quick reference guide - rmc water control · pdf filerelief valve selection guide determine...
Post on 31-Jan-2018
256 Views
Preview:
TRANSCRIPT
Quick Reference Guide
What Valves Do I Need?
Mains
Supply
LIMITED
TEMPERATU
RE WATER
(50-70°C NO
T for sanitary devicesintended for personal hygiene purposes as per A
S3500)
UN
CON
TROLLED
HO
T WATER
(At w
ater heater set temperature
or uncontrolled heat source)
For Controlled Pressure Water H
eater: Dom
estic BuildingValves �tted at the H
eater
ControlledPressure Storage
Water H
eater
HeatGuard(Blue Cap)
# Isolating Valve
# Isolating Valve
# Isolating Valve
# Isolating Valve
Inlet Controls
LS50* H
50PSL50
TEMPERED
WATER
(50°C maxim
um for sanitary devices
intended for personal hygiene purposes as per A
S3500)
# Optional
* Mandatory in som
e states
* PRVN
I50
P&T
Relief Valve
Primary TemperatureControl Valve
(Red Cap) - Optional
RMC™ valves meet the needs of the wide variety of hot water systems on the market and the differing plumbing regulations around Australia. We offer the lot - it’s why we’re the number one choice in plumbing valves.
Please refer to your local plumbing authority for system valve requirements in addition to water heater manufacturers’ installation requirements – the general schematic below shows you “what goes where”:
HeatGuard™ Tempering Valve Selection Guide
SYSTEMHEATGUARD
BLUE CAP(STANDARD)
HEATGUARD ULTRAORANGE CAP
(HIGH PERFORMANCE)
HEATGUARD ULTRA HFLARGE ORANGE CAP
(HIGH FLOW)
Mains pressure storage
Stable supply pressure Fluctuating supply pressure - -Solar
Suitable for mains pressure solar - Suitable for gravity fed solar - - Suitable for uncontrolled heat source - Heat Pump
Continuous flow water heaters - -Instantaneous water heaters - -Heat exchange water heaters - -Pumped ring main and trace heated systems with fluctuating supply pressures - -Low pressure storage - - Valve fitted remote from water heater near point of use - -
Relief Valve Selection Guide
Determine the P&T Pressure Setting
Check you have the correct P&T Valve Configuration1. If the water heater is a new installation, check that the P&T
valve provided is rated the same as the working pressure of the water heater.
2. If the valve is a replacement valve (e.g. for maintenance purposes), ensure that the replacement P&T valve is of the exact same configuration and pressure setting as the valve it is replacing.
Step One
Step Two
100Litre
Model Number: 9312782Serial Number: XZ65414Max Working Pressure: 1000 kPaMax Supply (No ECV): 800 kPaMax Supply (With ECV): 680 kPaEC Valve Setting: 850 kPa
Example: Water Heater Rating information sticker.
The P&T Relief valve setting should be the same as the working pressure on the water heater rating label
P&T Set Pressureon the heater label
Determine the correct valve combinationMatch the Reliance P&T Relief Valve with an Expansion Control Valve with a rating cap of the same colour.
Step Three
Rating Cap Colour
P&T ReliefExpansion
Control
Pressure Limiting
ValveBlack 700 kPa 550 kPa 350 kPaBlue 850 kPa 700 kPa 500 kPa
Green 1000 kPa 850 kPa 500 kPaRed 1400 kPa 1200 kPa 600 kPa
P & T Relief Valve Expansion Control Valve
The Water Heater Manufacturer
Standards Approved
Want more information?Call our national customer
service hotline 1800 810 803
or visit www.rmc.com.au
Download a QR code reader on your smartphone and scan this to go to the RMC website.
Uniquely Australian
RMC brand valves are the premier choice of valves in the Australian plumbing marketplace. Offering a complete range of valves including thermostatic mixing valves, combination non-return and isolating valves, pressure control, temperature control and expansion control valves. RMC is the leader in water flow control.
RMC valves are tested and certified here in Australia under the WaterMark Certification Scheme, ensuring they are fit for purpose and authorised for use in all plumbing and drainage installations.
