corrosion of stainless steel in chloride solution
TRANSCRIPT
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
1/18
Appl . Phy s . A 38 , 1 -18 (1985)
A p p l i e d
Physics
urfaces
9 Springer-V erlag 1985
C o r r o s i o n o f S t a in l e ss S t e el s in C h l o r id e
A n X P S I n v e s t ig a t i o n o f P a s s iv e F i lm s
P. Brf iesch and K. Mfi l l e r
B ro wn -B o v e r i R e s e a rc h C e n t e r , C H-5 4 0 5 B a d e n , S wi t z e r l a n d
A. At rens
Unive rs i ty o f Que ens land , S t . Lucia , Quee ns land , 4067 Aus t ra l i a
H . N e f f
No r t h C a ro l i n a S t a t e Un i v e r s i ty , R a le i g h, N C 27 65 0, U S A
Rece ived 13 Feb rua ry 1985 /Accep ted 12 June 1985
S o l u t i o n
Abstract Five commerc ia l s tee l s rang ing f rom the mar tens i t i c s ta in less s tee l con ta in ing
1 2 c h ro m i u m t o t h e s u p e r fe r r it e c o n t a i n in g 2 9 c h ro m i u m , 4 m o l y b d e n u m , a n d 2
n i c k el h a v e b e e n s t u d i e d b y XP S . In a d d i t io n , a p u re i r o n -c h ro m i u m a l l oy c o n t a i n in g 7
c h ro m i u m h a s b e e n in v e s ti g a te d . Arm c o i ro n a n d p u re c h ro m i u m (9 9 .9 9 ) we re i n c l u d e d
a s r e fe r en c e s. T h e fo rm a t i o n o f th e p a s s i v e fi lm s (o r c o r ro s i o n )o c c u r r e d i n d e o x y g e n a t e d
0 .1 M NaC1 so lu t io n (pH = 5 .6 ) , f rom w hich the samples w ere trans fer red d i rec t ly to the X PS
c h a m b e r u n d e r c o n t ro l l e d a t m o s p h e re (Ar ). C o n c e n t r a t i o n p ro fi l es (a t .- ) o f t h e a l l o y
cons t i tue n ts in the i r ox id ized and meta l l i c s ta tes have been de te rm ined se para te ly f rom the
m e a s u re d X P S d e p t h p rof il e s. F o r c > 1 2 c h ro m i u m t h e p as s i v e f il m s h a v e th e fo l lo wi n g
s t ruc tu re : there i s a dep le t ion o f Cr in the inner reg ion , fo l lowed by an en r ichm en t
(conc en t ra t ion max imum ) in the cen t ra l reg ion o f the f ilms. The he igh t o f th i s ma x im um
increases , and i t s pos i t ion sh i f t s towards the su rface wi th increas ing ch romium con ten t in
t h e a l l o y . T h e o u t e rm o s t m o n o l a y e r s a r e r i c h i n wa t e r a n d h y d ro x y l g ro u p s . Va r i o u s
s ign if ican t p rope r t i es o f the f i lms change d ras t i ca l ly a t the c r i ti ca l ch rom ium conc en t ra t io n
o f a b o u t 1 2 . T h is b e h a v i o u r i s r a t h e r i n d e p e n d e n t o f t h e o t h e r c o m p o n e n t s (M o , N i , C u )
p resen t in the a l loys and i s d i scussed in t e rms o f a phase t rans i t ion in the f i lms which i s
c o n t ro l l e d b y t h e c h ro m i u m c o n c e n t r a t i o n .
PACS: 68.45.v , 81.60.Bn
De ta i led inves t iga t ions o f b lade fa i lu res in low-
p re s s u re s t e a m t u rb i n e s t a g e s h a v e i n d i c a t e d t h a t t h e
b re a k d o w n o f p a s s i v it y i s a c r it i ca l s t e p i n t h e d a m a g e
process [1 ] . As a f i r s t s t ep in unders tand ing pass iv i ty
b reakdown, i t i s necessary to ga in in s igh t in to the
s t ru c t u re a n d c h e m i c a l c o m p o s i t i o n o f t h e p a s s iv e
f i lms which fo rm on re levan t t echn ica l a l loys under
cond i t ions chosen to s imula te those found in p rac t ice .
T h e r e l e v a n t e n v i ro n m e n t w i t h i n t h e l o w-p re s s u re
s team tu rb ine s tages i s the Wi lson zone where f i r s t
c o n d e n s a t i o n o c c u rs . T h e e x a c t c o m p o s i t i o n o f t h e
c o r ro s i v e m e d i u m i s s o m e wh a t d i f f i c u l t t o m e a s u re ,
bu t i t i s cer ta in tha t w e are dea l ing w i th a deaera ted
c h l o r id e s o l u t i o n ( t e m p e ra t u re r a n g in g b e t we e n 5 0 ~
a n d 1 0 0 ~ T h e b l a d e a l l oy s i n m o s t c o m m o n u s e a t
p resen t a re essen t ia l ly mar ten s i t i c s ta inless s tee ls con-
t a i ni n g 1 2 c h ro m i u m , a l t h o u g h p re c i p i ta t i o n -h a r -
dened mar te f i s i t ic s ta in less s tee ls and dup lex s ta in less
s tee l s have a l so been used .
T h i s p a p e r r e p o r t s a n X P S i n v e s t i g a t io n o f c o m m e rc i a l
a l lo y s . T h e y r a n g e f ro m 1 2 - c h ro m i u m m a r t e n s i ti c
s ta in less s tee l to the superfer r i t e con ta in ing 29 Cr ,
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
2/18
2 P. Briiesch et al.
4 % M o , a n d 2 % Ni . I n a d d i t i o n , a p u re i r o n -
c h r o m i u m a l lo y c o n t ai n in g 7 % c h r o m i u m h a s b e e n
i n v e s t i g a t e d . As e n d m e m b e r s , p u re Arm c o i ro n a n d
p u re c h ro m i u m h a v e a l s o b e e n s t u d i e d . I n o rd e r t o
s imula te the cond i t ions found in p rac t ice , the su rface
f i l m s wh i c h we re s t u d i e d b y XP S h a v e b e e n fo rm e d
u n d e r o p e n -c i r c u i t c o n d i t io n s a n d n o t u n d e r p o t e n t i o -
s t a ti c c o n t ro l a n d t h e c h l o r i d e e l e c t ro l y t e wa s d e a e ra -
t e d . F ro m XP S m e a s u re m e n t s a l t e rn a t i n g w i t h Ar - i o n
s p u t t e r i n g , d e p t h p ro f i l e s h a v e b e e n o b t a i n e d fo r t h e
m a i n a l l o y i n g e l e m e n t s i n b o t h t h e i r m e t a l l i c a n d
ox id ized s ta tes , as wel l as fo r oxygen . From a semi-
q u a n t i t a t i v e a n a l y s i s a b s o l u t e c o n c e n t r a t i o n s i n a t . -%
h a v e b e e n d e r i v ed . T h e d i s t o r t io n s o f t h e d e p t h p ro f il e s
o r i g i n a ti n g f ro m t h e f i n it e s a m p l in g d e p t h o f XP S h a v e
b e e n c o r r e c te d . B y t h is p ro c e d u re w e o b t a i n e d d i f-
f e r e n ti a l c o n c e n t r a t i o n s wh i c h a p p ro x i m a t e l y r e fl e ct
t h e t ru e c o n c e n t r a t i o n s a s a fu n c t i o n o f d e p t h . T o o u r
k n o w l e d g e o n l y i n t e g ra l c o n c e n t r a t i o n s o f t h e e l e-
m e n t s i n t h e p a s s i v e f i l m s h a v e b e e n o b t a i n e d i n t h e
l i te r a t ur e . S u c h i n t e g ra l c o n c e n t r a t i o n s c o m p r i s e
c o n t r i b u t i o n s f ro m a l l l e v e l s b e l o w t h e s u r f a c e ; t h e
p re s e n c e o f st e e p c o n c e n t r a t i o n g ra d i e n t s i n t h e p a s -
s ive fi lms impl ies tha t dep th p ro f i l es der ived o n the bas i s
o f i n t e g ra l c o n c e n t r a t i o n s a r e c o n s i d e ra b l y
d is to r ted .
Ad d i t i o n a l i n fo rm a t i o n a b o u t t h e c h e m i c a l n a t u re o f
t h e p a s s i v e f i l m s h a s b e e n o b t a i n e d b y a n g l e -
d e p e n d e n t XP S m e a s u re m e n t s . I n c o n t r a s t t o i o n
spu t te r ing , th is meth od i s nond es t ruc t iv e and serves to
check the re l i ab i l ity o f the resu l t s ob ta ine d by ion
s p u t te r i n g . T h e c o m b i n a t i o n o f t h e t wo m e t h o d s
y ie lds , no t on ly a de ta i l ed charac te r iza t ion o f the
su rface f ilms bu t a l so a c o rre la t ion o f f i lm p roper t i es as
a fu n c t i o n o f c h ro m i u m c o n t e n t i n t h e d i ff e r en t
al loys.
The pap er i s o rgan ized as fo l lows : Sect . 1 descr ibes the
exper imen ta l p rocedure , inc lud ing mater ia l s , e lec t ro -
c h e m i ca l m e a s u re m e n t s , X P S m e a s u r e m e n t s a n d d a t a
reduct ion . In Sec t s. 2 and 3 we p resen t the resu l t s o f the
Table 1. Designations and structures of materials studied
No . Com merc ia l Our
designation designa-
tion
1 Armco iron Fe
1A 7Cr
2 X2 0CrM oV1 2 12CrlMo
3 X 7 C r N i C u N b5 6 2 15Cr6Ni
4 X3C rNiM ol7 13 3 17Crl3Ni
5 X4CrMnNiMoN2646 26Cr6Mn
6 29-4-2 29Cr4Mo
7 99.99 Cr Cr
e l e c t ro c h e m i c a l a n d XP S m e a s u re m e n t s , r e s pe c t iv e l y.
The las t sec t ion i s devo ted to a d i scuss ion o f the
e x p e r i m e n t a l r e s u lt s i n t h e l i g h t o f p re s e n t k n o w l e d g e
from re la ted s tud ies o f pass ive f ilms. Spec ia l a t t en t io n
is g iven to the d ras t i c changes o f var ious f i lm p ro -
p e r t i e s o b s e rv e d n e a r t h e c r i t i c a l c h ro m i u m c o n -
c e n t r a t i o n o f a b o u t 1 3 a t . -% ( a b o u t 1 2 w t . -% ) , a n d
these su rface p roper t i es a re co rre la ted wi th the e lec t ro -
chem ica l p roPer t i es o f the a l loys .
1 E x p e r i m e n t a l
1 1 Ma ter ia ls
Tab le 1 con ta ins de s igna t ions and s t ruc tu res o f the
mater ia l s s tud ied .
T h e c o m p o s i t i o n s o f t h e s a m p l e s g i v e n in T a b l e 2 h a v e
b e e n d e t e rm i n e d b y o p t i c a l e m i s s i o n s p e c t ro s c o p y ,
x -ray f luo rescence and wet -chemica l ana lys i s . The
a l loys were s tud ied in a hea t - t rea ted cond i t ion cons i s -
ten t wi th no rma l use . The su rfaces were po l i shed in the
m a n n e r u s u a l l y p r a c t i c e d i n m e t a l l o g ra p h y . T h i s i n -
vo lves po l i sh ing them wi th ever f iner po l i sh ing
mater ia l , t e rm ina t ing wi th a lum ina o f l es s than 0 .3 gm
size and a mirror-qual i ty surface fin ish .
1 2 Electrochemical Setu p
T h e e l e c t ro ch e m i c a l s e t u p wa s u s e d ,
( i ) to fo rm f i lms fo r XPS s tud ies under open-c i rcu i t
cond i t ions ,
( ii ) t o m e a s u re t h e c o r r e s p o n d i n g o p e n -c i r c u it p o t e n -
t i a ls as fu nc t ions o f t ime,
( i i i ) to measure cu rren t -po ten t ia l cu rves .
