high power density converter for hev
TRANSCRIPT
-
8/3/2019 High Power Density Converter for HEV
1/21
High Power Density
Converterfor
HEV
Presented by:-
-
8/3/2019 High Power Density Converter for HEV
2/21
IEEE Paper
High Power Density 3-level Converter with
Switched Capacitors aimed for HEV byMitsuaki Hirakawa, Masao Nagano, YasutoWatanabe, Keigo Andoh, Somei Nakatomi,Satoshi Hashino and Toshihisa Shimizu
-
8/3/2019 High Power Density Converter for HEV
3/21
Enlightened Area
HEV
Boost converter
3-level DC/DC converter with SC
Experimental results
Reduction of emission noise
conclusion
-
8/3/2019 High Power Density Converter for HEV
4/21
Introduction to HEV Hybrid Electrical Vehicle (HEV)
combines an ICE propulsionsystem with an electricalpropulsion system.
Types are Series
Parallel
Power-split
Performance basically dependsupon the progress of battery.
-
8/3/2019 High Power Density Converter for HEV
5/21
Power requirement for HEV
To match the driving performance of conventionalgasoline-powered vehicles, the electrical power systemsof HEV need to be supplied with 50KW from batteries.
To achieve this amount of power densities boost
converter is used as an intermediate between thebatteries and the inverter which is connected to thedriving motor.
-
8/3/2019 High Power Density Converter for HEV
6/21
Boost converter Drive the output with required higher voltage than
that of available.
Achieved through proper switching ofswitches(typically semiconductor switches likeIGBT) and filtration with passive elements likeinductor and capacitor.
Boost converter has drawbacks of cost, size,weight.
-
8/3/2019 High Power Density Converter for HEV
7/21
For electrical power system of HEV required highpower densities which is achieved with singleinductor chopper circuit, an interleaved circuit, aninterleaved circuit with loose-coupled inductors.
Compensation for reduction in inductor volume issoft switching method.
DC magnetic flux is reduced with an interleavedcircuit with close-coupled inductor (CCIconverter).
Switched capacitor is another way to reduce thesize of inductor
-
8/3/2019 High Power Density Converter for HEV
8/21
3-level DC/DC converter with SC
The neutral point of C1 andC2 is connected to thetotem-pole arm.
It is a bidirectional DC/DCconverter with switchedcapacitor which is requiredfor the use in HEV.
-
8/3/2019 High Power Density Converter for HEV
9/21
Ripple current analysis
=(2 )( 1)
2
D < 0.5 or < 2D > 0.5 or > 2
=( 2)
2
-
8/3/2019 High Power Density Converter for HEV
10/21
Ripple current feature of an auxiliary inductor
It has a consistency in its input current featurecompared to CCI converter
-
8/3/2019 High Power Density Converter for HEV
11/21
Effective current of output capacitor
Maximum effective current of output capacitor is higherfor SC converter
-
8/3/2019 High Power Density Converter for HEV
12/21
Passive components
Input ripple current and flux density kept constant
-
8/3/2019 High Power Density Converter for HEV
13/21
The wattage loss of the capacitor is estimated bymultiplying the ERS in each frequency component andadding them.
-
8/3/2019 High Power Density Converter for HEV
14/21
The previous table is constructed by considering thecooling capability of 10KW/m2 .
From comparison the weight of main passive
components of SC converter is 44% of interleavedconverter and 64% of CCI converter. And also thevolume of main passive components is 43% ofinterleaved converter and 54% of CCI converter.
-
8/3/2019 High Power Density Converter for HEV
15/21
Experimental results
-
8/3/2019 High Power Density Converter for HEV
16/21
Maximum achievable output
power is 42KW and at 20KWmaximum efficiency isachieved with boost ratio of1.25
The rate of switching loss islarger than compare to the
two phase interleavedconverter and CCIconverter.
-
8/3/2019 High Power Density Converter for HEV
17/21
The inductor current has anAC component whosefrequency is twice the
switching frequency
Comparing with theamplitude of ripple currentwith the table, it has ahigher value.
-
8/3/2019 High Power Density Converter for HEV
18/21
When the input is higher than 180V, as given in table,output power go on increase.
At these condition maximum output power of 60KW isachieved. And also 26.8KW/liter of maximum powerdensity was achieved with efficiency exceeding 97.5 forboost ratio of 1.7.
-
8/3/2019 High Power Density Converter for HEV
19/21
Emission noise
Caused due to long electrical cable connectedbetween power source and converter inputterminal.
Direct impact on all sorts of devices for controland communication.
modified
-
8/3/2019 High Power Density Converter for HEV
20/21
References
All references of the above paper Google
Wikipedia
-
8/3/2019 High Power Density Converter for HEV
21/21