700-series 147148-06-000 · 10/22/2009 · 168688-02-02b gd gd section gd-gd (2) 21 bracket asm...

A

2

C

DO NOT SCALE DRAWING

D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

05 726A

2

147148

AIRSPRING INSTL-REAR,AUX

TO LEFT AIR BAG

TO RIGHT AIR BAG

AIRSPRING-REAR153119-03-000

15T

15T

15T

PANEL-SERVICE CENTER

16Y 08 FORD-14,500

15T AIR SPRING REAR

16Y

147148

700-SERIES147148-06-000

10/22/2009

1445

1028

631

THIRD ANGLE

ONE-PLACE (X.X)

COPYRIGHT 2010WINNEBAGO

INDUSTRIES, INC.

C

DATE

3

C

CHKR

ANGLE

D

7

REV

DWGNO

TWO-PLACE (X.XX)

6


8

7

UNSPECIFIED TOLERANCES ARE:

M.E.

WHOLE DIM (X)

P.E.

R

ORIG. DATE

1

D

TITLE:

8

OF

DFTR

5

ZONE

A

5

PROJECTION

4

DSNR

REV

REV

2REF:

ALL DIMENSIONS ARE IN MILLIMETERS

SHEET

MATERIAL:

DATE

3

REFER TO ES0018 FOR FASTENERTIGHTENING GUIDELINES

DFTR-ORIG

4

REVISION RECORD

FIRST USED

BB

2

PART NO

6

A

1

5. REMOVE TWO REAR SCREWS ON SEAT BELT MOUNT.

4. WELD PER ES0063, UNLESS OTHERWISE SPECIFIED.

3. SEAL ALL JOINTS OF COMPARTMENTS AND CLOSEOUT PANELS WITH SEALANT 53766-01-000.

2. CLEAN AND E-COAT ALL PIECES PRIOR TO ASSEMBLY.

1. SPRAY ALL WELDS WITH UNDERCOAT 100053-01 OR 100053-03-000.

NOTES:FOR COLOR VARIATIONS OF THIS PART

SEE CHART

WHEELBASE REF5594

DATUM

DETAIL BC

BD

1077

9. USE 3443mm OF 98408-01-000 ON BOTTOM OF COVER.

8. CUT NOTCHES AFTER WELDMENT.

7. USE SHIMS AS REQUIRED.

6. LEFT CHASSIS RAIL TOOLING HOLE IS USED FOR FIXTURING ASSEMBLY.

BBANGLE-FORMED126289-70-02B (7)

DETAIL AARAIL ASM172223-11

172223-11 1

ASM P/N SHT

172223-12 3

BA

172223-13 4

2989518

9PLATE-FLOOR,JOINT,CAB135915-08-02B

24

ANGLE-WIRE SUPPORT126624-01-02B (6)

EXTENSION-CHASSIS,FRAME147860-10-02B

EXTENSION-CHASSIS,FRAME RAIL147860-09-02B

THIRD ANGLE

ONE-PLACE (X.X)


INDUSTRIES, INC.

C

DATE

3

C

CHKR

ANGLE

D

7

REV

DWGNO

TWO-PLACE (X.XX)

6


8

7


M.E.

WHOLE DIM (X)

P.E.

R

ORIG. DATE

1

D

TITLE:

8

OF

DFTR

5

ZONE

A

5

PROJECTION

4

DSNR

REV

REV

2REF:


SHEET

MATERIAL:

DATE

3


DFTR-ORIG

4

REVISION RECORD

FIRST USED

BB

2

PART NO

6

A

1

A

10 730C

1.5

0.50

1

1 9

3

172223

FRAME ASM-CHASSIS,FORD

RELEASE


SEE CHART

172223

1505

7014

106

33

AB AB

SECTION AB-AB

666

TOP OF RAIL64

BOLT000C26-05-16B

(2)

1073

1358

1506

1503DATUM

ACAC

SECTION AC-AC

179 940 1450 1960

(4)107

ANGLE-WIRE SUPPORT126624-03-02B (4)

331

848

1345

SHIELD-HEAT145027-08-02B

SHIELD-HEAT135676-17-02B SHIELD-HEAT

145027-09-02B

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

2

172223


VIEW BA

VIEW BB

TOP OF FRAME RAIL 5098

VIEW BD

(2)57

DETAIL BC

236

37

BOLT-HEX-SER FLG 000C26-05-16B

130

56

172

53

168

100

BOLT000C26-05-16B

172223

2479 475

6 50-76

6 50-766 50-76

6 50-76

6 50-76

6 50-76

2880

BRACKET-LP SUPPORT147847-04-02B (2)

