ata specification breakdown manual

EMBRAER S.A. – P.O. BOX 8050

12227-901 SÃO JOSÉ DOS CAMPOS – SP

BRAZIL

PHONE:++ 55 12 3927-7517

FAX: ++ 55 12 3927-7546

http://www.embraer.com

e-mail: [email protected]

ATA SPECIFICATION

BREAKDOWN

MANUAL

ASBM/1347

EMBRAER S.A. – P.O. BOX 8050

12227-901 SÃO JOSÉ DOS CAMPOS – SP

BRAZIL

PHONE:++ 55 12 3927-7517

FAX: ++ 55 12 3927-7546

http://www.embraer.com

e-mail: [email protected]

ATA SPECIFICATION

BREAKDOWN

MANUAL

ASBM/1347AUGUST 31/2000

REVISION 23 – September 28/2010

CONTENTS

Page 1/2

September 28/10

TABLE OF CONTENTS

Page

INTRODUCTION ............................................................................................................ 1

1. Scope ................................................................................................................... 1

2. General ................................................................................................................ 1

3. Contents and Arrangement .................................................................................. 1

4. Numbering ............................................................................................................ 2

5. Revisions .............................................................................................................. 2

6. List of the Acronyms and Abbreviations used in the

Ata Breakdown Manual ................................................................................................... 3

7. Technical Feedback ......................................................................................................... 3

ATA SPECIFICATION BREAKDOWN MANUAL ........................................................... 4

September 28/10

INTRODUCTION

1. SCOPE

A. This manual forms a guide and is intended to standardize the production of all EMBRAER 170/175/190/195 and LINEAGE 1000 Technical Publications, based on ATA Specification 2200.

2. GENERAL

A. The purpose of this manual is to provide an easy and standardized reference to the Chapter / Section / Subject identification numbers used throughout the EMBRAER 170/175/190/195 and LINEAGE 1000 Technical Publications.

B. This manual must be used to locate the identification reference numbers for systems or components (Line Replaceable Units and Line Replaceable Modules), since this manual presents six-digit breakdown references.

C. Although some manuals use four-digit references with their own additional sequence numbers (e.g. Wiring Manual (WM), System Schematic Manual (SSM), Corrosion Prevention Manual (CPM), etc... ), this manual must be followed when further breakdown is required.

3. CONTENTS AND ARRANGEMENT

A. The ATA SPECIFICATION BREAKDOWN MANUAL contains an introduction and is organized by chapters.

B. The chapters presented in this manual are organized into four groups, namely: aircraft general group, airframe systems group, structure group, and power plant group. The chapters pertaining to each group are indicated below:

Aircraft General Chapters 05 thru 12.Airframe Systems Chapters 20 thru 38, 44 thru 46, 49, and 50.Structure Chapters 51 thru 57.Power Plant Chapters 70 thru 80.

NOTE: Chapter 91 defined in this manual is applicable only to the Wiring Manual.

C. This manual is made up of 159 pages.

4. NUMBERING

A. The Numbering System:

(1) It uses a three-element number, the elements being separated by dashes. Each element contains two digits, corresponding to Chapter / System; Section / Subsystem / Sub-subsystem; and Subject / Unit, as follows:

(2) The first pair of digits is assigned by ATA Specification 2200, and designates the Chapter /

System. For example:

21-XX-XX - identifies the air conditioning system.

(3) The second pair of digits designates the Section / Subsystem / Sub-subsystem, only the first digit being assigned by ATA Specification 2200. When the second pair is -00-, it indicates that the matter is treated in general and applies to the Chapter / System as a whole. The second digit of the pair is used when it is convenient to break down the Section / Subsystem and it is assigned by Embraer. For example:

21-20-XX - identifies the air conditioning distribution subsystem.

21-24-XX - identifies the air conditioning individual distribution subsystem.

(4) The third pair of digits is assigned by Embraer and designates a component or functions of chapters and sections covered by the previous elements. When the third pair is -00-, it indicates that the matter is dealt with in general and applies to the section as a whole, without treating of specific subjects concerning components or functions. For example:

21-24-03 - identifies the blower of the air conditioning individual distribution subsystem.

5. REVISIONS

A. This manual will be kept up-to-date by a semiannual revision service (unless there is not enough revision material).

B. The manual will be completely reissued each time. This means there will be no Highlights and no List of Effective Pages (LEP) in the manual. All the pages in the manual will carry the reissue data.

XX - XX - XXSUBJECT / UNIT

SECTION / SUBSYSTEM/ SUB-SUBSYSTEM

CHAPTER / SYSTEM

Page 2

September 28/10

6. LIST OF THE ACRONYMS AND ABBREVIATIONS USED IN THE ATA BREAKDOWN MANUAL

ATA - Air Transport AssociationCPM - Corrosion Prevention ManualLEP - List of Effective PagesSSM - System Schematic ManualWM - Wiring Manual

7. TECHNICAL FEEDBACK

A. This is a preliminary edition based on ATA Specification 2200. Future revisions will complement the information contained in this manual and will correct possible mistakes in it.

B. Comments about, or suggested changes to, this manual should be sent to:

Embraer S. A.Attention: Technical Publication DepartmentAv. Brigadeiro Faria Lima, 2.170CEP. : 12.227-901São José dos Campos - São Paulo - BrasilP.O Box 8050PHONE:++ 55 12 3927-7517FAX: (55) (12) 3927-7546http://www.embraer.come-mail: [email protected]

Page 3

September 28/10

54

ATA BREAKDOWN - EMBRAER 170/175/190/195 AND LINEAGE 1000

SYSTEM /CHAPTER

SUBSYSTEM ANDSUB-SUBSYSTEM /

SECTION

UNIT /SUBJECT

TITLE

05- TIME LIMITS/MAINTENANCE CHECKS

00 00 TIME LIMITS/MAINTENANCE CHECKS

10- 00 TIME LIMITS

20- 00 SCHEDULED MAINTENANCE CHECKS

21- 00 FUSELAGE AND TAIL CONE

22- 00 STABILIZERS

23- 00 ENGINE AND PYLON

24- 00 WINGS

25- 00 DOORS

26- 00 LANDING GEARS



50- 00 UNSCHEDULED MAINTENANCE CHECKS

50- 01 LIGHTNING STRIKE

50- 02 BIRD OR HAIL STRIKE

50- 03 HARD LANDING AND OFF-TEMPERATURE ENVELOPE

50- 04 HIGH DRAG/SIDE LOAD LANDING CONDITION

50- 05 HIGH LOAD FACTOR

50- 06 MAXIMUM OPERATING SPEED ENVELOPE

50- 07 MAXIMUM FLAP EXTENDED SPEED

50- 08 CABIN DEPRESSURIZATION

50- 09 TOILET OVERSERVICING

50- 10 VOLCANIC ASH OR SANDSTORM

50- 11 ICE OR SNOW CONDITION

50- 12 HIGH ENERGY STOP CONDITION

50- 13 LANDING GEAR DOWN OVERSPEED

50- 14 LANDING GEAR FREE-FALL CONDITION

50- 15 LANDING GEAR TIRE TREAD FAILURE OR TIRE BURST WITH LANDING GEAR FULLY RETRACTED

Page 4

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

05- TIME LIMITS/MAINTENANCE CHECKS

50- 16 OVERHEATED WHEELS

50- 17 ENGINE FIRE WARNING OR OVERHEAT INDI-CATION

50- 18 APU FIRE WARNING OR OVERHEAT INDICA-TION

50- 19 APU VOLCANIC ASH CONDITION

50- 20 HIGH THRUST FAILURE

50- 21 FUEL OVERFLOW

50- 22 WHEEL OVERSPEED

50- 23 ENGINE-DRIVEN PUMP

50- 24 LANDING GEAR SIGNIFICANT VIBRATION

50- 25 BRAKE USE DURING TOWING OPERATION

50- 26 CABIN DOOR PRESSED BY JET WAY

50- 27 OVERWEIGHT LANDING

50- 28 SEVERE OR EXTREME TURBULENCE, OR BUFFETING CONDITION

50- 29 NACELLE SUBJECTED TO ABNORMAL LOAD-ING CONDITION

50- 30 BATTERY DISCHARGED

50- 31 WINDSTORM ON GROUND - INSPECTION/CHECK

50- 32 OVERSTEERING

50- 33 ENGINE AIR INLET LIPSKIN MEASUREMENT

Page 5

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

06- DIMENSIONS AND AREAS

00 00 DIMENSIONS AND AREAS

00- 01 REFERENCE PLANES AND LINES

10- 00 DIMENSIONS AND AREAS

20- 00 AIRCRAFT STATION DIAGRAM

21- 00 BODY STATION DIAGRAM

22- 00 VERTICAL-TAIL STATION DIAGRAM

23- 00 HORIZONTAL-TAIL STATION DIAGRAM

24- 00 WING AND WINGLET STATION DIAGRAM

25- 00 POWERPLANT STATION DIAGRAM

26- 00 PYLON STATION DIAGRAM

30- 00 AIRCRAFT ZONING

40- 00 AIRCRAFT ACCESS DOORS AND PANELS

41- 00 FUSELAGE ACCESS DOORS AND PANELS

42- 00 HORIZONTAL AND VERTICAL TAILS ACCESS DOORS AND PANELS

43- 00 POWERPLANT AND PYLON ACCESS DOORS AND PANELS

44- 00 WING ACCESS DOORS AND PANELS

45- 00 DOORS ACCESS PANELS

46- 00 FLOOR ACCESS DOORS AND PANELS

47- 00 COCKPIT ACCESS PANELS

48- 00 PASSENGER-CABIN ACCESS PANELS

49- 00 CARGO-COMPARTMENT ACCESS DOORS AND PANELS

Page 6

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

07- LIFTING & SHORING

00 00 LIFTING & SHORING

10- 00 JACKING

10- 01 AIRCRAFT JACKING

Page 7

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

08- LEVELING & WEIGHING

00 00 LEVELING & WEIGHING

10- 00 WEIGHING AND BALANCING

10- 01 AIRCRAFT WEIGHING

20- 00 LEVELING

20- 01 AIRCRAFT LEVELING

Page 8

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

09- TOWING & TAXIING

00 00 TOWING & TAXIING

10- 00 TOWING

10- 01 TOWING WITH TOWBAR

10- 02 TOWBARLESS TOWING

10- 03 TOWING WITH ENGINE(S) REMOVED

10- 05 TOWING WITH FLAT TIRE(S)

20- 00 TAXIING

20- 01 AIRCRAFT TAXIING

Page 9

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

10-PARKING, MOORING, STORAGE & RETURN TO SERVICE

00 00 PARKING, MOORING, STORAGE & RETURN TO SERVICE

10- 00 PARKING/STORAGE

10- 01 AIRCRAFT NORMAL PARKING

10- 03 AIRCRAFT PROLONGED PARKING

10- 05 AIRCRAFT PARKING IN BAD WEATHER CONDI-TIONS

20- 00 MOORING

20- 01 AIRCRAFT MOORING

30- 00 RETURN TO SERVICE

30- 01 AIRCRAFT RETURN TO SERVICE

30- 03 AIRCRAFT RETURN TO SERVICE (PROLONGED PARKING)

Page 10

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

11- PLACARD AND MARKINGS

00 00 PLACARDS AND MARKINGS

10- 00 EXTERIOR COLOR SCHEMES AND MARKINGS

10- 01 FLAG DECAL INSTALLATION

10- 02 PERSONAL DECAL INSTALLATION

20- 00 EXTERIOR PLACARDS AND MARKINGS

21- 00 FUSELAGE

21- 01 FORWARD FUSELAGE

21- 03 CENTER FUSELAGE

21- 05 REAR FUSELAGE AND EMPENAGES

23- 00 LANDING GEAR

23 01 NOSE LANDING GEAR/DOORS

23- 03 MAIN LANDING GEAR/DOORS

25- 00 WING

25- 01 WING FUEL SYSTEM

25- 03 WING-TO-FUSELAGE FAIRING

25- 05 WING JACK POINT

25- 07 WING SAFETY POINTS

26- 00 POWERPLANT AND PYLON

26- 01 ENGINE OIL SERVICING

26- 03 ENGINE HOISTING POINT

26- 05 ENGINE FAN COWL

26- 07 ENGINE THRUST REVERSER

26- 09 ENGINE INLET

26- 11 PYLON

30- 00 INTERIOR PLACARDS

Page 11

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


31- 00 COCKPIT PLACARDS AND MARKINGS

31- 01 MAIN PANEL AND CONTROL PEDESTAL

31- 03 LH AND RH COCKPIT CONSOLE

31- 05 COCKPIT AFT CONSOLE

31- 07 COCKPIT/BULKHEAD

31- 09 CIRCUIT BREAKER PANEL

31- 11 CONTROL YOKES

31- 13 EMERGENCY-EXTENSION LEVER COMPART-MENT

31- 15 ELECTRONIC FLIGHT BAG

32- 00 PASSENGER CABIN PLACARDS AND MARK-INGS

32- 01 PASSENGER DOORS

32- 03 SERVICE DOORS

32- 05 EMERGENCY HATCH

32- 07 PASSENGER SEATS

32- 09 SEAT ROWS

32- 11 OVERHEAD BINS

32- 13 PARTITIONS

32- 15 CLOSETS

32- 17 EMERGENCY EQUIPMENT STOWAGE

32- 19 ADDITIONAL COMPARTMENTS

32- 21 FORWARD RH G1 GALLEY


32- 25 TROLLEY STOWAGE

32- 27 FORWARD LH GALLEY

32- 29 AFT RH GALLEY

Page 12

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


32- 31 AFT GALLEY

32- 35 FORWARD LAVATORIES

32- 36 MIDLLE LAVATORIES

32- 37 AFT LAVATORIES

32- 38 AFT BAGGAGE COMPARTMENT

33- 00 CARGO COMPARTMENTS PLACARDS AND MARKINGS

33- 01 FORWARD AND AFT CARGO COMPARTMENT

Page 13

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

12- SERVICING

00 00 SERVICING

10- 00 REPLENISHING

11- 00 FUEL SERVICING

11- 01 FUEL TANK FUELING/DEFUELING

11- 03 FUEL TANK GRAVITY REFUELING

11- 05 FUEL TANK DRAINING

11- 07 FUEL MAGNETIC LEVEL

12- 00 HYDRAULIC SERVICING

12- 01 HYDRAULIC RESERVOIR

12- 05 EMERGENCY/PARKING BRAKE ACCUMULA-TOR

12- 07 MAIN-LANDING-GEAR SHOCK STRUT

12- 08 MAIN-LANDING-GEAR SHIMMY DAMPER

12- 09 NOSE-LANDING-GEAR SHOCK STRUT

12- 10 NOSE AND MAIN LANDING GEARS CLEANING

12- 11 HYDRAULIC SYSTEM ECOLOGY BOTTLE

13- 00 OIL SERVICING

13- 01 ENGINE OIL

13- 05 APU OIL

13- 09 INTEGRATED DRIVE GENERATOR OIL

13- 11 AIR TURBINE STARTER OIL

14- 00 WATER/ WASTE SERVICING

14- 01 POTABLE WATER TANK

14- 05 WASTE TANK

15- 00 GASEOUS SERVICING

15- 01 MAIN-LANDING-GEAR TIRE PRESSURE

Page 14

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

12- SERVICING

15- 03 NOSE-LANDING-GEAR TIRE PRESSURE

15- 05 HYDRAULIC SYSTEM ACCUMULATOR

15- 06 COCKPIT OXYGEN CYLINDER

15- 07 PASSENGER-CABIN OXYGEN CYLINDER

20- 00 SCHEDULED SERVICING

21- 00 LUBRICATING SERVICING

21- 01 HORIZONTAL STABILIZER ACTUATOR

21- 02 CONTROL YOKE CHAIN

21- 03 CONTROL-YOKE DISCONNECT SYSTEM

21- 04 CONTROL-COLUMN DISCONNECT SYSTEM

21- 05 ROLL/PITCH TRIM SWITCHES

21- 07 FLAP ACTUATOR

21- 08 FLAP TRACK MECHANISM NEEDLE ROLLERS

21- 09 SLAT PINION, RACK, MAIN ROLLERS, SIDE ROLLERS AND TRACK

21- 10 FLAP TORQUE TUBES

21- 11 SLAT TORQUE TUBES

21- 13 LANDING GEAR MECHANICAL SYSTEM

21- 15 RUDDER PEDAL DAMPER

21- 16 CONTROL COLUMN DAMPERS

21- 18 BEARINGS OF THE AILERON POWER-CON-TROL-UNIT TOGGLE LINKS

21- 19 BEARINGS OF THE RUDDER POWER-CON-TROL-UNIT TOGGLE LINKS

21- 20 BEARINGS OF THE ELEVATOR POWER-CON-TROL-UNIT TOGGLE LINKS

22- 00 CLEANING SERVICING

Page 15

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

12- SERVICING

22- 01 AIRCRAFT CLEANING

24- 00 DISINFECT SERVICING

24- 01 AIRCRAFT DISINSECT/DISINFECT

25- 00 AIRFRAME SERVICING

25- 01 AIRFRAME DRAINS

30- 00 UNSCHEDULED SERVICING

31- 00 COLD WEATHER

31- 01 COLD WEATHER MAINTENANCE

Page 16

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

20- STANDARD MAINTENANCE PRACTICES

00 00 STANDARD PRACTICES-AIRFRAME

01- 02 IDENTIFICATION OF WIRES AND CABLES - DESCRIPTION

01- 04 ELECTRICAL AND ELECTRONIC SYMBOL - DESCRIPTION

10- 00 GENERAL MAINTENANCE PRACTICES

10- 01 BOLT TORQUE DATA

10- 02 TYPICAL SAFETYING METHODS

10- 03 TUBING

10- 04 TUBING (TEMPORARY)

10- 05 JAMMED SCREWS

10- 07 TORQ-SET SCREWS

10- 08 BEARINGS AND BUSHINGS

10- 09 PLACARDS AND MARKINGS

10- 10 ANTENNA SEALING

10- 12 V-BAND CLAMP (INSTALLATION)

10- 13 CLAMP SHELL (TYPICAL)

10- 14 GREASE FITTING

13- 00 ELECTRICAL COMPONENTS MAINTENANCE PRACTICES

13- 01 DEGAUSSING

13- 09 MOUNTING TRAYS (TYPICAL)

13- 10 ANTENNA COVERS (TYPICAL)

13- 21 ELECTRICAL BONDING

20- 00 FLIGHT CONTROLS MAINTENANCE PRAC-TICES

21- 10 TERMINAL CRIMPERS - MAINTENANCE PRAC-TICES

21- 20 CONTACT INSERTION AND REMOVAL TOOLS - MAINTENANCE PRACTICES

30- 00 CONSUMABLES

Page 17

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


30- 10 CONNECTOR-WIRE END FITTING

35- 00 ELECTRICAL COMPONENTS - MAINTENANCE PRACTICES

35- 03 JUNCTION MODULES - MAINTENANCE PRAC-TICES

38- 00 COMPONENT DATA

38- 01 COAXIAL CONNECTORS-MAINTENANCE PRACTICES

38- 02 TRIAXIAL CONNECTORS-MAINTENANCE PRACTICES

38- 03 QUADRAX CONTACTS - MAINTENANCE PRAC-TICES

39- 00 MODULAR PLUG CONNECTOR - MAINTE-NANCE PRACTICES

39- 10 CONNECTOR-WIRE END FITTING - MAINTE-NANCE PRACTICES

40- 00 ELECTROSTATIC DISCHARGE (ESD)

40- 02 STATIC GROUNDING

41- 00 ASSEMBLY PRACTICES - DESCRIPTION

41- 10 WIRE TERMINATION CODE - DESCRIPTION

41- 20 SPLICES - MAINTENANCE PRACTICES

41- 30 WIRE STRIPPING - MAINTENANCE PRACTICES

41- 40 SPARE WIRE - MAINTENANCE PRACTICES

43- 10 SOLDERING PROCEDURES - MAINTENANCE PRACTICES

45- 30 HARNESS TIES - MAINTENANCE PRACTICES

50- 00 INSTALLATION PRACTICES - DESCRIPTION

51- 00 CLAMPING - MAINTENANCE PRACTICES

52- 00 ELECTRICAL CONNECTOR MATING - MAINTE-NANCE PRACTICES

60- 00 MAINTENANCE PRACTICES - DESCRIPTION

Page 18

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


61- 10 HARNESS CLEANING - MAINTENANCE PRAC-TICES

61- 20 ELECTRICAL CONNECTORS CLEANING - MAIN-TENANCE PRACTICES

62- 00 REQUIREMENTS FOR EWIS COMPONENTS INSPECTIONS/CHECKS - MAINTENANCE PRACTICES

67- 00 PREVENTIVE MAINTENANCE

Page 19

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

21- AIR CONDITIONING

00 00 AIR CONDITIONING

00- 01 AMS CONTROLLER PROCESSOR MODULES

00- 02 AMS CONTROLLER MOTOR DRIVE MODULES

00- 03 AMS CONTROLLER I/O MODULES

20- 00 DISTRIBUTION

20- 01 MAIN DISTRIBUTION DUCTS

20- 02 CONDITIONED-AIR CHECK VALVES

20- 03 AIR MIX H-DUCT

21- 00 COCKPIT DISTRIBUTION

21- 01 COCKPIT DISTRIBUTION DUCTS

21- 02 COCKPIT AIR OUTLETS

21- 04 PILOTS FEET OUTLET SHUTOFF VALVES

21- 05 PILOTS FEET OUTLET SHUTOFF-VALVES CABLE

22- 00 PASSENGER-CABIN DISTRIBUTION

22- 01 PASSENGER-CABIN DISTRIBUTION DUCTS

22- 02 PASSENGER-CABIN OUTLETS

22- 03 PASSENGER-CABIN PLENUMS

23- 00 GASPER

23- 01 GASPER SHUTOFF VALVE

23- 02 GASPER CHECK VALVE

23- 03 GASPER DUCTS

23- 04 GASPER AIR OUTLET

24- 00 RECIRCULATION

24- 01 RECIRCULATION FANS

24- 02 RECIRCULATION AIR FILTERS

24- 03 RECIRCULATION DUCTS

24- 05 RECIRCULATION FANS RELAYS

24- 06 AVIONICS COMPARTMENT RELAYS

25- 00 RAM AIR VENTILATION

25- 01 EMERGENCY RAM AIR VALVE

25- 02 EMERGENCY RAM AIR VALVE ACTUATOR

25- 03 EMERGENCY RAM AIR CHECK VALVE

25- 04 NACA AIR INLETS

25- 05 RAM AIR DUCTS

25- 08 AFT-AVIONICS-COMPARTMENT-RACK VENTILA-TION FAN

Page 20

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


26- 00 AVIONICS-COMPARTMENT VENTILATION

26- 01 FORWARD-AVIONICS COMPARTMENT FANS

26- 02 FORWARD-AVIONICS-COMPARTMENT FLOW-SENSOR

26- 03 FORWARD-AVIONICS-COMPARTMENT VENTILA-TION DUCTS

26- 04 MIDDLE-AVIONICS-COMPARTMENT FANS

26- 05 MIDDLE-AVIONICS-COMPARTMENT FLOW-SEN-SOR

26- 06 MIDDLE-AVIONICS-COMPARTMENT VENTILA-TION DUCTS

26- 07 AFT-AVIONICS-COMPARTMENT VENTILATION DUCTS

26- 08 AFT-AVIONICS-COMPARTMENT-RACK VENTILA-TION FAN

26- 09 AFT-AVIONICS-COMPARTMENT-RACK VENT SHUTOFF-VALVE

26- 10 AFT-AVIONICS-COMPARTMENT-RACK AIRFLOW SWITCH

26- 11 MISSION/ENTERTAINMENT RACK VENTILATION SYSTEM DUCTS

26- 12 MISSION/ENTERTAINMENT RACK VENTILATION SYSTEM FAN

26- 13 MISSION/ENTERTAINMENT RACK SMOKE VENT VALVE

26- 14 MISSION/ENTERTAINMENT RACK VENTILATION SYSTEM AIRFLOW SWITCH

27- 00 CARGO-COMPARTMENT VENTILATION SYSTEM

27- 01 FORWARD-CARGO-COMPARTMENT FAN

27- 03 FORWARD-CARGO-COMPARTMENT CHECK VALVE

27- 04 FORWARD-CARGO-COMPARTMENT SHUTOFF-VALVE

27- 05 FORWARD-CARGO-COMPARTMENT VENTILA-TION DUCTS

27- 07 FORWARD-CARGO-COMPARTMENT SHUTOFF VALVE SERVO LINE

27- 08 AFT-BAGGAGE-COMPARTMENT VENTILATION DUCTS

Page 21

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


27- 09 AFT-BAGGAGE-COMPARTMENT INFLATION SHUTOFF-VALVE

27- 10 AFT-BAGGAGE-COMPARTMENT EXHAUST SHUTOFF-VALVE

28- 00 MISCELLANEOUS-EQUIPMENT VENTILATION SYSTEM

28- 01 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK VENTILATION-DUCTS

28- 02 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK VENTILATION-FAN

28- 03 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK GROUND-SHUTOFF-VALVE

28- 04 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK VENT-SHUTOFF-VALVE

28- 05 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK AIRFLOW-SWITCH

28- 06 AFT-CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT-RACK VENTILATION/SMOKE-MONI-TORING-PANEL

28- 07 CHILLER VENTILATION-SYSTEM DUCTS

28- 08 CHILLER VENTILATION-SYSTEM FAN

28- 09 CHILLER VENTILATION-SYSTEM GROUND-SHUTOFF-VALVE

28- 10 CHILLER VENTILATION-SYSTEM VENT-SHUT-OFF-VALVE

28- 11 CHILLER VENTILATION-SYSTEM PRESSURE-SWITCH

28- 12 CHILLER VENTILATION-SYSTEM CONTROLLER

28- 13 CHILLER VENTILATION-SYSTEM CIRCUIT-BREAKER AND RELAY BOX

28- 15 ELECTRONIC EQUIPMENT RACK (ENTERTAIN-MENT) FAN

28- 16 ELECTRONIC EQUIPMENT RACK (ENTERTAIN-MENT) AIR FLOW SENSOR

29- 00 LOW PRESSURE GROUND SUPPLY

29- 01 LOW-PRESSURE GROUND-CONNECTION NIP-PLE

29- 02 LOW-PRESSURE GROUND-CONNECTION CHECK-VALVE

29- 03 LOW-PRESSURE GROUND-CONNECTION DUCT

Page 22

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


30- 00 PRESSURIZATION CONTROL

30- 01 PRESSURIZATION CONTROL PANEL

31- 00 PRESSURIZATION CONTROL/INDICATION

31- 01 CABIN PRESSURE CONTROL SYSTEM (CPCS) CONTROLLER

31- 02 CPCS OUTFLOW VALVE

31- 03 CPCS OUTFLOW VALVE ACTUATOR

31- 07 CABIN RATE OF CLIMB INDICATION ON EICAS

31- 09 CABIN DIFFERENTIAL PRESSURE INDICATION ON EICAS

31- 11 CABIN ALTITUDE INDICATION ON EICAS

31- 13 LANDING FIELD ELEVATION INDICATION ON EICAS

32- 00 CABIN PRESSURE RELIEF

32- 01 POSITIVE-PRESSURE RELIEF VALVE (SAFETY VALVE)

32- 02 STATIC PORT

32- 03 STATIC PORT LINE

32- 04 NEGATIVE-PRESSURE RELIEF VALVE (NR VALVE)

33- 00 CARGO-COMPARTMENT PRESSURE EQUALIZA-TION

33- 01 FORWARD-CARGO-COMPARTMENT PRES-SURE-EQUALIZATION VALVE

33- 02 AFT-CARGO-COMPARTMENT PRESSURE-EQUALIZATION VALVE

40- 00 HEATING

41- 00 FLOOR-PANEL HEATING SYSTEM

41- 01 HEATED-FLOOR-PANEL CONTROL MODULE

41- 02 HEATED FLOOR PANEL

50- 00 COOLING

51- 00 COOLING PACK

51- 01 PACK FLOW-CONTROL VALVES

51- 02 FLOW SENSING VENTURIS

51- 03 VENTURI DP SENSORS

51- 04 DUAL HEAT EXCHANGERS

51- 05 AIR CYCLE MACHINES (ACMS)

