bard s3426
TRANSCRIPT
-
8/12/2019 Bard s3426
1/8
-
8/12/2019 Bard s3426
2/8
-
8/12/2019 Bard s3426
3/8
Form No. S3426-1213Supersedes S3426-813Page 3 of 8
Electr ic Heat Table
Electr ical Specif icatio ns
Heater Packages - Field Instal led
1 Maximum size of the time delay fuse or HACR type circuit breaker for protection of field wiring conductors.
2 Based on 75C copper wire. All wiring must conform to the National Electrical Code and all local codes.
3 These Minimum Circuit Ampacity values are to be used for sizing the field power conductors. Refer to the National Electrical code (latest version), Article 310 forpower conductor sizing.
Caution: When more than one field power circuit is run through one conduit, the conductors must be derated. Pay special attention to note 8 of Table 310 regarding
Ampacity Adjustment Factors when more than three (3) current carrying conductors are in a raceway.
* Top outlet supply option is available only factory installed and only on the selected models.
IMPORTANT: While this electrical data is presented as a guide, it is important to electrically connect properly sized fuses and conductor wires in accordance with the
National Electrical Code and all local codes.
lacirtcelE:gnitaR
stloVzH
esahP
tiucriCelgniS tiucriClauD
ledoMdleiF.oN
rewoPstiucriC
3
muminiMtiucriC
yticapmA
1 mumixaMtnerrucrevO
noitcetorP
2 dleiFrewoP
eziSeriW
2 dnuorGeriW
3 muminiMtiucriCyticapmA
1 mumixaMnoitcetorPtnerrucrevO
2 dleiFrewoP
eziSeriW
2 dnuorGeziSeriW
A.tkC B.tkC C.tkC A.tkC B.tkC C.tkC A.tkC B.tkC C.tkC A.tkC B.tkC C.tkC
Z0R-1VL3W/1VR3W50R01R
1-06-802/0321-05-002/022
11
2ro1
824508
530608
864
0101
8
A/NA/N45
A/NA/N62
A/NA/NA/N
A/NA/N06
A/NA/N03
A/NA/NA/N
A/NA/N
6
A/NA/N01
A/NA/NA/N
A/NA/N01
A/NA/N01
A/NA/NA/N
Z0S-1VL3W/1VR3W60S90S
3-06-802/032/022 3-05-002
111
917364
030405
0188
010101
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
Z0T-1VL3W/1VR3W90T21T
3-06-0643-05-004
111
215292
515203
410101
410101
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
Z0R-1VL5W/1VR5W01R02R
1-06-802/0321-05-002/022
12ro13ro1
9319341
06001051
8301
0186
A/N9393
A/N2525
A/NA/N25
A/N0606
A/N0606
A/NA/N06
A/N88
A/N66
A/NA/N
6
A/N0101
A/N0101
A/NA/N01
Z0S-1VL5W/1VR5W90S81S
3-06-802/0323-05-002/022
112
8255A/N
0406A/N
86
A/N
0101A/N
A/NA/N55
A/NA/N82
A/NA/NA/N
A/NA/N06
A/NA/N03
A/NA/NA/N
A/NA/N
6
A/NA/N01
A/NA/NA/N
A/NA/N01
A/NA/N01
A/NA/NA/N
Z0T-1VL5W/1VR5W90T51T
3-06-0643-05-004
111
812314
525354
0188
010101
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
Z0S-1VL6W/1VR6W90S81S
3-06-802/0323-05-002/022
122
24A/NA/N
06A/NA/N
8A/NA/N
01A/NA/N
A/N2424
A/N8255
A/NA/NA/N
A/N0606
A/N0306
A/NA/NA/N
A/N88
A/N01
6
A/NA/NA/N
A/N0101
A/N0101
A/NA/NA/N
Z0T-1VL6W/1VR6W90T51T
3-06-0643-05-004
111
226354
535405
888
010101
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
A/NA/NA/N
lanimoN
@WK
V042zH05ro06
segatloVdeilppArehtOtasgnitaRretaeHesahP-1
V042@ V032@ V022@ V802@ V002@
WK HUTB spmA WK HUTB spmA WK HUTB spmA WK HUTB spmA WK HUTB spmA