TOP OF FRAME RAIL

NEGATIVE BAR140031-03-01B

2541

STL-STRIP033377-66-001

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

3

172223


1503

DATUM

1504

178

DATUM(TOP OF CHASSIS RAIL)

TOP OF FLOOR FRAME

DETAIL CAFLOOR FRAME ASM172223-12

DATUM

REF1695

1188

REF19.0

MFG. HOLE REF12.7

172223

178350

DETAIL DA

EA

EA

ED

ED

EB

EB

FA

FA

EG

EG

FB

FB

FD

FD

FC

FC

EH

EH

(2)301

6904

676 1309

1948

2207 2561 3616

4519

5341

5496

116

837

1139

1645 2425 3182 3616

4519

5494 (2)

6016

(2)

6512

(2)

6944

EJ

EJ

TUBE-MITERED142628-02-02B (2)

EH

EH

EH

EH

EH

EH

EE

4891 6512

STRAP-TANK,HOLDING166729-02-02B

STL-TUBE130890-00-250 (2)

EE

STL-TUBE130885-00-376

STL-TUBE130885-00-400

STL-TUBE130885-00-483

STL-TUBE130885-00-456

STL-TUBE130885-00-376

TUBE-STEEL,MITERED127494-28-02B

STRAP-TANK,HOLDING166729-04-02B

EJ

EJ

FE

FE

EF

EF

EC

EC

EK

EK

EL

EL

TUBE-STEEL,MITERED127494-28-02B

3654 4518

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

4

172223


DATUM

DETAIL DAFLOOR FRAME ASM172223-13-02B

108

229

1731

DETAIL DB

(2)50

(2)23

1761

DETAIL DB

PLATE-ROLLER SUPPORT126315-01-02B (2)

626

1168

DETAIL DEDETAIL DE

196

SECTION TO BEREMOVED

172223

STL-TUBE130885-00-378 (2)

STL-TUBE130895-00-221 (2)

676

417

1168

1661

2228

616 616

327

762

982

STL-TUBE-W/HOLE150936-06-02B (2)

DETAIL DC

DETAIL DC

1644

1947

2206

2816

3491

2424

3182

3484

36154518

4930 5495

6016

5495

5495

6016

6016

6865

6511

6983

689

108

1731

2228

1169

1731

1841

463462

621

1731

973 976 976

621

445

1693

2373

8888

STL-TUBE130885-00-576

STL-TUBE130885-00-566 (2)

STL-TUBE130885-00-080

STL-TUBE130885-00-864 (2)

STL-TUBE130894-00-864

TUBE-STEEL,MITERED127494-04-02B (4)

STL-TUBE130885-00-940 (2)

STL-TUBE130885-02-466 (2)

STL-TUBE130885-00-603

STL-TUBE130885-00-890

STL-TUBE130885-01-955

STL-TUBE130874-00-114

STL-TUBE130874-00-140

STL-TUBE130874-00-565

STL-TUBE130885-00-582 (2)

(2)21

(2)33

767

STL-TUBE130885-00-770

STL-TUBE130895-00-221 (2)

STL-TUBE130895-00-221 (2)

STL-TUBE130895-00-221 (2)

STL-TUBE130885-01-370

STL-TUBE130885-01-672

STL-TUBE130885-00-566 (2)

STL-TUBE130885-01-129 (5)

STL-TUBE130874-00-576

6549

DETAIL DDDETAIL DE (OPPOSITE)

STL-TUBE130885-00-094

DETAIL DD

317

STL-TUBE130874-00-090

STL-TUBE130885-00-150

STL-TUBE130885-03-445

STL-TUBE130875-00-582

STL-TUBE130885-01-076

STL-TUBE130885-01-129 (5)

STL-TUBE130885-02-297 (3)

PLATE-ROLLER126315-01-CHT (2)

STL-TUBE130885-00-651

1814

STL-TUBE130874-00-719

STL-TUBE130874-00-565

STL-TUBE130881-00-409

STL-TUBE130885-02-389

20

10

578

836

1906

TUBE ASM156634-06-02BBOLT-HEX TOP106956-14-000

STL-TUBE130885-01-071

STL-TUBE130890-00-482

STL-TUBE130890-00-456

STL-TUBE130885-00-456

STL-TUBE130885-00-482

TUBE ASM156634-07-02BBOLT-HEX TOP106956-14-000

(2)

23(2)

50

TUBE W/HOLE150936-02-CHT

STL-TUBE130885-01-100

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

5

172223


172223

SECTION EA-EA

TUBE-MITERED142628-09-02B

TUBE-MITERED142628-07-02B (2)

169

7

7

175

PANEL-COMPT147924-01-02B

SECTION EB-EB

STL-TUBE130885-00-300

160

110

183

SECTION EH-EH(4 PLCS)

