Download - study on cactus
CSSR 06 ‘07
1
A STUDY ON CACTUS OPUNTIA AS NATURAL COAGULANT IN TURBID
WATER TREATMENT
By:
Yin Chun Yang1, *, Suhaimi Abdul-Talib
2, Lim Ying Pei
1, Mohd Safirun Nizan Ismail
1,
Siti Nor Aisah Abd-Razak1 and Ahmad Mahyuddin Mohd-Mohtar
1
1Faculty of Chemical Engineering, Universiti Teknologi MARA, 40450 Shah Alam, Selangor, 2Faculty of Civil Engineering, Universiti Teknologi MARA, 40450 Shah Alam, Selangor,
*Corresponding author. Phone: +603-5543 6348, Fax: +603-5543 6300
Email: [email protected]; [email protected]
Abstract
Coagulation is an important wastewater treatment process used to reduce water turbidity and
normally precedes the more complex secondary and tertiary water treatment processes. In this
study, the effectiveness of a natural macromolecular coagulant derived from a cactus species for
turbidity removal from estuarine and river waters were evaluated using jar test. Initial turbidity
values measured at 499 NTU and 547 NTU for estuarine and river waters respectively were
reduced by as much as 98% (estuarine) and 70% (river). Other parameters such as pH as well as
alkalinity were also studied. It was indicated that the coagulant did not have a considerable effect
on final pH of the waters. The amount of cactus added was well correlated with the final turbidity
and alkalinity of the waters. High turbidity removal determined in this study indicates that cactus
opuntia has the potential to be utilized for surface water treatment applications.
Keywords: Natural Macromolecular Coagulant, Turbidity, Alkalinity, pH, Estuarine and River
Waters
1. Introduction
Coagulation is an essential process in the treatment of both turbid surface and industrial
wastewaters. Examples of chemical-based coagulants that are available commercially include
lime, alum, ferric chloride and polyaluminium chloride. While the effectiveness of these
chemicals as coagulants are well noted (Edzwald, 1993; Kang et al., 2003), there are, nonetheless,
disadvantages linked with usage of these coagulants such as comparatively high costs, harmful
effects on human health as well as the fact that they appreciably affect pH of treated waters. As
such, it is desirable to substitute these chemical coagulants with cost-effective natural coagulants
to offset the aforesaid disadvantages. Research on natural coagulants have been focused on
Moringa oleifera seeds (Olsen, 1987; Muyibi and Evison, 1995; Ndabigengesere et al., 1995) for
the past 20 years but more researchers are studying application of other natural coagulants such as
long bean extract and cactus opuntia. It was determined, via two separate studies, that standalone
CSSR 06 ‘07
2
long bean extract (Liew et al., 2004) was ineffective in removing turbidity while cactus opuntia
(Zhang et al., 2006) exhibited high turbidity removal efficiency. Hence, the positive outcome of
the latter study justifies further research on cactus opuntia as a natural macromolecular coagulant.
2. Objectives of Study
The objectives of this study were to evaluate the efficiency of natural coagulant derived from
cactus opuntia for turbidity removal from surface waters (estuarine and river) using jar test and
determine the effect of dosage of cactus powder on turbidity, pH and alkalinity of the waters.
3. Methodology
3.1 Preparation and Characterization of Cactus Powder
Cactus opuntia used in the study was collected from a nursery in Sg Buloh, Selangor. The cactus
was washed with tap water and subsequently sliced into small pieces to facilitate drying. The
sliced cactus was then dried in oven for 8 hours at 80°C. The dried cactus was ground into fine
powders using pestle and mortar and subsequently sieved to sizes 53 – 106 µm. Elemental
analysis of the cactus powder to determine its carbon, hydrogen and nitrogen contents was carried
out using Thermo Electron Flash EA 1112 Elemental Analyzer. The pH of cactus powder was
determined by mixing the powder in distilled water at dosages of 13, 53, 213 and 853 mg/L and
stirred at 130 rpm for 3 minutes prior to measurement.
3.2 Collection of Surface Water Samples
Estuarine water samples were collected from the estuary of Klang river at Port Klang, Selangor. It
was observed that the samples were turbid and brown-yellowish in color. It was presumed that the
samples were contaminated with oil and grease that originated from spent diesel spilled from
boats in addition to other turbid-causing substances such as silt and plankton within the estuary.