The e lec t rochemica l se tup has been descr ibed in de ta i l
in a recen t pub l ica t ion [2 ] . He re we sha l l b r ie f ly g ive
the essen t ia l s (F ig . 1 ). The e lec t rochem ica l p rep ara t io n
cha mb er i s a ho r izon ta l g lass cy l inder d i rec t ly f l anged
t o t h e f a s t i n s e r t io n l o c k o f t h e KR AT OS E S 3 0 0 XP S
s p e c t ro m e t e r . T wo p o r t s a l l o w g a s a n d e l e c t ro l y t e
Structure
ferrite
ferrite
martensite
precipitation-
P H
hardened
austenite
duplex
ferrite
ferrite
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
3/18
Corr osion o f Stainless Steels in Chloride Solution
Table 2. Wt.- (upper lines) and at.- (lower lines) of elements contained in the materials studied
No. Fe Cr Mo Ni Cu Mn V Nb C Si
1 99.85
1A 93.00 7.00 . . . . . . . .
92.52 7.48 . . . . . . . .
2 85.52 11.9 0.92 0.66 - 0.48 0.28 - 0.24
84.36 12.60 0.53 0.62 - 0.48 0.30 - 1.09 -
3 75.28 14.8 1.65 5.2 1.53 0.8 - 0.23 0.06 0.45
74.86 15.81 0.95 4.92 1.34 0.81 - 0.14 0.27 0.89
4 65.98 17.8 2.3 11,5 - 1.7 0.09 0.05 0.029 0.55
65.67 19.03 1.33 10,89 - 1.72 0.10 0.03 0.13 1.09
5 62.04 25.9 2.22 42 - 5.6 - - 0.039 -
61.42 27.53 1.27 3.95 - 5.63 - - 0.18 -
6 64.24 29.0 3.6 2,44 - 0,07 0.12 0.05 0.005 0.48
63.58 30.83 2.07 2.30 - 0,07 0.13 0.03 0.02 0.95
7 - 99.99 . . . . . . . .
99.99 . . . . . . . .
I N S E R T I O N L O C K
E L E C T R O C H E M I C A L
P R E P A R A T I O N C H A M B E R
A u x i l i a r y P o r t
S a m p l e h o l d e r
t o U H V - P r e p a r a t i o n
C h a m b e r a n d
P h o t o e l e c t r o n -
S p e c t r o m e t e r
P l a t i n u m
C o u n t e r - E l e c t r o d e
G l a s s T u b e ~ _ ~
E l e c t r o d e -
E l e c t r o l y t e
C o n t a c t
g E l e c t r o d e
R e f e r e n c e - E l e c t r o d e
S a t . C a l o m e l - E l e c t ro d e )
t o P o t e n t i o s t a t
IIIIIIIIIIIIIIIIII
Fig. 1. Schematic diagram of the electrochemical preparation chamber in combination with the fast insertion lock
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
4/18
4 P. Brfiesch eta l.
s o l u t i o n t o b e a d m i t t e d . T h e w o rk i n g e l e c t ro d e is
m o u n t e d o n a s a m p l e h o l d e r , w h i c h i s a r o d t h a t c a n b e
m o v e d h o r i z o n t a l l y f ro m t h e a t m o s p h e re t h ro u g h t h e
p r e p a r a t io n c h a m b e r i n t o t h e v a c u u m s y s te m ( U H V
p re p a ra t i o n , c l e a n - s p u t t e r i n g ) a n d b a c k t o t h e c h a m -
b e r . A g l a s s t u b e m o u n t e d w i t h i ts o p e n i n g b e n e a t h t h e
e l e c t ro d e h o l d s a c e r t a i n v o l u m e o f t h e e l e c t ro ly t e
(0 .1 M N a C 1 , p H a b o u t 5 . 6 , r o o m t e m p e ra t u r e , m a d e
w i t h B A K E R o rg a n i c - f re e w a t er ) . Th i s v o l u m e c a n b e
l i f ted so tha t the me n iscus o f the liqu id con ta c t s the
e lec t rode when des i red . The e lec t ro ly te i s deaera ted in
a d v a n c e b y a rg o n b u b b l i n g . A s l i gh t a rg o n o v e rp re s -
s u re i n t h e c h a m b e r k e e p s o x y g e n o u t d u r i n g t h e
e l e c t ro c h e m i c a l m e a s u re m e n t s a n d f i l m - fo rm in g e x p o -
su re . Sa id g lass tube a l so ho lds the re fe rence e lec t rod e
wi th Lugg in cap i l l a ry . The coun tere lec t rode i s a wi re
(P t ) w o u n d a ro u n d t h e Lu g g i n c a p i l l a ry ' s t h i c k p o r -
t io n . I n v i e w o f t h e v e ry s m a l l v o l u m e o f e l e c tro l y t e
u s e d , t h e d e a e ra t e d c o n d i t i o n m a y n o t m e e t t h e
m o s t r i g o ro u s c r i t e r i a b u t i s e x p e c t e d t o b e c o n s i s t e n t
wi th cond i t ions in the Wi l son zone .
Th e t h r e e e l e c t ro d e s w e re c o n n e c t e d t o a P A R 1 23
p o t e n t i o s t a t t o r e c o rd d y n a m i c c u r r e n t -p o t e n t i a l
c u rv e s. O p e n -c i r c u i t p o t e n t ia l s (O C P ) w e re m o n i t o r e d
v i a t h e s a m e s y s t e m a n d r e c o rd e d a s fu n c t io n s o f t im e ,
u p t o p e r i o d s o f 5 t o 1 0 k s .
A l l e l e c t ro c h e m i c a l m e a s u re m e n t s w e re p e r fo rm e d
a f t e r su r f a c e p r e p a ra t i o n o f th e m e c h a n i c a l l y p o l i s h e d
e l e c t ro d e s a m p l e s b y a rg o n - i o n s p u t t e r i n g i n U H V
(10ra in , 4k eV , 12 gA /cm 2 , inc idence ang le 45~ The
d y n a m i c c u r r e n t -p o t e n t i a l c u rv e s w e re r e c o rd e d w i t h a
s c a n r a t e o f 1 0 0 m V / s . Th i s u n u s u a l l y h i g h s p e e d w a s
se lec ted in o rder n o t to m ask the e f fec t o f the p re t rea t -
m e n t b y g ro w t h o f s e c o n d a ry p a s s i v a t i o n f il m s. I n t h e
s a m e w a y w e c o u l d a v o i d t h e a c c u m u l a t i o n o f p e r t u r b-
i n g c o n c e n t r a t i o n s o f m e t a l i o n s i n t h e e l e c t ro l y t e
o r ig ina t ing f rom the ac t ive-d i s so lu t ion reg ion . Repea t
c u rv e s w e re a l w a y s r e c o rd e d a f t e r r e p e a t e d c l e a n -
s p u t t e r in g i n U H V . B y c o n t i n u o u s c y c li n g s t e a d y - s t a te
c u r r e n t -p o t e n t i a l c u rv e s c o u l d b e o b t a i n e d . A l l sw e e p s
w e re s t a r t e d f ro m t h e c a t h o d i c r e g i o n . Th e p o t e n -
t i o s t a t w a s s e t c l o s e t o t h e h y d ro g e n e v o l u t i o n p o t e n t i a l
befo re the c i rcu i t was c losed by the su rg ing e lec t ro ly te .
Th e s w e e p w a s t r ig g e re d o n e o r t w o s e c o n d s a f t e r
t h e m e n i s c u s t o u c h e d t h e e l e c t ro d e .
Th e r e s u l ts o b t a i n e d i n t h e s e p o t e n t i o d y n a m i c c u r r e n t
m e a s u re m e n t s w e re c h e c k e d i n s e p a ra t e e x p e r i m e n t s .
A m u c h l a rg e r v o l u m e o f t h e d e a e ra t e d e l e c t ro l y t e w a s
u s e d . Th e e l e c t ro d e s w e re ro t a t i n g d i s k s p r e t r e a t e d
m e c h a n i c a l l y a n d e l e c tro c h e m i c a ll y . Th e c u rv e s w e re
r e c o rd e d a t 1 0 0 m V / s , a s b e fo re , a n d a t t h e m u c h
s l o w e r s c a n r a t e s o f 20 a n d 2 m V / s . W i t h o u t d i s c us s in g
these resu l t s in fu r ther de ta i l a t th i s po in t , we wish to
po in t ou t tha t , ( i) a t 100 mV /s the shape o f a l l cu rves
(Fe , Cr , and s ix a l loys ) i s es sen t ia l ly the same as
repo r ted here fo r the spu t te r ed samples , ( ii ) a t s lower
scan ra tes , es sen t ia l new fea tu res do no t a r i se in the
fo rw ard scans ( there a re cases o f cons ide rab le hys te r -
es i s in the reverse scans fo l lowing t ranspass ive d i s so -
l u t i o n w h i c h a r e n o t r e l e v a n t t o t h e p r e s e n t w o rk ) , a n d
( ii i) mo s t consp icuo us ly , the typ ica l fea tu res o f pass iv -
a t ion cu rves , v iz ., a reg ion o f h igh cu rren t s (ac t ive
d i s s ol u t io n ) f o l l o w e d , b e y o n d a F l a d e p o t e n t ia l , b y a
reg ion o f d ras t i ca l ly lowe r cu rren t s , a re n o t ev iden t in
the cu rves reco rded in ch lo r ide so lu t ions ; sec t ions
where the charac te r i s t i c i s nega t ive a re e i ther to ta l ly
absen t o r qu i te in s ign i f i can t . Hence a l l d i scuss ion
base d on the resu l t s o f F ig . 9 wi l l be unaffec ted by the
u n c o n v e n t i o n a l p ro c e d u re a d o p t e d , b y n e c e s s i t y , i n
the ele ctroch em ical cel l of Fig . 1 .
P r i o r t o t h e X P S m e a s u re m e n t s t h e e i gh t s a m p l e s w e re
e x p o s e d t o t h e e l e c t ro l y t e fo r a p e r i o d o f 1 5 h . Th e
c o n d i t i o n s w e re e x a c t l y th e s a m e a s d e s c r i b e d a b o v e ,
w h e n m e a s u r i n g o p e n -c i r c u i t p o t e n t i a ls ; t h e e l e c t ro d e s
were t ru ly a t open c i rcu i t to s imula te p rac t i ca l con-
d i t ions . Af te r the exposure t ime the e lec t ro ly te was
s e p a ra t e d f ro m t h e e l e c t ro d e a n d t h e l a t t e r w a s
c a re fu l l y r i n s e d w i t h d e a e ra t e d B A K ER w a t e r w h i l e
keep ing the e lec t rochemica l ce l l under a rgon a tmo-
sphere . The e lec t rode wi th the su r face f i lm was then
t r a n s f e r r e d d i r e c t l y i n t o t h e X P S s p e c t ro m e t e r b y
us ing the fas t in ser t ion lock . Res idua l water rem ain ing
o n t h e e l e c t ro d e , a n d t h e a rg o n i n t ro d u c e d f ro m t h e
e lec t rochem ica l ce ll , were pu mp ed o f f a f t e r t rans fer in
t h e U H V s y s t e m .
1 .3 . X P S M e a s u r e me n t s a n d Da t a R e d u c ti o n
X P S m e a s u r e m e n t s w e re ca r r ie d o u t i n a K R A T O S E S
3 0 0 E l e c t ro n S p e c t ro m e t e r i n t h e F A T m o d e o f
ope rat ion using M gK~I,2 exci tat ion (1253.6 eV). The
b a s e p r e s s u re w a s a fe w ti m e s 1 0 -9 t o r t . B i n d i n g
energ ies o f e lec t rons were de te rm ined us ing a go ld
s t a n d a rd ; t h e o v e ra l l r e s o l u t i o n w a s a b o u t 1 . 3 e V .
