ISSN 0104-6632 Printed in Brazil
www.abeq.org.br/bjche
Vol. 33, No. 04, pp. 907 - 917, October - December, 2016 dx.doi.org/10.1590/0104-6632.20160334s20150376
*To whom correspondence should be addressed
Brazilian Journal of Chemical Engineering
LEACHING Zn FROM THE LOW-GRADE ZINC OXIDE ORE IN NH3-H3C6H5O7-H2O MEDIA
Ma Ai-yuan1,2,3,4, Peng Jin-hui1,2,3,4, Zhang Li-bo1,2,3,4, Shiwei Li1,2,3,4*,
Yang Kun1,2,3,4 and Zheng Xue-mei1,2,3,4
1Yunnan Provincial Key Laboratory of Intensification Metallurgy, Kunming 650093, China. Phone: + 86 871 65174756; Fax: + 86 871 65138997 E-mail: [email protected]; [email protected]
2National Local Joint Laboratory of Engineering Application of Microwave Energy and Equipment Technology, Kunming, Yunnan 650093, China.
3Key Laboratory of Unconventional Metallurgy, Ministry of Education, Kunming 650093, China. 4Faculty of Metallurgical and Energy Engineering, Kunming University of
Science and Technology, Kunming 650093, China.
(Submitted: March 25, 2015 ; Revised: June 15, 2015 ; Accepted: July 21, 2015)
Abstract - In this research, the effect of different citric acid concentrations, ammonia concentration, temperature, leaching time, stirring speed and liquid-to-solid ratio on the zinc leaching from low-grade zinc oxide ore in a NH3-H3C6H5O7-H2O system were studied. The results showed that the zinc leaching rate is only 4.7% when the citric acid concentration is 0 M, and the leaching efficiency of Zn increased with increasing citric acid concentration. Under the conditions: citric acid concentration of 1.0 M, ammonia concentration of 6 M, temperature of 25 °C, leaching time of 60 min, stirring speed of 300 rpm and the starting solid-to-liquid ratio of 1:5, 81.2% of Zn is leached. The mineralogical changes of the low-grade zinc oxide ores during the processes were characterized by X–ray fluorescence (XRF), X–ray powder diffraction (XRD), Scanning Electron Microscopy associated with Energy Dispersive Spectroscopy (SEM–EDS) and Fourier transform infrared spectroscopy (FT–IR). From the evidence we deduced that citric ions complexed with zinc ions, forming a Zn-citrate complex. As a result, the zinc leaching rate was improved without the risk of pollution or pretreatment. This makes it as a good choice for a more ecological treatment of hemimorphite. Keywords: Low-grade zinc oxide ores; Hemimorphite; Ammonia leaching; Citric acid.
INTRODUCTION
Considering the huge reserves of low grade zinc oxide ores with high alkaline gangue (CaO and MgO) in the world (Li et al., 2010), which is hard to handle by the traditional zinc smelting methods, re-covering zinc from low grade oxide zinc ores has been a matter of discussion recently. The leach-sol-vent extraction-electro-winning process route is the most common method of extraction of zinc from low-grade zinc oxide ores (de Wet and Singleton, 2008). This is a material which can be processed by flotation (Irannajad et al., 2009; Navidi Kashani and
Rashchi, 2008; Li et al., 2013) and acid-leaching methods (Irannajad et al., 2013; Xu et al., 2010; Xu et al., 2012; Li et al., 2010; He et al., 2010; He et al., 2011). However, sulfuric acid leaching could not ef-fectively recover zinc from a low grade oxide ore because of substantial iron dissolution (Yang et al., 2013). Because of the complexities of mineralogical composition and structure, separation of zinc oxide minerals from their gangues by flotation is an ex-tremely complex process (Majid et al., 2014). Hence, with the high consumption of leaching acid, the treat-ment of low-grade oxidized zinc ores by hydrometal-lurgical methods is expensive and complex.
908 Ma Ai-yuan, Peng Jin-hui, Zhang Li-bo, Shiwei Li, Yang Kun and Zheng Xue-mei
Brazilian Journal of Chemical Engineering
The application of alkaline leaching techniques has become an increasingly important aspect in the recovery of base and precious metals from complex low grade zinc oxide ores (Santos et al., 2010; Ding et al., 2010; Yin et al., 2010). However, alkaline leaching processing is often confronted with the problem of low-grade complex ores, especially zinc silicate. The low solubility of these ores does not usually allow for the recovery of the target metal, even by direct chemical leaching in many leaching reagents (Zhao et al., 2009). Extracting zinc from hemimorphite by leaching in sodium hydroxide solu-tion requires high temperature, pressure and alkalin-ity (Chen et al., 2009). Currently, hydrometallurgy in ammonia has been considered as a prospective me-dium for the leaching of complex zinc ores of both oxide and sulfide types (Li et al., 2014).
The use of organic acids for the extraction of metals has been studied by many researchers. It was reported that low molecular weight citric acid has been found to be effective in removing heavy metals by forming soluble complexes and chelates with metal ions (Chen et al., 2003; Hongki et al., 2013), and there is no concern about environmental prob-lems after the treatment. Citric acid was found to be more active than H2SO4. In hydrometallurgical treat-ments, the ability to recover metals or metal oxides depends on their chemical reactivities (Larba et al., 2013). So citric acid seems more appropriate to use as a less costly and more environmentally friendly leachant.
