complete vehicle inspection€¦ · ok sug req tire size: speed rating run flat f r y n tpms y n...

Year Make Model

MILEAGE:

Eng. Size

Hubcap Missing Windshield Cracked Scratches/DentsY N Y N Y N

State Inspection Due Month YearLic. #

SOHC VVT DIESEL Trans. Type

Auto Manual CVTHYBRIDDOHC

FWD RWD AWD 4WDDriveline

Visual Tread Depth32nds

OK SUG REQ

Tire Size: SpeedRating Run Flat

F

R

Y N

TPMS Y N

RotationTire Mainenance

Alignment Check

Balance

Pads greater than 6mm (Disc) or Shoes greater than 2.44mm (Drum)Pads greater than 3mm or less 6mm (Disc) or Shoes greater than 1.6mm or less than 2.4mm (Drum)

Document vehicle specific measurements & minimum specifications belowPads less than 3mm (Disc) or Shoes less than 1.6mm (Drum)

Document vehicle specific measurements & minimum specifications below

Maintenance Tire Wear

Tire Inspection

Brake Inspection

Left FrontPSI In: PSI Out:

Right FrontPSI In: PSI Out:

Right RearPSI In: PSI Out:

Left RearPSI In: PSI Out:

LF Pad

MM Actual

ActualMeas.

MachineTo

DiscardAt

ActualMeas.

MachineTo

DiscardAtMM Spec.

MM Actual

MM Spec.

RF PadLF Rotor

LF Rotor/Drum RF Rotor/Drum

RF Rotor

PSI In: PSI Out:

EdgewearCuppingCutsIrregularity

CrackingNailsRepairableNon-Repairable









MostVehicles

LR Pad/Shoe RR Pad/Shoe

MM Actual

Rear Clean / Adj

Brake Hose(s)

Parking Cables

Hardware Caliper RepackOther BrakeServices

WheelCylinder

ActualMeas.

MachineTo

DiscardAt

ActualMeas.

MachineTo

DiscardAtMM Spec.

MM Actual

MM Spec.

INSPECTED BY

FrontWiper Blades

Head Lights

Accessory Lights

Filters

Oil Level

Battery TerminalProtection

Belt Tensioner

Ignition Wires

Leaks

Timing Belt

Lift Supports

Struts/Shocks

Control Arms

Hub/Bearings

Strut Mounts

Spark Plugs

PCVAir Fuel

Washer Fluid

Brake Fluid Flush

Coolant Hoses

Cabin

Power StreeringFluid Level

Trans. ServiceAuto / ManualCoolantLevel / Flush

Battery Test

BatteryAccessories

Start / ChargeTest

Fuel SystemService

Master Cylinder(s)Fluid Level

Brake

Type

Copper parts per million0 10 30 100 200 300

Upper

Good

Cable Ends/ Cables

Corrosion

HosePower Steering

Pressure

Flush

Return Tailpipe

Preventive

Hold Downs

Lower

Weak cell(s) Replace

Bypass Heater

Oil Pan Valve Cover Intake Gasket

Hood Trunk/Lift Gate

PosNeg

ALTA/C

FlushPan

PSAP

Belts1 2 3 4Belts “V”

Serp

ParkingTurnSignal

LicensePlate

Fill

Rear

Maintenance SuggestedVisual Sched.

Maint.OK SUG REQInspect Why we recommend service

FrontRear

LeftLeft

RightRight

OK*Checked &Acceptable

Repair / Replacement Suggested1) Near end of useful life2) Customer requested to fix issue3) To comply with OE recommendation4) Necessary preventative wear replacement

Repair / Replacement RequiredA) No longer performs intended purposeB) Does not meet design specificationC) MissingD) Safety hazard

U-Joint Front Rear

Idler / Pitman Arm Idler Pitman

Bushings Control Arm Sway Bar FrontRear

Tie Rod Ends L Out L In R In R Out Sleeve (s)

