factory approved service products ... - mercedes...
TRANSCRIPT
Products
Factory Approved ServiceNovember 2001
ent parts,
r your vehicle model.
hich their reliability, safety
ervice products approved by
Mercedes-Benz USA recommends the use of Mercedes-Benz original parts, replacem
accessories as well as factory approved service products explicitly approved by us fo
We have subjected these parts, accessories and service products to special tests in w
and their special suitability for Mercedes-Benz vehicles have been verified.
Mercedes-Benz original parts, replacement parts, accessories and factory approved s
us are available at your authorized Mercedes-Benz Center.
F
IMvad’deMfiAorenusloap
Agrse
ion please refer to the Operator’s Manual.
1)
A
1
OR VEHICLES WITHOUT FLEXIBLE SERVICE SYSTEM
PORTANT: Engine oils are labeled on the container withrious ACEA (Association des Constructeurs EuropéensAutomobiles) and/or API (American Petroleum Institute)signations of quality. Mercedes-Benz recommends the use ofB approved engine oils listed in the Mercedes-Benz oil speci-
cation sheet 229.1 or 229.3 which also meet ACEA and/orPI classifications listed on the chart below. If a MB approved ACEA quality engine oil is not available, then an API qualitygine oil meeting the below listed API classification can beed. Only engine oils (including synthetic) with any of the fol-wing classification grades, or combinations thereof, areproved.
lways refer to the viscosity chart for the proper viscosityade based on ambient temperature. Note: This chart super-des ALL previously published viscosity charts. For additional
informat
Engine MB Sheet ACEA Classification 1)
API Classification 1)
Gasoline 229.1229.3
A3B3
SHSJ
Diesel 229.1229.3
B2B3B4
CF-4CG-4
only if MB sheet 229.1 or 229.3 is not available
PPROVED ENGINE OILS
FOMthevic
Coveus
gine oil used does not meet the above mentioned stan-gine damage is possible, which is not covered by thes-Benz New car Limited Warranty.
ny oil additives is not recommended by MBUSA andlt in damage to the engine which is not covered by thes-Benz New car Limited Warranty.M
MMVCCCQP7SS
2
R VEHICLES WITH FLEXIBLE SERVICE SYSTEMercedes-Benz recommends only the use of MB approved syn-tic motor oil for all vehicles equipped with the Flexible Ser-e System (FSS) as of Model Year 1998.
nventional petroleum based oils are not recommended forhicles equipped with the Flexible Service System but may beed on older vehicles.
If the endard, enMercede
Use of amay resuMercedeB Approved Synthetic Engine oil MB
Sheet
obil 1 Tri-Synthetic Formula 15W-50obil 1 Tri-Synthetic Formula 0W-40
alvoline SynPower Full Synthetic Motor Oil 5W-40astrol Syntec 5W-50astrol Syntec 10W-40astrol TXT Softec Plus 5W-30uaker State Full Synthetic European Formula 5W-40ennzoil Synthetic European Formula 5W-406 Pure Synthetic Motor Oil 5W-40hell Helix Ultra 5W-30hell Helix Ultra 5W-40
229.1229.1229.1229.1229.1229.3229.1229.1229.1229.3229.3
VSex
ODELS
ATIC TRANSMISSION FLUID 1
matic TransmissionMB part no. 001 989 21 03 10
FLUID (DOT 4 Plus)e Fluid MB Part no. 000 989 08 07 10
(0.75 liter container)MB part no. 000 989 08 07 11(5.0 liter container)
PAD PASTEe Pad Paste MB part no. 001 989 10 51
S GREASE (NLGI Class 01)sing points except front wheel hubs
tinax C
EX GREASE (NLGI Class 2) blocks of sliding/pop-up roof
rication Paste MB part no. 001 989 46 51
ESSOR OIL (R134a)
pressor oil MB part no. Q 1 13 0001
your authorized Mercedes-Benz Center regarding applications.