Several papers have been published on the coor-dination of citric acid and transition metals, lead citrate (Kourgiantakis et al., 2000), tungsten citrate (Zhang et al., 2003), aluminum citrate (Matzapetakis et al., 1999) and germanium citrate (Willey et al., 2001). Based on previous work, a new hydrometal-lurgical process for low-grade zinc oxide ore is put
forward. In this work, the effect of the concentration of citric acid, ammonia concentration, temperature, leaching time, stirring speed and liquid-to-solid ratio on the leaching of zinc from low grade zinc oxide ore in the NH3-H3C6H5O7-H2O system was studied. The aim of this work was to develop a new hydro-metallurgical technology, which intends to provide a green and economic method to extract zinc from low-grade zinc oxide ores.
MATERIALS AND METHODS Experimental Materials
The low-grade zinc oxide ores used were given by Lanping County of Yunnan Province, China. The main chemical composition of the low-grade zinc oxide ores obtained by chemical analysis is listed in Table 1. It can be observed that silica (SiO2) and a high content of alkaline gangues (CaO + MgO) are the main components of the ore. The zinc content in this ore, around 6.01%, is considered to be low for a successful pyrometallurgical treatment for zinc re-covery (Dutra et al., 2006), which leads to the greater interest in the hydrometallurgical treatment. The XRD spectrum of the low-grade zinc oxide ore is shown in Figure 1. The XRD analysis shows that silica (SiO2), calcium carbonate (CaCO3), lead carbonate (PbCO3), and hemimorphite (Zn4Si2O7(OH)2·H2O) are the main chemical components. Table 2 for the mineral com-position in zinc shows that the ore contains mainly 67.55% hemimorphite (Zn4Si2O7(OH)2·H2O), 29.78% zinc carbonate (ZnCO3), 1.53% zinc sulfide (ZnS), and 1.05% Franklinite ( ZnFe2O4). Other zinc-con-taining phases, which, on the basis of the chemical analysis, could be present (Table 1) are probably be-low the detection limit.
Table 1: Chemical analysis of the main elements present in the zinc oxide ore.
Element O Si Ca Fe Zn Pb Al C Mg S Weight
(mass %) 46.73 13.03 9.19 8.11 6.01 6.41 4.43 4.30 0.52 0.45
Table 2: Main mineral composition of zinc in ore sample.
Phase composition (Zn4Si2O7(OH)2·H2O) ZnCO3 ZnS ZnFe2O4 Zn Content (mass %) 4.06 1.79 0.092 0.063 Phase occupation ratio (%) 67.55 29.78 1.53 1.05
Enloinanzi
Scanning Energy Dispe
iques were uow-grade zinn Figure 2. nalyze the einc oxide or
Brazilian
Electron Mersive Spectrused for the nc oxide oreThree typicelement distre. It is seen
Fig
Leaching Zn from
Journal of Chem
Figure 1: T
Microscopy aroscopy (SEMmorphologic
e, and the resal phases wtribution in
n that Figure
gure 2: SEM
m the Low-Grade
mical Engineering
The XRD pat
associated wM / EDS) tecal study of sults are sho
were selectedthe low-gra
e 2b (point 1
M image (a) an
e Zinc Oxide Ore
g Vol. 33, No. 04,
ttern of the lo
with ech-
the own d to ade 1 in
thesomin pataigreco
nd EDS patte
in NH3-H3C6H5O
, pp. 907 - 917,
ow-grade zin
e black partsme other methe ore samrts) reveals ining compoey parts), it exist.
erns (b)-(d) i
O7-H2O Media
October - Decem
nc oxide ore.
s) shows thaetal element
mple. Figure the region
ounds. From can be foun
in different a
mber, 2016
at Zn, Si, O, ts are mutuae 2c (point 2ns enriched
Figure 2d (und that Si,
area.
9
Al, Fe, K anally embedde2 in the whi
in lead-co(point 3 in thO, Al, Fe, P
909
nd ed ite n-he Pb
91
E
1
a nth
mthamactileZfiTac
η
w(g(Lthlo
Flo TM
tu
10
Experimenta
The exper49 μm) fract
Two-step l300 mL clo
etic stirrer, ahe leaching p
The generments was as he conical flmmonia (6 Mcid were plaime 1 h andeaching expe
Zn content iniltrate was a
The leaching ccording to t
0Zn
ZnZ
C Vm C
η ×=
×
where Znη (%g/L) the zincL) the leachihe low-gradeow-grade zin
Figure 3: Floow-grade zin
ThermodynaMedium
Citric acid ural formula
al Method
riments usedtion as materleaching exp
osed glass reaand Figure 3 process. ral procedurfollows: 20 gask, 100 mL
M) with diffeaced in the red magneticaleriments we
n the solutionanalyzed by
recovery ofthe following
0 100%Zn
V×
%) is the leacc concentrating volume, e zinc oxide nc oxide ore.
ow diagram nc oxide ore l
amic Analysi
contains threis shown in
Ma Ai-yuan, P
d the −100 +rial. periments weactor equippshows the f
re for the leg of samples L of the soluerent concenteactor at 298lly stirred atere performen was determ
EDTA titrimf zinc (ηZn) g equation (E
ching recoveion of leach
0ZnC (%) the
ore, m (g) t
of the leachleaching.
is for the Zin
ee COO- groun Figure 4.