S a m p l e s h a v i n g a s u r f a c e a r e a o f 5 1 6 m m 2 a n d a
t h i ck n e s s o f 2 r a m w e re u s e d. D e p t h p ro fi l es w e re
o b t a i n e d b y s p u t t e r i n g w i t h a rg o n i o n s (4 k e V ,
12 jxA/cm 2, angle of inciden ce 45~ Th e sput ter rate
depends on the compos i t ion and wi l l , in genera l ,
chang e w i th dep th . As wi ll be shown b e low, the pass ive
f i lms on the a l loys to a l a rge ex ten t cons i s t o f Cr203
W e t h e re fore d e t e rm i n e d t h e s p u t t e r r a t e o f C r2 0 3 b y
u s i ng a f i l m o f k n o w n t h i c k ne s s p r e p a re d b y r e a c t iv e
spu t te r ing in a Balzers r f /dc mach ine . T he th ickness o f
t h e fi lm h a s b e e n m e a s u re d b y a n A l p h a -S t e p T e n c o n
i n s t ru m e n t . Th e s p u t t e r r a t e w a s a b o u t 3 0 A / m i n ; a
s i m i l a r s p u t t e r r a t e h a s b e e n o b t a i n e d fo r F e 2 0 3 .
Th e a b s o l u t e c o n c e n t r a t i o n s ei z) o f a t o m s i a t d e p t h z
f ro m t h e s u r f a c e h a v e b e e n e v a l u a t e d b y m e a n s o f
a rg o n - i o n s p u t t e r i n g a l t e rn a t i n g w i t h X P S m e a s u re -
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
5/18
Corrosion of Stainless Steels in Chloride Solution 5
meri ts . B y defini t ion
c , ( z ) = n ~ ( ~ )
Z j n j ( z )
(1)
wh e re
n i ( z )
i s t h e n u m b e r d e n s i t y (n u m b e r o f a t o m s p e r
u n i t v o l u m e ) o f a t o m s o f t y p e i a t a d e p t h z a n d t h e s u m
ex tends o ver a l l types o f a tom s in the sam ple . I t i s
shown in the Append ix tha t under cer ta in s impl i fy ing
a p p ro x i m a t i o n s
n i ( z )
i s g iven by
h i z ) : R i X z ) -
2 , ,
d g ~ s z )
a T ( 2 )
wh e re
R i s ( z ) = n ~ 1 7 6 (3)
He re I~ i s the in tens i ty o f pho to e lec t ro ns o r ig ina t ing
f ro m a t o m s o f ty p e i i n s t a t e s o f t h e p u re e l e m e n t i, a n d
I ~ ( z ) i s the co rrespond ing in tens i ty f rom the sample
after sp utter ing off a laye r of th ickness z. 2 ,~ is a m ean
escape d ep th (spa t ia l average) and n o i s the num ber
dens i ty o f a toms i in the pu re e lemen t i ; n ~ 1 7 6
wh e re z ~ i s th e n u m b e r o f a t o m s i p e r u n i t v o l u m e v o .
C h o o s i n g vo = 100 A we hav e n~ = 8 .549, nor = 8 .372,
n ~ a n d n ~ F o r o x y g e n w e p u t
n ~ wh i c h c l o se l y c o r r e s p o n d s t o t h e n u m b e r
d e n s i t y o f o x y g e n i o n s i n C r2 0 3 o r F e 2 0 3. T h e
in tens it i es I~ fo r the meta l s have be en de te rmin ed f rom
the o bserv ed in tens i t ies o f the a l loys a f te r su ff ic ien t ly
long argon- ion spu t te r ing , un t i l sa tu ra t ion va lues o f
the in tensi t i es were a t t a ined , an d by normal iz ing these
in tens it i es to 100% of the co rres pond ing m eta l . In th is
c o n n e c t i o n i t s h o u l d b e m e n t i o n e d t h a t a p u re F e -C r
a l l o y d o e s n o t u n d e rg o p re f e r e n t i a l s p u t t e r i n g wh e n
s p u t t e r e d w i t h Ar i o n s [3 ] .
Assum ing a me an spu t te r ra te f such tha t z = g t wh ere t
i s the sp u t te r t imel (2 ) can a l so be w r i t t en in the fo rm
n , ( t ) = R i , ( t ) - e i , R i ~ ( t ) ,
(4)
wh e re
R i ~ ( t ) = n ~ 1 7 6
a n d
f i ~ = X i j f .
T h e e s c a p e
d e p t h s fo r N i 2 p , F e 2 p , C r2 p , O l s , a n d M o 3 d a r e
est imated to be 13, 15, 16, 17, and 19/k , respect ively
[4 , 5 ] . Fo r the p rac t ica l ca lcu la t ions we have assumed
a m e a n e s c a p e d e p t h 2 -= 1 5 A fo r a ll 2'~ . I n o u r
e x p e ri m e n ts ~ - 0 . 5 A / s g i v in g i , ~ 3 0 s . T h e s e c o nd
term in (2 ) and (4) co rrec t s fo r the def o rm at ion o f the
dep th p ro f i l e assoc ia ted w i th the f in i te sampl ing de p th
[6 ] (2 -ef fec t) . In X PS 95% of the to ta l ph o toe lec t ro n
pea k in tens i ty o r ig ina tes f rom a layer o f dep th
6 = 3 2 - s i n O , wh e re O i s t h e t a k e -o f f a n g l e o f t h e
e lec t rons ; in ou r case O = 90 ~ and f i = 45 A. N eg lec t ing
t h e s e c o n d te rm o n e o b t a i n s i n te g ra l c o n c e n tr a t i o n s ,
a s m e n t i o n e d i n t h e In t ro d u c t i o n . A t t = 0 th e s l o p e
/~(0) in (4) usua l ly is not w ell defined. F or th is re aso n
a n d b e c a u s e o f u n a v o i d a b l e c o n t a m i n a t i o n s p r e s e n t a t
Cr20 ~ Cr
2 0 s
6 0 s
120s
l ~ 3 0 0 s
~ ' q ~ 6 0 0 s
6 7 0 6 7 5 6 8 0 6 8 5
Ek i n (e V )
Fig. 2. Evolution of the C r 2 p 3 / 2 XPS line of sample 2 as a
function of sputtering time
the su rface, the dep th p ro f i l es shown in F igs . 10 to 14
a r e un c e r ta i n f o r t < 1 0 s o r f o r z < 5 , a , .
C o n c e n t r a t i o n p ro fi le s o f F e , C r , M o , N i , a n d o x y g e n
h a v e b e e n d e t e rm i n e d b y o b s e rv i n g t h e i n t en s it i es o f
the Fe2p , Cr2p , M o3d , Ni2p , and O ls l ines. F igure 2
fo r in s tance sho ws the e vo lu t ion o f the Cr2p3 2 l ine o f
3+
sample 2 as a func t ion o f spu t te r ing time. On ly Cr i s
o b s e r v ed a t t = 0 a n d t = 2 0 s ; t h e s t ru c t u re t h en
gradual ly changes , and a f te r 600s the spec t rum i s
d o m i n a t e d b y m e t al l ic c h ro m i u m . An o t h e r e x a m p l e is
g i v en i n F i g . 3 wh i c h s h o w s t h e s p e c t r a o f th e M o 3 d -
and Ni2 p l ines o f sample 4 . These sp ec t ra wi l l be
d iscussed in Sec t . 3 . The eva lua t ion o f the in tens i t ies
i n v o lv e s b a c k g ro u n d s u b t r a c t io n , [ 7 ] d e c o n v o l u t i o n
of the com pos i te s t ruc tu res in to the i r meta l l i c and
o x i d ic c o m p o n e n t s , a n d m e a s u re m e n t s o f t h e a r e a s o f
t h e i n d i v i d u a l c o m p o n e n t s . F i g u re 4 fo r i n s t a n c e
shows the deco nvo lu ted spec t ra o f the Fe2p3 /2 ,
Cr2p3 /2 , and O l s peak s o f samp le 6 . In v iew o f poss ib le
spu t te r - ind uced ef fect s ( see be low) , the spec t ra re -
c o rd e d a f t e r s p u t t e r i n g h a v e b e e n d e c o m p o s e d i n a
more qua l i t a t ive manner . The Fe2pa/2 s t ruc tu re , fo r
e x a m p l e , wa s d e c o m p o s e d o n l y i n t o t h e m e t a l l i c
c o m p o n e n t F e a n d a s in g le o x i d ic c o m p o n e n t
Fe ox = Fe 2 + + Fe a + .
In o rd e r t o o b t a i n s o m e q u a l i ta t i v e i n fo rm a t i o n a b o u t
d e p t h p ro f i le s w i t h o u t a rg o n - i o n s p u t t e ri n g w e h a v e
me asured the XPS in tens it i es o f the Fe2p , Cr2p , and
O l s l ines as func t ions o f the e lec t ron emiss ion ang le O.
F i g u re 5 fo r in s t a n c e s h o ws t h e a n g u l a r v a r i a t i o n o f
the Fe2pa/2 l ine of sam ple 6 . The s ignificance of these
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
6/18
6 P . B r i ie sch e t a l .
a M o 6 M o
f . . . . u o ~ u d f . . . . . . .
0 s
2 0 s
/
1 01 5 t 0 2 0 10 2 5 1 0 3 0
E k i n e V )
b N i ~ p
O s
2 0 s
6 0 s
1 8 0 s
5 9 5 4 0 0 4 0 5
E k i n e V )
F i g . 3 a a n d b . E v o l u t i o n o f ( a ) t h e M 0 3 d , a n d ( b ) t h e N i 2 p X P S
lines as a function of sputtering time
spec t ra wi l l be d i scussed in Sect s. 3 and 4 . At th i s po in t
we u s e t h e o b s e rv e d a n g l e -d e p e n d e n t i n te n s it ie s I ~ , ( O )
in o rde r to che ck the re l i ab i l i ty o f dep th p ro f i l es c i ( z )
o b t a i n e d b y a rg o n - i o n s p u tt e r in g . T h e p ro c e d u re
invo lves ca lcu la t ing the I ~ ( 0 ) f ro m t h e c o n c e n t r a t i o n s
c ~(z ) a s i n p u t d a t a , a n d c o m p a r i n g t h e I ~ , ( O ) c , ~ wi t h
Is(O)obs- S ince in (1) the to ta l num ber dens i ty
N = E j n j ( z ) i s near ly indep ende n t o fz (as can be ver i f i ed
numerica l ly ) we have
I ~ ( 0 ) ~ g K ~ s ( O ) o~ q ( z ) e - ~ /x i~ s in O d z (5)
o
F o rm i n g t h e r a t i o
I ~ (6)
R i ( O ) ~ = I ~ + I . ~ ( 0 ) '
wh e re I ~ i s the in tens i ty observed fo r the to ta l
o x i d e (C r 3 +, F e 2 + + F e 3 + ) a n d I . ~ ( 0 ) i s the in tens i ty
o b s e rv e d fo r t h e m e t a l (C r, F e ) we o b t a i n
c ~ e - ~ z/ z s i nO d z
R i ( O ) ~ , z ~ = o , (7)
c ~(z) e -~ : s i ~
F e 2 p 3 / 2 a
5 4 0 5 4 5 5 5 0
6 7 5 6 8 0
7 2 0 7 2 5
F: k in EV )
Fig . 4 . De con vo l u t io n o f the Fe2p3 /2, C r2p3 /2 , and O ls X PS l ines
of sample 6 before sputtering
Fe s* Fe a+ Fe
90*
6 0 *
4 5 *
5 0
t 5
5 4 O 5 4 5 5 5 0
E k i n e V )
F i g . 5 . A n g u l a r v a r i a t i o n o f t h e F e 2p 3 /2 X P S l i n e o f sa m p l e 6
b e f o r e s p u t t e r i n g
wh e re q ( z ) = c ~ + c m ( z ). I t s h o u l d b e m e n t i o n e d t h a t
Ri (O)obs i s independ en t o f spu t te r - indu ced ef fect s
because the in tens i t i es in (6 ) have been measured
befo re spu t te r ing ; on the o ther hand , R i ( O ) c , l c is
a f f e ct e d b y s p u t t e r in g v i a t h e c o n c e n t r a t i o n s c~(z) .
