGINE 1 – PHASE E-MOTOR 220 VOLT / 2,2 KW 2 – PHASE E-MOTOR 380 VOLT / 2,2 KW DIMENSIONS L X W X H HONDA VERSION 70 X 36 X 47 CM ELECTRIC VERSION 63 X 36 X 47 CM WEIGHT E-VERSION 48 KG H-VERSION 45 KG ALTHOUGHT ATTRACTIVELY DESIGNED TO BE AS LIGHT AS POSSIBLE, NO COMPROMISE HAS BEEN MADE TO RAGGEDNESS AND DURABILITY, MAKING THESE SETS SUITABLE FOR THE TOUGHEST DUTIES.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 006 CTP 150-300 FF
The Allrounders
CTP 150 / 200 / 250 / 300 HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
Stand: 01-2008 006 CTP 150-300 FF
CTP 150/200/250/300 These compressors have shown themselves to be reliable, efficient and easily maintained under the most demanding conditions, from the heat and humidity of the tropics to the extreme cold of northern climates. They are robust, heavy duty units for amateur and professional use, available as portable or stationary compressors. A great range of accessories and their technical stability permit their adaptation to many specific applications in fire fighting, the military field as well as in industry and gas compression.
TECHNICAL DATA STANDARD UNIT Model CTP 150 CTP 200 CTP 250 CTP 300
Output acc. bottle filling standard in lit/min 150 210 260 300 Speed 1300 1300 1640 1850
Max. pressure 350 bar operating pressure 225 or 330 bar
No. of stages/cylinder 3 / 3 Cooling By air
No. of filling connections 1 Prime movers 3 – phase E-Motor 400 V Honda Petrol 4-stroke engine Honda Diesel engine Power required 4 kW 4 kW 5,5 kW 7,5 kW Dimensions L x W x H in cm Weight in kg E – Motor 87 x 42 x 73 99 99 103 108 Honda 4 stroke Petrol 107 x 44 x 70 115 115 115 121 Honda Diesel GD 411 107 x 44 x 70 148 148 148 155
NEW ALU-LINE ® E – Motor 87 x 42 x 73 89 89 93 98 Honda 4 stroke Petrol 107 x 44 x 70 105 105 105 111 Honda Diesel GD 411 107 x 44 x 70 138 138 138 145 ® Complete frame made in New Aluminium Technology The heart of the system is a 3-stage air-cooled compressor block, which utilises super efficient intercoolers, an aftercooler, condensate separators and safety valves after each compression stage. All models are designed for continuous operation at 350 bar. We reserve the right to modify technical design without further notice.
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2008 007 CTP-F 150-300 mobil
The Professionals
CTP - F 150 / 200 / 250 / 300 mobile HIGH PRESSURE BREATHING AIR COMPRESSOR
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
Stand: 01-2008 007 CTP-F 150-300 mobil
CTP - F 150/200/250/300 This series was designed to meet the special requirements of fire fighting. It is compact in design, incorporates a filling ramp for 4 connections, filling pressure gauges and advanced filter-systems for int. breathing air standards as f.i. DIN 3188 / EN 12021
TECHNICAL DATA STANDARD UNIT Model CTP-F 150 200 250 300
Output acc. bottle filling standard in lit/min 150 210 260 300 Speed 1300 1300 1640 1850
Max. pressure 350 bar operating pressure 225 or 330 bar
No. of stages/cylinder 3 / 3 Cooling By air
No. of filling connections 4 Prime movers Petrol 4 Stroke Honda or Diesel Power required Petrol 6,6 kW 6,6 kW 6,6 kW 8 kW Power required Diesel 6,6 kW 6,6 kW 6,6 kW 10,5 kW Dimensions L x W x H in cm Weight in kg Petrol 107 x 55 x 76 158 160 185 190 Diesel 107 x 55 x 76 158 158 158 169 NEW ALU-LINE ® E – Motor 90 x 60 x 87 143 145 170 175 We reserve the right to modify technical design without further notice The heart of the system is a 3 - stage air cooled compressor block , which utilises super efficient intercoolers, aftercooler, condensate separators and safety valves after each stage. All models are designed for continuous operation at 350 bar.
