Download - 80t Chapter Ⅲ Load Charts.pdf|
-
7/29/2019 80t Chapter Load Charts.pdf|
1/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 1 of 10
Table of Contents
1.General...........................................................................................................................................2
1.1.Calculation of Rated Loads.................................................................................................2
1.2.Use the Load Charts Properly.............................................................................................2
1.3.Operating Radius ................................................................................................................6
2.Operating Condition Codes............................................................................................................7
3. Operating Range Diagram ............................................................................................................8
3.1 Main boom operating condition (H)]..................................................................................8
3.2 Main boom + fixed jib operating condition (FJ).................................................................9
3.3 Main boom + extension jib operating condition (HC)........................................................9
4.Load Charts..................................................................................................................................10
-
7/29/2019 80t Chapter Load Charts.pdf|
2/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 2 of 10 3-1
1.General
1.1.Calculation of Rated Loads
Rated loads in the load charts are determined either by strength or by stability.
Rated loads determined by stability are calculated according to ISO 4305:1991 Mobile
CranesDetermination of Stability and these rated loads are always within the 75% of tipping
load.
1.2.Use the Load Charts Properly
1) Ground conditions: rated loads in the load charts are calculated in the condition that the craneis on hard, horizontal and evenly-supported ground with gradient smaller than 1%. If these
condition requirements are not fulfilled, the value of rated loads must be decreased for
calculation.
2) Actual Lifting Capacity: the weight of hook blocks, lifting devices, and wire ropes reevingbetween the hooks and boom/jib heads must be deducted from the rate load to obtain a net
lifting value, i.e. the actual lifting capacity.
3) When the crane is equipped with jib or extension jib, the weight of main hook, auxiliary hookand weight to deduct listed in the Table 3.1 are also included in the value of rated load.
Therefore, these weights and values, as well as the equivalent weights of wire ropes and
lifting devices onto boom head must be deducted from the rated load stipulated in the load
charts to obtain the actual lifting capacity; and the crane is not allowed to operate when the
value of actual lifting capacity obtained by the prescribed calculation is less than 0.8t
(1760lb).
Table 3.1
Jib Length (m)
(ft in)
9
(296)
13.5
(443)
18
(591)
Extension jib
Weight to deduct
(t) (lb)
1.0
(2,210)
1.3
(2,870)
1.65
(3,640)
0.2
(441)
-
7/29/2019 80t Chapter Load Charts.pdf|
3/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 3 of 10 3-1
Table 3.2 Hook Parameters
Nominal Load
(t) (Ust)
80
(88)
50
(55)
25(28)
9(10
Deadweight (t)
(lb)
1.25
(2,760)
0.75
(1,650)
0.55
(1,210)
0.25
(551)
Weight of wire ropes reeving between hooks (main hook, auxiliary hook) and boom/jib heads is
calculated by 2.8kg/m(1.88lb/ft).
4) Wind Speed: Calculating rated loads also takes allowable wind speed of each operatingcondition into consideration. The SCC800C crawler crane is allowed to operate when the
speed of stable wind or gust is not exceeding 16m/s(35.8mph). Hence the maximum allowable
wind speed for SCC800C crawler crane is 9.8m/s(21.9mph)16.0m/s (35.8mph) (equivalent
to 60160N/m2(0.0090.023psi)dynamic pressure); when the wind speed is higher than
16m/s and lower than 22m/s(49.2mph), the crane is not allowed to operate but allowed to
have the boom system upstanding when only boom is attached; when wind speed is higher
than 22m/s(49.2mph), the boom system must be lowered down to the ground.
Table 3.3 Allowable Wind Speed in H Operating Condition
Boom length (m)
(ft in)
Allowable wind speed (m/s)
( mph)
Corresponding allowable
dynamic pressure (N/m2)
(psi)
1319
(428624)
16
(35.8)
160
(0.023)
2234
(7221117)
15
(33.6)
140
(0.02)
3752
(12151707)
11.3
(26.40)
80
(0.012)
52 (1707) 9.8
(21.9)
60
(0.009)
-
7/29/2019 80t Chapter Load Charts.pdf|
4/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 4 of 10 3-1
Table 3.4 Allowable Wind Speed in FJ (LJ) Operating Condition
Length of boom + jib (m)
(ft in)
Allowable wind speed
(m/s)( mph)
Corresponding allowable
dynamic pressure (N/m2
) (psi)
37+(918)
1215+(296591)
11.3
(26.40)
80
(0.012)
40 ~52+(918)
(13131707)+ (296591)
9.8
(21.9)
60
(0.009)
If the wind speed at operating site cannot fulfill the requirements listed above, the crane is not
allowed to operate until the load is reduced accordingly based on the actual situation.
Table 3.5 Reduction of Rated Load Corresponding to Wind Speed
Boom length (m) (ft in) Wind speed (m/s) ( mph)Corresponding reduction of
rated load in percentage (%)
5258
(170.61903)11.3(26.40) 20
5258
(170.61903)
13.8 (30.87)50
4052+9(18)(1313170.6) + (296(591)
11.3(26.40) 50
5258, 4052+9(18)
(1313170.6) + (296(591)16 (35.8) Not allowed to operate
For further information on influences of wind speed, please refer to Influence of Wind Speed in
Chapter.
-
7/29/2019 80t Chapter Load Charts.pdf|
5/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 5 of 10 3-1
5) Scope of Application: values or rated loads listed in the load charts are all applicable for thewhole 360slewing range.
6) Rated Load for Traveling Crane: values of rated loads listed in the load charts are calculatedin condition that the crane is not traveling, and these values should be decreased accordingly
when the crane is traveling. For traveling steadily at low speed, 90% of the rated load is
allowed to attach in H operating condition for straight-line traveling, or 70% of the rated load
is allowed to attach in H operating condition for turning, or 50% of the rated load is allowed
to attach in FJ operating condition and LJ operating condition for straight-line traveling.
Notices requiring special care for traveling with load:
a) It is suggested to move the load in an area as small as possible and make the load close tothe ground enough (with maximum distance of 500mm (17.7)to the ground);
b) Only the low gear can be used if possible, and take proper measures to prevent the loadswinging. For specifications on traveling, please refer to the Traveling Operation in
Chapter of this manual.
7) Others:The use temperature applicable to these load charts ranges from -20C40C;
-
7/29/2019 80t Chapter Load Charts.pdf|
6/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 6 of 10 3-1
1.3.Operating Radius
Operating radius is the horizontal distance from slewing center to the center line along the wire
rope which is suspending load or the center of the pulley set bearing load.
Operating angle is the angle from the center line of operating equipment to horizontal line.
-
7/29/2019 80t Chapter Load Charts.pdf|
7/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 7 of 10 3-2
2.Operating Condition Codes
Operating Condition Codes
NO. Operating Condition Code
1 Main Boom H
2 Main Boom + Fix Jib FJ
3 Main Boom + Extension Jib HC
Note: As the difference between light boom and heavy boom, as well as some load charts are
specified for main hook only or for auxiliary hook only, the prescribed codes cannot fulfill the
requirements of various operating conditions. To keep the consistency of the technical documents,
it is suggested that:
1. the number of codes not to be increased;
2. some common subscripts be used: H standing for heavy duty, L for light duty, S for short boom,
M for main hook, and A for auxiliary hook;
3. each project team chooses codes according to their actual requirements, and specify these codes
with subscripts, such as:
Main boom + light fixed short jib can be indicated by SFL; and load charts for main hook in main
boom + fixed jib can be indicated by FJm.
-
7/29/2019 80t Chapter Load Charts.pdf|
8/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 8 of 10 3-3
3. Operating Range Diagram
3.1 Main boom operating condition (H)]
-
7/29/2019 80t Chapter Load Charts.pdf|
9/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 9 of 10 3-3
3.2 Main boom + fixed jib operating condition (FJ)
3.3 Main boom + extension jib operating condition (HC)
The operating range diagram of extension jib is the same as that of main boom; please refer to
Figure 5.1 Main Boom Operating Range Diagram
-
7/29/2019 80t Chapter Load Charts.pdf|
10/27
Chapter Load Charts SCC800C Operating Manual
Versions:02 page 10 of 10 3-4
4.Load Charts
Please refer to the appendix at the back of Chapter Load Charts for detailed load charts.