5 0.5 560,71 08.02 95.4 666,51 09.91 02.4 533,41 01.91 67.3 338,21 60.81 74.3 348,11 63.71
01 0.01 031,43 06.14 81.9 133,13 39.93 04.8 966,82 91.83 15.7 236,52 11.63 49.6 686,32 27.43
02 0.02 062,86 05.26 73.81 796,26 68.97 18.61 373,75 93.67 20.51 362,15 22.27 98.31 704,74 44.96
lanimoN
042@WK
V084ro
zH05ro06
segatloVdeilppArehtOtasgnitaRretaeHesahP-3
V084ro042@ V064ro032@ V044ro022@ V514ro802@ V004ro002@
WK HUTB spmA
V084/042 WK HUTB
spmA
V064/032 WK HUTB
spmA
V044/022 WK HUTB
spmA
V514/802 WK HUTB
spmA
V004/002
6 0.6 874,02 22.7/34.41 15.5 608,81 29.6/38.31 40.5 202,71 26.6/32.31 15.4 393,51 42.6/15.21 71.4 232,41 10.6/30.21
9 0.9 717,03 38.01/56.12 72.8 622,82 73.01/57.02 65.7 208,52 29.9/58.91 67.6 270,32 63.9/67.81 52.6 133,12 20.9/40.81
21 0.21 659,04 34.41/78.82 20.11 116,73 38.31/76.72 80.01 304,43 32.31/64.62 10.9 157,03 84.21/20.52 33.8 034,82 30.21/60.42
51 0.51 591,15 40.81/90.63 87.31 130,74 92.71/85.43 6.21 400,34 45.61/80.33 72.11 564,83 06.51/72.13 24.01 365,53 40.51/70.03
81 0.81 434,16 56.12/03.34 35.61 714,65 57.02/05.14 31.51 936,15 58.91/96.93 25.31 441,64 27.81/35.73 05.21 366,24 40.81/90.63
stinUWK0ottaeHcirtcelEgniddarofdengiseD sledoMV802/032nodradnatSrekaerBtiucriC
detsiLadanaC&SULTE sledoMV064nodradnatStcennocsiDelggoT
sledoM
sledoMR-1-802/032
sledoMS-3-802/032
sledoMT-3-064
#ledoMretaeH WK #ledoMretaeH WK #ledoMretaeH WK
1VR3W 50A-63HWHE01A-63HWHE
501
60B-30HWHE90B-30HWHE
69
90C-A63WHE21C-A63WHE
921
1VR5W 01A-40HWHE
02AH50AWHE0102
90B-50HWHE81B-A07WHE
981
90C-A50WHE51C-A50WHE
951
1VR6W 90BHA07WHE
81BHA07WHE981
90C-A50WHE51C-A50WHE
951
1VL3W L50AHA63WHE
L01AHA63WHE501
L60BHA63WHEL90BHA63WHE
69
L90CHA63WHEL21CHA63WHE
921
1VL5W L01A-40HWHE
02AH50LWHE0102
L90BH50AWHE81B-L07WHE
981
90C-L50WHE51C-L50WHE
951
1VL6W 90BHL07WHE
81BHL07WHE981
90C-L50WHE51C-L50WHE
951
-
8/12/2019 Bard s3426
4/8
Form No. S3426-1213Supersedes S3426-813Page 4 of 8
DIGITAL THERMOSTAT/CONTROLLER
C
5
3
1
6
4
R
7
BLOCKF
E
Y1
G
W1
W2
Y
UNIT LOWVOLTAGETERMINAL
2
IN3IN4-A+B
24V24 COM
IN2GND
OUT 9GND 7-9
OUT 8OUT 7RLY 6
SC 4-6RLY 5RLY 4RLY 3
SC 1-3RLY 2RLY 1
MIS-2852 C
8403-066 DIGITALCONTROLLER
lanimreT noitcnuF epyT mroF
B+ )desuton(+PTSM snoitacinummoC
A- )desuton(-PTSM snoitacinummoC
4NI rosneSerutarepmeTroodtuO tupnI 3epyTMHOK01
3NI recudsnarTerusserP tupnI GISP007-0,CDV5-0
DNG sdnuorGrosneS tupnI
2NI mralAtuokcoL tupnI erusolCyaleR
MOC42 moCCAV42 rewoP
V42 CAV42 rewoP
9TUO lortnoCrotoMnaF tuptuOgolanA CDV01-0
9-7DNG dnuorGlortnoC tuptuOgolanA
8TUO lortnoCdioneloSredaolnU tuptuOgolanA MWPCDV5ro0
7TUO lortnoCrotoMrewolB tuptuOgolanA CDV01-0
4YLR 1#rotcatnoCretaeH tuptuOyaleR yaleR
6-4CS 6-4stuptuOyaleRotCAV42 rewoP
5YLR 2#rotcatnoCretaeH tuptuOyaleR yaleR
6YLR )desuton(
3YLR )desuton(
3-1CS 3-1stuptuOyaleRotCAV42 rewoP
2YLR rotcatnoCrosserpmoC tuptuOyaleR yaleR
1YLR )desuton(
ECU OPERATING CONTROL SYSTEM
The W3R/LV1 through W6R/LV1 variable capacity air
conditioners utilize dedicated controllers and components
to optimize this unit for cooling operation from -40 degrees
F up to 131 degrees F (-40 degrees C to +55 degrees C).