F i g u re 6 s h o ws a c o m p a r i s o n b e t we e n t h e R i(O)o bs a n d
Ri(O)~alc- The agre em ent is sat isfac tory. I t sh ould be
men t ioned , ho weve r , tha t l ess sa t i s fac to ry resu l ts have
been ob ta ine d espec ia l ly fo r the i ron p ro f i l es in the case
o f very th in f ilms. The dev ia t ions resu l t ing in these
cases a re re la ted to e f fect s such as p referen t ia l re duc-
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
7/18
Corro s ion of Sta in less Steels in Chlor ide Solut ion 7
R O)
4 O
0 . 9
0 . 8
O . i
R o)
t . 0
0 . 9 -
0 . 8 -
0 . 7
0
i o x I I I I I
i ~ m
l l I I l I
I I I I I I
I I I I I
1 5 3 0 4 5 6 0 7 5 9 0 0 0
Fig. 6. Com par ison o f experimenta l (x , o) and ca lcula ted ( - - )
R O)
values for the Fe2p3n and Cr2pa/2 XPS l ines sam ples 1 ,
2, and 6 (see text)
t i o n o f ir o n b y a rg o n - i o n s p u t te r i n g, n o n u n i fo rm f il m
th ickness and /o r spu t te r - ind uced io n mix ing [8 ] . All
these e f fec t s wi l l be espec ia l ly impO rtan t in very th in
f il m s. T h a t s o m e r e d u c t i o n o f i r o n o x i d e b y a rg o n - i o n
s p u t t e r i n g m u s t b e e x p e c t e d h a s b e e n e s t a b l i s h e d b y
F ra n k e n t h a l [ 3 ] , wh o a l s o s h o we d th a t f o r C r2 0 3 t h e
reduct ion i s s ign i f ican t ly l ess than fo r Fe203 . The
in f luence o f spu t te r ing on the com pos i t io n o f the f ilms
is further d iscussed in Sect . 4 .1 .
2 E l e c t r o c h e m i s t r y
T h e s u r f ac e fi lm s s t u d i e d in t h e p r e s e n t wo rk b y X P S
we re p ro d u c e d a t o p e n c i r cu i t. F o r t h i s r e a s o n o p e n -
c i r cu i t p o t e n t ia l s (O C P ) o f t h e s a m p l e s we re m e a s u re d
under iden t ica l cond i t ions . Th is was done in o rder to
s i m u l a t e t h e c o n d i t i o n s e x i s t in g i n t h e W i l s o n z o n e a n d
a l s o i n o rd e r t o o b t a i n t h e d a t a r e q u i r e d fo r c o m -
p a r i s o n o f o u r p r e s e n t r e su l t s w i t h t h o s e o b t a i n e d b y
o t h e r wo rk e r s a t f i l m s p ro d u c e d u n d e r p o t e n t i o s t a t i c
con t ro l .
T h e OC P - t i m e c u rv e s s h o w s p o n t a n e o u s p a s s i v a t i o n
fo r t h e c h ro m i u m -c o n t a i n i n g s a m p l e s . T h e v a l u e s o f
po ten t ia l and the t rends in the po ten t ia l - t ime cu rves
p rov id e a measu re fo r nob i l i ty (stab i l ity aga ins t co rro -
sive act ion) of a g iven al loy.
P o t e n t i o d y n a m i c c u rv e s we re r e c o rd e d i n o rd e r t o
have a f ram e o f re fe rence (ac t ive /pass ive reg ion) fo r the
open-c i rcu i t po ten t ia l s . The abso lu te va lues o f the
c u r r e n t s m e a s u re d c a n b e t a k e n a s a m e a s u re o f
reac t iv i ty (e lec t rochemica l d i s so lu t ion ) . I t shou ld be
p o i n t e d o u t t h a t t h e d o u b l e - l a y e r ch a rg in g c u r r e n t s i n
o u r s y s t e m s a r e o f t h e o rd e r o f 5 g A .
I I I I I I I
0
1 o o ~
-zoo ~ |
~ ' ~ ~ A 7
r
- 4 0 0 ~ 2
Cr
IMo
~ ' ~ I ~ I ~5 c , O N i
5 o o i - . / l " I 7 c ~ 1 5 N i
- ~ - / 5 126
C r
6Mn
% s 2 9
r
4 M o
-~ooF
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
8/18
8 P. Brfiesch et a l .
0
1 0 0
2 o o
3 0 0
>
E
... 40 0
o - 5 0 0
6 0 0
7 0 0
t e I I I
;A c ~
I
12 Cr tMo
I
__ t5 Cr 6 N i ++ J
4 1 7 C r , 3 N i i + ( ~ + + ~ / -
5 2 6 C r 6 M n i . . - ~
2 9 C r 4 M o I + + ~ / J ~ 7 ~
t 0 t t 02 t 03 t 04
T I M E
/
s
a
~/PA/r
~ t 5 0 0
[ / / . .
/ / - ; 5 0 0 / . . -
. . T f ~ 5 0 0 i 5 0 0 t 0 0 0 t 5 0 0
U / m Y v s S C E
5 0 0
b
i p A c m : 1 5 0 0
t 0 0 0
/(ig) = ~
5 0 0 i
- t O . . . . . . . . . . . . . J
. ~ ~ . . ~ : 5 6 o o 5 0 0 1 o oo t 5 o o
7
U / m V v s S C E
5 0 0
F i g . 9 a a n d b . P o t e n t i o d y n a m i c c u r r e n t - p o t e n t i a l ( v s s c e) c u r v e s
fo r samples 1 to 7 in 0 .1 M N aC1 so lu t ion (deae ra ted w i th At ) ,
r e c o r d e d a t a s c a n r a t e o f 1 0 0 m V / s . ( a ) A n o d i c s c a n u s i n g f r e sh
su r face ( spu t te red in U H V , t rans fe r red d i rec t ly to the ce ll (F ig . 1 ),
e l ec t ro l y te c o n t a c t e s ta b l is h e d a t - 1 0 0 0 t o - 1 1 0 0 m V . ( b ) T h e
same a f te r 10 anod ic -ca thod ic cyc le s
n o t t h e s a m e a s t h e s t a t e o f t h e s u r f a c e to w h i c h F i g . 9 b
refers, s ince in the l a t t e r case , a l t e rna t ing ox ida t ion a nd
re d u c t i o n o f th e s u r f a c e a r e i n d u c e d e x t e rn a ll y b y
curren t f low (wi th a cu rre n t o f 100 IxA, som e 0 .3 a tom ic
layers can be d i s so lved anod ica l ly per second) . F igu res
Fig . 8 . O pen-c i rcu i t po ten t ia l s (v s sce ) a s func t ions o f the
l o g a r i t h m o f t i m e f o r s a m p l e s 1 t o 7 i n 0 .1 M N a C 1
s o l u t i o n ( d e a e r a t e d w i t h A t )
7 and 9b s t i l l revea l para l l e l s in e lec t rochemica l
b e h a v i o u r o f t h e a l l o y s u n d e r t h e t w o s e ts o f c o n -
d i t ions . Dur ing cyc l ing aga in , a l loys a re more nob le
w h e n t h e c h ro m i u m c o n t e n t i s h ig h e r. A l l o y 2 d i s p la y s
t h e l a rg e s t c h a n g e i n t h e v o l t a m m o g ra m b e t w e e n t h e
f i rs t a n d t e n t h s w e e p . Th e O C P c o n d i t i o n o f th e a l l o y s
c o r r e s p o n d s t o t h e p o t e n t i a l r e g i o n i n t h e s w e e p j u s t t o
the l e f t o f the co ord in a te o r ig in in the p lo t s o f
Fig. 9.
The charge passed dur ing f i r st sw eeps (F ig . 9a)
a m o u n t s t o v a l u e s o f 1 -2 m C / c m 2 , a n d t h u s c o r r e -
s p o n d s t o s o m e t h i n g l i k e t h r e e m o n o l a y e r s o f d i - o r
t r i v a le n t c o m p o u n d fo rm e d o n t o p o f t h e s u r fa c e
s p u t t e r e d c l e a n i n U H V .
Th e o p e n -c i r c u i t p o t e n t i a l s a t t a i n e d a f t e r 4 k s a c c o rd -
ing to F ig . 7 and the cu rren t s reco rded , a ccord ing to
Fig . 9 , a t U = 0 V (sce) have been p lo t t ed in F ig . 16a
a g a i n s t t h e c h ro m i u m c o n t e n t o f t h e a ll o y s. Th e t r e n d s
seen in these p lo t s wi l l be d i scussed be lo w in con junc-
t ion wi th the X PS resu l t s o f F igs . 16b and c .
3 X P S R e s u l ts
F i g u re 1 0 s h o w s t h e d e p t h p ro f il e s o f c h ro m i u m fo r t h e
d i f fe ren t a l loys , as measured a f te r exposure to the
e l e c t ro ly t e u n d e r O C P c o n d i t i o n s d u r i n g 1 5 h . I n t h e
a l loy subs t ra tes (a t spu t te r t imes t > 600 s ) the c on-
cen t ra t ions a re re la t ive ly c lose to the bu lk va lues l i s t ed
in Tab le 2 . Fo r a l loy 1A (7 Cr) the p ro f i l e i s
qua l i t a t ive ly d i f fe ren t compared wi th the o ther a l loys :
o n l y a v e ry s m a l l a c c u m u l a t i o n o f C r , o f th e o rd e r o f
1 , is obse rved near z ~ 20 A. The s i tua t ion i s qu i te
d i f fe ren t fo r the o ther a l loys con ta in ing 1 2 o r mo re
c h ro m i u m : In t h e i n t e r f a c e r e g i o n b e t w e e n t h e a l l o y
a n d t h e p a s s i v e fi lm t h e r e i s a d e p l e t i o n o f c h ro m i u m
w h i c h i s f o l l o w e d b y a p ro n o u n c e d m a x i m u m w i t h i n
the pass ive f ilm . Fo r a l loy 2 (12 .6a t . - Cr) the
ma x im um of Oct(Z) i s a t a de p th o f z ~ 30 A, w h i le fo r
the o ther a l loys con ta in ing mo re than 12 .6 a t ; - Cr
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
9/18
C o r r o s i o n o f S t a i n le s s S t e e ls i n C h l o r i d e S o l u t i o n 9
C c r ( t )
( at )
5 0
/ k - - - -
. . . . . ._ + ; . - :.
. o _ , ; . / 2
'10
0 I I I I I I I I / / ~
0 4 0 8 0 t 2 0 t 8 0
S p u t t e r t i m e
(s ) 5 0 0 6 0 0
I I I I I I / I
~
0 2 0 4 0 6 0 9 0 Approx, depth ( ~) t 5 0 3 0 0
F i g . 1 0. D e p t h p r o f i l e s o f th e t o t a l c h r o m i u m c o n c e n t r a t i o n
C r ~ +
C r ) o f s a m p l e s 1 A t o 6 . @ 7 . 0 C r ; @ 1 2 . 6 C r , 0 . 6 M o ,
0 . 6 N i ; @ 1 5 . 8C r , 0 . 9 M o , 4 . 9 N i ; @ 1 9 C r , 1 . 3 M o , 1 0 . 9 N i ;
@ 2 7 . 5 C r , 1 . 3 M o , 4 N i , 5 . 6 M n ; @ 3 0 . 8 C r , 2 M o , 2 .3 N i
( T ab le 2 )
the max imum is located between 10 and 15 A below the
surface. With increasing chromium content in the bulk,
the maximum becomes considerably higher but the
increments become smaller at the higher chromium
concentrations; this indicates that a saturation value
of the peak concentration near about 35-40 at.-% Cr
will be reached (normalized with respect to all compo-
nents, metal plus oxygen). Note that the chromium
concent ration for pure
Cr2 3
s 40 at.-%. The decrease
of the chromium concentra tion in the outermost layers
is due to the presence of hydroxides and water in this
region of the passive films, as well as to some disso-
lution o f chromium into the electrolyte. That appreci-
able amount s of hydroxides and water are contained in
the films can be deduced from the shape of the Ols
XPS line (Fig. 4c). Angle-dependent measurements
actually reveal that hydroxides and water are ac-
cumulated in the outermost layers of the films (Fig. 15).