51- 06 CONDENSER/REHEATERS

Page 23

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


51- 07 WATER COLLECTORS

51- 08 WATER SPRAY NOZZLES

51- 09 FAN BYPASS CHECK VALVE

51- 10 PACK BYPASS-VALVES

51- 11 LOW-LIMIT BYPASS-VALVES

51- 12 PRIMARY HEAT-EXCHANGER OUTLET TEMPER-ATURE-SENSORS

51- 13 COMPRESSOR OUTLET TEMPERATURE-SEN-SORS

51- 14 CONDENSER INLET TEMPERATURE-SENSORS

51- 17 PACK INLET TEMPERATURE-SENSORS

51- 18 PACK OUTLET TEMPERATURE-SENSORS

51- 19 PACK INLET/BYPASS DUCTS

51- 20 ADD HEAT VALVES

51- 21 PACK OUTLET DUCTS

51- 22 ACM VIBRATION ISOLATORS

60- 00 TEMPERATURE CONTROL

61- 00 COCKPIT-ZONE TEMPERATURE CONTROL

61- 01 COCKPIT-ZONE TEMPERATURE SENSOR

61- 02 COCKPIT-DUCT TEMPERATURE SENSOR

62- 00 PASSENGER-CABIN-ZONE TEMPERATURE CONTROL

62- 01 PASSENGER-CABIN-ZONE TEMPERATURE SEN-SOR

62- 02 PASSENGER-CABIN-DUCT TEMPERATURE SEN-SOR

62- 03 TRIM-AIR-SYSTEM LEAK DETECTORS

62- 05 TRIM AIR MODULATING-VALVES

62- 06 TRIM MUFFLERS

62- 07 TRIM AIR EJECTORS

62- 09 TRIM AIR DUCTS

62- 10 TRIM AIR MODULATING-VALVES SERVO-LINE

Page 24

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

22- AUTO FLIGHT CONTROL SYSTEM

00 00 AUTO FLIGHT

10- 00 AUTOPILOT

11- 00 FLIGHT GUIDANCE AND CONTROL SYSTEM (FGCS)

11- 01 GUIDANCE PANEL

11- 02 AP/TRIM DISC PUSHBUTTON

11- 03 AP/FD TCS PUSHBUTTON

11- 04 AUTOPILOT AILERON SERVO

11- 05 AUTOPILOT ELEVATOR SERVO

11- 06 AUTOPILOT RUDDER SERVO

11- 07 AUTOPILOT AILERON CABLE

11- 08 AUTOPILOT ELEVATOR CABLE

11- 09 AUTOPILOT RUDDER CABLE

30- 00 AUTO THROTTLE

31- 00 AUTO THROTTLE FUNCTION

Page 25

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

23- COMMUNICATIONS

00 00 COMMUNICATIONS

01- 00 COMMUNICATION ANTENNAS

10- 00 SPEECH COMMUNICATIONS

11- 00 HF COMMUNICATION SYSTEM

11- 01 HF TRANSCEIVER

11- 02 HF ANTENNA

11- 03 HF ANTENNA COUPLER

11- 04 HF POWER AMPLIFIER

11- 05 HF COUPLER BOOT

11- 06 HF1/HF2 SELECTION SWITCH

11- 07 HF1/HF2 SELECTION RELAY

11- 08 HF REMOTE CONTROL UNIT

11- 09 RADIOS INDICATION PANEL

12- 00 VHF COMMUNICATION SYSTEM

12- 01 VHF COMMUNICATION MODULE

12- 02 VHF ANTENNA

14- 00 V/UHF COMMUNICATION SYSTEM

14- 01 V/UHF REMOTE CONTROL UNIT

14- 02 V/UHF TRANSCEIVER

14- 03 V/UHF ANTENNA

14- 04 V/UHF LOW PASS FILTER

15- 00 SATCOM SYSTEM

15- 01 SATELLITE DATA UNIT (SDU)

15- 02 HIGH POWER AMPLIFIER (HPA)

15- 03 DIPLEXER / LOW NOISE AMPLIFIER

15- 04 INTERMEDIATE GAIN ANTENNA (IGA)

15- 05 IRIDIUM RING INHIBIT SWITCH

15- 06 IRIDIUM RING INHIBIT INSCRIPTION FACE PLATE

Page 26

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

23- COMMUNICATIONS

15- 07 IRIDIUM DUAL-ELEMENT ANTENNA

15- 08 SATELLITE TRANSCEIVER

15- 09 COCKPIT/CALL/AVOD PANEL

15- 10 CORDED TELEPHONE

15- 11 IRIDIUM BAND-PASS FILTER

15- 12 CORDLESS TELEPHONE - HANDSET/CRADLE

15- 13 CORDLESS TELEPHONE - BASE UNIT

15- 14 RJ11 FAX/PORT JACK

15- 16 SATELLITE IRIDIUM TRANSCEIVER

15- 17 IRIDIUM BAND-PASS FILTER

15- 18 CORDED TELEPHONE

15- 19 CORDLESS TELEPHONE - HANDSET/CRADLE

15- 20 CORDLESS TELEPHONE - BASE UNIT

15- 21 FAX MACHINE

20- 00 DATA TRANSMISSION AND AUTOMATIC CALL-ING

21- 00 SELCAL

22- 00 WIRELESS AIRCRAFT DATA LINK SYSTEM

22- 01 WADL LOW-NOISE AMPLIFIER

22- 02 WADL AIRBORNE UNIT (WAU)

22- 03 WADL ANTENNA

22- 04 WADL WIRELESS ETHERNET BRIDGE

23- 00 WIRELESS GATELINK SYSTEM

23- 01 WIRELESS GATELINK ROUTER

23- 02 WIRELESS GATELINK ANTENNA

24- 00 COMMUNICATION MANAGEMENT FUNCTION

24- 01 PRINTER

25- 00 CONTROLLER - PILOT DATALINK COMMUNICA-TION SYSTEM (CPDLC)

50- 00 AUDIO INTEGRATING

Page 27

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

23- COMMUNICATIONS

51- 00 AIRBORNE AUDIO SYSTEM

51- 01 DIGITAL AUDIO PANEL

51- 02 COCKPIT LOUDSPEAKER

51- 03 PTT/HOT MIC SWITCH

51- 04 PTT MIC SWITCH

51- 05 PILOT/COPILOT JACKS PANEL

51- 06 OBSERVER JACKS PANEL

51- 08 HEADSET & MICROPHONE

51- 09 PILOT/COPILOT HAND-MIC JACK PANEL

51- 10 CONSOLE AUDIO CONTROL PANEL

51- 11 AUX AUDIO PANEL

51- 13 HEADPHONE VOLUME CONTROL PANEL

51- 14 HOT/PTT SWITCH PANEL

51- 15 HEADSET BOOM/HDPH JACKS PANEL

51- 16 CONSOLE LOUDSPEAKER

51- 17 ICS/CALL PUSHBUTTONS/ANNUNCIATORS

51- 18 CONSOLE

52- 00 RAMP INTERPHONE

52- 01 FORWARD RAMP INTERPHONE PANEL

52- 02 AFT RAMP INTERPHONE PANEL

52- 03 CENTER RAMP INTERPHONE PANEL

52- 04 RAMP CALL HORN

60- 00 STATIC DISCHARGING

61- 00 STATIC DISCHARGERS

61- 01 BONDED-BASE STATIC DISCHARGER

61- 02 RIVETED-BASE STATIC DISCHARGER

61- 03 NLG STATIC DISCHARGER

Page 28

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

24- ELECTRICAL POWER

00 00 ELECTRICAL POWER

00- 01 ELECTRIC CONTROL PANEL

00- 02 CIRCUIT BREAKER

00- 03 HARNESS PROTECTION COVER

00- 04 FORWARD RELAY SUPPORT

00- 05 MIDDLE RELAY SUPPORT

00- 25 MULTI-SYSTEM HARNESS (W121 TO W149)







02- 01 MULTI-SYSTEM HARNESS (W201) PART I







03- 00 WING HARNESS

03- 01 WING LEADING EDGE HARNESS

03- 02 WING TRAILING EDGE HARNESS

03- 03 WING STUB HARNESS

20- 00 AC GENERATION

21- 00 GENERATOR DRIVE SYSTEM

21- 01 INTEGRATED DRIVE GENERATOR (IDG)

21- 02 IDG ELECTRICAL CABLES, CLAMPS AND COOLING LINES

Page 29

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


21- 03 IDG V-BAND CLAMP AND CONNECTORS

21- 04 IDG CABLE GROUNDING FITTING

21- 05 IDG OIL SYSTEM

21- 07 IDG AIR/OIL HEAT EXCHANGER

21- 09 IDG FUEL/OIL HEAT EXCHANGER

21- 11 IDG OIL-OUT FILTER ELEMENT

21- 13 IDG DIFFERENTIAL PRESSURE INDICATOR

21- 15 IDG OVERFLOW DRAIN PLUG ASSEMBLY

21- 17 IDG CASE DRAIN PLUG ASSEMBLY

21- 19 MAIN GENERATOR CONTROL UNIT (GCU)

21- 21 GENERATOR LINE CONTACTOR (GLC)

22- 00 APU AC GENERATION

22- 01 APU AC GENERATOR

22- 02 APU AC GENERATOR CABLE GROUNDING FIT-TING

22- 03 AUXILIARY GENERATOR CONTROL UNIT (AGCU)

22- 05 AUXILIARY LINE CONTACTOR (ALC)

22- 07 APU START CONTACTOR (ASC)

22- 09 APU START BUS CONTACTOR (ABC)

23- 00 EMERGENCY AC POWER GENERATION

23- 01 RAM-AIR-TURBINE (RAT)

23- 03 RAM-AIR-TURBINE (RAT) RESTOW PUMP

23- 05 RAM-AIR-TURBINE (RAT) DEPLOYMENT ACTU-ATOR

23- 07 RAM-AIR-TURBINE (RAT) UPLOCK ASSEMBLY

23- 08 RAM-AIR-TURBINE (RAT) STOW LOCK PIN

23- 09 RAM-AIR-TURBINE (RAT) GENERATOR CON-TROL UNIT

23- 11 RAM-AIR-TURBINE (RAT) MANUAL RELEASE HANDLE AND CABLE ASSEMBLY

Page 30

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


23- 13 RAM-AIR-TURBINE (RAT) LINE CONTACTOR (RLC)

24- 00 STATIC INVERTER

24- 01 AC STATIC INVERTER

25- 00 AC CONVERTER

25- 01 AC/AC CONVERTER FOR NON-PASSENGER-CABIN ELECTRICAL OUTLETS

25- 02 AC/AC CONVERTER FOR PASSENGER-CABIN ELECTRICAL OUTLETS

25- 03 HIGH-POWER CONVERTER

25- 04 GALLEY CONVERTER

30- 00 DC GENERATION

31- 00 DC GENERATION

31- 01 TRANSFORMER RECTIFIER UNIT (TRU)

31- 03 TRU CONTACTOR (TRUC)

33- 00 DC CONVERTER

33- 01 AC/DC CONVERTER FOR PASSENGER-CABIN ELECTRICAL OUTLETS

36- 00 MAIN BATTERIES

36- 01 MAIN BATTERY

36- 02 MAIN BATTERIES CABLE GROUNDING FITTING

36- 03 BATTERY CONTACTOR (BC)

36- 05 BATTERY AIR-ESCAPE HOSE

40- 00 EXTERNAL POWER

41- 00 EXTERNAL DC POWER

41- 01 EXTERNAL DC POWER RECEPTACLE

41- 02 EXTERNAL DC POWER SUPPLY

41- 03 EXTERNAL POWER DC CONTACTOR (EPDC)

41- 04 EXTERNAL DC POWER CABLE GROUNDING FITTING

42- 00 EXTERNAL AC POWER

Page 31

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


42- 01 EXTERNAL POWER MODULE (EPM)

42- 02 EXTERNAL AC POWER SUPPLY

42- 03 EXTERNAL AC POWER RECEPTACLE

42- 04 EXTERNAL AC POWER CABLE GROUNDING FITTING

42- 05 EXTERNAL POWER AC CONTACTOR (EPAC)

50- 00 AC ELECTRICAL LOAD DISTRIBUTION

51- 00 AC POWER DISTRIBUTION

51- 01 LEFT INTEGRATED CONTROL CENTER (LICC)

51- 02 LICC CABLE GROUNDING FITTING

51- 03 RIGHT INTEGRATED CONTROL CENTER (RICC)

51- 04 RICC CABLE GROUNDING FITTING

51- 06 EICC CABLE GROUNDING FITTING

51- 05 EMERGENCY INTEGRATED CONTROL CENTER (EICC)

51- 07 BUS TIE CONTACTOR (BTC)

51- 09 STANDBY CONTACTOR RELAY (EICC-K1)

51- 11 AC ESSENTIAL TRANSFER CONTACTOR (AETC)

51- 13 SPDA AC POWER MODULE

51- 15 GROUND SERVICE TRANSFER CONTACTOR (GSTC)

51- 16 AC GROUND SERVICE PANEL

51- 17 EICC ELECTRICAL POWER RELAYS

51- 19 EICC FUSE

51- 23 SPARE RELAY (LICC - K6)

51- 25 LICC RESISTOR (R4)

51- 27 RICC FUSE

51- 29 RICC ELECTRICAL POWER RELAYS

51- 33 RICC RESISTOR (R7)

Page 32

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


52- 00 AC CIRCUIT BREAKERS

52- 01 AC CIRCUIT BREAKERS

52- 03 AFT-CARGO-COMPARTMENT CIRCUIT-BREAKER AND RELAY BOX

52- 05 MIDDLE-AVIONICS-COMPARTMENT CIRCUIT-BREAKER AND RELAY BOX

52- 07 MISSION/ENTERTAINMENT AC CIRCUIT BREAKER AND RELAY BOX

54- 00 AC ELECTRICAL OUTLET

54- 01 COCKPIT AC ELECTRICAL OUTLET

54- 02 GALLEY ELECTRICAL OUTLET

54- 03 WARDROBE ELECTRICAL OUTLET

54- 04 AVIONICS-COMPARTMENT ELECTRICAL OUT-LET

54- 05 PC OUTLET RELAY

54- 06 PASSENGER-SEAT AC ELECTRICAL OUTLET

54- 07 CABIN PC-POWER MONITORING PANEL

54- 08 MEDICAL-KIT ELECTRICAL OUTLET

54- 09 PC-POWER CONTROL PANEL

54 10 WINDSCREEN ELECTRICAL OUTLET

54- 11 CABIN OUTLET CONTROL PANEL

54- 12 GROUND FAULT INTERRUPTER

54- 13 PAX OUTLETS/GALLEYS/IFE CONTROL PANEL

54- 14 LAVATORY AC ELECTRICAL OUTLET

54- 15 PAX OUTLETS/MEDICAL/IFE/RACK CONTROL PANEL

54- 16 MISSION/ENTERTAINMENT RACK AC ELECTRI-CAL OUTLET

54- 17 COMMUNICATION CONSOLE AC ELECTRICAL OUTLET

54- 18 DADO PANEL AC ELECTRICAL OUTLET

Page 33

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


54- 19 SIDELEDGE PANEL AC ELECTRICAL OUTLET

54- 20 PC-POWER ELECTRICAL OUTLET

54- 21 GROUND SERVICE OUTLET

60- 00 DC ELECTRICAL LOAD DISTRIBUTION

61- 00 DC POWER DISTRIBUTION

61- 01 SECONDARY POWER DISTRIBUTION ASSEM-BLY 1 (SPDA 1)

61- 03 SECONDARY POWER DISTRIBUTION ASSEM-BLY 2 (SPDA 2)

61- 05 SPDA DISCRETE I/O MODULE

61- 07 SPDA MICRO/COMMS MODULE

61- 09 SPDA ASCB COMMS MODULE

61- 11 SPDA POWER SUPPLY MODULE

61- 13 SPDA DC Power Module

61- 15 SPDA ARINC 429 Module

61- 17 SPDA Analog I/O Module

61- 19 AUXILIARY INTEGRATED CONTROL CENTER (AICC)

61- 21 DC TIE CONTACTOR (DCTC)

61- 23 ESSENTIAL TIE CONTACTOR (ETC)

61- 25 ESSENTIAL CONTACTOR (EC)

61- 27 AICC FUSE

61- 29 AICC VOLTAGE SENSOR RELAY (K1)

61- 31 LICC FUSE

64- 00 DC CIRCUIT BREAKERS

64- 01 DC CIRCUIT BREAKERS

64- 03 MISSION/ENTERTAINMENT DC CIRCUIT BREAKER AND RELAY BOX

66- 00 DC ELECTRICAL OUTLET

Page 34

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

25- EQUIPMENT / FURNISHINGS

00 00 EQUIPMENT/FURNISHINGS

00- 01 DETERMINATION OF DAMAGE IN COMPOSITE MATERIAL

00- 02 LIQUID DETECTION IN COMPOSITE MATERIAL

00- 03 REMOVAL OF LIQUID FROM DAMAGED COM-POSITE PARTS

00- 04 REMOVAL OF DAMAGED AREAS FROM COM-POSITE MATERIAL

00- 05 CLEANING OF COMPOSITE MATERIAL AREAS

00- 06 HONEYCOMB CORE REPLACEMENT

00- 07 REPLACEMENT OF COMPOSITE MATERIAL PLIES

00- 08 LAY-UP OF COMPOSITE MATERIAL

00- 09 EDGE DELAMINATION OF COMPOSITE MATE-RIAL

00- 10 EDGE FILL OF COMPOSITE MATERIAL

00- 11 PLY DELAMINATION OF COMPOSITE MATERIAL

00- 12 DISBONDING BETWEEN SKIN AND HONEY-COMB

00- 13 SMALL DAMAGE ON ONE SKIN OF COMPOSITE MATERIAL

00- 14 DAMAGE IN ONE SKIN AND HONEYCOMB CORE

00- 15 DAMAGE IN TWO SKINS AND HONEYCOMB CORE

00- 16 SOLID LAMINATES

00- 17 INSERTS IN COMPOSITE MATERIAL

00- 18 NUTPLATE AND RIVNUTS ON COMPOSITE MATERIAL

00- 19 DECORATIVE MATERIALS IN COMPOSITE MATERIAL

00- 20 SEALING OF JOINTS IN COMPOSITE MATERIAL

Page 35

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


00- 21 PAINTING OF COMPOSITE MATERIAL PARTS

00- 22 POLYCARBONATE PARTS

00- 23 GENERAL BONDING AND SEALING IN COM-POSITE MATERIAL

00- 24 FILLING AND FAIRING

00- 25 THERMOFORMED PLASTIC REPAIR

00- 26 EQUIPMENT/FURNISHINGS

00- 27 TROLLEY

10- 00 COCKPIT

10- 01 SOLID LAMINATE PARTS

10- 02 HONEYCOMB CORE PARTS WITH SOLID LAMI-NATE SKINS

10- 03 POLYCARBONATE PARTS

11- 00 COCKPIT SEATS

11- 01 PILOT SEATS

11- 02 OBSERVER SEAT

11- 03 PILOT SEAT ELECTRICAL ACTUATOR

11- 04 PILOT SEAT HEADREST

11- 05 PILOT-SEAT UNLOCKING CABLES

11- 06 PILOT-SEAT RECLINE-CONTROL CABLE

11- 07 PILOT-SEAT RECLINE ACTUATOR

11- 08 PILOT SEAT ARMREST

12- 00 COCKPIT LININGS

12- 01 CEILING LINING PANELS

12- 02 RH/LH COCKPIT SIDEWALL LININGS

12- 03 WINDSHIELD LININGS

12- 04 GLARESHIELD COVER

12- 05 FORWARD COCKPIT BULKHEAD

12- 06 PEDAL ASSEMBLY LINING

12- 09 RH/LH DIRECT-VISION WINDOW LININGS

Page 36

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


12- 11 CONTROL COLUMN LINING

12- 12 HEAD-UP DISPLAY SUNVISOR HOLDER

13- 00 COCKPIT CONSOLES

13- 01 RH COCKPIT CONSOLES

13- 02 LH COCKPIT CONSOLES

13- 03 RH AFT CONSOLE

13- 04 LH AFT CONSOLE

14- 00 COCKPIT FLOOR FINISHING

20- 00 PASSENGER CABIN

20- 02 OVERHEAD BIN/CABIN AND GALLEY STORAGE COMPARTMENT/CLOSETS

20- 03 AFT ELECTRONIC COMPARTMENT EMI-SHIELD AND BONDING JUMPERS

20- 04 AFT ELECTRONIC COMPARTMENT ACCESS DOOR EMI-SHIELD AND BONDING JUMPER

20- 05 PASSENGER CABIN MONUMENT ACCESS DOOR

20- 06 PASSENGER CABIN MONUMENT DOOR LATCHES

21- 00 PASSENGER CABIN SEATS

21- 10 PASSENGER SEAT ASSEMBLY

21- 11 PASSENGER SEATS

21- 12 PASSENGER-SEAT HYDRAULIC LOCK

21- 13 PASSENGER SEAT FOODTABLE

21- 14 PASSENGER SEAT HEADREST

21- 15 PASSENGER SEAT ARMREST

21- 16 PASSENGER SEAT LEGREST

21- 17 PASSENGER SEAT DIAPHRAGM

21- 18 PASSENGER SEAT BLOCKING DEVICE

21- 20 FLIGHT ATTENDANT SEATS

21- 21 AFT-FACING FORWARD LH ATTENDANT-SEAT

Page 37

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


21- 22 FORWARD-FACING AFT LH ATTENDANT-SEAT

21- 23 FORWARD-FACING FORWARD RH ATTEN-DANT-SEAT

21- 24 SIDEMOUNT FORWARD RH ATTENDANT-SEAT

21- 25 AFT-FACING AFT RH ATTENDANT-SEAT

21- 26 AFT-FACING LH FORWARD DOUBLE ATTEN-DANT-SEAT

21- 27 DIVAN SEATS

21- 28 BED

22- 00 PASSENGER CABIN CEILING

22- 01 BIN/PSU STRUCTURE TUBES

22- 03 PSU STRUCTURE

22- 04 PASSENGER SERVICE UNIT (PSU)

22- 07 CEILING PANEL

22- 08 AIR OUTLET COVER

22- 09 OVERHEAD BIN

22- 10 PASSENGER-CABIN GASPER OUTLET

22- 11 PLENUM

22- 12 HEADLINER

22- 13 VENTILATION DUCT

22- 14 OVERHEAD BIN DOORS

23- 00 PASSENGER CABIN SIDEWALL PANELS

23- 01 SIDEWALL PANELS

23- 02 DADO PANELS

23- 03 TOE KICK PANEL

23- 04 FORWARD PASSENGER-DOOR LINING

23- 05 AFT PASSENGER-DOOR LINING

23- 06 FORWARD SERVICE-DOOR LINING

23- 07 AFT SERVICE-DOOR LINING

23- 08 FORWARD PASSENGER-DOOR SURROUND

Page 38

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


23- 09 AFT PASSENGER-DOOR SURROUND

23- 10 FORWARD SERVICE-DOOR SURROUND

23- 11 AFT SERVICE-DOOR SURROUND

23- 12 ESCAPE HATCH TRIM SHROUD

23- 13 ESCAPE HATCH LINING

23- 14 ESCAPE HATCH SURROUND

23- 15 SIDEWALL WINDOW SHADE

23- 16 SIDELEDGE PANEL

23- 17 VALANCE PANEL

23- 18 WINDOW PANEL

23- 19 AFT BAGGAGE-DOOR LINING

23- 20 TRANSITION PANEL

23- 21 AFT BAGGAGE-DOOR SURROUND

24- 00 PASSENGER-CABIN FLOOR FINISH

24- 01 PASSENGER-CABIN FLOOR FINISH

24- 02 LAVATORY FLOOR FINISH

25- 00 FLIGHT ATTENDANT PANELS

25- 01 FORWARD ATTENDANT CONTROL-PANEL

25- 02 AFT ATTENDANT CONTROL-PANEL

25- 03 FLIGHT ATTENDANT PANELS RELAY

25- 04 FLIGHT ATTENDANT PANEL

26- 00 CLOSETS

26- 01 LH FORWARD WARDROBE

26- 02 RH FORWARD WARDROBE

26- 03 AIRSTAIRS STOWAGE

26- 04 AIRSTAIRS WARDROBE

26- 05 RH CLASS-DIVIDER WARDROBE

26- 06 LH CLASS-DIVIDER WARDROBE

26- 07 TROLLEY STOWAGE

26- 08 MISCELLANEOUS/TROLLEY STOWAGE

26- 11 LH FORWARD STOWAGE UNIT

Page 39

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


26- 12 RH FORWARD STOWAGE UNIT

26- 13 LH MID WARDROBE

26- 14 RH AFT WARDROBE

26- 15 LH VIP WARDROBE

26- 16 MINICREDENZA

26- 17 LH CREW REST WARDROBE CABINET

26- 18 RH CREW REST WARDROBE CABINET

26- 19 LH STORAGE CABINET

26- 20 CREDENZA

26- 21 LH FWD VIP WARDROBE

26- 22 LH VIP COUNTERTOP

26- 23 LH AFT VIP WARDROBE

27- 00 PARTITIONS

27- 01 COCKPIT BULKHEAD

27- 03 FORWARD RH WINDSCREEN

27- 04 FORWARD LH WINDSCREEN

27- 05 AFT RH WINDSCREEN

27- 06 AFT LH WINDSCREEN

27- 07 MOVABLE CLASS DIVIDER

27- 08 CLASS DIVIDER

27- 10 FORWARD GALLEY CURTAIN

27- 11 AFT WINDSCREEN CURTAIN

27- 12 AFT LH HANDICAPPED LAVATORY CURTAIN

27- 13 LH CLASS DIVIDER

27- 17 FORWARD LH FIRST CLASS WINDSCREEN

27- 18 FORWARD RH FIRST CLASS WINDSCREEN

27- 14 RH CLASS DIVIDER

27- 16 CURTAIN TRACKS

27- 19 CLASS DIVIDER CURTAIN

27- 20 CURTAIN

27- 22 MID BULKHEAD

27- 23 LONGITUDINAL DIVIDER

27- 24 TRANSVERSAL DIVIDER

Page 40

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


27- 25 FORWARD BULKHEAD

27- 26 AFT BULKHEAD

27- 21 FWD WARDROBE CURTAIN

28- 00 RACKS & CONSOLES

28- 01 MISSION/ENTERTAINMENT RACK

28- 02 COMMUNICATION CONSOLE

28- 03 ELECTRONIC EQUIPMENT RACK (ENTERTAIN-MENT)