These units are dual rated for 200-240V operation on both
50 and 60 Hz. Please read the following sequence of
operation before attempting any troubleshooting or repair.
Troubleshooting and repair procedures will be outlined
later (Page 5).
These models use a digital compressor and variable speed
indoor and outdoor motors. The motors and compressor
must be replaced with the exact same component to
maintain the above stated temperature and voltage ranges of
operation. The units are controlled by a Bard digital
thermostat/controller. This thermostat/controller contains
proprietary programming and must be placed with the exact
same component to ensure proper operation.
13-conductor 18 gauge control cable should be used for
making connections from thermostat/controller to the ECU.
Lead/Lag sequence available by special application of the8403-066 Digital Controllers. Consult ECU Installation
Instructions.
-
8/12/2019 Bard s3426
5/8
Form No. S3426-1213Supersedes S3426-813Page 5 of 8
SEQUENCE OF OPERATION
MODES OF OPERATION
Cool Only Mode:
Compressor will modulate from 100% down to 20%.
Compressor will cycle off if thermostat/controller set-point is
reached.
Heat Only Mode:
Electric heat Stage 1 operates at 1st-stage heating set-point.
Electric heat Stage 2 (if equipped) operates on 2nd-stage (-2F
below heating set-point).
Auto Mode:
Cooling or heating automatically selected based on building
temperature vs. thermostat/controller set-points and operates as
described above.
CCVC (Continuous Compressor Variable Capacity):
Compressor will modulate from 100% down to 20%.
Compressor will not cycle off if thermostat/controller set-point is
reached, and would stay running at the 20% minimum capacity.
If space temperature drops -2F below cooling set-point electric
heat Stage 1 will then cycle to maintain that condition.
If Stage 2 electric heat is installed, and if required, will cycle at -
4F below cooling set-point to maintain that condition.
If CCVC is terminated the controller will revert to Cool or
Auto operation.
CCVC would be an Operating Mode for all applications where
continuous run of the compressor is a requirement.
CCFC (Continuous Compressor Fixed Capacity):
The compressor is turned ON and locked ON as long as the
thermostat/controller is in CCFC.
When in CCFC the compressor does not modulate but will be
locked ON at 100% capacity.
If space temperature drops -2F below cooling set-point electric
heat Stage 1 will then cycle to maintain that condition.
If Stage 2 electric heat is installed, and if required, will cycle at -4F below cooling set-point to maintain that condition.
If CCFC is terminated the controller will revert to Cool or
Auto operation.
CCFC would not be considered an Operating Mode and should
only be used for system testing as required.
Indoor Blower Operation
The indoor blower speed will modulate with the compressor
operation from 50% to 100% of operation. Once compressor
operation is at 50 or below, percent airflow will be at 50% and no
further reduction of airflow will occur. Modulation is
accomplished by modulating a 0-10 volt signal from OUT 7 to the
indoor blower control board which then sends a PWM signal to
the indoor blower motor.
An additional option to maintain airflow at 100% is also available.
Outdoor Fan Motor Operation
The outdoor fan motor speed is varied in response to outdoor air
temperature and pressure. The fan motor will cycle on and off
with the compressor when not in a CCVC or CCFC. At all times
above 122 degrees OAT, the outdoor fan, OUT 9, will be
energized at high speed. From 122 degrees to 55 degrees the
outdoor fan, OUT 9, will be set at normal outdoor airflow. Below
55 degrees the outdoor fan will modulate to maintain a 300 psi
head pressure. This will act as a low ambient fan cycling control.