3
ISCOSITY GRADES FOR MOTOR OILSelect oil viscosity according to the lowest air temperaturepected before the next oil change using the chart below.
ALL M
AUTOM
MB AutoFluid
BRAKEMB Brak
BRAKEMB Brak
CHASSIFor all grea
Shell Re
COMPLFor sliding
MB Lub
COMPR
MB com
1) Please see
FFo
C
H(NFo
MB
HFo
M
LFoco
MM
MFo
37CER
MP Automotive Grease
e your authorized Mercedes-Benz Center regarding applications.
4
LUID GREASE (NLGI Class 00)r door lock pin and striker eye (except G-Class)
astrol CLS Grease
IGH TEMPERATURE ROLLER BEARING GREASELGI Class 2)
r front wheel bearings (except G-Class)
B High Temperature Antifriction earing Grease MB part no. 001 989 23 51 10
YPOID GEAR OIL 1)
r front and rear axle differentials (except G-Class)
B Hypoid Gear Oil MB part no. 001 989 17 03 10
ONG TERM LUBRICATING GREASE (NLGI Class 2)r release bearing, release arm and splines for connecting linkage on level ntrol valves
olykote Longterm 2 PlusB Long Term Grease MB part no. 000 989 63 51
ULTI-PURPOSE GREASE (NLGI Class 2)r all greasing points except front wheel
52 Almaguard Vari-Purpose Lubricantastrol LM Greasexxon Multi-Purpose Greaseenolit MP
Unocal
1) Please se
EM
Cretoroviwhapror
IELD WASHER CONCENTRATE
erwash Formula VR9422
o. 001 986 44 71 10 (40 ml)
Mixing Ratio (1:100)
windshield washer solvent (commercially available blue n 1 gallon container)
reMBSummer-wash
Added to Water Solvent 1)
e
F)
F)
40 ml
40 ml
added to
added to
1 Gallon
1 Gallon
5
NGINE COOLING SYSTEMB Anti-Corrosion/Anti-Freeze MB part no. Q 1 03 0002
aution! The use of aluminum components in M-B enginesquires that anti-corrosive/anti-freeze specifically formulated protect aluminum parts be used. Failure to use MB anti-cor-sive/anti-freeze may result in a significantly shortened ser-ce life. While there may be a number of products availablehich will provide the required protection, all such productsve not been tested for Mercedes-Benz vehicles. The aboveoduct is suitable for our engines and can be mixed with theiginal anti-corrosion/anti-freeze filled in at the factory.
WINDSH
MB Summ
MB part n
Suggested
1) Pre-mixedconcentrate i
AmbientTemperatu
Summer us
(above 32o
Winter use
(below 32o
S
AM
SMPe
E
SMor
HFoE-
M
4-Mor
D DEXTRON III AUTOMATICSSION FLUID 1)
xtron-III/Mercon ATF F-30341nsmax M-22257 / 22096TF Dextron III F-30108 / 30159i-Purpose ATF D-21571erflo ATF Dextron III F-30111TF Mercon/Dextron-III F-30321F Mercon/Dextron-III F-30321TF D-22413 / F-30110te Dextron-III/Mercon F30161F Dextron-III/Mercon F-30176lti-Purpose ATF D-22413 / 22431TF Type D
ur authorized Mercedes-Benz Center regarding applications.
6
and CL-Class
CTIVE BODY CONTROL FLUIDB ABC Fluid MB part no. 001 989 24 03 10
TEERING GEAR LUBRICANT - POWER STEERINGB Power Steering Fluid MB Part no. 001 989 24 03 10ntosin CHF11S
-Class
TEERING GEAR LUBRICANT - POWER STEERINGB Power Steering Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6
YDRAULIC OILr tandem pumps with common oil reservoir for steering and level control in class, Model Year 1996 and newer.
