au2dcd21

Upload: costel-burada

Post on 05-Apr-2018

218 views

Category:

Documents


0 download

TRANSCRIPT

  • 8/2/2019 AU2DCD21

    1/1

    AUDI 80, 1.6 CAT1992 to 1995

    Notes and Illustrations

    1595 cm3

    Engine and cooling systemType

    Capacity (cm3

    ) / number of cylindersCompression ratio / pressure bar

    Oil pressure bar

    Oil temperature C

    Valve clearance - inlet mm

    Valve clearance - exhaust mm

    Firing order

    No 1 cylinder position

    Thermostat opening temperature C

    Radiator cap pressure bar

    Fuel systemIdle speed - manual [auto] rpm

    Fast idle speed - manual [auto] rpm

    CO @ idle speed [3000 rpm] - see page VI %

    HC @ idle speed [3000 rpm] - see page VI ppm

    CO2 @ idle speed [3000 rpm] - see page VI %

    O2 @ idle speed [3000 rpm] - see page VI %

    Carburettor / fuel injection

    Type / refMain jet / needle

    Injection pressure bar

    Pump pressure bar

    Octane rating RON

    Ignition systemType

    Ignition coil

    Primary resistance ohmsBallast resistor ohms

    Voltage - Tmnl 15(+) to earth V

    Distributor

    Points gap (air gap) mm

    Dwell angle (%)

    Condenser capacity F

    Rotation

    Ignition timing - basic [static Crankshaft @ rpm

    V = Vacuum NV = No VacuumTotal ignition advance Crankshaft @ rpm

    Crankshaft @ rpm

    Crankshaft @ rpm

    Centrifugal check. Crankshaft @ rpm

    Crankshaft @ rpm

    Crankshaft @ rpm

    Vacuum range check mbar

    Maximum vacuum advance Crankshaft

    Spark plugs

    Type

    Electrode gap mm

    Electrical systemBattery V / CC / RC

    Alternator voltage / full load current / engine rpm

    Starter motor current / voltage - cranking A / V

    Starter motor current / voltage - locked A / V

    Running gearBrakes -

    Front (min. friction material thickness) mm

    Rear (min. friction material thickness) mm

    Tyres

    Saloon Size

    Estate / Van Size

    Pressure - front / rear - Saloon bar

    Pressure - front / rear - Estate / Van bar

    Front suspension / wheel alignmentToe-in (+) / Toe-out () mm []

    Camber

    Castor

    King pin inclination

    Rear suspension / wheel alignment

    Toe-in (+) / Toe-out () mm []

    Camber

    Torque wrench settingsCylinder head - stage 1 Nm

    Cylinder head - stage 2 Nm

    Cylinder head - stage 3 Nm

    Cylinder head - stage 4 Nm

    Big-end bearings Nm

    Main bearings Nm

    Clutch cover Nm

    Flywheel [driveplate] Nm

    Front hubs Nm

    Rear hubs Nm

    Wheel nuts / bolts Nm

    Spark plugs Nm

    CapacitiesEngine oil & filter litres

    Gearbox - 4-speed [5-speed] litres

    Automatic transmission - refill litres

    Final drive litres

    Cooling system litresFuel tank litres

    ABM (51kW) SOHC 8V

    1595 / 49.0 /7.0

    [2.0]

    80

    0: Hyd.

    0: Hyd.

    1-3-4-2

    TBE

    85

    1.2 to 1.5

    800 to 1000 N/A

    _

    0.5 N/A

    200

    _

    _

    Bosch

    Mono-Motronic_

    0.8 to 1.2

    _

    91[U]

    Motronic

    N70

    0.5 to 1.5_

    _

    Bosch

    _

    _

    _

    Clockwise

    62 BTDC @ 800 to 1000 N/A

    __

    _

    _

    Computer control

    _

    _

    Computer control

    _

    NGK

    BUR5ET

    0.90 to 1.10

    12 / 36, 45Ah

    14.0 / _ / 2000

    _

    _

    2.0

    2.5

    195/65x15: 205/60x15

    _

    2.0 / 2.0

    _

    [+1010]

    -4530

    +11530

    _

    [+2020]

    -120

    40 N

    60

    + 90

    + 90

    30 + 90

    65

    25

    60 + 90N

    265 LkC

    WSM110

    25

    3.0

    2.4

    _

    WT

    7.068

    Click on one of thebuttons above to view

    data for this car. Toreturn to this screen and

    make another choice,click anywhere on the

    data screen.

    AutomotiveTechnical

    DATA

    BOOK80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    80, 1.6 CAT 1992 to 1995

    AUDP3001633

    Engine &Cooling

    Fuel Ignition ElectricalRunning

    gearTorquesettings

    CapacitiesNotes &

    Illustrations

    MENU HELP

    http://../haymenu.pdfhttp://../hayhelp.pdfhttp://../hayhelp.pdfhttp://../haymenu.pdf