-
7/29/2019 80t Chapter Load Charts.pdf|
11/27
13 16 19 22 25 28
(428) (526) (624) (722) (82') (9110)
4.3 80.00
(141) (176.37)
4.5 76.50
(149) (168.65)
5 68.07 66.80(165) (150.07) (147.27)
5.5 59.18 58.90 58.72
(181) (130.47) (129.85) (129.45)
6 52.30 52.02 51.84 51.66
(198) (115.3) (114.68) (114.29) (113.89)
6.5 46.82 46.54 46.35 46.18 45.90
(214) (103.22) (102.6) (102.18) (101.81) (101.19)
7 42.34 42.06 41.88 41.70 41.42 40.72
(2212) (93.34) (92.72) (92.33) (91.93) (91.31) (89.77)
7.5 38.60 38.30 38.20 38.00 37.70 37.10 36.90 38.50
(247) (85.16) (84.52) (84.13) (83.73) (83.11) (81.7) (81.33) (84.88)
8 35.50 35.20 35.00 34.80 34.60 34.00 33.80 35.30 33.51 35.01
(263) (78.24) (77.6) (77.2) (76.81) (76.19) (74.89) (74.49) (77.8) (73.88) (77.18)
8.5 32.80 32.50 32.30 32.20 31.90 31.30 31.10 32.60 30.86 32.26
(2711) (72.31) (71.67) (71.27) (70.9) (70.26) (69.05) (68.65) (71.76) (68.03) (71.12)
9 30.47 30.20 30.00 29.80 29.60 29.00 28.90 30.20 28.56 29.88
(296) (67.17) (66.56) (66.16) (65.76) (65.15) (63.98) (63.6) (66.51) (62.96) (65.87)
10 26.65 26.37 26.20 26.00 25.70 25.30 25.10 26.30 24.79 25.97
(3210) (58.75) (58.13) (57.72) (57.34) (56.7) (55.67) (55.27) (57.89) (54.65) (57.25)
11 23.64 23.35 23.17 22.99 22.71 22.28 22.10 23.17 21.81 22.88
(361) (52.12) (51.48) (51.08) (50.68) (50.07) (49.12) (48.72) (51.08) (48.08) (50.44)
12 21.21 20.92 20.74 20.56 20.27 19.87 19.69 20.67 19.41 20.38
(394) (46.76) (46.12) (45.72) (45.33) (44.69) (43.81) (43.41) (45.57) (42.79) (44.93)
13 18.91 18.73 18.55 18.27 17.88 17.71 18.60 17.42 18.32
(428) (41.69) (41.29) (40.9) (40.28) (39.42) (39.04) (41.01) (38.4) (40.39)
14 17.23 17.04 16.87 16.58 16.22 16.04 16.87 15.80 16.60
(4511) (37.99) (37.57) (37.19) (36.55) (35.76) (35.36) (37.19) (34.74) (36.55)15 15.61 15.43 15.15 14.80 14.62 15.39 14.30 15.10
(493) (34.41) (34.02) (33.4) (32.63) (32.23) (33.93) (31.61) (33.31)
16 14.37 14.20 13.91 13.58 13.40 14.12 13.11 13.80
(526) (31.68) (31.31) (30.67) (29.94) (29.54) (31.13) (28.9) (30.49)
18 12.18 11.89 11.58 11.40 12.04 11.12 11.80
(591) (26.85) (26.21) (25.53) (25.13) (26.54) (24.51) (25.9)
20 10.31 10.01 9.84 10.41 9.55 10.12
(657) (22.73) (22.07) (21.69) (22.95) (21.05) (22.31)
22 9.03 8.75 8.58 9.09 8.29 8.81
(722) (19.91) (19.29) (18.92) (20.04) (18.28) (19.42)
24 7.72 7.54 8.01 7.25 7.73
(789) (17.02) (16.62) (17.66) (15.98) (17.04)
26 6.67 7.11 6.36 6.82
(854) (14.7) (15.67) (14.02) (15.04)
28 5.60 6.06
(9110) (12.35) (13.36)
30 4.94 5.39
(985) (10.89) (11.88)
27 27 27 27 27 27 27 27+2.5 27 27+2.5
(59.5) (59.5) (59.5) (59.5) (59.5) (59.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures
in framed and 25% greyed cells depends on the strength of the boom.
Main Boom Load Charts 1/3 kg(lb)1000
Counterweight
kg(lb)1000
31
(1018)
Boom m(ft)
Radius m(ft)
34
(1117)
Pa g e 1 of 1 7
-
7/29/2019 80t Chapter Load Charts.pdf|
12/27
8.5
(2711)
9 28.38 29.70
(296) (62.57) (65.48)
10 24.60 25.78 24.43 25.61 24.14 25.32
(3210) (54.23) (56.83) (53.86) (56.46) (53.22) (55.82)
11 21.63 22.70 21.45 22.52 21.17 22.23 20.98 22.05
(361) (47.69) (50.04) (47.29) (49.65) (46.67) (49.01) (46.25) (48.61)
12 19.22 20.20 19.05 20.02 18.76 19.73 18.58 19.55 18.40 19.37
(394) (42.37) (44.53) (42) (44.14) (41.36) (43.5) (40.96) (43.1) (40.56) (42.7)
13 17.24 18.13 17.06 17.95 16.77 17.67 16.59 17.48 16.41 17.30
(428) (38.01) (39.97) (37.61) (39.57) (36.97) (38.96) (36.57) (38.54) (36.18) (38.14)
14 15.60 16.40 15.40 16.20 15.10 15.90 14.92 15.75 14.75 15.57
(4511) (34.33) (36.16) (33.93) (35.76) (33.31) (35.12) (32.89) (34.72) (32.52) (34.33)
15 14.20 14.90 14.00 14.70 13.70 14.50 13.50 14.27 13.33 14.09
(49
3
) (31.19)(32.89)
(30.82)(32.5)
(30.18)(31.88)
(29.76)(31.46)
(29.39)(31.06)
16 12.90 13.70 12.80 13.50 12.50 13.20 12.28 13.00 12.11 12.82
(526) (28.51) (30.09) (28.11) (29.7) (27.49) (29.06) (27.07) (28.66) (26.7) (28.26)
18 10.90 11.60 10.80 11.40 10.50 11.10 10.28 10.92 10.11 10.74
(591) (24.1) (25.51) (23.7) (25.11) (23.08) (24.47) (22.66) (24.07) (22.29) (23.68)
20 9.40 9.90 9.20 9.80 8.90 9.50 8.70 9.30 8.50 9.10
(657) (20.66) (21.89) (20.26) (21.52) (19.62) (20.88) (19.22) (20.48) (18.78) (20.08)
22 8.11 8.62 7.93 8.44 7.61 8.16 7.40 8.00 7.20 7.80
(722) (17.88) (19) (17.48) (18.61) (16.78) (17.99) (16.34) (17.57) (15.92) (17.17)
24 7.05 7.54 6.86 7.37 6.54 7.08 6.34 6.90 6.10 6.70
(789) (15.54) (16.62) (15.12) (16.25) (14.42) (15.61) (13.98) (15.19) (13.54) (14.79)
26 6.15 6.64 5.96 6.46 5.64 6.17 5.44 6.00 5.30 5.80
(854
) (13.56) (14.64) (13.14) (14.24) (12.43) (13.6) (11.99) (13.14) (11.57) (12.72)
28 5.39 5.87 5.20 5.68 4.88 5.37 4.68 5.16 4.50 5.00
(9110) (11.88) (12.94) (11.46) (12.52) (10.76) (11.84) (10.32) (11.38) (9.9) (10.96)
30 4.74 5.19 4.55 5.00 4.23 4.68 4.03 4.48 3.83 4.28
(985) (10.45) (11.44) (10.03) (11.02) (9.33) (10.32) (8.88) (9.88) (8.44) (9.44)
32 4.17 4.59 3.98 4.40 3.66 4.08 3.46 3.88 3.27 3.69
(10412) (9.19) (10.12) (8.77) (9.7) (8.07) (8.99) (7.63) (8.55) (7.21) (8.13)
34 3.48 3.88 3.17 3.56 2.97 3.36 2.77 3.16
(1117) (7.67) (8.55) (6.99) (7.85) (6.55) (7.41) (6.11) (6.97)
36 2.73 3.10 2.53 2.90 2.33 2.70
(1181) (6.02) (6.83) (5.58) (6.39) (5.14) (5.95)
38 2.34 2.69 2.14 2.49 1.94 2.29
(1248) (5.16) (5.93) (4.72) (5.49) (4.28) (5.05)27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
(15011) (1609)(1215) (1313) (1411)
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures
in framed and 25% greyed cells depends on the strength of the boom.