The output may go to zero output to maintain the 300 PSI. The
outdoor ECM motor will be programmed with a minimum
RPM allowed to protect the bearing system. Any signal that is
less than the percent torque required to maintain the minimum
RPM will cause the motor to shut off. Once head pressure rise
the motor will restart.
COOLING SEQUENCE
Compressor Operation
The cooling capacity of the WV series is controlled by loading or
unloading the compressor. On a call for cooling, the unloader
solenoid is energized for one second to ensure pressureequalization in the compressor. The compressor contactor, RLY
2, is then energized and the compressor will start. A PI control
loop then calculates the compressor capacity needed to reach set
point and modulates the compressor . Modulation range is from
20% to 100% capacity. Modulation is accomplished by a pulse
width modulated signal from OUT 8 which energizes the solid
state relay (SSR) and energizes or de-energizes the unloader
solenoid. The required compressor capacity is calculated every
15 seconds.
20% loadmeans 0 VDC for 3.0 seconds and 5 VDC for 12.0
seconds from OUT 8.
30% loadmeans 0 VDC for 4.5 seconds and 5 VDC for 10.5seconds from OUT 8.
40% loadmeans 0 VDC for 6.0 seconds and 5 VDC for 9.0
seconds from OUT 8.
50% loadmeans 0 VDC for 7.5 seconds and 5 VDC for 7.5
seconds from OUT 8.
60% loadmeans 0 VDC for 9.0 seconds and 5 VDC for 6.0
seconds from OUT 8.
70% loadmeans 0 VDC for 10.5 seconds and 5 VDC for 4.5
seconds from OUT 8.
80% loadmeans 0 VDC for 12.0 seconds and 5 VDC for 3.0
seconds from OUT 8.
90% loadmeans 0 VDC for 13.5 seconds and 5 VDC for 1.5seconds from OUT 8.
100% loadmeans 0 VDC for 15 seconds and 5 VDC for 0.0
seconds from OUT 8.
HEATING SEQUENCE
On a call for heating, if the space temperature falls 1F below
setpoint, the first stage of heating, RLY 4, will cycle ON. If the
space temperature falls 3F below setpoint, the second stage of
heating, RLY 5, will cycle ON. Indoor Blower airflow is
maintained at the Rated unit airflow at all times during heating.
ADDITIONAL SOFTWARE FEATURESCOOLING MODE
High ambient operation mode- Unit will modulate capacity
down above 125 degrees outdoor temperature. The thermostat/controller display will indicate high ambient operation mode
when this occurs.
High head pressure operation mode- When the unit head
pressure exceeds 610 PSI, the Unit will modulate capacity
pressure down until it is at or below 600 psi. Controls will
indicate head pressure control mode on the display when this
occurs.
-
8/12/2019 Bard s3426
6/8
Form No. S3426-1213Supersedes S3426-813Page 6 of 8
1Return air temperature at 50% R.H.
2Application data based on compressor at 100% capacity operating as CCFC up to 125F. Above 125F compressor capacity will modulate lower
as required to stay below 610 PSIG and stay on-line.
1Return air temperature at 50% R.H.
2Application data based on compressor at 100% capacity operating as CCFC; see description page 5.
Coo ling App lication Data 60 Hz - Outd oo r Temp erature BTUH (KW) 22222
3Return air temperature at 35% R.H.
3Return air temperature at 35% R.H.