28- 04 WORKSTATION

28- 10 SIDELEDGE

29- 00 CABIN TABLE

29- 01 CONFERENCE TABLE

29- 02 EXECUTIVE TABLE

30- 00 GALLEYS

30- 03 GALLEY WASTE RECEPTACLES ACCESS DOORS/COVERS

31- 00 FORWARD GALLEYS



31- 04 FORWARD LH GALLEY

31- 05 FORWARD RH GALLEY

34- 00 AFT GALLEYS

34- 01 AFT RH GALLEY

34- 02 AFT GALLEY

36- 00 GALLEY ELECTRICAL SYSTEM

36- 01 GALLEY CONTROL MODULE

36- 02 GALLEY ICC RELAY

36- 03 GALLEY 2/3 RELAY

37- 00 GALLEY INSERTS

37- 01 HOT JUGS

37- 02 OVENS

37- 03 COFFEE MAKERS

37- 04 AIR CHILLER

37- 05 WATER BOILER

Page 41

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


37- 06 REFRIGERATOR

37- 07 MICROWAVE OVEN

38- 00 BAR

38- 01 LH BAR

40- 00 LAVATORIES

41- 00 FORWARD LAVATORIES

41- 01 FORWARD RH LAVATORY

41- 02 FORWARD LH LAVATORY

41- 03 CREW FORWARD LAVATORY

42- 00 AFT LAVATORIES

42- 01 AFT RH LAVATORY

42- 02 AFT LH LAVATORY

42- 03 AFT LH HANDICAPPED LAVATORY

43- 00 TOILET UNIT

43- 01 TOILET SHROUD

43- 02 HANDICAPPED TOILET SHROUD

44- 00 LAVATORY DOOR ASSEMBLY

44- 01 LAVATORY DOOR

44- 02 LAVATORY DOOR LATCH

45- 00 LAVATORY WASTE-DISPOSAL DOOR

45- 01 LAVATORY WASTE-DISPOSAL DOOR

46- 00 LAVATORY ITEMS

46- 01 LAVATORY SOAP DISPENSER

46- 02 LAVATORY MIRROR

47- 00 MID LAVATORIES

47- 02 MID LH LAVATORY

48- 00 VIP LAVATORIES

48- 01 VIP RH LAVATORY

48- 02 VIP LAVATORY SHOWER

50- 00 ADDITIONAL COMPARTMENTS

51- 00 DOORS COMPARTMENTS

52- 00 MISCELLANEOUS COMPARTMENT

52- 01 DOG HOUSE

Page 42

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


53- 00 AFT BAGGAGE COMPARTMENT

53- 01 AFT-BAGGAGE-COMPARTMENT AFT BULK-HEAD

53- 02 AFT-BAGGAGE-COMPARTMENT LINING

53- 03 AFT-BAGGAGE-COMPARTMENT DOOR PRO-TECTION

53- 04 AFT-BAGGAGE-COMPARTMENT CURTAIN

53- 05 AFT-BAGGAGE-COMPARTMENT CARPET

53- 06 AFT-BAGGAGE-COMPARTMENT NET

53- 07 AFT-BAGGAGE-COMPARTMENT INTERNAL-DOOR SEAL

53- 08 AFT-BAGGAGE-COMPARTMENT FWD BULK-HEAD

53- 09 AFT-BAGGAGE-COMPARTMENT SHELVES

53- 10 AFT-BAGGAGE-COMPARTMENT COAT ROD

53- 11 AFT-BAGGAGE-COMPARTMENT FINISHING

60- 00 EMERGENCY

61- 00 EMERGENCY LOCATOR TRANSMITTER SYS-TEM

61- 01 EMERGENCY LOCATOR TRANSMITTER

61- 02 ELT REMOTE SWITCH PANEL

61- 03 ELT ANTENNA

61- 04 ELT BATTERY

61- 05 ELT BUZZER

61- 06 ELT/NAV INTERFACE UNIT

62- 00 EMERGENCY MISCELLANEOUS EQUIPMENT

62- 01 FIRST-AID KIT

62- 02 FLOTATION EQUIPMENT

62- 03 MEGAPHONE

62- 04 CRASH AXE

62- 05 ESCAPE ROPE

62- 06 MEDICAL KIT

62- 07 SURVIVAL KIT

62- 08 DEFIBRILLATOR

Page 43

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


62- 09 LIFELINE

62- 10 BIOHAZARD KIT

62- 11 WHEELCHAIR

62- 12 FIRE GLOVE

63- 00 PORTABLE EMERGENCY-LOCATOR-TRANS-MITTER SYSTEM

63- 01 PORTABLE EMERGENCY-LOCATOR TRANSMIT-TER

65- 00 EMERGENCY-EVACUATION SLIDE SYSTEM

65- 01 EMERGENCY-EVACUATION SLIDE ASSEMBLY

66- 00 LIFE RAFTS SYSTEM

66- 01 LIFE RAFTS

67- 00 FLIGHT-ATTENDANT DEMONSTRATION KIT

70- 00 ACCESSORY COMPARTMENTS

80- 00 INSULATION

81- 00 COCKPIT AND PASSENGER CABIN INSULA-TION SYSTEM

81- 01 COCKPIT AND PASSENGER CABIN INSULA-TION

81- 02 FORWARD-FUSELAGE INSULATION

81- 03 UPPER-FORWARD-FUSELAGE PASSENGER-CABIN INSULATION

81- 04 UPPER-CENTER-FUSELAGE I INSULATION

81- 05 UPPER-CENTER-FUSELAGE II INSULATION

81- 06 UPPER-CENTER-FUSELAGE III INSULATION

81- 07 FORWARD PASSENGER-DOOR INSULATION

81- 08 AFT PASSENGER-DOOR INSULATION

81- 09 FORWARD SERVICE-DOOR INSULATION

81- 10 AFT SERVICE-DOOR INSULATION

81- 11 ESCAPE HATCH INSULATION

81- 12 FLOOR PANEL INSULATION

82- 00 SOUND DAMPENER SYSTEM

82- 01 SOUND DAMPENER

Page 44

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


83- 00 NOISE TREATMENT FELT SYSTEM

83- 01 NOISE TREATMENT FELT

84- 00 SMOKE SEAL SYSTEM

84- 01 SMOKE SEAL

85- 00 SOFT BLUE SOUND DAMPENER SYSTEM

85- 01 SOFT BLUE SOUND DAMPENER

86- 00 VIBRATION DAMPER SYSTEM

86- 01 VIBRATION DAMPER

Page 45

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

26- FIRE PROTECTION

00 00 FIRE PROTECTION

00- 01 FIRE PROTECTION SYSTEM TEST SWITCH

10- 00 FIRE/SMOKE DETECTION

10- 01 SMOKE DETECTOR PANEL

10- 04 SMOKE-SONOALERT AUDIBLE-SIGNAL DEVICE

11- 00 ENGINE FIRE/OVERHEAT DETECTION SYS-TEM

11- 01 ENGINE FIRE DETECTOR

11- 03 PYLON FIRE DETECTOR

11- 05 ENGINE FIRE DETECTION SYSTEM ELECTRI-CAL HARNESS

11- 07 PYLON FIRE DETECTION SYSTEM ELECTRI-CAL HARNESS

12- 00 APU FIRE/OVERHEAT DETECTION SYSTEM

12- 01 APU FIRE DETECTOR

12- 03 APU FIRE DETECTION SYSTEM ELECTRICAL HARNESS

13- 00 PASSENGER CABIN SMOKE DETECTOR SYS-TEM

13- 01 PASSENGER-CABIN SMOKE DETECTOR

14- 00 LAVATORY SMOKE DETECTION SYSTEM

14- 01 LAVATORY SMOKE DETECTOR

14- 02 LAVATORY SMOKE DETECTOR RELAY

15- 00 CARGO COMPARTMENT SMOKE DETECTION SYSTEM

15- 01 CARGO COMPARTMENT SMOKE DETECTOR

16- 00 RECIRCULATION BAY SMOKE DETECTION SYSTEM

16- 01 RECIRCULATION BAY SMOKE-DETECTOR

17- 00 LANDING GEAR BAY FIRE DETECTION SYS-TEM

Page 46

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

26- FIRE PROTECTION

17- 01 LANDING GEAR BAY FIRE DETECTOR

18- 00 ELECTRONIC-EQUIPMENT-RACK SMOKE-DETECTION SYSTEM

18- 01 ELECTRONIC-EQUIPMENT-RACK SMOKE DETECTOR

18- 02 ELECTRONIC-EQUIPMENT RACK MAINTE-NANCE/TEST PANEL

18- 03 ELECTRONIC-EQUIPMENT-RACK COOLING INDICATOR

20- 00 FIRE EXTINGUISHING

20- 01 FIRE EXTINGUISHER PANEL

21- 00 ENGINE FIRE EXTINGUISHING SYSTEM

21- 01 ENGINE FIRE SHUTOFF & EXTINGUISHING HANDLE

21- 03 ENGINE FIRE EXTINGUISHING BOTTLE

21- 05 ENGINE FIRE EXTINGUISHING BOTTLE PRES-SURE SWITCH (TCPS) 1

21- 07 ENGINE FIRE EXTINGUISHING BOTTLE CAR-TRIDGE

21- 09 TWO-WAY CHECK TEE VALVE

21- 11 ENGINE FIRE EXTINGUISHING SYSTEM DIS-CHARGE PIPING

21- 13 ENGINE FIRE EXTINGUISHING SYSTEM DRAIN VALVES

21- 15 ENGINE FIRE EXTINGUISHING SYSTEM DIS-CHARGE NOZZLE

22- 00 APU FIRE EXTINGUISHING SYSTEM

22- 01 APU FIRE EXTINGUISHING BOTTLE

22- 03 APU FIRE EXTINGUISHING BOTTLE PRES-SURE SWITCH (TCPS) 1

22- 05 APU FIRE EXTINGUISHING BOTTLE CAR-TRIDGE

Page 47

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

26- FIRE PROTECTION

22- 07 APU FIRE EXTINGUISHING SYSTEM DIS-CHARGE PIPING

22- 09 APU FIRE EXTINGUISHING SWITCH

23- 00 CARGO COMPARTMENT FIRE EXTINGUISH-ING SYSTEM

23- 01 CARGO COMPARTMENT FIRE EXTINGUISH-ING BOTTLE (HIGH RATE AND LOW RATE)

23- 03 CARGO COMPARTMENT FIRE EXTINGUISH-ING BOTTLE CARTRIDGE

23- 07 DRIER METERING UNIT

23- 09 CARGO COMPARTMENT DISCHARGE TUBING

23- 11 SWEPT TEE ASSEMBLY

23- 13 CARGO COMPARTMENT FIRE EXTINGUISH-ING PUSHBUTTON

23- 15 CARGO FIRE EXTINGUISHING RELAY

23- 17 CARGO COMPARTMENT DISCHARGE NOZZLE

24- 00 PORTABLE FIRE EXTINGUISHING SYSTEM

24- 01 PORTABLE FIRE EXTINGUISHER

25- 00 LAVATORY AUTO-DISCHARGE FIRE-EXTIN-GUISHING SYSTEM

25- 01 LAVATORY AUTO-DISCHARGE FIRE-EXTIN-GUISHING BOTTLE

26- 00 MONUMENT AUTO-DISCHARGE FIRE-EXTIN-GUISHING SYSTEM

26- 01 MONUMENT AUTO-DISCHARGE FIRE-EXTIN-GUISHING

Page 48

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

00 00 FLIGHT CONTROLS

00- 01 FLIGHT CONTROLS- ELECTRICAL HARNESS AND WIRES

00- 10 FLT CTRL FAULT

03- 00 FLIGHT CONTROLS ELECTRICAL SYSTEM

03- 01 FLIGHT CONTROLS PANEL

03- 02 FLIGHT CONTROL MODULE

03- 03 PRIMARY ACTUATOR-CONTROL ELECTRON-ICS

03- 04 TRIM CONTROL PANEL

03- 05 FLY-BY-WIRE BACKUP BATTERY

03- 06 FCS PRIMARY PWR BCK RELAYS

03- 07 FCS BCK BATT RLY

10- 00 AILERON

11- 00 AILERON MECHANICAL COMPONENTS

11- 01 CONTROL YOKE

11- 03 AILERON CONTROL CABLE

11- 05 AILERON FEEL UNIT

11- 06 AILERON TORQUE TUBE

11- 07 AILERON FUSELAGE SECTOR

11- 08 AILERON WING SECTOR

11- 09 AILERON SURFACE

11- 10 PULLEY

11- 11 AILERON OVERRIDE UNIT

11- 12 CONTROL-YOKE DISCONNECT DEVICE

11- 13 CONTROL-YOKE DISCONNECT HANDLE

12- 00 AILERON HYDRAULIC ACTUATION

12- 01 AILERON POWER CONTROL-UNIT

12- 02 AILERON POWER CONTROL-UNIT TOGGLE-LINK

13- 00 AILERON ELECTRICAL SYSTEM

13- 02 AILERON-SURFACE POSITION SENSOR

Page 49

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

14- 00 AILERON TRIM

14- 01 AILERON TRIM ACTUATOR

20- 00 RUDDER

21- 00 RUDDER MECHANICAL COMPONENTS

21- 01 RUDDER PEDAL ASSEMBLY

21- 03 RUDDER-PEDAL DAMPER

21- 04 RUDDER FEEL UNIT

21- 05 RUDDER SURFACE

22- 00 RUDDER HYDRAULIC ACTUATION

22- 01 RUDDER POWER CONTROL-UNIT

22- 02 RUDDER POWER CONTROL-UNIT TOGGLE-LINK

23- 00 RUDDER ELECTRICAL SYSTEM

23- 01 RUDDER-PEDAL COMMAND POSITION-SEN-SOR

23- 02 RUDDER SURFACE POSITION-SENSOR

23- 03 RUDDER-PEDAL ADJUSTMENT ACTUATOR

23- 04 RUDDER HINGE MOMENT LIMITER RELAYS

24- 00 RUDDER TRIM

24- 01 RUDDER TRIM ACTUATOR

30- 00 ELEVATOR

31- 00 ELEVATOR MECHANICAL COMPONENTS

31- 01 ELEVATOR CONTROL COLUMN

31- 02 CONTROL-COLUMN DAMPER

31- 03 ELEVATOR FEEL UNIT

31- 04 ELEVATOR TORQUE TUBE

31- 05 ELEVATOR SURFACE

31- 06 CONTROL-COLUMN DISCONNECT DEVICE

31- 07 CONTROL-COLUMN DISCONNECT HANDLE

31- 08 ELEVATOR CONTROL-COLUMN ROD ASSY

32- 00 ELEVATOR HYDRAULIC ACTUATION

32- 01 ELEVATOR POWER CONTROL-UNIT

Page 50

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

32- 02 ELEVATOR POWER CONTROL-UNIT TOGGLE-LINK

33- 00 ELEVATOR ELECTRICAL SYSTEM

33- 01 CONTROL-COLUMN COMMAND POSITION-SENSOR

33- 02 ELEVATOR SURFACE POSITION-SENSOR

33- 05 ELEVATOR THRUST COMPENSATION

33- 06 TAIL STRIKE AVOIDANCE

36- 00 STALL WARNING AND PROTECTION SYSTEM

36- 01 STICK SHAKER

36- 03 STICK PUSHER

40- 00 HORIZONTAL STABILIZER

41- 00 HORIZONTAL STABILIZER MECHANICAL COM-PONENTS

41- 01 HORIZONTAL STABILIZER TRIM ACTUATOR

41- 03 HORIZONTAL STABILIZER SURFACE

41- 09 AUTO CONFIG TRIM

43- 00 HORIZONTAL STABILIZER ELECTRICAL SYS-TEM

43- 01 HORIZONTAL STABILIZER ACTUATOR CON-TROL ELECTRONICS

43- 02 HORIZONTAL STABILIZER CONTROL-YOKE PITCH TRIM SWITCH

43- 03 HORIZONTAL STABILIZER ACTUATOR MOTOR ASSEMBLY

50- 00 FLAP

51- 00 FLAP MECHANICAL DRIVE LINE

51- 01 FLAP ACTUATOR

51- 02 FLAP ANGLE GEARBOX

51- 03 FLAP TORQUE TUBE

51- 04 FLAP BEARING SUPPORT

51- 05 FLAP POWER-DRIVE-UNIT

51- 06 INBOARD FLAP ASSEMBLY

Page 51

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

51- 07 OUTBOARD FLAP ASSEMBLY

51- 08 INBOARD AFT FLAP PANEL

51- 09 OUTBOARD AFT FLAP PANEL

51- 10 FLAP SURFACE SKEW

51- 11 INBOARD AND OUTBOARD FLAP ROLLERS

53- 00 FLAP ELECTRICAL SYSTEM

53- 01 SLAT/FLAP CONTROL-LEVER UNIT

53- 02 SLAT/FLAP ACTUATOR CONTROL ELEC-TRONIC UNIT

53- 03 FLAP ELECTRICAL MOTOR

53- 04 FLAP POSITION-SENSOR UNIT

53- 05 FLAP 6 POSITION INHIBITOR

53- 06 FLAP SKEW SENSOR

53- 07 FLAP ALTERNATE SWITCH

60- 00 SPOILERS AND AIR BRAKES

61- 00 GROUND SPOILER MECHANICAL COMPO-NENTS

61- 01 SPOILER PANEL SECTION 1


61- 03 GROUND-SPOILER PROXIMITY-SENSOR TAR-GET

62- 00 GROUND SPOILER HYDRAULIC ACTUATION

62- 01 GROUND-SPOILER HYDRAULIC ACTUATOR

62- 02 GROUND-SPOILER CONTROL MODULE

62- 03 GROUND-SPOILER DOWNLOCK VALVE

63- 00 GROUND SPOILER ELECTRICAL SYSTEM

63- 02 GROUND-SPOILER PROXIMITY SENSOR

64- 00 MULTIFUNCTION SPOILER MECHANICAL COM-PONENTS




Page 52

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

65- 00 MULTIFUNCTION SPOILER HYDRAULIC ACTU-ATION

65- 01 MULTIFUNCTION-SPOILER POWER-CONTROL UNIT

65- 02 MULTIFUNCTION SPOILER-DOWNLOCK VALVE

66- 00 MULTIFUNCTION SPOILER ELECTRICAL SYS-TEM

66- 01 CONTROL YOKE POSITION-SENSOR

66- 02 SPEED BRAKE HANDLE

67- 00 VENTRAL-AIR-BRAKE MECHANICAL COMPO-NENTS

67- 01 VENTRAL-AIR-BRAKE PANEL

68- 00 VENTRAL-AIR-BRAKE HYDRAULIC ACTUATION

68- 01 VENTRAL-AIR-BRAKE HYDRAULIC ACTUATOR

68- 02 VENTRAL-AIR-BRAKE CONTROL MODULE

68- 03 VENTRAL-AIR-BRAKE UPLOCK VALVE

69- 00 VENTRAL-AIR-BRAKE ELECTRICAL SYSTEM

69- 01 VENTRAL-AIR-BRAKE POSITION SENSOR

69- 02 VAB MODULE CMD WRAP RELAY

80- 00 SLAT

81- 00 SLAT MECHANICAL COMPONENTS

81- 01 SLAT ACTUATOR

81- 02 SLAT ANGLE GEARBOX

81- 03 SLAT TORQUE TUBE

81- 04 SLAT BEARING SUPPORT

81- 05 SLAT PANEL SECTION 1




81- 10 SLAT POWER-DRIVE-UNIT

81- 11 SLAT SURFACE SKEW

83- 00 SLAT ELECTRICAL SYSTEM

Page 53

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

27- FLIGHT CONTROL

83- 01 OUTBOARD SLAT SKEW SENSOR

83- 02 INBOARD SLAT SKEW SENSOR

83- 04 SLAT ELECTRICAL MOTOR

83- 06 SLAT POSITION-SENSOR UNIT

83- 07 SLAT HARNESS

83- 08 SLAT POSITION SENSOR UNIT BRACKET

Page 54

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

00 00 FUEL

10- 00 STORAGE

11- 00 WING TANK

11- 01 BAFFLE OVAL CHECK/FLAP VALVES

11- 03 FUEL TANK ACCESS PANEL

11- 05 DRAIN VALVE

11- 07 GROUNDING RECEPTACLE

12- 00 TANK VENT

12- 01 PRESSURE RELIEF VALVE

12- 03 FLOAT-ACTUATED DRAIN VALVE

12- 05 FLOAT VENT VALVE

12- 07 TANK VENT PLUMBING

12- 09 NACA AIR INLET

12- 11 FLAME ARRESTOR/SURGE RELIEF VALVE

13- 00 AUXILIARY FUEL TANK

13- 01 FORWARD AUXILIARY FUEL TANK

13- 02 AFT AUXILIARY FUEL TANK

13- 03 AUXILIARY FUEL TANK DRAIN VALVES

13- 04 AUXILIARY FUEL TANK DRY DRAIN LINES

13- 05 FORWARD-AUXILIARY-FUEL-TANK COVERS

13- 06 AFT-AUXILIARY-FUEL-TANK COVERS

14- 00 AUXILIARY FUEL TANK VENT

14- 01 FWD TANK VENT SHUTOFF VALVE ACTUATOR

14- 02 AFT TANK VENT SHUTOFF VALVE ACTUATOR

14- 03 FWD TANK VENT SHUTOFF VALVE

14- 04 AFT TANK VENT SHUTOFF VALVE

14- 05 FWD TANK PRESSURE RELIEF BACKUP (DELTA P) SWITCH

14- 06 AFT TANK PRESSURE RELIEF BACKUP (DELTA P) SWITCH

14- 07 FORWARD TANK DELTA-P SWITCH CHECK VALVE

14- 08 AFT TANK DELTA-P SWITCH CHECK VALVE

14- 09 FWD TANK AIR FILTERS

14- 10 AFT TANK AIR FILTERS

14- 11 FWD TANK FILTER CHECK VALVES

Page 55

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

14- 12 AFT TANK FILTER CHECK VALVES

14- 13 FWD VENT RELIEF VALVE

14- 14 AFT VENT RELIEF VALVE

14- 15 FWD VENT RELIEF CHECK VALVE

14- 16 AFT VENT RELIEF CHECK VALVE

14- 17 FWD TANK FLOAT DRAIN VALVE

14- 18 AFT TANK FLOAT DRAIN VALVE

14- 19 FWD SECOND BARRIER AIR FILTER

14- 20 FWD SECOND BARRIER AIR FILTER CHECK VALVE

14- 21 AFT SECOND BARRIER AIR FILTER

14- 22 AFT SECOND BARRIER AIR FILTER CHECK VALVE

14- 23 VENT CONTROL BOX ACCESS PANEL

14- 24 AFT AIR FILTER PRESSURIZATION HOSE

14- 25 VENT CONTROL BOX HARNESS ASSEMBLY

14- 26 AUX FUEL TANK VENT SYSTEM RELAYS

20- 00 DISTRIBUTION

21- 00 ENGINE FEED SYSTEM

21- 01 CHECK VALVE - ENGINE FEED

21- 03 AC AUXILIARY-BOOST-PUMP CARTRIDGE

21- 05 AC AUXILIARY BOOST-PUMP CANISTER

21- 06 AC FUEL PUMPS RELAYS

21- 07 AC PUMP PRESSURE SWITCH

21- 09 ENGINE SHUTOFF VALVE (SOV) ACTUATOR ASSY, 28 VDC

21- 11 CROSS-FEED SHUTOFF VALVE (SOV) ACTUA-TOR, 28 VDC

21- 13 ENGINE FEED EJECTOR PUMP

21- 15 CROSS-FEED VALVE

21- 16 CROSS-FEED OVERRIDE RELAYS

21- 17 ENGINE SHUTOFF VALVE (SOV)

21- 19 MOTIVE-FLOW SUPPLY LINE

21- 21 FUEL-FEED LINE

21- 22 MOTIVE-FLOW RELIEF VALVE

Page 56

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

21- 23 MOTIVE-FLOW CHECK VALVE

21- 25 SCAVENGER EJECTOR PUMP

21- 27 FUEL CONTROL PANEL

21- 33 FUEL AC PUMP FAIL CAUTION EICAS MES-SAGE

22- 00 AUXILIARY POWER UNIT (APU) FEED SYSTEM

22- 01 AUXILIARY POWER UNIT (APU)/ENGINE DC START PUMP CARTRIDGE

22- 03 AUXILIARY POWER UNIT (APU)/ENGINE DC START PUMP CANISTER

22- 05 DC PUMP PRESSURE SWITCH

22- 06 DC FUEL PUMP RELAY (RICC - K16)

22- 07 AUXILIARY POWER UNIT (APU) FEED SHUT-OFF VALVE (SOV) WITH ACTUATOR

22- 08 AUXILIARY POWER UNIT (APU) FUEL FEED LINE

22- 09 AUXILIARY POWER UNIT (APU) FUEL FEED LINE SHROUD

22- 11 AUXILIARY POWER UNIT (APU) FUEL LINE SHROUD DRAIN

22- 17 APU FUEL SOV CLSD STATUS EICAS MES-SAGE

22- 19 APU FUEL SOV FAIL CAUTION EICAS MES-SAGE

23- 00 PRESSURE REFUELING SYSTEM

23- 01 REFUELING/DEFUELING CONTROL PANEL

23- 03 REFUELING SHUTOFF VALVE (SOV)

23- 05 REFUELING CONTROL SOLENOID

23- 07 DEFUELING SHUTOFF VALVE (SOV)/TRANSF. VALVE ACTUATOR ASSY, 28 VDC

23- 09 FUEL-QUANTITY REPEATER INDICATOR

23- 11 PRESSURE REFUELING/DEFUELING ADAPTER ASSEMBLY

23- 13 PRESSURE REFUELING/DEFUELING ADAPTER CAP

23- 15 FLOAT PILOT VALVE

23- 17 REFUELING PRESSURE SWITCH

Page 57

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

23- 19 FUEL RESTRICTOR

23- 20 FUEL DIFFUSER

23- 21 DEFUELING SHUTOFF VALVE (SOV)

23- 23 FUEL QUANTITY CONTROL RELAYS

23- 27 REFUELING SHUTOFF VALVE CLOSED INDICA-TION LIGHT

23- 29 DEFUELING SHUTOFF VALVE OPEN INDICA-TION LIGHT

23- 31 DEFUEL VALVE OPEN ADVISORY EICAS MES-SAGE

23- 32 FWD TANK REFUEL SHUTOFF VALVE

23- 33 AFT TANK REFUEL SHUTOFF VALVE

23- 34 FWD TANK REFUEL SHUTOFF VALVE ACTUA-TOR

23- 35 AFT TANK REFUEL SHUTOFF VALVE ACTUA-TOR

23- 36 REFUEL/ISOLATION CONTROL BOX ACCESS PANEL

23- 37 REFUEL/ISOLATION CONTROL BOX HARNESS ASSEMBLY

24- 00 GRAVITY REFUELING

24- 01 GRAVITY REFUELING ADAPTER

24- 03 GRAVITY FILL CAP SEAL

24- 05 GRAVITY FILL CAP

25- 00 AC/DC FUEL PUMPS WIRING/CONNECTORS

25- 01 AC/DC FUEL PUMPS WIRING/CONNECTORS

26- 00 AUXILIARY FUEL TRANSFER SYSTEM

26- 01 FORWARD TRANSFER SHUTOFF VALVE

26- 02 FORWARD TRANSFER SHUTOFF VALVE ACTU-ATOR

26- 03 AFT TRANSFER SHUTOFF VALVE

26- 04 AFT TRANSFER SHUTOFF VALVE ACTUATOR

26- 05 FWD AC TRANSFER PUMP

26- 06 AFT AC TRANSFER PUMP

26- 07 AUXILIARY FUEL SYSTEM RELAY CONTROL BOX

Page 58

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

26- 08 WING STUB FWD TRANSFER LINE CHECK VALVE

26- 09 WING STUB AFT TRANSFER LINE CHECK VALVE

26- 10 FWD BOX TRANSFER LINE CHECK VALVE

26- 11 AFT BOX TRANSFER LINE CHECK VALVE

26- 12 FWD AC TRANSFER PUMP PRESSURE SWITCH

26- 13 AFT AC TRANSFER PUMP PRESSURE SWITCH

26- 14 FWD ISOLATION SHUTOFF VALVE

26- 15 AFT ISOLATION SHUTOFF VALVE

26- 16 FWD PUMP TRANSFER CONTROL BOX

26- 17 FWD VALVE TRANSFER CONTROL BOX

26- 18 AFT PUMP TRANSFER CONTROL BOX

26- 19 AFT VALVE TRANSFER CONTROL BOX

26- 20 FWD ISOLATION SHUTOFF VALVE ACTUATOR

26- 21 AFT ISOLATION SHUTOFF VALVE ACTUATOR

26- 24 VALVE TRANSFER CONTROL BOX HARNESS ASSEMBLY

26- 25 AUXILIARY FUEL TRANSFER SYSTEM RELAYS

40- 00 INDICATING

41- 00 ELECTRICAL FUEL-QUANTITY-INDICATING

41- 01 FUEL QUANTITY PROBES/COMPENSATOR

41- 02 AUXILIARY TANK FUEL QUANTITY PROBES/COMPENSATOR

41- 03 FUEL CONDITIONING UNIT

41- 04 AUXILIARY FUEL CONDITIONING UNIT

41- 05 TANK-UNIT HARNESS ASSEMBLY

41- 06 FUEL-QUANTITY-INDICATION HARNESS

41- 07 FUEL TANK WIRING/CONNECTORS

41- 08 AUXILIARY TANK-UNIT HARNESS ASSEMBLY

42- 00 MAGNETIC LEVEL INDICATING

42- 01 MAGNETIC LEVEL INDICATOR

43- 00 FUEL TEMPERATURE INDICATION SYSTEM

43- 01 FUEL TEMPERATURE SENSOR

Page 59

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

28- FUEL

44- 00 FUEL-LOW-LEVEL WARNING SYSTEM

44- 01 LOW-LEVEL SENSOR

Page 60

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

29- HYDRAULIC POWER

00 00 HYDRAULIC POWER

00- 01 HYDRAULIC FLUID

00- 05 ELECTRICAL HARDWARE

10- 00 MAIN HYDRAULIC POWER

10- 01 HYDRAULIC CONTROL PANEL

10- 10 HYDRAULIC SYSTEM TUBING

10- 11 NO. 1 AND NO. 2 HYDRAULIC SYSTEM TUBING

10- 12 NO. 3 HYDRAULIC SYSTEM TUBING

10- 15 HYDRAULIC TUBING SUPPORT

11- 00 NO. 1 AND NO. 2 HYDRAULIC SYSTEMS

11- 01 ENGINE DRIVEN PUMP

11- 02 NO. 1 AND NO. 2 HYDRAULIC-SYSTEM ALTER-NATING-CURRENT-MOTOR DRIVEN PUMP

11- 03 POWER TRANSFER UNIT (PTU)

11- 04 NO. 1 AND NO. 2 HYDRAULIC SYSTEM FILTER MANIFOLD

11- 05 NO. 1 AND NO. 2 HYDRAULIC SYSTEM FILTER ELEMENT (PRESSURE, RETURN, CASE DRAIN)