34

117

160

154


STL-TUBE130885-00-300

SECTION ED-ED

61

276

50


SECTION EG-EG

111

SECTION EJ-EJ(2 PLCS)

61

STL-TUBE130885-00-250

SECTION EE-EE

STL-TUBE130881-00-390 (2) 160M

104

245

SECTION EF-EF

ANGLE-FORMED137344-05-02B

127

236

156

SECTION EC-EC

PANEL-COMPARTMENT147924-01-02B


61

STL-TUBE130885-00-190

ANGLE137344-06-02B

SECTION EK-EK SECTION EL-EL




STL-TUBE130885-00-300

STL-TUBE130885-00-300

111

160

6161

160



REF

164

61

61

STL-TUBE130885-00-376

STL-TUBE130885-00-230

STL-TUBE130885-00-376

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

6

172223


172223

SECTION FA-FA

SECTION FC-FC

SECTION FD-FDSECTION FB-FB

68

222

61

STL-TUBE130885-00-300

160

76

129

ANGLE-FORMED137344-04-02B (2)

(2)

40

143

(2)

22

146

STL-TUBE130890-00-180 (2)

210

104

90


STL-TUBE130885-00-230




SECTION FE-FE

ANGLE-FORMED137344-04-02B (2)

110

6

STL-TUBE130890-00-250 (2)

21

110

147

146

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

7

172223


172223

SECTION GA-GA

SECTION GB-GB

GB

GB

GA

GAHB

HBHA

HA

STEP-ENTRANCE162352-01-02B

COMPT ASM-GENERATOR

GUARD-ROCK152277-01-02B(UP TO 10-29-09)152277-02-02B(AFTER 10-30-09)

45

GUARD-DIRT136389-02-02B (2) 33

TOP OFFLOOR FRAME

22

PANEL-SIDE,COMPT165696-01-02B





2479

PANEL-ROCK GUARD165695-02-02B

GC

GC

SECTION GC-GC

GUARD-DIRT 136389-02-02B

5613

6193



BRACKET ASM168688-04-02B

BRACKET ASM168688-02-02B

GD

GD

SECTION GD-GD

(2)

21

BRACKET ASM

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 730C

8

172223


172223

SECTION HA-HA SECTION HB-HB

57

PANEL-COMPT,SIDE147792-01-02B

76.0

PANEL-COMPT,SIDE147792-02-02B

ANGLE-GENERATOR122410-01-02B

57

PANEL-CLOSEOUT156601-04-02B

4/15/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

06 729H

1

VIEW CA

147872

EXHAUST SYSTEM INSTL

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

06 729H

59

VIEW CC-CC

147872


1536 873

HANGER EXHAUST

MUFFLER EXHAUST143929-07-000

CLAMP-EXHAUST094918-06-000

CLAMP-EXHAUST122392-02-02B

STL-TUBE130892-00-214

12010

CA

CB

VIEW CB

83

196

3370

3564


PIPE-EXHAUST,TAIL148094-03-000


3

HANGER ASM-EXHAUST FORD143811-01-000(2)4 3

3

ANGLE-FORMED138120-00-172

3 2 PLCS

726

CC

CC

147872

546

730C

730C2008FORD

CHASSIS147872-03-000

1/16/2010

09 FD E450

2

171834


171834

STRETCHED CHASSISEXHAUST IN FRONT OF REAR AXLE

BB

SECTION B-B

C

C

SECTION C-C(728B,730C)



HANGER ASM-EXHAUST FORD143811-01-000 (2)

PIPE-EXHAUST,TAIL148094-03-000 (730C)148094-04-000 (728B)

171834-07728B

171834-11730C

REARAXLE

FRONTAXLE

VIEW D

D

ANGLE-FORMED138120-00-172

MUFFLER-EXHAUST143929-07-000


CLAMP-EXHAUST094918-06-000

STL-TUBE130892-00-214

HANGER-EXHAUST

CLAMP-EXHAUST094918-01-000 (728B)

SHIELD-EXHAUST143138-04-02B (728B)

SHIELD-EXHAUST143138-03-02B (728B)

4/16/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

09 730C

5

156835

FUEL FILL INSTL

156835

DETAIL C

SHROUD-FUEL FILL, UPPER135557-06-01ASCREW000G13-06-10I (11)

DETAIL C

SHROUD-FUEL FILL127291-02-01ASCREW0G1208-12-170 (6)

GASKET078200-01-000SCREW0G1208-12-170 (3)

SEAL-STRAP099069-01-000 (300)

SEALANT

TANK ASM(CHASSIS SUPPLIED)

CABLE ASM-GROUND(CHASSIS SUPPLIED)

