7 parts manual 3700 3800 series ... - bennett pump company
TRANSCRIPT
117742 Rev D 11-15-17
For new manuals, visit our web page at: http://www.bennettpump.com
Bennett 1218 E. Pontaluna Road, Spring Lake, MI 49456 USA 800-235-7618 Outside USA 231-798-1310 [email protected] www.bennettpump.com
Bennett Pump Company 3700/3800 Series Spec. 100 (2nd Generation) Elec. Commercial & Retail Parts Manual
Only Trained Personnel May Work on This Equipment
Includes Parts For: All 3700 Spec. 100 Electronic Commercial Dispensers All 3800 Spec. 100 Electronic Retail Dispensers Remote Dispensers and Self-Contained Pumps
2 117742 Rev D 11-15-17
Introduction 3
Determining the Model # 3
To Place An Order 3
Table of Contents
Exterior Frame Low Hose - Exploded View 5
High Hose - Exploded View 6
Exterior Frame Parts List 7
Standard Hydraulics Standard Low Hose Hydraulics - Remote 15
Standard High Hose Hydraulics - Remote 16
Standard Low Hose Hydraulics - Suction 17
Standard High Hose Hydraulics - Suction 18
Hydraulics Hardware Table 19
SB-100 Mechanical Meter 20
SB-100 Electronic Meter 21
Type 75 Pumping Unit 24
Big Fueler Hydraulics Big Fueler 40 Low Hose - Suction 28
Big Fueler 40 High Hose - Suction 30
Big Fueler 60 Low Hose - Remote 32
Big Fueler 60 High Hose - Remote 34
Hydraulics Hardware Table 36
T-140 Pumping Unit 37
Electrical Electrical Components 43
Electronics Retail Electronics 45
Retail Electronics - Wire Harnesses 48
Commercial Electronics 51
Commercial Electronics - Wire Harnesses 53
Literature Literature 56
Bennett Limited Warranty ....................................................................... 57
Bennett International Limited Warranty ................................................... 58
3 117742 Rev D 11-15-17
This parts manual covers the 2nd generation 3000 Series Electronic SPEC. 100 dispensers (S/N 8Nxxx and later). Please refer to parts manual 107934 for the 1st generation of Electronic 3000 Series. Note: The two generations are almost identical, with exceptions to various hydraulic components and mounting brackets. For the mechanical 3000 series dispenser, refer to manual P/N 107930.
Determine the model and spec. number of the dispenser from the serial tag. The dispenser serial tag is located on side 1 of the electronics enclosure deck as shown in the picture below. This tag contains information on the features that the dispenser was ordered with.
Introduction
Determining the Model Number and the Dispenser Features
To Place an Order for Parts
Serial tag located on side 1 of the electronics enclosure
FAX YOUR ORDER TO: 1-231-799-6202 MAIL YOUR ORDER TO: BENNETT PUMP COMPANY 1218 E. PONTALUNA RD. SPRING LAKE, MI 49456 CALL: For USA ONLY 1-800-235-7618 (option 2 or 3) Outside USA 1-231-798-1310
ALL ORDERS MUST INCLUDE:
THE PART NUMBER, DESCRIPTION, AND QUANTITY REQUIRED.
THE COMPLETE “SHIP TO” ADDRESS
YOUR COMPANY’S NAME AND ADDRESS (IF DIFFERENT FROM THE SHIPPING DESTINATION) FOR BILLING PURPOSES.
Note: Many common fasteners can be purchased from a local hardware store
SPECIFICATION #
BUILT 1P (JAN. 2012)
YEAR LETTER CODE 2007 J 2008 K 2009 L 2010 M 2011 N 2012 P
4 117742 Rev D 11-15-17
Exterior Frame
5 117742 Rev D 11-15-17
Exterior Frame - Low Hose
4
1
2 3 5 6
7
8
9
10
14
13 12
11
15
16
17
18
20
21
19
6 117742 Rev D 11-15-17
Exterior Frame - High Hose
4
1
2
3 6 7
8
22
16
17
18
20
21
19
25
24
23
27
26 28
29
7 117742 Rev D 11-15-17
Exterior Frame - Parts List
Ref Part No. Description
1 107463 Pumping Unit Deck.Standard
1 112114 Meter Deck, Big Fueler **Not Shown
1 107464 Deck, Remote, Quad Dispenser **Not Shown
1 107465 Deck, Remote, Single, Twin **Not Shown
2 107446 Mount, Pumping Unit and Motor
3 111142 Cross Brace, Dispenser Base
4 111128 Base Frame
5 111122 Upright, Low Hose
6 J983201 Isolator
7 A004401 Washer, Flat, 7/16” I.D. , 1” O.D.
8 107468 Add Holder, Black
9 112734 Bracket, Nozzle, Single / Twin Pac. Boot
10 114632 Vapor Barrier, Blank
11 112754 End Panel, Low Hose, Side Mount, Stainless
11 112753 End Panel, Low Hose, Side Mount, Black
11 112752 End Panel, Low Hose, Side Mount, White
11 107505 End Panel, Low Hose, 1 Outlet, Black
11 107504 End Panel, Low Hose, 1 Outlet, Stainless Steel
11 107506 End Panel, Low Hose, 1 Outlet, White
11 107562 End Panel, Low Hose, 2 Outlet, Black
11 107561 End Panel, Low Hose, 2 Outlet, Stainless Steel
11 107563 End Panel, Low Hose, 2 Outlet, White
11 107502 End Panel, Low Hose, Blank, Black
11 109355 End Panel, Low Hose, Blank, Blue
11 107501 End Panel, Low Hose, Blank, Stainless Steel
11 107503 End Panel, Low Hose, Blank, White
12 109718 Cover, Low Hose End Column, Black
12 109720 Cover, Low Hose End Column, Silver
12 109719 Cover, Low Hose End Column, White BP933
13 108687 Bracket, Hose Hook Support
13 N785102 Hose Hook - Truck Pump
14 108661 Hose Reel Assembly
14 111105 Hose Reel Retractor Bracket
14 108686 Retaining Ring - External
14 109704 Nylon Rope - 126”
14 H550601 Eyelet, Hose Retractor
15 111124 End Frame, Low Hose, Black
16 111129 Cover, Electronics , Black
16 111130 Cover, Electronics, Stainless Steel
17 105906 Hinge, 1.5 x 5.0 Black
18 107466 Rain Lip, Black
18 107467 Rain Lip, Stainless Steel
8 117742 Rev D 11-15-17
Exterior Frame - Parts List
Ref Part No. Description
19 106378 Ad Panel, Unleaded Regular, White / Black
19 106243 Ad Panel, Unleaded Plus, White / Blue
19 106245 Ad Panel, Unleaded Premium, White / Red
19 108879 Ad Panel, Super Unleaded, White / Blue
19 106239 Ad Panel, Diesel, Black / Green
19 108875 Ad Panel, On Road Diesel, Black / Yellow
19 108808 Ad Panel, Off Road Diesel, Black / Yellow
19 108848 Ad Panel, Bio Diesel, Black / Yellow
19 108850 Ad Panel, E-85, Blue / White
19 108880 Ad Panel, Kerosene, White / Black
19 106504 Ad Panel, Blank, Black
19 *For non-standard Ad Panels - Call Bennett Customer Service
20 107526 Ad Panel, End Stops
21 111143 Bracket, Cross Brace
22 107545F Hinge 1.25 X 2.0 Removable, Female, Stainless Steel
22 107545M Hinge 1.25 X 2.0 Removable, Male, Stainless Steel
23 111125 End Frame, High Hose, Black
23 111126 End Frame, High Hose, Stainless Steel
24 107487 End Panel, High Hose, Blank, Black
24 107486 End Panel, High Hose, Blank, Stainless Steel
24 107488 End Panel, High Hose, Blank, White
24 112756 End Panel, High Hose, Island, Stainless Steel
24 112757 End Panel, High Hose, Island, Black
24 112758 End Panel, High Hose, Island, White
25 112854 Retainer Bar, Big Fueler
26 110488 Plate, 3” x 3.5”, Black
27 107455 Cover, Pump Top, High Hose Standard, Black
27 107456 Cover, Pump Top, High Hose Standard, Stainless Steel
27 110486 Cover, Outlet Housing, High Hose, Black, Big Fueler
27 110487 Cover, Outlet Housing, Stainless Steel, Big Fueler
28 112115 Hose Outlet / Speaker ,Big Fueler Flange, Black
28 107568 Hose Outlet, Island Oriented, Standard. Black
28 107866 Hose Outlet, Lane, 2 Sided, Twin, Standard, Black
29 111123 Upright, High Hose
N/A 113440 Door Chain
N/A 111118 Bracket Hose Support, Right Hand
N/A 111120 Bracket Hose Support, Left Hand
N/A 107851 Bracket, Hose Outlet Support
N/A 113758 Nozzle Boot Assembly
N/A 114720 Kit, Nozzle Boot Lever Replacement (Replaced w/ 124599)
N/A 109129 Power Supply Support Bracket
N/A 106250 Foam Gasket Seal - Upper Door, Seal
N/A 110314 Gasket Set, Service, Fleet Management System Option
9 117742 Rev D 11-15-17
Ref. Part No. Description
N/A 106834 Gasket, Edge Cover
N/A 106835 Hinge Gasket
N/A 114242 Lock Kit, Sealed, Upper Door
N/A 114244 Lock Kit, Non Sealed, Lower Door
N/A 108939 Stainless Steel Pipe Nipple, 3”
N/A 107411 Stainless Steel Pipe Nipple, 4”
N/A 107412 Stainless Steel Pipe Nipple, 5-1/2”
N/A 107413 Stainless Steel Pipe Nipple, 7”
N/A 108642 Stainless Steel Pipe Nipple, 7-1/2”
N/A 108452 Support, Meter, 1 Product, 2 Hose, Self Contained
N/A 116337 Upper Door, Single, Debit SPM, Gallons, Black
