aa · 2020. 11. 2. · 082134-01-000 52g gen-3.2 kw onan diesel gen-3.6kw onan lp ... room when...

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000

FOR ELECTRICALTORQUE

SPECIFICATIONSSEE DWG NO.

128783-01-000

CODES/STANDARDS USA

CODES/STANDARDS-CSA/CMVSS

2651B1

1B1

265

NOTES:

ROUTE TANK SENSOR WIRES SO THEY DO NOT PASS OVERSENSORS. USE WIRE TIE MOUNT 155366-01-000 AS NEEDED.TANK SURFACE MUST BE CLEANED USING ISOPROPYL ALCOHOLAND PRIME WITH PRIMER 94.

2.

AA

VIEW AA6 PIN HSGWITH GRN TAPE

2 PIN HSG FROMWIRE ASM-CHASSISCIRCUIT; AEZ

CLAMP10495-02-000 (2)SCREWG11-06-12U (2)

2 PIN HSG FROMWIRE ASM-CHASSISCIRCUITS; LLL,LLK

6 PIN HSGWITH YEL TAPE

4 PIN HSG FROMWIRE ASM-CHASSISCIRCUITS;ABY,ABZ,DR,DU

1. AT MINIMUM ALL WIRES TO BE SUPPORTED AND SECURED PERCODE REQUIREMENTS. USE CLAMP 10495 OR 10497 OR WIRETIE 8343 OR 108046 AND SCREW G67-XX-XXX OR G56-XX-XXXAS APPROPRIATE FOR INSTALLATION.

3

UNSPECIFIED TOLERANCES: MATERIAL:

C

D

1

TWO-PLACE (X.XX)

DSNR:

DESCRIPTION:

8

2

B

ALL DIMENSIONS ARE IN MILLIMETERSDFTR:

6

A

6

FIRST USED:

A

REV

WHOLE DIM (X)

D

REF:

8

ITEM/PART NO:

4

WEIGHT: (LBS)

SHEET:

7

B

2

4

REFER TO ES0018 FOR FASTENERTIGHTENING GUIDELINES

ANGLE

5

5

13

COPYRIGHT 2016 WINNEBAGO INDUSTRIES, INC.

ONE-PLACE (X.X)

C

7

WIRING INSTL-BODY,12V

1 OF 6 000188763 / 33556801000

3

1.5

0.50

1

20 C24P

CONTROL-SLIDEOUT, IN-WALL189400-01-000DETAIL AA

HARNESS-SLIDEOUT MOTOR191661-06-000(GRN)

HARNESS-SLIDEOUT MOTOR191661-02-000(YEL)

GROMMET016188-11-000

180

30-Aug-2019

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000

AFM,AFMCONNECT TO BLACK WIRECONNECTED TO STABILIZER SWITCHPANEL INDICATOR LIGHT

LOAD CENTER FUSESDETAIL DH



128783-01-000

1B1

CODES/STANDARDS-CSA/CMVSS265

CODES/STANDARDS USA1B1

265

SWITCHDETAIL DF

WIRE ASM-SLIDEOUT000189171 / 335752-01-000

NOTES:

AT MINIMUM ALL WIRES TO BE SUPPORTED AND SECURED PERCODE REQUIREMENTS. USE CLAMP 10495 OR 10497 OR WIRETIE 8343 OR 108046 AND SCREW G67-XX-XXX OR G56-XX-XXXAS APPROPRIATE FOR INSTALLATION.

1.

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000188763 / 33556801000 2 OF 6

WIRE ASM-MONITOR PANEL000040629 / 319486-01-000

USB-CHARGER DUAL,DC188312-01-000

PORT-SOLAR, SINGLE000163158 / 328863-01-000SCREWG39-10-12U (4) RECEPTACLE-12V

132958-01-000


PLATE-WALL,COAX EXTERIOR183638-01-CHT(COAX-RED)SCREWG39-08-16U (3)

RECEPTACLE-12V132958-01-000

DETECTOR-LP GAS150138-02-CHTSCREWG68-06-10U (2)