Coo ling App lication Data 50 Hz - Outd oo r Temp erature BTUH (KW) 22222
ledoM .B.W/.B.D11111
gnilooCyticapaC
F57 )C9.32( F58 )C4.92( F59 )C0.53( F501 )C6.04( F511 )C1.64( F521 )C7.15( F131 )C55(
1VR3W1VL3W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
004,93007,82
)45.11()14.8(
002,43005,72
)20.01()60.8(
005,03001,62
)49.8()56.7(
003,82006,42
)92.8()12.7(
008,62009,22
)58.7()17.6(
002,52001,12
)83.7()81.6(
021,51066,21
)34.4()17.3(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
000,24008,72
)03.21()51.8(
009,73002,72
)01.11()79.7(
000,53003,62
)52.01()17.7(
004,33002,52
)97.9()83.7(
000,23008,32
)83.9()79.6(
007,03002,22
)00.9()05.6(
024,81023,31
)04.5()09.3(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
001,05005,82
)86.41()53.8(
005,34004,72
)57.21()30.8(
009,83008,52
)04.11()65.7(
000,63000,42
)55.01()30.7(
005,33009,12
)28.9()24.6(
006,13007,91
)62.9()77.5(
069,81028,11
)65.5()64.3(
1VR5W1VL5W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
009,65005,44
)76.61()40.31(
009,05005,14
)19.41()61.21(
002,64003,93
)45.31()15.11(
006,24004,73
)84.21()69.01(
009,93001,63
)96.11()85.01(
009,63003,53
)18.01()43.01(
025,92042,82
)56.8()72.8(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
007,06001,34
)87.71()36.21(
005,65001,14
)55.61()40.21(
000,35006,93
)65.51()06.11(
002,05004,83
)17.41()52.11(
000,84006,73
)60.41()20.11(
005,64001,73
)26.31()78.01(
002,73086,92
)09.01()07.8(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
003,27002,44
)81.12()59.21(
009,46003,14
)20.91()01.21(
009,85009,83
)62.71()04.11(
001,45006,63
)58.51()27.01(
004,05006,43
)77.41()41.01(
008,74008,23
)10.41()16.9(
042,83042,62
)02.11()96.7(
1VR6W1VL6W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
006,07003,05
)96.02()47.41(
009,36006,74
)27.81()59.31(
003,85000,54
)80.71()81.31(
008,35006,24
)67.51()84.21(
001,05005,04
)86.41()78.11(
003,74006,83
)68.31()03.11(
574,53059,82
)93.01()84.8(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
004,57008,84
)90.22()03.41(
000,17001,74
)08.02()08.31(
000,76004,54
)36.91()03.31(
005,36007,34
)16.81()08.21(
003,06001,24
)76.71()43.21(
006,75006,04
)88.61()09.11(
002,34054,03
)66.21()29.8(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
008,98000,05
)13.62()56.41(
005,18003,74
)88.32()68.31(
004,47005,44
)08.12()40.31(
005,86007,14
)70.02()22.21(
004,36008,83
)85.81()73.11(
002,95009,53
)53.71()25.01(
004,44529,62
)10.31()98.7(
ledoM .B.W/.B.D11111
gnilooCyticapaC
F57 )C9.32( F58 )C4.92( F59 )C0.53( F501 )C6.04( F511 )C1.64( F521 )C7.15( F131 )C55(
1VR3W1VL3W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
009,53002,62
)25.01()86.7(
002,13001,52
)41.9()53.7(
008,72008,32
)51.8()79.6(
008,52004,22
)65.7()65.6(
000,52009,02
)23.7()21.6(
000,32003,91
)47.6()56.5(
008,31085,11
)40.4()93.3(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
003,83003,52
)22.11()14.7(
005,43008,42
)11.01()72.7(
009,13000,42
)53.9()30.7(
004,03000,32
)19.8()47.6(
001,03007,12
)28.8()63.6(
000,82003,02
)02.8()59.5(
008,61081,21
)29.4()75.3(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
006,54000,62
)63.31()26.7(
006,93000,52
)06.11()23.7(
004,53005,32
)73.01()98.6(
008,23009,12
)16.9()24.6(
006,13000,02
)62.9()68.5(
008,82000,81
)44.8()72.5(
082,71008,01
)60.5()61.3(