N/A 116344 Upper Door, Single, Credit, Gallons, Black
N/A 116382 Upper Door, Single , Debit SPM, Gallons, Call Button, Black
N/A 116848 Upper Door, Single , Debit SPM, Gallons, Satellite In Use Light, Black
N/A 116827 Upper Door, Single, Debit SPM, Gallons, Satellite In Use Light, Call Button, Black
N/A 116828 Upper Door, Single, Credit, Gallons, Call Button, Black
N/A 116849 Upper Door, Single, Credit, Gallons, Satellite In Use Light, Black
N/A 116829 Upper Door, Single, Credit, Gallons, Satellite In Use Light, Call Button, Black
N/A 116830 Upper Door, Single, Debit, Gallons, White
N/A 116831 Upper Door, Single, Credit, Gallons, White
N/A 116832 Upper Door, Single, Debit SPM, Gallons, Call Button, White
N/A 116850 Upper Door, Single, Debit SPM, Gallons, Satellite In Use, White
N/A 116833 Upper Door, Single, Debit SPM, Gallons, Satellite In Use Light, Call Button, White
N/A 116835 Upper Door, Single, Credit, Gallons, Call Button, White
N/A 116851 Upper Door, Single, Credit, Gallons, Satellite In Use Light, White
N/A 116834 Upper Door, Single, Credit, Gallons, Satellite In Use Light, Call Button, White
N/A 116836 Upper Door, Single, Debit SPM, Gallons, Stainless Steel
N/A 116837 Upper Door, Single, Credit, Gallons, Stainless Steel
N/A 116838 Upper Door, Single, Debit SPM, Gallons, Call Button, Stainless Steel
N/A 116852 Upper Door, Single, Debit SPM, Gallons, Satellite In Use Light, Stainless Steel
N/A 116839 Upper Door, Single, Debit SPM, Gallons, Satellite In Use, Call Button, Stainless Steel
N/A 116840 Upper Door, Single, Credit, Gallons, Call Button, Stainless Steel
N/A 116853 Upper Door, Single, Credit, Gallons, Satellite In Use Light, Stainless Steel
N/A 116841 Upper Door, Single, Credit, Gallons, Satellite In Use, Call Button, Stainless Steel
N/A 108514 Upper Door, Single, Retail, Call Button
N/A 109079 Upper Door, Single, Retail, Call Button, Preset, Stainless Steel
N/A 109075 Upper Door, Single, Retail, Call Button, Stainless Steel
N/A 108303 Upper Door, Single, Retail, Gallons, Call Button
N/A 109176 Upper Door, Single, Retail, Gallons, Call Button, Local Preset, Stainless Steel
N/A 109172 Upper Door, Single, Retail, Gallons, Call Button, Stainless Steel
N/A 109175 Upper Door, Single, Retail, Gallons, Local Preset, Stainless Steel
N/A 109160 Upper Door, Single, Retail, Gallons, Satellite in Use, Call Button, Local Preset, Black
N/A 109178 Upper Door, Single, Retail, Gallons, Sat. in Use, Call Button, Local Preset, Stainless Steel
N/A 109174 Upper Door, Single, Retail, Gallons, Satellite in Use, Call Button, Stainless Steel
Exterior Frame - Parts List
10 117742 Rev D 11-15-17
Ref. Part No. Description
N/A 109159 Upper Door, Single, Retail, Gallons, Satellite in Use, Local Preset, Black
N/A 109177 Upper Door, Single, Retail, Gallons, Satellite in Use, Local Preset, Stainless Steel
N/A 109173 Upper Door, Single, Retail, Gallons, Satellite in Use, Stainless Steel
N/A 109171 Upper Door, Single, Retail, Gallons, Stainless Steel
N/A 110117 Upper Door, Single, Retail, Galones, Venta Total
N/A 110118 Upper Door, Single, Retail, Galones, Venta Total, LP
N/A 109560 Upper Door, Single, Retail, Liters, Black
N/A 109180 Upper Door, Single, Retail, Liters, Call Button, Stainless Steel
N/A 109184 Upper Door, Single, Retail, Liters, Call Button, Stainless Steel
N/A 109562 Upper Door, Single, Retail, Liters, Local Preset, Black
N/A 109563 Upper Door, Single, Retail, Liters, Local Preset, White
N/A 109162 Upper Door, Single, Retail, Liters, Satellite in Use Light, Call Button, Local Preset, Black
N/A 109182 Upper Door, Single, Retail, Liters, Satellite in Use, Call Button, Stainless Steel
N/A 109186 Upper Door, Single, Retail, Liters, Satellite in Use, Call Button, Stainless Steel
N/A 109161 Upper Door, Single, Retail, Liters, Satellite in Use, Local Preset, Black
N/A 109181 Upper Door, Single, Retail, Liters, Satellite in Use, Stainless Steel
N/A 109185 Upper Door, Single, Retail, Liters, Satellite in Use, Stainless Steel
N/A 109183 Upper Door, Single, Retail, Liters, Stainless Steel
N/A 109179 Upper Door, Single, Retail, Liters, Stainless Steel
N/A 109561 Upper Door, Single, Retail, Liters, White
N/A 109557 Upper Door, Single, Retail, Local Preset, White
N/A 108651 Upper Door, Single, Retail, Satellite in Use
N/A 108650 Upper Door, Single, Retail, Satellite in Use, Call Button
N/A 109076 Upper Door, Single, Retail, Satellite in Use, Call Button, Preset, Stainless Steel
N/A 109073 Upper Door, Single, Retail, Satellite in Use, Call Button, Stainless Steel
N/A 109078 Upper Door, Single, Retail, Satellite in Use, Preset, Stainless Steel
N/A 109074 Upper Door, Single, Retail, Satellite in Use, Stainless Steel
N/A 109556 Upper Door, Single, Retail, White
N/A 108290 Door Upper Single, Volume, Gallons, Black
N/A 109134 Door Upper Single, Volume, Gallons, Stainless Steel
N/A 108291 Door Upper Single, Volume, Gallons, Call Button
N/A 109135 Door Upper Single, Volume, Gallons, Call Button, Stainless Steel
N/A 108292 Door Upper Single, Volume, Liters, Black
N/A 109138 Door Upper Single, Volume, Liters, Stainless Steel
N/A 108293 Door Upper Single, Volume, Liters, Call Button
N/A 109137 Upper Door, Single, Volume Only, Gallons, Call Button, Stainless Steel
N/A 109136 Upper Door, Single, Volume Only, Gallons, Satellite in Use, Call Button, Stainless Steel
N/A 109135 Upper Door, Single, Volume Only, Gallons, Satellite in Use, Stainless Steel
N/A 109139 Upper Door, Single, Volume Only, Liters, Call Button, Stainless Steel
N/A 109141 Upper Door, Single, Volume Only, Liters, Satellite in Use Light, Call Button, Stainless Steel
N/A 103140 Upper Door, Single, Volume Only, Liters, Satellite in Use Light, Stainless Steel
N/A 109640 Upper Door, Single, Volume Only, Plain, Black
N/A 109641 Upper Door, Single, Volume Only, Plain, Call Button, Black
Exterior Frame - Parts List
11 117742 Rev D 11-15-17
Ref. Part No. Description
N/A 109642 Upper Door, Single, Volume Only, Plain, Satellite in Use, Black
N/A 109643 Upper Door, Single, Volume Only, Plain, Satellite in Use, Call Button, Black
N/A 108646 Upper Door, Single, Volume Only, Satellite in Use, Call Button
N/A 108647 Upper Door, Single, Volume Only, Satellite in Use, Call Button
N/A 109760 Upper Door, Single, Volume Only, White
N/A 107691 Upper Door, Twin, Retail
N/A 108515 Upper Door, Twin, Retail, Call Button
N/A 108894 Upper Door, Twin, Retail, Call Button, Preset
N/A 109062 Upper Door, Twin, Retail, Call Button, Stainless Steel
N/A 109195 Upper Door, Twin, Retail, Gallons Stainless Steel
N/A 109199 Upper Door, Twin, Retail, Gallons Stainless Steel
N/A 109196 Upper Door, Twin, Retail, Gallons, Call Button, Stainless Steel
N/A 109200 Upper Door, Twin, Retail, Gallons, Call Button, Stainless Steel
N/A 109166 Upper Door, Twin, Retail, Gallons, Satellite in Use, Call Button, Local Preset, Black
N/A 109198 Upper Door, Twin, Retail, Gallons, Satellite in Use, Call Button, Stainless Steel
N/A 109202 Upper Door, Twin, Retail, Gallons, Satellite in Use, Call Button, Stainless Steel
N/A 109165 Upper Door, Twin, Retail, Gallons, Satellite in Use, Local Preset, Black
N/A 109197 Upper Door, Twin, Retail, Gallons, Satellite in Use, Stainless Steel
N/A 109201 Upper Door, Twin, Retail, Gallons, Satellite in Use, Stainless Steel
N/A 109564 Upper Door, Twin, Retail, Liters, Black
N/A 109208 Upper Door, Twin, Retail, Liters, Call Button, Local Preset, Stainless Steel
N/A 109204 Upper Door, Twin, Retail, Liters, Call Button, Stainless Steel
N/A 110221 Upper Door, Twin, Retail, Liters, Local Preset
N/A 109566 Upper Door, Twin, Retail, Liters, Local Preset, Black
N/A 109207 Upper Door, Twin, Retail, Liters, Local Preset, Stainless Steel
N/A 109567 Upper Door, Twin, Retail, Liters, Local Preset, White
N/A 110220 Upper Door, Twin, Retail, Liters, No Preset