Peng Jin-hui, Zha
Brazilian Jou
+200 mesh (
re conductedped with a mflow diagram
eaching expewas placed i
ution containtrations of ci.15 K, leach
t 300 rpm. Ted in triplica
mined. Zn in metric methwas calcula
Eq. (1)):
ry of zinc, Ching solution
zinc contentthe mass of
hing process
nc - Citric A
up and its strThe ionizat
ang Li-bo, Shiwe
urnal of Chemica
74-
d in mag-m of
eri-into
ning itric hing The ate. the
hod. ated
(1)
ZnC n, V t of the
for
Acid
ruc-tion
conpKsolof carandiset solbe
6C
K
6C
K
6C
K
a fLapreH2H(ionmospeof tural.et
Fig(C
Ef
tio
ei Li, Yang Kun a
al Engineering
nstants of cKa2=4.76 ; pKlution has a sionized citr
rboxyls are d, upon dissstilled water,al., 2013). Inlution. The dexpressed a
6 8 7 2
a1
H O H O
7.4 10−
+ ↔
= ×
6 7 7
a2
H O (aq) H
1.7 10
−
−
+
= ×
26 6 7
a3
H O (aq) H
4.0 10
−
−
+
= ×
The fractionfunction of papidus, 2014edominates b2(Cit)− specie(Cit)2− appean. Because ore than 9, a ect to Eq. (4zinc citrate
re. The comp, 2005) and al., 1983).
gure 4: Th6H8O7).
RES
ffect of Citri
The study fon on the ex
and Zheng Xue-m
itric acid areKa3=6.40, andstrong acidityric acid are
contained isociation of , 3 M H+ is n fact, not aldissociation s follows (D
3 (aq) 6
41
H O C
, pK 3.
+
−
↔ +
=
2 3 (aq)
52
H O H O
, pK 4
+
−
↔
=
2 3 (aq
73
H O H O
, pK
+
−
↔
=
ns of each cipH at 298.15), where it cbelow pH = es dominatesar and, initiathe pH of tbasic reactio). Few studiecomplexes w
pounds found[Zn(II)(C6H
he structural
SULTS AND
ic Acid Conc
for the effecxtraction of
mei
re as followsd show that y. The main related to t
in one C6Hf 1 mol citritheoretically
all the H+ is rreaction of
Demir et al., 2
6 7 7H O (aq),
.13
−
2) 6 6 7C H O (a
4.76
−+
3q) 6 5 7C H O (a
6.40
−+
itrate species5 K (Zárate-can be note3 and betwes; only aboveating at pH the reaction on was carriees focused owith non-mod are C12H14OH5O7)2 ·4NH
l formula o
D DISCUSSI
centration
ct of citric azinc was c
s: pKa1=3.13the citric acexisting form
the pH. ThrH8O7 molecu
c acid in 1 y produced (released to thcitric acid ca2006):
(2
q), (3
aq), (4
s are shown -Gutiérrez and that H3(Cen 3 and 5 the pH = 5 do= 7, the Citmedium w
ed out with rn the structuolecular struO16Zn3 (Che 4
+ ] (Swanso
of citric ac
ION
cid concentrcarried out b
3 ; cid ms ee
ule L
Li he an
2)
3)
4)
as nd it) he
oes t3−
was re-ure uc-
et on
cid
ra-by
vraFoconzisp2inexdindefinmlein
ceinoretimknac
bwra
Freletwle
arying concange. The a
Figure 5, whif Zn increasoncentrationamely 0 andinc were expectively. Th4.57% to 81ncreased froxtraction as tue to the citrng the C5H7Oissolution offficiencies wng, under the
monia, 1.0 Meaching timen stirring spe
As seen inentration incng the proceusly consumesulting in aion at low c
maximum recnown to drivcid, facilitati
The downe the product
winning or pration of impu
Figure 5: Effecovery fromeaching rate wo steps; theeaching rate
Brazilian
centrations inaverage leacich shows thsed with then. At the lowd 0.05 M, oxtracted in the zinc extr.27% when t
om 0.05 to the citric acitric acid concO5COO- actif zinc contai
were obtainede following le
M in citric ace, 298.15 K ineed. n Figure 5, ancreases the diess of leachmed as it gea possible incitric acid ccovery. An ive the reactioing an increanstream proction of zinc brecipitation ourities.
fect of concem low-graderepresents the first step lin the first st
Leaching Zn from
Journal of Chem
n the 0-1.0 ching rates hat the leache increase ofw citric acid only 4.73% the two-stagraction was the citric aci1.0M. Incre
id concentratcentration efivity, that reining ore. 81d for Zn by tweaching condid concentran temperatur
n increase in issolution raing, citric a
ets convertednsufficient ciconcentrationincrease in con of zinc resase in leachincessing of leby solvent exof Zn2+ after
entration of Ce zinc oxidehe total leachleaching ratetep as shown
m the Low-Grade
mical Engineering
M citric aare shown
ing efficiencf the citric aconcentratioand 24.57%e leaching, improved frd concentrat
easing the ztion increaseffect of increesults in furt1.27% leachwo-stage leadition: 6 M aation, 60 minre, and 300 r
citric acid cte of zinc. D
acid is contind into produitric acid sitns, limiting concentrationsidue with cing. each liquor cxtraction elect
chemical se
C6H8O7 on ze ores. Overhing rate in e represents n in Figure 3.
e Zinc Oxide Ore
g Vol. 33, No. 04,
acid in
cies acid ons,
% of re-
rom tion zinc s is
eas-ther hing ach-am-n in rpm
on-Dur-
nu-uct, tua-the
n is itric
can tro-
epa-
zinc rall the the .