1VR5W1VL5W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
008,15005,04
)81.51()78.11(
004,64008,73
)06.31()80.11(
001,24008,53
)43.21()94.01(
008,83001,43
)73.11()99.9(
004,63009,23
)76.01()46.9(
008,43002,23
)02.01()34.9(
048,72067,52
)61.8()55.7(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
003,55003,93
)02.61()15.11(
005,15005,73
)90.51()99.01(
003,84001,63
)51.41()85.01(
007,54000,53
)93.31()52.01(
007,34003,43
)08.21()50.01(
000,24008,33
)13.21()09.9(
006,33040,72
)48.9()29.7(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
008,56003,04
)03.91()18.11(
001,95006,73
)23.71()20.11(
006,35004,53
)07.51()73.01(
003,94004,33
)44.41()97.9(
009,54005,13
)54.31()32.9(
005,34009,92
)57.21()67.8(
008,43029,32
)02.01()10.7(
1VR6W1VL6W
F26/57)C7.61/9.32(
gnilooClatoTgnilooCelbisneS
003,46008,54
)48.81()24.31(
002,85004,34
)50.71()27.21(
001,35000,14
)65.51()10.21(
000,94008,83
)63.41()73.11(
006,54009,63
)73.31()18.01(
001,34002,53
)36.21()13.01(
523,23004,62
)74.9()47.7(
F76/08)C4.91/7.62(
gnilooClatoTgnilooCelbisneS
007,86005,44
)31.02()40.31(
007,46009,24
)69.81()75.21(
000,16004,14
)78.71()31.21(
008,75008,93
)49.61()66.11(
009,45004,83
)90.61()52.11(
005,25000,73
)83.51()48.01(
573,93057,72
)45.11()31.8(
27/58)C2.22/4.92(
gnilooClatoTgnilooCelbisneS
008,18005,54
)79.32()33.31(
002,47001,34
)47.12()36.21(
008,76005,04
)78.91()78.11(
004,26000,83
)82.81()31.11(
007,75004,53
)19.61()73.01(
009,35007,23
)97.51()85.9(
524,04525,42
)48.11()91.7(
SLEDOM .B.W/.B.D 33333 .H.R% yticapaCgnilooC )C05(F221 )C55(F131
1VL3W/1VR3W F56/58
)C3.81/4.92( 53
latoTelbisneS
)51.8(008,72)51.8(008,72
)40.6(006,02)40.6(006,02
1VL5W/1VR5W F56/58
)C3.81/4.92( 53
latoTelbisneS
)08.31(001,74)08.31(001,74
)57.21(005,34)57.21(005,34
1VL6W/1VR6W F56/58
)C3.81/4.92( 53
latoTelbisneS
)30.61(007,45)30.61(007,45
)49.41(000,15)49.41(000,15
SLEDOM .B.W/.B.D 33333 .H.R% yticapaCgnilooC )C05(F221 )C55(F131
1VL3W/1VR3W F56/58
)C3.81/4.92( 53
latoTelbisneS
)81.7(005,42)81.7(005,42
)84.5(007,81)84.5(007,81
1VL5W/1VR5W F56/58
)C3.81/4.92( 53
latoTelbisneS
)82.21(009,14)82.21(009,14
)15.11(002,93)15.11(002,93
1VL6W/1VR6W F56/58
)C3.81/4.92( 53
latoTelbisneS
)33.41(009,84)33.41(009,84
)17.31(008,64)17.31(008,64
-
8/12/2019 Bard s3426
7/8
Form No. S3426-1213Supersedes S3426-813Page 7 of 8
)mm(sehcnI-stnemeriuqeRnoitallatsnIdnalarutcetihcrAroftinUcisaBfosnoisnemiD
LEDOM HTDIW
)W(HTPED
)D(THGIEH
)H(
YLPPUS NRUTER
A B C B E F G I J K L M N O P Q R 1S 2S T
1VR3W1VL3W
002.83)079(
521.71)534(
365.07)2971(
88.7)002(
88.72)807(
88.31)353(
88.72)807(
00.04)6101(
88.01)672(
57.52)456(
39.71)554(
83.62)076(
57.82)037(
52.92)347(
00.72)686(
57.2)07(
91.93)699(
57.22)875(
41.9)232(
91.4)601(
00.21)503(
00.21)503(
00.5)721(
1VR5W1VL5W
570.24)9601(
234.22)075(
578.48)6512(
88.9)152(
88.92)957(
88.51)304(
88.92)957(
88.34)5111(
65.31)443(
66.13)408(
00.03)267(
13.23)028(
49.62)486(
96.43)188(
34.23)428(
73.3)68(
88.24)9801(
88.32)706(
00.01)452(
44.1)73(
00.61)604(
00.61)604(
88.1)84(
1VR6W1VL6W
570.24)9601(
234.22)075(
578.49)0142(
88.9)152(
88.92)957(
88.51)304(
88.92)957(
88.34)5111(
65.31)443(
66.14)6501(
00.03)267(
13.24)4701(
49.63)939(
96.44)5311(
34.24)8701(
73.3)68(
88.24)9801(
88.33)168(
00.01)452(
44.1)73(
00.61)604(
00.12)335(
88.1)84(
W*RV
RIGHT
UNIT
W*LV
LEFTUNIT
Dimensional drawings are not to scale.