INSULATION KITS
VC137 P&T Valve, HT/H Valve, Tempering Valve
HT1012 HT/H Valve
MX1951 Tempering Valve
PRESSURE LIMITING VALVES
PS Range
PSL Range
PS501 15mm Female x Female 350 kPa
PS502 15mm Female x Female 500 kPa
PS503 15mm Female x Female 600 kPa
PSC501 15mm Male Compression 350 kPa
PSC502 15mm Male Compression 500 kPa
PSC503 15mm Male Compression 600 kPa
PS701 20mm Female x Female 350 kPa
PS702 20mm Female x Female 500 kPa
PS703 20mm Female x Female 600 kPa
PS1001 25mm Female x Female 350 kPa
PS1002 25mm Female x Female 500 kPa
PS1003 25mm Female x Female 600 kPa
PSL511 15mm Female x Female 350 kPa
PSL512 15mm Female x Female 500 kPa
PSL513 15mm Female x Female 600 kPa
PSLA511 15mm Internal Flare 350 kPa
PSLA512 15mm Internal Flare 500 kPa
PSLA513 15mm Internal Flare 600 kPa
PSLC511 15mm Male Compression 350 kPa
PSLC512 15mm Male Compression 500 kPa
PSLC513 h15mm Male Compression 600 kPa
PSL714 20mm Tapered BSP Thread 350 kPa
PSL715 20mm Tapered BSP Thread 500 kPa
PSL716 20mm Tapered BSP Thread 600 kPa
PSL721 20mm Male Compression 350 kPa
PSL722 20mm Male Compression 500 kPa
PSL723 20mm Male Compression 600 kPa
PRESSURE REDUCING VALVES
Pressure Reducing Valve PRV45PRV015 15mm 155-550 kPa
PRV020 20mm 155-550 kPa
PRV025 25mm 155-550 kPa
PRV035 32mm 155-550 kPa
PRV040 40mm 155-550 kPa
PRV050 50mm 155-550 kPa
PRV4520 20mm 150-600 kPa
PRV4520R 20mm 150-600 kPa
TEMPERING VALVES
HeatGuard Insulated
With SharkBite™ Fittings
HeatGuard Ultra Insulated
HeatGuard Ultra High Flow
MIX11009I 15mm
MIX11012I 20mm
MIXF11009I 16mm HeatGuard
MIXF11012I 20mm HeatGuard
MIXF11116I 16mm HeatGuard Ultra
MIXF11117I 20mm HeatGuard Ultra
MIXRA11009I 15mm HeatGuard
MIXRA11116I 15mm HeatGuard Ultra
MIX11116I 15mm
MIX11117I 20mm
MIX11511 20mm
PRIMARY TEMPERATURE CONTROL VALVE
SOLAR TRANSFER VALVE
MIX11092
MIX11091
MIX11092 20mm
MIX11091 20mm
PRESSURE & TEMPERATURE RELIEF VALVES
HT55/HT575 HTE55-1/HTE575-1
HTE55-2/HTE575-2
HTT55-1
HT501 15mm 500 kPa
HT503 15mm 700 kPa
HT505 15mm 850 kPa
HT507 15mm 1000 kPa
HT511 15mm 1400 kPa
HT701 20mm 500 kPa
HT703 20mm 700 kPa
HT705 20mm 850 kPa
HT707 20mm 1000 kPa
HT711 20mm 1400 kPa
HTE501 15mm 700 kPa
HTE502 15mm 850 kPa
HTE504 15mm 1000 kPa
HTE506 15mm 1400 kPa
HTE701 20mm 850 kPa
HTE703 20mm 1000 kPa
HTE705 20mm 1400 kPa
HTE509 15mm 850 kPa
HTE511 15mm 1000 kPa
HTE513 15mm 1400 kPa
HTE710 20mm 850 kPa
HTE709 20mm 1000 kPa
HTT515 15mm 700 kPa
HTT516 15mm 850 kPa
HTT517 15mm 1000 kPa
HTT518 15mm 1400 kPa
SLICK COMBO INSTALLATION KITS
Slick Combo Set Insulated Solar Slick Combo Set InsulatedMIX12013I MIX12015I
NON-RETURN / ISOLATING VALVES
Non-Return Valves
Duo Valve
Trio Valve
High Pressure Expansion Non-Return Valve
NI501 15mm
NIA501 15mm
NIC501 15mm
NI701 20mm
NI703 20mm
NR50HT 15mm
NR75HT 20mm
NR100HT 25mm
NRS501 15mm
NRIS501 15mm
HPNR503 15mm 1400 kPa
EXPANSION CONTROL VALVES
H50 High Pressure Expansion Control Valve
H75 High Pressure Expansion Control Valve
H502 15mm 550 kPa
H504 15mm 700 kPa
H506 15mm 850 kPa
H511 15mm 1200 kPa
H513 15mm 1400 kPa
H702 20mm 550 kPa
H703 20mm 700 kPa
H704 20mm 850 kPa
H707 20mm 1200 kPa
H708 20mm 1400 kPa
top related