46 49
Main Boom Load Charts 2/3 kg(lb)1000
43
Counterweight
kg(lb)1000
Boom m(ft)
Radius m(ft)
37 40
Pa g e 2 of 1 7
-
7/29/2019 80t Chapter Load Charts.pdf|
13/27
11
(361)
12 18.11 19.08
(394) (39.93) (42.06)
13 16.13 17.02 15.94 16.83 15.66 16.55
(428) (35.56) (37.52) (35.14) (37.1) (34.52) (36.49)
14 14.46 15.28 14.28 15.10 13.99 14.81
(4511) (31.88) (33.69) (31.48) (33.29) (30.84) (32.65)
15 13.04 13.81 12.86 13.62 12.57 13.34
(493) (28.75) (30.45) (28.35) (30.03) (27.71) (29.41)
16 11.82 12.53 11.63 12.35 11.35 12.06
(526) (26.06) (27.62) (25.64) (27.23) (25.02) (26.59)
18 9.82 10.45 9.63 10.27 9.32 9.98
(591) (21.65) (23.04) (21.23) (22.64) (20.55) (22)
20 8.20 8.80 8.00 8.60 7.70 8.40
(657) (18.1) (19.44) (17.66) (19.05) (16.95) (18.41)
22 6.90 7.50 6.70 7.30 6.40 7.00
(722) (15.21) (16.56) (14.77) (16.14) (14.09) (15.45)
24 5.80 6.40 5.60 6.20 5.30 5.90
(789) (12.85) (14.18) (12.41) (13.65) (11.71) (12.96)
26 4.90 5.50 4.70 5.30 4.40 4.90
(854) (10.87) (12.13) (10.43) (11.57) (9.74) (10.89)
28 4.20 4.70 4.00 4.50 3.70 4.10
(9110) (9.19) (10.36) (8.75) (9.81) (8.07) (9.13)
30 3.52 4.01 3.32 3.77 3.00 3.45
(985
) (7.76) (8.84) (7.32) (8.31) (6.61) (7.61)
32 2.95 3.41 2.75 3.17 2.44 2.85
(10412) (6.5) (7.52) (6.06) (6.99) (5.38) (6.28)
34 2.46 2.88 2.25 2.65 1.94 2.33
(1117) (5.42) (6.35) (4.96) (5.84) (4.28) (5.14)
36 2.02 2.42 1.81 2.18 1.50 1.87
(1181) (4.45) (5.34) (3.99) (4.81) (3.31) (4.12)
38 1.63 2.01 1.42 1.77 1.11 1.46
(1248) (3.59) (4.43) (3.13) (3.9) (2.45) (3.22)
27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figuresin framed and 25% greyed cells depends on the strength of the boom.
Counterweight
kg(lb)1000
Main Boom Load Charts 3/3 kg(lb)1000
Boom m(ft)
Radius m(ft)
52 55 58
(1707) (1805) (1805)
Pa g e 3 of 1 7
-
7/29/2019 80t Chapter Load Charts.pdf|
14/27
0 9 13.5 18 0 9 13.5 18 0 9 13.5 18 0 9 13.5 18
(00) (296) (443) (591) (00) (296) (443) (591) (00) (296) (443) (591) (00) (296) (443) (591)
8.5(2711)
9 28.38 27.38 27.08 26.73 29.70 28.70 28.40 28.05 (296) (62.6) (60.4) (59.7) (58.8) (65.4) (63.2) (62.6) (61.7)
10 24.60 23.60 23.30 22.95 25.78 24.78 24.48 24.13 24.43 23.43 23.13 22.78 25.61 24.61 24.31 23.96 (3210) (54.2) (52) (51.3) (50.7) (56.8) (54.6) (54) (53.1) (53.7) (51.5) (50.9) (50.2) (56.4) (54.2) (53.5) (52.9)
11 21.63 20.63 20.33 19.98 22.70 21.70 21.40 21.05 21.45 20.45 20.15 19.80 22.52 21.52 21.22 20.87 (361) (47.6) (45.4) (44.7) (44) (50) (47.8) (47.1) (46.2) (47.3) (45.1) (44.5) (43.6) (49.6) (47.3) (46.7) (46)
12 19.22 18.22 17.92 17.57 20.20 19.20 18.90 18.55 19.05 18.05 17.75 17.40 20.02 19.02 18.72 18.37
(394) (42.3) (40.1) (39.4) (38.8) (44.5) (42.3) (41.6) (40.7) (41.8) (39.6) (39) (38.3) (44) (41.8) (41.2) (40.5)
13 17.24 16.24 15.94 15.59 18.13 17.13 16.83 16.48 17.06 16.06 15.76 15.41 17.95 16.95 16.65 16.30 (428) (37.9) (35.7) (35) (34.3) (39.9) (37.6) (37) (36.3) (37.6) (35.4) (34.8) (33.9) (39.6) (37.4) (36.8) (35.9)
14 15.57 14.57 14.27 13.92 16.40 15.40 15.10 14.75 15.39 14.39 14.09 13.74 16.22 15.22 14.92 14.57
(4511) (34.3) (32.1) (31.5) (30.6) (36.1) (33.9) (33.2) (32.4) (33.9) (31.7) (31) (30.2) (35.7) (33.5) (32.8) (32.1)
15 14.15 13.15 12.85 12.50 14.92 13.92 13.62 13.27 13.98 12.98 12.68 12.33 14.74 13.74 13.44 13.09
(493) (31.3) (29.1) (28.4) (27.5) (32.8) (30.6) (29.9) (29.3) (30.8) (28.6) (27.9) (27.1) (32.4) (30.2) (29.5) (28.8)
16 12.93 11.93 11.63 11.28 13.65 12.65 12.35 12.00 12.75 11.75 11.45 11.10 13.47 12.47 12.17 11.82
(526) (28.4) (26.2) (25.5) (24.9) (29.9) (27.7) (27.1) (26.4) (28.2) (26) (25.3) (24.4) (29.7) (27.5) (26.8) (26)
18 10.93 9.93 9.63 9.28 11.57 10.57 10.27 9.92 10.75 9.75 9.45 9.10 11.39 10.39 10.09 9.74
(591) (24) (21.8) (21.1) (20.5) (25.5) (23.3) (22.7) (21.8) (23.8) (21.6) (20.9) (20) (25.1) (22.9) (22.2) (21.3)
20 9.37 8.37 8.07 7.72 9.93 8.93 8.63 8.28 9.19 8.19 7.89 7.54 9.76 8.76 8.46 8.11
(657) (20.7) (18.5) (17.8) (16.9) (21.8) (19.6) (18.9) (18.2) (20.2) (18) (17.4) (16.5) (21.6) (19.4) (18.7) (17.8)
22 8.11 7.11 6.81 6.46 8.62 7.62 7.32 6.97 7.93 6.93 6.63 6.28 8.44 7.44 7.14 6.79
(722) (17.8) (15.6) (14.9) (14.3) (18.9) (16.7) (16) (15.4) (17.4) (15.2) (14.5) (13.8) (18.5) (16.3) (15.6) (14.9)
24 7.05 6.05 5.75 5.40 7.54 6.54 6.24 5.89 6.86 5.86 5.56 5.21 7.37 6.37 6.07 5.72
(789) (15.4) (13.2) (12.5) (11.9) (16.5) (14.3) (13.6) (13) (15.2) (13) (12.3) (11.4) (16.3) (14.1) (13.4) (12.5)
26 6.15 5.15 4.85 4.50 6.64 5.64 5.34 4.99 5.96 4.96 4.66 4.31 6.46 5.46 5.16 4.81
(854) (13.6) (11.4) (10.8) (9.9) (14.5) (12.3) (11.6) (11) (13.2) (11) (10.3) (9.4) (14.3) (12.1) (11.4) (10.5)
28 5.39 4.39 4.09 3.74 5.87 4.87 4.57 4.22 5.20 4.20 3.90 3.55 5.68 4.68 4.38 4.03
(9110) (11.9) (9.7) (9) (8.1) (13) (10.8) (10.1) (9.2) (11.4) (9.2) (8.5) (7.7) (12.5) (10.3) (9.7) (8.8)
30 4.74 3.74 3.44 3.09 5.19 4.19 3.89 3.54 4.55 3.55 3.25 2.90 5.00 4.00 3.70 3.35
(985) (10.3) (8.1) (7.4) (6.8) (11.4) (9.2) (8.5) (7.7) (9.9) (7.7) (7) (6.3) (11) (8.8) (8.1) (7.2)
32 4.17 3.17 2.87 2.52 4.59 3.59 3.29 2.94 3.98 2.98 2.68 2.33 4.40 3.40 3.10 2.75
(10412) (9.2) (7) (6.3) (5.5) (10.1) (7.9) (7.2) (6.3) (8.8) (6.6) (5.9) (5) (9.7) (7.4) (6.8) (5.9)
34 3.48 2.48 2.18 1.83 3.88 2.88 2.58 2.23
(1117) (7.7) (5.5) (4.8) (3.9) (8.5) (6.3) (5.7) (4.8)
36
(1181)
Counter-
weight
Rating Load Table of main hook with fixed jibboom length m unit kg (lb)1000
37 40
27 27+2.5 27 27+2.5
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed and 25% greyed cells depends on the strength
of the boom.