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
008-01 Reference list.doc
AUSZUG AUS DER REFERENZLISTE FÜR COMP - TRADE - ATEMLUFTKOPRESSOREN
( Stand 26-02-2010 )
SOME REFERENCES FOR COMP - TRADE COMPRESSORS: AUSTRIA WARPED SPORTS 1 x CTC 100 P TAUCHER 1 x CTC 100 P 1 x CTC 100 E3 EL-TEAM (TAUCHSTATION) 1 x CTP 100 E DIVING 2 x CTC 100 E3 HOFER 1 x CTC 100 E3 HIRTENBERGER 1 x CTC 100 E3 PENSION BERGDOKTOR 1 x CTP-F 200 HAUPTFEUERWEHRWACHE FIRE STATION KLAGENFURT 1 x CTP-F 750 FFW VIECHTWANG 1 x CTP-F 250 INDUSTRY 1 x CTP-250 N2 6 x CTP-S 750 E3 BULGARIA FEUERWEHRSTATION 2 x CTP 100 E FIRE STATION 1 x CTP-F 200 BELGIUM FIRE TRUCK MAN. 3 x CTC 100 E3 2 x CTP-B 200 E3 SOMATI-FIRE TRUCKS 2 x CTP-B 200 Silent BRUNEI FIRE STATION 1 x CTP-S 250 E3 + Storage FIRE STATION 1 x CTP-S 550 E3 + Storage FIRE STATION SCHOOL 1 x CTP-F 260 P MOBILE CHINA FIRE STATION 10 x CTC 100 E3 2 x CTP-S 250 E3 CROATIA BEZIRKSFEUERWEHREN 10 x CTP 100, DISTRICT FIRE STATIONS 4xCTP-F 200, 4 x CTP 200 DEUTSCHLAND PKG 1 x CTC 100 E1 R. KUHN GMBH. 1 x CTP-F 150 E3 SCHUBACK 1 x CTC 100 E1 2 x CTP-F 750 E3 EGYPT FIRE STATION 1 x CTC 100 E3 2 x CTP 100 E 1 x CTP 150 P 4 x CTP 300 E3
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
EGYPT 1 x CTP-F 250 E 4 x CTP-F 300 E3 1 x CTP-F 550 E3 ESTONIA HAUPTFEUERWEHRWACHE TALLINN 1 x CTP-F 550 BEZIRKSFEUERWEHREN 1 x CTP-200 Silent ESTONIA RESCUE BORD TALLINN 3 x CTP-S 450 Silent DISTRICT FIRE STATIONS 9 x CTP – F 450 FINLAND BEZIRKSFEUERWEHR 12 x CTP-F 200 E DISTRICT FIRE STATIONS 1 x CTP-F 250 GERMANY FEUERWEHR NEUNBURG 1 x CTP 550 with external FR FIRE STATION NEUNBURG 1 x CTP-F 250 10 x CTP-F 300 E3 LUKAS HYDRAULIK 26 x CTC 100 P FIRESTATION 6 x CTC 100 P 1 x CTP 250 E3 GREAT BRITAIN NOC 1 x CTC 100 E3 GREECE HELLENIC NAVY FAST 21 x CTP-F 250 PATROL BOATS 4 x CTP-F 250 FIRE TRAINING SCHOOL HONG KONG / CHINA STADTFEUERWEHREN 4 x CTP 200 (PLOVER ENG.) FIRE STATIONS 3 x CTP 100 4 x CTP 150 1 x CTP 450 4 x CTP-B 200 E (Booster) 1 x CTP-F 200 truck mounted 1 x CTP-F 250 E3 1 x CTP-F 300 E3 3 x CTP-F 550 E3 3 x CTP-S 200 1 x CTP-S 600 FIRE STATION AUDI GYOER 2 x CTP-F 650 E3 1 x CTP-S 250 HUNGARY LOCAL FIRE STATION 2 x CTP 70 19 x CTC 100 22 x CTP 100 1 x CTP 150 3 x CTP 200 1 x CTP 250 D 1 x CTP-B 200 E3 4 x CTP-F 250 1 x CTP-F 650 E3 1 x CTP-S 200
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
008-01 Reference list.doc
HUNGARY FW INSTITUT 1 x CTP 200 DISTRICT FIRE STATION SZASA 1 x CTP 500 DISTRICT FIRE STATION SZOMBA THELY 2 x CTP-BM 200 EH (Booster) 3 x CTP-B 200 E (Booster) FIRE STATION AUDI GYOER 2 x CTP-F 650 E3 1 x CTP-S 250 INTERSPIRO FÜR FEUERWEHREN WELTWEIT 1 x CTP 100 – 550 GROUP FOR FIRE STATIONS WORLD-WIDE 1 x CTP 250 E3 6 x CTP-F 300 E3 INDIA NAVY 4 X CTC 100 FIRE STATION 1 x CTC 100 Honda 1 x CTP 100 P FIRE STATION AHMEDABAD 3 x CTP-F 200 for truck-install. SHIP CARE 19 x CTC 100 SHIPYARD ABG 8 x CTC 100 P 4 x CTC 100 E3 1 x CTP 