CAP ASM(CHASSIS SUPPLIED)

NECK ASM-FUEL FILL167421-02-000

HOSE-FILL (350)CLAMP (2)(CHASSIS SUPPLIED)

HOSE-VENT (350)CLAMP (2)(CHASSIS SUPPLIED)

COVER-FUEL FILL149431-02-02BSCREW000G62-08-12B (6)

PANEL-CLOSEOUT,FUEL FILL167129-01-10A

730C156835-08

1/16/2010

SKID PLATE149454-01-02B (2)

21BOLT000C26-08-24T (6)

NUT000D39-08-00T (6)

WASHER000E13-22-OOT (12)


2. USE LOCTITE 62917-02-000 ON ALL THREADS WHEN INSTALLING BOLTS.

1. TORQUE BOLTS TO: 70-85 Nm (52-62 FT-LBS).

SEE CHART

THIRD ANGLE

ONE-PLACE (X.X)


INDUSTRIES, INC.

C

DATE

3

C

CHKR

ANGLE

D

7

REV

DWGNO

TWO-PLACE (X.XX)

6


8

7


M.E.

WHOLE DIM (X)

P.E.

R

ORIG. DATE

1

D

TITLE:

8

OF

DFTR

5

ZONE

A

5

PROJECTION

4

DSNR

REV

REV

2REF:


SHEET

MATERIAL:

DATE

3


DFTR-ORIG

4

REVISION RECORD

FIRST USED

BB

2

PART NO

6

A

1

A

05 726A

1.5

0.50

1

RELEASE

HITCH INSTL-CLASS 3

147864

1 2

1

DRAWBAR ASM-HITCH170943-01-04BLABEL-HITCH RATING172243-01-01A

147864

4/15/2010

2

THIRD ANGLE

D

REV

4

DFTR-ORIGREV

DWGNO

DFTR

1

MATERIAL:

DSNR


WHOLE DIM (X)

R

ORIG. DATE

B

DATE

P.E.



INDUSTRIES, INC.

TWO-PLACE (X.XX)

6

D

5

ANGLE

6 5

8REV

REF:

8

PROJECTION

C

7

3

ZONE

SHEET

REVISION RECORD

FIRST USEDM.E.

C

B

TITLE:

OF

DATE

A

2

PART NO

A

1

CHKR


4

ONE-PLACE (X.X)

3

7

A

10 700-SERIES

1.5

0.50

1

1 4

3

173064

LEVELING SYSTEM INSTL-HWH

RELEASE

1. PARTS INCLUDED WITH LEVELING KIT.

UNIT/WHEELBASEDWG NO

730C/220"

173064-01

NOTES:

173064-02

728B/200"

173064

CHASSIS

E450 FORD

E450 FORD

INDICATES CRITICAL SAFETYPROCEDURE TO BE FOLLOWED

2. SEE BATTERY INSTALLATION FOR ADDITIONAL INFORMATION.

3. FOR WIRING SCHEMATICS OF LEVELING SYSTEM SEE DRAWING 158506-01-000.

4. COVER ALL HOSES FULL LENGTH WITH CONDUIT 041953-09-000.

5. TIE WIRES TO HOSE FITTINGS.

6. HOSES CAN BE BENT TO A 50 mm MINIMUM RADIUS TO AVOID KINKS OR FLOW RESTRICTIONS.

7. TORQUE TO 47 Nm (35 FT LB).



10 SEE WIRING INSTL-CHASSIS FOR "JACK DOWN" LIGHT AND CHIME INSTALLATION.

11 HOOK RETAINER OVER BOTTOM FLANGE OF CHASSIS RAIL (2 PER JACK).

12 CLAMP OR WIRE TIE ALL HOSES AT 900 mm MAXIMUM INTERVALS AND WHERE NECESSARY TO PREVENT HOSES FROM CONTACTING MOVING PARTS OR HEAT PRODUCING ITEMS.

13 HOSE LENGTHS FOR JACKS MUST BE A MINIMUM OF 60" LONG. ROUTE EXTRA HOSE ON TOP OF JACK CROSSMEMEMBER. SECURE WITH WIRE TIES.

14 ALL JACK CYLINDERS MUST BE ALLOWED TO ROTATE INBOARD AND OUTBOARD FREELY WITHOUT HOSES AND WIRES RUBBING OR INTERFERING WITH MOTORHOME COMPONENTS. HOSES AND WIRES MUST NOT BE CLAMPED OT TIED ANY CLOSER THAN 300 mm FROM JACKS.