(1313)
(59.5) (59.5 5.5)(59.5) (59.5 5.5)
radius m
/(ft)(1215)
Page 4 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
15/27
0 9 13.5 18 0 9 13.5 18 0 9 13.5 18 0 9 13.5 18
(00) (296) (443) (591) (00) (296) (443) (591) (00) (296) (443) (591) (00) (296) (443) (591)
8.5
(2711)
9(296)
10 24.14 23.14 22.84 22.49 25.32 24.32 24.02 23.67 (3210) (53.1) (50.9) (50.2) (49.6) (55.7) (53.5) (52.9) (52.2)
11 21.17 20.17 19.87 19.52 22.23 21.23 20.93 20.58 20.98 19.98 19.68 19.33 22.05 21.05 20.75 20.40 (361) (46.7) (44.5) (43.8) (42.9) (48.9) (46.7) (46) (45.4) (46.2) (44) (43.4) (42.5) (48.5) (46.2) (45.6) (44.9)
12 18.76 17.76 17.46 17.11 19.73 18.73 18.43 18.08 18.58 17.58 17.28 16.93 19.55 18.55 18.25 17.90
. . . . . . . . . . . . . . .
13 16.77 15.77 15.47 15.12 17.67 16.67 16.37 16.02 16.59 15.59 15.29 14.94 17.48 16.48 16.18 15.83 (428) (37) (34.8) (34.1) (33.2) (39) (36.8) (36.1) (35.2) (36.5) (34.3) (33.7) (32.8) (38.5) (36.3) (35.7) (34.8)
14 15.11 14.11 13.81 13.46 15.93 14.93 14.63 14.28 14.92 13.92 13.62 13.27 15.75 14.75 14.45 14.10
(4511) (33.2) (31) (30.4) (29.7) (35) (32.8) (32.1) (31.5) (32.8) (30.6) (29.9) (29.3) (34.6) (32.4) (31.7) (31)
15 13.69 12.69 12.39 12.04 14.46 13.46 13.16 12.81 13.50 12.50 12.20 11.85 14.27 13.27 12.97 12.62
(493) (30.2) (27.9) (27.3) (26.4) (31.9) (29.7) (29.1) (28.2) (29.7) (27.5) (26.8) (26.2) (31.5) (29.3) (28.6) (27.7)
16 12.47 11.47 11.17 10.82 13.18 12.18 11.88 11.53 12.28 11.28 10.98 10.63 13.00 12.00 11.70 11.35
(526) (27.5) (25.3) (24.6) (23.8) (29.1) (26.8) (26.2) (25.3) (27.1) (24.9) (24.2) (23.3) (28.6) (26.4) (25.7) (24.9)
18 10.47 9.47 9.17 8.82 11.10 10.10 9.80 9.45 10.28 9.28 8.98 8.63 10.92 9.92 9.62 9.27
(591) (23.1) (20.9) (20.2) (19.4) (24.4) (22.2) (21.6) (20.9) (22.7) (20.5) (19.8) (18.9) (24) (21.8) (21.1) (20.5)
20 8.90 7.90 7.60 7.25 9.47 8.47 8.17 7.82 8.72 7.72 7.42 7.07 9.29 8.29 7.99 7.64
(657) (19.6) (17.4) (16.7) (16) (20.9) (18.7) (18) (17.1) (19.1) (16.9) (16.3) (15.6) (20.5) (18.2) (17.6) (16.7)
22 7.61 6.61 6.31 5.96 8.16 7.16 6.86 6.51 7.41 6.41 6.11 5.76 7.97 6.97 6.67 6.32
(722) (16.7) (14.5) (13.8) (13.2) (18) (15.8) (15.2) (14.3) (16.3) (14.1) (13.4) (12.7) (17.6) (15.4) (14.7) (13.8)
24 6.54 5.54 5.24 4.89 7.08 6.08 5.78 5.43 6.34 5.34 5.04 4.69 6.89 5.89 5.59 5.24
(789) (14.3) (12.1) (11.4) (10.8) (15.6) (13.4) (12.7) (11.9) (13.8) (11.6) (11) (10.3) (15.2) (13) (12.3) (11.4)
26 5.64 4.64 4.34 3.99 6.17 5.17 4.87 4.52 5.44 4.44 4.14 3.79 5.96 4.96 4.66 4.31
(854) (12.3) (10.1) (9.4) (8.8) (13.6) (11.4) (10.8) (9.9) (11.9) (9.7) (9) (8.3) (13.2) (11) (10.3) (9.4)
28 4.88 3.88 3.58 3.23 5.37 4.37 4.07 3.72 4.68 3.68 3.38 3.03 5.16 4.16 3.86 3.51
(9110) (10.8) (8.5) (7.9) (7) (11.9) (9.7) (9) (8.1) (10.3) (8.1) (7.4) (6.6) (11.4) (9.2) (8.5) (7.7)
30 4.23 3.23 2.93 2.58 4.68 3.68 3.38 3.03 4.03 3.03 2.73 2.38 4.48 3.48 3.18 2.83 (985) (9.2) (7) (6.3) (5.7) (10.3) (8.1) (7.4) (6.6) (8.8) (6.6) (5.9) (5.2) (9.9) (7.7) (7) (6.1)
32 3.66 2.66 2.36 2.01 4.08 3.08 2.78 2.43 3.46 2.46 2.16 1.81 3.88 2.88 2.58 2.23
(10412) (8.1) (5.9) (5.2) (4.4) (9) (6.8) (6.1) (5.2) (7.7) (5.5) (4.8) (3.9) (8.5) (6.3) (5.7) (4.8)
34 3.17 2.17 1.87 1.52 3.56 2.56 2.26 1.91 2.97 1.97 1.67 1.32 3.36 2.36 2.06 1.71
(1117) (7) (4.8) (4.1) (3.3) (7.9) (5.7) (5) (4.1) (6.6) (4.4) (3.7) (2.8) (7.4) (5.2) (4.6) (3.7)
36 2.73 1.73 1.43 1.08 3.10 2.10 1.80 1.45 2.53 1.53 1.23 0.88 2.90 1.90 1.60 1.25
(1181) (5.9) (3.7) (3) (2.4) (6.8) (4.6) (3.9) (3) (5.5) (3.3) (2.6) (1.9) (6.3) (4.1) (3.5) (2.6)
38 2.34 1.34 1.04 2.69 1.69 1.39 1.04 2.14 1.14 0.84 2.49 1.49 1.19 0.84
(1248) (5) (2.8) (2.2) (5.9) (3.7) (3) (2.2) (4.6) (2.4) (1.7) (5.5) (3.3) (2.6) (1.7)
Counter-
weight
27+2.5
(59.5 5.5) (59.5 5.5)
(15011)(1411)
27
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed and 25% greyed cells depends on the strength
of the boom.