Ball Joints L UpperL Lower

R UpperR Lower Spec

L UpperL Lower

R UpperR Lower

Actual

Rack & PinionAssembly Flush Filter Boots

CV Boots/Joints L Out L In R In R Out

Exhaust System Intermediate Pipe Muffler

OBD Codes RetrievedOBD code:Notes:

Complete Vehicle Inspection

Exhaust, Steering and Suspension

InnerOuter

LF Rotor

LF Rotor/Drum RF Rotor/Drum

RF Rotor

Strut Mounts Strut

Sway Bar Link

Rack & PinionInner Tie Rod

Outer Tie Rod

Sway BarBracket/Bushings

Sway BarBracket/Bushings

Ball Joint

Control Arm Bushings

CV Axle/BootControl Arm

Idler ArmPitman Arm

Hub/Bearings

Coil Spring

Center LinkDraglink

LowerControl Arm

Control ArmBushings

LowerBall Joint

Brake Fluid Flush

Power Streering Fluid Level

Trans. Service Auto / Manual

Master Cylinder(s) Fluid Level

Copper parts per million0 10 30 100 200 300

Flush Pan Service

Flush Filter Boots

Visual Sched.Maint.OK SUG REQInspect Why we recommend service

Year Make Model

MILEAGE:

Eng. Size

Hubcap Missing Windshield Cracked Scratches/DentsY N Y N Y N

State Inspection Due Month YearLic. #

SOHC VVT DIESEL Trans. Type

Auto Manual CVTHYBRIDDOHCVIN FWD RWD AWD 4WDDriveline

Visual Tread Depth32nds

OK SUG REQ Outer Inner

Tire Size: SpeedRating Run Flat

F

R

Y N

TPMS Y N

RotationTire Mainenance

Alignment Check

Balance

Maintenance Tire Wear

Tire Inspection

Maintenance Suggested

Left FrontPSI In: PSI Out:

Right FrontPSI In: PSI Out:

Right RearPSI In: PSI Out:

Left RearPSI In: PSI Out:

PSI In: PSI Out:











INSPECTED BY

Pads greater than 6mm (Disc) or Shoes greater than 2.44mm (Drum)Pads greater than 3mm or less 6mm (Disc) or Shoes greater than 1.6mm or less than 2.4mm (Drum)

Document vehicle specific measurements & minimum specifications belowPads less than 3mm (Disc) or Shoes less than 1.6mm (Drum)

Document vehicle specific measurements & minimum specifications below

Brake Inspection

LF Pad

MM Actual

ActualMeas.

MachineTo

DiscardAt

ActualMeas.

MachineTo

DiscardAtMM Spec.

MM Actual

MM Spec.

RF Pad

MostVehicles

LR Pad/Shoe RR Pad/Shoe

MM Actual

Rear Clean / Adj

Brake Hose(s)

Parking Cables

Hardware Caliper RepackOther BrakeServices

WheelCylinder

ActualMeas.

MachineTo

DiscardAt

ActualMeas.

MachineTo

DiscardAtMM Spec.

MM Actual

MM Spec.

U-Joint

Idler / Pitman Arm

Center Link

Link Pins

Struts/Shocks

Control Arms

Hub/Bearings

Strut Mounts

Rack & PinionAssembly

Front

Idler

CV Boots

Tie Rod Ends

Pitman

Rear

Bushings Control Arm Sway Bar FrontRear

FrontRear

LeftLeft

RightRight

L OutL In

R OutR In

Sleeves

L OutL In

R OutR In

FrontRear

LeftLeft

RightRight

Ball Joints L UpperL Lower

R UpperR Lower Spec

L UpperL Lower

R UpperR Lower

Actual

OK*Checked &Acceptable

Repair / Replacement Suggested1) Near end of useful life2) Customer requested to fix issue3) To comply with OE recommendation4) Necessary preventative wear replacement

Repair / Replacement RequiredA) No longer performs intended purposeB) Does not meet design specificationC) MissingD) Safety hazard

Undercar Inspection

Steering and Suspension

Flush Filter Boots

complete vehicle inspection€¦ · ok sug req tire size: speed rating run flat f r y n tpms y n...

Documents