In addi tion to these species, the surface will hold some
unavoidable oxygen-containing contamination also
contributing to the decrease in chromium concen-
tration very close to the surface.
On the basis of deconvolution of the Fe2p and Cr2p
XPS lines it is possible to derive individual con-
centration profiles for the metals (Fe , Cr ) as well as
for the oxides (Fe ~ Cr~ These profiles are shown in
Figs. 11 to 13. In these figures Cr ~ stands for Cr 3+
while Fe ~ represents the sum of Fe 2+ and Fe 3+. In
pure Armco iron (sample 1, Fig. 11a) the broad con-
centration profile of Fe ~ reflects a relatively thick
oxide film of the order of 50 A. In this case the oxide
film contains abou t 90% Fe 3+ and 10% Fe z+ (Fig.
16c). For pure FezO3 the concentration of iron would
be 40at .-%, the 10% Fe 2+ would raise this figure to
40.8 at.-%. These values agree well with the mean iron
concent ration in the film of sample 1 (Fig. 11a). From
Figs. 11 to 13 it is seen that with increasing chromium
concentration in the alloy the iron and chromium
peaks become narrower and also shift towards the
surface. The coexistence of iron and chromium in the
passive films indicates that an iron-chromium oxide
exists at least in the inner part of the passive films, while
the outer part is enriched in hydroxides and water as
mentioned above. It should be emphasized, however,
that no sharp interface between the outer hydroxide-
water region and the inner oxide region exists; this
can be seen from the angle-dependent XPS measure-
ments (Fig. 15).
Figures 11 to 13 seem to indicate that metallic iron and
chromium coexist with the iron-chromium oxides.
Such an overlap between oxide and metal profiles
would be expected if the oxide contained metallic
clusters. Nothing is known about the stability of such
metallic clusters in very thin oxide films. On the other
C i ( t )
( a t )
7 0
6 0
5 0
C i
( a t
4 0 ~
I
oy
2O -
1 0
O
0
(t)
% ) - -
- g O -
6 O
5 O
4 O
3 O
2 O
l 0
i
L-
/ k - - - ~
, i
. . . . /
f
i
/ / / \ \ \ ~ / Fe
I I - . .we ] I I
t I ~ q l - - -
4 0 8 0 4 ~ . 0 t 8 0 S p u t t e r t i m e ( s ) 5 0 0 ]< 6 00 L --
I I I I 1 i / I ~ _
2 0 4 0 6 0 9 0 A p p r o x. d e p t h ( ~ ) 1 5 0 3 0 0
/ / - - ~
._..._.~/. ---~
Fg x
/ (
O r . .
. . . . c r T
- /
t----/r
0 4 0 8 0 t ~ -0 ~ 8 0 S p u t t e r t im e ( s ) 5 0 0 6 0 0
j I I I I l // I],,_
O 2 0 4 0 6 0 9 0 A p p r o x . d e p t h
~)
t 5 0 5 0 0
F i g . 1 a a n d b . D e p t h p r o f i l e s o f ( a) s a m p l e 1 ( p u r e A r m c o i r o n )
and ( b ) sample 2 ( 12 .6 Cr , 0 .5 M o , 0 .6 Ni ) . Fe m, Cr ~ : m e ta l l i c i r on
a n d c h r o m i u m , F e ~ = F e z + + F e 3 + , C r ~ = C r 3 +
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
10/18
10 P. Brfiesch et al.
c l ( t )
( a t % ) ' a
7 0
6 0
5 0
4 0
3 0
2 0
t 0
0
I
0
J
4O
I
2O
.Fe~
l k - ' - -
,,,,-.---
% . c o x m
~ ~ . . . ~ j . - - . C r
l , ~ ~ ' r - ~ I s - ~ r - -' I - = - / / ~
8 0 ' 1 2 0 t 8 0 S p u t t e r t i m e ( s ) ~ 0 0 6 0 0
I l I 1 I
4 . 0 6 0 9 0 A p p ro x . d e p th ( .~ ) ' ~50 3 0 0
. . . . . / / - - -
/ / - - - -
c l ( t )
( a t % )
7 0
6 0 t ~ . . . . ~ . - = = ~ - ~ ' ~ Fern
4 0
3 0 . c ~
r m
20 ..-----~--
r
I J L - : ~ _ t '-.+-.., J_ I I / F - -
0 4 0 8 0 4 2 0 t 8 0 S p u t t e r t i m e ( s) 3 0 0 6 0 0
l I I I I I l i
~
0 2 0 4 0 6 0 9 0 A p pr ox . d e p t h ( ~ ) 4 5 0 3 0 0
Fig. 12. Dep th profiles of(a) sam ple 3 (15.8 Cr, 0.9M o, 0,4 Ni)
and (b) samp le 4 (19 Cr, 1.3 Mo, 10.9 Ni). Fe ~, Cr : m etallic iron
and chromium, Fe~ 2+ +F e 3+, Cr~ 3+
h a n d , i t s h o u l d b e k e p t i n m i n d t h a t , a l t h o u g h w e h a v e
d e r i v e d d i f f e r e n t i a l d e p t h p r o f i le s , o u r d e p t h r e s o l u t i o n
s t il l i s li m i t e d d u e t o i n t r i n s i c e f fe c t s s u c h a s i n h o m o g e -
n e o u s f i lm t h ic k n e s s a n d s p u t t e r - i n d u c e d m i x i n g o f
t h e a t o m s a n d i o ns . T h e l i m i t a t io n s o f d e p t h r e s o l u t i o n
d u e t o t h e s e i n t r i n s i c e f f ec t s w i l l b e p a r t i c u l a r l y s e v e r e
f o r t h e v e r y t h i n f il m s w h e r e t h e m e t a l - o x i d e o v e r l a p i s
f o u n d t o b e m o s t p r o n o u n c e d . I n r e a l i t y t h e m e t a l l i c
p h a s e i s e x p e c te d t o b e b e t t e r s e p a r a t e d f r o m t h e o x i d e
p h a s e t h a n t h e f ig u r e s i n d i c a t e ; a c o m p l e t e s e p a r a t i o n
i s un l i ke ly .
T h e d e p t h p r o f i l e o f o x y g e n i s s h o w n i n F i g . 1 4a . F o r
p u r e i r o n ( s a m p l e 1 ) t h e o x y g e n p r o f i l e d e c r e a s e s v e r y
s l o w l y w i t h i n c r e a s i n g d i s t a n c e f r o m t h e s u r f a c e .
A l r e a d y f o r th e a l l o y c o n t a i n i n g 1 2. 6 a t . - % C r ( s a m -
p l e 2 ) t h e o x y g e n c o n c e n t r a t i o n
C o ( Z )
d e c r e a s e s m o r e
r a p i d l y , a n d t h i s t e n d e n c y c o n t i n u e s t o h o l d w i t h
i n c r e a s i n g c h r o m i u m c o n t e n t . T h i s o b s e r v a t i o n i n d i -
c a t e s t h a t t h e m e a n f il m t h ic k n e s s d e c re a s e s c o n s i d e r -
a b l y w i t h i n c r e a s i n g c h r o m i u m c o n c e n t r a t i o n i n t h e
b u l k . I t is a ls o w o r t h n o t i n g t h a t t h e s l o p e o f
C o ( Z
f o r
I/---
c i ( t ) ] _
( e l % } F
/
6 0 , ~ F = m , ' I ~
5 0
4 0
3 0 c , ~ i / - -
z o g ^ i
\ _
, , 1 I .
F l
I ~. w . f .
Io I - /~ .~-
VJ'~Y-,_ 3 -.,--..,_., , %%0
4 0 8 0 t 2 0 t 8 0 S p u l t e r t i m e
e )
3 ( ~ 0
I I I I I : I
2 0
40
6 0 9 0 A p p rox . d e p th (n )
t 5 0 300
I
0
c; I t }
l e t % )
7 0
6 0 ~ ~ ' F .
5 0
4 0
3 ~ / . / y c , ' . . . . . . . ~ . - - . . . . . . .
;v ;
: >_ . .
L 5 , ,4 , J I ' I * - - - ~ - . 1 ~
o 4 0
I
2 o
. . . . t . . .
- - , i
I I
8 0 4 2 0 t 8 0 S p u t t e r t i m e ( =1 3 0 0 6 0 0
I I i l i i i =
4 0 6 0 9 0 A p p ro x . d e p l h ( l ) 4 5 0 ] 0 0
. f
r, ~ cSx
1 / ' ~ - ~ . . 4 .- -- ,~ , . . . . . . 4
4 0 8 0 t 2 0 4 8 0 p u t t e r t im e ( e )
l I I I
2 0 4 0 6 0 9 0 A p p r o x . d e p t h ( ~ i
Fig. 13a~z. De pth p rofiles of(a) sa mple 5 (27.5 Cr, 1.3 Mo , 4N i,
5.6Mn), (b)sample 6 (30.8Cr, 2M o, 2.3N i), and (c) pure
chromium. Fem, Cr : metall ic iron and chromium.
Feox =F e z+ +Fe 3+, Crox =C r 3+
I
o
c; ( t )
I t '& )
9
8
7
6
5
4
3
2
1
I
s a m p l e s 1 a n d 2 c h a n g e s c o n s i d e r a b l y n e a r z ~ 1 0 A .
T h i s i n d i c a t e s e x c e s s o x y g e n v e r y c lo s e t o t h e s u r f a c e
d u e t o t h e a c c u m u l a t i o n o f h y d r o x i d e s a n d w a t e r a s
w e l l a s o t h e r o x y g e n - c o n t a i n i n g c o n t a m i n a t i o n s . F i -
n a l ly , it s h o u l d b e n o t e d t h a t e v e n a f t e r lo n g s p u t t e r in g
t i m e s a n a p p r e c i a b l e o x y g e n le v e l o f t h e o r d e r o f
5 - 8 a t . - % i s o b s e r v e d i n t h e a l l o y s a n d a l s o i n p u r e
c h r o m i u m . T h i s m i g h t b e s u r p r i s i n g a t f i r s t s i g h t ;
h o w e v e r , i t i s a w e l l - k n o w n f a c t t h a t t h e c o m p l e t e
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
11/18
Co rrosi on of Stainless Steels in Ch loride Solu tion 11
o
I
o
c . o ( t )
a t 1
C o I t ) / t t - - -
. ; 3 a
I i I i L t i
I ; ; _ _
4 0 B O t 2 0 t 8 0
S p u l i e r t i m e
( t ) 3 0 0
1 I I I I
2 0 4 0 6 0 9 0 A p p ro x. d ep th ~ ) ~ 5 0
t . 4
t . 2
t . 0
0 . 8
0 . 6
0 . 4
0 . 2
0
I
0
c ~ p ( t )
a t
%
4 4
t Z
t 0
8
6
4
2
0
I
0
b
/
: f @
/ f t . ~ |
/ I I I I I I
4 0 - 8 0 t 2 0
1 I I
2 0 4 0 6 0
6 0 0
3 0 0
# - - -
- / , - -
. m
, ' - -
I I / L _
1 8 0 S p u l te r t im e
I s) 3 0 0 6 0 0
I I I ; I _
9 0 A p p r o x . d e p t h
~ ) t 5 0 3 0 0
- - -
c \
/ . . . ~ > . . . . . . . . . . . . . . . . . . . l /_
I
_ ._ t i t __
' I I I I I I I I H- --
4 0 8 0 4 2 0 t 8 0
S p u t ter t im e
( e) 3 0 0 6 0 0
I I I I I l I ~
2 0 4 0 6 0 9 0 A p p r ox . d e p t h l l ) t 5 0 3 0 0
Fig. 14a-c. Dept h profiles of a) oxyg en, b) metall ic mo lyb-
denum, and (c) metallic nickel of selected samples @ pure
Armco ir on; @ 12.6Cr, 0 .5Me, 0 .6N i; @ 15.8Cr, 0 .9Me,
4.9Ni; | 1 .3M o, 10.9Ni; @27.5Cr, 1 .3M e, 4Ni,
5.6 M n; @__30.8Cr, 2 Me, 2.3 Ni; @ pure chromium
rem oval o f oxygen i s d if f icu l t o r e ven imposs ib le us ing
a rg o n - i o n s p u t t e r in g o f m e t a l s a n d a l l oy s w i t h h ig h
oxygen af f in i ty [10 ] .