River water samples were collected from a river located with Shah Alam, Selangor. These
samples were also turbid possibly due to high concentrations of silt along the river. Both the
CSSR 06 ‘07
3
estuarine and river water samples were collected via grab sampling and stored in plastic
containers prior to immediate experimentation.
3.3 Jar test
Jar test was used to determine the effectiveness of using cactus powder as coagulant. The test was
conducted via jar test apparatus (Chemix Floc-Tester – CL6) using 300 mL-capacity jars (Figure
1). Raw water samples of 300 mL each were stirred at 130 rpm for 3 minutes in which cactus
powder was added during this time. Cactus powder of dosages of 13, 53, 213 and 853 mg/L for
each water samples were tested. This was the mixing stage. After 3 minutes, the coagulation stage
commenced where the samples were stirred again at 80 rpm for 30 minutes. After the coagulation
stage, the samples were allowed to stand for 30 minutes after which treatment was completed
(settling stage). Turbidity, pH and alkalinity of samples before and after jar test were measured
and tabulated. Turbidity values were determined via 2100P HACH Turbiditimeter while pH
values were determined via Mettler-Toledo Delta 320 pH meter. Alkalinity values were
determined by using HACH basic laboratory test kit via Method 8203.
Figure 1. Jar test
4. Results and Discussion
4.1 Characterization of cactus opuntia
Elemental analysis (Table 1) was carried out to provide a preliminary comparison between the
elemental compositions of the cactus with that of a conventional natural coagulant, Moringa
oleifera as determined by Ndabigengesere et al. (1995). In this study, it was determined that
cactus opuntia contained 2.3% nitrogen, 29.4% carbon and 1.7% hydrogen. From Table 1, it was
CSSR 06 ‘07
4
evident that the carbon percentage of both the shelled and non-shelled Moringa were almost twice
the carbon percentage of cactus. This was perhaps attributed to the composition of Moringa
which consisted of more organic matter as compared to cactus. Table 2 shows the pH of the
natural coagulants mixed in distilled water (cactus) and tap water (Moringa). The latter was
determined by Ndabigengesere and Narasiah (1999). Both coagulants were slightly acidic in the
presence of water. It was observed that increased cactus dosages correlated with decreased pH.
Table 1. Elemental analysis of natural coagulants Cactus opuntia Shelled Moringa seeds
a Non-shelled Moringa seeds
a
N (%) 2.3 6.1 5.0
C (%) 29.4 54.8 53.3
H (%) 1.7 8.5 7.7 aAs determined by Ndabigengesere et al. (1995)
Table 2. pH of natural coagulants Cactus opuntia Shelled Moringa seeds
b Non-shelled Moringa seeds
b
Water only 7.00 7.30 7.30
13 mg/L 6.88 - -
53 mg/L 6.50 - -
213 mg/L 6.21 - -
853 mg/L 6.00 - -
50,000 mg/L - 6.40 5.8 bAs determined by Ndabigengesere and Narasiah (1999)
4.2 Effect of Cactus Dosage on Turbidity Removal
It was observed that the powdered cactus formed large flocs with impurities in the sample which
facilitated settling and as a result, clear supernatant was produced. Similar observation was also
noted for treated river water. Figure 1 shows the effect of dosage of cactus powder on turbidity of
the waters. Initial turbidity values measured were 499 and 547 NTU for estuarine and river
waters respectively. Turbidity removal efficiencies after treatment at various dosages range from
93.1 – 98.2% (estuarine) and 49.9 – 69.7% (river). From Figure 2, the optimum dosage for both
waters was approximately 13 mg/L which incidentally, was the smallest dosage used in the study.
This was compared with the finding of a study conducted by Zhang et al (2006) where the
optimum dosage of cactus opuntia used for turbidity removal of seawater (980 NTU) was 60
mg/L. In that study, the highest removal efficiency reached 99% which was comparatively similar
to the highest removal efficiency obtained for treated estuarine water (98.2%) in this study.