150 E3 1 x CTP-F 450 exprofed FIRE STATION 2 x CTP-F 650 E3 INTERSPIRO / IND. NAVY 5 x CTC 100 P 5 x CTP 200 Honda Petrol INDIA 1 x CTP 250 Honda Diesel SABRE INDIA 1 x CTP-F 450 E SHIP YARDS BHARATY 7 x CTP-F 200 E3 SHIP YARDS TEBMA 16 x CTC 100 E3 22 x CTP 200 E3 INDONESIA FIRE STATION 1 x CTC 100 P 8 x CTC 100 E1 3 x CTP 100 E3 5 x CTP 150 E 2 x CTP 200 DHo IRAN RESCUE 2 x CTC 100 16 x CTC 100 P 20 x CTP-F 150 E3 ITALY FIRE STATION 6 x CTC 100 E1 28 x CTC 100 E3 13 x CTP 200 E3 1 x CTP 250 DHO 4 x CTP 300 DHA 1 x CTP-F 250 E3 3 x CTP-F 300 E3 2 x CTP-F 550 E3 2 x CTP-F 550 DHA 1 x CTP-S 250 E3
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
ITALY 1 x CTP-S 550 E3 1 x CTP-S 750 E3 SHIPYARD FINCANTIERI 24 x CTC 100 E3 AIRFORCE SERVICE STATION 2 x CTP-S 150 E3 FIRE STATION CRUISE SHIP 1 x CTP-S 550 E3 KOSOVO FIRE STATION 1 x CTP 100 P KOREA FIRE STATION 1 x CTP 250 2 x CTP 100 EM 1 x CTP 70 10 x Aircheck LITAUEN FIRE STATION 2 x CTP 250 P 2 x CTL 300 LUXEMBOURG BEZIRKSFEUERWEHREN 2 x CTP-S 250 DISTRICT FIRE STATIONS MALAYSIA ABF 1 x CTP-F 250E NAVY 1 x CTP-150 E 1 x CTP-F 150 H PETRONAS 2 x CTP 100 H 2 x CTP-S 450 FIRE AND RESCUE DEPARTMENT 185 x CTP-F 250 H OF MALAYSIA MAZEDONIEN INFO PROTECT 2 x CTC 100 P NETHERLANDS RESQTEC 1 x CTC 100 E1 6 x CTL 300 1 x CTP-F 300 + Storagesys. NORWAY SHIP CARE 14 x CTC 100 E1 56 x CTC 100 E3 1 x CTP 150 E3 PORTUGAL BEZIRKSFEUERWEHREN Booster Compressor DISTRICT FIRE STATIONS 1 X CTC 100 P 1 x CTP 100 1 X CTC 100 E3 4 x CTP 150 E3 1 x CTP 200 DHo 1 x CTP-B 250 Silent 1 X CTP-F 200 1 X CTP-F 550 E3 1 X CTP-S 300 E3 1 X CTP-S 550 E3
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
008-01 Reference list.doc
POLAND BEZIRKSFEURWEHREN 2 x CPT-F 450, DISTRICT FIRE STATIONS 1 x CTC 100 E1 1 x CTC 100 E3 5 x CTC 100 P 1x CTP 150 E3 1 x CTP 200 1 x CTP 250 E3 17 x CTP-F 200, 88 x CTP-F 250 E 2 x CTP-F 300 E 1 x CTP-S 250 E3 1 x CTP-S 450 SHIPYARDS 40 x CTP-N2 150 E3 10 x CTP-N2 200 E3 POLAND SHIPYARDS 1 x CTP-N2 300 E3 1 x CTP-N2 550 E3 1 x CTP-N2 670 E3 ROMANIA BEZIRKSFEUERWEHREN 8 x CTC 100 E1 (DRÄGER ROMANIA) DISTRICT FIRE STATIONS 3 x CTP 100 SINGAPORE FIRE ACADEMY 1 x CTP 100 E3 ( SK FIRE ) 5 x CTP 100 P 1 x CTP-F 250 P 1 x CTP-F 250 1 x CTP-F 450 Diesel Mobil 1 x CTP-S 250 E3+Storage SYRIEN FIRE STATIONS 1 x CTP 200 E3 15 x CTP-F 250 P 1 x CTP-F 300 E3 RUSSIA FIRE STATIONS 2 x CTP 70 P 103 x CTC 100 E1 1 x CTC 100 P 21 x CTP 100 E3 21 x CTP 150 E3 1 x CTP 150 P 1 x CTP 250 P 40 x CTP 200 E3 2 x CTP 200 P 16 x CTP 250 E3 1 x CTP 250 Dho 1 x CTP 300 E3 1 x CTP 300 P RUSSIA 1 x CTP-B 250 DHo 17 x CTP-F 200 E3 13 x CTP-F 250 E3 1 x CTP-F 300 E3
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at