15 THE LEVEL SENSOR IS LOCATED ON THE RIGHT SIDE OF CONTROL BOX. USING A HEX WRENCH AND A PHILLIPS SCREWDRIVER, ADJUST THE ANGLE OF THE SENSOR IN BOTH DIRECTIONS UNTIL THE FOUR YELLOW LEDS ARE OFF.

16 HOSE FITTINGS TO BE INSTALLED FINGER TIGHT PLUS TWO FLATS OF THE HEX FITTING. IF FITTING HAS BEEN REMOVED AND IS BEING INSTALLED A SECOND TIME, TIGHTEN FITTING FINGER TIGHT PLUS ONE FLAT.

17 WELD BOLT TO FRONT LEVELING JACKS. PAINT WELD AREA.

GROUNDWIRES

GROUNDBOLT

BATTERYCABLE

PUMPRELAY

MASTERRELAY

SW BATTERY

MASTER RELAYCONTROL

PUMP RELAYCONTROL

LR JACKSOLENOID

LF JACKSOLENOID

RF JACKSOLENOID

RR JACKSOLENOID

3000#PRESSURE

SWITCH

50#PRESSURE

SWITCH

2

3 PUMP WIRING DIAGRAM(AP36610)

MASTER CYLINDER BRACKET LOCATED ON FIREWALL UNDER DASH

CHIME AND BRACKETSCREW000G39-08-12B (2)

RUN CHIME WIRE ABOVE CRUSH BLOCK UNDER DASH

VIEW E-E 10

1

1/16/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 700-SERIES

2

173064


173064

B

B

SECTION B-B

11

ROTATION OF CYLINDER

BOLT-3/8-16 X 1.00 GR5 (2/JACK)WASHER-3/8 (2/JACK)NUT-3/8-16 (1/JACK)(MATCH TOP HOLES WITH HOLES IN FRAME)

BOLT-7/16-14 X 4.50 GR5 (2/JACK)WASHER-7/16 (2/JACK)NUT-7/16-14 (2/JACK)RETAINER (2/JACK)

BOLT-3/8-16 X 1.25 GR5 (4/JACK)NUT-3/8-16 (2/JACK)

BOLT-3/8-16 X 1.25 GR5 (2/JACK)WASHER-3/8 (2/JACK)(BOLT CROSSTIE TO EXTENSION)

FRONTAXLE

REARAXLE

VIEW AFRONT JACKS

VIEW CREAR JACKS

VIEW F(PUMP NOT SHOWN)

VIEW H(PUMP NOT SHOWN)

VIEW J

CROSSTIE

REAR JACK

CONTROL BOX

PANEL-CONTROL BOX,LEVELING166732-01-02BSCREW000G39-10-12T (6)(ATTACH TO FLOOR TUBES)

BRACKET ASM-MOUNTING,PUMP162503-01-02B

17

CLIP (2)SCREW000G39-08-20T (2)

PLATE-BODY MOUNT135712-04-02B

14

14ROTATION OF CYLINDER

BRACKET ASM-MOUNTING,PUMP162503-01-02B

SECTION G-G

CLIP (2)SCREW000G39-08-20T (2)

CONTROL BOX

BRACKET-CONTROL BOX,LEVELING158627-01-02BSCREW000G39-10-12T (4)

PLATE-BODY MOUNT135712-01-02B

1/16/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

10 700-SERIES

4

173064


173064

HOSE 186"

HOSE 132"HOSE 146"

HOSE 180"

LEVELING SYSTEM KIT157770-01-000FLUID128270-01-000(APPROX 1.5 GAL)

CONTROL BOX(SEE VIEW J)

HOSE KIT100536-64-000

BATTERY CABLE

FRONT STORAGE COMPARTMENT CONTROL PANEL

HARNESS-HWHAP36602 (JACKS)AP36603 (CONTROL PANEL)AP36610 (PUMP)

PUMPBOLT-3/8-16 X 1.5 GR5 (2)WASHER 3/8 (2)

1

1

1

2

3

15

4 6 12 16

55

CAB MOUNT

DATUM(REAR SURFACE OF CAB)

FRONTAXLE

REARAXLE

REARAXLE

FRONTAXLE

AC

H

730C

E

1/16/2010

COPYRIGHT © 2009 WINNEBAGO INDUSTRIES INC.

157770-01-000KEY PART NUMBER U/M DESCRIPTION VENDOR NO.