N/A 109168 Upper Door, Twin, Retail, Liters, Satellite in Use, Call Button, Local Preset, Black
N/A 109170 Upper Door, Twin, Retail, Liters, Satellite in Use, Call Button, Local Preset, Black
N/A 109210 Upper Door, Twin, Retail, Liters, Satellite in Use, Call Button, Local Preset, Stainless Steel
N/A 109206 Upper Door, Twin, Retail, Liters, Satellite in Use, Call Button, Stainless Steel
N/A 109167 Upper Door, Twin, Retail, Liters, Satellite in Use, Local Preset, Black
N/A 109209 Upper Door, Twin, Retail, Liters, Satellite in Use, Local Preset, Stainless Steel
N/A 109205 Upper Door, Twin, Retail, Liters, Satellite in Use, Stainless Steel
N/A 109203 Upper Door, Twin, Retail, Liters, Stainless Steel
N/A 109565 Upper Door, Twin, Retail, Liters, White
N/A 109559 Upper Door, Twin, Retail, Local Preset, White
N/A 108892 Upper Door, Twin, Retail, Preset
N/A 108653 Upper Door, Twin, Retail, Satellite in Use
N/A 108652 Upper Door, Twin, Retail, Satellite in Use, Call Button
N/A 108891 Upper Door, Twin, Retail, Satellite in Use, Call Button, Preset
N/A 109064 Upper Door, Twin, Retail, Satellite in Use, Call Button, Preset, Stainless Steel
N/A 109063 Upper Door, Twin, Retail, Satellite in Use, Call Button, Stainless Steel
N/A 108893 Upper Door, Twin, Retail, Satellite in Use, Preset
Exterior Frame - Parts List
12 117742 Rev D 11-15-17
Ref. Part No. Description
N/A 109061 Upper Door, Twin, Retail, Satellite in Use, Stainless Steel
N/A 109558 Upper Door, Twin, Retail, White
N/A 108296 Upper Door, Twin, Volume Only
N/A 108513 Upper Door, Twin, Volume Only, Call Button
N/A 109147 Upper Door, Twin, Volume Only, Gallons, Call Button, Stainless Steel
N/A 109149 Upper Door, Twin, Volume Only, Gallons, Satellite in Use, Call Button, Stainless Steel
N/A 109148 Upper Door, Twin, Volume Only, Gallons, Satellite in Use, Stainless Steel
N/A 109146 Upper Door, Twin, Volume Only, Gallons, Stainless Steel
N/A 109151 Upper Door, Twin, Volume Only, Imperial Gallons, Call Button, Stainless Steel
N/A 109153 Upper Door, Twin, Volume Only, Imperial Gallons, Satellite in Use, Call Button, Stainless Steel
N/A 109152 Upper Door, Twin, Volume Only, Imperial Gallons, Satellite in Use, Stainless Steel
N/A 109150 Upper Door, Twin, Volume Only, Imperial Gallons, Stainless Steel
N/A 109644 Upper Door, Twin, Volume Only, Plain, Black
N/A 109645 Upper Door, Twin, Volume Only, Plain, Call Button, Black
N/A 109646 Upper Door, Twin, Volume Only, Plain, Satellite in Use, Black
N/A 109647 Upper Door, Twin, Volume Only, Plain, Satellite in Use, Call Button, Black
N/A 108649 Upper Door, Twin, Volume Only, Satellite in Use
N/A 108648 Upper Door, Twin, Volume Only, Satellite in Use, Call Button
N/A 110311 Upper Door, Volume Only, Fleet Management System, Option Black
N/A 110316 Upper Door, Volume Only, Fleet Management System, Option Stainless Steel
N/A 113062 Lower Door, Single Hose, Silver (BP-9774)
N/A 112832 Lower Door, Single Hose, Red (BP-9898)
N/A 112744 Lower Door, Single Hose, Yellow (BP-9476)
N/A 112745 Lower Door, Single Hose, Green (BP-9726)
N/A 112746 Lower Door, Single Hose, Blue (BP-9390)
N/A 112747 Lower Door, Single Hose, Red (BP-925)
N/A 112748 Lower Door, Single Hose, Stainless Steel
N/A 112749 Lower Door, Single Hose, Black (BP-9778)
N/A 112750 Lower Door, Single Hose, White (BP-933)
N/A 112937 Lower Door, Single Hose, Pearl (RAL 1013)
N/A 115270 Lower Door, Single Hose, Yellow (PMS-123C)
N/A 116654 Lower Door, Single Hose, Gray (PMS-8C)
N/A 113063 Lower Door, Single Hose, Gray (PMS 10C)
N/A 117044 Lower Door, Single Hose, Blue (PMS-293C)
N/A 117063 Lower Door, Single Hose, Blue (PMS-280C)
N/A 112831 Lower Door, Dual Hose, Red (BP-9898)
N/A 112739 Lower Door, Dual Hose, Yellow (BP-9476)
N/A 112740 Lower Door, Dual Hose, Green (BP-9726)
N/A 112741 Lower Door, Dual Hose, Blue (BP-9390)
N/A 112742 Lower Door, Dual Hose, Red (BP-925)
N/A 112737 Lower Door, Dual Hose, Stainless Steel
N/A 112738 Lower Door, Dual Hose, Black (BP-9778)
N/A 112743 Lower Door, Dual Hose, White (BP-933)
Exterior Frame - Parts List
13 117742 Rev D 11-15-17
Ref. Part No. Description
N/A 114935 Lower Door, Dual Hose, Pearl (RAL 1013)
N/A 115271 Lower Door, Dual Hose, Yellow (PMS-123C)
N/A 117061 Lower Door, Dual Hose, Blue (PMS-293C)
N/A 117064 Lower Door, Dual Hose, Blue (PMS-280C)
N/A 107868 Lower Door, Blank, Red (BP-925)
N/A 107874 Lower Door, Blank, Blue
N/A 107875 Lower Door, Blank, Green
N/A 107876 Lower Door, Blank, Yellow
N/A 107529 Lower Door, Blank, White
N/A 107530 Lower Door, Blank, Black
N/A 109005 Valance, Front/Back, Black
N/A 109007 Valance, Front/Back, Red BP - 925
N/A 109008 Valance, Front/Back, Red BP - 9898
N/A 109006 Valance, Front/Back, Stainless Steel
N/A 109004 Valance, Front/Back, White
N/A 116644 Valance, Front/Back, Yellow PMC-9774
N/A 113357 Valance, Front/Back, Silver
N/A 112199 Valance, Front/Back, White
N/A 111176 Valance, Front/Back, Yellow BP-9476
N/A 112507 Valance, Front/Back, Green BP-9726
N/A 111175 Valance, Front/Back, Blue
N/A 109027 Valance, Kit, Black
N/A 109029 Valance, Kit, Red BP– 9898
N/A 108974 Valance, Kit, Red BP-925
N/A 109028 Valance, Kit, Stainless Steel
N/A 110418 Door Upper Blank 3K Black Bennett Logo
N/A 110419 Door Upper Blank 3K Black Bennett Logo
Exterior Frame - Parts List
14 117742 Rev D 11-15-17
Hydraulics
15 117742 Rev D 11-15-17
Item Part Number Description Comment
1 H386801 Check Valve Cover
2 H384901 Gasket - Check Valve Cover
3 H914201 Check Valve
4 112585 Body-Check Valve & Filter
104816 Check Valve & Filter Assembly Includes Item 1, 2, 3, 4, 5, 6, 7
A311901 35 Micron Paper Filter (Not Shown)
N/A 104815 Spin On Filter Adaptor (Not Shown) Does Not Include Spin On Filter P/N A270501
5 N162201 Filter Cover Gasket
6 N154701 Filter Cover
7 110430 Drain Plug
8 100535 Meter Inlet Gasket
9 114689 SB-100 Meter, Gallon, E-CAL
114706 SB-100 Meter, Liter, E-CAL
114694 SB-100 Meter, Liter, M-CAL
10 A247018 Square Seal
11 104439 Meter Outlet
12 116690 1” Solenoid Valve Assembly 24vdc **Quad Dispensers - Use 117473 24vdc Valve Assembly
13 N636401 Gasket-Solenoid to Flange
14 104444 Adaptor, Outlet, Solenoid
15 107412 SS Pipe Nipple 1” x 5-1/2 “
16 N741301 1” Elbow Painted
17 A583701 Reducer– 1” to 3/4”
18 104443 Inlet Manifold, Single Product Twin
1 3
4
5
6
7
8
2
9
10
10
11 12
13
14
15
16
17
A
B
B
D
E
C
D
Y
18
Securing Hardware Table on page 19 (Alpha)
Standard Low Hose Remote Hydraulics Spec. 100 Parts
16 117742 Rev D 11-15-17
1
3
4
5
6 7
2
9
10
10 13
14
8 B
B
H
11
12
15
16
A
E
D
C
Y
Item Part Number Description Comment
1 H386801 Check Valve Cover
2 H384901 Gasket - Check Valve Cover
3 H914201 Check Valve
4 112585 Body-Check Valve & Filter
104816 Check Valve & Filter Assembly Includes Item 1, 2, 3, 4, 5, 6, 7
A311901 35 Micron Paper Filter (Not Shown)
N/A 104815 Spin On Filter Adaptor (Not Shown) Does Not Include Spin On Filter P/N A270501
5 N162201 Filter Cover Gasket
6 N154701 Filter Cover
7 110430 Drain Plug
8 100535 Meter Inlet Gasket
9 114689 SB-100 Meter , E-CAL
114706 SB-100 Meter, Liter, E-CAL
114694 SB-100 Meter, Liter, M-CAL
10 A247018 Square Seal
11 104439 Meter Outlet
12 116690 1” Solenoid Valve Assembly 24vdc **Quad Dispensers - Use117473 24vdc Valve Assembly
13 N636401 Gasket-Solenoid to Flange
14 116100 1” Tube 3K Island Hose
14 116101 1” Tube 3K Quad
14 116102 1” Tube 3K Lane Single Twin
14 106103 1” Tube 3K Lane Single Side
15 110759 Male Elbow 1 3/16” to 3/4” NPT
16 117428 Hose Outlet-Non Vapor, 1”
17 104443 Inlet Manifold, Single Product Twin
17
Standard High Hose Remote Hydraulics Spec. 100 Parts
Securing Hardware Table on page 19 (Alpha)
17 117742 Rev D 11-15-17
3
2
1
5
6
4
9
8
7
10 11 10
12
15
16 17
14 13
G
F
B
D
E
C
H
*
**
18
Securing Hardware Table on page 19 (Alpha)
Standard Low Hose Suction Hydraulics Spec. 100 Parts
Item Part Number Description Comment
