F2000EX EASY 02-30-00
CODDE 1 PAGE 1 / 2
DGT94085
ATA 30 – ICE AND RAIN PROTECTION TABLE OF CONTENTS
ISSUE 3
DASSAULT AVIATION Proprietary Data
02-30 ATA 30 – ICE AND RAIN PROTECTION
02-30-00 TABLE OF CONTENTS
02-30-05 GENERAL
Introduction Anti-icing protection sources Anti-ice system location overview
02-30-10 DESCRIPTION
Pneumatic anti-icing Electrical anti-icing
02-30-15 CONTROL AND INDICATION
Control Indication
02-30-20 SYSTEM PROTECTION
Introduction Circuit breakers
02-30-25 NORMAL OPERATION
Introduction IN-FLIGHT situations
02-30-30 ABNORMAL OPERATION
Introduction Airplane in flight in icing conditions with wings overheat CAS messages
02-30-00 F2000EX EASY
PAGE 2 / 2 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION TABLE OF CONTENTS
DGT94085
DASSAULT AVIATION Proprietary Data
INTENTIONALLY LEFT BLANK
F2000EX EASY 02-30-05
CODDE 1 PAGE 1 / 4
DGT94085
ATA 30 – ICE AND RAIN PROTECTION GENERAL
ISSUE 3
DASSAULT AVIATION Proprietary Data
INTRODUCTION
The ice-protection system is intended to permit safe flight in intermittent or continuous maximum icing conditions.
The F2000EX EASy uses pneumatic and electrical power for its anti-icing and rain protection system.
An anti-fogging and demisting system is also provided for the cabin and flight deck windows.
Two electrically-operated windshield wipers are also provided.
02-30-05 F2000EX EASY
PAGE 2 / 4 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION GENERAL
DGT94085
DASSAULT AVIATION Proprietary Data
CAS windows
BLD synoptic
Anti-ice and raincircuit breakers
Anti-ice and rain controls
Bleed air controls
FIGURE 02-30-05-00 FLIGHT DECK OVERVIEW
F2000EX EASY 02-30-05
CODDE 1 PAGE 3 / 4
DGT94085
ATA 30 – ICE AND RAIN PROTECTION GENERAL
ISSUE 3
DASSAULT AVIATION Proprietary Data
ANTI-ICING PROTECTION SOURCES
The Falcon 2000EX EASy is equipped with two anti-icing systems:
- one pneumatic system (LH and RH bleed air manifold),
- one electrical system using heating resistors.
PNEUMATIC SYSTEM SOURCES ELECTRICAL SYSTEM SOURCES
Engines No 1 and 2
BUS A1
BUS A2
BUS B1
BUS B2
BUS ESS
The pneumatic system, using hot bleed air from the engines, protects the following structural parts and equipment:
- wing inboard leading edge,
- outboard slats,
- air conditioning heat exchanger ventilation air intake,
- engine air intake lips,
- wheel brakes (optional).
The electrical anti-ice system protects the following probes, parts and equipment:
- LH and RH pitot pressure probes,
- LH and RH static pressure probes,
- Total Air Temperature probe,
- Angle-of-Attack sensors,
- stand-by pitot pressure probe,
- P1-T1 sensors (one per engine),
- cockpit windshields and windows,
- water drains.
In addition, wipers are provided for the main windshields.
02-30-05 F2000EX EASY
PAGE 4 / 4 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION GENERAL
DGT94085
DASSAULT AVIATION Proprietary Data
ANTI-ICE SYSTEM LOCATION OVERVIEW
FIGURE 02-30-05-01 ANTI-ICE AREA OVERVIEW
F2000EX EASY 02-30-10
CODDE 1 PAGE 1 / 6
DGT94085
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
ISSUE 3
DASSAULT AVIATION Proprietary Data
PNEUMATIC ANTI-ICING
GENERAL
Each engine is fitted with LP and HP bleed air ports located on the compressor HP spool. The main LP bleed ports supply air to the interconnection manifold, named the “distribution line” to which the main systems are connected. When the LP air pressure is not high enough to achieve correct anti-icing or defogging, HP air, extracted through the main HP bleed ports, is injected into the LP bleed air through an electric valve. The Bleed Air System Computer (BASC) controls the electric valve opening and closing. The BASC monitors the wings anti-ice system and displays the corresponding CAS message(s). Ice protection of engine air intakes is provided by HP air extracted from the corresponding engine through the auxiliary HP bleed air port.