(59.5) (59.5)
Rating Load Table of main hook with fixed jibradius m
/(ft)
boom length m unit kg (lb)1000
43 46
27 27+2.5
Page 5 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
16/27
0 9 13.5 18 0 9 13.5 18 0 9 13.5 0 9 13.5
(00) (296) (443) (591) (00) (296) (443) (591) (00) (296) (443) (00) (296) (443)
8.5
(2711)
9
(296)
10
(3210)
11(361)
12 18.40 17.40 17.10 16.75 19.37 18.37 18.07 17.72 18.11 17.11 16.81 19.08 18.08 17.78
(394) (40.5) (38.3) (37.6) (36.8) (42.7) (40.5) (39.9) (39) (39.9) (37.6) (37) (42.1) (39.9) (39.2)
13 16.41 15.41 15.11 14.76 17.30 16.30 16.00 15.65 16.13 15.13 14.83 17.02 16.02 15.72 (428) (36.1) (33.9) (33.2) (32.6) (38.1) (35.9) (35.2) (34.6) (35.4) (33.2) (32.6) (37.4) (35.2) (34.6)
14 14.75 13.75 13.45 13.10 15.57 14.57 14.27 13.92 14.46 13.46 13.16 15.28 14.28 13.98
(4511) (32.4) (30.2) (29.5) (28.8) (34.3) (32.1) (31.5) (30.6) (31.9) (29.7) (29.1) (33.7) (31.5) (30.8)
15 13.33 12.33 12.03 11.68 14.09 13.09 12.79 12.44 13.04 12.04 11.74 13.81 12.81 12.51
(493) (29.3) (27.1) (26.4) (25.7) (31) (28.8) (28.2) (27.3) (28.6) (26.4) (25.7) (30.4) (28.2) (27.5)
16 12.11 11.11 10.81 10.46 12.82 11.82 11.52 11.17 11.82 10.82 10.52 12.53 11.53 11.23
(526) (26.6) (24.4) (23.8) (23.1) (28.2) (26) (25.3) (24.6) (26) (23.8) (23.1) (27.5) (25.3) (24.6)
18 10.11 9.11 8.81 8.46 10.74 9.74 9.44 9.09 9.82 8.82 8.52 10.45 9.45 9.15
(591) (22.2) (20) (19.4) (18.7) (23.5) (21.3) (20.7) (20) (21.6) (19.4) (18.7) (23.1) (20.9) (20.2)
20 8.52 7.52 7.22 6.87 9.11 8.11 7.81 7.46 8.21 7.21 6.91 8.82 7.82 7.52
(657) (18.7) (16.5) (15.8) (15.2) (20) (17.8) (17.1) (16.5) (18) (15.8) (15.2) (19.4) (17.1) (16.5)
22 7.22 6.22 5.92 5.57 7.79 6.79 6.49 6.14 6.90 5.90 5.60 7.51 6.51 6.21
(722) (15.8) (13.6) (13) (12.3) (17.1) (14.9) (14.3) (13.4) (15.2) (13) (12.3) (16.5) (14.3) (13.6)
24 6.14 5.14 4.84 4.49 6.71 5.71 5.41 5.06 5.83 4.83 4.53 6.43 5.43 5.13
(789) (13.4) (11.2) (10.5) (9.9) (14.7) (12.5) (11.9) (11.2) (12.7) (10.5) (9.9) (14.1) (11.9) (11.2)
26 5.25 4.25 3.95 3.60 5.77 4.77 4.47 4.12 4.93 3.93 3.63 5.50 4.50 4.20
(854) (11.4) (9.2) (8.5) (7.9) (12.7) (10.5) (9.9) (9) (10.8) (8.5) (7.9) (12.1) (9.9) (9.2)
28 4.49 3.49 3.19 2.84 4.97 3.97 3.67 3.32 4.17 3.17 2.87 4.70 3.70 3.40
(9110) (9.9) (7.7) (7) (6.1) (11) (8.8) (8.1) (7.2) (9.2) (7) (6.3) (10.3) (8.1) (7.4)
30 3.83 2.83 2.53 2.18 4.28 3.28 2.98 2.63 3.52 2.52 2.22 4.01 3.01 2.71
(985) (8.3) (6.1) (5.5) (4.8) (9.4) (7.2) (6.6) (5.7) (7.7) (5.5) (4.8) (8.8) (6.6) (5.9)
32 3.27 2.27 1.97 1.62 3.69 2.69 2.39 2.04 2.95 1.95 1.65 3.41 2.41 2.11
(10412) (7.2) (5) (4.4) (3.5) (8.1) (5.9) (5.2) (4.4) (6.6) (4.4) (3.7) (7.4) (5.2) (4.6)
34 2.77 1.77 1.47 1.12 3.16 2.16 1.86 1.51 2.46 1.46 1.16 2.88 1.88 1.58
(1117) (6.1) (3.9) (3.3) (2.4) (7) (4.8) (4.1) (3.3) (5.5) (3.3) (2.6) (6.3) (4.1) (3.5)
36 2.33 1.33 1.03 2.70 1.70 1.40 1.05 2.02 1.02 2.42 1.42 1.12
(1181) (5) (2.8) (2.2) (5.9) (3.7) (3) (2.4) (4.4) (2.2) (5.2) (3) (2.4)
38 1.94 0.94 2.29 1.29 0.99 1.63 2.01 1.01
(1248) (4.1) (1.9) (5) (2.8) (2.2) (3.5) (4.4) (2.2)
Counter-
weight
(1707)(1609)
radius m
/(ft)
boom length m unit kg (lb)1000
49
Rating Load Table of main hook with fixed jib
52.00
27 27 27+2.5
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed and 25% greyed cells
depends on the strength of the boom.
(59.5 5.5) (59.5 5.5)(59.5) (59.5)
27+2.5
Page 6 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
17/27
13 16 19 22 25 28
(42'8") (52'6") (62'4") (72'2") (82') (91'10")
4.3 79.80
(141) (175.9)
4.5 76.30
(149) (168.2)
5 67.87 66.60
(165) (149.6) (146.8)
5.5 58.98 58.70 58.52
(181) (130) (129.4) (128.9)
6 52.10 51.82 51.64 51.46
(198) (114.8) (114.1) (113.7) (113.5)
6.5 46.62 46.34 46.15 45.98 45.70
(214) (102.7) (102) (101.8) (101.4) (100.7)
7 42.14 41.86 41.68 41.50 41.22 40.52
(2212) (92.8) (92.3) (91.9) (91.4) (90.8) (89.2)
7.5 38.43 38.10 38.00 37.80 37.50 36.90 36.69 38.30(247) (84.6) (83.9) (83.7) (83.3) (82.6) (81.3) (80.9) (84.4)
8 35.29 35.00 34.82 34.64 34.36 33.77 33.59 35.09 33.31 34.81(263) (77.8) (77.1) (76.7) (76.2) (75.8) (74.5) (74) (77.3) (73.4) (76.7)
8.5 32.60 32.31 32.13 31.96 31.67 31.12 30.94 32.35 30.66 32.06
(2711) (71.8) (71.2) (70.7) (70.5) (69.8) (68.5) (68.1) (71.4) (67.6) (70.7)
9 30.27 29.99 29.81 29.63 29.35 28.82 28.65 29.97 28.36 29.68
(296) (66.7) (66.1) (65.6) (65.2) (64.8) (63.4) (63.2) (66.1) (62.6) (65.4)
10 26.45 26.17 25.98 25.81 25.52 25.05 24.87 26.06 24.59 25.77
(3210) (58.4) (57.7) (57.3) (56.8) (56.2) (55.3) (54.8) (57.5) (54.2) (56.8)
11 23.44 23.15 22.97 22.79 22.51 22.08 21.90 22.97 21.61 22.68
(361) (51.5) (51.1) (50.7) (50.2) (49.6) (48.7) (48.2) (50.7) (47.6) (50)
12 21.01 20.72 20.54 20.36 20.07 19.67 19.49 20.47 19.21 20.18
(394) (46.2) (45.6) (45.1) (44.9) (44.3) (43.4) (42.9) (45.1) (42.3) (44.5)
13 18.71 18.53 18.35 18.07 17.68 17.51 18.40 17.22 18.12
(428) (41.2) (40.7) (40.5) (39.9) (39) (38.5) (40.5) (37.9) (39.9)
14 17.03 16.84 16.67 16.38 16.02 15.84 16.67 15.56 16.38
(4511) (37.4) (37) (36.8) (36.1) (35.2) (34.8) (36.8) (34.3) (36.1)
15 15.41 15.23 14.95 14.60 14.42 15.19 14.14 14.91
(493) (33.9) (33.5) (33) (32.1) (31.7) (33.5) (31) (32.8)
16 14.17 14.00 13.71 13.38 13.20 13.92 12.91 13.63
(526) (31.3) (30.8) (30.2) (29.5) (29.1) (30.6) (28.4) (29.9)
18 11.98 11.69 11.38 11.20 11.84 10.92 11.55
(591) (26.4) (25.7) (25.1) (24.6) (26) (24) (25.5)
20 10.11 9.81 9.64 10.21 9.35 9.92
(657) (22.2) (21.6) (21.1) (22.4) (20.7) (21.8)
22 8.83 8.55 8.38 8.89 8.09 8.61
(722) (19.4) (18.9) (18.5) (19.6) (17.8) (18.9)
24 7.52 7.34 7.81 7.05 7.53
(789
) (16.5) (16) (17.1) (15.6) (16.5)
26 6.47 6.91 6.16 6.62
(854) (14.3) (15.2) (13.6) (14.5)
28 5.40 5.86
(9110) (11.9) (13)
30 4.74 5.19
(985) (10.3) (11.4)
27 27 27 27 27 27 27 27+2.5 27 27+2.5
(59.5) (59.5) (59.5) (59.5) (59.5) (59.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
31 34
Main Boom Load Charts 1/3 kg(lb)1000
With Boom extension
Boom m(ft)
Radius m(ft) (101'8") (111'7")
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures
in framed and 25% greyed cells depends on the strength of the boom.