1 100636 1.5” Union
2 102594 Motor Pulley, 2.25” Diameter 60 Hz
100007 Motor Pulley, 2.75” Diameter 50 Hz
3 E169122 Pipe Nipple 1.5” x 2.25”
4 106840 1 HP Motor, 115/230 VAC 50/60 Hz 1PH
106859 1 Hp Motor, 380 VAC 50 Hz, 3 PH
5 100636 Adaptor Inlet (Pumping Unit) Includes Item 1, 2, 3, 4, 5, 6, 7
6 N795301 Gasket, Inlet Adaptor
7 N190705 T75 Pumping Unit HD with Strainer
8 100535 Meter Inlet Gasket
9 114689 SB-100 Meter, E-CAL
114706 SB-100 Meter, Liter, E-CAL
114694 SB-100 Meter, Liter, M-CAL
10 A247018 Square Seal
11 104439 Meter Outlet
12 116690 1” Valve Assembly 24vdc **Quad Dispensers - Use117473 24vdc Valve Assembly
13 N636401 Solenoid Gasket to Flange
14 105887 1” Galvanized Pipe Coupling
15 107412 SS Pipe Nipple 1” x 5.50”
16 N741301 1” Elbow Painted
17 A583701 Reducer, 1” to 3/4”
18 N152902 Manifold, 1 product, 1 hose
* 104479 Manifold, 1 product twin
** 107560 Manifold, Quad
18 117742 Rev D 11-15-17
3
2
1
5
6
4
8
7
9
10
11
12
14
13
G
F
B
D
E
C
H
10
16
15
*
**
18
Item Part Number Description Comment
1 100636 1.5” Union
2 102594 Motor Pulley 2.25” Diameter 60 Hz
2 100007 Motor Pulley, 2.75” Diameter 50 Hz
3 E169122 Pipe Nipple 1.5” x 2.25”
4 106840 1 HP Motor 115/230 VAC 50/60 Hz 1PH
4 106859 1 HP Motor, 380 VAC 50 Hz, 3 PH
5 100636 Adaptor Inlet (Pumping Unit) Includes Item 1, 2, 3, 4, 5, 6, 7
6 N795301 Gasket, Inlet Adaptor
7 N190705 T75 Pumping Unit HD with Strainer
8 100535 Meter Inlet Gasket
9 114689 SB-100 Meter, E-CAL
114706 SB-100 Meter, Liter, E-CAL
114694 SB-100 Meter, Liter, M-CAL
10 A247018 Square Seal
11 104439 Meter Outlet
12 116690 1” Valve Assembly 24vdc
13 N636401 Solenoid Gasket to Flange
14 116100 1” Tube 3K Island Hose
14 116101 1” Tube 3K Quad
14 116102 1” Tube 3K Lane Single Twin
14 106103 1” Tube 3K Lane Single Side
15 110759 Male Elbow 1 3/16” to 3/4” NPT
16 108633 Hose Outlet-Non Vapor
18 N152902 Manifold, 1 product, 1 hose
* 104479 Manifold, 1 product twin
** 107560 Manifold, Quad
Securing Hardware Table on page 19 (Alpha)
Standard High Hose Suction Hydraulics Spec. 100 Parts
19 117742 Rev D 11-15-17
Hydraulics Hardware Table
Item Part No. Description Comment
A 109809 SCREW,HEX HD, M5-.8 X 16mm
B A479902 SCREW HEX HD CAP M8-1.25 x 25mm 8.8
C 100534 SCREW-SOC HD. CAP,M6 x 1 x 20 mm
D 105337 SCREW SOCKET HD CAP 1/4-20 X 1 BLK
E A219010 NUT-HEX/EXT LW, #1/4-20
F A504701 SCREW-SOC HD M10-1.5, 25MM
G A479901 SCREW HEX HD CAP M8-1.25 x 20mm 8.8
H A147601 SCREW, HEX HD CAP, 5/16-18 x 7/8
I 100637 SCREW, SOC HD M10-1.5, LENGTH = 40MM
J A294001 SCREW SOCKET HD CAP 3/8-16 x ¾
K 116458 SCREW SOCKET HD CAP 3/8-16 X 1
L 106743 SCREW SOC HD CAP M8-1.25 x 25MM
M 109914 SCREW SOC HD CAP M8-1.25 x 40MM
N 109463 SCREW, HEX, M6-1.0 x 12mm
O 112106 BRACKET, OUTLET TO FRAME BS HIGH HOSE
P 112854 RETAINER BAR BIG FUELER
Q 108922 SCREW BUTTON HD SOC CAP M6-1 X 16mm SS
R A173801 SCREW, HEX HD CAP, 5/16-18 x 1-1/2 PLATE
S 114602 SCREW HEX HD CAP 5/16-18 x 3"
T 114600 SCREW HEX HD CAP 5/16-18 X 5"
U A390801 SCREW SOC HD CAP M8-1.25 x 20MM
V 108540 SCREW, SOCKET HD CAP, 5/16-18 x 1"
W 114953 BRACKET OUTLET TO FRAME LH
X 116973 BRACKET OUTLET TO FRAME RH
Y A586901 SCREW, HEX, M6-1.0 x 20mm
20 117742 Rev D 11-15-17
SB100 Mechanical Meter
21 117742 Rev D 11-15-17
SB100 Electronic Meter
22 117742 Rev D 11-15-17
Item Part Number Description Comment
1 N/A Lead Seal Wire Please Call 231-798-1310 for details
2 N/A Universal Link Please Call 231-798-1310 for details
3 H651203 Half Coupling Unthreaded See Kit List
4 H650402 Half Coupling Threaded
5 H650501 Screw
6 A480001 Screw, Flat Head M3.5 - 0.6 X 8 mm
7 N666401 Shaft Seal Retainer
8 107694S Shaft Seal Kit, Lipseal for Service
9 A586901 Screw, Hex Head M6 - 1.0 X 20 mm
9 N840401 Screw, Hex Head M6 - 1.0 X 20 mm with Seal Hole
10 A247018 O-Ring, Square Section
11 N646502 Collector Cover
11 103044 Collector Cover High Alcohol
12 A247019 O-Ring, Square Section
13 N673201 Gasket
14 103077 Spring
15 A631901 Screw, Fil Head M4 - 0.7 X 10 mm Stainless Steel
16 N685901 Inner Diaphragm Retainer
17 100081 Diaphragm
18 N673101 Gasket
19 N902501 Counter Valve
20 101183 Counter Valve Assembly Includes Items 15,17,18,19,21
21 N685801 Outer Diaphragm Retainer
22 A586801 Screw, Pan Head M5 - 0.8 X 12 mm
23 101184 Collector Cover Assembly
23 103048 Collector Cover Assembly High Alcohol
24 N672601 Drive Pin
25 N891601 Distributor
26 A579901 Retaining Ring
27 A584001 Washer Crankshaft Support
28 101185 Meter Body Assembly
28 103049 Meter Body Assembly High Alcohol
29 N903701 Roller & Bearing Assembly
30 A631801 Washer
31 A239401 Lock Nut
32 N903801 Crank Shaft Assembly Gallons
32 N903802 Crank Shaft Assembly Liters
33 114149 Pin Cylinder Cover Gallons
33 114444 Pin Cylinder Cover Liters
33 114442 Pin Cylinder Cover High Alcohol Gallons
33 114445 Pin Cylinder Cover High Alcohol Liters
33 N659201 Cylinder Cover (Non Pin)
34 A247010 O-Ring, Square Section
35 N792201 Piston Screw, Hex Head With Nylon Patch (also use with High Alcohol)
36 N701502 Piston Assembly
36 103046 Piston Assembly High Alcohol
38 N654801 Connecting Rod
39 A586401 Retaining Ring
40 N683701 Calibrating Cover
40 103043 Calibrating Cover High Alcohol
41 111787 O-Ring
42 N701601 Calibrating Dial & Screw Assembly
43 N675801 Seal Pin
44 N779601 Calibration Cover Assembly
44 103047 Calibration Cover Assembly High Alcohol
45 100535 Gasket, Meter Inlet Not Shown
46 N902401S Valve Plate Not Shown
47 A586601 Screw, Valve Plate Not Shown
48 A578404 DU Bearing, Meter Body Not Shown, for meters built since 1995
49 N906501 DU Bearing and Retainer, Meter Body Not Shown, for meters built before 1995
SB100 Meter Parts List
23 117742 Rev D 11-15-17
SB-100 Kit List
Part Number Description Comment
100965 Kit, SB100, V'Plate/C'Valve Replacement Includes 1 each of items 8, 10, 12, 13, 14, 20, 25 & 46
KR043601 Kit, SB-100 Piston Retail, 4 Per Includes 4 of items 34, 35, & 36, 1 each of 10 & 45
112343 Kit, SB-100 Piston Retail, Alcohol Meters Includes 4 of items 34, 35, & 36, 1 each of 10 & 45
107170 Kit, Crankshaft Bearing Replacement Includes 2 of item 29, 1 ea. of 10, 31 & 45
112246 Kit, Lower Hydraulic Gallon SB-100 Includes 4 of items 34, 35, & 36, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
112347 Kit Lower Hydraulic Gallon SB-100 Alcohol Includes 4 of items 34, 35, & 36, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
112247 Kit Lower Hydraulic Liter SB-100 Includes 4 of items 34, 35, & 36, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
112348 Kit Lower Hydraulic Liter SB-100 Alcohol Includes 4 of items 34, 35, & 36, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
KR044601 Kit, SB-100 Diaphragm/Distributor Includes 4 of item 15, 1 ea. of 8, 10, 12, 13, 14, 17, 25 & 45
112651 Kit, SB-100 Meter Coupling Includes items 3, 4 & 5
103490 Kit, Tools for Du Bearing Replacement
112248 Field Du Bearing Install/Removal Tool
114377 Kit, Meter Gallon Pin Covers M-Calibration Includes 3 of items 33 & 34, 2 ea. of 29, 1 ea. of 10, 8, 38, 48, 45
114400 Kit, Meter Gallon Pin Covers E-Calibration Includes 4 of items 33 & 34, 2 ea. of 29, 38, 1 ea. of 10, 8, 45, 48
114446 Kit, Meter Liter Pin Covers M-Calibration Includes 3 of items 33 & 34, 2 ea. of 29, 1 ea. of 10, 8, 38, 48, 45
114447 Kit, Meter Liter Pin Covers E-Calibration Includes 4 of items 33 & 34, 2 ea. of 29, 38, 1 ea. of 10, 8, 45, 48
These two kits are for SB100 meters built after 1995
KR044703 Kit, SB-100 Meter, Crankshaft, Gallons Includes 4 of item 34, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
KR044704 Kit, SB-100 Meter, Crankshaft, Liters Includes 4 of item 34, 1 ea. of 8, 10, 12, 26, 32, 45 & 48
These two kits are for SB100 meters built before 1995
KR044701 Kit, SB-100 Meter, Crankshaft, Gallons Includes 4 of item 34, 1 ea. of 8, 10, 12, 26, 32, 45 & 49