RELAY-STABILIZERS063912-02-000SCREWG11-08-12U

LIGHT-DOME,SGL,W/SWITCH000040266 / 319326-01-CHTSCREWG11-08-16U (2)CONNECTOR058028-01-000 (2)

3

WIRE ASM-LEFT000189170 / 335751-01-000

TO WATER PUMP

SEE DETAIL BB FOR WIRING CONNECTION TO SENSOR PROBES.3

WIRE ASM-OVERHEAD000163535 / 328928-01-000

WIRE ASM-OVERHEAD000163535 / 328928-01-000

ADAPTER-CABLE TO CABLE082134-01-000HOUSINGS TO WIRE ASM-CHASSIS

HOLDINGTANK

SEE DETAIL BCFOR ATTACHMENTDETAILS

WIRE ASM-MONITOR PANEL

1/3 (YEL)

2/3 (GRN)

SPLICE-BUTT(REF)

GND (WHT)

HOLDING TANK WALL(REF)

NUT-WELL(REF)

TERMINAL-RING(REF)

FULL (ORG)

WASHER000E13-10-00U

SCREW143056-01-CHT

2DETAIL BC

RED

DETAIL BB

WHT

WHT

WIRE ASM

YEL

TYPICAL WIRE ATTACHMENT AT ALL LEVEL PROBES(4 EACH) FOR WATER, MAIN, AND AUX HOLDING TANKS.

2

LIGHT-LED,ROUND W/SWITCH,3.5 PLASTIC000166892 / 329927-01-CHT (2)SCREW000G13-06-10U (6)CONNECTOR058028-01-000 (4)

LIGHT-LED,ROUND W/SWITCH,3.5 PLASTIC000166892 / 329927-01-CHT (2)SCREW000G13-06-10U (6)CONNECTOR058028-01-000 (4)


RECEPTACLE-12V132958-01-000

15 PIN HOUSINGS CONNECTING WIRE ASM-CHASSISTO WIRE ASM-SLIDEOUT. LOCATED BEHIND ACCESSPANEL IN EXTERIOR COMPARTMENT.

4

4

WIRE ASM-CHASSISROUTED TOWIRE ASM-SLIDEOUT

WIRE ASM-EXTENSION000189123 / 335737-01-000

THERMOSTAT000016556 / 313194-01-CHT

2 PIN HSG TOTHEATER SEATING

THEATER SEATING42Z

42Z

30-Aug-2019

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

1B1 265

1B1 CODES/STANDARDS USA

265 CODES/STANDARDS-CSA/CMVSS

CA

DETAIL CA

ROUTE WIRESTHRU HOLE

GROMMET8386-01-000

3

MOUNT MAGNET USING PILOT HOLES IN SCREEN DOOR FRAME.MOUNT WITH MAGNET TOWARD SWITCH.

3 MOUNT SWITCH AND SPACER TO BLOCK ON JAMB.ADJUST HEIGHT TO MATCH MAGNET.

2

DETAIL CB

2

SWITCH/MAGNET-STEP, ELECTRIC116995-03-000SCREWG11-06-08U (4)

JAMB-DOORPLATE-WALL179004-02-CHTSCREWG12-06-16U (2)

NOTES:

AT MINIMUM ALL WIRES TO BE SUPPORTED AND SECURED PERCODE REQUIREMENTS. USE CLAMP 10495 OR 10497 OR WIRETIE 8343 OR 108046 AND SCREW G67-XX-XXX OR G56-XX-XXXAS APPROPRIATE FOR INSTALLATION.

1.

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000188763 / 33556801000 3 OF 6

REMOVE SCREW FROM MAGNET SWITCH TO INSTALLLOCK WASHER AND TERMINALS.