MIS-3076
EntrancesElectrical
Side Wall
Brackets
LocationShipping
(Built In)
Return Air OpeningOptional
Supply Air OpeningMounting
Top RainFlashing
BottomInstallationBracket
Back View
P
L
O
E
R
S1
M
S1
S2
S2
T
N
S1
Q
B
PanelAccess
Cond.
Heat
Heater
(Lockable)Access Panel
Low Voltage
AirInlet
Entrance
Electric
Electrical
Rain Hood4 Pitch
Built In
Disconnect
Entrance
C. Breaker/
High VoltageElectrical
DrainSide View
C H
K
J
I
D
2.13
A
Panel
DoorVent Option
CondenserAir Outlet
Filter Access
VentilationAir
Front View
5.75
F
W
G
D
A
C
K
2.13
I
J
2.63
9.06
P
M
L
O
E
.44 W
5.75
F
G
R
S1
S1
S1
S2
S2
T
H
Panel
Condenser
Return Air Opening
Back ViewMIS-3077
Heater
Drain
AirAir Outlet
Front View
Cond.
Access
Side View
Inlet
InstallationBottom
Panel
Bracket
MountingSide Wall
Electric
Brackets
Heat
FlashingShippingLocation
OptionalElectricalEntrances
High VoltageElectrical
ElectricalEntrance
VentilationAir
Vent OptionDoor
Entrance
(Built In)
Top Rain
Low Voltage
Access Panel(Lockable)
Filter Access
DisconnectC. Breaker/
Built InRain Hood4 Pitch
Supply Air Opening
Note 1:Extreme Duty control panel door is shown and is standard. For optional flush Moderate Duty Control Panel
Cover, order Control Cover option M. See Nomenclature on Page 8.
See
Note 1
See
Note 1
sseccAecivreSrofderiuqeRsecnaraelCwolfriAresnednoCetauqedAdna
SLEDOM EDISTFEL EDISTHGIR
1VR3W "51 "02
1VL3W "02 "51
1VR6W,1VR5W "02 "02
1VL6W,1VL5W "02 "02
otderiuqeRsecnaraelCmuminiMslairetaMelbitsubmoC
SLEDOM TCUDRIAYLPPUS
TEEFEERHTTSRIF TENIBAC
1VL/R3W "4/1 "0
1VL/R5W1VL/R6W
"4/1 "0
NOTE: For side by side installation of two (2) W*RV models there must be 20" between
units. This can be reduced to 15" by using a W*LV model (left side compressor and
controls) for the left unit and W*R (right side compressor and controls) for right unit.
-
8/12/2019 Bard s3426
8/8
Form No. S3426-1213Supersedes S3426-813Page 8 of 8
Bard Manufacturing Company, Inc.
Bryan, Ohio 43506
www.bardhvac.com
Since 1914 . . . Moving ahead, just as planned.
Due to our continuous product improvement policy,
all specifications subject to change without notice.
