denture and partial troubleshooting guide
TRANSCRIPT
![Page 2: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/2.jpg)
Which topic best describes the problem?
Esthetics PhoneticsSwallowing
InterferenceGagging Instability
BitingCheeks/Tongue
RednessMandibular
PainDiscomfort Burning
www.MorseDentalLab.com
![Page 3: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/3.jpg)
Esthetic Troubleshooting
Which best describes your problem?
Too bulky under nose.
Sinking in under nose.
Upper lip sinks in too far.
Shows too much teeth.
Looks too false.
www.MorseDentalLab.com
![Page 4: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/4.jpg)
Too bulky under nose:
Labial flange of upper too long or too thick.
Upper anterior teeth set too far out.
CAUSES:
SOLUTIONS:
Reduce bulk and/or length and repolish.
Reset anteriors lingually.
www.MorseDentalLab.com
![Page 5: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/5.jpg)
Sinking in under nose:
Upper labial flange needs more bulk.
Upper labial flange needs more length.
CAUSES:
SOLUTIONS:
Add wax to build up to proper contour and have lab build out base.
Grind out tissue side of labial flange, add compound border and take
wash impression
Reset anteriors for lip support.
www.MorseDentalLab.com
![Page 6: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/6.jpg)
Upper lip sinks in too far:
Upper anterior teeth set too far lingually.
CAUSES:
SOLUTIONS:
Add wax on teeth to proper contour and have lab set
teeth more labial for lip support.
www.MorseDentalLab.com
www.MorseDentalLab.com
![Page 7: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/7.jpg)
Shows too much teeth:
Vertical too great.
Occlusal plane too low.
Cuspids and laterals set too prominent.
Upper anterior teeth set out too far.
CAUSES:
SOLUTIONS: Have lab reset all teeth closing vertical. Maintain esthetics by determining
whether to raise or lower upper or lower teeth.
Have lab reset all teeth raising occlusal plane.
Replace cuspids and laterals with smaller teeth and rotate them in.
Reset teeth back to ridge.
www.MorseDentalLab.com
![Page 8: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/8.jpg)
Denture looks too false:
Teeth are set too “regular”; technique type set up.
All teeth appear to be the same shade.
No gingival contouring or staggering of gingival depth.
CAUSES:
SOLUTIONS:
Try sculpturing anterior incisals to give abraded appearance. Rotate and
stagger teeth in set up.
Change to characterized anterior teeth.
Have lab process new base with anatomical finish and characterized base.
www.MorseDentalLab.com
![Page 9: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/9.jpg)
Phonetics Troubleshooting
Which best describes your problem?
Whistle on “S” sound.
Lisping on “S” sound.
“Th” and “T” sounds indistinct.
“F” and “V” sound indistinct.
www.MorseDentalLab.com
![Page 10: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/10.jpg)
Whistle on “S” sound:
Not enough room for tongue between upper bicuspids.
Space between centrals.
CAUSES:
SOLUTIONS:
Remove and move bicuspids to the buccal or (if room)
grind out more area for the tongue.
Close central anterior space.
www.MorseDentalLab.com
![Page 11: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/11.jpg)
Lisping on “S” sound:
Too much space for tongue between upper bicuspids.
CAUSES:
SOLUTIONS:
Narrow palate space between upper bicuspids by
adding ledge of acrylic.
www.MorseDentalLab.com
![Page 12: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/12.jpg)
“Th” and “T” sound indistinct:
Not enough room in dentures for tongue.
If “Th” and “T” sound alike the anteriors are too far lingual.
CAUSES:
SOLUTIONS:Thin out dentures from lingual sides. Don’t grind tissue
side.
Remount and move anteriors out to the buccal.
![Page 13: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/13.jpg)
“F” and “V” sound indistinct:
Improper position of upper anterior- either vertically or
horizontally.
CAUSES:
SOLUTIONS:
Difficult adjustment- must decode and try to correct.
![Page 14: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/14.jpg)
Swallowing interference Troubleshooting
Which best describes your problem?
Maxillary Interference
Mandibular Interference
Over Closed Vertical
Open Vertical
Posteriors too far lingual.
www.MorseDentalLab.com
![Page 15: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/15.jpg)
Maxillary Swallowing Interference:
Over extension in the posterior buccal flanges.
Too thick in lingual posterior flanges.
CAUSES:
SOLUTIONS:Carefully reduce distal buccal flange.
Adjust by thinning dentures from the outside, not the
tissue side.
www.MorseDentalLab.com
![Page 16: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/16.jpg)
Mandibular Swallowing Interference:
Over extension in the lingual.
Too thick in the posterior.
CAUSES:
SOLUTIONS:
Carefully reduce flange.