Ef
bythezinaci25rat
moleato in
Figrec Ef
ontioof mobildersul
H3cremaratzinwi Ef
in NH3-H3C6H5O
, pp. 907 - 917,
ffect of Amm
Zinc oxide y two-step lee total ammonc. The leacid concentra °C; stirringtio of 5:1. Th
As shown ionia concentaching effici80.21%. Hoa stable rang
gure 6: Effecovery from
ffect of Temp
An investign zinc extracons were the
effect of amonia concentlity of zinc ir the same clts are shownThe zinc
3C6H5O7-H2Oeased temperained in a cotion under thnc extractionith increased
ffect of Leac
Figure 8 sh
O7-H2O Media
October - Decem
monia Conce
ore sampleseaching to inonia concentrch conditionation of 0.7
speed of 30he results arein Figure 6, trations fromency increas
owever, the sge of approxi
ect of ammolow-grade zi
perature
gation into thction was als
same as thommonia conctration was an the NH3-Hconditions wn in Figure 7
leaching eO system inrature. The zonstant rangehe studied ten was found temperature
ching Time
hows the ef
mber, 2016
entration
s were leachnvestigate thtration on thens were as f75 M; temp00 rpm; and e shown in Fi, with the in
m 2.0 M to 8sed quickly solubility of imately 6 M.
onia concentinc oxide ore
he influence oso performeose detailed centration, eadjusted to 6H3C6H5O7-H2was measure7. efficiency i
ncreased steazinc leachinge, which wastemperature. d to exhibit e.
ffect of leac
9
hed for 60 me influence e extraction follows: citrerature set liquid-to-soligure 6.
ncrease of am.0 M, the zinfrom 23.06zinc remaine.
tration on zines.
of temperatued. The cond
in the sectioexcept the am6 M. The sol
2O system ud, and the r
in the NHadily with ig efficiency rs close to sat
In this studa little impa
ching time o
911
min of of ric at
lid
m-nc % ed
nc
ure di-on m-lu-un-re-
H3-in-re-tu-dy, act
on
91
lemoplioinredd
Flo
Ffr E
actirale
12
eaching efficmin to 90 min
f 0.75 M; amerature set aiquid-to-solidf Zn increaseng time increaction was aemonstrated uration is su
Figure 7: Effeow-grade zin
Figure 8: Efrom low-grad
Effect of Stir
Under the cid concentrion of 6 M, tatio of 5:1, eaching effic
ciency of Znn, maintaininmmonia concat 25 °C; stird ratio of 5:ed from 61.3reased from almost comp that the dur
ufficient to ac
fect of tempernc oxide ores
ffect of leachde zinc oxide
rring Speed
technical paration of 0.7temperature o
the effects ciency were
Ma Ai-yuan, P
n for leachingng citric acidcentration of
rring speed o:1. The leac36% to 79.5320 min to 9
pleted in 60 mration of abouchieve maxim
rature on zincs.
hing time one ores.
arameters as75 M, ammoof 25 °C andof stirring
studied, and
Peng Jin-hui, Zha
Brazilian Jou
g time from d concentratf 6 mol/L; teof 300 rpm; ahing efficien
3% as the lea90 min and min. The resuut 60 to 80 m
mum efficien
c recovery fr
n zinc recov
s follows: citonia concentd liquid-to-so
speed on zd the results
ang Li-bo, Shiwe
urnal of Chemica
20 tion em-and ncy
ach-the ults min ncy.
rom
very
tric tra-olid zinc are
dislea78to a srpmof thicrethiducreBusolficspe
Figfro Ef
usitio0.7rpmlea
incan theof watersystherapmo
ei Li, Yang Kun a
al Engineering
splayed in Faching effici.44% as the 300 rpm, an
significant efm. This is bhemimorphi
in diffusion ease the stirrickness attac
ucing the thiease the reacut the stirrinlid and the d
ciency cannoeed exceeds
gure 9: Effeom low-grade
ffect of Liqu
The leachining various
ons were as 75 M; tempem; and ammach time of 1
Figure 10 screases signiincreased li
e zinc leachinapproximate
ard a possibleristics of zincstem. At a loe zinc ion copidly. Howevost invariable
and Zheng Xue-m
Figure 9. It ency of Zn istirring spee
nd that the stiffect on the recause the aite on the sulayer at the ring speed reched to the ckness of thction rate anng cannot ddiffusion layeot be substan350 rpm.
ect of stirrine zinc oxide
uid-to-Solid R
ng efficienciliquid-solid follows: cit
erature of 25monia concen
h. The resultshows that thificantly fromquid/solid rang efficiencyely 5:1. This e cause of thc oxide ore iow liquid-soloncentrationver, the zince in the range
mei
can be obseincreased fro
ed increased tirring speed recovery of ammonia leaurface of the
solid-liquidreduces the dsolid surfac
he diffusion nd the dissodestroy adheer, so the zinntially increa
ng speed on ores.