11- 06 NO.1 AND NO. 2 HYDRAULIC SYSTEM CASE DRAIN FILTER MANIFOLD

11- 07 NO.1 AND NO. 2 HYDRAULIC SYSTEM CASE DRAIN FILTER MANIFOLD FILTER ELEMENT

11- 08 NO. 1 HYDRAULIC SYSTEM RESERVOIR


11- 10 NO.1 AND NO. 2 HYDRAULIC SYSTEM RESER-VOIR MANUAL RELIEF/BLEED/SAMPLE VALVE

11- 11 FIREWALL HYDRAULIC SHUTOFF VALVE

11- 12 NO. 1 AND NO. 2 HYDRAULIC SYSTEM ACCU-MULATOR

11- 13 HEAT EXCHANGER

11- 14 HEAT EXCHANGER THERMAL BYPASS VALVE

Page 61

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

29- HYDRAULIC POWER

11- 15 HEAT EXCHANGER CHECK VALVE (IN-LINE)

11- 16 NO. 1 AND NO. 2 HYDRAULIC SYSTEM ECOL-OGY BOTTLE

11- 17 POWER TRANSFER UNIT (PTU) SELECTOR VALVE

11- 18 POWER TRANSFER UNIT (PTU) CHECK VALVE (IN-LINE)

11- 19 THRUST REVERSER CHECK VALVE (IN-LINE)

11- 20 NO. 1 AND NO. 2 HYDRAULIC SYSTEM PRIOR-ITY VALVE

11- 21 NO. 1 AND NO. 2 HYDRAULIC SYSTEM ALTER-NATING CURRENT MOTOR PUMP (ACMP) SHOCK MOUNT

11- 22 FILTER MANIFOLD ENGINE-DRIVEN PUMP (EDP) CHECK VALVE

11- 23 NO.1 AND NO. 2 HYDRAULIC SYSTEM FILTER MANIFOLD ALTERNATING CURRENT MOTOR PUMP (ACMP) CHECK VALVE

11- 24 NO. 1 AND NO. 2 HYDRAULIC SYSTEM CASE-DRAIN CHECK VALVE

11- 25 CASE-DRAIN CHECK VALVE (IN-LINE)

11- 26 NO. 1 AND NO. 2 HYDRAULIC SYSTEM DUMP/THERMAL RELIEF VALVE

11- 27 ENGINE-DRIVEN PUMP (EDP) PRESSURE ATTENUATOR

11- 28 ENGINE-DRIVEN PUMP (EDP) SUCTION ATTENUATOR

11- 29 NO. 1 AND NO. 2 HYDRAULIC SYSTEM ALTER-NATING CURRENT MOTOR PUMP (ACMP) PRESSURE ATTENUATOR

11- 30 NO. 1 AND NO. 2 HYDRAULIC SYSTEM ACCU-MULATOR PRESSURE GAUGE

11- 31 ENGINE-DRIVEN-PUMP PRESSURE-LINE QUICK-DISCONNECT

Page 62

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

29- HYDRAULIC POWER

11- 32 ENGINE-DRIVEN-PUMP SUCTION-LINE QUICK-DISCONNECT

11- 33 ENGINE-DRIVEN-PUMP CASE-DRAIN QUICK-DISCONNECT

11- 34 THRUST-REVERSER-ACTUATION-SYSTEM SUPPLY-LINE QUICK-DISCONNECT

11- 35 THRUST-REVERSER-ACTUATION-SYSTEM RETURN-LINE QUICK-DISCONNECT

11- 36 HYDRAULIC PUMP CONTACTOR 1B (HPC 1B)


11- 38 HYDRAULIC FIREWALL SHUTOFF VALVE RELAY

11- 39 HYDRAULIC SHUTOFF THERMO SWITCH LATCHING RELAYS

11- 40 DIFFERENTIAL PRESSURE INDICATOR (DPI) PROTECTIVE CAP

11- 41 CASE DRAIN DIFFERENTIAL PRESSURE INDI-CATOR (DPI) PROTECTIVE CAP

12- 00 NO. 3 HYDRAULIC SYSTEM

12- 01 NO. 3 HYDRAULIC SYSTEM ALTERNATING CURRENT MOTOR PUMP (ACMP)

12- 02 NO. 3 HYDRAULIC SYSTEM FILTER MANIFOLD

12- 03 NO. 3 HYDRAULIC SYSTEM FILTER ELEMENT (PRESSURE, RETURN)

12- 04 NO. 3 HYDRAULIC SYSTEM CASE DRAIN FIL-TER MANIFOLD

12- 05 NO. 3 HYDRAULIC SYSTEM CASE DRAIN FIL-TER MANIFOLD FILTER ELEMENT


12- 07 NO. 3 HYDRAULIC SYSTEM RESERVOIR MAN-UAL RELIEF/BLEED/SAMPLE VALVE

Page 63

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

29- HYDRAULIC POWER

12- 08 NO. 3 HYDRAULIC SYSTEM ACCUMULATOR

12- 09 NO. 3 HYDRAULIC SYSTEM PRIORITY VALVE

12- 10 NO. 3 HYDRAULIC SYSTEM ECOLOGY BOTTLE

12- 11 NO. 3 HYDRAULIC SYSTEM ALTERNATING CURRENT MOTOR PUMP (ACMP) SHOCK MOUNT

12- 12 NO. 3 HYDRAULIC SYSTEM RETURN CHECK VALVE (IN-LINE)

12- 13 NO. 3 HYDRAULIC SYSTEM CASE-DRAIN CHECK VALVE

12- 14 ALTERNATING CURRENT MOTOR PUMP (ACMP) 3A CHECK VALVE

12- 15 ALTERNATING CURRENT MOTOR PUMP (ACMP) 3B CHECK VALVE

12- 16 NO. 3 HYDRAULIC-SYSTEM DUMP/THERMAL RELIEF VALVE

12- 17 NO. 3 HYDRAULIC SYSTEM ALTERNATING CURRENT MOTOR PUMP (ACMP) PRESSURE ATTENUATOR

12- 18 NO. 3 HYDRAULIC SYSTEM FILTER MANIFOLD CHARGING ACCUMULATOR PRESSURE GAUGE

12- 19 NO. 3 HYDRAULIC SYSTEM FLOW LIMITER VALVE

12- 20 NO. 3 HYDRAULIC SYSTEM PUMP UNLOADER VALVE

12- 21 HYDRAULIC PUMP CONTACTOR 3A (HPC 3A)


12- 23 HYDRAULIC AUTO SHUTOFF RELAY (K0228)

12- 24 NO. 3 DIFFERENTIAL PRESSURE INDICATOR (DPI) PROTECTIVE CAP

13- 00 HYDRAULIC GROUND SERVICE CONNEC-TIONS

Page 64

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

29- HYDRAULIC POWER

13- 01 PRESSURE QUICK DISCONNECT

13- 02 RETURN QUICK DISCONNECT

13- 03 FILL QUICK DISCONNECT

30- 00 INDICATING

31- 00 HYDRAULIC PRESSURE INDICATING SYSTEM

31- 01 HYDRAULIC PRESSURE TRANSDUCER

31- 02 POWER TRANSFER UNIT (PTU) PRESSURE SWITCH

31- 03 NO.1 AND NO. 2 HYDRAULIC SYSTEM ENGINE-DRIVEN PUMP (EDP) PRESSURE SWITCH

31- 04 NO. 1 AND NO. 2 HYDRAULIC-SYSTEM ALTER-NATING-CURRENT-MOTOR-PUMP PRESSURE-SWITCH

31- 05 NO. 3 HYDRAULIC SYSTEM ALTERNATING CURRENT MOTOR PUMP (ACMP 3A) PRES-SURE SWITCH

31- 06 NO. 3 HYDRAULIC-SYSTEM ALTERNATING-CURRENT-MOTOR-PUMP 3B PRESSURE-SWITCH

31- 07 DIFFERENTIAL PRESSURE INDICATOR

31- 08 DIFFERENTIAL PRESSURE INDICATOR (CASE DRAIN)

31- 09 CASE DRAIN DIFFERENTIAL PRESSURE INDI-CATOR (DPI) PROTECTIVE CAP

32- 00 HYDRAULIC FLUID QUANTITY INDICATING SYSTEM

32- 01 RESERVOIR QUANTITY INDICATOR

33- 00 HYDRAULIC TEMPERATURE INDICATING SYS-TEM

33- 01 HYDRAULIC TEMPERATURE TRANSDUCER

33- 02 HYDRAULIC TEMPERATURE SWITCH

Page 65

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

30- ICE AND RAIN PROTECTION

00 00 ICE AND RAIN PROTECTION

00- 01 ICE PROTECTION CONTROL PANEL

10- 00 AIRFOIL

11- 00 WING THERMAL ANTI-ICING SYSTEM

11- 01 WING ANTI-ICE VALVE

11- 02 WING ANTI-ICE BACKWALL-TEMPERATURE-SENSOR

11- 03 WING ANTI-ICE PRESSURE-SENSOR

11- 04 WING ANTI-ICE TELESCOPIC-TUBE

11- 05 WING ANTI-ICING PICCOLO-TUBES

11- 06 WING ANTI-ICE SLAT-HOSE

11- 07 WING ANTI-ICE DUCTS

11- 08 ANTI-ICING LEAK DETECTORS

11- 09 FENCE TUBE

11- 11 A-I WING VALVE OPEN STATUS EICAS MES-SAGE

11- 13 A-I WING NO DISPATCH CAUTION EICAS MES-SAGE

20- 00 AIR INTAKES

20- 01 INTERBULKHEAD ASSEMBLY

20- 02 ENGINE ANTI-ICE SHROUD LEAK-DETECTOR-SWITCH

21- 00 ENGINE THERMAL ANTI-ICING SYSTEM

21- 01 ENGINE ANTI-ICE VALVE

21- 02 ENGINE ANTI-ICE PRESSURE TRANSDUCER

21- 03 ENGINE ANTI-ICE DUCT

21- 04 ENGINE ANTI-ICE PICCOLO TUBE

21- 05 SWIRL NOZZLE

21- 06 MUSCLE LINE

Page 66

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


21- 07 INLET"D" DUCT

21- 09 A-I ENG VALVE OPEN STATUS EICAS MES-SAGE

30- 00 PITOT AND STATIC

31- 00 INTEGRATED PITOT/STATIC/AOA SENSOR HEATING SYSTEM

31- 01 PITOT/STATIC/AOA HEATER POWER

31- 02 P/S AOA 3 HEATER RELAY (K16)

31- 03 ADS PROBES HEATER PANEL

31- 04 ADS PROBES HTR RELAY

32- 00 STATIC PORT HEATING SYSTEM

33- 00 TAT SENSOR HEATING SYSTEM

40- 00 WINDOWS, WINDSHIELDS AND DOORS

40- 01 DRAINS

41- 00 WINDSHIELD WIPER SYSTEM

41- 01 MOTOR/CONVERTER

41- 02 SEALING GASKET ASSEMBLY

41- 03 ARM ASSEMBLY

41- 04 BLADE ASSEMBLY

41- 05 BLADE RUBBER ASSEMBLY

41- 06 WINDSHIELD WIPER CONTROL PANEL

42- 00 WINDSHIELD HEATING SYSTEM

42- 01 WINDSHIELD HEATER CONTROL-UNIT

42- 02 WHCU MODULE FEED RELAY

42- 03 WINDSHIELD SENSORS

43- 00 PASS DOOR HEATING SYSTEM

43- 01 DOOR SILL HEATER

43- 02 DOOR SILL HEATER (RICC-K4)

Page 67

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


44- 00 EFVS HEATING SYSTEM

44- 01 EFVS WINDOW HEATING

70- 00 WATER LINES

70- 01 WATER/WASTE HEATER (LICC-K11)

70- 02 FREEZE PROTECTION CONTROL UNIT

70- 03 WATER/WASTE FREEZE-PROTECTION PANEL

70- 04 WATER THERMOSTAT WITH WIRE

70- 05 WATER HEATER THERMOSTAT

70- 06 HOT BUS OPERATION RELAY

71- 00 POTABLE WATER HEATING SYSTEM

71- 01 POTABLE-WATER-LINE HEATER/SENSOR

71- 02 DRAIN MAST HEATER

71- 03 WATER-TANK BLANKET HEATER

71- 04 POTABLE WATER FILL/DRAIN NIPPLE HEATER

71- 05 POTABLE-WATER VALVE HEATER

71- 06 POTABLE-WATER-MANIFOLD T-FITTING HEATER/SENSOR

71- 07 POTABLE-WATER VALVE INSULATION

71- 08 POTABLE-WATER TANK INSULATION

71- 09 THERMOSTAT ASSEMBLY VALVE

71- 10 BIDET SHIELD BLANKET

72- 00 GRAY-WATER HEATING SYSTEM

72- 01 GRAY-WATER HOLDING TANK BLANKET HEATER

72- 02 GRAY-WATER LINE HEATER

72- 03 GRAY-WATER VALVE HEATER

72- 04 GRAY-WATER VALVE INSULATION

73- 01 FWD RECIRCULATING WSP VALVE HEATER

Page 68

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


74- 00 VACUUM WASTE HEATING-SYSTEM

74- 01 VACUUM WASTE-SERVICE-PANEL VALVE HEATER

74- 02 VACUUM WASTE-SERVICE-PANEL RINSE-NIP-PLE HEATER

74- 03 VACUUM WASTE TANK INSULATION

74- 04 VACUUM-WASTE-TANK BLANKET-HEATER/SENSOR

80- 00 DETECTION

81- 00 ICE DETECTOR SYSTEM

81- 01 ICE DETECTOR

82- 00 SUPER-LARGE-DROPLET ICE-DETECTOR SYSTEM

82- 01 SUPER-LARGE-DROPLET ICE-DETECTOR

Page 69

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

31- INDICATING / RECORDING SYSTEMS

00 00 INDICATING/RECORDING SYSTEMS

10- 00 INSTRUMENT & CONTROL PANELS

11- 00 MAIN INSTRUMENT PANEL - GENERAL

11- 01 MAIN INSTRUMENT PANEL

12- 00 GLARESHIELD PANEL - GENERAL

12- 01 GLARESHIELD PANEL

13- 00 LIGHTING CONTROL PANEL - GENERAL

13- 01 LIGHTING CONTROL PANEL

14- 00 CONTROL PEDESTAL - GENERAL

14- 01 CONTROL PEDESTAL

15- 00 OVERHEAD PANEL - GENERAL

15- 01 OVERHEAD PANEL

16- 00 CIRCUIT BREAKER PANEL - GENERAL

16- 01 LH CIRCUIT BREAKER PANEL

16- 02 RH CIRCUIT BREAKER PANEL

17- 00 MULTIFUNCTION PANELS

17- 01 GROUND PROXIMITY TERRAIN INHIBIT/EMER-GENCY PARKING BRAKE CONTROL PANEL

17- 02 GROUND PROXIMITY GLIDE SLOPE INHIBIT/LANDING GEAR WARNING INHIBIT CONTROL PANEL

17- 03 WATER DUMP/CABIN LIGHTS TIMER CONTROL PANEL

17- 04 AIR CONDITIONING/PNEUMATIC CONTROL PANEL

17- 05 COCKPIT MAINTENANCE PANEL

17- 06 WATER DUMP/ADS PROBES HEATER CON-TROL-PANEL

17- 07 WATER DUMP/CABIN LIGHTS TIMER/ADS PROBES HEATER CONTROL PANEL

Page 70

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


17- 08 CABIN LIGHTS TIMER/ADS PROBES HEATER CONTROL PANEL

17- 09 MAINTENANCE PANEL

20- 00 INDEPENDENT INSTRUMENTS

21- 00 CLOCK SYSTEM

21- 01 DIGITAL CLOCK

22- 00 CHRONOMETER SYSTEM

22- 01 CHRONOMETER PUSHBUTTON

30- 00 RECORDERS

31- 00 DIGITAL VOICE-DATA RECORDER (DVDR) SYS-TEM

31- 01 DVDR UNIT

31- 02 UNDERWATER LOCATOR BEACON

31- 03 TRIAXIAL ACCELEROMETER

31- 04 LOAD CELLS

31- 05 IMPACT SWITCH

31- 06 AREA MICROPHONE

31- 07 DVDR CONTROL PANEL

31- 08 RECORDER INDEPENDENT POWER SUPPLY

32- 00 QUICK ACCESS RECORDER SYSTEM

32- 01 QAR UNIT

40- 00 CENTRAL COMPUTERS

41- 00 MODULAR AVIONICS UNIT (MAU)

41- 01 MAU CABINET

41- 02 MAU POWER SUPPLY

41- 03 AIRCRAFT PERSONALITY MODULE (APM)

41- 04 NIC + PROCESSOR MODULE

41- 05 CONTROL I/O MODULE

41- 06 GENERIC I/O MODULE

Page 71

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


41- 07 CUSTOM I/O MODULE

41- 08 MAU CABINET FAN

41- 09 MAU AIR MANAGEMENT MODULE

41- 10 AIOP MODULE

41- 11 MAU 2 POWER SUPPLY RELAY

42- 00 ASCB BUS / STRAPS CONFIGURATION

42- 01 ASCB TERMINATOR

42- 02 ASCB BUS COUPLER

43- 00 GENERAL PURPOSE A429 BUS

50- 00 CENTRAL WARNING SYSTEMS

51- 00 AURAL WARNING FUNCTION

51- 01 TO CONFIG PANEL

52- 00 MASTER WARNING/CAUTION INDICATION

52- 01 MASTER WARNING/CAUTION PUSHBUTTONS/ANNUNCIATORS

53- 00 VISUAL WARNING FUNCTION (CAS)

60- 00 CENTRAL DISPLAY SYSTEMS

61- 00 DISPLAYS

61- 01 DISPLAY UNIT

61- 02 DISPLAY REVERSIONARY PANEL

61- 03 ADVANCED GRAPHICS MODULE (AGM)

61- 04 EICAS FULL PANEL

62- 00 CURSOR CONTROL SYSTEM

62- 01 CURSOR CONTROL DEVICE (CCD)

Page 72

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

32- LANDING GEAR

00 00 LANDING GEAR

00- 01 LANDING-GEAR ELECTRICAL-HARNESS AND WIRES

00- 03 LANDING-GEAR MECHANICAL SYSTEM

00- 05 LANDING-GEAR DOWNLOCK SAFETY-PINS

10- 00 MAIN-LANDING-GEAR AND DOORS

11- 00 MAIN-LANDING-GEAR

11- 01 MAIN-LANDING-GEAR SHOCK STRUT

11- 02 MAIN-LANDING-GEAR SPARE-SEAL ACTIVAT-ING-VALVE

11- 03 MAIN-LANDING-GEAR SHIMMY DAMPER

11- 04 MAIN-LANDING-GEAR SHOCK-STRUT SEALS

11- 05 MAIN-LANDING-GEAR SIDE STAY

11- 07 MAIN-LANDING-GEAR LOCKING STAY

11- 09 MAIN-LANDING-GEAR DOWNLOCK SPRING

11- 11 MAIN-LANDING-GEAR TORQUE LINK

11- 13 MAIN-LANDING-GEAR SLAVE LINK

12- 00 MAIN-LANDING-GEAR DOORS

12- 01 MAIN-LANDING-GEAR UPPER-DOOR LINKAGE

12- 02 MAIN-LANDING-GEAR UPPER DOOR

12- 03 MAIN-LANDING-GEAR MIDDLE-DOOR LINKAGE

12- 04 MAIN-LANDING-GEAR MIDDLE DOOR

12- 05 MAIN-LANDING-GEAR LOWER-DOOR LINKAGE

12- 06 MAIN-LANDING-GEAR LOWER DOOR

20- 00 NOSE-LANDING-GEAR AND DOORS

21- 00 NOSE-LANDING-GEAR

21- 01 NOSE-LANDING-GEAR SHOCK STRUT

21- 02 NOSE-LANDING-GEAR SPARE-SEAL ACTIVAT-ING-VALVE

21- 03 NOSE-LANDING-GEAR DRAG BRACE

Page 73

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

32- LANDING GEAR

21- 04 NOSE-LANDING-GEAR SHOCK-STRUT SEALS

21- 05 NOSE-LANDING-GEAR LOCKING STAY

21- 09 NOSE-LANDING-GEAR TORQUE LINK

21- 07 NOSE-LANDING-GEAR DOWNLOCK SPRING

22- 00 NOSE-LANDING-GEAR DOOR LINKAGE

22- 01 NOSE-LANDING-GEAR FORWARD-DOOR LINK-AGE

22- 02 NOSE-LANDING-GEAR FORWARD DOOR

22- 03 NOSE-LANDING-GEAR AFT-DOOR LINKAGE

22- 04 NOSE-LANDING-GEAR AFT DOOR

30- 00 EXTENSION AND RETRACTION

31- 00 MAIN-LANDING-GEAR EXTENSION/RETRAC-TION SYSTEM

31- 01 MAIN-LANDING-GEAR RETRACTION ACTUA-TOR

31- 03 MAIN-LANDING-GEAR UPLOCK

31- 05 MAIN-LANDING-GEAR DOWNLOCK-RELEASE ACTUATOR

32- 00 NOSE-LANDING-GEAR EXTENSION/RETRAC-TION SYSTEM

32- 01 NOSE-LANDING-GEAR RETRACTION ACTUA-TOR

32- 03 NOSE-LANDING-GEAR UPLOCK

32- 05 NOSE-LANDING-GEAR DOWNLOCK-RELEASE ACTUATOR

33- 00 LANDING-GEAR EXTENSION-AND-RETRAC-TION SYSTEM

33- 01 LANDING-GEAR CONTROL LEVER

33- 02 LANDING-GEAR CHECK VALVE

33- 03 LANDING-GEAR SELECTOR VALVE

33- 04 LANDING-GEAR SHUTOFF VALVE

Page 74

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

32- LANDING GEAR

34- 00 EMERGENCY-EXTENSION SYSTEM

34- 01 EMERGENCY-EXTENSION SELECTOR VALVE

34- 03 EMERGENCY-EXTENSION COCKPIT-QUAD-RANT/LEVER

34- 05 EMERGENCY-EXTENSION CENTER-FUSE-LAGE QUADRANT

34- 07 EMERGENCY-EXTENSION-SYSTEM NOSE-GEAR CABLE

34- 09 EMERGENCY-EXTENSION-SYSTEM CLOSED-LOOP CABLE

34- 11 EMERGENCY-EXTENSION-SYSTEM MAIN-GEAR CABLE

34- 17 EMERGENCY-EXTENSION SELECTOR-VALVE ROD

35- 00 EMERGENCY-EXTENSION ELECTRICAL-RELEASE SYSTEM

35- 01 EMERGENCY-EXTENSION OVERRIDE SWITCH

40- 00 WHEELS AND BRAKES

41- 00 MAIN BRAKE SYSTEM

41- 01 MAIN-BRAKE PEDAL TRANSDUCER

41- 02 MAIN-BRAKE AUTO BRAKE MODULE

41- 03 MAIN-BRAKE SHUTOFF VALVE

41- 04 MAIN-BRAKE AUTO-BRAKE SWITCH

41- 05 MAIN-BRAKE PRESSURE TRANSDUCER

41- 07 MAIN-BRAKE CONTROL MODULE

41- 09 MAIN-BRAKE CONTROL VALVE

41- 11 MAIN-BRAKE WHEEL-SPEED TRANSDUCER

41- 13 MAIN-BRAKE WHEEL-HUBCAP DRIVE

41- 15 MAIN-BRAKE HYDRAULIC FUSE

41- 17 MAIN-BRAKE CHECK VALVE

44- 00 EMERGENCY/PARKING BRAKE SYSTEM

Page 75

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

32- LANDING GEAR

44- 01 EMERGENCY/PARKING BRAKE VALVE

44- 03 EMERGENCY/PARKING BRAKE CABLE-AND-HANDLE

44- 05 EMERGENCY/PARKING BRAKE SHUTTLE-VALVE

44- 07 EMERGENCY/PARKING BRAKE HYDRAULIC-FUSE

44- 09 EMERGENCY/PARKING BRAKE PRESSURE-SWITCH

44- 11 EMERGENCY/PARKING BRAKE CHECK-VALVE

44- 13 EMERGENCY/PARKING BRAKE ACCUMULA-TOR

44- 15 EMERGENCY/PARKING BRAKE ACCUMULA-TOR-CHARGING-VALVE

44- 17 EMERGENCY/PARKING BRAKE-ACCUMULA-TOR PRESSURE-TRANSDUCER

44- 19 EMERGENCY/PARKING BRAKE INDICATION LIGHT

47- 00 BRAKE-TEMPERATURE MONITORING SYSTEM

47- 01 BRAKE TEMPERATURE SENSOR

49- 00 WHEELS, BRAKES AND TIRES

49- 01 NOSE WHEEL

49- 03 NOSE WHEEL TIRE

49- 05 MAIN WHEEL

49- 07 MAIN WHEEL TIRE

49- 11 BRAKE ASSEMBLY

49- 13 NOSE WHEEL SPINBRAKE

49- 15 WHEEL PRESSURE GAUGE

50- 00 STEERING

52- 00 STEERING HYDRAULIC SYSTEM

52- 01 STEERING MANIFOLD

Page 76

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

32- LANDING GEAR

52- 03 STEERING CYLINDER

53- 00 STEERING ELECTRIC/ELECTRONIC SYSTEM

53- 01 STEERING CONTROL MODULE

53- 03 STEERING PEDAL-SENSOR RVDT

53- 05 STEERING HANDWHEEL

53- 07 STEERING DISARMING SWITCH

53- 08 STEERING FEEDBACK ASSEMBLY

53- 09 STEERING FEEDBACK SENSOR

53- 13 STEERING OVERTRAVEL SENSOR

60- 00 POSITION AND WARNING

61- 00 LANDING-GEAR INDICATING SYSTEM

61- 01 PROXIMITY-SENSOR ELECTRONIC MODULE

61- 03 NOSE-LANDING-GEAR DOWNLOCK SENSOR

61- 05 NOSE-LANDING-GEAR UPLOCK SENSOR

61- 07 MAIN-LANDING-GEAR DOWNLOCK SENSOR

61- 09 MAIN-LANDING-GEAR UPLOCK SENSOR

61- 11 TOWING INDICATION LIGHT BOX

61- 13 NOSE-LANDING-GEAR DOOR-POSITION SEN-SOR

62- 00 AIR/GROUND (WEIGHT-ON-WHEELS) SYSTEM

62- 01 NOSE-LANDING-GEAR WEIGHT-ON-WHEELS SENSOR

62- 03 MAIN-LANDING-GEAR WEIGHT-ON-WHEELS SENSOR

63- 00 WARNING SYSTEM

Page 77

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

00 00 LIGHTS

10- 00 COCKPIT

10- 01 COCKPIT LIGHTS PANEL

11- 00 COCKPIT LIGHTS

11- 01 DOME LIGHT

11- 03 READING LIGHT

11- 05 CHART LIGHT

11- 07 DOME LIGHT CONTROL RELAY

12- 00 INSTRUMENTS AND PANEL LIGHTS

12- 01 MULTI-CHANNEL DIMMER

12- 03 ANNUNCIATORS TEST RELAY

15- 00 FLOOD/STORM LIGHTS

15- 01 FLOOD/STORM LIGHT ASSEMBLY

20- 00 PASSENGER CABIN

20- 01 LAVATORY CALL PANEL

20- 02 PSU PCB

20- 03 MID LAVATORY CALL PANEL

21- 00 CABIN LIGHTS

21- 01 RH CEILING LIGHT

21- 03 RH CEILING LIGHT AC BALLAST

21- 05 LH CEILING LIGHT

21- 07 LH CEILING LIGHT AC BALLAST

21- 09 LH CEILING LIGHT DC BALLAST

21- 11 RH SIDEWALL LIGHT

21- 13 RH SIDEWALL LIGHT BALLAST

21- 15 LH SIDEWALL LIGHT

21- 17 LH SIDEWALL LIGHT BALLAST

21- 18 FORWARD LH ENTRANCE-AREA SPOT LIGHT

Page 78

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

21- 19 FORWARD LH ENTRANCE-AREA FLUORES-CENT LIGHT

21- 20 FORWARD LH ENTRANCE-AREA LED ASSEM-BLY

21- 21 FORWARD RH ENTRANCE-AREA LIGHT

21- 23 FORWARD LH ENTRANCE-AREA LIGHT BAL-LAST

21- 25 FORWARD RH ENTRANCE-AREA LIGHT BAL-LAST

21- 27 AFT ENTRANCE-AREA LIGHT

21- 29 AFT ENTRANCE-AREA LIGHT BALLAST

21- 31 CEILING LIGHTS RELAY (LICC - K9)