WASHER-LOCK000007554 / 310611-01-000 (2)4

SPLITTER-TV,2 WAY086756-01-000

SWITCHDETAIL DA

LIGHT-TAPE,LED,DIFFUSED190025-11-CHT

REMOTE PANEL-INVERTER000037772 / 318694-01-CHTSCREWG11-06-08U (2)

WIRE ASM-RIGHT000162905 / 328844-01-000

CONTROL-CHARGE,SOLAR 30 AMP191278-01-000SCREWG11-08-08U (2)

4

6-PIN HSGTO WIRE ASM-SIDEWALL

SWITCHDETAIL DB

SWITCHDETAIL DD

LED-2

SWITCHESDETAIL DC

PLATE-WALL149557-13-CHTSCREWG12-06-06U (2)

RELAY-AWNING063912-02-000SCREWG11-08-12U

DOOR SWITCHDETAIL CB

PLATE-WALL,COAX EXTERIOR183638-01-CHT(COAX-YEL)SCREWG39-08-16U (3)

SWITCHDETAIL DG

TO FURNACEDETAIL DJ

TO WIRE ASM-CHASSIS

TO WATER HEATERDETAIL DE

ADAPTER-CABLE TO CABLE082134-01-000

52G

GEN-3.2 KW ONAN DIESEL

GEN-3.6KW ONAN LP MICROQUIET

33F

52G

33F

LIGHT-LED,ROUND W/SWITCH,3.5 PLASTIC000166892 / 329927-01-CHTSCREW000G13-06-10U (3)CONNECTOR058028-01-000 (2)

PANEL-MONITOR,W/O GEN, W/O LP000172081 / 331584-01-CHTPANEL-MONITOR, 2TK,WH,GENWTR PMP,W/O LP000040605 / 319482-01-CHT

GROMMET016188-11-0005

GENERATOR CABLE ROUTED THROUGH FLOOR HERE.5

150 DROP3 PIN HSG TOLEVELING JACKS HARNESS

TOUCHPAD-LEVELING JACKS(REF)60M

HYDRAULIC LEVEL JACKS-AUTO60M

60M

RELAY-LEVELINGSYSTEM063912-02-000SCREW000G11-08-12U

CRUSH HAZARD. Keep people and objectsclear of the inside and outside of the slideoutroom when operating. Failure to comply couldresult in death or serious injury.

116549-02G

WARNING

TANKS

F

FRESH

L G

GAS

BLACKBATT

PUMP

WATER

2/3

WATERHEATER

STOP

1/3

GENERATORSTART

BATTERY

GRAY

C

FE

30-Aug-2019

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

1B1 265



DETAIL DA

DETAIL DB

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000188763 / 33556801000 4 OF 6

FUSE-15 AMP62901-05-000 (6)

SWITCH-ROCKER135740-01-CHTSWITCH-BASE135741-01-CHTSWITCH-BEZEL135742-01-CHTSCREWG11-08-08U (2)

JPRRA

SWITCH-ROCKER108357-17-000SWITCH-ACTUATOR108356-31-CHTSCREWG11-06-10U (2)PLATE-SWITCH144363-02-CHTSCREWG11-06-10U (2)

LABEL-WARNING,SLIDEOUT116549-02-000

DETAIL DH

CIRCUIT BREAKER-20 AMP184387-01-000

PE

FUSE-5 AMP062901-02-000

JC


DETAIL DC

SWITCH-ROCKER108357-16-000ACTUATOR-SWITCH108356-12-CHT

DETAIL DG


SWITCH-ROCKER108357-18-000ACTUATOR-SWITCH108356-19-CHTCIRCUITS: LH,LJ,LG,JP,JAWIRE ASM-THERMISTOR186796-01-000SWITCH-ROCKER

108357-19-000

DETAIL DF


JCPC

JC 14 Y(LAMPS)

JD 14 Y(LAMPS)

JE 14 Y(LAMPS)

JF 14 Y(USB PORTS)

JA 14 Y(MONITOR PANEL & PUMP)

JB 14 Y(FURNACE)

FFD 12 Y(AWNING)

WB 16 Y(LP DETACTOR)

PLATE-SWITCH158431-22-CHTSCREWG11-06-10U (4)

PLATE-SWITCH158431-19-CHTSCREWG11-06-10U (4)


SPLICE-BUTT (4)(REF)


WIRE ASM-RIGHT

JWWIRE ASM-

RIGHT

REDGRN

JU

JH

YEL

JB

LT BLU

JMRED

JX

LT BLUWITH (+) ID

WIRE TAG

JJ

DETAIL DJ

BLU

DETAIL DE

SWITCH-ROCKER135740-01-CHT (2)SWITCH-BASE135741-02-CHTSWITCH-BEZEL135742-02-CHTSCREWG11-08-08U (4)

DETAIL DD

JCXX

JCPL

CRUSH HAZARD. Keep people and objectsclear of the inside and outside of the slideoutroom when operating. Failure to comply couldresult in death or serious injury.

