algal concentrates in hatchery culture
TRANSCRIPT
International Aquafeed is published five times a year by Perendale Publishers Ltd of the United Kingdom.All data is published in good faith, based on information received, and while every care is taken to prevent inaccuracies, the publishers accept no liability for any errors or omissions or for the consequences of action taken on the basis of information published. ©Copyright 2009 Perendale Publishers Ltd. All rights reserved. No part of this publication may be reproduced in any form or by any means without prior permission of the copyright owner. Printed by Perendale Publishers Ltd. ISSN: 1464-0058
November | December 2011
Feature title: Algal concentrates in hatchery culture
The International magazine for the aquaculture feed industry
Culture of uni-cellular algae is a pre-requisite for successful operations in hatchery practices for
shrimp, crab and most fish.
Problems with algal culture and inherent disadvantages are described here, with their advantages in many cases being overcome by these disadvantages. The current study describes a novel, industrialised approach to negate these disadvantages and to place hatchery culture methods on a more con-sistent and stable platform.
This strategy was designed and imple-mented by Meriden Animal Health of the UK and is presented in the form of the Phyconmmix range of products.
The important factorsIt is estimated that over 40 species of
uni-cellular algae are in use in the aquacul-ture sector. They are generally recognised as difficult to grow in mass culture, particularly in low light (cloudy) or rainy conditions. The most important factors to consider in algal culture are temperature, salinity, pH, light intensity, photoperiod and nutrient
composition; the major expense in algal culture comes in the nutrient component.
Algae can require up to 17 different trace components in their culture medium.
The cost of production is further increased due to the requirement for specialist technicians. Large-scale culture increases the likelihood of breaches in bio-security, as pathogens can easily be trans-mitted from nearby culture tanks or via inadvertent intro-duction of insects etc.
Generally speaking, only one algal species tends to be cul-tured per single farmed species, therefore nutrient composition becomes a critical factor espe-cially when algae is entering its decline and death phases, and composition can therefore vary widely.
Since single species algae cannot provide all of the nutri-ents required by larval shrimp and fish, careful selection of a range of algal species which cover the spectrum of larval
nutrient requirements would seem a logical progression. Said species of algae can be grown in a sterile, hermetically sealed, bio-secure environment, then harvested at pre-determined times during the log phase of growth to optimize nutrient quality and consistency.
Algal concentratesin hatchery culture by John S Clark PhD, Aquatic Animal Health and Nutrition Technical Consultant, Bangkok, Thailand
30 | InternatIonal AquAFeed | november-December 2011 november-December 2011 | InternatIonal AquAFeed | 31
F: Algal concentrates
IAF11.06.indd 30 04/11/2011 08:42
Such algae can then be concen-trated via centrifuge then packaged and stored prior to use.
Such a system is flexible in terms of algal composition in that formula-tions for fish and shrimp larvae can be tailored to meet the require-ments of the larvae.
These concentrates are easily stored and applied to tanks and can also be used to enhance and enrich living feeds such as rotifers and Artemia nauplii. Its use reduces the need for mass culture tanks which can then be turned over to larval and nursery rearing and also reduces demand on labour time and equipment.
Larval quality is improved and development is accelerated, result-ing in healthier, stronger larvae which can be sold at a premium, thereby improving returns on investment.
Materials and methodsA trial was run comparing live
Chaetoceros with a commercially available algal concentrate (Meridens Phyconmmix
Shrimp ZM) as food sources for larvae of the white shrimp (Litopenaeus vannamei) in Thailand.
There were three control treatments and three test treatments in each study
group, tank size was five tonne and stocking density at nauplius was 200/litre. As well as their conventional feeds the test groups were fed on Shrimp ZM two times/day to Mysis 3 and then three times/day to
"Anectodal evidence
suggests that Zoea 2
Syndrome commonly
experienced in
many hatcheries is
nutritional in origin
but complicated by
secondary invasion
by bacteria or viruses
(Li. Pers. Comm.)"
30 | InternatIonal AquAFeed | november-December 2011 november-December 2011 | InternatIonal AquAFeed | 31
F: Algal concentrates
Meet us in one of the following cities:
New Delhi – India, 1/2 March 2011 Mexico City – Mexico, 11/12 April 2011Cape Town – South Africa, 11/12 May 2011Sao Paulo – Brazil, 6/7 June 2011 Cairo – Egypt, 12/13 July 2011 Warsaw – Poland, 14/15 September 2011 Atlanta – USA, 17/18 October 2011Bangkok – Thailand, 22/23 November 2011
Register now on www.tour2011.org
Good Agricultural Practice
New Delhi I Mexico City I Cape Town I Sao Paulo I Cairo I Warsaw I Atlanta I Bangkok
Everything you need to know about Good Agricultural Practice Certification at a place near you!