21- 33 SIDEWALL LIGHTS RELAY (LICC - K10)

21- 35 CABIN LIGHTS RELAY

21- 37 EMERGENCY LIGHT DIM RELAY

21- 38 OPERATIONAL AREA LIGHTS

21- 39 CONSOLE LIGHTING PANEL

21- 41 CONSOLE LIGHTS RELAY

21- 42 CONSOLE SIDEWALL LIGHT PANEL

21- 43 COMM OFFICE SIDEWALL LIGHT RELAY

21- 44 LH OPERATIONAL AREA LIGHT SWITCH

21- 45 CREW ROOM SIDEWALL/CEILING LIGHT RELAY

21- 47 SPOTLIGHT

21- 49 SPOTLIGHT SWITCH

21- 51 PAX CABIN/VIP ROOM LT RELAY

21- 53 UPWASH/DOWNWASH LIGHT

21- 55 UPWASH LIGHT RELAY

21- 57 DOWNWASH LIGHT RELAY

21- 59 TABLE LIGHT

21- 61 TABLE LIGHT RELAY

Page 79

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

21- 63 SPOT/WASH/TABLE LIGHT SWITCH PANEL

21- 65 SPOT/WASH LIGHT SWITCH PANEL

21- 66 ACCENT LIGHT

21- 67 DOME LIGHT

22- 00 AIRSTAIR LIGHTS

23- 00 WARNING SIGNS

23- 01 PASSENGER INSTRUCTION SIGNS

23- 03 LAVATORY-OCCUPIED SIGN

23- 07 PASSENGER SIGNS PANEL

23- 11 PASSENGER WARNING SIGNS RELAY

24- 00 ATTENDANT CALL INDICATORS

24- 01 PSU ATTENDANT-CALL SWITCH AND INDICA-TOR LIGHT

24- 05 ZONAL ATTENDANT-CALL LIGHT

24- 07 FORWARD ATTENDANT-LIGHT INDICATOR PANEL

24- 09 AFT ATTENDANT-LIGHT INDICATOR PANEL

24- 11 ATTENDANT CALL AND PILOT RELAY

24- 13 PANEL CONTROL UNIT

24- 15 2 BUTTON PANEL CONTROL UNIT

24- 17 BLUE MARKER INDICATION LIGHT ASSEMBLY

25- 00 READING LIGHTS

25- 01 PASSENGER READING-LIGHT

25- 03 PASSENGER READING-LIGHT SWITCH

25- 05 ATTENDANT READING-LIGHT

25- 13 FORWARD LH ATTENDANT READING-LIGHT SWITCH

25- 15 FORWARD RH ATTENDANT READING-LIGHT SWITCH

Page 80

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

25- 17 AFT LH ATTENDANT READING-LIGHT SWITCH

25- 19 AFT RH ATTENDANT READING-LIGHT SWITCH

25- 21 LED READING LIGHTS

26- 00 COURTESY LIGHTS

26- 01 FORWARD PASSENGER-ENTRANCE COUR-TESY-LIGHT

26- 03 AFT PASSENGER-ENTRANCE COURTESY-LIGHT

26- 05 FORWARD SERVICE-ENTRANCE COURTESY-LIGHT

26- 07 AFT SERVICE-ENTRANCE COURTESY-LIGHT

26- 09 FORWARD COURTESY SWITCH PANEL

26- 11 AFT COURTESY SWITCH PANEL

26- 13 FORWARD PASSENGER-DOOR COURTESY-LIGHT MICROSWITCH

26- 15 AFT PASSENGER-DOOR COURTESY-LIGHT MICROSWITCH

26- 17 AIRSTAIR COURTESY-LIGHT

26- 19 COCKPIT STEP COURTESY-LIGHT

26- 21 COURTESY LIGHTS TIMER RELAY

26- 23 TIMER RESET RELAY

26- 25 AIRSTAIR LIGHT RELAY

26- 27 GROUND SERVICE BUS RELAY

27- 00 WARDROBE/STOWAGE LIGHT

27- 01 WARDROBE/STOWAGE LIGHT

27- 03 WARDROBE/STOWAGE LIGHT SWITCH

27- 04 WARDROBE LED LIGHT

28- 00 LAVATORY LIGHTS

28- 01 LAVATORY DOME-LIGHT

28- 03 LAVATORY FLUORESCENT-LIGHT

28- 05 LAVATORY BALLAST

Page 81

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

28- 07 LAVATORY DOOR-LATCH ENGAGE-MICRO-SWITCH

28- 09 LAVATORY MANUAL SWITCH

28- 11 LAVATORY PCB

28- 13 MID LAVATORY MIRROR LIGHTS

28- 15 MID LAVATORY CEILING LIGHT

28- 17 MID LAVATORY READING LIGHT

28- 19 MID LAVATORY VANITY LIGHT

28- 21 MID LAVATORY LIGHTS SWITCH PANEL

28- 23 MID LAVATORY LIGHTS RELAY

28- 25 LAVATORY CEILING LIGHT

28- 26 LAVATORY READING LIGHT

28- 27 LAVATORY VANITY LIGHT

28- 28 LAVATORY MIRROR LIGHT

28- 29 LAVATORY-LIGHT SWITCH PANEL

28- 30 LAVATORY DOWNWASH LIGHT

29- 00 GALLEY LIGHTS

29- 01 FORWARD GALLEY WORK-LIGHT ASSEMBLY

29 02 GALLEY SPOTLIGHT

29- 03 GALLEY LED-STRIP LIGHT

29- 04 GALLEY SWITCH PANEL

29- 07 AFT GALLEY WORK-LIGHT ASSEMBLY

30- 00 CARGO AND SERVICE COMPARTMENTS

31- 00 CARGO COMPARTMENT LIGHTS

31- 01 FORWARD CARGO LIGHTS

31- 03 AFT CARGO LIGHTS

31- 04 AFT-CARGO-COMPARTMENT IFE-RACK LIGHT

31- 05 FORWARD LOADING-LIGHT

31- 07 AFT LOADING-LIGHT

31- 09 FORWARD CARGO DOOR MICROSWITCH

Page 82

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

31- 11 AFT-CARGO-DOOR MICROSWITCH

31- 13 FORWARD CARGO-COMPARTMENT MANUAL SWITCH

31- 15 AFT CARGO-COMPARTMENT MANUAL SWITCH

31- 17 CARGO COMPARTMENT LIGHT RELAY

32- 00 SERVICE COMPARTMENT LIGHT

32- 01 SERVICE COMPARTMENT LIGHT ASSEMBLY

32- 03 SERVICE COMPARTMENT LIGHT SWITCH

32- 05 SERVICE COMPARTMENT LIGHT HARNESS

33- 00 BAGGAGE COMPARTMENT LIGHT

33- 01 BAGGAGE COMPARTMENT SPOTLIGHT

33- 02 BAGGAGE-COMPARTMENT LIGHT RELAY

33- 03 BAGGAGE-COMPARTMENT LIGHT-SWITCH PANEL

33- 04 BAGGAGE-COMPARTMENT COURTESY-LIGHT PANEL

40- 00 EXTERNAL LIGHTS

40- 01 EXTERNAL LIGHTS PANEL

40- 03 AFT NAVIGATION/STROBE-LIGHT ASSEMBLY

40- 05 LANDING/TAXI LIGHT GASKETS

41- 00 LANDING LIGHTS

41- 01 WING-ROOT LANDING-LIGHT

41- 03 NOSE-LANDING-GEAR LANDING-LIGHT

41- 05 WING-ROOT LANDING-LIGHT TRANSFORMER

41- 07 NOSE-LANDING-GEAR LANDING-LIGHT TRANSFORMER

42- 00 TAXI LIGHTS

42- 01 WING-ROOT TAXI-LIGHT

42- 03 NOSE-LANDING-GEAR TAXI-LIGHT

42- 05 WING-ROOT TAXI-LIGHT TRANSFORMER

Page 83

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

42- 07 NOSE-LANDING-GEAR TAXI-LIGHT TRANS-FORMER

43- 00 NAVIGATION LIGHT

43- 01 FORWARD MAIN/STANDBY NAVIGATION-LIGHT

43- 03 AFT MAIN/STANDBY NAVIGATION-LIGHT

43- 05 NAVIGATION LIGHT TRANSFORMER

44- 00 INSPECTION LIGHT

44- 01 WING INSPECTION-LIGHT

45- 00 RED BEACON LIGHT

45- 01 RED-BEACON-LIGHT

45- 03 RED-BEACON POWER SUPPLY

46- 00 LOGOTYPE LIGHT

46- 01 LOGOTYPE-LIGHT

47- 00 STROBE LIGHT

47- 01 FORWARD STROBE-LIGHT ASSEMBLY

47- 05 STROBE-LIGHT POWER SUPPLY

50- 00 EMERGENCY LIGHTING

50- 01 EMERGENCY-LIGHT POWER UNIT

50- 03 COCKPIT EMERGENCY-LIGHT ASSEMBLY

50- 05 FORWARD LH PASSAGEWAY EMERGENCY-LIGHT

50- 07 FORWARD RH PASSAGEWAY EMERGENCY-LIGHT

50- 09 AFT LH PASSAGEWAY EMERGENCY-LIGHT

50- 11 AFT RH PASSAGEWAY EMERGENCY-LIGHT

50- 13 CABIN EMERGENCY-LIGHT ASSEMBLY

50- 15 EXIT IDENTIFIER SIGNS

50- 17 EXIT MARKING SIGNS

50- 19 EXIT LOCATOR SIGNS

Page 84

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

33- LIGHTS

50- 21 PHOTOLUMINESCENT INDICATOR STRIP LIGHT

50- 23 SWITCH EMERGENCY LIGHTS

50- 25 EXTERNAL EMERGENCY LIGHTS

50- 27 LED FLOOR PROXIMITY EMERGENCY ESCAPE PATH MARKING

51- 00 FLASHLIGHT

51- 01 FLASHLIGHT ASSEMBLY

Page 85

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

34- NAVIGATION

00 00 NAVIGATION

01- 00 NAVIGATION ANTENNAS

02- 00 MODULAR RADIO CABINET SYSTEM

02- 01 MODULAR RADIO CABINET

02- 02 MRC AIRCRAFT PERSONALITY MODULE 2

02- 03 MRC REAR FAN COVER

02- 04 NETWORK INTERFACE MODULE (NIM)

02- 05 MINI MODULAR RADIO CABINET (MMRC)

10- 00 FLIGHT ENVIRONMENT DATA

11- 00 INTEGRATED ELECTRONIC STANDBY SYSTEM

11- 01 INTEGRATED ELECTRONIC STANDBY UNIT

11- 04 STBY PWR SUPPLY ENABLE RELAY

13- 00 INTEGRATED PITOT/STATIC/AOA SYSTEM

13- 01 INTEGRATED PITOT/STATIC/AOA SENSOR

15- 00 ADC SYSTEM

15- 01 AIR DATA APPLICATION FUNCTION

15- 02 TAT SENSOR

20- 00 ATTITUDE & DIRECTION

23- 00 STANDBY COMPASS SYSTEM

23- 01 STANDBY COMPASS UNIT

25- 00 HEAD-UP GUIDANCE SYSTEM

25- 01 HGS COMPUTER

25- 03 HGS OVERHEAD UNIT (OHU)

25- 04 HGS COMBINER

25- 05 HGS COMPUTER FAN

25- 06 HGS COMPUTER MOUNTING TRAY

25- 07 HGS COMPUTER EMI FILTER

26- 00 INERTIAL REFERENCE SYSTEM

26- 01 MICRO INERTIAL REFERENCE UNIT

Page 86

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

34- NAVIGATION

26- 02 MICRO IRU AIRCRAFT PERSONALITY MODULE

26- 03 MICRO IRU MOUNTING TRAY

27- 00 ENHANCED FLIGHT VISION SYSTEM

30- 00 LANDING AND TAXIING AIDS

31- 00 RADAR ALTIMETER SYSTEM

31- 01 RADAR ALTIMETER UNIT

31- 02 RADAR ALTIMETER ANTENNA

31- 03 RADAR ALTIMETER CONFIGURATION MODULE

32- 00 VHF NAV

32- 01 VHF NAV MODULE

32- 03 VOR/LOC ANTENNA

32- 04 MARKER BEACON ANTENNA

32- 05 MARKER BEACON ANTENNA SPLITTER

32- 06 GLIDE SLOPE ANTENNA

32- 07 NAVCOM 3 MODULE

32- 09 VOR/LOC ANTENNA COUPLER

40- 00 INDEPENDENT POSITION DETERMINING

41- 00 EGPWS/WINDSHEAR

41- 01 EGPWS/WINDSHEAR MODULE

41- 03 GROUND PROXIMITY FLAP WARNING OVER-RIDE CONTROL PANEL

41- 05 STEEP APPROACH CONTROL PANEL

41- 06 RAAS INHIBIT CONTROL PANEL

42- 00 WEATHER RADAR SYSTEM

42- 01 WEATHER RADAR RECEIVER/TRANSMITTER ANTENNA

42- 02 SATELLITE DIGITAL WEATHER ANTENNA

43- 00 TRAFFIC ALERT AND COLLISION AVOIDANCE SYSTEM

43- 01 TCAS COMPUTER

Page 87

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

34- NAVIGATION

43- 02 TCAS TOP DIRECTIONAL ANTENNA

43- 03 TCAS BOTTOM OMNIDIRECTIONAL ANTENNA

43- 04 TCAS MUTE RELAY

44- 00 LIGHTNING SENSOR SYSTEM

44- 01 LIGHTNING SENSOR UNIT

44- 02 LIGHTNING ANTENNA

50- 00 DEPENDENT POSITION DETERMINING

51- 00 DISTANCE MEASURING EQUIPMENT

51- 01 DME MODULE

51- 02 DME ANTENNA

52- 00 TRANSPONDER SYSTEM

52- 01 TRANSPONDER MODULE

52- 02 TRANSPONDER TOP/BOTTOM ANTENNAS

53- 00 AUTOMATIC DIRECTION FINDER SYSTEM

53- 01 ADF MODULE

53- 02 ADF ANTENNA

56- 00 GLOBAL POSITIONING SYSTEM

56- 01 GPS RECEIVER MODULE

56- 02 GPS ANTENNA

60- 00 FLIGHT MANAGEMENT COMPUTING

61- 00 FLIGHT MANAGEMENT SYSTEM

61- 02 MULTIFUNCTION CONTROL DISPLAY UNIT

Page 88

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

35- OXYGEN

00 00 OXYGEN

10- 00 CREW OXYGEN

10- 06 OXYGEN-CYLINDER ACCESS PANEL

10- 07 OXYGEN CYLINDER

10- 08 CHARGING VALVE

10- 09 OXYGEN-MASK STOWAGE BOX

10- 10 OXYGEN MASK

11- 00 CREW CONTROL/INDICATING

11- 01 PRESSURE GAUGE

11- 02 PRESSURE TRANSDUCER

11- 03 OXYGEN-CYLINDER OVERBOARD-DIS-CHARGE INDICATOR

11- 04 OXYGEN-CYLINDER-BAY TEMPERATURE SEN-SOR

12- 00 OXYGEN-CYLINDER-BAY VENTILATION

12- 01 FLAP VALVE

12- 02 NOISE SUPPRESSOR

20- 00 PASSENGER CABIN OXYGEN

20- 01 CHEMICAL OXYGEN GENERATOR

20- 02 OXYGEN-BOX-DOOR ELECTRICAL LATCHES

20- 03 OXYGEN-BOX-LANYARDS

20- 04 PASSENGER-CABIN OXYGEN MASK

20- 05 OXYGEN BOX

20- 07 GALLEY AND FLIGHT ATTENDENT OXYGEN BOX

21- 00 PASSENGER CONTROL/INDICATING

21- 01 PASSENGER OXYGEN CONTROL-PANEL

21- 02 ALTITUDE PRESSURE SWITCH

Page 89

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

35- OXYGEN

22- 00 PASSENGER CABIN GASEOUS OXYGEN SYS-TEM

22- 01 SEQUENCE REGULATOR VALVE

22- 02 PULSE LATCHING VALVE

22- 03 TEMPERATURE/PRESSURE TRANSDUCER

22- 04 LOW PRESSURE SWITCH

22- 05 PASSENGER OXYGEN CYLINDER

22- 06 PASSENGER OXYGEN-CYLINDER OVER-BOARD-DISCHARGE INDICATOR

30- 00 PORTABLE OXYGEN

30- 01 PORTABLE OXYGEN CYLINDER

30- 02 CONTINUOUS FLOW MASK

30- 03 PROTECTIVE BREATHING EQUIPMENT

Page 90

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

36- PNEUMATIC

00 00 PNEUMATIC

10- 00 AIR BLEED DISTRIBUTION

10- 01 CROSS-BLEED VALVE

11- 00 ENGINE PNEUMATIC BLEED SYSTEM

11- 01 HIGH-STAGE BLEED VALVE

11- 02 LOW-STAGE BLEED CHECK-VALVE

11- 03 NACELLE PRESSURE REGULATING SHUTOFF VALVES

11- 04 ENGINE BLEED LINES

11- 05 NACELLE PRESSURE-REGULATING SHUTOFF-VALVE FILTER

11- 06 TORQUE MOTOR CONTROLLER

11- 08 PRECOOLER

11- 09 FAN AIR VALVE

11 10 FAN AIR VALVE SERVO-LINE

11- 11 RAM-AIR CHECK VALVE

11- 12 FAN-AIR DISTRIBUTION DOOR / ACTUATOR

11- 13 FAN AIR INLET DOOR ACTUATOR RELAY

11- 14 FIXED SCOOP SLEEVE

12- 00 APU-PNEUMATIC BLEED SYSTEM

12- 01 APU-BLEED SHUTOFF VALVE

12- 02 APU-BLEED CHECK VALVE

12- 03 APU BLEED LINES

13- 00 GROUND AIR SUPPLY

13- 01 HP GROUND CONNECTION

14- 00 CONTROL

14- 01 BLEED OVERPRESSURE SWITCH

14- 02 BLEED PRESSURE SENSOR

Page 91

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

36- PNEUMATIC

14- 03 BLEED TEMPERATURE SENSOR

14- 05 BLEED OVERPRESSURE AUX RELAY

14 06 BLEED SLAT-SUPPLY TEMPERATURE-SENSOR

14- 07 BLEED OVERPRESSURE HPSOV AUX RELAY

14- 08 BLEED OVERPRESSURE HPSOV SWITCH

15- 00 WATER TANK PRESSURIZATION

15- 01 WATER-TANK PRESSURIZATION LINE

20- 00 INDICATING

20- 01 LEAK-DETECTOR CERAMIC PIN

21- 00 ENGINE PNEUMATIC INDICATING

21- 02 BLEED LINES LEAK DETECTORS

22- 00 APU PNEUMATIC INDICATING

22- 01 APU LINE LEAK DETECTORS

30- 00 OZONE CONVERTERS

Page 92

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

38- WATER AND WASTE

00 00 WATER/WASTE

00- 01 WATER & WASTE SYSTEM CONTROLLER

00- 02 VALVE CONTROL UNIT

00- 03 SUMP ASSEMBLY

00- 04 WATER & WASTE CONTROL UNIT

10- 00 POTABLE WATER

11- 00 STORAGE AND DISTRIBUTION

11- 01 WATER TANK

11- 02 WATER FILTER

11- 03 WATER LINES

11- 04 FILL/DRAIN VALVE

11- 05 FILL/DRAIN SWITCH

11- 06 FILL/DRAIN NIPPLE

11- 07 FAUCETS

11- 08 MANUAL SHUTOFF VALVES

11- 09 FORWARD DRAIN VALVE

11- 12 SERVICE PANEL DOOR SWITCH

11- 14 AFT DRAIN VALVE

11- 15 GALLEY SPIGOTS

11- 16 COCKPIT IN-FLIGHT DRAINAGE PANEL

11- 17 POTABLE-WATER-TANK INSULATION

11- 18 POTABLE-WATER VALVE INSULATION

11- 19 OVERFLOW VALVE

11- 20 MOTORIZED SHUTOFF VALVE

11- 21 INFRA-RED SENSOR

11- 22 SHOWER SYSTEM ASSEMBLY

11- 23 HAND BIDET SPRAYER

11- 24 HAND-BIDET DECK VALVE

12- 00 WATER HEATER SYSTEM

12- 01 WATER HEATER

13- 00 WATER TANK QUANTITY INDICATION

13- 02 WATER TANK LEVEL SENSOR

Page 93

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

38- WATER AND WASTE

13- 04 SERVICE PANEL INDICATION

30- 00 WASTE DISPOSAL

31- 00 GRAY WATER - DRAIN SYSTEM

31- 01 GRAY-WATER TANK UNIT

31- 02 DRAIN LINE

31- 03 DRAIN MASTS

31- 04 AUTO DRAIN VALVE

31- 05 WASH BASIN SINK DRAIN

31- 06 GRAY WATER TANK INSULATION

31- 07 DRAIN PORT

31- 08 GRAY-WATER DRAIN VALVE

31- 09 GRAY-WATER GROUND VALVE

31- 10 DRAIN STRAINER

32- 00 VACUUM WASTE SYSTEM (VWS)

32- 02 VWS TOILET ASSEMBLY

32- 03 VWS FLUSH SWITCH

32- 05 OVERBOARD AIR EXHAUST LINE

32- 06 WATER SEPARATOR

32- 07 VACUUM WASTE SYSTEM TANK

32- 08 VWS RINSE NOZZLE

32- 09 VACUUM GENERATOR

32- 10 VWS CHECK VALVE

32- 11 VWS TANK DRAIN VALVE

32- 12 VWS SERVICE-PANEL DRAIN-VALVE

32- 13 VACUUM WASTE SYSTEM DRAIN LINES

32- 14 WASTE DRAIN CABLE

32- 15 VACUUM WASTE SYSTEM LINES

32- 16 VWS RINSE NIPPLE

32- 17 VWS RINSE LINE

32- 18 VWS SERVICE PANEL SWITCH

32- 20 WASTE-TANK LEVEL-SENSORS

32- 21 VWS MOTOR STARTING RELAY

Page 94

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

38- WATER AND WASTE

33- 00 RECIRCULATION TOILET SYSTEM (RTS)

33- 01 RECIRCULATION TOILET ASSEMBLY

33- 02 RTS FLUSH SWITCH

33- 03 RTS WASTE DRAIN VALVE

33- 04 RTS WASTE DRAIN VLV CONTROL CABLE

33- 05 RTS WASTE DRAIN LINE

33- 06 RTS SERVICE PANEL DRAIN VALVE

33- 07 RTS RINSE VALVE

33- 08 RTS VENT LINE

33- 09 RTS RINSE LINE

34- 00 BIDET SYSTEM

34- 01 BIDET NOZZLE

34- 02 BIDET WATER HEATER

34- 03 BIDET-WATER-HEATER CONTROLLER

34- 04 BIDET TIMER MODULE

34- 05 BIDET-WATER-CONTROL VALVE

34- 06 BIDET FLUSH SWITCH

35- 00 TOILET-FLOOR-DRAIN SYSTEM

35- 01 TOILET-FLOOR DRAIN

35- 02 TOILET-FLOOR-DRAIN VALVE

35- 03 TOILET-FLOOR-DRAIN VALVE CONTROLLER

36- 00 VENTING SYSTEM

36- 01 DRAIN MUFFLER

40- 00 AIR SUPPLY

41- 00 AIR MANIFOLD

41- 01 WATER TANK PRESSURE SWITCH

41- 02 AIR COMPRESSOR

41- 03 AIR FILTER

41- 04 AIR SUPPLY HOSES

41- 05 WATER-TANK VENT VALVE

Page 95

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMS

00 00 CABIN SYSTEMS

10- 00 CABIN CORE SYSTEM

11- 00 PASSENGER ADDRESS AND CABIN INTER-PHONE SYSTEM

11- 01 PASSENGER ADDRESS/CABIN INTERPHONE CONTROLLER

11- 02 PASSENGER ADDRESS CONTROL PANEL

11- 03 PACIC CONFIGURATION CONNECTOR

12- 00 CABIN LOUDSPEAKERS

12- 01 PASSENGER LOUDSPEAKERS

12- 02 LAVATORY LOUDSPEAKERS

12- 03 CEILING PANEL LOUDSPEAKERS

13- 00 CABIN INTERPHONE

13- 01 FLIGHT-ATTENDANT HANDSET/CRADLE

13- 02 HANDSET CRADLE SHROUD

20- 00 IN-FLIGHT ENTERTAINMENT SYSTEM

21- 00 AMBIENT MUSIC SYSTEM

21- 01 CD PLAYER

21- 02 PRA/MP3 PLAYER

21- 03 CD/DVD PLAYER

22- 00 ENTERTAINMENT SYSTEM DISTRIBUTION

22- 01 ENTERTAINMENT SYSTEM SPLITTER

22- 02 ENTERTAINMENT SYSTEM AMPLIFIER

22- 03 ENTERTAINMENT SYSTEM COMBINER

22- 04 ENTERTAINMENT-SYSTEM MULTI-CHANNEL RECEIVER MODULATOR (MRM)

22- 05 ENTERTAINMENT-SYSTEM VIDEO SERVER UNIT (VSU)

22- 06 ENTERTAINMENT-SYSTEM RF DISTRIBUTION AMPLIFIER (RDA)

Page 96

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMS

22- 07 ENTERTAINMENT-SYSTEM VIDEO-MODULA-TOR UNIT (VMU)

22- 08 ENTERTAINMENT-SYSTEM VIDEO-DISPLAY UNIT (VDU)

22- 09 ENTERTAINMENT-SYSTEM CREDIT-CARD READER (CCR)

22- 10 ENTERTAINMENT-SYSTEM SEAT ELEC-TRONIC BOX

22- 11 ENTERTAINMENT-SYSTEM PASSENGER-CON-TROL UNIT

22- 12 ENTERTAINMENT-SYSTEM AUDIO JACK

22- 13 ENTERTAINMENT-SYSTEM FLIGHT-ATTEN-DANT CONTROL PANEL

22- 14 ENTERTAINMENT-SYSTEM FLIGHT-ATTEN-DANT RESET SWITCH

22- 15 ENTERTAINMENT-SYSTEM MAINTENANCE/MONITORING PANEL

22- 16 ENTERTAINMENT-SYSTEM BUFFER AMPLI-FIER

22- 18 ENTERTAINMENT-SYSTEM VARISTOR

22- 19 IFE/CSS POWER CONTROL PANEL

22- 20 PC POWER/IFE CONTROL PANEL

22- 21 ENTERTAINMENT-SYSTEM ETHERNET PORT - RJ-45

22- 22 ENTERTAINMENT-SYSTEM USB PORT

22- 23 ENTERTAINMENT-SYSTEM ETHERNET SWITCHING UNIT (ESU)

22- 24 ENTERTAINMENT-SYSTEM TRANSFORMER RECTIFIER UNIT (TRU)

22- 25 ENTERTAINMENT-SYSTEM WALL JUNCTION BOX (WJB)

22- 26 ENTERTAINMENT-SYSTEM DIGITAL SERVER UNIT (DSU)

Page 97

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMS

22- 27 ENTERTAINMENT-SYSTEM ARINC 429 SERIAL CONVERTER

22- 28 ENTERTAINMENT-SYSTEM PASSENGER-ADDRESS MATCHING NETWORK

22- 29 ENTERTAINMENT SYSTEM CMT INTERFACE PANEL

22- 30 IFE POWER CONTROL PANEL

22- 31 ENTERTAINMENT-SYSTEM SEAT POWER-MODULE

22- 32 ENTERTAINMENT-SYSTEM FILE SERVER

22- 33 ENTERTAINMENT SYSTEM CONTROLLER

22- 34 ENTERTAINMENT-SYSTEM MAIN POWER-UNIT

22- 35 ENTERTAINMENT-SYSTEM MANAGEMENT PANEL

22- 36 ENTERTAINMENT-SYSTEM CONTENT SERVER AND SYSTEM CONTROLLER (CSSC)

22- 37 ENTERTAINMENT-SYSTEM DIGITAL SATEL-LITE CONCENTRATOR AND DISTRIBUTOR (DSCD)

22- 38 ENTERTAINMENT-SYSTEM ZONE ETHERNET BOX (ZEB)

22- 39 FILE SERVER (FS)

22- 40 SYSTEM CONTROLLER - AUDIO (SC-A)

22- 41 ADVANCED MASTER CONTROL UNIT (AMCU)

22- 42 CREW PANEL (CP)

22- 43 DIRECT CURRENT - SEAT ELECTRONIC BOX (DC-SEB)

22- 44 DIRECT CURRENT - ZONE TERMINATOR (DC-ZT)