ynarof"seraps"saderedisnocebyehttahtdednemmocersiti,eroferehT.yllacoldnuofebtonyamdnangisedtcudorpsihtoteuqinuerastrapgniwollofehT
.liatederomrofstsilstrapetelpmocotrefeR.deriuqerebreveecivresdluohselbaliavayletaidemmiebdluowyehtosnoitallatsnilacitircnoissim
lacitirCnoissiMstnenopmoC noitpircseD ledoMtinU
.oNtraPdraB R-1VL/R3W S-1VL/R3W T-1VL/R3W R-1VL/R5W S-1VL/R5W T-1VL/R5W S-1VL/R6W T-1VL/R6W
553-0008 031-VFP-E5K43DPZrosserpmoC X
653-0008 031-5FT-E5K43DPZrosserpmoC X
753-0008 031-DFT-E5K43DPZrosserpmoC X
253-0008 031-VFP-E5K45DPZrosserpmoC X
063-0008 031-5FT-E5K45DPZrosserpmoC X
163-0008 031-DFT-E5K45DPZrosserpmoC X
853-0008 031-5FT-ECK27DPZrosserpmoC X
953-0008 031-DFT-ECK27DPZrosserpmoC X
6700-740-6018S lortnoCdemmargorP/wrotoMresnednoCMCEPH2/1 X X X
0800-740-6018S lortnoCdemmargorP/wrotoMresnednoCMCEPH2/1 X X X X X
5700-250-6018S lortnoCdemmargorP/wrotoMrewolBMCEPH2/1 X X XA9700-710-7018S lortnoCdemmargorP/wrotoMrewolBMCEPH4/3 X X X X X
412-1565 VXTgnilooC X X X
512-1565 VXTgnilooC X X X
312-1565 VXTgnilooC X X
940-0565 evlaVdioneloS X X X X X X X X
2640-4081 sdaeLdeReralFOC#056hctiwSerusserPhgiH X X X X X X X X
6830-4081 sdaeLeulBeralFIC#54OC#23hctiwSerusserPwoL X X X X X X X X
930-8048 tatsomrehTeniLegrahcsiD X X X X X X X X
821-6048 CDV5ISP007-0recudsnarTerusserP X X X X X X X X
840-7048 AV56V42-V802/032remrofsnarT X X X X X
050-7048 AV56V42-V084remrofsnarT X X X
520-1048 A04eloP-2rotcatnoCrosserpmoC X X
720-1048 A03eloP-3rotcatnoCrosserpmoC X X X X X X
880-1028 eludoMlortnoCrosserpmoC X X X X X X X X
621-1028 rotinoMesahP X X X X X X421-1028 draoBlortnoCrewolB X X X X X X X X
140-1038 ylppuSCDV5 X X X X X X X X
321-1028 yaleRetatSdiloS X X X X X X X X
410-1038 rosneSriAroodtuO X X X X X X X X
660-3048 rellortnoCtatsomrehT X X X X X X X X
111KS tiKtratSdraH 1
dellatsnIdleiFlanoitpO X X
Form No.
S3426
December, 2013
Supersedes: S3426-813
1 Vent option X does not have exhaust capability. May require separate field supplied barometric relief in building.
2 Blank-Off Plate recommended whenever maximum requirements against outside air intrusion are needed.
3 Stainless Steel cabinet and coated coils recommended for maximum durability in all harsh environments.
4Moderate Duty Door not recommended for harsh environments where wind and/or very fine dust are prevalent.
5All units equipped with flush Moderate Duty Door can be field retrofitted with the Severe Duty Door.
Order DDD3A-color for W3R, DDD3L-color for W3L, DDD5A-color for W5R or WGR and DDD5L-color for W5L or W6L.
KW
Electric
Heat @Rated
Voltage
MODEL
SERIES
Wall-Mount
OTHER OPTIONS
X - None
S - Hard Start Kit1-Phase Only
ELECTRICAL RATING
R - 230/208-60-1 & 220/200-50-1
S - 230/208-60-3 & 220/200-50-3
T - 460-60-3 & 400-50-3
REVISIONS
VENTILATION OPTIONS
X - Barometric Fresh Air Damper (Std.)1
B - Blank-off Plate2
FILTER OPTIONS
X - One Inch Throwaway (Standard)
W - One Inch Washable
P - Two Inch Pleated (MERV 8)
COLOR OPTIONS
X - Beige (Standard)
1 - White4 - Buckeye Gray
5 - Desert Brown6 - Dark Bronze
A - Aluminum
S - Stainless Steel3
COIL OPTIONSX - Standard Copper Tube/Aluminum Fin
1 - Phenolic Coated Indoor Coil2 - Phenolic Coated Outdoor Coil
3 - Phenolic Coated Indoor & Outdoor Coil
CONTROL COVER DOOR
X - Extreme Duty Door (Standard)
M - Moderate Duty Door45
NOMINAL TONS
3 - 3 Ton (37,000 on 60Hz; 33,700 on 50Hz)
5 - 5 Ton (54,000 on 60Hz; 49,200 on 50Hz)
6 - 6 Ton (68,000 on 60Hz; 61,900 on 50Hz)
COMPRESSOR &
CONTROLS LOCATIONR - Right Side
L - Left Side
SYSTEM DESIGN
Variable Capacity
(Digital Compressor) ECU
W 3 R V 1 R 10 X X S X 3 X
Enviro nmental Control Unit (ECU) Wall-Mount Mod el Nomenclature
SPECIAL
FEATURES
1 Factory standard PTCR motor starting device must be removed if optional SK111 hard start kit is field installed.