exhaust emission datasheet - …service.multiquip.com/pdfs/dca36spxu4f_emission_data_2018.pdf ·...
Post on 26-Sep-2018
219 Views
Preview:
TRANSCRIPT
EXHAUST EMISSION DATA SHEET
MQ POWER GENERATOR SET
The engine used in this generator set is certified to comply with
United States EPA Tier and CARB Mobile Off-Highway emission regulations.
ENGINE DATA
Manufacturer: Bore: in. ( mm)
Model: Stroke: in. ( mm)
Type: Displacement: cid ( liters)
Aspiration: Compression Ratio:
PERFORMANCE DATA
SAE Gross HP @ 1800 RPM (60 Hz)
Rated Load Fuel Consumption (gal/Hr)
Rated Load Exhaust Gas Flow (cfm)
Rated Load Exhaust Gas Temperature (ºF)
United States EPA - Mobile Off-Highway Tier Limits - BHP
Criteria Pollutant Emission Requirements Certified Engine Emissions
NOx (Oxides of Nitrogen as NO2)
HC (Total Unburned Hydrocarbons)
NOx + HC (Combined)
CO (Carbon Monoxide)
PM (Particulate Matter)
NMHC (Non-Methane Hydrocarbons)
NMHC + NOx
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
gr/bhp-hr
EPA Engine Family:
EPA Certificate of Conformance:
ARB Executive Order:
Effective Date:
Note: Engine operation with excessive air intake or exhaust restriction beyond factory published
maximum limits, or with improper service maintenance, may result in higher emission levels.
Data And Specifications Subject To Change Without Notice Date:
Model: DCA36SPXU4F
Isuzu
4LE2X
4-Cycle, In-Line, 4-Cylinder, Diesel
Turbocharger, ECM, EGR,DOCElectronic Direct Injection, Charge Air Cooler
4
4
3.35 85
3.78 96
133 2.2
17.6:1
65.7
2.93
237
1078
50≤ ~ <75
N/A
N/A N/A
N/A N/A
3.72 0.007
0.022 0.014
N/A
N/A N/A
3.50 2.38
JSZXL02.2PXB JSZXL02.2PXB-001
U-R-006-0446Model Year 2018
2/1/2018
UNITED STATES ENVIRONMENTAL PROTECTION AGENCY2018 MODEL YEAR
CERTIFICATE OF CONFORMITYWITH THE CLEAN AIR ACT
OFFICE OF TRANSPORTATIONAND AIR QUALITY
ANN ARBOR, MICHIGAN 48105
Certificate Issued To: Isuzu Motors Limited (U.S. Manufacturer or Importer)
Certificate Number: JSZXL02.2PXB-001
Effective Date:04/27/2017
Expiration Date:12/31/2018
_________________________Byron J. Bunker, Division Director
Compliance Division
Issue Date:04/27/2017
Revision Date:N/A
Model Year: 2018Manufacturer Type: Original Engine ManufacturerEngine Family: JSZXL02.2PXB
Mobile/Stationary Indicator: MobileEmissions Power Category: 37<=kW<56Fuel Type: DieselAfter Treatment Devices: Diesel Oxidation CatalystNon-after Treatment Devices: Electronic Control, Electronic/Electric EGR - Cooled
Pursuant to Section 213 of the Clean Air Act (42 U.S.C. section 7547) and 40 CFR Part 1039, and subject to the terms and conditions prescribed in those provisions, this certificate of conformity is herebyissued with respect to the test engines which have been found to conform to applicable requirements and which represent the following engines, by engine family, more fully described in the documentationrequired by 40 CFR Part 1039 and produced in the stated model year.
This certificate of conformity covers only those new compression-ignition engines which conform in all material respects to the design specifications that applied to those engines described in thedocumentation required by 40 CFR Part 1039 and which are produced during the model year stated on this certificate of the said manufacturer, as defined in 40 CFR Part 1039.
It is a term of this certificate that the manufacturer shall consent to all inspections described in 40 CFR 1068 and authorized in a warrant or court order. Failure to comply with the requirements of such awarrant or court order may lead to revocation or suspension of this certificate for reasons specified in 40 CFR Part 1039. It is also a term of this certificate that this certificate may be revoked or suspended orrendered void ab initio for other reasons specified in 40 CFR Part 1039.
This certificate does not cover engines sold, offered for sale, or introduced, or delivered for introduction, into commerce in the U.S. prior to the effective date of the certificate.
ENGINE MODEL SUMMARY ATTACHMENT 1 OF 1
ENGINE ENGINE ENGINE BHP@RPM FUEL RATE: mm3/stroke
FAMILY CODE MODEL (SAE Gross) @peak HP
JSZXL02.2PXB 4LE2XDPBA-01 BP-4LE2X 65.7@1800 56.1 (49.0k
JSZXL02.2PXB 4LE2XDPBB-01 BP-4LE2X 65.7@1800 56.1 (49.0kW)
ENGINE ENGINE ENGINE EMISSION CONTROL DEVICE Per SAE J1930
FAMILY CODE MODEL
JSZXL02.2PXB 4LE2XDPBA-01 BP-4LE2X ECM, TC, CAC, DFI, EGR, DOC
JSZXL02.2PXB 4LE2XDPBB-01 BP-4LE2X ECM, TC, CAC, DFI, EGR, DOC
CARB EO: DATE:
FUEL RATE: lbs/hr
@peak HP
22.4
22.4
U-R-006-0446 05/04/17
TORQUE@RPM lbs ft
192@1800 (260Nm)
192@1800 (260Nm)
FUEL RATE: FUEL RATE: mm3/stroke lbs/hr
@peak TORQUE @peak TORQUE
56.1 22.4
56.1 22.4
top related