B Hydraulic Oil MB part no. 001 989 20 03 10
MATIC TRANSFER CASE LUBRICANTB Transfer Case Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6)
APPROVETRANSMI
Castrol DeCastrol TraChevron ACitgo MultExxon SupHavoline ATexaco ATPennzoil AQuaker StaSunoco ATUnocal MuValvoline A
1) Please see yo
C
MFo
MT
S
MPe
SM
SM
CHFo
M
SMor
ss
ULIC OILeveling system, hydropneumatic suspension, hydraulic soft top
raulic Oil MB part no. 000 989 91 03 10
NG GEAR LUBRICANT - POWER STEERINGer Steering Fluid MB Part no. 000 989 88 03
proved Dextron III ATF, see page 6
lass
CHARGER OIL - Engine M111 EVOercharger Oil MB Part no. 000 989 62 01
CHARGER OIL - Engine M112et Oil II
NG GEAR LUBRICANT - POWER STEERINGer Steering Fluid MB Part no. 000 989 88 03
proved Dextron III ATF, see page 6
ULIC OILulic soft top
raulic Oil MB part no. 000 989 91 03 10
7
-Class
ANUAL TRANSMISSION FLUIDr MB manual transmission - 6 speed
B Manual ransmission Fluid MB part no. 001 989 26 03
TEERING GEAR LUBRICANT - POWER STEERING
B Power Steering Fluid MB Part no. 001 989 24 03 10ntosin CHF11S
UPERCHARGER OIL - Engine M111 EVOB Supercharger Oil MB Part no. 000 989 62 01
UPERCHARGER OIL - Engine M112obil Jet Oil II
LK-CLASSYDRAULIC OILr hydraulic soft top
B Hydraulic Oil MB part no. 000 989 91 03 10
TEERING GEAR LUBRICANT - POWER STEERINGB Power Steering Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6
SL-Cla
HYDRAFor load l
MB Hyd
STEERIMB Powor an ap
SLK-C
SUPERMB Sup
SUPERMobil J
STEERIMB Powor an ap
HYDRAFor hydra
MB Hyd
SMFo
MTFo
MT
M
S
Mor
TMor
s
FER CASE LUBRICANTnsfer Case Fluid MB Part no. 001 989 28 03
ERM LUBRICATING GREASE (NLGI Class 2) ller shafts - universal joints
g Term Grease MB part no. 000 989 63 51
EMPERATURE ANTIFRICTION GREASElass 2)
ousing
h Temperature Antifriction MB Part no. 001 989 23 51 10
-PURPOSE GREASEwheel bearings
lti-Purpose Grease MB Part no. 000 989 28 51
ETIC AXLE OILand rear differentials
thetic Axle Oil MB Part no. 001 989 27 03 10
8
LK-Class (continued)
ANUAL TRANSMISSION FLUIDr MB manual transmission - 6 speed
B Manual ransmission Fluid MB part no. 001 989 26 03r MB manual transmission - 5 speed
B Manual ransmission Fluid MB part no. 000 989 26 03
-Class
TEERING GEAR LUBRICANT - POWER STEERING
B Power Steering Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6
RANSFER CASE LUBRICANTB Power Steering Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6
G-Clas
TRANSMB Tra
LONG TFor prope
MB Lon
HIGH T(NLGI CFor joint h
MB HigGrease
MULTIFor front
MB Mu
SYNTHFor front
MB Syn
GBFo
M
SMor
LFo
EEM
CFo
M
9
-Class (continued)
RAKE FLUIDr differential lock mechanism
B Brake Fluid (DOT 4 Plus) MB Part no. 000 989 08 07 10(0.75 liter container)MB part no. 000 989 08 07 11(5.0 liter container)
TEERING GEAR LUBRICANT - POWER STEERINGB Power Steering Fluid MB Part no. 000 989 88 03 an approved Dextron III ATF, see page 6
IQUID GREASE (NLGI Class 00)r door locks
xxon Mobil Chassis Grease LBZxxon Mobil Grease TCL 435B Liquid Grease MB part no. 001 989 08 51 10
OMPLEX GREASE (NLGI Class 2)r sliding blocks of sliding/pop-up roof
B Lubrication Paste MB part no. 001 989 46 51
F
1.