100532-01-717 EA MOTOR FOR PMP/RESRV RAP90014 RAP90311100532-03-716 EA SOLENOID-CONTINUOUS DUTY RAP7505100532-03-717 EA VALVE-PRESS., RETURN SHUTTLE RAP7964100532-03-726 EA SWITCH - PRESSURE RAP8003100532-09-705 EA SWITCH-PRESS - 3000 LB. RAP0993100532-09-710 EA SOLENOID-INTERMITENT DUTY RAP0533100532-12-707 EA SPRING KIT (PAIR) R3847100532-32-704 EA CHIME - JACK WARNING RAP90681/AP19765131306-11-704 EA PRESSURE SWITCH - 50 PSI RAP2082131306-12-702 EA VALVE-PRESS SOLENOID (SMALL) RAP90729/AP24604144226-01-700 EA SWITCH - WARNING/MAGNETIC RAP90968/AP26641144226-08-702 EA SENSOR/BI-AXIS - PROGRAMABLE RAP91172/AP28010157770-01-700 EA CYLINDER W/O FOOT - 4K RAP91855/AP36046157770-01-701 EA CYLINDER W/O FOOT - 6K RAP91856157770-01-702 EA SPRING KIT - 4K JACK R91916157770-01-703 EA TOUCH PAD - 625 FORD C BODY RAP91864/AP36468157770-01-704 EA ENCLOSURE BOX W/SENSING UNIT RAP91762/AP36595157770-01-705 EA PUMP/MOTOR/TANK ASM RAP91912/AP37416


157770-01-700 EA CYLINDER W/O FOOT - 4K RAP91855/AP36046157770-01-702 EA SPRING KIT - 4K JACK R91916157770-02-700 EA FOOT - 4K JACK RAP92048


157770-01-700 EA CYLINDER W/O FOOT - 4K RAP91855/AP36046


Wheel Part Number

Wheel Rating

Weight (lbs.)

TireMaximum Tire

RatingBrand

Tire Part Number

Weight (lbs.)

Do

dg

e 3500 Sprinter 500 Series

Magnetto (Mercedes Benz)A 001 401 70 0216 X 5.5, 6 bolt

CHASSIS SUPPLIED

Wheel not marked

27 LT215/85R16E 2680/2470 @ 80 Continental 27.1

E350/E450 Super Duty200,300 & 700 Series

Arvin Meritor 16 X 6, 8 bolt @ 6.5

8C2Z-1015-G

CHASSIS SUPPLIED

Wheel not marked

_ _ _ LT225/75R16E 2680/2470 @ 80 Michelin LTX M/S 083425-14-000 71

F53 16, 18 (2011 chassis) GVWRE26P

Hayes/Lemmerz (Boriem)19.5 X 6.0 10 bolt

8U94-1015-BA

CHASSIS SUPPLIED

3750 @ 110 51.5 225/70R19.5G 3970/3750 @ 110 Continental HSR 60.8

F5318 (2009 chassis), 20.5, & 22K GVWR E30W,E32K D31E,D33C, D35J W/19.5 TIRE ONLY

Accuride 29875 19.5 X 6.75, 10 bolt

5U94-1015-AA

CHASSIS SUPPLIED

4000 @ 115 59 245/70R19.5F 4080/3970 @ 85 Goodyear G670 66

W16/W18 E30W

Maxion W0007492 19.5 X 6, 10 bolt

Steel156482-02-000

Black 3750 @ 110 58.5 225/70R19.5F 3640/3415 @ 95 Michelin XRV 091673-07-000 52

W20-227,500 GAWR-F D33C, E32K

Maxion W0002404 19.5 X 6.75, 8 bolt

Steel 118814-05-000 5000 @ 115 61 245/70R19.5F

F53 16, 18 (2011 chassis) GVWRE26P

Goodyear G670RV 102340-08-000 70

W21/W228,000/8,500 GAWR-F D31E

Maxion W0002404 19.5 X 6.75, 8 bolt

Steel 118814-05-000 5000 @ 115 61 245/70R19.5G 4540/4410 @ 110 Goodyear G670RV 102340-09-000 70

Fo

rdSpare Wheel and Tire Matrix

Chassis Model Year 2008 - CurrentMarch 17, 2009

Wheel

Wo

rkh

ors

e

Chassis

09 730C

15683712

156837

SPARE TIRE COMPL

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

NUT-WING064081-03-000

PIN-HITCH-3/16 WIRE034513-01-000

NUT000D29-09-008 (2)

FRAME EXTENSION

1

BOLT-ELEVATOR000C18-06-56A

BRACKET-CLAMP,SPARE TIRE116338-02-02B

BOLT000C26-06-128 (2)WASHER000E13-17-00B (2)

BUMPER069726-02-000

BRACKET-HINGE,SPARE TIRE159923-01-02B (2)

CRADLE ASM-SPARE,TIRE135796-02-02B

NUT000D39-06-008 2

FRAME EXTENSION

NOTES:

1. SEE SHEET 1 MATRIX.

730C156837-20-XXX

TAB-20,PG-21

1/16/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

07 MOTORHOMES

1

CONTINUED ON NEXT PAGE

159483

WHEEL INSTL

TIRE AND WHEELS

TIRE/WHEEL& WIDTH

WHEEL P/N& MFGR

159483

1

VALVEEXTENSION

WHEELCOVERS

6 USE NUT SUPPLIED ON EXTENSION BETWEEN STABILIZER AND CAP.

WHEELCOVERS

WHEELLINERS

WHEEL LINERS

VALVEEXTENSION

STABILIZER

(2)95012-07 41-47 NM30-35LB/FT

TORQUE

TORQ.WHEELLINER

STABILIZERALUMINUMWHEEL

FORDA BODY

F5310 BOLT19.5"

E/D SERIES

HUBCOVER

VALVEEXTENSION

CHASSIS-SUPPLIED PARTS IF ORDERED W/ALUMINUM WHEEL

245/70R19.5"X6.75"

NUTCOVER

5 WINNEBAGO INSTALLED.

4 FREIGHTLINER LOGO NOT FOR WORKHORSE APPLICATION.

3 NO WINNEBAGO 8 BOLT HUB COVER WITHOUT PORT.

2 BRACKET-17/20 FOR 145 AXLE, BRACKET-21/22 FOR 144 AXLE.

1 CHASSIS SUPPLIED

SOME PARTS UNIQUE TO CHASSIS MFGR., NO WINNEBAGO P/N

. .

FORDA BODY

F53D/J SERIES

235/80R22.5"X7.5"

ALCOADURA-BRITE

873400

N/A . . . . . . KIT WITHATTACHMENT150723-01

REAR INNER(2)77030-10

. .

2010 AND UP WHEEL TRIM MATRIX

2

ACCURIDE29875

55

154672-01 N/A .N/A N/A

255/80R22.5"X8.25"

295/80R22.5"X8.25"

ACCURIDE50487

N/A N/A.

REAR INNER(2)77030-11REAR OUTER(2)77030-10

FRONT(2)77030-01

(2)77030-11 41-47 NM30-35LB/FT

TORQUE

(2)133429-03(2)133429-04

ACCURIDE 29697IFS ONLY FRONTACCURIDE 29560

FRONT FCCC(2)A22-53422-000

129058-15(2)129058-16/19129058-17/20

OR129058-21/22

REAR 1INSIDE

129058-06 (2)

129058-18(2)

(40)129058-10FREIGHTLINER(REAR

ENGINE)P/R SERIES


FRONTCAP ONLY

6

.

CHEVY C BODY(14050)

225/75R16"X6.5"

ACCURIDE29361AFTERMARKETACCURIDE29588

109443-05 REAR:(4)77030-01REMOVE COVERFOR ACCESSFRONT: (2)77030-01

110435-23-000


FRONT(2)77030-10

6(2)95012-07

PUSHON

(NA)

156797-01 (2) FRONT-02 (2) REAR

156797-03 (2) FRONT-04 (2) REAR


. REPLACE NUTS W/(32) 156797-06

NUT COVERS(32) 149749-05

SPRINTER 6 BOLT 16"

(DUAL)50O/H SERIES

215/85R16"X5.5" MAGNETTO

MERCEDESA 001 401 71 02

N/A

N/A

154970-02 CHASSISSUPPLIED

REAR

.PUSH

ON(NA)

168919-01 SET FRONT-02 SET REAR

168919-03 SET FRONT-04 SET REAR

--- --- PART OF HUB COVER

SET(S)

225/75R16"X6"

(ARVIN MERRITOR)

FORD8C24-1015-H

109443-05-000

REAR: FORD 1/2"FRONT: FORD 1/2"(LIKE 077030-10)

REMOVE COVERFOR REAR ACCESS

REAR INNER(2)95012-05REAR OUTERAND FRONT

CHASSIS SUPPLIED1/2"(77030-10)

(2)95012-07 PUSHON

(NA)

(2)149749-01(2)149749-02

(UP TO 06-22-09)(2)149749-07(2)149749-08

(AFTER 06-23-09)

156797-03(2)FRONT-04(2)REAR


---FORDC BODY

E350/450200/300/700

SERIES

6

6

154672-01

110435-23-000 REPLACE NUTS W/(32) 149749-06

NUT COVERS(32) 149749-05

FORD ABODY F5316K 2009

E26P18K (2011)E/D SERIES

225/70R19.5"X6.0"

(HAYES LAMMERZ)

FORD 8U94-1015-BA

N/A N/A 154672-02 REAR INNER(2)95012-09REAR OUTER(2)77030-10

FRONTCAP ONLY

6(2)95012-07 41-47NM

30-35LB/FT

N/A --- --- --- ---

1

FRONTENGINE

FREIGHTLINER

J SERIES

225/80R22.5"X8.25"