FIGURE 02-30-10-00 ENGINE BLEED AIR PORTS
02-30-10 F2000EX EASY
PAGE 2 / 6 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
DGT94085
DASSAULT AVIATION Proprietary Data
DISTRIBUTION
FIGURE 02-30-10-01 PNEUMATIC SYSTEM SIMPLIFIED DIAGRAM WITH WINGS ANTI-ICE ON
F2000EX EASY 02-30-10
CODDE 1 PAGE 3 / 6
DGT94085
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
ISSUE 3
DASSAULT AVIATION Proprietary Data
WINGS ANTI-ICE
The wings anti-icing system protects the wing inboard leading edges, the outboard slats (through telescopic tubes) and the air-conditioning heat exchanger ventilation air intake. Wings anti-icing is provided by circulation of mixed LP and HP hot air. A minimum N1 value depending on altitude and Total Air Temperature (TAT) is necessary to ensure proper anti-icing. When the system is in AUTO mode, the wings anti-icing valve is commanded to open.
- if one of the throttle levers is set to MAX CLIMB position or further, the valve partially opens, in order to reduce the amount of air bled from the engine.
- if both throttle levers are below MAX CLIMB, the valve fully opens. When the feeder isolation valve is closed, No 2 engine is the only anti-icing supply source for this system.
HEAT EXCHANGER RAM AIR INLET ANTI-ICE
Air is tapped downstream the wings anti-icing valve and supplies the intake duct of the air conditioning heat exchanger.
BRAKE HEATING (OPTION)
On each wing line, a pick-off in front of the main gear well supplies hot air to the brake unit.
ENGINE NACELLE INTAKE ANTI-ICE
The No 1 and 2 air intake anti-icing systems are fully independent. They are supplied with dedicated HP bleed air from the corresponding engine. The pneumatic A/I valve controls the bleed air supply to maintain a constant pressure in the anti-icing line. In case of duct rupture, a venturi limits the airflow of the HP compressor.
WINDOW DEMISTING
The cockpit air conditioning system helps to remove mist, especially from: - front windshield, - pilot windshield, - copilot windshield.
02-30-10 F2000EX EASY
PAGE 4 / 6 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
DGT94085
DASSAULT AVIATION Proprietary Data
ELECTRICAL ANTI-ICING
ELECTRICAL SYSTEM SCHEMATIC
FIGURE 02-30-10-02 ELECTRICAL SYSTEM SCHEMATIC
F2000EX EASY 02-30-10
CODDE 1 PAGE 5 / 6
DGT94085
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
ISSUE 3
DASSAULT AVIATION Proprietary Data
WINDSHIELD AND SIDE WINDOWS
The cockpit windows are electrically heated by a network of heating elements incorporated into the transparent panes. The electrical anti-icing system of the windshields is composed of two identical circuits:
- one pilot circuit, - one copilot circuit.
The pilot and copilot circuits are fitted with dual heat regulating sensors, one active and one stand-by. The heating temperature is automatically regulated between 25°C (77°F) and 30°C (86°F).
Front windshield
Copilot windshield
RH lateral window
LH opening window
Pilot windshield
LH rear window RH rear window
FIGURE 02-30-10-03 WINDSHIELD AND SIDE WINDOWS
PROBES
The pitot pressure probes, static pressure probes, AOA sensors and Outside Air Temperature probe are heated by resistors controlled by pushbuttons. Resistors controlled by the PITOT NORMAL pushbutton heat the following probes and sensors:
- LH and RH pitot pressure probes, - LH and RH static pressure probes, - LH and RH Angle Of Attack sensors, - Outside Air Temperature probe.
Resistor controlled by the PITOT ST-BY pushbutton heats the stand-by pitot pressure probe.
02-30-10 F2000EX EASY
PAGE 6 / 6 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION DESCRIPTION
DGT94085
DASSAULT AVIATION Proprietary Data
WATER WASTE DRAIN
Drain masts of the water system (one for the front galley, one for the rear washbasin) are electrically anti-iced. The water drain hoses between rear mast and pressurized area include an electrical resistor which surrounds end fittings. The drain masts and the heating elements of the lines are supplied from the DRAINS HEAT circuit breakers.