22- 45 SEAT POWER MODULE (SPM)

22- 46 SMART DISPLAY UNIT (SDU)

22- 47 AUDIO JACK

Page 98

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMS

22- 48 UNIVERSAL SERIAL BUS (USB) PORT

22- 49 MAGNET SWITCH

22- 50 ENTERTAINMENT-SYSTEM VIDEO MONITOR

22- 51 ENTERTAINMENT-SYSTEM AIRSHOW UNIT

22- 52 ENTERTAINMENT SYSTEM SUBWOOFER

22- 53 ENTERTAINMENT-SYSTEM REMOTE CON-TROLS

22- 54 ENTERTAINMENT-SYSTEM AUDIO AMPLIFIER

22- 55 ENTERTAINMENT-SYSTEM AUDIO/VIDEO SWITCH

22- 56 ENTERTAINMENT-SYSTEM POWER SWITCH-ING MODULE

22- 57 ENTERTAINMENT-SYSTEM DATA BUS CON-VERTER

22- 58 ENTERTAINMENT-SYSTEM DATA BUS REPEATER

22- 59 ENTERTAINMENT SYSTEM SERIALIZER

22- 60 ENTERTAINMENT-SYSTEM CD PLAYER

22- 61 ENTERTAINMENT-SYSTEM DVD PLAYER

22- 62 ENTERTAINMENT-SYSTEM AREA CONTROL PANEL

22- 63 ENTERTAINMENT-SYSTEM AUDIO VIDEO INPUT

22- 64 ENTERTAINMENT-SYSTEM BRIEFER AMPLI-FIER

22- 65 ENTERTAINMENT-SYSTEM AIRSHOW FLIGHT-DECK CONTROLLER

22- 67 SEB/VDU INTERFACE HARNESS

23- 00 DIRECT-BROADCAST-SATELLITE TV SYSTEM

23- 01 DBS TV ANTENNA-CONTROL-SUBSYSTEM (ACS) UNIT

Page 99

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMSv

23- 02 DBS TV INTERMEDIATE FREQUENCY INTER-FACE (IFI)

23- 03 DBS TV GPS ANTENNA

23- 04 DBS TV ANTENNA

23- 05 DBS TV VOLTAGE SUPPRESSOR

23- 06 DBS TV SYSTEM HARNESS (W1506 AND W1512)

24- 00 SATELLITE DIGITAL RADIO SYSTEM

24- 01 SATELLITE DIGITAL RADIO RECEIVER UNIT

24- 02 SATELLITE DIGITAL RADIO ANTENNA

25- 00 FLIGHT INFORMATION SYSTEM

26- 00 PRIVATE ENTERTAINMENT SYSTEM

26- 01 DVD PLAYER

26- 02 23" MONITOR

26- 03 3.5" COLOR TOUCH SCREEN CONTROL PANEL

26- 04 INFRA-RED DETECTOR

26- 05 EXTERNAL INFRA-RED SENSOR

26- 06 REMOTE CONTROL

26- 07 VGA PORT

26- 08 VGA SPLITTER

26- 09 SUB-WOOFER

26- 10 DIGITAL AUDIO AMPLIFIER

26- 11 STEREO SPEAKER

26- 12 DC-DC CONVERTER

26- 13 USB PORT

26- 14 AUDIO/VIDEO DC POWER RELAY

30- 00 EXTERNAL COMMUNICATION SYSTEM

31- 00 HIGH SPEED DATA (HSD) SYSTEM

31- 01 HIGH GAIN ANTENNA (HGA)

31- 02 DIPLEXER/NOISE AMPLIFIER (D/LNA)

Page 100

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

44- CABIN SYSTEMSv

31- 03 SATELLITE DATA UNIT (SDU)

31- 04 SATELLITE DATA UNIT CONFIGURATION MOD-ULE (SCM)

31- 05 AIRBORNE TELEPHONY SERVER (ATS)

31- 06 CABIN ACCESS POINT (CAP)

31- 07 WI-FI ANTENNAS

31- 08 HIGH-SPEED-DATA (HSD) MAINTENANCE PANEL

31- 09 CABIN NETWORK DISTRIBUTION UNIT (CNDU)

31- 13 RJ-45 ETHERNET PORT

31- 15 HIGH-SPEED-DATA (HSD) CONTROL PANEL

50- 00 CABIN MONITORING SYSTEM

51- 00 CABIN SURVEILLANCE SYSTEM

51- 01 CSS VIDEO CAMERA

51- 02 CSS CAMERA CONTROL UNIT

51- 03 CSS MONITOR UNIT

51- 04 CSS CAMERA SUPPORT

51- 05 CSS VIDEO CAMERA COVER

51- 06 CSS MONITOR UNIT SUPPORT

51- 07 VIDEO SURVEILLANCE CONTROL PANEL

51- 08 CABIN OUTLET/VSS CONTROL PANEL

Page 101

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

45- CENTRAL MAINTENANCE SYSTEM (CMS)

00 00 CENTRAL MAINTENANCE SYSTEM

45- 00 CENTRAL MAINTENANCE SYSTEM

45- 01 CENTRAL MAINTENANCE COMPUTER MOD-ULE

45- 02 LAN PORT

45- 03 DATA-LOADER MANAGEMENT UNIT (DMU)

45- 04 DATA BASE MODULE

Page 102

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

46- INFORMATION SYSTEMS

00 00 INFORMATION SYSTEMS

20- 00 FLIGHT DECK INFORMATION SYSTEMS

21- 00 ELECTRONIC FLIGHT BAG SYSTEM

21- 01 ELECTRONIC DISPLAY UNIT (EDU)

21- 02 ENHANCED EXPANSION MODULE UNIT (EEMU)

21- 03 EFB CONTROL PANEL

21- 04 EFB DISPLAY UNIT (DU)

21- 05 EFB DOCKING STATION (DS)

21- 06 EFB PROCESSING UNIT (PU)

40- 00 PASSENGER CABIN INFORMATION SYSTEMS

41- 00 PRERECORDED ANNOUNCEMENT

41- 01 PBS-400 REMOTE COMPUTER

41- 02 PBS-400 CONTROL HEAD

41- 03 PBS-600 CONTROL FACE

Page 103

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

49- AIRBORNE AUXILIAY POWER

00 00 AIRBORNE AUXILIARY POWER

00- 01 AUXILIARY POWER UNIT (APU) OVERHEAD PANEL

10- 00 AUXILIARY POWER UNIT (APU) POWERPLANT

10- 01 AUXILIARY POWER UNIT (APU)

15- 00 AUXILIARY POWER UNIT (APU) ENGINE HAR-NESS ASSEMBLY

15- 01 AUXILIARY POWER UNIT (APU) ENGINE HAR-NESS

16- 00 AUXILIARY POWER UNIT (APU) AIR INTAKE

16- 01 AIR INLET SILENCER ASSEMBLY

17- 00 AUXILIARY POWER UNIT (APU) DRAINS

17- 01 AUXILIARY POWER UNIT (APU) COMBUSTOR DRAIN

17- 02 BEARING VENT TUBE

17- 05 AUXILIARY POWER UNIT (APU) GEARBOX VENT TUBE

17- 07 INTERSEAL VENT TUBE

17- 09 AUXILIARY POWER UNIT (APU) COMPART-MENT DRAINS

20- 00 AUXILIARY POWER UNIT (APU) ENGINE

22- 00 AIR INLET SECTION

22- 01 SHROUD ASSEMBLY

23- 00 AUXILIARY POWER UNIT (APU) COMPRESSOR SECTION

23- 01 COMPRESSOR IMPELLER

23- 02 TIE BOLT

23- 03 COMPRESSOR DIFFUSER ASSEMBLY

23- 04 THRUST BALL BEARING

23- 05 CARBON SEAL

23- 06 MID SHAFT

23- 07 LABYRINTH RING

Page 104

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


24- 00 AUXILIARY POWER UNIT (APU) COMBUSTOR SECTION

24- 01 COMBUSTOR LINING

24- 02 COMBUSTOR HOUSING

25- 00 AUXILIARY POWER UNIT (APU) TURBINE SEC-TION

25- 01 1ST STAGE NOZZLE

25- 02 1ST STAGE TURBINE WHEEL

25- 03 2ND STAGE NOZZLE

25- 04 2ND STAGE TURBINE WHEEL

25- 05 AFT ROLLER BEARING

26- 00 AUXILIARY POWER UNIT (APU) ACESSORY DRIVES

26- 01 AUXILIARY POWER UNIT (APU) GEARBOX ASSEMBLY

30- 00 AUXILIARY POWER UNIT (APU) ENGINE FUEL AND CONTROL

31- 00 AUXILIARY POWER UNIT (APU) FUEL DISTRI-BUTION SYSTEM

31- 01 SIMPLEX FUEL INJECTOR

31- 03 DUPLEX FUEL INJECTOR

31- 05 START (PRIMARY) FUEL MANIFOLD

31- 07 SECONDARY FUEL MANIFOLD

31- 09 AUXILIARY POWER UNIT (APU) FUEL FILTER ELEMENT

32- 00 AUXILIARY POWER UNIT (APU) FUEL CON-TROL

32- 01 FUEL MODULE

40- 00 AUXILIARY POWER UNIT (APU) IGNITION / STARTING

41- 00 AUXILIARY POWER UNIT (APU) IGNITION

41- 01 EXCITER

42- 00 AUXILIARY POWER UNIT (APU) STARTING

Page 105

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


42- 01 ELECTRONIC STARTER CONTROLLER

42- 03 BRUSHLESS STARTER/GENERATOR

42- 05 IGNITER

42- 07 IGNITION CABLE

42- 09 AUXILIARY POWER UNIT (APU) STARTING HARNESS

42- 11 ELECTRONIC STARTER CONTROLLER / AICC INTERFACE HARNESS (W205)

50- 00 AUXILIARY POWER UNIT (APU) AIR

52- 00 AUXILIARY POWER UNIT (APU) COOLING

52- 01 AUXILIARY POWER UNIT (APU) COMPART-MENT COOLING AIR INLET DUCT

52- 02 ELECTRONIC STARTER CONTROLLER (ESC) COOLING DUCT

52- 03 ELECTRONIC STARTER CONTROLLER (ESC) COOLING FAN

53- 00 AUXILIARY POWER UNIT (APU) COMPRESSOR CONTROL

53- 01 ANTI-SURGE VALVE

60- 00 AUXILIARY POWER UNIT (APU) ENGINE CON-TROLS

61- 00 AUXILIARY POWER UNIT (APU) CONTROL SYSTEM

61- 01 AUXILIARY POWER UNIT (APU) FADEC

62- 00 AUXILIARY POWER UNIT (APU) EMERGENCY SHUTDOWN

62- 01 AUXILIARY POWER UNIT (APU) EMERGENCY SHUTDOWN SWITCH

70- 00 AUXILIARY POWER UNIT (APU) INDICATING

71- 00 RPM INDICATING

71- 01 SPEED SENSOR PROBE

72- 00 EGT INDICATING

72- 01 THERMOCOUPLE

Page 106

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


74- 00 MAINTENANCE INDICATING SYSTEM

74- 01 DATA MEMORY MODULE

80- 00 AUXILIARY POWER UNIT (APU) EXHAUST

81 00 EXHAUST COLLECTOR

82- 00 EXHAUST SILENCER

82- 01 EXHAUST SILENCER LINER

90- 00 AUXILIARY POWER UNIT (APU) OIL

91- 00 AUXILIARY POWER UNIT (APU) OIL STORAGE

91- 01 AUXILIARY POWER UNIT (APU) OIL FILL CAP

91- 03 AUXILIARY POWER UNIT (APU) OIL FILTER ELEMENT

91- 05 MAGNETIC DRAIN PLUG

91- 07 DE-PRIME SOLENOID VALVE

92- 00 AUXILIARY POWER UNIT (APU) OIL DISTRIBU-TION

92- 01 OIL COOLER

92- 02 AFT BEARING LUBE TUBE

92- 03 OIL RETURN TUBE

93- 00 AUXILIARY POWER UNIT (APU) OIL INDICAT-ING

93- 01 OIL TEMPERATURE SENSOR

93- 03 OIL PRESSURE SENSOR

Page 107

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

50- CARGO AND ACCESSORY COMPARTMENTS

00 00 CARGO AND ACCESSORY COMPARTMENTS

10- 00 CARGO COMPARTMENTS

20- 00 CARGO COMPARTMENT LOADING SYSTEMS

21- 00 CARGO COMPARTMENT RETRIEVAL SYSTEM - GENERAL

21- 01 CARGO COMPARTMENT RETRIEVAL SYSTEM

22- 00 CARGO COMPARTMENT NETS

22- 01 CARGO DOOR NET

22- 02 CARGO NET

22- 03 CARGO CREW-LUGGAGE NET

30- 00 CARGO COMPARTMENT RELATED SYSTEMS

31- 00 CARGO COMPARTMENT LININGS

31- 01 FORWARD CARGO-COMPARTMENT SIDE-WALL-PANEL

31- 02 AFT CARGO-COMPARTMENT SIDEWALL-PANEL

31- 03 FORWARD CARGO-DOOR LINING

31- 04 AFT CARGO-DOOR LINING

31- 05 FORWARD CARGO-DOOR SURROUND

31- 06 AFT CARGO-DOOR SURROUND

31- 08 CARGO-COMPARTMENT FLOOR FINISHING

31- 09 FORWARD CARGO-COMPARTMENT CEILING

31- 10 AFT CARGO-COMPARTMENT CEILING

31- 11 CEILING PROTECTIVE COVER

32- 00 CARGO COMPARTMENT PARTITIONS

32- 01 FORWARD CARGO-COMPARTMENT FORWARD BULKHEAD

32- 02 FORWARD CARGO-COMPARTMENT AFT BULK-HEAD

32- 03 AFT CARGO-COMPARTMENT FORWARD BULK-HEAD

Page 108

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

50- CARGO AND ACCESSORY COMPARTMENTS

32- 04 AFT CARGO-COMPARTMENT AFT BULKHEAD

32- 05 AFT CARGO-COMPARTMENT WATER-SPILL-AGE SHIELD

50- 00 ACCESSORY COMPARTMENTS

51- 00 SAFE

51- 01 FORWARD CARGO-COMPARTMENT SAFE

52- 00 CARGO-COMPARTMENT ELECTRONIC-EQUIP-MENT RACK

52- 01 AFT CARGO-COMPARTMENT ELECTRONIC-EQUIPMENT RACK

60- 00 INSULATION

61- 00 CARGO COMPARTMENT INSULATION SYSTEM

61- 01 CARGO COMPARTMENT INSULATION

61- 02 LOWER-FORWARD-FUSELAGE PASSENGER-CABIN INSULATION

61- 03 LOWER-CENTER-FUSELAGE I INSULATION

61- 04 LOWER-CENTER-FUSELAGE II INSULATION

61- 05 LOWER-CENTER-FUSELAGE III INSULATION

61- 06 FORWARD CARGO-DOOR INSULATION

61- 07 AFT CARGO-DOOR INSULATION

Page 109

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

51-STANDARD PRACTICES AND STRUCTURES GENERAL

00 00 STANDARD PRACTICES AND STRUCTURES

00- 01 ENVIRONMENTAL EFFECTS

00- 03 STRUCTURAL REPAIR CATEGORY DEFINI-TIONS

00- 04 STRUCTURE CLASSIFICATION

00- 05 REPAIR INSPECTIONS REQUIREMENTS

10- 00 AERODYNAMIC SMOOTHNESS AND DAMAGE TREATMENT

10- 01 AERODYNAMIC SMOOTHNESS

10- 02 DAMAGE ASSESSMENT - INVESTIGATION, CLAS-SIFICATION AND REMOVAL

10- 03 BLEND-OUT

10- 04 CRACK-STOP HOLE DRILLING

10- 05 DENT FILLING

11- 00 CORROSION DEFINITION

11- 01 TYPES AND CAUSES OF CORROSION

11- 02 IDENTIFICATION AND CORROSION LEVELS

12- 00 CORROSION REMOVAL

12- 01 CORROSION REMOVAL FOR ALUMINUM AND ITS ALLOYS

12- 02 CORROSION REMOVAL FOR CARBON STEEL AND STAINLESS STEEL

12- 03 CORROSION REMOVAL FOR TITANIUM ALLOYS

13- 00 CORROSION - INSPECTION AND DETECTION

14- 00 CORROSION PROTECTION

14- 01 PROTECTION AFTER MERCURY SPILLAGE

14- 02 PROTECTION AFTER ACID/ALKALINE SPILLS

14- 03 PROTECTION AFTER SKYDROLL SPILL

14- 04 PROTECTION AFTER FIRE DAMAGE

Page 110

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


20- 00 PROCESSES

21- 00 SEALING

21- 01 FAYING SURFACE SEALING

21- 02 FILLET SEALING

21- 03 AERODYNAMIC SEALING

21- 04 GAPS AND VOIDS SEALING

21- 05 FASTENER SEALING

21- 06 FORM-IN-PLACE GASKET SEALING

21- 07 SEALING REMOVAL

22- 00 HEAT TREATMENT OF ALUMINUM ALLOYS

22- 01 APPLICATION OF SPEED TAPE

22- 02 SEAL BONDING

23- 00 PROTECTIVE TREATMENT AND PAINTING

23- 01 PAINT SCHEME

23- 02 PAINT REMOVAL/STRIPPING

23- 03 MIRROR-FINISHED ALUMINUM-SHEET SKIN POLISHING

23- 04 PRETREATMENT TO METAL PARTS

23- 05 SURFACE PROTECTION - PRIMER

23- 06 TOPCOAT

23- 07 COMPOSITE MATERIAL PARTS - PAINTING

23- 08 CERAMIC EPOXY COATING - PAINT APPLICA-TION

23- 08 CERAMIC EPOXY COATING - PAINT APPLICA-TION

23- 09 FUEL VAPOR BARRIER SEALANT

23- 10 FIREPROOF PROTECTION COATING

23- 20 PAINTED ALUMINUM-SHEET SKIN POLISHING

23- 21 ACRYLIC TRANSPARENCY - SANDING AND POLISHING

Page 111

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


23- 22 WINDOW PANE ANTIFOG APPLICATION

24- 00 FINISHING

24- 01 INTERNAL AND EXTERNAL FINISHING - SUR-FACE PROTECTION

24- 02 INTERNAL AND EXTERNAL FINISHING - STRIP-PING

24- 03 INTERNAL AND EXTERNAL FINISHING - SUR-FACE CLEANING

24- 04 INTERNAL AND EXTERNAL FINISHING - SUR-FACE PREPARATION

24- 05 INTERNAL AND EXTERNAL FINISHING - FINAL SURFACE PROTECTION

24- 06 INTERNAL AND EXTERNAL FINISHING - FINISH TOPCOAT

24- 07 EXTERNAL FINISHING REPAIRS

24- 08 MIRROR-FINISHED ALUMINUM-SHEET SKIN POLISHING

24- 09 COMPOSITE-MATERIAL PARTS PAINTING

24- 10 INTERNAL FINISHING - FUEL VAPOR BARRIER SEALANT

24- 11 FIREPROOF PROTECTION COATING

24- 12 PAINT STRIPPING

25- 00 CORROSION-INHIBITING COMPOUND - REMOVAL AND APPLICATION

26- 00 BIOCIDE PROTECTION

27- 00 CORROSION PREVENTIVE MAINTENANCE

27- 01 AIRCRAFT CLEANING AND WASHING

27- 02 LUBRICATION

27- 03 DRAINS - CLEANING

30- 00 MATERIALS

31- 00 SHEET METAL MATERIALS

Page 112

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


33- 00 METALLIC AND NONMETALLIC MATERIALS

35- 00 CONSUMABLE MATERIALS

40- 00 FASTENERS

40- 01 FASTENERS - IDENTIFICATION CODES

40- 02 FASTENERS - DRILLING

40- 03 FASTENERS - HOLE SIZES

40- 04 FASTENERS - COUNTERSINKING

40- 05 FASTENERS - LENGTH SELECTION

40- 06 ALTERNATIVE FASTENERS

41- 00 SOLID RIVETS

41- 01 SOLID RIVETS - PROTRUDING HEAD

41- 02 SOLID RIVETS - FLUSH HEAD

42- 00 BLIND RIVETS

42- 01 CHERRYMAX BLIND RIVETS - PROTRUDING HEAD

42- 02 CHERRYMAX BLIND RIVETS - FLUSH HEAD

42- 03 CHERRYLOCK BLIND RIVETS - PROTRUDING HEAD

42- 04 CHERRYLOCK BLIND RIVETS - FLUSH HEAD

43- 00 SWAGED COLLAR FASTENERS

43- 01 HI-LOK FASTENERS - PROTRUDING HEAD

43- 02 HI-LOK FASTENERS - FLUSH HEAD

43- 03 HI-LITE FASTENERS - PROTRUDING HEAD

43- 04 HI-LITE FASTENERS - FLUSH HEAD

44- 00 HELICOIL INSERTS

50- 00 AIRCRAFT ALIGNMENT CHECK

60- 00 CONTROL SURFACE BALANCING

60- 01 CONTROL SURFACE BALANCING - ELEVATOR

60- 02 CONTROL SURFACE BALANCING - RUDDER

Page 113

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


70- 00 TYPICAL REPAIRS

70- 01 COMPOSITES - DETERMINATION OF DAMAGE

70- 02 COMPOSITES - LIQUID DETECTION

70- 03 COMPOSITES - REMOVAL OF LIQUID FROM DAMAGED AREA

70- 04 COMPOSITES - REMOVAL OF DAMAGED AREA

70 05 COMPOSITES - CLEANING OF AREA

70- 06 COMPOSITES - HONEYCOMB CORE REPLACE-MENT

70- 07 COMPOSITES - PLIES REPLACEMENT

70- 08 COMPOSITES - LAY-UP/BAGGING PROCEDURE

70- 09 COMPOSITES - REPAIR CURE

70- 10 COMPOSITES - REFINISHING

70- 11 COMPOSITES - MATERIAL SUBSTITUTION

71- 00 COMPOSITES - STRUCTURE REPAIRS AT ROOM TEMPERATURE

71- 01 COMPOSITES - REPAIR OF EDGE DELAMINA-TION AT ROOM TEMPERATURE

71- 02 COMPOSITES - REPAIR OF PLY DELAMINATION AT ROOM TEMPERATURE

71- 03 COMPOSITES - REPAIR OF DISBONDING BETWEEN SKIN AND HONEYCOMB AT ROOM TEMPERATURE

71- 04 COMPOSITES - REPAIR OF SKIN AT ROOM TEMPERATURE

71- 05 COMPOSITES - REPAIR OF ONE SKIN AND HONEYCOMB CORE AT ROOM TEMPERATURE - TYPE A

71- 06 COMPOSITES - REPAIR OF ONE SKIN AND HONEYCOMB CORE AT ROOM TEMPERATURE - TYPE B

Page 114

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


71- 07 COMPOSITES - REPAIR OF DAMAGE IN BOTH SKINS AND HONEYCOMB CORE AT ROOM TEMPERATURE

71- 08 COMPOSITES - REPAIR OF SOLID LAMINATES AT ROOM TEMPERATURE - TYPE A

71- 09 COMPOSITES - REPAIR OF SOLID LAMINATES AT ROOM TEMPERATURE - TYPE B

71- 10 COMPOSITES - REPAIR OF DENTS

72- 00 COMPOSITES - STRUCTURE REPAIRS AT 121°C (250°F)

72- 01 COMPOSITES - REPAIR OF SKIN AT 121°C (250°F)

72- 02 COMPOSITES - REPAIR OF ONE SKIN AND HONEYCOMB CORE AT 121°C (250°F) - TYPE A

72- 03 COMPOSITES - REPAIR OF ONE SKIN AND HONEYCOMB CORE AT 121°C (250°F) - TYPE B

72- 04 COMPOSITES - REPAIR OF DAMAGE IN BOTH SKINS AND HONEYCOMB CORE WHERE ACCESS IS LIMITED TO ONE SIDE AT 121°C (250°F)

72- 05 COMPOSITES - REPAIR OF DAMAGE IN BOTH SKINS AND HONEYCOMB CORE WHERE ACCESS IS POSSIBLE TO TWO SIDES AT 121°C (250°F)

72- 06 COMPOSITES - REPAIR OF SOLID LAMINATES AT 121°C (250°F) - TYPE A

72- 07 COMPOSITES - REPAIR OF SOLID LAMINATES AT 121°C (250°F) - TYPE B

73- 00 COMPOSITES - REPAIR OF EXPANDED COP-PER FOIL AND BONDING METALLIC PLATE

75- 00 METAL SKIN - REPAIRS

75- 01 METAL SKIN - TEMPORARY CIRCULAR REPAIR

Page 115

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE


75- 02 METAL SKIN - INTERNAL CONVERSION CIRCU-LAR REPAIR

75- 03 METAL SKIN - INTERNAL DIRECT CIRCULAR REPAIR

75- 04 METAL SKIN - EXTERNAL CONVERSION CIR-CULAR REPAIR

75- 05 METAL SKIN - EXTERNAL DIRECT CIRCULAR REPAIR

75- 06 METAL SKIN - CIRCULAR REPAIR ON RIVET ROW

75- 07 METAL SKIN - TEMPORARY RECTANGULAR REPAIR

75- 08 METAL SKIN - INTERNAL CONVERSION RECT-ANGULAR REPAIR

75- 09 METAL SKIN - INTERNAL DIRECT RECTANGU-LAR REPAIR

75- 10 METAL SKIN - EXTERNAL CONVERSION RECT-ANGULAR REPAIR

75- 11 METAL SKIN - EXTERNAL DIRECT RECTANGU-LAR REPAIR

75- 12 METAL SKIN - RECTANGULAR REPAIR CROSS-ING RIVET ROW (1 DOUBLER)

75- 13 METAL SKIN - RECTANGULAR REPAIR CROSS-ING RIVET ROW (2 DOUBLERS)

75- 14 METAL SKIN - RECTANGULAR REPAIR FOR DAMAGE ON RIVET ROW

75- 15 METAL SKIN - EXTERNAL CONVERSION RECT-ANGULAR REPAIR - 2 DOUBLERS

Page 116

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

00 00 DOORS

00- 02 DOOR SEAL RETAINERS

00- 05 DOOR LOCK WITH KEYS

00- 06 DOOR STRAP-LOCK

00- 21 DOOR SEAL00- 23 DOOR PINS10- 00 PASSENGER DOORS11- 00 FORWARD PASSENGER DOOR11- 01 FORWARD PASSENGER-DOOR SKIN11- 02 FORWARD PASSENGER-DOOR STRUCTURES11- 20 FORWARD PASSENGER-DOOR ACTUATING

AND LOCKING MECHANISM11- 21 FORWARD PASSENGER-DOOR SEAL11- 22 FORWARD PASSENGER-DOOR BOX-MECHA-

NISM11- 23 FORWARD PASSENGER-DOOR FITTINGS11- 25 FORWARD PASSENGER-DOOR VENT-FLAP11- 26 FORWARD PASSENGER-DOOR VENT-FLAP-

SEAL11- 27 FORWARD PASSENGER-DOOR DAMPER11- 28 FORWARD PASSENGER-DOOR DEFLECTOR

11- 30 FORWARD PASSENGER-DOOR SUPPORT-ARM11- 40 FORWARD-PASSENGER-DOOR EMERGENCY-

EVACUATION-SLIDE MECHANISM11- 41 FORWARD PASSENGER-DOOR GIRT-BAR11- 50 FORWARD PASSENGER-DOOR EMERGENCY

OPENING SYSTEM11- 51 FORWARD PASSENGER-DOOR PNEUMATIC

ASSEMBLY11- 52 FORWARD PASSENGER-DOOR CONTROL

MECHANISM11- 53 FORWARD-PASSENGER-DOOR PNEUMATIC-

ASSEMBLY DIAPHRAGM12- 00 AFT PASSENGER DOOR

Page 117

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

12- 01 AFT PASSENGER-DOOR SKIN12- 02 AFT PASSENGER-DOOR STRUCTURES12- 20 AFT PASSENGER-DOOR ACTUATING AND

LOCKING MECHANISM12- 21 AFT PASSENGER-DOOR SEAL12- 22 AFT PASSENGER-DOOR BOX-MECHANISM12- 23 AFT PASSENGER-DOOR FITTINGS12- 25 AFT PASSENGER-DOOR VENT-FLAP12- 26 AFT PASSENGER-DOOR VENT-FLAP-SEAL12- 27 AFT PASSENGER-DOOR DAMPER12- 28 AFT PASSENGER-DOOR DEFLECTOR12- 30 AFT PASSENGER-DOOR SUPPORT-ARM12- 40 AFT-PASSENGER-DOOR EMERGENCY-EVACU-