Reduce from outside- do not grind tissue side.
www.MorseDentalLab.com
![Page 17: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/17.jpg)
Over Closed Vertical Swallowing Interference:
Vertical is over closed.
CAUSES:
SOLUTIONS:
Remount and reset to correct VDO.
www.MorseDentalLab.com
![Page 18: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/18.jpg)
Open Vertical Swallowing Interference:
Vertical is open.
CAUSES:
SOLUTIONS:
Remount and reset to correct VDO.
www.MorseDentalLab.com
![Page 19: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/19.jpg)
Posterior too far lingual swallowing interference:
Posteriors too far lingual
Tongue Crowding
CAUSES:
SOLUTIONS:
Remount and reset opening arch to allow more
tongue room.
www.MorseDentalLab.com
![Page 20: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/20.jpg)
Gagging Troubleshooting
Which best describes your problem?
Gagging immediately upon insertion.
Delayed Gagging: 2 weeks to 2 months post delivery.
www.MorseDentalLab.com
![Page 21: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/21.jpg)
Immediate Gagging on Insertion:
Maxillary: Over extension, too thick at posterior border.
Mandibular: Distal-Lingual Flange too thick.
CAUSES:
SOLUTIONS:Maxillary: Double post dam and cut back to anterior
post dam. Shorten appliance.
Mandibular: Reduce from the outside. Do not grind tissue side.
www.MorseDentalLab.com
![Page 22: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/22.jpg)
Delayed Gagging- 2 weeks to 2 months
post delivery:
Faulty post dam allowing saliva to creep under denture.
Malocclusion allowing denture to loosen causing saliva
seepage.
CAUSES:
SOLUTIONS:
Grind out post dam area and take wash impression for
lab to rebase.
Remount and mill-in. May be necessary to reset teeth.
www.MorseDentalLab.com
![Page 23: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/23.jpg)
Instability Troubleshooting
Which best describes your problem?
Instability when not Occluding
Instability when chewing food
Instability when Occluding in Centric
www.MorseDentalLab.com
![Page 24: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/24.jpg)
Instability when not occluding:
Overextension of borders and posterior
limits.
Under extended borders.
Loss of post dam seal, misplaced post dam
or insufficient post dam.
Dehydration of tissue due to alcoholism or
medication.
Flabby tissues displaced when taking
impression due to improper tray.
CAUSES:
SOLUTIONS:
A new impression is necessary. It is best to grind out the tissue side and take a
wash impression, using compound where necessary to extend impression to
include post dam area. Rebase entire denture.
www.MorseDentalLab.com
![Page 25: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/25.jpg)
Instability when chewing food:
Loss of post dam seal.
Anterior teeth too far labial.
Flabby anterior tissue.
Improper incising habits.
Lower posteriors set off ridge.
CAUSES:
SOLUTIONS: A new impression is necessary. It is best to grind out the tissue side and take a wash impression, using
compound where necessary to extend impression to include post dam area. Rebase entire denture.
Remount and reset bringing anteriors back lingually.
Surgery to remove poor denture foundation and rebase.
Patient education.
Reset and correct posterior alignment.
![Page 26: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/26.jpg)
Instability when Occluding in Centric:
Malocclusion
Upper denture “riding” on hard palate
surface.
Flabby tissues over ridge.
Teeth set too far buccally
Centric occlusion not in harmony with
centric relationship.
CAUSES:
SOLUTIONS: Remount, grind and mill-in selective
teeth.
Remount and reset.
Try chairside mill-in or remount and set.
Relieve pressure area.
Remove flabby tissue with surgery and
rebase.
Remount and reset lingual.
Remake one denture.
![Page 27: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/27.jpg)
Biting Cheeks and Tongue:
Posterior teeth set end to end.
Over closed.
Posterior teeth set too far to the lingual or buccal.
CAUSES:
SOLUTIONS:
Rearticulate and reset posteriors (wax try-in highly recommended).
Rearticulate and reset all teeth opening bite.
Rearticulate and reset posterior teeth.
www.MorseDentalLab.com
![Page 28: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/28.jpg)
Redness of Tissue Troubleshooting
Which best describes your problem?
Tissue getting red in denture bearing area.
All tissues becoming fiery red including cheeks and tongue.
www.MorseDentalLab.com
![Page 29: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/29.jpg)
Tissue getting red in denture bearing area:
Ill fitting denture base.
Improper cure of denture base.
Avitaminosis.
CAUSES:
SOLUTIONS: Take a wash impression and rebase denture. Check for prematurity
in the occlusion.
Rebase with heat cure acrylic.
Consider vitamin deficiency solutions.