Ratio
ies of zinc wd ratios. Thetric acid con
5 °C; stirringntration as 6ts are shownhe zinc leachm 65.75% toatio from 3 ty remained in observation
he difficult lein the NH3-Hlid ratio (fro
n in the soluc leaching efe of 5:1 to 7:1
erved that thom 63.72% from 200 rpdoes not havzinc after 30
aching proce solid forms
d interface. Idiffusion layce, thereby r
layer, and iolving procesesion betweenc leaching eased when th
zinc recove
were evaluatee leach condncentration
g speed of 306 mol/L andn in Figure 10hing efficienco 80.85% wito 7. Howeven a stable rangn may point taching chara
H3C6H5O7-H2om 3:1 to 5:1ution increasefficiency is a1. The possib
he to
pm ve 00 ess s a In-yer re-in-ss. en ef-he
ery
ed di-of 00
d a 0. cy ith er, ge to-ac-2O 1), ed al-ble
calodmb
Fre F
stsytero
F
ciwvri
ause of this ow liquid-soiffusion proc
mainly in they chemical r
Figure 10: Eecovery from
FT-IR Analy
In order totructure, we ynthesized cechniques. Toom tempera
Figure 11: FT
The FT-Initric acid and
were recordedibrationally ic and symm
Brazilian
problem is olid ratio mcess and thee concentratireaction cont
Effect of liqm low-grade z
sis
o obtain morestudied the
compound uThe experimeature are show
T-IR of differe
nfrared spectrd different cid in KBr anactive carboxmetric vibra
Leaching Zn from
Journal of Chem
that the exmight be cone diffusion reion gradienttrol in the lat
quid-to-solidzinc oxide or
e informatioe vibrational using FT-IRental IR specwn in Figur
ent citric acid
ra (400-4000itric acid lea
nd revealed txylate groupations for t
m the Low-Grade
mical Engineering
xtraction ratentrolled by esistance ex, but is maiter stage.
d ratio on zres.
n on the crysspectra of
R spectroscoctra recordedre 11.
d concentratio
0 cm−1) of soaching solutiothe presence
ps. Antisymmhe carboxyl
e Zinc Oxide Ore
g Vol. 33, No. 04,
e at the ists inly
zinc
stal the
opic d at
ons.
olid ons
e of met-late
grosenstrcarThυs13vibwh13ricrevwime(Ctheordmybantheingshiditat droanionvarescoass
tioeffgrocanacicarpo RC M Ch LeXR
duterbypat
in NH3-H3C6H5O
, pp. 907 - 917,
oups of the nt in the sretching vibrrboxylate ca
he correspon(COO−) for 50-1550 cmbration peakhich shifted 97 cm-1) com
c stretching vealed the ioith metal catietric and antOO−)), was e citrate carbdinated to zyrsi et al., 2nd at 3496 ce citrate ligang intermolecifted to lowetion, the com3496 cm−1,
oxyl group od involved inized and thulues (Zárate-spect, it couordination tosembly. Steer and G
on might be fects from Loups attachen play an ids are only rboxylate an
otentially alte
-COO +MO
– metal; R –
haracterizat
eaching ResRF
The X-ray ue was perforrns of the ley 1 M citric attern of leac
O7-H2O Media
October - Decem
coordinated spectra. In ations υas (C
arbonyls in thnding symme
the same grm−1 (Kaliva eks (VC=O: 17
to lower frempared with
vibrations aonized COO−
ions. The difisymmetric sgreater than
boxylate grouinc in a mo
2001). Presencm−1 shows tnd is protonacular H bonder frequency
mpound givesattributed to
of water. Wen coordinatius undergo d-Gutiérrez anuld employ o zinc ion(s)
Griffiths (201better explaewis acid/ba
ed to the carimportant ropartially dis
nion (RCOO−
er the extracti
RCOOM
– organic sub
tion of the L
idue Chara
characterizarmed after th
eached residuacid are showch residue ob
mber, 2016
d citrate ligaparticular,
COO−) were pthe range 15etric stretchroups were pet al., 2006).740 cm−1) oequencies (1free citric ac
and symmet− groups fromfference betwstretches, (
n 200 cm-1, iups were eith
onodentate fance of a brothat the hydrated. Becausd, the absor
y (Che et al.,s a strong abo the vibrati
e found that ion to zinc mdeprotonationnd Lapidus, all of its capossibly pro
13) noted thaained by subase theory. Trboxylic acidrole. Althougssociated ‘we−) shown in
tion capabilit
2M+H O
bstituent grou
Leaching Res
acterization
ation of the he process. Tue obtained wn in Figurebtained was
9
nds were prantisymmetrpresent for th62-1630 cming vibrationpresent aroun
The carboxof citric aci1579 cm-1 ancid. Asymmetric vibrationm AC chelateween the sym(υas (COO−)-indicating thher free or c
fashion (Tsaroad absorptioroxyl group se of the exisrption band , 2005). In absorption banion of the hthe citrate li
may further bn at higher p2014). In th
arboxylates omoting a ne
at zinc extrabstituent grouThe substitued functionaligh carboxyleak acids’, thEq. (5) cou
ty.