F i g u re 3 a s h o ws t h e M o 3 d s p e c t r a o f s a m p l e 4 a t
different sputt ering t imes. Befo re sputtering, at t = 0 s ,
t h e s t ru c t u re o f t h e M o 3 d d o u b l e t i s c o m p l e x a n d
d i f fe ren t f rom the s t ruc tu res observed a f te r spu t te r ing
a t 20, 60 , and 180s . Befo re spu t te r ing the Mo3d3 /2
s t ruc tu re i s b ro ade r and s l igh tly sh i f ted tow ards
h igher b ind ing energ ies compared to the spec t ra a f te r
spu t te r ing ; in add i t ion a shou lder i s observed a t the
h igh-b ind ing-energy s ide o f th i s s t ruc tu re . These fea-
tu res imply tha t the meta l l i c Mo3d3 /2 l ine over laps
wi th l ines o f ox id ic 3ds/z s ta tes ind ica t ing the ex i s tence
o f sm a ll a m o u n t s o f m o l y b d e n u m o x id e s a n d / o r
oxyh ydrox ides [5 ] . The fac t tha t a f te r a spu t te r ing t ime
o f o n l y 2 0 s t h e s p e c t ru m a l r e a d y s h o w s t h e f e a t u re s o f
m e t a l l i c m o l y b d e n u m c o n f i rm s t h a t m o l y b d e n u m
o x i d e s a r e r a p i d ly r e d u c e d b y a rg o n - io n b o m b a rd m e n t
[1 1 -1 3 ] .
In c o n t r a s t t o m o l y b d e n u m , e s s e n t ia l ly n o n i c k el i n t h e
ox id ic s ta te has been observed in the pass ive f i lms .
E v e n i n s a m p l e 4 c o n t a i n in g a s m u c h a s 1 3 % N i , o n l y
meta l l i c n icke l has been observed befo re and a f te r
spu t te r ing (F ig. 3b ) : F igures 14b and c show th e dep th
pro f i l es o f meta l l i c M e and Ni . There i s a s t rong
dep le t ion in the reg ion o f the pass ive fi lms . Conce rn ing
t h e c o e x i st e n c e o f m e t a l l ic M e a n d N i w i t h m i x e d i ron -
c h ro m i u m o x i d e s t h e s a m e r e m a rk s a p p l y a s m a d e
a b o v e fo r m e ta l li c C r a n d F e . F o r s a m p l e s 4 a n d 6 we
o b s e rv e a p ro n o u n c e d a c c u m u l a t i o n o f m e t a ll i c n ic k e l
in the reg ion o f the in te r face be tw een the pa ss ive f ilm
and the a l loy .
Whi le no n icke l ox ides and on ly re la t ive ly smal l
a m o u n t s o f m o l y b d e n u m o x id e s a n d / o r o x y h y d r o x -
ides have been observed in the pass ive f i lms , the
s i tua t ion i s d i f fe ren t fo r the manganese con ta ined in
samp le 5 (Tab le 2 ) . In th i s a l loy ma ngan ese i s obse rved
i n b o t h t h e m e t a ll i c a n d o x i d ic s ta t e (M n O, M n O 2 , a n d
poss ib ly oxyhyd rox ides ) , even a f te r 180 s o f a rgon- ion
sputtering.
The su rface sens i t iv i ty o f XP S w hich i s a conse quenc e
o f th e l i m i t e d m e a n f r ee p a t h o f t h e e l e c t ro n s i n t h e
so l id , can be increased by lower ing the e lec t ron
emiss ion ang le O. F igure 15 shows the angu lar de-
p e n d e n c e o f th e r a t i o
I1 0) /I2 0) ,
w h e r e 11 0) is the
i n te n s it y d ue to O H - a n d H 2 0 a n d I 2 ( O ) i s t h e
in tens i ty o f 0 2 - bo un d to m eta l ions in the ox ide .
T h e s e i n te n s it ie s h a v e b e e n o b t a i n e d b y d e c o n v o l u t i o n
of the O ls l ines as show n in F ig . 4c , and the ang u lar
depen dence o f these in tens i t ies i s g iven by (5 ) . F igure 15
re fl e ct s t h e f a c t t h a t O H - a n d H 2 0 a r e e n r i c h e d i n t h e
ou te r par t o f the pass ive fi lms , the en r ichmen t be ing
m o s t p ro n o u n c e d i n t h e h i g h -a l l o y e d s a m p l e 6 c o n -
ta in ing 31 a t . -% chrom ium.
In o rd e r t o i n v e s t ig a t e c h l o r i d e p e n e t r a t i o n i n t o t h e
pass ive f i lms we have s tud ied two ex t reme cases ,
nam ely pure i ron (sample 1 ) and the a l loy con ta in ing
31 a t . -% chro miu m (sam ple 6 ). In pu re i ron we do f ind
s m a l l a m o u n t s o f c h l o r in e i n c o rp o ra t e d i n t h e o x i d e
f ilm, even a f te r a rgon- ion spu t te r ing o f 180 and 300 s ;
s i n c e a t t h e s e s p u t t e r t i m e s n o s o d i u m h a s b e e n
detec ted we can exc lude the poss ib i l i ty tha t the
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
12/18
12 P . Br t i e sch e t a l .
I
2
2 0
1 8
t 6
t 4
t 2
t 0
0 8
0 6
0 4
0 2
t s
[
0 t 5 3 0 4 5 6 0 7 5 9 0 O
F i g . 1 5. A n g u l a r d e p e n d e n c e o f l l O ) o f s a m p l e s 1 , 3 , a n d 6 . I 1 :
i n t e n si t y o f O H - a n d H 2 0 , 1 2 : i n t en s i ty o f 0 2 - b o u n d t o m e t a l
ions in the oxide
c h l o r i d e o r i g i n a te s f ro m r e s i d u a l t ra c e s o f N a C 1 p re -
sen t a t the su r face o f the sample . In samp le 6 , howe ver ,
n o d e t e c t a b l e i n c o rp o ra t i o n o f c h l o r id e s i n t o t h e
p a s s i v e f i l m h a s b e e n o b s e rv e d .
4 Di scuss i on
4 1 The Composit ion o f the Passive Films
In t h e fo l l o w i n g w e s u m m a r i z e t h e m o s t i m p o r t a n t
resu l t s concern ing the com pos i t io n o f the pass ive f ilms
a n d c o m p a re t h e m w i t h t h e r e s u l t s f r o m t h e
l i terature.
A n g l e -d e p e n d e n t X P S m e a s u re m e n t s h a v e s h o w n t h a t
h y d ro x i d e s a n d w a t e r a r e a c c u m u l a t e d i n t h e o u t -
e rm os t l ayers o f the pass ive f ilms and tha t the c en t ra l
r e g i o n o f t h e f i lm s c o n s i s ts m a i n l y o f ir o n -c h ro m i u m
o x id e s . Th e t r a n s i ti o n f ro m t h e o u t e r h y d ro x i d e -
wa ter reg ion to the inner ox ide reg ion i s con t in -
u o u s . Th e s e r e s u l t s a g re e w i t h t h o s e o b t a i n e d b y
O l e f j o rd [4, 5 ]; O k a m o t o [1 4 ] a n d B o c k r i s e t a l. [ 1 5,
1 6 ] h a v e a l s o e s t a b l i s h e d t h a t h y d ro x i d e s a n d w a t e r
are es sen t ia l com pon en ts o f the su r face f ilms.
Th e p a s s i v e f i l m s a r e e n r i c h e d i n c h ro m i u m . In t h e
r e g i o n o f t h e c r it i ca l c h ro m i u m c o n c e n t r a t i o n o f a b o u t
1 3 % , t h e c h ro m i u m c o n c e n t r a t i o n i n t h e f i l m s i n -
c r e a s e s n o n l i n e a r l y w i t h t h e c h ro m i u m c o n t e n t i n t h e
b u l k . F o r a l l o y s c o n t a i n i n g m o re t h a n 2 0 % c h ro m i u m
the cen t ra l reg ion o f the pass ive f i lms cons i s t s ma in ly o f
C r~ O 3 . O u r d e p t h p ro f i l e s s h o w p ro n o u n c e d m a x i m a
i n t h e c h ro m i u m c o n c e n t r a t i o n w h i c h a r e l o c a t e d c l o se
t o t h e s u r f a c e . Th e s e m a x i m a a r e m o re p ro n o u n c e d
t h a n t h o s e fo u n d i n t h e l i t e r a t u r e [1 7 -2 0 ] a n d a r e
qual i t a t ive ly s imi la r to the p ro f i l es observed fo r a i r -
o x i d iz e d i r o n -c h ro m i u m a l l oy s [2 1 ]. O n l y v e ry fe w
ind ica t ions a re foun d in the l i te ra tu re fo r a min im um in
t h e c h ro m i u m c o n c e n t r a t i o n a t t h e i n t e r f a c e b e t w e e n
the pass ive f i lm and the under ly ing a l loy [18 ] . A
poss ib le exp lana t ion fo r th i s observa t ion i s d i scussed
at the end of Sect . 4 .3 .
S i n ce i n F i gs . 1 1 -1 4 w e s h o w a b s o l u t e c o n c e n t r a t i o n s
o f t h e e l e m e n t s, o n e m i g h t b e t e m p t e d t o d e r i ve t h e
s to ich iom et ry o f the pass ive f ilms as a func t ion o f dep th
be low the su r face . Th is i s, in p rinc iple , poss ib le , bu t i t
s h o u l d b e k e p t i n m i n d t h a t t h e o b s e rv e d s t o i c h io m e -
t ry m a y d e v i a t e c o n s i d e ra b l y f ro m t h e t r u e s t o i c h io m e -
t ry due to spu t te r - induced e f fec t s , in par t i cu la r to
se lec tive spu t te r ing o f oxygen . W e have es t ima ted the
s to ich iom et ry in the cen t ra l re g ion o f the su r face f i lms
( i.e. , a t the ma x im um of the Fe ~ o r Cr ~ p ro f i l es in
F i g s . 1 1 -1 3 ) a n d h a v e fo u n d a c o m p o s i t i o n M 2 0 ~
( M 2 = F e ~1 76 w h e r e x ~ 1 . 8 - 2 . 3 f o r % < 2 0 %
a n d x ~ 3 f o r % > 2 0 % . T h e s e r e su lt s a g re e q u a li ta -
t i ve l y w i t h F ra n k e n t h a l ' s s p u t t e r e x p e r i m e n t s o f F e 2 0 3
as d i scussed a t the e nd o f Sect . 1 .3 . To f ind the t rue
c o m p o s i t i o n m a y r e q u i r e t h e u s e o f si g n if i ca n t ly m i l d e r
s p u t t e r c o n d i t i o n s . O n t h e o t h e r h a n d , t h e e a s e o f
spu t te r - ind uced redu c t ion o f the f ilms wi th l es s than
20% Cr i s a fu r ther ind ica t ion fo r the i r in su ff ic ien t
chemica l s t ab i l ity .