![Page 30: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/30.jpg)
All tissues becoming fiery red including
cheeks and tongue:
Denture base allergy (extremely rare).
CAUSES:
SOLUTIONS:
Change base material by having lab “jump” a
vinyl base material. Remove all acrylic teeth
and replace. A patch test should be taken.
![Page 31: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/31.jpg)
Pain in Mandibular Joint:
Vertical over closed.
Centric relation off.
Arthritis
Trauma
CAUSES:
SOLUTIONS: Rearticulate and reset all teeth to open bite.
Take intra-oral tracing and reset. Retrial advised.
Consult patient’s doctor.
Difficult to correct.www.MorseDentalLab.com
![Page 32: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/32.jpg)
Comfort Troubleshooting
Which best describes your problem?
Sore spot in vestibule
Sore spot in maxillary post dam
Individual sore spots on crest of ridge
General overall soreness on ridge
Sore under lower lingual flange
Sore under lower labial flange
![Page 33: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/33.jpg)
Sore spot in vestibule- maxillary or
mandibular denture:
Overextended borders.
Rough spot in base.
CAUSES:
SOLUTIONS:
Shorten borders and polish.
Refinish borders.
www.MorseDentalLab.com
![Page 34: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/34.jpg)
Sore spot in upper post dam or posterior
limit of upper:
Post dam too deep.
Sharp edges on the posterior seal.
Overextended.
CAUSES:
SOLUTIONS: Reduce base carefully and gradually to avoid loss of the border
seal.
Shorten borders and polish.
Refinish borders.www.MorseDentalLab.com
![Page 35: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/35.jpg)
Individual sore spots on the crest of the
ridge:
Premature occlusion
Inaccurate denture base.
Voids or porosity in acrylic.
Nodules under base.
CAUSES:
SOLUTIONS: New centric registration or accurate bite.
Remount dentures on articulator and
adjust.
Take wash impression and rebase after
tissue treatment.
Reduce base carefully and gradually to
avoid loss of the border seal.
Shorten borders and polish.
Refinish borders.
Remove nodules.
![Page 36: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/36.jpg)
General overall soreness on ridge:
Vertical open too much.
Totally inaccurate denture base.
Malocclusion or improper interdigitation.
CAUSES:
SOLUTIONS: Remake one of the dentures to correct vertical, if plane of
occlusion is correct.
Try a wash impression and rebase.
Remake denture after tissue treatment.
![Page 37: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/37.jpg)
Sore under lower lingual flange:
Centric off, mastication drives lower forward.
Lingual flange overextended.
Posteriors too far distal.
CAUSES:
SOLUTIONS: Recheck vertical and centric. Rearticulate and remove the
interfering cusps or change to non-interfering teeth.
Shorten and polish flange.
Remove second molars.
![Page 38: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/38.jpg)
Sore under lower labial flange:
Too much overbite.
Over extended labial flange.
When masticating, patient throws lower forward.
CAUSES:
SOLUTIONS:
Rearticulate and change tooth position.
Shorten flange and repolish.
Recheck vertical and centric. Check lingual flanges, shorten.www.MorseDentalLab.com
![Page 39: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/39.jpg)
Burning Sensation Troubleshooting
Which best describes your problem?
Burning feeling on hard palate area or on lower anterior ridge
Burning feeling in bicuspid area to tuberosities
Burning feeling on upper anterior ridge
www.MorseDentalLab.com
![Page 40: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/40.jpg)
Burning feeling on hard palate area or on
lower anterior ridge:
High pressure area in the acrylic base.
Pressure on a nerve as it leaves nasopalatine.
Under-cured base.
Diabetic nerve pain
CAUSES:
SOLUTIONS:
Locate the high area, remove and polish.
Rebase denture with heat cured acrylic.www.MorseDentalLab.com
![Page 41: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/41.jpg)
Burning feeling in bicuspid area to
tuberosities:
High pressure area in the acrylic base.
Pressure on a nerve as it leaves nasopalatine.
Under-cured base.
Diabetic nerve pain
CAUSES:
SOLUTIONS:
Locate the high area, remove and polish.
Grind first bicuspid out of occlusion.
Rebase denture with heat cured acrylic.
![Page 42: Denture and Partial Troubleshooting Guide](https://reader031.vdocuments.us/reader031/viewer/2022012418/6172c088ff657f3bca6ce2ac/html5/thumbnails/42.jpg)
Burning feeling on upper anterior ridge:
Pressure on papilla and rugae area.
Pressure on a nerve as it leaves nasopalatine.
Under-cured base.
Diabetic nerve pain
CAUSES:
SOLUTIONS:
Relieve denture in papilla and/or rugae area.
Rebase denture with heat cured acrylic.
www.MorseDentalLab.com