(5
up.
sidue
by XRD an
leaching resThe XRD pawith leachin 12. The XRmatched wi
913
re-ric he
m-1. ns nd
xyl id, nd et-ns ed m--υs hat co-ra-on of st-is
ad-nd
hy-ig-be
pH his in
ew
ac-up ent ity lic he
uld
5)
nd
si-at-ng
RD ith
91
thacdPSreleacmstlacob
at3pac
inmspdow
14
hat of the rawcid, the peak iminished s
PbCO3 diminiO2 and CaCecovery of Zeaching, the cterized as n
may be used tock feed forandfill, if avontents, subjility study in
Chemical t 6.0 M am00 rpm, solierature of 2cid leaching
The resultng citric aci
markedly whpondingly. Tue are quarxide mineral
with the disso
Table
w ore. Obvioufor hemimor
significantly. ished margin
CO3 were notZn is directlleaching res
non-hazardouas material r steel maki
vailable, depject to an econ each case. composition
mmonia concid-liquid rati5 °C after 0are shown ins in Table 3 id concentrahile the Zn The main mirtz and smals of iron, le
olution of sili
3: Analysis
Concentration(M)
Zn (wt.%) Si (wt.%) Fe (wt.%)
Ma Ai-yuan, P
usly, in the prrphite (Zn4Si However, nally and thet diminishedly related tosidue can theus solid wastfor road conng plants, orending on thonomic and
ns of the resentration, stio of 5:1and0.05, 0.45 ann Table 3. showed that
ation, Si ancontent de
inerals in thell amounts
ead and calciica.
Figure raw ore
of the leach
n
Peng Jin-hui, Zha
Brazilian Jou
resence of cii2O7(OH)2·H2the peaks
e peaks for bd. As the overo hemimorpherefore be chte. This residnstruction orr just placedhe heavy metechnical fea
sidues obtainirring speed
d leaching tend 1.0 M cit
t, upon incrend Fe enrichecreased core leaching reof undissolvium, associa
12: XRD pae.
hing residue
0.05
4.61 13.62
8.40
ang Li-bo, Shiwe
urnal of Chemica
itric 2O) for
both rall hite har-due r as d in etal asi-
ned d of em-tric
eas-hed rre-esi-ved ated
M
chElesivuseressho
of indionlasbri(Fipothe(FiconCathemedislea
atterns of the
after leachi
ei Li, Yang Kun a
al Engineering
orphology o
To obtain maracteristics ectron Microve Spectrosced for the msidue leachedown in FiguThe elemeninteresting a
dicative of thns overlap, thst image in wight particlesigure 13a po
oint 3) on the ions of Oigure 13d), Cnfirm the hi
a, Pb and Al e distributionetal with thscussed abovaching residu
e leaching res
ing in differ
0.45
1.74 14.69
8.98
and Zheng Xue-m
of the Leach
more informaof the main
oscopy assoccopy (SEM morphologicd by 1 M citrure 13. nt distributionaspects. The he signal inthis may or m
which only ons (Figure 13oint 2) and we distributio
O (Figure 13Ca (Figure 1igh content ioxides and Sn map for Zne low conte
ve. The zinc ue, and can b
sidue and
ent citric ac
mei
hed Residue
ation about thmetal eleme
ciated with E/ EDS) tec
cal study ofric acid, and
n maps reveintensity of
tensity of eamay not lead ne colour can3a point 1), white particleon maps, cor3b), Si (Fig13e), and Pbin the leachSi minerals. Fn indicates tent, validatindid not get e
be leached by
cid concentr
1.0
1.23 15.02
9.31
he distributioents, Scannin
Energy Dispechniques wef the leachinthe results a
aled a numbf each image ach ion. Wheto areas in thn be seen. Thgrey particl
es (Figure 13rresponding gure. 13c), Ab (Figure 13ing residue Figure 13g fthat this is thng the resulenriched in thy citric acid.
ations.
on ng er-ere ng are
ber is
en he he les 3a to Al f), of
for he lts he
Leaching Zn from the Low-Grade Zinc Oxide Ore in NH3-H3C6H5O7-H2O Media 915
Brazilian Journal of Chemical Engineering Vol. 33, No. 04, pp. 907 - 917, October - December, 2016
Figure 13: (a) SEM image of the leaching residue, EDS mapping of O (b), Si (c), Al (d), Ca (e), Pb (f), Zn (g).
CONCLUSIONS
The dissolution behavior of low grade zinc oxide ores in the NH3-H3C6H5O7- H2O system was investi-gated.
(1) The concentration of citric acid was found to have an important role in low-grade zinc oxide ore dissolution, maximizing at 1 M, and a zinc leaching efficiency of about 81.2% was obtained, under the fol-lowing leaching conditions: ammonia 6 M, tempera-ture of 25 °C, leaching time of 60 min, stirring speed of 300 rpm and solid to liquid ratio of 1:5. The zinc leaching efficiency increased with the increase in cit-ric acid concentration, liquid-solid mass ratio, leach-ing time, stirring speed and ammonia concentration.