FIGURE 02-30-10-04 DRAIN MASTS LOCATION
WIPERS
Pilot and copilot windshield panes are both equipped with a wiper arm powered by an electrical motor-converter and designed to keep the field of view clear during taxi, take-off, approach and landing phases when raining or snowing. When the wipers are not used, they are stowed in a recess located at the bottom of each windshield. Each wiper is powered and controlled independently of the other by a pushbutton on the LH and RH side of the overhead panel.
F2000EX EASY 02-30-15
CODDE 1 PAGE 1 / 10
DGT94085
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
CONTROL
OVERHEAD PANEL
FIGURE 02-30-15-00 OVERHEAD PANEL CONTROLS
AUTOMATIC SETTINGS
WINDSHIELD and PITOT functions
At airplane power-on, the overhead panel configuration is: WINDSHIELD PILOT, WINDSHIELD COPIL., PITOT NORMAL and PITOT ST-BY controls in OFF mode.
These controls are automatically set to NORMAL mode when: - one throttle lever is in TAKE-OFF position and one engine is on and with WOW
signal, or - without WOW signal.
They are automatically set to OFF mode when Flight / WOW transition occurs and IAS < 20 kt.
P1-T1 probe
The heating of the P1-T1 probe is effective when the ENG anti-ice control is set to ON.
Water waste drain masts
The drain masts and the heating elements of the lines are automatically activated as soon as the airplane is electrically powered.
Other anti-ice controls
All other overhead panel anti-ice controls are set to off mode when energizing the airplane systems (ANTI-ICE and WIPER functions).
02-30-15 F2000EX EASY
PAGE 2 / 10 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
DGT94085
DASSAULT AVIATION Proprietary Data
SYNTHETIC TABLE
ENG controls
TO ACTIVATE CONTROL FUNCTION
TO DE-ACTIVATE SYNOPTIC
Push ON
ON
controls hot air supply to air intake lips of No 1 and No 2 engines
Push off
Off
WINGS and BRAKE controls
TO ACTIVATE CONTROL FUNCTION
TO DE-ACTIVATE SYNOPTIC
Push AUTO
When in AUTO mode, the wings anti-ice valve is open and the BASC controls HP1 and HP2 valves to provide the required manifold pres-sure
CAUTION Never activate wings anti-ice on ground, except for test with
engines idle.
Push off
F2000EX EASY 02-30-15
CODDE 1 PAGE 3 / 10
DGT94085
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
TO ACTIVATE
CONTROL FUNCTION TO DE-ACTIVATE
SYNOPTIC
Push O’RIDE
Forces HP1 and HP2 valves to full open
When O'RIDE is de-activated, wings mode is automatically set to off
Push off
Push ON
Option
controls the power supply to the brake heating system,
the BRAKE anti-ice is effective only when WINGS is set to AUTO or O’RIDE modes (because the same duct is used).
Push off
NOTE
The brake anti-ice symbol is displayed only when the option is installed.
02-30-15 F2000EX EASY
PAGE 4 / 10 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
DGT94085
DASSAULT AVIATION Proprietary Data
WINDSHIELD controls
TO ACTIVATE CONTROL FUNCTION
TO DE-ACTIVATE SYNOPTIC
Automatic mode
Push MAX
allows three modes activated by pushing the pushbutton in the following logic:
- OFF,
- automatic,
- MAX,
- automatic,
- OFF.
PILOT in automatic mode: the following windshield pane heating circuits are supplied:
- LH half of front windshield pane,
- Pilot windshield pane,
- LH opening window,
- RH side window.
COPIL in automatic mode: the following windshield pane heating circuits are supplied:
- RH half of front windshield pane,
- Copilot windshield pane,
- LH rear window,
- RH rear window.
PILOT / COPIL in MAX mode: the corresponding windshield heating power is increased and the related half of front pane heating power is reduced.