Page 7 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
18/27
9 28.18 29.50
(296) (62.13) (65.04)
10 24.40 25.58 24.23 25.41 23.94 25.12
(3210) (53.79) (56.39) (53.42) (56.02) (52.78) (55.38)
11 21.43 22.50 21.25 22.32 20.97 22.03 20.78 21.85
(361) (47.24) (49.6) (46.85) (49.21) (46.23) (48.57) (45.81) (48.17)
12 19.02 20.00 18.85 19.82 18.56 19.53 18.38 19.35 18.20 19.17
(394) (41.93) (44.09) (41.56) (43.69) (40.92) (43.06) (40.52) (42.66) (40.12) (42.26)
13 17.04 17.93 16.86 17.75 16.57 17.47 16.39 17.28 16.21 17.10
(428) (37.57) (39.53) (37.17) (39.13) (36.53) (38.51) (36.13) (38.1) (35.74) (37.7)
14 15.37 16.20 15.19 16.02 14.91 15.73 14.72 15.55 14.55 15.37
(4511) (33.88) (35.71) (33.49) (35.32) (32.87) (34.68) (32.45) (34.28) (32.08) (33.88)
15 13.95 14.72 13.78 14.54 13.49 14.26 13.30 14.07 13.13 13.89
(493) (30.75) (32.45) (30.38) (32.05) (29.74) (31.44) (29.32) (31.02) (28.95) (30.62)
16 12.70 13.50 12.60 13.30 12.30 13.00 12.10 12.80 11.90 12.60
(526) (28.06) (29.65) (27.67) (29.25) (27.05) (28.62) (26.63) (28.22) (26.26) (27.82)
18 10.70 11.40 10.60 11.20 10.30 10.90 10.10 10.70 9.90 10.50
(591) (23.66) (25.07) (23.26) (24.67) (22.64) (24.03) (22.22) (23.63) (21.85) (23.24)
20 9.17 9.70 9.00 9.60 8.70 9.30 8.50 9.10 8.30 8.90
(657) (20.22) (21.45) (19.82) (21.08) (19.18) (20.44) (18.78) (20.04) (18.34) (19.64)
22 7.91 8.40 7.70 8.20 7.40 8.00 7.20 7.80 7.00 7.60
(722) (17.44) (18.56) (17.04) (18.17) (16.34) (17.55) (15.9) (17.13) (15.48) (16.73)
24 6.85 7.34 6.70 7.20 6.30 6.90 6.10 6.70 5.90 6.50
(789) (15.1) (16.18) (14.68) (15.81) (13.98) (15.17) (13.54) (14.75) (13.1) (14.35)
26 5.95 6.44 5.76 6.26 5.44 5.97 5.24 5.76 5.05 5.57
(854) (13.12) (14.2) (12.7) (13.8) (11.99) (13.16) (11.55) (12.7) (11.13) (12.28)
28 5.19 5.67 5.00 5.48 4.68 5.17 4.48 4.96 4.29 4.77
(9110
) (11.44) (12.5) (11.02) (12.08) (10.32) (11.4) (9.88) (10.93) (9.46) (10.52)
30 4.54 4.99 4.35 4.80 4.03 4.48 3.83 4.28 3.63 4.08
(985) (10.01) (11) (9.59) (10.58) (8.88) (9.88) (8.44) (9.44) (8) (8.99)
32 3.97 4.39 3.78 4.20 3.46 3.88 3.26 3.68 3.07 3.49
(10412) (8.75) (9.68) (8.33) (9.26) (7.63) (8.55) (7.19) (8.11) (6.77) (7.69)
34 3.28 3.68 2.97 3.36 2.77 3.16 2.57 2.96
(1117) (7.23) (8.11) (6.55) (7.41) (6.11) (6.97) (5.67) (6.53)
36 2.53 2.90 2.33 2.70 2.13 2.50
(1181) (5.58) (6.39) (5.14) (5.95) (4.7) (5.51)
38 2.14 2.49 1.94 2.29 1.74 2.09
(1248) (4.72) (5.49) (4.28) (5.05) (3.84) (4.61)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Main Boom Load Charts 2/3 kg(lb)1000
37 40 43
With Boom extension
Boom m(ft)
Radius m(ft) (121'5") (141'1") (150'11") (140'9")(131'3")
46 49
Counterweight
kg(lb)
1000Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures
in framed and 25% greyed cells depends on the strength of the boom.
Page 8 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
19/27
12 17.91 18.88(394) (39.48) (41.62)
13 15.93 16.82 15.74 16.63 15.46 16.35
(428) (35.12) (37.08) (34.7) (36.66) (34.08) (36.04)
14 14.26 15.08 14.08 14.90 13.79 14.61
(4511) (31.44) (33.25) (31.04) (32.85) (30.4) (32.21)
15 12.84 13.61 12.66 13.42 12.37 13.14
(493) (28.31) (30) (27.91) (29.59) (27.27) (28.97)
16 11.62 12.33 11.43 12.15 11.15 11.86
(526) (25.62) (27.18) (25.2) (26.79) (24.58) (26.15)
18 9.62 10.25 9.43 10.07 9.12 9.78
(591) (21.21) (22.6) (20.79) (22.2) (20.11) (21.56)
20 8.01 8.62 7.81 8.44 7.49 8.15
(657) (17.66) (19) (17.22) (18.61) (16.51) (17.97)
22 6.70 7.30 6.50 7.10 6.20 6.80
(722) (14.77) (16.12) (14.33) (15.7) (13.65) (15.01)
24 5.60 6.20 5.40 6.00 5.10 5.70
(789) (12.41) (13.73) (11.97) (13.21) (11.27) (12.52)
26 4.73 5.30 4.50 5.10 4.20 4.70
(854) (10.43) (11.68) (9.99) (11.13) (9.3) (10.45)
28 3.97 4.50 3.80 4.30 3.50 3.90
(9110) (8.75) (9.92) (8.31) (9.37) (7.63) (8.69)
30 3.32 3.81 3.10 3.60 2.80 3.30
(985) (7.32) (8.4) (6.88) (7.87) (6.17) (7.16)32 2.75 3.21 2.55 2.97 2.24 2.65
(10412) (6.06) (7.08) (5.62) (6.55) (4.94) (5.84)
34 2.26 2.68 2.05 2.45 1.74 2.13
(1117) (4.98) (5.91) (4.52) (5.4) (3.84) (4.7)
36 1.82 2.22 1.61 1.98 1.30 1.67
(1181) (4.01) (4.89) (3.55) (4.37) (2.87) (3.68)
38 1.43 1.81 1.22 1.57 0.91 1.26
(1248) (3.15) (3.99) (2.69) (3.46) (2.01) (2.78)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figuresin framed and 25% greyed cells depends on the strength of the boom.
Main Boom Load Charts 3/3 kg(lb)1000
52 55 58Boom m(ft)
Radius m(ft) (1707)
With Boom extension
Counterweight
kg(lb)1000
(1805) (1903)
Page 9 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
20/27
4.78 5.16 4.51 4.87 4.06 4.40 3.60 3.60 3.48 3.50 2.40 2.40
(10.54) (11.38) (9.94) (10.74) (8.95) (9.7) (7.94) (7.94) (7.67) (7.72) (5.29) (5.29)
5.00 5.39 4.71 5.00 4.25 4.60 3.60 3.60 3.50 3.50 2.40 2.40
(11.02) (11.88) (10.38) (11.02) (9.37) (10.14) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.24 5.64 4.91 5.00 4.46 4.82 3.60 3.60 3.50 3.50 2.40 2.40
(11.55) (12.43) (10.82) (11.02) (9.83) (10.63) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.49 5.90 5.00 5.00 4.67 5.04 3.60 3.60 3.50 3.50 2.40 2.40
(12.1) (13.01) (11.02) (11.02) (10.3) (11.11) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.76 6.00 5.00 5.00 4.90 5.27 3.60 3.60 3.50 3.50 2.40 2.40
(12.7) (13.23) (11.02) (11.02) (10.8) (11.62) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.15 5.53 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (11.35) (12.19) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.41 5.81 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (11.93) (12.81) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.70 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (12.57) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Fixed Jib Load Charts 1/6 kg(lb) 1000
Boom length
m(ft)
37m
(121'5")
Jib length
m(ft)
9m 13.5m 18m
(29'6") (44'3") (59'1")
30 15 30
58
Jib angle
Boom angle15 30 15
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
Page 10 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
21/27
4.13 4.49 3.91 4.25 3.52 3.84 3.26 3.56 3.01 3.30 2.40 2.40
(9.1) (9.9) (8.62) (9.37) (7.76) (8.47) (7.19) (7.85) (6.64) (7.28) (5.29) (5.29)
4.34 4.71 4.10 4.45 3.70 4.03 3.41 3.60 3.17 3.47 2.40 2.40
(9.57) (10.38) (9.04) (9.81) (8.16) (8.88) (7.52) (7.94) (6.99) (7.65) (5.29) (5.29)
4.57 4.95 4.30 4.66 3.89 4.23 3.50 3.60 3.34 3.50 2.40 2.40
(10.07) (10.91) (9.48) (10.27) (8.58) (9.33) (7.72) (7.94) (7.36) (7.72) (5.29) (5.29)
4.81 5.20 4.51 4.88 4.10 4.45 3.60 3.60 3.50 3.50 2.40 2.40
(10.6) (11.46) (9.94) (10.76) (9.04) (9.81) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.06 5.46 4.74 5.00 4.32 4.68 3.60 3.60 3.50 3.50 2.40 2.40
(11.16) (12.04) (10.45) (11.02) (9.52) (10.32) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.34 5.75 4.98 5.00 4.56 4.93 3.60 3.60 3.50 3.50 2.40 2.40
(11.77) (12.68) (10.98) (11.02) (10.05) (10.87) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.63 6.00 5.00 5.00 4.71 5.09 3.60 3.60 3.50 3.50 2.40 2.40