116549-02G

WARNING

OUT

IN

AWNING

15

5

15

15

15

15

20 AMP

15

F5F6

F8F1

40

F2

POS+

F7F9

NEG-

F10

40

F11

F3F4

+VCC

30-Aug-2019

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

1B1 265



NOTES:

SEE ROOF ASM FOR ADDITIONAL INFORMATION.1.

EA

DETAIL EA

DETAIL EB

WIRE ASM-COACH

PORT-SOLAR, 3 POSITION(REF)

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000188763 / 33556801000 5 OF 6

PANEL-SOLAR 100 WATT, FLEXIBLE000131101 / 325665-01-000 (2)WASHER077071-01-000 (12)SCREW000G39-10-16U (12)

296

300(2)163

254

85

2 SEE ANTENNA INSTALLATION MANUAL FOR CORRECTINSTALLATION PROCEDURE.

2

LIGHT-LED,ROUND W/SWITCH,3.5 PLASTIC000166892 / 329927-01-CHTSCREW000G13-06-16U (3)CONNECTOR058028-01-000 (2)

LIGHT-LED,ROUND 4.5 PLASTIC000166889 / 329926-01-CHT (8)SCREW000G13-06-16U (24)CONNECTOR058028-01-000 (16)

CONNECT VENDOR RED WIRE TO WINNEBAGOBLK WIRE MARKED WITH RED TAPE.

3

CONNECT VENDOR BLK WIRE TO WINNEBAGOGRN WIRE.

4

PORT-SOLAR, 3 POSITION000170803 / 331218-01-CHTDETAIL EB

3

4

ANTENNA-TV, OMNIDIRECTIONAL000171487 / 331386-01-CHTSCREW000G67-10-20U (4)

PLACE ROOF SEALANT HERE (APPROXIMATELY 75MM WIDE)AND PUSH THE CABLES INTO THE SEALANT TO STABILIZE THEM.

5

5

5

30-Aug-2019

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

1B1 265



158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000188763 / 33556801000 6 OF 6

WIRE ASM-CAMERA CABLE(REFERENCE)

CABLE-FAKRA C, SIGNAL BLUE000182978 / 334056-01-000

CONNECT TO CHASSIS SUPLLIED CABLES

CONNECT TO CHASSIS SUPLLIED CABLES


CABLE ASM-CAMERA

CAMERA-REAR000185316 / 334773-01-000SHROUD-CAMERA,REAR000171916 / 331533-01-CHTSCREW-PAN,HEAD000G55-08-16U (3)RETAINER-CAMERA,REAR000171924 / 331534-01-CHTSCREW-PAN,HEAD000G39-08-06U (2)TAPE-LOOP029094-07-000DETAIL FA

TO CHASSIS SUPPLIEDSATELLITE RADIO ANTENNA

CABLE-FAKRA A, JET BLACK000182977 / 334055-01-000CABLE-FAKRA C, SIGNAL BLUE000182978 / 334056-01-000CABLE-FAKRA D, CLARET VIOLET000182979 / 334057-01-000CABLE-FAKRA E, LEAF GREEN000182980 / 334058-01-000

TO CHASSIS SUPPLIEDRADIO ANTENNA

WHT

NOTES:

BLK

BLU

1

GRN

BLK

1

YEL

BRN

DETAIL FA

RED

BLK

RED/WHT

TO CHASSISCAMERA CABLE

CONNECTIONS PUR

PUR/WHT

RED

WHT

RED

SEE WIRING INSTL-CHASSIS FOR ADDITIONAL INFORMATION.

BLU

30-Aug-2019

aa · 2020. 11. 2. · 082134-01-000 52g gen-3.2 kw onan diesel gen-3.6kw onan lp ... room when...

Documents