what attacks steel_pipes_borecasing_underground

Bore Casing & Screens Pipes & Components Environmental Drilling Water Treatment Safety Products Sand Spears Pumps

Article

Ph 1300 133 000

What Attacks Steel Casing ?

Ph 1300 133 000

In this article we will discuss some of the major enemies of steel pipe, which are laid underground and the ways to minimize it in the best possible way

Ph 1300 133 000

This can be in the form of Borecasing, Rising Main, Steel Column and Shaft

Ph 1300 133 000

There are 3 Main culprits.

Ph 1300 133 000

1: Stray Currents

Ph 1300 133 000

2: Total Dissolved Salts

Ph 1300 133 000

3: Ground Water Quality

Ph 1300 133 000

One of the major threats to underwater steel pipes are DC currents as well as AC currents which can also be termed as the stray currents.

Ph 1300 133 000

This is caused by immersion of steel pipes in a conductive medium.

Ph 1300 133 000

It basically happens when two different types of metals are in the ground

Ph 1300 133 000

Specially if there are at opposite ends on the Galvanic scale.

Ph 1300 133 000

Steel Column and casing in the ground has seen a noticeable difference in lifetime spans over the last 8 years

Ph 1300 133 000

In some areas we have seen the lifetime gone from 15 years plus, to 2 years or less

Ph 1300 133 000

Most of the stray currents which can be both AC andDC come from electrical wiring, that is laid underground or earthed in the ground.

Ph 1300 133 000

Most of the AC currents comes from the leakage from local power lines, this can be rectified by

the authorities.

Case Study

Ph 1300 133 000

DC currents, the local catholic protection of the electric fencing etc, earthing should be Installed correctly to minimize stray current.

Case Study

Ph 1300 133 000

This can be checked by a Standard Voltage and Amp meter.

Ph 1300 133 000

If you have a electric fence or telephone lines near your steel pipelines,

Ph 1300 133 000

then you are prone to lose almost 40 pounds or 18 kgs of steel annually by only 2 AMPs of DC current. That is why periodic check up by the local power authorities or a electrician must be done.

Ph 1300 133 000

Even sacrificial anode attached to the steel pipes, will make a difference.

Ph 1300 133 000

Now, the second biggest enemy of the steel pipes is the TDS(Total Dissolved Salts).

Ph 1300 133 000

If the concentration is above 700 ppm then the pipelines are prone to corrosion.

Ph 1300 133 000

TDS meters are easily available or you can have a water sample checked before laying pipelines or installation of casing and Column and periodically inspection is suggested.

Ph 1300 133 000

The higher the TDS, the higher will be the potential of corrosion taking place.

Ph 1300 133 000

The third problem with the steel pipes is the ground water, which is quite prone to the high bacterial concentration.

Ph 1300 133 000

The corrosive enzymes released by some of the bacteria present underground, increases the steel pipes corrosion by almost 250%.

Ph 1300 133 000

Most common type of bacteria are sulphate reducing as well as the Iron reducing bacteria.

Ph 1300 133 000

Both of them at humid conditions, help in a faster corrosion of the steel pipes.

Ph 1300 133 000

Other Prime causes are Iron Biofouling

Ph 1300 133 000

The most common way is to get the water checked and then apply a general alkaline solution to the outer perimeter of the pipes and even look at other solutions to this problem.

Ph 1300 133 000

The coli form count of the underground water is also one of the major problems that the urban

cities are facing.

Ph 1300 133 000

The E.Coli and the coli form count of the ground water must be checked periodically and therefore should be treated by alkaline solution and other disinfectants.

Ph 1300 133 000

You need to be aware of the potential dangers and take periodic checks of the TDS, PH, Stray current , the bacterial concentration and the ground water analysis and act according to the results urgently.

Ph 1300 133 000

How can I minimize this Problem?

Ph 1300 133 000

Check earth stakes are working and in good condition

Ph 1300 133 000

Check for Stray Voltages

Ph 1300 133 000

Neutralize water conditions

Ph 1300 133 000

Use Non Corrosive materials

Ph 1300 133 000

Similar metals on the galvanic scale

Thank you for taking the time to look at the information we have created for you,We hope this will be of assistance to solving your piping, drainage and drilling challenges.

If you have any more questionsPlease feel free to contact myself or one of our team

Article

For more Articles, Case Studies, How to and Information go to www.deps.com.au

then click onto Handy Linksor contact us on1300 133 000

askus@deps.com.au

Case Study

Ph 1300 133 000

SlottingCuttingFabricatingPipe TestingPerforationDrawingsSpear PointsSafetyPumps

Deps Products and Capabilities

ThreadingTurningWeldingSlitting

DesigningWater Treatment

PipeDrilling products

Pipe Fittings

Ph 1300 133 000

Solving your Piping, Drilling and

Drainage Challenges

with Trust and Integrity

what attacks steel_pipes_borecasing_underground

steel pipes corrosion

steel pipelines

steel column

underwater steel pipes

immersion of steel pipes

kgs of steel

stray currents

underground water

Business

panic er final… · what keeps panic attacks going? often...

denial of service attacks - department of computer...

the best dr and “undo” virus attacks!! what can zerto do...

ddos attacks and what to do about them

what are panic attacks?

attacks attacks and attacks!

what causes heart attacks - wordpress.com · 2014-10-26 ·...

server-side web security (part 1 - attacks)...we illustrate...

terrorist attacks and financial markets - ifo.de · what is...

lethal client side attacks using powershell · pdf file ·...

web application security. agenda attacks types web...

dos attacks..by aleksei zaitsenkov. outline “dos...

security and verification lecture 3: what kind of attacks...

what are malicious attacks? malicious attacks are any...

emp attacks—what the u.s. must do now

what to do when social media attacks your brand

distributed denial of service attacks - cornell...

the who, what, why and how of ddos attacks: a guide …

cloudflare ddos attacks 101: what are they and how to...

distributed denial of service - cisco - global home …name:...