CSSR 06 ‘07
5
0
100
200
300
400
500
600
0 100 200 300 400 500 600 700 800 900
Cactus powder (mg/L)
Turbidity of water (NTU)
Estuarine water
River water
Figure 2. Effect of dosage of cactus powder on turbidity of estuarine and river waters
4.3 Effect of Cactus Dosage on pH and Alkalinity of Samples
Initial pH of cactus powder mixed in distilled water was 6.50 (slightly acidic). Figure 3 shows the
effect of dosage of cactus powder on final alkalinity and pH of the waters. It appeared that
increased cactus dosages from 13 to 853 mg/L had a marginal effect on final pH of the waters
with values ranged from 7.25 to 7.69 (estuarine) and 7.83 to 8.49 (river). This result implied that
even though the dosages were substantially increased, final pH values of the waters were
relatively unaffected as compared to usage of chemical-based coagulants. This notion was
reinforced by study conducted by Fatoki and Ogunfowokan (2002) involving coagulation of
turbid river water by means of alum and ferric chloride showed that dosage of 10 mg/L either
chemical constituted pH increase by at least 0.4. It was therefore, anticipated that further increase
in dosage of the chemicals would substantially increase the pH of treated water. It can be seen
that the amount of cactus added was well correlated with the final alkalinity to pH 5.1, albeit at
contrasting trend for the two waters. For estuarine water, increase of cactus dosage from 0 to 853
mg/L represented decrease of alkalinity values from 71.2 to 64.8 mg CaCO3/L. For river water,
initial dosage at 13 mg/L decrease alkalinity values from 104.8 to 91.2 while further increase of
dosages increased alkalinity values from 98.8 mg CaCO3/L (dosage 53mg/L) to 105.6 mg
CaCO3/L (dosage 853mg/L).
CSSR 06 ‘07
6
0
20
40
60
80
100
120
140
160
0 13 53 213 853Dosage of cactus powder (mg/L)
Final alkalinity to pH 5.1
(mg CaCO3/L)
1
2
3
4
5
6
7
8
9
Final pH
Alkalinity of estuarine water Alkalinity of river water
pH of estuarine water pH of river water
Figure 3. Effect of dosage of cactus powder on final alkalinity and pH of estuarine and river
waters
5. Conclusions
It was shown that powdered and dried cactus opuntia was very effective in removing turbidity
from both estuarine and river waters as evident by the high removal efficiencies. It was also
proven that the cactus powder did not have a significant effect on final pH of the waters as
compared to chemical-based coagulants. Increased cactus dosages correlated with decreased pH
of surface water. It can be concluded that cactus opuntia has the potential to be utilized for
surface water treatment applications.
References
Edzwald, J.K. (1993). “Coagulation in drinking water treatment: particles, organics and
coagulants.” Water Science Technology, 27(11), 21 – 35.
Fatoki, O.S. and Ogunfowokan, A.O. (2002). Effect of coagulant treatment on the metal
composition of raw water.” Water SA, 28(3), 293 – 298.
Kang, M., Kamei, T. and Magara, Y. (2003). “Comparing polyaluminium chloride and ferric
chloride for antimony removal.” Water Research, 37(17), 4171 – 4179.
CSSR 06 ‘07
7
Liew, A.G., Noor, M.J.M.M. and Ng, Y.M. (2004). “Coagulation of turbid waters using
extraction of long bean.” Malaysian Journal of Science, 23, 185 - 191.
Ndabigengesere, A., Narasiah, K.S. and Talbot, B.G. (1995). “Active agents and mechanism of
coagulation of turbid waters using Moringa oleifera.” Water Research, 29(2), 703 - 710.
Ndabigengesere, A. and Narasiah K.S. (1998). “Quality of water treated by coagulation using
Moringa oleifera seeds” Water Research, 32(3) 781 – 791.
Muyibi, S.A. and Evison, L.M. (1995). “Optimizing physical parameters affecting coagulation of
turbid water with Moringa oleifera seeds.” Water Research, 29(12), 2689 - 2695.
Olsen, A. (1987). “Low technology water purification by bentonite clay and Moringa oleifera
seeds flocculation as performed in sudanese villages: effects on Schistosoma Mansoni
cericariae.” Water Research, 21(5), 81 - 92.
Zhang, J., Fang, Z., Luo, Y. and Yang, H. (2006). “A preliminary study on cactus as coagulant in
water treatment.” Process Biochemistry, 41(3), 730 – 733.