(12.41) (13.23) (11.02) (11.02) (10.38) (11.22) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.10 5.50 3.60 3.60 3.50 3.50 2.40 2.40
(13.12) (13.23) (11.02) (11.02) (11.22) (12.08) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.40 5.80 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (11.86) (12.74) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.70 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (12.57) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Fixed Jib Load Charts 2/6 kg(lb) 1000
Boom length
m(ft)
40m
(131'3")
Jib length
m(ft)
9m 13.5m 18m
(29'6") (44'3") (59'1")
30 15 30
58
Jib angle
Boom angle15 30 15
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
Page 11 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
22/27
3.59 3.93 3.40 3.73 3.05 3.36 2.83 3.12 2.60 2.88 2.37 2.40
(7.91) (8.66) (7.5) (8.22) (6.72) (7.41) (6.24) (6.88) (5.73) (6.35) (5.22) (5.29)
3.78 4.13 3.58 3.91 3.22 3.54 2.98 3.28 2.76 3.05 2.40 2.40
(8.33) (9.1) (7.89) (8.62) (7.1) (7.8) (6.57) (7.23) (6.08) (6.72) (5.29) (5.29)
4.00 4.36 3.77 4.11 3.41 3.73 3.14 3.44 2.92 3.21 2.40 2.40
(8.82) (9.61) (8.31) (9.06) (7.52) (8.22) (6.92) (7.58) (6.44) (7.08) (5.29) (5.29)
4.22 4.59 3.97 4.32 3.61 3.94 3.32 3.60 3.18 3.48 2.40 2.40
(9.3) (10.12) (8.75) (9.52) (7.96) (8.69) (7.32) (7.94) (7.01) (7.67) (5.29) (5.29)
4.47 4.85 4.19 4.55 3.82 4.16 3.50 3.60 3.29 3.50 2.40 2.40
(9.85) (10.69) (9.24) (10.03) (8.42) (9.17) (7.72) (7.94) (7.25) (7.72) (5.29) (5.29)
4.73 5.12 4.42 4.79 4.05 4.40 3.60 3.60 3.49 3.50 2.40 2.40
(10.43) (11.29) (9.74) (10.56) (8.93) (9.7) (7.94) (7.94) (7.69) (7.72) (5.29) (5.29)
5.01 5.41 4.64 5.00 4.29 4.65 3.60 3.60 3.50 3.50 2.40 2.40
(11.04) (11.93) (10.23) (11.02) (9.46) (10.25) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.30 5.70 4.90 5.00 4.60 4.90 3.60 3.60 3.50 3.50 2.40 2.40
(11.71) (12.61) (10.89) (11.02) (10.03) (10.85) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.60 6.00 5.00 5.00 4.80 5.20 3.60 3.60 3.50 3.50 2.40 2.40
(12.43) (13.23) (11.02) (11.02) (10.67) (11.51) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.10 5.50 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (11.33) (12.21) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.50 5.90 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (12.06) (12.96) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.80 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (12.85) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Fixed Jib Load Charts 3/6 kg(lb) 1000
Boom length
m(ft)
43m
(141'1")
Jib length
m(ft)
9m 13.5m 18m
(29'6") (44'3") (59'1")
30 15 30
58
Jib angle
Boom angle15 30 15
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
Page 12 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
23/27
3.04 3.36 2.88 3.36 2.58 2.87 2.39 2.67 2.19 2.46 1.99 2.24
(6.7) (7.41) (6.35) (7.41) (5.69) (6.33) (5.27) (5.89) (4.83) (5.42) (4.39) (4.94)
3.23 3.56 3.06 3.56 2.74 3.04 2.54 2.82 2.34 2.62 2.12 2.38
(7.12) (7.85) (6.75) (7.85) (6.04) (6.7) (5.6) (6.22) (5.16) (5.78) (4.67) (5.25)
3.43 3.77 3.24 3.77 2.92 3.23 2.70 2.99 2.50 2.78 2.26 2.40
(7.56) (8.31) (7.14) (8.31) (6.44) (7.12) (5.95) (6.59) (5.51) (6.13) (4.98) (5.29)
3.65 4.00 3.44 4.00 3.11 3.43 2.87 3.17 2.67 2.96 2.38 2.40
(8.05) (8.82) (7.58) (8.82) (6.86) (7.56) (6.33) (6.99) (5.89) (6.53) (5.25) (5.29)
3.88 4.24 3.65 4.24 3.32 3.65 3.04 3.34 2.85 3.15 2.40 2.40
(8.55) (9.35) (8.05) (9.35) (7.32) (8.05) (6.7) (7.36) (6.28) (6.94) (5.29) (5.29)
4.13 4.50 3.87 4.50 3.53 3.86 3.23 3.54 3.04 3.35 2.40 2.40
(9.1) (9.92) (8.53) (9.92) (7.78) (8.51) (7.12) (7.8) (6.7) (7.39) (5.29) (5.29)
4.39 4.77 4.11 4.77 3.77 4.11 3.43 3.60 3.25 3.50 2.40 2.40
(9.68) (10.52) (9.06) (10.52) (8.31) (9.06) (7.56) (7.94) (7.16) (7.72) (5.29) (5.29)
4.70 5.10 4.40 5.10 4.00 4.40 3.60 3.60 3.50 3.50 2.40 2.40
(10.32) (11.18) (9.61) (11.18) (8.86) (9.66) (7.94) (7.94) (7.65) (7.72) (5.29) (5.29)
5.00 5.40 4.60 5.40 4.30 4.70 3.60 3.60 3.50 3.50 2.40 2.40
(11.02) (11.93) (10.23) (11.93) (9.46) (10.27) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.34 5.80 4.90 5.80 4.60 5.00 3.60 3.60 3.50 3.50 2.40 2.40
(11.77) (12.7) (10.89) (12.7) (10.12) (10.96) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.70 6.00 5.00 6.00 4.90 5.30 3.60 3.60 3.50 3.50 2.40 2.40
(12.57) (13.23) (11.02) (13.23) (10.82) (11.68) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 5.30 5.70 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (11.57) (12.48) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 5.63 6.00 3.60 3.60 3.50 3.50 2.40 2.40(13.23) (13.23) (11.02) (13.23) (12.41) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 6.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (13.23) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Fixed Jib Load Charts 4/6 kg(lb) 1000
Boom length
m(ft)
46m
(150'11")
Jib length
m(ft)
9m 13.5m 18m
(29'6") (44'3") (59'1")
30 15 30
58
Jib angle
Boom angle15 30 15
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
Page 13 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
24/27
2.56 2.87 2.43 2.73 2.18 2.46 2.02 2.29 1.83 2.09 1.67 1.91
(5.64) (6.33) (5.36) (6.02) (4.81) (5.42) (4.45) (5.05) (4.03) (4.61) (3.68) (4.21)
2.74 3.06 2.60 2.90 2.34 2.63 2.17 2.44 1.98 2.24 1.79 2.04
(6.04) (6.75) (5.73) (6.39) (5.16) (5.8) (4.78) (5.38) (4.37) (4.94) (3.95) (4.5)
2.93 3.25 2.78 3.09 2.51 2.81 2.32 2.60 2.13 2.40 1.93 2.18
(6.46) (7.16) (6.13) (6.81) (5.53) (6.19) (5.11) (5.73) (4.7) (5.29) (4.25) (4.81)
3.14 3.47 2.96 3.28 2.69 2.99 2.48 2.77 2.29 2.57 2.07 2.33
(6.92) (7.65) (6.53) (7.23) (5.93) (6.59) (5.47) (6.11) (5.05) (5.67) (4.56) (5.14)
3.36 3.70 3.17 3.50 2.80 3.11 2.65 2.94 2.47 2.76 2.22 2.40
(7.41) (8.16) (6.99) (7.72) (6.17) (6.86) (5.84) (6.48) (5.45) (6.08) (4.89) (5.29)
3.60 3.95 3.30 3.64 3.09 3.41 2.84 3.14 2.66 2.95 2.38 2.40
(7.94) (8.71) (7.28) (8.02) (6.81) (7.52) (6.26) (6.92) (5.86) (6.5) (5.25) (5.29)
3.85 4.21 3.61 3.96 3.32 3.65 3.03 3.34 2.86 3.16 2.40 2.40
(8.49) (9.28) (7.96) (8.73) (7.32) (8.05) (6.68) (7.36) (6.31) (6.97) (5.29) (5.29)
4.10 4.50 3.90 4.20 3.60 3.90 3.20 3.60 3.10 3.40 2.40 2.40
(9.1) (9.94) (8.51) (9.3) (7.85) (8.6) (7.14) (7.85) (6.77) (7.45) (5.29) (5.29)
4.40 4.80 4.10 4.50 3.70 4.10 3.50 3.60 3.30 3.50 2.40 2.40
(9.77) (10.63) (9.08) (9.9) (8.2) (8.97) (7.65) (7.94) (7.3) (7.72) (5.29) (5.29)
4.75 5.20 4.40 4.80 4.10 4.50 3.60 3.60 3.50 3.50 2.40 2.40
(10.47) (11.35) (9.72) (10.56) (9.06) (9.85) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.11 5.50 4.70 5.00 4.40 4.80 3.60 3.60 3.50 3.50 2.40 2.40
(11.27) (12.19) (10.41) (11.02) (9.72) (10.56) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.49 5.92 5.00 5.00 4.80 5.10 3.60 3.60 3.50 3.50 2.40 2.40
(12.1) (13.05) (11.02) (11.02) (10.47) (11.33) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