Push OFF
No synoptic
F2000EX EASY 02-30-15
CODDE 1 PAGE 5 / 10
DGT94085
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
PITOT controls
TO ACTIVATE CONTROL FUNCTION
TO DE-ACTIVATE SYNOPTIC
Automatic mode
Controls automatic anti-icing of pitot, static, AOA probes and temperature sensors
Push OFF
No synoptic
Automatic mode
Controls automatic anti-icing of stand-by pitot probe
Push OFF
No synoptic
02-30-15 F2000EX EASY
PAGE 6 / 10 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
DGT94085
DASSAULT AVIATION Proprietary Data
WIPER controls
TO ACTIVATE CONTROL FUNCTION
TO DE-ACTIVATE SYNOPTIC
Off mode
Push SLOW
Allows three modes, activated by pushing the pushbutton in the following logic:
- off,
- SLOW,
- FAST,
- off.
PILOT and COPIL controls are indepen-dent.
Push FAST
No synoptic
F2000EX EASY 02-30-15
CODDE 1 PAGE 7 / 10
DGT94085
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
INDICATION
Anti-ice indication can be found on the BLEED synoptic:
Wing and brake anti-ice diagram
Engine air intake lip anti-ice diagram
FIGURE 02-30-15-01 BLEED SYNOPTIC WITH ANTI-ICE OFF
02-30-15 F2000EX EASY
PAGE 8 / 10 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
DGT94085
DASSAULT AVIATION Proprietary Data
ENGINE ANTI-ICE AND FLOW LINE
Anti-ice ON (no failure detected)
Anti-ice OFF (no failure detected)
Anti-ice ON
Low Pressure
Anti-ice ON
Over Pressure
Anti-ice OFF
Residual pressure
WINGS ANTI-ICE
Wings anti-ice on (no failure detected)
Wings anti-ice command off (no failure detected)
Wings anti-ice monitoring malfunction
Wings anti-ice on and low pressure
Wings anti-ice on and over pressure
Wings anti-ice command off with residual pressure
F2000EX EASY 02-30-15
CODDE 1 PAGE 9 / 10
DGT94085
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
BRAKE HEATING (OPTION)
Brake heating off Brake heating ON Brake heating failure
02-30-15 F2000EX EASY
PAGE 10 / 10 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION CONTROL AND INDICATION
DGT94085
DASSAULT AVIATION Proprietary Data
INTENTIONALLY LEFT BLANK
F2000EX EASY 02-30-20
CODDE 1 PAGE 1 / 2
DGT94085
ATA 30 – ICE AND RAIN PROTECTION SYSTEM PROTECTION
ISSUE 3
DASSAULT AVIATION Proprietary Data
INTRODUCTION
The circuit protection is provided with conventional trip-free circuit breakers located above the overhead panel.
CIRCUIT BREAKERS
FIGURE 02-30-20-00 ANTI-ICE CIRCUIT BREAKERS
02-30-20 F2000EX EASY
PAGE 2 / 2 CODDE 1
ISSUE 3
ATA 28 – FUEL SYSTEM TABLE OF CONTENTS
DGT94085
DASSAULT AVIATION Proprietary Data
INTENTIONALLY LEFT BLANK
F2000EX EASY 02-30-25
CODDE 1 PAGE 1 / 2
DGT94085
ATA 30 – ICE AND RAIN PROTECTION NORMAL OPERATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
INTRODUCTION
Icing conditions exist when the OAT on the ground and for take-off, or TAT in flight is 10°C or below, and visible moisture in any form is present (such as clouds, fog with visibility of one mile or less, rain, snow, sleet or ice crystals). Icing conditions also exist when the OAT on the ground and for take-off is 10°C or below when operating on ramps, taxiways or runways where surface snow, ice, standing water, or slush may be ingested by the engines or freeze on engines, nacelles or engine sensor probes.
IN-FLIGHT SITUATIONS
In the following, typical in-flight situations have been selected to help the crew to understand the symbols provided in the various panels and displays.
AIRPLANE IN FLIGHT IN NON-ICING CONDITIONS
In this case, pitot, static, AOA probes and water waste masts are the only anti-iced systems.
FIGURE 02-30-25-00 OVERHEAD PANEL
FIGURE 02-30-25-01 BLEED SYNOPTIC WITHOUT ANTI-ICE
02-30-25 F2000EX EASY
PAGE 2 / 2 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION NORMAL OPERATION
DGT94085
DASSAULT AVIATION Proprietary Data
AIRPLANE IN FLIGHT IN ICING CONDITIONS
In this case, pitot, static, AOA probes, water waste masts, engines and wings are anti-iced.