N i c k e l a n d c o p p e r h a v e b e e n o b s e rv e d o n l y i n t h e
meta l l i c s t a te ; these e lemen ts a re s t rong ly dep le ted in
the pass ive f i lms . On the o ther hand , we observe an
accu mu la t ion o f meta l l i c n icke l in the in te r face reg ion
between the pass ive f i lm and the a l loy ; th i s accumu-
la t ion i s mos t p ronounced in the n icke l - r i ch a l loy 4
con ta in ing 13% n ickel . An accu mu la t ion o f n icke l in
t h e i n t e r f a c e r e g i o n h a s a l s o b e e n o b s e rv e d b y
Olef jo rd [22 ] .
A s e x p e c t e d , m e t a l l ic m o l y b d e n u m i s st r o n g l y d e p l e t e d
in the pass ive f i lms . Molybdenum in ox id ic s ta tes i s
p resen t befo re spu t te r ing , s imi la r to the resu l t s o f
O l e f j o rd a n d B ro x [5 ] . Th e d i s t r i b u t i o n o f t h e s e s p ec i e s
in the pass ive f i lms canno t be dedu ced s ince a rgon- ion
s p u t t e r in g l e a d s to i n s t a n t a n e o u s r e d u c t i o n [1 1 -1 3 ] .
A n e n r i c h m e nt o f m o l y b d e n u m w a s f o u n d i n th e
p a s s i v e f i l m b y G o e t z a n d La n d o l t [ 2 3 ] f o r a n a l l o y
c o n t a i n in g 1 1 % M o ; t h i s c o n c e n t r a t i o n i s c o n s i d e r-
a b l y h i g h e r th a n t h e m o l y b d e n u m c o n c e n t r a t i o n s i n
o u r s a m p l e s , s o t h a t a d i r e c t c o m p a r i s o n w i t h t h e s e
resu l t s i s no t poss ib le . In con t ras t to Olef jo rd [2 2 ] bu t
i n a g re e m e n t w i t h Lu m s d e n a n d S t a e h l e [2 4 ] , w e d o
n o t f i nd a n e n r i c h m e n t o f m e t a l l ic m o l y b d e n u m b e l o w
the pass ive f ilm . Th is migh t b e due to the fac t tha t i t i s
d i f f i cu l t to de tec t such accumula t ions in nar row
reg ions by a m eth od invo lv ing spu t te r ing ; in add i t ion ,
in compar ing d i f fe ren t resu l t s i t shou ld be bo rne in
min d tha t the p referen t ia l d i s so lu t ion o f a l loy ing
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
13/18
C o r r o s i o n o f S t a i n le s s S t e el s i n C h l o r i d e S o l u t i o n 1 3
c o m p o n e n t s d e p e n d s t o s o m e e x t e n t o n t h e e l e ct ro l yt e
used fo r the e lec t rochemica l exper imen ts .
In sample 5 (dup lex s tee l) con ta in ing 5 .6 Mn , the
pass ive f i lm con ta ins manganese in the ox id ized s ta te .
S i n ce t h e M n 2 p 3 /2 b i n d i n g e n e rg ie s o f M n O , M n 2 0 3 ,
and M n3 0 4 a re o n ly s l igh tly d i f fe ren t [25 ] , i t i s no t
poss ib le to es tab l i sh the ac tua l ox ida t ion s ta te ; the
s p e c t r a a r e c o m p a t i b l e w i t h M n / a n d M n 3 b u t n o t
wi th M n 4+ .
S m a l l a m o u n t s o f c h l o r id e o r i g i n a t in g f ro m t h e
e lec t ro ly te cou ld be observed in the su rface f i lm on
p u re i ro n . Un d e r o u r e l e c t ro c h e m i c a l c o n d i t i o n s
(OC P) th i s f i lm i s no t a pass ive f ilm and a l lows ch lo r ide
to pene t ra te to a cons iderab le ex ten t . Th is i s no t the
c a s e fo r t h e c h ro m i u m - r i c h s a m p l e 6 c o n t a i ni n g 3 1
C r , a n d p ro b a b l y n e i t h e r fo r th e o t h e r a l lo y s c o n t a in -
i n g m o re th a n 1 2 C r ; t h e a b s e n c e o f c h l o r id e s f ro m
t h e p a s s i v e fi lm s h a s a l s o b e e n r e p o r t e d b y E l f s t r6 m
[1 9 ] a n d S z k l a r s k a -S m i a l o ws k a [2 6 ] .
4.2. Passive Fi lm s
and Cri t ical Chromium Concentrat ion
I t i s a wel l -know n fac t tha t be low a c r i t i ca l ch rom ium
conc en t ra t io n Corit o f abo u t 12 the co rro s ion ra te o f
i ron -ch romium s tee l s increases d ras t i ca l ly wi th de-
creas ing ch rom ium con te n t [27 ] . Al loys wi th c < co rlt
a r e n o n n o b l e , t h a t i s , t h e y n o rm a l l y s h o w s t ro n g
corr osion , w hile al loys w ith c > co,i t are noble , that is ,
they fo rm a pass ive f i lm which s t rong ly suppresses
corros ion . Th is c r i t i ca l l imi t i s observed , no t on ly in
p u re i ro n -c h ro m i u m a l lo y s b u t a l s o in t h e c o m m e rc i a l
s tee ls inves t iga ted in th i s s tudy . F igure 16a shows the
open-c i rcu i t p o ten t ia l s (OC P) a t 4 ks f rom Fig . 7 as
wel l as the cu rren ts a t U = 0 V (sce) f rom Fig . 9b . On e
c a n s e e i m p o r t a n t c h a n g e s o f b o t h t h e O C P a n d t h e
corro s ion cu rren ts a t c ~ co rit . The resu l t s fo r OC P are
c o n s i s te n t w i t h t h o s e o f Uh l i g [9 ] o b t a i n e d u n d e r
s imi la r cond i t ions (deaera ted NaC1 so lu t ion ) .
T h e q u e s t i o n s n o w a r i se t o w h a t e x t e n t t h e p ro p e r t i e s
o f the pass ive f i lms chan ge a t corot and how these
p ro p e r t i e s c a n b e c o r r e l a t e d w i t h t h e e l e c t ro ch e m i c a l
b e h a v i o u r .
F i g u re 1 6 b i l lu s t ra t e s th e c h ro m i u m a c c u m u l a t i o n ,
dccr as def ined in F ig . t 0 as w el l as the me an th ickness
d o f the su rface f i lms as func t ions o f the ch rom ium
conc en t ra t io n in the a l loys . The f i lm th icknesses d have
been es t im ated f rom the de p th p ro f i l es (F igs . 11 to 13
and 14a). Both quanti t ies change drast ical ly at Cc~it .
Accord ing to F ig . 16b co rros ion -res i s tan t a l loys
(c > co, it ) a re charac te r ize d by th in pass ive f i lms which
a re s t ro n g l y e n ri c h e d i n c h ro m i u m . O n t h e o t h e r h a n d ,
non nob le s tee ls (c < C ,~ t) a re ch arac te r ized by re la t ive ly
th ick ox ide o r hydrox ide f i lms , the ch romium enr ich -
me n t o f wh ich i s on ly smal l o r n il . As men t ioned in
, a
t . 5 - . ...... ......
I
I
. .
n
~ 0 . 5
Z
0 - - t i i
0 8 t 6 2 4 5 2
C c r ( a t ) l n a l l o y
kd b A )
6 0 .
5(> 9
/
4 g
3 0
d
o I j o o
0 ~ )
t o
2 0
3 0
C c r ( a t ) i n a g o y
c ,C : ~ 1 7 6 - - . I - - - :
0 4
0 , 2 - - , , 4
2
~ C c r i t
0 ~' I ~ I I
0 1 0 2 0 3 0
C c r ( a t
) l n a l l o y
A C c
a t %1-
+ 1 0 0
ul
0
I00
>
E
- 3 0 0 -
|
5 o o
0
70 0
~ 1 4
12
I0
8
6
4
2
t . O
F e 3 +
F e 2 + + F e 3 +
0 . 9
0 . 8
0 . 7
F i g . 1 6 . ( a ) O p e n - c i r c u i t p o t e n t i a l s f ro m F i g . 7 ( p o i n t s a t 4 k s ;
r i g h t - h a n d s c a l e ) a n d p o t e n t i o d y n a m i c c u r r e n t s
ipa)
f r o m F i g s .
9a (e ) a nd 9b (0 ) (po in ts a t 0 V, le f t -hand sca le ) a s func t io ns o f the
c h r o m i u m c o n t e n t i n t h e a l l o y s. T h e v e r t ic a l a r ro w s i n d i c a t e t h e
t e n d e n c y t o w a r d s 1 0 k s ; t h e l o w e r p a r t o f t h e O C P c u r v e is
i n t e r p o l a t e d a c c o r d i n g t o U h l i g [ 9 ] . ( b ) M e a n t h i c k n e s s d o f t h e
s u r f a c e l a y e r s a n d c h r o m i u m e n r i c h m e n t A c c r (Fig. 10) as
f u n c t i o n s o f th e c h r o m i u m c o n t e n t i n t h e a ll o y s . | a c c o r d i n g t o
E l f s t r 6 m [ 1 9 ] . ( c ) N o r m a l i z c d c o n c e n t r a t i o n o f C r 3 +
[ C r ~ ~ + F e ~ ( - - f r o m d e p t h p r o f i le s ; . . . . . f r o m i n t e g r a l
c o n c e n t r a ti o n s ) a n d n o r m a l i z e d c o n c e n t r a t i o n o f F e 3 +
[ F e 3 + / F e z + + F e 3 + )] a s f u n c t i o n s o f t h e c h r o m i u m c o n c e n -
t r a t i o n i n t h e a l l o y s
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
14/18
14 P. Brfiesch et al.
Sect. 4.1, the lat ter films do not const itute passive films,
since they were formed under OCP conditions not
leading to a point in the passive region at long
exposure times. This s tatement applies in particula r to
the films formed on pure iron and alloy 1A whose film
thicknesses are not well reproducible and probably
also depend on the electrolyte [28]. The film thick-
nesses of samples 1 and 1A plotted in Fig. 16b are
estimated mean thicknesses with an uncertainty of at
least __ 20 A. We do not believe, however, tha t these
films were formed only after the end of exposure of the
samples to the electrolyte, because all manipula tions
were carried out under controlled conditions (transfer
of the sample in argon atmosphere). We cannot rule
out that precipitation of corrosion products from the
solution has con tributed to the films found on samples
1 and 1A and is responsible for some of the irreproduci-
bility in film thickness. On the o ther hand, it is known
that the passive films (c>%it) formed under OCP
conditions after a long exposure time (about 15 h) are
quite stable [29], and for this reason their film
thicknesses are expected to be well reproducible and
unaffected by precipitation effects. At this point it
should be mentioned that a qualitatively similar
behaviour of film thickness as a function of chromium
concentration has also been found for pure iron-
chromium steels by means of ellipsometric
methods [30].
Figure 16c shows the normalized cation concentr ation
ofCr 3 +, tha t is the ratio R = Cr~ ~ + Fe~ as well
as the normalized concent ration of Fe 3+, that is
P = Fe 3+/(Fe 2+ + Fe 3 +), in the passive films, as func-
tions of chromium concentration c in the alloys. The
values of P have been determined by deconvolu tion of
the Fe2p3/2 spectra before argon i on sputtering
(Fig. 4a). Alloy 2 with c = 12.6 at.-% Cr is just at %~t
9 and R-~ 40%. For the true passive films with c > corotwe
obtain R > 50% in agreement with Fischmeister et al.
[31] and with Asami et al. [28]. A quali tatively similar
behaviour for P(c) has been found by Asami using
1N H2SO 4 as the e lectrolyte [32]; his absolute values
are, however, significantly different from our values,
possibly because of the different electrolyte or the
different method used for d ata evaluation. The fact that
alloy 2 is just at the limit between active and passive
behaviour is also reflected in Fig. 7 (compare the
corresponding remarks made in Sect. 2).