KR044702 Kit, SB-100 Meter, Crankshaft, Liters Includes 4 of item 34, 1 ea. of 8, 10, 12, 26, 32, 45 & 49
24 117742 Rev D 11-15-17
Type 75 Pumping Unit
25 117742 Rev D 11-15-17
Type 75 Pumping Unit Parts List
Item Part Number Description Comment
1 A479902 Bolt M8-1.25 X 25 mm (Use N840502 for Seal Wire Bolt)
2 N152902 Meter Inlet Adaptor With Tap
105588 Meter Inlet Adaptor High Alcohol
3 N162801 Gasket, Meter Inlet Adaptor
4 111874 Housing, Air Valve Float Assembly
5 108737 Gasket
9 108734 Float
10 111537 Retainer Ring
11 110211 ID Tag
12 N152801 Cover, Atmospheric Chamber Meter Mount Style
105787 Cover, Atmospheric Chamber Meter Mount Style - High Alcohol
13 N347901 Cover, Atmospheric Chamber Pipe Outlet with Motor Mount Ears
103055 Cover, Atmospheric Chamber Pipe Outlet with Motor Mount Ears - High Alcohol
108945 Cover, Atmospheric Chamber GPU
109582 Cover, Atmospheric Chamber GPU - High Alcohol
17 N162901 Gasket - Atmospheric Cover
18 A480101 Bolt - Round Head M6-0.7 X 20 mm
19 N888301 Non-Reversing Float
20 111788 O-Ring #O17 Also used with High Alcohol
21 109892 Atmospheric Float Assembly
22 N162901 Gasket - Atmospheric Cover
23 113078 One Piece Air Separator Body
113079 One Piece Air Separator Body High Alcohol
24 N162501 Gasket, Inlet Separator
25 N162601 Gasket, Outlet Separator
26 N190201 Insert - Air Separator Inlet
27 108727 Tube - Air Separator
28 108730 Piston OIML Only
29 108725 Spring
30 108728 End Cap
31 N225301 Tube - Air Separator
32 109668 Screw - Air Test Valve
33 109666 Adaptor - Air Test Valve
34 110430 Pipe Plug 1/4 - 18NPT
35 N154801 Cover, Control Valve
103053 Cover, Control Valve High Alcohol
36 N162301 Gasket
37 E008001 Spring Standard Delivery Pump 12 GPM
J325201 Spring Heavy Duty Delivery Pump 22 GPM
38 113022 Control Valve Assembly Aluminum Body Version with Hard Coat
39 A321901 Pressure Relief Valve
40 111790 O-Ring #210 Also used with High Alcohol
41 N150602 Pump Body
103052 Pump Body High Alcohol
N150603 Pump Body Side Inlet Version
109735 Pump Body Side Inlet High Alcohol
42 N160301 Filter Insert
43 100070 Strainer, 70 Micron / 200 Mesh Standard Production
A311901 Paper Filter, 35 Micron
N333501 Strainer, 100 Micron
N347301 Cloth Sack. 10 Micron For use with Strainer
26 117742 Rev D 11-15-17
Type 75 Pumping Unit Parts List
Item Part Number Description Comment
44 N905001 Filter Spring
45 N162201 Gasket
46 N154701 Filter Cover
103054 Filter Cover High Alcohol
47 N154901 Bypass Cover Non-Adjustable
105585 Bypass Cover High Alcohol
48 N162401 Gasket
49 N481201 Bypass Valve Standard - Silver Spring Low Pressure
N481202 Bypass Valve Standard - Green Spring Medium Pressure
N481203 Bypass Valve Standard - Copper Spring High Pressure
50 111791 O-Ring #229 Also used with High Alcohol
51 A620801 Cap Nut
52 A620901 Seal Ring
53 N873001 Disc
54 N872801 Adaptor Not Sold Separately - See Item #60
55 A620101 Retaining Ring
56 N872901 Check Valve Body
57 N873201 Spring
58 N873101 Washer
59 N872701 Shaft
60 N873301 Check Valve Assembly With out Ring
KR044102 Check Valve Assembly Includes Item #50 & Item #60
61 N308301 Cap
62 N308201 Adjustment Screw
63 A507901 Washer
64 N308101 Cover - Adjustable Bypass
65 A479903 Screw M8 - 1.25 X 20 mm
66 A000301 Lock Washer
67 A028101 Flat Washer
68 N106901 Pulley - Single Groove
100040 Pulley - Dual Groove
69 N155901 Clamping Ring
70 N162701 Gasket
71 J682702 Rotor Cover Assembly
72 A480001 Flat Head Screw
73 H352101 Shaft Seal Retainer
74 A323702 Shaft Seal (with insertion tool) 109711 Shaft Seal Kit - Includes #74 & 75 with install plug
75 A247014 Square Seal
76 N103801 Rotor Cover
77 N650401 Throw Out Ring Standard Delivery Pump
N238101 Throw Out Ring Heavy Duty Pump
78 A199501 Woodruff Key
79 A263101 Retaining Ring
80 N238301 Rotor & Shaft Assembly Standard 6 Blade Rotor
*KR0420xx *Rotor Replacement Kit Includes #70, 74, 75, (2) 77, 80, (6) 81 xx=“01” Std Delivery
“02” Heavy Duty
81 110704 Rotor Blade
82 N156401 Stator Standard Delivery Pump
N159501 Stator Heavy Duty Pump
KR036604 Gasket Set for Pumping Unit Complete Set of Gaskets, Seals, and O-Rings for P/U
27 117742 Rev D 11-15-17
Big Fueler Hydraulics Spec. 100
28 117742 Rev D 11-15-17
1
2
6
5
4 3
7
8
9 10
11
12
8
13
14
16 13
15 17
Big Fueler - 40 Low Hose Suction Hydraulics Spec. 100 Parts
18
I
G
K
L
J
M
29 117742 Rev D 11-15-17
Ref Part No. Description
1 111103 Pumping Unit T-140 High Flow
2 J802401 Pumping Unit Inlet Gasket
3 104536 Adaptor Inlet
4 110190 2 HP Motor 230 VAC 50/60 Hz 1PH
4 110191 2 HP Motor 380 VAC 50/60 Hz 3PH
5 A267809 V-Belt (4L380)
6 N162801 Gasket, Meter Inlet Adaptor
7 111137 Adaptor Inlet, FPP Meter 1”
8 113025 O-Ring #131
9 112101 30 Micron Filter
10 113715 1” FPP Meter Assembly
117710 Pulser Kit, 1” FPP, Big Fueler Suction
11 108474 Pipe Plug, Square Head, 1.5” NPT
12 112259 Manifold, Outlet FPP 1”
13 A247016 Square Seal
14 114606 1.5” Solenoid Valve 24vdc
14 114604 1.5” Solenoid Valve 110vac Satellite
14 114605 1.5” Solenoid Valve 230vac Satellite
15 112004 Adaptor Outlet Low Hose
16 108548 Pipe Nipple SS
17 N779401 Elbow 1.25” Black
18 100007 Motor Pulley, 2.75” Diameter, 60 Hz
18 100037 Motor Pulley, 3.00” Diameter, 50 Hz
Big Fueler - 40 Low Hose Suction Hydraulics Spec. 100 Parts
Securing Hardware Table on page 36
30 117742 Rev D 11-15-17
Big Fueler - 40 High Hose Suction Hydraulics Spec. 100 Parts
1
2
6
5
4 3
7
8
9 10
11
12
8
13
14
16 13
15 17
19
18
17
13
15 16
17
20
I
G
J
K
L
L
N O
O
N
Q
31 117742 Rev D 11-15-17
Ref Part No. Description
1 111103 Pumping Unit T-140 High Flow
2 J802401 Pumping Unit Inlet Gasket
3 104536 Adaptor Inlet
4 110190 2 HP Motor 230 VAC 50/60 Hz 1PH
4 110191 2 HP Motor 380 VAC 50/60 Hz 3PH
5 A267809 V-Belt (4L380)
6 N162801 Gasket, Meter Inlet Adaptor
7 111137 Adaptor Inlet, FPP Meter 1”
8 113025 O-Ring #131
9 112101 30 Micron Filter
10 113715 1” FPP Meter Assembly
117710 Pulser Kit, 1” FPP, Big Fueler Suction
11 108474 Pipe Plug, Square Head, 1.5” NPT
12 112259 Manifold, Outlet FPP 1”
13 A247016 Square Seal
14 114606 1.5” Solenoid Valve 24vdc
14 114604 1.5” Solenoid Valve 110vac Satellite
14 114605 1.5” Solenoid Valve 230vac Satellite
15 112107 Outlet Valve to Tube Flanged
16 110430 Pipe Plug
17 112569 Oring # 325
18 112116 1.5” Tube
19 112110 Outlet Hose Left High Flow Flange
19 112109 Outlet Hose Right High Flow Flange
20 100007 Motor Pulley, 2.75” Diameter, 60 Hz
20 100037 Motor Pulley, 3.00” Diameter, 50 Hz
Big Fueler - 40 High Hose Suction Hydraulics Spec. 100 Parts
Securing Hardware Table on page 36
32 117742 Rev D 11-15-17
Big Fueler - 60 Low Hose Remote Hydraulics Spec. 100 Parts
6
7
9
10
4
4
3
2
1
5
10
11
13
12
14
T
V
L
U
M
W X
10
U
33 117742 Rev D 11-15-17
Big Fueler - 60 Low Hose Remote Hydraulics Spec. 100 Parts
Ref Part No. Description
1 112101 5” x 11” 30 Micron Particle Filter
2 112099 Inlet Manifold Filter Adaptor, High Flow
3 114531 Checkvalve Assembly High Flow
4 A247020 Square Seal
5 108948 1.5” FPP Meter
112124 1.5” FPP Meter Pulser Kit
6 108474 Pipe Plug 1.5”
7 117408 Satellite Outlet, Left
7 117409 Satellite Outlet, Right
9 111997 Meter Outlet 1.5” Left Flange
9 111991 Meter Outlet 1.5” Right Flange
10 A247016 Square Seal
11 114606 1.5” Solenoid Valve 24vdc
11 114604 1.5” Solenoid Valve 110vac Satellite
11 114605 1.5” Solenoid Valve 230vac Satellite
12 112004 Adaptor Outlet Low Hose
13 108548 Pipe Nipple SS
14 N779401 Elbow 1.25” Black
Securing Hardware Table on page 36
34 117742 Rev D 11-15-17
Big Fueler - 60 High Hose Remote Hydraulics Spec. 100 Parts
16
15
14
10
12 13
14
T
V
L
U
L
N O
O
N
Q
1
2
3
4
5
4
6
10
11
9
10
7
U
35 117742 Rev D 11-15-17
Ref Part No. Description
1 112101 5” x 11” 30 Micron Particle Filter
2 112099 Inlet Manifold Filter Adaptor, High Flow
3 114531 Checkvalve Assembly High Flow
4 A247020 Square Seal
5 108948 1.5” FPP Meter
112124 1.5” FPP Pulser Kit