FIGURE 02-30-25-02 OVERHEAD PANEL
FIGURE 02-30-25-03 BLEED SYNOPTIC WITH ANTI-ICE ACTIVATED
F2000EX EASY 02-30-30
CODDE 1 PAGE 1 / 4
DGT94085
ATA 30 – ICE AND RAIN PROTECTION ABNORMAL OPERATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
INTRODUCTION
In the following, one abnormal operation has been selected to help the crew to understand the symbols provided in the various panels and displays.
AIRPLANE IN FLIGHT IN ICING CONDITIONS WITH WINGS OVERHEAT
ABNORMAL STATUS
FIGURE 02-30-30-00 OVERHEAD PANEL
FIGURE 02-30-30-01 BLEED SYNOPTIC WITH WINGS OVERHEAT
CONTEXT RESULT
Wings anti-ice excessive heating
A/I: WINGS OVHT CAS message is displayed
+ light on
- Wings symbol in amber
- OVER PRESSURE amber indication onBLEED synoptic
02-30-30 F2000EX EASY
PAGE 2 / 4 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION ABNORMAL OPERATION
DGT94085
DASSAULT AVIATION Proprietary Data
AFTER PROCEDURE COMPLETE
FIGURE 02-30-30-02 OVERHEAD PANEL
FIGURE 02-30-30-03 BLEED SYNOPTIC WITH WINGS ANTI-ICE OFF
ACTION RESULT
WINGS pushbutton off Wings symbol in GRAY
F2000EX EASY 02-30-30
CODDE 1 PAGE 3 / 4
DGT94085
ATA 30 – ICE AND RAIN PROTECTION ABNORMAL OPERATION
ISSUE 3
DASSAULT AVIATION Proprietary Data
CAS MESSAGES
CAS MESSAGE DEFINITION
WHEEL XX OVHT Excessive temperature in (LH/RH) wheel compartment(option)
A/I CMPTR CONT FAULT CODE Parking only, a failure message that may affect dispatch has been recorded by the BASC
A/I CMPTR MONIT FAULT CODE Parking only, a failure message that may affect dispatch has been recorded by the BASC
A/I: ENG .. LO PRESS Low pressure in engine (1/2) inlet anti-ice system with anti-ice ON
A/I: ENG .. OVERPRESS Overpressure in engine (1/2) inlet anti-ice system with anti-ice ON
A/I: ENG .. UNWANTED OPS Pressure in engine (1/2) inlet anti-ice system while not activated
A/I: WINGS CMPTR FAIL Failure of wings anti-ice computer (BASC)
A/I: WINGS LO PRESS Low pressure in wings anti-ice system
A/I: WINGS OVHT Overpressure in wings anti-ice system
A/I: WINGS UNWANTED OPS Pressure in wings anti-ice system while not activated
AOA HEAT .. Angle-of-Attack probe (1/2) heating system failure
PITOT HEAT .. In-flight failure of Pitot (1/2) probe heating system
STATIC HEAT .. In-flight failure of static probe (1/2) heating system
ST-BY PITOT HEAT In-flight failure of stand-by Pitot and static probe heating system
WINDSHIELD XFR Pilot (copilot) windshield pane temperature control is transferred to copilot (pilot) temperature regulator unit
A/I: BRAKES MISCONFIG Brake anti-ice valves are not in the commanded position
02-30-30 F2000EX EASY
PAGE 4 / 4 CODDE 1
ISSUE 3
ATA 30 – ICE AND RAIN PROTECTION ABNORMAL OPERATION
DGT94085
DASSAULT AVIATION Proprietary Data
CAS MESSAGE DEFINITION
A/I CMPTR CONT FAULT CODE In flight, a failure message has been recorded by the BASC
A/I CMPTR MONIT FAULT CODE In flight, a failure message has been recorded by the BASC
ICE DETECTED Icing conditions detected (option)
ICE DETECTION FAIL Ice detection has failed (option)
PITOT ON On-ground indication that probes are heated
PROBE HEATING FAIL On-ground indication of probe heating system failure
WING A/I ON Wings anti-ice activated with airplane on ground (displayed with 1 min delay)