ATION-SLIDE MECHANISM12- 41 AFT PASSENGER-DOOR GIRT-BAR12- 50 AFT PASSENGER-DOOR EMERGENCY OPEN-

ING SYSTEM

12- 51 AFT PASSENGER-DOOR PNEUMATIC ASSEM-BLY

12- 52 AFT PASSENGER-DOOR CONTROL MECHA-NISM

12- 53 AFT-PASSENGER-DOOR PNEUMATIC-ASSEM-BLY DIAPHRAGM

20- 00 EMERGENCY EXITS21- 00 OVERWING ESCAPE HATCH21- 01 OVERWING ESCAPE-HATCH SKIN21- 02 OVERWING ESCAPE HATCH - STRUCTURES21- 20 OVERWING ESCAPE-HATCH DOOR-LOCK

MECHANISM21- 21 OVERWING ESCAPE-HATCH DOOR SEAL21- 22 OVERWING-ESCAPE-HATCH ICE BREAKERS21- 23 OVERWING ESCAPE HATCH - HATCH STOPS

AND FITTINGS21- 25 OVERWING ESCAPE-HATCH DOOR-LOCK-

MECHANISM SEAL30- 00 CARGO DOORS31- 00 FORWARD CARGO DOOR31- 01 FORWARD CARGO-DOOR SKIN

Page 118

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

31- 02 FORWARD CARGO-DOOR STRUCTURES31- 20 FORWARD CARGO-DOOR ACTUATING AND LOCK-

ING MECHANISM31- 21 FORWARD CARGO-DOOR SEAL31- 23 FORWARD CARGO-DOOR FITTINGS31- 24 FORWARD CARGO-DOOR BELLCRANK-

ASSEMBLY31- 25 FORWARD CARGO-DOOR VENT-FLAP31- 26 FORWARD CARGO-DOOR VENT-FLAP-SEAL31- 27 FORWARD CARGO-DOOR ACTUATOR31- 28 FORWARD CARGO-DOOR DRIVE-ROD31- 29 FORWARD CARGO-DOOR LOCK-CABLE31- 30 FORWARD CARGO-DOOR INSPECTION-WIN-

DOWS32- 00 AFT CARGO DOOR32- 01 AFT CARGO-DOOR SKIN32- 02 AFT CARGO-DOOR STRUCTURES

32- 20 AFT CARGO-DOOR ACTUATING AND LOCKING MECHANISM

32- 21 AFT CARGO-DOOR SEAL32- 23 AFT CARGO-DOOR FITTINGS32- 24 AFT CARGO-DOOR BELLCRANK-ASSEMBLY32- 25 AFT CARGO-DOOR VENT-FLAP32- 26 AFT CARGO-DOOR VENT-FLAP-SEAL32- 27 AFT CARGO-DOOR ACTUATOR32- 28 AFT CARGO-DOOR DRIVE-ROD32- 29 AFT CARGO-DOOR LOCK-CABLE32- 30 AFT CARGO-DOOR INSPECTION-WINDOWS33- 00 AFT BAGGAGE DOOR33- 01 AFT-BAGGAGE-DOOR SKIN33- 02 AFT-BAGGAGE-DOOR STRUCTURES33- 20 AFT-BAGGAGE-DOOR ACTUATING AND LOCK-

ING MECHANISM33- 21 AFT-BAGGAGE-DOOR SEAL33- 22 AFT-BAGGAGE-DOOR BOX-MECHANISM33- 23 AFT-BAGGAGE-DOOR FITTINGS33- 25 AFT-BAGGAGE-DOOR VENT-FLAP

Page 119

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

33- 26 AFT-BAGGAGE-DOOR VENT-FLAP SEAL33- 27 AFT-BAGGAGE-DOOR DAMPER33- 28 AFT-BAGGAGE-DOOR DEFLECTOR33- 30 AFT-BAGGAGE-DOOR SUPPORT-ARM33- 52 AFT-BAGGAGE-DOOR CONTROL MECHANISM40- 00 SERVICE DOORS41- 00 FORWARD SERVICE DOOR41- 01 FORWARD SERVICE-DOOR SKIN41- 02 FORWARD SERVICE-DOOR STRUCTURES41- 20 FORWARD SERVICE-DOOR ACTUATING AND

LOCKING MECHANISM41- 21 FORWARD SERVICE-DOOR SEAL41- 22 FORWARD SERVICE-DOOR BOX-MECHANISM41- 23 FORWARD SERVICE-DOOR FITTINGS41- 25 FORWARD SERVICE-DOOR VENT-FLAP41- 26 FORWARD SERVICE-DOOR VENT-FLAP-SEAL41- 27 FORWARD SERVICE-DOOR DAMPER

41- 28 FORWARD SERVICE-DOOR DEFLECTOR41- 30 FORWARD SERVICE-DOOR SUPPORT-ARM41- 40 FORWARD-SERVICE-DOOR EMERGENCY-

EVACUATION-SLIDE MECHANISM41- 41 FORWARD SERVICE-DOOR GIRT-BAR41- 50 FORWARD SERVICE-DOOR EMERGENCY

OPENING SYSTEM41- 51 FORWARD SERVICE-DOOR PNEUMATIC

ASSEMBLY41- 52 FORWARD SERVICE-DOOR CONTROL MECHA-

NISM41- 53 FORWARD-SERVICE-DOOR PNEUMATIC-

ASSEMBLY DIAPHRAGM42- 00 AFT SERVICE DOOR42- 01 AFT SERVICE-DOOR SKIN42- 02 AFT SERVICE-DOOR STRUCTURES42- 20 AFT SERVICE-DOOR ACTUATING AND LOCK-

ING MECHANISM42- 21 AFT SERVICE-DOOR SEAL42- 22 AFT SERVICE-DOOR BOX-MECHANISM42- 23 AFT SERVICE-DOOR FITTINGS

Page 120

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

42- 25 AFT SERVICE-DOOR VENT-FLAP42- 26 AFT SERVICE-DOOR VENT-FLAP-SEAL42- 27 AFT SERVICE-DOOR DAMPER

42- 28 AFT SERVICE-DOOR DEFLECTOR42- 30 AFT SERVICE-DOOR SUPPORT-ARM42- 40 AFT-SERVICE-DOOR EMERGENCY-EVACUA-

TION-SLIDE MECHANISM42- 41 AFT SERVICE-DOOR GIRT-BAR42- 50 AFT SERVICE-DOOR EMERGENCY OPENING

SYSTEM42- 51 AFT SERVICE-DOOR PNEUMATIC ASSEMBLY42- 52 AFT SERVICE-DOOR CONTROL MECHANISM42- 53 AFT-SERVICE-DOOR PNEUMATIC-ASSEMBLY

DIAPHRAGM43- 00 FORWARD AVIONICS-COMPARTMENT

ACCESS-HATCH

43- 20 FORWARD AVIONICS-COMPARTMENT ACCESS-HATCH ACTUATING AND LOCKING MECHANISM

43- 21 FORWARD AVIONICS-COMPARTMENT ACCESS-HATCH SEAL

44- 00 FUELING COMPARTMENT ACCESS-DOOR45- 00 REAR FUSELAGE DOOR45- 01 REAR-FUSELAGE DOOR SKIN46- 00 MIDDLE AVIONICS-COMPARTMENT ACCESS-

DOOR46- 20 MIDDLE-AVIONICS-COMPARTMENT ACCESS-

DOOR ACTUATING AND LOCKING MECHANISM46- 21 MIDDLE AVIONICS-COMPARTMENT ACCESS-

DOOR SEAL47- 00 RAT DOOR48- 00 AUXILIARY-FUEL-TANK COMPARTMENT DOOR48- 01 AUXILIARY-FUEL-TANK COMARTMENT-DOOR

SKIN48- 02 AUXILIARY-FUEL-TANK COMPARTMENT DOOR

STRUCTURES

Page 121

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

48- 20 AUXILIARY-FUEL-TANK COMPARTMENT DOOR ACTUATING AND LOCKING MECHANISM

48- 21 AUXILIARY-FUEL-TANK COMPARTMENT DOOR SEAL

48- 23 AUXILIARY-FUEL-TANK COMPARTMENT DOOR FITTINGS

48- 24 AUXILIARY-FUEL-TANK COMPARTMENT DOOR BELLCRANK-ASSEMBLY

48- 25 AUXILIARY-FUEL-TANK COMPARTMENT DOOR VENT-FLAP

48- 26 AUXILIARY-FUEL-TANK COMPARTMENT DOOR VENT-FLAP-SEAL

48- 27 AUXILIARY-FUEL-TANK COMPARTMENT DOOR ACTUATOR

48- 28 AUXILIARY-FUEL-TANK COMPARTMENT DOOR DRIVE-ROD

48- 30 AUXILIARY-FUEL-TANK COMPARTMENT DOOR INSPECTION-WINDOWS

50- 00 FIXED INTERIOR DOORS51- 00 COCKPIT DOOR ASSEMBLY51- 01 COCKPIT DOOR51- 02 COCKPIT DOOR PANELS51- 03 COCKPIT DOOR ELECTROMECHANICAL

LATCH51- 04 COCKPIT DOOR RELAY POWER SUPPLY51- 05 COCKPIT-DOOR BLOWOUT PANEL52- 00 POCKET-DOOR POSITION DETECTOR53- 00 BAGGAGE-COMPARTMENT DOOR POSITION

DETECTOR54- 00 INTERNAL DOORS54- 01 POCKET DOORS54- 02 INTERIOR DOORS60- 00 AIRSTAIRS60- 02 AIRSTAIRS TORSION BARS61- 00 AIRSTAIRS BASE PLATE61- 20 AIRSTAIRS ACTUATOR61- 22 AIRSTAIRS BACKUP ACTUATOR

Page 122

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

61- 24 AIRSTAIRS MICROSWITCHES61- 26 AIRSTAIRS ACTUATING PANEL61- 28 AIRSTAIRS ACTUATING MECHANISM61- 50 AIRSTAIR FORWARD CONTROL SYSTEM61- 51 AIRSTAIR AFT CONTROL SYSTEM62- 00 AIRSTAIRS TRACKS63- 00 AIRSTAIRS STRUCTURE63- 20 AIRSTAIRS HANDRAIL63- 22 AIRSTAIRS STEPS63- 24 AIRSTAIRS FOLDEN STEP70- 00 DOORS WARNING71- 00 COMPARTMENT DOORS WARNING71- 20 COMPARTMENT DOORS WARNING-MICRO-

SWITCH72- 00 PASSENGER DOORS WARNING72- 20 FORWARD PASSENGER-DOOR WARNING-

SENSOR72- 21 AFT PASSENGER-DOOR WARNING-SENSOR73- 00 CARGO DOORS WARNING73- 20 FORWARD CARGO-DOOR WARNING-SENSOR73- 21 AFT CARGO-DOOR WARNING-SENSOR74- 00 SERVICE DOORS WARNING74- 20 FORWARD SERVICE-DOOR WARNING-SEN-

SOR74- 21 AFT SERVICE-DOOR WARNING-SENSOR75- 00 EMERGENCY EXITS WARNING76- 00 AFT-BAGGAGE-DOOR WARNING76- 20 AFT-BAGGAGE-DOOR WARNING-SENSOR77- 00 AUXILIARY-FUEL-TANK COMPARTMENT DOOR

WARNING77- 20 AUXILIARY-FUEL-TANK COMPARTMENT DOOR

WARNING-SENSOR78- 00 POCKET-DOOR WARNING78- 20 POCKET-DOOR WARNING SENSOR80- 00 LANDING GEAR DOORS81- 00 MAIN LANDING-GEAR DOOR81- 01 MAIN LANDING-GEAR DOOR-SKIN

Page 123

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

81- 02 MAIN LANDING-GEAR DOOR-STRUCTURES81- 23 MAIN LANDING GEAR DOOR-SEALING BRUSH81- 25 MAIN-LANDING-GEAR DOOR - FAIRING SEAL81- 26 MAIN-LANDING-GEAR DOOR - FAIRING82- 00 NOSE LANDING-GEAR DOOR82- 01 NOSE LANDING-GEAR DOOR-SKIN82- 02 NOSE LANDING-GEAR DOOR-STRUCTURES82- 21 NOSE LANDING-GEAR DOOR-SEAL82- 22 NOSE-LANDING-GEAR-DOOR BELLCRANK90- 00 FUSELAGE PLUGS91- 00 FORWARD FUSELAGE PLUG91- 01 FORWARD-FUSELAGE-PLUG SKIN91- 02 FORWARD-FUSELAGE-PLUG STRUCUTRES91- 20 FORWARD-FUSELAGE-PLUG ACTUATING AND

LOCKING MECHANISM91- 21 FORWARD FUSELAGE-PLUG SEAL91- 22 FORWARD-FUSELAGE-PLUG BOX-MECHA-

NISM91- 23 FORWARD-FUSELAGE-PLUG FITTINGS91- 25 FORWARD-FUSELAGE-PLUG VENT-FLAP91- 28 FORWARD FUSELAGE-PLUG DEFLECTOR91- 52 FORWARD-FUSELAGE-PLUG CONTROL

MECHANISM92- 00 OVERWING FUSELAGE PLUG (LH)92- 01 OVERWING FUSELAGE-PLUGH (LH) SKIN92- 02 OVERWING-FUSELAGE-PLUG (LH) STRUC-

TURES92- 20 OVERWING-FUSELAGE-PLUG (LH) LOCK-

MECHANISM92- 23 OVERWING-FUSELAGE-PLUG (LH) STOPS AND

FITTINGS93- 00 AFT FUSELAGE PLUG93- 01 AFT-FUSELAGE-PLUG SKIN93- 02 AFT-FUSELAGE-PLUG STRUCTURES93- 20 AFT-FUSELAGE-PLUG ACTUATING AND LOCK-

ING MECHANISM93- 21 AFT FUSELAGE-PLUG SEAL93- 22 AFT-FUSELAGE-PLUG BOX-MECHANISM

Page 124

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

52- DOORS

93- 23 AFT-FUSELAGE-PLUG FITTINGS93- 25 AFT-FUSELAGE-PLUG VENT-FLAP93- 28 AFT FUSELAGE-PLUG DEFLECTOR93- 52 AFT-FUSELAGE-PLUG CONTROL MECHANISM