Coming Your Way
Would you like to know more about the GLOBALG.A.P TOUR 2011? Then please see www.tour2011.org or contact Nina Kretschmer: [email protected] Follow us on Twitter@GLOBALGAP!
Hosted by:California Aquaculture Association
IAF11.06.indd 31 04/11/2011 08:42
10 | InternatIonal AquAFeed | november-December 2011 november-December 2011 | InternatIonal AquAFeed | 11
Providing proficient tools to achieve cost-effective and sustainable aquaculture practices
ECOBIOL Aquaa highly effective single strain probiotic
GUSTOR Aquaa natural growth promoter
BIOMET Aquaan organic mineral source
NOREL,S.A. • Jesús Aprendiz, 19, 1º A y B • 28007 Madrid (SPAIN)Tel. +34 91 501 40 41 • Fax +34 91 501 46 44 • www.norel.es
Natural nutr
ition
AN. REV. 90X132.indd 1 02/08/11 13:13
Your partner in technology, equipment and plants for animal- and aqua feed and petfood.
Wynveen International b.v.P.O. Box 386666 ZG HeterenThe Netherlands
Tel: +31 (0)26 - 479 06 99Fax: +31 (0)26 - 479 06 [email protected]
V A C U U M C O A T E R
See our website www.arvotec.fi
Feeding robots Single feedersCentralised feedingCentralised feeding
See our website www.arvotec.fi
Professional Feeding Technology
•Suitableformanytypesoffishfarms•Robotfeedingunitforupto240tanks•Mostaccuratefeederevermade•Centralisedpipefeedingsystem•Export/importforproduction
managementsystems
Aquaculture UK 201223-24 May 2012
Aviemore, Scotland
The UK’s major Aquaculture exhibition and conference
featuring the latest aquaculture products and innovations.
Visit www.aquacultureUK.com for further information or
contact [email protected]
Fish_Farming Int_1/8_107X146.indd 1 17/10/2011 12:45
IAF11.06.indd 11 04/11/2011 08:41
than a single species diet and this will aid in the protection of target animals.
The improved water quality using concentrates may simply be a function of improved shrimp larval health lead-ing to improved vigour and appetite; it was noted feed consumption rates were higher but were non-detrimental to the larval environment. In such an environ-ment and with a much more complete, nutritionally balanced dietary regimen, it is not surprising that survival, growth, feed intake and resistance to stress are all significantly improved.
The developmental and structural advantages seen in the harvested post-larvae are of considerable interest to grow out farmers. In Plate 1 an examination of the carapace by SEM reveals the carapace to be thin and pliable, and therefore more prone to damage. By contrast, the carapace of animals fed on concentrate appears much denser and stronger, and would therefore be capable of resisting much more handling stress. Such considerations are of vital importance to farmers.
Even in the case of the compound eye, the eye seems incomplete in the controls (Plate 3) and this will of course impact on feeding behavior. It seems in general the concentrate fed animals are more devel-oped than controls (Plate 4) and therefore more suited to the rigours of pond life. Advantages are therefore not restricted to simple survival and growth; there are many subtle advantages that may escape direct attention but become evident on deeper study.
This developmental advantage is also observed in trials with concentrates in the nutrition of larval fish. In a recent study on larval sea bass (Lates calcarifer) apart from the advantages in terms of survival and growth, significant developmental accel-eration was observed in development of dentition (Plate 5), taste bud (Plate 6) and buccal microbial flora (Plate 7).
When factors such as ease of storage, ease of use, nutritional consistency, absence of potential pathogens, reduced labour cost and freeing of tank space are considered alongside the aforementioned performance superiority, the future of algal concentrates as a significant tool in hatchery culture seems secure.
Acknowledgements The author would like to thank all
concerned for their support during the development of the products and those involved in the demonstration of the prod-uct performance.
(see Figure 2) and significantly heavier (see Figure 3) than controls, which results in a significantly more favourable length/weight ratio (see Figure 4).