6 108474 Pipe Plug 1.5”
7 117408 Satellite Outlet, Left
7 117409 Satellite Outlet, Right
9 111197 Meter Outlet 1.5” Left Flange
9 111191 Meter Outlet 1.5” Right Flange
10 A247016 Square Seal
11 114606 1.5” Solenoid Valve 24vdc
11 114604 1.5” Solenoid Valve 110vac Satellite
11 114605 1.5” Solenoid Valve 230vac Satellite
12 112107 Outlet Valve to Tube Flanged
13 110430 Pipe Plug
14 112569 Oring # 325
15 112116 1.5” Tube
16 112110 Outlet Hose Left High Flow Flange
16 112109 Outlet Hose Right High Flow Flange
Big Fueler - 60 High Hose Remote Hydraulics Spec. 100 Parts
Hydraulic Securing Hardware Table on page 36
36 117742 Rev D 11-15-17
Item Part No. Description Comment
A 109809 SCREW,HEX HD, M5-.8 X 16mm
B A479902 SCREW HEX HD CAP M8-1.25 x 25mm 8.8
C 100534 SCREW-SOC HD. CAP,M6 x 1 x 20 mm
D 105337 SCREW SOCKET HD CAP 1/4-20 X 1 BLK
E A219010 NUT-HEX/EXT LW, #1/4-20
F A504701 SCREW-SOC HD M10-1.5, 25MM
G A479901 SCREW HEX HD CAP M8-1.25 x 20mm 8.8
H A147601 SCREW, HEX HD CAP, 5/16-18 x 7/8
I 100637 SCREW, SOC HD M10-1.5, LENGTH = 40MM
J A294001 SCREW SOCKET HD CAP 3/8-16 x ¾
K 116458 SCREW SOCKET HD CAP 3/8-16 X 1
L 106743 SCREW SOC HD CAP M8-1.25 x 25MM
M 109914 SCREW SOC HD CAP M8-1.25 x 40MM
N 109463 SCREW, HEX, M6-1.0 x 12mm
O 112106 BRACKET, OUTLET TO FRAME BS HIGH HOSE
P 112854 RETAINER BAR BIG FUELER
Q 108922 SCREW BUTTON HD SOC CAP M6-1 X 16mm SS
R A173801 SCREW, HEX HD CAP, 5/16-18 x 1-1/2 PLATE
S 114602 SCREW HEX HD CAP 5/16-18 x 3"
T 114600 SCREW HEX HD CAP 5/16-18 X 5"
U A390801 SCREW SOC HD CAP M8-1.25 x 20MM
V 108540 SCREW, SOCKET HD CAP, 5/16-18 x 1"
W 114953 BRACKET OUTLET TO FRAME LH
X 116973 BRACKET OUTLET TO FRAME RH
Y A586901 SCREW, HEX, M6-1.0 x 20mm
Hydraulics Hardware Table
37 117742 Rev D 11-15-17
T - 140 Pumping Unit
Ref BPC DWG P1672
38 117742 Rev D 11-15-17
Ref No. Part Number Description Comment
1 110359 Housing, Air Valve Float Assembly
2 108737 Gasket
3 110360 Shaft
6 108734 Float
8 111694 Label Serial Number
9 A479902 Bolt M 8 - 1.25 x 25 mm
10 111058 Cover, Atmospheric Chamber
11 111059 Gasket - Atmospheric Cover
12 A480101 Bolt - Round Head M 6 - 0.7 x 20 mm
14 111788 O-Ring
15 109892 Atmospheric Float Assembly
16 111051 Bolt - Round Head
17 111741 Air Separator Body
18 111047 Gasket, Inlet Separator
19 111049 Gasket - Round, Outlet Separator
20 111048 Gasket, Outlet Separator
21 111050 Insert - Air Separator Inlet
22 111046 Tube - Air Separator
23 111636 Piston
24 108725 Spring
25 108728 End Cap
26 A019902 Pipe Plug 1/4 - 18 NPT
27 111034 Cover, Control Valve
28 111033 Gasket
29 J325201 Spring
30 111026 Control Valve Assembly
31 111031 Pressure Relief Valve
32 111032 O-Ring
33 111004 Pump Body
34 N160301 Filter Insert
35 111055 Strainer
36 N905001 Filter Spring
37 111056 Gasket
38 111057 Filter Cover
39 109668 Screw - Air Test Valve
40 109666 Adaptor - Air Test Valve
41 111043 Cap Nut B.P.
42 111042 Adjustment Screw B.P.
43 A507901 Gasket B.P. Screw
44 111041 Cover B.P.
45 111040 Gasket Cover B.P.
T - 140 Parts List
39 117742 Rev D 11-15-17
Ref No. Part Number Description Comment
46 111035 Bypass Valve
47 111647 Pipe Plug - 1 1/2” NPT
48 111053 O-Ring
62 111054 Retainer - Wire
63 111052 Check Valve Assembly
64 A479903 Screw
65 A000301 Lock Washer M 8 - 1.25 x 20 mm
66 111025 Washer
67 N106901 Pulley
69 111023 Flat Head Screw
70 111021 Bearing Retainer
71 115714 Ball Bearing R.C.
72 111019 Washer R.C.
73 111018 Lip Seal R.C.
74 111016 Rotor Cover
75 111017 O-Ring R.C.
76 115711 Throw Out Ring
77 A199501 Woodruff Key #406
78 A263101 Retaining Ring Rotor
79 115735 Rotor & Shaft Assembly
80 111015 Pump Blade
81 111010 Lip Seal Stator
82 115715 Needle Bearing
83 115718 Stator, 100mm
84 111648 Pipe Plug 1/4”
T - 140 Parts List
40 117742 Rev D 11-15-17
Part No. Description Quantity
112167 Instructions 1
111015 Blade 8
111018 Rotor Cover Lip Seal 1
Not Available Non-Reversing Float 1
Part No. Description Quantity
112159 Instructions 1
111018 Rotor Cover Lip Seal 1
T-140 Parts List
Part No. Description Quantity
112163 Instructions 1
111053 O-Ring 1
111052 Check Valve Assembly 1
Inlet Check Valve Kit (112164):
Part No. Description Quantity
112155 Instructions 1
111017 Rotor Cover O-Ring 1
111040 Bypass Valve Cover Gasket 1
111033 Control Valve Cover Gasket 1
111056 Filter Cover Gasket 1
111059 Gasket - Atmospheric Cover 1
111010 Stator Lip Seal 1
111018 Rotor Cover Lip Seal 1
Part No. Description Quantity
112165 Instructions 1
111874 Air Valve Sub Assembly 1
108734 Float 1
111537 C-Clip 2
111538 Gasket Valve 1
111059 Gasket - Atmospheric Cover 1
Shaft Seal Kit (112160):
Sump Float Kit (112162):
Part No. Description Quantity
112161 Instructions 1
109892 Float Valve Assembly 1
111788 O-Ring 1
Not Available Non-Reversing Float 1
8 Blade Kit (112168):
Master Seal Kit (112156):
Over Flow Check Valve Kit (112166):
41 117742 Rev D 11-15-17
Bypass Valve Kit (112152):
Part No. Description Quantity
115737 Instructions 1
115735 Rotor and Shaft Assembly 1
111015 Blade 8
115711 Throw Out Ring 2
111018 Rotor Cover Lip Seal 1
A199501 Woodruff Key #406 1
111010 Stator Lip Seal 1
111017 Rotor Cover O-Ring 1
113658 Plug (Insertion Tool) 1
T-140 Parts List
Part No. Description Quantity
112151 Instructions 1
111035 Bypass Valve 1
Strainer Kit (112154):
Part No. Description Quantity
112153 Instructions 1
111055 Strainer 1
Part No. Description Quantity
112157 Instructions 1
111026 Control Valve Assembly 1
J325201 Spring 1
Rotor & Bearing Rebuild 100mm Kit (115731)
Part No. Description Quantity
115734 Instructions 1
115735 Rotor and Shaft Assembly 1
115715 Needle Bearing 1
115714 Ball Bearing 1
111010 Lip Seal Stator 1
111018 Lip Seal Rotor Cover 1
113658 Plug (Insertion Tool) 1
Control Valve Kit (112158):
Pumping Element - 8 Blade Field Rebuild 100mm Kit (115736):
42 117742 Rev D 11-15-17
Electrical
43 117742 Rev D 11-15-17
Electrical Components
Ref Part No. Description
N/A 107859 J-Box Sub Assembly
N/A J515801 J-Box Cover
N/A A411901 J-Box - 22 Position Terminal Strip
N/A A402501 J-Box - Marker Strip
N/A 111141 Conduit 3/4” Self Contained J-Box
N/A 111139 Conduit 3/4” Remote J-Box
N/A 106412 J-Box Conduit Coupling, 3/4”, Rigid
N/A 107843 Bracket - J-Box, Self Contained
N/A J752101 J-Box Terminal Strip - Support
N/A 106840 Motor - 1 Hp, 115/230 Volt, 50/60 Hz, 1 Phase (Standard Hydraulics)
N/A 106859 Motor - 1 Hp, 380 Volt, 50 Hz, 3 Phase (Standard Hydraulics)
N/A 110190 Motor - 2 Hp, 230 Volt, 50/60 Hz, 1 Phase (Big Fueler)
N/A 110191 Motor - 2 Hp, 380 Volt, 50/60 Hz, 3 Phase (Big Fueler)
N/A 108817 Motor Belt - 36”, “V” (Standard Hydraulics)
N/A A267809 Motor Belt - 38” “V” (Big Fueler)
N/A 102594 Motor Pulley, 2.25” Diameter (Standard Hydraulics T-75 60 Hz)
N/A 100007 Motor Pulley, 2.75” Diameter (Standard Hydraulics T-75 50 Hz)
N/A 100007 Motor Pulley, 2.75” Diameter (Big Fueler T-140 60 Hz)
N/A 100037 Motor Pulley, 3.00” Diameter (Big Fueler T-140 50 Hz)
N/A 107668 Motor Wire Conduit - Shaped, 1/2”, Potted
N/A H033301 Slip Joint Assembly
N/A 107907 Speaker Assembly
N/A 106233 Speaker Conduit - 3/4” X 9 3/8”
N/A 106231 Speaker Conduit - Potted, 1/2” X 6”
N/A 107684 Speaker Wiring Enclosure
N/A 107683 Speaker Wiring Enclosure - Cover
N/A 104187 RC Network Kit, Includes 3 (Used for Remote Relays or Motor Contactor)
N/A 109648 A/B Box ( Used for switching current loop communication to backup POS)
44 117742 Rev D 11-15-17
Electronics
For warranty purposes, always use factory re-built boards. A “Re-Built” board will have the same part number as a brand new board, but, will be preceded with the letters “RB”. When submitting warranty claims to Bennett, the warranty administrator will reimburse your claim for the amount of the re-built price, not the new part price. Please refer to your Bennett Pump Company Warranty Policies and Procedures Manual for more information.