Page 125

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

00 00 FUSELAGE

00- 10 FUSELAGE FLOOR STRUCTURE

00- 20 FUSELAGE FLOOR STRUCTURE PULYURE-THANE TAPE

00- 40 FUSELAGE POLYURETHANE FILMS

01- 00 FLOOR PANELS

01- 35 FORWARD AVIONICS COMPARTMENT FLOOR PANELS

01- 37 COCKPIT FLOOR PANELS

01- 39 PASSENGER-CABIN FLOOR PANELS

01- 41 REAR-FUSELAGE FLOOR PANELS

01- 43 FORWARD CARGO-COMPARTMENT FLOOR-PANELS

01- 44 MIDDLE AVIONICS COMPARTMENT FLOOR PANELS

01- 45 AFT CARGO-COMPARTMENT FLOOR-PANELS

01- 46 RECIRCULATION-BAY MAINTENANCE-COM-PARTMENT FLOOR PANELS

01- 47 ELECTRIC/FUEL MAINTENANCE-COMPART-MENT FLOOR PANELS

02- 00 NOSE LANDING GEAR INTERNAL ACCESS PANEL

03- 00 FUSELAGE EXTERNAL ACCESS DOOR AND PANELS

03- 55 FORWARD FUSELAGE EXTERNAL ACCESS PANELS

03- 56 CENTER FUSELAGE I OXYGEN ACCESS DOOR

03- 57 CENTER FUSELAGE I EXTERNAL ACCESS PANELS

03- 59 CENTER FUSELAGE II EXTERNAL ACCESS PANELS

03- 60 CENTER FUSELAGE III WASTE ACCESS DOOR

03- 61 CENTER FUSELAGE III EXTERNAL ACCESS PANELS

03- 62 CENTER FUSELAGE III WATER ACCESS DOOR

03- 63 REAR FUSELAGE EXTERNAL ACCESS PANELS

Page 126

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

03- 64 TAIL-CONE EXTERNAL ACCESS PANELS

04- 00 WING-TO-FUSELAGE FAIRING

04- 02 WING-TO-FUSELAGE FAIRING FITTINGS

04- 20 WING-TO-FUSELAGE FAIRING FORWARD PANEL

04- 30 WING-TO-FUSELAGE FAIRING CENTER PANEL

04- 34 MAIN LANDING GEAR SEALING BRUSH

04- 35 MAIN LANDING GEAR WHEELWELL

04- 40 WING-TO-FUSELAGE FAIRING SIDE PANEL

04- 50 WING-TO-FUSELAGE FAIRING AFT PANEL

04- 51 WING-TO-FUSELAGE FAIRING AFT PANEL RUPTURE-STRIP

04- 52 WING-TO-FUSELAGE FAIRING AFT-SECTION

04- 60 REAR-FUSELAGE DRAIN-TUBE FAIRING

05- 00 FUSELAGE DRAINS

05- 65 FORWARD FUSELAGE DRAINS

05- 67 CENTER FUSELAGE I DRAINS

05- 69 CENTER FUSELAGE II DRAINS

05- 71 CENTER FUSELAGE III DRAINS

05- 73 REAR-FUSELAGE DRAIN TUBE

06- 00 TRACKS

06- 01 FORWARD-FUSELAGE COCKPIT SEAT-TRACKS

10- 00 FORWARD FUSELAGE

10- 01 FORWARD FUSELAGE SKIN

10- 02 FORWARD FUSELAGE STRUCTURES

10- 03 FORWARD FUSELAGE STRINGERS

10- 04 FORWARD FUSELAGE FRAMES

10- 06 FORWARD PRESSURE BULKHEAD

10- 08 FORWARD FUSELAGE LANDING GEAR FIT-TINGS

10- 09 FORWARD FUSELAGE WINDOW FORMERS

10- 10 FORWARD FUSELAGE FLOOR STRUCTURE

10- 11 FORWARD FUSELAGE DOOR SURROUNDING STRUCTURE

Page 127

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

10- 12 FORWARD FUSELAGE WINDOW SURROUNDING STRUCTURE

10- 18 NOSE-LANDING-GEAR BAY

10- 21 FORWARD PASSENGER-DOOR FRAME-FIT-TINGS

10- 22 FORWARD PASSENGER-DOOR PROTECTIVE-PLATE

10- 25 FORWARD SERVICE-DOOR FRAME-FITTINGS

10- 26 FORWARD SERVICE-DOOR PROTECTIVE-PLATE

10- 27 FORWARD AVIONICS-COMPARTMENT WATER PROTECTION-COVER

10- 29 FORWARD-AVIONICS-COMPARTMENT ACCESS-HATCH FRAME-STOPS

10- 30 FORWARD AVIONICS-COMPARTMENT ACCESS-HATCH BONDING PLATE

10- 31 NOSE-LANDING-GEAR DOOR SUPPORTS

10- 35 FORWARD-FUSELAGE-PLUG FRAME-FIT-TINGS

10- 75 FORWARD FUSELAGE DECK AVIONICS COM-PARTMENT

10- 77 FORWARD FUSELAGE SLIDE-RACE DIRECT-VISION WINDOW

10- 79 FORWARD FUSELAGE DOOR SILLS

10- 81 FORWARD-AVIONICS-COMPARTMENT ACCESS-HATCH TRACKS

14- 00 RADOME

14- 21 RADOME DIVERTERS

20- 00 CENTER FUSELAGE

21- 00 CENTER FUSELAGE I

21- 01 CENTER FUSELAGE I SKIN

21- 02 CENTER FUSELAGE I STRUCTURES

21- 03 CENTER FUSELAGE I STRINGERS

21- 04 CENTER FUSELAGE I FRAMES

21- 09 CENTER FUSELAGE I WINDOW FORMERS

Page 128

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

21- 10 CENTER FUSELAGE I FLOOR STRUCTURE

21- 11 CENTER FUSELAGE I DOOR SURROUNDING STRUCTURE

21- 12 CENTER FUSELAGE I WINDOW SURROUNDING STRUCTURE

21- 29 FORWARD CARGO-DOOR FRAME-FITTINGS

21- 30 FORWARD CARGO-DOOR PROTECTIVE-PLATE

22- 00 CENTER FUSELAGE II

22- 01 CENTER FUSELAGE II SKIN

22- 02 CENTER FUSELAGE II STRUCTURES

22- 03 CENTER FUSELAGE II STRINGERS

22- 04 CENTER FUSELAGE II FRAMES

22- 09 CENTER FUSELAGE II WINDOW FORMERS

22- 10 CENTER FUSELAGE II FLOOR STRUCTURE

22- 11 CENTER FUSELAGE II DOOR SURROUNDING STRUCTURE

22- 12 CENTER FUSELAGE II WINDOW SURROUNDING STRUCTURE

22- 16 DBS TV PLATFORM

22- 17 DBS TV PEDESTAL ANTENNA

22- 18 DBS TV BIRD-STRIKE REINFORCEMENT

22- 20 DBS TV RADOME

22- 22 DBS TV RADOME-SKIRT ASSEMBLY

22- 25 DBS TV SKIRT-SEAL

22- 27 MIDDLE AVIONICS-COMPARTMENT WATER PROTECTION-COVER

22- 28 HSD ANTENNA ADAPTER PLATE

23- 00 CENTER FUSELAGE III

23- 01 CENTER FUSELAGE III SKIN

23- 02 CENTER FUSELAGE III STRUCTURES

23- 03 CENTER FUSELAGE III STRINGERS

23- 04 CENTER FUSELAGE III FRAMES

23- 09 CENTER FUSELAGE III WINDOW FORMERS

23- 10 CENTER FUSELAGE III FLOOR STRUCTURE

Page 129

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

23- 11 CENTER FUSELAGE III DOOR SURROUNDING STRUCTURE

23- 12 CENTER FUSELAGE III WINDOW SURROUND-ING STRUCTURE

23- 21 AFT PASSENGER-DOOR FRAME-FITTINGS

23- 22 AFT PASSENGER-DOOR PROTECTIVE-PLATE

23- 25 AFT SERVICE-DOOR FRAME-FITTINGS

23- 26 AFT SERVICE-DOOR PROTECTIVE-PLATE

23- 29 AFT CARGO-DOOR FRAME-FITTINGS

23- 30 AFT CARGO-DOOR PROTECTIVE-PLATE

23- 31 AFT-BAGGAGE-DOOR FRAME-FITTINGS

23- 32 AFT-BAGGAGE-DOOR PROTECTIVE-PLATE

23- 35 AFT-FUSELAGE-PLUG FRAME-FITTINGS

23- 39 AUXILIARY-FUEL-TANK COMPARTMENT DOOR FRAME-FITTINGS

23- 79 CENTER FUSELAGE III DOOR SILLS

30- 00 REAR FUSELAGE

30- 01 REAR FUSELAGE SKIN

30- 02 REAR FUSELAGE STRUCTURES

30- 03 REAR FUSELAGE STRINGERS

30- 04 REAR FUSELAGE FRAMES

30- 06 REAR PRESSURE BULKHEAD

30- 10 REAR FUSELAGE FLOOR STRUCTURE

30- 11 REAR FUSELAGE DOOR SURROUNDING STRUCTURE

30- 21 REAR-FUSELAGE ADJUSTABLE RODS

30- 81 TAIL BUMPER

30- 83 REAR FUSELAGE-TO-HORIZONTAL STABI-LIZER HINGE FITTINGS

30- 84 REAR FUSELAGE-TO-VERTICAL STABILIZER FILLETS

30- 85 REAR FUSELAGE-TO-HORIZONTAL STABI-LIZER SLIDING-PLATE GUIDES

31- 00 TAIL CONE

31- 01 TAIL CONE SKIN

Page 130

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

53- FUSELAGE

31- 02 TAIL CONE STRUCTURES

31- 03 TAIL CONE STRINGERS

31- 04 TAIL CONE FRAMES

31- 10 AUXILIARY-POWER-UNIT (APU) OIL COOLER DUCT

31- 21 AUXILIARY-POWER-UNIT (APU) FIREWALL PANELS

31- 23 AUXILIARY-POWER-UNIT (APU) FIREWALL SEAL

31- 25 RUDDER-ROOT AFT FAIRING

31- 27 AUXILIARY-POWER-UNIT (APU) MOUNTS

31- 29 AUXILIARY-POWER-UNIT (APU) TOP MOUNT

31- 31 AUXILIARY-POWER-UNIT (APU) LEFT MOUNT

31- 33 AUXILIARY-POWER-UNIT (APU) RIGHT MOUNT

31- 35 AUXILIARY-POWER-UNIT (APU) SUPPORT STRUTS

Page 131

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

54- NACELLES / PYLONS

00 00 NACELLES/PYLONS

50- 00 PYLON

50- 01 PYLON SKIN

50- 02 PYLON STRUCTURES

50- 03 PYLON STIFFENERS

50- 05 PYLON CHORDS

50- 07 PYLON RIBS

50- 21 PYLON FORWARD FAIRINGS

50- 22 PYLON SIDE FAIRINGS

50- 23 PYLON AFT FAIRINGS

50- 24 PYLON LINKS

50- 25 PYLON ACCESS PANELS

50- 26 PYLON MOVABLE FAIRINGS

Page 132

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

55- STABILIZERS

00 00 STABILIZERS

03- 00 STABILIZERS ACCESS PANELS

03- 27 HORIZONTAL STABILIZER ACCESS PANELS

03- 29 VERTICAL STABILIZER ACCESS PANELS

03- 31 ELEVATOR ACCESS PANELS

03- 33 RUDDER ACCESS PANELS

03- 53 DORSAL FIN ACCESS PANELS

04- 00 STABILIZERS POLYURETHANE FILMS

10- 00 HORIZONTAL STABILIZER

10- 01 HORIZONTAL STABILIZER SKIN

10- 02 HORIZONTAL STABILIZER STRUCTURES

10- 03 HORIZONTAL STABILIZER STRINGERS

10- 05 HORIZONTAL STABILIZER SPARS

10- 07 HORIZONTAL STABILIZER RIBS

11- 00 HORIZONTAL STABILIZER FITTINGS

14- 00 HORIZONTAL STABILIZER FAIRING

14- 21 HORIZONTAL STABILIZER SLIDING FAIRING

14- 23 HORIZONTAL STABILIZER SLIDING PLATES

14- 25 HORIZONTAL STABILIZER TIP FAIRING

14- 27 HORIZONTAL STABILIZER AERODYNAMIC SEAL

14- 29 HORIZONTAL STABILIZER TRAILING EDGE FAIRING

15- 00 HORIZONTAL STABILIZER LEADING EDGE

15- 01 HORIZONTAL STABILIZER LEADING EDGE SKIN

20- 00 ELEVATOR

20- 01 ELEVATOR SKIN

20- 02 ELEVATOR STRUCTURES

21- 00 HORIZONTAL STABILIZER-TO-ELEVATOR HINGE FITTINGS

24- 00 ELEVATOR FAIRINGS

Page 133

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

55- STABILIZERS

24- 35 ELEVATOR ROOT FAIRING

24- 37 ELEVATOR TIP FAIRING

30- 00 VERTICAL STABILIZER

30- 01 VERTICAL STABILIZER SKIN

30- 02 VERTICAL STABILIZER STRUCTURES

30- 03 VERTICAL STABILIZER STRINGERS

30- 05 VERTICAL STABILIZER SPARS

30- 07 VERTICAL STABILIZER RIBS

31- 00 VERTICAL STABILIZER FITTINGS

34- 00 VERTICAL STABILIZER FAIRINGS

34- 41 VERTICAL STABILIZER TIP FAIRING

34- 48 VERTICAL STABILIZER ROOT SEAL

34- 49 VERTICAL STABILIZER AERODYNAMIC SEAL

34- 51 DORSAL FIN

35- 00 VERTICAL STABILIZER LEADING EDGE

35- 01 VERTICAL STABILIZER LEADING EDGE SKIN

35- 02 VERTICAL STABILIZER LEADING EDGE NACA INTAKE

40- 00 RUDDER

40- 01 RUDDER SKIN

40- 02 RUDDER STRUCTURE

40- 21 RUDDER ROOT AERODYNAMIC SEAL

41- 00 VERTICAL STABILIZER-TO-RUDDER HINGE FITTINGS

44- 00 RUDDER FAIRINGS

44- 43 RUDDER ROOT FAIRING

44- 45 RUDDER TIP FAIRING

Page 134

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

56- WINDOWS

00 00 WINDOWS

10- 00 COCKPIT

11- 00 COCKPIT WINDSHIELD

12- 00 COCKPIT DIRECT-VISION WINDOW

12- 21 COCKPIT DIRECT-VISION WINDOW SEAL

20- 00 PASSENGER CABIN WINDOWS

20- 01 OVERWING ESCAPE-HATCH WINDOW

30- 00 DOOR WINDOW

Page 135

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

57- WINGS

00 00 WINGS

00- 21 WING POLYURETHANE FILMS

00- 23 WING ACCESS PANELS

00- 41 WING BALANCE-WEIGTH

01- 00 WING STUB

01- 01 WING STUB SKIN

01- 02 WING STUB STRUCTURES

01- 05 WING STUB SPARS

01- 07 WING STUB RIBS

01 21 WING STUB DAM

10- 00 WING MAIN BOX

10- 01 WING MAIN BOX SKIN

10- 02 WING MAIN BOX STRUCTURES

10- 03 WING MAIN BOX STIFFENERS

10- 05 WING MAIN BOX SPARS

10- 07 WING MAIN BOX RIBS

10- 21 WING MAIN BOX ACCESS PANELS

20- 00 OUTER WING

20- 01 OUTER WING SKIN

20- 02 OUTER WING STRUCTURES

20- 05 OUTER WING SPARS

20- 07 OUTER WING RIBS

20- 08 OUTER WING LANDING GEAR FITTINGS

20- 21 OUTER WING ACCESS PANELS

30- 00 WING TIP

30- 01 WING TIP SKIN

30- 02 WING TIP STRUCTURES

35- 00 WINGLET

35- 01 WINGLET SKIN

35- 02 WINGLET STRUCTURES

35- 05 WINGLET SPARS

Page 136

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

57- WINGS

35- 07 WINGLET RIBS

35- 16 WINGLET LEADING EDGE

35- 21 WINGLET LEADING EDGE POLYURETHANE FILM

36- 00 ANTI COLISION LIGHT FAIRING

40- 00 LEADING EDGE

40- 01 LEADING EDGE SKIN

41- 00 SLAT 1

41- 01 SLAT SKIN

41- 02 SLAT 1 STRUCTURES

41- 03 SLAT 1 GIRDERS

41- 05 SLAT 1 SPAR

41- 07 SLAT 1 RIBS

41- 08 SLAT 1 LONGITUDINAL AND CHORDWISE SEALS

41- 09 SLAT 1 LOWER SEALS

41- 10 SLAT 1 END SEAL

42- 00 SLAT 2

42- 01 SLAT 2 SKIN



42- 05 SLAT 2 SPAR

42- 07 SLAT 2 RIBS



42- 11 SLAT 2 WEATHER SEAL

43- 00 SLAT 3

43- 01 SLAT 3 SKIN



43- 05 SLAT 3 SPAR

Page 137

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

57- WINGS

43- 07 SLAT 3 RIBS




44- 00 SLAT 4

44- 01 SLAT 4 SKIN



44- 04 SLAT 4 RIBS

44- 05 SLAT 4 SPAR




45- 00 SLAT 1 TRACKS AND RACKS

45- 01 LH/RH SLAT 1 THRU 4 SPHERICAL BEARINGS

45- 02 LH/RH SLAT 1 THRU 4 TRACK SPHERICAL BEARINGS

45- 03 LH/RH SLAT 1 THRU 4 TRACK ROLLERS




49- 00 WING LEADING EDGE

49- 01 WING LEADING EDGE SKIN

49- 02 WING LEADING EDGE STRUCTURES

49- 03 WING LEADING EDGE STRINGER

49- 07 WING LEADING EDGE RIBS

49- 20 WING-ROOT LANDING-LIGHT-LENS FAIRING

49- 21 WING-ROOT LANDING-LIGHT-LENS FAIRING POLYURETHANE FILM

49- 23 WING LEADING EDGE ACCESS PANELS

Page 138

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

57- WINGS

50- 00 TRAILING EDGE

50- 01 TRAILING EDGE SKIN

50- 09 WING TRAILING-EDGE SEAL

50- 10 AILERON CABLE FAIRLEAD

51- 00 FLAP FITTINGS

51- 02 FLAP AERODYNAMIC SEALS

52- 00 INBOARD FLAP

52- 01 INBOARD FLAP SKIN

52- 02 INBOARD FLAP STRUCTURES

52- 03 INBOARD MAIN-FLAP TRACKS

53- 00 INBOARD AFT FLAP

53- 01 INBOARD AFT FLAP SKIN

53- 03 INBOARD AFT-FLAP TRACKS

54- 00 INBOARD FLAP MECHANISM

54- 21 INBOARD FLAP TRACK SUPPORT

54- 23 INBOARD FLAP MAIN TRACK

54- 25 INBOARD FLAP AFT TRACK

54- 27 INBOARD FLAP MAIN CARRIAGES

54- 28 INBOARD-FLAP AFT CARRIAGES

54- 29 INBOARD FLAP BELLCRANK ASSEMBLY

54- 30 INBOARD FLAP ROD ASSY

55- 00 OUTBOARD FLAP

55- 01 OUTBOARD FLAP SKIN

55- 03 OUTBOARD FLAP TRACKS

56- 00 OUTBOARD AFT FLAP

56- 01 OUTBOARD AFT FLAP SKIN

57- 00 OUTBOARD FLAP MECHANISM

57- 31 OUTBOARD FLAP TRACK SUPPORT

57- 33 OUTBOARD FLAP MAIN TRACK

57- 35 OUTBOARD FLAP AFT TRACK

57- 37 OUTBOARD FLAP MAIN CARRIAGES

57- 38 OUTBOARD FLAP AFT CARRIAGES

Page 139

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

57- WINGS

57- 39 OUTBOARD FLAP BELLCRANK ASSEMBLY

57- 40 OUTBOARD FLAP ROD ASSY

58- 00 INBOARD AND OUTBOARD FLAP FAIRINGS

58- 21 INBOARD FLAP ROOT FAIRINGS

58- 23 INBOARD FLAP TRACK FAIRINGS

58- 25 OUTBOARD FLAP TRACK FAIRINGS

58- 27 OUTBOARD-AFT FLAP TRACK ADDITIONAL FAIRINGS

59- 00 FLAP SHROUDS

60- 00 AILERON GENERAL

60- 01 AILERON SKIN

61- 00 AILERON HINGE FITTINGS

68- 00 AILERON SHROUDS

70- 00 SPOILERS

71- 00 SPOILER HINGE FITTINGS

72- 00 SPOILER 1

72- 01 SPOILER 1 SKIN

73- 00 SPOILER 2


74- 00 SPOILER 3


75- 00 SPOILER 4


76- 00 SPOILER 5


Page 140

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

71- POWERPLANT

00 00 POWERPLANT

00- 01 POWERPLANT SYSTEM

00- 02 POWERPLANT PANEL

10- 00 COWLING

11- 00 FAN COWL ASSEMBLY

11- 01 FAN COWL SKIN

11- 02 FAN COWL STRUCTURES

11- 03 FAN COWL STRAKE

11- 21 FAN COWL HINGE

11- 23 FAN COWL LATCH

13- 00 AFT CORE COWL ASSEMBLY

13- 01 AFT CORE COWL SKIN

13- 02 AFT CORE COWL STRUCTURES

13- 07 AFT CORE COWL RIBS

13- 08 AFT CORE COWL OVERPRESSURE RELIEF DOOR

13- 21 AFT CORE COWL HINGE

13- 23 AFT CORE COWL LATCH

15- 00 HOLD-OPEN RODS ASSEMBLY

15- 01 FAN COWL HOLD-OPEN RODS

15- 03 AFT CORE COWL HOLD-OPEN RODS

20- 00 MOUNTS AND EBU

21- 00 ENGINE MOUNT

21- 01 ENGINE AFT MOUNT

21- 03 ENGINE FORWARD MOUNT

22- 00 ENGINE VIBRATION CONTROL SYSTEM - EVCS

22- 01 ENGINE VIBRATION CONTROL SYSTEM - CON-TROL MODULE (EVCS-CONTROL MODULE)

22- 03 ENGINE VIBRATION CONTROL SYSTEM - CON-TROL MODULE HARNESSES

Page 141

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

71- POWERPLANT

22- 05 ENGINE VIBRATION CONTROL SYSTEM - ACTUATOR (EVCS-ACTUATOR)

22- 07 ENGINE VIBRATION CONTROL SYSTEM - ACTUATOR HARNESSES

30- 00 FIRESEALS SYSTEM

30- 01 ENGINE FIREZONE

30- 02 ENGINE FIREWALL

31- 00 THRUST REVERSER SEALS

31- 01 THRUST REVERSER - REAR SEAL

31- 02 THRUST REVERSER - LOWER BIFURCATION SEAL

31- 03 THRUST REVERSER - UPPER BIFURCATION SEAL

31- 04 THRUST REVERSER - PYLON SEAL

40- 00 ATTACH FITTINGS

50- 00 ELECTRICAL HARNESSES

50- 01 ENGINE ELECTRICAL HARNESSES

50- 02 ENGINE T1.2 ELECTRICAL HARNESSES (W13 AND w14 ELECTRICAL HARNESSES)

50- 03 ENGINE W1 AND W2 ELECTRICAL HAR-NESSES

50- 04 ENGINE W8A ELECTRICAL HARNESS

50- 05 ENGINE W9B ELECTRICAL HARNESS


50- 07 ENGINE W3 ELECTRICAL HARNESS







50- 14 ENGINE W8C ELECTRICAL HARNESS


Page 142

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

71- POWERPLANT




50- 19 ENGINE W10C ELECTRICAL HARNESS






60- 00 AIR INTAKES

61- 00 AIR INLET MODULE ASSEMBLY

61- 01 AIR INLET MODULE SKIN

61- 02 AIR INLET MODULE STRUCTURES

61- 03 AIR INLET MODULE NOSE CAP

61- 07 AIR INLET MODULE RIBS

70- 00 ENGINE DRAINS

71- 00 ENGINE DRAIN TUBES ASSEMBLY

71- 01 ENGINE DRAIN TUBES

71- 02 ENGINE DRAIN MAST ASSEMBLY

Page 143

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

72- ENGINE

00 00 ENGINE

20- 00 COLD SECTION MODULE

21- 00 FAN ROTOR ASSEMBLY

21- 01 FORWARD SPINNER

21- 02 ENGINE FAN SPINNER

21- 03 AFT SPINNER

21- 05 FAN BLADES

21- 07 FAN ROTOR DISK

21- 09 NO. 1 BEARING (ANNULAR BEARING)

21- 11 NO. 2 BEARING (CYLINDRICAL ROLLER)

21- 13 FAN DRIVE SHAFT

22- 00 ENGINE INLET

22- 02 ENGINE INLET LIP

23- 00 FAN STATOR ASSEMBLY

23- 01 FAN BLADE CONTAINMENT CASE

23- 02 FAN OUTLET GUIDE VANE FRAME

23- 03 TIE ROD

23- 04 A5 SEAL

30- 00 COMPRESSOR SECTION

31- 00 ENGINE FRONT FRAME ASSEMBLY

31- 01 NO. 3 BEARING (ANNULAR BEARING)

31- 03 ENGINE BOOSTER

32- 00 COMPRESSOR STATOR ASSEMBLY

32- 01 COMPRESSOR CASE

32- 02 COMPRESSOR VARIABLE AND STATIONARY VANES

32- 03 ACTUATING RING

32- 04 VARIABLE GEOMETRY ACTUATOR

32- 05 STAGE 4 SHUT OFF VALVE DUCT

33- 00 COMPRESSOR ROTOR ASSEMBLY

33- 01 COMPRESSOR ROTOR BLADES

33- 02 STAGE 1 AND STAGE 2 COMPRESSOR BLISK

33- 03 STAGE 3 COMPRESSOR BLISK

33- 04 COMPRESSOR ROTOR FORWARD SHAFT

Page 144

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

72- ENGINE

33- 05 COMPRESSOR ROTOR AFT SHAFT

33- 06 COMPRESSOR DISCHARGE SEAL

33- 07 VORTEX SPOILER

33- 09 COMPRESSOR BLEED AIR PORTS

33- 11 ENGINE RELIEF DOORS

40- 00 COMBUSTION SECTION

41- 00 B-SUMP

41- 01 NO. 4 BEARING (TRILOBED BEARING)

41- 02 FORWARD CARBON SEAL

41- 03 AFT CARBON SEAL

41- 04 STATIONARY CDP SEAL

41- 05 NO. 4 BEARING AIR SEAL

41- 06 THERMAL BLANKET

44- 00 COMBUSTION LINER AND S1 NOZZLE ASSEM-BLY

44- 01 COMBUSTION LINER

50- 00 TURBINE SECTION

51- 00 HIGH PRESSURE TURBINE ROTOR ASSEMBLY

51- 01 STAGE 1 FORWARD COOLING PLATE

51- 03 STAGE 1 ROTOR DISK

51- 05 STAGE 2 FORWARD COOLING PLATE


53- 00 HIGH PRESSURE TURBINE STATOR ASSEM-BLY

53- 01 STAGE 2 NOZZLE SEGMENT

53- 03 SHROUD SEGMENTS

56- 00 LOW PRESSURE TURBINE

57- 00 LOW PRESSURE TURBINE STATOR ASSEMBLY

57- 01 STAGE 3 NOZZLE




57- 09 NO. 5 BEARING HOUSING

Page 145

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

72- ENGINE

57- 11 NO. 5 BEARING - CYLINDRICAL ROLLER

58- 00 LOW PRESSURE TURBINE ROTOR ASSEMBLY





59- 00 TURBINE EXHAUST FRAME ASSEMBLY

59- 01 EXHAUST FRAME

59- 03 EXHAUST CENTERBODY

60- 00 ACCESSORY DRIVE SECTION

62- 00 POWER TAKE OFF ASSEMBLY

63- 00 ACCESSORY GEARBOX COMPONENTS

64- 00 ACCESSORY GEARBOX ASSEMBLY

64- 01 ACCESSORY GEARBOX

Page 146

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

73- ENGINE FUEL AND CONTROL

00 00 ENGINE FUEL AND CONTROL

10- 00 ENGINE FUEL DISTRIBUTION

11- 00 FUEL DISTRIBUTION SYSTEM

11- 01 FUEL PUMP

11- 03 FUEL MANIFOLD

11- 05 FUEL INJECTOR NOZZLES

11- 07 HOSES/TUBES, FUEL DISTRIBUTION SYSTEM

11- 09 MOTIVE FLOW/MAIN FUEL SUPPLY LINES

20- 00 ENGINE FUEL CONTROLLING

21- 00 FUEL CONTROLLING SYSTEM

21- 01 FULL AUTHORITY DIGITAL ELECTRONIC CON-TROL (FADEC)

21- 03 FUEL METERING UNIT (FMU)

21- 05 ENGINE FUEL FILTER ELEMENT

21- 07 FUEL FILTER IMPENDING BYPASS SWITCH

21- 08 FUEL FILTER DELTA PRESSURE INDICATOR

21- 09 P3 AIR TUBE

21- 11 PERMANENT MAGNET ALTERNATOR (PMA)

30- 00 ENGINE FUEL INDICATING

31- 00 FUEL INDICATING SYSTEM

31- 01 FUEL LOW-PRESSURE SWITCH

Page 147

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

74- IGNITION

00 00 IGNITION

10- 00 IGNITION ELECTRICAL-POWER-SUPPLY

11- 00 IGNITION POWER SUPPLY

11- 01 IGNITION EXCITER

11- 03 IGNITION EXCITER RELAY

20- 00 DISTRIBUTION

20- 01 IGNITION LEAD

20- 03 IGNITERS

20- 05 IGNITION HARNESS

30- 00 SWITCHING

31- 00 POWERPLANT-PANEL IGNITION SWITCHES

31- 01 IGNITION SWITCH

Page 148

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

75- AIR

00 00 AIR

20- 00 COOLING AND SEALING

21- 00 AIR SEAL SYSTEM

21- 01 SEAL-PRESSURE REGULATOR VALVE

22- 00 A5 SEAL SYSTEM

22- 01 A5 SEAL

22- 03 A5 SEAL PRESSURE PIPE

23- 00 TURBINE CLEARANCE CONTROL

23- 01 HIGH PRESSURE TURBINE ACTIVE CLEAR-ANCE CONTROL VALVE

23- 02 LOW PRESSURE TURBINE ACTIVE CLEAR-ANCE CONTROL VALVE

30- 00 COMPRESSOR CONTROL

31- 00 COMPRESSOR CONTROL ACTUATION

31- 01 MASTER-COMPRESSOR VARIABLE-GEOME-TRY (CVG) ACTUATOR

31- 03 SLAVE-COMPRESSOR VARIABLE-GEOMETRY (CVG) ACTUATOR

31- 04 VARIABLE STATOR VANE ACTUATOR

32- 00 COMPRESSOR BLEED-CONTROL-SYSTEM

32- 01 OPERABILITY-BLEED-VALVE

32- 02 VARIABLE BLEED VALVE ACTUATOR

32- 03 TRANSIENT BLEED VALVE

Page 149

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

76- ENGINE CONTROLS

00 00 ENGINE CONTROLS

10- 00 THRUST CONTROL

10- 01 THRUST CONTROL HARNESS

11- 00 THRUST CONTROL QUADRANT

11- 01 THRUST CONTROL QUADRANT (TCQ) ASSEM-BLY

11- 03 THRUST CONTROL QUADRANT (TCQ) EDGE LIGHT PANEL

11- 05 THRUST CONTROL QUADRANT (TCQ) SLOT CLOSURE

12- 00 ELECTRONIC CONTROL SYSTEM

12- 01 ENGINE CONFIGURATION PLUG

20- 00 EMERGENCY SHUTDOWN

Page 150

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

77- ENGINE INDICATING

00 00 ENGINE INDICATING

10- 00 POWER

11- 00 N1 INDICATING SYSTEM

11- 01 N1 FAN SPEED SENSOR

12- 00 N2 INDICATING SYSTEM

12- 01 N2 SPEED SENSOR

13- 00 BLEED INDICATING SYSTEM

13- 01 DELTA P3 SENSOR

20- 00 TEMPERATURE

21- 00 TEMPERATURE INDICATING SYSTEM

21- 01 FAN INLET TEMPERATURE TRANSMITTER (T2 SENSOR)

21- 02 T2 HEATER RELAYS

21- 03 LOWER THERMOCOUPLE ASSEMBLY (T4.5 SENSOR)

21- 05 UPPER THERMOCOUPLE ASSEMBLY (T4.5 SENSOR)

21- 07 ENGINE T4.5

21- 08 T1.2 TEMPERATURE SENSOR

21- 09 T2.5 TEMPERATURE SENSOR

21- 10 T3 TEMPERATURE SENSOR

21- 11 TCASE TEMPERATURE SENSOR

21- 12 LOWER EGT PROBE ASSEMBLY

21- 13 UPPER EGT PROBE ASSEMBLY

30- 00 ANALYZERS

31- 00 ENGINE VIBRATION MONITORING SYSTEM

31- 01 ENGINE VIBRATION MONITOR (EVM) MODULE

31- 03 ACCELEROMETER

40- 00 INTEGRATED ENGINE INSTRUMENT SYSTEM

41- 00 ENGINE MAINTENANCE SYNOPTIC DISPLAY

Page 151

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

78- EXHAUST

00 00 EXHAUST

10- 00 PRIMARY EXHAUST

10- 01 PRIMARY EXHAUST NOZZLE

10- 03 PRIMARY EXHAUST CENTERBODY

10- 05 CENTER VENT TUBE

30- 00 THRUST REVERSER

30- 01 THRUST REVERSER

30- 02 THRUST REVERSER OPENING ACTUATOR

30- 03 THRUST- REVERSER POWER DOOR OPEN-ING (PDO) ACTUATOR

31- 00 THRUST REVERSER STRUCTURE

31- 01 THRUST-REVERSER TRANSCOWL SKINS

31- 02 THRUST-REVERSER COWL STRUCTURES

31- 04 THRUST REVERSER COWL FRAME

31- 05 THRUST REVERSER SEALS

31- 17 THRUST REVERSER BEAMS

31- 21 THRUST REVERSER TRANSCOWL

31- 22 THRUST-REVERSER INNER FIXED-STRUC-TURE (IFS)

31- 23 THRUST REVERSER TRANSCOWL LATCHES

31- 24 THRUST-REVERSER INNER FIXED-STRUC-TURE (IFS) LATCHES

31- 25 THRUST-REVERSER TRANSCOWL-TRACK LIN-ERS

31- 26 THRUST-REVERSER OUTER V-GROOVE (OVG) TORQUE BOX LATCH

31- 27 THRUST-REVERSER LATCH BEAM LATCHES

31- 28 THRUST REVERSER TRANSCOWL LATCH-DOOR ASSEMBLY

31- 29 AFT CORE COWL LATCH

31- 30 THRUST-REVERSER ACCESS DOORS AND FAIRINGS

31- 31 THRUST REVERSER CASCADES

32- 00 THRUST-REVERSER ACTUATION SYSTEM

32- 01 THRUST-REVERSER LOCKING ACTUATOR

Page 152

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

78- EXHAUST

32- 03 THRUST-REVERSER FEEDBACK ACTUATOR

32- 05 THRUST-REVERSER ELECTRO-HYDRAULIC COWL-LOCK (EHCL)

32- 07 MANUAL DRIVE

32- 10 TRANSMISSION

32- 11 SYNCHRONIZING SHAFT

32- 12 FLEXIBLE TUBE

32- 13 RIGID TUBE

33- 00 THRUST REVERSER CONTROL

33- 01 ISOLATION CONTROL UNIT (ICU)

33- 02 GROUND MAINTENANCE OVERRIDE (GMO) SWITCH

33- 05 DIRECTION CONTROL UNIT (DCU)

33- 07 THRUST-REVERSER (ICU) RELAYS

33- 09 THRUST-REVERSER DCU/COWL-LOCK RELAYS

34- 00 THRUST REVERSER INDICATING

34- 02 THRUST-REVERSER LOCK SWITCH

Page 153

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

79- OIL

00 00 OIL

10- 00 STORAGE

11- 00 OIL TANK SYSTEM

11- 01 OIL TANK

11- 03 OIL TANK PRESSURIZING VALVE

11- 05 OIL FILL CAP

11- 07 FLAPPER VALVE

11- 08 VENT VALVE

11- 09 TANK DRAIN PLUG

11- 11 OIL LEAKS

12- 00 ACCESSORY GEARBOX (AGB)

12- 01 AGB DRAIN PLUG

12- 03 AIR OIL SEPARATOR

20- 00 OIL DISTRIBUTION

21- 00 OIL FILTER

21- 01 LUBE AND SCAVENGE OIL PUMP

21- 03 OIL FILTER MODULE

21- 05 ENGINE OIL FILTER ELEMENT

21- 07 FUEL/OIL HEAT EXCHANGER

21- 08 SERVO FUEL/OIL HEAT EXCHANGER

21- 09 OIL SCAVENGE SCREENS

21- 11 LUBE AND SCAVENGE HOSES AND TUBES

21- 13 OIL FILTER BOWL

30- 00 OIL INDICATING

31- 00 OIL TEMPERATURE/QUANTITY INDICATING

31- 01 OIL LEVEL/TEMPERATURE SENSOR

31- 03 OIL TANK OIL LEVEL INDICATOR

31- 05 OIL TANK OIL LEVEL INDICATOR RELAY

33- 00 OIL PRESSURE INDICATING

33- 01 LOW OIL PRESSURE SWITCH

33- 03 OIL PRESSURE TRANSMITTER

33- 05 PUMP RELIEF VALVE

34- 00 OIL FILTER BYPASS WARNING INDICATING

34- 01 OIL FILTER BYPASS SENSOR

34- 03 OIL FILTER BYPASS VALVE

Page 154

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

79- OIL

35- 00 CHIP DETECTOR INDICATING

35- 01 CHIP DETECTOR

35- 03 SELF-CLOSING VALVE

Page 155

September 28/10

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

80- STARTING

00 00 STARTING

10- 00 CRANKING

10- 01 AIR TURBINE STARTER (ATS)

10- 02 STARTER CONTROL VALVE (SCV)

10- 03 AIR TURBINE STARTER (ATS) DUCTS

10- 05 EMERGENCY START SWITCH


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

91- CHARTS

00 00 CHARTS

10- 00 VENDORS LIST

10- 01 EQUIPMENT LIST

10- 02 HOOK-UP CHART

10- 03 WIRE LIST

10- 04 COMPONENTS LOCATION

10- 13 HARNESS LCTN DIAGRAM ISPDA

11- 00 STATION DIAGRAM

11- 01 BODY STATION DIAGRAM

11- 02 FORWARD FUSELAGE STATION DIAGRAM

11- 03 CENTER FUSELAGE I STATION DIAGRAM

11- 04 CENTER FUSELAGE II STATION DIAGRAM

11- 05 CENTER FUSELAGE III DIAGRAM

11- 06 REAR FUSELAGE STATION DIAGRAM

11- 07 WING AND WINGLET STATION DIAGRAM

12- 00 GROUND STUD LOCATION

12- 01 GROUND LCTN DIAGRAM FWD FUSELAGE NOSE

12- 02 GROUND LCTN DIAGRAM COCKPIT FLOOR

12- 03 GROUND LCTN DIAGRAM FWD CENTRAL FUSELAGE I

12- 04 GROUND LCTN DIAGRAM CENTRAL FUSE-LAGE I - FLOOR

12- 05 GROUND LCTN DIAGRAM FWD CENTRAL FUSELAGE II

12- 06 GROUND LCT DIAGRAM CENTRAL FUSELAGE II - FLOOR

12- 07 GROUND LCTN DIAGRAM AFT CENTRAL FUSELAGE II

12- 08 GROUND LCTN DIAGRAM WING FAIRING

12- 10 GROUND LCTN DIAGRAM CENTRAL FUSE-LAGE III - FLOOR

Page 157

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

91- CHARTS

12- 11 GROUND LCTN DIAGRAM TAIL CONE

12- 12 GROUND LCTN DIAGRAM HORIZONTAL STABI-LIZER

13- 01 SPLICE REGION LCTN DIAGRAM FORWARD FUSELAGE

13- 02 SPLICE REGION LCTN DIAGRAM FWD CEN-TRAL I

13- 03 SPLICE REGION LCTN DIAGRAM CENTRAL FUS I

13- 04 SPLICE REGION LCTN DIAGRAM CENTRAL FUS II



13- 07 SPLICE REGION LCTN DIAGRAM CENTRAL FUS III

13- 08 SPLICE REGION LCTN DIAGRAM TAIL CONE

14- 00 RELAY LOCATION

14- 01 FORWARD ELECTRONIC COMPARTMENT-RELAY LOCATION

14- 02 MIDDLE ELECTRONIC COMPARTMENT-RELAY LOCATION

14- 03 REAR ELECTRONIC COMPARTMENT-RELAY LOCATION

14- 04 AICC - AUXILIARY INTEGRATED CONTROL CENTER-RELAY LOCATION

14- 05 EICC - ESSENTIAL CONTROL CENTER-RELAY LOCATION

14- 06 LICC - LEFT INTEGRATED CONTROL CENTER-RELAY LOCATION

14- 07 RICC - RIGHT INTEGRATED CONTROL CEN-TER-RELAY LOCATION

20- 00 HARNESS LOCATION

20- 50 HARN LCTN DIAGRAM FORWARD FUSELAGE

Page 158

September 28/10


SYSTEM /CHAPTER


SECTION

UNIT /SUBJECT

TITLE

91- CHARTS

20- 51 HARN LCTN DIAGRAM COCKPIT PANEL

20- 52 HARN LCTN DIAGRAM FORWARD CENTRAL FUSELAGE I

20- 53 HARN LCTN DIAGRAM CENTRAL FUSELAGE I

20- 54 HARN LCTN DIAGRAM FORWARD CENTRAL FUSELAGE II

20- 55 HARN LCTN DIAGRAM CENTRAL FUSELAGE II

20- 56 HARN LCTN DIAGRAM AFTER CENTRAL FUSE-LAGE II

20- 57 HARN LCTN DIAGRAM WING FAIRING

20- 58 HARN LCTN DIAGRAM WING

20- 59 HARN LCTN DIAGRAM CENTRAL FUSELAGE III

20- 60 HARN LCTN DIAGRAM TAIL CONE

20- 61 HARN LCTN DIAGRAM EMPENNAGE

20- 62 HARN LCTN DIAGRAM ENGINE

20- 63 HARN LCTN DIAGRAM ANTENNA

20- 64 HARN LCTN DIAGRAM POWER CABLE

20- 65 HARN LOCATION DIAGRAM IFE/CSS SYSTEM

20- 66 HARN LCTN DIAGRAM PAX CABIN PC PWR OUTLET

Page 159

September 28/10

ata specification breakdown manual

Documents