5.91 6.00 5.00 5.00 5.11 5.51 3.60 3.60 3.50 3.50 2.40 2.40(13.03) (13.23) (11.02) (11.02) (11.27) (12.15) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.52 5.94 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (12.17) (13.1) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 5.96 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.14) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
6.00 6.00 5.00 5.00 6.00 6.00 3.60 3.60 3.50 3.50 2.40 2.40
(13.23) (13.23) (11.02) (11.02) (13.23) (13.23) (7.94) (7.94) (7.72) (7.72) (5.29) (5.29)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
Boom length
m(ft)
49m
(160'9")
Fixed Jib Load Charts 5/6 kg(lb) 1000
Jib length
m(ft)
9m 13.5m 18m
(29'6") (44'3") (59'1")
30 15 30
58
Jib angle
Radius m(ft)15 30 15
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
Counterweight
kg(lb)1000
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
Page 14 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
25/27
2.05 2.35 1.94 2.22 1.74 2.01 1.62 1.88
(4.52) (5.18) (4.28) (4.89) (3.84) (4.43) (3.57) (4.14)
2.19 2.49 2.08 2.37 1.90 2.18 1.76 2.02
(4.83) (5.49) (4.59) (5.22) (4.19) (4.81) (3.88) (4.45)
2.34 2.65 2.22 2.52 2.06 2.34 1.91 2.18
(5.16) (5.84) (4.89) (5.56) (4.54) (5.16) (4.21) (4.81)
2.51 2.83 2.37 2.68 2.24 2.53 2.06 2.33
(5.53) (6.24) (5.22) (5.91) (4.94) (5.58) (4.54) (5.14)
2.69 3.02 2.54 2.85 2.42 2.72 2.23 2.51
(5.93) (6.66) (5.6) (6.28) (5.34) (6) (4.92) (5.53)
2.88 3.22 2.64 2.96 2.63 2.94 2.41 2.70
(6.35) (7.1) (5.82) (6.53) (5.8) (6.48) (5.31) (5.95)
3.08 3.43 2.89 3.22 2.84 3.16 2.60 2.90
(6.79) (7.56) (6.37) (7.1) (6.26) (6.97) (5.73) (6.39)
3.30 3.70 3.10 3.40 3.10 3.40 2.90 3.20
(7.28) (8.07) (6.81) (7.56) (6.79) (7.52) (6.35) (7.01)
3.50 3.90 3.30 3.70 3.30 3.70 3.00 3.30
(7.8) (8.62) (7.28) (8.05) (7.34) (8.09) (6.66) (7.34)
3.80 4.20 3.50 3.90 3.60 4.00 3.30 3.60
(8.38) (9.22) (7.78) (8.58) (7.94) (8.71) (7.19) (7.89)
4.09 4.50 3.80 4.00 3.90 4.30 3.50 3.60
(9.02) (9.9) (8.33) (8.82) (8.6) (9.39) (7.74) (7.94)
4.39 4.80 4.00 4.00 4.20 4.60 3.60 3.60
(9.68) (10.58) (8.82) (8.82) (9.3) (10.12) (7.94) (7.94)
4.73 4.80 4.00 4.00 4.50 4.80 3.60 3.60(10.43) (10.58) (8.82) (8.82) (9.92) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.66 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.27) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
4.80 4.80 4.00 4.00 4.80 4.80 3.60 3.60
(10.58) (10.58) (8.82) (8.82) (10.58) (10.58) (7.94) (7.94)
27 27+2.5 27 27+2.5 27 27+2.5 27 27+2.5
(59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5) (59.5) (59.5+5.5)
52m
(170'7")
Fixed Jib Load Charts 6/6 kg(lb) 1000
Boom length
m(ft)
64
30
58
59
60
Jib angle
Boom angle15 30 15
74
75
76
69
70
71
72
73
65
66
67
68
61
62
63
Jib length
m(ft)
9m 13.5m
(29'6") (44'3")
Note: italic figures in 40% greyed cells indicate rated load when the crane is equipped with additional counterweight; and figures in framed
and 25% greyed cells depends on the strength of the boom.
77
78
Counterweight
kg(lb)1000
Page 15 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
26/27
13 16 19 22 25 28 31 34
(42'8") (52'6") (62'4") (72'2") (82') (91'10") (101'8") (111'7")
4.3 9.0
(141) (19.8)
4.5 9.0
(149) (19.8)
5 9.0 9.0
(165) (19.8) (19.8)
5.5 9.0 9.0 9.0
(181) (19.8) (19.8) (19.8)
6 9.0 9.0 9.0 9.0
(198) (19.8) (19.8) (19.8) (19.8)
6.5 9.0 9.0 9.0 9.0 9.0
(214) (19.8) (19.8) (19.8) (19.8) (19.8)
7 9.0 9.0 9.0 9.0 9.0 9.0
(2212) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
7.5 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(247) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
8 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0(263) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
8.5 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(2711) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
9 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(296) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
10 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(3210) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
11 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(361) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
12 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(394) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
13 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(428) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
14 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(4511) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
15 9.0 9.0 9.0 9.0 9.0 9.0
(493) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
16 9.0 9.0 9.0 9.0 9.0 9.0
(526) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
18 9.0 9.0 9.0 9.0 9.0
(591) (19.8) (19.8) (19.8) (19.8) (19.8)
20 9.0 9.0 9.0 9.0
(657) (19.8) (19.8) (19.8) (19.8)
22 8.8 8.6 8.4 8.1
(722) (19.4) (19) (18.5) (17.9)
24 7.5 7.2 7.1
(789) (16.5) (15.9) (15.7)26 6.5 6.2
(854) (14.3) (13.7)
28 5.4
(9110) (11.9)
30 4.7
(985) (10.4)
32
(10412)
34
(1117)
Boom Extension Load Chart kg(lb)1000
Boom Length m(ft)
Radius
m(ft)
Page 16 of 17
-
7/29/2019 80t Chapter Load Charts.pdf|
27/27
37 40 43 46 49 52 55 58
(121'5") (131'3") (141'1") (150'11") (160'9") (170'7") (180'5") (190'3")
8.5
(2711)
9 9.0
(296) (19.8)
10 9.0 9.0 9.0
(3210) (19.8) (19.8) (19.8)
11 9.0 9.0 9.0 9.0
(361) (19.8) (19.8) (19.8) (19.8)
12 9.0 9.0 9.0 9.0 9.0 9.0
(394) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
13 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(428) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
14 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(4511) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
15 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(493) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
16 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0(526) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
18 9.0 9.0 9.0 9.0 9.0 9.0 9.0 9.0
(591) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8) (19.8)
20 9.0 9.0 8.7 8.5 8.3 8.0 7.8 7.5
(657) (19.8) (19.8) (19.2) (18.7) (18.3) (17.6) (17.2) (16.5)
22 7.9 7.7 7.4 7.2 7.0 6.7 6.5 6.2
(722) (17.4) (17) (16.3) (15.9) (15.4) (14.8) (14.3) (13.7)
24 6.9 6.7 6.3 6.1 5.9 5.6 5.4 5.1
(789) (15.2) (14.8) (13.9) (13.4) (13) (12.3) (11.9) (11.2)
26 6.0 5.8 5.4 5.2 5.1 4.7 4.5 4.2
(854) (13.2) (12.8) (11.9) (11.5) (11.2) (10.4) (9.9) (9.3)
28 5.2 5.0 4.7 4.5 4.3 4.0 3.8 3.5
(9110) (11.5) (11) (10.4) (9.9) (9.5) (8.8) (8.4) (7.7)
30 4.5 4.4 4.0 3.8 3.6 3.3 3.1 2.8
(985) (9.9) (9.7) (8.8) (8.4) (7.9) (7.3) (6.8) (6.2)
32 4.0 3.8 3.5 3.3 3.1 2.8 2.6 2.2
(10412) (8.8) (8.4) (7.7) (7.3) (6.8) (6.2) (5.7) (4.9)
34 3.3 2.9 2.8 2.6 2.3 2.1 1.7
(1117) (7.3) (6.4) (6.2) (5.7) (5.1) (4.6) (3.7)
36 2.5 2.3 2.1 1.8 1.6 1.3
(1181) (5.5) (5.1) (4.6) (4) (3.5) (2.9)
38 2.1 1.9 1.7 1.4 1.2 0.9
(1248) (4.6) (4.2) (3.7) (3.1) (2.6) (2)
Radius
m(ft)
Boom Extension Load Chart kg(lb)1000
Boom Length m(ft)