The general behaviour of the normalized concent-
ration of Fe a +, that is of P c ) , can be explained if one
assumes tha t Fe 3 + ions lost from the film by disso-
lution in the electrolyte are partially replaced by Cr 3
supplied from the alloy by diffusion. Note the rela-
tively large deviation of the data point for sample 5
containing 27.5 at.-% Cr a nd 5.6 at.-% Mn (Table 2).
This deviation would be expected under the assump-
tion that the substitution of Fe by Mn occurs mainly
in the divalent state. According to Pourba ix [33] the
system is just at the bound ary between Mn 2+ and
Mn 3 +.
It is very remarkable that the functions ACc~(C),d c),
R c ) ,
and
P c )
shown in Figs. 16b and c are largely
independent of alloy structure an d the presence of the
alloying elements Mo, Ni, and Cu (Table 2). This is
understandable if one remembers that Ni and Cu are
very strongly depleted in the passive films and that Mo
occurs only in very small quantities. The functional
dependences shown in Figs. 16b and c are therefore
almost completely determined by the main elements
iron and chromium. Deviations are expected to occur
only if the alloying elements are present in the oxidic
state in appreciable quantities, as is the case for
manganese in sample 5 (Fig. 16c).
4 . 3. T h e H y p o t h e s i s o f a P h a s e T r a n s it i on
in th e Pa ss ive F i lm
The properties of the surface films depicted in Figs. 16b
and c all show a drastic change near the critical
chromium concentration c=c~rit~12.5at.-%. This
strongly suggests that the transition from corrosive
behaviour at c < eerit o the passive behaviour at c > co,it
is due to a phase transition in the surface film which is
driven by the chromium concen tration c in the alloy, or
more precisely, by the corresponding chromium con-
centration x c ) in the films.
Transmission-electron-diffraction studies by McBee
and Kruger [-34] indicate that the anodically formed
surface films are composed of iron-chromium oxides
of the spinel type with the composition
2 3 3
Fe Fe2-x(c~Crx(c)O,. If this is the case the phase
transition is expected to occur at a critical con-
centration x = xcrit. The results obtained by XPS and
SAM show, however, that the composition of the
surface films is more complicated, because the films not
only contain oxides but also hydroxides and water, the
latter species being accumulated in the outermost
monolayers.
Consider now an alloy with chromium concentrat ion c
whose clean surface (such as ob tained after argon-ion
sputtering) is exposed to the electrolyte. In the first
monolaye rs certain reaction products, such as hydrox-
ides will be formed. Further oxidation of the alloy
below the surface film can continue only if the oxygen-
carrying species (O) can migrate from the electrolyte
throu gh the surface film already formed. In the station-
ary state the rate of oxidation at the alloy-film nterface
is equal to the dissolution rate at the film-electrolyte
interface so that the film thickness and composition
remain constant. The oxygen current is therefore
equivalent to a corresponding current of iron and
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
15/18
Corrosion of Stainless Steels in Chloride Solution 15
chromium in to the e lec t ro ly te . Le t Do be an e f fec t ive
d i f fus ion coeff ic ien t fo r oxygen (which inc ludes pos -
sible effects of electrical f ields acr oss the fi lm). Do wil l
i n g e n e ra l d e p e n d o n x ( a n d h e n c e o n c ) : Do = Do x).
Fr om the dep th p ro f i l es o f oxyge n (F ig. 14a) i t fo llows
t h a t
Do x)
is lar ge for x < x~rlt (slow ly falling profiles),
b u t t h a t
Do x)
is sm all for x >Xcr~t (rapidly fal l ing
pro f i l es ) . Thus , the phase t rans i t ion men t ioned above
man i fes t s i t se lf a l so in a s t rong change o f
Do x)
n e a r
x = xcr i r The na tu re o f th is p hase t rans i t ion i s no t
k n o wn ; i t m i g h t b e a s t ru c t u ra l p h a s e t r a n s i t i o n
(crys ta ll ine to amo rpho us , fo r example [34 ]) o r a phase
t r a n s i ti o n i n a m i x e d c o n d u c t o r i n wh i c h t h e e l e c t ro n ic
a n d i o n i c c o n d u c t i v i t y a r e s t ro n g l y c o u p l e d a n d
s t ro n g l y d e p e n d o n c h ro m i u m c o n c e n t r a t i o n x i n t h e
film.
In the case o f a s lowly fa l ling dep th p ro f i l e o f oxygen
(X
-
7/25/2019 Corrosion of Stainless Steel in Chloride Solution
16/18
16 P. Br/iesch et al.
s ta in less s tee l num ber 2 be ing on the m arg ins o f
showing p i t t ing co rros ion [48 ] . Indeed , the e lec t ro -
c h e m i c a l r e s u l t s h a v e s h o wn t h a t t h e s e e x p e c t a t i o n s
we re fulfil led , w ith al l the s tainless s teels as well as the
p u re C r s h o wi n g p a s s i v e c o r ro s i o n b e h a v i o u r .
Un d e r t h e e x p e r i m e n t a l c o n d i t i o n s c o n s i d e re d i n t h is
s t u d y a l l o y 2 c a n b e c o n s i d e re d a t r a n s i t i o n b e t we e n
t h e n o n p a s s i v e i ro n a n d t h e i ro n -c h ro m i u m a l l o y
c o n t a i n i n g 7 C r o n t h e o n e h a n d a n d t h e fu l ly p a s s i v e
b e h a v i o u r e x h i b i t e d b y a l l o ys 3 t o 6 o n t h e o t h e r h a n d .
I f these a l loys 3 to 6 a re then sa id to exh ib i t s t ab le
pass iv i ty , it i s c lear tha t the s tab le pass ive f i lm i s la rge ly
i n d e p e n d e n t o f a l l o y c o m p o s i t io n . I t c a n b e c h a ra c t e r -
ized by a fou r- layer s t ruc tu re cons i s t ing in tu rn o f a
h y d ra t e d l a y e r c o n t a i n i n g m u c h o x y g e n a n d O H - i o n s
i n c o n t a c t w i t h t h e s o l u ti o n , a l a y e r c o m p o s e d o f a
m i x e d i ro n -c h ro m i u m o x i d e , a l a y e r a p p ro x i m a t i n g
C r2 0 3 wh i c h i s i n i m m e d i a t e c o n t a c t w i t h a m e t a l l i c
l a y e r d e p l e te d i n c h ro m i u m a n d e n r i c h e d i n n ic k el . T h e
ou te r 3 layers a re on ly 1 .5 to 2 .0 nm in dep th and thus
re p re s e n t o n l y s e v e ral m o n o l a y e r s : t h e a c t u a l n u m b e r
o f m o n o l a y e r s d e p e n d s o n w h e t h e r o x y g e n o r C r 2 0 3 i s
t a k e n a s t h e s t a n d a rd o f m e a s u re m e n t . W i t h i n t h is
g e n e ra l s t ru c t u re t h e re a re t wo a d d i t i o n a l n o t e w o r t h y
fe a t u re s : n o c h l o r i d e i s i n c o rp o ra t e d i n t o t h e p a s s i v e
f il m ; a n d m e t a l li c c h ro m i u m a n d i ro n c o e x i s t w i t h i n
the ox ide layers. Th is las t observ a t ion can be in te rp re-
ted as e i ther meta l l i c c lus te rs wi th in the pass ive f i lm o r
a s i n h e re n t (p ro b a b l y l o c a l i z e d ) i n h o m o g e n e i t i e s i n
fi lm thickness .
These s imi la r i t i es in the s t ruc tu re and compos i t ion o f
the s tab le pass ive f i lm fo r a l loys 3 to 6 wou ld be
expec ted to l ead to s imi la r p roper t i es . Thus , fo r
e x a m p l e , t h e c o r ro s i o n r a t e s h o u l d b e g o v e rn e d b y
e i ther the d i f fus ion ra te th rough the f i lm o r a l t e rna-
t i v e l y b y l e a k a g e s t h ro u g h l o c a l i z e d s p o t s wh e re t h e
f i lm is par t i cu la r ly th in . These exp ec ta t ions a re cons i s -
t e n d w i t h t h e e x p e r i m e n t a l o b s e rv a t i o n s t h a t t h e c o r ro -
s i o n r at e , a s m e a s u re d b y i p a i s v i r tua l ly the same fo r
al loys 3 to 6 .
On t h e o t h e r h a n d , wh e n t h e c o r ro s i o n r e s i s t a n c e i s
cons ider ed in te rms o f res i s tance to p i t ting co r ros ion in
m o re c o n c e n t r a t e d c h l o r i d e s o l u t i o n s a t h i g h e r t e m -
p e ra t u re s, t h e n a n a d d i t i o n a l c o n s i d e ra t i o n c o m e s i n to
p lay . Th is i s the cons ide ra t ion o f the f i lm s tab i l i ty
under the more aggress ive cond i t ions . The d i f fe rences
in th is so r t o f co rro s ion res i s tance m us t res ide in
differing abi l i t ies o f the d ifferent s tainless s teels to
ma in ta in the s tab i l i ty o f the i r pass ive f ilm in env i ron-
me n ts o f d if fe ren t aggress iv ity . As th i s so r t o f co rro s ion
re s i s t a n c e i n c re a s e s w i t h b o t h c h ro m i u m a n d m o l y b -
denum con ten ts , i t appears tha t the ava i lab i l i ty o f
ch ro miu m in the a l loy i s one o f the c r i ti ca l fac to rs in
p a s s iv i ty , a n d t h a t t h e ro l e o f m o l y b d e n u m m u s t b e i n
fac i l i t a t ing ch romium ava i lab i l i ty e i ther by eas ing
c h ro m i u m t r a n s p o r t t o s i te s wh e re i t m a y b e o x i d i z ed
t o C rz O3 o r b y d e c re a s i n g t h e a c t i v it y o f e n v i ro n -
m e n t a l s p e c ie s wh i c h wo u l d t e n d t o s o l v a t e t h e
c h ro m i u m .
S i n ce t h e fi lm s t ru c t u re a n d c o m p o s i t i o n a s m e a s u re d
in th is s tud y is very s imi la r to tha t de te rm ined in o th er
studies [-4 , 5 , 14-24, 26, 56] i t appea rs t hat a s table
pass ive f i lm wi l l have s imi la r s t ruc tu re and compo-
s i ti o n u n d e r a l l c o n d i t i o n s o f a l l oy c o m p o s i t i o n a n d
env i ronmen ta l exposure . Th is f i lm s t ruc tu re wi l l then
p ro d u c e c o m p a ra b l e c o r ro s i o n r a te s . T h is is d o c u m e n t -
e d i n T a b l e 3 wh e re t h e p a s s i v e c u r r e n t d u r i n g
p o l a r i z a t i o n s t u d i e s h a s b e e n t a k e n a s a m e a s u re o f
the co rros ion ra te . The va lues in th i s t ab le do indeed
show th a t a w ide range o f s ta in less s tee ls under a wide
ra n g e o f e n v i ro n m e n t a l c o n d i ti o n s , h a v e p a s s iv e c u r -
ren t dens i t i es wi th in a re la t ive ly narro w range o f va lues .
Ho w e v e r , it s h o u l d a l s o b e n o t e d t h a t t h e re is a
sys temat ic increase in pass ive cu rren t dens i ty wi th a
d e c re a s e i n p H , a d e c re a s e i n m o l y b d e n u m c o n t e n t o r
an increase in t empera tu re . These re la t ive ly minor
d i f fe rences in pass ive cu rren t dens i ty mus t then b e
a c c o u n t e d fo r b y t h e r a t h e r s u b t l e d i f f e r e n c e s i n t h e
p a s s i v e f i l m s t ru c t u re a n d c o m p o s i t i o n . W h a t i s
n e e d e d i s a n i n -d e p t h s t u d y r e l a t in g p a s s i v e c o r ro s i o n
Table 3. Passive current densities for a wide range of stainless steels under a wide range of environmentalconditions
Material Environment Passive current Scan rate Ref.
[ga/c m