RUSSIA 7 x CTP-F 450 E 4 x CTP-F 550 E 1 x CTP-F 620 E3 2 x CTP-F 750 E3 2 x CTP-S 150 E3 4 x CTP-S 250 E3 2 x CTP-S 300 E3 1 x CTP-S 550 E3 SLOVAKIA BEZIRKSFEUERWEHREN 1 x CTC 100 E1 DISTRICT FIRE STATIONS 2 x CTP 100 8 x CTP 150 E 1 x CTP-F 250 E3 + Speicher 1 x CTP-S 250 SYRIA CIVIL DEFENCE 2 x CTC 100 E3 35 x CTC 100 P 35 x CTP 250 DHo 5 x CTL 300 P TAIWAN STADTFEUERWEHREN 4 x CTP 100 FIRE STATION 1 x CTC 100 E1 1 x CTP 150 E3 3 x CTP 200 2 x CTP 450 2 x CTP-F 250 1 x CTP-F 450 truck mounted 1 x CTP-F 300 E3 2 x CTP-F 650 Diesel truck m. MINISTRY OF DEFENSE 13 x CTP-B 250 H with
booster HAZMAT OF CHEMICALS Storage Cyl.and Fragm. Pack TSCHECHIEN HAUPTFEUERWEHRWACHE BRÜNN 1 x CTP 250 Silent (DRÄGER AUSTRIA) BEZIRKSFEUERWEHREN 1 x CTP 200 MAIN FIRE STATION BRNO 1 x CTP-F 150 DISTRICT FIRE STATIONS 1 x CTC 100 3 x CTP-F 200 2 x CTP-S 200 SILENT TRELLEBORG FEUERWEHRSTATIONEN IN RUSSLAND 1 x CTP 100, CTP 70 SWEDEN FIRE SERVICES IN RUSSIA 1 x CTP-F 150 1 x CTP-F 250 TURKEY BEZIRKSFEUERWEHREN Booster Compressor BEZIRKSFEUERWEHREN 1 x CTC 100 E1 DISTRICT FIRE STATIONS 6 x CTP 100 1 x CTP-F 150 E3 PETROLEUM REFINERY 2 x CTP-F200 CIVIL DEFENCE 3-x CTP 200 Honda 25 x CTP 150 H
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GmbH
A – 3052 Innerfurth 2 Tel: +43 2774 6364 / Fax: +43 2774 63645 / eMail: [email protected] / www.comptrade.at
008-01 Reference list.doc
TURKEY NAVY 9 x CTP 200 P 2 x CTP 320 FIRE STATION ISTANBUL 1 x CTP-F 250 E 10 x CTP-F 300 E3 FIRE STATION DIARBAKIR 4 x CTP 150 P FIRE STATION TURKEY 1 x CTP 200 E3 FIRE STATION ANKARA/ISTANBUL 4 x CTP 450 E3 FIRE STATION TURKEY 23 x CTC 100 E1 2 x CTP 200 Dho 10 x CTP-S 550 E3 UKRAINA FIRE STATION 1 x CTC 100 E1 1 x CTP-B 300 E 3 UNITED KINGDOM NOC 1 x CTC 100 E3
COMP – TRADE AUSTRIA Feuerwehr- und sicherheitstechnische Ausrüstung
COMP TRADE AUSTRIA
Feuerwehr- und sicherheitstechnische Ausrüstungs-, Handels- und Beteiligungs GesmbH A – 3052 Innerfurth 2
Tel: +43 2774 6364 / Fax: +43 2774 63645 / E-Mail: [email protected] / www.comptrade.at Bank: Bank AustriaCreditanstalt Tulln Kto No. 0478-32407/ 00 Firmenbuch No. 139101K / UID No.: ATU 39664902
Stand: Feb 2008 008-02 Ref.letter for applic.doc
Leaflets and Reference – Pictures
Innerfurth, 2009
Dear sirs,
More and more we are again established in European and also some oversee
countries and wellknown for non-standard high and low pressure breathing air
stations.
With these pictures we want to show up, that our product range not only contains the
standard versions but also includes specifically developed parts , which made the
use of the filling station and the breathing air regeneration effective, save , with good
value and in full compliance with national and international breathing air quality
standards. Through our own production of parts and accessories, the development
of additional elements to contribute to the distribution and monitoring of the breathing
air, and so with COMP TRADE AUSTRIA
is in the position to offer a complete program of high pressure filling systems.
Therefore you are welcome also with non-standard inquiries.
With best regards
COM TRADE AUSTRIA
Friedrich Bös