45 117742 Rev D 11-15-17
1
2
14 15
3
4
5
12
6
13
Retail Electronics
7 11
10 9 8
46 117742 Rev D 11-15-17
Retail Electronics
16
20
19
18
17
21
22
47 117742 Rev D 11-15-17
Retail Electronics
Ref Part No. Description
1 107662 210 CPU, Retail **Use 114016 for 210 Door Sensor CPU (International Only)
106167 3 Amp Fuse - CPU Main Power Fuse
108458 Programmed Software, Retail CPU
114745 Magnet, Activate Totals & Audit Trail
106174 Totalizer, Electro - Mechanical
111129 Cover, CPU board ,Plastic (only applicable with printer option)
108527 Main Display Lens, Retail
108284 Main Display Gasket, Retail
2 110737 Backlight, Circuit Board, Retail
108414 Backlight Diffuser, Retail
3 107664 210 Auxiliary Display
4 107576 Barrier Board
109604 Cover, Barrier Board
5 107061 Satellite Board
109390 Satellite Kit, Retail (Includes Satellite Board and all necessary hardware for upgrade)
6 107520 Local Preset
108975 Overlay, Universal, Local Preset (Retail Only)
108886 Plate - Local Preset - 3000 Series
108895 Gasket - Local Preset - 3000 Series
7 108644 Pilot Light Head (Satellite In Use)
8 108645 Lamp Module (Pilot Light)
9 108018 Call Button Switch
10 108019 Call Button Contact Block
11 108746 Motor Contact Relay (High flow suction, 3 phase suction, or subpump relay option)
12 107802 Pulse Output Board
108489 Software For Pulse Output Board
108818 Pulse Output Kit (Includes Pulse Output Board and all necessary hardware for upgrade)
13 106360 Manager Keypad
14 107927s Pulser, Standard Flow
107928 Pulser Cover - Plastic
108014 Pulser Kit (Includes Ribbon Cables, Dust Cover, and hardware)
117710 Pulser Kit, 1” FPP, Big Fueler Suction **See Hydraulics Section
112124 Pulser Kit, 1.5” FPP, Big Fueler Remote **See Hydraulics Section
15 111171s Handle Switch
Nozzle Boot Assembly & Repair Kit **See Exterior Frame Section
16 113606 Hecon Printer Kit
1217 Thermal Printer Paper (Order from Specialty Roll Products 800-647-6267)
17 111209 Power Supply, Credit Reader, SPM, Mx760
109234 Cover, Power Supply 3K
18 N/A SPM, Reference Credit / Debit Module Programming, Service, and Parts Manual
19 N/A Mx760,*Contact Bennett Customer Service
20 113850 Door Switch Assembly (International Only) **113855 for Twin Hose
21 114036 RS-232 Port Serial Board (International Only)
22 104187 RC Network Kit, Includes 3 (Used for Remote Relays or Motor Contactor)
48 117742 Rev D 11-15-17
1
7
6
5 4 3
2
8 9
10 11 12
Retail Electronics - Wire Harnesses
49 117742 Rev D 11-15-17
Retail Electronics - Wire Harnesses
13 14 15
16
17 18
19 20
21
22
50 117742 Rev D 11-15-17
Retail Electronics - Wire Harnesses
Ref Part No. Description
1 108938 AC Power Wire Jumper 48”
108937 AC Power Wire Jumper 24”
2 108480 Wire Assembly, Pulse Output to CPU
3 108544 Ribbon Cable, 10 Conductor, Barrier to CPU 30”
4 108542 Wire Assembly, Big Fueler Barrier Harness to Barrier Board
5 108543 Ground Strap 16” Ring-Ring
6 109391 AC Power Wire Jumper 8” to Satellite Board
7 108326 Wire Assembly, Barrier Assembly
8 108541 Wire Assembly, Barrier Assembly Big Fueler
9 109345 Data Jumper from CPU to Satellite Board
10 108747 Contactor Control Harness (For Use with 108746 Relay)
11 114595 Bennett SPM Power and Data Harness, 3K
12 113533 Hecon Printer Data Cable
13 115407 Hecon Printer Power Cable
14 115607 Ribbon Cable, 10 position, Debit CPU to Softkeys
15 116247 Thermistor Bennett SPM
16 114585 Keypad Ribbon Cable, Credit Only
17 114586 Printer Power Adaptor
18 114587 Encrypted Pin Pad Harness, Debit
19 115670 Wire Assembly, Mx760 - Printer Power Cable (3K / H2)
20 114049 Power Harness, RS-232 Port Serial Board (International Only)
21 108829 Ribbon Cable, 16 Conductor, CPU to Aux. Display.
22 116311 Ribbon Cable, Local Preset (International)
51 117742 Rev D 11-15-17
12
13
4 5
11
6
10
9 8
7
Commercial Electronics
1 2
3
14
52 117742 Rev D 11-15-17
Commercial Electronics
Ref Part No. Description
1 107057 531 CPU, Circuit Board, Commercial
110259 3.15 Amp Fuse - CPU Main Power Fuse
108455 Programmed Software, Commercial CPU
106174 Totalizer, Electro - Mechanical
114745 Magnet, Activate Totals & Audit Trail
108528 Main Display Lens, Commercial
108286 Main Display Gasket, Commercial
2 110734 Backlight, Circuit Board, Commercial
107842 Backlight Diffuser, Commercial
3 107059 Auxiliary Display Circuit Board, Commercial
4 107576 Barrier Board
109604 Cover, Barrier Board
5 107061 Satellite Board
109395 Satellite Kit, Commercial (Satellite Board and all necessary hardware for upgrade)
6 108644 Pilot Light Head (Satellite In Use)
7 108645 Lamp Module (Pilot Light)
8 108018 Call Button Switch
9 108019 Call Button Contact Block
10 108746 Motor Contact Relay (High flow suction, 3 phase suction, or subpump relay option)
11 107802 Pulse Output Board
108489 Software For Pulse Output Board
108818 Pulse Output Kit (Includes Pulse Output Board and all necessary hardware for upgrade)
12 107927s Pulser, Standard Flow
107928 Pulser Cover,Standard - Plastic
108014 Pulser Kit , Standard (Includes Ribbon Cables, Dust Cover, and hardware)
117710 Pulser Kit, 1” FPP, Big Fueler Suction **See Hydraulics Section
112124 Pulser Kit, 1.5” FPP, Big Fueler Remote **See Hydraulics Section
13 111171s Handle Switch
Nozzle Boot Assembly & Repair Kit **See Exterior Frame Section
14 104187 RC Network Kit, Includes 3 (Used for Remote Relays or Motor Contactor)
53 117742 Rev D 11-15-17
Commercial Electronics - Wire Harnesses
1
7
6
5 4 3
2
8 9
10
11
54 117742 Rev D 11-15-17
Commercial Electronics - Wire Harnesses
Ref Part No. Description
1 108938 AC Power Wire Jumper 48”
2 108480 Wire Assembly, Pulse Output to CPU
3 108544 Ribbon Cable, 10 Conductor, Barrier to CPU 30”
4 108542 Wire Assembly, Big Fueler Barrier Harness to Barrier Board
5 108543 Ground Strap 16” Ring-Ring
6 109391 AC Power Wire Jumper 8” to Satellite Board
7 108326 Wire Assembly, Barrier Conduit Assembly
8 108541 Wire Assembly, Barrier Conduit Assembly Big Fueler
9 109345 Data Jumper from CPU to Satellite Board
10 108747 Contactor Control Harness (For Use with 108746 Relay)
11 108829 Ribbon Cable, 16 Conductor, CPU to Aux. Display.
55 117742 Rev D 11-15-17
Literature
56 117742 Rev D 11-15-17
Part No. Description
107931 3000 Series Electronic Installation Manual
108795 3000 Series Electronic Operator's Manual - Commercial
108796 Electronic Operator's Manual - Retail
107934 3000 Series Electronic Parts Manual (1st Generation)
117742 3000 Series Electronic Parts Manual (SPEC. 100)
107932 3000 Series Electronic Service Manual - Commercial
107933 Electronic Service Manual - Retail
116029 SPM Credit / Debit Module Programming, Service, and Parts Manual (Monochrome)
118601 SPM Credit / Debit Module Programming, Service, and Parts Manual ( Blk-White)
118602 SPM Credit / Debit Module Programming, Service, and Parts Manual (Color)
117429 Quick Reference, 3K & DEF Communication Notes
117439 Quick Reference, 3K SPM Install Notes
109044 3000 Series Home Study Course
109766 Product ID Installation Instructions
Literature
**Note: Most literature is found on the CD provided with the dispenser.
57 117742 Rev D 11-15-17
Dispensers – 3000 Series Retail & Commercial Self Contained and Remote Warranty on parts, labor, and travel is 12 months from date of installation or 18 months from date of Bennett’s original invoice, whichever comes first. Warranty excludes nozzles, hoses and fittings, hose retractor, hose reels, filters, belt adjustments, paper jams, light bulbs, or any leaks after the installation start-up and audit. Minor adjustments such as meter calibration, pulser adjustments, and handle switch adjustments, customer specified items manufactured by others, and customer requested reprogramming of equipment are not covered by warranty. Field Retrofit Card Readers, Payment Modules, Cash Acceptors, and all other field retrofit Accessories The field retrofit assembly is warranted for parts only for 12 months from date of installation or 18 months from date of original invoice, whichever comes first, except the receipt printer and driver board which is warranted for parts for ninety (90) days from the date of installation or 180 days from original invoice, whichever comes first. Consumable Items such as receipt paper are not warranted. The use of receipt paper not specified by Bennett will void the printer assembly warranty. Model 515 Pump Controller, 621 Module, Fan Out Boxes Warranty on parts, labor and travel is 12 months from the date of installation or 18 months from the date of original invoice, whichever comes first. Software Bennett Pump Company warrants Bennett products and software packages, whose operation is controlled by Bennett designed and developed software, shall be free of material defects and conform to current Bennett specifications for a period of ninety (90) days from the date of original invoice. Bennett shall use its best effort to correct such defects and to supply to purchaser at Bennett’s expense, a corrected version within a reasonable time after purchaser notifies Bennett in writing of any defects and provides the programs and instructions required to reproduce the claimed defect. Warranty does not cover any modification to the program, the Bennett product, and/or connection to unapproved equipment made by any person or any defect caused by such modifications/connections. Upgrade Kits Bennett offers kits which are installed as an option to enhance operating features of an existing Bennett product are warranted for parts only for ninety (90) days from date of installation or 12 months from date of original invoice, whichever comes first. Upgrade Kit warranty applies to kit components only. Warranty status of the remainder of the product remains unchanged. Spare Parts For equipment under warranty: The warranty period for all spare parts replaced is the remainder of the original warranty. Spare Parts are warranted for the value of the parts only (no labor, mileage, or other charges). For equipment not under warranty: The warranty period is 90 days from the date of invoice to the end user, or 12 months from the date of original invoice, whichever comes first. Spare Parts are warranted for the value of the parts only (no labor, mileage, or other charges). General Exclusions
1. Warranty does not apply to any product which has not been installed to our published recommendations or has been altered, subjected to unusual physical or electrical stress, an Act of God, damaged by accident, tampered with, or subjected to misuse or abuse including substituting parts or accessories from other manufacturers without the written consent of Bennett Pump Company. The above warranties shall not exist if the original identification marks have been removed or altered.