(2) The FT-IR spectra reflect the changes in the structural group units and justify the leaching mecha-nism for zinc dissolution, and the complex demon-strated that the Zn (II) ion is coordinated. Three strong FT-IR bands at 1579 cm-1 and 1397cm-1 were
found and they were assigned to a zinc–citrate com-plex in the aqueous solution.
(3) The results of XRD, IR, and SEM/EDS ex-periments indicate that hemimorphite is soluble, and the oxides of Si, Ca, Pb, Fe and Al are the main minerals in the leaching residue that are undissolved.
ACKNOWLEDGEMENTS
The authors are grateful for the financial support from the National Program on Key Basic Research Project of China (973 Program, 2014CB643404), the National Natural Science Foundation of China (51404118), the Yunnan Province Young Academic Technology Leader Reserve Talents (2012HB008), the Yunnan Provincial Science and Technology Inno-vation Talents scheme Technological Leading Talent (2013HA002), and the 2014 PhD Newcomer Award in Yunnan Province (1319880207).
916 Ma Ai-yuan, Peng Jin-hui, Zhang Li-bo, Shiwei Li, Yang Kun and Zheng Xue-mei
Brazilian Journal of Chemical Engineering
NOMENCLATURE
Znη leaching rate of zinc, (%) ZnC zinc concentration of leaching solution
(g/L)V the leaching volume, (L)
0ZnC the zinc content of the low-grade zinc
oxide ore (%)m the mass of the low-grade zinc oxide ore
(G)
REFERENCES Che, P., Fang, D. Q., Zhang, D. P., Feng, J., Wang, J.
P., Hu, N. H., Meng, J., Hydrothermal synthesis and crystal structure of a new two-dimensional zinc citrate complex. Journal of Coordination Chemistry, 58(17), 1581-1588 (2005).
Chen, A. L., Zhao, Z. W., Jia, X. J., Long, S., Huo, G. S., Chen, X. Y., Alkaline leaching Zn and its concomitant metals from refractory hemimor-phite zinc oxide ore. Hydrometallurgy, 97(3-4), 228-232 (2009).
Chen, Y. X., Lin, Q., Luo, Y. M., He, Y. F., Zhen, S. J., Yu, Y. L., Tian, G. M., Wong, M. H., The role of citric acid on the phytoremediation of heavy metal contaminated soil. Chemosphere, 50(6), 807-811 (2003).
de Wet, J. R., Singleton, J. D., Development of a viable process for the recovery of zinc from ox-ide ores. Journal of the South African Institute of Mining and Metallurgy, 108(5), 253-259 (2008).
Demir, F., Laçin, O., Dönmez, B., Leaching kinetics of calcined magnesite in citric acid solutions. Industrial & Engineering Chemistry Research, 45(4), 1307-1311 (2006).
Ding, Z. Y., Yin, Z. L., Hu, H. P., Chen, Q. Y., Dis-solution kinetics of zinc silicate (hemimorphite) in ammoniacal solution. Hydrometallurgy, 104(2), 201-206 (2010).
Dutra, A. J. B., Paiva, P. R. P., Tavares, L. M., Alka-line leaching of zinc from electric arc furnace steel dust. Minerals Engineering, 19(5), 478-485 (2006).
Ejtemaei, M., Gharabaghi, M., Irannajad, M., A re-view of zinc oxide mineral beneficiation using flotation method. Advances in Colloid and In-terface Science, 206(SI), 68-78 (2014).
He, S. M., Wang, J. K., Yan, J. F., Pressure leaching of high silica Pb–Zn oxide ore in sulfuric acid me-dium. Hydrometallurgy, 104(2), 235-240 (2010).
He, S. M., Wang, J. K., Yan, J. F., Pressure leaching of synthetic zinc silicate in sulfuric acid medium. Hydrometallurgy, 108(3-4), 171-176 (2011).
Irannajad, M., Ejtemaei, M., Gharabaghi, M., The effect of reagents on selective flotation of smith-sonite-calcite-quartz. Minerals Engineering, 22 (9-10), 766-771 (2009).
Irannajad, M., Meshkini, M., Azadmehr, A. R., Leaching of zinc from low grade oxide ore us-ing organic acid. Physicochemical Problems of Mineral Processing, 49(2), 547-555 (2013).
Steer, J. M., Griffiths, A. J., Investigation of car-boxylic acids and non-aqueous solvents for the selective leaching of zinc from blast furnace dust slurry. Hydrometallurgy, 140, 34-41 (2013).
Kaliva, M., Kyriakakis, E., Gabriel, C., Raptopoulou, C. P., Terzis, A., Tuchagues, J. P., Salifoglou, A., Synthesis, isolation, spectroscopic and structural characterization of a new pH complex structural variant from the aqueous vanadium(V)-peroxo-citrate ternary system. Inorganica Chimica Acta, 359(14), 4535-4548 (2006).
Kourgiantakis, M., Matzapetakis, M., Raptopoulou, C. P., Terzis, A., Salifoglou, A., Lead–citrate chemistry. Synthesis, spectroscopic and struc-tural studies of a novel lead(II)–citrate aqueous complex. Inorganica Chimica Acta, 297(1-2), 134-138 (2000).