Similarly, feed utilisation seems superior in that the gut/muscle ratio favours muscle in the test groups (see Figure 5) and this is manifested as an increased Artemia nauplius and flake feed consumption (see Figures 6 and 7).
The final post-larvae are significantly stronger and more resistant to for-malin stress as evinced by survival rates displayed in Figure 8. Scanning Electron Microscope studies show significant differences in exo-skeletal structure and strength (Plates 1 and 2) as well as in development rate of the compound eye (Plates 3 and 4).
Such differences in stress survival and the structural improvement in the animals fed concentrates has significance to the grow-out phase of farming operations.
Finally, cost and return on invest-ment figure prominently in the
vocabulary of any hatchery operator. It can be seen from Table 1 that use of concen-trates does in fact lead to more profitable production of post-larvae and that this, coupled with the many advantages relating to ease of use make algal concentrates very attractive to hatchery operators.
DiscussionAnectodal evidence suggests that Zoea 2
Syndrome commonly experienced in many hatcheries is nutritional in origin but com-plicated by secondary invasion by bacteria or viruses (Li. Pers. Comm.). This study, in which no outbreak was experienced in the test groups, would tend to support that premise. The nutritional profile of a multi-algal species diet will be more complete
PL15 following the manufacturers feeding instructions.
Survival, length, weight, length/weight ratio, gut/muscle ratio, feed consumption, hepatopancreatic Vibrio count, formalin stress test were all recorded during this trial. Scanning Electron Microscope studies of the harvested post-larvae were also conducted.
The accumulated data allowed for a return on investment calculation to be
made between the use of live and concen-trated algae during larval shrimp culture.
ResultsBy Zoea 2 an obvious size difference was
noted (Li, pers. Comm.). At the same time, controls experienced
an outbreak of Zoea 2 Syndrome and a significant mortality occurred. It was note-worthy that water quality in the test tanks was viewed as superior to that observed in live controls. This has been mirrored in other trials (Pota, pers comm.; Somhathai, pers.comm).
Figure 1 shows mean survival in the three concentrate treatments to be sig-nificantly higher than in the live controls. Animals are significantly greater in length
32 | InternatIonal AquAFeed | november-December 2011
F: Feature
november-December 2011 | InternatIonal AquAFeed | 33
IAF11.06.indd 32 04/11/2011 08:42
18 | InternatIonal AquAFeed | november-December 2011
HeadquartersEvonik Industries AGHealth & Nutritionfeed additives Rodenbacher Chaussee 4 63457 Hanau-Wolfgang, Germanyphone +49 6181 59-2256 fax +49 6181 59-6734
Europe & Middle East Africa +49 6181 59-6766Latin America +49 6181 59-6761North America +1 678 797-4300Asia North +86 10 85 27-6400Asia South +65 6890-6861
Amino AcidsChoosing the right nutrients for your Aquafeed
Our amino acids help to• replace costly and scarce raw materials • improve protein balance and production efficiency • reduce environmental pollution
[email protected] | www.evonik.com/feed-additives
11-01-377 vND AZ Aquaculture A4 us.indd 1 27.10.11 16:58IAF11.06.indd 19 04/11/2011 08:41
www.aquafeed.co.uk
LINKS• Seethefullissue• VisittheInternationalAquafeedwebsite
• ContacttheInternationalAquafeedTeam
• SubscribetoInternationalAquafeed
VOLUME 14 I S SUE 6 2 011
THE INTERNATIONAL MAGAZINE FOR THE AQUACULTURE FEED INDUSTRY
BioMarine Business Convention
Ecobiol Aqua– A unique and highly effective single strain probiotic
Evaluation of probiotic bacteria in tilapia production
Marine based protein hydrolysate- Improve the performance of feeds containing
a low level of fish meal
IAF11.06.indd 1 04/11/2011 08:40
Thisdigitalre-printispartoftheNovember|December2011editionofInternationalAquafeedmagazine.Contentfromthemagazineisavailabletoviewfree-of-charge,bothasafullonlinemagazineonourwebsite,andasanarchiveofindividualfeaturesonthedocstocwebsite.Pleaseclickheretoviewourotherpublicationsonwww.docstoc.com.
Topurchaseapapercopyofthemagazine,ortosubscribetothepapereditionpleasecontactourCirculationandSubscriptionsManageronthelinkabove.
INFORMATIONFORADVERTISERS-CLICKHERE