2. Bennett makes no warranty with respect to the Bennett equipment or Bennett’s performance of services under this agreement, express or implied, and Bennett hereby disclaims the implied warranties of merchantability and fitness for a particular purpose.
3. In no event shall Bennett be liable for any loss of profits, loss of use, interruption of business or indirect, special, incidental or consequential dam-ages of any kind in connection with or arising out of the furnishing, performance, use or failure of the Bennett equipment, software or services ac-quired from Bennett, the distributor or the user, whether alleged as a breach of contract or tortuous conduct, including negligence. Bennett’s liability hereunder for damages shall not, in any event, exceed the amounts paid by the buyer to Bennett for equipment, software or services as to which the claim arose.
4. No action arising out of any claimed breach of the Warranty Agreement or transaction under this Warranty Agreement may be brought by either party more than two (2) years after the cause of action has accrued.
5. Use of non-Bennett replacement parts, unless specified by Bennett, will void the equipment warranty. 6. This warranty only applies to Bennett equipment installed in the United States of America and is non-transferable. 7. Failure to pay the Bennett invoice within stated invoice terms, covering the respective Bennett equipment purchased under this limited warranty
may, at Bennett’s discretion, void this limited product warranty. THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER WARRANTIES EXPRESSED OR IMPLIED INCLUDING, WITHOUT LIMITATION, THE WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
BENNETT PUMP COMPANY 1218 E. Pontaluna Road Spring Lake, MI 49456 Tel: 231-798-1310 Fax: 231-799-6202
Bennett Limited Warranty for Products Installed in the United States - 3000 Retail & Commercial
Bennett Pump Company guarantees new Service Station Equipment manufactured by Bennett against defects in material or workmanship during the warranty period in accordance with the provisions stated below:
The Site Audit Report issued with all equipment must be completed and returned at time of installation to Bennett Pump Company, Spring Lake, MI to initiate warranty.
Warranty service must be performed by the nearest Bennett Authorized Service Representative qualified to perform service on the defective equipment. Only Author-
ized and Certified Service Representatives are allowed to perform warranty service. Use of service personnel other than qualified Bennett Service Representatives without prior approval by Bennett Pump Company will void payment of any warranty claims.
Labor and travel costs incurred while servicing Bennett equipment will be paid at previously contracted rates subject to published standard repair time allowances to
qualified Bennett Service Representatives with travel cost limited to 200 miles. Travel cost shall be limited to 4 hours round trip.
Bennett equipment has been installed according to the manufacturer’s instructions and diagrams. Deviations will void this warranty.
During the warranty period, Bennett Pump Company will, at its option, repair or replace defective parts returned to its factory, transportation charges prepaid.
The manufacturer reserves the right to make changes in the design or to make additions at any time.
Form 1-1010-2 Rev D 6-29-17 Part# 135249
58 117742 Rev D 11-15-17
Dispensers (Remote and Self-contained styles) (excluding Natural Gas, Hydrogen and Hydraulic-less Dispensers) The Warranty will cover repair or replacement, at Bennett’s option, of the parts only that are deemed to be defective in material or workmanship at Bennett’s discretion, for a period of 12 months from date of installation or 18 months from date of Bennett’s original invoice, whichever comes first. Warranty excludes nozzles, hoses and fittings, hose retractor, filters, belt adjustments, paper jams, light bulbs, or any leaks after the installation start-up and audit. Minor adjustments such as meter calibration, pulser adjustments, and handle switch adjustments, customer specified items manufactured by others, and customer requested repro-gramming of equipment are not covered by warranty. Field Retrofit Card Readers, Payment Modules, Cash Acceptors, and all other field retrofit Accessories The field retrofit assembly is warranted for parts only for 12 months from date of installation or 18 months from date of original invoice, whichever comes first, except the receipt printer and driver board which is warranted for parts for ninety (90) days from the date of installation or 180 days from original invoice, whichever comes first. Consumable Items such as receipt paper are not warranted. The use of receipt paper not specified by Bennett will void the printer assembly warranty. Model 515 Pump Controller, 621 Module, Fan Out Boxes Warranty on parts only is 12 months from the date of installation or 18 months from the date of original invoice, whichever comes first. Software Bennett Pump Company warrants Bennett products and software packages, whose operation is controlled by Bennett designed and developed software, shall be free of material defects and conform to current Bennett specifications for a period of ninety (90) days from the date of original invoice. Bennett shall use its best effort to correct such defects and to supply to purchaser at Bennett’s expense, a corrected version within a reasonable time after purchaser notifies Bennett in writing of any defects and provides the programs and instructions required to reproduce the claimed defect. Warranty does not cover any modification to the program, the Bennett product, and/or connection to unapproved equipment made by any person or any defect caused by such modifications/connections. Upgrade Kits Bennett offers kits which are installed as an option to enhance operating features of an existing Bennett product are warranted for parts only for ninety (90) days from date of installation or 12 months from date of original invoice, whichever comes first. Upgrade Kit warranty applies to kit components only. Warranty status of the remainder of the product remains unchanged. Spare Parts For equipment under warranty: The warranty period for all spare parts replaced is the remainder of the original warranty. Spare Parts are warranted for the value of the parts only (no labor, mileage, or other charges). For equipment not under warranty: The warranty period is 90 days from the date of invoice to the end user, or 12 months from the date of original invoice, whichever comes first. Spare Parts are warranted for the value of the parts only (no labor, mileage, or other charges). General Exclusions
1. Warranty does not apply to any product which has not been installed to our published recommendations or has been altered, subjected to unusual physical or electrical stress, an Act of God, damaged by accident, tampered with, or subjected to misuse or abuse including substituting parts or accessories from other manufacturers without the written consent of Bennett Pump Company. The above warranties shall not exist if the original identification marks have been removed or altered.
2. Bennett makes no warranty with respect to the Bennett equipment or Bennett’s performance of services under this agreement, express or implied, and Bennett hereby disclaims the implied warranties of merchantability and fitness for a particular purpose.
3. In no event shall Bennett be liable for any loss of profits, loss of use, interruption of business or indirect, special, incidental or consequential damages of any kind in connection with or arising out of the furnishing, performance, use or failure of the Bennett equipment, software or services acquired from Bennett, the distributor or the user, whether alleged as a breach of contract or tortuous conduct, including negligence. Bennett’s liability hereunder for damages shall not, in any event, exceed the amounts paid by the buyer to Bennett for equipment, software or services as to which the claim arose.
4. No action arising out of any claimed breach of the Warranty Agreement or transaction under this Warranty Agreement may be brought by either party more than two (2) years after the cause of action has accrued.
5. Use of non-Bennett replacement parts, unless specified by Bennett, will void the equipment warranty. 6. This warranty only applies to Bennett equipment installed outside the United States of America and is non-transferable. 7. Failure to pay the Bennett invoice within stated invoice terms, covering the respective Bennett equipment purchased under this limited warranty
may, at Bennett’s discretion, void this limited product warranty. THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER WARRANTIES EXPRESSED OR IMPLIED INCLUDING, WITHOUT LIMITATION, THE WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
BENNETT PUMP COMPANY 1218 E. Pontaluna Road Spring Lake, MI 49456 Tel: 231-798-1310 Fax: 231-799-6202
Bennett International Limited Warranty for Dispensers and Pumps
Bennett Pump Company guarantees new Service Station Equipment manufactured by Bennett against defects in material or workmanship during the warranty period in accordance with the provisions stated below:
The Site Audit Report issued with all equipment must be completed and returned at time of installation to Bennett Pump Company, Spring Lake,
MI to initiate warranty.
Warranty service must be performed by the nearest Bennett Authorized Service Representative qualified to perform service on the defective
equipment. Only Authorized and Certified Service Representatives are allowed to perform warranty service. Use of service personnel other than qualified Bennett Service Representatives without prior approval by Bennett Pump Company will void payment of any warranty claims.
Labor and travel costs incurred while servicing Bennett equipment is not covered under this limited warranty.
Bennett equipment has been installed according to the manufacturer’s instructions and diagrams. Deviations will void this warranty.
During the warranty period, Bennett Pump Company will, at its option, repair or replace defective parts returned to its factory, transportation
charges prepaid.
The manufacturer reserves the right to make changes in the design or to make additions at any time.
Form 1-1010-2 Rev D 6-29-17 Part# 135249
59 117742 Rev D 11-15-17
Revision Log
Revision Date Description
A - -
B 6/6/13 -
C 4/24/17 Added Bennett Standard and International Warranties
D 11/15/17 Page 8 - Part # 114720 replaced with 124599 Page 9 - Part # 108515 changed to 108514 to match description Page 10 - Part #108514 changed to 108515 to match description Page 57 - Updated 3k Retail && Commercial Warranty to Rev D Page 58 - Updated Big Fueler & BlueFueler Warranty to Rev D
60 117742 Rev D 11-15-17
Bennett 1218 E. Pontaluna Road, Spring Lake, MI 49456 USA 800-235-7618 Outside USA 231-798-1310 [email protected]
www.bennettpump.com