Larba, R., Boukerche, I., Alane, N., Habbache, N., Djerad, S., Tifouti, L., Citric acid as an alterna-tive lixiviant for zinc oxide dissolution. Hydro-metallurgy, 134, 117-123 (2013).
Li, M. X., Jian, S., Zhao, W. J., Study on pre-concen-tration and Calcium Removal of low grade zinc oxide ore. Applied Mechanics and Materials, 316-317, 830-833 (2013).
Li, C. X., Xu, H. S., Deng, Z. G., Li, X. B., Li, M. T., Wei, C., Pressure leaching of zinc silicate ore in sulfuric acid medium. Transactions of Nonfer-rous Metals Society of China, 20(5), 918-923 (2010).
Li, Q. X., Chen, Q. Y., Hu, H. P., Dissolution mecha-nism and solubility of hemimorphite in NH3-(NH4)2SO4-H2O system at 298.15 K. Journal of Central South University, 21(3), 884-890 (2014).
Li, L., Ge, J., Wu, F., Chen, R. J., Chen, S., Wu, B. R., Recovery of cobalt and lithium from spent lithium ion batteries using organic citric acid as leachant. Journal of Hazardous Materials, 176 (1-3), 288-293 (2010).
Matzapetakis, M., Raptopoulou, C. P., Terzis, A., Lakatos, A., Kiss, T., Salifoglou, A., Synthesis, structural characterization, and solution be-havior of the first mononuclear, aqueous alumi-
Leaching Zn from the Low-Grade Zinc Oxide Ore in NH3-H3C6H5O7-H2O Media 917
Brazilian Journal of Chemical Engineering Vol. 33, No. 04, pp. 907 - 917, October - December, 2016
num citrate complex. Inorganic Chemicals, 38(4), 618 -619 (1999).
Navidi Kashani, A. H., Rashchi, F., Separation of oxi-dized zinc minerals from tailings: Influence of flotation reagents. Minerals Engineering, 21(12-14), 967-972 (2008).
Park, H., Jung, K., Alorro R. D., Yoo, K., Leaching behavior of copper, zinc and lead from contami-nated soil with citric acid. Materials Transac-tions, 54(7), 1220-1223 (2013).
Santos, F. M. F., Pina, P. S., Porcaro, R., Oliveira, V. A., Silva, C. A., Leão, V. A., The kinetics of zinc silicate leaching in sodium hydroxide. Hydro-metallurgy, 102(1-4), 43-49 (2010).
Swanson, R., Ilsley, W. H., Stanislowski, A. G., Crys-tal structure of zinc citrate. Journal of Inorganic Biochemistry, 18(3), 187-194 (1983).
Tsaramyrsi, M., Kavousanaki, D., Raptopoulou, C. P., Terzis, A., Salifoglou, A., Systematic synthesis, structural characterization, and reactivity studies of vanadium(V)–citrate anions [VO2(C6H6O7)]2
2−, isolated from aqueous solutions in the presence of different cations. Inorganica Chimica Acta, 320(1-2), 47-59 (2001).
Willey, G. R., Somasunderam, U., Aris, D. R., Err-ington, W., Ge(IV)–citrate complex formation: Synthesis and structural characterisation of GeCl4(bipy) and GeCl(bipy)(Hcit) (bipy=2,2´-bipyridine, H4cit=citric acid). Inorganica Chimica Acta, 315(2), 191-195 (2001).
Xu, H. S., Wei, C., Li, C. X., Fan, G., Deng, Z. G.,
Li, M. T., Li, X. B., Sulfuric acid leaching of zinc silicate ore under pressure. Hydrometal-lurgy, 105(1-2), 186-190 (2010).
Xu, H. S., Wei, C., Li, C. X., Fan, G., Deng, Z. G., Zhou, X. J., Qiu, S., Leaching of a complex sul-fidic, silicate-containing zinc ore in sulfuric acid solution under oxygen pressure. Separation and Purification Technology, 85, 206-212 (2012).
Yang, J. L., Zhang, H. M. Wang, G. F., Ma, S. J., Zhang, M., Sulfuric acid leaching on low grade oxide ore. Advanced Materials Research, 826, 122-125 (2013).
Yin, Z. L., Ding, Z. Y., Hu, H. P., Liu, K., Chen, Q. Y., Dissolution of zinc silicate (hemimorphite) with ammonia–ammonium chloride solution. Hydrometallurgy, 103(1-4), 215-220 (2010).
Zhao, Z. W., Long, S., Chen, A. L., Huo, G. S., Li, H. G., Jia, X. J., Chen, X. Y., Mechanochemical leaching of refractory zinc silicate (hemimor-phite) in alkaline solution. Hydrometallurgy, 99(3-4), 255-258 (2009).
Zhang, H., Zhao, H., Jiang, Y. Q., Hou, S. Y., Zhou, Z. H., Wan, H. L., pH- and mol-ratio dependent tungsten(VI)–citrate speciation from aqueous solutions: Syntheses, spectroscopic properties and crystal structures. Inorganica Chimica Acta, 351, 311-318 (2003).
Zárate-Gutiérrez, R., Lapidus, G. T., Anglesite (PbSO4) leaching in citrate solutions. Hydrometallurgy, 144-145, 124-128 (2014).