ACCURIDE50487

N/A N/A 145580-05 REAR INNER(2)77030-11REAR OUTER(2)77030-10

FRONT(2) 77030-01

(2)77030-11 41-47NM30-35LB/FT

TORQUE

(2)133429-03(2)133429-04

ACCURIDE29697

FRONT FCCC(2)A22-53422-000129058-15(2)129058-17/20

REARINSIDE

129058-06(2)

129058-18(2)

(40)129058-10

DODGESPRINTER2500BVAN100 SERIES

245/75R16"X6.5"

ALUMDODGE68004980AASTL(SPARE)DODGE1J97SZ0AA

N/A N/A N/A N/A N/A N/A

DODGE68004980AA

DODGE51045708AA

(CENTER CAP) N/A N/ABOLT/DODGE68013444AA

1

1

NOT USED

1L1 1LL

16N

16C 16Y

1AF 1LE 1LT 1LU

16L 16Z

16H

16K

1KB 1KM

1KD

(2009)

16H (2011)

3/3/2010

A

2

C


D

PART NO

C

DWGNO

1

REV

5

5

A

4

D

16

8

B

3

7

TITLE:

SHEET

8

3 2

7

6

4

B

FIRST USED

07 MOTORHOMES

3

140

159483

WHEEL INSTL

LUG WRENCH

112358-02CHEVY CUTAWAYG3500 8 BOLT

GMT610 8 BOLT

CHASSIS

2007 AND UP LUG WRENCH APPLICATION MATRIX

LEVERAGE BAR

---

TORQUE FT/LBS

110-140

159483

80208-0280208-06

FORD CUTAWAYE350SD/E450SD

8 BOLT

CHASSISSUPPLIED112358-02

--- 140

FORD RAILF53 10 BOLT

19.5"

CHASSISSUPPLIED112358-01

--- 140

FREIGHTLINER10 BOLT

80208-04 80208-05 450-500

CHASSISSUPPLIED

(FLOOR COMPT.@ PASS. FEET)

140(130-150)

CHASSISSUPPLIED

WORKHORSEW16/18 10 BOLT

19.5"

WORKHORSEW20-25 SERIES

AND UFO8 BOLT

80208-04 80208-05 450-500

CHEVY CUTAWAYALUMINUM WHEELS

G3500/GMT610 8 BOLT

80208-02150

(145-155)

FORD CUTAWAYALUMINUM WHEELS

E350SD/E450SD8 BOLT

80208-06 80208-02 140

80208-06

80208-04 80208-05 450-500FORD RAILF53 8 BOLT

22.5" ALUMINUM

DODGESPRINTER

16"6-BOLT

*FOR WINNEBAGO MODEL YEAR 2007, WINNEBAGO WILL SUPPLY LUG WRENCHES WHICH ARE SUPPLIED TO WINNEBAGO WITH THE CHASSIS. (CURRENTLY, FORD E350/E450 CUTAWAY, DODGE SPRINTER, AND FORD F53 19.5" RAIL) IN ADDITION, C-BODY CUTAWAY CHASSIS WITH ALUMINUM WHEEL OPTION, FORD CHASSIS SUPPLIED LUG WRENCH WHICH NO LONGER FITS ALUMINUM WHEEL FASTENERS WILL BE STORED UNDER PART NUMBER 112358-02-000. WINNEBAGO WILL PROVIDE LUG WRENCH AND LEVERAGE BAR TO FIT ALUMINUM WHEEL HARDWARE. WINNEBAGO WILL PROVIDE 112358-02-000 WITH STANDARD CHEVY STEEL WHEEL CHASSIS.

OTHER APPLICATIONS LISTED FORWRENCH FIT REFERENCE

*

*

*

*

*

*

100/500/H SERIES

NOT USED

NOT USED

200/300/700 SERIES

200/300/700 SERIES

E/D SERIES

D/J SERIES

NOT USED

E26P/E30W

E/D/J SERIES

1KB 1KD 1KM

16C 16Y

16Y16C

16H 16K

16L 16Z

1PJ 1PL

1PE 1PR 1PS 1PU 1PV

2/17/2010



110435-01-711 EA DECAL-CENTER CAP- 2" - QTY 2 DIAMOND/2 PER BAG110435-23-700 EA COVER/WHEEL - FRONT - 1 ONLY FL60-59-FWC110435-23-701 EA COVER/WHEEL - REAR - 1 ONLY RWCFL60-59

700-series 147148-06-000 · 10/22/2009 · 168688-02-02b gd gd section gd-gd (2) 21 bracket asm...

Documents