Rtaanthbeno
Mwalreva
G
Aupusbu
extended period of using fuels without such additives,deposits can build up, especially on the intake valvesthe combustion area, leading to engine performances such as:
m up hesitation,
table idle,
cking /pinging,
fire,
er loss.
T blend other fuel additives with the fuel. These addi-dditives only result in unnecessary cost and may be to engine operation.
or malfunction resulting from poor fuel quality ornding additional fuel additives are not covered by theDES-BENZ Limited Warranty or by any pre-owned ord Limited warranties.
del year 1986, all gasoline models except 190E 2.3premium unleaded gasoline. As of model year 1987, all engines require premium unleaded gasoline.
10
UEL REQUIREMENTS
Gasoline Engines
eformulated gasolines (RFG) and/or unleaded gasoline con-ining oxygenates such as Ethanol, TAME, ETBE, IPA, IBA,d TBA can be used provided that the ratio of any one ofese oxygenates to gasoline does not exceed 10%. MTBE may added up to 15%. The ratio of Methanol to gasoline mustt exceed 3% plus co-solvents.
ixtures of Ethanol and Methanol must not be used. Gasohol,hich contains 10% Ethanol and 90% unleaded gasoline, canso be used. These blends must also meet all other fuelquirements such as resistance to spark knock, boiling range,por pressure, etc.
asoline Additives
major concern among engine manufacturers is carbon build- caused by gasoline. MERCEDES-BENZ recommends toe only quality gasoline containing additives that prevent theild up of carbon deposits.
After ancarbon and in problem
• war
• uns
• kno
• mis
• pow
DO NOtional aharmful
Damagefrom bleMERCEExtende
For morequire gasoline
UD91R(MK
Conunlo
•
•
•
•
ears 1975 - 1985 and model year 1986 190 E 2.3
eaded regular gasoline meeting ASTM standard D439.ne number posted at the pump must be at least 87 min.
ears 1972 - 1974
aded or unleaded gasoline meeting ASTM standardhe octane number posted at the pump must be at least
When only unleaded gasoline is being used, check thelearance on engines with mechanically adjustablet half the recommended interval.
el year 1972
mium unleaded gasoline meeting ASTM standardhe octane number posted at the pump must be at least Check the valve clearance at half the recommended
l Engines
y commercially available vehicular diesel fuel numberber 1 (ASTM D975 Number 2-D or Number 1-D).
rmation on cold weather operation, refer to the vehicler’s Manual or Service Information 00/007(11-82).
11
se only premium unleaded gasoline meeting ASTM standard439. The octane number posted at the pump must be at least min. In the U.S., this octane number is an average of the
esearch octane number (R) and the Motor octane number): (R + M) / 2. The octane number is also known as the Anti-
nock Index.
aution! To maintain the engine’s durability and performance,ly premium unleaded gasoline is to be used. If premiumleaded is not available and low octane gasoline is used, fol-w these precautions:
Partially fill the fuel tank with unleaded regular gasoline and fill up with premium unleaded as soon as possible.
Avoid full throttle driving and abrupt acceleration.
Do not exceed an engine speed of 2000 rpm if the vehicle has a light load (two occupants and no luggage for exam-ple).
Do not exceed 2/3 of maximum accelerator pedal position if the vehicle is fully loaded or operating in mountainous terrain.
Model y
Use unlThe octa
Model y
Used leD439. T87 min.valve cvalves a
Pre-mod
Use preD439. T91 min.interval.
2. Diese
Use onl2 or num
For infoOperatoMBNA
Distributor in the United States:
Mercedes-Benz USA, LLC.One Mercedes Drive, P.O. Box 350Montvale, NJ 07645-0350
www.MBUSA.com
Technical Information
©2001 Mercedes-Benz USA, LLCA DaimlerChrysler CompanyOrder No. S-0473-02Q
Printed in U.S.A